7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 1/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System

Edit Article

Ad

How to Construct a Small SepticSystem

Questions and Answers

Most private septic systems are made up of two parts: the holding and digesting tanks, and

the dispersal field. The system shown here is a small system, designed for limited use of by

two people with no laundry. The concept is not the same as a larger system. The tank is much

smaller than required and the design is missing some important items such as internal baffles

and a qualified site assessment. This system uses two 55 gallon (208.2 L) drums, as opposed

to the 1,000 to 2,000 gallon (3,785.4 to 7,570.8 L) tanks used for a standard home septic

system. The system we are creating here also has a dispersal field about one third that of a

large home.

Property owners planning a system similar to this one should be aware that this system would

not pass muster with any public health department in the USA, The owner to a hefty fine if the

system was discovered in use. On the other hand it is better to safely dispose of waste then

not. Today's water saving toilets use less than two gallons per flush. This system will handle

such a load. For people living in places without septic treatment it could be a life saver.

1Ad

Dig a ditch 4 feet (1.2 m) wide, 26 feet (7.9 m) long, and 3 feet (0.9 m) deep.

What topics are you knowledgeable about?

About this wikiHow

1,416 reviews

Exceptionally helpful 887,498 views

Updated yesterday 39 Co-authors

Random Article   Write An Article

Made Recently · 4

Add your photo

Related Articles

How to

Find a Water Leak in Your House

How to

Attach a GardenHose to a KitchenFaucet

Home » Categories » Home and Garden » Home Improvements and Repairs » Plumbing Drains Waste and VentsArticle Edit Discuss

Steps

  Search MESSAGESLOG INEXPLOREHELP USEDIT

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 2/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 2

2 Assemble all the supplies, parts, and equipment. See the "Things You'll Need"

list below.

3 Cut a hole in the top of each drum the size of the toilet flange pipe outside

measurement. It should be near the edge. A saber saw is best for this task.

How to

Install a TanklessHot Water Heater

How to

Recaulk aBathtub

Share

52K+

Featured Articles

How to

Be an Air TrafficController

How to

Create SaltDough

How toWrite anAutobiographicalEssay

How to

French Braid

Meet a Community Member

Sarah is a wikiHowian fromthe US who has been activein the community for over ayear. She’s a FeaturedAuthor and Welcomer andhas started 17 articles here.

She enjoys starting articles about realproblems she has in life, as well as onesabout quirky topics like How to Use Life

Hacks. She says, “I love to write, andhelping people in the process is killing twobirds with one stone.” To new editors shesays, “Just try things out! There’s nothingwrong with making mistakes”.

Join The Community

Follow Us On...

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 3/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 3

4Attach a 4" toilet flange to each hole.

5Cut two holes in the top side of the lower drum, as shown in the photo, 45

degrees away from a perpendicular line drawn from the hole on top to the far

side.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 4/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 4

6Cut one hole in the upper drum opposite the hole in the top, as shown in the

photo.

7 Place the drum with one hole in the side at the end of the trench. Level thedrum. The top of the drum should be at least 4 inches (10.2 cm) below grade.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 5/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 5

8Dig a hole about one foot deeper for the placement of the second drum in

front of the first.

9 Dig the hole mentioned in step 8 a little deeper and fill with gravel until the 90ell fits perfectly from the hole in the side of the top drum to the toilet flange

of the lower drum.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 6/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 6

10Cut a 3 1/2" piece of 4" ABS pipe (nipple) and glue it into one end of the

90 ell. Cut another nipple about 2 1/2" long and glue it in the other end.

11 Test the fit for alignment between the two drums. The end with the shortnipple should go into the upper drum. It should look like the photo in Step 9.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 7/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 7

12When you are sure about the fit, glue the end of the 3 1/2" nipple into the

toilet flange. We will deal with sealing the connection to the upper drum later.

13 Glue a "Y" to 3 1/2 nipples and add a 45 degree bend to the left side of the"Y". Align the "Y" to meet the incoming waste line, and glue it into the toilet

flange.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 8/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 8

14Cut and glue (2) 2 1/2" nipples to the remaining two 45 degree bends at

one end only and insert into holes in the side of the lower drum, as shown

in the photo in step 7. The face of the two 45 degree bends should be perpendicular to

the trench.

15 See photo in Step 7

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 9/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 9

16Pound a stake into the ground so that the top of the stake is level with the

bottom of the 45 degree bend coming out of one side of the bottom drum.

17 Tape a 1" wide block to the end of a 4 foot (1.2 m) level, as shown in thephoto to the right.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 10/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 10

18Start the second stake a little less than 4 feet (1.2 m) down the trench

from the first.

19 Lay the end of the level without the block on the first stake and the block on the second. Pound the stake down until the level shows level when the

block is on the second stake. The second stake is now 1" lower than the first, or 1/4" per

foot.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 11/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 1

20Repeat this process until you have stakes the length of the trench.

21Place the gravel in the trench until the top of the gravel is equal with the

top of the stakes.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 12/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 12

22The gravel should now slope away from the drums at 1/4" to the foot.

23Place two pieces of 10 foot (3.0 m) 4" perforated drain pipe connected

with a slip coupler (holes down). Slide one end into the 45 degree bend of

the lower drum. Repeat on the other side.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 13/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 13

24Check the drain pipes with the level and block to see if the 1/4" grade is

consistent along the length of the pipe. Adjust by adding or removing gravel

under the pipe.

