breville customer service centres.productreview.com.au/products/manuals/216503_5656544a6b6c9.… ·...

www.breville.com.au

Breville is a registered trademark of Breville Pty. Ltd. A.B.N. 98 000 092 928. Copyright Breville Pty. Ltd. 2012.

Due to continued product improvement, the products illustrated/photographed in this brochure may vary slightly from the actual product.

BJS600 Issue - A12

Australian Customers

Mail: PO Box 22 Botany NSW 2019 AUSTRALIA

Phone: 1300 139 798

Fax: (02) 9384 9601

Email: Customer Service: [email protected]

New Zealand Customers

Mail: Private Bag 94411 Botany Manukau 2163 Auckland NEW ZEALAND

Phone: 0800 273 845

Fax: 0800 288 513

Email: Customer Service: [email protected]

Breville Customer Service Centre

BJS600

the Juice Fountain™ CrushInstruction Booklet

CONGRATULATIONSon the purchase of your Breville Product

3

CONTENTS

4 Breville recommends safety first

6 Know your Breville product

8 Assembling your Breville product

12 Operating your Breville product

15 Disassembling your Breville product

17 Care & cleaning

19 Troubleshooting

23 Recipes

4

BREvILLE RECOMMENdS SAFETy FIRST

At Breville we are very safety conscious. We design and manufacture consumer products with the safety of you, our valued customer, foremost in mind. In addition we ask that you exercise a degree of care when using any electrical appliance and adhere to the following precautions.

REAd ALL INSTRUCTIONS BEFORE USE ANd SAvE FOR FUTURE REFERENCE• Carefully read all instructions before

operating the appliance for the first time and save for future reference.

• Remove and safely discard any packaging materials and promotional labels before using the appliance for the first time.

• To eliminate a choking hazard for young children, remove and safely discard the protective cover fitted to the power plug of this appliance.

• To protect against electrical shock, do not immerse the power cord, power plug or motor base in water or any other liquid.

• Always use the appliance on a dry, level surface.

• Do not use the appliance on a sink drain board.

• Do not place the appliance near the edge of a bench or table during operation. Vibration during operation may cause the appliance to move.

• Do not place the appliance on or near a hot gas or electric burner, or where it could touch any other source of heat.

• Unwind the power cord fully before use.• Do not allow the power cord to hang

over the edge of a table or counter, touch hot surfaces or become knotted.

• Always ensure the appliance is completely assembled before connecting to the power outlet and operating. The appliance will not turn on unless properly assembled. Follow the instructions provided in this book.

• Always avoid contact with moving parts.• Strictly follow the care and cleaning

instructions described in this book.• This appliance is for household use only.

Do not use the appliance for anything other than its intended purpose as described in this book. Do not use outdoors. Do not use in moving vehicles or boats.

• The use of attachments not sold or recommended by Breville may cause fire, electric shock or injury.

• Do not leave the appliance unattended when in use.

• Do not operate the juice extractor without the pulp and juice container in place.

• Do not use the juice extractor if the juicing screw is damaged.

• Do not push produce into the feed chute with your fingers. Always use the food pusher provided.

• Do not juice stone fruit unless seeds and/or stones have been removed.

• Always switch the juice extractor off after each use. Ensure the motor stops completely and unplug the power cord from the wall outlet before attempting to move the appliance, before cleaning, disassembling, assembling and when storing the appliance.

• Do not operate the machine longer than 20 seconds before inserting ingredients.

IMPORTANT SAFEGUARdS

5

BREvILLE RECOMMENdS SAFETy FIRST

5

IMPORTANT SAFEGUARdS FOR ALL ELECTRICAL APPLIANCES• Fully unwind the power cord before use.• Do not let the power cord hang over

the edge of a bench or table, touch hot surfaces or become knotted.

• To protect against electric shock do not immerse the power cord, power plug or appliance in water or any other liquid.

• The appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety.

• Children should be supervised to ensure that they do not play with the appliance.

