S-14617XZ-C1Nov 2009

UHF TRANSCEIVERS

This service manual describes the latest technical information for the IC-F4001IC-F4002IC-F4003IC-F4006IC-F4008 UHF TRANSCEIVERS at the time of publication

NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than the specified voltage This will ruin the transceiver

DO NOT expose the transceiver to rain snow or any liquids

DO NOT reverse the polarities of the power supply when connecting the transceiver

DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna connector This could damage the transceiverrsquos front-end

To upgrade quality any electrical or mechanical parts and internal circuits are subject to change without notice or obligation

MODEL VERSIONCHANNELSPACING

(kHz)

FREQUENCYRANGE(MHz)

IC-F4001

USA-11

125250

400ndash470

USA-12

USA-13

IC-F4002

EUR-21

125200250EUR-22

EUR-23

UK-01

125250

UK-02

UK-03

IC-F4003

EXP-11

EXP-12

EXP-13

EXP-21

EXP-22

EXP-23

EXP-01

EXP-03

EXP-31

AUS-21

AUS-22

AUS-23

IC-F4006

RUS-21

RUS-22

RUS-23

IC-F4008 CHN-31

Be sure to include the following four points when ordering replacement parts

1 10-digit Icom part number2 Component name3 Equipment model name and unit name4 Quantity required

ltORDER EXAMPLEgt 1110003491 SIC TA31136FNG IC-F4001 MAIN UNIT 5 pieces

8820001210 Screw 2438 screw IC-F4003 Top cover 10 pieces

Addresses are provided on the inside back cover for your convenience

ORDERING PARTS

1 Make sure that the problem is internal before disassembling the transceiver

2 DO NOT open the transceiver until the transceiver is disconnected from its power source

3 DO NOT force any of the variable components Turn them slowly and smoothly

4 DO NOT short any circuits or electronic parts An insulated tuning tool MUST be used for all adjustments

5 DO NOT keep power ON for a long time when the transceiver is defective

6 DO NOT transmit power into a Standard Signal Generator or a Sweep Generator

7 ALWAYS connect a 50 dB to 60 dB attenuator between the transceiver and a Deviation Meter or Spectrum Analyzer when using such test equipment

8 READ the instructions of the test equipment throughly before connecting it to the transceiver

REPAIR NOTES

INTRODUCTION CAUTION

(IC-F4001)

Icom Icom Inc and the Icom logo are registered trademarks of Icom Incorporated (Japan) in Japan the United States the United Kingdom Germany France Spain Russia andor other countries

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTION

SECTION 4 CIRCUIT DESCRIPITON 4-1 RECEIVER CIRCUITS 4-1

4-2 TRANSMITTER CIRCUITS 4-2

4-3 FREQUENCY SYNTHESIZER CIRCUITS 4-3

4-4 VOLTAGE BLOCK DIAGRAM 4-3

4-5 PORT ALLOCATIONS 4-4

SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION 5-1

5-2 FREQUENCY ADJUSTMENT 5-5

5-3 TRANSMIT ADJUSTMENT 5-6

5-4 RECEIVE ADJUSTMENT 5-7

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS

SECTION 8 BOARD LAYOUTS

SECTION 9 BLOCK DIAGRAM

SECTION 10 VOLTAGE DIAGRAM

1 - 1

SECTION 1 SPECIFICATIONS

M GENERALbull Frequency range 400ndash470 MHz bull Number of conventional channels 16 channelsbull Type of emission [EUR] Wide 16K0F3E (250 kHz)

Middle 14K0F3E (200 kHz)Narrow 8K50F3E (125 kHz)

Except [EUR] Wide 16K0F3E (250 kHz) Narrow 11K0F3E (125 kHz)

bull Antenna impedance 50 Ω (Nominal)bull Operating temperature range ndash30˚C to +60˚C ndash22˚F to +140˚F Except [EUR] [UK]

ndash25˚C to +55˚C [EUR] [UK]bull Power supply voltage Specified Icoms battery packs only (72 V DC negative ground)bull Current drain (Approx) Receiving 70 mA (stand-by)

330 mA (max audio)Transmitting 13 A (at 40 W)

bull Dimensions (Projections not included)

