dpg-482
TRANSCRIPT
152 Kennedy Road South Brampton, Ontario
CanadaL6W 3G4
General Inquiry Number: (905) 459-1232
Material Safety Data Sheet Attached
WITBREAK™ DPG-482
15-03014
: Surfactant.
Material Safety Data Sheet
Product name
Supplier/Manufacturer
Material Uses
MSDS#
Section 1. Product and Company Identification
AKZO NOBEL SURFACE CHEMISTRY LLC525 West Van BurenChicago, IL 60607-3823www.surfactants.akzonobel.com
AKZO NOBEL CHEMICALS LTD.1 City Centre Drive, Suite 318Mississauga, Ontario L5B 1M2Canada
In Case of Emergency
Page: 1/5
can
CHEMTREC: 800-424-9300CANUTEC: 613-996-6666Medical/Handling: 914-693-6946Product/Technical: 800-906-9977
Section 2. Hazards Identification
Absorbed through skin. Eye contact.Routes of Entry
Emergency Overview
Physical State Liquid.
See Toxicological Information (section 11)
CAUTION!MAY CAUSE EYE IRRITATION.
Avoid contact with eyes. Wash thoroughly after handling.
Yellow.ColorPolyether-like. (Slight.)Odor
Section 3. Composition/ Information on Ingredients
oxirane, methyl-, polymer with oxirane, ether with1,2,3-propanetriol (3:1)
9082-00-2 100
propylene oxide 75-56-9 <0.001
Name CAS # % by Weight
Check for and remove any contact lenses. In case of contact, immediately flush eyes with plenty ofwater for at least 30 minutes. Get medical attention.
Do NOT induce vomiting unless directed to do so by medical personnel. Never give anything bymouth to an unconscious person. If large quantities of this material are swallowed, call a physicianimmediately. Loosen tight clothing such as a collar, tie, belt or waistband.
Wash with soap and water. Get medical attention if irritation develops.
If inhaled, remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, giveoxygen. Get medical attention.
Section 4. First Aid MeasuresEye Contact
Skin Contact
Inhalation
Ingestion
Medical ConditionsAggravated byOverexposure
Repeated or prolonged exposure is not known to aggravate medical condition.
Continued on Next Page
This product is distributed by Canada Colors and Chemicals LimitedGeneral Inquiry Phone Number: (905) 459-123224 Hour Emergency Phone Number (416) 444-2112
CCC Product Code:______________________
CCC Product Name:_______________________________________
953857
WITBREAK DPG-482
WITBREAK™ DPG-482 Page: 2/5
May be combustible at high temperature.
These products are carbon oxides (CO, CO2).
Closed cup: >93°C (199.4°F). (Pensky-Martens.)
SMALL FIRE: Use DRY chemical powder.LARGE FIRE: Use water spray, fog or foam. Do not use water jet.
Section 5. Fire Fighting MeasuresFlammability of theProduct
Flash Points
Products of Combustion
Fire Fighting Mediaand Instructions
Be sure to use an approved/certified respirator or equivalent.Protective Clothing (Fire)
Absorb with an inert material and put the spilled material in an appropriate waste disposal.Absorb with an inert material and put the spilled material in an appropriate waste disposal. Finishcleaning by spreading water on the contaminated surface and allow to evacuate through the sanitarysystem.
Section 6. Accidental Release MeasuresSmall Spill and LeakLarge Spill and Leak
Keep container tightly closed. Keep container in a cool, well-ventilated area.Avoid contact with eyes. Wash thoroughly after handling.
Section 7. Handling and StorageHandlingStorage
propylene oxide: This product contains trace amounts of propylene oxide, a condition which creates thepotential for accumulation of propylene oxide in the headspace of shipping and storage containers and inenclosed areas where the product is being handled or used. If this product is handled according to therecommendations in the MSDS, the presence of these trace amounts of propylene oxide is not expectedto result in any short term or long term hazard.
Other SpecialConsiderations
Provide exhaust ventilation or other engineering controls to keep the airborne concentrations ofvapors below their respective occupational exposure limits. Ensure that eyewash stations and safetyshowers are proximal to the work-station location.
Splash goggles. Full suit. Boots. Gloves. Suggested protective clothing might not be sufficient; consulta specialist BEFORE handling this product.
Section 8. Exposure Controls/ Personal ProtectionEngineering Controls
Personal Protection inCase of a Large Spill
Ingredient Name Exposure Limits United States
Not applicable.
Splash goggles.Lab coat.
Not applicable.
Personal ProtectionEyesBodyRespiratoryHandsFeet
Protective Clothing(Pictograms)
oxirane, methyl-, polymer with oxirane,ether with 1,2,3-propanetriol (3:1)
Not available. Not available.
propylene oxide ACGIH TLV (United States, 2006). Notes:Substance identified by other sources asa suspected or confirmed humancarcinogen. 1996 Adoption Substancesfor which the TLV is higher than the
Not available.
Exposure Limits Canada
Suitable protective footwear.
