feasibility study of oxygen /hydrogen - nasa · pdf filethe raney nickel powder was entrained...
TRANSCRIPT
![Page 1: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/1.jpg)
F E A S I B I L I T Y S T U D Y O F
POWDERED METAL IGNITION OXYGEN /HYDROGEN
F I N A L R E P O R T 16 SEPTEMBER 1964 TO 15 SEPTEMBER 1965
F
I t 'a\., CONTRACT NO. NAS 8-11250 \
- 4 - - SEPTEMBER 19615
" ( D -
I (ACCESSION NUMBER) (THRU) L
2 E z 2
(NASA CR OR TMX OR AD NUMBER)
(GODE)
(CATEGO'RY)
REPORT NO. 25,179 ~
GPO PRICE $
CFSTI PRICE(S) $
Hard copy (HC)
Microfiche 1MF) T H E MARQUARDT CORPORATION
ff 663 July 85
https://ntrs.nasa.gov/search.jsp?R=19670022638 2018-05-19T07:22:20+00:00Z
![Page 2: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/2.jpg)
FEASLBILITY STUDY OF ~ G E N / H Y D R O G E N POWEXED METAL IGNITION
Prepared Under National Aeronautics and Space Administration Contract No. NAS8-11250
Control No. DCN 1-4-50-01075-01, S1, & S2 (I!?)
DCN 1-5-96-45001-01 (1F)
FINAL W O R T
16 September 1964 t o 15 September 1965
Publication Date: 1 September 1965
Prepared by:
Principal Investigator
Approved by:
. . ._
ASTRO The Marquardt Corporation
Van Nuys, California
![Page 3: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/3.jpg)
Report 25,179
FEASIBILITY STUDY OF OXYGEN/HYDROGEN POWDERED METAL I G N I T I O N
(TMc Project 358)
This report was prepared by The Marquardt Corporation under Contract No. ~8-11250, “Feas ib i l i ty Study of Oxygen/Hydrogen Powdered Metal Ignition”, f o r the George C. Marshall Space Flight Center of the National Aeronautics and Space Adminis- t r a t ion . The work w a s administered under the technical direc- t i o n of the Propulsion and Vehicle Engineering Laboratory of the Grorge C. Marshall Space Flight Center.
ii
![Page 4: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/4.jpg)
Maryuardt LURFORA TION VAN NUYS, CACICOINIA Report 25,179
ABSTRACT
Theoretical and experimental s tudies were performed on the subject of producing low temperature H2/02 ignit ions by the use of ca ta ly t i c and/or pyrophoric powdered metals.
In te res t centered on the use of Raney nickel powder, which is both ca ta ly t i c f o r H2/02 ignition, and pyrophoric with oxygen. Tests w i t h t h i s material produced a large number of ignit ions with cold gaseous hydrogen and l iqu id oxygen. Ignit ion times of the order of 10 milliseconds were observed under favorable conditions, and this does not appear l i m i t . stream, by passing the l a t t e r through a f lu id ize r assembly j u s t upstream of the injector.
t o be a The Raney nickel powder was entrained i n the hydrogen
It was demonstrated t ha t Raney nickel powder, stored under an atmosphere of hydrogen, should have indefinite shelf l i f e i n the act ivated s t a t e , being able t o produce ignit ions a t any time upon contact with oxygen.
It is considered tha t the most promising application would take the form of the Raney nickel powder stored under these conditions Fn a side tank near the rocket engine. A bleed stream from the main hydrogen flow would entra in some of the nickel powder as it passed through th i s f lu idizer . This hydrogen stream would then be hypergolic with e i the r l iquid o r gaseous oxygen. son w i t h noble metal catalysts) lends support t o t h i s application.
The l o ~ j cost of Raney nickel ( in compari-
The data of this report appear t o j u s t i f y continued tes t ing on a larger scale, comparable t o actual rocket engine opera- t i ng conditions.
iii
![Page 5: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/5.jpg)
T k
~ / 4aryuardf CORWRATJON VAN NUYS, CAl l fORNlA Report 25 179
TAT3LF: OF CONTENTS
Sect ion
ABSTRACT
TABU7 OF CONTENTS
PREFACE
ANALYTICAL STUDlES
A .
B . Basic Approach
General Consideration of: Igni t ion Mechanisms
I.
Ir.
6. Mechanism of Raney Nickel €$/02 Ignitions
D. Li terature Survey
PLANNING OF EXPERIMENTAL PROGRAM
A . General Appraoch
B. Description of Igni t ion Test Apparatus
1. Preliminary Apparatus Using Fixed Bed Catalysts
2. C o q i a l Injector Ut i l iz ing Fixed Bed Catalysts
3. Coaxial Injector Ut i l iz ing Entrained Raney Nickel Powder
4. Igni t ion Sensing
C Ignition Mechanism and Storage Characteristics of Raney Nickel
Page
iii
iv
v i i i
1
1
3
3
6
7
7
7
8
10
11
14
15
15 D. Gas Adsorption Studies
![Page 6: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/6.jpg)
Section
111 * EXPERIMENTAL STUDY
A. Experimental Ignition:. Data
1.
2.
Preliminary Ignitions Using Fixed Bed Catalystg
Coaxial Inject ion Ut i l iz ing Fixed Bed Catalysts
3 . Coaxial Inject ion Ut i l iz ing Entrained Raney Nickel Powder
B . Igni t ion Mekhanism and Storage Characteristics of Raney Nickel
Iv.
C . Gas Adsorption Studies
EVALUATION OF EXPERIMENTAL DATA
A . General Summary
B. Itemized Discussion of R&uiL'ks
c . Kebommendatibns
Page - 16
16
16
18
20
V
![Page 7: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/7.jpg)
LIST O F ILLUSTRATIONS
Figure
1 2
3 4 5 6 7 8
9 10 11
12
13 14
1.5
16 1.7
18
Preliminary H2/02 Igni t ion Assembly, Mark I
Ignition Device, Mark 11
Ignit ion Device, Mark 111
Ignition Device, Mark I11
Ignit ion Device, Mark IV (Schematic)
Ignition Device, Mark IV (Assembled)
Coaxial Igni t ion Device, Mark V
Coaxial Igni t ion Device, Mark V
Coaxial Injector Nozzle and Sensors, Mark V
H2/02 Catalytic Igni t ion Device, Mark V I
Coaxial Igni t ion Device, Mark V I 1
Schematic of Mark V I 1 1 Igni'cion Assembly
Detail of Mark V I 1 1 Igni ter
Oscilloscope Igni t ion Traces - Preliminary Tests with
Oscilloscope Igni t ion Traces - Preliminary Tests with
G a s Flow Calibration Runs, Mark I11
Oscilloscope Igni t ion Traces Fixed Bed Catalysts;
Oscilloscope Igni t ion Traces, Raney Nickel Powder
Fixed Bed Raney Nickel Catalyst
Fixed Bed Raney Nickel Catalyst
Coaxial Inject ion
Entrained i n H2 Stream
19 Oscilloscope Igni t ion Traces, Raney Nickel Powder Entrained i n H2 Stream
Page - 39 %7 4s 9Q 49 4P, 47 46 4li! 48 49 5Q 53
58
53 5'1.
55
54
53 20 Oscilloscope Igni t ion Traces, Raney Nickel Powder
21 Oscilloscope Igni t ion Traces, Raney Nickel Powder Entrained i n H2 Stream, Liquid Oxygen Inject ion 58
Entrained i n H2 Stream, Liquid Oxygen Inject ion 59 22 Oscilloscope Igni t ion Traces, Mark V I I I , Raney
23 Oscilloscope Igni t ion Traces, Mark V I I I , Raney
Nickel Powder Entrained i n H2 Stream
Nickel Powder Entrained i n H2 Stream
60
61
v i
![Page 8: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/8.jpg)
Report 25,179
LIST OF ILLUSTRATIONS ( Continue d )
Figure
24
25 Hydrogen Adsorption Isotherms on Raney Nickel
Hydrogen Adsorption Isotherms on Platinum Black
Table
1
P
I1
I11
Iv V
LIST OF TABLES
Preliminary Ignit ion Tests with Raney Nickel Fixed Bed Catalyst
Coaxial Injection Ignit ion Tests Using Fixed Bed
Ignit ion Tests Using Dry Raney Nickel Powder Entrained
Catalysts 6e
In H2 S t r e m 6-8' Ignit ion Tests With Liquid Oxygen
Igni t ion Tests Vith Mark V I 1 1 Ign i te r
v i i
![Page 9: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/9.jpg)
' H ~ r ~ u ~ ~ d ~ LYIRPURTION VAN N W S . CAl I fORNIA Report 25,179
PRBFACE
i For planning purposes, the subject research program w a s divided
in to four phases, as follows:
Phase I Analytical Studies
Phase I1 Planning of Experimental Program
Phase I11 Experimental Study
Phase IV Evaluation of Experimental Data
The r e su l t s of the program are discussed i n the t ex t i n the above order.
v i i i
![Page 10: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/10.jpg)
I. AEJALY'PICAL STUDIES
A. General Consideration of Ignit ion Mechanisms
Theoretical and experimental s tudies since 1928 have established that the reaction between gaseous hydrogen and gaseous oxygen i s a branched- chain reaction. Beginning with Gibson and Hinshelwood (Reference 1) i n 1928 and the experimental work of Kovalskii (Reference 2), numerous experimental studies have established that the general nature of the reaction can be in te r- preted i n terms of Reactions (1-14) l i s t e d below (References 3-5).
H 2 + M + 2 H + M
02 + M + 2 0 + M
H e + 02+ 2 OH
H2 + 0 2 4 H + H 0 2
0 + Ij + M-OH + M
H + 0 2 4 0 H + 0
0 + H 2 + 0 H + H
OH + H 2 + H 2 0 + H
In i t i a t i on
In i t i a t i on
In i t i a t i on
In i t i a t i on
Addit ion
Chain-branching
Chain-branching
Propagat ion
2 OH-HpO + 0 Propagation
H + OH + M - + H 2 0 + M Termination
OH + w a l l - 5 O2 1
Term ina t i on
H + w a l l - - , H2 + w a l l Termination
0 + w a l l + 5 02 + w a l l Termination
1 2 + - H 2 + w a l l
3-
H + 02 + M-"$H02 + M
I H02 + w a l l - 2 H2
+ O2 + w a l l Term ina t ion
-1-
![Page 11: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/11.jpg)
' ,%/-v...df CORFORA TION VAN NUYS, CALIfORNIA Report 25,179
Reaction (4) represents an i n i t i a t i o n step i n hydrogen-oxygen combustion, i n which a hydrogen atom i s generated by a pa i r of molecules reacting with suf f i- c ient act ivation energy. Reactions (6) and (7) represent very important steps i n the fur ther reactions occurring between hydrogen and oxygen molecvles and atoms, and hydroxyl f ree radicals . In these steps, chains are branched. That is, they produce two reactive atoms or f ree radicals , (0 , H, OH) by the reac- t i on of one atom or f ree radical (0 , H, OH) with a molecule (H2, 02) e Thus, when a hydrogen atom i s produced, as by Reaction ( k ) , a se r ies of chain- branching and propagation reactions (6-9) are then in i t i a ted , which quickly culminate i n an extremely rapid oxidation. The chain-branching steps may be rapidly terminated by the hydroxyl rad ica l (OH), or the hydrogen atom or the oxygen atom, s t r ik ing the w a l l of the vessel and losing i t s chemical energy, as i n Reactions (11-a) e The termination reactions of the type of (11-13) may also occur by these same atoms or radicals s t r ik ing hydrogen or oxygen molecules, which are not i n the activated energy s t a t e required t o react and branch, thus losing t h e i r energy as by Reaction (14) or the reverse of Reactions (1-3)
This sequence of reactions w i l l not spontaneously i n i t i a t e the
An al ternat ive approach i s t o essen t ia l ly bypass Reac- chain process a t low temperature. One poss ib i l i ty would be t o excite Reac- t i on (4) by heating, t i on (4) by otherwise providing atoms or f ree radicals t o promote Reactions (6-7) Based upon well-known concepts of bond energy, it i s eas ier t o pre- pare hydrogen atoms than oxygen atoms. With t h i s view the appropriate way t o induce the chain process outlined by Reactions (6-95 i s by means of chemical process which can readi ly generate hydrogen atoms
It i s well established chemically that hydrogen molecules can be readi ly dissociated on selected cata lys ts in to hydrogen atoms, as by the following reaction. ,
H2+ 2 H (chemisorbed on cata lys t ) (15)
This process has been well established as occurring on the noble metal cata- l y s t s , such as platinum,palladium, and the l ike , and on cer ta in other tran- s i t i on metals, such as nickel. These types of metal ca ta lys ts must, there- fore, be considered as potent ia l igni t ion cata lys ts .
The use of pyrophoric metal powders t o obtain igni t ions gene- r a l l y represents a case i n which a reaction similar t o (4) above i s caused t o occur, as a r e su l t of the high temperature which the pyrophoric metal powders a t t a in . associated with the reaction of the pyrophoric metal pa r t i c les w i t h oxygen.
This high temperature is a r e su l t of the heat release
-2-
![Page 12: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/12.jpg)
B. Basic Approach
It w a s considered desirable tha t t h i s research program empha- s ize the study of powdered metal igni t ion agents which would be applied i n the form of an entrained powder i n one of the propellant streams, since a considerable amount of work has already been performed u t i l i z i ng fixed cata- l y s t beds, It was also of i n t e r e s t t o evaluate the use of materials con- siderably l e s s expensive than the noble metal ca ta lys t s normally employed i n ignit ion studies of t h i s type.
These considerations, and others, led t o the selection of act ive nickel powders of the "Raney nickel" type Tor evaluation. reasons fo r considering t h i s material are discussed bklow. It should be noted, however, that , f o r completeness of study, work w a s also performed on fixed bed catalysts , both nohle metal and nickel.
The
C . Mechanism of Raney Nickey F$/Oy YgnitLons
The following discussion i s concerned w i t h u t i l i z i ng a pre- formed layer of chemisorbed hydrogen on a powdered metal substrate t o i n i - t i a t e combustion. This method qobbines t o some extent the character is t ics of both ca ta ly t i c and pyrophoric powdered metal ignit ion.
Catalytic igni t ion i n the H2/02 system i s normaly considered t o operate through a mechanism Qf hydrogen chemisorption. molecule i s adsorbed so strongly t o the surface of the cata lys t t ha t the H-H bond i s p a r t i a l l y or wholly ruptured, being replaced by H-M bonds, where M denotes the cata lys t .
That is, the He
In schematic equation form,
I I I I ' (chemisorption) t I
- M - M -
-3-
![Page 13: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/13.jpg)
H a r y u a r d j LVRHIRA TION VAN NUIS, CALifORNIA Report 25,179
The process of chemisorption i s the sum of Reactions (16) and (17). Reaction (18), the generation of f ree H radicals , i s shi f ted f a r t o the l e f t ; i .e . , the concentration of f ree H atoms i s very s m a l l . However, only small amounts of H atoms are necessary t o i n i t i a t e reaction.
Reaction (16), physical adsorption, normally occurs rapidly, even at low temperatures. Chemisorption, however, i s usually associated with an energy of act ivation. possessing t h i s energy can undergo chemisorption. A s i s well known, the f ract ion of molecules possessing a given energy decreases exponentially with the absolute temperature. A t the cryogenic temperatures concerned i n th i s stupy, t h i s f ract ion may become so small t ha t the kinet ics of chemisorption may be too slow t o i n i t i a t e combustion i n the desired time in terval .