With BP-264 586 (W)times1110 (H)times310 (D) mm 2 516 (W)times4 3frasl8 (H)times1 7frasl32 (D) inWith BP-265 586 (W)times1110 (H)times355 (D) mm 2 516 (W)times4 3frasl8 (H)times1 13frasl32 (D) in

bull Weight With BP-264 Approx 330 g 11 2132 ozWith BP-265 Approx 270 g 9 1732 oz

bull Intermediate frequency 1st 4635 MHz2nd 450 kHz

bull Output impedance (Audio) 8 Ωbull Input impedance (Audio) 22 kΩ

M TRANSMITTERbull Output power 4 Wbull Modulation Variable reactance frequency modulationbull Maximum frequency deviation Narrow plusmn25 kHz

Middle plusmn40 kHzWide plusmn50 kHz

bull Frequency stability plusmn25 ppmbull Spurious emissions 70 dB min Except [EUR] [UK]

025 microW (le1 GHz) 10 microW (gt1 GHz) [EUR] [UK]bull Adjacent channel power Narrow 60 dB min 66 dB typ

Middle 70 dB min 73 dB typWide 70 dB min 73 dB typ

bull Audio harmonic distortion Wide Middle 10 typ at AF 1 kHz 40 deviationNarrow 15 typ at AF 1 kHz 40 Deviation

bull FM hum and Noise (Except [EUR] [UK])(Without CCITT FILTER)

Narrow 34 dB min 40 dB typ Wide 40 dB min 46 dB typ

bull Residual modulation ([EUR] [UK])(With CCITT FILTER)

Narrow 40 dB minMiddle 43 dB minWide 45 dB min

bull Limitting charact of modulator 60ndash100 of max deviation

1 - 2

M RECEIVER bull Sensitivity 025 microV typ at 12 dB SINAD Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ at 20 dB SINAD [EUR] [UK]bull Squelch sensitivity (at threshold) 025 microV typ Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ [EUR] [UK]bull Intermodulation 70 dB min 74 dB typ Except [EUR] [UK]

65 dB min [EUR] [UK]bull Spurious response 70 dB minbull Audio output power 08 W typ at 5 distortion with 12 Ω (Int speaker)

04 W typ at 5 distortion with 8 Ω (Ext speaker)bull Hum and noise (Except [EUR] [UK])

(Without CCITT Filter) Narrow 34 dB min 47 dB typ

Wide 40 dB min 52 dB typ bull Hum and noise ([EUR] [UK])

(With CCITT Filter) Narrow 40 dB min

Middle 43 dB minWide 45 dB min

bull Adjacent channel selectivity Narrow 60 dB min 65 dB typMiddle 70 dB min 73 dB typWide 70 dB min 73 dB typ

Specifications are measured in accordance with TIAEIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation

2 - 1

SECTION 2 INSIDE VIEWS

LED CTRL(Q82Q83)

VCO

bull MAIN-A UNIT (TOP VIEW)

CPU5 LINE REGULATOR(IC54)

+5V LINE REGULATOR(Q76)

PLL IC(IC2)

MICAF LINE SW(IC56)

APC AMP(IC1)

TCXO(X2)

TONE FILTER SW(Q52)

TONE LPF(IC59)

HPF(IC58)

MIC GAIN CONTROLLER(IC62)

2ND IF BPF(FI2)

2ND IF BPF (For narrow mode only)(FI3)

LPF(Q51)

BEEP SW(IC61)

+5V LINE REGULATOR(Q75)

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

This service manual describes the latest technical information for the IC-F4001IC-F4002IC-F4003IC-F4006IC-F4008 UHF TRANSCEIVERS at the time of publication

NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than the specified voltage This will ruin the transceiver

DO NOT expose the transceiver to rain snow or any liquids

DO NOT reverse the polarities of the power supply when connecting the transceiver

DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna connector This could damage the transceiverrsquos front-end

To upgrade quality any electrical or mechanical parts and internal circuits are subject to change without notice or obligation

MODEL VERSIONCHANNELSPACING

(kHz)

FREQUENCYRANGE(MHz)

IC-F4001

USA-11

125250

400ndash470

USA-12

USA-13

IC-F4002

EUR-21

125200250EUR-22

EUR-23

UK-01

125250

UK-02

UK-03

IC-F4003

EXP-11

EXP-12

EXP-13

EXP-21

EXP-22

EXP-23

EXP-01

EXP-03

EXP-31

AUS-21

AUS-22

AUS-23

IC-F4006

RUS-21

RUS-22

RUS-23

IC-F4008 CHN-31

Be sure to include the following four points when ordering replacement parts

1 10-digit Icom part number2 Component name3 Equipment model name and unit name4 Quantity required

