chapter 9 schematic diagrams, overlays, and parts...

9-1

Chapter 9 Schematic Diagrams, Overlays, and Parts Lists

9.1 IntroductionThis chapter provides schematic diagrams, overlays, and parts lists for the radio circuit boards and interface connections.

9.1.1 Notes For All Schematics and Circuit Boards* Component is frequency sensitive. Refer to the Electrical Parts List for value and usage.

1. Unless otherwise stated, resistances are in Ohms (k = 1000), and capacitances are in pico-farads (pF) or microfarads (µF).

2. DC voltages are measured from point indicated to chassis ground using a Motorola DC multi-meter or equivalent. Transmitter measurements should be made with a 1.2 µH choke in series with the voltage probe to prevent circuit loading.

3. Reference Designators are assigned in the following manner:- 100 Series = Transmitter- 200 Series = Frequency Generation- 300 Series = Receiver- 400/500 Series = Controller and Low-Band Receiver Front End- 600 Series = Keypad Board

4. Interconnect Tie Point Legend:- UNSWB+ = Unswitched Battery Voltage (7.5 V)- SWB+ = Switched Battery Voltage (7.5 V)- R5 = Receiver Five Volts- CLK = Clock- Vdda = Regulated 3.3 Volts (for analog)- Vddd = Regulated 3.3 Volts (for digital)- CSX = Chip Select Line (not for LVZIF)- SYN = Synthesizer- DACRX = Digital to Analog Voltage (For Receiver Front End Filter)- VSF = Voltage Super Filtered (5 V)- VR = Voltage Regulator

9-2 Schematic Diagrams, Overlays, and Parts Lists: Flex Layout

9.2 Flex Layout

Figure 9-1. Keypad-Controller Interconnect Flex

LAYER 1 (L1)LAYER 2 (L2)LAYER 3 (L3)LAYER 4 (L4)LAYER 5 (L5)LAYER 6 (L6)

INNER LAYERS

SIDE 1

SIDE 2

6-LAYER CIRCUIT

COPPER STEPS IN PROPER LAYER SEQUENCE

BOARD DETAIL VIEWING

98C

J200

40

J100

40 <- TO KP

8480475Z02 REV A TO CTRL ->

Front MetalView from Top side

Schematic Diagrams, Overlays, and Parts Lists: Flex Layout 9-3

9.2.1 Keypad-Controller Interconnect Flex Schematic

Figure 9-2. Keypad-Controller Interconnect Flex Schematic Diagram

9.2.2 Keypad-Controller Interconnect Flex Parts List

Reference Symbol

Motorola Part No. Description

J100 0980521Z01 Connector, 40 pinJ200 0905505Y04 Speaker, 20 ohm

KEYPADJ100

EXT_MIC

VS_CS

SW_B+

Vddd

VS_AUDSEL

Det_Aud_Snd

Rx_Aud_Rtn

Tx_Aud_Snd

Tx_Aud_Rtn

Flat_Tx_Rtn

Opt_Bd_En

Rdy/Req

Rx_Aud_Snd

ON

INT_EXT_Vdd

Key_Row

Key_Col

PTT

KEY_INT

VS_INT

RESET

LED_EN

OFF_BATT_DATA_OUT

VS_GAINSEL

SrD_Rtn (MISO)

SrD_Snd (DATA)

R_W

LCD_SEL

DB0

DB1

DB2

DB3

DB4

DB5

DB6

DB7

A0

SCK_Snd (CLK)

VS_RAC

Gnd

40

39

38

37

36

35

34

33

32

31

30

29

28

27

26

25

24

23

22

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

CONTROLLERJ200

40

39

38

37

36

35

34

33

32

31

30

29

28

27

26

25

24

23

22

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

EXT_MIC

VS_CS

SW_B+

Vddd

VS_AUDSEL

Det_Aud_Snd

Rx_Aud_Rtn

Tx_Aud_Snd

Tx_Aud_Rtn

Flat_Tx_Rtn

Opt_Bd_En

Rdy/Req

Rx_Aud_Snd

ON

INT_EXT_Vdd

Key_Row

Key_Col

PTT

KEY_INT

VS_INT

RESET

LED_EN

OFF_BATT_DATA_OUT

VS_GAINSEL

SrD_Rtn (MISO)

SrD_Snd (DATA)

R_W

LCD_SEL

DB0

DB1

DB2

DB3

DB4

DB5

DB6

DB7

A0

SCK_Snd (CLK)

VS_RAC

Gnd

FL0830765O

9-4 Schematic Diagrams, Overlays, and Parts Lists: Flex Layout

9.2.3 Universal Flex Connector

Figure 9-3. Universal Flex Connector

Front MetalView From Top Side

20J403

J404J405

J406J407

J408J409J410

J411J412

J413J414

J415J416M

40

1

FL

08

30

76

7O

VIE

WE

D F

RO

M S

IDE

1

Back MetalView From Top Side

c

98

8480549Z03 rev B

C4

02

M4

00

FL0830768O

Schematic Diagrams, Overlays, and Parts Lists: Flex Layout 9-5

9.2.4 Universal Connector Flex Schematic

Figure 9-4. Universal Flex Connector Schematic Diagram

9.2.5 Universal Flex Connector Parts List

Reference Symbol


C402 2113740A55 Cap, 100pFM400 5085962A02 Speaker, 20 ohmM401 5013920A04 Microphone for 5000 and 7000 SeriesM401 5005227J08 Microphone for 9000 Series

8480549Z01 Flex, Speaker Microphone

13 PIN UNIVERSAL CONN

EXT_SPKR+

EXT_SPK-

OPT_B+

EXT_MIC

OPT_SEL_2

OPT_SEL_1

GND

RX_DATA

TX_DATA

J404

J405

J406

J407

J408

J409

J410

J411

J412

SPKR_20

SPKR_20

OPT_B+30

RSSI

RX_AUDIO/TX_AUDIO

BOOT_CTRL

NC

J413

J414

J415

J416

1

2

C402100pF

M401

GND

INT_SPK+

INT_SPK-

EXT_SPKR+

EXT_SPK-

DPT_B+

EXT_MIC

OPT_SEL_2

OPT_SEL_1

GND

RX_DATA

TX_DATA

GND

RSSI

RX_AUDIO/TX_AUDIO

BOOT_CTRL

NC

MIC

GND

GND

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

J40320 PIN CONN

M400SPKR_20

SPKR_20

9-6 Schematic Diagrams, Overlays, and Parts Lists: Keypad Top and Bottom Overlays

9.3 Keypad Top and Bottom Overlays

Figure 9-5. Keypad Top and Bottom Board Overlays

Top View

Bottom View

D601 D602

D603

D604 D605

D606

M604 M605 M606

M607M608

M609

M610 M611 M612

M613 M614 M615

M616 M617 M618

VIEWED FROM SIDE 1

M619 M620 M621

FL0830719O

C612 C613

2J601

40

39

C61

0

R63

7

R632

C611 C61

5R622

R63

3

R64

6

U60

2

C60

9

R61

1

R61

2

R61

3

R62

5R

630

R62

8

R63

9R

641

R64

3R

645

R63

8R

640

R64

2R

644

R60

1

R63

1

R61

8

R64

9

J602

18

C61

4R626R60

2

R60

3

R60

4

R60

5

R60

7

R60

8R

609

R61

0

R620

R61

4R

615

R61

6

R61

7

R627

R629

R63

4

C61

6

Q601Q602

Q603

R61

9

R64

8

R64

7

R606

R62

1

VIEWED FROM SIDE 2

FL0830720A

Keypad Circuit Board/Schematic Diagrams and Parts List 9-7

9.4 Keypad Circuit Board/Schematic Diagrams and Parts List

Figure 9-6. Keypad Board (5000 and 7000 Series) Schematic Diagram

J601-11

J601-14

J601-22

J601-20

J601-23

J601-28

J601-32

J601-35

J601-38

R6191K

R6201K1K

R618

79U01D601

79U01D605D604

79U01

1KR623

1KR621 R622

1K

79U01D602 D606

79U0179U01D603

47KR649

PNPQ601

R628

R_WNU

A0

LCD_SEL

R629

R6270

NU

100pF

C616

R633100K

Q602NPN

100KR646 R648

100K

3KR647

Q603NPN

R625

R630

DATA

CLK

NU

NU

J602-7

J602-13

J602-15J602-16

J602-18J602-17

J602-2J602-3J602-4J602-5J602-6

J602-1

J602-14

J602-11J602-10

J602-12

J602-8J602-9

0R626

0R631

C614

Vddd

SWB+NU

RESET

100pFC622

100KR632

51pFC644

51pFC642

100pFC645

100pFC650

100pFC651

100pFC652

100pFC653

100pFC654

100pFC655

100pFC643

E645

E644

51pFC640

51pFC638

51pFC636

100pFC641

100pFC639

100pFC637

E643

E642

C634

C632

51pF

51pF

100pF

C635

100pF

C633

E639

E640

E641

100pF

C631

E638

51pFC630

DATA

RESET

100pF

C615

C613100pF

KEYPAD_COL

100pF

C612

C611100pF

KEYPAD_ROW

C621100pF

C620100pF

C610100pF

E637

100pFC619

Vddd

VS_INT

VS_GAINSEL

EXT_MIC

R_WLCD_SEL

FLAT_TX_RTN

RX_AUD_RTNTX_AUD_SNDTX_AUD_RTN

OPT_ENARDY

URX_SNDON

INT_EXT_Vdd

PTTKEY_INT

OFF_BATT_DATA_OUT

MISO

VS_CSSWB+

VS_AUDSELFLAT_RX_SND

C617100pFC618

NU

J601-13

J601-39

J601-36J601-37

J601-1

J601-40

J601-33J601-34

J601-4

J601-6J601-5

J601-7

J601-9J601-10

J601-29J601-30J601-31

J601-8

J601-16J601-17J601-18

J601-3

J601-26J601-25

J601-2CLK

VS_RAC

C64751pF

C646100pF

E634

A0

51KR601

13KR603

R60251K

KEYPAD_COL

Vddd

KEYPAD_ROW43KR605

130KR606

130KR610

R604

R60943K

22K

R60822K13K

R607

ROW2

COL2 COL3

ROW3 ROW4

COL5

ROW5

C609

R612560K 1MEG

R613

R61151K

4

31

2

5

U602LMC7211

Vddd

KEY_INT

Vddd

NU

KEYPAD_COL COL2

IN4

OUT11

OUT22

M619SWITCH

GND3*

M616

GND3

IN4

OUT11

OUT22

SWITCH

7

GND3

IN4

OUT11

OUT22

M613SWITCH

4

GND3

IN4

OUT11

OUT22

SWITCHM610

1

GND3

IN4

OUT11

OUT22

M607SWITCH

P1GND3

IN4

OUT11

OUT22

SWITCHM608

P2

4

OUT11

OUT22

M611SWITCH

GND3

IN

2

GND3

IN4

OUT11

OUT22

SWITCHM614

5

GND3

IN4

OUT11

OUT22

M617SWITCH

8

M620

GND3

IN4

OUT11

OUT22

SWITCH

COL3

0 OUT22

SWITCHM621

GND3

IN4

OUT11

ROW5

#

M618

GND3

IN4

OUT11

OUT22

SWITCH

ROW4

9

GND3

IN4

OUT11

OUT22

M615SWITCH

ROW3

6

1

OUT22

M612

GND3

IN4

OUT1SWITCH

ROW2

3

GND3

IN4

OUT11

OUT22

M609SWITCH

KEYPAD_ROW

P3

OUT22

SWITCHM606

GND3

IN4

OUT11

ROW5

+GND3

IN4

OUT11

OUT22

M605SWITCH

ROW4

0R614

0

GND3

IN4

OUT11

OUT22

R617

SWITCHM604

R615

R616

OFF_BATT_DATA_OUT

ROW3

COL5

ON

-NU

NU

EXT_MICVS_CSSW_B+VdddVS_AUDSELDet_Aud_SndRx_Aud_RtnTx_Aud_SndTx_Aud_RtnFlat_Tx_RtnOpt_Bd_EnRdy/ReqRx_Aud_SndONINT_EXT_VddKey_RowKey_ColPTTKey_IntrpVS_INTRST*LED_ENOFF_BATT_DATA_OUTVS_GAINSELSrD_RtnSrD_SndR/W*CS*DB0DB1DB2DB3DB4DB5DB6DB7A0SCK_SndVS_RACGnd

40 PIN CONNECTOR

MOSISCKD0D1D2D3D4D5D6D7A0R/W*RST*CS*LED_ENGndVdddSW_B+

J60218 PIN CONNECTOR

J601-27

J601-24

J601-21

J601-19

J601-15

J601-12

ZMY0130090-B

9-8 Keypad Circuit Board/Schematic Diagrams and Parts List

Keypad Board Parts List (5000 and 7000 Series)

Circuit Ref. Motorola Part No. Description

B501 0986237A02 Battery Contact Module

B503 3980502Z01 Backup battery B+ B504 3980501Z01 Backup battery B- C610 2113743N50 100 pFC613 2113743N50 100 pFC615 2113743N50 100 pFC616 2113743N50 100 pFD601 4880479U01 79U01D602 4880479U01 79U01D603 4880479U01 79U01D604 4880479U01 79U01D605 4880479U01 79U01D606 4880479U01 79U01J601 0980521Z01 44 pin connectorJ602 0905505Y03 18 pin connectorQ601 4805128M67 MMBT3906

transistor (PNP)Q602 4880214G02 MMBT3904

transistor (NPN)Q603 4880214G02 MMBT3904

transistor (NPN)R601 0662057V20 51K R602 0662057V20 51K R603 0662057V05 13K R604 0662057V11 22K R605 0662057V18 43K R606 0662057V30 130K R607 0662057V05 13K R608 0662057V11 22K R609 0662057V18 43K R610 0662057V30 130K R611 0662057N16 51K R612 0662057N41 560K R613 0662057N47 1M R614 0662057M01 0 ohm R617 0662057M01 0 ohm R618 0662057M74 1K R619 0662057M74 1K R620 0662057M74 1K R621 0662057M74 1K R622 0662057M74 1K R623 0662057M74 1K R626 0662057M01 0 ohm R627 0662057M01 0 ohm R631 0662057M01 0 ohm R632 0662057N23 100K R633 0662057N23 100K R634 0662057M01 0 ohmR637 0662057M01 0 ohmR638 0662057M01 0 ohmR639 0662057M01 0 ohmR640 0662057M01 0 ohmR641 0662057M01 0 ohm

R642 0662057M01 0 ohmR643 0662057M01 0 ohmR644 0662057M01 0 ohmR645 0662057M01 0 ohmR646 0662057N23 100KR647 0662057M85 3KR648 0662057N23 100KR649 0662057N15 47KU602 5102463J49 LMC7211

comparator

Circuit Ref. Motorola Part No. Description


Figure 9-7. 9000 Series Keypad Top and Bottom Board Overlays

D602

M601 M602

D601

M604 M605

VIEWED FROM SIDE 1

M607M608

D604

M610 M611

M613 M614

D603

M616 M617

M619 M620

D607

M618

M621

D608

M612

M615

D605

M606

M609

D606

M603

ZMY0130334-O

Q60

6

R643

Q60

5R

624

R641

R62

6

Q604

Q60

7

R644

Q60

8

R647

R622R623

R62

8

R62

5

U60

2

39

C60

3

C605

C60

6

C607

C60

2

Q60

3R

601

J601

C60

4

R60

5

40 2

Q60

1Q

602

R602

R603

C601

R63

0

R63

2

E613

E61

4

E61

6

E61

8 E62

0

R60

6

R62

7

E60

9

J602

18 1

R60

7

R60

8

R61

0

R61

2

E61

5

E61

7E

619

E62

1

R629

R633

R63

4

R631

VIEWED FROM SIDE 2

ZMY0130335-O


Figure 9-8. 9000 Series Keypad Board Schematic Diagram

J601-11

CLK

DATA0

R607

R6080

E609

R_WRESET

R6060

A0

LCD_SEL

Vdd

R60110K

Q603

LED_Enable

R602

R6032.2K

5.1KQ604

C601100pF

Q602

Q601

47R643

47R647R644

4747R641 R622

51K

KEYPAD_ROW

Vdd

13KR626

100pFC604

51KR624

R62713K 22K

R630

R62922K

ROW3ROW2

R63143K

43KR632

R633130K

130KR634

ROW5ROW4

COL5COL4COL3C605100pF

LMC7211U602

Vdd

COL2

4

31

2

5

560KR625

R62351K

Vdd

R6281MEG

KEY_INT

Q605

D605

D601

79U01

79U01

Q606

D60679U01 79U01

D607

D60379U0179U01

D602

Q607 Q608

79U01D608

79U01D604

D7

D5

D6

D4

E621

E620

E618

E619

A0

VS_RAC

CLK

J601-20J601-19

J601-9J601-10

J601-33

J601-24

J601-14

J601-16J601-15

J601-17J601-18

J601-28

J601-30J601-29

J601-32J601-31

J601-13

J601-38

J601-34

J601-1J601-2

J601-25

J601-39J601-40

J601-35

J601-23

J601-26J601-27

J601-36J601-37

J601-3

J601-5J601-4

J601-6

J601-8J601-7

J601-22J601-21

0R605LCD_SEL

TX_AUD_RTNTX_AUD_SNDRX_AUD_RTN

FLAT_RX_SNDVS_AUDSEL

R_WDATAMISO

OFFLED_Enable

RESET

KEY_INTPTT

KEYPAD_COLKEYPAD_ROW

INT_EXT_VddON

URX_SNDRDY

OPT_ENA

VS_GAINSEL

VS_INT

FLAT_TX_RTN

E614

E616

E617

E615

D0

D3

D2

D1

C603100pF

1uFC602

1000pFC607

C606100pF

SWB+ VddEXT_MIC

SWB+VS_CS

R6120

E613D0

D7D6D5D4D3D2D1

J602-12

J602-15J602-16

J602-10J602-9

J602-5J602-6

J602-17J602-18

J602-11

J602-14J602-13

J602-1J602-2J602-3J602-4

J602-7J602-8

0R610

SWB+

Vdd

J602-20J602-19

SWB+

KEYPAD_COL

NOSISCKD0D1D2D3D4D5D6D7A0R/W*RST*CS*LED_ENGndVddSW_B+

J60218PINS CONNECTOR

EXT_MICVS_CSSW_B+VddVS_AUDSELRx_Aud_SndRx_Aud_RtnTx_Aud_SndTx_Aud_RtnFlat_Tx_RtnOpt_Bd_EnRdy/ReqDet_Aud_SndON_OFF_1INT_EXT_VddKey_RowKey_ColPTTKey_IntrpVS_INTRST*LED_ENOFFVS_GAINSELSrD_RtnSrD_SndR/W*CS*DB0DB1DB2DB3DB4DB5DB6DB7A0SCK_SndVS_RACGnd