Thus, only tha t f ract ion of H;! molecules
This slow kinet ic step could be eliminated i f one could provide a pre-formed layer of chemisorbed hydrogen on the cata lys t surface. A chemi- sorbed layer of hydrogen can be deposited readi ly enough on a number of metal surfaces at ambient, or s l i gh t l y higher, temperature. A question ar ises , however, concerning the f e a s i b i l i t y of protecting t h i s layer , Depending on the nature of the hydrogen chemisor&.on process, t h i s might involve s tor ing the cata lys t under an atmosphere of hydrogen u n t i l it enters the igni t ion chamber
If a metall ic ca ta lys t were suf f ic ien t ly f ine ly divided, it might behave as a pyrophoric metal powder; i . e . , the powdered metal would i t s e l f be oxidized, i n i t i a t ed by the heat release of the ca ta ly t ic reaction, and would no longer, s t r i c t l y speaking, be only a cata lys t . It should be noted t ha t the pyrophoricity i n t h i s case would be due t o the adsorbed hydrogen layer
Early i n th i s project, it appeared t ha t Raney nickel, and The term "Raney nickel"
The resul t ing f ine ly
It w a s considered l i k e l y t ha t the pyrophoric
s i m i l a r materials, sh t i s fy these requirements ., re fe r s t o a form of nickel obtained by leaching the aluminum from a nickel- aluminum a l loy by reaction w i t h sodium hydroxide. divided nickel powder contains large amounts of bound hydrogen, presumably i n the chemisorbed s t a t e . propert ies of Raney nickel are due t o the presence of thLs chemisorbed layer of hydrogen, -the evolution of the l a t t e r being primarily responsible fo r the gradual l o s s i n a c t i v i t y observed when Raney nickel i s stored under an i ne r t atmosphere.
Raney nickel has long been known t o be a very active cata lys t for many applications. It has been u t i l i z ed almost exclusively, however, i n the f i e l d of organic chemistry, f o r a var ie ty of purposes, such as hydro- genation of esters , desulfuration of thiazoles, e tc . It i s l i k e l y t ha t t h i s close association w i t h specialized organic reactions has tended t o obscure
-4-
![Page 14: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/14.jpg)
the f ac t tha t Raney nickel (and modifications thereof) -. i s a very promising catalyst fo r inorganic reactions i n which B source of act ive hydrogen i s required. In par t icular , it appears t ha t past applications of t h i s material have not been concerned with i t s propert ies as a source of hydrogen atoms at cryogenic temperatures. In the form i n which it i s usually described i n the l i t e r a tu r e , Raney nickel i s stored under an iner t carr ier , such as ethanol, u n t i l use. In addition t o being an ipconvenient arrangement fo r the present application, Raney nickel stored i n t h i s manner has a limited active l i f e , generally a few weeks at most. techniques for handling and storing dried Raney nickel powders.
It w a s therefore necessary t o develop new
It w a s a l so necessary t o ver i fy the above postulated mechanism of the H2/02 igni t ions obtained from Raney nickel powders.
These goals were achieved by a var ie ty of t e s t s , reported i n more d e t a i l below. The r e su l t s are summarized here b r ie f ly .
It has been c lea r ly demonstrated that it i s a pre-chemisorbed layer of hydrogen on the Raney nickel powders which 5s responsible fo r i t s ca ta ly t ic ac t i v i t y . It has been demonstrated t ha t the basic mechanism of H2/02 igni t ion obtained from Raney nickel i s ca ta ly t i c i n nature. pyrophoricity of the Raney nickel represents a secondary process; namely, the oxidation of the nickel powders due t o the heat generated by the reaction of oxygen with t h i s chemisorbed hydrogen. Upon removal of the chemisorbed hydrogen layer (by vacuum desorption), the material i s no longer ca ta ly t i- ca l l y act ive fo r the cryogenic temperature ignit ion of hyarogen and oxygen, and i s no longer pyrophoric. the associated pyrophoricity) can be restored by redeposition of a layer of chemisorbed hydrogen.
The
The low temperature ca ta ly t i c a c t i v i t y (and
It has a lso been shown tha t the reaoted, oxidized nickel pow- ders can be reactivated, This i s accomplished by hydrogen reduction of the nickel oxide, followed by degassing and subsequent hydrogen chemisorption. The resul t ing material i s pyrophoric.
Based upon t h i s theoret ica l and experimental model, act ive Rwey nickel powders should have indef ini te shelf l i f e when stored under an atmosphere of hydrogen. Experimental observations made during t h i s project are i n agreement with t h i s hypothesis.
Samples of dry Raney nickel pOwder stored under these condi- t ions fo r nearly f ive months have produced cryogenic temperature igni t ions at the end of t h i s period.
-5-
![Page 15: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/15.jpg)
* ' Haryuardt CORIYIRATION VAN NUYS. CALIFORNIA Report 25,179
D. Literature Survey
A l i t e r a t u r e survey was conducted ea r ly i n the program. The i n i t i a l emphasis of t h i s survey w a s placed on reviewing the preparation of ca ta ly t i c agents which are specif ic for the chemisorption of hydrogen. resul t ing p a r t i a l dissociat ion of hydrogen molecules i n to atoms should i n i t i a t e the &/02 combustion reaction, as discussed above, known tha t ca ta lys ts prepared i n the laboratory are more active fo r t h i s purpose than many commercially available materials. Much information i s available i n the chemical l i t e r a t u r e describing very active hydrogen cata- lys t s , prepared fo r a wide var ie ty of uses. studied fo r preparative techniques which appeared feas ible for t h i s appli- cation. t a i n pert inent information on cata lyt ic a c t i v i t y of the desired type. Based on t h i s survey, platinum, palladium, and nickel ca ta lys t s have been prepared and evaluated i n cryogenic igni t ion t e s t s under the subject program. cata lys ts have been i n the form of both agglomerates and f ine ly divided powders e
The
It i s well
Accordingly, the l i t e r a t u r e was
References 6-21 consti tute a p a r t i a l l i s t of publicatians which con-
These
A l i t e r a t u r e survey concerning pyrophoric metal powders w a s also performed. methods of preparing cer ta in m e t a l powders i n very f ine ly divided s t a t e s . References 22-34 comprise a p a r t i a l l i s t of publications which describe both experimental techniques and theoret ica l considerations of i n t e r e s t t o the proposed application of pyrophoric metal powders.
This survey was directed primarily towards experimental
-6-
![Page 16: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/16.jpg)
' Maryuardj CORPrRATlON VAN NVYS. CALlfORNIA Re-Dort 25,179
11 0 PLANNING OF EXPERIMENTAL PROGRAM
A . General Approach
The basic experimental approach followed throughout t h i s con- t r a c t has been directed toward the object of reducing Che time required between inception of an idea and i t s experimental ver i f ica t ion. experimental tes t ing, u t i l i z i ng small-scale laboratory apparatus, w a s i n i - t i a t ed very ea r ly i n the program. The f i r s t t e s t s were of a preliminary, proof-of-principle nature, with simplici ty and straightforward experimental techniques being paramount a A s the program progressed and more information became available, the experimental arrangements became more complex, i n order t o make more accurate measurements under more severe operating condi- t ions . The scale of t e s t ing w a s kept at the laboratory level . This w a s done primarily for the following reasons.
Accordingly,
1. Wide ranges of variables were required t o be experimentally evaluated i n t h i s program. These included the type of ca ta lys t t o be used; method of i ts preparation and u t i l i za t ion ; e f fec t of mixture ra t io , tempera- ture, and pressure; e t c . It w a s believed tha t a greater body of meaningful experimental observations could be gathered by r e s t r i c t i ng the physical scope of the t e s t arrangements. cation, and pre-run checkout of larger, more inf lexible apparatus.
This reduced the time required for design, fabri-
2. Early i n the program, it w a s planned t o include a cer ta in amount of t e s t i ng u t i l i z i ng a larger scale set-up at The Marquardt Corpora- t i o n ' s Magic Mountain Remote Test Fac i l i ty . These t e s t s were intended to serve as hardware-size'' duplication of the main laboratory study. Certain factors caused t h i s approach to be discontinued, however: was the continued delay i n delivery of necessary hardware for the l iquid hydrogen system. a f t e r the th i rd successive delivery due date expired, with no prospect of rapid delivery.
11
The main factor
The purchase order fo r t h i s c r i t i c a l hardware was cancelled
B. Description of Ignit ion T e s t Apparatus
This sub-section describes the experimental apparatus used during t h i s program. are given i n following sections.
The presentation and discussion of the data obtained
-7-
![Page 17: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/17.jpg)
e ' Maryuardt WRRJRATION VAN NUYS, CALIFORNIA Report 25,179
1. Preliminary Apparatus Using Fixed Bed Catalysts
The f i r s t t e s t s were performed i n the Mark I igni ter , shown schematically i n Figure 1. The catalyst , contained on e i ther glass wool or a 200-mesh nickel screen, was mounted i n a s m a l l g lass tube, positioned behind a safety-glass shield. The hydrogen and oxygen control valves (located at the-@lometer i n l e t s ) were adjusted t o provide the desired flow r a t e s upon activation of the solenoid salves. i n to a Dewar f lask, i n which l iquid nitrogen or another cooling medium w a s placed. voir for l iquid nitrogen, t o obtain more effect ive ch i l l ing of the i n l e t gases and the igni t ion tube i n the oxygen and hydrogen l i ne s j u s t upstream of the igni t ion tube i n l e t .
Each gas was Qassed through a copper c o i l
The insulat ion around the-top of the igni t ion tube provided a reser-
Copper/constantan thermocouples were ins ta l l ed
Glass wool w a s used t o mix the gas streams before contact with the cata lys t . The flow r a t e s of oxygen and hydrogen were se t at low values so t ha t the igni t ions were not violent . before and a f t e r each igni t ion t e s t .
A purge of nitrogen w a s used
I n i t i a l t e s t s with t h i s apparatus used visual detection of ignit ion. was a lso used fo r t h i s purpose. f ied, w a s displayed on a Hewlett-Packard Model l 3 O A oscilloscope, Using small amounts of a platinum-powder cata lys t prepared by a method similar t o t ha t of Reference 10, igni t ion was demonstrated with both hydrogen and oxygen gases cooled t o cryogenic temperatures. The igni t ion tube, with catalyst , w a s also chi l led substantial ly by the l iquid nitrogen i n these tests. Re-ignition w a s repeatedly obtained under these conditions.
Later, a platinum/platinum-rhodium thermocouple (0.005 in . d ia . ) The output of the l a t t e r , sui tably ampli-
rCkie next expkrimental set-up, the Mark I1 igni ter , per- mitted inser t ion of the en t i re assembly, including cata lys t and gas i n l e t l ines , i n to a l iquid nitrogen Dewar. This permitted more uniform control fo r low-temperature t e s t s . fast-response thermocouple i n the posit ion shown, the oscilloscope t race indicated the i n i t i a l temperature r i s e of the cata lys t bed caused by the water formation reaction. Using t h i s more rugged apparatus, higher gas flow r a t e s (with more vigorous ignit ions) could be tes ted.
This apparatus i s shown i n Figure 2. With the
With t h i s apparatus and the same type of p l a t i n m cata lys t mentioned above, it w a s demonstrated t ha t igni t ions could be obtained when the catalyst , the hardware, and both gases were at approximately 90°K (162"a), the boil ing point of l iquid oxygen.
-8-
![Page 18: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/18.jpg)
The next apparatus, the Mark I11 igni ter , provided more posit ive control and measurement of the temperature of the gases and of the cata lys t . l ag involved from activation of the solenoid valves t o t h e establishment of steady flow of both gases past the cata lys t zone. This was accomplished by u t i l i z i ng small diameter conduits fo r a l l gases, up t o the sudden enlarge- ment at the cata lys t zone.
The main body of t h i s device w a s brass. The lower body portion w a s a tube with three s l o t s cut through the w a l l . The th in body w a l l and the s l o t s reduced the thermal path, allowing a measure of tempera- ture control of the gases and cata lys t by varying the immersion depth of the apparatus i n l iquid nitrogen.
This device i s shown i n Figure 3 and 4. It a lso reduced the time
The oxygen and hydrogen entered the un i t from opposite sides in to a centra l port, and then flowed in to the cata lys t zone. stantan thermocouple placed in the centra l port measured the gas temperature.. The nitrogen entered through a side port, purging the reaction zone.
A copper/con-
Both por ts opened in to a sudden enlargement, which con- tained the cata lys t and two thermocouples, a l l of which were held i n place between two sections of 200-mesh nickel screen. One thermocouple w a s copper/ constantan, t o measure the cata lys t temperature. The second w a s a fast res- ponse Pt/P't-lO$ Rh thermocouple (0.005 i n . d ia . ) t o measure the response time of the reaction e
The posit ion of the cata lys t w a s maintained by a support r ing which w a s placed over the top section of nickel screen. The copper exhaust tube was positioned by slipping onto the brass base un i t .
The outputs of the two copper/constantan thermocouples were measure by two Leeds and Northrop mi l l ivo l t potentiometers. small diameter gas conduits used, the temperatures of the hydrogen and oxygen gas streams were quite sensit ive t o the temperature of the surrounding metal. The output of the Pt/Pt-10$ Rh thermocouple w a s amplified by a Kinte l Model l l lBF voltage amplifier, and portrayed on a Tektronix Type 564 storage oscilloscope. oscilloscope camera.
Due t o the
Photographs of the l a t t e r were made with a Tektronix C- 1 2
When operating at low temperatures, gas temperatures were measured by flowing only one propellant at a time. avoid heating of the cata lys t bed, since there was some reaction at the cata- l y s t with the Mark I11 ign i te r even with the nitrogen purge flowing. low temperature runs, the reading of the top copper/constantan thermcouple (placed near the cata lys t ) w a s normally about lO-l5OF higher than t ha t of the gas temperature thermocouple.
This w a s necessary t o
During
-9-
![Page 19: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/19.jpg)
This apparatus w a s used i n a large numbercof cryogenic igni t ions u t i l i z i ng platinum and Raney nickel fixed-bed cata lys ts .
The Mark IV Igniter , shown i n Figures 5 and 6, was a revision of the Mark I11 apparatus, with provisions fo r operating under f u l l or p a r t i a l vacuum conditions. A secondary cata lys t bed, maintained at ambient temperature, w a s provided t o prevent explosive mixtures of hydrogen and oxygen from entering the vacuum pump.
2. coaxial Injector Vti l izir ig PixeT Bk'd' Catalysts
In order t o more closely simulate the actual 5-2 and RL-10 motor conditions, a new ignit ion device was designed and fabricated; it i s shown i n schematic form i n Figure 7 . The motor simulation was based upon a request by NASA personnel. nozzle. In order t o reduce flow t ransients associated with i n i t i a t i o n and termination of flow, 3-way solenoid valves with balancing flow resistance l egs were incorporated i n the laboratory flow system. pellant flow w a s maintained continually and w a s diverted rapidly t o the igni- t i on device. The switching time of the solenoid valves w a s l e s s than 20 milliseconds, as determined by flow response at the pressure transducer. A l s o , a high-response thermocouple w a s inserted i n the coaxial in jector nozzle t o determine the propellant temperature pr ior t o ignit ion. graph of the coaxial igni t ion device may be seen i n Figure 8. In the nozzle employed i n the laboratory device, the oxygen flowed through a 1/16-ine tube w5th an inner diameter of 0.040 i n . This tube w a s positioned concentrically i n a 1/8-in. tube with i n t e r i o r diameter of 0.101 in . tube w a s formed in to a converging nozzle of 0.082-in. inside diameter. This insured contact of the hydrogen, flowing i n the annulus, with the oxygen. Figure 9 i s a top view showing the coaxial nozzle and the various sensors, located rad ia l ly abyut the reaction zone at 90" separation. Included are the quartz c rys ta l transducer, the fast-response Pt/Pt-Rh thermocouple, and a copper/constantan thermocouple. thermocouple used t o measure the i n l e t gas temperature, and the i n l e t n i t ro- gen purge l i ne l ized from Figure 7.