ltORDER EXAMPLEgt 1110003491 SIC TA31136FNG IC-F4001 MAIN UNIT 5 pieces

8820001210 Screw 2438 screw IC-F4003 Top cover 10 pieces

Addresses are provided on the inside back cover for your convenience

ORDERING PARTS

1 Make sure that the problem is internal before disassembling the transceiver

2 DO NOT open the transceiver until the transceiver is disconnected from its power source

3 DO NOT force any of the variable components Turn them slowly and smoothly

4 DO NOT short any circuits or electronic parts An insulated tuning tool MUST be used for all adjustments

5 DO NOT keep power ON for a long time when the transceiver is defective

6 DO NOT transmit power into a Standard Signal Generator or a Sweep Generator

7 ALWAYS connect a 50 dB to 60 dB attenuator between the transceiver and a Deviation Meter or Spectrum Analyzer when using such test equipment

8 READ the instructions of the test equipment throughly before connecting it to the transceiver

REPAIR NOTES

INTRODUCTION CAUTION

(IC-F4001)

Icom Icom Inc and the Icom logo are registered trademarks of Icom Incorporated (Japan) in Japan the United States the United Kingdom Germany France Spain Russia andor other countries

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTION

SECTION 4 CIRCUIT DESCRIPITON 4-1 RECEIVER CIRCUITS 4-1

4-2 TRANSMITTER CIRCUITS 4-2

4-3 FREQUENCY SYNTHESIZER CIRCUITS 4-3

4-4 VOLTAGE BLOCK DIAGRAM 4-3

4-5 PORT ALLOCATIONS 4-4

SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION 5-1

5-2 FREQUENCY ADJUSTMENT 5-5

5-3 TRANSMIT ADJUSTMENT 5-6

5-4 RECEIVE ADJUSTMENT 5-7

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS

SECTION 8 BOARD LAYOUTS

SECTION 9 BLOCK DIAGRAM

SECTION 10 VOLTAGE DIAGRAM

1 - 1

SECTION 1 SPECIFICATIONS

M GENERALbull Frequency range 400ndash470 MHz bull Number of conventional channels 16 channelsbull Type of emission [EUR] Wide 16K0F3E (250 kHz)

Middle 14K0F3E (200 kHz)Narrow 8K50F3E (125 kHz)

Except [EUR] Wide 16K0F3E (250 kHz) Narrow 11K0F3E (125 kHz)

bull Antenna impedance 50 Ω (Nominal)bull Operating temperature range ndash30˚C to +60˚C ndash22˚F to +140˚F Except [EUR] [UK]

ndash25˚C to +55˚C [EUR] [UK]bull Power supply voltage Specified Icoms battery packs only (72 V DC negative ground)bull Current drain (Approx) Receiving 70 mA (stand-by)

330 mA (max audio)Transmitting 13 A (at 40 W)

bull Dimensions (Projections not included)

With BP-264 586 (W)times1110 (H)times310 (D) mm 2 516 (W)times4 3frasl8 (H)times1 7frasl32 (D) inWith BP-265 586 (W)times1110 (H)times355 (D) mm 2 516 (W)times4 3frasl8 (H)times1 13frasl32 (D) in

bull Weight With BP-264 Approx 330 g 11 2132 ozWith BP-265 Approx 270 g 9 1732 oz

bull Intermediate frequency 1st 4635 MHz2nd 450 kHz

bull Output impedance (Audio) 8 Ωbull Input impedance (Audio) 22 kΩ

M TRANSMITTERbull Output power 4 Wbull Modulation Variable reactance frequency modulationbull Maximum frequency deviation Narrow plusmn25 kHz

Middle plusmn40 kHzWide plusmn50 kHz

bull Frequency stability plusmn25 ppmbull Spurious emissions 70 dB min Except [EUR] [UK]

025 microW (le1 GHz) 10 microW (gt1 GHz) [EUR] [UK]bull Adjacent channel power Narrow 60 dB min 66 dB typ

Middle 70 dB min 73 dB typWide 70 dB min 73 dB typ

bull Audio harmonic distortion Wide Middle 10 typ at AF 1 kHz 40 deviationNarrow 15 typ at AF 1 kHz 40 Deviation

bull FM hum and Noise (Except [EUR] [UK])(Without CCITT FILTER)

Narrow 34 dB min 40 dB typ Wide 40 dB min 46 dB typ

bull Residual modulation ([EUR] [UK])(With CCITT FILTER)

