general use tank showers - heat tracing · (export model exp-mh-14k/350) emergency tank shower...
Post on 08-Sep-2020
1 Views
Preview:
TRANSCRIPT
General Use Tank Showers
57
General Use Tank ShowersO u t d o o r a n d I n d o o r E m e r g e n c y Ta n k S h o w e r s
• Light BoxIf a Light Box is fitted it allows the safety signsto be back-lit for greater visibility on dull daysand at night, as well as shining lightdownwards to ensure the operatingmechanism and shower area are well lit at alltimes.Note: Available as an optional fitting, eitherNon-Flameproof or Zone 1 & 2.
• Twin Ball CocksFitted to ensure a continuous and adequateflow rate, even when the tank has emptied.Also enables speedy replenishment of waterin the tank.
• Panic Bar OperationTo allow easy operation of the unit should theoptional Foot Panel be obstructed.
• Galvanised or Stainless Steel OptionAll Tank Showers within the range areavailable with either galvanised mild steel orstainless steel frames.
• Colour OptionThe standard colour is white, with green andwhite safety stripes. Green is available as analternative if preferred.
• Insulation OptionFor indoor heated areas and for outdoors inmild climates, versions of all models areavailable with insulation only. For very hotclimates, special insulation can be fittedwhich has a higher thermal resistance andincorporates a layer of silver foil to reflectradiated heat.
• Sunshield OptionSunshields are available for fitting around thetank and above the lid to give extraprotection from solar radiation.
• Cooling OptionsChillers and Cooling Coils can be fitted tocool the water in the tank when units areinstalled in areas that experience highambient temperatures.
• Export OptionA version is available specifically for export. Ithas the same features and construction as thestandard (STD) model except for the legs.These are removable and made in severalsections for easier packing and shippingwhich helps to keep transport costs to aminimum. All export models are denoted bythe prefix EXP.
5 8
for the latest updates go to
A range of heavy dutyEmergency Tank Showers,for use when warm wateris required, or a constantsupply of water cannot beguaranteed. These unitsare essential where thereis a problem withinsufficient water pressureor inadequate flow rate.This improved rangeincorporates models tosuit a wide range ofsituations. The outdoortypes are heated and pre-insulated to preventfreezing during conditionsof frost, whereas theindoor or tropical versionsare insulated but withoutheating, to ensure asteady temperature ismaintained.
Tank Showers areavailable in three sizes:the 350 litre modelsupplies a guaranteedflow of warm water forseveral minutes.With the mains supplypermanently connectedthe 750 litre model willdeliver warm water forthe 15 minutesrecommended by theANSI standard. The 1200 litre model willmeet the standard evenwithout an externalsupply connected.
(Export Model EXP-MH-14K/350)
Emergency Tank Showerincorporating a 350 litre tank todeliver a guaranteed flow of warmwater for several minutes.
An integral immersion heater,controlled by a dual safetythermostat, maintains the water inthe insulated tank at a constanttemperature.
The shower is activated when thecasualty stands on the optionalFoot Panel or pushes the panicbar.
Insulated models available,without heatingSTD-J-14K/350EXP-J-14K/350
Versions are available with orwithout the externally mountedEye/Facewash Fountain.
STD-MH-14K/350
5 9
TANK CAPACITY 350 LITRES
DEPTH 8801030 450
1170
3170
General UseTank
Showers
General Use Tank ShowersO u t d o o r a n d I n d o o r E m e r g e n c y Ta n k S h o w e r s
6 0
(Export Model EXP-MH-14K/750)
Emergency Tank Showerincorporating a 750 litre tank todeliver a guaranteed flow of warmwater for 15 minutes with themains supply connected.
An integral immersion heater,controlled by a dual safetythermostat, maintains the water inthe insulated tank at a constanttemperature.
The shower is activated when thecasualty stands on the optionalFoot Panel or pushes the panicbar.
A version is available with theEye/Facewash Fountain mountedinternally. Alternatively theEye/Facewash Fountain can beomitted.