This device incorporated a coaxial in jector
In t h i s manner, pro-
A photo-
The t i p of the exterior
A l s o seen are the O.O05-in0-diameter
'Ifne re la t ive placement of ther sensors may be' be t t e r visua-
Due t o the laxger physical dimensions of the coaxial igni- t ion device as compared t o the Mark I11 apparatus, the minimum obtainable propelPant temperature, u t i l i z i ng gaseous propellants, w a s approximately 115 OK
Usifig t h i s apparatus, a large number of cryogenic igni- t ions were obtained using fixed-bed cata lys ts of platinum, palladium, and Raney nickel.
-10-
![Page 20: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/20.jpg)
3. Coaxial Injector Ut i l iz ing Entrained Raney Nickel Powder
The apparatus described i n the preceding subsection yielded a great deal of useful information concerning cryogenic igni t ions u t i l i z i ng a fixed-bed cata lys t .
The method of application of greatest i n t e r e s t t o the pre- sent program, however, involved the entrainment of the dry nickel powders i n the hydrogen stream. With t h i s arrangement, igni t ion occurs when t h i s stream, with i t s entrained nickel powder, comes i n to contact with the oxygen stream. Accordingly, t e s t ing with fixed-bed cata lys ts was discontinued, and the empha- sis was placed on entrained powder ignit ions.
The i n i t i a l f lu id ize r arrangement i s shown schematically i n Figure 10. The cata lys t f lu id ize r section was loaded i n a dry box, under an atmosphere of nitrogen,.with the Raney nickel powder. shown i n Figure 10, the Raney nickel powder was protected from contact with the air by burs t diaphragms.
In the arrangement
Upon activation of the three-way hydrogen solenoid valve, gas pressure ruptured these diaphragms, causing some of the f ine Raney nickel powder t o be entrained i n the hydrogen gas stream, as it l e f t the f lu id ize r and entered the coaxial in jector .
In another arrangement, the burs t diaphragms were replaced by check valves. This change was made i n order t o simulate more closely the operation of a system possessing multiple r e s t a r t capabil i ty. Both f lu id ize r arrangements produced low-temperature ignit ions.
A s can be seen from Figure 10, t h i s apparatus was basical ly the same as the Mark V version, with the addition of the f lu id ize r assembly. Accordingly, the Mark V I device was subject to the same temperature l imitat ion, i . e . , the in ject ion of gaseous propellants at approximately ll5'K.
The next step, therefore, w a s the modification of the appar- atus t o permit the in ject ion of l iquid oxygen and cold gaseous hydrogen; both being cooled t o the temperature of l iquid nitrogen. This w a s accomplished by modifying the Mark V I apparatus t o posit ion the oxygen i n l e t l i n e i n l iquid nitrogen, thereby assuring l iquefaction of the flowing oxygen. This arrange- ment (Mark V I I ) i s shown schematically i n Figure 11. The depth of immersion i n l iquid nitrogen w a s greater, with t h i s device, i n order t o ensure tha t both propellants, and the in jector hardware, were at l iquid nitrogen temperature. The Mark V I 1 device had the feature t ha t the cata lys t f lu id ize r assembly w a s also immersed i n l iqu id nitrogen, thereby providing information on the func- tioning of t h i s component at cryogenic temperatures. The f lu idizer , together with i t s associated check valves, functioned i n a normal manner under these conditions.
-11-
![Page 21: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/21.jpg)
Using t h i s arrangement, igni t ions were obtained with l iqu id oxygen and Raney nickel entrained i n the cold gaseous hydrogen stream. w a s a lso determined, by v isua l observation, t h a t the Raney nickel powders were pyrophoric i n the presence of l iqu id oxygen.
It
The only remaifing experimental requirement w a s t o fur ther lower the temperature of the cold gaseous hydrogen. Since safety regulations precluded the use of l iqu id hydrogen i n the Physical Chemistry Laboratory, t h i s was accomplished by u t i l i z i n g l iquid helium f o r cooling purposes. The overal l system schematic of the arrangement used t o achieve t h i s goal i s shown i n Figure 12. A more detai led schematic of the igni t ion assembly i t s e l f i s given i n Figure 13. The sa l i en t features of t h i s arrangement are as follows:
The igni t ion device was located within a double Dewar arrangement. The outer Dewar contained l iquid nitrogen, This served t o c h i l l and l iquefy the oxygen stream, and t o c h i l l the nitrogen purge. It a l s o served as a pre- chi l l for the hydrogen stream. The la t te r was then directed in to the inner Dewar , which was fbther cooled by the flow of cold gweous helium. The helium was obtained from a commercial l iqu id helium D e w a r . The temperature inside the inner Dewar (as measured by the copper/constantan thermocouple, T.C. 2) was controlled by adjusting the rate of addition of cold helium from the l iqu id helium source. It was found t h a t t h i s technique permitted a convenient control of temperature i n t h i s region over the desired range.
The temperature of the cold hydrogen w a s measured by another copper/constantan thermcouple, T.C in jec tor . Hydrogen flowed through the annulus of this injector , through a 0.11l-Zn. bore. The inqer, oxygen l ine w a s 0,035 in . O.D. by 0.019 in . I .D. The oxygen and nitrogen purge streams were normally not cooled excessively by the cold gaseous heikiwn, since these l i n e s passed s t r a igh t from the l iqu id nitrogen Dewar t o the in jec tor assembly. This tended t o place a lower l i m i t on the hydrogen temperature, however, since the oxygen stream could conceiv- ably approach i t s freezing temperature (55°K) i f the temperature of the hydrogen stream were permitted t o get too low. This became even more impor- tan t a t the lower mixture ra t ios , at which the oxygen flow ra te , and hence the effect ive thermal mass of the flowing oxygen stream, was reduced.
1, j u s t p r io r t o entering the coaxial
Both propellants were obtained from pressurized, ambient- temperature gas cylinders. determined from the gas rotameter, F 1 9 which w a s also at ambient temperature,
Referring t o Figure 12, hydrogen flow r a t e s were
-12-
![Page 22: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/22.jpg)
A three-way solenoid valve, V1, diverted the hydrogen flow t o the bypass l i n e except when an ignit ion t e s t was being performed. The f lu id resistance of the bypass l i n e was adjusted By the needle valve, V2, t o match t ha t of the in ject ion l i ne . the three-way valve was activated t o the igni t ion mode. three-way solenoid valve was the cata lys t f lu id ize r . gen stream entrained a small amount of Raney nickel powder. the f lu id ize r were protected by check valves, C1 and C2, or, i n cer ta in tesks, by burst diaphragms.
This provided a smooth flow t rans i t ion when Downstream of the
In t h i s device the hydro- The contents of
The hydrogen l i ne downstream of the f lu id ize r w a s purged and pre-chilled by a portion of the hydrogen bypass flow, by activation of the two- way solenoid valve, V3' The hydrogen l i ne was then passed in to the Guter Dewar fo r pre- chi l l .
The oxygen system w a s straightforward. Flow r a t e s were measured by the gas rotameter, F2. The gaseous oxygen flow was vented t o the bypass l i ne by the three-way solenoid valve, V4, except when flow t o the injec- t o r w a s desired. The f l u id resistance of the oxygen bypass linecwas adjusted t o match t ha t of the in ject ion l i ne by means of the needle valve, V5. gaseous oxygen w a s then l iquefied by passing through a c o i l of 1/16-in.-O9D. tubing immersed i n l iquid nitrogen i n the outer Dewar, and then flowed as a l iquid t o the in jector .
The
The pre-cooled, gaseous nitrogen purge normally flowed con- t inually, except during igni t ion periods. Provisions were made, by means of
1 valves V7 and
ducer traces, Oscilloscope,
follows :
92 flow, g/min
SCFM
H2 flow, g/min
SCFM
78, t o purge each propellant system with nitrogen,
Output data, consisting of thermocouple and pressure trans- $ere recorded on a Tektronix Type 564 Four Channel Storage 2nd photographed by a Te,ktronic C-19 Oscilloscope Camera.
The nominal flow ra tes used i n these igni t ion t e s t s were as
NOMINAL MIX- RATIO, O/F
0 -5, -1.5 4 .O 6 .o 0.283 0.85 2.22 2.22
7.00 x 10-3 0 -0210 0 9055 0 0055 0 566 0 a 566 0,555 0 0370 0.222 0.222 0.218 0.1455
-13-
![Page 23: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/23.jpg)
4. Ignit ion Sensing
Two types of instrumentation were used f o r ignit ion sensing;
The unshielded thermocouple The quartz transducer was
It is of i n t e r e s t t o compare The pressure transducer output
(1) one o r more 0.005-in. Pt/Pt-lo$ Rh f a s t response thermocouples, and (2) a Kis t l e r 601-~1 qua r t z c rys ta l pressure transducer. beads were mounted d i rec t ly i n the igni t ion zone. mounted a t one end of a 2-in. long, 1/8-in. dia. tube; the open end of the l a t t e r vas mounted d i rec t ly over the injector. the information gained from these two sources. w a s the primary signal , since this program was concerned with the establishment of a well-defined detonation wave. ignit ion had occurred which should have been capable of producing combustion i n a large engine The thermocouple output provided useful supporting information concerning the mechanism of th is ignition; e.g., whether o r not a f i n i t e pre- ignit ion reaction occurred. temperature developed i n the immediate v ic in i ty of the ignit ion zone.
The l a t t e r was posit ive evidence t ha t an
It a l so provided information concerning the loca l
The response time of the pressure transducer plus amplifier was of the order of 10 microseconds, and was therefore negligible f o r the purpose of this program. With th is a s a bas is , one can then estimate the response time of the 0.005-in. Pt/Pt-lO$ Rh thermocouple. experimental resul ts , discussed subsequently, reveals that the response time of th is thermocouple t o a detonation wave was too short t o be measured a t the oscilloscope t race speeds u t i l i zed i n th is study (generally 100-200 m i l l i - seconds/cm) and could not have been greater than about Moreover, the present exTerimenta1 data verify tha t , w i t h Raney nickel cata- l y s t s a t the higher mixture ra t ios , the i n i t i a l r i s e of the thermocouple out- put signal corresponds t o the detonation wave. thermocouple trace was strongly dependent on the par t i cu la r geometry prevailing f o r the t e s t in question. In some cases the trace continued smoothly up t o the maximum temperature; i n others, there was a l ag o r discontinuity in the trace. The indicated maximum temperature accompanying ignit ion was normally about 2000°K, but was sometimes much lower. occurred i n a few cases, generally associated w i t h t e s t s i n the Mark N appara- tus . ignit ion area, as a result of the modified exhaust l i n e . couple burnout w a s not a problem during t h i s study.
fied, were portrayed on a storage oscilloscope. l a t t e r provided permanent records of ignit ion data.
Analysis of the
5 milliseconds.
The subsequent behavior of the
Thermocouple f a i l u r e (due t o melting)
This was presumably due t o the a l t e red flow patterns prevailing i n the Otherwise, thermo-
The outputs of these instrumentation probes , suitably ampli- Polaroid photographs of the
The radio noise associated with the act ivation of the sole- noid valves produced a pip on the oscilloscope track. fo r computing ignit ion delay times. mined by blank runs i n which only one gas was flowing. represents the time interval between the valve "on" pip and the pressure transducer response. hydrogen stream) was subtracted from the overall ignit ion delay time.
This provided the basis The delay due t o gas lead t i m e was deter-
The gas lead time
This lead time (approximately 20 milliseconds f o r the
![Page 24: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/24.jpg)
A%ryuardt CORWRATION VAN N w s , CAlIfORNIA Report 25,179
A l l temperature measurements of the cryogenic propellants were made with copper/constantan thermocouples, w i t h room temperature reference compensation. These thermocouples were not individually calibrated, since a high degree of accuracy was not required i n these measurements. ture vs. emf relat ionship at the cryogenic conditions involved w a s based on the data of NBS Circular 561, extrapolated with the aid of a cal ibra t ion curve f o r a specif ic copper/constantan thermocouple.
The tempera-
C. Ignit ion Mechs3?ism and’ stor’gk’ %h‘aracteristics of Raney Nickel
A s mentioned previously, it was necessary t o develop new storage methods for Raney nickel powders, and t o determine the mechanism respbnsible fo r the igni t ions obtained from t h i s material . ser ies of observations involving desorption and re-adsorption t e s t s , as des- cribed i n the following section.
This was accomplished by a
D. G a s Adsorption Studies
Gas adsorption studies were made on samples of Raney nickel powder. B .E .T (Brunauer-Emmett-Teller) volumetric method. information concerning the surface area of these powders and t o observe the hydrogen adsorption character is t ics at various temperatures. Although only limited time was available for these t e s t s , in teres t ing data were obtained. These data are presented and discussed i n the following sections.
These studies were performed by a modification of the c lass ica l The purpose was t o gain
-15-
![Page 25: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/25.jpg)
I11 * EXPERIt&NTAL S W Y
This section presents the experimental data obtained during the pro- gram, together with a b r i e f description of the experimental conditions under which they were taken, Analyses of these data, and a discussion of the signi- Jicance Of the resul ts , are a l so given i n the following section.
The igni t ion data of t h i s section are given i n approximately chrono- logical order. I n i t i a l data therefore represent the more quali tat ive, proof- of-principle resu l t s , while the l a t t e r body of data gives the more quantitative, precise results. u t i l i zed i n the preceding section.
The igni t ion data are grouped in to the same headings as
A. Experiment a1 Ignit ion D a t a
1. Preliminary Ignit ions Us'ing Fixed Bed Catalysts
Ignit ion devices Mark I and Mark I1 were uged t o demonstrate igni t ions u t i l i z i ng a platinum cata lys t . similar t o that of Reference 10, which involved the formaldehyde reduction process. The cata lys t w a s i n the form of an agglomerated powder. The ac t i - v i t y of t h i s material decreased very noticeably with temperature. Ignit ions were demonstrated, however, at temperatures near tha t of l iquid oxygen, 90°K (162O~) e
technique of recording igni t ions by means of f a s t response Pt/Pt-lO$ Rh thermocouples.
The l a t t e r w a s prepared by a method
These preliminary items of apparatus also served t o check out the
The Mark I11 apparatus (Figures 3 and 4) w a s used for the
In
Since t h i s material became pyrophoric when dry, it w a s necessary
preliminary evaluation of Raney nickel powders. pared by modifications of the procedures given i n References 11 and 18. these i n i t i a l t e s t s <he nickel w a s stored i n the form of a sludge under methanol. t o protect it from contact with oxygen u n t i l time for an igni t ion t e s t . was done i n the following manner: rature, a small amount (1-2 grams) of the Raney nickel-methanol sludge w a s placed i n the igni t ion zone (see Figure 3) . slipped on, and the nitrogen purge s tar ted. methanol, leairing the dry, pyrophoric Raney nickel behind. The l a t t e r w a s broken up in to a powdery form by inser t ion of a s ta in less s t ee l spatula down the exhaust tube. Liquid nitrogen w a s then added t o the containing Dewar, and the en t i re apparatus chi l led . protected the Raney nickel by excluding air and moisture, Ignit ion w a s accomplished by activating %he hydrogen and oxygen solenoid valves e
preliminary igni t ion data are l i s t e d i n Table I.
The Raney nickel w a s pre-
This With the Mark 111 device at ambient tempe-
The exhaust tube was quickly This served t o vaporize the
During t h i s period the nitrogen purge
These
-16-
![Page 26: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/26.jpg)
~ Maryuardt LVRHIRA TlON VAN NUYS. CALICOINIA Report 25,179
For the i n i t i a l se r ies of tests described i n Table I, i n no case was an attempted igni t ion unsuccessful a t atmospheric pressure. Normally, four o r f ive ignit ions could be obtained from the sample of Raney nickel before the nickel powders became completely oxidized.