• It is recommended to regularly inspect the appliance. To avoid a hazard do not use the appliance if power cord, power plug or appliance becomes damaged in any way. Return the entire appliance to the nearest authorised Breville Service Centre for examination and/or repair.

• Any maintenance other than cleaning should be performed at an authorised Breville Service Centre.

• This appliance is for household use only.• Do not use this appliance for anything

other than its intended use. Do not use in moving vehicles or boats. Do not use outdoors. Misuse may cause injury.

• The installation of a residual current device (safety switch) is recommended to provide additional safety protection when using electrical appliances. It is advisable that a safety switch with a rated residual operating current not exceeding 30mA be installed in the electrical circuit supplying the appliance. See your electrician for professional advice. SAvE THESE

INSTRUCTIONS

KNOWyour Breville Product

7

KNOW yOUR BREvILLE PROdUCT

A. Food PusherB. Hopper And LidC. Juicing ScrewD. Filter BasketE. Scraper WiperF. Pulp Container

B

A

G. Motor BaseH. Juicing JugI. ON | OFF | REVERSEJ. Juicing BowlK. Filter Cleaning Brush

J

I

G

C. D. K.E.

F

H

ASSEMBLINGyour Breville Product

9

ASSEMBLING yOUR BREvILLE PROdUCT

BEFORE FIRST USEBefore using the juice extractor for the first time, remove and safely discard any packaging material and promotional labels. Ensure the power cord is unplugged from the wall outlet. Wipe the motor base with a damp cloth. Dry thoroughly.Wash the juicing bowl, filter basket, juicer cover, food pusher, juice jug and pulp container in warm soapy water with a soft cloth or nylon brush. Rinse and dry thoroughly.

NOTE

These parts are not dishwasher safe.

1. Place the motor base on a flat dry surface such as a counter-top. Ensure the power cord is unplugged from the wall outlet.

2. Underneath the filter bowl is the pulp extraction silicon, which is used to remove the pulp from the spout of the juicing bowl. Ensure that the silicon is firmly inserted into the juicing spout.

3. Place the juicing bowl on top of the motor base. Align the arrows to the ALIGN position then turn slightly clockwise to the ALIGN/LOCK (closed) position.

4. Assemble the filter basket into the scraper wiper then place this assembly in to the juicing bowl.

5. Note that the orange dot on the filter needs to align with the orange dot on the juicing bowl and motor base. Ensure that the filter basket is completely pushed down.

10

8. Ensure that the hopper is placed on the feed chute. Place the food pusher into the hopper.

9. Place the pulp container supplied into position by tilting slightly and placing under the pulp spout.

NOTE

To minimize clean up, place a produce bag into the pulp container to collect the pulp.


6. Place the juicing screw into the filter basket. Ensure that the juicing screw is in position by pressing down on it, and feel it click into place.

7. Place the lid on to the juicing bowl. Align the orange dot on the lid with the orange dot on the motor base and turn clockwise to the closed position. The lid will click into position.

11


10. Place the juice jug under the juicer spout; ensure that it is placed in position under the spout.

OPERATINGyour Breville Product

13

6. With the motor running gently guide food down the feed chute. To extract the maximum amount of juice, always push the food pusher down slowly.

NOTE

Do not exert excess pressure, the fruit or vegetable should almost be pulled down by the screw.

NOTE

If the fruit or vegetables become jammed in the screw and the juicer stops operating press the OFF button to the center. Ensure that the juicer comes to a complete stop. Press the REVERSE button and hold it until the fruit or vegetables become dislodged.

NOTE

The screw will move in reverse and release the food that is caught in the screw. Once the food is released, press the ON button and start juicing again.

IMPORTANTDo not load the feed chute with food until the motor is running.

OPERATING yOUR BREvILLE PROdUCT

OPERATING THE BREvILLE JUICE FOUNTAIN CRUSH™

1. Wash and prepare your selection of fruit and/or vegetables: Fruits with hard or inedible skins such as citrus fruit and melons should be peeled before juicing. Pineapple can be juiced with or without the rind removed. Fruits with pits, hard seeds or stones such as nectarines, peaches, mangoes, apricots, plums and cherries must be pitted before juicing.

