p92 echo p92 echo - red sky ventures
Post on 03-Feb-2022
22 Views
Preview:
TRANSCRIPT
October ‘ 98 i-1
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
INTRODUCTION FLIGHT MANUAL
Flight Manual
P92 ECHO & P92 ECHO/100
(ROTAX 912UL 81Hp or ROTAX 912ULS 100Hp engine )
MANUFACTURER : COSTRUZIONI AERONAUTICHE TECNAM S.r.l.
AIRCRAFT TYPE : P92 ECHO & P92 ECHO/100
SERIAL NUMBER :...............................................................
MANUFACTURING DATE :.....................................................................
Warning
The Flight Manual must always be kept on board the aircraft. The aircraft described herein is to be operated in accordance with procedures and limitations described in this Flight Manual.
This manual is valid for the P92 Echo with either Rotax 912 81 Hp engine or Rotax 912S 100 Hp engine( P92 Echo/100).
For evident safety reasons and upon reading this ma nual for the first time, it is necessary to underline (perhaps also hi ghlight with a colored marker) any differences in charts and tables as app licable to personal aircraft.
October ‘ 98 i-2
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
INTRODUCTION FLIGHT MANUAL
Record of Revisions
All revisions to the current Manual, except for actual weighing data, must be recorded in the following table and, in case of approved sections, must be endorsed by the Responsible Airworthiness Authority.
New text or amendments to revised pages shall be clearly marked by a vertical black line on the left hand margin, with revision N° and date indicated on left side of page.
Record of Revisions
Rev N° Affected
Sections
Affected
Pages
Date Date inserted
October ‘ 98 i-3
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
INTRODUCTION FLIGHT MANUAL
Table of Contents
General Section 1
Limitations Section 2
Emergency procedures Section 3
Normal procedures Section 4
Performance Section 5
Weight and balance Section 6
Systems description Section 7
Ground handling and servicing Section 8
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-4
Section 1
General
Table of Contents
INTRODUCTION...................................................................................................... 5
WARNINGS - CAUTIONS - NOTES ........................................................................ 5
THREE VIEW DRAWING ........................................................................................ 6
DESCRIPTIVE DATA............................................................................................... 7
CONTROL SURFACES TRAVEL LIMITS .............................................................. 7
ENGINE ..................................................................................................................... 8
PROPELLER.............................................................................................................. 8
FUEL ......................................................................................................................... 9
OIL ............................................................................................................................. 9
COOLING ................................................................................................................. 9
WEIGHTS ............................................................................................................... 10
SPECIFIC LOADINGS ............................................................................................ 10
ABBREVIATIONS AND TERMINOLOGY........................................................... 11
UNIT CONVERSION FACTORS............................................................................ 14
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-5
Introduction
The P92 ECHO is a twin seat single engine aircraft with a strut-braced rectangular high wing, fixed main landing gear and steerable nose wheel.
This Flight Manual has been prepared to provide pilots and instructors with information for the safe and efficient operation of this aircraft.
This Flight Manual contains 8 sections. Section 1 provides basic data and information of general interest in addition to definitions and explanations of symbols, abbreviations and terminology commonly used.
Warnings - Cautions - Notes
The following definitions apply to warnings, cautions and notes used in the Flight Manual.
means that the non-observation of the corresponding procedure leads to an immediate or important degradation of the flight safety.
means that the non-observation of the corresponding procedure leads to a minor or to a more or less long term degradation of the flight safety.
draws the attention to any special item not directly related to safety but which is important or unusual.
WARNING
CAUTION
NOTE
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-6
Three View Drawing
• Dimensions shown refer to aircraft weight of 450 kg and normal operating tire pressure.
• Propeller clearance 360mm • Propeller clearance with deflated front tire and compressed shock
absorber 142mm • Minimum ground steering radius 5.5m
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-7
Descriptive Data (P92 Echo & P92 Echo/100)
Wing Wing span: 9.6 m Wing chord 1.4 m Wing surface 13.2 m2 Wing loading 34.1kg/m2 Aspect ratio 6.2 Taper ratio 1.0 Dihedral 1.5°
Fuselage
Overall length 6.3 m Overall width 1.1 m Overall height 2.5 m
Empennage
Stabilator span 2.9 m Vertical tail span 1.2 m
Landing Gear
Wheel track: 1.8 m Wheel base: 1.6 m Main gear tire. Air Trac Wheel hub and brake Marc Ingegno
5.00-5
Nose gear tire Sava 4.00-6 Control Surfaces Travel Limits
Ailerons Up 20° down 15° ± 2° Stabilator Up 18° down 3° ± 1° Trim-Tab +2° +12° ± 1° Rudder RS 25° LS 25° ± 1° Flaps 0° - 35° ± 1°
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-8
Engine
P92 Echo P92 Echo 100
Manufacturer: Bombardier-Rotax GmbH Bombardier-Rotax GmbH
Model 912 UL 912 S
Engine type: Four cylinder horizontally-opposed twins with overall displacement of 1211.2 c.c., mixed cooling, (water-cooled heads and air-cooled cylinders), twin carburetors, integrated reduction gear, (2.273:1) with torque damper. Compression ratio: 9.0:1.
Four cylinder horizontally-opposed twins with overall displacement of 1352 c.c., mixed cooling, (water-cooled heads and air-cooled cylinders), twin carburetors, integrated reduction gear, (2.4286:1) with torque damper. Compression ratio: 10.3:1.
Maximum power: 81Hp (59.6 kW ) at 5800 rpm - max 5 min..
100 Hp (73.5 kW) at 5800 rpm - max 5 min..
Propeller
P92 Echo P92 Echo 100
Manufacturer: F.lli Tonini Giancarlo & Felice S.n.c.
F.lli Tonini Giancarlo & Felice S.n.c.