Some of the attempted vacuum runs f a i l e d t o produce an indi- cation of ignit ion. I n every case, however, post-run inspection revealed that the nickel powders had been oxidized, w i t h the l ibera t ion of considerable heat. It is l i ke ly t ha t t h i s occurred during the process of evacuating the system, since a small leak would permit atmospheric oxygen t o come into contact w i t h the pyrophoric powder. Subsequent t e s t s have indicated that the geometric arrangement of the ignit ion chamber may be an important variable. results of some of these runs are shown i n Figures 14 and 15.
Photographic
Table I indicates that the majority of ignit ions occurred w i t h a time lag of the order of 200-500 milliseconds, w i t h a f e w runs proving that more rapid ignit ions are possible under favorable circumstances. Control measurements w i t h the pressure transducer output showed tha t only a negligible f ract ion of thLs delay could be a t t r ibu ted t o thermocouple response time.
The response times of the solenoid valves, and of the f l u i d s concerned, were next considered. Information on this subject is given i n Figure 16, which shows the response of the pressure transducer t o flow of each separate gas with the Mark 111 ignit ion device. The response times f o r the valves were negligible f o r present purposes, but the times required f o r the gas flows t o become established were not negligible. It can be seen from Figure 16 tha t the hydrogen flow required about 120 milliseconds t o reach steady state, while the oxygen flow took about 440 milliseconds f o r steady s t a t e t o be obtained. It is of course readily possible t o obtain ignitions before steady-state flow has been at tained. cates, however, t h a t cer ta in minimum time intervals a re required before gas flow becomes s ignif icant . These minimums appear t o be, roughly, 20 m i l l i - seconds f o r hydrogen and 50 milliseconds f o r oxygen. Since an oxygen lead was normally used, 20 milliseconds were subtracted from the overall ignit ion times.
An inspection of Figure 16 indi-
Sl ight i r regu la r i t i e s i n the flow pulses, which occurred when one o r both of the solenoid valves were activated, could w e l l have delayed the attainment of a suitable mixture r a t i o i n the ignit ion zone. This factor i s possibly one of the main reasons f o r the s ca t t e r i n the observed ignit ion times. t i on device.
The problem was a l levia ted i n the coaxial injec-
In Run 114, performed a t a pressure of 2.2 psia, the i n i - t i a l r i s e of the thermocouple t race was not c lear ly defined. transducer was not ins ta l l ed f o r t h i s test. There was no detectable audible s ignal accompanying the ignition.
The pressure
-17-
![Page 27: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/27.jpg)
These tests w i t h the Mark I11 device demonstrated t h a t igni- t ions could be routinely a t ta ined a t temperatures down to about WOK (1.62’~) u t i l i z i ng Raney nickel.
2. Coaxial Injection Ut i l iz ing Fixed Bed Catalysts
In accordance w i t h requests of the contracting agency, fur- ther ignit ion tes t ing was res t r i c ted t o devices employing coaxial injection of the propellants.
The first of these, the Mark V ignit ion device (Figures 7-9), continued the f ixed ca ta lys t bed t e s t s described previously. In addition t o Raney nickel, t e s t s were performed with vzrious types of platinum and palla- dium cata lys ts , primarily f o r comparative purposes. r ized i n Table 11. appl icabi l i ty t o this program. however, i n order t o afford a bas is of comparison, and t o demonstrate the effectiveness of various in-house activation treatments.
These t e s t s a re summa- Some of the cata lys ts l i s t e d therein a re not of d i rec t
They were included i n the t e s t schedule,
It should be noted t ha t the corrected ignit ion times reported i n Table I1 represent the observed t o t a l ignit ion delay time, minus the gas lead t i m e , which was of the order of 20 milliseconds f o r these tests.
A s can be seen from Table 11, these systems have demonstrated f ea s ib i l i t y f o r low-temperature ignit ions, with corrected ignit ion times i n the vic ini ty of 10 milliseconds having been measured. of these runs a re shown i n Figure 17.
Oscilloscope traces of two
The r e l i a b i l i t y of the attempted ignit ions u t i l i z ing Raney nickel as a f ixed bed was exceptionally good, yielding successful resu l t s f o r a l l attempts. An inspection of Table I1 reveals that ignit ion delays of the order of 40-50 milliseconds can be obtained w i t h this material, with resu l t s i n the 10-20 millisecond range under optimum conditions. ignitions was obtained from each sample before the nickel powders were deac- t ivated. over the coaxial injector t o get minimum ignit ion delays. It is l i ke ly tha t t h i s fac tor was responsible f o r the s ca t t e r observed i n the ignit ion t i m e s . This indicated t ha t the optimum cata lys t bed geometry had not yet been ascer- tained. However, no e f f o r t was directed toward optimizing t h i s parameter, as it was f e l t t h a t the f luidized bed concept offered greater potential .
An average of 11
However, in many instances the cata lys t would need t o be repositioned
was l a r
Two types of noble metal ca ta lys ts were a lso evaluated. One i n the form of essent ia l ly pure platinum black, prepared by a method simi- t o that of Reference 10. The other was a commercial 5$ palladium on ac t i -
vated alumina. conditions. however, produced no ignitions.
Both materials consistently produced ignitions a t ambient Attempts t o use the same catalysts a t cryogenic temperatures,
-18-
![Page 28: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/28.jpg)
. %af$wimdt 6VRH)RATION VAN NUYS. CAL I IO IN IA Report 25,179
Portions of both materials were subjected t o a process of evacuation, followed by exposure t o ambient hydrogen gas. a marked improvement, par t icular ly f o r the palladium cata lys t , as shown by Runs 145-157 i n which ignit ions were obtained a t 134OK. with fh? postulate t ha t pre-chemisorbed hydrogen is responsible f o r the cryo- genic ca ta ly t ic a c t i v i t y of noble metal ca ta lys ts f o r H2/02 ignition. regard, it is believed that the basic mechanism of igni t ion obtained from Raney nickel is s imilar t o t h a t of noble metal catalysts .
This treatment made
This is i n keeping
I n t h i s
The observations of th is program therefore indicate that there is a problem area associated with the exposure of t h i s type t o the vacuum of space. w i l l be greatly speeded up if the cata lys t bed is s t i l l warm from previous engine f i r ing) . be necessary t o deposit a new layer of chemisorbed hydrogen before the cata- l y s t w i l l be capable of producing cryogenic ignit ions.
of fixed-bed cata lys ts Desorption of hydrogen w i l l r e su l t (and
According t o the mechanism postulated i n th is report , it w i l l
It is, of course, possible that cer ta in noble metal formu- la t ions may chemisorb hydrogen more rapidly than the materials investigated i n th is program. Based upon quite general kinetic considerations, however, it does not appear l i k e l y tha t th i s adsorption process w i l l occur extremely rapidly pract ica l system.
(a few milliseconds o r less) a t cryogenic temperatures f o r any
The implication i s , therefore, that a fixed-bed, noble metal ca ta lys t would have t o be protected f r o m exposure t o space vacuum i n order t o provide cryogenic r e s t a r t capability.
. _- This condition does not a f f ec t the application of Raney
nickel, since it is proposed t o u t i l i z e the l a t t e r by f lu idizat ion in to the hydrogen stream, ra ther than a s a fixed bed catalyst .
A modified form of h n e y nickel was u t i l i zed i n some of the This material was prepared i n a manner similar t o t h a t used
. _
fixed-bed t e s t s . w i t h e a r l i e r batches, except that the final stage of washing with methanol (and subsequent storage under methanol) was stopped a f t e r the water r inse stage and the f inal product w a s s tored under d i s t i l l e d water. The reason f o r doing t h i s was as follows: During the water r inse stage, the Raney nickel ex i s t s i n the form of re la t ive ly large par t i c le agglomerates, with no f ines present. It is only a f t e r the material is r insed with absolute (anhydrous) alcohol that the par t i c le s i ze becomes very small (approaching col lo idal s ize ) . It is l i k e l y that this pronounced par t i c le s ize reduction is due t o a combination of surface tension effects , and the strong a f f i n i t y of the anhydrous methanol f o r any bound water which may be associated with the par t i c le agglomerates. a r e broken up in to t h e i r constituent f i ne par t ic les .
omitted. That is, the process was
The r e su l t is that the coarse agglomerates
-19-
![Page 29: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/29.jpg)
~ Maryuardi GORP(IRATI0N VAN NUYS, CALIFOINIA Report 25,179
The e f f ec t of stopping a t the water r inse stage is, therefore, the production of Raney nickel i n a coarser par t i c le form, which has perhaps more bound hydrogen than in the form used previously. This modified form of Raney nickel produced ignit ions which were among the most rapid observed. this application, the material was present i n the igni t ion zone a s a fixed bed. Although quite act ive cata lyt ica l ly , this form was l e s s pyrophoric than the others, due t o i ts coarser par t i c le (or agglomerate) s i z e . This provided a la rger thermal mass and a smaller surface-to-mass r a t i o . The heat of reaction between oxygen and the chemisorbed hydrogen could thus be dissipated more readily.
In
3. Coaxial Injection Uti l izing Entrained Raney Nickel Powder
I n i t i a l data of t h i s type were obtained from the Mark V I ignit ion device (Figure 10) i n which the dry Raney nickel powder was entrained i n the hydrogen stream. down to near the boil ing point of oxygen, W O K (162O~). These data are summa- rized i n Table 111. tions by the use of dry Raney nickel powders entrained by f lu idizat ion i n the H2 stream.
This uni t operated with gaseous propellants, cooled
They demonstrated the f ea s ib i l i t y of obtaining rapid igni-
The ignit ion delay times i n i t i a l l y obtained by t h i s method were subject t o sca t te r , as shown i n Table 111. It is believed t ha t t h i s was primarily a matter of mechanical design of the f lu id ize r chamber, ra ther than a fundamental l imitat ion. most rapid ignit ion times (of 20-30 milliseconds) reported i n Table I11 (Runs 191 and 192, Figure 18), compare favorably with the bes t results obtained from the fixed bed technique.
This statement is supported by the f a c t t h a t the
A pronounced difference i n the ignit ion character is t ics as a function of mixture r a t i o was observed. Ignitions obtained a t a .mixture r a t i o (O/F) of 6.0 were consistently exemplified by a sharp, well-defined detonation pulse. A t the oscilloscope t race speeds used i n these studies, the ignit ion pressure surge appeared as a sharp, ve r t i ca l pip on the pressure trans- ducer trace {see Figure 18). On the millisecond scale, there was no appreciable pre- ignition reaction time.
The s i tua t ion was quite d i f ferent a t the lower mixture r a t i o These ignit ions were of a much milder nature, w i t h indica- of 1.5, however.
t ions of a reaction pressure buildup stage l as t ing on the order of 200 m i l l i - seconds. In addition, it was found, by visual observation of the in te r io r of the ignit ion tube (by means of a prism), that most ignitions were occurring
w e l l downstream of the region i n which the ignit ion a t O/F = 6.0 occurred.
-20-
![Page 30: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/30.jpg)
This factor was doubtless one of the major reasons fo r the apparent sca t te r and nonuniformity observed i n the igni t ions at O/F = 1.5 (Runs 214 through 228 of Table 111). The pressure r i s e s accompanying these more gentle igni- t ions were so s l igh t that , unless the exhaust tube was firmly stoppered, they did not reg i s te r on the pressure transducer t race . Also, the igni t ions some- times occurred suff ic ient ly f a r downstream of the fast-response thermocouple t ha t no signal w a s obtained from the l a t t e r .
These points are i l l u s t r a t ed i n Figure 19. The top photo
Vote t ha t the pressure buildup curve has a therein shows the pressure transducer t race for a cal ibra t ion run i n which hydrogen gas alone was flowing. negative second derivative (i .ea , the curve i s concaye t o the time axis) . This character is t ic was observed i n all cal ibra t ion runs, wherein the pressure buildup was due solely t o the gas flow.
The bottom photograph of Figure 19 depicts an igni t ion (at This run had. an oxygen O/F = 1.5) obtained w i t h the exhaust tube stoppered.
lead, as indicated by the s l igh t r i s e i n pressure p r io r t o opening the hydro- gen valve. After actuation of the l a t t e r valve, the pressure buildup curve showed a posit ive second derivative ( i .e . , convex t o the time ax i s ) . This was due t o the more rapid pressure r i s e resul t ing from the H2/02 combustion reaction, which began shor t ly a f t e r the hydrogen gas ( w i t h entrained Raney nickel) entered the igni t ion zone. an increasing r a t e for approximately 240 milliseconds before the detonation pulse occurred. exhaust tube, causing the pressure t race t o decrease t o i t s base l i n e valve. The fact t h a t the thermocouple t race did not regpond indicates tha t the igni- t i on occurred considerably downstream of the in jector .
This igni t ion pressure r i s e continued at
The l a t t e r blew out the r e s t r i c t i on which had. blocked the
The next phase of t es t ing involved the in ject ion of l iquid, This was accomplished with the Mark V I 1 appara-
The igni t ion data are given i n Table Tv, with selected ra ther than gaseous, oxygen. t u s (Figure 11). ignit ion t races shown i n Figures 20 and 21.
All of the igni t ions (15) recorded i n Table Tv were obtained from a single charge of Raney nickel (about 4 grams) e
there were approximately as many igni t ions obtained from t h i s sample which were not recorded. The charge of Raney nickel had not been depleted when these t e s t s were discontinued. Upon disassembly, there appeared t o be approximately one gram of nickel powder remaining.
In addition,
Liquid oxygen w a s v i sua l ly observed (by means of a prism) t o be welling out of the oxygen tube or in jector . be heard (and usually seen) almost immediately upon opening of the hydrogen valve.
Generally, sparking could
This w a s due t o the pyrophoric reaction which occurred when small
-21-
![Page 31: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/31.jpg)
' %arYuardt CORMRATION VAN NUYS, CALlfO#NlA Report 25,179
par t i c les of Raney nickel contacted l iqu id oxygen. detected by the instrumentation. A t times, the pronounced detonation wave accompanying ignit ion was delayed, presumably un t i l su f f ic ien t mixing of the propellants had occurred. viding a brief oxygen lead. defined ignit ion) were obtained i n every attempt. vailed, the ignit ion would proceed cata lyt ica l ly . S t r i c t l y speaking, the combustion process would be well underway before the Raney nickel powders themselves react pyrophorically w i t h the oxygen. permit the nickel powders t o be i n a localized zone which is very oxygen r ich , the powders would become incandescent before the ignit ion proper occurred. por t the incandescent par t i c les in to a region of favorable mixture ra t io . Thus, although ignit ions w i l l be obtained i n both cases they w i l l be more rapid and uniform under conditions which provide f o r thorough mixing i n the immediate v ic in i ty of the injector.
These sparks could not be
This delay could be reduced considerably by pro- Posit ive r e su l t s (e i ther sparking o r a c lear ly
If complete mixing pre-
Should incomplete mixing
The l a t t e r would be delayed by the mixing time required t o trans-
The corrected ignit ion time f o r Run 246 (Figure 21) was approximately 10 milliseconds. t ions of the program. admission of H2 gas t o the attainment of steady-state combustion. cussed previously, a t a mixture r a t i o (O/F) of 6.0, the detonation wave accompanying ignit ion was v i r tua l ly simultaneous (on the millisecond scale) with the i n i t i a l r i s e of the thermocouple trace. This is shown i n the traces f o r Runs 242 and 243 (Figure 20), which yielded corrected ignit ion times of about 60 and 1 5 milliseconds, respectively. t i v e i n Run 246. The corrected ignit ion times were obtained by subtracting the H2 gas lead time (approximately 20 milliseconds) from the t o t a l time in terval between the He valve "on" pip and the ignit ion. These data demon- s t r a t e t ha t the ignit ion characterist ics of Raney nickel i n the presence of l iqu id oxygen a re a t l e a s t as favorable as those when gaseous oxygen is used.
