gujarat pollution control board · 6. regional office, gujarat pollution control board,...
Post on 27-Mar-2020
6 Views
Preview:
TRANSCRIPT
Gujarat Pollution Control Board Regional Office,
C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar – 382 010
Website: www.gpcb.gov.in
PUBLIC HEARING PROCEEDINGS
As per the provision of notification S.O. 1533 dated 14th September, 2006 and its
subsequent amendments S.O. 3067(E) dated 1st December, 2009, Issued by the Ministry
of Environment and Forests & Climate Change, Government of India, New Delhi, Public
Hearing was conducted for the proposed Expansion Project of Pharmaceutical products
unit (Total Capacity of 3.25 MTPM to 138.0 MTPM), located at Block No. 155/1, 159,
Village: Dhanot, Ta. Kalol, Dist. Gandhinagar (Gujarat) by M/s. ORBIT PHARMA
LABORATORIES, which is covered under “Category A” of the schedule 5(f) of the above
referred notification.
A copy of the draft Environment Impact Assessment Report and the Summary of
Environment Impact Assessment Report ware sent to the following authorities or offices to
make available the draft EIA report for inspection to the public during normal office hours,
till the Public Hearing is over.
1. The District Collector Office, Gandhinagar
2. District Development Office, Gandhinagar
3. District Industry Centre, Dist. Gandhinagar
4. Taluka Development Office, Tal: Kalol, Dist. Gandhinagar
5. The Chief Conservator of Forests,
Ministry of Environment and Forest, GOI, Regional Office (West Zone), Kendriya
Paryavaran Bhavan, E-5, Arera Colony, Link Road-3, Ravisankar Colony, Bhopal -
462016.
6. Regional Office, Gujarat Pollution Control Board, Gandhinagar, C/o. “Paryavaran
Bhavan”, Sector-10A, Gandhinagar -382 010.
Other concerned persons having plausible stake in environmental aspects were requested
to send their responses in writing to the concerned regulatory authorities.
The Public Hearing was scheduled on 13/10/2017 at 11:45 hrs. at Chhatral GIDC Industrial
Association Hall, 1st Floor, GIDC Shopping Center, GIDC Chhatral, Mahesana Highway
Road, Ta : Kalol, Dist. : Gandhinagar, (Gujarat).
An advertisement in English was published in “DNA” dated 12/09/2017 and in Gujarati
language in “Divya Bhaskar” dated 12/09/2017.
Shri S. A. Patel, IAS, Collector and District Magistrate, Gandhinagar supervised and
presided over the entire public hearing proceedings.
A statement showing participants present during the public hearing is enclosed as
Annexure A.
Guiarat Pollution Control BoardRegional Office,C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar - 382 010Website: lyt 4dgpsb.goyjr
ANNEXURE - AA Statement showins participants present durins the public hearins
As per Ministry of Environm'ent, Forest and Climate Change, Government of India, New Delhivides its notification No. s.o. 1533(E) dated 14-09-2006, and its subsequent amendmentsS.O.3067(E) dated 1st December 2009, , Public Hearing was fixed for M/s. ORBTT PHARMALABORATORIES, for Proposed Expansion of Pharmaceutical products unit (3.25 MTPM to1 38.0 MTPM), located at Block No. '155/1 , 1 59, Vittage: Dhanot, Ta. Katot, Dist. candhinagar(Gujarat), covered under Category "A" of the schedule 5(f).
The statement showing Participants present during Public Hearing held on 13-10-2017 at 11:45A.M. at Chhatral Gidc Industrial Association Hall, 1st Floor, GIDC Shopping Center, GIDCChhakal, Mahesana Highway Road, Ta : Kalol, Dist. : Gandhinagar, (Gujarat), is as under:
otl.?ct tt?8l.?ott qa{q?qL ea ui ualeegr riarear qi sc{rrJL? l-r, "tdl dledlar rn&?"tr{r s{ig,?].n.r,rl. trr:r (o ctt.1u-oe-?oo9 rAa a" udl"!. ur{?r srris: ?].u.r{]. 3090 (rt) c ..or-1?-?ooe
utgriui Lrtd r,iltdla gt{ d6lla{trr, ocrls "i. rqqn, rr{e, a2ttcr- g{ r-ls, cu{: tu4la, .u.sctlcr,
R. critll"tcte, (qn?tcr) utl gQa rl.g{{i lt{rgrlsa 6d{eor (s.e.{ rll{.dl.{I.?l{. ell tgc.o
{x.dl.{l.rh.1 uurAd f{r<rr+ ultga itsala rrir -qGlg), })cr{l "fl,, {i qrq{l Q.qtLa E. f"tiuqriuaxl trBr ctls U"u.cq0 alyq.r{i rlrac{.
gQa u{talnarar Q+ctrrqt {r} uEe a1e gatcrg0"j r,u?rlva at. 13/ro/?o1o +i r-lqr nq.r) rr:yr{gettl, trate U.r4t6.gt.dl. o"srflarct rL+tlr{Irlrt+ elet, rcrf :{re, U.r,trJ.gl.r{1. slNrr il."?r,
U.{€t.gl.dl. 8atet, {}iltgu fl6a ?-ls, ar. scrfct, [i. ctitll"tcrr ({l'?rd) r,ui qfcrqr{t r{det. tr}rclr gategft e?rer4 acr? t}eti etlgl"0 ardl "{Itr lvor d.
Sr. No.
I {'tsName & Designation
"u{ raa. €lq]
Organizationruillageri+EUq.r.{
Signaturendl
Fc-t-.<-c<a ta- lJ- ?=l \ Gt l>'---/-z_ Ftrq,',lv N -s.ha..A
=L,l,az*Szq!3 V"IUh\J P \*L* Bi)edl,^v-o.*r, O n+u.,1.*tt1
I
\J
/7 ^ | -Jqumy'/fn0t ( 7hu/v ), 4 t.t|,.,.-
Page: f 0f t
:EllA.l-.
w\t7t
Guiarat Pollution Control BoardRegional Office,C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar - 382 010Website:
:w\t7tSr. No.
9{tEName & Designation
. atx r,ri 61e1
Organization/Villagett+s{./Jtt {
Signaturendl
-d\
$$\9 !1n1t5 t-lrqt2_ @4Ara--_
I J7-ft 'fo'"t- €tr <'rt Z-_ lZ'r-E
lo 0 la,sthe,.rDl o 6r4rpt* u .* S"l ilt\.te4^ @ao
\\ f,.n l*4.Cg"-.r,^) t{) *'n"s fi'nlL
t ' '/') e---J",' noh*; NA ,
I JttJ,Ltt- A\r DI(.L YYlt ls^w ,e]-rt
r-a't A^ZJralt'L {.
".p"s")l/\I
t((\r b^Ir c-lUlY,"-l 4>VL_\6 -ltfter" f"i'eri \t CJt"h-aJ.b'.e'l $:r\'@t.7 V t 5\ ,; o5 V.'it- 2^, U"-\ctr- ,W4l! n)1cu1g e rrlJqt j? *nqt_b
t7 s,\6 z S;-rrr -esJ -:,r 5aVR. >--' -Ct_:
l7 t\c'vqtdrt^( )-., 2--l t>r.r) t. ffi.ffi#,
lq -)&otr:l-Erltr.t-l Z',,rr2- ( -'tr;-)2a .\ . LV. - Or c- - 6H.{IJI<47 -1 lbl\\ )-'tx t ht ot )*-X-t ,
OI \--s)dr k2<1.r-, tl \2-u ut txl t-l lSuru,
Ofl.'l aqf- *r^o { Q>6T c1 12 i-t' \\.6t
Page:2 0f 11
Guiarat Pollution Control Board w\t7tRegional Office,C/o, Paryavaran Bhavan, Sector -10A, Gandhinagar - 382 010Website:
Sr. No.
sxisName & Designation
<Lu qa AEI
Organization/VillagetttEt/rtt {
Signaturendt
2) U)- .^'(u-zaa' cLr*^ pL^' -'(-'f4
P"+"L Joqx fA kJ"l EW2e Pd*-|"-l-.ie* . lir-ldh [r$4ft,aan .,€@?6 ?awcA^i Bkbzuld1,{ C 6^a,-ttu:2.-!.
/-'-'---">^-'=ryH/L4.9 q\ r<o-t J.+t etr -" r.t rFC! A 3dt :il-ttr,rrtl"\LJ
L{ BraL*$'A+ 1fr,tU;,, try: Katol W"'=2? (ztfticAb h'l\"S"9lX
r 56) axrr.rdarrr-vl
3o ItW el k a.lo-,^ rYA /.'qe\ f.c.'9c/,
?t .'Y..a;(e4^ l< st>5a., ' l4J,-l *J4-.g1_ Arw\ Q\cu4-{n 9--L1 F""l-t
"^q & qdtrr 21n0c41L frat3tt /rA.. I - /' I(YlcYzy<t4rt I Sn\ -1-' <',; (- lobr4n MI,J3f po^ ":.r1 N ?c-lJa Prcr ) de^'-l -
cAlo.rral Fo)c fttro. ,h^bLAtJO h4U-< hkr-r. h ' DL'tw,.j
1t' ./arn.UAn-,*' *L*\b-r,
)q' -J "'.'tD-il k PA*;rnoF| k"A
t"*-2@*ryP '
31 Sct sulfetl 2 ew-bn v^--j<--.af y,a r,.,t, h- 6e
Page:3 0f {
Guiarat Pollution Control BoardRegional Office,C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar - 382 010
w\t7tName & Designation
4r{ ?aa. €-lsl.
Jg-"rL P".lc.l - knLs-rsJ Fnvrs\a"r ti*tN
PuS\tr,t periS*a_5 Cf: n_>
Page: lr 0f \
Website:Sr. No.
sqisOrganization/Village
uNluctt}{Signature
+t6l
4o l*ht 41ffi42- A"t st-"it
t<r.\l.tA tcr'^ ts\Arf s4s
Gujarat Pollution Control Regional Office,
C/o. ParyavaranBhavan, Sector
Website: www.gpcb.gov.in
A statement showing issues raised by the participants and responses by the
representative of the applicant during the public hearing
As per the provisions of notification No. S.O. 1533(E) dated 14
subsequent amendment S.O.3067 (E) dated 1
Environment, Forest and Climate Change, Government of India, New Delhi, Public Hearing
was conducted for Proposed Expansion of
138.0 MTPM), located at Block No. 155/1, 159, Village: Dhanot, Ta. Kalol, Dist.
Gandhinagar, Gujarat by M/s. ORBIT PHARMA LABORATORIES
Category “A” of the Schedule 5(f) of the above referred Notification.
Public Hearing has been conducted
Association Hall, 1st Floor, GIDC
Road, Ta : Kalol, Dist. : Gandhi
Shri S. A. Patel, IAS, Collector &
presided overthe entire public hearing proceedings.
Shri D.C. Vankani, Regional
Member Secretary, GPCB; welcome
various provisions of the Notification and briefed the procedural details for conducting this
public hearing including the actions taken by GPCB for vide publicity of
including the advertisement given earlier in the local daily in English newspaper “DNA”
dated 12/09/2017 and in Gujarati “Divya
per the provision of Notification, only locally affected per
the public hearing while others having plausible stake holders may give their representation
in writing which would be included in the proceedings.
He then opened the Public Hearing forum after the due permission from
District Magistrate. He invited the project proponent
the presentation of their project in local vernacular language i.e. Gujarati.
Mr. Jignesh Patel-representative of project proponent welcomed the gat
power point presentation in local language i.e. in Gujarati covering technical information,
detail of proposed project, safety precautions, Environmental Management System, its
impact on environment along with proposed mitigation measures a
social responsibilities.
After the completion of presentation, Shri D.C. Vankani, Regional Officer, GPCB,
Gandhinagar and Representative of member Secretary, GPCB with the due permission of
Gujarat Pollution Control Board
C/o. ParyavaranBhavan, Sector -10A, Gandhinagar – 382 010
ANNEXURE – B (English)
A statement showing issues raised by the participants and responses by the
representative of the applicant during the public hearing
ation No. S.O. 1533(E) dated 14th September, 2006, and its
S.O.3067 (E) dated 1st December 2009, issued by the
Environment, Forest and Climate Change, Government of India, New Delhi, Public Hearing
Proposed Expansion of Pharmaceutical products unit
138.0 MTPM), located at Block No. 155/1, 159, Village: Dhanot, Ta. Kalol, Dist.
M/s. ORBIT PHARMA LABORATORIES, which is
(f) of the above referred Notification.
has been conducted 13/10/2017 at 11:45 A.M. at Chhatral GIDC Industrial
GIDC Shopping Center, GIDC Chhatral, Mahesana Highway
Road, Ta : Kalol, Dist. : Gandhinagar, (Gujarat) for the proposed expansion
Collector & District Magistrate, Gandhinagar supervised and
the entire public hearing proceedings.
Regional officer, GPCB, Gandhinagar and representative
welcomed all present in the Public Hearing. He outlined the
various provisions of the Notification and briefed the procedural details for conducting this
public hearing including the actions taken by GPCB for vide publicity of this public hearing
including the advertisement given earlier in the local daily in English newspaper “DNA”
in Gujarati “Divya Bhasker” dated 12/09/2017. He announced that as
per the provision of Notification, only locally affected persons will be allowed to represent in
the public hearing while others having plausible stake holders may give their representation
in writing which would be included in the proceedings.
He then opened the Public Hearing forum after the due permission from
District Magistrate. He invited the project proponent to give their introduction and to make
the presentation of their project in local vernacular language i.e. Gujarati.
representative of project proponent welcomed the gathering and made
power point presentation in local language i.e. in Gujarati covering technical information,
detail of proposed project, safety precautions, Environmental Management System, its
impact on environment along with proposed mitigation measures and industry’s corporate
After the completion of presentation, Shri D.C. Vankani, Regional Officer, GPCB,
Gandhinagar and Representative of member Secretary, GPCB with the due permission of
A statement showing issues raised by the participants and responses by the
representative of the applicant during the public hearing
September, 2006, and its
issued by the Ministry of
Environment, Forest and Climate Change, Government of India, New Delhi, Public Hearing
unit (3.25 MTPM to
138.0 MTPM), located at Block No. 155/1, 159, Village: Dhanot, Ta. Kalol, Dist.
which iscovered under
2017 at 11:45 A.M. at Chhatral GIDC Industrial
Shopping Center, GIDC Chhatral, Mahesana Highway
for the proposed expansion.
Gandhinagar supervised and
epresentative of the
. He outlined the
various provisions of the Notification and briefed the procedural details for conducting this
this public hearing
including the advertisement given earlier in the local daily in English newspaper “DNA”
Bhasker” dated 12/09/2017. He announced that as
sons will be allowed to represent in
the public hearing while others having plausible stake holders may give their representation
He then opened the Public Hearing forum after the due permission from Collector and
to give their introduction and to make
hering and made
power point presentation in local language i.e. in Gujarati covering technical information,
detail of proposed project, safety precautions, Environmental Management System, its
nd industry’s corporate
After the completion of presentation, Shri D.C. Vankani, Regional Officer, GPCB,
Gandhinagar and Representative of member Secretary, GPCB with the due permission of
Gujarat Pollution Control Regional Office,
C/o. ParyavaranBhavan, Sector
Website: www.gpcb.gov.in
the Collector and District Magistrate de
objections/questions from the participants present during the public hearing.
The statement showing issues/ suggestions/ objections/ opinions rose verbally by the
participants and responded to by the r
Public Hearing are as under:
Sr.
No.
Name and
Address
Points R
1 Shri Acharya Akshaykumar Rajendrabhai, Village Dhanot, Ta. Kalol, Dist. Gandhinagar
•
2. Shri Rajubhai P. Acharya Tal. Kadi, Dist. Mehsana
• He asked thatmany people got employment in the company and how many people will get employment from nearby villages when company will establish.
• CSR activities presented by company in this plant, how many
Gujarat Pollution Control Board
C/o. ParyavaranBhavan, Sector -10A, Gandhinagar – 382 010
the Collector and District Magistrate declared forum open for representations/ suggestions/
objections/questions from the participants present during the public hearing.
The statement showing issues/ suggestions/ objections/ opinions rose verbally by the
participants and responded to by the representative of the Project Proponent during the
Points Represented Replies from Project
He asked that, what is
the purpose of this
project?
• It is replied that, our industry is an API industry. It will manufacture API based pharmaceutical products and mainly it will be exported. This product can be used as medicine for various types of disease. In our existing unit we manufacture pain relief medicine and we give it to formulator. In our new project we will manufacture medicines related to human and animals.
• When our plant become operational we required around 100 personnel, for which we emploskilled/unskilled personnel from nearby villages through advertisement.
• CSR activities will be undertaken every year as per presented in project.
He asked that, how many people got employment in the company and how many people will get employment from nearby villages when company will establish.
CSR activities presented by company in this plant, how many
• It is replied that, around 100 personnel will be required in our new unit and will be employed from the nearby villages.
• Approx 18 villages of Kalol taluka and around 34 villages of Kadi Taluka were included.
clared forum open for representations/ suggestions/
objections/questions from the participants present during the public hearing.
The statement showing issues/ suggestions/ objections/ opinions rose verbally by the
epresentative of the Project Proponent during the
roject Proponent
It is replied that, our industry is an API industry. It will manufacture API based pharmaceutical products and mainly it will be exported. This product can be used as medicine for various types of
e. In our existing unit we manufacture pain relief medicine and we give it to formulator. In our new project we will manufacture medicines related to human and animals.
When our plant become operational we required around 100 personnel, for which we employee skilled/unskilled personnel from nearby villages through
CSR activities will be undertaken every year as per presented in project.
It is replied that, around 100 personnel will be required in our new unit and will be employed from the nearby villages.
Approx 18 villages of Kalol taluka and around 34 villages of
were included.
Gujarat Pollution Control Regional Office,
C/o. ParyavaranBhavan, Sector
Website: www.gpcb.gov.in
Sr.
No.
Name and
Address
Points R
villages from Kadi and Kalol talukaand whether it will help to local NGO or not?
3. Shri Dahyaji Kanaji, Village: Dhanot, Ta. Kalol, Dist. Gandhinagar.
•
4. Shri Rajubhai Rabari Village: Dhanot, Ta. Kalol, Dist. Gandhinagar
•
Gujarat Pollution Control Board
C/o. ParyavaranBhavan, Sector -10A, Gandhinagar – 382 010
Points Represented Replies from Project
villages from Kadi and Kalol taluka are shown and whether it will help to local NGO or not?
These numbers represent the villages present within 10 km radius of the project site.
• CSR activities will be carried out
in more villages and in future it will be carried out in nearby villages in consultation with sarpanch.
He asked that, what
you will do of the
waste water
generated from
company’s plant?
• It is replied that after expansion
total 31.3 KLD waste water
be generated which will be
segregated into two streams
namely concentrated stream
and dilute stream. Dilute
stream will be treated in ETP
and then evaporated through
single stage evaporator.
Hence, no waste water will be
discharged outside. While
concentrated stream after
collection, it will be sent to
common spray dryer facility
located at Chhatral and it will
be disposed after further
treatment. Hence, there will be
no discharge of any polluted
water from this unit.
He asked that
whether there will be
an impact on
environment of our
village due to release
of gases by the
company?
• It is replied that, as shown in
the presentation to control the
air emission from the proposed
stack pollution control
measures will be taken for
which we install equipment like
cyclone separator and bag filter
due to which emission level of
pollutants in air environment
will be below GPCB/CPCB
standards. Hence there will be
no adverse impact on
environment.
roject Proponent
These numbers represent the villages present within 10 km radius of the project site.
CSR activities will be carried out in more villages and in future it will be carried out in nearby villages in consultation with
It is replied that after expansion
total 31.3 KLD waste water will
be generated which will be
segregated into two streams
namely concentrated stream
and dilute stream. Dilute
stream will be treated in ETP
and then evaporated through
single stage evaporator.
Hence, no waste water will be
discharged outside. While
centrated stream after
collection, it will be sent to
common spray dryer facility
located at Chhatral and it will
be disposed after further
treatment. Hence, there will be
no discharge of any polluted
water from this unit.
It is replied that, as shown in
the presentation to control the
air emission from the proposed
ollution control
measures will be taken for
which we install equipment like
cyclone separator and bag filter
due to which emission level of
pollutants in air environment
will be below GPCB/CPCB
standards. Hence there will be
no adverse impact on
Gujarat Pollution Control Board Regional Office,
C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar – 382 010
Website: www.gpcb.gov.in
1
����� - �� 1 (�� ����)
��к ������� ������� �� � ��к� ���� ��� к������ ��� !�"�# $�� $� ����� %�����&
���� '����� ��� ���
ભારત સરકારના પયા�વરણ, વન અન ે પયા�વરણ મ�ંાલય અને કલાઇમટે ચે�જ, નવી દ��હ�ના
�હ રનામા !માકંઃ એસ.ઓ. ૧૫૩૩ (ઈ) તા.૧૪-૦૯-૨૦૦૬ અન ેતેના પછ�ના 3ધુારા !માકંઃ એસ.ઓ.
૩૦૬૭ (ઈ) તા.૦૧-૧૨-૨૦૦૯ અ7સુધંાને ��(() #���* +���) �����,*�-., 8લોક ન.ં ૧૫૫/૧, ૧૫૯,
છ�ાલ- કડ� રોડ, ગામ : ધાનોટ, તા. કલોલ, >જ. ગાધંીનગર, (?જુરાત) ખાત ે 3Bૂચત એકમમા ં
ફામા�DEટુ�કલ ઉGપાદન (૩.૨૫ એમ.ટ�.પી.એમ. થી ૧૩૮.૦ એમ.ટ�.પી.એમ.) JDતાિવત િવDતરણ
JોLકટ શેડEલુ !માકં -૫(એફ), ક ટ ગર� “એ” મા ંઆવર� લેવાયેલ છે. Lના ંઅ7સુધંાનમા ં�હ ર લોક
3નુાવણી યોજવામા ંઆવેલ.
3Bુચત પર�યોજનાના િવDતરણ માટ �હ ર લોક 3નુાવણી7ુ ંઆયોજન તા. ૧૩/૧૦/૨૦૧૭ ના ં રોજ
સવાર ૧૧:૪૫ કલાક , છ�ાલ O.આઇ.ડ�.સી. ઇ�ડDP�યલ એસોસીએશન હોલ, ૧લો માળ,
O.આઇ.ડ�.સી. શોિપRગ સ�ેટર, O.આઇ.ડ�.સી. છ�ાલ, મહ સાણા હાઇવ ે રોડ, તા. કલોલ, >જ.
ગાધંીનગર (?જુરાત) ખાત ેયોજવામા ંઆવલે.
સમS લોક 3નુાવણીની કાય�વાહ� Tી એસ. એ. પટ લ, આઇએએસ, કલેકટર અને >જ�લા મેODP ટTી,
ગાધંીનગરની દ ખર ખ તથા અUયVપણા હ ઠળ કરવામા ંઆવેલ.
Tી. ડ�. સી. વકંાણી, Jાદ િશક અિધકાર�, ?જુરાત JXૂષણ િનય�ંણ બોડ�, ગાધંીનગર અન ે , સ[ય
સBચવTી, ?જુરાત JXૂષણ િનય�ંણ બોડ�ના ંJિતિનિધએ લોક 3નુાવણીમા ંઉપ\Dથત સૌને આવકાયા�.
તેઓએ ઇ.આઇ.એ. નોટ�ફ�ક શન ^તગ�ત િવિવધ જોગવાઇઓ અને લોક 3નુાવણી J_!યા બાબત
સBંV`તમા ં મા_હતી આપી. તેમણે આ લોક 3નુાવણીની બહોળ� JિસaUધ ^ગે કર લ કાય�વાહ�ની
મા_હતી આપી અન ેDથાિનક દb િનક વત�માન પ�ો ^SેO વત�માન પ� ÔÔડ�. એન. એ.ÕÕ તા. ૧૨-૦૯-
૨૦૧૭ તથા ?જુરાતી વત�માન પ� ÔÔ_દeય ભાDકરÕÕ તા. ૧૨-૦૯-૨૦૧૭ ના ંરોજ આપેલ �હ રખબર
િવશે જણાવેલ. વfમુા ંએમણે જણાeEુ ં ક , નોટ�ફ�ક શનની જોગવાઇઓ અ7સુાર Dથાિનક અસરSDત
લોકો જ આ 3નુાવણીમા ંમૌBખક રgૂઆત કર� શકશે, જયાર અ�ય eયાજબી _હત ધરાવતા eય\hતઓ
Gujarat Pollution Control Board Regional Office,
C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar – 382 010
Website: www.gpcb.gov.in
2
તેઓની રgૂઆત લેBખતમા ંકર� શકશે. Lનો કાય�3Bુચમા ંસમાવેશ કરવામા ંઆવશે.
Gયારબાદ કલેકટર અને >જ�લા મેODP ટTીની પરવાનગીથી લોક 3નુાવણીનો Jારંભ કર લ. તઓેએ
ઉધોગના ં Jિતિનિધને તમેની 3Bૂચત પર�યોજના િવશે મા_હતી ?જુરાતી ભાષામા ં ijય Tાeય
Jેઝે�ટ શન lારા આપવા જણાeEુ.ં
Gયારબાદ ઉધોગના તકનીક� Jિતિનિધ Tી Omનેશ પટ લ lારા કંપનીનો પર�ચય, JોLકટની nપર ખા,
3Bૂચત JોLકટની મા_હતી, સાવચેતીઓ, પયા�વરણની eયવDથાપન પUધિત તેની અસરો અને 3Bૂચત
િનય�ંણો, ઉપાયો અન ેસામા>જક તથા આિથoક િવકાસ ^ગે ?જુરાતી ભાષામા ંijય Tાeય Jેઝે�ટ શન
કરવામા ંઆeEુ.ં
JોLhટના Jિતિનિધ lારા Jેઝે�ટ શન pણૂ� થયા બાદ Tી ડ�. સી. વકંાણી, Jાદ િશક અિધકાર�, ?જુરાત
JXૂષણ િનય�ંણ બોડ� lારા કલેકટર અને >જ�લા મેODP ટTીની પરવાનગીથી Dથાિનક અસરSDત
લોકોની રgુઆતો/વાધંાઓ/ અBભJાય/3ચુનો માટ મચં q�ુલો rકુવામા ંઆeયો.