Model: GT- ECHO 2/166/145 GT- ECHO 2/172/164
Number of blades: 2 2
Diameter: 1660 mm 1720 mm
Type: Fixed pitch - wood Fixed pitch - wood
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-9
Fuel (P92 Echo E P92 Echo/100)
Fuel grade: • High octane gasoline DIN 51600, O-NORM 1103 (red)
• Unleaded gasoline DIN 51603, O-NORM 1101
• AVGAS 100LL
Fuel tanks: 2 wing tanks integrated within the wing's leading edge with drainage reservoir located in engine cowling
Capacity of each wing tank 35 liters
Total capacity 70 liters
Oil (P92 Echo & P92 Echo/100)
Oil system: Forced, with external oil reservoir
Oil: Automotive grade type oil type API "SF" or "SG" preferably synthetic or semi-synthetic
Oil Capacity: 2.5 liters
Cooling (P92 Echo & P92 Echo/100)
Cooling system: Mixed air and liquid pressurized closed circuit system
Coolant: Antifreeze and water liquid mixture
Capacity 3 liters
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-10
Weights (P92 Echo & P92 Echo/100)
Maximum takeoff: 450 kg
Standard empty weight 280 kg
Specific Loadings
P92 Echo P92 Echo 100
Wing Loading 34.1 kg/m2 34.1 kg/m2
Power Loading 5.5 kg/hp 4.5 kg/hp
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-11
Abbreviations and Terminology
Airspeed Terminology and Symbols
CAS Calibrated Airspeed is indicated airspeed corrected for position and instrument error.
IAS Indicated Airspeed: is the speed shown on the on-board airspeed indicator.
TAS True Airspeed: is calibrated airspeed corrected for altitude and temperature.
VFE Maximum Flap Extended Speed: is the highest speed permissible with wing flaps in a prescribed extended position.
VNO Maximum Structural Cruising Speed: is the speed that should not be exceeded except in smooth air, then only with caution.
VNE Never Exceed Speed: is the speed limit that may not be exceeded at any time.
VS Stalling Speed.
VS0 Stalling Speed or the minimum steady flight speed at which the airplane is controllable in the landing configuration at the most forward center of gravity.
VX Best Angle-of-Climb Speed is the speed which results in the greatest gain of altitude in a given horizontal distance.
VY Best Rate-of-Climb Speed is the speed which results in the greatest gain in altitude in a given time.
Vr Rotation speed: is the speed at which the aircraft rotates about the pitch axis during takeoff
Vobs Obstacle speed: is the speed at which the aircraft flies over a 15m obstacle during takeoff or landing
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-12
Meteorological Terminology
OAT Outside Air Temperature is the free air static temperature expressed in degrees Celsius (°C).
TS Standard Temperature is 15°C at sea level pressure altitude and decreased by 2°C for each 1000 ft of altitude.
HP Pressure Altitude is the altitude read from an altimeter when the barometric subscale has been set to 1013 mb.
Engine Power Terminology
RPM Revolutions Per Minute: is the number of revolutions per minute of the propeller, multiplied by 2.273 (912UL) or 2.4286 (912S) yields engine RPM.
Airplane Performance And Flight Planning Terminology
Crosswind Velocity
is the velocity of the crosswind component for which adequate control of the airplane during takeoff and landing was actually demonstrated.
Usable fuel is the fuel available for flight planning.
Unusable fuel is the quantity of fuel that cannot be safely used in flight.
G is the acceleration of gravity.
TOR is the takeoff distance measured from actual start to wheel liftoff point
TOD is total takeoff distance measured from start to 15m obstacle clearing
GR is the distance measured during landing from actual touchdown to stop point
LD is the distance measured during landing, from 15m obstacle clearing to actual stop.
S/R is specific range, that is, the distance (in nautical miles) which can be expected at a specific power setting and/or flight configuration per kilo of fuel consumed
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-13
Weight And Balance Terminology
Datum is an imaginary vertical plane from which all horizontal distances are measured for balance purposes.
Arm is the horizontal distance from the reference datum to the center of gravity (C. G.) of an item.
Moment is the product of the weight of an item multiplied by its arm.
C. G. Center of Gravity is the point at which the airplane, or equipment, would balance if suspended. Its distance from the reference datum is found by dividing the total moment by the total weight of the airplane.
Standard Empty Weight
is the weight of a standard airplane, including unusable fuel, full operating fuels and full engine oil.
Basic Empty Weight
is the standard empty weight plus the weight of optional equipment.
Useful Load is the difference between takeoff weight and the basic empty weight.
Maximum Weight
is the maximum weight of the aircraft.
Maximum Takeoff Weight
is the maximum weight approved for the start of the takeoff run.
Maximum Landing Weight
is the maximum weight approved for the landing touch down.
Tare is the weight of chocks, blocks, stands, etc. used when weighing an airplane, and is included in the scale readings. Tare is deducted from the scale reading to obtain the actual (net) airplane weight.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GENERAL FLIGHT MANUAL
October ‘ 98 1-14
Unit Conversion Factors
Multiplying By ���� Yields
Temperature Fahrenheit [F°] ( )5
932⋅ −F Celsius [C°]
Celsius [C°] 9
532⋅
+C
Fahrenheit [F°]
Weights Kilograms [Kg] 2.205 Pounds [Lb] Pounds [Lb] 0.4536 Kilograms [Kg]
Speed Meters per second [m/s] 196.86 Feet per minute. [ft/min] Feet per minute [ft/min] 0.00508 Meters per second. [m/s] Knots [Kts] 1.852 Kilometers / hour [Km/h] Kilometers / hour [Km/h] 0.540 Knots [Kts]
Pressure Atmosphere [Atm] 29.921 Pounds / sq. in [psi] Pounds / sq. in [psi] 0.0334 Atmosphere [Atm]
Length Kilometers [Km] 0.540 Nautical miles [nm] Nautical miles [nm] 1.852 Kilometers [km] Meters [m] 3.281 Feet [ft] Feet [ft] 0.3048 Meters [m] Centimeters [cm] 0.3937 Inches [in] Inches [in] 2.540 Centimeters [cm]
Volume Liters [lt] 0.2642 Gallons US [US gl] Gallons US [US gl] 3.785 Liters [lt]
Surface Square meters [m2] 10.76 Square feet [sq ft] Square feet [sq ft] 0.0929 Square meters [m2]
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-15
Section 2
Limitations
Table Of Contents
INTRODUCTION 16
AIRSPEED LIMITATIONS 16
AIRSPEED INDICATOR MARKINGS 17
POWERPLANT LIMITATIONS 18
PROPELLER 19
POWERPLANT INSTRUMENT MARKINGS 20
OTHER INSTRUMENT MARKINGS 21
WEIGHT LIMITS 21
CENTER OF GRAVITY LIMITS 21
APPROVED MANEUVERS 21
FUEL 22
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-16
Introduction Section 2 includes operating limitations, instrument markings, and basic placards necessary for safe operation of the P92 ECHO, , its engine, standard systems and standard equipment.