This represents one of the most rapid igni- It should be noted that t h i s is the t o t a l time from
A s d is-
The pressure t race was not opera-
The f i r i ngs reported i n Table IV were obtained w i t h a l l in jector hardware, including the f lu id ize r , a t l iqu id nitrogen temperature, approximately 77% (138OR). a l so a t this temperature.
Both the l iquid oxygen and gaseous hydrogen were
It is a lso of in te res t t o note t h a t the f lu id ize r , using standard check valves, operated s a t i s f ac to r i l y a t 77%. encountered with the downstream check valve, which was exposed t o the stream of gaseous hydrogen with entrained Raney nickel powder. t ha t the concept of u t i l i z i ng entrained Raney nickel should not present unusual hardware and plumbing problems.
No problems were
It therefore appears
The final experimental stage involved coollng the hydrogen stream w i t h helium, i n order t o obtain ignit ion data w i t h the hydrogen tempe- rature i n the range of 40-140°R (approximately 22-78%). with the Elark V I 1 1 device (Figures 12 and 13) . These data are given i n Table V.
This was accomplished
Figures 22 and 23 show some of the ignit ion oscilloscope traces.
-22-
![Page 32: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/32.jpg)
The first group of data i n Table V (Runs 250-264) were made at l iquid nitrogen temperature (propellants plus hardware). It can be seen t ha t the igni t ion times reported therein are consistently longer than those obtained with the former apparatus under these same experimental conditions (see Table IV) . device did not promote rapid mixing of the propellants as well as did i t s predecessor, the Mark V I I device.
It appears, therefore, t h a t the geometry of the Mark V I 1 1
Runs 265-274 were performed with l iqu id helium cooling of The hydrogen temperatures reported i n Table V were the hydrogen stream.
measured with the thermocouple designated T.C. 1 i n Figure 13. procedure, igni t ions were obtained i n the contractual temperature range. The igni t ion times observed i n Runs 265-274 were of the same magrtitu.de as those of Runs 250-264. temperature of the hydrogen stream e
With t h i s
There was no observable e f fec t on igni t ion of the lower
The lowest hydrogen temperature at which an igni t ion occurred was 57°K (lO3"R), i n Run 270, shown i n Figure 22. t i on time could not be determined i n t h i s case, due t o the fa i lu re of the hydrogen valve "ontt pip t o reg i s te r on the oscilloscope. normal, however, and could not have required over 500 milliseconds, i .e . , the same order as other igni t ions obtained with t h i s apparatus.
The exact igni-
The igni t ion w a s
Referring again t o Figure 13, it can be seen tha t the coaxial in ject ion feature, combined with the low flow rates of these labora- to ry devices, places a minimum on the permissible hydrogen i n l e t temperature. Recalling t ha t the freezing temperature of l iquid oxygen i s about 55°K (99"R), it can be appreciated t ha t hydrogen temperatures substant ia l ly lower than t h i s could lead t o p a r t i a l plugging of the oxygen flowing i n the centra l tube of the in jector e It appears, therefore, t ha t hydrogen i n l e t temperatures much below tha t of Run 270 would not be feas ible with t h i s apparatus. Additional information on t h i s subject may be gained from Runs 275-278. In Run 275, an igni t ion was obtained at 64"~. helium t o the inner Dewar was increased, i n order t o lower the temperature. When the hydrogen gas temperature read 48"~, an igni t ion was attempted, but w a s unsuccessful (Run 276). On permitting the hydrogen temperature t o r i s e s l ight ly , igni t ions were again obtained. Although one cannot say with cer- t a in ty what prevented the igni t ion i n Run 276, it i s l i k e l y t ha t p a r t i a l or complete plugging of the oxygen l ine , due t o freezing, w a s responsible.
Following th is , the flow r a t e of cold gaseous
This e f fec t could have been minimized i n the exis t ing appara- tu s by introducing the hydrogen and oxygen strearas separately i n to the igni t ion zone. The preferred coaxial in jector approach w a s followed, however, i n accord- ance with requests of the contracting agency.
i
-23-
![Page 33: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/33.jpg)
~ 2-%!!kpardt CORPIRA TION VAN NUYS, CALIFORNIA Regort 25,179
It w i l l be noted i n Figures.-22 and 23 t ha t a second thermo- couple t race appears on the oscilloscope t races . The middle t race i s due t o the Pt/Pt-10% R h fast-response thermocouples located i n the igni t ion zone immediately downstream of the in jector . The bottom t race i s the output of a similar thermocouple located further downstream, i n the exhaust tube. The l a t t e r thermocouple w a s useful for detecting ignit ions at low mixture r a t i o s and at p a r t i a l vacuum conditions, as Run 279 (Figure 23) demonstrates.
The r e su l t s obtained under p a r t i a l vacuum conditions (such as Runs 279-283) were more d i f f i c u l t t o in te rpre t . The igni t ions detected by the instrumentation usually occurred a f t e r re la t ive ly long delays (several hundred milliseconds) tha t ignit ions had occurred which were not picked up by the instrumentation, presumably due t o the f a c t t ha t they occurred downstream of the thermocouple ins ta l l a t ions . It appears, therefore, t ha t considerable work would s t i l l have t o be done i n evaluating the e f fec t of igni t ion zone geometry on mixing e f f i - ciency under vacuum conditions.
In several cases, however, post-run inspection c lea r ly showed
It i s in teres t ing t o note t h a t igni t ion Runs 279-283 were obtained from a sample of Raney nickel which had been stored for almost f ive months (under hydrogen gas) p r io r t o t h i s use. The material used i n these tests gave every indication of being as active as the other samples.
B. Ignit ion Mechanism and Storage Characterist ics of Raney Nickel
Raney nickel i s prepared by reacting a nickel-aluminum al loy ( i n the form of a f ine powder) w i t h sodium hydroxide. The reaction i s
NiA12 + 2NaOH + 4H20+2Na(H2M03) + N i f 6LH] (19)
The nascent (atomic) rhydrogen i s therefore formed i n close proximity t o the newly exposed nickel surface. hydrogen and escapes; a small par t i s chemisorbed on the fresh nickel surfaees. In simplified notation,
Most of th i s nascent hydrogen forms molecular
Thus the Raney nickel contains some chemisorbed hydrogen as a d i rec t r e su l t of i t s method of preparation.
In the usual application, the product i s stored under an i ne r t carr ier , such as ethanol, u n t i l ready for use. During t h i s period, slow but continual evolution of hydrogen may be observed. the gradual desorption of the chemisorbed hydrogen. weeks, at most, the Raney nickel loses i t s ac t iv i ty .
This doubtless represents In a period of a f e w
-24-
![Page 34: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/34.jpg)
. Haryuardt IWRPORATIOIY VAN NUYS, CALIFORNIA Report 25,179
It was evident, therefore, t ha t a more suitable storage tech- nique would have t o be developed which would permit long-term storage of the material i n the active s t a t e . Theoretical considerations indicated the desir- a b i l i t y of storage under an atmosphere of hydrogen, preferably i n the form of the dry nickel powder under hydrogen gas at ambient conditions. This w a s done, with indications of a v i r t ua l l y indef ini te storage l i f e under these l a t t e r conditions. The experimental arrangement w a s as follows:
Eight samples were withdrawn from a common source of Raney nickel-methanol sludge. One sample w a s placed i n each of eight f lasks, and immediately covered with methanol. Next, the eight flasks were simultaneously evacuated t o dryness. mately 100,UHg. f lasks, t o approximately atmospheric pressure, These f l asks were then s e t aside, t o serve as long-term storage t e s t s . remainder of the contract period, these f l asks were opened and tes ted fo r pyrophoricity i n ambient air. cryogenic-temperature igni t ion t e s t s .
The exact pressure was not measured, but was approxi- Hydrogen gas w a s then admitted simultaneously t o the eight
A t various times throughout the
Some of these samples were a l so used i n
The r e su l t s of these t e s t s were as follows:
Sample Total Storage Time Condition , No. Under Ambient H2 Gas when Openex Remarks
1 7 Days Intensely pyrophoric
2 14 Days I t t?
t? tt 3 29 Days
4 58 Days tl t? Used successfully i n en- trained metal igni t ion t e s t s , Runs 190-194
5 86 Days If I? Low- temperature i gni - 6 120 Days ( 23 4 months) t'
7 159 Days ( NN 5 months) tl I t Used successfully i n low-
t ions obtained tt
temperature vacuum igni- t ions, Runs 279-283
The procedure i n opening these f lasks was t o quickly evacuate t o a crude vacuum ( t o remove the bulk of the gaseous hydrogen, and back- f i l l with nitrogen gas. phere, in to the f lu id ize r ,
The contents could then be transferred, under an i n e r t atmos-
-25-
![Page 35: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/35.jpg)
These observations represent, as f a r as i s known, the longest storage periods at tained with Raney nickel . Quali tat ively, each of these samples w a s immediately pyrophoric upon contact with air, with no observable decrease i n ac t i v i t y with storage time. According t o the theoret ica l model described ea r l i e r , there should be no reasonable l i m i t t o the shelf l i f e of Raney nickel powder stored under these conditions.
It w a s next necessary t o demonstrate conclusively t ha t the pyro- phorici ty of the Raney nickel being used i n these t e s t s i s due t o a chemi- sorbed layer of hydrogen, ra ther than simply being a r e su l t of the s m a l l pa r t i c le s ize of the nickel powder. simple experiment.
This w a s accQmplished by the following
Two dif ferent samples were withdrawn from a common batch of Raney nickel stored under methanol; t h i s parent batch of nickel was shown t o be pyrophoric j u s t before the samples were withdrawn. The two samples were then evacuated t o dryness (at approKimately 100/ccHg), and then back-filled with ambient nitrogen gas. After a short period of time, both samples were exposed t o the air and found t o be completely inactive (nonpyrophoric). These same two samples were then returned t o the vacuum desiccator and re- evacuated, followed by back- fi l l ing with ambient hydrogen gas. Two days l a t e r , these samples were exposed t o air ( a f t e r pumping off the hydrogen gas) and found t o pyrophoric. the theoret ica l model presented previously.
These r e su l t s are i n complete agreement with
Additional ve r i f i ca t ion came from t e s t s i n which reacted, oxi- dized Raney nickel (now i n the form of nickel oxide) w a s regenerated. w a s done by reducing under hydrogen at about 300°C and removing the water formed by the reaction:
This
N i O + H2--) N i + H20.
Upon chemisorbing a layer of hydrogen onto the reduced nickel powder, the l a t t e r w a s again made active, as evidenced. by i t s pyrophoricity.
A s a r e su l t of the preceding observations, the igni t ion mech-
The ca ta ly t i c a c t i v i t y of Raney nickel f o r low temperature H2/
anism of Raney nickel may be summarized as follows:
02 igni t ion i s due sole ly t o a pre-existing layer of chemisorbed hydrogen. This serves t o produce igni t ions by one or both of two main paths. i s based on the f ac t tha t the chemisorbed hydrogen has a s m a l l but f i n i t e tendency t o desorb, producing an extremely small concentration of hydrogen atoms i n the v i c in i t y of the nickel surface. This i s the same as Reaction (18) , discussed previously.
The f i r s t
This very s m a l l concentration af f r e e hydrogen
-26-
![Page 36: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/36.jpg)
atoms may react with oxygen molecules t o i n i t i a t e the combustion process by Reactions (6-10) described i n Section I. may react d i rec t ly with the chemisorbed hydrogen atoms, t o produce f ree radical species, such as OH, which could then desorb and t r igger the combus- t i on reaction by a similar process.
Alternatively, --the oxygen molecules
The heat release associated with these reactions, which occur e i the r on or very near the nickel surface, r a i s e s the temperature of the nickel pa r t i c les . The l a t t e r , due t o t h e i r small thermal mass, quickly a t t a in a temperature suff ic ient t o promote the d i rec t oxidation reaction between elemental nickel and oxygen; i . e . , the nickel powders are pyrophoric. Although t h i s pyrophoricity may be quite useful i n promoting an ignit ion, it def in i t e ly represents a secondary process, resul t ing from the primary cata- l y t i c reaction involving the chemisorbed hydrogen. with no change i n par t i c le s ize or configuration, the nickel i s no longer pyrophoric.
Upon removal of the l a t t e r ,
C . G a s Adsorption' Studie's'
One of the purposes of the gas adsorption studies was t o obtain information concerning the surface area of the Raney nickel powders. This w a s done i n a volumetric apparatus, using standard B.E.T. nitrogen adsorption techniques (35).
The surface area determined by t h i s method for two di f ferent batches of Raney nickel powder was approximately 50 m2/g (square meters per gram of nickel powder). In comparison, a sayple of the pure platinum cata- l y s t used e a r l i e r i n the program had a surface area of 6 m2/g. accordance with the greater a c t i v i t y observed fo r the Raney nickel at low temperatures as compared t o the platinum black.
This i s i n
Additional information on t h i s subject i s provided from the data of Figures 24 and 25, which show hydrogen adsorption isotherms for these two materials.
The present discussion i s concerned with the adsorption iso- therms at ambient temperature. (298-300°K), since these curves may be expected t o represent the desired phenomenon of chemisorption (as opposed t o the physical adsorption which may occur at lower temperatures) e
It can be seen from these curves t ha t the Raney nickel chemi- sorbs considerably more hydrogen per uni t weight than the platinum black. Even on the basis of ca ta lys t volume ( t o take i n to account the greater den- sity of platinum) the Raney nickel adsorbs more hydrogen..
-27-
![Page 37: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/37.jpg)
The significance of these curves i s t ha t the amount of chemi- sorbed hydrogen i s a measure of the amount of f ree hydrogen atoms which may be available t o produce a ca ta ly t i c ignit ion.
It must be emphasized tha t the f i e l d of adsorption measurements i s a complex one, par t icular ly as it applies t o the Raney nickel powders. After a rapid i n i t i a l uptake of hydrogen, long periods of t i m e ( 2 days or more) were sometimes required t o reach f i n a l equilibrium. This could represent a specif ic type of activated chemisorption, complicated by the diffusion pro- cesses involved i n permeating through the nickel powder. Further work would be required i n order t o provide unambiguous in terpre ta t ion of the data shown i n Figures 24 and 25.
-28-
![Page 38: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/38.jpg)
Maryuardt CORPORATION VAN Nurs, CALIIOINIA Report 25,179
Tv. EVALUATIOR OF EXPERIMENTAL DATA
The preceding section gave br ie f analyses of each group of data, at The purpose of this section i s t o r e l a t e the time those data were presented.
a l l the previously reported observations with the general question of the f ea s ib i l i t y of producing re l i ab le low-temperature igni t ions i n f u l l - size rocket engines.
A. General Summary and Conclusions
One of the main goals of t h i s program w a s t o investigate novel, unconventional methods of producing low-temperature H2/02 igni t ions e
the f luidized metal powder concept w a s of prime in t e r e s t ( ra ther than a fixed cata lys t bed), a matter of some concern was the development of ca ta ly t i c and/ or pyrophoric metal powders of much lower cost than the noble metals such as platinum and palladium.
Since
Theoretical considerations ea r ly i n the program l e d t o i n t e r e s t i n materials of the Raney nickel type. It was decided t o investigate the low- temperature igni t ion character is t ics of Raney nickel, and t o simultaneously determine i f t h i s material could be put in to a form possessing indef ini te shelf l i f e i n the activated s t a t e .
Results of both of these tasks were highly encouraging. f inely divided Raney nickel powders entrained i n the hydrogen gas stream, a large number of cryogenic igni t ions with l iquid oxygen were obtained. t ion times of the order of 10 milliseconds were observed i n the most favorable conditions. igni t ion zone t o the detonation pulse accompanying a c lea r ly defined igni t ion. The most rapid of the igni t ions observed i n t h i s program were of the same order a$ cer ta in l imit ing conditions, primarily the hydrogen gas lead time. The above f igure of 10 milliseconds does not, therefore, appear t o represent a l i m i t . t i on process could be sub-divided by the instrumentation i n use i n t h i s pro- gram, which w a s primarily of a screening nature.