લોક 3નુાવણીમા ંહાજર લોકો lારા મૌBખકમા ંરgુ કરવામા ંઆવેલ Jsો/3ચુનો/વાધંાઓ/અBભJાય
તેમજ અરજદારના Jિતિનિધ lારા આપવામા ંઆવલે જવાબો નીચે rજુબ છે:
0� !��� ��� ���1��
��� $�� (���!� ��� ����� ��� !�"�#
2&�3�� %�����& ���� '�����
��� ���
૧ Tી આચાય�
અVયtુમાર
રાL�iભાઇ,
ગામ : ધાનોટ,
તા. : કલોલ,
O. : ગાધંીનગર
• તેમણે રgુઆત કરતા pછૂuુ ંક ,
કંપનીની આજની આ લોક
3નુાવણી રાખવામા ં આવી છે
તો કંપનીની આ પર�યોજનાનો
rvુય હ w ુxુ ંછે?
• કંપની Jિતિનિધએ જણાeEુ ં ક ,
અમાર� ઇ�ડDP� એ.પી.આઇ
ઇ�ડDP� છે. ત ેએપી.આઇ. બેઝડ
ફામા�DEટુ�કલ Jોડકટ બનાવશે
અન ે rvુયGવે ત ે એVપોટ� થશે.
આ Jોડકટ અલગ અલગ
Jકારના ં રોગ માટ દવા તર�ક
ઉપયોગમા ં લઇ શકાશે. અમાzુ
હાલમા ં L Eિુનટ ચા{ ુ છે તેમા ં
Xુખાવાની દવા બનાવવામા ં
Gujarat Pollution Control Board Regional Office,
C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar – 382 010
Website: www.gpcb.gov.in
3
0� !��� ��� ���1��
��� $�� (���!� ��� ����� ��� !�"�#
2&�3�� %�����& ���� '�����
��� ���
આવે છે અન ે તેને અમે
ફો|Eુ�લેટરને આપીએ છ�એ.
અમારા નવા JોLકટમા ં પxનુ ે
અન ે માણસોન ે લગતી દવાઓ
બનાવવામા ંઆવશે.
• જયાર અમારો `લા�ટ ચા{ ુથશ ે
Gયાર અમને ૧૦૦ માણસોની
જnર રહ શે અન ે તેના માટ
આgુબાgુના ં ગામના ં
Dક��ડ/અનDક��ડ માણસોને
�હ રાત કર� લેવામા ંઆવશે.
• સી.એસ.આર. J}િૃત દર વષ�
JોLકટમા ં જણાeયા rજુબ
કરવામા ંઆવશ.ે
૨ Tી રાgુભાઇ
આચાય�,
તા. : કડ�
O. : મહ સાણા
• તેમણે રgુઆત કરતા pછૂuુ ંક ,
કંપનીની ^દર ક ટલા લોકોને
રોજગાર� મળ� છે અને આ
`લા�ટ બનશે Gયાર
આgુબાgુના ં ગામના ં ક ટલા
લોકોને રોજગાર� મળશે.
• કંપની lારા આ `લા�ટમા ં L
સી.એસ.આર. J}િૃતની વાત
કર� છે ત ે rજુબ કડ� અને
કલોલ તા{કુાના ંક ટલા ગામન ે
દશા�eયા છે અન ે Dથાિનક
એન.O.ઓ. ન ે મદદ કરશ ે ક
• કંપની Jિતિનિધએ જણાeEુ ં ક ,
અમારા નવા `લા�ટમા ં ૧૦૦
માણસોની જnર�યાત રહ શે અન ે
તે આgુબાgુના ં ગામમાથંી
લેવામા ંઆવશ.ે
• કંપની Jિતિનિધએ જણાeEુ ં ક ,
કલોલ તા{કુાના ં tુલ ૧૮ ગામ
અન ે કડ� તા{કુાના ં આશર ૩૪
ગામનો સમાવશે કરવામા ં
આવેલ છે. આ ગામોની સvંયા
JોLકટ સાઇટથી ૧૦ _ક.મી.ના ં
Gujarat Pollution Control Board Regional Office,
C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar – 382 010
Website: www.gpcb.gov.in
4
0� !��� ��� ���1��
��� $�� (���!� ��� ����� ��� !�"�#
2&�3�� %�����& ���� '�����
��� ���
ક મ? િવDતારમા ં આવલે ગામની
સvંયા છે.
• સી.એસ.આર. J}િૃત વf ુ
ગામમા ં કરવામા ં આવશ ે અન ે
ભિવ�યમા ંપણ નOકના ંગામના ં
સરપચંની સાથ ે મળ� કરવામા ં
આવશે.
૩ Tી ડાહયાO
કાનાO,
ગામ : ધાનોટ,
તા. : કલોલ,
O. : ગાધંીનગર
• તેમણે રgુઆત કરતા pછૂuુ ં
ક , કંપનીના ં `લા�ટમાથંી
નીકળતા ગદંા પાણી7ુ ં xુ ં
કરશો?
• કંપની Jિતિનિધએ જણાeEુ ં ક ,
JDથાિપત િવDતરણ બાદ
`લા�ટમાથંી tુલ ૩૧.૩ ક .એલ.ડ�.
ગXું પાણી ઉGપ� થશ.ે Lન ે બે
DP�મમા ં અલગ કરવામા ં
આવશે. (૧) કો�સ�P ટ ડ DP�મ
અન ે (૨) ડાય�Eટુ DP�મ.
ડાય�Eટુ DP�મને ઇ.ટ�.પી.મા ં
P�ટમ�ેટ કયા� બાદ િસRગલ Dટ જ
ઇવેપોર ટર lારા ઇવપેોર શન
કરવામા ં આવશ.ે Lથી કોઇપણ
પાણી બહાર નીકળશ ે નહ�.
જયાર કો�સ�P ટ ડ DP�મને
એકિ�ત કર�ને નOકના ંછ�ાલ
ખાત ે આવેલ કોમન DJ�ેાયર
ફ સીલીટ�મા ં મોકલવામા ંઆવશ ે
અન ેએ લોકો વf ુP�ટમે�ટ કર�
તેનો િનકાલ કરશે.. Lથી આ
એકમમાથંી કોઇપણ ગXું પાણી
છોડવામા ંઆવશે નહ�.
Gujarat Pollution Control Board Regional Office,
C/o. Paryavaran Bhavan, Sector -10A, Gandhinagar – 382 010
Website: www.gpcb.gov.in
5
0� !��� ��� ���1��
��� $�� (���!� ��� ����� ��� !�"�#
2&�3�� %�����& ���� '�����
��� ���
૪ Tી રાgુભાઇ રબાર�
ગામ : ધાનોટ,
તા. : કલોલ,
O. : ગાધંીનગર
• તેમણે રgુઆત કરતા pછૂuુ ં
ક , કંપની lારા વાતાવરણમા ં
L વાE ુ છોડવામા ં આવશે
તેનાથી અમારા ગામના ં
વાતારવણન ે કોઇ અસર થશે
ક ક મ?
• કંપની Jિતિનિધએ જણાeEુ ં ક ,
Jેઝેનટ શનમા ં દશા�વયા rજુબ
આ JોLકટમા ં L Dટ ક આવશ ે
તેમાથંી L વાE ુ ઉGસ�ન થશ ે
તેની મા�ા7ુ ં િનયમન કરવા
માટ JXૂષણ િનય�ંણના ંપગલા
લેવામા ં આવશ.ે Lમા ં અમે
સાઇકલોન સેપર ટર અન ે બેગ
ફ��ટર Lવા સાધનો rકુ�x ુ ક
Lનાથી Dટ કમા ંO.પી.સી.બી. ક
સી.પી.સી.બી. ની િનયત કર લ
મા�ા કરતા ઓછ� મા�ાના ં
વાE7ુ ુ ંઉGસ�ન થશે અને જયાર
તે7 ુવાતાવરણમા ંિવસ�ન થશ ે
અન ે તેના લીધે વાતવરણ પર
કોઇ આડઅસર થશે નહ�.
Gયારબાદ Jાદ િશક અિધકાર�Tી, ?જુરાત JXૂષણ િનય�ંણ બોડ� ઉપ\Dથત જનસrદુાયને જણાવલે ક ,
લોક 3નુાવણી અગાઉ અ�ય _હત ધરાવતા Tી મહ શ પડંયા, પયા�વરણ િમ�, અમદાવાદ તરફથી
તા.૧૦-૧૦-૨૦૧૭ ના ંરોજ લેBખત રgુઆતો મળેલ છે. આ લેBખત રgુઆતો એનેVર C-Q-1 તર�ક અન ે
ઉધોગ lારા આપવમા ં આવલે લેBખત જવાબ એનVેર C-A-1 તર�ક ?જુરાતી અને ^SેO તર�ક
કાય�3Bૂચ સાથે Bબડવામા ંઆવશ.ે
કલેકટર અન ે >જ�લા મેODP ટTીએ જણાવેલ ક , કંપની lારા �ગૂ�ભ જળ �ોતનો પાણી વપરાશદર
વધાર હોઇ નમ�દા ક નાલ ક અ�ય કોઇ પાણી �ોતનો ઉપયોગ કરવો જોઇએ તથા JXૂિષત પાણીનો
ઉ�ભવ જ�થો ઘટાડવા JયGન કરવો જોઇએ તથા �ગૂ�ભ જળની ?ણુવતા જળવાય ત ેમાટ પગલા ં
લેવા જોઇએ. વfમુા ંતેઓએ જણાવલે ક , ઉ�ભવતા ઘન કચરાનો કાયદા rજુબ eયવDથાપન અને
Annexure – C-Q-1
From: D.C.Vankani, RO-GPCB,Gandhinagar [mailto:rognrgpcb@gmail.com] Sent: Wednesday, October 11, 2017 3:42 PM
To: info@orbitpharma.co.in Subject: Fwd: EPH of M/s. Orbit Pharma Laboratoriesat Block No. 155/1, 159, Village: Dhanot, Ta. Kalol, Dist. Gandhinagar to be scheduled on October 13th 2017.
Ref: PM/MP/EPHC/2857/2017 Date: 10/10/2017
To, Member Secretary
Gujarat Pollution Control Board Gandhinagar
Sub: Environmental Public Hearing of M/s. Orbit Pharma Laboratoriesat Block No. 155/1, 159, Village: Dhanot, Ta. Kalol, Dist. Gandhinagar to be scheduled on October
13th 2017.
Sir, We have studied the draft EIA report of the above-mentioned project. Following are
our observation/comments/questions regarding project and draft EIA report.
1. Whether company has been issued show cause notice / closure order / notice under water act 1974 or Air act 1981 or Environmental Protection Act 1986 since starting of existing unit? If Yes, then please give copy. What remedies had been
taken for restarting operations?
2. Whether company has valid consolidated consent and authorization of GPCB under various acts for its existing unit? Please give CCA and compliance report of consent and authorization.
3. What was the previous land use of the land for proposed project? Has Industry
obtained NA permission for the land? Please provide the document. 4. Please give copy of the GPCB visit report and air / water / solid waste sample
analysis report for the existing unit in last three years.
5. Whether unit has submitted Environmental Audit reports regularly to GPCB for existing plant?
6. Is there any cost-benefit analysis carried out for proposed projects benefits vs loss of ecosystem including flora, fauna and vegetation?
7. What is the regular monitoring plan that shall be carried out for odor control by
the project proponent? 8. How will the project proponent plan to get coal / wood waste / agro waste as a
fuel in regular basis? Please provide any agreement made with the supplier
9. Please give exact dates of ambient air quality, surface water, ground water, noise monitoring and soil quality monitoring.
10. Please justify domestic water requirement for existing and proposed expansion.
11. What types of precautions will be taken for storage and transportation of hazardous material and waste?
12. Please give name of an authorized re-processor to whom used oil will be sold.
13. Please give name of an authorized recycler to whom discarded containers / barrels/ plastic will be sold.
14. What will be the impact of temporary housing availed by labors during construction phase on surrounding environment?
15. What will be action plan for socioeconomic development of an area by project
proponent? 16. What activities industry will take up as a part of CSR and what will be the budget
for it?
17. Please give detail list of people who will be responsible for implementation of EMP?
Yours truly,
Mahesh Pandya
CC: 1. Collector, Gandhinagar 2. Regional officer, GPCB Gandhinagar
Paryavaran Mitra 502, Raj Avenue, Bhaikakanagar Road
Thaltej, Ahmedabad - 380059 Telefax - 079-26851321
email - paryavaranmitra@yahoo.com website - www.paryavaranmitra.org.inv
A.nne;rtre - c-A -1(enjtfuhT
@oRBn i|FG. OF BULI( DRUGS AND INTERII|EDTATES
Block No. 155/1, 159, Chhatral - Kadi Road, DHANOT - 382 729.Ta. Kalol - Dist. Gandhinagar. Gujarat (lNDlA) Phone : 02704 - 234 093
ToShri Mahesh PandyaPryavaran Mitra502, Raj Avenue,Bhaikaka Road,Thaltej, Ahmedabad-3 80059
Date: 12-10-2017
Subject: Environmental Public Hearing of M/s. Orbit Pharma Laboratories at Block No.155/l , 159, Village: Dhanot, Ta. Kalol, Dist. Gandhinagar to be scheduled onOctober Ba 2017
Reference Your Letter No. PM/MP/EPHC/2857 /2017 dated l0-10-2017
Dear Sir,
Answers to your query are as under:
Sr.No.
Question Answer
I Whether company has been issuedshow cause notice / closure order /notice under water act 1974 or Air act1981 or Environmental Protection Act1986 since starting of existing unit? IfYes, then please give copy. Whatremedies had been taken for restartinsoperations?
Show cause/ closure order / notice and itsremedies are given in annexure-1.
2 Whether company has validconsolidated consent andauthorization of GPCB under variousacts for its existing unit? Please giveCCA and compliance report ofconsent and authorization.
For CCA Please refer Annexure-Xll of EIAreport (page No. A-31 to A-38). CCA compliancereport is given vide Annexure-Xlll of EIA report(page No. A-39 to A-42).
l What was the previous land use of theland for proposed project? HasIndustry obtained NA permission forthe land? Please nrovide thedocument.
Proposed expansion is in existing premises, henceno new land is purchased, land document is givenin annexure-Il of EIA report (page No. A-10 to A-I 3).
t
@ORB|T IIFG. OF BI,LI( D||UGS AND INTERT,IEDIATES
M,n$l raKar,Nn I RR/l r ao a.kr-TT|E'I , , I we, vr || r€[rilr _ t\aot i{oao, UHANoT _ 3l0l - Dist. Gandhinagar. Guiarat NDIA) phone Iol:/ea-.
)2 729.l?, noa
4 Please give copy of the GpCB visitreport and air / water / solid wastesample analysis report for the existinsunit in last three years.
GPCB visit report and air / water / solid wastesample analysis report are given in annexure-ll.
Environmental audit is not applicable to our unit.
Environmental cost benefit analysis was notrecommended at the scoping stage; hence costbenefit analysis is not carried out.
5 Whether unit has submittedEnvironmental Audit reports regularlyto GPCB for existing plant?
6 Is there any cost-benefit analysiscarried out for proposed project'sbenefits vs loss .of ecosystemincluding flora, fauna and vegetation?
7 What is the regular monitoring planthat shall be carried out for odorcontrol by the project proponent?
Odour Management Plan is given in section10.1.1.2 of EIA report (page l0-3) monitoringschedule as per plan given in Table 6.1 of EIAreport (page 6-l )
8 How will the project proponent planto get coal / wood waste / agro wasreas a fuel in regular basis? Pleaseprovide any agreement made with thesupplier
Cunently coal / wood waste / agro waste is beingpurchased from local market based on qualitv andavailability.
9 Please give exact dates of ambient airquality, surface water, ground water,noise monitoring and soil qualitymonilorins.
Exact date of monitoring are as under:
o Ground water samples: 25-12-2016r Surface water samples: 25-12-2016o Ambient air quality samples: 03-10-2016 to
04-01-2017r Noise monitoring: l0-1 l -2016 to 25-11-2016o Soil quality monitoring: 25-12-2016
l0 Please justiff domestic waterrequirement for existing and proposedexpanslon.
Consider 35 liter per capita per day waterrequirement.
Existing l9 people, hence water required
=19t35:665 lir/day=0.65 KL/d
Manpower required during expansion will be 8l ,hence water required
@ORB|T MFG. OF BULK DRUGS AND INTERMEDIATES
Block No. 155/1, 159, Chhatral - Kadi Road, DHANOT - 382 729.Ta. Kalol - Dist. Gandhinagar. Gujarat (lNDlA) Phone : 02764 - 234 093
= 2835litlday=3KL/d
Please refer Section 7.2.3.2 of EIA report (page
7.5 to 7.6).
Refer Section 4.5 of EIA report (page 4.10 to4.1l).
What types of precautions will be
taken for storage and transportation ofhazardous material and waste?
Used oil is reused or send to re-processors inpremises.
Please give name of an authorized re-processor to whom used oil will be
sold.
Name of an authorized recycler for discardedcontainers / banels/ plastic is M/s. HindustanEnvirolife Protection Services Ltd.
Please give name of an authorizedrecycler to whom discarded conlainers/ banels/ plastic will be sold.
Refer Section 2.8.4 of EIA report (page no 2.34)and Section 4.9 of EIA report (page 4.13.
What will be the impact of temporaryhousing availed by labors duringconstruction phase on sunoundingenvironment?
What will be action plan forsocioeconomic development of anarea by project proponent?
Refer Section 8.2 of EIA report (page no. 8.1).
Refer Table 8.1 of EIA report (page no. 8.2).What activities industry will take upas a part of CSR and what will be thebudget for it?
Please give detail list of people whowill be responsible for implementationof EMP?
Refer Section 10.4 of EIA report (page no. 10.10to 10.12).
For Orbit Pharma Laboratories
(Authorized Signatory)
ll
12
l3
14
l5
lo
tt
(z
@ At l e*qre - c- A - 1 [C.l.icra.rtil
r|FG. OF BULI( DRUGS AND INTERI,|EDIATESoriBnBlock No. 155/1, 159, Chhatral - Kadi Road, DHANOT - 382 729.Ta. Kalol - Dist. Gandhinagar. Gujarat (lNDlA) Phone:02764 - 234 093
uG,gll
'rdqr r.isq r
uerfqaer Eq,uoe, etv elc)-g,rrlgststq.re e)s,etcid.t, ?trtretqte - 3cc- oot{c
o tilra : qe.qo.eoqo
Gqat:rrt)olTatgrfdor))aJll, oc{)s"i.qqq/q, qqc-, rrq:atq)a cttgs],5c1)cl, Uc<rt,ctitJlqcte,gverc ,,rrd qg"' ot'lsalote eoqo orte)q qlvqrJl uqfqae0q cr)s go torell
aieol :ur rq*ll"r'.| qq sq is .leiq/?iq{/4fti4+[l/ecqo/eoqo d t. qo. qo. Qoqo
lio)e?r sil,
efltrtgilott 6.{a)sd vqc) uc4rt?.fli U.r<,r d.
aq vq ucgd"
q A=,q.ilai3 EEI cqr?eil 5u4d cr)za zisaqcou ?rerqr aie risa qc-cq ?rzlcll
,..rq fc]eer ( g"al) €rl?) qc-cq ztic"fcl
sr?erecfs q)dla/se)Ia ar){e/.idlacrvqqrqi ztrrdcr rlt Q or, cr) qsci
"gsa). uiu)qrq saleil qr? seqt ,lt) sqt6qta) seqtri ?dtcat?
sraerects q)dld/scr'tr:a Ur){e/-l)da6utq) ulQre-q 'ri eqrlc)cr d.
clq r
? E=uAulrl a"1t qcfqt.l ris'r .lr) RG€r
sreret?ri) aricrclcr g{hilo[) j }ils?.I
s)-a)cil3)s s-J-a erd z'r)et)erEtqrq drs-i-a zrd z'r)er)ergiqrq4 +iltilai z'id
slrc{ letoa ilq)J aq sd.
rilzilei ,rr) u?n€t?i ilqlJ:i zidae-qe Qqt
G"iG. luro "i. ei-aq eil ai-sc ). ?ihihisRcrqo?r ilq)d uaar€Jzi elu)d.lr ?idae-qs(uro .i. d-ac- eil ai-ue ) qi ?'lrle r).
3 yr.-rrGa v Qer)"tq r trr) UtJrr64 .tilqdcrero $ ecflr g dq4J "rlil.l qr) ?iqeiueqrqrll lqdcr ilr er.rrdg garot agseqr fA"iG.
y ?.1R;-G ?.Rpt ctcf,ltq ?e]('l q? ct erql:i
c)cr reil qcil qrilq qJeqr4 w3e oeil. vrilo'rrgercir zidae-e (qtq "i. :i-c- ejl ri-q:) qi
zrrlQcr d.
@oRBn r|FG. ('F BULI( DRUGS AND INTERTTIEDIATES
Block No. 155/1, 159, Chhatral - Kadi Road, OHANOT ' 382 729Ta. Kalol - Dist. Gandhinagar. Guiarat (lNDlA) Phone:02764 - 234 093
d U\n?floil"il ?Eo Scrlsldol) ?)idqlcr uaqcfqtq zisrr.'rt dc<l t lel qd
ocr/ureil/a)Crs d*aqr ziqrRr?ila e1u)d egseqr G"iG.
v$ril"il.il enr.tr Ucrtsrdq) erdqtc'l zrrd
eqr/,rrell/a)Grs deadt ai.irGrJla elq)dy lQrta-r rri eerfdcr t).
o
r_l
s
a
-g
asl aor qcfqtq urt-aqt rlc<rt qet qdql
?)"q rq?l-acl zrr)sla ilv)d gril+iloilriGqllc ilct "rqt setdcr t)?
arr.{rer ?isqd ?i "cl tq ?l -ecr ztilslla dod crtg
us5i .reil.
ur.r--rGa vt?.r).vrqdr tr.leru) {A iqtqd?,.{G, yte "r:tcd aote Ssato tit2
s'lea-ci"flsla riqrRrJl+t seqtqi urdcr d?
rsM'"r o.rsst e?ltllq s)ra-ci.lltlaeidrR?ila4 crcttret seqtqi airc)cr dei), deil
s) ea-ci.ilsl a zidrRr?ila saqtqi ?xtdcr qeil.
..{ l?el)"tqtq-qtq t w)"1-a dl"l "ia Geiaer :r r)'r) |
Gallc ql"ilae'lcr urr.i $ t)? |
,rQet)tat.tt y,r).t') cr(ndel celd
s'\cral/qs c)+a/dq) d+a G?rGc {asgild -lcnqc) z at<rtala ate)'l) 5"1? ?g
lsaqr G"iG.
ffi el.t)ddt [ac.lr"r
qo.q.q.? (tlt.t "i.qo.3) errd T )'ilail-cr lQrsgcr
s)uas q.r (qlq .i.E.q ) '1i uricr r).
c)raleitJ) c)€ telrGs c'rva'lieil tadeclttri
:rr rc) t).
eerr.r,ri cildcr d. ]
€rcrri qc- ca lFcrarr) d, ")ail qreil'il vlQettc :
qc- x e,{ cil. = Egu cilae uG lEqa
= o.EuBcr) cilaa YG Boa
@'ro,et'to{qro, altqt./i q).ilzil.r zid "rril'l"il gelqrlldll
4).ila?:l"r.il.-?l){611 cr rill.'l'l'fl z) 3v<''r d.
airaqta"il cot4 getortt: o3.qo.?oqq erl
06.oq..?oqo
aur83! vut: aq.q?.eoqq
SJro{ qrrrt: aq.qa.eoqq
?rtcl|ct:i tr)4adtr: qo.qq.aoqq E]
?q.qq.?oqE
"rril.r.il gerortt: ?q. q?. ?oqE
ffiureil"il taE.ilt
c- zrrreura"il 6qt"il gQlcrdl, avlel:i c/o,
cltrof "ytn, urq r.r.i ,r).ila?Trr zid "ri]d"il\>.
"]etq.rt.lt ,l).ilzalltr'[l at) ssa crrdt'i afituclt
x.^looi lcl.
qo qcfrtr.t ?isqqt errd urdtfclcl lcl?d?eldl
algi vreil4 w3l?arcrd cal'rc'il daqqt
0"iG.
@oRBn MFG. OF BULI( DRUGS AND INTERMEDIATES
Bfock No. 155/1, 159, Chhatral - Kadi Road, DHANOT - 382 729.Ta. Kalol - Dist. Gandhinagar. Gujarat (lNDlA) Phon6:02764 - 234 093
Gtreer cate cq ca fFarrr).il "r?e usr),ureil"il v1Qato :
eq x s,r cil. = ?z3q cile? uG Gqa
= slEcr) cilaa YG Gqa
ldcrtttt ,o.e.s.e (uro "i.to.u ei)
o.E) urd fdctrt"t r.q (ut.t .i.x.to erl u.qq)
dcrr O"iR.
ldlJacr zid saetdt ri:to zttd''.t liqeq qr) sar uste"il arqr)cflarr)
err4qr4i Urtqq) ?
gts ui)-ildrt"ilri g.r :6ua)cr erdur 1?1.r
al-u)adq r seqrtti ?fird d.g:rs.rr)ucr Qqd .l)sctclrqi zrtroqte r) ?iclt
:rrl?r1cr e1-v)ad.rt qtr zrttul.
ds s-aud"/ciac+/rcrtlEsrr) z'r
el-atascie iazf Ggrcrro zi'<ile)Gttts
u))serc aOrfla GrG)s r).
sltsrJs s-)U.re/<iec;n/rcrfDsq)seqtqi rdtqdte d zicrr +r[014 el-
arqscr{qt ortq ut,.i.
u?,1rrj?i "luUq)
fdcrt:t l.c'x (qlq "i.?.3u )
ard l0crt.t u.e (qld "i.r.n:; dqr O"iG.c,rittstqqt dcrtss I e?rqlol el lls) dl?l
c.rrtll tr'lee) aBqr"il carq?el t lqqqt{iarrrqq) d4 ut?|r{l?loll ,.lqlqaet ue 3i uaevse) ?
€Ju ru?i ilu)dq) [Oc'ttct z.l (q14 'l.c.q ) qlql
-Rrr)qr.il"1r
yu)q-a dt?t Ordteqr
arrtgs-artlDls Gsra ltr) $ a)er'rr tlruerrEd elu)Jg s)tas e.q (vt'l "i...e) qiql
azrre etio"fo du"i) su ucl
dg caia g cdrffi"i.qo.qoeilto.te) Qor lO"iG.