Airspeed Limitations
For all models SPEED km/h IAS REMARKS
VNE Never exceed speed 260 Never exceed this speed in any operation.
VNO Maximum Structural Cruising Speed
200 Never exceed this speed unless in smooth air, and then only with caution.
VA Maneuvering speed 150 Do not make full or abrupt control movements above this speed as this may cause stress in excess of limit load factor
VFE Maximum flap extended speed
110 Never exceed this speed for any given flap setting.
Rev. A date 15.01.99
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-17
Airspeed Indicator Markings
Airspeed indicator markings and their color code are explained in the following table:
For all models Marking
IAS km/h
Significance
White arc 71 – 110
Flap Operating Range (lower limit is VSO, at maximum weight and upper limit is maximum speed permissible with flaps extended at 35°)
Green arc 110 – 200
Normal Operating Range (lower limit is VS1 at maximum weight and flaps at 0° and upper limit is maximum structural speed VNO).
Yellow arc 200 – 260
Operations must be conducted with caution and only in smooth air.
Red line 260
Maximum speed for all operations.
Rev. May 2002
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-18
Powerplant Limitations
The following table lists operating limitations for aircraft installed engine:
Engine Manufacturer: Bombardier Rotax Gmbh.
Engine Model: 912 UL / 912 S
Maximum Power:
Max Power (HP) Max RPM Max time (minuti)
912UL 912 S 912UL 912 S 912UL 912S
Takeoff 81 100 5800 5800 5 5
Max continuous 79 94 5500 5500 / /
Temperatures:
912UL 912 S
Coolant, monitored at cylinder heads 150° C 135° C
Maximum Oil: 140° C 130° C
Minimum Oil 50° C 50° C
Oil Pressure:
912UL 912 S
Minimum 1.5 bar 1.5 bar
Maximum 5 bar 5 bar
Caution
Admissible pressure for cold start is 7 bar maximum for short periods.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-19
Viscosity
Use viscosity grade oil as specified in the following table:
CAUTION
Use of Aviation Grade Oil with or without additives is not permitted
Coolant:
Mixture: 80% concentrated antifreeze (e.g. Fiat Paraflu) with anticorrosion additive and 20% demineralized water.
Propeller
P92 Echo P92 Echo/100
MANUFACTURER: F.lli Tonini Giancarlo & Felice F.lli Tonini Giancarlo & Felice
MODEL: GT-ECHO 2/166/145 GT-ECHO 2/172/164
PROP. TYPE: Wood twin blade fixed pitch Wood twin blade fixed pitch
DIAMETER: 1660 mm 1720 mm
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-20
Powerplant Instrument Markings Powerplant instrument markings and their color code significance are shown below:
P92 Echo
Instrument
Red Line
Minimum
Limit
Green Arc
Normal
Operating
Yellow Arc
Caution
Red Line
Maximum Limit
Prop tach RPM -------- 2160-5500 5500-5800 5800
Oil Temp. °C 50 90-110 50 - 90 110-140
140
Cylinder heads and coolant temp.
°C -------- 0 - 150 ------ 150
Oil pressure bar 1.5 1.5 - 5 5 - 7 7
Fuel gage liters
------ ------ 0-5 ------
P92 Echo/100
Instrument
Red Line
Minimum
Limit
Green Arc
Normal
Operating
Yellow Arc
Caution
Red Line
Maximum Limit
Prop tach RPM -------- 2160-5500 5500-5800 5800
Oil Temp. °C 50 90-100 50 - 90 100-130
130
Cylinder heads and coolant temp.
°C -------- 0 - 135 ------ 135
Oil pressure bar 1.5 1.5 - 5 5 - 7 7
Fuel gage liters
------ ------ 0-5 ------
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-21
Note
The table below is valid for both P92 models.
Other Instrument Markings
INSTRUMENT RED LINE
Minimum limit
GREEN ARC
Normal operating
YELLOW ARC
Caution
RED LINE
Maximum limit
Voltmeter 10 Volt 12 - 14 Volt ------ ------
Weight Limits
Maximum takeoff weight: 450 kg
Center Of Gravity Limits
Forward limit 23% MAC
Aft limit 26% MAC
Datum Propeller support flange w/o spacer
Bubble Level Cabin floor
It is the pilot's responsibility to insure that airplane is properly loaded.
Approved Maneuvers
This aircraft is è intended for non-aerobatic operation only. Non-aerobatic operation includes:
• Any maneuver pertaining to “normal” flight
• Stalls (except whip stalls)
• Lazy eights
• Chandelles
• Turns in which the angle of bank is not more than 60°
Acrobatic maneuvers, including spins, are not approved.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
L IMI TAT IONS FLIGHT MANUAL
October ‘ 98 2-22
Fuel
Two tanks: 35 liters each. Total fuel capacity: 70 liters
Optional: Two tanks, 45 l each, total 90 l.
