3000vdc isolation electronic productse e e e e e e e e mitterfeldstrasse 5 d-83527 haag e-mail:...
TRANSCRIPT
EEEE EEEE EEEE
EEEE EEEE EEEE
EEEE EEEE EEEEMitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
Features:
3000VDC ISOLATION
EFFICIENCY UP TO 83%
INTERNAL SMD TECHNOLOGY
LOW COST
NO HEATSINK REQUIRED
1W UNREGULATED OUTPUT POWER
SINGLE IN LINE PACKAGE
100% BURNED IN
MTBF > 2,000,000 HOURS
Specifi cations:
Output Specifi cations Voltage Setpoint AccuracyTemperature Coeffi cientRipple & Noise (20MHz BW)Line Regulation1 Load Regulation2 Minimum LoadShort Circuit ProtectionTransient Response3
+/-2% max+/-0.05%/ °C100mVp-p max+/-1.2% max+/-8% max10% of Full LoadMomentary100uS max
Input Specifi cations Input Voltage RangeInput FilterInput Refl ected Ripple CurrentProtection
+/-10% maxCapacitor Type50mAp-p maxFuse Recommended
Environmental Specifi cations
Operating TemperatureStorage TemperatureHumidityCooling
-25 °C to +71 °C -55 °C to +125 °C95% maxFree-Air Convection
General Specifi cations Effi ciencyIsolation Voltage4 Isolation ResistanceSwitching FrequencyIsolation CapacitanceMTBF5
WeightCase MaterialCase Size
Conducted Emissions Radiated Emissions
70%-83%3000 VDC min109 ohms min100 KHz min80pF max2,000,000 Hours2.1g TypNon-Conductive Plastic 19.6mm*6.1mm*10.2mm19.6mm*7.1mm*10.2mmEN55022 Class AEN55022 Class A
All Specifi cations Typical at Nominal Line, Full Load , and 25 °C Unless Otherwise Noted.
1 Line Regulation is for a 1.0% change in input Voltage. 2 Load Regulation is for output load current change from 20% to 100%.3 25% Step Load Change. 4 For 3 seconds. 5 MIL-HDBK-217F @25°C , Ground Benign.
Footnotes:
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
EEEE EEEE EEEE
EEEE EEEE EEEE
EEEE EEEE EEEETel. : +49/(0) 80 72/37 677-20
Fax : +49/(0) 80 72/37 677-70
Mitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Selection Guide 1W 3000VDC Isolation
MODEL NUMBERINPUT
VOLTAGE(VDC)
OUTPUT VOLTAGE
(VDC)
OUTPUT CURRENT
(mA)
INPUTCURRENT(mA) EFF
(%)ISOLATION
(VDC) PACKAGEFULL LOAD
NOLOAD
Simplifi ed Schematic Single Output Dual Output
EPM201 5 3.3 300 274 21 73 3000 B
EPM202 5 5 200 274 21 73 3000 B
EPM203 5 9 111 257 25 78 3000 B
EPM204 5 12 84 255 28 78 3000 B
EPM205 5 15 67 253 28 79 3000 B
EPM206 5 +/-5 +/-100 274 21 73 3000 B
EPM208 5 +/-12 +/-42 253 28 79 3000 B
EPM209 5 +/-15 +/-34 253 28 79 3000 B
EPM210 12 3.3 300 112 11 74 3000 B
EPM211 12 5 200 112 11 74 3000 B
EPM212 12 9 111 107 11 78 3000 B
EPM213 12 12 84 102 10 82 3000 B
EPM214 12 15 67 100 11 83 3000 B
EPM215 12 +/-5 +/-100 112 11 74 3000 B
EPM217 12 +/-12 +/-42 101 10 83 3000 B
EPM218 12 +/-15 +/-34 101 10 83 3000 B
EPM219 24 3.3 300 57 9 73 3000 D
EPM220 24 5 200 57 9 73 3000 D
EPM221 24 9 111 56 8 75 3000 D
EPM222 24 12 84 54 8 77 3000 D
EPM223 24 15 67 52 7 80 3000 D
EPM224 24 +/-5 +/-100 57 9 73 3000 D
EPM226 24 +/-12 +/-42 54 8 77 3000 D
EPM227 24 +/-15 +/-34 52 7 80 3000 D
Note: Other input to output voltages may be available. Please contact factory.