I oi.rci ,{) qrqK4ER ca lFaur)4
Gorc) eS seclr 0"iG'
?rt(tt? ?l€,
qcfl, ot)olTa ttqf dor)laJl
erGrqc adlscI
H6.
oe
or(BlT
GPCB lD: 28133
To,.l
hc Rcgional ( )l'llccr.(iu.jarat I)ollution ( ontrol Iloartl.(iandhinagar
K.lrti Al,ent :l'irir l''. r. r'1. '.ii.-.Subiect :('otnpiiatttc ol Vi.tiReference : (iP( li Visit. <lated:
it. L,!ri I
In.l I I i( l lr ,rlt;
I ll,/l t)i I {) | (r
MFf: i.ri: BUl..K DRUGS Ary9-LryI_E-lMEDla r
.r, -.i. r. r' 'i : I . l:):l C i",l]alral-Kadr Foar'. DHANC-I-3eZ
' 1'..! 'l i.,' G:rr:clll.r.igai, tJU'jAHAI (lNDlA) Phone (02764)234
DATE: 2ll10/20t6
Yours laith full;-.For. Orbt Pharma Laboratorics,t/
u/w'Authorized signatory-.
iqaral Pollrition conifol 80doSoc{or No. 10 A,
O.ndhlMlar. 382 010
Respected Sir.
In connection to above rrrcntionc,.i snl'jcct. \\r rrould like to draw your kind attention as
per lbllowing
Sir. as pcr vour kinrl suggrslion rrt rrill :rpplr lirr ( ( \-llcnoral to lour board nithin l5
dar s.
Sir. kindlr notc th t lc hrrc irlleirtlr prorirlltl atlet;ruttc SNll'at ncn lllR boilcr. l)hoto of'
thc sanre is atlachetl hcrt.rr i(h.
Sir, kindll n()t{j thirt r)ur l)unrl):rtlll('he(l lrr rcIrrlrlrr.r'rrrtr in ntiiintcnancc at the tinrc 0ftrrur
risit duc to that scrulrhcr'\rr!\ nr)t ilr ur. r:rrrl pll ll ser'ulrbcr ntcdia uas obscrr c<l acidic. rrVe
h;:i* r'cctifierl rhir Problcnr rritlrirr shrrll lirrrc allu rour risit:rnd *c have maintrined pll of
thesamcantl lcrrill nr:rintlrin tltc sutttr irt ltitute toc.
So. kindl;" cottsidct abovc all irr r orr r('r'{r'(l plia\c.Il'you requirc anr rlorg ilctails grlclrsc c:.rll on rrs.
'[hanking you. ('opr to,Shri .t,H.l ciitlu sirI' tt it hcftl-(;utrdhiuagu,Gui(rut P. lulitrn Control Bounl,
Gantlhinagar
oe
orGlIT M F_9. 9.r.. 9.y !5-,Dj_qg_s_ x s I N r E I r\,rE o I A r
Works: Block No.l55/1, 159' Chhatral-Kadi Boad, DHANOT-38zTa. Kalol, Dist. Gandhinagar, GUJARAT' (lNDlA) Phona : (02764) 23
Adequate SMF at new IBR boiler
(nlm url eucr e.rqr"il rlueln (oildlu)
oi. : -t f{ 3J
qre0 ufdtGgr tgqr- :ctt-+3, r'<ii r,'i:iilr.l! ,rr:z9..ii .,r1{-en eld u:rioeer (geflr)zrErGtax-r<-cgofl sol*qo dscr errri'.,1 r!,-;-! ..r,.:i .iii ,',ilr; ..ii9 fldl *tate rart)i "r1{l crn'l
i"ll AOtq crdi aatl axe) "ltr).1 dqu) ,'l ,,lr.i: ,yri_lill Ltr4c1 er.ll,t'l Uii aqta Se"ltllt)uBsre eerdld dh;t.
,..,, (1) ut{)d al'itrr atrru c'r)s-d.q u?5r-:.r lir.'ri'.1 qra.i (r) ul< s)d sreti.a",r.t.lor, 14 .r .-* , ,.: a,.c:.it:,t-r 3a qqtqqtott d uEqt ul
urlAGatr rder.tr .l dgrrr ticq ilr,'lrirqt i,:'t..ii ?'!! .f .-r ii't Gl er r1 Cotn <rr"rrc)c{l t)d 'r)dlg"ll,' siatl t)eJ gs.a"il, arrtqr"il 'r'tpr(l e,trr''r, ',r;; ;-,1fi15 y1r1'31nil std Qrrqrd"j qtc{ot 3?cI{iutcl eqi ddutctotsl.ltri '1;;,:,:i 1c I 'i.11 ,,',,.i:3i:r.1,,{! t)q}tt:.
(3) lirj * i-'.r.4 ,r1r;-,i,, ,'1111,, '1' ', . r:. . . . r .'(ir,.r .,Hj,rgr t ldtl s'ld {e<<r.fl drd"ildqta 3eqr ui <1.{l sa)dl aecl.'l dc1 ri,;: r.rer.rr .i .y:rrui id rlll rlaqr"l st?ut 6\q }arr srarer i d docn s)crr Gtu{i 1.rca siri .)1.{'! :'?.rt4i ?xrcrr) d urgqt Eqtdl fur{ei e,idl skj.r:atr"ll rsdl clqt qra rni .l."i rjiq ar*rqrol 5t"r}t 6-).t 8 ril srael i A.de('| gleGat{) detn lQrarurn s'19 r1.r) geri"ir .ier.r), .i.tr at€ior ar.rr,fi, uilGr)llts qFa, lgi,?Ula?, €t(|lc)qt rltEclt l,|od rt(.|cqoil q..rl i;(4.,i c){rr }'rl ul "lld cyudc{ a{a erri<tett,ril dld,&1)at/ster4tdr{i etrae aqr.a'l ?trr: ?:1r..,,'rlr}1t,..dlr {.i ;lr5cJll, ayQ t 190 1*t1ufrl{l iltc) a6lq xt) .lld"il ,rr{&rli qr,; d.
,,.., .., t,
r....Jtl.:....+.:1..J......: i.i:. .. . . :.. ' ,'
"-', "'lo ltt.t*t1 ,' V:
L,':,' ', ,i ;'f4'
'((A PPnaL'J- i')
, . /n L414 ,2Ul -
r.................,.. I " 1t ) t'''()' "- ertut-o*I r'il(t )tr4ti ' '',,1''"lrr[,^t', ,r!,, (A/ {)rldf;.3.................... ,1 .-.r.r., ,rtliurr{ '|i,,,}r 4rL/tltdl.
;l ",.tt- s' vzi' '*'t*t-'6 )
,4 ,3 ".-,1 -r..',, . 't{:" !)r "- '' t av\t/ '
- li A-l | .151t(1 t\ir1tt /'l;t | ' '/' hVuR, ...1.X..t....j1i.11.1.,1.... .. . . ,. ,,ro: :- //' / _ ii,rlisii"i <r>r:- ,t)*t' 5fr"*t f'U
CRBIT'fHARfrlA-ii'Atit,RtqtOq'F'j old - >1 ' U"€J'
1i511 1:.3 il.i,:.1.ir 'i'.::i, jii;.....,D}i*;" j.,....-i,...,.,, iu,,',.r.;
0ir1. Sannir:,,ragar
.r..{"r.! ,
\,!r\'- r-r i-'
ols q5s lds d.ut rgot 1da1n1 ioo"rrr'il ldr '-
cJcrrlcl uRqul heirlel or)Cvrdlirs siil : clieilopn ffi\Zc/o'uqfqret oteot', t)5?? ro-rl, oti€ilou?-34?oto. : (otoc-) Q3e eaoc-g
Website : httpJ/gpcbxgn.gujarat.gov.in
Grrria uD eucr qct"il q1qol (oildla)
;. tf aLL-Jqreil uGBq4 qc-.gu'il sc{q-a3, cqr urlEGqr qc-eq"fl scrq-au urd qeriqeur (gear1url?rGuer-rc-eqoil sq.{-qo dotn urq)d qricr arr"il 3i urr) .lF) adl seqre ur{)d qrlil crrc'l
d'il aerq crdd dqrq arra) 'ilr)q r Bgur) rrrl uruo qraerrrri eFlcr q.rtq) ud drrru sect.r'lorlEsre qer.ihi €thi.(q) urq'ld il)ticr r er"rrr crr)i-dqq aasreori srri tlrv.rqrorr dg rr r).(a) urrqr s'ltJ srqf t,rvqqrorr d C lrr ud drr e)q c) stl Cli qqtqqrqt d uetqt ul
url?rGqq urerqr d dour slcrr Gqq)"fl uercr ?{r urlEGrefi doq orxc)c{l s'ltJ .t)a1la'il,
slcrr s)d gsa'il, urder'fl raqqr un)crr s)d urlCrsreuq.il s'ltl dcrqrd.'j uraor seereri
ut.fl aQ d 3 trrcrd seqrqi rarql t) 3 3q d .rssl se.rror dg rrtd.
(3) s)d arer.r arqcjl, rr)€r) lSrs rc{raa, lsi, eg+ae, ecdr.)qy edprcrt ur"er s)el rroctr"fl or<3"i)
dqrd s?qr urd d"il sa)dl se.rr.rr dg rrd ura.rr i qcttt{i id dq qrqqrd steet €)et }rrr 3rqer 3 i dorrt slcrr Gql) yrca s)d
"J.r) se.rrqi urr.rr) t} urer.rr q.rrof) dqrilqi d,
dcil s'kl qrrqr"fl lsdl c)qr qr) urd di aiq rrdcrd sreer e)er d rir sr?rer * d ds(,| slcrEqq'l ds(,| Rrarurq s)tl c1.r) sai.r) ger.r), dqr aEr'r arqcjl, ur)q)l5rs larr-a, lsi,?Uia?, et<ttd"r rrrerqr ?rdr rre<<r"{l or<1 scrr* c)qr rrr} errl 'flr) qrurdcr aqe) eF rcr
ucl :- ( D,l"r.L^'^fra&srzl'j"r*:- J)."n, 4lf OUc)q) ,- c1r\&r1+,qft$
[Y'eA .-s fr tndrle--
rls "rxr {dq d.ut rpct (.t)a1a) r)oq"ttr'il il€l
edri tilei., Ga)cr/srzrarorrqi enacr qqrol) drr.r: dcu?orldi"r.' f3 =
o\Egr & , at.lL I t /.""gur{d)ddaolqqr}"lld"flcarl*ru)rrur d. ( l--'-,
t 9 Rt:- sn\& c+erh- et'rrgt-'0/2'8z. r1 I'61 ,-,p\.. ^i . r .>.,. n. r.r. Nlt +rh 9llllu4!&i EPfi
H0 otc
,' o€)
or(8ff M F G . o i.. B u-"1-_ l..( oll _'l G 9-. +- ry _D__'$ g ly E 9llrWorks: Block No.i55/1 , 159, Chhatral-Kadi Road, DHANOT-38zTa. Kalof , Dist. Gandhinagar, GUJARAT. (lNDlA) Phone : (02764\ 23
GPCB ID: 28133
To,The Regional Office,Gujarat Pollution Control Board,Gandhinagar
DATE:2710112017
Kind Attent : Shri D.C. Vankani/S. R. PATEL sirSubiect : Compliance of Visit instructionsReference : GPCB Visit, dated: l8l0l/2017
Respected Sir,
In connection to above mentioned subject, we would like to draw your kind attention as
per following
o Sir, kindly note that as a per compliance of visit instructyion dated on l8/Ol/2017 we have
disposed 28.780 MT ETP Sludge at Saurashtra Enviro Projects Pvt. Ltd. Copy of the same
is attached herewith.
So, kindly consider above all in your record please.
lf you require any more details please call on us.
Thanking you,Yours faith fully,ForO Orbit Pharma Laboratories
nryAglhorized signatory
Copy to'
, )hti S.H.Vegda sirL-/ Un't head-Gandhinagar,
Gujorat Pollution Contrul Boanl,
Gon**or*
rry{r'\\n
-,ifstP;$;?;TdEoafd
o.si,Is"",ffi''o
cJGY?lcl Y(qel Graiclul or'lCudlQIs siil : ctitilotorr
un, .+JI.gtrtt.a....k.et.u0...-..fr..qI
oi8r PHAtrr' [r gonitYdtEJ "15511, t59, Cittro.|.l(rdt Rord""DHA|WT'r3t27lf'ri.ii(atitf ".........
Olrt. 3:nrlhinrgir
ffi
eucr qqtor) erd cuta seqtq)
\Zc/o'qqfqeer otctot', il5at ro-rl, ctitilaut-3eeoto. : (orcc-) a3Q aloc-g
drilil Hte en4c{ Eqtoil r (rildla)
"i. :
qruil ?rrEGqq cc-,gr"fl sc{q-?3, cqr ral&Grerr qc-eq"i)
zrrl?rliarr-tc-cq,ofl scrrr-qo dotn errq)d 4slcr +r<r t.il 1ei eltr)
d'il acrq c{tld cqrq aqd .iF).rr dgra'l ,rr) raruoil rycqlqulisre t]er.n?i dl?i.
ud uuicreer (gear)ae1) seqre urrr)d "r?ell crrc'l
(c) urq)d a)tlcrr ellet or)i-iqq aesteqi st:i olcrrqqtott rlrd.
(a) rarqr s)rl srerf t,r qqrorr t) 3 iq rad dq c)er a) ild <dqrqqrdr t) ogqt ?rrt
ds(,| oFtadci s)tl 't)alet"il,s)d d:rqrcJ'j qrcrot seqrqi
url0Grqq raqqr i do(,| slcrr Gerq)'il ra?.rqt ?xt ?rrfdr
sicrr s)tl gsr"il, urrd,er'il uerqr ?dricrr s)rJ zd
(3) g')d *rrq'r arrrcjl, ur'ltr)l3rs \Grqa, lsi, eu+ae, e*rrc)pr raqqr aaoer s)d ucco"il .re<1"i)
crr{r?r s?cr urd d"il sa)a'l scqtott dg lt} uaor i qrolrrri dd dq {r'tqrd sreur c)q }?nr srqsr * d dou| slcrr l;|qrr'l 1"rc'r s)d cg.t) seoteri rar.q) t) zterqt qqtofl dqrilqi d,d.i s)d "voqr'il lscil c)qr qri erd dd riq qr.rqrd srepr e)er S ert steret i d do(/| slcrGqq) do(,| lQrarurq s)c, JJ.r) su[.r) gero), dqr srtrot *|rryil, ur)er'll5ts rstoe, lsi,?Ve?", ercrc)"y utercr rrorr qcd"il org scad dor {rr) url "ild vertde al:) eprcreffI?t dht.6g)rr/srrqrdr{i enac{erqror'l?rltq:ttcr?otlsi"rqrtrt:0O scrr},cr.@C/ -g /coqguqrdrrp)scrqqrl"{li"fl.arl}rur)qurd. o0dlcr\ l- Ga A ai Urf.l) eCA,
. an,ss. rPp{rfr cih,d,a) o.;lr*lT"flt:$' efflueo+ cl
co[ectisn c\mb* a oufxqh6e|td "zn{l erber o{qorir0eclo ePd *"0 cili od+.1r0ulu0 orh 6\G.
aol) :-
ufisrrl,j olu
e'lq) ,-
J)he.4.{.osse
tls €q rdq d.ur 4u'rr (c)a1a)
rarcfl eQ t) d qrcror saqr{i orrqi d } il d 'rs51) seor.rl dg rrtl.
Itnq"itr4 a€l :-
d).\.0/
: http://gpcbxgn.gujarat.gov.in
Ho olo
oe
or(BlT MFG. oF BULK DRUGS AND INTERMF9-I4LBlock No.155i 1, 159, chhalral-Kadi Roacl, DI'IANOT-382 '
-ri"l. e"nanin"bar, GUJAFTAT- (lNDlA) Phone : (927641 234Works :
Ta. Kalol,
GPCB ID: 28133
To,The Regional Officer,Gujarat Pollution Control Board,Gandhinagar
Kind Attent : A. P. Thakkar Madam/ S. S. Jaiswal SirSubiect : Compliance of Visit instructions
Reference : GPCB Visit, dated: 2810712017
Respected Sir/Madam,
In connection to above
attention as per following
DIITE:2910712011
mentioned subject, we would like to draw your kind
As per your kind suggestion we will cover collection tanlq so that the rain water does
not mix with wastewater.
So, kindry consider "o*. r1i"J#jJ;ii:jf,. ..* rffiT||:|I"'
Ifyou require any more details please call on us. y-, GandhlnEr,.
Thanking you,Yours faith fully,For, Orbit Pharma Laboratories
, %'tto,L-,/ The Member Secrclary,
Shri S. H. Vegda sir (Unit head-Gandhinagar)'
Gujarat Pollution Control Board'
Gandhinagarorized signatory
i5 t Lrrt ?rx!Y. .*t '. ! . tr ltrr.p
xrllQr* *dell , :titiloi.rlr
Cl*\nftRs; fioa', d9*t ra.d, rtirtrlo|rtt-3dlo.ro.
dqtet Hd En{€l Eqbil daldl (or)a'la}
ri. :
qruil rrtGlGrrr{ qc-sr.il sg*i-e:, e qt uGjlasrr qc<q.ril tcr}r-Qt ra"l uui.nUr (qaar}
ufilliarr-re cq"|) *<rr-qo dotn ur)d rraic-i *rcr"tli Eri r;rr) ,'ilq) nc't *eqle ur{i er1{l gr$
tl.0 ntrs c,rrJd rxra tlrtr) .il{'tr d"F,ir orri utqoil 'r)atl{i eucl p"rat,'tl rr"l aql*l 8a{tol'l
ur&*r: e.rar"i)il] relri ,
{ s} }l}r}41 au{Jr ar**r c**:C+++++*;'*r*l;i -''ra:;qrn-gqqr} '
ir) a,rrr1t *)d *tql .4.ttg"lt<tll d * *r ard da clrr al srJ ikl o1cnqqi"ll t| uts'lt ult
erlc|tiral ura.rqt d den riclr fiqq)"i} ut€lql u|l r,rlallraq dotn atvrddl g'ld "r)dlrr"Il '
slcrr dd g*rt*,{I, urirr"il uerqr *rtr}<rr ;)d urll*rr.reoll 519 cl;rrr *I.! uKla e:qt{iurrcil t6i t! * utt*ol se.lt{i rtrrqi r} ri lir 'r 'rr*l 5?{tt"rr 6q }tl/ '
{31 sld ar*td atxrjl. liir-r'tF rl .crt"e. i*r. lF;*di. tttrt.t'v i}lPJqt e'l",rl s)d aOa"l} cratl"i}
dutit seqt *r$ i.il :rrlil ir.;-ur*lr €q rrd ue,rclt "v rr::tt|li di r]}x !r.l<lli sreur e)u *
{rr gle,te.t * tl doq *ltlr Grairi 1.r..1 3ld :1-*i *:<,tri rx r.ei r} }te}qt aot"il ierr{Ui d,ac'| sid crre ,il nscil *qr rrri al.r ri.i rilrr xrqcrpt *rtur €lrr $ rrrt *lqgt * d ds*n lltrFrErl) dorn lilarutr *1gJ rj.t) seri<'t gat"r), i.rt nttt't ar{''j|. uil€l)Frs lttlqa, its.agEaa, e?('rir rx:lqt u.an rJ6..l.il q?$ 3ra"| t)"rr {l} u:i "ile)
qr:rr.)rr xl) eF{(l
aiJd tf)$.Gtr):V*rErrrqrli etr"tct EqtotJ atx.t: *l(l?orl/fiirydltd ('C'-- 5({t+'dt'9'/"$ /laqguard)an)a€rqrrri"{l$"il ca'*lErar'lqal d. aA4}|gl - iga 3 ai Ur{4) +acA.
/Q uflclarirtl afl5tirrrr efflu€nl J. .Y-e.$1r.fr.fldt.d,l)...-- a'\\e1 qqlol a\'5 arafir+
follfrl\0'n chorobet a ou{xrrhefiti *f]\.,f] d:e} .2r]40llqJl
orBr PHArrr trBotrttotlSt'1551.l, 131t Crrhfrl .drdl Rord
' "'DHlLO? . ]|ttll. Ti,:diloi0ttr.5;nlninr;ii
ds ass lrtict d.ur ry<r 1.r)Bn1 r)oqatroi'l a6.| '-
irir t.t qf .+ \t)q\un (.|d 6\\9
.1d ud+ttt
fio.} ;-
uQ1sr;1)'j olo)q) *
eUhtr.u-1 vl- ;::'til rl i."
\:7
\a^sI!
IJ-
GUJARAT POLLUTION CONTROL BOARDPARYAVARAN BHAVAN
Sector-': 0-A, Gandhinagar.3S2 021 .
Websit€ : www.gpcb,gov.in
qLe.rll.d.Jl
\rd_ltlg_tRqrqg_lraQ?ia$l_j40qqrr -! s.r!4,!g!Ir,Gq1sL ioo. 6ala oitl s?_q4,Egt.({-t840lc)
r4r\{ Arrd r,ltfda gr{ d.,+]laflu, r,cilsi. r qu/t, r '{e,
. uar<.t-sj[ ?'is, ru{-tuo1].e. dr-rcilcr.p-:,ritl[.t:rr urLi 6a-tcL rlcuq] ol rti srar<, ]is a1fla{ uLt dlTo0{I, sretritiis ql}lftelr.
sra:'c.tllis strl 6e1ruc{ rlxl(i'u1.1 6arie"t s r-I ti.qrua erqtqq({i r,ti 0 }, or13 ar.ocTotTtora 4t t"lt qf3"t( Q3{.ior? ewn-qsmu rll
qr\ri 6ulcr {atqqL .t) r.rgfl qLQcr B.
qtui qlS 6r?r r,{Ju6 urq0 r,t0fiurdl sc.r\ (33 ) (q) $6ur aqr u[E<L rL]at gr:rc.t r"tctr.?g/Ott/tE ctL e-lv r,.rrr..tqL L{tdcl
urui ngteorl 3 6alrr.il dr.o1/o.e/?o1u "u ?-lv urq{l ufQRar"0 sq{-(?3 ) $or^ qf5,1r
ttlQrtfl?af{ Uc.tsrcr c{lQcr erl rqtcu xdta }..(?,{) {atl5t.l {la Bulk Dr ugs lrrtcrmediares cj 6.ut€4 q(g Aql qd(1.
(q) dsqr-ti wood l>irscd Boirer llc{tq 4qi o{-lOar? .qp('M u{a {q"{1 artr Insrrti 3}c.r 0. *.tt qt{lfu^Qcr .i€11.
(s) {hige? atA clruaci ,,\pcrM du rlte'lia "{l lx r\{l3ls d.crL rdra.(s) ari qfa? u"td.z g uJlrld utu\arddr rri e{l}r dqL qAr.c,r. ula:ig urqft r<niltaxi cruear
.slqtrll cr!0"r{i hsLa ucj d+r x0rcr Ca1 a5a1 c0Qcl.
utud rgrLecrrui rtQ B !, urfSi r,rt'{at Gulrrdl 6€,0{c{ctl ugqqr ortqi r4rg ortvorr
[dr<ra"t r0rit cnf€l gQ?rrr] {ara d 4i r{rqdt 6a\tdl vpvgL"u snql r,trVorrvdu ?dhitou
+qtrari qizqaqt i.{lctLqs zr{lazrls dar oproi ter${l.ti r,rtq"tL Ga'l:tqiell .0:oat cier
urq{lar lisrcrdl qrata uicr,arer D.
qls.u r4{dsr{lu d r4rq"ri 6 }t.([ dr.oi/oo/?otx <r r1v larsta c0Qe eul utq0q(Qfielq gaq-(ar) lnor:ier utq{lar alar Qcuui uLda. r,u <rj<Lal VEss?qr q&qrcl "iot.:grcrdt. ? a/00/?ol Y qatd 0 B, (BoE!31OO m&/t, COo-?lTO r-g/t, S.5. 358 m&/t, rDS 24876 m8,/t) r4('{"tt
Galrrqirli ugRa utq0 e13 r,tla utrr u}g rrai qrr(l ur1{r.{i q€r? srr ?€ B.
r,l3 ctrt rqcrr6 r,tu,it utg{l urfiQalq"0 sa{-(]3) (r4) }oo qtrtrL.rrr qqdr q2..i.?1EU3J,
d(.?s/o'r,/?olx "rL'e-lt u{Lr{c{txi rltdcil qi rr{ua +uudr rt+t et) 1ac0 ds u{rqcrrti l,{taft €.0.
6'lrlsa {erlcnri g, lQtc-.t dorsr leRu ualcrqt ttniel, rlvrra uEuqL hziaE al3, utqftr,rQQql.ft s(.irr-(3i) (r,t) .!ern dll $ra<1 gsrr s3 $.r) ,ursrefts "{l rlnrdl iaruar 6alrr"0 6c{LE'd uBqr oitr s?9i1.
rtnl r,{r.r"{l €.lrEdi v[&.{[ rtLrraL.ldr"u. (]Ulc{) qrq? u-u,e } SL9. {aell rlcrd pfar al i uqrqt1 srsil.
Pagc I of2
Clean Gujarat Green GujaratISO - 9001 - 2008 & ISO - 14001 - 2004 Certilied Organisation
I
3) cur6tc.{le r4t{?dl qtr{dr 6alrt.if dlt gr crol dhx sq.{l tcrtar tai 1dl o{it1 €s{ .( €nq .rri
qdl sr,li aruc1.
d 6'tar €grii dtrsrcft8 r*+lrr{l qrc-ta ddl s?qt{L r,r.Ld. a] r4tu r*}, r,tu"tt
qrcrLc{etr r,rfQst{h'l. ruq{l reoaar-tcox "0 rax (sr)(a) tvot slal{i t{lqre s ec.(ti \ata oeail..
:lcd?ld q[qql [iaiag ,e13ar "tLl qi qc[.
frtqle^"-y'{Glcr d'tstl
cRU ual.rrqt uvie
,ioR:- {. u. R. ql3u:ro{ir c t:: zdidtrl-p{'ruu ?3?e / ZZZ I t^ 6t 9La l.^lg1 tuuR, lnd utr(Qz !L{ dtr}a{ln.
oc.lsoi.iqrr/1,tqe, Eate-g(t t-ls,
our{-t{Aa. at-g(itcL 9-rtitll.tJt?
d8(.t ?a(att:-
1) ufi lzl"t r,ri ligrt C3lratr{I.
6t{? .Jet?td .{lv 3u.0 c{l{t}s,
G. 4ctr r-Is,
ti+rtqtt.
r ) dtqq ovilt{I,6rr? l%?r.cr dlv iu"{l c{l{lls,
uor Adln"t r,LQu,ga]a.
llccrl-sala. p-ctitil<ctt.
r,rtell aqfi [d"i.[ stqLui r,rtd B ]' 6ut tqttda 6a1rr<1 a{v 9t+o1at..sr(?r r'r rd st{l
dtu{qf ui idt ttqt AOc uxell qfii srdl.