Approved Fuel
∗ High octane gasoline DIN 51600, O.NORM 1103 ∗ Unleaded gasoline DIN 51603, O.NORM 1101 ∗ Avgas 100LL
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
EMERGENCY PROCEDURES FLIGHT MANUAL
October ‘ 98 3-23
Section 3
Emergency Procedures
Table of Contents
introduCTION 24 ENGINE Failure 24 FORCED LANDING 25 SMOKE AND FIRE 25 RECOVERY FROM UNINTENTIONAL SPIN 26 deployment of emergency parachute (OPTIONAL EQUIPMENT) 27
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
EMERGENCY PROCEDURES FLIGHT MANUAL
October ‘ 98 3-24
Introduction
Section 3 includes checklists and detailed procedures to be used in the event of emergencies. Emergencies caused by a malfunction of the aircraft or engine are extremely rare if appropriate maintenance and pre-flight inspections are carried out.
In case of emergency, suggestions presented in this section should be considered and applied as necessary to correct the problem.
Before operating the aircraft, the pilot should become thoroughly familiar with the present manual and, in particular, with the present section. Further, a continued and appropriate training should be provided.
Engine Failure
Depending on the case that may apply, the emergency procedure should follow the guidelines listed below.
Engine failure during takeoff run
1. Throttle: idle (fully out) 2. Brakes: apply as needed 3. Magnetos: OFF 4. Flaps: extend 5. Master switch: OFF 6. Fuel shutoff valves: OFF
Engine Failure Immediately Af ter Takeof f 1. Locate landing area 2. Throttle: idle (fully out) 3. Fuel shutoff valves: OFF 4. Magnetos OFF 5. Flaps: as needed 6. Master switch: OFF 7. Land with wings level
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
EMERGENCY PROCEDURES FLIGHT MANUAL
October ‘ 98 3-25
Forced Landing
Emergency Landing W ithout Engine Power
1. Set glide speed to optimal value of 110 Km/h 2. Select terrain area most suitable for emergency landing, possibly upwind 3. Fuel shutoff valves: OFF 4. Magnetos: OFF 5. Tighten safety belts, release door safety lock and unlatch doors 6. Flaps: as needed 7. When ready to land, Master switch: OFF
Power-On Forced Landing
1. Adjust descent slope 2. Extend flaps as needed 3. Select terrain area most suitable for emergency landing and
flyby checking for obstacles and wind direction 4. Tighten safety belts, release door safety lock and unlatch
doors 5. Before touchdown: fuel shutoff valves OFF 6. Flaps: extended 7. After touchdown: Magnetos: OFF, Master switch: OFF
Smoke And Fire
Engine Fire W hile Parked Or During Takeoff
1. Fuel shutoff valves: OFF 2. Abort takeoff if possible 3. If engine is running let it use up remaining fuel in carburetors 4. Magnetos and Master switch: OFF 5. Warn bystanders to clear the area as fast as possible 6. Without removing the engine cowling use a CO2 or a powder fire
extinguisher to put out flames directing spray towards cowling's air intakes
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
EMERGENCY PROCEDURES FLIGHT MANUAL
October ‘ 98 3-26
Note DO NOT USE WATER to put out fire and do not open engine cowling until absolutely certain fire is extinguished. In case an appropriate fire extinguisher is not handy, still keeping engine cowling closed, it is possible to use a woolen blanket, sand or dirt to try smothering the fire.
Engine Compartment Fire In Fl ight
1. Fuel shutoff valves: OFF 2. Throttle: fully inward 3. Magnetos: OFF 4. Do not try airstarting engine 5. Extend flaps as needed 6. Carry out forced landing emergency procedure 7. Master switch OFF
Cabin Fire During Flight
1. Master switch OFF 2. Door vents: open 3. Extinguish fire with on-board fire extinguisher (if available) directing spray
towards flame base 4. Land as soon as possible
Recovery From Unintentional Spin
In case of unintentional spin entry, follow the emergency procedure described below:
1. Adjust throttle to minimum (full outward position) 2. Activate rudder bar by pushing foot opposite spin direction 3. Push control stick full forward and keep in position until spin is halted 4. Center rudder bar 5. Gradually recover flight attitude easing back on the control stick avoiding to
exceed VNE and maximum load factor 6. Readjust throttle to restore engine power
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
EMERGENCY PROCEDURES FLIGHT MANUAL
October ‘ 98 3-27
Deployment of Emergency Parachute (optional equipment)
Keeping in mind that full deployment of parachute is achieved after two seconds, the following procedure is recommended:
1. Try leveling aircraft as much as possible 2. Minimum altitude for successful deployment is about 33m (100 ft).1 3. Pull firing clip firmly and to end-travel 4. Shut off fuel valves, magnetos and master switch 5. Tighten safety belt and helmet chinstrap 6. Release door safety lock and unlatch doors 7. Assume tucked position before touch-down
1 This altitude is only representative,successful deployment depends on aircraft attitude and speed, greater deployment altitude yields better chances for successful deployment.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-28
Section 4
Normal Procedures
Table of Contents
INTRODUCTION 29 RIGGING AND DERIGGING ENGINE COWLING 29 PREFLIGHT INSPECTION 30 CHECKLISTS 33
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-29
Introduction
Section 4 contains checklists and amplified procedures for the conduct of normal operation.
Rigging and Derigging Engine Cowling
Upper Cowling:
I. Parking brake ON.
II. Fuel shutoff valves OFF.
III. Master switch OFF, Magnetos OFF.
IV. Unlatch all four butterfly Cam-locks mounted on the cowling by rotating them 90° counterclockwise while slightly pushing inwards.
