the uiuigl mfdxum for tri t3j& ox$& mcco~o~/67531/metadc866538/...the tse of tri uiuigl...
Post on 03-May-2020
5 Views
Preview:
TRANSCRIPT
THE tSE OF TRI
UiUigL MFDXUM FOR T3J& OX$&
Do M c C O ~ O ~ Radiation Monitoring Section
Environmental Health & Engineering Department
LEGAL N O l W
This report wos prepared oa on account of Government sponsored work. Neither the Unwed Stoter nor the Cornmiadon, nor ony person acting on behoif of the Corpdssionr .
A. Mokn any worronty w repreawntotion, e x p r e d or implid, with respect to the occurocy, com- pleteness, or usefulness of the informollon contoined in this report, or tho, the u u of on informolon, opporotua, mothod, or procow dhcloaod in thlc nport moy not lnhlngo privot*ly ownod r lg lw or
b. Auums ony llabiiitiea with respect to thq uae of, w for domogr rruhhr(l from tho u u of ony information, opporotua, method, or proceas disclosed in this report.
h uaed In the obove, *penon acting on kholf 'of tha Commission' includes ony employee or contmctw of tho Commhdon, or employ.. of such controctw, to tho extent that such employee w con- tmctor of tho tommiuiol, or ompl ** d wch contractor pnporu, dhhmlnotoa, w pmvidos occw to, ony Informallon punwnt to Ma omzqmont or controct with thi Commission. or his employment with such contractor.
'. PACIFIC NORTHWEST LABORATORY
RICHLAND, WASHINGTON
operated by n w I Q N OF TRIS DO- 1s m m hl. BATTELLE MEMORIAL INSTITUTE
for the ' 54-1 100-057 ( 6 -68 ) Ace-nwo IICIUIL wma. UNITED STATES ATOMIC ENERGY COMMISSION UNDER CONTRACT AT(45-1)-1830
DISCLAIMER
This report was prepared as an account of work sponsored by an agency of the United States Government. Neither the United States Government nor any agency Thereof, nor any of their employees, makes any warranty, express or implied, or assumes any legal liability or responsibility for the accuracy, completeness, or usefulness of any information, apparatus, product, or process disclosed, or represents that its use would not infringe privately owned rights. Reference herein to any specific commercial product, process, or service by trade name, trademark, manufacturer, or otherwise does not necessarily constitute or imply its endorsement, recommendation, or favoring by the United States Government or any agency thereof. The views and opinions of authors expressed herein do not necessarily state or reflect those of the United States Government or any agency thereof.
DISCLAIMER
Portions of this document may be illegible in electronic image products. Images are produced from the best available original document.
INTRODUCTION
The radiation protection program at a heavy water reactor such as the
Plutonium Recycle Test Reactor (PRTR) is 'complicated by the presence of
tritium, primarily in the form of tritium oxide, Neutron activation of
the deuterium in reactor systems produces tritiub which escapes to the
working environment through' system leaks and accidental heavy water spills, . .
The human.body readily assimilates tritium in the oxide form from the
environment by inhalation and direct absorption through the intact skin. '
The,presence of tritium in the air and on exposed surfaces is difficult
to detect with ordinary sampling techniques and monitoring instrumentation
because of the low energy of the beta particle emitted during the disinte- . .
gration of the tritium atom (0.018 Mev, maximum energy), This. paper
describe8 rapid, reliable, and simple methods of. sampling for airborne
and surface tritium contamination with a'high collection efficiency.
. . ! . .
'SUMMARY ' - A sampling technique for airborne tritium oxide was developed and tested,
Under the experimental conditions consi dered, the efficiency of this method :,
averaged 98%. The :technique employs a gas wash battle filled with ordinary
distille'd water through which air i s bubbled at a constant flow rate, The
method is rapid, reliable, and sensitive and has been proven under a
variety of field conditions, The minimum detectable tritium oxide air
concentration that can reliably be measured is 1 x log7 uCi /cc. Additionally,
a technique is described for determining'the amount of tritium oxide surface I . . .
contamination; Because of difficulties in measking the collection effi-
ciency of the technique, it is presently used' for qualitative measurements ,
as a trend indicator only, : .
111, SAMPLING AND MONITORING TECHNIQUES' FOR' TRITIUM
Among the methods employed to monitor for airborne tritium is an ion chamber
device through which air is continuously drawn after passing through an ion
trap, The chamber may be gamma-ray compensated if it is used in a high
gamma-ray backglrolled ares, or the sample may Be drawn from the work ore& to /
a low background location where the instr-ent is situateda This method , -------
does not provide any discrimination ag'*inst interfering airborne--riad< ./'
activity such as that emitted by noble gases produced during reactor
operation and serious errors in estimates:of .the air contamination status, .
may result.