{et?.a u1.\+ Ruzet re13"l arl $ y!'8r-q/:-^K
(uteyr$\st)qQu ,.rerl.r&t Ovir
Page 2 of 2
I
6oriBn MFG. OF BULK DRUGS AND INTERMEDIATES
Block No. 155/1, 159, Chhatral - Kadi Road, DHANOT - 382 729.Ta. Kalol - Dist. Gandhinagar. Gujarat (lNDlA) Phon€ : 02764 - 234093
To,The Member SecretaryGujarat Pollution Control BoardParyavaran BhavanSector - l0AGANDHINAGAR _ 382 OIO
Sub:
September 03,2014.
Ref: lD No.28133
Your Reft GPCB/LD-28I33|CCA-GNR-3291 222146.Dt. z l4/08D014
^ Dear Sir,
With reference to above, we wish to inform you that our electrical supply is already
disconnected on 25.08.2014. Our meter reading is as under:
Our Consumer No. is 27934100128/2Reading : KWH 63331I
KVARH 372901KVAH 8I37I3
Further to this, we are submitting herewith following documents:
a) Notorizedundertaking.b) UGVCL'sElectricityDisconnectionletter dt:25/08/2014.c) Application form for revocation ofclosure order.d) CCA copye) Water cess payment letter
0 No lab bill water cess pending print
C) Monthly parak ( from February' 2014 to July' 2014)h) CPCB_Form 2l (Annual Retum)i) ENV Form (2013-14)
With all above, we request you to kindly revoke our closure order and direct concerned authorityto reconnect the power supply at the earliest.
Your early action in this regard will be highly appreciated.
Thanking you,
Yours faithfully,
For, Orbit Pharma Laboratories. %\s ' ,..',ti BoardGuiara.
Sectci tii). l0 A,crndhlnag.f - 382 010.
r)l^/.I a- / -rtlN lJ r -\\'\l\ 7 'A\V e- \
'.- l\r-
f,- it*g./_-/-
orized Signatory)
Encls : As Above
.:ffi\iltt
GPCB
GUJARAT I'OLLUTION CONTROL BOARDPARYAVARAN BHAVAN
Sector': 0-A, Gandhinagar-382 021 -
Website : www.gpcb.gov.in
r4r?,tn.a.Jt
\rd-'rtlqlqqtig-ga -AgaqLu(Qqgq -f!e!4 gglr:(go_ll4l ioo. 6a'lct ciq 5?_qr"itJgt.tfl--Sr<{l.el
r4tu ir{d r,rfrlQa gt{ Qq]leflu. r,etlli. rqq,rt, r,rc,. oarcr-rjl r-ls, rur.{-tt(ole. dr-8cicr,gl-rritll4:te qri 6a-t:r qcuql ol qi sLaucrllis al qu u{Lo{lf([{l, star.it}is ql}s[q{.sL.{rarf}is s(u oEuJc( rl'iGul1 Gd{re.l sr'I ri.
utui yqucetti urLd E 3, o{lJ dr.oe /01/?or. ? 4t a-lqr lrl3at Qs}r "iot? nwu-lsooz rllr{qi 6u'lcr qarqqL rrL} rig{l r,uicr D.
r4tt{a 6{13 6t?r r,{ruG urq{i rroaur"{l sar{ (3 3 ) (?4) }6c1 2ql rllb4r qt}o ?ta{c-( a.rctt.? s/oq/ly 61r. e-l"/ 4qcnri r,{d.A
trLui tEccr'J 3 6a]ct,{l dr.o1/o.e/rorv .u rlr uq0 qOR4{"0 scr{-(a3 ) }otlt qlj"uorQsr{luild tcrrsrd c{l0.ar aul xgLer xdr< }..(?{) l(-tt5t( {r{l Bulk l)rugs lrrrcrmediares "j 6.uLea utq fr+ udtC-t.
(q) {3{t{i \| oorl blsccl Boiler flqtq "tq oloct? .qp(.t\a r,ri {lr{d +{ri Insralt 5}a O. €"{t {r{tiuLdc{ ar1l.
(3) {lAsa? ttr <.trtLaci ;tpcrv "tr Nredia "ft r'H r\{lJl: vlc{r ){Arar.
(s) are ql.a? uqaa O tJA{"0 r{roqct r,"r {i c{l3s crl.rL udrq. rai cig qrqft \m"lrLorqi qrqear
r:lqpll tr0aH( fisra ucj rlcr e0rct *"it a1.r1 c{lQct.
trui rqu<etui r,ud E !, qlSi r4ruat Gd.cre{l 6€a{c{dL yRqqr o{rori r4rg otVqu
fdutaat tdlril d?5r(l rQ?ut] Hda B e'tqt zrLuar 6loL<i upuE"u urql r,ugt tV4L tdletr"u
iqrreqi rrizr,raqt rldlar?rs r'fta2.{ts aut ..{crd *qzr,{l"r;l r,{Lqar Ga'Icruidl "{lsoar :iet
urq0ar Rsrc-ti{l -jrura ui.ctzatu B.
ql3"tL .r0sr{lr, A rrq{t 6al:rdt dr.o1/oo/?orr at r1r letsra c{lQct rutl utg0
rt0Raq gaq-Gr) 1vr,1 oier urqftaL 'tlat Aerui urda. r,n <1"ua1 UEj6?qr q&qr( "i0{?-33..i.tt.?4,/OO/?o1r claLQ B !, (BoD-3100 m8/t, coD-7970 mtlt, s.s.-358 ms/t, TDs,24s76 mglt) ?lttqatl
Galrtrirll ugRa qtq0 o f qrqcl e?ru}q 5?cri qtnl Hrarqi rr.:rr yti r(i D.
<,[3 qtrt rqcu6 uLui uLq[ r,rQ{iqrrdl sct}{-(33) iu{) .oar gtnrt.rt q:r"[ \.rz,"i.?1yx3g,
d(.?9/oq/?o1r aL il"r qtuquri r*tdal rli. r{ua ru€cu saaL xt) \rd ds l,uucttrl r,ttlc.t o.ft.
6,{rlsd *rit{i e, qQlcr dcLsr (qRrs qalqrE tt"rirl, :1rrr< uF\qr Aq:r{+ c13. uLqft
,,rfQRqr"ft B(.r{-(33) (ur).!orn "{ll t%o{"11 €s{ sj !i.r.) cttcgre{is "0 qsrrll qru"t 6ilrt"{l GarLea uBar o{tr srrii.
r)rf rqLu"{l €.vred u[} qtq"{r q1dr"u (}{l.r) urqa qlr.e } {1.v. {a{l qta.ft eia a1 A ugqu:rril
Pagc I of2
Clean Gujarat Green GujaratISO - 9001 - 2008 & ISO - 14001 - 2004 Certilied Organisation
I
3) dttac{ls r.,(tt?dl lrtu"tt 6ufrt. cll"d lrqd 4ey 3q4 tqrt errri {tll c{lvl Es{ { ru?r d{
{t1l s({l "itqql.A 6q?dr Es{"j dtcstdb qt{?dl r{er4 -tdi s?qt{ 4a dl uttt r,{a qru"tl
rqrcl€r? qlQsr{[{1 qrg0 r,{[iRq{-1eox "{l sc.r{ (rr)(e) lvor s]:{i. !{lanE s?qra ura orsl..
{vrtd gqqqt liaiag o13at 4tA r4a q((l,
A*J)9^u-fftil" ar,r,r
.iQU ,r?rtqrqL uve.r
<or?:- {.V. R. r,rf3zqrO{lr e t:: zdir{irl-Ui.'i?,{ \1i ?e / ZZZ I L^A/ 9La trz'l Vlt r',
u[i. lad ufrfda !t{ ctrq]ia{il.octlga. r,r,V r, r q c, tratct-s{t r'ls,
cttq.qtale. .tt-scil.cr, p.rrit{tacte
ct5(.{ lcttctt:-
rt yli lel"t ui digct Blsau{I,
6!t? w?rd d'r 3q"ft c.{l{l}s,
ld.aacrr r-Is,
\(it{gtt.
e) atqr+ 6qriar{i,
6rr? {Y ( 4cr iu"{l c0{l)s,
e(or ildlJt't d[!u,scr]ct,
Uc<tl-3ci('{, !'cLidldcLr.ur(sll dQa fd"i.{l srqt{i qtd B }, 6qr
"graar 6lrtA .ftv je.ro1.u.$@r r{nrrll st{
drqql qi i"0 stqt dO..l uadl o Si sedl.
qr?r.r uf(qq aaa+ aSat atlfr,]*Va,z
tutiY*4\''r.rRtO qql.{dl Ovir
Page 2 of 2
I
THi lHlUi?Ae.{: a€Et:_rit!-t:iECOOP BANX LTO 00.00
3S3 '10 C G !J.I RA.T
.3.ret{lSPF(:IA ANHFSIVF
zltt+zSr. N0.......,.........,...... ./20i4
(l
-*\PIYUSH G. OZANOTANY
C'r,VT. OF lfiOlA
- 5 SLP ?01q
UNDER,TAKINGTo,The Member SccretarYGujarat Pollution Control Board'Paryavaran Bhavan, Sector - l0A'GANDHINAGAR - 382,010.Dear Sir.
t. Mr. Naranbhai P. Kikani, aged adult, being Partner of orbit Pharrna Laboratdtie:.
tocated at Block no. 155/1, 159; Chhatral-Kadi Road, Dhanot - 382729. Ta. Kalol. l)ist:
Gandhinagar, do hereby tlndertake as under:
\\'ithrespecttoGPCB'Sclosureordervide'GPCB/ID-2813f/CCA-GNR-329172?146'Dt.: l4108/2014,1 undertake herewilh as follows:
1. We agree that we carry out manufacturing of the Diclof'enac Sodiurn IP /BP, Diclolbnac
Petassiutn. Diclolenac Diethyl Amine at said location'
2. WL agr.e that we have been granted CCA vide no' AWH-45002, Dt : 09 01 20l2'
3. Wj" u"sr"" that we have been granted to operate unit for 3 months on trial rttn basis as on
26.0{2u44. Our point-wise compliances/ clarifications with reference to GPCB Officers' visit to otrr
unit on DT: 0110712014 is as follows.) At the time of visit, the production of bulk dlugs intermediatgs was cotrtinued.
- C)ur Compliance: We agree.
> the Unit has installed a new boilcr and Chirnney with APCM. othcr than wood basc
boiler, fbr which the unit don't have permission of GPCB'
- our clompliance: we were issued prohibitory order by office of Boiler lnspectot tor
stopping non-lBR Boiler, Ahmadabad vide letter of date after 1710612014' \te arc
attaching herewith copy of Letter of Office of Boiler Inspector tbr ready r9ferel3e.
t{errce ie had to replace then existing old boiler by new IBR boiler' We had applied
fbr CTE-arnendrnent tbr Boiler replacernent which was rejected We have again
appliedlbrCT'E-amendurentleconsidervidelnrvardNo'77581,Dt:2lt)82014'I
>>,it rvas observed that pH of APClr4's rledia. attached with Reactor, \';as acidic.
- our compliance: we had soon corrected pH of media of APCM attached to Reactor
and rve assure )'otl to nTaintain it'
)>Ther.d rvas leakage tbund in Waste Water pipe lnlet to ETP and as \\asle $atcr;!u5
being used for plantation. of which satnple rvas taken.
- our compliance: $e had soon repaireci leakages and now it is perl'ectl1-se aled.
5. F'u|ther. rve have started segregation of steanls and rve plan
effl(ent streants and dilute washing eflluent streanls We
eflhent slreanl and dilute washing effluent streams separately.
1() segr€gaJc concenlklcdshall collect concentratcd
.it{q
il':DlA
PARTNER
FOR, ORBII.:,
6. We have applied for membership of CHWI of M/s Society for Clean Earth (SCE). GIDCVatva, and Ahmedabad, who has common Spray Dryer: 02 Nos, 50 Kl each. M/s SCFhas stailed spray drying of high concentrated as well as liquefied dyes materials formember units. SCE has been granted NOC vide CTE No. GPCB/ABD/AMC/CCA-792llD 382501151 124, DT: 24.06.2013. SCE has applied for CCA Fresh videsApplication No.82198, DT: 30.05.2014 which is under process by CPCB.
7. We shall .soon apply for CTE-amendrnent for (l) Spray Drying of our concentratedeftluent to Society for L^lean Earth and (2) fbr dilute washing effluent to be treated at
El'P and then to be disposed on land for gardening.
We also assure you to fulfill all GPCB norms continuously.Ttre above said information is true to the best ofmv knowledse and belief. I know that it is lesal
offence to give false undertaking. ruR, SRBIT prf$,i,lA ..; r _ :.,ilCR iES
DATE,ortgtzotq.PARTNER
PLACE : . (Mr. Naranbhai P, Kikani) Partner
\For, Orbit P ratories.. SIGNEDBEFORE ME
GOVT OF
- 5 sr-P
(e f.o.a't D ('-rtq-
NOTAR\
OIAIY
tat, -_\
| s
2014
rlir DT.Eitft'll.illdffD
a{?d.jqieft \iqr,tlatur ue
ELECTION COMMISSION OF INDIA
IDENTITY CARDUHH2/141905
rtdet?i otl'r{
Electois Name ; Kikani Naranbhai
Qat"1 "ttu : q?cld{att6
Fathe/s Name : Parshottambhai
tt[i I sex : Y?\ ,/ Male
Y"r{ d[{lu{ ,/ Date of Birth : 07/1
FOR, oRBIT PHARMT LAS0RATORIE9
, [}aLQ{l 'ttrqontJ
v'
s*,,Yd'.. ,.*,
i:'13/
n?aurJ :5, itrr}{ }dls"r{, g{t,tlru-3 8005 8.
.iL. -e nsl.d. R. -r,t{ et qr e
Address: 6, Sangam Residency, Ghuma,Ghuma-380058,Tal.-Daskroi Dist.-Ahmedabad
(itrt<uctt rr<fdottrr"lr
{d€tr "1lqe0 urQrt{I.{i n$l"{l u15ti
For 4 1 -Ghatlodia ConstituencyFacsimile Signaturs of the
FOR, ORBIT PHI
ilhc;*,jl'tTi{1ii.
i,'.",fiI,i
UHH244190r
ghavan,
-A
Divlsion
l.
Anrrlication Format for Rcvoke Of Closure Order
Full name and address ofthe unit:
Orbit Pharma LaboratoriesBlock no. 155/1, 159,
Chhatral-Kadi Road,
Dhanot - 382 729.Ta. Kalol, Dist: Gandhinagar
GPCB l.D No: 28133
No. and date of closure order for which revocation is sought for:
No. GPCB/ID-28133/CCA-GNR-329 t 222146, Dt' : 141081201 4
4. Date ofdisconnection ofElectrical supply: 25'08'2014
5. Date ofdisconnection of Water supPly: NA
6. Remedial measures taken to control pollution (in the Table mentioned below):
2.
3.
WhenCompliance
requires morethan 07days,likely date of
Date ofcompletion ofthe measures.
Remedial measures takenReasons of closure
W" agt"e We h*e t"lid CCA for theAt the time of visi!the production ofbulk drugsintermediates was
continued.2t l08l20lJw" *E6 ist,,ed ptohibitory order bY
Office of Boiler Inspector for stopping
nonlBR Boiler, Ahmedabad vide letter
of date after l7/0612014. \Ne are
attaching herewith copy of Letter ofOffice of Boiler lnspector for readv
reference. Hence we had to replace then
existins old boiler by new IBR boiler'
We hal aoplied for CTE-amendment for
Boiler replacement which was rejected'
We have again aPPlied for CTE-amendment reconsider vide lnward No'7?581, Dt.: 21.08.2014
The unit has
installed a newboiler and ClrimneYwith APCM. other
than wood based
boiler, for which the
unit don't havepermission ofCPCB.
dh"d so*6At"d pH of media ofAPCM attached to Reactor and we
assure you to maintain iL
pH of nedia ofAPCM attached to
Reactor was acidic.We had soon t€patred leakages and now
it is pedectly sealed.Waste Water piPe
Inlet to ETP
(...2...)
?. where remedial measures to miligate pollution are likely to last more than 07 days, then an
Undertaking (on stamp paper of Rs. 1001 duly signed and sealed by Notary) shall be submitted to
GpCB stating the measures and likely date of their completion. In addition to this, company shall
also undertafe ro comply with ofthe provisions ofthe Water act (1974), Air act (1981) and.lhe
Hazardous Waste (Ma;agement, Handling and Transboundary movement) rules (2008) and shall
also comply with conditions stipulated in the Consolidated Consents and Authorisation (CCA) by
the Board.
(A) Segregation of steams viz. concentrated effluent streams and
dilute washing efT'luent streams.(B) Obtaining membership of CHWI of M/s Society for Clean Earth
(SCE). GIDC Vatva, Ahmedabad,(C)Spray Drying of our concentrated effluent to Society for Clean
Earth and for dilute washing ef'fluent to be treated at ETP and then
to be disposed on land for gardening.
Relevant documents are attached here with.
8. Letter ofBank Guarantee (lfrequired): Not Applicable.
9. Status of CC&A status with date of Expiry :
CCA No. AWH-45002, Dt: 30.11.2016
10. Up to which period the Water cess is paid:
Water cess till FY 2013-14 is paid. Copy ofwater cess AOfor FY 2013-14 is attachedherewith.
I l. Are samples analysis charges paid: Yes, all laboratory bills are paid off.
12. lfthe unit is in critically dark zone, what is the source ofwater? Ifbore-well is in use, can it be
sealed? Exolain with reasons.
No. Our water supply is Tube Well.13. Closure order(s) issued to the unit by GPCB in last 2 years : No.
14. Status of monthly Report frorn lndustry (Form-20) : Attached herewith
15. Status of monthly Report frorn Industry (Form-21) : Attached herewith
16. Env. Audit Report (lfapplicable) : Not Applicable
16.I Compliance of Last year Env. Audit Report: Not Applicable
16.2 For current year Env. Auditor's acknowledgement Letter: Nol Applicable
17. Status ofEnv. Statement (Form-V, EP Act): Attached herewith
Date: Ahmedabad.
Place: 03/092014Signature of Authorized person
w\7t
l" Consent ordet No' AWH-45002
GUJARAT POLLUTION CONTROL BOARDParyavaran Bhavan
Sector-10-A, Gandhinagar-382 01 0.
Phone : (079) 23226295Fax : (079) 23232155
Wcbslte : www.gpcb. gov. in
date of lssuc: 09-{11-2012
And whereas Eoard has received conso|idaied consent app|ication |,9: 12091
dated. 01-12-20t1 lor ttre consotida-ted Consent and Authorization (cc & A) of this Board
uiout rn" ot*iaions / rules of the a{olesaid Acts. consents & Authorizatlon are hercby
oranted as undcl6orseNts AND AUTHoRISATIoN:(Under the p'ovisrons /rules of the aloresad envrronmentar act5'
1oM/s. OIbit pharma laboratoriegB.No:15511,159Chhtral Kadi Road,Dhenot,Ial: Kadi,Oist: Gandhinagar
71
2/,) .\
lhe consents shall be valid up lo 30-'11-20 i6 lot t-trc of
trade dftluent & emission due lo operation of industrial pli
foliowang items/products:
CONDITIONS UNDER THE WATER ACT:
lhc auantilv of trade effluent from the industrial plant shall nol excccd 3450 | ryday
I he quantity ot Sewage cftluent from the induslrlal planl silall nol cxccod 650 l lt/day
I he applicant shall provide adeq$ate efituent treatrnent system in order to achieve thc
quality of the treated effluent as per GPCB norms
C lean Gujarat Green Guj ara t
-
iQuantity
I 2.s Mr/M
I 0.5 Mri M0.25 MT/M
IJi I
IernperalureColour (pt.co.scale) tn unitsSuspended Solids
Orl anribrcase,l)hcnolic CompoundsI llr(r, r.jl)s
6 5 TO B 5
4C'C100 unils]00 mg/l
10 mg/l1 mg/ll rnll/l
Sr No Product1 i)rf:lotcnac Soolum ll-lup? l)clolenac Potassrurrl3 {Jtciok)nac DrelhYl Ammonlum
GPCB NORMS
- All efforts shall be made to remove colour & unpleasant odour asfar as practlcable
2.4 'l he linal treated effluent coniirming lo the above standards shall be utrlrzed on land for
gardening and/or plantatron purpose
2 5 All the effiuent treatment unrts shall be operated and mainta.ined eftictently so that the
treated eff luent always c;i;I; to thi specifications refened in condition no 2 3
above.
2.6 Domestic efiluent shall be disposed off through septic tank/soak pit system'
3. CONDITIONS UNDER THE AIR ACT:
3.1 -l he following shall be used as fuel in Boller/ Heater respectively
3.2 The applicant shall install & op€rale air potlution control system in order to achleve
norms Prescribed below
3.3 :fn" tf,ie gu" emission through stack attached to Bath Heater/Treater shall cordorm lo
lhe Process emlssion through vatious stacks/vent oi reactors' process vessel shall
conlorm to the following standards
Air Pollution -
ParameterControl system
I'ATTER' soz
Sticiheighl inlYelgr11
Permtsstblelimrt
L
150 mg/NM3100 pPmq! Ppr! I
-I
Sulohrdes i 2 mg/l
I nrnnronical Nrtrogen I so tnglt .
.,tr: ll'r;:,: L,r;l rlLg'
I YUTo 5Ulvlv.ll
I 96 hours ln- 100% elfluent
If lexavalent Chromrum i 01mgil I
{ioD (! dayg qt_?o'cl 1 .Sq rnsll l
r,OD 100 Ingi I
r:t'tn"rtes 600 mg/li Chlorrdes - -f 609 mgil
' Sutphat,es I l ooo mg/l
I oral L)rssolved solids . , 2100 mg/l'
)rr secticrdes/l)esticrdes i- Abseot' Sodrurn Absorpiion llahc I 26
llio assay test i 90% survival ol fish-ailer
::::aw&$ttt
GUJARAT POLLUTION CONTROL BOARDParYavaran Bhavan
Sector-l 0-A, Gandhinagar-382 01 0'Phone : (079) 23226295
Fax : (079) 23232156
r,aramJlg?bsiteFdlfll{lg*cb' sov. inL inJrt
scrubber Hcl-20 Mg/Nm3
StackN(Jtl
Slackaltached toReactionvcss3:5
alB
39
4.1
4.2
The applicant shall Install & operale air pollution control equipment very eficrenlly and
c{rntanuouslv so that tne gaseouJ "ttitit" always conlorms to the standards
spscrfred in conditiorr No 3 3 & '
u "n1"013",
"nt" lapse { at any time the parameters oi
The conscnt to operate the industr
,#;;;;;;;';;ilon "t" nut withi; the tolerance limrts specified In lhe condrrro'r
No3.3&35aboveii'"
"ppli"r"i"na, provide podholes, laddor plattorm o1c at chrrnncy(s) lor nrcnilorLrr"
ti)o air emrssions arrd the same "Ji ou op"n lol rn:Pecti3lt-o11;':1 1:' "to of uoarc:
sl;ll Nurrbcrs such as S f s z "i". "hif
design ti'c chimney(s). venls 'tttached
lo
vaflous solrrces ol emtsslon 'na--tnltu shali be patllted/displayed io tacllltaic
ide ntificationlhe industry shall take adequarc measures for control ot noise levels from its own
sources within the premrses "o ""
ioii"tr"'n "T!Pll."jlsYily^ttandards io respect
o{ nsise to tess than 75dB(a) ounng-i"V i'; and70 dB (A) durrng ght time Daytime
is reckoned rn between Oa t "no't"o-i't "nJ
nrghtlrmc rs reckon( jd tlotween 10 p'rr
andOarn
cl:NTRAL CONDITIONS: -
Anv change in personnel, equrpment or working conditois as mentroned in the
".,i"Jni. rin*loriiur should immediately be intimated to lh't B?:'^o-,
!fi;;;; die to accident or other unloreseen act or ever suci emlssrorrs ocol!'or ::l
apprehended 10 occl.if ln """""" Ji
"tuno""is lald down such rrrforrYiallon shall inj
iorlhwrth rcported ,o oo"r.o, cnn"oinJl'otrce Sratron ollrce ol t)ireclorate of I leai!:l
Scivtcc l)eparin.lenl 0t t xp'os'ucs inspcctorate o.f Factories an-.d {ocal b()dy ln case
oi lailurc of polluton control uq''Jt"nL' the produclion proc€ss connected to it shall
be stoDoed. Remedtal u"onn''t!""il*" snait ue itpttm"nted rmmediately to brrnil
iJ'JrHll$:ruiJ?1 oouro ro pedorm s functrons of ascc arnrls ,"" .t"n,irrd. ,,'
cflillcr)l laril down bv lt fu' 'n"
i'"'"iutg"' of the oflluen uncjer lhc con(iltron io ? 3 'rj
rhrs ordcr are complied wrtn oy t'tre coripany wh'le caYslls 1::l':q":t eftlJell-'".,
lp"pri"i'J .tt"rit "'1"
io subm;t "uety
niontit the analysis -reporl^ot
the samp'es or
etilueni qot collecteo "no
,n"'ytJ iy' on; of the laboraiories recogntzed by the stale
tsoard
43
(2 Nosl Alkali scrubber
I n.r "nni"niJtn
ot the fotlowrng p;Arneteis ;n ttre ambrent arr filhrn the prernisesi . (2 N99)
.' ,odcrPLi{i|i'SSIBLE LIMITPAXAMEIETaT ' _ ::"'-- --
r ;;;ffl* il:ll::.',','?1il,, i'""i! U[[i=!fi: "
Tl lililruliU;' 50 Mtcroqramiut ou lvlcr(rg ''rr'/r"f
'
41 1l ':roiran'rrry'' '1'1 t11 'r" \'NO,
Clean Guiarat Green Guj arat
Ine I nvrronmentai Management Univcell shatl be setup to ensure rmplementalto| or]afd .nonrtonng ol envtronmental safeguards and other condilrons stipulaled bystatulory authofltres The Envrronmental Managemenl CelUUnrl shall direc y repo( kl:hc Chref Lxccutrve oi tlto ofgan[ation and shall work as a focal pornt for lnternaitzrll{jenvrtonmental rssues- These cellVunits Also coordinate the exercise of environmentalaudit and preparalion of environmental statements.