40 PINS CONNECTOR

KEYPAD_COL COL2

M619SWITCH

GND3

IN4

OUT11

OUT22

GND3

IN4

OUT11

OUT22

SWITCHM620

* 0

GND3

IN4

OUT11

OUT22

M613SWITCH

OUT22

SWITCHM614

GND3

IN4

OUT11

GND3

IN4

OUT11

OUT22

IN4

OUT11

OUT22

SWITCHM616 M617

SWITCH

GND3

4 5

87

OUT22

GND3

IN4

OUT11SWITCHM610

OUT22

M607SWITCH

GND3

IN4

OUT11

GND3

IN4

OUT11

OUT22

SWITCHM608

GND3

IN4

OUT11

OUT22

M611SWITCH

P1 P2

1 2

GND3

IN4

OUT11

OUT22

SWITCHM602

GND3

IN4

OUT11

OUT22

IN4

OUT11

OUT22

SWITCHM604 M605

SWITCH

GND3

GND3

IN4

OUT11

OUT22

M601SWITCH

ROW4

ROW4ROW3

ROW3

-

M606

GND3

IN4

OUT11

OUT22

3

IN4

OUT11

OUT22

SWITCH

M603SWITCH

GND

ROW5

ROW5

+

GND3

IN4

OUT11

OUT22

M609SWITCH

SWITCHM612

GND3

IN4

OUT11

OUT22

ROW3

ROW2

KEYPAD_ROW

P3

3

M615SWITCH

GND3

IN4

OUT11

OUT22

OUT22

SWITCHM618

GND3

IN4

OUT11

ROW4

6

9

IN4

OUT11

OUT22

M621SWITCH

GND3

ROW5

COL3

#

COL5

COL4

J601-12

ZMY0130333-O


Keypad Board Parts List (9000 Series)

Circuit Ref Motorola Part No. Description

B501 0986237A02 Battery Contact Module

B503 3980502Z01 Backup battery B+ B504 3980501Z01 Backup battery B- C601 2113743N50 100 pFC602 2311049A86 1 uFC603 2113743N50 100 pFC604 2113743N50 100 pFC605 2113743N50 100 pFC606 2113743N50 100 pFC607 2113743L17 1000 pFC608 2113743N50 100 pFC609 2113743N50 100 pFC610 2113743N50 100 pFC611 2113743N50 100 pFC612 2113743N50 100 pFC613 2113743N50 100 pFD601 4880479U01 LEDD602 4880479U01 LEDD603 4880479U01 LEDD604 4880479U01 LEDD605 4880479U01 LEDD606 4880479U01 LEDD607 4880479U01 LEDD608 4880479U01 LEDE609 2480640Z01 IND BEADE613 2480640Z01 IND BEADE614 2480640Z01 IND BEADE615 2480640Z01 IND BEADE616 2480640Z01 IND BEADE617 2480640Z01 IND BEADE618 2480640Z01 IND BEADE619 2480640Z01 IND BEADE620 2480640Z01 IND BEADE621 2480640Z01 IND BEADJ601 0980521Z01 44 pin connectorJ602 0905505Y03 18 pin connectorQ601 4813824A10 40V.2A NPN

TRANSISTORQ602 4813824A10 40V.2A NPN

TRANSISTORQ603 4813824A17 40V.2A PNP






TRANSISTORR601 0662057M98 10 KR602 0662057A66 51K

R603 0662057M82 2.2K R605 0662057M01 0 ohm R610 0662057M01 0 ohm R622 0662057V20 51KR623 0662057N16 51K R624 0662057V20 51KR625 0662057N41 560KR626 0662057V05 13K R627 0662057V05 13K R628 0662057N47 1.0MEGR629 0662057V11 22KR630 0662057V11 22KR631 0662057V18 43K R632 0662057V18 43K R633 0662057V30 130K R634 0662057V30 130KR641 0662057M42 47KR643 0662057M42 47KR644 0662057M42 47KR647 0662057M42 47KU602 5102463J49 LMC7211