Using
Igni-
This represents the time from admission of hydrogen gas in to the
It represents, rather, the smallest time increment i n which the igni-
The lowest hydrogen gas temperature (measured at the in jector) at which an igni t ion w a s recorded w a s 57°K ( l 3 O " R ) . appear t o represent a fundamental l i m i t , but ra ther r e f l e c t s l imi ta t ions imposed by the specif ic apparatus and experimental conditions involved. par t icular it should be noted tha t the coaxial in ject ion technique ut i l ized, together with the small flow r a t e s involved, tends t o place l imi ta t ions on how low the hydrogen gas temperature may be i n the immediate v i c in i t y of the in jector . Chief of these i s the f ac t t ha t the l iquid oxygen, flowing i n the centra l tube, may approach i t s freezing point (approximately 55°K) should the temperature of the surrounding hydrogen, flowing through the annulus, be substant ia l ly colder e
Again, t h i s does not
In
-29-
![Page 39: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/39.jpg)
It is believed t h a t ignit ions could be obtained with lower hydro- gen temperature, provided that di f ferent injection techniques, o r l a rger flow ra tes , were employed.
It is fur ther believed that the observed variat ion i n igni t ion times is primarily a function of the degree of mixing a t ta ined i n the igni- t i on zone. It appears that development work is necessary on the de t a i l s of ignit ion zone geometry, pa r t i cu la r ly with regard t o vacuum ignit ions.
The second major task has produced conclusive theoret ica l and experimental observation t o demonstrate that Raney nickel powder may be stored indef ini te ly i n the form of a dry powder under an atmosphere variety of means might be employed t o introduce t h i s ca ta ly t i c (and a l so pyro- phoric) agent in to the ignit ion zone. involved entrainment in to the hydrogen stream (from a cata lys t f lu id ize r ) j u s t upstream of the injector. low t o j u s t i f y t h i s approach.
of hydrogen. A
The technique u t i l i zed i n t h i s program
The price of Raney nickel powder i s suf f ic ien t ly
B. Itemized Discussion of Results
This sub-section presents a br ief itemized discussion of the resu l t s of this program as they apply t o the specif ic items l i s t e d i n the Scope of Work.
1. Analytically investigate the f e a s i b i l i t y of using metal powders as ca ta lys ts f o r hypergolic ignit ion of hydrogen-liquid oxygen mixtures.
This was performed during the l i t e ra tu re survey a t the beginning of the program. i n Raney nickel, which possesses both cata lyt ic and pyrophoric properties.
"his analyt ica l investigation resulted i n i n t e r e s t
2. Select the metal powders which appear most promising theo- re t i ca l ly , then experimentally determine the ignit ion character is t ics of hydrogen-liquid oxygen combustion ignited through the use of each type of powder, the parameters t o be varied according t o the following:
a . Hydrogen temperature, 4OoR t o lbOR.
b. Combustion chamber pressure, 0.5 psia to 1 5 psia.
-30-
![Page 40: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/40.jpg)
e. O/F ra t ios , 4.0 t o 6.0 and 0.5 to 1.5.
d. Powder concentration be varied as required t o achieve sa t is factory igni t ion.
This was performed, primarily fo r Raney nickel, which w a s Experimental work was also the material of major i n t e r e s t i n t h i s program.
performed on cer ta in types of platinum and palladium ca ta ly t ic powders.
Other types of m e t a l powders were a lso considered, including There w a s not suff ic ient Raney cobalt and f ine ly divided pyrophoric aluminum.
time t o evaluate a l l of these materials, however, since specia l preparative
materials are also of in te res t , Raney nickel appeared t o represent the best compromise
% techniques would generally be required. It was decided that , although other
Hydrogen temperatures were investigated i n the designated range. For reasons specified previously, equipment and experimental condi- t ions placed a prac t ica l lower l i m i t on the hydrogen temperature (at the in jector) of about 50°K (9OOR) . i n l e t temperature of 57°K.
An igni t ion was obtained at a hydrogen
The majority of t es t ing was done at atmospheric pressure. Ignit ions were obtained under p a r t i a l vacuum conditions (down t o about 2 psia) , but these were more d i f f i c u l t t o in terpre t than those at ambient pressure. It i s believed t ha t the igni t ion zone geometry i s a c r i t i c a l variable here.
Ignit ions were obtained at nominal mixture r a t i o s covering the above range. The evidence of this report i s t h a t more re l iable , rapid igni t ions are obtained with Raney nickel at the higher mixture ra t ios , par- t i cu l a r l y at O/F = 6 .O .
The concentration of Raney nickel powder i n the hydrogen stream d i d not seem t o be an important variable. It was visual ly observed during cryogenic t e s t s t ha t the individual pa r t i c les of Raney nickel would become incandescent upon contact with l iquid oxygen (due t o t he i r pyro- phorici ty) - S t r i c t l y speaking, even one such incandescent par t i c le should be suff ic ient t o produce igni t ion. The efficiency of the mixing process i n the immediate v i c in i t y of the in jector appears t o be the c r i t i c a l parameter i n t h i s regard.
3. Investigate the e f fec t of variables which might be a prob- lem i n actual rocket engine systems using powdered metal igni t ion. of these variables includes, but i s not res t r i c ted to :
A l i s t
-31-
![Page 41: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/41.jpg)
. . Maryuardt CORpllRATlON VAN NUIS. C A L I ~ O R N I A Report 25,179
a . P a r t i a l oxidation of the powder.
b. Powder pa r t i c l e agglomeration.
c. Powder pa r t i c l e s ize .
Since Raney nickel powders a re pyrophoric, it is evident that contact w i t h a given mass of a i r w i l l result i n the oxidation of a stoichiometric amount of the nickel powders. The oxidized nickel powder has no ca ta ly t i c a c t i v i t y f o r the proposed application. consider the recommended ins ta l l a t ion i n which the Raney nickel is stored a s a dry powder under an atmosphere of ambient hydrogen gas. consequences of three di f ferent types of f a i l u r e conditions (which may reason- ably be expected t o cover the range of possible occurrences).
In p rac t ica l terns ,
Consider now the
(1) f lu id ize r vessel t o the atmosphere (due t o a hypothetical mistake, o r t o t o t a l mechanical f a i l u r e of the vessel).
Complete and sudden exposure of the contents of the
(This condition was simulated a t various times during th i s contract when sealed samples of Raney nickel were exposed t o a i r t o tes t f o r pyrophoricity. )
The en t i re mass of Raney nickel powder would be oxi- dized i n a very rapid reaction. most, a very few milliseconds a f t e r exposure t o a i r . there is a b a l l of flame surrounding the powders, which pers i s t s on the order of one t o a few seconds. t o the oxidation of the large amount of chemisorbed hydrogen present on the surface of the metal pa r t i c les .
This reaction would be i n i t i a t ed in, a t During the reaction,
This phenomenon is doubtless due primarily
Although the reaction is very rapid, accompanied by a large heat release, it does not consti tute an explosion. reasons f o r th is . A l s o , the nickel powders a r e so reactive i n the presence of a i r that the par t ic les would be oxidized before suf f ic ien t time could elapse disperse throughout an area as a dust suspension. t i on normally associated w i t h explosions involving f i ne ly divided powders.
The hydrogen atmosphere, under which the powder had
There a re two The main reaction product i s a so l i d (nickel oxide).
The l a t t e r is the condi-
been stored, would of course igni te a t once; it should be noted, however, that the actual mass of hydrogen gas required f o r t h i s function would be re la t ively quite small. That is , essen t ia l ly a l l the inner bulk volume of the f lu id ize r would be occupied by the nickel powders. The f ree hydrogen gas would occupy only the in ter- par t ic le void volume. This hydrogen gas could therefore be expected t o be consumed i n essent ia l ly a single sheet of flame. t ion of the nickel par t ic les .
The lat ter would occur simultaneously with the combustion reac-
-32-
![Page 42: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/42.jpg)
Summarizing this worst possible case, one may s t a t e t ha t the results would be essen t ia l ly as follows.
(a) complete and rapid combustion of the f lu id ize r contents, associated w i t h one t o a f e w seconds of v is ib le flame, and large heat release
(b) no explosion
Moderate leak of a i r into the f lu id ize r in te r io r (due t o hypothetical improper assembly, f o r example) but overal l mechanical inte- g r i t y of f lu id ize r not impaired.
(2 )
This condition would r e su l t in a rapid temperature r i s e of the contents of the f lu id ize r , perhaps t o 3 0 O - b O 0 C , depending on the sever i ty of the leak. The temperature should not r i s e high enough t o damage metal components, but would be suff ic ient t o damage or destroy rubber o r p l a s t i c materials i n the immediate v ic in i ty ( i .e . , ' 0 ' rings, gaskets, e t c . ) . There would be very l i t t l e likelihood of open flame or an explosion, since the oxygen of the a i r would be quanti tat ively consumed as it passed over the closely packed nickel powders. An a i r leak of t h i s magnitude could be expected t o render the f lu id ize r contents ca ta ly t i ca l ly inactive within a few minutes t o an hour. detected by standard means ( i .e . , a
The onset of such an occurrence could readily be thermocouple act ivated relay).
Very small a i r leak into f lu id ize r contents. (3)
Such a process, if permitted t o continue unchecked, could lead t o oxidation and deactivation of the nickel powders over a period of hours o r days. It appears l ike ly , however, tha t a sensit ive thermocouple, located within the f lu id ize r , could detect quite small a i r leaks, due t o the heat release associated w i t h the pyrophoric reaction of Raney nickel.
There would be no s ignif icant external e f fec t s .
It should be pointed out that a small posit ive pressure of hydrogen gas within the f lu id ize r could be expected to effec- t i ve ly eliminate this source of contamination.
Regardless of how it could conceivably occur, however, p a r t i a l oxidation of the nickel powders would be detrimental. could s t i l l be obtained, but more of the f lu id ize r contents would have t o be entrained in to the combustion zone i n order t o obtain an equivalent amount of act ive powder. This would require longer, and l e s s uniform, ignit ion time delays. extent of powder oxidation.
Ignitions
The magnitude of this e f fec t would of course be a function of the
-33-
![Page 43: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/43.jpg)
Maryuardt G0RN)MTION VAN NWS, CALI IOINIA Report 25,179
Based upon the observations of t h i s program, it appears that, quali tat ively, p a r t i a l oxidation amounting t o t a l could perhaps be tolerated. This statement is based on the f a c t t ha t ignitions were obtained i n cases i n which it was cer ta in that a f ract ion of the Raney nickel powders had been oxidized.
t o a t l e a s t a few percent of the
There was no agglomeration tendency of the dry Raney nickel powders observed a t any time during t h i s program. in to contact w i t h water, they would form a sludge. o r grease contaminants, however, the evidence of t h i s work is t ha t pa r t i c le agglomeration should not be a problem area with the use of Raney nickel pow- ders as prepared i n th is program.
Should the powders come In the absence of moisture
Auantitative data a re not available a t t h i s time concerning the absolute magnitude of the Raney nickel pa r t i c le size. speaking, however, the par t i c le s ize is controlled d i rec t ly by the method of formation of the Raney nickel, and by the par t i c le s ize of the or ig inal nickel-aluminum al loy used. The chemical procedures involved i n the formation of Raney nickel are straightforward. minor variations i n the specif ic procedure used had no observable e f fec t on the par t i c le s ize of the f i n a l dried Raney nickel powder. The nickel-aluminum a l loy used as s t a r t i ng material is a widely available commercial product which appears t o be quite uniform i n character. me re was no observable difference between any of the several batches of Raney nickel prepared during th is con- t r ac t . Every batch of Raney nickel powder tes ted i n the f lu id ize r was success- f u l l y entrained i n the hydrogen stream. used i n t h i s work was by no means an optimum design.
Pract ica l ly
The experience of t h i s program is that
It should be noted t ha t the f lu id ize r
4. Consider the re la t ive merits of:
a . Mixing powder w i t h l iquid hydrogen in the propellant tank, and
b. Injecting powder in to the combustion chamber o r hydrogen feed l i ne , and a lso consider the effects of metal pow- ders on turbine bearings, valves, e tc .
A s mentioned previously, the only method of entrainment used experimentally i n t h i s program was that of f lu idizat ion of the nickel powders i n the gaseous hydrogen upstream of the injector.
The poss ib i l i ty of s tor ing the Raney nickel a s a powder mixed w i t h the l iquid hydrogenein the main propellant tank was considered analytical ly. primarily due t o the very large density difference (a fac to r of 127) between the nickel powders and l iqu id hydrogen.
The f e a s i b i l i t y of t h i s approach did not appear high, however,
Only if very f i ne par t i c le sizes were
-34-
![Page 44: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/44.jpg)
uuluI VAN NUYS, CALlfOlNIA Report 25,179
u t i l i zed (of the order of 10-100 8 i n diameter) would the phenomena associated w i t h Brownian motion be expected t o allow the par t i c les t o remain i n suspen- sion. sions does not appear t o be feas ible a t present. Experimental study of t h i s subject would represent a substant ia l program i n itself. If l iqu id hydrogen can be gelled, this might be a means of suspending the Raney nickel powders. However, the amount of gellant required might compromise the performance potent ia l of the hydrogen.
The preparation and s tab i l i za t ion of par t icula te matter of such dimen-
Observations were made i n a l l t e s t s concerning any problems which might a r i s e due t o the act ion of the metal powders on valves and other f i t t i ngs . problem area, but one which can be surmounted by proper design. For example, standard check valves were exposed t o the flow of hydrogen gas plus entrained nickel powders. Some plugging and valve st icking occurred, but t h i s was largely eliminated by such simple expedients as enlarging por t areas and increasing annular clearances. appears t ha t the very small par t i c le s ize and non-agglomerating character of the Raney nickel powder render t h i s system amenable t o use with a wide range of hardiqare components.
The indications of this program were t ha t this is potent ia l ly a
More work on th i s subject is needed, but it
C . Recommendations
It is believed t h a t th i s program has demonstrated the feas ibi- l i t y of obtaining re l i ab le low-temperature ignit ion of hydrogen and oxygen by the use of Raney nickel powder entrained i n the hydrogen stream. Based on t h i s work, the following system i s proposed. Dry Raney nickel powder is con- tained i n a small f lu id ize r vessel located near the rocket engine. The f lu idizer , f i l l ed with the nickel powders, is maintained under a s l i gh t posit ive pressure of ambient temperature hydrogen gas. gaseous hydrogen is caused t o flow through the f lu id ize r , entraining nickel powders in the process. the main hydrogen flow, o r it may be desired t o tap off d i rec t ly from the main hydrogen tank.
Upon engine start,
This hydrogen stream may be obtained a s a bleed from
The hydrogen stream leaving the f lu id ize r flows in to the injec- t o r , where it mixes w i t h a sui table flow r a t e of e i t he r l iqu id o r gaseous oxygen, producing an ignition.
This basic concept has been demonstrated by the ignit ions A system such as t h i s would possess multiple obtained i n this program.
restart capabi l i t ies under space conditions, and would not be significantly affected by wide variations i n the range of propellant inlet conditions.
-35-
![Page 45: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/45.jpg)
, _ . I
’ . * Haryuardt CVRFVRATION V A N NUIS, EALICOINIA , Report 25,179
The main areas i n which fur ther work would be required are:
a . optimum f lu id ize r design
b. attainment of thorough mixing, in the immediate v ic in i ty of the injector, between the entrained powder hydrogen stream, and the corresponding oxygen stream.