Narrow 40 dB minMiddle 43 dB minWide 45 dB min

bull Limitting charact of modulator 60ndash100 of max deviation

1 - 2

M RECEIVER bull Sensitivity 025 microV typ at 12 dB SINAD Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ at 20 dB SINAD [EUR] [UK]bull Squelch sensitivity (at threshold) 025 microV typ Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ [EUR] [UK]bull Intermodulation 70 dB min 74 dB typ Except [EUR] [UK]

65 dB min [EUR] [UK]bull Spurious response 70 dB minbull Audio output power 08 W typ at 5 distortion with 12 Ω (Int speaker)

04 W typ at 5 distortion with 8 Ω (Ext speaker)bull Hum and noise (Except [EUR] [UK])

(Without CCITT Filter) Narrow 34 dB min 47 dB typ

Wide 40 dB min 52 dB typ bull Hum and noise ([EUR] [UK])

(With CCITT Filter) Narrow 40 dB min

Middle 43 dB minWide 45 dB min

bull Adjacent channel selectivity Narrow 60 dB min 65 dB typMiddle 70 dB min 73 dB typWide 70 dB min 73 dB typ

Specifications are measured in accordance with TIAEIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation

2 - 1

SECTION 2 INSIDE VIEWS

LED CTRL(Q82Q83)

VCO

bull MAIN-A UNIT (TOP VIEW)

CPU5 LINE REGULATOR(IC54)

+5V LINE REGULATOR(Q76)

PLL IC(IC2)

MICAF LINE SW(IC56)

APC AMP(IC1)

TCXO(X2)

TONE FILTER SW(Q52)

TONE LPF(IC59)

HPF(IC58)

MIC GAIN CONTROLLER(IC62)

2ND IF BPF(FI2)

2ND IF BPF (For narrow mode only)(FI3)

LPF(Q51)

BEEP SW(IC61)

+5V LINE REGULATOR(Q75)

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTION

SECTION 4 CIRCUIT DESCRIPITON 4-1 RECEIVER CIRCUITS 4-1

4-2 TRANSMITTER CIRCUITS 4-2

4-3 FREQUENCY SYNTHESIZER CIRCUITS 4-3

4-4 VOLTAGE BLOCK DIAGRAM 4-3

4-5 PORT ALLOCATIONS 4-4

SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION 5-1

5-2 FREQUENCY ADJUSTMENT 5-5

5-3 TRANSMIT ADJUSTMENT 5-6

5-4 RECEIVE ADJUSTMENT 5-7

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS

SECTION 8 BOARD LAYOUTS

SECTION 9 BLOCK DIAGRAM

SECTION 10 VOLTAGE DIAGRAM

1 - 1

SECTION 1 SPECIFICATIONS

M GENERALbull Frequency range 400ndash470 MHz bull Number of conventional channels 16 channelsbull Type of emission [EUR] Wide 16K0F3E (250 kHz)

Middle 14K0F3E (200 kHz)Narrow 8K50F3E (125 kHz)

Except [EUR] Wide 16K0F3E (250 kHz) Narrow 11K0F3E (125 kHz)

bull Antenna impedance 50 Ω (Nominal)bull Operating temperature range ndash30˚C to +60˚C ndash22˚F to +140˚F Except [EUR] [UK]

ndash25˚C to +55˚C [EUR] [UK]bull Power supply voltage Specified Icoms battery packs only (72 V DC negative ground)bull Current drain (Approx) Receiving 70 mA (stand-by)

330 mA (max audio)Transmitting 13 A (at 40 W)

bull Dimensions (Projections not included)

With BP-264 586 (W)times1110 (H)times310 (D) mm 2 516 (W)times4 3frasl8 (H)times1 7frasl32 (D) inWith BP-265 586 (W)times1110 (H)times355 (D) mm 2 516 (W)times4 3frasl8 (H)times1 13frasl32 (D) in

bull Weight With BP-264 Approx 330 g 11 2132 ozWith BP-265 Approx 270 g 9 1732 oz

bull Intermediate frequency 1st 4635 MHz2nd 450 kHz

bull Output impedance (Audio) 8 Ωbull Input impedance (Audio) 22 kΩ

M TRANSMITTERbull Output power 4 Wbull Modulation Variable reactance frequency modulationbull Maximum frequency deviation Narrow plusmn25 kHz

Middle plusmn40 kHzWide plusmn50 kHz

bull Frequency stability plusmn25 ppmbull Spurious emissions 70 dB min Except [EUR] [UK]

025 microW (le1 GHz) 10 microW (gt1 GHz) [EUR] [UK]bull Adjacent channel power Narrow 60 dB min 66 dB typ