comparator8480574Z05 PC Board, Keypad

Circuit Ref Motorola Part No. Description


Notes

Controller Circuit Board/Schematic Diagrams and Parts List 9-13

9.5 Controller Circuit Board/Schematic Diagrams and Parts List

Figure 9-9. VHF/UHF Complete Controller Schematic Diagram

INTERFACE

RESET

RX_AUD_RTN

R_W

SWB+

TX_AUD_RTNTX_AUD_SND

URX_SND

VS_AUDSEL

VS_CS

VS_GAINSEL

VS_INT

VS_RAC

Vddd

D6D7

DATA

EXT_MIC

FLAT_RX_SND

FLAT_TX_RTN

INT_EXT_Vdd

KEYPAD_COLKEYPAD_ROW

KEY_INT

LCD_SEL

LEDBL

MISO

OFF_BATT_DATA_OUT

OPT_ENA

PTT

RDY

A0CLK

D0D1D2D3D4D5

Vddd

FLAT_TX_RTN

VS_GAINSEL

DATA

OFF_BATT_DATA_OUT

MISO

VS_RACCLK

EXT_MIC

LCD_SELR_W

SWB+

VS_AUDSEL

VS_CS

FLAT_RX_SND

TX_AUD_SND

OPT_ENA

RX_AUD_RTN

TX_AUD_RTN

RDY

KEYPAD_ROW

URX_SND

INT_EXT_Vdd

KEYPAD_COL

KEY_INT

RESET

PTT

VS_INT

LEDBL

ON

A17

A2A3A4A5A6A7A8A9

A0A1

A10A11A12A13A14A15A16

D7

D0D1D2D3D4D5D6

FLA

SH

_EN

FLA

SH

_OE

RA

M_C

S

R_W

Vdd

d

XA

18

MEMORY

Vdd

d

FLA

SH

_OE

RA

M_C

S

FLA

SH

_EN

R_W

XA

18

LVZIF_SEL

VS_CS

LCD_SEL

VS_CS

Vddd

XA18

RAM_CS

R_W

FLASH_EN

FLASH_OE

LCD_SEL

LVZIF_SEL

A9

D0D1D2D3D4D5D6D7

A1

A10A11A12A13A14A15A16A17

A2A3A4A5A6A7A8

A0

SQ

_DE

T

SW

B+

SY

N

UN

SW

B+

VO

X

RE

SE

T

F12

00

HS

IO

LSIO

MIS

O

BA

TT

_DA

TA

_IN

CH

AC

T

CLK

CS

X

DA

TA

EE

_CS

SCI_RX

SCI_TX

VOL

VS_RAC

OPT_ENA

OPT_SEL1

OPT_SEL2

RDY

RSSI

RTA0

RTA1

RTA2

RTA3

SB1

SB2

SB3

KEYPAD_COL

KEYPAD_ROW

LI_ION

MECH_SWB+

OFF_BATT_DATA_OUT

BOOT_CTRL

VS

_IN

T

PT

T

EM

ER

KE

Y_I

NT

LOC

K

KE

Y_I

NT

PT

T

EM

ER

VS

_IN

T

LOC

K

RTA3

SB3

SB2

OFF_BATT_DATA_OUT

VOL

MECH_SWB+

VS_RAC

KEYPAD_COL

KEYPAD_ROW

OPT_ENA

RDY

LI_ION

RTA1

RTA0

RTA2

SB1MICRO_P

5VVdda

RESETBATT_CODE

LI_ION

LOCK

4V_3.3V

CSXMODIN

DATACLK

UNSWB+DEMOD

RSSI16.8MHz

RTA2RTA3

MECH_SWB+VOLPTT

LVZIF_SELSWB+

DACRx

RED_LEDGREEN_LED

SB1SB2SB3

EMERRTA0RTA1

IF_Vdda_CTRL

IF_LVZIF_SEL_CTRL

IF_16.8MHz_CTRL

IF_EMER_CTRL

IF_CSX_CTRL

IF_LI_ION_CTRL

IF_SB3_CTRL

IF_RESET_CTRL

IF_DATA_CTRL

IF_5V_CTRL

IF_BATT_CODE_CTRL

IF_SWB+_CTRL

IF_GREEN_LED_CTRL

IF_SB2_CTRL

IF_VOL_CTRL

IF_4V_3.3V_CTRL

IF_CLK_CTRL

IF_UNSWB+_CTRLIF_LOCK_CTRL

IF_PTT_CTRL

IF_MECHSWB+_CTRL

IF_RTA1_CTRL

IF_RED_LED_CTRL

IF_RTA3_CTRL

IF_MODIN_CTRL

IF_DACRX_CTRL

IF_RTA2_CTRL

IF_SB1_CTRL

IF_RTA0_CTRL

IF_DEMOD_CTRLIF_RSSI_CTRL

16.8MHz

5VVddaRESETBATT_CODELI_ION

LOCK

4V_3.3V

DACRxCSXMODINDATACLK

UNSWB+DEMODRSSI

RTA2RTA3MECH_SWB+VOLPTTLVZIF_SELSWB+

RED_LEDGREEN_LEDSB1SB2SB3EMERRTA0RTA1

TO/FROM RF

C432NU

NUR403

Vdda VdddSWB+

RESET

UNSWB+

MISO

DATA

CSX

CLK

VS_AUDSEL

VS_GAINSEL

Vddd

DEMOD

DACRX

4V_3.3V

VS_AUDSEL

VS_GAINSEL

Vdda

Vddd

LSIO

ME

CH

_SW

B+

MIS

O

MO

DIN

OF

F_B

AT

T_D

AT

A_O

UT

RE

D_L

ED

RE

SE

T

RX

_AU

D_R

TN

SQ

_DE

T

SW

B+

SY

N

TX

_AU

D_R

TN

TX

_AU

D_S

ND

UN

SW

B+

UR

X_S

ND

VO

X

CLK

CS

X

DACRX

DA

TA

DEMOD

EE

_CS

EXT_MIC

EXT_SPKR_SEL

F12

00

FLAT_RX_SND

FLA

T_T

X_R

TN

GR

EE

N_L

ED

HS

IO

INT

_EX

T_V

dd

INT_MIC

LED

BL

16.8

MH

z

4V_3.3V

5V

AUDIO

AUDIO_PA_ENA

BA

TT

_CO

DE

BA

TT

_DA

TA

_IN

CH

AC

T

16.8

MH

z

RE

D_L

ED

RX

_AU

D_R

TN

TX

_AU

D_R

TN

TX

_AU

D_S

ND

UR

X_S

ND

OF

F_B

AT

T_D

AT

A_O

UT

MO

DIN

ME

CH

_SW

B+

LED

BL

INT

_EX

T_V

dd

GR

EE

N_L

ED

FLA

T_T

X_R

TN

BA

TT

_CO

DE

ASFIC

Vdd

a

FLA

T_R

X_S

ND

EX

T_M

IC

5V

RS

SI

BO

OT

_CT

RL

OP

T_S

EL1

OP

T_S

EL2

RS

SI

SC

I_R

X

SC

I_T

X

AU

DIO

_PA

_EN

A

EX

T_M

IC

EX

T_S

PK

R_S

EL

FLA

T_R

X_S

ND

INT

_MIC

SW

B+

UN

SW

B+

Vdd

a

5V

AU

DIO

AUDIO_PA

MEMORY SHIELD

SH400SHIELD

1

ON/OFF SHIELD

SH401SHIELD

1

MICROPIC SHIELD

SH402SHIELD

1

ASFIC/AUDIO PA SHIELD

1

SH403SHIELD

FL0830734O

9-14 Controller Circuit Board/Schematic Diagrams and Parts List

Figure 9-10. VHF/UHF Controller ASFIC/ON_OFF Schematic Diagram

0.1uFC428

12

4

3

6

75

U407X25320_2.7V

MISO

8

WP

CLKCS

HOLDSI

SO

VCC

VSS

4K x 8 BITEEPROM

100pF

C427

R42910K

EE_CS

5V

R4130

47KR400

C4220.1uF

0.1uF

C421Vdda

.01uF

C420

SQ

DE

T

GN

DS

YN

HS

IO

LCA

P

LSIO

GC

B0

GC

B1

GC

B2

CLK

CS

X

DA

TA

CH

AC

T17 2319 2418151413 2120 2216

VOX

UIO

VDDA

VDDDAC

PLCAPSQIN

GNDA

DACGDACRDACU

DISC

AGCCAP

7

10

1

11

89

3

654

2

12

U404

VDDSYN

TXRTN

VDDCPVDDD

NCPLCAP2

SYN

GNDDGNDD0

F1200

GCB3CLK168

VD

DR

CT

XS

ND

UR

XO

UT

MIC

INT

MO

D

GN

DR

CM

ICE

XT

GC

B4

GC

B5

AU

DIO

AU

XR

XA

UX

TX

45 44 3946 404748 37384143 42

TX

_AU

D_S

ND

MO

DIN

AU

DIO

FLA

T_T

X_R

TN

LED

BL

270KR448

220KR446C480

10uF

R4471.5MEG

MECH_SWB+

CR440

1

23

39KR416

13

2

Q403

Q405

2

4

1 3

C402

0.1uF

C40310uF

3

1

2

Q400

75KR406

UNSWB+

2.7KR427

5

3

1

2

4

CR412

BATT_CODEVddd

27

36

3233

2625

28

313029

3534

C4160.1uF

SYN

F1200

TX_AUD_RTN

16.8MHzRED_LED

C419NU

DA

TA

CLK

CS

X

CH

AC

TS

Q_D

ET

LSIO

HS

IO

EX

T_S

PK

R_S

EL

AU

DIO

_PA

_EN

AG

RE

EN

_LE

D

Vddd

BATT_DATA_IN

OFF_BATT_DATA_OUT

R476

24K

OUTPUT

SENSESHUTDOWNVTAP

ERRORFEEDBACK

GN

D

INPUT

LP2951ACMM-3.3U400

4

1

26

5378

C400.01uF

4V_3.3V

NUR402

0R405

SWB+

Vddd

INT

_MIC

EX

T_M

IC

68K

R407

TP406

C4010.1uF

0R401

INT_EXT_Vdd

0.1uFC410

TP410 C408

100pF 0.1uFC409

0R475

Vdda

RESET

C4110.1uF

DEMOD

24KR449

C47930K

0.1uF

R425

0.1uFC407

R44524K

Vdda

URX_SND

RX_AUD_RTN

VOXVS_AUDSELVS_GAINSEL

DACRx

FLAT_RX_SND

C4300.1uF

.01uF

C415

4.7uF

C452

0.1uF

C414 C451

.022uF

FL0830735O

Freq. Range Board Number

403-470 MHz 8480450Z03

450-527 MHz 8485641Z02

136-174 MHz 8486062B098486062B12


Figure 9-11. VHF/UHF Controller ASFIC/ON_OFF Schematic Diagram

INT_

MIC

EX

T_M

IC

TP4101

R4750

Vdda

C4100.1uF

C408100pF 0.1uF

C409

TX_A

UD

_SN

D

MO

DIN

AU

DIO

FLA

T_TX

_RTN

LED

BL

C4110.1uF

VDDDAC

VD

DR

C

VDDSYN

VOX

SQIN SYN

TXRTNTXS

ND

UIO

VDDA

VDDCPVDDD

MO

D

NC

PLCAP

PLCAP2

RX

RTN

RX

SN

D

SQCAP

SQ

DE

T

GNDDO

GN

DR

C

GN

DS

YN

HS

IO

LCA

P

LSIO

MIC

EX

T

MIC

INT

GC

B0

GC

B1

GC

B2

GCB3

GC

B4

GC

B5

GNDA

GNDD

CLK168

CS

X

DACGDACRDACU

DA

TADISC

F1200

AU

DIO

AU

XTN

CH

AC

T

CLK

U40463A53

11

45

27

7

9 28

36

44

10

1

3233

40

26

8

25

43 39

12

17

30

47

2319 2418

48 46151413

35

37383

31

34

20

654

222

29

4142

16 21

0R413

C420.01uF

0.1uFC416

R40047K

C4220.1uF

C4210.1uF

SYNF1200

Vdda

0.1uFC479

R42530K

0.1uFC407

24KR449

R44524K

URX_SND

RX_AUD_RTN

Vdda

DEMOD

FLAT_RX_SND

VOXVS_AUDSELVS_GAINSEL

DACRx

C4300.1uF

C4150.1uF .022uF

C4510.1uFC414 C452

1uF

DA

TAC

LKC

SX

CH

AC

TS

Q_D

ET

LSIO

HS

IO

EX

T_S

PK

R_S

EL

AU

DIO

_PA

_EN

AG

RE

EN

_LE

D

.01uFC41916.8MHz

RED_LEDTX_AUD_RTN

5V

Vddd

0.1uFC428C427

100pF

R42910K

EE_CS

31

7

6

5

U407X25128-2.7

WPCS

HOLD

SCK

SI

SO

VC

CV

SS

4

2

8

MISO4Kx8 BITEEPROM

4V_3.3V

R402NU

R4050

SWB+

Vddd

C4010.1uF

68KR407

R4010

INT_EXT_Vdd

TP4061

C400.01uF

R476330K

SENSESHUTDOWNVTAP

ERRORFEEDBACK

4G

ND

INPUT OUTPUT

LP2951ACMM-3.3U400

236

578 1 2.2uF

C403C4020.1uF

RESET

MECH_SWB+

R44810K

R452100K

C48010uF

R453

1.5MEGR447

NU

R45115K

R455NU

R454NU

R45603

2

1

Q403CR440

1

23

Q400

3

1

2

75KR406

UNSWB+BATT_CODE

1 3

Q405

2

4

10KR416

OFF_BATT_DATA_OUT

K21 K3

CR412

4A15A26A3

3 K12

2.7KR427

BATT_DATA_IN

Vddd

ZMY0130544-B


403-470 MHz 8480450Z138480587Z05

450-527 MHz 8485641Z068485677Z03

136-174 MHz 8486062B168486062B178486101B11


Figure 9-12. VHF/UHF Controller Microprocessor Schematic Diagram

PH1_PW2PH2_PW3PH3_PW4PH4_CSIOPH5_CSGP1PH6_CSGP2PH7_CSPROG

PG1_XA14PG2_XA15PG3_XA16PG4_XA17PG5_XA18PG6_AS

PH0_PW1

PG0_XA13

PC0_DATA0PC1_DATA1PC2_DATA2PC3_DATA3PC4_DATA4PC5_DATA5PC6_DATA6PC7_DATA7

VS

SR

VS

S

VS

SL

PI1

PI2

PI3

PI4

PI5

PI6

PI7

PI0

PF

2_A

DD

R2

PF

3_A

DD

R3

PF

4_A

DD

R4

PF

5_A

DD

R5

PF

6_A

DD

R6

PF

7_A

DD

R7

PF

O_A

DD

R0

PF

1_A

DD

R1

PB

1_A

DD

R9

PB

2_A

DD

R10

PB

3_A

DD

R11

PB

4_A

DD

R12

PB

5_A

DD

R13

PB

6_A

DD

R14

PB

7_A

DD

R15

PB

O_A

DD

R8

AV

SS

XIRQ

PJ1_CSGP4PJ2PJ3PJ4PJ5PJ6PJ7

RESET

PJ0_CSGP3

PG7_R_W

PE1_AN1PE2_AN2PE3_AN3PE4_AN4PE5_AN5PE6_AN6PE7_AN7

PE0_AN0

ECLKIRQ

MODA_LIRMODB_VSTBY

XF

C

XT

AL

VD

D

VD

DL

VD

DR

VD

DS

YN

VR

HV

RL

PD

0_R

XD

PD

1_T

XD

PD

2_M

ISO

PD

3_M

OS

IP

D4_

SC

KP

D5_

SS

PD

6_LV

IN

PA

0_IC

3P

A1_

IC2

PA

2_IC

1P

A3_

IC4_

OC

5_O

C1

PA

4_O

C4_

OC

1P

A5_

OC

3_O

C1

PA

6_O

C2_

OC

1P

A7_

PA

1_O

C1

AV

DD

EX

TA

L

LVO

UT

U409

4894

4

8996

5857 VST

72737475767778

71 CSGP3CSGP4

66656463626160

67

8713 4055545352515049 56 7010119211587 14272625242322 2928

3031323334353637

46454443424138

47

1620191718

5

6

979899100

123 7980818283848586 9391 1292696890 95 3988 59

C431

100pF 100pF

C449 C453

100pF

C423

100pF

R41110K 100pF

C456

KEY_INT

RESET

R_W

RTA0

RTA2RTA3SB1SB2SB3OFF_BATT_DATA_OUT

RTA1

VS_RACVOL

RSSIVOXKEYPAD_COLKEYPAD_ROW

EMER

OPT_SEL1OPT_ENA

LOCKVS_INT

PTT

C43622pF

GND

INO

UT

2

13

FL401XTAL

22pFC437

330KR426

R42010MEG

A4A3A2A1

A17A16A15A14A13A12A11A10

A9A8A7A6A5

A0

D7

D0D1D2D3D4D5D6

LVZIF_SEL

LCD_SEL

VS_CS

RAM_CSFLASH_EN

XA18BATT_DATA_IN

CLKCSX

EE_CS

OPT_SEL2

390nHL410

390nHL411

R437NU

HS

IO

DA

TA

FLA

SH

_OE

SY

N

RD

Y

LSIO

SQ

_DE

TC

HA

CT

MIS

O

R4180

TP402TP401

SCI_RXSCI_TX

F1200Vddd

10KR409R457

10K

Vddd Vddd

LOW BATT

91KR415

1%

180KR414

1%

.01uFC433

TP415

Vddd

Mech_SWB+

RT40033.0K

51KR432

UNSWB+ SWB+

6

4

1

3

2

3

5 1

2

4

CR413R463300

Q417

TP405

BOOT_CTRL

LI_ION

510R419

10KR462

5

3

1

2

4

1

23

Q416

CR411

C4350.1uF 4.7K180

R461 R4600.1uFC434

2

1V

SS

VIN VOUT 3

ILC7062CM-33

U410

3.3V

UNSWB+Vddd

FL0830736O

Controller Board -- Mic


403-470 MHz 8480450Z03

450-527 MHz 8485641Z02

136-174 MHz 8486062B098486062B12


Figure 9-13. VHF/UHF Controller Microprocessor Schematic Diagram

Vddd F1200

10KR409

10KR457

SCI_RXSCI_TX

1TEST_POINTTP402

0R4181

DA

TA

TEST_POINTTP401

FLA

SH

_OE

MIS

O

SY

N

RD

Y

LSIO

HS

IOS

Q_D

ET

CH

AC

T

LCD_SEL

CLK

LVZIF_SEL

VS_CS

XA18BATT_DATA_IN

OPT_SEL2

RAM_CSFLASH_EN

CSXEE_CS

A2A3A4A5A6A7

A14A15A16A17

D1D2D3D4D5D6D7

A0A1

A8A9

A10A11A12A13

D0

VdddUNSWB+

0.1uFC435

4.7KR460R461

180

VS

S1

U410ILC7062CM-33

VIN2

VOUT3

C4340.1uF

3.3V

510R419

5A2 6A3

3K1

2 K21K3

CR411

4A1

3

1

2

Q416

4A1

5A26A3

3K1

2K2 1K3

CR413

LI_ION

R46210K

R463300

UNSWB+

Q417

SWB+

TP405TEST_POINT

1

BOOT_CTRL

2

1

3

6

4

47K

4.7K

10K

47K

OPT_SEL1OPT_ENA

EMER

LOCKVS_INT

PTT

22pFC436

22pFC437

10MEGR420

R426330K

FL401

GND2

IN1

OU

T3

XTAL

33.0KRT400

R43251K

Vddd

Mech_SWB+

VS_RACVOL

RSSIVOXKEYPAD_COLKEYPAD_ROW

SB3OFF_BATT_DATA_OUT

RTA1RTA0

RTA2RTA3SB1SB2

RESETR_W

KEY_INT

TEST_POINT1

TP415R41591K1Z

.01uFC433

R414180K1ZLOW BATT

M400

L410390nH

R437NU

L411390nH

91 69689899100

123 97 80818283848586 9079 9392

454443424138

201917185

4746

616

31323334

30

353637

545352515049 56552625242322 292827 119211587 1410

48

737475767778

94

7172

4

8996

5857

66656463626160

67

13 4087 70

VST

CSGP3CSGP4

Vddd Vddd

100pFC453

100pFC449

100pFC431 C423

100pF

10KR411 C456

100pF

39881295 59

U409MC68HC11FL0

PH1_PW2PH2_PW3PH3_PW4PH4_CSIOPH5_CSGP1PH6_CSGP2PH7_CSPROG

PG1_XA14PG2_XA15PG3_XA16PG4_XA17PG5_XA18PG6_AS

PH0_PW1

PG0_XA13

PD

3_M

OS

IP

D4_

SC

KP

D5_

SS

PD

6_LV

IN

PC0_DATA0PC1_DATA1PC2_DATA2

PD

0_R

XD

PD

1_T

XD

PD

2_M

ISO

PA

0_IC

3P

A1_

IC2

PA

2_IC

1P

A3_

IC4_

OC

5_O

C1

PA

4_O

C4_

OC

1P

A5_

OC

3_O

C1

PA

6_O

C2_

OC

1P

A7_

PA

1_O

C1

XT

AL

VR

HV

RL

EX

TA

L

XF

CV

DD

SY

N

LVO

UT

VD

D

VD

DL

VD

DR

AV

DD

ECLK

XIRQRESET

PG7_R_W

IRQ

MODA_LIRMODB_VSTBY

PJ1_CSGP4PJ0_CSGP3

PJ2PJ3PJ4PJ5PJ6PJ7

PE2_AN2PE3_AN3PE4_AN4PE5_AN5PE6_AN6PE7_AN7

PE0_AN0PE1_AN1

VS

SR

VS

S

VS

SL

AV

SS

PI1

PI2

PI3

PI4

PI5

PI6

PI7

PI0

PB

1_A

DD

R9

PB

2_A

DD

R10

PB

3_A

DD

R11

PB

4_A

DD

R12

PB

5_A

DD

R13

PB

6_A

DD

R14

PB

7_A

DD

R15

PB

O_A

DD

R8

PF

2_A

DD

R2

PF

3_A

DD

R3

PF

4_A

DD

R4

PF

5_A

DD

R5

PF

6_A

DD

R6

PF

7_A

DD

R7

PF

O_A

DD

R0

PF

1_A

DD

R1

PC3_DATA3PC4_DATA4PC5_DATA5PC6_DATA6PC7_DATA7

ZMY0130541-A


403-470 MHz 8480450Z138480587Z05

450-527 MHz 8485641Z068485677Z03

136-174 MHz 8486062B168486062B178486101B11


Figure 9-14. Controller Memory Schematic Diagram

26 1817161514133 1931112451110 20

A11

A10A

9A

8A

7A

6A

5A

4A

3A

2A

1A

0

A14

A17

A16

A15

A13

A12

A9

A17

A2

A3

A4

A5

A6

A7

A8

A1

A10

A11

A12

A13

A14

A15

A16

A0

D7

NC

D0

D1

D2

D3

D4

D5

D6

FLASH ROM

24

GND

XA

18

D0

D1

D2

D3

D4

D5

D6

D7

299 21222325262728

EN

_CE

EN

_OE

EN

_WE V

CC

FLA

SH

_EN

U406

8

303270

R492

NU

R408

XA

18

C429

0.1uF

100KR

410

FLA

SH

_OE

2.2R

428

C424

10uF

VSS14

WE

OE

CS

27 22 20

D0

D1

D2

D3

D4

D5

D6

D7

D2

D3

D4

D5

D6

D7

D8

D1

RA

M

12131516171819 11

A4

A5

A6

A7

A8

A9

A1

A10

A11

A12

A13

A14

A2

A3

A0

VDD 28U

405

65432524 921232261 87 10A

0A

1A

2A

3A

4A

5A

6A

7A

8A

9A

10A

11A

12A

13A

14

RA

M_C

S

C425

0.1uF100pFC

426

Vddd

R478

10K

Vddd

R_W

Issue:R

evision Detail:

Release D

ate:

ILLUS

TRA

TOR

RE

GIO

ND

AT

E

Application :

ME

DIA

& C

OM

MU

NIC

AT

ION

S D

EP

T.

DW

G. N

O.

ED

ITOR

DA

TE

Adobe Illustrator 7.0

WA

RIS

CO

NV

. MD

C U

HF

PC

B 8480450Z

03

Ram

esh R.

23/07/1998

LN C

han

FL0830737

FL0830737O

OPenang

23/07/199823/07/1998

Penang

Controller B

oard -- Mem

ory


Figure 9-15. Controller Audio Power Amplifier Schematic Diagram

J403-2

J403-1

J403-3

J403-12

J403-19

J403-16

J403-18

J403-13

J403-8

J403-9

J403-15

J403-14

J403-17

J403-20

J403-7

J403-5

J403-6

J403-4

J403-10

J403-11

GND

INT_SPK+

INT_SPK-

EXT_SPK+

EXT_SPK-

OPT_B+

EXT_MIC

OPT_SEL_2

OPT_SEL_1

GND

RX_DATA

TX_DATA

GND

RSSI

RX_AUDIO/TX_AUDIO

BOOT_CTRL

NC

MIC

GND

GND

VR44510.0V 10.0V

VR446 VR44710.0V 10.0V

VR448 VR44910.0V

J40320 PIN CONNECTOR

68R450

C471100pF

C472100pF

C473100pF

SWB+

OPT_SEL2OPT_SEL1

VR4346.8V

100pFC493

100pFC490

100pFC492

100pFC491

5.6VVR433

C497100pF

100pFC496

C495100pF

C494100pF

5.6VVR432

FLAT_RX_SND

SCI_RX

SCI_TX

RSSI

BOOT_CTRL

C441100pF

L400390nH

R4212K

INT_MIC

2KR435

C444*100pF

R4360

C4404.7uF

R4771K

100pFC445

390nHL401C443

0.1uF

EXT_MIC

C4420.1uF

10R473

10uFC475 UNSWB+

AUDIO

0.1uFC447

3.6KR472

0.1uFC448

36KR424

R431470K

VCC1 VCC2

OUT1NEGOUT1POS

OUT2NEGOUT2POS

SELECT

SVR

IN1NEGIN1POS

IN2NEGIN2POS

MODENC2NC3NC4NC5

NC1

GN

D1

GN

D2

6

5

1716

1415

4

R42347K

U420TDA854720 11

791219

183

138

2

1

10

10uFC476

SWB+

R4715.6K

Q41046

1 32AUDIO_PA_ENA EXT_SPKR_SEL

Vdda

R434330 Ohm

5V

0.1uFC450

VR45010.0V

* NOTE: FOR VHF RADIOS, C444 HAS A VALUE OF 4.7uF.

FL0830721O


Figure 9-16. Controller Interface Schematic Diagram

MISO

VS_RAC

D7

D4D5

D3

D6

D2D1D0

Vddd

R_W

RESET

LCD_SEL

LEDBL

KEY_INT

INT_EXT_Vdd

VS_INT

VS_AUDSEL

VS_GAINSEL

FLAT_RX_SNDRX_AUD_RTN

URX_SND

TX_AUD_SND

PTT

SWB+

KEYPAD_ROWKEYPAD_COL

A0

OFF_BATT_DATA_OUT

OPT_ENA

DATA

RDY

FLAT_TX_RTNTX_AUD_RTN

VS_CSEXT_MIC

CLK

J400-23

J400-2

J400-5

J400-20

J400-14

J400-26

J400-17

J400-35J400-34J400-33J400-32J400-31

J400-13

J400-15

J400-4

J400-9

J400-18

J400-11

J400-40

J400-25

J400-39

J400-28

J400-21

J400-27

J400-37J400-36

J400-30J400-29

J400-22

J400-3

J400-19

J400-8

J400-12

J400-6

J400-24

J400-1

J400-38

J400-10

J400-16

J400-7

EXT_MICVS_CSSW_B+VdddVS_AUDSEL

Det_Aud_SndRx_Aud_RtnTx_Aud_SndTx_Aud_RtnFlat_Tx_RtnOpt_Bd_En

Rdy/ReqRx_Aud_SndONINT_EXT_VddKey_RowKey_ColPTTKey_IntrpVS_INTRST*LED_ENOFF_BATT_DATA_OUTVS_GAINSELSrD_RtnSrD_Snd

R/W*CS*DB0DB1DB2DB3DB4DB5DB6DB7A0

SCK_SndVS_RACGnd

E406E405

E403E402

E401

E404

E409E408

E407

C463100pF

0.1uFC481

0.1uFC482

0.1uFC467

E400

R48124K

100pF

100pF

C458

C466

100pFC459

J40040-PINS CONNECTOR

FL0830738O

UHF Band 1 Circuit Board/Schematic Diagrams and Parts List (PCB 8480450Z03) 9-21

9.6 UHF Band 1 Circuit Board/Schematic Diagrams and Parts List (PCB 8480450Z03)

L400R

421

TP405

VR

434VR450 C

R41

3

Q41

7

1

1

TP406

J403

20

22

C441

C491

C492

C490

C493

C494

C495

C496

C497

R477

R450

21

1

C471

C472

C473

L401

TP410

VR

447

VR

449

C443

40

R435

TP401

TP402 C427

C444

C428

RT400

8

5 4

1

U407

J400

C42

3 E407

E40

8

E409

R41

8

R437

R410

SH400

8 21

U405

1

1

7 22

C426 C425

C429

C424

R408R49

2

R42

9

R478

R428

1 16

U406

1732

PB503

3

1 2

FL201B503

C43

2

SH201

TP201

C220

C22

9C

217

C228 L201

L203

C260

C29

4

C23

5

C29

1L2

02

U247

C203

Q210

3145

R256

R255

C21

0

C211C21

2

C213

C21

4

C23

0

C292 C23

3

C238

C29

7

L232Q26

0 34

C257

CR

201

C251

C28

9

C253

Q2613

1

4

5

R26

0SH241C247

C28

5

C248

C28

6

L282

Q241

R24

3

R248

R25

3

C273

3

L243

VIEWED FROM SIDE 1

C37

0

C27

6

C27

1

C27

2

L273

3

L253 L271

C37

4

C38

6

L321

R33

3

R33

9

C12

2

C12

5

C16

5

C161

C12

9C16

9

L114

L115

L113

R16

1

9 16

C109C11

0

C11

4

C166

C111

C112

C11

3

C131

L106

L107

3

2

Q110C119

C171

L108

R103

R10

4

R12

0

R17

1

R173

U101

8 1

C11

8

C121

C160

C115

C117

C116

C12

0

C127

L109L160

R10

6

R10

7R108

SH101

TP202

TP302

C37

5

C32

0

C31

9

L309

R348

T302

3

1

4

6

C38

1

C322

L310

R30

9

R308

R310

SH303

T301

3

1

4

6

C32

4

C32

3

L311

C325

FL301 R35

1

R352SH323

B504

C397

PB504

R300

VR

444

C328

C39

1

R32

6

R314

R31

6

R325

R33

4

R335

R338

RT301

VR

300

Q315

Q316

R318

R31

9

R32

7

RT

300

C33

1

C396

C333

CR

308

R317

R336

R34

2

C10

4

C10

3

C106

C107

CR

102

L102

L104

SH100

C10

1

C102

CR101

L101

L105

C140

C141

L116

C520

PB505

VR443

C30

2

C301

CR

301

L301

C30

8

C30

3

C304

C30

5

CR

302L302

R301

R302

SH301

C512

C384

C385

C36

4

C351

C349C350

C352C353

C35

4

L325

Q320R355

R32

2

R34

5

R32

0

R32

4

R34

6

C362C363

CR310

L332

R321

SH321

C521

PB501

VR440

C50

5

C50

2

R50

7

VR501

Q505

R506

C513Q502

R505

C51

1

C51

4

CR503

21

3 4

R50

2

R501

PB502

TP415

C40

1

C40

0

CR412 Q40

0R401

R40

2

R40

3

R405

R40

6R407

R427

R476U400

85

C402C467

C403

CR

440

Q405

3

3

4

4

5

5

R41

6 R481 R44

6

4 1

C48

2

C48

0

Q403

R44

7

R44

8

SH401

FL0830739O

Figure 9-17. UHF (403-470 MHz) 5000/7000 Series Main Board Top Side PCB 8480450Z03

