Continuing Airworthiness
Objectives
To provide an overview of EASA Part M(g) as applicable to CAT operators
• Continuing Airworthiness Management Organisation approval
• The ‘Controlled Environment’
• Airworthiness Review Certificates (ARC)
2
Regulation Overview
3
Commission Regulation
(EC) No 1321/2014, as amended
(Continuing Airworthiness)
Annex I – Part M
Annex II – Part 145
Annex III – Part 66
Annex IV – Part 147
Council Regulation (EC) No 216/2008
(Basic Regulation)
Annex I - Essential Requirements
Annex II - Excluded Aircraft
Annex III – Pilot Licensing
Annex IV – Air Operations
Established
by the
European
Parliament
AMC & GM
(Continuing
Airworthiness)
EASA
(The Agency)
Commission Regulation
(EC) No 748/2012, as amended
(Certification)
Annex I - Part 21(Includes Noise and
Environmental Requirements)
Implementing
Rules
Articles
5 & 6
of
Basic
Regulation
Acceptable
Means
of Compliance
(AMC) & GM
(Certification)
Article
19
of
Basic
Regulation
Not Binding
in EU Law
Established
by the
European
Commission
Binding in
EU Law
Certification Specifications
Airworthiness Codes
+ associated AMC & GM(Certification &
Continuing Airworthiness)
Part M – Section A
• Subpart A – General• Subpart B – Accountability• Subpart C – Continuing Airworthiness• Subpart D – Maintenance Standards• Subpart E – Components• Subpart F – Maintenance Organisation• Subpart G – Continuing Airworthiness
Management Organisation
• Subpart H – Certificate of Release to Service• Subpart I – Airworthiness Review Certificate
4
Responsibilities1) The operator is responsible for the continuing airworthiness of an
aircraft and shall ensure that no flight takes place unless:
2) The aircraft is maintained in an airworthy condition; and
3) Any operational, emergency equipment systems fitted are correctly installed and serviceable or clearly identified as unserviceable; and
4) The airworthiness review certificate remains valid; and
5) All aircraft maintenance is performed in accordance with the Approved Maintenance Programme.
5
Responsibilities
• The operator shall be responsible for the satisfactory accomplishment of the pre-flight inspection.
• Maintenance of large aircraft, aircraft used for commercial air transport and their components shall be carried out by Part-145 approved maintenance organisations.
6
Responsibilities
Responsibilities
For holders of an Air Operators Certificate (AOC)
• Must be approved to Part M subpart G, for the aircraft it operates (as part of the AOC)
• Be approved to Part 145 or have a contract with one9Copyright © 2011 CAA International Ltd Part M; V01
Occurrence Reporting
Any person or organisation responsible under M.A.201 shall report any identified condition of an aircraft or component which endangers flight safety to the following:
i. Competent authority of the state of registry
ii. TC / STC holder
iii. Member state of operator
iv. Report to the owner, the operator or managing CAMO
Reports shall be made as soon as practical but within 72 hours
10
Continuing Airworthiness
The aircraft CAW and the serviceability of both operational and emergency equipment shall be ensured by:
1) The accomplishment of pre-flight inspections
2) The rectification of any defect and damage affecting safe operation taking in to account the MEL.
3) The accomplishment of all maintenance, in accordance with the approved Aircraft Maintenance Programme (AMP)
4) The analysis of the effectiveness of the AMP
11
Continuing Airworthiness
12
The AMP must establish compliance with:
a) Instructions issued by the competent authority,
b) Instructions for CAW (ICAW)
issued by TC, Restricted TC
and STC holders, major
repair design approval,
ETSO authorisation and any
other relevant approval
holder that publishes such
data
Continuing Airworthiness
13
c) This may include:
▪ Lubrication tasks
▪ Inspection tasks
(E.G: GVI, DVI or NDT)
▪ Component tasks
▪ Operational /Functional
checks
▪ Life limitations
Continuing Airworthiness
14
5) The accomplishment of any applicable:
i. Airworthiness Directive
(a) State of Design Airframe, Engine, Propeller, Equipment.