44
4.5 I he audit shall be carried out yearly and the envlronnenlal staiementsPertaining to year shall be submitting to this State Board latest by 30thSeptember every year
4 7 lhe Board reserves the right to review and/or revoke the consent dnd/or make variatronsin the conditions, which lhe Board deems, tit in accordance wilh Section 27 of the Acl
4.8 ln case ol change o{ ownershrp/management thc name and address of the newowners/partners/directors/proprielor should immediately be intimated to the Boa.d
5. AUTHORISATION FOR THE MANAGEMENT & HANOLING OF HAZARDOUSWASTES Form-2 (see rule-s {4})
5.1 l-orm for grant of aulhorization lor occupier or operalor hand|ng harardous waste
5.1 M/s Orbil pharma laboratories is hereby granted an authorizatton to operate laciltly lorfollowing hazardous wastes on the premises situated at- B.No:155/1,159,Chhtral KadlRoad,Dhanot, Tal: Kadi,Dist. Gandhinaqar
S tio i t ype ol wiste Facility
MT /earCollectian, storage lran$portalion.disposal by selling to Registered
Coniainer300No/year
vutrcvu.,r rr e,.YslDecontamrnatron and sale or sale l(,
Date SO Collectron. slorage l realrnentTransportation. Disposal atCHWIiTSDF
lhe authorization is granted lo operale a facility for colleclion, storage, transporlationand ultimate disoosal of Hazardous wastes at TSDF of NEPL
I hc authoflzatron shall b€ In force for a oeflod uD to 30- 1 1.2016
T he aulhorization is subject to the condilions stated below and such other conditionsas may be specified in lhe rules from time to lame under the Environmenl (Protectron)Act 1986
discared & offSpecificationlvledacines
ever Io Degenerated
az
53
5.4
Uuantny
2 -t
28.3
6
GUJARAT POLLUTION CONTROL BOARDParYavaratt Bhavar'
Sector-1 0'.A' G:-rrrdhinagar -382 0 1 ;Phone : {079) 23226295
Fax : (079) 23232156Website : wYvw'gPcb' gov' in
TERMS AND CONOITTONS OF AUTHORISATION
a) lhe applrcant shall comply with the provtsions of the Environment (Protection) Act1986 aod the rules made there under
b) lhe authorization shall be produced for inspection at the request of an officerauthorized by the Gujarat Pollutbn C,ontrol 8oard.
c) The p€rsorE aulhorized shall not rent, lend, sell, and transler ol olherwise transportlhe hazardous hrasted wlthout oblaining prior p€rmission of the Gujarat PollutionControl Board.
d) Any unauthorized change ih personnel, equipment or workrng conditions as menlionedin the authorization order by the persons aulhorized shall constitute a breach ol thisauthorizalion
e) lt rs the duty of the authorized person to take prior permrssron of the GuJarat fJollolronConlrol Board to close down the facililv
An aooiication for the renewal of an authorization shall be made as laid down in rule 5(6) (tt).
lndustry shall have to mange wasle orl, discarded contiatners etc as per Amendedllules-2003 and shall apply Authorization/submil details for all applicable waste as per
Amended Rules-2003 with 15 days.
Industry shall submit annual report within 15 days and sub squinty by 31'' Januaryevery year
General ConditionE:
The waste generator shall be totally tesgonsible for (!e.!9!leq-!!on. sloraoe. treafnen!,
lt4ll3sedalia!,aqd-u{iEdc-dEpgggU of the wastes generated
Records of waste generation its managemenl and annual retum shall be submitted to
C! rtarat Pollulion Control Board in Form - 4 by 31'' January of every year
In case of any accident. details of the same shall be submitled in Form - 5 to Gujarat
Potlution Control Board.
As per " Public t.iability Insurance Act - 91 " company shall gel lnsurance Policy ri
aDolicable.
Fflotv drums and containers o{ toxic and hazards rnaterial shall be trealed as pe'
g(Jideline published for'Managemenl & Handling ot discarded containers . Records ol
the same shall be mainiained and loMarded lo Gujarat Pollution Control Board
regularly.ln no case any kind of hazardous waste shall be imported wilhoul priot approval ol
appropriate authority.
s)
7.
7.1
74
72
7.5
7.6
Clean GuJarat Green Guia'rat
7/ ln casc ol transport ol hazardous wastes to a factltty lor (L9 [ganrent sloraqqj]rrri
.lsrosall) exrshng in a State other than lhe Statc whcle hala'dous wasles aro
geneftlted.theoccupErsha||oblain,NoobJectioncertificale.fromtheSta|ePo||UtionControl Board or Committee of the concerned Stale or Unton territory AdminrstratLorr
whe.e lhe facilfy exrsts
Unit shall take all concreie measules to show tangible results in waste generat(.trl
reduclion avotdance, reuse and recycle Aclion taken in this regards shall lr{l
submitted wthin three months and also along wilh Form 4
lnduslry shall have to display the rebvant infomation with regard to hazardous wasle
as indicated in the Courts OrderinW.P. No 657 of 1gg$dated 14r'' October-2003
7.10 lnduslry shall have to display ontine data outside the main faciory gale wrth r€rgard lrl
quantily and nature of hazardous chemicals being handled lrl the plant' rrrcludrtrg
waslc waler ano atr emlssions and solid hazardous wastes g{"neraied wilhrn thc
tactcry prernise.
7.8
t.9
For and on behaii rj..,uiaral i)oiirr qir C7t:1)t :n,'r "
*{B.R.FAJJAR
Environmental Enginee-
. lsirdd to:
,/*". orotr rnt ^a |aboratories
V B.No;l55/1,1ss
NO: PC/GPCU/lD2B-l
Chhtral Kadi Road,Dhanot,Tal: Xadi,Oist Gandhinagar
Orbit Pharma Laboratories-2813JBLO('K NO, I 55/I,I 59,,CHHATRAL-KADI ROAD
T9lqn / Vill : DHANOT-382729
r :.alol.Dist.:Candh inagar.,S IDC:Not ln Cidc
*.ry6-9_8.gtG ujarat Pollution Control Board
Paryavaran Bhavan, Sector- I 0/A.
Candhinagar - 382010
Phone: 079-2f,2:l5l76
Wrter Cess Assessm€nt Order / Bill
Assessment Order No. : 179877
Assessment Order Dt. : 0810512014
Assessed Period :2013-20'14
W.C. Return Dt. / By : 19/04/2014 - IND
Biff Date | 1210512014
Payment Due Date ; 111Q612O14
Credit Balance : 907, 0 pRN / INT
Due from Date | 1210512014
T) pe lKilo Ltsl Consumption Ilate Total
Cooling/Boiler 12a9 0.10 128 90
Domcstic 1804 0.03 54 12
Process-BioDerd 881 420 176.20
0 0.30 000
Rebate AdliAm- 'NO Total :,l<O
Less Rebate Princioal + lnterest Prev CREDIT Prev INT Pavable Amt Pavment lD Remarks
0 359 0 (907 )(548) 9999 From SurPlus
Pavment Details 0 .Dtr12/05/'14
Pavable Amount has been CLEARED from CREDIT Balance
, .t-.. l'','t.
Signolure ( Membe. S€crotory )
P!9ry!9:-a. Please make payments through RTGS/NEFT.
1. GOTO RTGS/NEFT Challan in wTC Menu in XGN and Generate challan for by selecting A o
2. After Printing challan make Payment in the bank and Enter UTR No. on XGN against the printed challan
on RTGS/NEFT Challan in WTC menu
3. UTR No is a Transaction No. provided by the bank at the time of payment
4. Bank Detail and Bank Charges will be entered by lndustry for printing Challan'
b.lf you want to send thru DD then write payment lD on backside of D'D & send it thru Post / Courier to PCB
Head offlce( ln Favour of : Member secretary, Gujarat Pollution control Board, Payable at AHMEDABAD)'
c. For fulure correspondence / enquiry, always refer to A'O No
d. Always prepare a challan after entering the Payment Date in XGN & adding the Interest Payable Then
do the Payment and enter the UTR No.
-{ payment of the amount of WATERCESS is not made within the DATE specified, You shall be Liable to
p,dy 1NTEREST at 2o/o per month as per amended act
f. Any Paymenl shall be credited against Previous outstanding Amts --> then current Returns Interest
,Principal Amts & then towards Surplus Amount
I lllll llill lilli lll lllll lllll ll il lllll llil llll ill fitl Lill llil llil ll lll
Prlnt Oate : 22.08-2014 N'E
Non BioDgrd
Credit Balance : Rs 548
ee
I;e
{F
iI
I
1
l
I
t
o
t-
B
EE?l
Eqffisl
ffiq
HHnd_liillffi$ltif I
ffiHkJ ;lESt :l
ffiFli{ffi
ffiY
l!EIo
utEvD
FFF
FDItA
FttIt4o
Dn
:
o
;{
L-l
€
Fl
EE]
Monthly Report from Industry
Gujarat Pollution Control Board
Form-20
February,2013
l. Name & address oflndustry : Orbit Pharma Laboratories,CHHATRAL-KADI ROAD-,DHANOT -382129DIST : Gandhinagar., TAL : Kalol, SIDC : Not ln cidc
ID:
2. Phone No. : -3. Date of commencement of Manufacturing process : 1510311992,1. CTES No. & Date :
5. CCA No. & Date of Expiry: AWH-45002, lOi ll/2016^ 6. Water Ccss (with Intercst) paid up to rvhich Period : 2009-2010
7. Laboratorv charges pending if anv : 08. \l'ater consumcd during thc month (by all sources )in KL : Meter Reading:O,Kilo Litrc=214
Water Ccss Cooling Boilcr/Dom/BIO DegrableiNon BIO Degrablc : 108 I 66 / 60 | 09. Ele ctricity consumed in PRODUCTION : 6030 ETP/CETP: 654 APCM: 2869A. Stack attached to : Boil€r,Hot Air Generator
10. Fuel consumed during tle month : Wood11. Products : DICLOFENAC SODIUM I.P./B.P.
12. Work of Control Measures In Proqress: Nothing in progress
13. Uppradation / Addition of PCM is Reouired : ETp14, HAZ Waste Disposal(in Metric Tonne): NtL
Date: '11103/2013 1t'l ^"ff#Company Seal
Gujarat Pollution Control Board
Form-20
March ,2013
l. Name & address of Industry : Orbit Pharma Laboratories,CHHATRAL-KADI ROAD..DHANOT - 382729DIST : Gandhinagar,, TAL : Kalol, SIDC : Not In Gidc
2. Phone No. : -HMR-RET^.3. Date of commenccment of Manufacturing process : l5/03/1992
4. CTEs No. & Date :
5. CCA No. & Date of Expiry : AWH-45002, l0/ll/2016
^ 6. Wut"r Ccss (with Interest) paid up to rvhich Period: 2009-2010
7. Laboratory chargcs pcnding if anr' : 0
8. Water consumed during thc month (by all sources )in KL : Meter Reading=345,Kilo Litre-345
water ccss cooling Boiler/Dom/BIO Degrable/Non BIO Degrable : I l0 / 151 I 78 I 0
PCB lD : 281-l-1
ETP/CETP: 347 APCM: 4439. Electricity consumed in PRODUCTION | 142J8
9A. Stack attached to: Boiler,Hot Air Cenerator
@woodll. Products : DICLOFENAC SODIUM I.P./B.P.
12. Work of Control Measures In Progress : Nothing in Progress
13. Upgradation / Addition of PCM is Required : ETP
14. HAZ Waste Disposal(in Metric Tonne): NIL
E ' E Date:06/04/20'13 1t1 Company Seal
Monthly Report from Industry
Gujarat Pollution Control Board
Form No D2
Apfl,2014
l. Name & address of Industry : Orbit Pharma Laboratories,CHHATRAL-KADI ROAD-,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Cidc
2. Phone No. : 02'761-234093
3. Date of commenccment of Manufacturing process: l5/03/1992
4. CTEs No. & Datc: CEE-60136.29101/2019
5. CCA No . & Date of Expiry : AWH-45002, 30/l l/2016
^ 6, Water Cess (with Interest) paid up to rvhich Period : 2013-2014
7. Laboratory chargcs pcnding if any: 0
8. Watcr consumed during the month (by all sources )in KL : Meter Reading=4688,Ki1o Litre:369
Water Ccss Cooling Boilcr/Dom/BIO Degrable/Non BIO Degrable : l2l i I68 i 80 / 0
9. Electricity consumed in PRODUCTION : 14385
9A. Stack attached to : Boiler,Hot Air Cenerator
10. Fuel consumed during the month : Wood
11. Products : DICLOFENAC SODIUM I.P./B.P.
ETP/CETP : 768 APCM: 869
12. Work of Control Measures ln Progress : Nothing in Progress
13. Uogradation / Addition of PCM is Rcquired : APCM,ETP
14, HAZ Waste Disposat(in Metric Tonne): Land Filling Waste to TSDF= l5.850,Trucks despatched:2
T) pe Code Name Qty-Unit Remark
woD iy'ood 7700.000-KGS
PRD liclofenac sodium i.p./b.p. 2.400-M.T
E ' E Data:07/os/2014 111 ^'iffig;;;a
tPCBIp;2n3f-
Form No D2
May ,2014Gujarat Pollution Control Board
l. Name & address of Industry : Orbit Pharma Laboratories,CHHATRAL.KADI ROAD-,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not ln Gidc
2. Phone No. : 02764-234093
3. Date of commencement of Manufacturing process z 1510311992
4. CTEs No. & Date : CEE-60136,2910112019
5. CCA No . & Date of Expiry : AWH-45002,30/l l/2016A6. W"t.t Ccss (with Intcrcst) paid up to which Period ; 2013-2014
7. Laboratory chargcs pending if any : 0
8, Watcr consumcd during the month (by all sources )in KL : Meter Reading=502l,Kilo Litre=333
Water Cess Cooling Boiler/Dom/BlO Dcgrable/Non BIO Degrable : 125 / l0l / 105 / 0
ID:
9. Electricity consumed in PRODUCTION : 15201
9A. Stack attached to : Boiler,Hot Air Cenerator
10. Fuel consumed during the month : Wood
I l. Products : DICLOFENAC SODIUM l.P./B.P.
12. Work of Control Measures In Progress : Nothing in Progress
13. Upgradation / Addition of PCM is Reouired : APCM,ETP
14. HAZ Waste Disposal(in Metric Tonne): NIL
ETP/CETP: 858 APCM: 757
Type Code Name Qty-Unit Remark
woD 8600.000-KGS
PR I) Jiclofcnac sodium i.p.6.p. 2.500-M.T
E' E Date:ro/06/2014 1t1 ^"kil&*H#l-
Form No D2
June , 2014Gujarat Pollution Control Board
Monthlv Report from lndust
l. Name & addrcss of Industry : Orbit Pharma Laboratories,CHHATRAL-KADI ROAD.,DHANOT - 382129DIST : Candhinagar., TAL : Kalol, SIDC : Not In Cidc
ID:
2. Phone No. : 02764-234093
3. Date of commenccmcnt of Manufacturing process : 1510311992
,1. CTEs No. & Date: CEE-60136,29101/2019
5. CCA No . & Date of Expiry : AWH-215002, 30/l l/2016
^ 6. Wutet Cess (with Intcrest) paid up to rvhich Period : 2013-2014
7. Laboratorv charges pending if any : 0
8. Water consumed during the month (by all sources )in KL : Meter Reading=53 74,Kilo Litrc=353
Water Cess Cooling Boiler/Dom/BlO Dcgrable/Non BIO Dcgrablc : 145 I 172 I 36 I o
9. Electricity consumed in PRODUCTION : 206'72 ETP/CETP : 1398 APCM : 893
9A. Stack atlached to: Boiler,Hot Air Generalor
10. Fuel consumed during the month : Wood
ll.Products:DICLOFENACPOTTASIUMI'P./B'P.,DICLOFENACSODIUMI'P./B'P.
12. Work of Control Mcasures In Progrcss : Nothing in Progrcss
13. Upsradation / Addition of PCM is Rcquired : APCM'ETP
l,l. HAZ Waste Disposal(in Mctric Tonnc): NIL
l ypei-
I'R.D
CodewoD
Name Qty-Unit Remark
Wood----5oo.ooo-Kcs
51469 t'"6Ed6tt tru;t l'"/bt 0.500-M.T
57.168 liclofenac sodium i.p. 2.500-M.T
E ' E Date:08/07/2014 1t1 Authorised. qignatqry
,ilt*ffi-
Monthly Report from Industry
Gujarat Pollution Control Board
Form No D2
July,2O14
l. Name & address of Industry : Orbit Pharma Laboratories,CHHATRAL-KADI ROAD-,DHANOT - 382'729DIST : Gandhinagar., TAL : Kalol, SIDC : Not ln Cidc
2. Phone No. : 02164-234093
3, Date ofcommencement ofManufacturing process z 1510311992
4. CTf,s No. & Date : CEE-60136,2910112019
5. CCA No . & Date of Expiry : AWH-45002,30lll12016o 6. W"t". Cess (with Interest) paid up to which Period : 2013-2014
7. Laboratory chargcs pending if any : 0
8. Water consumed during the month (by all sources )in KL : Meter Reading=5524,KiIo Litre=150
Water Cess Cooling Boiler/Dom/BIO Degrable/Non BIO Degrable : 36 129 185 l0
PCB ID : 28133
ETP/CETP: l219 APCM : 4889. Electricity consumed in PRODUCTION : 147589A. Stack attached to : Boiler.Hot Air Cenerator
10. Fuel consumed during the month : Wood
ll.Products: DICLOFENACDI-ETHYLAMMOINUM,DICLOFENACPOTTASIUMI.P./B.P.,DICLOFENAC SODIUM I.P./B.P.
12. Work of Control Measures In Progress : Nothing in Progress
13. Upgradation / Addition of PCM is Reouired : APCM,ETP
14. HAZ Waste Disposal(in Metric Tonne): NIL
Type Code i\-ame Qty-Unit Remark
FUE woD Wood 8700.000-KGS
PR t) 57411 liclofenac di-ethyl ammoinum 0.100-M.T
57469 liclofenac pottasium i.p.fu .p. 0.500-M.T
RD 5 7,168 liclofenac sodium i. 2.250-M.T
E ' E Da:.-t21tolt2o14 1t1 Authorised ^Signatpry,M-
I
,^;
5
GUJARAT POLLTITION CONTROL BOARI)"Paryavaran Bhavan", Sector - l0-A,
GANDHINAGAR- 3820IO.
ANNUAL REPORT OF INDUSTRIAL UNIT FOR YEAR 2OI3-I4
(To be submitted outline (XCN) by each industrial unit on or before 3l" March in respectof Calendar Year ended on previous 3 l " December)
GPCB ID No.Name &Address of the Unit
Phone Nos.CCA No.. Date & Validity (copy ofconsent should be enclosed)Production:
ID No.28133Orbit Phanna Laboratories.Block no. 155/l,159,Chhatral-Kadi Road,Dhanot - 382 729.Ta. Kalol, Dist: Gandhinagar932881 5365
CCA vide no. AWH-45002,Dt,09.01.2012, valid up roDt.: 30. I I .201 6
Sr.1\ O.
Name of the Products Consented (CCA)Quantity per month
Total Producedduringprevious year20t2-t3
Totalproducedduring theyear 2013-14
Name of thesupportlngdocument orrecord
I Diclofenace Sodium
I.P.
2.5 mT,4vlonth
(30.0 mT/year)
24.625 mT 23.65 mT Attachedherewith
2. Diclofenace Potassium
B.P.
0.5 mTMonth
(6.0 mT/year)
2.375 mT 0.1 5 mT
J. Diclofenac Diethyl
Ammonium
0.25 mT/Month
(3.0 mT/year)
Sr.No. Name of the RawMaterials
Uonsented (CCA) orcalculated quantity peryear
Total consumedduring the year2013-14
Name of thesupporting documentor record
I Toluene 10.8 m l 8.925 mT
Sll6 mT
Attached herewith2. Caustic Soda Flakes 12 mT
...2
6 Rarv Materials (PM):
(..2..)
Utilities:
3. Activated Carbon 0.6 mT 0.476 mT
.+. 2.6 Dichloro Phenol 24 mT 19.825 mT
5. Methyl Mono
Chloro Acetate
18 mT 15.470 mT
6. Aniline Oil 21 mT 10.710 mT
7. Methanol 6.78 mT 10.710 mT
8. Sodium Metal 3.84 mT 2.570 mT
9. Chloro Acetyl
Chloride
31.2 mT 21.420 mT
10. Aluminium Chloride 36 mT 19.040 mT
11. Potassium
Carbonate
10.8 mT 10.234 rnT
12. Hydrow 0.4 mT 0.357 mT
I l. Hyflow 0.5 mT 0.4'76 mT
14. Caustic Potash 0.07 mT 0.060 mT
Total consumed duringthe year 2013-14
Name of the supportingdocument or record
Sr.No. Name of the Utility Consented (CCA)quantity per year
l. 2. 3. 4. 5.
l. Electric Power 178593 units
2. Captive Power
3. Water 3974 Kl
4. Coal/Coke5. Lignite6. Baggas
7. oil(NaqellpQ_8. Gas(Name)
Others.(woo4) 7E.435 m I
I
... 3
7
(..3..)
Wastes Generation & Disposal during the vear:
Sr.No.
NameoftheWaste
State(s,L,G)
Consented
Quantity
Total Quantity generated
during the year2013-14
Type &capacity oftreatmentfacility at site(ETP, APCMetc.)
Out sideDisposalfacility fortreatedwaste(dischargeplace)
TotalWastesdisposedduringthe year.
l. 2. 3. 4. 5. 6. 7. 8. 9. 10.
generated Reuse Treated
Effluent L t259.25KL
995 KL 995 Kr ETP NA 995 KI
Details of Elfluent Disnosal after Treatment:
10 Details of Solid/Gaseous wastes after treatment:
Sr.No. Name of the Wastestream
Total quantity disposed during the year
Disposal on landby
Directly dischargedto GIDCdrain/municipaldrain/sea.
Discharged to CETPby
I 2.3.
Tankers Pipeline
^ 6.
Effluent 995 KL NA NA NA
Total quantity disposed during the year 2012SrNo.
Nameof thewaste
Sent for
processrng
Sent toTSDF
lncinerated at Evaporated at Ventedthroughflue gas
stack
Ventedthroughprocessgas
scrubber
Ownsite
Commonfacility
Ownsite
Commonfacility
l. 2. 3. A 5. 6. 7. 8. 9. 10.
l. NA Nil...4
(..4..)
1 I Details of disnosal of Solvents. Ammonia Solutions and Acids after use:
Sr.No. Name of the Solvent,Ammonia solution orAcid
Total Quantity disposed during the year
Solvent distillation at Spent Acid Re-use or treatmentaI
Own site Othersite
Sale toActualUsers
Ownsite
Other site Sale toUSCTS
NA NA NA NA NA NA NA
12 Other Details:
(l) CETP Membership No., Date, Place & booked quantity (membership certificate should be
attached) : Not APPlicable
(2) TSDF Membership No., Date & Place : No Nil, dated: l7'03 201 1 '
(3) CHWI Membership No., Dated & Place : Not Applicable(4) Consent No' & Date of Reuser/Recycler etc': Not Applicable
Sr.No. Name, Address &Phone Nos. ofReuser/Recycler etc.
Consent No. & Date fromGPCB/CPCB./Other SPCB (For
transboundarY movement)
Total Quantity disPosed duringth-.,aor
Name of theWaste
Total Quatitysent during the
year.
1. 2. 3. 4. 5.
NA NA NA NA
A (5) Wastes' Transporters Details:
Sr.No.
NameAddress&PhoneNos. of theTransporters
VehicleRegistration Nos. ofTrucks/Tankers &capacity
Used to carry wasters HavingAuthorizationfromGPCB?
GPSsystemimplanted?
OnlineManifestS
implemented?
Log-bookmaintained?
Nameof thewaste
To cany atwhich place
for disposal
1 2.. 3. 4. 5. 6. 7. 8.
l. NA NA NA NA NA NA NA NA
2-
3....5
l3
(s)
Need of Ups:adation. if anv:Looking to the above production and wastes generation or/ and future planning to increase
production, mention any upgradation or addition of pollution control measures are
necessary in respect of-I, ETP2. Fuel change or use
3. APCM4. Scrubbing system for process gases
5. Noise control6. Solvent Recovery Unit
) NrL) NIL) NIL) NrL) NIL) NIL
Name &Designation
Note : Any false information or suppression of information to cancellation ofall tYPe ofpermissions from Board.
w
fr!!-: .h. t \\'r,rll(:il!L!{]
r()RIl * \'(\c( rul(s | -1 |
I r, rrt
(lltl]11'l'tlARi\t.\ l.r\ll(lR '\'l ( )ll I I'SElock Nrr. : lSSi l, lSq. ('hhalnrl-Kldi l{rttttl,I)lt.{lo'f 3ttl 119' I a. : Krtlol.l)ist. : (;dNl)lll..'/\GAli.
t.-
'[hc mcmbr'r Sccrttlq.Gujatat lt,,rlluti.rtr C ontr!,1 B('lfd.Secl0r l0 \,(i\NI)lll\.\(i \ll i5l lr I i
llNvIlt()N\|I.]i\ | j\L s I A | }.rt}:N.I iirr the tirlgncial}!' r cnJing the il.,\larchl!!!.
Ff\t{ -\ 1
\atttc .tnJ ird.lrcss,rt tttrJ trrrttcr( )a! Ufrir r\l lllt lllJ'.1\tr) \rl)('ritllr\llI)rr,itr..
Indurtry catc8nr) -
Prinrari - (SI( CodclSecondln tST(. f rrdc)
I'rudrrctic'n c:tpacity Llnits
Ycur,rt'eslrtrlishrncnt
I I,rrc ,,1 rht' lxJl l:tr\ tr!)llmclltltlSl te lcIl \lthll]11(cit
Il r. \. l'. Kill|ni l['rrrtntrt( )t{Bl1 tll.\ltuA t..\}'l()R \ l()Rll \
: llhrck \o. l55rl. l5t). ( hlrrtrll-Krttli Rorttl'
llllAl()'l Jlll :19. I a. : halttl,Ilirr.: (; \\ l)11li\A{ ' An.
: 'l ag l.i. SSI glf
: -Iag l.k. lt.-\\\' Pdf,
: l(l r{)Si 191)1.