-Vin
+Vin+Vout
-Vout
OSCILLATORDRIVER
-Vin
OSCILLATORDRIVER
+Vin+Vout
-Vout
COMMON
EEEE EEEE EEEE
EEEE EEEE EEEE
EEEE EEEE EEEETel. : +49/(0) 80 72/37 677-20
Fax : +49/(0) 80 72/37 677-70
Mitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Mechanical Dimensions & Recommended Footprint Details
Package A
Package B
PIN SINGLE DUAL
1 +Vin +Vin
2 -Vin -Vin
4 -Vout -Vout
5 NP Common
6 +Vout +Vout
PIN SINGLE DUAL
1 +Vin +Vin
2 -Vin -Vin
5 -Vout -Vout
6 NP Common
7 +Vout +Vout
2.54[0.10]
All dimensions are in mm[inches]
19.6[0.77]
3.81[0.15]
6.1[0.24]1 2 5 6
0.9[0.04]
10.14[0.40]
4
FRONTVIEW
BOTTOM VIEW
2.54mm
2.54
mm
2 6
TOP VIEW
2.54mm
1 4
SINGLEOUTPUT
2.54mm
2 65
TOP VIEW
2.54mm
1 4
DUALOUTPUT
2.54[0.10]
All dimensions are in mm[inches]
19.6[0.77]
3.81[0.15]
6.1[0.24]1 2 5 6
0.9[0.04]
10.14[0.40]
7
FRONTVIEW
BOTTOM VIEW
2.54mm
2.54
mm
2 7
TOP VIEW
2.54mm
1 5
SINGLEOUTPUT
2.54mm
2 65
TOP VIEW
2.54mm
1 7
DUALOUTPUT
EEEE EEEE EEEE
EEEE EEEE EEEE
EEEE EEEETel. : +49/(0) 80 72/37 677-20
Fax : +49/(0) 80 72/37 677-70
Mitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Mechanical Dimensions & Recommended Footprint Details
Package C
Package D
PIN SINGLE DUAL
1 +Vin +Vin
2 -Vin -Vin
4 -Vout -Vout
5 NP Common
6 +Vout +Vout
PIN SINGLE DUAL
1 +Vin +Vin
2 -Vin -Vin
5 -Vout -Vout
6 NP Common
7 +Vout +Vout
EEEE
2.54[0.10]
All dimensions are in mm[inches]
19.6[0.77]
3.81[0.15]
7.1[0.28]1 2 5 6
0.9[0.04]
10.14[0.40]
4
FRONTVIEW
BOTTOM VIEW
2.54mm
2.54
mm
2 6
TOP VIEW
2.54mm
1 4
SINGLEOUTPUT
2.54mm
2 65
TOP VIEW
2.54mm
1 4
DUALOUTPUT
2.54[0.10]
All dimensions are in mm[inches]
19.6[0.77]
3.81[0.15]
7.1[0.28]1 2 5 6
0.9[0.04]
10.14[0.40]
7
FRONTVIEW
BOTTOM VIEW
2.54mm
2.54
mm
2 7
TOP VIEW
2.54mm
1 5
SINGLEOUTPUT
2.54mm
2 65
TOP VIEW
2.54mm
1 7
DUALOUTPUT
EEEE EEEE EEEE
EEEE EEEE
EEEE EEEE EEEETel. : +49/(0) 80 72/37 677-20
Fax : +49/(0) 80 72/37 677-70
Mitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Mechanical Dimensions & Recommended Footprint Details
Package E
EEEE
PIN SINGLE DUAL
1 +Vin +Vin
2 -Vin -Vin
4 NP -Vout
5 -Vout Common
6 +Vout +Vout 2.54[0.10]
All dimensions are in mm[inches]
19.6[0.77]
3.81[0.15]
6.1[0.24]1 2 5 6
0.9[0.04]
10.14[0.40]
4
FRONTVIEW
BOTTOM VIEW
2.54mm
2.54
mm
2 65
TOP VIEW
2.54mm
1
SINGLEOUTPUT
2.54mm
2 65
TOP VIEW
2.54mm
1 4
DUALOUTPUT
Typical Applications Single Output Dual Output
LOAD
INPUT
+Vin
OUTPUT
-Vout
+Vout
-Vin
DC-DCCONVERTER
+Vout
-Vin -Vout
INPUT
DC-DCCONVERTER
+Vin
LOAD1
OUTPUT
Common
LOAD2
Typical Performance Curves
Specifi cations typical at TA=25 °C, nominal input voltage, rated output current unless otherwise specifi ed.