9-22 UHF Band 1 Circuit Board/Schematic Diagrams and Parts List (PCB 8480450Z03)

C108

J101

4

3

2

J102

R101

2

S501

C

8

C

4

CR

303

L303

SH302

C307

R340

R328

C309R303

R304

C315

C321

C310

C314 C306

C311

R347

R305 C313

C318

C380

C316 C317

C312

CR304 CR305

R306

R307

C395L340

L306

L307

L305L304

Q301

C337

C347

C348C356C

339

C340

C341

C342

C343

C383

C390

C346

C357C358

R344

C345

C334

C359

SH322

1325

37 1

U301

C329

C336

C360

C355

C361

L314

C344

C382

L331

R343

R350

C327

C330

C326

C338

L330

Q302

R315

R313

R311

R312

C503

CR306

F501SH304

C123E101

R329

VR

439

C130

C138

C151

C170

C126

C128

C150

C152

L11

2

R1

02

C105

C174

C133

C135

C134

CR105 R109R130

R131

R132

25

917

U102

1

C295

C378

CR241L281L

242

R11

0R

112

R11

1

R349

C281

C372 C371

C373

Q310

R330

R332

R245

R331

C255

C252C254

CR

251

L251

R251 R

252

R254

U241

10

201

11

C241

C246

C242

C243

C250

C244

C245

CR

242

CR

243

L241

R242R241

R244

SH242

C224

C231

C232

C234

R231

R232

R233

13

2537

1

U201

C296

C258

C259

U210

3 4

U21134

C201

C223

C219

C293

L261

R202

R201

SH202

C264

C218

C298

C202

C204

C206

C207

C208C263

C265

CR

203

R204

R281

C277

C279

C522

C278

L505

U2

48

VR

441

VR

506

C523VR442 C436

C437

R420

R426

C431

C433

3

FL401

R463

R414

R415

C435

CR

411

Q416

R460

C434

R462R419

R461

U410

U409

761

C453

C456

L410

L411

R409R411

R457

R432

C458

C459

C466

E400

C449

C463

E401

E402

E403

26

E404

E405

E406

SH402

51

C407

C479

R475

R425R

445

R449

C420

C419

C421

C481

R413

SH403 C422

C416 C447

C448

C475

R400

R423

R424

R431

R472

25

20 11

13

37

1

U404C408

C409

C411

C414

C451

C410

C430C415

C440

C452R436

R434

C450

C476

Q410

34

R471

U420

101

C445

VR

432

VR

433

C442

VR

445

VR

446

VR

448

R473

2

S502

3 5

4

B501

3

2

1

C132

C173

C172

H101

P100

Q111

34

R170

R133

R172

CR501

FL0830740O

VIEWED FROM SIDE 2

Z01

Figure 9-18. UHF (403-470 MHz) 5000/7000 Series Main Board Bottom Side PCB 8480450Z03


DEMOD

LVZIF_SEL

RSSI

16.8MHz

CLK

DACRx

DATA

Vdda

Vdda

RX_IN RX_INJ

R5

RECEIVER

DATA

CLK

DACRX

DEMOD

RSSI

LVZIF_SEL

16.8MHz

RX_INJ

SWB+

TX_INJ

Vdda

FGU

16.8MHz4V_3.3V

5V

CLK

CSX

DATA

LOCK

MODIN

R5CSX

4V_3.3V

SWB+

LOCK

MODIN

5V

DATA

RESETRX_IN TX_INJ

UNSWB+

TRANSMITTER

5V

CLK

CSX

5VUNSWB+

RESET

B503

B504

LI_ION

C505100pF

R5070

C5020.47uF

VR5016.8V

1

5

HIG

H

3 2

SWITCHS502

4

LOW

Vdda

VOL

MECH_SWB+

100pFC503 VR506

6.8V10VVR439

L505390nH

24VF501

2

CR5011

BATT_CODEUNSWB+

BATT —

BATT +

RADIO_CODEBATTERY_CONTACT

CONN_J

B501

2 DATA1 NEG3 POS

PB501

12SWITCH

.01uFC521

6.8VVR440

SB1

12

PB502SWITCH

C522.01uF

VR4416.8V

PB503

SB2

C523.01uF 6.8V

VR442

SWITCHPB504

12

12SWITCH

VR4446.8V

PTT

SB3

6.8VVR443

12SWITCHPB505

.01uFC520

EMER

47KR506

Q505

R50510K

Vdda

GREEN_LED

IMX1

51

6

24

3

SWB+

RED_LED

Q502

680R501

180R502

4

1 3CR503

2

RTA0

RTA1

RTA2

RTA3

100pFC514

100pF

C513

100pF

C511

100pF

C512

SWITCHS501

GND GND1

PC3PC2C0C1

PC0PC1

84C0C1

12

7 9

FL0830741O

,

Figure 9-19. UHF (403-470 MHz) Controls and Switches Schematic Diagram


100pFC386

Q31013

2NU

R331 C372R330 C371NU NU NU NU

2 1

R335

RT301

R338

C3916.8KR325

R5

NU

NUNU

NU

VR300

R326

Q316

13

2

R334

NU

NUNU

NU

33.0KRT300

2

1

13

2

Q315

R319150

R31818K

R32733K

C333

R336

R5

NU

NU

R31691K

C396NU

C3971uF

2.2KR300

RSSI

RX_INJ

100pFC370

0R339

R332NU

100pFC374R333

0R349

L321

C373

NU NU

NUC378NU

100pFC375

16.28nHL309

C320 C3197.5pF 1.8pF

2

T302XFMR

46

31

C3819.1pF

TP3023.6KR348

R5

7.5pFC318

9.1pFC317

R3290

CR305CR304

100KR307R306

100K

L30613.9nH

L30713.9nH

C3163.9pF

C31310pF

C311

27nHL305

6.8pFC312

C306

NU

NU

R3031K

C3100.1uF

Q3011

3

2

R3406.8K

2.7R328

C3140.1uF510

12K

R305

C309100pF

R304

180nHL304

100pFC321

100pFC315

R5R342

100K

C380.01uF

DACRx

2

XFMRT301

4

6

3

1

18R309

270270R310R308

CR30634

IF

2 1

82pFC322

L310150nH

R3171K

23

CR308HSMP3820

1

100pFC331C395

100pF

L340390nH

R3471K

R5

C3013.6pF

RX_IN

CR301

13.9nHL301C302

10pF

CR302

R302100K

R301100K

3.9pFC303

100pFC308

C30520pF

L302

13.9nH

C3049.1pF

CR303

2

3

1220nHL303

C3070.1uF

SHIELDSH301

RXFE Top Shield

SH302SHIELD

SH304SHIELD

RXFE Bottom Shield

RX Mixer Diod Shield

SH303SHIELD

Mixer Shield

FL0830742O

Figure 9-20. UHF (403-470 MHz) Receiver Front End Schematic Diagram


Vdd_FILTERED

(SOURCE)

L3312.2uH

R34310

10uFC382

C3290.1uF

0.1uFC348

0.1uFC344

Vdda

C3430.22uF

0.1uFC347 C346

0.1uF 0.1uFC345

DEMOD

100KR350

C390100pF

R34412K

100pF

C383

VddFILTERED

C349.022uF

C350330pF

C35120pF

.022uFC334

16.8MHz

CLKDATA

LVZIF_SEL

0.22uFC357

1200pFC358

C3590.1uF

VA

G

VA

G_R

EF

RO

SE

_VC

CR

OS

E_V

SS

LIM

PH

S_L

CK

DE

MO

D_O

UTC4M

DE

MO

D_H

F

C1M

C2M

C3M

TESTAIOUT

MLPD_CR

FREFGND

GOLD_VSS

CEXCLK

COL

DATA

BROWN_VCCBRP_OFF

PR

E_A

GC

GREEN_VSSMIX_BYP

MIX_INPREAMP_OUT

GREEN_VCC

C3PC4P

BLUE_VSS

C1PC2P

BLUE_VCC

TE

ST

DV

PP

PR

E_I

N

RE

D_V

CC

RE

D_V

SS

RS

SI_

FLT

RS

SI_

OU

T

EM

IT

EX

TB

S

GO

LD_V

CC

AF

C

BA

SE

U301

8 931 2 54

11

6

10

7

12

1615

24

2120

14

1918

13

17

2223

48

4342

4647

41

3837

44

4039

45

32 2530 2931 262736 28333435

0.15uF

15pF

C338

C361.01uF

RSSI

C3280.1uF

R3143K

R5

330R313

C355

C337100pF

.022uFC356

C326.01uF

L3142.2uH

C3360.1uF

Vdd_FILTERED

C3421uF

C3411uF

C3401uF

1uFC339

LVZIF BTM SHEILDCRYSTAL FILTER SHIELD LVZIF TOP SHEILD

SH322SHIELD

SH321SHIELD

SH323SHIELD

Q3203

212pFC352

1

C35343pF

0R355

R3203.9K

2.2uHL325

R34656K

47pFC354

2KR324

CR310

C385

56pF 100nHL332

1KR321 R322

200K8200pFC364C362

0.1uF

C3631uF

C38456pF10K

R345

C360.022uF

680nHL330

C33010pF

C327100pF

2.4KR312

Q302R3510

R31512K

.01uFC325

30KR311

3.3KR352

XTALFL301

TBD

OUTIN

GN

DG

ND

1G

ND

2G

ND

3

36

1 2 4 5

IF

C323150pF

L311750nH

20pFC324

FL0830743O

Figure 9-21. UHF (403-470 MHz) Receiver Back End Schematic Diagram


GND3

2

NC

1 4

U210

VCC5

GND3

2

NC

1 4

VCC5

U211C2960.1uF

C265NU 100pF

C257

A2A3

K1K2K3

A1

CR201

54

6123

C258.01uF

.01uFC259

C230100pF 1000pF

C2294.7uFC228

C2190.22uF

0.1uFC292

C2980.1uF

L2022.2uH

(SOURCE)5V

0.47uFC291

0.1uFC223

2.2uFC235

246

53

1U247

GN

D

INSD

NROUTERR

C2930.47uF100pF

C294

L2032.2uH

SWB+

Vdda

U248

ON

_OF

F*

VIN

GND

VO

UT

NC

3 1

5

2

4

C277100pF 2.2uF

C278

4V_3.3V

C2330.1uFR255

4.3K

C2792.2uF

.047uFC232

C234

0.47uFR231120

R25630

R5

0.1uFC231

620R232

R233560

12uHL232

1

3

Q210

2

4

5V

100pFC260

AUX3AUX4

LOCK

C213100pF

TP201

XTAL1XTAL2

VMULT1VMULT2VMULT3VMULT4

MODOUTFREFOUT

AUX4

AUX1AUX2AUX3

2324

15141211

1941

48123

TEST2

WARP

SFOUT

TEST1

IADAPT

INDMULT

IOUT

LOCKADAPTSW

25

28

3738

45

16

43

446

VC

PV

RO

PR

E_V

DD

PD

_VD

D

DV

DD

AV

DD

47135 34 3620

VBPASSPVREF

SFIN

MODIN

BIAS1BIAS2

CEXCLK

DATA

2135

30

10

4039

98

7

REFSEL

SFBASESFCAP

NC1NC2NC3

PREIN

CCOMP

18

2726

172931

32

42

PD

_GN

DP

RE

_GN

D

DG

ND

AG

ND

44336 22

U201

C204

100KR202

82KR201

100pFC211

C214100pF

DATAMODIN

2.2uF

100pFC264

39nHL261

C2630.75pF

PRESC

100pFC210

C212100pF

CSXCLK

VSF

1000pF

C202C201100pF 4.7uF

C203

SH201SHIELD

SYNTHESIZER TOP SHIELD

SH202SHIELD

SYNTHESIZER BOTTOM SHIELD

R20447K

CR203

45J49FL201

GND

3

IN1

OUT2

C2081.6pF

C20756pF

C206330pFNU

R281

VCTRL

470pFC238

TP202

0.1uFC224

2.2uFC217 C218

0.1uF 100pFC220

2.2uHL201

16.8MHz

FL0830744O

Figure 9-22. UHF (403-470 MHz) Synthesizer Schematic Diagram


33nHL273

390nHL281

100pFC281

240R245

2.2uFC276

NUC272

0.1uFC273

C2860.1uF

L27168nH

RX_SW

TX_SW

PRESC

NUC271

TX_SWITCH

VC

C_B

UF

FE

RS

VC

C_L

OG

IC

RX_OUT

RX_SWITCH

SUPER_FLTR

TRB_IN

TX_BASETX_EMITTER

TX_IADJTX_OUT

FLIP_IN

GN

D_B

UF

FE

RS

GN

D_F

LAG

GN

D_L

OG

IC

PRESC_OUTRX_BASE

RX_EMITTER

RX_IADJ

COLL_RFINU241

11 917

10

13

8

7

12

23

19

1615

1

4

20

56

1418

SHIELDSH242SH241

SHIELD

VCO TOP SHIELD VCO BOTTOM SHIELD

R2601K

C297.01uF

4

1

3Q260

2AUX3

5V

AUX4

1

3

Q261

2

100pFC289

330R252 R251

18

100pFC255

R2547.5K

1

2

3

3.6pF

L253RESONATOR

C254

P1

P2

P3

C2531.5pF

CR251

10pFC252

C247100pF

30R248

0.1uFC2487.5K

R253

Tx_sw

100pFC251

L25133nH

CR242

L241

CR243

390nHVCTRL

100pFC241

2

CR241

1

3

L282390nH

1

3

2

Q241

VSF

R24412K

R24310K

2.4pFC245

C2442pF

Rx_sw

1

7.5pFC242

7.5pF

C243

C2507.5pF

220nHL242

100pFC246

R24118

R242200

L243RESONATOR

2

3

VSF

C285100pF

TX_INJ

RX_INJ

4

FL0830745O

Figure 9-23. UHF (403-470 MHz) Voltage Controlled Oscillator Schematic Diagram


VL6 VLIM 19

TEM

P30

V10

14

V45

16

17V5EXT

20VAR1

18VAR2

24VAR3

VG

15

22NA

Q11

QX

10

1 RFIN

RS 21

31R

SE

T

RX 23T12

CLK

26

CQ

12

CQ

X13

DA

TA28

F168

9

GND18

GN

D2

25

INT4 U102

AN

O32

BP

OS

27

CE

X29

CI3

CJ5

CL7

C138100pF

CR105

GND

3

1

PO

S

2VOUT

R131

LM50

10KR130

18K

100pFC170

C110100pF

0.1uFC126

.022uFC173

5V

TX_BIAS

RESET

UNSWB+

DATA

CLK

CSX

100pFC122

C105100pF

4

1

3

100pFC132

Q111

2

6

100pFC174

R133

UNSWB+

NU

10K

4.7K

47K

47K

1000pF

C127

L115

C133

390nH1000pF C134

3300pF

C135

.022uF

C166

100pF

L113

C129

5.6nH

6.8pF

100pFC165

.022uFC131

390nHL114

200KR109

100KR132

2pFC169

UNSWB+

RFI

N6

RFO

UT1

7R

FOU

T21

VC

NTR

L14

VD

12

VG

13

VG

2

GND15GND212GND313GND4

8N

C1

9N

C2

10N

C3

15N

C4

16

U101

11G

2

4

9.1pFC120

100pFC121

C150.022uFC151

100pF

C1610.1uF

200R161

100pF

C130C128

.022uF

390nHL112

R1085.6K

L16015.0nH

56pFC160

.022uFC152

UNSWB+

11pFC116

C11710pF

11.03nHL109

4.22nHL108

10R106

100pF

C115

C118

27pF

C125100pF

100pFC295

300R112R110300

20R111

R107

C180

TX_INJ_1

TX_INJ

NU

NU

Microstrip Microstrip1

2

3C111

13.0pFC11236pF

L10733.47nH

0.1R102

L11722.0nH

C113

15pF

BEADE101

C114100pF

C12310uF

200R172

0.1uFC172

C181

Q110 Microstrip

NU

L105C108100pF

390nH

240R170

240R101

C109100pF 7.66nH

L106

UNSWB+

3.3pF

1A1

2A2

K 3

C107 CR102

L10412.39nH

4.7pFC106

RX_IN

CR101

L10212.39nH12.39nH

L101

6.2pFC104C103

13pFC1026.2pF

C101100pF

4GND

1

2

3

J101RF_JACK

C141

TAB5 5

C140

TAB11TAB22

TAB3 3TAB4 4

ANTENNA_NUTJ102

9.75nHL116

HEATSINKH101

POS1

NU

NU

43KR120

100pFC119

100pF

C171R173180K 43K

R171

R174NU

SH100SHIELD SHIELD

SH101

HF SHIELD PA SHIELD

R104

47K

FL0830746O

Figure 9-24. UHF (403-470 MHz) Transmitter Schematic Diagram


UHF (403-470 MHz) Radio Parts List (PCB 8480450Z03)