: -]tl ll' 'lll l.l
\\ irtgr .r:rd ltil\r \llrlcttiLl | \r:]\illr)l)lrr'll
r I t \\ dlet ( ( 11'trlrtlti,'n lrl l)a)
['r,]ccss i :."1 lvl']/l)e] (averagt) (881 Mr/ycnr]
( d{.)linf i {.29 l\'lr/Dnl'(r}er$gt') (1289 lltriycar;
lnrnrcrlic : 6'{lt }tril)ll! {lla0{ Nlr/yesr) (lt includcr *tttcr for glrdcning also'1
\\ trl!r . . \ l]]flll\t1 |(l llJllt il
iir:01.r- lJ
( I I l)ickrfcnrcc Sodlrrnr l.P.(ll l)lclol(llilct I'otirrstunt ll l''
i
l'r . .\lr.r! t.
l irrarrcial r eltl0t2-tJ
o Inilrrstrl llli|\ rtlc c,'.lcs of dis'clt";itrg dctail i'l rJrr rnalcri&l rrt'ttld riolatc c{)Irtrlr(urtl
.!hli(.rti{.!r)\.,rtltt'nr isc .rlI indttstrtcr'
\II,\II,
\ll\II.
I ||r nctxl ) u;ll(ll
I ..li ,\\ \ 1.\ t l{ 1. l.
,\ I1'.\( llhl) IIl,RE\\ lTll'
Pollutit'n dischlrged tcr snrirontnrnt unit ofoutptrt(llurrrncter $s spccificd in ths cunscnt issucd)
of'pollutantsdischargcd
lmassr 0Il)')
rli, i 1.,,r l),,rrrtrtir I fllttcrtt : Lh'llior lnrlustrinl []l[']||tut : .1,,i2 ll'/l)i! lrr.trl|8()
( irntClilflll lrlO ',1l.)i lLrt.tlrt\ rllrlir,,lt;ttss
I lll.l\: \ \!luI)lC l
:All pollutrtlt\ t\lth (;P( ll lorrt.;.\ll U)llutrr|ls $itlt (,1'( ll |l'rr-ttt
: i\lll)ollull|nl\ riith (;P( ll oornr,
(0,
rht
Iirrrnt pfirctlr
I I0in ln,llulii)rl c\rrIr',)i litiiiilics
t ll (Jrrantrtr [,,'c )'c ler.1 Lrt tt'-utrltredw ith in the urlil
(2) Sold
(3i Di$po$cd
l',lla l l)ll,\/ \l{1,()l \ \\,\\l l \
! \r rpr:.rticrl Lrndcr lltrlittiiutts \\ ltsicr i\llrtlt'luttttrrl .trltl llxrlJlin!l l{ttlt" lirll';:
lirli!l (Jrri!r1:'r I Kr I
F-;fS,'lid \\';rstcr
I |.-J trr I
\ .
N .
I Lt,l mf
l) ring thc llrrr iousfinanc iol .rear
21.?.lml.
1)||r lrIlr( .!t , i
I r.ir- : ., r
]|)t-l tJ
lrl\tl
I {..12 nr I
\II,
Nn.
Itl.J6 m-I'
fhRr-?l
_l -t
P'\Rl - r
l)lel!e .'pcerl\ tlr. cllrfilelall/ u!rlt\ lin tcrnls '.rl q()nrr{!:ili{nl i'll}d quillllulltr')l ll'lTilltioll\ 'tr 'rtll ''
i ,tl(l \\il\tfs urrd irr.liclrt.'di,|],,..r1 pnr,.lict ud'tl\tc(l Ii,r h,rth tllert !xtL!oric\ 'r1 \\il\1c\
\(, | \l'l'l lt \ltl I
l'\la l ('
lrnpacr of thc ptrllulion Ebrtsnr€nt measures t*'en on conscrvation oi nalurul rEs(rurces and \)n tlr{
coct of ptoducliotl.
\()t \l't'l.t( \lll Ir
I'ART II
Additirrnal Ine&su$rinre$ment propo$l lor cnvironmenul iocluding protreliotl at]slcmenl
of pollutibn / prer'ention ot'pollution,
NOT APFLICABI,E
t'..\ lt I - I
Ar) ('lhcr pnnierlars lc'r inlpr,'rrittg lhc {usntit! ofthc envirc'nnrcnt-
\() | \l)l'l.l( \lll l.
I r*te ; 2ll/0li !01.1
L)csigrrotion : Authorlzctl signtrlory
Ur. \. l'. Kikxni
()RBl I Pll.\lt\! \ l, \lt(lltA l ()llll \Block No. : 155,'1. 159. ( hhstrrrl-htt(lt
- J82 t2e.l)i\t. : (;,\\l)lll\.\( ;.\l{.
Nitme
Address:
i
I!rd tl5lr) 'trIcr;tii!rn 1rl ft\'rc\\)
I ll)
I ). rlL l{}/{l- lllIJ
iI-1::trJli,,! \ rtlhot irtll \i*tl;ll r!
\rrtt.' \lt'. \. l'. Kikltri
\i1..!*.. t)l(Bl'f I'tl'\l{11\ 1.\tl(}R,\ l(tRll \Bluch Nu. : l55rl, l5q. (lhhll r';r l'h:trliRoud, DHAIO I -- J8? 719''ta. : Kalnl. l)irr. : CANDHTNA{; \l{'
I'r orlrrtt \ | ;r tt tt llt t t tl r t r| :
\, r:rt ( )l I't.rrlLt,.l l l .l- t l10 | :-1.]
t. l)i;1, lcrr,ric \,,,liutll I I' li. hS nr I
a. |)iil',l,,lt,rrt lr,,1,r. 'ltrllr lt l'',i 0littr
l.t 1,, \l.rlr'j II |,: ilr r,
\r ,.1.' 20lt-lJ 201.r- l,l
I t01
'i 8ll
r-l{l lr\ ,'l
; I I i(i{' kg. I
I
('.
1: .'., I0l | {)[,],
n \r'Lliuttr \lct.t I
q ( lrl' 'ri\ \.(t\ | ( lrl{rrirl(
I ().
il I 1610 kgr I
Ir. I l. ,1,,,\ I :: L:.
Il . ll, ,r i ',' l.:.
I.l
l
One Time Updationsp - On South Direction of the location of the Company -Chhatral-Kadi Road
e - Electric Company Name (Power Supply) UGVCL
p - On West Direction of the location of the Company -Mirambica (Factory)
p - On North Direction of the location of the Company -Audichem (Facotory)
o - Production since (Date) or Proposed 15/03/1992
p - On East Direction of the location of the Company -Open Plot
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
g - Nos of Stacks ( Flue Gas & Process ) 0, 0
h - Regd with T.S.D.F SEP-Bhachau-Saurashtra Enviro Projects Pvt. Ltd
k - Recycler Registration Valid ?? N.A
f - Display Board Provided at the Entrance ? Yes
j - Name & Address of MAIN Re-Cycler -
i - Recyclable Hazd Waste Disposal to O/s State
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
General Observationa - Is the Industry in Operation ?? Yes
a - R.O File No 391
b - Industry Operating without CCA Applied Applied for CCA renewal
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? N.A
h - Seperate Energy Meter for A.P.C.M ? N.A
h - Provision of any STAND-BY Pump ?? N.A
Air Relateda - Fuel Type confirmitive with CCA ? Yes
b - Av. Fuel Consumption EXCEEDING CCA limits No.
c - APC Measures confirmitive with CCA conditions ?? Yes
d - ALL APCMs are in operation Yes
e - SMF availability Provided
f - Thick Smoke observed in Flue Gas/Processes ?? No.
g - ph of Scrubbing Media as per requirement ?? Yes
h - Ultimate Disposal of Scrubbing Media ETP
i - Nos of Samples : Stack & Ambient 1, 0
Haz Waste Relateda - Haz waste Catg confirmitive with CCA Yes
b - H.W generation exceeding CCA limits No.
c - Collection, Storage, Treatmnt, Disposal Facility Adequate ?? Yes
d - Reusing or Recycling of Haz Waste by Industry ? No
e - LogBook / XGN Manifests / Disposal Records TALLYING ?? Fully
f - Stock of Haz-Waste @ premises/Whether EXCESS ? @
g - Recycler/ Actual user has valid Authorization under rules 6 or 9 of HOWR-2016? Yes not required
h -Installed capacity of the plane based on machinery installed (Capacity of Machine,No. of Batch/Day,Annual Capacity)
-
N I C2/6 ( Through XGN )19/01/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
PCB-ID: ( 28133 )
Remarks :
-
Site Observations during Inspection ,
i - Technical capability and equipment complying with the SOP/Guideline? Yes
j - Is unit complying the conditions gives in SOP/Guidelines? Yes
k - Facility is adequate for the applied process Yes
l - Passbook is maintained? Yes not required
m - Details of PLI, if applicable -
n - Details of safety spects provieded by the facility -
o - Seprate storage area for Haz. Waste for the utilization or generation from the process is provided? Yes
p - Quantity of Hazardous waste procured as per CCA? Yes
Water Parameterb - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 0
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C3/6 ( Through XGN )19/01/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
During visit ETP and APCM were found in operation. OPerate regularly.Dispose of stored hazardous solid waste from the solid waste storage area to TSDF site and submit details to the board.
Unit was visited with respect to CCA Renewal along with amendment application to manufacture (1) Diclofenac Sodium IP / BP = 2.5 MT/Month, (2) Diclofenac Potassium = 0.5 MT/Month and (3) Diclofenac Diethyl Ammonium = 0.25 MT/Month and found in operation during visit. Flow meter reading was noted 14710 KL provided on own bore well line for source of fresh water supply. Industrial water consumption was 10150 lpd and industrial wastewater generation was 3450 lpd. Domestic water consumption was 950 lpd and domestic wastewater generation was 650 lpd. Domestic wastewater was disposed of throuogh septic tank and soak pit system. It had provided Collection tank, Lime solution preparation tank, Neutralization tank, Zigzag chamber, Primary settling tank, Secondary collection tank (earlier aeration tank), Secondary settling tank with Hydrodynamic Cavitational treatment, Filter press, treated waste water holding tank. It had also provided single stage steam jacketed evaporator (capacity @ 4.5 KL/12 hrs) with condenser and condensate w/w collection tank. ETP with evaporator were found in operation during visit. No wastewater discharge was observed during visit. It had one HAG with stack which was found not in operation. During visit wood fired IBR Boiler (1TPH capacity) and its APCM (Multi cyclone) was found in operation. CTE amendment for IBR boiler was obtained and now applied for CCA amendment. Unit has provided two stage water scrubber followed by alkali ventury Scrubber for control of process emission from reaction vessel. During visit process reaction was going on and provided APCM was found in operation, hence one process gas emission sample was collected for HCl parameter during visit. pH of scrub liquor was found alkaline (9 to 10) on pH strip. Unit has one DG set of 100 KVA as a standby. During visit approx 32 MT ETP sludge was observed stored in a hazardous waste storage area. It is a member of TSDF – SEPPL and the person contacted informed that they were in contact with the TSDF and would send stored hazardous waste to TSDF at the earliest and would submit details to the board for the same. ETP sludge (24 MT/Year), Used Oil (0.025 MT/Year), Discarded Containers 300 No./year, Date Expired discarded and Off-specification medicines (0.5 MT/Year) and spent catalyst (0.2 MT/Year) are hazardous waste generated from the industry. General housekeeping was found fair. [537]-19/01/2017~ RO Comments/Reply : / I recommend :May be GRANTED (After making necessary verification; I agree with inspecting officer; hence issuance / renewal of Authorization to the Industry is recommended as per the provisions of Rule 6(2) of the Hazardous and Other Wastes (Management & Handling & Transboundary Movement) Rules 2016.)-19/01/2017
W.C Notings: not furnished[401-DEE]~
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Compliance Observed in this Inspections.Instructions in Previous Visits and Reply Insp Det Instruction Status
pH @ 6 411778(18/10/16) Partial Compliance
IBR Adequate SMF 411778(18/10/16) Partial Compliance
CCA Amendment CCA
CCA Renewal
411778(18/10/16) Fully Complied
1) RO Reject water
The corrective compliance dated 8/2/16 has been
submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
373764(05/02/16) Partial Compliance
N I C4/6 ( Through XGN )19/01/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark SMF APCM Fuel Consp-Unit Insp Remk1 Boiler 12 Old boiler to be
scrappedYES NOT Wood 0 Kg./hour
2 Hot Air Generator 8 YES NOT Wood 18Kg./hour3 Boiler 30 New IBR Boiler YES MUL Wood 12 Kg./hour
Details about Hazardous Waste Management :
Sample Details
Sr Act Ph/Temp/Air Sampled Time Type Sampling Point Col-Cond 1 A-1 30 lit / 1315-1330 REP from stack attached to reaction vessel through apcm ~ -
D
A
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical sludge from waste water treatment I -35.3 24.000-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 2 Used or Spent Oil I -5.1 0.025-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 3 Empty barrels/containers/liners contaminated with hazardous
chemicals /wastesI -33.1 4.000-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 4 Spent Catalyst I -28.2 0.200-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 5 Date-expired products I -28.5 0.500-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment,
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 dichlorophenol 2.600 - M.T2 acetic acid 0.000 - M.T3 activated carbon 0.165 - M.T4 alluminium chloride 3.900 - M.T5 aniline oil 1.765 - M.T6 caustc flakes 0.825 - M.T7 Caustic Potash 0.200 - M.T8 chloro acetyl chloride 2.600 - M.T9 diethyl amine. 0.200 - M.T10 filter aid dicamol 0.130 - M.T11 iso propyl alcohol 0.100 - M.T12 methanol 0.610 - M.T13 mono methyl chloro acetate 2.000 - M.T14 pottasium cabonate 1.170 - M.T15 s d s sprit 0.000 - M.T16 soda ash 0.306 - M.T17 sodium metal 0.420 - M.T18 sulphuric 0.000 - M.T19 toluene 1.300 - M.T
Raw material :F
Water Consumption & Generation Break upG
N I C5/6 ( Through XGN )19/01/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team : D. C. Vankani, E.E - S.R. Patel,SSA
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Signature By(D. C. Vankani, E.E )
Solid WasteH
N I C6/6 ( Through XGN )19/01/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
info@orbitpharma.co.in
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 18/10/2016 14:20 / Air , Water , Hazd
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
411778 ( After Notice of DIR )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak PitZero Discharge. / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Bhachau-Saurashtra Enviro Projects Pvt. Ltd
Person Contacted : MR. Kunal Kikani
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 21303-24/10/2016
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No30/07/2016 NOT 04/10/2016 33A,, 400323 NOT SCN 37205105/02/2016 SCN 23/03/2016 ,, 373764 SCN ROU 35053919/06/2015 REV 30/06/2015 3MT, 344368 REV REV 319202
Lab Charges Pending : Rs. 6270.00 Water Cess Charges Pending : NIL
Last Env. Form V : 2014-2015 Water Cess Return : 2015-2016 HW Monthly Return : 2016-99
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 21549, ETP - 1545, APCM - 1029 Meter Reading - 13278, Kilo Litre - 398 Meter Reading - 2356, Kilo Litre - 93
Monthly Patrak Data : Last Return : 201609 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/6 ( Through XGN )24/10/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
One Time Updationse - Electric Company Name (Power Supply) UGVCL
p - On South Direction of the location of the Company -Chhatral-Kadi Road
p - On North Direction of the location of the Company -Audichem (Facotory)
p - On East Direction of the location of the Company -Open Plot
o - Production since (Date) or Proposed 15/03/1992
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
p - On West Direction of the location of the Company -Mirambica (Factory)
g - Nos of Stacks ( Flue Gas & Process ) 0, 0
k - Recycler Registration Valid ?? N.A
f - Display Board Provided at the Entrance ? Yes
h - Regd with T.S.D.F SEP-Bhachau-Saurashtra Enviro Projects Pvt. Ltd
j - Name & Address of MAIN Re-Cycler -
i - Recyclable Hazd Waste Disposal to O/s State
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
General Observationa - Is the Industry in Operation ?? Yes
a - R.O File No 391
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? N.A
h - Seperate Energy Meter for A.P.C.M ? N.A
h - Provision of any STAND-BY Pump ?? N.A
Air Relateda - Fuel Type confirmitive with CCA ? Yes
b - Av. Fuel Consumption EXCEEDING CCA limits No.
c - APC Measures confirmitive with CCA conditions ?? Yes
d - ALL APCMs are in operation Yes
e - SMF availability Inadequate
f - Thick Smoke observed in Flue Gas/Processes ?? No.
g - ph of Scrubbing Media as per requirement ?? No. pH of scrubbing media @6 on pH strip
h - Ultimate Disposal of Scrubbing Media ETP
i - Nos of Samples : Stack & Ambient 0, 0
Haz Waste Relateda - Haz waste Catg confirmitive with CCA Yes
b - H.W generation exceeding CCA limits No.
c - Collection, Storage, Treatmnt, Disposal Facility Adequate ?? Yes
d - Reusing or Recycling of Haz Waste by Industry ? No
e - LogBook / XGN Manifests / Disposal Records TALLYING ?? Fully
f - Stock of Haz-Waste @ premises/Whether EXCESS ? @30MT ETP sludge
Water Parameterb - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
N I C2/6 ( Through XGN )24/10/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
pH @ 6
IBR Adequate SMF
CCA Amendment CCA CCA Renewal
This unit is visited with reference to notice of direction issued by board. Unit is engaged in manufacturing of Diclofenac Sodium, Diclofenac Potassium and Diclofenac Diethyl Ammonium. During visit unit is found in operation. Water is source through their own bore well and flow meter reading noted during visit is 13460KL. During visit one water sample is collected from bore well of unit. Unit has provided Collection tank, Lime solution preparation tank, Neutralization tank, Zigzag chamber, Primary settling tank, Secondary collection tank (earlier aeration tank), Secondary settling tank with Hydrodynamic Cavitational treatment, Filter press, treated waste water holding tank. Unit has provided single stage steam jacketed evaporator (capacity @ 4.5 KL/12 hrs) with condenser and condensate w/w collection tank. During visit ETP is found in operation. Unit is using Aluminum Chloride Anhydrous in process and separated Aluminum Chloride collected into HDPE tank of capacity 10KL. Unit is having one HAG with stack which is found not in operation. During visit wood fired IBR Boiler (1TPH capacity) and its APCM (Multi cyclone) is found in operation. SMF of stack attached IBR boiler is not adequate. Unit has obtained CTE amendment for IBR boiler and CCA amendment is still pending hence contacted person is instructed to apply for same. Unit has provided two stage water scrubber followed by alkali ventury Scrubber for control of process emission from reaction vessel. During visit reaction is found over and only distillation process is going on. Scrubbing media pH found @6 on pH strip hence contacted person is instructed to maintained alkaline pH of scrubbing media. Unit has one DG set of 100KVA as a standby. During visit @30MT ETP sludge observed stored in a hazardous waste storage area. Written instructions are given to contacted person. [655]-21/10/2016
W.C Notings: not furnished[401-DEE]~
PCB-ID: ( 28133 )
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Remarks :
-
Site Observations during Inspection ,
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 0
Compliance Observed in this Inspections.
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C3/6 ( Through XGN )24/10/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Instructions in Previous Visits and Reply Insp Det Instruction Status
1) RO Reject water
The corrective compliance dated 8/2/16 has been
submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
373764(05/02/16) Partial Compliance
The corrective compliance is submitted on 11/1/16 to Unt Head,
GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
DG Set CCA-Amendment The corrective
compliance is submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
The corrective compliance is
submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
Alcl2 Hcl The corrective
compliance is submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
N I C4/6 ( Through XGN )24/10/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark SMF APCM Fuel Consp-Unit Insp Remk1 Boiler 12 Old boiler to be
scrappedYES NOT Wood 0 Kg./hour
2 Hot Air Generator 8 YES NOT Wood 18Kg./hour3 Boiler 30 New IBR Boiler YES MUL Wood 12 Kg./hour
Details about Hazardous Waste Management :
Sample Details
Sr Act Ph/Temp/Air Sampled Time Type Sampling Point Col-Cond 1 W-22 @7 to 8 on ph strip / 30 1430-1430 REP borewell water of orbit pharma unit ~ colorless
D
A
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical sludge from waste water treatment I -35.3 24.000-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 2 Used or Spent Oil I -5.1 0.025-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 3 Empty barrels/containers/liners contaminated with hazardous
chemicals /wastesI -33.1 4.000-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 4 Spent Catalyst I -28.2 0.200-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment, 5 Date-expired products I -28.5 0.500-M.T Collection, Incineration, Reuse, Storage,
Transportation, Treatment,
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Water Consumption & Generation Break upG
N I C5/6 ( Through XGN )24/10/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team : Desai Saurabhkumar S - S.R. Patel,SSA
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Signature By(Desai Saurabhkumar S )
Solid WasteH
N I C6/6 ( Through XGN )24/10/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
info@orbitpharma.co.in
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 30/07/2016 15:30 / Water
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
400323 ( After SCN Inspection )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak PitZero Discharge. / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Bhachau-Saurashtra Enviro Projects Pvt. Ltd
Person Contacted : N P Kikani, Incharge
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 20850-16/08/2016
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No05/02/2016 SCN 23/03/2016 ,, 373764 SCN ROU 35053919/06/2015 REV 30/06/2015 3MT, 344368 REV REV 31920228/04/2015 DIR 08/06/2015 33A,O15, 337804 DIR VIG 316641
Lab Charges Pending : NIL Water Cess Charges Pending : NIL
Last Env. Form V : 2014-2015 Water Cess Return : 2015-2016 HW Monthly Return : 2016-07
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 23535, ETP - 2750, APCM - 1372 Meter Reading - 12475, Kilo Litre - 241 Meter Reading - 2168, Kilo Litre - 93
Monthly Patrak Data : Last Return : 201607 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/5 ( Through XGN )16/08/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Remarks :
-
One Time Updations
p - On South Direction of the location of the Company -Chhatral-Kadi Road
e - Electric Company Name (Power Supply) UGVCL
p - On North Direction of the location of the Company -Audichem (Facotory)
p - On East Direction of the location of the Company -Open Plot
o - Production since (Date) or Proposed 15/03/1992
p - On West Direction of the location of the Company -Mirambica (Factory)
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
k - Recycler Registration Valid ?? N.A
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
General Observation
a - R.O File No 391
a - Is the Industry in Operation ?? Yes
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? No.
h - Seperate Energy Meter for A.P.C.M ? No.
h - Provision of any STAND-BY Pump ?? No.
Water Parameter
b - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 1
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C2/5 ( Through XGN )16/08/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
please refer genral complain report [211]-09/08/2016
W.C Notings: 14.1 klpd[533-AEE]~
PCB-ID: ( 28133 )
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Site Observations during Inspection ,
Compliance Observed in this Inspections.Instructions in Previous Visits and Reply Insp Det Instruction Status
1) RO Reject water
The corrective compliance dated 8/2/16 has been
submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
373764(05/02/16) ---
The corrective compliance is submitted on 11/1/16 to Unt Head,
GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
DG Set CCA-Amendment The corrective
compliance is submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
The corrective compliance is
submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
Alcl2 Hcl The corrective
compliance is submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar.~The corrective compliance dated 11/1/16 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
369637(08/01/16) Still Pending
Alcl3 HCL (by product)
The corrective compliance
dated 20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O.~The corrective compliance dated 20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
351336(17/08/15) Still Pending
New Boiler (1T) D.G.Set (100 KVA) CTE CCA-
Amendment The corrective compliance dated
20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O.~The corrective compliance dated 20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
351336(17/08/15) Still Pending
ETP
Active TSDF ETP
The corrective compliance dated
20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O.~The corrective compliance dated 20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar. (05/03/2016)
351336(17/08/15) Still Pending
N I C3/5 ( Through XGN )16/08/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark SMF APCM Fuel Consp-Unit Insp Remk1 Boiler 12 Old boiler to be
scrappedYES NOT Wood 0 Kg./hour
2 Hot Air Generator 8 YES NOT Wood 18Kg./hour3 Boiler 30 New IBR Boiler YES MUL Wood 12 Kg./hour
Details about Hazardous Waste Management :
Sample Details
Sr Act Ph/Temp/Air Sampled Time Type Sampling Point Col-Cond 1 W-21 @ 7 to 8 on ph strip / 29 1535-1535 REP from bore well of the unit ~ Colourless
D
A
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical sludge from waste water treatment I -35.3 24.000-M.T COL,DST,STO,TRA2 Used or Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Empty barrels/containers/liners contaminated with hazardous
chemicals /wastesI -33.1 4.000-M.T COL,REU,STO
4 Spent Catalyst I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-expired products I -28.5 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C4/5 ( Through XGN )16/08/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team : M.P. Shah, SO - Nayee Bhupendrakumar V. - Ms. Thakkar Alpaben P - G.B. Shah,SSA(M)
Signature By(M.P. Shah, SO )
N I C5/5 ( Through XGN )16/08/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
info@orbitpharma.co.in
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 05/02/2016 14:50 / Water
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
373764 ( Routine Visit )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak PitZero Discharge. / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Bhachau-Saurashtra Enviro Projects Pvt. Ltd
Person Contacted : MR. Kunal Kikani
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 19676-20/02/2016
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No19/06/2015 REV 30/06/2015 3MT, 344368 REV REV 31920228/04/2015 DIR 08/06/2015 33A,O15, 337804 DIR VIG 31664108/09/2014 REV 11/11/2014 PER, 307275 REV APP 230268
Lab Charges Pending : NIL Water Cess Charges Pending : NIL
Last Env. Form V : 2014-2015 Water Cess Return : 2014-2015 HW Monthly Return : 2016-01
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 22259, ETP - 1456, APCM - 950 Meter Reading - 10250, Kilo Litre - 376 Meter Reading - 1620, Kilo Litre - 89
Monthly Patrak Data : Last Return : 201601 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/6 ( Through XGN )20/02/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Remarks :
-
One Time Updations
p - On South Direction of the location of the Company -Chhatral-Kadi Road
o - Production since (Date) or Proposed 15/03/1992
e - Electric Company Name (Power Supply) UGVCL
p - On North Direction of the location of the Company -Audichem (Facotory)
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
p - On West Direction of the location of the Company -Mirambica (Factory)
p - On East Direction of the location of the Company -Open Plot
k - Recycler Registration Valid ?? N.A
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
General Observation
a - R.O File No 391
a - Is the Industry in Operation ?? Yes
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? N.A
h - Seperate Energy Meter for A.P.C.M ? No.
h - Provision of any STAND-BY Pump ?? No.