Continued on Next Page
WITBREAK™ DPG-482 Page: 3/5
OSHA Permissible Exposure Limit (PEL)and/or the NIOSH RecommendedExposure Limit (REL). See CFR 58(124):36338-33351, June 30, 1993, for revisedOSHA PEL. Refers to Appendix A --Carcinogens. TWA: 2 ppm 8 hour(s).OSHA PEL (United States, 1997). TWA: 240 mg/m3 8 hour(s). TWA: 100 ppm 8 hour(s).OSHA PEL 1989 (United States, 1989). TWA: 50 mg/m3 8 hour(s). TWA: 20 ppm 8 hour(s).
Decomposes.
Liquid.
6 to 7 (Conc. (% w/w): 50) [Acidic.]
Not available.Not available.
Insoluble in cold water.
Polyether-like. (Slight.)Yellow.
Boiling/CondensationPoint
Section 9. Physical and Chemical PropertiesPhysical State
pH
Vapor PressureVapor DensitySolubility
OdorColor
The product is stable.
Reactive with OXIDIZING AGENTS.
Will not occur.
Section 10. Stability and ReactivityStability and Reactivity
Incompatibility withVarious Substances
HazardousPolymerization
:Prolonged contact may cause irritation.
Section 11. Toxicological InformationToxicity to Animals
Special Remarks onToxicity to Animals
Special Remarks onOther Toxic Effects onHumans
propylene oxide LD50LD50LD50LD50
380 mg/kg440 mg/kg440 mg/kg500 to 1000 mg/kg
OralOralOralDermal
RatMouseMammalRabbit
Ingredient Name or Productname
Test Result Route Species
Harmful effects are not expected from short periods of contact. Short-term harmful health effects arenot expected from vapor generated at ambient temperature.
Slightly irritating to the skin.Acute Effects Skin
Moderately irritating to the eyes.Acute Effects Eyes
Continued on Next Page
WITBREAK™ DPG-482 Page: 4/5
These products are carbon oxides (CO, CO2) and water.
Section 12. Ecological InformationEcotoxicity
Products of Degradation
propylene oxide Lepomis macrochirus (LC50) 96 hour(s) 215 mg/lIngredient Name or Product name Species Period Result
Waste must be disposed of in accordance with federal, state and local environmental controlregulations.
Waste Information
Section 13. Disposal Considerations
Consult your local or regional authorities.
- -
Section 14. Transport Information
DOTClassification
TDGClassification
-
-
Notregulated.
-
IMDG Class - -
Notregulated.
IATA-DGRClass
-
RegulatoryInformation
UNnumber
Proper shipping name Class PackingGroup
Label Additional information
-
Notregulated.
-
-
Notregulated.
-
-
-
-
-
-
-
-
-
U.S. Federal Regulations
Section 15. Regulatory Information
CEPA DSL: oxirane, methyl-, polymer with oxirane, ether with 1,2,3-propanetriol (3:1); propylene oxide
WHMIS (Canada) Not controlled under WHMIS (Canada).
European UnionEC NumberComponent EC Status EC Annex
oxirane, methyl-, polymer withoxirane, ether with 1,2,3-propanetriol(3:1)
Not available. Not available. Not available.
propylene oxide 200-879-2 Not available. 603-055-00-4
Not applicable.Other Regulations
TSCA: All intentionally present components are listed on the TSCA inventory.
DSL: All intentionally present components are listed on the DSL.
Continued on Next Page
WITBREAK™ DPG-482 Page: 5/5
Australia (NICNAS): oxirane, methyl-, polymer with oxirane, ether with 1,2,3-propanetriol (3:1);propylene oxide
China: oxirane, methyl-, polymer with oxirane, ether with 1,2,3-propanetriol (3:1); propylene oxide
Germany water class: oxirane, methyl-, polymer with oxirane, ether with 1,2,3-propanetriol (3:1)
Japan (MITI): propylene oxide
Korea (TCCL): oxirane, methyl-, polymer with oxirane, ether with 1,2,3-propanetriol (3:1); propyleneoxide
Philippines (RA6969): oxirane, methyl-, polymer with oxirane, ether with 1,2,3-propanetriol (3:1);propylene oxide
Other International Lists
Section 16. Other Information
Other Information
Notice to ReaderThe information in the material safety data sheet should be provided to all who will use, handle, store, transport or otherwise be exposedto this product. All information concerning this product and/or suggestions for handling and use contained herein are offered in goodfaith and are believed to be reliable as of the date of publication. However, no warranty is made as to the accuracy of and/or sufficiencyof such information and/or suggestions or as to the product’s merchantability or fitness for any particular purpose, or that any suggesteduse will not infringe any patent. Nothing contained herein shall be construed as granting or extending any license under any patent.Buyer must determine for himself, by preliminary tests or otherwise, the suitability of this product for his purposes, including mixingwith other products. The information contained herein supersedes all previously issued bulletins on the subject matter covered. If thedate on this document is more than three years old, call to make certain that this sheet is current.
Hazardous MaterialInformation System(U.S.A.)
210 0
12
National FireProtectionAssociation(U.S.A.)
Health
Specific Hazard
Reactivity
Fire HazardHealth
Fire Hazard
Physical Hazards
Validation Date 5/25/2010.Print Date 5/25/2010.Validated by Product Safety Specialist
Witbreak™ is a trademark of Akzo Nobel or affiliated companies.
Previous Validation Date 5/17/2007.Phone Number 312-544-7038
Personal Protection