CircuitRef


B501 0986237A02 Battery Contact ModuleB503 3980502Z01 Backup battery B+ B504 3980501Z01 Backup battery B- C101 2113740F51 100pFC102 2113740F22 6.2pF, 0.1C103 2113740F27 10pFC104 2113740F22 6.2pF, 0.1C105 2113743N50 100pFC106 2113740F19 4.7pF, 0.1C107 2113740F15 3.3pF, 0.1C108 2113743N50 100pFC109 2113740F51 100pFC110 2113743N50 100pFC111 2113740F30 13pFC112 2180605Z32 47pFC113 2180605Z16 10pFC114 2113743N50 100pFC115 2113743N30 15pFC116 2113743N38 33pFC117 2113743N37 30pFC118 2113743N50 100pFC119 2113743N50 100pFC120 2113743N26 10pFC121 2113743N50 100pFC122 2113743N50 100pFC123 2311049A18 10uF, 10%; 16VC125 2113743N50 100pFC126 2113743M24 0.1uF, +80%/-20%C127 2113743L17 1000pF, 10%C128 2113743M08 .022uF, +80%/-20%C129 2113743N23 7.5pF, 0.5C130 2113743N50 100pFC131 2113743M08 .022uF, +80%/-20%C132 2113743N50 100pFC133 2113743L17 1000pF, 10%C134 2113743L29 3300pF, 10%C135 2113743M08 .022uF, +80%/-20%C138 2113743N50 100pFC140 Not PlacedC141 Not PlacedC150 2113743M08 .022uF, +80%/-20%C151 2113743N50 100pFC152 2113743M08 .022uF, +80%/-20%C160 2113743N50 100pFC161 2113743M24 0.1uF, +80%/-20%C165 2113743N50 100pFC166 2113743N50 100pFC169 2113743N16 3.9pF, 0.25C170 2113743N50 100pFC171 2113743N50 100pFC172 2113743E20 0.1uF, 10%C173 2113743M08 .022uF, +80%/-20%C174 2113743N50 100pFC201 2113743N50 100pF

C202 2113743L17 1000pF, 10%C203 2311049A56 4.7uF, 20%; 10VC204 2104993J02 2.2uFC206 2113740F63 330pFC207 2113743N44 56pFC208 2113743N08 1.6pFC210 2113743N50 100pFC211 2113743N50 100pFC212 2113743N50 100pFC213 2113743N50 100pFC214 2113743N50 100pFC217 2104993J02 2.2uFC218 2113743M24 0.1uF, +80%/-20%C219 2113743K16 0.22uF, +80%/-20%C220 2113743N50 100pFC223 2113743M24 0.1uF, +80%/-20%C224 2113743M24 0.1uF, +80%/-20%C228 2311049J11 4.7uF, 10%; 16VC229 2113743L17 1000pF, 10%C230 2113743N50 100pFC231 2113743M24 0.1uF, +80%/-20%C232 2113743E12 .047uF, 10%C233 2311049A01 0.1uF, 10%; 35VC234 2311049A05 0.47uF, 10%; 25VC235 2104993J02 2.2uFC238 2113741F17 470pFC241 2113743N50 100pFC242 2113743N23 7.5pF, 0.5C243 2113743N23 7.5pF, 0.5C244 2113740F10 2pF, 0.25C245 2113743N11 2.4pF, 0.25C246 2113743N50 100pFC247 2113743N50 100pFC248 2113743M24 0.1uF, +80%/-20%C250 2113743N23 7.5pF, 0.5C251 2113743N50 100pFC252 2113743N26 10pFC253 2113740F07 1.5pF, 0.25C254 2113743N15 3.6pF, 0.25C255 2113743N50 100pFC257 2113743N50 100pFC258 2113743L41 .01uF, 10%C259 2113743L41 .01uF, 10%C260 2113743N50 100pFC263 2113743N02 0.75pF, 0.25C264 2113743N50 100pFC265 Not PlacedC271 Not PlacedC272 Not PlacedC273 2113743M24 0.1uF, +80%/-20%C276 2104993J02 2.2uFC277 2113743N50 100pFC278 2311049A09 2.2uF, 10%; 20VC279 2104993J02 2.2uFC281 2113743N50 100pFC285 2113743N50 100pF

CircuitRef


C286 2113743M24 0.1uF, +80%/-20%C289 2113743N50 100pFC291 2113743A27 0.47uF, 10%C292 2113743M24 0.1uF, +80%/-20%C293 2113743A27 0.47uF, 10%C294 2113743N50 100pFC295 2113743N50 100pFC296 2113743M24 0.1uF, +80%/-20%C297 2113743L41 .01uF, 10%C298 2113743M24 0.1uF, +80%/-20%C301 2113743N15 3.6pF, 0.25C302 2113743N26 10pFC303 2113740L08 3.9pF, 0.1C304 2113743N25 9.1pF, 0.5C305 2113743N33 20pFC306 Not PlacedC307 2113743M24 0.1uF, +80%/-20%C308 2113743N50 100pFC309 2113743N50 100pFC310 2113743M24 0.1uF, +80%/-20%C311 Not PlacedC312 2113743N22 6.8pF, 0.5C313 2113743N26 10pFC314 2113743M24 0.1uF, +80%/-20%C315 2113743N50 100pFC316 2113740L08 3.9pF, 0.1C317 2113743N25 9.1pF, 0.5C318 2113743N23 7.5pF, 0.5C319 2113743N69 1.8pF, 0.5C320 2113743N23 7.5pF, 0.5C321 2113743N50 100pFC322 2113743N48 82pFC323 2113743N54 150pFC324 2113743N33 20pFC325 2113743L41 .01uF, 10%C326 2113743L41 .01uF, 10%C327 2113743N50 100pFC328 2113743M24 0.1uF, +80%/-20%C329 2113743M24 0.1uF, +80%/-20%C330 2113743N26 10pFC331 2113743N50 100pFC333 Not PlacedC334 2113743M08 .022uF, +80%/-20%C336 2113743M24 0.1uF, +80%/-20%C337 2113743N50 100pFC338 2113743N30 15pFC339 2180478Z20 1.0uF, 10%C340 2180478Z20 1.0uF, 10%C341 2180478Z20 1.0uF, 10%C342 2180478Z20 1.0uF, 10%C343 2113743A23 0.22uF, 10%C344 2113743M24 0.1uF, +80%/-20%C345 2113743M24 0.1uF, +80%/-20%C346 2113743M24 0.1uF, +80%/-20%C347 2113743M24 0.1uF, +80%/-20%C348 2113743M24 0.1uF, +80%/-20%

CircuitRef


C349 2113743E07 .022uF, 10%C350 2113743L05 330pF, 10%C351 2113743N33 20pFC352 2113743N28 12pFC353 2113743N41 43pFC354 2113743N42 47pFC355 2113743A21 0.15uF, 10%C356 2113743M08 .022uF, +80%/-20%C357 2113743A23 0.22uF, 10%C358 2113741A23 1200pFC359 2109720D14 0.1uFC360 2113743E07 .022uF, 10%C361 2113741F49 0.1uF, 10%C362 2113928N01 0.5pF,0.25C363 2311049A07 1uF, 10%; 16VC364 2113743L39 8200 pFC370 2113743N50 100pFC371 Not PlacedC372 Not PlacedC373 Not PlacedC374 2113743N50 100pFC375 2113743N50 100pFC378 Not PlacedC380 2113743L41 .01uF, 10%C381 2113743N25 9.1pF, 0.5C382 2311049A59 10uF, 10%; 6VC383 2113743N50 100pFC384 2113743N44 56pFC385 2113743N44 56pFC386 2113743N50 100pFC390 2113743N50 100pFC391 Not PlacedC395 2113743N50 100pFC396 Not PlacedC397 2311049A07 1uF, 10%; 16VC400 2113743L41 .01uF, 10%C401 2113743M24 0.1uF, +80%/-20%C402 2113743M24 0.1uF, +80%/-20%C403 2113928D08 10uF, +80%/-20%C407 2113928N01 0.1uF, 10%C408 2113743N50 100pFC409 2113743M24 0.1uF, +80%/-20%C410 2113928N01 0.1uF, 10%C411 2113743M24 0.1uF, +80%/-20%C414 2113743M24 0.1uF, +80%/-20%C415 2109720D01 .01uF, 10%C416 2113928N01 0.1uF, 10%C419 Not PlacedC420 2113743L41 .01uF, 10%C421 2113928N01 0.1uF, 10%C422 2113743M24 0.1uF, +80%/-20%C423 2113743N50 100pFC424 2311049A59 10uF, 10%; 6VC425 2113743M24 0.1uF, +80%/-20%C426 2113743N50 100pFC427 2113743N50 100pF

CircuitRef



C428 2113743M24 0.1uF, +80%/-20%C429 2113743M24 0.1uF, +80%/-20%C430 2113928N01

0662057M010.1uF, 10% 0 (SUB on LS+ Models Only)

C431 2113743N50 100pFC432 Not PlacedC433 2113743L41 .01uF, 10%C434 2113743M24 0.1uF, +80%/-20%C435 2113743M24 0.1uF, +80%/-20%C436 2113743N34 22pFC437 2113743N34 22pFC440 2113743G26 4.7uF, +80%/-20%C441 2113743N50 100pFC442 2113743E20 0.1uF, 10%C443 2113928N01 0.1uF, 10%C444 2113743N50 100pFC445 2113743N50 100pFC447 2113928N01 0.1uF, 10%C448 2113928N01 0.1uF, 10%C449 2113743N50 100pFC450 2113743M24 0.1uF, +80%/-20%C451 2113743M08 .022uF, +80%/-20%C452 2113743G26 4.7uF, +80%/-20%C453 2113743N50 100pFC456 2113743N50 100pFC458 2113743N50 100pFC459 2113743N50 100pFC463 2113743N50 100pFC466 2113743N50 100pFC467 2113928N01 0.1uF, 10%C471 2113743N50 100pFC472 2113743N50 100pFC473 2113743N50 100pFC475 2113743H14 10uF, +80%/-20%C476 2113928D08 10uF, +80%/-20%C479 2113928N01 0.1uF, 10%C480 2113928D08 10uF, +80%/-20%C481 2113928N01 0.1uF, 10%C482 2113928N01

0662057M010.1uF, 10% 0 (SUB on LS+ Models Only)

C490 2113743N50 100pFC491 2113743N50 100pFC492 2113743N50 100pFC493 2113743N50 100pFC494 2113743N50 100pFC495 2113743N50 100pFC496 2113743N50 100pFC497 2113743N50 100pFC502 2311049A05 0.47uF, 10%; 25VC503 2113743N50 100pFC505 2113743N50 100pFC511 2113743N50 100pFC512 2113743N50 100pFC513 2113743N50 100pFC514 2113743N50 100pFC520 2113743L41 .01uF, 10%

CircuitRef


C521 2113743L41 .01uF, 10%C522 2113743L41 .01uF, 10%C523 2113743L41 .01uF, 10%CR101 4880973Z02 Pin DiodeCR102 4802245J41 Pin DiodeCR105 5185963A15 Temperature SenseCR201 4802233J09 Triple DiodeCR203 4862824C03 VaractorCR241 4805649Q13 Dual VaractorCR242 4862824C01 VaractorCR243 4862824C01 VaractorCR251 4802245J22 VaractorCR301 4862824C01 VaractorCR302 4862824C01 VaractorCR303 4880154K03 Dual Common Anode-CathodeCR304 4862824C01 VaractorCR305 4862824C01 VaractorCR306 4802245J42 Ring Quad DiodeCR308 4802245J41 Pin DiodeCR310 4862824C01 VaractorCR411 4802245J47 Schottky DiodeCR412 4802245J47 Schottky DiodeCR413 4802245J47 Schottky DiodeCR440 4813833C02 Dual Diode Common CathodeCR501 4880107R01 RectifierCR503 4805729G49 LED Red/YellowE101 2484657R01 Ferrite BeadE400 2480640Z01 Ferrite BeadE401 2480640Z01 Ferrite BeadE402 2480640Z01 Ferrite BeadE403 2480640Z01 Ferrite BeadE404 2480640Z01 Ferrite BeadE405 2480640Z01 Ferrite BeadE406 2480640Z01 Ferrite BeadE407 2480640Z01 Ferrite BeadE408 2480640Z01 Ferrite BeadE409 2480640Z01 Ferrite BeadF501 6580542Z01 Fuse 3AFL201 4802245J49 16.8 MHz Xtal Clip (not field

serviceable)FL301 4802245J43 Xtal Filter 45.1 MHzFL401 4870368G02 Osc Xtal 38.4 kHzH101 2680499Z01 Heat SpreaderJ101 0180117S05 RF Jack AssemblyJ102 0280519Z02 Antenna NutJ400 0905505Y04 40-pins ConnectorJ403 0905505Y02 20-pins ConnectorL101 2460591B80 19.61nH, 10%L102 2460591B80 19.61nH, 10%L104 2460591B80 19.61nH, 10%L105 2462587N22 390nH, 10%L106 2460591A11 7.66nH, 10%L107 2460591G24 33.47nH, 10%L108 2460591A01 4.22nH, 10%L109 2460591B04 11.03nH, 10%L112 2462587N22 390nH, 10%

CircuitRef


L113 2413926H09 5.6nH, 5%L114 2462587N22 390nH, 10%L115 2462587N22 390nH, 10%L116 2460591A50 9.75nH, 10%L160 2413926H14 15.0nH, 5%L201 2462587Q20 2.2uH, 20%L202 2462587Q20 2.2uH, 20%L203 2462587Q20 2.2uH, 20%L232 2462587P25 12uH, 5%L241 2462587V41 390nH, 10%L242 2462587V38 220nH, 5%L243 2460593C01 Teflon ResonatorL251 2462587V28 33nH, 5%L253 2460593C02 Teflon ResonatorL261 2462587V29 39nH, 5%L271 2462587V32 68nH, 5%L273 2462587V28 33nH, 5%L281 2462587V41 390nH, 10%L282 2462587V41 390nH, 10%L301 2460591C04 13.9nH, 10%L302 2460591C04 13.9nH, 10%L303 2462587V38 220nH, 5%L304 2462587V37 180nH, 5%L305 2462587V27 27nH, 5%L306 2460591C04 13.9nH, 10%L307 2460591C04 13.9nH, 10%L309 2460591C16 16.28nH, 10%L310 2462587V36 150nH,5%L311 2462587N65 750nH,5%L314 2462587N72 2.2uH, 5%L321 Not PlacedL325 2480646Z20 2.2uHL330 2462587N64 680nH, 5%L331 2480646Z20 2.2uHL332 2462587N53 100nH, 5%L340 2462587V41 390nH, 10%L400 2462587Q42 390nH, 10%L401 2462587Q42 390nH, 10%L410 2462587Q42 390nH, 10%L411 2462587Q42 390nH, 10%L505 2462587Q42 390nH, 10%P100 3905643V01 Gnd Contact FingerPB501 4080523Z01 Tactile, PushbuttonPB502 4080523Z01 Tactile, PushbuttonPB503 4080523Z01 Tactile, PushbuttonPB504 4080523Z01 Tactile, PushbuttonPB505 4080523Z01 Tactile, PushbuttonQ110 4802245J55 RF Power FETQ111 4802245J50 Dual NPN/PNPQ210 4802245J50 Dual NPN/PNPQ241 4805218N63 NPNQ260 4802245J50 Dual NPN/PNPQ261 4802245J50 Dual NPN/PNPQ301 4802245J44 NPNQ302 4802245J44 NPNQ310 Not Placed

CircuitRef


Q315 4880214G02 NPNQ316 Not PlacedQ320 4805218N63 NPNQ400 4809579E18 MOSFET P-ChanQ403 4880214G02 NPNQ405 4802245J54 Dual NPNQ410 4802245J54 Dual NPNQ416 4809579E18 MOSFET P-ChanQ417 4802245J50 Dual NPN/PNPQ502 5180159R01 Dual NPNQ505 4880214G02 NPNR101 0662057A34 240R102 0680539Z01 0.1, 1%R103 0662057M41 43R104 0662057M81 2KR106 0662057M26 10R107 Not PlacedR108 Not PlacedR109 0662057N30 200KR110 0662057M61 300R111 0662057M33 20R112 0662057M61 300R120 0662057M01 0R130 0662057M98 10KR131 0662057M98 10KR132 0662057N39 470KR133 Not PlacedR161 0662057M57 200R170 0662057A34 240R171 0662057M92 5.6KR172 0662057A32 200R173 0662057N47 1MEGR201 0662057N21 82KR202 0662057N23 100KR204 0662057N15 47KR231 0662057M52 120R232 0662057M69 620R233 0662057M68 560R241 0662057M32 18R242 0662057M57 200R243 0662057M98 10KR244 0662057N01 12KR245 0662057M59 240R248 0662057M37 30R251 0662057M32 18R252 0662057M62 330R253 0662057M95 7.5KR254 0662057M95 7.5KR255 0662057M89 4.3KR256 0662057M37 30R260 0662057M74 1KR281 0662057M01 0R300 0662057M82 2.2KR301 0662057N23 100KR302 0662057N23 100KR303 0662057M74 1K