(b) State of Design for STCs
(c) EASA
(d) State of Registry
Continuing Airworthiness
15
5) The accomplishment of any applicable:
ii. Any Operational directive with a continuing airworthiness impact
iii. Continued airworthiness requirement established by the EASA
iv. Measures mandated by the competent authority in immediate reaction to a safety problem
Continuing Airworthiness
16
6) The accomplishment of modifications and repairs in accordance with M.A.304
7) For non-mandatory modifications and/or inspections, the establishment of an embodiment policy
8) Maintenance check flights when necessary
Continuing Airworthiness
17
Continuing Airworthiness
18
Continuing Airworthiness
• The aircraft CAW records shall consist of, as appropriate,
• An aircraft logbook
• Engine logbook(s) or engine module log cards,
• Propeller logbook(s)
• Log cards for any service life limited
component
• Component authorised release
document i.e EASA form 1
19
Continuing Airworthiness
Operator’s technical log system
a) Shall contain the following information:
1) Flight safety information
2) Current CRS
3) Current maintenance statement
4) Outstanding deferred defects (ADDs)
5) Maintenance support arrangements
20
Continuing Airworthiness
Operator’s technical log system (cont)
b) Operators technical log system and subsequent amendments shall be approved by the authority
c) Operator shall ensure the technical log is retained for 36 months after the last entry.
21
Continuing Airworthiness Management
Exposition (CAME)
The CAME contains 7 parts
Part 0 - General Organisation (Including corporate commitment)
Part 1 - Continuing Airworthiness Management Procedures
Part 2 - Quality System
Part 3 - Contracted Maintenance
Part 4 - Airworthiness Review Procedures
Part 4B – Permit to Fly Procedures
Part 5 - Appendices
22
FacilitiesThe CAMO shall provide suitable office accommodation at appropriate locations
23
Personnel Requirements1) Accountable Manager.
2) Management personnel.
3) For CAT, a ‘nominated post holder’ responsible for management and supervision of CAW activities.
4) All persons shall be able to show relevant knowledge, background and appropriate experience relating to aircraft CAW
5) For CAT and Large aircraft, the organisation is required to establish and control the competence of all personnel involved in continuing airworthiness management, airworthiness reviews and / or quality audits.
24
Example Organisation Structure
25
Accountable
Manager
Nominated
post holder
Quality
Assurance
TechnicalContracts PlanningRecords
Airframe Engines Avionics
Nominated
post holder for
CAW required
for CAT
Airworthiness Review Staff
26
To be approved to carry out airworthiness reviews, a CAMO shall have appropriately qualified airworthiness review staff to issue ARCs or make recommendations and if applicable to issue a Permit to Fly
Continuing Airworthiness Management
27
All continuing airworthiness management shall be carried out according to the prescriptions of M.A. Subpart C.
1) Develop and control a maintenance programme for the aircraft managed including any applicable reliability programme;
2) Present the aircraft maintenance programme and its amendments to the competent authority for approval
3) Manage the approval of modifications and repairs
Continuing Airworthiness Management
28
4) Ensure that all maintenance is carried out in accordance with the approved maintenance programme and released by Part 145 approved maintenance organisations;
5) Ensure that all applicable airworthiness directives and operational directives with a continuing airworthiness impact, are applied;
6) Ensure that all defects discovered during scheduled maintenance or reported are corrected by an appropriately approved maintenance organisation;
Continuing Airworthiness Management
29
7) Ensure that the aircraft is taken to an appropriately approved maintenance organisation whenever necessary;
8) Co-ordinate scheduled maintenance, the application of airworthiness directives, the replacement of service life limited parts, component inspection and to ensure the work is carried out properly;
9) Manage and archive all continuing airworthiness records and the operator's technical log;
10) Ensure that the mass and balance statement reflects the current status of the aircraft.
Airworthiness Review
To ensure the validity of the airworthiness certificate, an AR shall be carried out periodically.
1) Review of aircraft records
2) Physical survey of aircraft
Note: Airworthiness Review tasks cannot be sub-contracted
30
Airworthiness Review
31
A full documented review of the aircraft records to be satisfied that:
1) airframe, engine and propeller hours / cycles have been properly recorded
2) the flight manual is up to date and reflects the A/C configuration
3) all due maintenance has been carried out iaw AMP
4) all known defects rectified or appropriately carried forward
5) all applicable ADs have been applied / recorded
Airworthiness Review
32
6) all modifications and repairs are approved and correctly
applied, and;
7) all service life limited components installed are within
the approved life limits, and;
8) all maintenance has been correctly released, and;
9) the current mass and balance statement reflects the
configuration of the aircraft and is valid, and;
10) the aircraft complies with the latest revision of its
approved type design, and;
11) if required, the aircraft holds a noise certificate
corresponding to the configuration of the aircraft
Airworthiness Review
33
The approved airworthiness review staff shall carry out a
physical survey of the aircraft.
If the airworthiness
review staff are not
appropriately qualified to
Part-66 they shall be
assisted by someone
that is.
Airworthiness Review
34
The physical survey of the aircraft shall ensure that:
1) all required markings and placards are properly installed,
2) the aircraft complies with its approved flight manual,
3) the aircraft configuration complies with the approved
documentation,
4) no evident defect can be found that has not been
appropriately addressed,
5) no inconsistencies can be found between the aircraft and
documented records
Privileges of the Organisation
A1) Manage the continuing airworthiness of non-CAT aircraft as listed on the approval certificate and CAT aircraft when listed on both the approval certificate and AOC.