2. Ensure the juice extractor is correctly assembled with the juice jug and pulp container is under the spout.

NOTE

As a safety precaution, the juicer will not operate if it has not been assembled correctly.

3. Plug the power cord into a 230/240V power outlet.

4. Cut fruit and vegetables into pieces that will fit down the feed chute.

NOTE

As a guide, apples should be cut in to quarters.

5. Push the ON button.

7. As the fruits and vegetables are processed, juice will flow into the juice jug and the separated pulp will accumulate in the pulp container.

NOTE

The pulp container can be emptied during juicing by turning the juicer to the off position and removing the pulp container. Replace the empty pulp container into position before continuing to juice.

WARNINGDo not operate juicer longer than 20 seconds before inserting ingredients.

8. Immediately after use, slowly pour a glass of water down the feed chute. Ensure that there is a separate jug under the spout as the water will pour directly into the juice jug that you juiced into. This is a cleaning aspect and will help when cleaning the filter basket.

NOTE

If you are making different fruit juices you can pour a glass of water (about 6oz) in between the different juices to rinse any left over flavors. It is not always necessary to completely clean the juicer in between making multiple juices.

OvERLOAd PROTECTIONThis protection device safeguards against overloading the motor with excessive loads.If overloading occurs, the motor will stop. The overload protection will automatically de-activate the motor. When this occurs, unplug the power cord from the wall outlet and allow the appliance to cool for at least 1 hour. Then reconnect the power cord to the wall outlet. Then recommence normal use.

OPERATING yOUR BREvILLE PROdUCT

14

15

PAGE HEAdER

dISASSEMBLINGyour Breville Product

dISASSEMBLING yOUR BREvILLE PROdUCT

1. Ensure the juicer is turned off and the power cord is unplugged from the power outlet.

2. Remove the pulp container and juicing jug.

3. Remove the lid by turning it to the open position (anti-clockwise).

4. The juice bowl, scraper wiper, filter basket and juicing screw can all be removed together. Grip the juice bowl and turn to the open position (anti-clockwise) slightly, it will click out of position. This is a very small movement. The juicing bowl and all the internals can now be lifted off the motor base for cleaning.

WARNINGThe juicing screw is a heavy object. Take care when removing the juicing screw. Be careful not to drop the juicing screw.

16

PAGE HEAdER

CARE & CLEANING

18

CARE & CLEANING

Always ensure that the juicer is turned off and the power cord is unplugged from the power outlet before cleaning, disassembling or assembling and storing the appliance.

1. Immediately after each use, use the provided nylon brush to thoroughly clean the fine mesh holes of the filter basket. Brush the inside of the filter basket under running water, holding it up towards the light to ensure the fine mesh holes are not blocked.

2. Use the filter brush provided with the juicer. This brush has been specially designed to clean the filter basket. Simply place the filter basket inside the brush and under running water twist the brush left and right to remove the pulp from the filter basket. You will need to use the small brush provided to clean the inside of the filter basket, this should also be done under running water.

If the holes are blocked, soak the filter basket in hot water with 10% lemon juice to loosen the blocked holes.

TIP

If the filter basket cannot be cleaned immediately after use, soak the filter basket in hot soapy water immediately after juicing is complete. If pulp is left to dry on the filter basket, it may clog the fine mesh holes, thereby lessening the effectiveness of the juicer. Do not soak the filter basket in bleach.

3. Wash the juice bowl, scraper wiper, juicing screw, pulp container and juicing jug in warm soapy water with the small nylon brush provided or a soft cloth. Rinse and dry thoroughly.

NOTE

Do not place any part of the juicer in the dishwasher.

TIP

Discoloration of the plastic parts may occur with brightly colored fruit and vegetables. To help prevent this, wash parts immediately after use. If discoloration does occur, the plastic parts can be soaked in 10% lemon juice and water or they can be cleaned with a non abrasive cleaner. Do not soak the filter basket in bleach. Do not soak the motor base.