CircuitRef



* Motorola Depot Servicing only

R304 0662057N01 12KR305 0662057M67 510R306 0662057N23 100KR307 0662057N23 100KR308 0662057M60 270R309 0662057M32 18R310 0662057M60 270R311 0662057N10 30KR312 0662057M83 2.4KR313 0662057M62 330R314 0662057M85 3KR315 0662057N01 12KR316 0662057A96 36KR317 0662057M74 1KR318 0662057A79 18KR319 0662057A29 150R320 0662057M88 3.9KR321 0662057M74 1KR322 0662057N30 200KR324 0662057M81 2KR325 0662057M94 6.8KR326 Not PlacedR327 0662057N11 33KR328 0662057M12 2.7R329 0662057M01 0R330 Not PlacedR331 Not PlacedR332 Not PlacedR333 Not PlacedR334 Not PlacedR335 Not PlacedR336 Not PlacedR338 Not PlacedR339 0662057M01 0R340 0662057M94 6.8KR342 0662057N23 100KR343 0662057M26 10R344 0662057N01 12KR345 0662057M98 10KR346 0662057N17 56KR347 0662057M74 1KR348 0662057M87 3.6KR349 0662057C01 0R350 0662057N23 100KR351 0662057C01 0R352 0662057M86 3.3KR355 0662057M01 0R400 0662057N15 47KR401 0662057M01 0R402 Not PlacedR403 Not PlacedR405 0662057M01 0R406 0662057N20 75KR407 0662057N19 68KR408 Not PlacedR409 0662057M98 10K

CircuitRef


R410 0662057N23 100KR411 0662057M98 10KR413 0662057M01 0R414 0662057V34 180K, 1%R415 0662057V26 91K, 1%R416 0662057N13 39KR418 0662057M01 0R419 0662057M67 510R420 0662057B46 10MEGR421 0662057M81 2KR423 0662057N15 47KR424 0662057N12 36KR425 0662057N10 30KR426 0662057N35 330KR427 0662057M84 2.7KR428 0662057M10 2.2R429 0662057M98 10KR431 0662057N39 470KR432 0662057N16 51KR434 0662057M62 330 OhmR435 0662057M81 2K OhmR436 0662057M01 0R437 Not PlacedR445 0662057N08 24KR446 0662057N31 220KR447 0662057N50 1.3MR448 0662057N33 270KR449 0662057N08 24KR450 0683962T45 68, 1WR457 0662057M98 10KR460 0662057M90 4.7KR461 0662057M56 180R462 0662057M98 10KR463 0662057M61 300R471 0662057M92 5.6KR472 0662057M87 3.6KR473 0662057M26 10R475 0662057M01 0R476 0662057N08 24KR477 0662057M74 1KR478 0662057M98 10KR481 0662057N08 24KR492 0662057M01 0R501 0662057M70 680R502 0662057M56 180R505 0662057M98 10KR506 0662057N15 47KR507 0662057M01 0RT300 0680590Z01 Thermistor 33KRT301 Not PlacedRT400 0680590Z01 Thermistor 33KS501 4080502B03 Channel SwitchS502 1880619Z01 Volume SwitchSH100 2680507Z01 Harmonic Filter ShieldSH101 2680510Z01 PA ShieldSH201 2680511Z01 Synthesizer Top Shield

CircuitRef


SH202 2680511Z01 Synthesizer Bottom ShieldSH241 2680513Z01 VCO Top ShieldSH242 2680514Z01 VCO Bottom ShieldSH301 2680554Z01 Rx Pre-filter shield\SH302 2680555Z01 Rx Post-filter/RF Amp ShieldSH303 2680509Z01 Mixer ShieldSH304 2680624Z01 Mixer Diode ShieldSH321 2680508Z01 Zif 2nd LO ShieldSH322 2680514Z01 ZIF ShieldSH323 2680553Z01 Xtal Filter ShieldSH400 2680505Z01 Controller Memory ShieldSH401 2680506Z01 Controller On/Off ShieldSH402 2680515Z01 Controller Microprocessor ShieldSH403 2680516Z01 Controller AsficCmp/Audi PA ShieldT301 2580541Z01 Transformer CoilT302 2580541Z01 Transformer CoilU101 5105109Z67 LDMOS DriverU102 5185765B01 Power Control ICU201 5185963A27 Low Voltage FRACN ICU210 5102463J61 InverterU211 5102463J61 InverterU241 5105750U54 VCO BufferU247 5105739X05 Regulator LinearU248 5102463J58 3.3V RegulatorU301 5109632D83 Low Voltage ZIFU400 5102463J40 3.3V RegulatorU404 5185963A53 ASFIC (LTR Models Only)U405 Not Placed

5102463J36 RAM 32Kx8U406 *5102463J59 ROM 256K

*5102463J60 ROM 512Kx8U407 *5102463J64 EEPROM 16Kx8U409 5102226J55 Microcontroller

or 5102226J56U410 5102463J57 3.3V RegU420 5102463J44 Audio PAVR300 Not PlacedVR432 4805656W08 5.6V Zener VR433 4805656W08 5.6V ZenerVR434 4802245J51 6.8V ZenerVR439 4880140L15 10V ZenerVR440 4802245J51 6.8V ZenerVR441 4802245J51 6.8V ZenerVR442 4802245J51 6.8V ZenerVR443 4802245J51 6.8V ZenerVR444 4802245J51 6.8V ZenerVR445 4802245J53 10V ZenerVR446 4802245J53 10V ZenerVR447 4802245J53 10V ZenerVR448 4802245J53 10V ZenerVR449 4802245J53 10V ZenerVR450 4802245J53 10V ZenerVR501 4813830A18 6.8V ZenerVR506 4802245J51 6.8V Zener

CircuitRef


UHF Band 1 Circuit Board/Schematic Diagrams and Parts List (PCB 8480450Z13 / 8480587Z05) 9-33

9.7 UHF Band 1 Circuit Board/Schematic Diagrams and Parts List (PCB 8480450Z13 / 8480587Z05)

J400

1

E409

U405

17

8 21

22

C426 C425

E407R437

R410

40

C42

3

E40

8

R41

8

8

5 4

1

U407

C427 C428

U406

116

1732

C429

C424R408

R492

R429

R478

R428

C432

SH400

C404

C443

R435

TP401

TP402

FL201

1 3

46

PB502PB503

B503

TP201

SH201

B504

C325

C324C323

FL301

R351

L311

R352

SH323

C210

C211

C212C213

C214

C220

C230

C257

C260

C294

C292

C229

C203

C217

C23

5

C228

C233

C238

C297

C29

1

CR201

L201 L202

L203

L232

Q210

3

4

Q26034

R256

R255

U247

C375 C320

C381C319

C322

L309

L310R309

R308

R310

R348

SH303

T301

3 4

6

T302

34

6

TP202

TP302

C328

C391

C397

PB504

Q315

Q316

R326

R300

R314 R316

R318

R319R325

R327

R334

R335

R338

RT300

RT301

VR300

VR444

PB501

C521VR440

C362

C364

C351

C349C350

C352C353

C354

C363

C384

C385

CR310

L325

L332

Q320

R355

R322

R345

R320

R321

R324

R346

SH321

C396

C333

R317

R336C331

CR308

R342

SH301

C304

C308

C302

C301

C303

C305

CR301

CR302

L301

L302

R301

R302

C505

C502

Q505

R506

R507

VR501

C511

C512 C513

C514

C520

CR5032

3 4

Q502

R505

R502

R501

VR443

C441

C444

C471C472

C473

C490

C491

C492

C493

C494

C495

C496

C497

21

1

J403

20

22

L401

Q41734

R477

R450

RT400

TP410

VR447 VR449

CR413

L400

R421

TP405 TP406 TP415

VR434VR450

C401

C402

C40

0

C40

6

C467

C482

C403

C480

CR412

CR440

Q40

0

Q403

Q405

3

4

R401R402

R40

3

R405

R454

R45

5

R45

6

R416

R448R447

R452

R40

6

R407

R427

R476

R481

R451

R453

SH401

U400

85

4

3

L253

1

3

L243

1

C247C251

C285

C289

C370

C374

C386

C248 C273

C286

C276

C253

C271C272

L282

L273

L271

L321

Q26134

Q241

R333

R339

R243

R248

R253

R260

SH241

U101

9

8

16

1

C121

C160

L160

R108

3

2

Q110

1

C109C11

0

C11

4

C118 C119

C12

2

C12

5

C16

5

C166

C171

C111

C112

C113

C115

C117

C116

C120

C161

C127

C131C12

9

C16

9 L114

L115

L106

L107

L108

L109

L113

R103

R104

R106R107

R174

R120

R171

R161

R173

R175

R176

SH101

C101

C141

C102

C104C103

C106

C107

C175

CR101

CR102

L101L102

L104

L105

SH100

C140L116

PB505

ZMY0130183-B


9-34 UHF Band 1 Circuit Board/Schematic Diagrams and Parts List (PCB 8480450Z13 / 8480587Z05)