A2) Arrange to carry out limited CAW tasks with any organisation working under under its quality system as listed on the approval certificate. (sub-contracting)
A3) Extend any ARCs issued by the CAA or by another appropriately approved CAMO (subject to meeting the applicable requirements of subpart I)
35
Privileges of the Organisation
B1) Issue an Airworthiness Review Certificate (ARC) and extend it in accordance with Subpart I.
B2) Make a recommendation to the competent authority of the state of registry to issue an ARC
C) Issue Permits to Fly in accordance with Part 21
Note: Privileges - APrivileges - A + BPrivileges - A + B + C
36
Quality System
To ensure CAMO continues to meet the requirements of Part M, it shall establish a Quality System and designate a Quality Manager to monitor compliance with and adequacy of procedures required to ensure an airworthy aircraft.
37
Accountable
Manager
Nominated
post holder
Quality
Assurance
Compliance monitoring
shall include a feedback
system to the Accountable
manager to ensure
corrective action as
necessary
Quality System
The Quality System shall monitor:
• Compliance with Part M
• Maintenance is carried out iaw the contract
• CAW activities performed iaw approved procedures
Records shall be kept for at least two years
38
Quality System
The Quality System can be combined with another approval. (e.g. Part-145)
In the case of Commercial Air Transport, the Quality System shall be an integrated part of the operators quality system.
39
Quality System
Subpart
GAOC
Changes to the Organisation
The CAMO shall inform the competent authority (CAA) of any of the following changes• Name of organisation• Location of organisation• Additional locations• Accountable manager• Management personnel• Scope of work, facilities, staff, procedures that
could effect the approval
40
Record Keeping
The CAMO record all details of work carried out.
• Records required by M.A.305 & 306
• A copy of each ARC issued, recommended or extended including supporting documents
• Retain records for up to 24 months after the A/C is permanently withdrawn from service
• Records protected from damage, theft and alteration
• Computer back-ups stored in a different location from the working data
41
Airworthiness Review Certificate
To ensure the aircraft remains airworthy, a review of the aircraft and its records must be carried out periodically.
42
Patch
repair
Airworthiness Review CertificateThe ‘Controlled Environment’
• An aircraft in a controlled environment is an aircraft continuously managed by a unique M.A. Subpart G approved continuing airworthiness management organisation in the previous 12 months, and;
• Which has been maintained for the previous 12 months by approved maintenance organisations (Part 145).
43
Airworthiness Review Certificate
• An Airworthiness Review Certificate is valid for 12 months.
• Aircraft in a controlled environment may have the ARC extended twice and only require a full airworthiness review to be carried out every three years.
• Aircraft that are not in a controlled environment, the ARC cannot be extend, a full airworthiness review will be required every year.
• An ARC can only be issued or extended if the aircraft remains airworthy.
44
Aircraft Airworthiness Review Pattern
45
A/C in Controlled Environment
AR Extend
12 Months
Extend
12 Months
AR
12 Months
A/C not in a Controlled Environment
AR AR
12 Months12 Months
AR
12 Months
AR
Aircraft Airworthiness Review Pattern
46
To allow the physical review to take place during a maintenance check, the
airworthiness review can be anticipated by a maximum period of 90 days
without loss of continuity.
AR
12 Months 12 Months 12 Months
Extend Extend
90 Days
30 Days
It is acceptable to anticipate the extension of the ARC by a maximum of 30
days without a loss of continuity of the airworthiness review pattern, which
means that the new expiration date is set up one year after the previous
expiration date. If the ARC is extended after its expiry, the new expiry date
is the same as it would have been if extended at the correct time
47
ARC valid for
twelve months
Statement to confirm
aircraft is airworthy and
in a controlled
environment (1st
extension)
Statement to confirm
aircraft is airworthy and
in a controlled
environment (2nd
extension)
Continuing Airworthiness Management Organisation Approval
48
Summary1) Part M Subpart G is an approval to manage aircraft
continuing airworthiness. The privilege can also be extended to include the issue of Airworthiness Review Certificates (or making recommendations to the CAA for the issue of Airworthiness Review Certificates) and the issue of Permits to Fly.
2) All Cat aircraft must be managed by a Subpart G organisation that is part of the AOC.
3) All maintenance must be performed by Part 145 approved organisations
49
Summary
4) The Quality system of the Subpart G must be an integral part of the operators Quality system.
5) An Airworthiness Review Certificate for all aircraft can only be extended by an appropriately approved) Subpart G organisation, when the aircraft has remained within their controlled environment.
50
Questions?