V. Remove engine cowling paying attention to propeller shaft passing through nose.
VI. To assemble: rest cowling horizontal insuring proper fitting of nose base reference pins.
VII. Secure latches by applying light pressure, check for proper assembly and fasten Cam-locks.
Butterfly Cam-locks are locked when tabs are horizontal and open when tabs are vertical. Verify tab is below latch upon closing.
Lower Cowling
I. After disassembling upper cowling, bring propeller to horizontal position.
II. Using a standard screwdriver, press and rotate 90° the two Cam-locks positioned on lower cowling by the firewall.
III. Disconnect landing light wire
IV. Pull out the first hinge pin positioned on the side of the firewall, then, while holding cowling, pull out second hinge pin; remove cowling with downward motion.
V. For installation follow reverse procedure.
WARNING !
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-30
Preflight Inspection
Before each flight, it is necessary to carry out a complete inspection of the aircraft as hereby detailed.
Cabin Inspection
A Weight and balance: check if within limits
B Safety belts used to lock controls: free
C Flight controls: activate flight controls to insure unhindered movement of control rods and surfaces.
D Parking brake: engage
E Master switch: ON
F Check generator switch is illuminated and ammeter is operational.
G Flaps control: activate control to full extension checking end travel and instrument indication.
H Trim control: activate control to full scale checking end travel and instrument indication
I Master switch: OFF
J Fuel level: check level on the basis of flight plan
External Inspection
To carry out the external inspection it will be necessary to follow the checklist below with the station order outlined in fig. 4-1
A Left side tank cap: Check proper fastening.
B Left fuel tank blow-out plug: check for obstructions
C Remove protection cap and check pitot is unobstructed, do not blow inside vents, place protection cap inside aircraft.
D Leading edge and wing skin: check integrity
E Left aileron: check integrity and unhindered movement
F Left flap and hinges: check integrity
G Check integrity of left side main landing gear, tire inflation (1.4 bar), condition and alignment; check fuselage skin condition.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-31
H Horizontal tail and tab: check integrity and unhindered movement.
I Vertical tail and rudder: check integrity and unhindered movement.
L Check integrity of right side main landing gear, tire pressure (1.4 bar), condition and alignment; check fuselage skin condition.
M Right flap and hinges: check integrity.
N Right aileron: check integrity and unhindered movement.
O Leading edge and wing skin: check integrity
P Check right side tank cap is fastened and blow-out plug is unobstructed.
Q Check right side static vent is unobstructed, do not blow inside vents (read note).
R Check integrity of nose landing gear strut, tire inflation (1.0 bar) and condition; check condition of rubber shock absorbers.
S Propeller and spinner condition: check for nicks and fastening.
T Open engine cowling and perform the following checklist:
I. Check no foreign objects are present.
II. Check the cooling circuit for losses from tubing, check coolant reservoir level, insure radiator honeycomb cooling fins are unobstructed.
III. Check lubrication circuit for losses from tubing, check oil reservoir level, insure radiator honeycomb cooling fins are unobstructed
IV. Open both fuel taps, inspect fuel circuit for losses from tubing, check integrity of fireproof protection braids, drain circuit using a container to collect fuel activating the specific drainage tap located on the firewall, shut fuel taps. Check for absence of water or other contaminants.
Drainage operation must be carried out with aircraft parked on level surface.
V. Check integrity of silent-blocks.
VI. Check firmness and integrity of air intake system, check externally that ram air intake is unobstructed.
VII. Check that all parts are secure or safetied.
U Close engine cowling.
V Check left side static port is unobstructed
WARNING !
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-32
Z Remove tow bar and chocks
NOTE
Avoid blowing inside left strut mounted pitot and inside airspeed indicator system's static vents as this may damage instruments.
FIG. 4-1
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-33
Checklists
Before Starting Engine (after preflight inspection)