An alternative method for tritium monitoring is to sample the moisture .
cdntained in the working atmosphere. A popular medi-urn for moisture
collection is a silica gel trap which collects water by adsorption and has . "
a low efficiency for interfering gases;' +he water i s driven off the
silica gel'by heating, collected, and .analyzed .for tritium content by . . ._li--..--%...::l
liquid scintillation counting or internal gas counting, Certain problems '
exist with the silica 'gel sampling technique for tritium. The procedure
i s cumbersome'snd tame consuming, requiring additional equipment such as a ,
furhace and water condenser, The collection efficiency of silica gel for
'water varies with use both in'successive sampling periods and during a ..
single sampling period.' Finally, all the water collected during a sampling
period is not dtstilled out of the silica gel which leads to dilutions or
concentrations of subeequent samples,
Another method sometimes used to sample air for tritium oxide employs a
freeze trap apparatus. Moisture is frozen out of the air which is drawn
through a chamber cooled by dry ice ox-;.li quid nitrogen. he s&nple i s then
, , .
analyzed f o r tritium content by l i q u i d s c i & i l l a t i o n o r i n t e r n a l gas count-
ing. This method requires @ long sampiing time t o obta in a sample of
adequate volume, p a r t i c u l a r l y i n atmospheres of low r e l a t i v e humidi t y . In
addt t ion , t h e 'method does not have a very.,high c o l l e c t i o n e f f i c iency
because ice crystals forwed i n the chwber mw Behave oe e m d l partgclee . .
and pass r i g h t on through t h e chamber,
Because o f t h e above problems with each or t h e monitoring o r sampling
methods f o r t r i t i u m , a d i f f e r e n t technique was developed i n which a i r is
bubbled through d i s t i l l e d water, The water is then analyzed f o r tritium
by l i q u i d s c i n t i l l a t i o n counting and t h e quan t i ty r e l a t e d t o a i rborne
tritium concentration. A series o f tests irere devised t o i n v e s t i g a t e t h e . , . ". . . ...
c o l l e c t i o n e f f i c iency of t h e method under:various environmental conditions. ,
A I R SAMPLING 'I TEST 'PROCEDURE
A s e r i e s of experiments was devi sed t o t&t t h e e f fec t iveness o f . the sampling
technique f o r t r i t i u m oxide col lec t ion. The co l l ec t ion e f f i c i e n c y o f t h e
technique was measured f o r 'various combinations ,of sampling t i m e , tritium . . . . .
eoncentra t i on, ' and r e l a t i ve humidity. The "experf mental arrangement i s
shdwn i n Figure 1. Dried room a i r was drawn through a gas wash b o t t l e
containing approxfmately 100 mls, of d i l u t e tritium oxide of known co=en-
t r a t i o n . T h e a i r c a r r i e d . . . moisture from t h e , s o l u t i o n i n t h e gas wash b o t t l e
t o t h e sampler, ~ r o v i s i o n s were included t o . route t h e a i r throukh another.
gas wash b o t t l e while samples were being changedo The a i r was exhausted ,
through s i l i c a g e l t o remove most of t h e 'water leaving t h e experimental ,-. . .
set-up, A i r flow r a t e as measured with a rotanheter was maintained at - 3- ----- /-- -.
I l i t e r s p e r minute. The r e l a t i v e humidity of t h e r e s u l t i n g atkospheres was
. . hpproxiniately 80%. I n order t o measure' c b l l ~ c t i o n e f f i c iency a t lower
r e l a t i v e humidities:, t h e appartus was changed s l i g h t l y a s shown i n Figure 2
by t h e inc lus ion of a s i l i c a g e l column, 'The l i n e was branched downstream
of t h e gas wash b o t t l e conta in ing t h e tritium s o l u t i o n t o permit measure-
ments of the wet and dry bulb temperatures, Calcula t ions o f t h e moisture
' . weight pe r . un i t volume o f sir and r e l a t i v e humidity o f t h e a i r pass ing
through t h e sampler were made based on wetsand dry bulb temperatures,
Temperature measurements were made with a.0-50' C p rec i s ion thermometer,
It was assumed t h a t t h e moisture i n t h e air en te r ing t h e sampler had t h e
same t r i t i u m concentrat ion a s t h a t i n t h e . sp ike so lu t ion , Measurements of.
t h e tritium concentra t ions i n t h e water so lu t ions were done by l i q u i d
s c i n t i l l a t i o n counting, A t o t a l of 9 trials were completed, each t r i a l
. . l a s t i n g approximately 3 hours, .