Insulated models available,without heatingSTD-J-14K/750EXP-J-14K/750
Note: An Earthquake proof versionof this model is available whichhas been designed to conform tothe California Building Code 1998Chapter 16, Division 1.
STD-MH-14K/750
TANK CAPACITY 750 LITRES
DEPTH 1480 1310 450
1170
3235
for the latest updates go to
A range of heavy dutyEmergency Tank Showers,for use when warm wateris required, or a constantsupply of water cannot beguaranteed. These unitsare essential where thereis a problem withinsufficient water pressureor inadequate flow rate.This improved rangeincorporates models tosuit a wide range ofsituations. The outdoortypes are heated and pre-insulated to preventfreezing during conditionsof frost, whereas theindoor or tropical versionsare insulated but withoutheating, to ensure asteady temperature ismaintained.
Tank Showers areavailable in three sizes:the 350 litre modelsupplies a guaranteedflow of warm water forseveral minutes.With the mains supplypermanently connectedthe 750 litre model willdeliver warm water forthe 15 minutesrecommended by theANSI standard. The 1200 litre model willmeet the standard evenwithout an externalsupply connected.
61
STD-MH-14K/1200
TANK CAPACITY 1200 LITRES
DEPTH 1480 1310 450
1170
3590
General UseTank
Showers
(Export Model EXP-MH-14K/1200)
Emergency Tank Showerincorporating a 1200 litre tank todeliver a guaranteed flow of warmwater for up to 15 minutes evenwhen the mains supply has beendisrupted.
An integral immersion heater,controlled by a dual safetythermostat, maintains the water inthe insulated tank at a constanttemperature.
The shower is activated when thecasualty stands on the optionalFoot Panel or pushes the panicbar.
A version is available with theEye/Facewash Fountain mountedinternally. Alternatively theEye/Facewash Fountain can beomitted.
Insulated models available,without heatingSTD-J-14K/1200EXP-J-14K/1200
Note: An Earthquake proof versionof this model is available whichhas been designed to conform tothe California Building Code 1998Chapter 16, Division 1.
Optional Fittings
6 2
• Light & Light BoxFor Non-Flameproof models the optional LightBox is fitted with two lights inside, whereas onZone 1 & 2 models a single bulkhead typelight is fitted (as shown in picture).Other types of light are available such asfluorescent and MBF/U (Mercury) lights shouldthese be preferred.
• Hand Held Eyebath UnitEyebath on a flexible hose, as an additionalmeans of flushing eyes, face or hands.N.B. Eyebath can be tank or mains fed.
• Panel Foot ControlAs an additional means of operating the shower.
• GRP PanellingTo reduce overspray especially when the unit is locatedin an exposed position. Available in a choice of colours.
• Visual Level IndicatorTo enable an operator to easily checkthe water level inside the tank.
• Level SwitchFitted inside the tank to indicate at a remoteposition that the tank is not full and needsrefilling.
• Syphon Dump ValveTo automatically discharge a proportion ofwater on a regular basis to ensure the waterin the tank remains fresh at all times.
• Eye/Facewash FountainFitted to the Tank Shower legs fordecontamination of eyes, face or hands. On 750 and 1200 litre models this can beinternally or externally mounted.N.B. Eye/Facewash can be tank or mains fed.
for the latest updates go to
6 3
• Drain SumpTo contain the used water and directit into a drain.
• Strip ScreensClear or coloured PVC Strip Screensare available to reduce overspray andspillage to an absolute minimum andafford privacy to the user.
• Water Temperature GaugeTo allow the water temperature in the tank to be monitored.
• Shower DoorsAvailable in a choice of designs and materials for fitting tothe entrance.
• Audible and Visual AlarmsVarious options available to suit client's requirements.
• Mains Fed Shower SystemAdditional Mains Fed Shower System to supplement the flowfrom the Tank Shower rose, (various options available).
• Shower Test HandleTo allow the shower to be tested withoutthe operator getting wet.
• Proximity SwitchesCan be fitted to the shower and/oreye/facewash to indicate at a remote positionthat the unit is being operated.