I. Flight planning, fuel consumption, refueling.
II. Aircraft loading and related inspections (see section 6)
III. Seat and safety belts adjustment
IV. Doors secured
V. Parking brake ON.
Starting Engine
I. Master switch ON.
II. Both fuel taps ON.
III. Engine throttle to idle.
IV. Choke as needed.
V. Magnetos switch to ON.
VI. Prop area: free
VII. Ignition key set to: START.
VIII. Prop RPM: 2400 - 2600 RPM
IX. Choke OFF
X. Check engine instruments
XI. Check oil pressure rise (maximum value cold 7 bar)
Before Taxing
I. Radio and utilities ON.
II. Altimeter: reset.
III. Navigation lights: as required
Taxiing
I. Brakes: check operation
II. Flight instruments: check operation
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-34
Holding
I. Parking brake ON.
II. Turn on navigation lights, strobe light, and landing light (optional equipment)
III. Check engine parameters.
912UL 912 S
Oil temperature 50° - 110° 50° - 100°
Cylinder heads temperature 150° 135°
Oil pressure 1.5 - 7 1.5 - 7
IV. Check ammeter to insure alternator is charging.
V. Prop rpm’s at 3800 RPM and test magnetos.
VI. Visual check of fuel indicators.
VII. Flaps at 15° (takeoff)
VIII. Stick free and zero trim
IX. Seat belts fastened and doors secured.
Takeoff And Climb
I. Control Tower for takeoff
II. Check for clear final and wind on runway.
III. Parking brake OFF, full throttle.
IV. Carburetor heat: OFF
V. Taxi to line-up
VI. Rotation and takeoff
VII. Slight braking to stop wheel spinning.
VIII. Flaps retracted
IX. Landing light OFF.
X. Trim adjustment
XI. Establish climb rate
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
NORMAL PROCEDURES FLIGHT MANUAL
October ‘98 4-35
Cruise
I. Reach cruising altitude
II. Set power and engine rpm's for cruise.
III. Check engine parameters 912UL 912 S
Oil temperature 90° - 110° 90° - 100°
Temperature cylinder heads 90° - 150 90° - 135°
Oil pressure 1.5 - 5 1.5 - 5
IV. Carburetor heat as needed, see paragraph on carb heat in Section 3. NOTE
Compensate unpredicted asymmetrical fuel consumption between left and right fuel tanks by shutting off appropriate fuel tap located inside cabin
Landing
I. Turn on landing light (if installed)
II. Check runway final and establish descent and approach to final.
III. Extend flaps gradually to maximum deflection of 35°.
IV. Optimal touchdown speed 70 Km/h
V. Land and taxi.
VI. Flaps to 0°.
VII. Parking brake ON.
VIII. Turn off landing light, navigation lights and strobe light.
Engine Shut Down
I. Keep engine running at 3000 RPM for about two minutes in order to reduce latent heat.
II. Turn off all electrical utilities
III. Set magnetos switch and Master switch to OFF
IV. Set both fuel taps to OFF.
V. Insert hood over pitot tube on left side wing strut.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-36
Section 5
Performance
Table of Contents
INTRODUCTION........................................................................... 37
AIRSPEED CALIBRATION .......................................................... 38
STALL SPEEDS ............................................................................. 38
CROSSWIND.................................................................................. 39
TAKEOFF PERFORMANCE......................................................... 40
LANDING....................................................................................... 41
CLIMB PERFORMANCE.............................................................. 42
CRUISE........................................................................................... 43
CONSEQUENCES FROM RAIN AND INSECT.......................... 43
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-37
Introduction
This section provides all necessary data for accurate and comprehensive planning of flight activity from takeoff to landing.
Data reported in graphs and/or tables were determined using:
• aircraft and engine in good condition • average piloting techniques
Each graph or table was determined according to ICAO Standard Atmosphere (ISA - m.s.l.); evaluations of the impact on performance was carried out by theoretical means for:
• airspeed • external temperature • altitude • weight
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-38
Airspeed Calibration
The difference between indicated airspeed and calibrated airspeed is within JAR-VLA limits of ± 3% for all speeds above 1.3 Vs.
Stall Speeds
CONDITIONS: - weight 450 kg
- engine idle - no ground effect
Note The table below is valid for both P92 Echo and P92 Echo/100.
Lateral Banking
0° 30° 45° 60°
Flaps IAS km/h IAS km/h IAS km/h IAS km/h
0° 74 78 84 101
15° 69 76 79 97
35° 64 69 76 91
Rev. May, 2002
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-39
Crosswind
Maximum demonstrated crosswind velocity is 15 Kts
⇒ Example: Given Find
Wind direction = 30° Headwind = 17.5 Kts Wind velocity = 20 Kts Crosswind = 10 Kts
Fig. 5-1 CROSSWIND CHART
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-40
Takeoff Performance
Takeoff Distance
Conditions: - ISA - Flaps: 15° - Engine: full throttle - Slope: 0° Wind: zero - Runway: dry, compact, grass
Fig. 5-2 TAKEOFF
0
50
100
150
200
250
300
400 410 420 430 440 450 460 470 480 490 500
WEIGHT (Kg)
Gro
und
roll,
Dis
tanc
e (m
)
Ground roll P92 Echo
Ground roll P92 Echo/100
DISTANCE P92 Echo
DISTANCE P92 Echo/100
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-41
Landing
Ground Roll Distance And Landing Distance (P92 Echo & P92 Echo/100)
Conditions:
- Flaps: 35° Runway: dry, compact, grass - Engine: throttle idle - Slope: 0° Wind: zero Distance over a 15 m obstacle
The graph below is valid for both P92 Echo and P92 Echo/100
Fig. 5-3 LANDING
0
50
100
150
200
250
300
400 410 420 430 440 450 460 470 480 490 500
WEIGHT (Kg)
Gro
und
roll,
Dis
tanc
e (m
) Ground roll
DISTANCE
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-42
Climb Performance
Climb Rate In Clean Configuration
Conditions:
- ISA - Flaps: 0° - Weight 450 kg - Engine: full throttle
Fig. 5-4 CLIMB RATE
P92 Echo � VY = 120 km/h
P92 Echo /100 � VY = 120 km/h
NOTE
• For each 10 kg weight increase, R/C decreases by 0.15 m/sec (30 ft/min).
• For each 10 kg weight decrease, R/C increases by 0.15 m/sec (30 ft/min).
0
1
2
3
4
5
6
7
0 500 1000 1500 2000 2500 3000
Altitude (m)
R/C
(m
/sec
)
P92 Echo
P92 Echo/100
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
PERFORMANCE FLIGHT MANUAL
October ‘98 5-43
Cruise
Conditions:
- ISA - Altitude: 0
- Wind: 0
P92 Echo
RPM CAS km/h Hourly consumption [lt/h]
4300 155 13
4800 170 14
5000 180 16
P92 Echo/100
RPM CAS km/h Hourly consumption [lt/h]
4300 165 14
4800 180 18
5000 196 20
Consequences From Rain And Insect
Flight tests have demonstrated that neither rain nor insect impact build-up on leading edge has caused substantial variations on aircraft's flight qualities.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
WEIGHT & BALANCE FLIGHT MANUAL
October ‘98 6-44
Section 6
Weight & Balance
Table of Contents
INTRODUCTION 45 aircraft weighing procedures 45 weighing report 46 C. G. TRAVEL 47
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
WEIGHT & BALANCE FLIGHT MANUAL
October ‘98 6-45
Introduction
This section describes the procedure for establishing the basic empty weight and moment of the aircraft. Loading procedure information is also provided.