S5022

3 5

4

C357C358

C359

C383

C390

C346

R344

C343

C3

39

C3

40

C3

41

C3

42

C345 C334

M301

SH322

1325

37 1

U301

C347 C348C356 C337

C329 C336

C344

C360

C355

C361

C382

L314

L331

R343

R350

C327

C330

C326

C338

L330

Q302

R315

R313

R311

R312

M101

3

2

1

B501U248C277 C279

C522 C523

C278

L505VR441

VR442VR506

SH202

L261 C204

C234

13

2537

1

U201

C201

C223

C2

31

C219

C232

C293

R201

R202

R231

R2

32

R2

33

C264

C2

98

C2

02

C263

C218

C206C207

C208

C265

CR203

R204

R281

C296

C258C259

U2103 4

U211

3

4

C224

1

2

S501 C

8

C

4Q301

C309

C315

C321

C395

C313

C3

07

C310C314

C318

C380C306

C311

C316

C317C312

CR304 CR305

CR303 L340

L306 L307

L303

L305L304

R3

06

R3

07

R3

04

R303

R347

R305

R3

40

R3

28

SH302

1

J101

4

3

2

J102

P100

M100

Q111

3

4

CR160

CR103

C108

R101

R170

C132

C173

C172

CR105

H101

R133

R172

C105

C130

C138 C151

C170

C174

C126

C133

C128

C1

35

C150C152

C1

34

L112

R109

R132

R1

36

25

917

U102

1

R102

C123E101

R130

R131

VR439

CR306

R329

SH304

C503

CR501

F501

CR241

C241

C246

C281C295

C372

C242C243

C250

C244

C245

C371

C373C378

CR242

CR243

R349

L241

L281L242

Q310

R330

R332R110

R112 R111

R242R241

R244

R245

R331

SH242

U241

10

201

11

C255C252C254

CR251

L251

R251

R252

R254

M400

CR411

C431

C434

C435

C433

C436C437

3

FL401

Q416

R463

R462R419

R414

R415

R420R426

R460

R461

SH

40

2

51

76

U410

U409

26

1

C449

C453

C456

C458

C459

C463

C466

C524

C525

C526

C527

C528

C529

E400

E401E402

E403

E404

E405

E406

L410

L411

R409

R411 R457

R432

M300

SH403

M401

C4

05

C408

C409

C4

11

C414

C450C451

C415

C410

C430C476

C440

C452Q410

3

4

R436

R471

R4

34

131

U404 U420

101

VR460

2537

20 11

R498

C422

C4

20

C4

19

C407

C416

C4

21

C4

47

C4

48

C479

C481 C475

R400

R4

13

R475

R499

R4

23

R425

R424

R431

R445

R449

R472

C445

C442

R473

VR432

VR433

VR445

VR446

VR448

ZMY0130182-B



1

40

J400

C404

C443

L401

R435

TP401

TP402

TP410

VR

447

C444

C471

RT400

VR

449

C441

C472C473

C490

C491

C492

C493C494C495C496C497

R477

2220

121

J403

L400R

421

TP405

VR

434VR450 CR

413

4 3

Q41

7

TP406 TP415

R45

0C

423

C424

C425C426

C427 C428

C429

E407

E40

8

E409

R408

R410

R41

8R428

R42

9

R437

R478R

492

SH400

22

218

71

U405

32 17

161

U40

6

145

8

U40

7

C40

0

C40

1

C402

C403

C40

6

C467

C48

0

C48

2

CR412

CR

440

Q40

0

Q403

43Q405

R401

R40

2

R40

3

R405

R40

6R407

R41

6

R427

R44

7

R44

8

R45

1

R45

2 R453 R454R

455

R45

6

R476

R481

SH401

4

5 8U400

B50

3

B50

4

C203

C21

0

C211

C21

2

C213

C21

4C

217

C220

C22

8

C22

9

C23

0

C23

3

C23

5

C238C257

C260

C29

1

C292

C29

4

C29

7

C43

2

CR

201

6 431

FL20

1

L201

L202

L203

L232

PB502PB503

43

Q210

4 3

Q26

0

R255

R256

SH201

TP201

U247

C247 C248C251

C253

C27

1

C27

2

C273

C27

6

C28

5

C28

6

C28

9

C37

0

C37

4

C38

6

1

3

L2431

3

L253 L271

L273

L282

L321

Q241

4 3

Q26

1

R24

3

R248

R25

3

R26

0

R33

3

R33

9

SH241

C31

9

C32

0

C32

2

C37

5

C38

1

L309

L310

R308R30

9 R310

R348

SH303

643

T301

64 3

T302

TP202

TP302

C32

3

C32

4

C325

FL30

1

L311

R35

1

R352

SH323

C33

1

C333C396

CR

308

R317

R336

R34

2

C328

C39

1

C397

PB504

Q315

Q316

R300

R314

R31

6

R318

R31

9R325R32

6R

327

R334

R335

R338

RT3

00

RT301

VR

300

VR

444

C349C350

C351 C352C353

C35

4

C362 C363

C36

4

C384C385

CR

310

L325 L332

Q320

R32

0

R321

R32

2

R32

4

R34

5

R34

6

R355

SH321

C301

C30

2C

303

C304

C30

5

C30

8

CR301

CR302

L301

L302

R301R302

SH301

C140

C141

C50

2

C50

5

C51

1

C512 C513

C51

4

C520

43

2CR503

L116

PB

505

Q502

Q505

R501

R50

2

R505

R506

R50

7

VR443

VR501

VR440C521

PB501

C10

1

C102

C10

3

C10

4

C106

C107

C175

CR

101

CR102

L101L102

L104

L105

SH100

C109

C11

0

C111C112

C11

3

C11

4

C115

C116

C117

C11

8

C119

C12

0

C121

C12

2

C12

5

C127

C12

9

C131

C160

C161

C16

5

C166C16

9

C171

L106

L107

L108

L109

L113

L114

L115

L160

1

2

3Q110

R103

R10

4R10

6

R10

7

R108

R12

0

R16

1

R17

1 R173

R174R175

R176

SH101

1

16

8

9U101



C701

C702C703

C70

4C

705

C70

6C

707

C708C709

C711

C71

3

C714C715

C71

7C

718

C719

CR700

R701R702

R703

R704

R705

R706R70

7

R708R709

R71

0

R716 R717

SH

701

2815

141

U70

08 7

114

U71

01

458

U72

0

C442

C445

R47

3

VR

432

VR

433

VR445

VR446

VR448

C40

5

C40

7

C408C409C410

C41

1C414

C415

C416

C41

9C

420

C42

1

C42

2

C430C440

C44

7C

448

C450 C451

C45

2

C475

C476

C47

9

C481

M401

43

Q410

R400R

413

R42

3R

424

R42

5

R431

R43

4

R436

R44

5R

449

R471

R472

R475

R498 R499

SH403

1

3725

13

U404

11

1

20

10

U420

VR

460

C431C433

C434C

435

C43

6

C437

C438C439

C44

9

C45

3

C45

6

C458C459

C46

3

C466

CR

411

E400

E40

1

E402

E40

3

E404E405

E406

3

FL401

L410

L411

M400

Q41

6

R409

R41

1

R41

4

R415

R419

R42

0 R42

6

R43

2

R457

R460

R46

1

R462

R46

3

SH

402

1 765126

U40

9

U41

0

C20

1

C20

2C204

C20

6

C20

7

C208

C21

8C219

C223

C224

C23

1

C232

C234

C25

8

C25

9C263

C264

C265

C29

3

C29

6

C29

8

CR203

L261

R201

R202

R204

R23

1R

232

R23

3

R281

SH202

1

3725

13

U20154 3U210

5 43

U21

1

C27

7

C27

8

C27

9

C522

C523 L505

U24

8

VR

441

VR442V

R50

6 12

3B

501

M101

C32

7C

330

C338

L330

Q30

2

R311

R312

R31

3

R31

5

C32

6

C32

9

C33

6

C33

7

C344

C35

5

C360

C361

C38

2

L314

L331

R34

3

R350

C33

4

C34

5

C358

C359

R344

1 372513

U30

1

SH302

SH322

C33

9

C34

0

C34

1

C34

2

C343

C346

C357

C383C390

C34

7

C34

8

C35

6

M301

4

5 3

2 S502

4C

8C

2

1

S50

1

2

3

4

1

J101

J102

C306

C30

7C309C310

C31

1

C31

2

C313

C31

4 C315

C316

C31

7

C318 C32

1

C380

C39

5

CR

303

CR

304

CR

305

L303

L304L305

L306L307

L340

Q30

1

R303

R30

4

R30

5

R30

6R

307

R32

8R

340

R34

7

C10

8

CR

103

CR160

M100

P10

0

43

Q111

R101

R170

C13

2C172

C17

3CR105

H10

1

R13

3

R172

C10

5C

126C138

C170

R10

2

R130

R131

1725

C128C130

C133

C13

4C

135

C150

C151

C152

C17

4L1

12

R109

R132

R13

6

19

U10

2

C123

CR306

CR501

E101

F501

SH304

VR

439

C503

R32

9

C24

1

C24

2

C243

C24

4

C245

C246C250C252 C254

C25

5

C28

1

C29

5

C371 C372

C373 C37

8

CR241

CR242

CR243

CR

251

L241

L242

L251

L281

M300

Q310

R11

0

R11

1R

112

R241R242

R24

4

R24

5

R25

1R

252

R25

4

R330 R331

R33

2 R349

11

120

10

U24

1

SH242



DEMOD

LVZIF_SEL

RSSI

16.8MHz

CLK

DACRx

DATA

Vdda

Vdda

RX_IN RX_INJ

R5

RECEIVER

DATA

CLK

DACRX

DEMOD

RSSI

LVZIF_SEL

16.8MHz

RX_INJ

SWB+

TX_INJ

Vdda

FGU

16.8MHz4V_3.3V

5V

CLK

CSX

DATA

LOCK

MODIN

R5CSX

4V_3.3V

SWB+

LOCK

MODIN

5V

DATA

RESETRX_IN TX_INJ

UNSWB+

TRANSMITTER

5V

CLK

CSX

5VUNSWB+

RESET

B503

B504

LI_ION

C505100pF

R5070

C5020.47uF

VR5016.8V

1

5

HIG

H

3 2

SWITCHS502

4

LOW

Vdda

VOL

MECH_SWB+

100pFC503 VR506

6.8V10VVR439

L505390nH

24VF501

2

CR5011

BATT_CODEUNSWB+

BATT —

BATT +

RADIO_CODEBATTERY_CONTACT

CONN_J

B501

2 DATA1 NEG3 POS

PB501

12SWITCH

.01uFC521

6.8VVR440

SB1

12

PB502SWITCH

C522.01uF

VR4416.8V

PB503

SB2

C523.01uF 6.8V

VR442

SWITCHPB504

12

12SWITCH

VR4446.8V

PTT

SB3

6.8VVR443

12SWITCHPB505

.01uFC520

EMER

47KR506

Q505

R50510K

Vdda

GREEN_LED

IMX1

51

6

24

3

SWB+

RED_LED

Q502

680R501

180R502

4

1 3CR503

2

RTA0

RTA1

RTA2

RTA3

100pFC514

100pF

C513

100pF

C511

100pF

C512

SWITCHS501

GND GND1

PC3PC2C0C1

PC0PC1

84C0C1

12

7 9

FL0830741O

,

Figure 9-29. UHF (403-470 MHz) Controls and Switches Schematic Diagram


100pFC386

Q31013

2NU

R331 C372R330 C371NU NU NU NU

2 1

R335

RT301

R338

C3916.8KR325

R5

NU

NUNU

NU

VR300

R326

Q316

13

2

R334

NU

NUNU

NU

33.0KRT300

2

1

13

2

Q315

R319150

R31818K

R32733K

C333

R336

R5

NU

NU

R31691K

C396NU

C3971uF

2.2KR300

RSSI

RX_INJ

100pFC370

0R339

R332NU

100pFC374R333

0R349

L321

C373

NU NU

NUC378NU

100pFC375

16.28nHL309

C320 C3197.5pF 1.8pF

2

T302XFMR

46

31

C3819.1pF

TP3023.6KR348

R5

7.5pFC318

9.1pFC317

R3290

CR305CR304

100KR307R306

100K

L30613.9nH

L30713.9nH

C3163.9pF

C31310pF

C311

27nHL305

6.8pFC312

C306

NU

NU

R3031K

C3100.1uF

Q3011

3

2

R3406.8K

2.7R328

C3140.1uF510

12K

R305

C309100pF

R304

180nHL304

100pFC321

100pFC315

R5R342

100K

C380.01uF

DACRx

2

XFMRT301

4

6

3

1

18R309

270270R310R308

CR30634

IF

2 1

82pFC322

L310150nH

R3171K

23

CR308HSMP3820

1

100pFC331C395

100pF

L340390nH

R3471K

R5

C3013.6pF

RX_IN

CR301

13.9nHL301C302

10pF

CR302

R302100K

R301100K

3.9pFC303

100pFC308

C30520pF

L302

13.9nH

C3049.1pF

CR303

2

3

1220nHL303

C3070.1uF

SHIELDSH301

RXFE Top Shield

SH302SHIELD

SH304SHIELD

RXFE Bottom Shield

RX Mixer Diod Shield

SH303SHIELD

Mixer Shield

FL0830742O

Figure 9-30. UHF (403-470 MHz) Receiver Front End Schematic Diagram


Vdd_FILTERED

(SOURCE)

L3312.2uH

R34310

10uFC382

C3290.1uF

0.1uFC348

0.1uFC344

Vdda

C3430.22uF

0.1uFC347 C346

0.1uF 0.1uFC345

DEMOD

100KR350

C390100pF

R34412K

100pF

C383

VddFILTERED

C349.022uF

C350330pF

C35120pF

.022uFC334

16.8MHz

CLKDATA

LVZIF_SEL

0.22uFC357

1200pFC358

C3590.1uF

VA

G

VA

G_R

EF

RO

SE

_VC

CR

OS

E_V

SS

LIM

PH

S_L

CK

DE

MO

D_O

UTC4M

DE

MO

D_H

F

C1M

C2M

C3M

TESTAIOUT

MLPD_CR

FREFGND

GOLD_VSS

CEXCLK

COL

DATA

BROWN_VCCBRP_OFF

PR

E_A

GC

GREEN_VSSMIX_BYP

MIX_INPREAMP_OUT

GREEN_VCC

C3PC4P

BLUE_VSS

C1PC2P

BLUE_VCC

TE

ST

DV

PP

PR

E_I

N

RE

D_V

CC

RE

D_V

SS

RS

SI_

FLT

RS

SI_

OU

T

EM

IT

EX

TB

S

GO

LD_V

CC

AF

C

BA

SE

U301

8 931 2 54

11

6

10

7

12

1615

24

2120

14

1918

13

17

2223

48

4342

4647

41

3837

44

4039

45

32 2530 2931 262736 28333435

0.15uF

15pF

C338

C361.01uF

RSSI

C3280.1uF

R3143K

R5

330R313

C355

C337100pF

.022uFC356

C326.01uF

L3142.2uH

C3360.1uF

Vdd_FILTERED

C3421uF

C3411uF

C3401uF

1uFC339

LVZIF BTM SHEILDCRYSTAL FILTER SHIELD LVZIF TOP SHEILD

SH322SHIELD

SH321SHIELD

SH323SHIELD

Q3203

212pFC352

1

C35343pF

0R355

R3203.9K

2.2uHL325

R34656K

47pFC354

2KR324

CR310

C385

56pF 100nHL332

1KR321 R322

200K8200pFC364C362

0.1uF

C3631uF

C38456pF10K

R345

C360.022uF

680nHL330

C33010pF

C327100pF

2.4KR312

Q302R3510

R31512K

.01uFC325

30KR311

3.3KR352

XTALFL301

TBD

OUTIN

GN

DG

ND

1G

ND

2G

ND

3

36

1 2 4 5

IF

C323150pF

L311750nH

20pFC324

FL0830743O

Figure 9-31. UHF (403-470 MHz) Receiver Back End Schematic Diagram


GND3

2

NC

1 4

U210

VCC5

GND3

2

NC

1 4

VCC5

U211C2960.1uF

C265NU 100pF

C257

A2A3

K1K2K3

A1

CR201

54

6123

C258.01uF

.01uFC259

C230100pF 1000pF

C2294.7uFC228

C2190.22uF

0.1uFC292

C2980.1uF

L2022.2uH

(SOURCE)5V

0.47uFC291

0.1uFC223

2.2uFC235

246

53

1U247

GN

D

INSD

NROUTERR

C2930.47uF100pF

C294

L2032.2uH

SWB+

Vdda

U248

ON

_OF

F*

VIN

GND

VO

UT

NC

3 1

5

2

4

C277100pF 2.2uF

C278

4V_3.3V

C2330.1uFR255

4.3K

C2792.2uF

.047uFC232

C234

0.47uFR231120

R25630

R5

0.1uFC231

620R232

R233560

12uHL232

1

3

Q210

2

4

5V

100pFC260

AUX3AUX4

LOCK

C213100pF

TP201

XTAL1XTAL2

VMULT1VMULT2VMULT3VMULT4

MODOUTFREFOUT

AUX4

AUX1AUX2AUX3

2324

15141211

1941

48123

TEST2

WARP

SFOUT

TEST1

IADAPT

INDMULT

IOUT

LOCKADAPTSW

25

28

3738

45

16

43

446

VC

PV

RO

PR

E_V

DD

PD

_VD

D

DV

DD

AV

DD

47135 34 3620

VBPASSPVREF

SFIN

MODIN

BIAS1BIAS2

CEXCLK

DATA

2135

30

10

4039

98

7

REFSEL

SFBASESFCAP

NC1NC2NC3

PREIN

CCOMP

18

2726

172931

32

42

PD

_GN

DP

RE

_GN

D

DG

ND

AG

ND

44336 22

U201

C204

100KR202

82KR201

100pFC211

C214100pF

DATAMODIN

2.2uF

100pFC264

39nHL261

C2630.75pF

PRESC

100pFC210

C212100pF

CSXCLK

VSF

1000pF

C202C201100pF 4.7uF

C203

SH201SHIELD

SYNTHESIZER TOP SHIELD

SH202SHIELD

SYNTHESIZER BOTTOM SHIELD

R20447K

CR203

45J49FL201

GND

3

IN1

OUT2

C2081.6pF

C20756pF

C206330pFNU

R281

VCTRL

470pFC238

TP202

0.1uFC224

2.2uFC217 C218

0.1uF 100pFC220

2.2uHL201

16.8MHz

FL0830744O

Figure 9-32. UHF (403-470 MHz) Synthesizer Schematic Diagram


33nHL273

390nHL281

100pFC281

240R245

2.2uFC276

NUC272

0.1uFC273

C2860.1uF

L27168nH

RX_SW

TX_SW

PRESC

NUC271

TX_SWITCH

VC

C_B

UF

FE

RS

VC

C_L

OG

IC

RX_OUT

RX_SWITCH

SUPER_FLTR

TRB_IN

TX_BASETX_EMITTER

TX_IADJTX_OUT

FLIP_IN

GN

D_B

UF

FE

RS

GN

D_F

LAG

GN

D_L

OG

IC

PRESC_OUTRX_BASE

RX_EMITTER

RX_IADJ

COLL_RFINU241

11 917

10

13

8

7

12

23

19

1615

1

4

20

56

1418

SHIELDSH242SH241

SHIELD

VCO TOP SHIELD VCO BOTTOM SHIELD

R2601K

C297.01uF

4

1

3Q260

2AUX3

5V

AUX4

1

3

Q261

2

100pFC289

330R252 R251

18

100pFC255

R2547.5K

1

2

3

3.6pF

L253RESONATOR

C254

P1

P2

P3

C2531.5pF

CR251

10pFC252

C247100pF

30R248

0.1uFC2487.5K

R253

Tx_sw

100pFC251

L25133nH

CR242

L241

CR243

390nHVCTRL

100pFC241

2

CR241

1

3

L282390nH

1

3

2

Q241

VSF

R24412K

R24310K

2.4pFC245

C2442pF

Rx_sw

1

7.5pFC242

7.5pF

C243

C2507.5pF

220nHL242

100pFC246

R24118

R242200

L243RESONATOR

2

3

VSF

C285100pF

TX_INJ

RX_INJ

4

FL0830745O

Figure 9-33. UHF (403-470 MHz) Voltage Controlled Oscillator Schematic Diagram


VL6 VLIM 19

TEM

P30

V10

14

V45

16

17V5EXT

20VAR1

18VAR2

24VAR3

VG

15

22NA

Q11

QX

10

1 RFIN

RS 21

31R

SE

T

RX 23T12

CLK

26

CQ

12

CQ

X13

DA

TA28

F168

9

GND18

GN

D2

25

INT4 U102

AN

O32

BP

OS

27

CE

X29

CI3

CJ5

CL7

C138100pF

CR105

GND

3

1

PO

S

2VOUT

R131

LM50

10KR130

18K

100pFC170

C110100pF

0.1uFC126

.022uFC173

5V

TX_BIAS

RESET

UNSWB+

DATA

CLK

CSX

100pFC122

C105100pF

4

1

3

100pFC132

Q111

2

6

100pFC174

R133

UNSWB+

NU

10K

4.7K

47K

47K

1000pF

C127

L115

C133

390nH1000pF C134

3300pF

C135

.022uF

C166

100pF

L113

C129

5.6nH

6.8pF

100pFC165

.022uFC131

390nHL114

200KR109

100KR132

2pFC169

UNSWB+

RFI

N6

RFO

UT1

7R

FOU

T21

VC

NTR

L14

VD

12

VG

13

VG

2

GND15GND212GND313GND4

8N

C1

9N

C2

10N

C3

15N

C4

16

U101

11G

2

4

9.1pFC120

100pFC121

C150.022uFC151

100pF

C1610.1uF

200R161

100pF

C130C128

.022uF

390nHL112

R1085.6K

L16015.0nH

56pFC160

.022uFC152

UNSWB+

11pFC116

C11710pF

11.03nHL109

4.22nHL108

10R106

100pF

C115

C118

27pF

C125100pF

100pFC295

300R112R110300

20R111

R107

C180

TX_INJ_1

TX_INJ

NU

NU

Microstrip Microstrip1

2

3C111

13.0pFC11236pF

L10733.47nH

0.1R102

L11722.0nH

C113

15pF

BEADE101

C114100pF

C12310uF

200R172

0.1uFC172

C181

Q110 Microstrip

NU

L105C108100pF

390nH

240R170

240R101

C109100pF 7.66nH

L106

UNSWB+

3.3pF

1A1

2A2

K 3

C107 CR102

L10412.39nH

4.7pFC106

RX_IN

CR101

L10212.39nH12.39nH

L101

6.2pFC104C103

13pFC1026.2pF

C101100pF

4GND

1

2

3

J101RF_JACK

C141

TAB5 5

C140

TAB11TAB22

TAB3 3TAB4 4

ANTENNA_NUTJ102

9.75nHL116

HEATSINKH101

POS1

NU

NU

43KR120

100pFC119

100pF

C171R173180K 43K

R171

R174NU

SH100SHIELD SHIELD

SH101

HF SHIELD PA SHIELD

R104

47K

FL0830746O

Figure 9-34. UHF (403-470 MHz) Transmitter Schematic Diagram


UHF (403-470 MHz) Radio Parts List (PCB # 8480450Z13 / 8480587Z05)

CircuitRef


B501 0986237A02 Battery Contact ModuleB503 3980502Z01 Backup battery B+ B504 3980501Z01 Backup battery B- C101 2113740F51 100pFC102 2113740F22 6.2pFC103 2113740F27 10pFC104 2113740F22 6.2pFC105 2113743N50 100pFC106 2113740F19 4.7pFC107 2113740F15 3.3pFC108 2113743N50 100pFC109 2113740F51 100pFC110 2113743N50 100pFC111 2113740F30 13pFC112 2180605Z32 47pFC113 2180605Z16 10pFC114 2113743N50 100pFC115 2113743N30 15pFC116 2113743N38 33pFC117 2113743N37 30pFC118 2113743N50 100pFC119 2113743N50 100pFC120 NOT PLACED GCAM DUMMY PART NUMBERC121 2113743N50 100pFC122 2113743N50 100pFC123 2311049A18 10uFC125 2113743N50 100pFC126 2113743M24 100000pFC127 2113743L17 1000pFC128 2113743M08 22000pFC129 2113743N23 7.5pFC130 2113743N50 100pFC131 2113743M08 22000pFC132 2113743N50 100pFC133 2113743L17 1000pFC134 2113743L29 3300pFC135 2113743M08 22000pFC138 2113743N50 100pFC140 NOT PLACEDC141 NOT PLACEDC150 2113743M08 22000pFC151 2113743N50 100pFC152 2113743M08 22000pFC160 2113743N50 100pFC161 2113743M24 100000pFC165 2113743N50 100pFC166 2113743N50 100pFC169 2113743N20 5.6 pFC170 2113743N50 100pFC171 2113743N50 100pFC172 2113740F51 100pFC173 2113743M08 22000pFC174 2113743N50 100pFC175 2113740L25 20pF

C201 2113743N50 100pFC202 2113743L17 1000pFC203 2311049A56 4.7uFC204 2104993J02 2.2uFC206 2113740F63 330pFC207 2113743N40 39pFC208 NOT PLACEDC210 2113743N50 100pFC211 2113743N50 100pFC212 2113743N50 100pFC213 2113743N50 100pFC214 2113743N50 100pFC217 2104993J02 2.2uFC218 2113743M24 100000pFC219 2113743K16 0.220uFC220 2113743N50 100pFC223 2113743M24 100000pFC224 2113743M24 100000pFC228 2311049J11 4.7uFC229 2113743L17 1000pFC230 2113743N50 100pFC231 2113743M24 100000pFC232 2113743E12 0.047uFC233 2311049A01 0.1uFC234 2311049A05 0.47uFC235 2104993J02 2.2uFC238 2113741F17 470pFC241 2113743N50 100pFC242 2113743N23 7.5pFC243 2113743N23 7.5pFC244 2113740F10 2.0pFC245 2113743N11 2.4pFC246 2113743N50 100pFC247 2113743N50 100pFC248 2113743M24 100000pFC250 2113743N23 7.5pFC251 2113743N50 100pFC252 2113743N26 10pFC253 2113740F09 1.8pFC254 2113743N15 3.6pFC255 2113743N50 100pFC257 2113743N50 100pFC258 2113743L41 10000pFC259 2113743L41 10000pFC260 2113743N50 100pFC263 2113743N02 0.75pFC264 2113743N50 100pFC265 NOT PLACEDC271 NOT PLACEDC272 NOT PLACEDC273 2113743M24 100000pFC276 2104993J02 2.2uFC277 2113743N50 100pFC278 2311049A57 10uFC279 2104993J02 2.2uFC281 2113743N50 100pF