A l l $as wash b o t t l e s and s i l i c a g e l co1umns:'were weighed before and a f t e r a . D
trial run t o measure t h e water balance ? f : t h e sybtem. I n add i t ion , t h e
amount o f tritium l o s t from t h e sp ike so lu t ion was measured and compared
t o t h e t o t a l amount o f tritium co l l ec ted , Resul ts o f t h e water balance . .
and t r i t i u m recovery measurements a r e given i n Table 1.
Vo TEST RESULTS '
The r e s u l t s o f t h e e f f i c i ency measurements are given i n Table 2, Sampling
time had l i t t l e e f f e c t Dn t h e c o l l ~ c t i o n e f f i c i ency of t h e system. A s
sampling time increased, ' the measured eff ic , iency dec reased s l i g h t l y due t o
water l o s s e s from t h e sampler, which amounted t o a O , l m l during a 5 minute
sampling per iod o r less. than 1% f o r a s,ample c o l l e c t e d f o r 30 minutes.
'There was no evidence. t h a t t h e c o l l e c t i o n e f f i cJency depended' upon t h e
r e l a t i v e humidity nor on tGitium concentrat ion i n t h e range 7 x log7 t o , '. .
1 x loo3 pCi/cc, From t h e da ta i n able '2, a f i v e minute sampling time i s . . . .
TABLE 1 I
Water Balance and Tritium Recovery of t h e Experimental Ar.rangement
Water ~ a l & c e - gms Tritium Recovery Run Tota l Weight Tota l Weight pCi H-3 Lost. u C i H-3 Gained Percent
Number before Run a f t e r Run from Spike i q. Equipment Recovery_ - 1 Not Determined ' . . s 0 9 5 -0 86
TABLE 2
Percent Collect ion Eff ic iency of t h e Bubbler Technique i n Sampling f o r Airborne Tritium Oxide
Calculated Tritium A i r
concentrat ions Relatf ve Sampli ng Times pCi/cc Hmf d i ty $ Minutes 10 Minutes' 20 Minutes 30 Minutes
.
adequate to achieve an average collection:efficiency of.98% in the range ,
of air eoncentrations studied, . .
. . . . .
VI, DISCUSSION AND FIELD EXPERIENCE
The largest e'rror in the test pro=edure involved measurement of the tem-
perature,, he thermometer$ used had inaicated precisidn of 2 /
Calculations of the water volume per unit weight of dry air were completed --.
..- J'
rather than determinations of the water:volume per unit wei-ght of moist
lira This error is estimated to..be less, *hair l%b(l) The maximum error in
the 'collection efficiency measurements is. estimated to be 10%.
The minimum tritium concentration.in a water solution detectable by liquid
scintillation counting is 1.3 x log5 p~i/cc.*(~)' For a five-minute sampling
period, this yields a tritium air concentration of -1 x log7 pCi/cc, The P .
normal levels encountered at the PRTR ranee from 10'' to log5 pCi/cco . , . .
The bubbler sampler developed for field .use. is shown in Figure 30 The -.,-.-- .--. .
vacuum source is a small diaphragm pump which.draws.an air sample through
" 100 mls, of distilled water at .the rate of 3 liters/minute, The gas wash . .
bottle has a 125 mlo capacity,. The. systep.has . . been used routinely at the :
PRTR under a variety of operating and outage conditions, The main virtue
of the system is the simplicity and ease with which a sample may be col- . .
leeted, Experience has shown that results 'of. a sample analysis can be . . . . ,
available in as little as 30 minutes after the sample is collected, The
'typical air eoncentrat'ions measured with this system through an operation-
\. outage cycle at the PRTR are shown in Ffgure 4 , A plot of the parti culate I
beta-gamma airborne.radioactivity coliected at a location near the tritium
*For a sample volume of 1 m l , and a 3 6 minute counting period, the accuracy is 2 25% and the counting precision is 2.20% at. the 95% confidence. level,
- 7 0 . :' BNWL-CC-547
. . r . . :
sampling s t a t i o n i s given f o r compariscin. 1 ~ i r b b r n e . t r i t ium contamination
l e v e l s 'remain r e l a t i v e l y constant during..,operation, then increase a t t h e
beginning of an outage gnd gradually decrease t o pre-operational l e v e l s ,
The. average tritium a i r contamination l e ~ e l during operat ion has been
3 x loo6 l~Ci /cc , while during shutdowns i t increases t o an kverage vaiue
' \
of 1 x 10'~ pCi/cc, The airborne betaOg&nma contamination (composed
of f i s s i o n gases and t h e i r daughter i s .somewhat I ;
higher during operat ion but falls o f f r ap id ly at t h e s t a r t of an outage,
The highes t a i rborne tritium l e v e l s normally occur i n t h e v i c i n i t y of an .
i r r a d i a t e d heavy water s p i 11, The m a x i m b m concentrat ion measured t o da te
i n t h i s s i t u a t i o n i s 3 x loo3 pCi/cco '
'
V I I , ' SURFACE CONTAMINATION SAMPLING .. '
A " d i f f e r e n t technique f o r determining se&-quantiSatively t h e amount o f . . . . ,
smearable tritium surface contamination yas a l s o developed, The technique
involves t ak ing a wet smear of a known surface tares with a dampened . . . .