Middle 70 dB min 73 dB typWide 70 dB min 73 dB typ

bull Audio harmonic distortion Wide Middle 10 typ at AF 1 kHz 40 deviationNarrow 15 typ at AF 1 kHz 40 Deviation

bull FM hum and Noise (Except [EUR] [UK])(Without CCITT FILTER)

Narrow 34 dB min 40 dB typ Wide 40 dB min 46 dB typ

bull Residual modulation ([EUR] [UK])(With CCITT FILTER)

Narrow 40 dB minMiddle 43 dB minWide 45 dB min

bull Limitting charact of modulator 60ndash100 of max deviation

1 - 2

M RECEIVER bull Sensitivity 025 microV typ at 12 dB SINAD Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ at 20 dB SINAD [EUR] [UK]bull Squelch sensitivity (at threshold) 025 microV typ Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ [EUR] [UK]bull Intermodulation 70 dB min 74 dB typ Except [EUR] [UK]

65 dB min [EUR] [UK]bull Spurious response 70 dB minbull Audio output power 08 W typ at 5 distortion with 12 Ω (Int speaker)

04 W typ at 5 distortion with 8 Ω (Ext speaker)bull Hum and noise (Except [EUR] [UK])

(Without CCITT Filter) Narrow 34 dB min 47 dB typ

Wide 40 dB min 52 dB typ bull Hum and noise ([EUR] [UK])

(With CCITT Filter) Narrow 40 dB min

Middle 43 dB minWide 45 dB min

bull Adjacent channel selectivity Narrow 60 dB min 65 dB typMiddle 70 dB min 73 dB typWide 70 dB min 73 dB typ

Specifications are measured in accordance with TIAEIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation

2 - 1

SECTION 2 INSIDE VIEWS

LED CTRL(Q82Q83)

VCO

bull MAIN-A UNIT (TOP VIEW)

CPU5 LINE REGULATOR(IC54)

+5V LINE REGULATOR(Q76)

PLL IC(IC2)

MICAF LINE SW(IC56)

APC AMP(IC1)

TCXO(X2)

TONE FILTER SW(Q52)

TONE LPF(IC59)

HPF(IC58)

MIC GAIN CONTROLLER(IC62)

2ND IF BPF(FI2)

2ND IF BPF (For narrow mode only)(FI3)

LPF(Q51)

BEEP SW(IC61)

+5V LINE REGULATOR(Q75)