It appears that the l imitat ions which were encountered during t h i s program were due p r h r i l y t o l imi ta t ions of the laboratory scale hardware involved, and t ha t even more encouraging results would be obtained from larger- scale t e s t s . It is a l so recommended that experimental study be continued on the subject of the optimum method of introducing the Raney nickel powder in to the ignit ion zone.
-36-
![Page 46: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/46.jpg)
1. Gibson and Hinshelwood, Proe .Roy.Soc . , - 118~': 170 (1928) ; - I l g A : 591
A. A. Kovalskii, Pys.Z.Sowjet. - 4, 723 (1933). (1928)
2.
4.
5.
6.
8.
10.
11 s
12.
Semenov, N . N., Some' Problem's' of Chemical Kinetics and Reactivity, Vol. 2, p. 47, Pergammon Press, New Yrok (1959).
Lewis, B. and G . Von Elbe, Combustion, Flames, and Explosions of Gases, Academic Press, New York (1951).
Duff, R . E. , J.Chem.Phys., - 28, 1193-1197 (1958).
Adkins, H., and Pavlic, A. A . , J.Am.Chem.Soc., - 69; 3040 (1947).
Adkins, H.
Brown, D. J., J.Soc.Chem.Ind., - 69', 355 (1950).
Covert, L. W., and Adkins, H., J.Am.Chem.Soc., 5q, 4116 (1932).
Feulgen, Ber., _. 54, 360 (1921) e
Hurd, C . D., and Rudner, B., J.Am.Chem.Soe., - 73, 5157 (1951).
Mozingo, R. , ibid, - 66, 1015 (1943).
Adams, R., e t a l a , Organic Syntheses, C011,- Vol. - 1, 463 (1941).
Starr , D., and Hixon, R . M., ibid, Coll,. Vol. -9 2 566 (1943)
Bi l l i ca , H. R., and Adkins, H., ibid, Coll,. V o l . c 3, 176 (1955)
Neuman, F. W., e t al., ibid, Coll. V o l . - 3, 519 (1955).
Mozingo, R., i b i d , Coll, Vol. c 3, 685 (1955).
and Bi l l i ca , H. R . , ibid, - 7'0, 695 (1948).
18.
19.
Pavlic, A. A., and Adkins, H., J.Am.Chem.Soc., - 68, 1471 (1946).
Raney, U. S . Patent No a 1,628,190 (1927) a
-37-
![Page 47: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/47.jpg)
* ' Maryuardt WRPORATION VAN NUYS. CALIFORNIA Report 25,179
20.
21.
22.
23
24
25
26.
27
28 a
29
30 *
31.
32 9
33 *
34
35 9
R a l l s J. W. , Dodson, R. M., and Riegel, B,, J.Am.Chem,Soc., - 71, 3320 (19493 9
Shriner, R . L., and Adams, R , , ibid, - 46, 1683 (1924).
Bahn, G.S., Pyrodynamics, 3, 27-39 (1965). Fat t , I., and Tashima, M., "Alkali Metal Dispersions", D. van Nostrand, Princeton, N, J. (1961).
Fraser, A , N., and Gibbard, J., Canad. J . Research, - lo', 133 (1932).
Hauser, E. A . , "Colloidal Phenomena", McGraw-Hill, N.Y. (1939) e
Jirgenson, B., and Straumanis, M. E., "A Short Textbook of Colloid Chemistry", 2nd Ed., MacMillan, N.Y. (1962).
McBain, J. W., "Colloid Science", D. C . Eeath, N.Y. (1950).
Mysels, K. J., "Introduction t o Colloid Chemistry", Interscience, N.Y. (1.959)
Packter, A . , J . Phys. Chem., - 62', 102.5 (1958).
Richter, K., Kolloid-Z., - 61', 208 (1932)
Shinoda, K., e t al., tt Colloidal Surfactants", Academic Press, N.Y. ( 1963 1 =
Stauff, J., "Kolloidchemie", Springer Verlag, Ber l in ( 1960) . Svedberg, T., "Colloid Chemistryf', Chemical Catalog Co., N.Y e (1924) a
Weiser, H. B., "A Textbook of Colloid Chemistry", 2nd Ed., Wiley & Sons, N.Y. (1949).
Brunauer, S., ESnmett, P. H., and Teller, E., J.Am,Chem.Soc., - 60, 309 (1938) -
![Page 48: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/48.jpg)
b
PRELIMINARY H 2 - O2 I G N I T I O N ASSEMBLY
MARK I
\ N2 PURGE LINE
WMETER
3LENOID ALVE
R - l 9 , O 9 0
N2
I GNlTlON r F L O W ETER
SOLENOID VALVE
,,/’ L. G L 2 A ~ ~ ~ s T \ DEWAR FLASKS
H2
-39- Figure 1
![Page 49: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/49.jpg)
IGNITION DEVICE MARK I I
EXHAUST TUBE
OXYGEN
GLASS WOOL
CATALYST POWDER I I \
HYDROGEN N I TRO GEN PURGE
Y
GLASS WOOL
LIQUID N2 COP PER CON S TAN TAN/ TH ERM OCOU PLE S
R-19 ,I 74 -40-
Figure 2
![Page 50: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/50.jpg)
IGNITION DEVICE MARK 1 1 1
R-19 ,I 64 Figure 3 -41-
![Page 51: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/51.jpg)
IGNITION DEVICE MARK 1 1 1
R-19,170 Neg. 6494-2
-42- Figure 4
![Page 52: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/52.jpg)
0
IGNITION DEVICE MARK IV (SCHEMATIC)
su
NEEDLE
PPORT CO
EXHAUST PATH^ VACUUM COUPLING
1 PPER / CON STAN TAN THERMOCOUPLES--
VACUUM GAUGE
RETAINER SCREEN
CATALYST AND GLASS WOOL
+ TO VACUUM
BALL VALVE
-BLOWOFF VENT
-Pt/Pt-lO% Rh THERMOCOUPLE
u 2 0 0 MESH NICKEL SCREENS -THERMAL PATH RESTRICTION
\.CATALYST
-DEWAR
R-19,247 -43- Figure '5
![Page 53: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/53.jpg)
IGNITION DEVICE MARK I V (ASSEMBLED)
R- 19, 244 Neg. 6542-2 -44- Figure 6
![Page 54: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/54.jpg)
' Maryuardf VAN NUVS, CALIFORNIA Report 25,179 C0RA)RATlATHIN
COAXIAL IGNITION DEVICE MARK V '
EXHAUST TUBE
P+/ P+-1 0 % COPPER/CONSTANTAN THERM OCOU THERMOCOUPLE
PRESSURE TRANSDUCER NICKEL SCREEN CATALYST
INLET GAS N i TRO GEN THERMOCOUPLE
THERMAL PATH RESTRICTION
Figure 7 -45-
![Page 55: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/55.jpg)
COAXIAL IGNITION DEVICE -MARK V
R- 1 9,474 Neg. 6655-1 -46- Figure 8
![Page 56: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/56.jpg)
COAXIAL INJECTOR NOZZLE AND SENSORS MARK V
R- 19,476 Neg. 6655-3 -47- Figure 9
![Page 57: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/57.jpg)
w 0
> w n
-
N 0 \
I N
0 z I- v) 3
X W P
W
Q > 3
K W V 3
In 2 =x er t- W K D v) v) W K
a
n
W
=x > 3
P 0
0 In cu 0
I
II. z
fl 0 z W -1 0 v)
cu
R-19,945
-48- Figure 10
![Page 58: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/58.jpg)
COAXIAL IGNITION DEVICE MARK V I 1
EXHAUST TUBE
Pt/ Pt-1070 Rh THERMOCOUPLE THERMOCOUPLE
COPPER/CON STAN TAN
NITROGEN PURGE THERMOCOU PL
LIQUID - OXYGEN n
Y - [ THERMAL PATH
RESTRICTION
R-19,471A -49- Figure 11
![Page 59: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/59.jpg)
>- m E
A
W v, m a z 0
9 >
M >
R-20,220 I
Figwe -12
![Page 60: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/60.jpg)
Maryuardt VAN NVYS, CAl I fORNIA Report 25,179
WRKIRA TON
D E T A I L OF MARK V l l l I G N I T E R
EXHAUSTTUBE
GH FROM LN2 5 RE-CHILL
?
t i
LO2 GN2 FROM LN2
CHILL
INNER /DEWAR
R-20,219 -51- Figure 13
![Page 61: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/61.jpg)
OS C I LLOS COPE I GN IT I ON TRACES PRELIMINARY TESTS WITH FIXED BED RANEY NICKEL CATALYST
0 AND H2 VALVES ON W l c m r" 2 E 0 \
0 > E (v
U -
4
Y-
E a,
w 1 a z) 0 0 0 z @L w , I I- TIME, 200 msec/cn
RUN 110; 98°K (176"R), 1 atm
CORRECTED IGNITION TIME = 180 msec
0 AND H2 VALVES ON f - 2
1cm
w I * I- TIME, 200 msee/cm
RUN 108; 95"K(171°R), 1 atrn
CORRECTED IGNITION TIME = 1 3 0 msec
R-l9,32 2 -52- Figure 14
![Page 62: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/62.jpg)
' Maryuardi WRWRA TON VAN NUYS, CALIFORNIA Report 25,179
OSCILLOSCOPE IGNITION TRACES
PRELIMINARY TESTS WITH FIXED BED RANEY NICKEL CATALYST
O 2 AND H2 VALVES ON ~ l c m /-
W J a
TIME, 200 msec/cm RUN 114; 97°K (175"R); p = 2.2 psia CORRECTED IGNITION TIME = 700 msec
H VALVE ON (02 LEAD) H1 cm f - 2
,THERMOCOUPLE
-PRESSURE TRANSDUCER
TIME, 200 msec/cm RUN 126: 91°K(1640R); 1 a h
CORRECTED IGNITION TIME = 45 msec
R-l9,32 3 -53- Figure 1-5
![Page 63: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/63.jpg)
GAS FLOW CALIBRATION RUNS M A R K 1 1 1
ATMOSPHERIC PRESSURE, AMBIENT TEMPERATURE
0 VALVE ON f - - 2
I w E 2 m m W CY a E W a 5 a I 0
A
TIME, 200 msec/c!n
RUN 115; 0, FLOW ONLY (STEADY STATE FLOW = 7.9 x lO-’g/sec) L
H l c r n H VALVE ON /----2
w CY 3 m m W CY
CY W c13 3 I 0
a
a
RUN 116;
R-19,324
TIME, 200 msec/cm
H2 FLOW ONLY (STEADY STATE F L O W = ~ . ~ X ~ O - ~ g/sec)
-$4=. Figure 16
![Page 64: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/64.jpg)
' H a r y u a r d t CORHJRA TON VAN Nurs. c A i i F o m i i A Report 25,179
OSCILLOSCOPE IGNIT ION TRACES FIXED BED CA ALYSTS; COAXIAL INJECTION
1 cm O 2 VALVE ON /--- H VALVE ON
r H 2 VALVE oN
TIME, 1 0 d msec/cm RUN 164, 126"K, 1 atm
RAN EY NICKEL (M ODlFl ED PREPARATION)
lMOCOUPLE TRACE
IGNITION TIME = 40 msec
.E TRACE
>COUPLE TRACE
I GNl TI0 N
TIME = 10-20 msec
TIME, 200 msec/ cm RUN 146, 134"K, 1 atm
570 PALLADIUM ON ACTIVATED ALUMINA (MODIFIED) R-19,820 -55- Figure 17
![Page 65: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/65.jpg)
. I Maryuardt CORFORA TION V A N NVYS. C A l l F O R N l A Report 25,179
OSCILLOSCOPE I G N I T I O N TRACES RANEY NICKEL POWDER ENTRAINED IN H2 STREAM
cm IGNITION PRESSURE SURGE C RUN NO. 191, 90"K, 1
ON
O/F= 6.0; O2 LEAD
CORRECTED I GNl TlON TIME = 20 rnsec
atrn
RUN NO. 192, 9OoK, 1 atm
ON O/F = 6.0; O2 LEAD
CO RR EC TE D I GN I T ION TIME = 30 msec
:ACE
R-19,944 - 56 Figure 18
![Page 66: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/66.jpg)
I Maryuardt CORPORATION V A N NUYS, CALIFORNIA Report 25,179
w ce 3 v) v) w ce
IY w
a
m 5 a I 0
OSCILLOSCOPE IGNITION TRACES RANEY NICKEL POWDER ENTRAINED IN H2 STREAM
H VALVE ON H 1 c m /- 2
RUN NO. 213 CALIBRATION RUN, H2 GAS ONLY FLOWING, AMBIENT
TIME, 200 msec/cm
1 1 kDETONATI0 N WAVE
TIME, 200 msec/cm
R-2 0 , 0 1 6 -57-
U
RUN NO. 219, 90°K, 1 atm
O/F = l . 5 j O2 LEAD
Figure 19
![Page 67: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/67.jpg)
OSCILLOSCOPE IGNITION TRACES RANEY NICKEL POWDER ENTRAINED IN H2 STREAM
t---=jl cm LIQUID OXYGEN INJECTION
TIME, 200 msec/cm
t-+/ 1 cm
- TIME, 200 msec/cm
RUN NO. 242, 77"K, 1 atm
O/F= 6.0, LO2 LEAD
CORRECTED IGNITION TIME = 60 msec
RUN NO. 243, 77'K, 1 atm
O/F= 6.0, LO2 LEAD
CORRECTED IGNITION TIME = 15 msec
R-20,083 -58- Figure 20
![Page 68: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/68.jpg)
’ Maryoarard-t VAN NVYS. CAllFORNlA Report 25,179 \ CORFORA TION
0 S C I LLOS COP E I GN I T I ON TRACES
RANEY NICKEL POWDER ENTRAINED IN H2 STREAM
LIQUID OXYGEN INJECTION
TIME, 100 msec/cm
RUN NO. 246, 77OK, 1 atm
O/F= 6.0t O2 LEAD
CORRECTED IGNITION TIME = 10 msec
(CHAMBER PRESSURE TRACE NOT OPERATIVE)
R-20,082 -59- Figure 21
![Page 69: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/69.jpg)
OSCILLOSCOPE IGNITION TRACES MARK V I l l
RANEY NICKEL POWDER ENTRAINED IN H2 STREAM
cm
\ 4
0 > E 9 co cv
-
.
ESSURE TRACE
UPLE TRACES
- TIME, 2 0 0 msec /cm
RUN 270; 57"K(103"R), 1 atm
RUN 273; 64"K(115"R), 1 atm CORRECTED IGNITION TIME = 130 msec
TRACE
TRACES
R-20,213 -60- Figure 22
![Page 70: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/70.jpg)
" H a r y u a r d f LYIRP(IRATl0N VAN NUYS, CAll fORNIA Report 25,179
OSCILLOSCOPE IGNITION TRACES MARK V l l l
RANEY NICKEL POWDER ENTRAINED IN H, STREAM
9 co N "'
5 u-
W -.I
3 0 0 0
a
z PL W I I-
L
cm
E TRACE
:OUPLE TRACES
W I
TIME, 200 rnsec/crn RUN 274; 63"K(113"R), 1 atm
CORRECTED IGNITION TIME = 70 rnsec b-+-j1 crn
TRACE
UPLE TRA ICES
I I-+
TIME, 2 0 0 msec/crn RUN 279; 76"K(137"R), p=4.9 psia
R-20,2 1 2 -61- Figure 23
![Page 71: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/71.jpg)
30
25
20
15
N
= 1c w
a
HYDROGEN ADSORPTII ON I SOTHERMS ON RANEY N I CKEL
R-20,221
e
1 1
0 ' 400 . 500 e HYDROGEN PRESSURE, p, mmHg
IO 7
Figure 24 -62-
0
![Page 72: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/72.jpg)
. ' Maryuardt CVRMh'ATION VAN NUVS. CALIFORNIA Report 25,179
HYDROGEN ADSORPTION ISOTHERMS ON PLATINUM BLACK
~
I RUN #148, T = 29' 1 (DESORBED AT 477OK) I I
I I
I I
I / I I
I I -
- I 1
I I
..- . _ . -.. .\ (DESORBEi AT 671°K) I I
1 (DESORBED AT 6 8 3 0 ~ ) I 1 .'