:.
'2" x 2" gauze pad, adding 9 known amount o f d i s t i l l e d water t o t h e gauze 0 . .
pad i n a conta iner , and allowing e q u i l i b r a t i o n of t h e t r i t i u m i n t h e pad
and t h e water t o take p lace over a pre-determined per iod of t imeo !l!he
d i s t i l l e d water i s then,drawn o f f and analyzed f o r tritium content by
l i q u i d s c i n t i l l a t i o n counting,
Studies were compldted t o def ine t h e parameters involved i n t h e smear
technique, The f i rs t study x& designed t o determine t h e quant i ty of
t r i t i u m t h a t would be 'recovered i n t h e added d i s t i l l e d water, I"o'tr gauze/
pads were moistened with 0,5 m l . of so lu t ions 'containing known amounta of-- --- '
. . *' i
tritium. Approximately 80% of t h e tritium edded t o t h e ga<;= pads was
'de tec ted i n t h e d i s t i l l e d water 'in t h i s ,andcsubsequent s tud ies , The . .
r e s u l t s of t h e test are given i n Table 36. . .
TABLE. 3
Percent Recovery Measured for the Wet Pad Tritium Smear Technique
Equilibration Solution - 10 m l . Equilibration Time - 10 min,
Spike Trf tfw 'Tritium Detected Concentration Added to id Equilibration Percent
pci/cc Pad - pCi Solution - pCi Recovery
Another study was designed to determine the variation in results with . ,
various quantities of distilled water equilibration solutions, The results
are given in Table 4, The data does not 'fnd4cate any appreciable variation
in results with the various amounts of equilibration solution used,' However,
.P
there is not sufff cient data to indicate. thi s with certainty,
TABLE .4
Variation of Percent Recovery with Different Amounts of.Equ9libration Solution
Equilibration Time - PO minutes Spike - O,5 ml, of 64 pCi/c,c tritium solution
. : .Tritium ~etected
Equi librati on in Equilibration Percent Solutf on - m l , Solution -.pCf . . Recovery
5 19 , : . 6 o , 10 19 .. ' 6 0
' 20 28 . . . 88 30 ? 1 66'
. . . ' \
~:.,Pinal study was done to estimate the time necessary for equilibrium. ! !
The results given in Table 5 indieate that the equilibration time is short ; !
. .
and that 10 minutes is adequate for equilibrium to be established,
TABLE 5
'Variation of Percent Reco~ery with Different Equilibration Times
Equilibration Solution - 10 ml, Spike - 0,5. ml , of 64 pdi/cc tritium solution
Tritium Detected Equf lf brat Pon in Equilibration Percent Time - Mi n, Solution - uCi Recovery
. .
Because of difficulties in preparing a surface with a known quantity of
tritium oxide contamination and because .'the collection efficiency depends ' .
on the characteristics of the surface being smeared, coLlection efficiency
measurements were not completed, The technique has some value qualitatively .....
as a trend indicator. The sampling technique presently used involves a smear
of a 4 sq, ft, area, an equilibration solution of 10 m l , of distilled water,
and an equilibration time of 10 minut='s.: It is estimated that the minimum . .
smearable tritium surface contamination detectable by this method is . ,
5 x 10' pCi/sq, ft, for i 4 sq, fto area, Normal smearable tritium oxide
surface contami,nation at the PRTR has been approximately 0,03 u~i/sq. ft,
. .
REFERENCES
. . 1 , Unpublished work of R. J: Erigelman.
2, Unpublished work of L, S, Kellogg,
3, Do McConnon, A Review .of the Air ~0nitori.k~ Program at the PRTR, HW-82705, May 15, 1964,
To Vacuum
A i r Intake
FIGURE 1 \
Experimental Arrangement for Determining Trit ium Oxide Collection Efficiency . . I. .
To Vacuum . .
I FIGURE 2
. . . . . .
Air Intake
I I Modifications of Experimental Arrangement for Determining Tritium Oxide Collection Efficiency
' Time - ~ a ~ s
FIGURE 4
Typical Air contamination. Levels at the PRTR
top related