CircuitRef


C285 2113743N50 100pFC286 2113743M24 100000pFC289 2113743N50 100pFC291 2311049A69 10uFC292 2113743M24 100000pFC293 2113743A27 0.470uFC294 2113743N50 100pFC295 2113743N50 100pFC296 2113743M24 100000pFC297 2113743L41 10000pFC298 2113743M24 100000pFC301 2113743N15 3.6pFC302 2113743N26 10pFC303 2113740L08 3.9pFC304 2113743N26 10pFC305 2113743N33 20pFC306 NOT PLACEDC307 2113743M24 100000pFC308 2113743N50 100pFC309 2113743N50 100pFC310 2113743M24 100000pFC311 NOT PLACEDC312 2113743N25 9.1pFC313 2113743N26 10pFC314 2113743M24 100000pFC315 2113743N50 100pFC316 2113740L08 3.9pFC317 2113743N25 9.1pFC318 2113743N23 7.5pFC319 2113743N69 1.8pFC320 2113743N23 7.5pFC321 2113743N50 100pFC322 2113743N48 82pFC323 2113743N54 150pFC324 2113743N33 20pFC325 2113743L41 10000pFC326 2113743L41 10000pFC327 2113743N50 100pFC328 2113743M24 100000pFC329 2113743M24 100000pFC330 2113743N26 10pFC331 2113743N50 100pFC333 NOT PLACEDC334 2113743M08 22000pFC336 2113743M24 100000pFC337 2113743N50 100pFC338 2113743N30 15pFC339 2180478Z20 1uFC340 2180478Z20 1uFC341 2180478Z20 1uFC342 2180478Z20 1uFC343 2113743A23 0.220uFC344 2113743M24 100000pFC345 2113743M24 100000pFC346 2113743M24 100000pFC347 2113743M24 100000pF

CircuitRef


C348 2113743M24 100000pFC349 2113743E07 0.022uFC350 2113743L05 330pFC351 2113743N33 20pFC352 2113743N28 12pFC353 2113743N41 43pFC354 2113743N42 47pFC355 2113743A24 0.330uFC356 2113743M08 22000pFC357 2113743A23 0.220uFC358 2113741A23 1200pFC359 2109720D14 0.1uFC360 2113743E07 0.022uFC361 2113741F49 10nFC362 2113743M08 22000pFC363 2311049A40 2.2uFC364 2113743L41 10000pFC370 2113743N50 100pFC371 NOT PLACEDC372 NOT PLACEDC373 NOT PLACEDC374 2113743N50 100pFC375 2113743N50 100pFC378 NOT PLACEDC380 2113743L41 10000pFC381 2113743N21 6.2pFC382 2311049A59 10uFC383 2113743N50 100pFC384 2113743N44 56pFC385 2113743N44 56pFC386 2113743N50 100pFC390 2113743N50 100pFC391 NOT PLACEDC395 2113743N50 100pFC396 NOT PLACEDC397 2311049A05 0.47uFC400 2113743L41 10000pFC401 2113743M24 100000pFC402 2113743M24 100000pFC403 2113743G24 2.2uFC404 NOT PLACEDC405 NOT PLACEDC406 NOT PLACEDC407 2113928N01 0.1uFC408 2113743N50 100pFC409 2113743M24 100000pFC410 2113928N01 0.1uFC411 2113743M24 100000pFC414 2113743M24 100000pFC415 2185895Z01 0.01uFC416 2113928N01 0.1uFC419 NOT PLACEDC420 2113743L41 10000pFC421 2113928N01 0.1uFC422 2113743M24 100000pFC423 2113743N50 100pF

CircuitRef



C424 2311049A59 10uFC425 2113743M24 100000pFC426 2113743N50 100pFC427 2113743N50 100pFC428 2113743M24 100000pFC429 2113743M24 100000pFC430 2113928N01

0662057M010.1uF0 (SUB on LS+ Models Only)

C431 2113743N50 100pFC432 NOT PLACEDC433 2113743L41 10000pFC434 2113928N01 0.1uFC435 2113743M24 100000pFC436 2113743N34 22pFC437 2113743N34 22pFC440 2113743G26 4.7FC441 2113743N50 100pFC442 2113743E20 0.10uFC443 2113928N01 0.1uFC444 2113743N50 100pFC445 2113743N50 100pFC447 2113743M08 22000pFC448 2113928N01 0.1uFC449 2113743N50 100pFC450 NOT PLACEDC451 2113743M08 22000pFC452 2113743B29 1uFC453 2113743N50 100pFC456 2113743N50 100pFC458 2113743N50 100pFC459 2113743N50 100pFC463 2113743N50 100pFC466 2113743N50 100pFC467 2113928N01 0.1uFC471 2113743N50 100pFC472 2113743L09 470pFC473 2113743L09 470pFC475 2113743H14 10uFC476 2113928D08 10uFC479 2113928N01 0.1uFC480 2113928D08 10uFC481 2113928N01 0.1uFC482 2113928N01

0662057M010.1uF0 (SUB on LS+ Models Only)

C490 2113743N50 100pFC491 2113743N50 100pFC492 2113743N50 100pFC493 2113743N50 100pFC494 2113743N50 100pFC495 2113743N50 100pFC496 2113743N50 100pFC497 2113743N50 100pFC502 2311049A05 0.47uFC503 2113743N50 100pFC505 2113743N50 100pFC511 2113743N50 100pF

CircuitRef


C512 2113743N50 100pFC513 2113743N50 100pFC514 2113743N50 100pFC520 2113743L41 10000pFC521 2113743L41 10000pFC522 2113743L41 10000pFC523 2113743L41 10000pFC524 2113743N50 100pFC525 2113743N50 100pFC526 2113743N50 100pFC527 2113743N50 100pFC528 2113743N50 100pFC529 2113743N50 100pFCR101 4880973Z02 Pin diodeCR102 4802245J41 Pin diodeCR103 4802245J41 Pin diodeCR105 5185963A15 Temperature sensorCR160 NOT PLACEDCR201 4802233J09 Triple diode (SOT 25)CR203 4862824C03 VaractorCR241 4805649Q13 VaractorCR242 4862824C08 VaractorCR243 4862824C08 VaractorCR251 4802245J22 VaractorCR301 4862824C08 VaractorCR302 4862824C08 VaractorCR303 4880154K03 Dual common anode-cathode

diodeCR304 4862824C08 VaractorCR305 4862824C08 VaractorCR306 4802245J42 Ring Quad diode (SOT-143) CR308 4802245J41 Pin diodeCR310 4862824C08 VaractorCR411 4802245J62 Diode SchottkyCR412 4802245J62 Diode SchottkyCR413 4802245J62 Diode SchottkyCR440 4813833C02 Dual common cathode diodeCR501 4880107R01 RectifierCR503 4805729G49 LED Red/YellowE101 2484657R01 Ferrite beadE400 2480640Z01 Ferrite beadE401 2480640Z01 Ferrite beadE402 2480640Z01 Ferrite beadE403 2480640Z01 Ferrite beadE404 2480640Z01 Ferrite beadE405 2480640Z01 Ferrite beadE406 2480640Z01 Ferrite beadE407 2480640Z01 Ferrite beadE408 2480640Z01 Ferrite beadE409 2480640Z01 Ferrite beadF501 6580542Z01 3A fuseFL201 4805875Z04 16.8 MHz Xtal oscillator (not field

serviceable)FL301 4802245J43 Xtal Filter 45.1 MHzFL401 4870368G02 Xtal Oscillator 38.4 kHzH101 2680499Z01 Heat spreader

CircuitRef


J101 0985613Z01 RF JackJ102 0280519Z02 Antenna nutJ400 0905505Y04 40-pin connectorJ403 0905505Y02 20-pin connectorL101 2479990B02 19.61nHL102 2479990B02 19.61nHL104 2479990B02 19.61nHL105 2462587N22 390nHL106 2479990A02 7.66nHL107 2479990G01 33.47nHL108 2479990A01 4.22nHL109 0662057C01 0L112 2462587N45 22nHL113 2413926H09 5.6nHL114 2462587N45 22nHL115 2462587N22 390nHL116 2479990A03 9.75nHL160 2413926H14 15nHL201 2462587Q20 2200nHL202 2462587Q20 2200nHL203 2462587Q20 2200nHL232 2462587P25 12000nHL241 2462587V41 390nHL242 2462587V38 220nHL243 2460593C01 Multi-layered Teflon resonator, RxL251 2462587V28 33nHL253 2460593C02 Multi-layered Teflon resonator, TxL261 2462587V29 39nHL271 2462587V32 68nHL273 2462587V28 33nHL281 2462587V41 390nHL282 2462587V41 390nHL301 2479990C01 13.9nHL302 2479990C01 13.9nHL303 2462587V26 22nHL304 2462587V37 180nHL305 2462587V26 22nHL306 2479990C01 13.9nHL307 2479990C01 13.9nHL309 2479990C02 16.28nHL310 2462587V36 150nHL311 2462587N65 750nHL314 2462587N72 2200nHL321 NOT PLACEDL325 2480646Z20 2.2uHL330 2462587N64 680nHL331 2480646Z20 2.2uHL332 2462587N53 100nHL340 2462587V41 390nHL400 2462587Q42 390nHL401 2462587Q42 390nHL410 2462587Q42 390nHL411 2462587Q42 390nHL505 2462587Q42 390nHP100 3905643V01 Ground contact fingerPB501 4080523Z01 Tactile switch, pushbutton

CircuitRef


PB502 4080523Z01 Tactile switch, pushbuttonPB503 4080523Z01 Tactile switch, pushbuttonPB504 4080523Z01 Tactile switch, pushbuttonPB505 4080523Z01 Tactile switch, pushbuttonQ110 4813828A09 RF PAQ111 4802245J50 Dual NPN/PNP transistorQ210 4802245J50 Dual NPN/PNP transistorQ241 4805218N63 RF NPN transistorQ260 4802245J50 Dual NPN/PNP transistorQ261 4802245J50 Dual NPN/PNP transistorQ301 4802245J44 NPN TransistorQ302 4802245J44 NPN TransistorQ310 NOT PLACEDQ315 4880214G02 NPN Q316 NOT PLACEDQ320 4805218N63 RF NPN transistorQ400 4809579E18 Mosfet P - channelQ403 4813824A17 Bipolar Transistor, PNPQ405 4802245J54 Dual NPN TransistorQ410 4802245J54 Dual NPN TransistorQ416 4809579E18 Mosfet P - channel Q417 4802245J50 Dual NPN/PNP transistorQ502 5180159R01 DUAL TRANS NPNSQ505 4880214G02 NPN R101 0662057A34 240R102 0680539Z01 0.1R103 0662057M41 43R104 0662057N15 47kR106 0662057M26 10R107 NOT PLACEDR108 0662057M92 5600R109 0662057N30 200k R110 0662057M61 300R111 0662057M33 20R112 0662057M61 300R120 0662057N14 43k R130 0662057M98 10k R131 0662057N05 18kR132 0662057N33 270kR133 NOT PLACEDR136 0662057N47 1MR161 0662057M57 200R170 0662057A34 240R171 0662057N14 43k R172 0662057A32 200R173 0662057N29 180k R174 0662057N15 47kR175 0662057B67 6.2R176 0662057B67 6.2R201 0662057N21 82kR202 0662057N23 100kR204 0662057N15 47kR231 0662057M52 120R232 0662057M69 620R233 0662057M68 560R241 0662057M32 18

CircuitRef



* Motorola Depot Servicing only

R242 0662057M57 200R243 0662057M98 10k R244 0662057N01 12kR245 0662057M59 240R248 0662057M37 30R251 0662057M32 18R252 0662057M62 330R253 0662057M95 7500R254 0662057M95 7500R255 0662057M89 4300R256 0662057M37 30R260 0662057M74 1000R281 NOT PLACEDR300 0662057M82 2200R301 0662057N23 100kR302 0662057N23 100kR303 0662057M74 1000R304 0662057N01 12kR305 0662057M67 510R306 0662057N23 100kR307 0662057N23 100kR308 0662057M60 270R309 0662057M32 18R310 0662057M60 270R311 0662057N10 30kR312 0662057M83 2400R313 0662057M62 330R314 0662057M85 3000R315 0662057N01 12kR316 0662057A96 91KR317 0662057M74 1000R318 0662057A79 18R319 0662057A29 150R320 0662057M74 1000R321 0662057M83 2400R322 0662057N30 200k R324 0662057M81 2000R325 0662057M94 6800R326 NOT PLACEDR327 0662057N11 33kR328 0662057M12 2.7R329 0662057M01 0R330 NOT PLACEDR331 NOT PLACEDR332 NOT PLACEDR333 NOT PLACEDR334 NOT PLACEDR335 NOT PLACEDR336 NOT PLACEDR338 NOT PLACEDR339 0662057M01 0R340 0662057M94 6800R342 0662057N23 100kR343 0662057M26 10R344 0662057N01 12kR345 0662057M98 10k

CircuitRef


R346 0662057N17 56kR347 0662057M74 1000R348 0662057M87 3600R349 0662057C01 0R350 0662057N23 100kR351 0662057C01 0R352 0662057M86 3300R355 0662057M01 0R400 0662057N15 47k R401 0662057M01 0R402 NOT PLACEDR403 NOT PLACEDR405 0662057M01 0R406 0662057N20 75k R407 0662057N19 68k R408 NOT PLACEDR409 0662057M98 10k R410 0662057N23 100k R411 0662057M98 10k R413 0662057M01 0R414 0662057V34 180k R415 0662057V26 91kR416 0662057M98 10k R418 0662057M01 0R419 0662057M67 510R420 0662057B46 10MR421 0662057M81 2000R423 0662057N39 470k R424 0662057N12 36kR425 0662057N10 30kR426 0662057N35 330kR427 0662057M84 2700R428 0662057M10 2.2R429 0662057M98 10k R431 0662057N39 470k R432 0662057N16 51kR434 0662057M62 330 OhmR435 0662057M81 2k OhmR436 0662057M01 0R445 0662057N08 24kR447 0662057N23 100k R448 0662057M98 10k R449 0662057N08 24kR450 0683962T45 68 ohms, 1WR451 0662057N03 15kR452 0662057N23 100k R453 NOT PLACEDR454 NOT PLACEDR455 NOT PLACEDR456 0662057M01 0R457 0662057M98 10k R460 0662057M90 4700R461 0662057M56 180R462 0662057M98 10kR463 0662057M61 300R471 0662057N06 20k

CircuitRef


R472 0662057N12 36kR473 0662057M26 10R475 0662057M01 0R476 0662057N35 330kR477 0662057M74 1000R478 0662057M98 10k R481 0662057N08 24kR492 0662057M01 0R498 0662057M98 10kR499 0662057M98 10kR501 0662057M70 680R502 0662057M56 180R505 0662057M98 10kR506 0662057N15 47k R507 0662057M01 0RT300 0680590Z01 THERMISTOR_33KRT301 NOT PLACEDRT400 0680590Z01 THERMISTOR_33KS501 4080710Z01 Frequency switchS502 1880619Z02 Volume/on-off switchSH100 2680507Z01 Harmonic Filter shieldSH101 2680510Z01 RF PA shieldSH201 2680511Z01 Synthesizer top shieldSH202 2680511Z01 Synthesizer bottom shieldSH241 2680513Z01 Resonators shieldSH242 2680514Z01 VCO Buffer IC shieldSH301 2680554Z01 Receiver front end shieldSH302 2680555Z01 Receiver front end bottom shieldSH303 2680509Z01 Mixer shieldSH304 2680624Z01 Mixer diode shieldSH321 2680508Z01 LVZIF 2nd LO shieldSH322 2680514Z01 LVZIF shieldSH323 2680553Z01 Crystal Filter shieldSH400 2680505Z01 Controller Memory ShieldSH401 2680506Z01 Controller on-off shieldSH402 2680515Z01 Microprocessor shieldSH403 2680516Z01 Asfic_Cmp/Audio PA shieldT301 2580541Z01 Balun transformerT302 2580541Z01 Balun transformerU101 5185130C65 VHF/UHF/800 MHZ LDMOS

DRIVERU102 5185765B28 PCICU201 5185963A27 LVFRACN Synthesizer ICU210 5102463J61 InverterU211 5102463J61 InverterU241 5105750U54 VCO BUFFER ICU247 5105739X05 SOT 5V RegulatorU248 5102463J58 3.3V RegulatorU301 5109632D83 LVZIF ICU400 5102463J40 3.3V RegulatorU404 5185963A53 ASFIC_CMP ICU405 NOT PLACEDU406 *5102463J59 Flash ROM 128K x 8U407 *5102463J64 16K x 8 EEPROMU409 5102226J56 MicroprocessorU410 5102463J57 3.3V Regulator

CircuitRef


U420 5102463J44 Audio PAVR432 4805656W08 5.6V ZenerVR433 4805656W08 5.6V ZenerVR434 4802245J73 ZENER DIODE-6.8VVR439 4880140L17 Zener diode-12VVR440 4802245J73 ZENER DIODE-6.8VVR441 4802245J73 ZENER DIODE-6.8VVR442 4802245J73 ZENER DIODE-6.8VVR443 4802245J73 ZENER DIODE-6.8VVR444 4802245J73 ZENER DIODE-6.8VVR445 4802245J53 ZENER_DIODE-10VVR446 4802245J74 ZENER DIODE-10VVR447 4802245J74 ZENER DIODE-10VVR448 4802245J74 ZENER DIODE-10VVR449 4802245J74 ZENER DIODE-10VVR450 4802245J75 ZENER DIODE-12VVR460 4802245J73 ZENER DIODE-6.8VVR501 4813830A18 6.8V ZenerVR506 4802245J73 ZENER DIODE-6.8V

1485777Z01 INSULATOR (KAPTON)8480450Z13 UHF B1 main PC board

CircuitRef


chapter 9 schematic diagrams, overlays, and parts...

Documents