Download - Power Suppy Unit
-
7/25/2019 Power Suppy Unit
1/15
POWER SUPPY UNIT
-
7/25/2019 Power Suppy Unit
2/15
POWER SUPPY UNIT
A power supplyis an internalhardware component that suppliescomponents in a computer with power.The power supply converts a 110-115 or
220-230 volt alternating current (ACinto a steady low-voltage direct current(!C usa"le "y the computer and rated
"y the num"er o# watts it generates.
http://www.computerhope.com/jargon/a/ac.htmhttp://www.computerhope.com/jargon/d/dc.htmhttp://www.computerhope.com/jargon/d/dc.htmhttp://www.computerhope.com/jargon/a/ac.htm -
7/25/2019 Power Suppy Unit
3/15
POWER SUPPY UNIT
-
7/25/2019 Power Suppy Unit
4/15
COMPONENTS OF POWER SUPPLY UNITTransformer
The transformer is a static device that transfers electrical energyfrom the primary winding to the secondary winding withoutaffecting the frequency. It is used to step-up or step-down the acvoltage level and isolates the remainder of the electronic systemfrom the ac power.
RectifierThe rectifier is a device used to change the ac power into pulsatingdc. The basic rectifier is the diode. The three basic rectifier circuitsusing diodes are the half-wave, full-wave center-tapped and full-wave bridge type.
FilterThe filter of the power supply is used to keep the ripple componentfrom appearing in the output. It is designed to convert pulsatingDC from rectifier circuits into a suitably smooth dc level. The twobasic types of power supply filters are the capacitance filter (C-filter) and RC-filter.
-
7/25/2019 Power Suppy Unit
5/15
COMPONENTS OF POWER SUPPLY UNIT
Voltage RegulatorsA voltage regulator is designed to provide a very steady orwell regulated dc output.
-
7/25/2019 Power Suppy Unit
6/15
POWER SUPPLY UNIT
$epa %-1&00ma (2015 model'C 'ower and Coolingilencer )50 (200) model
-
7/25/2019 Power Suppy Unit
7/15
TRASFORMER
$epa %-1&00ma (2015 model 'C 'ower and Cooling
ilencer )50 (200) model
Silencer is a single
transformer design cooled by
an 80mm fan and a pair of
massive heatsinks.
The main transformer has highdensity it easily copes with thetask.
-
7/25/2019 Power Suppy Unit
8/15
RECTIFIER
$epa %-1&00ma (2015 model 'C 'ower and Cooling
ilencer )50 (200) model
It uses one GBJ1506 rectifyingbridge in its primary, which candeliver up to 15 A (rated at 100C). As you can see in Figure 9this bridge is attached to aheatsink.
The single bridge rectifier isbolted on a dedicated heatsink.Its model number isLL25XB60
and it can handle up to 25A ofcurrent.
http://www.shindengen.co.jp/product/semi/datasheet/J534_LL25XB60.pdfhttp://www.shindengen.co.jp/product/semi/datasheet/J534_LL25XB60.pdf -
7/25/2019 Power Suppy Unit
9/15
CAPACITOR
$epa %-1&00ma (2015 model 'C 'ower and Cooling
ilencer )50 (200) model
Rated at 400v 400uF
Rated at 400V, 330F, 105C
-
7/25/2019 Power Suppy Unit
10/15
FILTER
$epa %-1&00ma (2015 model
The AC receptacle incorporates a complete line filter(YO15T1) and reinforce it with two additional Y caps. Thetransient filter continues on the main PCB with three CMchokes, one X and two Y caps and an MOV.
-
7/25/2019 Power Suppy Unit
11/15
FILTER
'C 'ower and Cooling ilencer )50 (200) model
It providing two extra Y capacitors, one extra ferrite coil, one extraX capacitor and a ferrite bead attached to the main AC cable. Thispower supply also provides an X capacitor after the rectifyingbridge.
-
7/25/2019 Power Suppy Unit
12/15
PCB
$epa %-1&00ma (2015 model
These two small PCBs house some interesting components. On the
right one the PFC controller anICE2PCS01and anLM393voltagecomparator, which assists in overvoltage and undervoltageprotection, are installed. On the left PCB resides aUCC28950IC
which is the controller responsible for the main switchers and theother IC on this board is aUCC27324, a high speed low-side power
mosfet driver.
http://www.infineon.com/dgdl/ProductDatasheetICE2PCS01_v2_2+Oct2007.pdf?folderId=db3a304412b407950112b4182a3d24f8&fileId=db3a304412b407950112b427caa43ccfhttp://www.ti.com/lit/ds/symlink/lm393-n.pdfhttp://www.ti.com/lit/ds/symlink/ucc28950.pdfhttp://www.datasheetcatalog.org/datasheet/texasinstruments/ucc27323.pdfhttp://www.datasheetcatalog.org/datasheet/texasinstruments/ucc27323.pdfhttp://www.ti.com/lit/ds/symlink/ucc28950.pdfhttp://www.ti.com/lit/ds/symlink/lm393-n.pdfhttp://www.infineon.com/dgdl/ProductDatasheetICE2PCS01_v2_2+Oct2007.pdf?folderId=db3a304412b407950112b4182a3d24f8&fileId=db3a304412b407950112b427caa43ccf -
7/25/2019 Power Suppy Unit
13/15
CAPACITOR
$epa %-1&00ma (2015 model 'C 'ower and Cooling
ilencer )50 (200) model
the widespread adoption of the120mm fan design.
It used 135 mm a high speed coolerADN512UB-A90. The rotation speed
is directly proportional to increase intemperature, which temperaturemonitoring system is used in thedevice, based on the temperaturesensor. For optimum air flowdirection using guiding plastic plate
with eight holes for cooling radiatorsof high-diode bridge.
-
7/25/2019 Power Suppy Unit
14/15
2015 MODEL
LEPA G-1600 MA
-
7/25/2019 Power Suppy Unit
15/15
2007 MODEL
SILENCER 750
QUAD