25 Seal the 45 degree bends and the 90 degree bend to the lower and upper

drums, respectively. Try a two part epoxy. You could also use silicon caulk.

See the photo in step 6 for finished view of epoxy. Consider using flex pipe for this, so

that if the ground shifts it will give a l ittle.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 14/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 14

26If sealant has cured, fill drums with water to prevent the drums from

collapsing under the weight of the gravel. Bury the trench to the top of the

bottom drum with the remaining gravel.

27 Lay landscape fabric over the gravel. This will prevent the soil from seeping

into the gravel.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 15/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 15

28Fill the remaining trench area with soil, compacting well to the original

grade.

29Ad

Fill the upper drum with water.

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 16/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 16

Be the first to ask a question about this topic:

What do you need to know? We'll do our best to find the answer.

Submit

Can you tell us about

Creating

Menorahs?

Can you tell us about

Clothing

Stains?

Can you tell us about

Sewing

clothes?

Can you tell us about

Cell phones?

septic

It is presumed that you know how to work with plastic ABS pipe. You must also have

equipment to dig the trench (or be willing to get a lot of exercise).

After a while, you may see settlement where the trench was. Fill with more soil and

compact with wheel of your car. Don't drive over the area that contains the drums.

The vertical side of the "Y" will be used to pump out the tank when it is completely fill

with solids.

The horizontal side of the "Y" connects to the waste source, and should be fitted with

a connector that fits the source supply line.

Questions and Answers

Give us 3 minutes of knowledge!

Video

Tips

Yes No Yes No Yes No Yes No

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 17/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 17

The digestive tanks are made of two plastic 55 gallon (208.2 L) drums. The waste fills

the first tank, with the solids falling to the bottom. When the liquid reaches the level of

the outfall to the second tank, it drains into it. If any solids are there, they fall to the

bottom. When the liquid from the second tank reaches the two outfalls, it travels to

the gravel leaching field for dispersal. Most of the solids will liquefy over time and be

dispersed. After a couple of years, the solids may come to the top of the tank, and the

tank will have to be pumped out.

30% of the waste goes down in the ground and 70% is evaporated by sunlight. Don't

compact; it messes up the evaporation process.

Instead of a 90° elbow, you should put two of them together, to form a U. That way

the end that's in the first barrel will be pointing towards the bottom of the tank. Add a

short section of straight pipe to this, extending it a few inches deeper towards the

bottom. Solids either float or they sink. They don't stay around the middle. This way,

the solids don't ever make it to the second tank, only the broken down liquid waste.

The same should be done for each of the drainage pipes coming from the second

barrel. Just to make absolutely sure that no solids make their way into the world leach

field.

The depth of the trench is relative to the depth of the waste source line. If the line is

deeper or higher than the one shown, you will have to dig the trench deeper or

shallower to accommodate that depth. It's not that hard to figure. (Note: If you have

too shallow a trench, your septic system could be damaged easier.)

Local Septic Regulations should be followed when constructing a septic system. It is

illegal to install a septic system with no permit, the permit will detail the local

requirements for installation of a septic system.

This is a very small capacity system. This is not designed to meet the needs of a

large household. It is designed for a small travel trailer and two people.

Depending on use, you may have to pump the upper drum once a year. The system

shown here has been pumped twice in five years.

Don't locate your septic system too close to trees, as tree roots will grow into your

line, and cause them to clog (with roots) and with time, cause harm to your system.

Warnings

Things You'll Need

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 18/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

http://www.wikihow.com/Construct-a-Small-Septic-System 18

(9) cubic yards of 3/4 or 1 1/2 crushed rock or blue metal

(80) square feet of landscape fabric

(2) 55 gallon (208.2 L) plastic drums

(10) ft of 4" ABS plastic pipe

(1) 4" ABS 90 degree bend (sometimes called a street Ell)

(1) 4" ABS Y branch (sometimes called a Y bend)

(3) 4" ABS 45 degree bend

(4) 10 feet (3.0 m). length of 4" perforated drain pipe

(2) 4" drain pipe couplers

(2) 4" toilet flanges

(1) 4' Level

(10) Wood Stakes

(1) Set of PVC glue

(1) Two part epoxy or silicon sealant

(1) 1" thick wood block

(1) Duct tape

(1) 4" ABS removable cap for pump out when needed

How to

Create a SepticSystem for PetWaste

How to

Hide a SepticTank Riser or Cap

How to

Care for a SepticSystem

How to

Establish aRemote WaterSystem

Thanks to all authors for creating a page that has been read 887,498 times.

Did this article help you?

 

Discuss Print Email Edit Send fan mail to authors

Categories: Plumbing Drains Waste and Vents

In other languages:

Español: construir un pequeño sistema séptico, Русский: сделать небольшую

септическую систему, Português: Construir um Pequeno Sistema de Fossa

Séptica, Deutsch: Ein kleines septisches System bauen

Related wikiHows

Article Info

7/23/2019 How to Construct a Small Septic System

http://slidepdf.com/reader/full/how-to-construct-a-small-septic-system 19/19

12/6/2015 How to Construct a Sm all Septic System ( with Pictures) - wikiHow

Yes   No

All text shared under a Creative Commons License.  Powered by Mediawiki.

Home About wikiHow Jobs Terms of Use RSS Site map Log In Mobile view