Accessories are availableto help you make themost of your TankShower. Each site isdifferent – each has itsown requirements. With awide choice of matchedaccessories available, youcan create a safetysolution that is perfectlysuited to your needs. Youcan make your showereasier to identify, moreaccessible and simpler tooperate.
ANSI Standard Z358.1-2004 states:7.4.3. Be located in anarea identified with ahighly visible signpositioned so the signshall be visible within thearea served by thecombination unit. Thearea around thecombination unit shall bewell lit.
EX
TR
AS
HO
WE
RH
EIG
HT
TOA
CC
OM
MO
DAT
ES
UM
P22
5
GALVANISEDMILD STEEL SUMP
2 INCH BSP FEMALEDRAIN OUTLET
General UseTank
Showers
• SunshieldsWhen operating in extreme temperatures,Tank Showers can be fitted with Sunshieldsto protect the water in the tank from theeffects of heat transfer by conduction,convection and radiation. High densitypolyurethane insulation stops theconduction and convection and the integralsilver foil stops radiation. The combinedresult of the Sunshields and the highefficiency insulation is the maintaining of aneven temperature during day and night.
• Chillers and Cooling CoilsCan be fitted to cool the water in the tankto ensure it remains lower than ambientday time temperatures when units areinstalled in hot climates.
STD-MH-14K/350
STD-MH-14K/750
STD-MH-14K/1200
STD-J-14K/350
STD-J-14K/750
STD-J-14K/1200
EXP-MH-14K/350
EXP-MH-14K/750
EXP-MH-14K/1200
EXP-J-14K/350
EXP-J-14K/750
EXP-J-14K/1200
Optional Fittings and Technical Details
Han
dH
eld
Eyeb
ath
Uni
t
Opt
iona
l Fit
ting
s
Poin
ter T
ype
Leve
l Ind
icat
or
Pane
l Foo
t Con
trol
Leve
l Sw
itch
Ligh
t -Zo
ne1
&2
Show
erD
oors
Show
erTe
stH
andl
eSu
nshi
elds
Coo
ling
Coi
lC
hille
r Uni
tM
ains
Fed
Show
erSy
stem
Syph
onD
ump
Valv
e
Strip
Scre
ens
Dra
inSu
mp
GRP
Pane
lling
onLe
gs
Eye/
Face
was
hFo
unta
in
Audi
ble/
Visu
alAl
arm
Prox
imity
Switc
h- N
onFl
amep
roof
Ligh
t -N
onFl
amep
roof
Prox
imity
Switc
h- Z
one
1&
2
6 4
Technical DetailsGalvanised Stainless Depth Width Height Weight Inlet Size Min. Pressure Water Flow
Steel mm mm mm kg (“ inches) BSP kg/cm2 (bar g) l/min
STD-MH-14K/350 STD-MH-14KS/350 880 1035 3115 150 3/4” Female 0.5 75STD-MH-14K/750 STD-MH-14KS/750 1480 1320 3315 270 3/4” Female 0.5 75STD-MH-14K/1200 STD-MH-14KS/1200 1480 1320 3525 320 3/4” Female 0.5 75STD-J-14K/350 STD-J-14KS/350 880 1035 3115 150 3/4” Female 0.5 75STD-J-14K/750 STD-J-14KS/750 1480 1320 3315 270 3/4” Female 0.5 75STD-J-14K/1200 STD-J-14KS/1200 1480 1320 3525 320 3/4” Female 0.5 75EXP-MH-14K/350 EXP-MH-14KS/350 880 1035 3115 150 3/4” Female 0.5 75EXP-MH-14K/750 EXP-MH-14KS/750 1480 1320 3315 270 3/4” Female 0.5 75EXP-MH-14K/1200 EXP-MH-14KS/1200 1480 1320 3525 320 3/4” Female 0.5 75EXP-J-14K/350 EXP-J-14KS/350 880 1035 3115 150 3/4” Female 0.5 75EXP-J-14K/750 EXP-J-14KS/750 1480 1320 3315 270 3/4” Female 0.5 75EXP-J-14K/1200 EXP-J-14KS/1200 1480 1320 3525 320 3/4” Female 0.5 75
top related