4. Wipe the motor base with a soft damp cloth and dry thoroughly. Do not use abrasive scouring pads or cleaners when cleaning the motor base as these may scratch the surface. Wipe any excess food particles from the power cord.

PAGE HEAdER

TROUBLESHOOTING

20

TROUBLESHOOTING

POSSIBLE PROBLEM EASy SOLUTION

Juicer will not work or suddenly turns off during juicing

• Check that the power plug is securely inserted into wall outlet.

• Insert the power plug into an independent outlet.

• Insert the power plug into a different outlet.

• Ensure the juicer is assembled correctly.

• The Overload Protection may have automatically de-activated the motor. Unplug the power cord from the wall outlet and allow the appliance to cool for at least 1 hour. Insufficient cooling time may result in the motor de-activating again. After sufficient cooling time, reconnect the power cord to the wall outlet and recommence normal use.

Motor appears to stall when juicing

• Either too much food is being processed at one time or the pieces are not small enough. Try trimming food, cutting food into smaller pieces of even size and/or processing a smaller amount per batch.

• Ensure the motor is running before loading the feed chute with food. Also try the reversing method to unstuck the screw.

• Hard fruits and vegetables will put excess strain onto the motor.

Reduced juice extraction

• Stop the juicing process and remove the power cord from the wall outlet. Use the nylon brush provided to thoroughly clean the fine mesh holes of the Filter Basket. Brush the inside of the Filter Basket under running water, holding it up towards a light to ensure the fine mesh holes are not blocked. If the holes are blocked, soak the Filter Basket in hot water with 10% lemon juice to loosen the blocked holes. Cleaning the Filter Basket will remove excess fiber build up (from juicing the fruit or vegetables) which could be inhibiting the juice flow.

PAge heAder

21

TROUBLESHOOTING

POSSIBLE PROBLEM EASy SOLUTION

Pulp too wet and reduced extracted juice

• Try a slower juicing action.

• Remove juice disc and thoroughly clean mesh walls with a cleaning brush. Rinse the juice disc under hot water. If the fine mesh holes are blocked, soak the basket in a solution of hot water with 10% lemon juice to unblock the holes or wash in the dishwasher. This will remove excess fibre build up (from fruit or vegetables) which could be inhibiting the juice flow.

Juice leaks between the rim of the Juicer Cover

• Try a slower juicing speed and push the food pusher down the feed chute more slowly.

22

PAge heAderTROUBLESHOOTING

PREPARATION OF FRUIT ANd vEGETABLES FOR JUICING• If using fruits with hard or inedible skins

such as mangoes, citrus, melons and pineapples, always peel before juicing.

• Some vegetables, such as cucumbers, can be processed un-peeled depending on the softness of the skin and the juicing requirements.

• All fruits with large pits, hard seeds or stones such as nectarines, peaches, mangoes, apricots, plums and cherries must be pitted before juicing.

• Ensure vegetables such as beetroots, carrots etc have all soil removed, are washed well and trimmed of leaves before juicing.

• Citrus fruits can be juiced in the juicer but remove the skin and excess pith before juicing.

• A small amount of lemon juice can be added to apple juice to reduce discoloration.

PURCHASING ANd STORAGE OF FRUIT ANd vEGETABLES• Always wash fruit and vegetables

before juicing.• Always use fresh fruit and vegetables

for juicing.• To save money and obtain fresher

produce, purchase fruit or vegetables that are in season.

• Keep your fruit and vegetables ready for juicing by washing them before storing.

• Most fruits and hardier type vegetables can be stored at room temperature. The more delicate and perishable items such as berries, leafy greens, celery, cucumbers and herbs should be stored in the refrigerator until required.

RECIPES

24

PAge heAderRECIPES

ORANGE, BROCCOLI & CARROTServes 2

INGREdIENTS3 oranges (750g), peeled and segmented2 cups (150g) broccoli florets and stems2-3 medium carrots(280g), cut into quarters

Process through juicer and serve.