Aircraft Weighing Procedures
Preparation
a. Carry out weighing procedure inside closed hangar b. Remove from cabin all objects left unintentionally c. Align nose wheel d. Drain fuel using draining reservoir e. Oil, hydraulic fluid and coolant to operating levels f. Position seats to most forward position g. Flaps retracted (0°) h. Control surfaces in neutral position i. Place scales (min. capacity 150 kg) under each wheel
Leveling
a. Level the aircraft using cabin floor as datum b. Center bubble on level by deflating nose tire
Weighing
a. Record weight shown on each scale b. Repeat weighing procedure three times c. Calculate empty weight
Determination of C.G. location
a. Drop a plumb bob tangent to the leading edge (in non-tapered area of one half-wing, approximately one meter from wing root) and trace reference mark on the floor.
b. Repeat operation for other half-wing. c. Stretch a taught line between the two marks d. Measure the distance between the reference line and main
wheel axis e. Using recorded data it is possible to determine the aircraft's
C.G. location and moment (see following table)
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
WEIGHT & BALANCE FLIGHT MANUAL
October ‘98 6-46
Weighing Report
Model P92 ECHO & P92 ECHO/100 s/n:____ Weighing n°____ Date:_________
Datum: Propeller support flange without spacer
Kg meters
Nose wheel weight W1 = Plumb bob distance from LS wheel AL =
LS wheel weight WL = Plumb bob distance from RS wheel AR =
RS wheel weight WR = Average distance (AL+ AR)/2 A =
W2 = WL+WR = Bob distance from nose wheel. B =
Empty weight We = W1 + W2 =
DW A W B
We=
⋅ − ⋅=2 1 m D
D%
.= ⋅ =
14100
Empty weight moment: M = [(D+1.39) .We] = Kg . m
Maximum takeoff weight WT = 450 kg
Empty weight We =
Maximum useful load WT - We Wu =
Deleted: +1.9
Deleted: +3.2
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
WEIGHT & BALANCE FLIGHT MANUAL
October ‘98 6-47
C. G. Travel
Maximum admissible C.G. travel exceeds actual operational limits. Moreover, occupants and fuel impact only marginally on CG travel.
When on flat terrain, exceeding CG travel aft limit will cause aircraft tail to lower.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
SYSTEMS FLIGHT MANUAL
October ‘98 7-48
Section 7
Airplane and System Descriptions
Table of Contents
INTRODUCTION 49 AIRFRAME 2 FLIGHT CONTROLS 49 INSTRUMENT PANEL 50 SEATS AND SAFETY HARNESS 51 DOORS 51 BAGGAGE COMPARTMENT 51 ENGINE 52 FUEL SYSTEM 52 ELECTRICAL SYSTEM 52 AIRSPEED INDICATOR SYSTEM 53 BRAKES 53
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
SYSTEMS FLIGHT MANUAL
October ‘98 7-49
Introduction
This section provides description and operation of the aircraft and its systems.
Airframe
Wing
The wing is made up of a central light alloy torque box; a composite leading edge is attached to the front spar and geometrically similar flap and aileron are hinged to rear. Flaps and ailerons are both made up of an aluminum spar connected to formed sheet metal leading edge and ribs and are covered by a thermoretractible synthetic material.
Fuselage
The front part of the fuselage is made up of a truss structure with special steel tubing and, beginning at the cabin's rear section, by an aluminum alloy semi-monococque structure. The engine housing is isolated from the cabin by a stainless steel firewall; the steel stringers engine mount is attached to the cabin's truss structure in four points.
Empennage
The vertical tail is entirely metal: the vertical stabilizer is made up of a twin spar with load carrying skin while the rudder consists of an aluminum torque stringer connected to light alloy ribs and skin. The horizontal tail is an all-moving type (stabilator); its structure consists of an aluminum tubular spar connected to ribs and leading edge; the entire structure is covered with thermoretractible synthetic material.
Flight Controls
Aircraft flight controls consist of aileron, rudder and stabilator control surfaces. The control surfaces are manually operated using a control stick for ailerons and stabilator and rudder pedals for the rudder; longitudinal control acts through a system of push-rods and is equipped with a trim tab. Aileron control is of mixed type with push-rods and cables; the cable control circuit is confined within the cabin and is connected to a pair of push-rods positioned in the wings that control ailerons differentially. Aileron trimming is carried out on ground through a small tab positioned on left aileron.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
SYSTEMS FLIGHT MANUAL
October ‘98 7-50
Flaps are extended via an electric servo actuator controlled by a switch on the dashboard. Flaps act in continuous mode, an LED indicator shows surface position. Two lighted LEDs indicate takeoff position (15°). The electric circuit is protected by a breaker positioned on the right side of the dashboard. Longitudinal trim is performed by a small tab positioned on the stabilator and controlled via an electric servoactuator by pushing an Up/Down push-button located on the control stick or on the dashboard.
Instrument Panel
The instrument panel is of conventional type, allowing space for a broad range of equipment. Instruments marked with an asterisk (*) are optional.
Fig. 7-1. INSTRUMENT PANEL
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
SYSTEMS FLIGHT MANUAL
October ‘98 7-51
Throttle Friction Lock
It is possible to adjust the engine's throttle friction by tightening appropriately the friction lock located on the dashboard near center throttle control.
Seats and Safety Harness
Aircraft features three point fitting safety belts with waist and diagonal straps adjustable via a sliding metal buckle. Seats on the P92 can be of two types: • Standard seats are fiberglass with easily removable cushions. Seats may be
adjusted on ground by operating on the latch mechanism located below seating cushion.
• Optional seats (type J) are built with light alloy tube structure and synthetic material cushioning. A lever located on the right lower side of each seat allows adjustment of seat position according to pilot size.
Doors
Doors available on the P92 can be of two types:
• Standard doors feature a light alloy tubular frame supporting a transparent or tinted panel. An internal safety latch mechanism is positioned in proximity of door's upper edge and must be used before flight to secure door. Mechanism rotates to engage door frame to cabin tubular framework.
• Optional doors can be equipped with door handles on both sides of doors and left side external door handle equipped with a door lock. An internal safety latch mechanism is positioned in proximity of door's upper edge and must be used before flight to secure door. Mechanism rotates to engage door frame to cabin tubular framework.