0 HYDROGEN PRESSURE, p, mmHg
R-20,222 -63- Figure 25
![Page 73: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/73.jpg)
. -
' ' Maryuardf CORRIRATION VAN NUIS. CALIPORNIA , , ReDort 25,179
TABLE I
PRELIMINARY IGNITION TESTS W I T " RANEY NICKEL
F m D BED CATALYST
Nominal Mixture Ratio: Og/H2 = 6.0 Apparatus: Mark I11
Corre cted Catalyst Sample Ignition G a s Temp(1) Flow Ignition Time No. Run No. O K Sequence milliseconds Remarks
101 134 No lead 1000 Normal 102 135 H2 lead 510 Normal 103 108 H2 lead 480 Normal
104 92 H2 lead 220 Strong detonation
#1
Catalyst deact i- vated
#2
105 106
#3
107 108
110 111 112 113
#5 114 Mark IV (Vacuum Run)
89 88 90 95 93
93 91 88 93
97
300 300 300
No lead 180 No lead 720 No lead 500 No lead 130 H2 lead 3%
No lead 150 No lead 480 No lead 10 50 H2 lead 340
82 prepurge; TOO no lead; N2 s t i l l flowing
Normal Normal Normal Normal More violent igni- t ion than #io8
Normal Normal Normal More violent igni- t ion than #112
p = 2.2 psig T .C . burned out
Flow
checks . cal ibrat ion
-64-
![Page 74: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/74.jpg)
* ' Maryuardt MRKMdTION VAN NUYS. CALIFORNIA , , Report 25,179
TABU3 I (Continued)
Catalyst Corrected Sample Ignit ion G a s Temp(l-1 Flow Ignit ion Time No. Run No. "K Sequence milliseconds Remarks
118 97 No lead 180 Normal 1x9 95 No lead 280 Normal 120 95 02 lead 800 Strong detonation 121 95 H2 lead 240 Normal 122 94 O2 lead 260 No pressure rise;
#6
only T.C. rise
123 95 No lead 800 Normal 124 95 H2 lead 440 Normal 125 94 H2 lead 820 Normal 126 91. O2 lead 45 Normal 127 93 O2 lead 560 Normal
#7
See Table I1 fo r Runs 128-137
#lo 138 122 No lead 700 Normal . 139 122 No lead 700 Normal
Notes:
(1) G a s temperature measure by Cu/Constantan thermocouple. This w a s approximately equal t o the temperature of the igni t ion device and of the cata lys t i n the fixed bed.
-65-
![Page 75: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/75.jpg)
' ' Maryuardl GORM)RAT/ON VAN NUVS. CALICOINIA Report 25,179
TABLF: I1
COAXIAL IlWECTION IGNITION TESTS USING FMED BED CATALYSTS
Nominal Mixture Ratio: O/F = 6.0 Apparatus: Mark V
Catalyst Corrected
Sample No. Run No. OK Sequence milliseconds and Ignition G a s Temperature Flow Ignit ion Time
Platinum No. 1 128 129 130 131 132 133 134 135
Raney Nickel NO. 8 136
Raney Nickel No. 9 137
Palladium No. 1 140 (unactivated 141 c ommer c i al) 142
143 144
Palladium No. 2 145 ( activated 146 comer c i a ) 147
148 149 150 151 152 153 154 155 156 157
299 299 299 299 299 299 299 299
142
143
283 283 283 283 283
134 134 134 134 134 134 134 134 134 134 1-34 134 134
No lead No lead No lead No lead No lead No lead No lead No lead
No lead
No lead
No lead No lead No lead No lead No lead
No lead 02 lead No lead No lead No lead No lead No lead No lead No lead No lead No lead No lead 02 lead
1500
1500 1300 1500 1500 600 1100
1400
1200
680
180 430 80 20 40
1000 20 680 160 320 180 180 90 160 160 4 0 ~ 100 20
-66-
![Page 76: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/76.jpg)
. . . I
TABLE I1 (Continued)
Catalyst Corrected
Sample No. Run No. OK Sequence milliseconds and Ignit ion G a s Temperature Flow Ignit ion Time
Raney Nickel No. 11 158
159 160 161
Raney Nickel No. 12 162 (Mod i f i ed 163 preparation) 164
165 166 167 168 169 170
Platinum No. 2 171
173 ( activated) 172
Palladium No. 1 174 (activated) 175
176 177 178
Raney Nickel NO. 13 179
180 181 182 183 184 185 186 187
Palladium No. 3 189 (Modified prepasat ion)
131 131 131 128
126 126 126 126 126 126 126 126 126
126 290 290
300 300 300 300 300
128 128 128 128 128 128 128 128 128
287
02 lead 02 lead 02 lead No lead
O2 lead No lead 02 lead O2 lead 02 lead O2 lead 02 lead 02 lead 02 lead
02 lead No lead No lead
No lead No lead No lead O2 lead O2 lead
02 lead 02 lead 02 lead 02 lead 02 lead O2 lead O2 lead 02 lead O2 lead
No lead
380 130 160 330
280 330 40 10 130 10 40 20 230
230 100 130
80 120 130 100 100
80 90 100 40 50 60 70 50 10
80 I
-67-
![Page 77: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/77.jpg)
TABLE I11
I G N I T I O N TESTS USING
DRY RAZVEY NICKEL POWDER ENTRAINED I N Hp STREAM
Gaseous Propellant Injection Apparatus: Mark V I
Nominal Corrected ( 2) Ignition(1) M.R. Flow Ignition Time Run No. O/F Sequence msec Remarks - - Catalyst
Raney Nickel 190 6.0 02 Lead 110 Normal; two previous ign9- Batch RNi-5 (5) t i ons obtained but not stored under H2 gas 58 days pr ior t o use; 191 6.0 O2 Lead 20 Normal single catalyst charge; burst 192 6.0 02 Lead 30 Normal diaphragms used.
193 6,0 02 Lead 120 Normal
194 4.0 02 Lead 53 0 Violent ignition; t h i s run
recorded on oscilloscope.
presumably expended the charge of Raney nickel,
195-207 Calibration runs t o measure gas lead times u t i l i z ing f lu id izer w i t h check valves.
Raney Nickel Batch RNI-8 (2)
208 1.5 02 Lead zs 1400 Mild ignitions; d i f f i c u l t t o detect due t o igni t ion
209 1.5 02 Lead 600 apparently occurring down- stream of thermocouple and
210 1 .5 02 Lead 500 p r e s sur e pickups ,
211-213
-68-
-Gas lead time cal ibrat ion runs.
![Page 78: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/78.jpg)
. ' Maryuardt WRHIR4TION VAN NUYS. CALICORNIA Report 25.179
TABU I11 (Continued)
Nominal Correc tea 2) Ignitfon(1) M.R. Flow Ignition Time
Catalyst Run No. O/F Sequence msec Remarks
Raney Nickel 214 1.5 02 Lead Batch RNI-8 (2) (new charge 1 215 1.5 $ Lead
Raney Nickel Batch mi-9 (1)
217 L5 02 Lead
218 1.5 02 Lead
219 1.5 02 Lead
220
221
222
223
224
225
226
227
228
1.5 02 Lead
1.5 02 Lead
Not Measured
400
Not Measured
Not Me a sur ed
Not Me a sur ed
10-20 msec t o i n i t i a t i o n of reaction = 40 msec t o deto- nation pulse.
Not Measured
Not Measured
Not Measured
Not Measured
Rapid igni t ion on H2 valve actuation. Mild igni t ion, appeared t o occur before thermocouple response. These igni t ions also appeared t o occur down- of the instrumentation z o q precluding accurate senshg.
Exhaust tube ex i t blocked, permitting pressure trans- ducer output t o be detec- able. No thermocouple response.
Normal ignition, but H2 valve "on" pip did not p r in t out, precluding accurate measurement of ign i t ion t i m e ,
Rapid ignition, no instru- mentation response. Visual. observation of the e e a u s t tube in t e r io r confirmed t h a t most of the igni t ions were occurring downstream of the instrumentation zme, precluding igni t ion senaiqg,
L 5 02 Lead Not Measured
1.5 02 Lead Not Measured
1.5 O2 Lead - 600 1.5 H2 Lead F 600 Delayed, violent ignition,
1.5 % Lead 100
-69-
![Page 79: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/79.jpg)
TABLE I11 (continued)
Nominal Corrected( 2, Ignition(1) M.R. Flow Ignition Time
Catalyst Run No. O/F Sequence msec Remarks
Raney Nickel Batch mi-9 (1) (new charge)
This charge of Raney nickel had been i n t h e f lu id izer =18 hrs pr ior t o use.
229 6.0 02 Lead Not Measured Delayed ignition, strong
23 0 6.0 02 Lead Not Measured Rapid ignition.
detonation pulse.
23 1 6.0 02 Lead = 620 Sparks were observed i n t h e igni t ion chamber before H2 admitted.
232 6.0 02 Lead = 1000 Strong, delayed ignition.
233 6.0 02 Lead Not Measured Strong, delayed ignition.
234 6,O O2 Lead Not Measured Strong, delayed ignition.
(1) Gas temperatures not measured; experimental conditions were such tha t both gas temperatures were near the boi l ing point of LO2 (90°K).
Corrected times obtained by subtracting 20 msec (H2 gas lead time) from overal l igni t ion t i m e .
(2)
-70-
![Page 80: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/80.jpg)
TABLE IV
IGNITION TESTS WITH LIQUID OXYGEN
Apparatus: Mark V I 1
Test Conditions:
(a) Dry Raney nickel ca ta lys t entrained i n hydrogen stream (s ingle batch of Raney nickel used)
Fluidizer, catalyst , hardware, and both propel- lant streams at a temperature of N" 77°K (138"~)
Nominal Mixture Ratio (O/F) = 6.0
(b)
( e )
( d ) Liquid Oxygen Lead
Corrected Ignition Ignition Run No. Time(1) Millisec. Remarks
235
236 237 238
239 240
241
242
243
244
245
246
247
248
249
not measured( 2)
60 not measured not measured - 400 75
not measured
60
15
not measured
not measured
10
not measured
not measured
220
Local, undetected ignit ion occurred pr io r t o main igni t ion
Rapid ignition, not picked up by i n s t m e n t a t i o n
Sparking occurred pr io r t o ignit ion
Rapid ignition, not recorded
Normal ignit ion
Normal ignit ion
Normal ignit ion
Normal ignit ion
Normal igni t ion
Normal ignit ion
Normal ignit ion
Normal ignit ion
-71-
![Page 81: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/81.jpg)
' Maryuardt CORKJRA TION VAN NUYS, CA l lFOlN IA Report 25,179
TAEXZ IV (Continued)
Corrected igni t ion time obtained by subtracting the hydrogen gas lead time ( - 20 mil l i sec) f rm the time of hydrogen valve opening t o igni t ion pressure peak.
Certain igni t ion times w e r e not measured fo r one of the following reasons:
(a ) Eydrogen valve "on" pip did not appear on the oscilloscope trace.
(b) Ignit ion occurred off the oscilloscope time scale.
( c ) Ignit ion not detected with suff ic ient c l a r i t y by instrumen- ta t ion.
-72-
![Page 82: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/82.jpg)
TABLE V
IGNITION TESTS W I T H MARK V I 1 1 IGNITER
Test Conditions :
(a)
(b) Liquid oxygen injection; To2 77°K ( 1 - 3 8 ~ ~ )
Dry Raney nickel ca ta lys t entrained i n hydrogen stream
Nominal Ignition H2 Temp. Mixture Ignit ion Run No. OK Ratio, O/F Characterist ics Remarks
250 ambient 6.0 251 ambient 6.0 252 77 6 .o
253 78 6 .o 254 78 6 .o 25 5 77 8 .o
256 77 6.0 3
257 77 6 .o
258 77 6 .o 259 77 1.5
260 77 1.5
261 77 1.5
262 75 1.5
263 75 1.5
264 75 1.5
0 95
Normal Ambient temperature Normal Check runs Strong, delayed igni- t ion, LO2 lead Normal, 140 msec Normal, 140 msec cooling only Delayed igni t ion 30 min. delay
Runs 252-264 were performed with L;N2
between Runs 254 and 255
Strong ignition, 180 msec Delayed ignit ion,
Normal, 180 msec Delayed ignit ion, Poor mixing w a s appa- 360 msec ren t ly encountered at Delayed ignit ion, O/F = 1.5; igni t ions 500 msec often occurred upon
opening the N2 purge valve
400 msec
Delayed ignit ion, 800 msec Delayed ignit ion, 1 hr . delay between 600 msec Delayed ignition, 500 msec Delayed ignition, 500 msec Sever& unrecorded igni t ions obtained, very s i m i l a r t o those of Runs 259-264
Runs 261 and 262
Single charge of Raney nickel ( -4 grams) used for the above ignit ions.
-73-
![Page 83: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/83.jpg)
TABLE V (Continued)
Nominal Ignition H2 Temp. Mixture Ignition Run No. O K Ratio, O/F Characteristics Remarks
268
269
270
71
63
57
265 71 6 .o Strong, delayed ign. Runs 265-274 performed 266 70 6 .o Strong, delayed ign., using LHe cooling of
500 msec the H2 stream. Single charge of Raney
used for Runs 266-274. Several unrecorded am- bient temperature check f i r ings a l s o obtained.
267 79 6 .o Normal nickel ( QI 4 grams)
6 .o Normal, = 3 O O msec
6 .o Normal, 400 msec
6 .o Normal ~ 5 0 0 msec; could not get exact t i m e due t o fa i lure of H2 valve "ont' pip t o appear on t race
271
272
273 274
275
276
277 278
64
63
6 4 63
64
48
85 75
Strong ignition, 540 msec
N2 flow l e f t on 6 .o
6 .o Normal, 520 msec Prior igni t ion audible, but did not appear on scope
6 .o Normal, 130 msec 6 .o Normal, 70 msec Raney nickel presum-
ably expended
4 .O Strong, delayed New charge of Raney ignition, 600 msec nickel
4 .O No igni t ion Lowest temp. reached obtained i n t h i s t e s t series;
O2 flow may have been impeded by t h i s low H2 temp. Shortly afterward, supply of LHe w a s exhausted.
4 .O Strong igni t ion Normal, 400 msec T e s t s discontinued
I due t o depletion of LHe
-74-
![Page 84: FEASIBILITY STUDY OF OXYGEN /HYDROGEN - NASA · PDF fileThe Raney nickel powder was entrained in the hydrogen It was demonstrated that Raney nickel powder, stored under an ... cient](https://reader031.vdocument.in/reader031/viewer/2022030501/5aad6b977f8b9a8d678e1ae0/html5/thumbnails/84.jpg)
TABLE v (Continued)
Nominal Ignit ion H2 Temp. Mixture Ignition Run NO. OK Ratio, O/F Characterist ics Remarks
279 76 6 .o p = 4.9 psia; igni- t ion occurred a f t e r N2 purge w a s turned on
normal igni t ion
normal igni t ion
normal igni t ion
normal ignit ion
280 76 4 .O p = 2.5 psia,
281 76 1 . 5 p = 2.5 p i a ,
282 76 1.5 p = 2.5 psia,
283 76 0.5 p = 4.9 psia,
Runs 274-283 were con- ducted under p a r t i a l vacuum, with LN2 cooling. Ignit ions obtained i n Runs 280-283 were delayed several hundred msec a f t e r H2 valve opening.
-75-