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev=1130000103285010000000000A69C718000788C0013001010FD3CC15000E975A0140A320A0A3C3C0F13002010BBA18809090D32640D3A1E3C0000000013003010B5AD91B094878C822419141414325064130040100F030E00000000000000000000000000130050100000000000000000000000000000000013006010000000000000000000000000000000001300701000000000000000000000000000000000130080100000000000000000000000000000000013009010000000000000000000000000000000001300A01000000000000000000000001E8E0000001300B010000000000000000000000000000000001300C010000000000000000000000000000000001300D010000000000000000000000000000000001300E010000000000000000000000000000000001300F0100000000000000000000000000000000013010010000000000000000001000000000000001301101002EE06A8018006860000000000000000130120100001000A001205EC0000000000000000130130108302000201000003030500000000050313014010800000000000000080000000000000001301501000000000000000000000000000000000130160100000000000000000000000000000000013017010000000000000000000000000000000001301801017D7840017D784008000800000001C0313019010A1801C03A1808000800000001C03A1801301A0101C03A18080008000000019ED92C019ED1301B01092C080008000000019ED92C019ED92C01301C01080008000000019ED92C019ED92C080001301D0108000000019ED92C019ED92C0800040071301E010000019ED92C019ED92C08000800040001301F01019ED92C019ED92C080008000000019ED1302001092C019ED92C08000002D000019ED92C01302101019ED92C080008000000017D7840017D713022010840080008000400000000000000000001302301080008000400000000000000000008000130240108000400000000000000000008000800013025010400000000000000000008000800040001302601045000E0000000000FFFF09C480E809C41302701080E809C480E809C480E809C480E809C41302801080E809C480E809C480E809C480E809C41302901080E809C480E809C480E809C480E809C41302A01080E809C480E809C480E809C480E809C41302B01080E809C480E809C480E809C480E809C41302C01080E809C480E809C480E809C480E809C41302D01080E809C480E809C480E809C480E809C41302E01080E809C480E809C480E80000000081021302F0103000000100000000000081023000000113030010000000000000810230000001000000001303101000008302300000010000000000008202130320103000000100000000000081023000000113033010000000000000810230000001000000001303401000008102300000010000000000008102130350103000000100000000000081023000000113036010000000000000810230000001000000001303701000008102300000010000000000008302130380103000000100000000000083023000000113039010000000000000830230000001000000001303A010000083023000000100000000000012341303B0101593570000000000138827103E80FDF21303C010000000000000000000F8F80A0E0F02011303D010000401000001643214505050500A0A0A1303E0100A0A1E321E10100000001E14050A1E001303F0103C3C0A000000323C0032640000000010130400100000000000000000000000000000800013041010E7000009000100003C1E0800000000001304201000000000000000000000000020202020130430102020202020202020202020202020202013044010202020202020202020202020099209F6130450107E54837C099209F67E54837C099209F6130460107E54837C099209F67E54837C099209F6130470107E54837C099209F67E54837C099209F6130480107E54837C099209F67E54837C099209F6130490107E54837C099209F67E54837C000000001304A010000000000000000000000000000000081304B0100A140A140A140A140A140A140A140A141304C0100A140A1400000375037503751180A1801304D010001000000000000000000000000000001304E010000000000000000000000000000000001304F0100000000000000000000000000000000013050010000011002200330044005500660077001305101088009900AA10BB10CC10DD10EE10FF1013052010001011102210331044105510661077101305301088109910AA10BB10CC30DD30EE30FF301305401001FFFFFF00008203000001FFFFFF0000130550108302000001FFFFFF00008302000001FF13056010FFFF00008302000001FFFFFF0000830213057010000001FFFFFF00008302000001FFFFFF1305801000008302000001FFFFFF0000830200001305901001FFFFFF00008302000001FFFFFF00001305A0108302000001FFFFFF00008302000000001305B010000000000000000000000000000000001305C01000000000000004D20001B433100504001305D010003201000000000002028300140A0A0A1305E0103C3C1E0A00000000000064000002000E1305F0100010018000000005000800010260000013060010000C0002000102680000000F0004002013061010026A000000280004000102EA0000000313062010000C001002EE00000006007E000103AE130630100000000700200001042C000000090080130640100001044C0000000D000A000104CC000013065010000E000E000304D6000000100002002013066010050000000011000A000B054000000012130670100008000105AE000000130008000205B61306801000000014000A000105C600000029000413069010000105D0000000300018000105D400001306A01049434F4D20496E6300000000000000001306B010000000000000000000000000000000001306C010000000000000000000000000000000001306D010000000000000000000000000000000001306E010000000000000000000000000000000001306F010000000000000000000000000000000001307001000000000000000000000000000000000130710100000000000000000000000000000000013072010000000000000000000000000000000001307301000000000000000000000000000000000130740100000000000000000000000000000000013075010000000000000000000000000000000001307601000000000000000000000000000000000130770100000000000000000000000000000000013

1 - 1

SECTION 1 SPECIFICATIONS

M GENERALbull Frequency range 400ndash470 MHz bull Number of conventional channels 16 channelsbull Type of emission [EUR] Wide 16K0F3E (250 kHz)

Middle 14K0F3E (200 kHz)Narrow 8K50F3E (125 kHz)

Except [EUR] Wide 16K0F3E (250 kHz) Narrow 11K0F3E (125 kHz)

bull Antenna impedance 50 Ω (Nominal)bull Operating temperature range ndash30˚C to +60˚C ndash22˚F to +140˚F Except [EUR] [UK]

ndash25˚C to +55˚C [EUR] [UK]bull Power supply voltage Specified Icoms battery packs only (72 V DC negative ground)bull Current drain (Approx) Receiving 70 mA (stand-by)

330 mA (max audio)Transmitting 13 A (at 40 W)

bull Dimensions (Projections not included)

With BP-264 586 (W)times1110 (H)times310 (D) mm 2 516 (W)times4 3frasl8 (H)times1 7frasl32 (D) inWith BP-265 586 (W)times1110 (H)times355 (D) mm 2 516 (W)times4 3frasl8 (H)times1 13frasl32 (D) in

bull Weight With BP-264 Approx 330 g 11 2132 ozWith BP-265 Approx 270 g 9 1732 oz

bull Intermediate frequency 1st 4635 MHz2nd 450 kHz

bull Output impedance (Audio) 8 Ωbull Input impedance (Audio) 22 kΩ

M TRANSMITTERbull Output power 4 Wbull Modulation Variable reactance frequency modulationbull Maximum frequency deviation Narrow plusmn25 kHz