Water Parameter
b - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 0
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C2/6 ( Through XGN )20/02/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
1) RO Reject water
With respect to Complain regarding contaminated bore well water found at Survey No-76/1, At-Ankhol, Po-Indrad, Ta- Kadi, Dist-Mehsana received from Shri Dr. Hardanbhai R Gadhavi, preliminary investigation was carried out on dtd: 28/01/2016 & 03/02/2016 by Mehsana Regional Office. In continuation of this since the bore well is located near the Adjoining boundaries of District Mehsana and Gandhinagar it was decided to carry out further investigation of the surrounding area and industries jointly by monitoring team of Regional office Mehsana and Regional office Gandhinagar. This Joint Investigation has been carried out on dtd: 05/02/2016 and 12/02/2016, under the supervision of both Regional Officers. Detailed visit report uploaded herewith [387]-17/02/2016
W.C Notings: Not submitted.[387-NRO]~
PCB-ID: ( 28133 )
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Site Observations during Inspection ,
Compliance Observed in this Inspections.
N I C3/6 ( Through XGN )20/02/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Instructions in Previous Visits and Reply Insp Det Instruction Status
The corrective compliance is submitted on 11/1/16 to Unt Head,
GPCB, Gandhinagar. (21/01/2016)
369637(08/01/16) Still Pending
DG Set CCA-Amendment The corrective
compliance is submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar. (21/01/2016)
369637(08/01/16) Still Pending
The corrective compliance is
submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar. (21/01/2016)
369637(08/01/16) Still Pending
Alcl2 Hcl The corrective
compliance is submitted on 11/1/16 to Unt Head, GPCB, Gandhinagar. (21/01/2016)
369637(08/01/16) Still Pending
Alcl3 HCL (by product)
The corrective compliance
dated 20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O. (21/08/2015)
351336(17/08/15) Still Pending
New Boiler (1T) D.G.Set (100 KVA) CTE CCA-
Amendment The corrective compliance dated
20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O. (21/08/2015)
351336(17/08/15) Still Pending
ETP
Active TSDF ETP
The corrective compliance dated
20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O. (21/08/2015)
351336(17/08/15) Still Pending
ETP
CTE-Re consideration CCA-Amendment
Aluminum chloride solution Amendment
Condensate water
; The corrective compliance reply dated 19/6/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O., GPCB, Gandhinagar. (31/07/2015)
344368(19/06/15) Partial Compliance
N I C4/6 ( Through XGN )20/02/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team :
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark APCM Fuel Consp-Unit SMF1 Boiler 12 Old boiler to be scrapped NOT Wood 0 Kg./hour YES2 Hot Air Generator 8 NOT Wood 18Kg./hour YES3 Boiler 30 New IBR Boiler MUL Wood 12 Kg./hour YES
Details about Hazardous Waste Management :
Sample Details
D
A
B.N.PATEL,SSA - H.A.Rathod,SO
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical Sludge From Waste Water Treatment I -34.3 24.000-M.T COL,DST,STO,TRA2 Used Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Discarded Containers / Barrels / Liners contaminated with
Hazardous Wastes/ChemicalsI -33.3 4.000-M.T COL,REU,STO
4 Spent Catalyst / Spent Carbon I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-Expired, Discarded And Off-Specification Drugs/Medicines I -28.4 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C5/6 ( Through XGN )20/02/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Signature By(B.N.PATEL,SSA )
N I C6/6 ( Through XGN )20/02/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
info@orbitpharma.co.in
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 08/01/2016 16:30 / Air , Water , Hazd
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
369637 ( Routine Visit )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak PitZero Discharge. / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Bhachau-Saurashtra Enviro Projects Pvt. Ltd
Person Contacted : MR.Kunal Kikani
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 19480-27/01/2016
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No19/06/2015 REV 30/06/2015 3MT, 344368 REV REV 31920228/04/2015 DIR 08/06/2015 33A,O15, 337804 DIR VIG 31664108/09/2014 REV 11/11/2014 PER, 307275 REV APP 230268
Lab Charges Pending : NIL Water Cess Charges Pending : NIL
Last Env. Form V : 2014-2015 Water Cess Return : 2014-2015 HW Monthly Return : 2015-99
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 17984, ETP - 1389, APCM - 810 Meter Reading - 0, Kilo Litre - 360 Meter Reading - 0, Kilo Litre - 89
Monthly Patrak Data : Last Return : 201512 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/6 ( Through XGN )27/01/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
One Time Updations
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
p - On West Direction of the location of the Company -Mirambica (Factory)
o - Production since (Date) or Proposed 15/03/1992
p - On North Direction of the location of the Company -Audichem (Facotory)
p - On East Direction of the location of the Company -Open Plot
p - On South Direction of the location of the Company -Chhatral-Kadi Road
e - Electric Company Name (Power Supply) UGVCL
g - Nos of Stacks ( Flue Gas & Process ) 0, 0
h - Regd with T.S.D.F NAR-Naroda Enviro Prj Ltd. Ahmedabad [12719]
k - Recycler Registration Valid ?? N.A
f - Display Board Provided at the Entrance ? Yes
j - Name & Address of MAIN Re-Cycler --
i - Recyclable Hazd Waste Disposal to O/s State
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
General Observation
a - R.O File No 391
a - Is the Industry in Operation ?? Yes
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? No.
h - Seperate Energy Meter for A.P.C.M ? No.
h - Provision of any STAND-BY Pump ?? No.
Air Relateda - Fuel Type confirmitive with CCA ? Yes
b - Av. Fuel Consumption EXCEEDING CCA limits No.
c - APC Measures confirmitive with CCA conditions ?? Yes
d - ALL APCMs are in operation Yes
e - SMF availability Provided
f - Thick Smoke observed in Flue Gas/Processes ?? No.
g - ph of Scrubbing Media as per requirement ?? Yes
h - Ultimate Disposal of Scrubbing Media ETP
i - Nos of Samples : Stack & Ambient 0, 0
Haz Waste Relateda - Haz waste Catg confirmitive with CCA Yes
b - H.W generation exceeding CCA limits No.
N I C2/6 ( Through XGN )27/01/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
This unit is visited with reference to routine monitoring. Unit is engaged in manufacturing of Diclofenic Sodium, Diclofenic Potessium, Diclofenic Diethyl Ammonium. During visit unit is found in operation. Water is sourced through their own bore well and flow meter reading noted during visit is 10285 KL. Unit is using Aluminum Chloride Anhydrous in process. Now unit has started separating of Aluminum Chloride stream and they have provided one HDPE tank 10 KL capacity for collection of Aluminum Chloride solution. Unit has provided Collection tank, Lime solution preparation tank, Neutralization tank, Zig zag chamber, Primary settling tank, Secondary collection tank (earlier aeration tank), Secondary settling tank with Hydrodynamic Cavitational treatment, Filter press, treated waste water holding tank. Unit has provided single stage steam jacketed evaporator (capacity @ 4.5 KL/12 hrs) with condensor and condensate w/w collection tank. During visit all ETP units are found in operation and evaporator is also found in operation. No any wastewater discharge is observed at the time of visit. Unit is having one HAG with stack height of @ 8 meter & SMF. During visit new Boiler (1 TPH capacity) and its APCM (Multi cyclone) are found not in operation upon asking person contacted replied that due to waiting of boiler inspection some maintenance are taken. Unit has provided two nos. water scrubbers in series followed by Alkali Venturi Scrubber for control of process emission. This unit is also having one DG set of 100 KVA as a standby facility. Unit has yet not applied for CCA - Amendment for new Boiler (1 TPH capacity) and DG set of 100 KVA. During visit @ 17 MT ETP sludge observed stored in a hazardous waste storage area. CTE – Amendment for selling of Byproduct ALCL3 & HCL was rejected by Board. [387]-19/01/2016
W.C Notings: Not submitted[387-NRO]~
PCB-ID: ( 28133 )
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Remarks :
-
Site Observations during Inspection ,
c - Collection, Storage, Treatmnt, Disposal Facility Adequate ?? Yes
d - Reusing or Recycling of Haz Waste by Industry ? No
e - LogBook / XGN Manifests / Disposal Records TALLYING ??
Partially
f - Stock of Haz-Waste @ premises/Whether EXCESS ? @ 17 MT
Water Parameter
b - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 0
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C3/6 ( Through XGN )27/01/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
DG Set CCA-Amendment
Alcl2 Hcl
Compliance Observed in this Inspections.Instructions in Previous Visits and Reply Insp Det Instruction Status
Alcl3 HCL (by product)
The corrective compliance
dated 20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O. (21/08/2015)
351336(17/08/15) Still Pending
New Boiler (1T) D.G.Set (100 KVA) CTE CCA-
Amendment The corrective compliance dated
20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O. (21/08/2015)
351336(17/08/15) Still Pending
ETP
Active TSDF ETP
The corrective compliance dated
20/8/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O. (21/08/2015)
351336(17/08/15) Still Pending
ETP
CTE-Re consideration CCA-Amendment
Aluminum chloride solution Amendment
Condensate water
; The corrective compliance reply dated 19/6/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O., GPCB, Gandhinagar. (31/07/2015)
344368(19/06/15) Partial Compliance
337804(28/04/15) Still Pending
CTE (NOC) TPH) 337804(28/04/15) Partial Compliance
337804(28/04/15) Partial Compliance
ZLD 337804(28/04/15) Partial Compliance
ETP SST
ETP
ETP
337804(28/04/15) Fully Complied
We are strictly producing as gtanted in our CC&A.
(19/01/2016)
337804(28/04/15) Still Pending
N I C4/6 ( Through XGN )27/01/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team :
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark APCM Fuel Consp-Unit SMF1 Boiler 12 Old boiler to be scrapped NOT Wood 0 Kg./hour YES2 Hot Air Generator 8 NOT Wood 18Kg./hour YES3 Boiler 30 New IBR Boiler MUL Wood 12 Kg./hour YES
Details about Hazardous Waste Management :
Sample Details
D
A
V.R. Patel, R.O Head - K.M. Thakar,S.O - B.N.PATEL,SSA
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical Sludge From Waste Water Treatment I -34.3 24.000-M.T COL,DST,STO,TRA2 Used Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Discarded Containers / Barrels / Liners contaminated with
Hazardous Wastes/ChemicalsI -33.3 4.000-M.T COL,REU,STO
4 Spent Catalyst / Spent Carbon I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-Expired, Discarded And Off-Specification Drugs/Medicines I -28.4 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C5/6 ( Through XGN )27/01/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Signature By(V.R. Patel, R.O Head )
N I C6/6 ( Through XGN )27/01/2016
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
pharmaa_orbit@yahoo.com
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 17/08/2015 15:55 / Air , Water , Hazd
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
351336 ( On Application )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak PitZero Discharge. / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Naroda Enviro Prj Ltd. Ahmedabad [12719]
Person Contacted : MR.KUNAL KIKANI - GENERAL MANAGER
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 18784-31/08/2015
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No19/06/2015 REV 30/06/2015 3MT, 344368 REV REV 31920228/04/2015 DIR 08/06/2015 33A,O15, 337804 DIR VIG 31664108/09/2014 REV 11/11/2014 PER, 307275 REV APP 230268
Lab Charges Pending : NIL Water Cess Charges Pending : NIL
Last Env. Form V : 2013-2014 Water Cess Return : 2014-2015 HW Monthly Return : 2015-07
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 16967, ETP - 715, APCM - 673 Meter Reading - 0, Kilo Litre - 341 Meter Reading - 0, Kilo Litre - 90
Monthly Patrak Data : Last Return : 201507 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
One Time Updations
e - Electric Company Name (Power Supply) UGVCL
p - On South Direction of the location of the Company -Chhatral-Kadi Road
p - On East Direction of the location of the Company -Open Plot
p - On West Direction of the location of the Company -Mirambica (Factory)
p - On North Direction of the location of the Company -Audichem (Facotory)
o - Production since (Date) or Proposed 15/03/1992
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
g - Nos of Stacks ( Flue Gas & Process ) 0, 0
h - Regd with T.S.D.F NAR-Naroda Enviro Prj Ltd. Ahmedabad [12719]
k - Recycler Registration Valid ?? N.A
f - Display Board Provided at the Entrance ? Yes
j - Name & Address of MAIN Re-Cycler --
i - Recyclable Hazd Waste Disposal to O/s State
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
General Observation
a - R.O File No 391
a - Is the Industry in Operation ?? No. due to mainteinance unit is found not in operation
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? N.A
h - Seperate Energy Meter for A.P.C.M ? N.A
h - Provision of any STAND-BY Pump ?? N.A
Air Relateda - Fuel Type confirmitive with CCA ? Yes
b - Av. Fuel Consumption EXCEEDING CCA limits No.
c - APC Measures confirmitive with CCA conditions ?? Yes
d - ALL APCMs are in operation No.
e - SMF availability Provided
f - Thick Smoke observed in Flue Gas/Processes ?? No.
g - ph of Scrubbing Media as per requirement ?? Yes
h - Ultimate Disposal of Scrubbing Media ETP
i - Nos of Samples : Stack & Ambient 0, 0
Haz Waste Relateda - Haz waste Catg confirmitive with CCA Yes
b - H.W generation exceeding CCA limits No.
N I C2/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
PCB-ID: ( 28133 )
Remarks :
-
Site Observations during Inspection ,
c - Collection, Storage, Treatmnt, Disposal Facility Adequate ?? Yes
d - Reusing or Recycling of Haz Waste by Industry ? No
e - LogBook / XGN Manifests / Disposal Records TALLYING ??
Fully
f - Stock of Haz-Waste @ premises/Whether EXCESS ? @ 12 MT
Water Parameter
b - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? No
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 0
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C3/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Alcl3 HCL (by product)
New Boiler (1T) D.G.Set (100 KVA) CTE CCA-Amendment
ETP Active
TSDF ETP
This unit is visited on 17-8-2015 with reference to CTE – Amendment application for recovery of Byproduct ALCL3 & HCL and for sell out to actual user. Unit is engaged in manufacturing of Diclofenic Sodium, Diclofenic Potessium, Diclofenic Diethyl Ammonium. During visit unit is found not in operation due to maintenance. Water is sourced through their own bore well and flow meter reading noted during visit is 08304 KL. Unit is using Aluminum Chloride Anhydrous in process. Now unit has started separating of Aluminum Chloride stream and they have provided one HDPE tank 10 KL capacity for collection of Aluminum Chloride solution. Unit has provided Collection tank, Lime solution preparation tank, Neutralization tank, Zig zag chamber, Primary settling tank, Secondary collection tank (earlier aeration tank), Secondary settling tank with Hydrodynamic Cavitational treatment, Filter press, treated waste water holding tank. Unit has provided single stage steam jacketed evaporator (capacity @ 4.5 KL/12 hrs) with condensor and condensate w/w collection tank. Evaporator inlet flow meter reading noted during visit is 01124 KL. During visit all ETP units are found not in operation and evaporator is also found not in operation. Condensate w/w being collected in final collection tank. Unit has not clarified disposal of Condensate water. No any wastewater discharge is observed at the time of visit. Unit is having one HAG with stack height of @ 8 meter & SMF. During visit new Boiler (1 TPH capacity) and its APCM (Multi cyclone) are found not in operation upon asking person contacted replied that due to waiting of boiler inspection some maintenance are taken. Unit has provided two nos. water scrubbers in series followed by Alkali Venturi Scrubber for control of process emission. This unit is also having one DG set of 100 KVA as a standby facility. Written instruction given for applied for the CCA - Amendment for new Boiler (1 TPH capacity) and DG set of 100 KVA. During visit @ 12 MT ETP sludge observed stored in a hazardous waste storage area, hence written instruction is also issued to become a member of active TSDF site & dispose all the generated & accumulated ETP sludge and intimate to board along with proof. [324]-26/08/2015~ RO Comments/Reply : / I recommend :May be REJECTED-31/08/2015
W.C Notings: not furnished[401-DEE]~
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Compliance Observed in this Inspections.
N I C4/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Instructions in Previous Visits and Reply Insp Det Instruction Status
ETP
CTE-Re consideration CCA-Amendment
Aluminum chloride solution Amendment
Condensate water
; The corrective compliance reply dated 19/6/15 has been submitted to Unit Head, GPCB, Gandhinagar & a copy to R.O., GPCB, Gandhinagar. (31/07/2015)
344368(19/06/15) Partial Compliance
337804(28/04/15) Still Pending
CTE (NOC) TPH) 337804(28/04/15) Partial Compliance
337804(28/04/15) Partial Compliance
ZLD 337804(28/04/15) Partial Compliance
ETP SST
ETP
ETP
337804(28/04/15) Fully Complied
337804(28/04/15) Still Pending
SMF ladder Adequate SMF 307275(08/09/14) Still Pending
Sludge Storage area leachate collection facility 307275(08/09/14) Partial Compliance
ETP units cleaning & Maintenance
ETP
307275(08/09/14) Partial Compliance
N I C5/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team :
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark APCM Fuel Consp-Unit SMF1 Boiler 12 Old boiler to be scrapped NOT Wood 0 Kg./hour YES2 Hot Air Generator 8 NOT Wood 18Kg./hour YES3 Boiler 30 New IBR Boiler MUL Wood 12 Kg./hour YES
Details about Hazardous Waste Management :
Sample Details
D
A
K.M. Thakar,S.O - S.R. Patel,SSA
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical Sludge From Waste Water Treatment I -34.3 24.000-M.T COL,DST,STO,TRA2 Used Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Discarded Containers / Barrels / Liners contaminated with
Hazardous Wastes/ChemicalsI -33.3 4.000-M.T COL,REU,STO
4 Spent Catalyst / Spent Carbon I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-Expired, Discarded And Off-Specification Drugs/Medicines I -28.4 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C6/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Signature By(K.M. Thakar,S.O )
N I C7/7 ( Through XGN )31/08/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
pharmaa_orbit@yahoo.com
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 19/06/2015 12:05 / Air , Water , Hazd
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
344368 ( On/For Revocation )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak Pitpartly to CHWI,SocietyforClean Earth&Gardening / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Naroda Enviro Prj Ltd. Ahmedabad [12719]
Person Contacted : MR.KUNALBHAI KIKANI
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 18425-23/06/2015
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No28/04/2015 DIR 08/06/2015 33A,O15, 337804 DIR VIG 31664108/09/2014 REV 11/11/2014 PER, 307275 REV APP 23026801/07/2014 SCN 16/08/2014 33A,IMM, 299708 SCN SCN 222275
Lab Charges Pending : NIL Water Cess Charges Pending : Rs. 0.00
Last Env. Form V : 2013-2014 Water Cess Return : 2013-2014 HW Monthly Return : 2015-05
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 12255, ETP - 377, APCM - 671 Meter Reading - 7516, Kilo Litre - 345 Meter Reading - 0, Kilo Litre - 0
Monthly Patrak Data : Last Return : 201505 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
One Time Updations
e - Electric Company Name (Power Supply) UGVCL
p - On West Direction of the location of the Company -Mirambica (Factory)
o - Production since (Date) or Proposed 15/03/1992
p - On North Direction of the location of the Company -Audichem (Facotory)
p - On East Direction of the location of the Company -Open Plot
p - On South Direction of the location of the Company -Chhatral-Kadi Road
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
g - Nos of Stacks ( Flue Gas & Process ) 0, 0
h - Regd with T.S.D.F NAR-Naroda Enviro Prj Ltd. Ahmedabad [12719]
f - Display Board Provided at the Entrance ? Yes
k - Recycler Registration Valid ?? N.A
j - Name & Address of MAIN Re-Cycler --
i - Recyclable Hazd Waste Disposal to O/s State
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
General Observation
a - R.O File No 391
a - Is the Industry in Operation ?? Yes
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? No.
h - Seperate Energy Meter for A.P.C.M ? No.
h - Provision of any STAND-BY Pump ?? No.
Air Relateda - Fuel Type confirmitive with CCA ? Yes
b - Av. Fuel Consumption EXCEEDING CCA limits No.
c - APC Measures confirmitive with CCA conditions ?? Yes
d - ALL APCMs are in operation Yes
e - SMF availability Provided
f - Thick Smoke observed in Flue Gas/Processes ?? No.
g - ph of Scrubbing Media as per requirement ?? Yes
h - Ultimate Disposal of Scrubbing Media ETP
i - Nos of Samples : Stack & Ambient 0, 0
Haz Waste Relateda - Haz waste Catg confirmitive with CCA Yes
b - H.W generation exceeding CCA limits No.
N I C2/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
PCB-ID: ( 28133 )
Remarks :
-
Site Observations during Inspection ,
c - Collection, Storage, Treatmnt, Disposal Facility Adequate ?? Yes
d - Reusing or Recycling of Haz Waste by Industry ? No
e - LogBook / XGN Manifests / Disposal Records TALLYING ??
Fully
f - Stock of Haz-Waste @ premises/Whether EXCESS ? @ 9.0 MT
Water Parameter
b - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 1
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C3/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
ETP
CTE-Re consideration
CCA-Amendment
Aluminum chloride solution Amendment
Condensate water
This unit is visited with ref. to closure direction issued by Board under section-33 A of the Water Act-1974 within fifteen days effect. Unit is engaged in manufacturing of Diclofenic Sodium, Diclofenic Potessium, Diclofenic Diethyl Ammonium. Unit is found in operation at the time of visit Hydrolysis of DicloFenic Crude is going on. Water is sourced through their own bore well and flow meter reading noted 7724 KL. Unit is using Aluminum Chloride Anhydrous in process. Now unit has started separating of Aluminum Chloride solution and they have provided one HDPE tank 10 KL capacity for collection of Aluminum Chloride solution. No spent acid is sold outside during visit. Unit has provided Collection tank, Lime solution preparation tank, Neutralization tank, Zig zag chamber, Primary settling tank, Secondary collection tank (earlier aeration tank), Secondary settling tank with Hydrodynamic Cavitational treatment, treated waste water holding tank. Unit has provided single stage steam jacketed evaporator(capacity @ 4.5 KL/12 hrs) instead of MEE with condensor and condensate w/w collection tank. Evaporator inlet flow meter (Old meter provided) reading noted 01014 KL. During visit all ETP units are found in operation and evaporator is also found in operation and condensate w/w being collected in final collection tank and one condensate water sample collected to know the quality. No any wastewater discharge is observed at the time of visit. Unit has procured one filter press for ETP but yet not commissioned. During visit new Boiler (1 TPH capacity) and its APCM are found in operation upon asking person contacted replied that they have old boiler by new boiler as par direction given by Boiler Inspectior. Unit has provided two nos. water scrubbers in series followed by Alkali Venturi Scrubber for control of process emission. During visit process stages leading to emission of HCl, Cl2 & SO2 are not going on. This unit is also having one DG set of 100 KVA as a standby facility. Written instruction given for applied for Amendment for Aluminum Chloride disposal, new boiler and reply regarding condensate waste water disposal. [387]-23/06/2015
W.C Notings: Not submitted[387-NRO]~
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Compliance Observed in this Inspections.
N I C4/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Instructions in Previous Visits and Reply Insp Det Instruction Status
337804(28/04/15) Still Pending
CTE (NOC) TPH) 337804(28/04/15) Still Pending
337804(28/04/15) Partial Compliance
ZLD 337804(28/04/15) Partial Compliance
ETP SST
ETP
ETP
337804(28/04/15) Fully Complied
337804(28/04/15) Still Pending
SMF ladder Adequate SMF 307275(08/09/14) Still Pending
Sludge Storage area leachate collection facility 307275(08/09/14) Still Pending
ETP units cleaning & Maintenance
ETP
307275(08/09/14) Still Pending
ETP SDB Ground Floor Level 305145(20/08/14) Fully Complied
305145(20/08/14) Still Pending
CTE-Amendment 305145(20/08/14) Fully Complied
N I C5/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark APCM Fuel Consp-Unit SMF1 Boiler 12 Old boiler to be scrapped NOT Wood 0 Kg./hour YES2 Hot Air Generator 8 NOT Wood 18Kg./hour YES3 Boiler 30 New IBR Boiler MUL Wood 12 Kg./hour YES
Details about Hazardous Waste Management :
Sample Details
Sr Act Ph/Temp/Air Sampled Time Type Sampling Point Col-Cond 1 W-12 @ 7 to 8 on ph strip / 30 1215-1215 REP condensate w/w of evaporator ~ Pink
D
A
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical Sludge From Waste Water Treatment I -34.3 24.000-M.T COL,DST,STO,TRA2 Used Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Discarded Containers / Barrels / Liners contaminated with
Hazardous Wastes/ChemicalsI -33.3 4.000-M.T COL,REU,STO
4 Spent Catalyst / Spent Carbon I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-Expired, Discarded And Off-Specification Drugs/Medicines I -28.4 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C6/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team : B.N.PATEL,SSA - S.R. Patel,SSA
Signature By(B.N.PATEL,SSA )
N I C7/7 ( Through XGN )23/06/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
pharmaa_orbit@yahoo.com
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals (Excluding Formulation). / In Operation Inspection Dt & Time : 28/04/2015 16:30 / Water , Hazd
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
337804 ( By Vigilance Team )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Irrigation / Soak Pitpartly to CHWI,SocietyforClean Earth&Gardening / Gardening & Plantation
Ind : Dom : 0.9503.450Ind : Dom : 0.650
27934/00128/2
Waste Water generation / Discharge (klpd) :
AWH-45002-30/11/2016 Last Inward:52097-01/12/2011-[GRT]
No
TSDF Name : Naroda Enviro Prj Ltd. Ahmedabad [12719]
Person Contacted : Mr. Kunal Kikani (GM)
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Tube well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All = 15 HP
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 18144-11/05/2015
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No08/09/2014 REV 11/11/2014 PER, 307275 REV APP 23026801/07/2014 SCN 16/08/2014 33A,IMM, 299708 SCN SCN 22227501/07/2014 SCN 16/08/2014 33A,IMM, 299708 SCN SCN 222146
Lab Charges Pending : NIL Water Cess Charges Pending : Rs. 0.00
Last Env. Form V : 2013-2014 Water Cess Return : 2013-2014 HW Monthly Return : 2015-04
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 16818, ETP - 446, APCM - 617 Meter Reading - 7171, Kilo Litre - 308 Meter Reading - 855, Kilo Litre - 50
Monthly Patrak Data : Last Return : 201504 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/5 ( Through XGN )11/05/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
CTE (NOC) TPH)
ZLD
ETP SST
ETP ETP
This unit is visited as a part of a drive to visit spent acid generating in Chhatral / Kalol region in view of acidic wastewater accumulated in natural drain / open land behind the Karan Paper Mills. Unit is found in operation at the time of visit. Unit is engaged in manufacturing of Diclofenac Sodium, Diclofenac Potessium, Diclofenac Diethyl Ammonium. Water is sourced through their own bore well. Unit is using Aluminum Chloride Anhydrous in process. Unit is not separating and selling Aluminium Chloride solution and it is drained to the ETP along with other process effluent. No spent acid is sold outside During visit, ETP units are found idle and aeration is not going on in Aeration Tank. They have stopped secondary treatment of effluent and they have started Hydrodynamic Cavitational treatment with help of chlorine instead of secondary treatment. Hydrodynamic Cavitational treatment is carried out in the Secondary Settling Tank (SST); however, SST is found empty at the time of visit. Construction of two sheds is going on near the ETP. It is learnt that these sheds are constructed for the MEE Plant to be set up to achieve zero liquid discharge. Presently, industrial effluent is reused for plantation / gardening within the premises after its primary and hydrodynamic cavitational treatment. They have provided a fixed line with flow meter for reuse of treated effluent for plantation / gardening but the flow meter and line have got buried beneath the soil due to construction of MEE Plant Sheds. No any wastewater discharge is observed at the time of visit, hence sample of treated wastewater could not be collected. During visit existing old wood based Boiler is found in operation. Unit has installed new Boiler (1 TPH capacity) along with APCM but it is not found in operation. Unit has provided two nos. water scrubbers in series followed by Alkali Venturi Scrubber for control of process emission. During visit process stages leading to emission of HCl, Cl2 & SO2 are not going on. This unit is also having one DG set of 100 KVA as a standby facility. Written instructions are issued to the person contacted. [527]-08/05/2015
W.C Notings:
PCB-ID: ( 28133 )
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Remarks :
-
Site Observations during Inspection ,
Compliance Observed in this Inspections.