Vout vs Load (3.3Vout Models) Vout vs Load (5Vout Models)
3.0
3.3
3.6
3.9
4.2
0 75 150 225 300
Output Current(mA)
Vo
ut(
V)
4.8
5.2
5.6
6.0
6.4
0 50 100 150 200
Output Current(mA)
Vout(V)
Vo
ut(
V)
EEEE EEEE EEEE
EEEE EEEE EEEE
EEEE EEEE EEEETel. : +49/(0) 80 72/37 677-20
Fax : +49/(0) 80 72/37 677-70
Mitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Typical Performance Cureves
Specifi cations typical at TA=25 °C, nominal input voltage, rated output current unless otherwise specifi ed.
Vout vs Load (+/-5Vout Models) Vout vs Load (9Vout Models)
Vout vs Load (12Vout Models) Vout vs Load (+/-12Vout Models)
Vout vs Load (15Vout Models) Vout vs Load (+/-15Vout Models)
Vo
ut(
V)
4.8
5.2
5.6
6.0
6.4
0 +/-25 +/-50 +/-75 +/-100
Output Current(mA)
Vout(V)
Vo
ut(
V)
8.8
9.2
9.6
10.0
10.4
0 28 56 84 111
Output Current(mA)
Vout(V)
Vo
ut(
V)
11.5
12.0
12.5
13.0
13.5
0 20 40 60 80
Output Current(mA)
Vout(V)
Vo
ut(
V)
11.5
12.0
12.5
13.0
13.5
0 +/-10 +/-20 +/-30 +/-40
Output Current(mA)
Vout(V)
Vo
ut(
V)
14.5
15.0
15.5
16.0
16.5
0 15 30 45 60
Output Current(mA)
Vout(V)
Vo
ut(
V)
14.5
15.0
15.5
16.0
16.5
0 +/-7.5 +/-15 +/-22.5 +/-30
Output Current(mA)
Vout(V)
Vo
ut(
V)
EEEE EEEE EEEE
EEEE EEEE EEEE
EEEE EEEE EEEETel. : +49/(0) 80 72/37 677-20
Fax : +49/(0) 80 72/37 677-70
Mitterfeldstrasse 5
D-83527 Haag
E-mail: [email protected]
Internet: www.electronic-products.com
R. Nafe – Electronic Products
1W Unregulated 3kVDC-DC Converter SIL 7
MEZ GmbH
MEZ ElectronicProducts E lektronisches K nowhow aus e iner Hand
ElectronicProducts E lektronisches K nowhow aus e iner Hand
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
Electronic Products E l e k t r o n i s c h e s K n o w h o w a u s e i n e r H a n d
P u l v e r b e s c h i c h t u n g
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
Electronic Products R . Nafe • E lekt ronisches K nowhow aus e iner Hand
EPM 200 SERIES APPLICATION NOTES
External Capacitance Requirements:Output fi ltering is required for operation. A minimum of 10uF is needed. Output capacitance may be increased for additional fi ltering, not to exceed 220uF.To meet the refl ected ripple requirements of the converter, an input impedance of less than 0.5ohm from DC to 250KHz is required.
Negative Outputs:A negative output voltage may be obtained by connecting the +OUT to circuit ground and connecting –OUT as the negative output.
Spezifi kationen können jederzeit ohne Vorankündigung geändert werden.
Temperature Derating
Specifi cations typical at TA=25 °C, nominal input voltage, rated output current unless otherwise specifi ed.
Effi ciency vs Load Derating Curve
0.0
20.0
40.0
60.0
80.0
0 20 40 60 80 100
% OF RATED LOAD(%)
EF
FIC
IEN
CY
(%)
0.0
0.3
0.6
0.9
1.2
-25 0 25 50 70 100
TA(degree C)
SAFEOPERATINGAREA
OU
TP
UT
PO
WE
R(W
)