Middle plusmn40 kHzWide plusmn50 kHz

bull Frequency stability plusmn25 ppmbull Spurious emissions 70 dB min Except [EUR] [UK]

025 microW (le1 GHz) 10 microW (gt1 GHz) [EUR] [UK]bull Adjacent channel power Narrow 60 dB min 66 dB typ

Middle 70 dB min 73 dB typWide 70 dB min 73 dB typ

bull Audio harmonic distortion Wide Middle 10 typ at AF 1 kHz 40 deviationNarrow 15 typ at AF 1 kHz 40 Deviation

bull FM hum and Noise (Except [EUR] [UK])(Without CCITT FILTER)

Narrow 34 dB min 40 dB typ Wide 40 dB min 46 dB typ

bull Residual modulation ([EUR] [UK])(With CCITT FILTER)

Narrow 40 dB minMiddle 43 dB minWide 45 dB min

bull Limitting charact of modulator 60ndash100 of max deviation

1 - 2

M RECEIVER bull Sensitivity 025 microV typ at 12 dB SINAD Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ at 20 dB SINAD [EUR] [UK]bull Squelch sensitivity (at threshold) 025 microV typ Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ [EUR] [UK]bull Intermodulation 70 dB min 74 dB typ Except [EUR] [UK]

65 dB min [EUR] [UK]bull Spurious response 70 dB minbull Audio output power 08 W typ at 5 distortion with 12 Ω (Int speaker)

04 W typ at 5 distortion with 8 Ω (Ext speaker)bull Hum and noise (Except [EUR] [UK])

(Without CCITT Filter) Narrow 34 dB min 47 dB typ

Wide 40 dB min 52 dB typ bull Hum and noise ([EUR] [UK])

(With CCITT Filter) Narrow 40 dB min

Middle 43 dB minWide 45 dB min

bull Adjacent channel selectivity Narrow 60 dB min 65 dB typMiddle 70 dB min 73 dB typWide 70 dB min 73 dB typ

Specifications are measured in accordance with TIAEIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation

2 - 1

SECTION 2 INSIDE VIEWS

LED CTRL(Q82Q83)

VCO

bull MAIN-A UNIT (TOP VIEW)

CPU5 LINE REGULATOR(IC54)

+5V LINE REGULATOR(Q76)

PLL IC(IC2)

MICAF LINE SW(IC56)

APC AMP(IC1)

TCXO(X2)

TONE FILTER SW(Q52)

TONE LPF(IC59)

HPF(IC58)

MIC GAIN CONTROLLER(IC62)

2ND IF BPF(FI2)

2ND IF BPF (For narrow mode only)(FI3)

LPF(Q51)

BEEP SW(IC61)

+5V LINE REGULATOR(Q75)

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

1 - 2

M RECEIVER bull Sensitivity 025 microV typ at 12 dB SINAD Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ at 20 dB SINAD [EUR] [UK]bull Squelch sensitivity (at threshold) 025 microV typ Except [EUR] [UK]

ndash4 dBmicroV (EMF) typ [EUR] [UK]bull Intermodulation 70 dB min 74 dB typ Except [EUR] [UK]

65 dB min [EUR] [UK]bull Spurious response 70 dB minbull Audio output power 08 W typ at 5 distortion with 12 Ω (Int speaker)

04 W typ at 5 distortion with 8 Ω (Ext speaker)bull Hum and noise (Except [EUR] [UK])

(Without CCITT Filter) Narrow 34 dB min 47 dB typ

Wide 40 dB min 52 dB typ bull Hum and noise ([EUR] [UK])

(With CCITT Filter) Narrow 40 dB min

Middle 43 dB minWide 45 dB min

bull Adjacent channel selectivity Narrow 60 dB min 65 dB typMiddle 70 dB min 73 dB typWide 70 dB min 73 dB typ

Specifications are measured in accordance with TIAEIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation

2 - 1

SECTION 2 INSIDE VIEWS

LED CTRL(Q82Q83)

VCO

bull MAIN-A UNIT (TOP VIEW)

CPU5 LINE REGULATOR(IC54)

+5V LINE REGULATOR(Q76)

PLL IC(IC2)

MICAF LINE SW(IC56)

APC AMP(IC1)

TCXO(X2)

TONE FILTER SW(Q52)

TONE LPF(IC59)

HPF(IC58)

MIC GAIN CONTROLLER(IC62)

2ND IF BPF(FI2)

2ND IF BPF (For narrow mode only)(FI3)

LPF(Q51)