Baggage Compartment
The baggage compartment is located behind the pilots' seats. Baggage shall be uniformly distributed on utility shelf.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
SYSTEMS FLIGHT MANUAL
October ‘98 7-52
Engine
�P92 Echo ROTAX 912UL, 4 stroke, horizontally-opposed 4 cylinder, mixed air and
water cooled, twin electronic ignition, forced lubrication Maximum rating - 81Hp (59.6 kW) at 5800 RPM Reduction gearbox - 2.273:1 Prop. GT-ECHO 2/166/145
�P92 Echo/100 ROTAX 912S, 4 stroke, horizontally-opposed 4 cylinder, mixed air and water
cooled, twin electronic ignition, forced lubrication Maximum rating - 100 Hp (73.5 kW) a 5800 g/min Reduction gearbox - 2.4286:1 Prop. GT-ECHO 2/172/164 For further information refer to “Engine Operating Manual”.
Fuel System
The system consists of two composite material fuel tanks that are integral part of the leading edge featuring a viewport to visually monitor fuel level of each tank. Capacity is 35 liters each. Each tank is equipped with cabin installed shut-off valve and of a main filter located on the firewall and equipped with a drainage valve. Fuel level is detected via a calibrated scale located on fuel tank walls visible from cabin. The fuel system also features a mechanical pump operated by the engine and an emergency non-return valve that allows gravity feed in case of main pump failure.
Electrical System
The aircraft's electrical system consists of a 12 Volt DC circuit controlled by a Master switch located on dashboard. Electricity is provided by an alternator or by a buffer battery placed in tailcone. Generator light is located on the right side of the instrument panel.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
SYSTEMS FLIGHT MANUAL
October ‘98 7-53
Oil and Cylinder Head Temp. - Oil Pressure
These instruments are connected in series with their respective sensors. Temperature instruments are protected by the same breaker; oil pressure indicator and a second breaker protects other instruments.
Avionics
The central part of the dashboard holds room for avionics equipment. System's manufacturer furnishes features for each system.
Airspeed Indicator System
The aircraft's airspeed indicator system is shown below and consists of two static vents located on both sides of the aircraft forward of cabin and by a pitot tube located on left wing strut
FIG. 7-2. AIRSPEED INDICATOR SYSTEM
Brakes
The aircraft's braking system is a single system acting on both wheels of main landing gear through disk brakes, the same circuit acts as parking brake via an intercept valve. To activate brakes it is sufficient to verify that brake shut-off valve positioned on tunnel between pilots is OFF, then activate brake lever as necessary. To activate parking brake pull brake lever and set brake shut-valve to ON.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GROUND HANDLING AND SERVICE FLIGHT MANUAL
Ottobre ‘98 8-54
Section 8
Ground Handling And Service
Table of Contents
INTRODUCTION 55
AIRPLANE INSPECTION PERIODS 55
GROUND HANDLING 55
CLEANING AND CARE 56
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GROUND HANDLING AND SERVICE FLIGHT MANUAL
Ottobre ‘98 8-55
Introduction
This section contains factory-recommended procedures for proper ground handling and routine care and servicing. It also identifies certain inspection and maintenance requirements which must be followed if the aircraft is to retain its new-plane performance and dependability. It is wise to follow a planned schedule of lubrication and preventive maintenance based on climatic and flying conditions encountered locally.
Airplane Inspection Periods
Inspection intervals occur at 50, 100 hours and in accordance with special inspection schedules which are added to regularly scheduled inspections. Correct maintenance procedures are described in the aircraft’s Service Manual or in the engine’s Service Manual.
Ground Handling
Towing
The aircraft is most easily and safely maneuvered by hand by pushing on wing struts near attachments or by pulling it by its propeller near the axle. A tow bar can be fixed onto nose gear fork. Aircraft may be steered by turning rudder or, for steep turns, by pushing lightly on tailcone to lift nose wheel.
Parking And Tie-Down
When parking airplane outdoors, head it into the wind and set the parking brake. If chocks or wedges are available it is preferable to use the latter.
In severe weather and high wind conditions it is wise to tie the airplane down. Tie-down ropes shall be fastened to the wing strut attachments and anchoring shall be provided by ramp tie-downs. Nose gear fork can be used for front tie-down location. Flight controls shall be secured to avoid possible weathervaning to end travel damage of moving surfaces. For this purpose, seatbelts may be used to latch control stick to prevent its movement.
COSTRUZIONI AERONAUTICHE
TECNAM S.r.l.
P92 Echo P92 Echo/100
GROUND HANDLING AND SERVICE FLIGHT MANUAL
Ottobre ‘98 8-56
Jacking
Given the light empty weight, lifting one of the main wheels can easily be accomplished even without the use of hydraulic jacks. It is in fact sufficient that while one person lifts one half-wing by acting on the spar immediately before the wingtip, another person places a suitable stand below the steel spring attachment.
Leveling
Aircraft leveling may become necessary to check wing incidence, dihedral or the exact location of CG. Leveling is obtained when the lower cabin edge and the main gear support beam are horizontal.
Road Transport
It is recommended to secure tightly all aircraft components onto the cart to avoid damage during transport. Minimum cart size are 7x2.5 meters. It is suggested to place wings under the aircraft’s bottom, secured by specific clamps. Secondary components such as stabilators and struts shall be protected from accidental hits using plastic or other material. For correct rigging and derigging procedure, refer to Service Manual.
Cleaning and Care
To clean painted surfaces, use a mild detergent such as shampoo normally used for car finish; use a soft cloth for drying
The plastic windshield and windows should never be dusted when dry; use lukewarm soapy water and dry using chamois only. It is possible to use special glass detergents but, in any case, never use products such as gasoline, alcohol, acetone or other solvents. To clean cabin interior, seats, upholstery and carpet, it is generally recommended to use foam-type detergents.
top related