POMEGRANATE, BEETROOT & ORANGEServes 2

INGREdIENTS1 pomegranate (360g), skin and white pith removedOr 1 ¼ cups pomegranate seeds1 medium (230g) beet, scrubbed and cut into pieces3 oranges (750g), peeled and segmented


BEETROOT, ORANGE & GINGERServes 2

INGREdIENTS1 medium (230g) beet, scrubbed and cut into pieces3 oranges (750g), peeled and segmented1 inch (2cm) piece of fresh ginger


CARROT, CELERy, PEAR & BEETROOTServes 2

INGREdIENTS2-3 medium (280g) carrots, cut into quarters1 trimmed (100g) celery stalk1 medium (230g) pear, cut into quarters1 medium (230g) beetroot, scrubbed and cut into pieces


TOMATO, CELERy & CARROTServes 2

INGREdIENTS1 pint (250g) cherry tomatoes or 3 small tomatoes1 trimmed (100g) celery stalk2-3 medium (280g) carrots, cut into quarters


GRAPES, PEAR & CUCUMBERServes 2

INGREdIENTS2 cups (184g) grapes1 large (330g) pear, cut into quarters1 (160g) Lebanese cucumber, quartered


25

PAge heAderRECIPES

PINEAPPLE, MINT & APPLEServes 2

INGREdIENTS1 ¾ cup (300g) pineapple, skin removed, roughly chopped2-3 sprigs mint2 medium (300g) green apples, cut into pieces


CUCUMBER, CARROT, LEMON & MINTServes 2

INGREdIENTS2 (320g) Lebanese cucumbers, quartered2-3 medium (280g) carrots, cut into quarters½ lemon, skin and white pith removed2-3 sprigs mint


CARROT, APPLE & BEETROOTServes 2

INGREdIENTS2-3 medium (280g) carrots, cut into quarters2 medium (300g) green apples, cut into pieces1 small (100g) beet, scrubbed and cut into pieces


CARROT, CELERy, PARSLEy & GINGERServes 2

INGREdIENTS3 medium (360g) carrots, cut into quarters2 trimmed (200g) celery stalks2-3 sprigs flat leaf parsley1 inch (2cm) piece ginger


TOMATO, CARROT & REd BELL PEPPER Serves 2

INGREdIENTS1 small (150g) red bell pepper, trimmed, seeds removed1 pint (250g) cherry tomatoes or 3 small tomatoes3 medium (360g) carrots, cut into quarters2-3 sprigs flat leaf parsley


SWEET POTATO, CELERy, GINGER & ORANGE Serves 2

INGREdIENTS½ (300g) sweet potato, peeled and roughly chopped1 trimmed (100g) celery stalk1 inch (2cm) piece fresh ginger3 oranges (750g), peeled and segmented


26

RECIPES

TOMATO, CUCUMBER, PARSLEy ANd CARROT Serves 2

INGREdIENTS1 pint (250g) cherry tomatoes or 3 small tomatoes1 (160g) Lebanese cucumber, quartered2-3 sprigs flat leaf parsley2-3 medium (280g) carrots, cut into quarters


SWISS CHARd, KIWI + APPLEServes 2

INGREdIENTS3-4 Swiss Chard leaves, ribs removed3 medium (255g) kiwi fruit, peeled, cut into quarters1 medium (150g) green apple, cut into pieces

CARROTS, BEETROOT, ORANGE + PEARServes 2

INGREdIENTS2-3 medium (280g) carrots, cut into quarters1 medium (230g) beetroot, scrubbed and cut into pieces1 medium (240g) orange, peeled and segmented1 medium (230g) pear, cut into quarters


CELERy, TOMATO, CILANTRO, GREEN BELL PEPPER + GARLICServes 2

INGREdIENTS4 trimmed (400g) celery stalks2 medium (300g) tomatoes, roughly chopped2 sprigs cilantro1 medium (200g) green bell pepper, trimmed, seeds removed1 clove garlic , peeled