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C2/5 ( Through XGN )11/05/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Instructions in Previous Visits and Reply Insp Det Instruction Status
SMF ladder Adequate SMF 307275(08/09/14) Still Pending
Sludge Storage area leachate collection facility 307275(08/09/14) Still Pending
ETP units cleaning & Maintenance
ETP
307275(08/09/14) Still Pending
ETP SDB Ground Floor Level 305145(20/08/14) Fully Complied
305145(20/08/14) Still Pending
CTE-Amendment 305145(20/08/14) Fully Complied
pH 299708(01/07/14) Still Pending
299708(01/07/14) Still Pending
ETP w/w 299708(01/07/14) Still Pending
ETP 299708(01/07/14) Still Pending
299708(01/07/14) Still Pending
N I C3/5 ( Through XGN )11/05/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team :
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark APCM Fuel Consp-Unit SMF1 Boiler 12 Old boiler to be scrapped NOT Wood 0 Kg./hour YES2 Hot Air Generator 8 NOT Wood 18Kg./hour YES3 Boiler 30 New IBR Boiler MUL Wood 12 Kg./hour YES
Details about Hazardous Waste Management :
Sample Details
D
A
T.C. Patel,DEE - Ujjaval.G.Mistry, AEE
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical Sludge From Waste Water Treatment I -34.3 24.000-M.T COL,DST,STO,TRA2 Used Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Discarded Containers / Barrels / Liners contaminated with
Hazardous Wastes/ChemicalsI -33.3 4.000-M.T COL,REU,STO
4 Spent Catalyst / Spent Carbon I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-Expired, Discarded And Off-Specification Drugs/Medicines I -28.4 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.250 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.500 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 2.500 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 DICHLOROPHENOL 2.000 - M.T2 ACTIVATED CARBON 0.050 - M.T3 ALLUMINIUM CHLORIDE 3.900 - M.T4 ANILINE OIL 1.750 - M.T5 CAUSTC FLAKES 1.000 - M.T6 CHLORO ACETYL CHLORIDE 2.600 - M.T7 DIETHYL AMINE. 0.300 - M.T8 FILTER AID DICAMOL 0.100 - M.T9 ISO PROPYL ALCOHOL 1.300 - M.T10 METHANOL 0.565 - M.T11 pottasium cabonate 9.000 - M.T12 S D S SPRIT 1.100 - M.T13 SODA ASH 0.132 - M.T14 SODIUM METAL 0.320 - M.T15 SULPHURIC 1.050 - M.T16 TOLUENE 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C4/5 ( Through XGN )11/05/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Signature By(T.C. Patel,DEE )
N I C5/5 ( Through XGN )11/05/2015
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
10
3
1
2
5
6
7
8
11
PLOT NO:BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD, -,DHANOT - 382729DIST : Gandhinagar., TAL : Kalol, SIDC : Not In Gidc
Industry Details
Email :
Telephone :
info@orbitpharma.co.in
02764-234093
Type / Scale / Sector / Status : RED / SMALL / Pharmaceuticals / In Operation Inspection Dt & Time : 28/07/2017 14:00 / Water
Water Consumption in Kilo Lts Per Day 10.150
Consumer No.(Electric Meter): Disposal Mode of Industrial / Domestic :
Status of water consent Under the Water Act,1974:
Effluent Treatement plant (ETP) : Units, if provided and status :
446389 ( Routine Visit )Inspection Id :
12 Whether Industry is a member of CETP ?13
Discharge Pt / Final Receiving Body (Ultimate):9Zero Discharge / IrrigationZero Discharge. / No generation of industrial wastewater
Ind : Dom : 0.9503.450Ind : Dom : 0.650 Waste Water generation / Discharge (klpd) :
AWH-84612-08/01/2022 Last Inward:115894-09/01/2017-[GRT]
No
TSDF Name : B.E.I.L, Ankleshwar [14983]
Person Contacted : MR. Kunal Kikani
4
17
Orbit Pharma Laboratories
Ro Name : Gandhinagar
Last 3 Legal Action :
Source of Water Supply: Bore well
Commissioned Dt :
Production Start Dt :
15/03/1992 15/03/1992
Borewells: 0Tubewells: 0
Boilers=2 , DG Sets=0 , Flue Gas =3, Process =1 , ETP Cap = 175 , Capacity of All =
Env Audit Detail : Sch : N.A , Not Applicable . , Year : 2011 , On Dt : 14/02/2014
Applicability of CRZ Rules : No
Outward No: 26498-31/07/2017
14
1516
Insp Dt Act Leg Dt For Insp ID IR-Leg Type Out No30/07/2016 NOT 04/10/2016 33A,, 400323 NOT SCN 37205105/02/2016 SCN 23/03/2016 ,, 373764 SCN ROU 35053919/06/2015 REV 30/06/2015 3MT, 344368 REV REV 319202
Lab Charges Pending : NIL Water Cess Charges Pending : NIL
Last Env. Form V : 2016-2017 Water Cess Return : 2016-2017 HW Monthly Return : 2017-99
Electricity Units Consumed in month Water Consumed in month Effluent Discharged in month Production - 27103, ETP - 590, APCM - 1267 Meter Reading - 16669, Kilo Litre - 360 Meter Reading - 3203, Kilo Litre - 97
Monthly Patrak Data : Last Return : 201706 HAZD Waste Disposal : 0.000 (0 Trucks)
ETP Details : P-Collection Tank,P-Nuetralization,P-Oil-Grease Trap,P-Pri Settling Tank,S-Aeration Tank,S-Settling Tank,S-Sludge Dry Beds,T-Sand Filter
APCM Details : Multi Cyclone ,Not provided,Scrubber
Fuel Used : Wood
Stack Attached to : Boiler,Hot Air Generator
N I C1/5 ( Through XGN )31/07/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
PCB-ID: ( 28133 )
Remarks :
-
Site Observations during Inspection ,
One Time Updationsp - On South Direction of the location of the Company -Chhatral-Kadi Road
e - Electric Company Name (Power Supply) UGVCL
o - Production since (Date) or Proposed 15/03/1992
p - On North Direction of the location of the Company -Audichem (Facotory)
p - On East Direction of the location of the Company -Open Plot
p - On West Direction of the location of the Company -Mirambica (Factory)
0 - Air - Water - Hazd ACTs Applicability ? Air, Water, Haz
k - Recycler Registration Valid ?? N.A
m - W.W.G Treatment thru Pri / Sec / Tertiary / N.A : Primary
d - Is Industry ZERO DISCHARGE Catg (If Yes, HOW ?) No.
n - Nos of Flow-Meters - W.C / W.W.G / ETP = 0, 0, 0
General Observationa - Is the Industry in Operation ?? Yes
a - R.O File No 391
b - Industry Operating without CCA No.
c - Has Production exceeded (last 3 MTHs) than CCA-Qty No.
d - Any products-NOT in CCA, manufactured-Last 3 MTHs No.
e - Foul Odour/Fugitive Emission/Bye Pass in Premises ?? No.
f - Industry Name CHANGED in recent times ?? No.
g - Has Regn with CETP or TSDF expired ?? No.
h - Seperate Energy Meter for A.P.C.M ? No.
h - Provision of any STAND-BY Pump ?? No.
Water Parameterb - Source of Water Supply Tube well
c - W.W.G is EXCEEDING the CCA Limits No.
d - W.W Disposal as per the Consent Conditions ? Yes
e - Was the ETP in operation ? Yes
f - Treatment System ADEQUATE to handle existing effluent Adequate
g - Did u observe ANY ILLEGAL Discharge ?? No.
h - Nos of Samples collected 0
Note: EIA 2006 / SEIAA / E.C / MOEF Applicable : Yes
N I C2/5 ( Through XGN )31/07/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
effluent collect collection chamber
This unit was visited w.r.to monsoon monitoring and found in operation. It was engaged in manufacturing of Diclofenac Sodium IP / BP , Diclofenac Potassium and Diclofenac Diethyl Ammonium. During visit, production of Diclofenac Sodium was going on. During visit, dehydration and addition stages were going on. It had provided Collection tank, Lime solution preparation tank, Neutralization tank, Zigzag chamber, Primary settling tank, Secondary collection tank (earlier aeration tank), Secondary settling tank with Hydrodynamic Cavitational treatment, Filter press, treated waste water holding tank and single stage steam jacketed evaporator with condenser and condensate w/w collection tank as ETP units. It had covered ETP tanks with metallic sheet to avoid contamination of rainy water with effluent. Provided ETP units were found in operation. Written instruction was given to covered collection chamber provided to collect effluent from plant. [683]-31/07/2017
W.C Notings: Data not furnished[683-AEE]~
Specific Instructions given to Industry at the time of visit , for Pt to Pt Compliance
Compliance Observed in this Inspections.Instructions in Previous Visits and Reply Insp Det Instruction Status
During visit ETP and APCM were found in operation. OPerate regularly. 423279(18/01/17) Fully Complied
Dispose of stored hazardous solid waste from the solid waste storage area to TSDF site and submit details to the board.
423279(18/01/17) Partial Compliance
pH @ 6 411778(18/10/16) Partial Compliance
IBR Adequate SMF 411778(18/10/16) Partial Compliance
CCA Amendment CCA
CCA Renewal
411778(18/10/16) Fully Complied
N I C3/5 ( Through XGN )31/07/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Sr Stack attached to Mts Remark Details of APCM Probable Pollutants.1 Reaction Vessels 9 SCR hcl
B Process Stacks
C Flue gases StacksSr Stack attached to Mts Remark SMF APCM Fuel Consp-Unit Insp Remk1 Boiler 12 Old boiler to be
scrappedYES NOT Wood 0 Kg./hour
2 Hot Air Generator 8 YES NOT Wood 18Kg./hour3 Boiler 30 New IBR Boiler YES MUL Wood 12 Kg./hour
Details about Hazardous Waste Management :
Sample Details
D
A
Annexure Details - Air,Stack,Hazardous Waste & Samples PCB-ID: (28133)
Sr Source of Hazardous Waste Catg Qty/Year HW Disposal Management1 Chemical sludge from waste water treatment I -35.3 24.000-M.T COL,DST,STO,TRA2 Used or Spent Oil I -5.1 0.025-M.T COL,STO,RRE,TRA3 Empty barrels/containers/liners contaminated with hazardous
chemicals /wastesI -33.1 4.000-M.T COL,REU,STO
4 Spent Catalyst I -28.2 0.200-M.T COL,DSI,STO,TRA5 Date-expired products I -28.5 0.500-M.T COL,DSI,REU,STO,DST,TRA
Sr Product Name NOC Qty CCA Qty Applied Qty Inspection Remark1 DICLOFENAC DI-ETHYL AMMOINUM 0.250 0.000 - M.T 0.000 power supply found disconnected2 DICLOFENAC POTTASIUM I.P./B.P. 0.500 0.000 - M.T 0.000 Mar.14=Nil,Apr.14=Nil,May.14
=Nil3 DICLOFENAC SODIUM I.P./B.P. 2.500 0.000 - M.T 0.000 Mar.14=2.5, Apr.14=2.4,
May.14=2.5 MT
Products :E
Sr Raw Material Name Capacity - Unit / Month1 2:6 dichlorophenol 2.600 - M.T2 acetic acid 0.000 - M.T3 activated carbon 0.165 - M.T4 alluminium chloride 3.900 - M.T5 aniline oil 1.765 - M.T6 caustc flakes 0.825 - M.T7 Caustic Potash 0.200 - M.T8 chloro acetyl chloride 2.600 - M.T9 diethyl amine. 0.200 - M.T10 filter aid dicamol 0.130 - M.T11 iso propyl alcohol 0.100 - M.T12 methanol 0.610 - M.T13 mono methyl chloro acetate 2.000 - M.T14 pottasium cabonate 1.170 - M.T15 s d s sprit 0.000 - M.T16 soda ash 0.306 - M.T17 sodium metal 0.420 - M.T18 sulphuric 0.000 - M.T19 toluene 1.300 - M.T
Raw material :F
Sr Water Code (Qty in klpd - Kilo Ltr per Day) WC : 11.100 WWG : 4.100 Water Source Remark1 Agriculture 3.000 0.000 Tankers2 Boiler Feed 4.000 0.200 Tankers3 Cooling Water 2.500 0.150 Tankers4 Domestic Purpose 0.950 0.650 Tankers5 Others ..... 0.150 0.100 Tankers6 Wash Water 3.500 3.000 Tankers
Water Consumption & Generation Break upG
Solid WasteH
N I C4/5 ( Through XGN )31/07/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Inspection Team : Ms. Thakkar Alpaben P - S.S.Jayaswal,SSA
Signature By(Ms. Thakkar Alpaben P )
I hereby affirm, that all the PDF, Data mentioned above, fees paid has been checked & certified.
N I C5/5 ( Through XGN )31/07/2017
PCB Id: 28133( Inspection Report ) - Air,Water,Hazardous
Gujarat Pollution Control Board
(Under Section 23 of The Water Act 1974, Under Section 24 of The Air Act 1981 and Under Section 10 of EP Act 1986)
Sample ID:198213 - Analysis Completion:07/11/2016
ANALYSIS REPORT FOR
WATER / WASTE WATER SAMPLE
Pharmaceuticals / LAB Inward : 48479
Gujarat Pollution Control Board,
Central Laboratory
Paryavaran Bhavan
Sector-10A
Gandhinagar-382010
Accreditation Standards & NABL Certificate Details : T-2105 / ISO/IEC 17025:2005 / 21/12/2011 / 20/12/2013
TEST REPORT
Test Report No. : 48479 Date: 07/11/2016
3. Nature of Sample
4. Sample Collected By
5. Quantity of Sample Received
6. Code No. of the Sample
7. Date & Time of Collection & Inwarding
8. Date of Start & Completion of Analysis
9. Sampling Point
10. Flow Details (Remarks)
11. Mode of Disposal
12. Ultimate Receiving Body
13. Temperature on Collection
14. Carboys Nos for
15. Water Consumption & W.W.G (KLPD)
1. Name of the Customer
2. Address
Range of TestingTest MethodSr ResultUnitParameter
Ambient oC - 60 oCIS: 3025 (Part – 9) – 1984(Reaffirmed 2006)CentigradeTemperature 1 30
1 – 14 pH value As on digital pH meter.4500 H+ B APHA Standard Methods 22nd edi.2012pH UnitspH 2 7.54
2 - to 99 Hazen & 1-500 hazen2120 B APHA Standard Methods 22nd edi. 2012Pt.Co.Sc.Colour 3 10
10 – 200000 mg/LGravimetric method. (2540 C APHA Standard Methods 22nd edi.)2012mg/lTotal Dissolved Solids 4 3436
2 – 10000 mg/LGravimetric method. (2540 D APHA Standard Methods 22nd edi.)2012mg/lSuspended Solids 5 10
1 - 2000 mg/l.1).Titrimetric method (4500 NH3 B & C APHA Standard Methods 22nd edi.)-2012mg/lAmmonical Nitrogen 6 0.56
0.01 – 100%.IS11624-1986(Reaffirmed 2009)%NaPercent Sodium 7 76
1 - 50000 mg/lArgentometric method. (4500 Cl? B APHA Standard Methods 22nd edi.)-2012mg/lChloride 8 1512
2-40mg/lAPHA(22nd edi)4500 SO4 Emg/lSulphate 9 417
-5310 C APHA standard method 21st edimg/lTotal Organic Carbon 10 15.64
0.1 – 8 mg/lWinkler method – Azide modification. (4500-O– C APHA Standard Methods 22nd edi.)-2012mg/lDissolved Oxygen 11 4.64
5.0- 50000 mg/lAPHA (22nd Edition)- 5220 B Open Reflux Method-2012mg/lChemical Oxygen Demand 12 10
01 – 1000 mg/lLiquid – Liquid Partition Gravimetric method. (5520 B APHA Standard Methods 22nd edi.)-2012mg/lOil & Grease 13 BDL
0.1 – 50 mg/l4 Amino Antipyrene method without Chloroform Extraction (Direct Photometric method) (5530 D APHA Standard Methods 22nd edi.) -2012mg/lPhenolic Compounds 14 BDL
1-500.0 mg/lAPHA (22nd Edi.)4500-s2-F –iodometric Methodmg/lSulphide 15 BDL
0.02-150mg/l(3111 B APHA Standard methods 21st edi)mg/lIron 16 BDL
0.005-100mg/l(3111 B APHA Standard methods 21st edi)mg/lZinc 17 BDL
0.02-150mg/l3111 B APHA Standard methods 21st edi)mg/lTotal Chromium 18 BDL
0.01-150 mg/l3111 B APHA Standard methods 21st edi)mg/lCopper 19 BDL
0.02-150 mg/l(3111 B APHA Standard methods 21st edi)mg/lNickel 20 BDL
05–50000 mg/l3 – Day BOD test. (IS 3025 (Part 44) 1993 Reaffirmed 1999)-2009mg/lB.O.D (3 Days 27oC) 21 1.7
1 – 50 v Meq/LIS11624-1986(Reaffirmed 2009)SARSodium Absorption Ratio(SAR) 22 17
: REP-Representative/Grab, (Insp Type : NOT-After Notice of DIR)
: Desai Saurabhkumar S
: 5 lit. DO,
: 198213
: 18/10/2016 , (1430 to 1430) & 19/10/2016
: 19/10/2016 & 07/11/2016
: BOREWELL WATER OF ORBIT PHARMA UNIT ~
: -
: -
: No generation of industrial wastewater
: 30 & pH Range on pH Strip :@7 to 8 on pH strip
: barcode & Color & Appearance :colorless
: Ind :10.150 , Dom :0.950 & Ind :3.450 , Dom :0.650
: Orbit Pharma Laboratories - 28133
: BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD,-
DHANOT-382729, Taluka : Kalol, District : Gandhinagar., GIDC : Not In Gidc
Laboratory Remarks : Approved By:134-lab_134 Dt.: 07/11/2016
Meenakshi Shah, SSO
13/10/2017N I C
Note :
1. * - These parameters are covered under the scope of NABL.
2. The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred nor implied.
3. Samples will be destroyed after 10 days from the date of issue of test report unless otherwise specified.
4. This report is not to be reproduced wholly or in part or used in any advertising media without the permission of the Board in writing.
5. The Board is not responsible for the authenticity for the samples not collected by the Board’s officials.
6. Total liability of our laboratory is limited to the invoiced amount. Any dispute arising out of this report is subject to
Gujarat Jurisdiction only.
7. Permissible Limits: as per Schedule VI of EPA Rules, 1986 as ammended by Second and Third ammendment 1993 for Effluents
8. Physicochemical and microbiological parameters, Std.Methods for Water and Waste Water- 22nd Edition by APHA.
9. Bioassay test (for toxicity) -IS:6582:Part-2:2001; Reaffirmed 2007.
Field Observation :
Sample ID:164797 - Analysis Completion:13/07/2015
ANALYSIS REPORT FOR
WATER / WASTE WATER SAMPLE
Pharmaceuticals / LAB Inward : 40047
Gujarat Pollution Control Board,
Central Laboratory
Paryavaran Bhavan
Sector-10A
Gandhinagar-382010
Accreditation Standards & NABL Certificate Details : T-2105 / ISO/IEC 17025:2005 / 21/12/2011 / 20/12/2013
TEST REPORT
Test Report No. : 40047 Date: 14/07/2015
3. Nature of Sample
4. Sample Collected By
5. Quantity of Sample Received
6. Code No. of the Sample
7. Date & Time of Collection & Inwarding
8. Date of Start & Completion of Analysis
9. Sampling Point
10. Flow Details (Remarks)
11. Mode of Disposal
12. Ultimate Receiving Body
13. Temperature on Collection
14. Carboys Nos for
15. Water Consumption & W.W.G (KLPD)
1. Name of the Customer
2. Address
Range of TestingTest MethodSr ResultUnitParameter
Ambient oC - 60 oCIS: 3025 (Part – 9) – 1984(Reaffirmed 2006)CentigradeTemperature 1 30
1 – 14 pH value As on digital pH meter.4500 H+ B APHA Standard Methods 22nd edi.2012pH UnitspH 2 6.27
2 - to 99 Hazen & 1-500 hazen2120 B APHA Standard Methods 22nd edi. 2012Pt.Co.Sc.Colour 3 20
10 – 200000 mg/LGravimetric method. (2540 C APHA Standard Methods 22nd edi.)2012mg/lTotal Dissolved Solids 4 616
2 – 10000 mg/LGravimetric method. (2540 D APHA Standard Methods 22nd edi.)2012mg/lSuspended Solids 5 20
1 - 2000 mg/l.1).Titrimetric method (4500 NH3 B & C APHA Standard Methods 22nd edi.)-2012mg/lAmmonical Nitrogen 6 24.42
1 - 50000 mg/lArgentometric method. (4500 Cl? B APHA Standard Methods 22nd edi.)-2012mg/lChloride 7 110
2-40mg/lAPHA(22nd edi)4500 SO4 Emg/lSulphate 8 61
5.0- 50000 mg/lAPHA (22nd Edition)- 5220 B Open Reflux Method-2012mg/lChemical Oxygen Demand 9 491
01 – 1000 mg/lLiquid – Liquid Partition Gravimetric method. (5520 B APHA Standard Methods 22nd edi.)-2012mg/lOil & Grease 10 BDL
0.1 – 50 mg/l4 Amino Antipyrene method without Chloroform Extraction (Direct Photometric method) (5530 D APHA Standard Methods 22nd edi.) -2012mg/lPhenolic Compounds 11 15.32
05–50000 mg/l3 – Day BOD test. (IS 3025 (Part 44) 1993 Reaffirmed 1999)-2009mg/lB.O.D (3 Days 27oC) 12 156
: REP-Representative/Grab, (Insp Type : REV-On/For Revocation)
: B.N.PATEL,SSA
: 5000
: 164797
: 19/06/2015 , (1215 to 1215) & 20/06/2015
: 30/06/2015 & 13/07/2015
: CONDENSATE W/W OF EVAPORATOR ~
: --
: --
: No generation of industrial wastewater
: 30 & pH Range on pH Strip :@ 7 to 8 on pH strip
: Barcpde & Color & Appearance :Pink
: Ind :10.150 , Dom :0.950 & Ind :3.450 , Dom :0.650
: Orbit Pharma Laboratories - 28133
: BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD,-
DHANOT-382729, Taluka : Kalol, District : Gandhinagar., GIDC : Not In Gidc
Laboratory Remarks : Approved By:434-r.o_434 Dt.: 14/07/2015
H.P.Patel,R.O Head
13/10/2017N I C
Note :
1. * - These parameters are covered under the scope of NABL.
2. The results refer only to the tested samples and applicable parameters. Endorsement of products is neither inferred nor implied.
3. Samples will be destroyed after 10 days from the date of issue of test report unless otherwise specified.
4. This report is not to be reproduced wholly or in part or used in any advertising media without the permission of the Board in writing.
5. The Board is not responsible for the authenticity for the samples not collected by the Board’s officials.
6. Total liability of our laboratory is limited to the invoiced amount. Any dispute arising out of this report is subject to
Gujarat Jurisdiction only.
7. Permissible Limits: as per Schedule VI of EPA Rules, 1986 as ammended by Second and Third ammendment 1993 for Effluents
8. Physicochemical and microbiological parameters, Std.Methods for Water and Waste Water- 22nd Edition by APHA.
9. Bioassay test (for toxicity) -IS:6582:Part-2:2001; Reaffirmed 2007.
Field Observation :
Sample ID:203651 - Analysis Completion:27/01/2017
Pharmaceuticals / LAB Inward : 49826
ANALYSIS REPORT FOR AIR
TYPE : Stack-Process
Gujarat Pollution Control Board
Central Laboratory
Paryavaran Bhavan
Sector-10A
Gandhinagar-382010
Tele:23222756
: REP-Representative/Grab , (Insp Type : APP-On Application)
: D. C. Vankani, E.E
: 18/01/2017, (1315 to 1330)
: 19/01/2017 & 27/01/2017
: From stack attached to reaction vessel through APCM ~
: -
: Two stage water scrubber followed by alkali ventury scrubber
: -
: & Volume-Absord Media : 50 ml
: 30 lit
: 1 & Oper Time(Min) : 15 min
3. Nature of Sample
4. Sample Collected By
5. Date & Time of Collection & Receipt
6. Date of Start & Completion of Analysis
7. Sampling Point
8. Fuel
9. APCM
10. Thimble & Weight (gm)
11. Temperature on Collection
12. Volume-Gas Passed
13. Parameters
Range of TestingTest MethodSr ResultUnitParameter
-ArgentometricMG/NM3HCL-Stack 1 25.73
1. Name &
2. Address of the Unit
: Orbit Pharma Laboratories - 28133
: BLOCK NO. 155/1,159,,CHHATRAL-KADI ROAD,-
DHANOT - 382729,Taluka : Kalol, District : Gandhinagar., GIDC : Not In Gidc
13/10/2017
K.B.Vaghela, SO
Laboratory Remarks : APPROVED. By:331-lab_331 Dt.: 27/01/2017
n i c
Field Observation :
top related