BROCCOLI, PARSLEy, APPLE ANd CELERyServes 2

INGREdIENTS6 cups (450g) broccoli florets and stems3-4 sprigs flat leaf parsley2 medium (300g) green apples, cut into pieces1 trimmed (100g) celery stalk


27

RECIPES

ORANGE, GRAPEFRUIT + PAPAyAServes 2

INGREdIENTS2 medium (480g) oranges, peeled and segmented1 small (350g) grapefruit, peeled and segmented1 small (650g) papaya, seeds and skin removed, roughly chopped


HONEydEW, APPLE + MINTServes 2

INGREdIENTS¼ large (400g) honeydew melon, skin and seeds removed, roughly chopped1 medium (150g) green apple, cut into pieces2 sprigs mint


ORANGE ANd BANANA ICE BLOCKS

INGREdIENTS3 oranges (750g), peeled and segmented 2 medium (400g) ripe bananas

METHOd

1. Add bananas into slow juicer followed by oranges.

2. Stir juice to combine. Pour into ice cube tray mold and freeze until frozen.

WATERMELON + HONEy ICE BLOCKS

INGREdIENTS1 large 2.25lb (1kg) watermelon, skin removed, roughly chopped 1 tablespoon honey

METHOd

1. Add watermelon into slow juicer.2. Stir juice and honey to combine. Pour

into ice cube tray mold and freeze until frozen.

28

GRAPE ICE BLOCKS

INGREdIENTS6 L cup (600g) red grapes, stem removed

METHOd

1. Add grapes to slow juicer.2. Stir juice and cream together. Pour

into ice cube tray mold and freeze until frozen.

BLUEBERRy ICE CREAMMakes approximately 800ml

INGREdIENTS3 ¾ cups (600g) fresh or frozen blueberries 1 tablespoon honey

¼ cup (60ml) condensed milk

½ cup (125ml) cream

¼ cup (60ml) milk

METHOd

1. Add grapes to slow juicer. If using frozen blueberries, thaw first.

2. Stir juice, condensed, cream and milk together.

3. Churn in an automatic ice cream maker until frozen.

RECIPES

HONEydEW MELON MILK ICEMakes approximately 1 quart

INGREdIENTS¼ large (400g) honeydew melon, skin and seeds removed, roughly chopped

¼ cup (60ml) condensed milk

¾ cup (185ml) cream

METHOd

1. Add honeydew to slow juicer. 2. Stir juice, condensed milk and cream

and together.3. Churn in an automatic ice cream maker

until frozen.

PINEAPPLE ANd MINT SORBETMakes approx 750ml

INGREdIENTS1 cup (250ml) water

1 cup (200g) granulated sugar

1 medium (1.25kg) pineapple, skin removed, roughly chopped

1 tablespoon finely shredded mint

METHOd

1. Place the water and sugar in a small saucepan. Stir over a low heat until the sugar dissolves. Bring to a boil and cook for 2 minutes. Remove from heat. Refrigerate until cold.

2. Add pineapple to slow juicer.3. Combine the sugar syrup, 2 ½ cups

pineapple juice and shredded mint and stir to combine.


29

RECIPES

GREEN APPLE GELATOMakes approx 1 quart

INGREdIENTS3 small green apples

½ lemon, skin and white pith removed

1 cup (250ml) water

1 cup (200g) granulated sugar 2⁄3 cup (160ml) cream

Green food coloring (optional)

METHOd

1. Add apples and lemon to slow juicer.2. Place the water, sugar, apple and lemon

juice in a small saucepan. Stir over a low heat until the sugar dissolves. Bring to a boil and cook for 2 minutes. Remove from heat.

3. Strain mixture through a fine sieve. Refrigerate until cold.

4. Combine apple mixture and cream and stir to combine.


30

NOTES

31

NOTES

breville customer service centres.productreview.com.au/products/manuals/216503_5656544a6b6c9.… ·...

Documents