BEEP SW(IC61)

+5V LINE REGULATOR(Q75)

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

2 - 1

SECTION 2 INSIDE VIEWS

LED CTRL(Q82Q83)

VCO

bull MAIN-A UNIT (TOP VIEW)

CPU5 LINE REGULATOR(IC54)

+5V LINE REGULATOR(Q76)

PLL IC(IC2)

MICAF LINE SW(IC56)

APC AMP(IC1)

TCXO(X2)

TONE FILTER SW(Q52)

TONE LPF(IC59)

HPF(IC58)

MIC GAIN CONTROLLER(IC62)

2ND IF BPF(FI2)

2ND IF BPF (For narrow mode only)(FI3)

LPF(Q51)

BEEP SW(IC61)

+5V LINE REGULATOR(Q75)

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

2 - 2

CLONE BUFFER(Q81 D51)

TUNED BPF(D24 D26)

bull MAIN-A UNIT (BOTTOM VIEW)

DRIVE AMP(Q2)

POWER AMP(Q1)

PRE-DRIVE AMP(Q3)

PRE-AMP(Q4)

RF AMP(Q22)

RESET IC(IC53)

EEPROM(IC52)

AF AMP(IC55)

IF DEMODULATOR IC(IC3)

XTAL BPF(FI1)

AGC CTRL(Q21)

S5 LINE REGULATOR(Q71)

RIPPLE FILTER(Q15)

R5 LINE REGULATOR(Q72)

1ST IF MIXER(Q23)

POWER CTRL(Q63)

CPU(IC51)

DA CONVERTER(IC57)

BUFFER(IC60)

BUFFER(Q9)

+5V LINE REGULATOR(Q74)

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev=1130000103285010000000000A69C718000788C0013001010FD3CC15000E975A0140A320A0A3C3C0F13002010BBA18809090D32640D3A1E3C0000000013003010B5AD91B094878C822419141414325064130040100F030E00000000000000000000000000130050100000000000000000000000000000000013006010000000000000000000000000000000001300701000000000000000000000000000000000130080100000000000000000000000000000000013009010000000000000000000000000000000001300A01000000000000000000000001E8E0000001300B010000000000000000000000000000000001300C010000000000000000000000000000000001300D010000000000000000000000000000000001300E010000000000000000000000000000000001300F0100000000000000000000000000000000013010010000000000000000001000000000000001301101002EE06A8018006860000000000000000130120100001000A001205EC0000000000000000130130108302000201000003030500000000050313014010800000000000000080000000000000001301501000000000000000000000000000000000130160100000000000000000000000000000000013017010000000000000000000000000000000001301801017D7840017D784008000800000001C0313019010A1801C03A1808000800000001C03A1801301A0101C03A18080008000000019ED92C019ED1301B01092C080008000000019ED92C019ED92C01301C01080008000000019ED92C019ED92C080001301D0108000000019ED92C019ED92C0800040071301E010000019ED92C019ED92C08000800040001301F01019ED92C019ED92C080008000000019ED1302001092C019ED92C08000002D000019ED92C01302101019ED92C080008000000017D7840017D713022010840080008000400000000000000000001302301080008000400000000000000000008000130240108000400000000000000000008000800013025010400000000000000000008000800040001302601045000E0000000000FFFF09C480E809C41302701080E809C480E809C480E809C480E809C41302801080E809C480E809C480E809C480E809C41302901080E809C480E809C480E809C480E809C41302A01080E809C480E809C480E809C480E809C41302B01080E809C480E809C480E809C480E809C41302C01080E809C480E809C480E809C480E809C41302D01080E809C480E809C480E809C480E809C41302E01080E809C480E809C480E80000000081021302F0103000000100000000000081023000000113030010000000000000810230000001000000001303101000008302300000010000000000008202130320103000000100000000000081023000000113033010000000000000810230000001000000001303401000008102300000010000000000008102130350103000000100000000000081023000000113036010000000000000810230000001000000001303701000008102300000010000000000008302130380103000000100000000000083023000000113039010000000000000830230000001000000001303A010000083023000000100000000000012341303B0101593570000000000138827103E80FDF21303C010000000000000000000F8F80A0E0F02011303D010000401000001643214505050500A0A0A1303E0100A0A1E321E10100000001E14050A1E001303F0103C3C0A000000323C0032640000000010130400100000000000000000000000000000800013041010E7000009000100003C1E0800000000001304201000000000000000000000000020202020130430102020202020202020202020202020202013044010202020202020202020202020099209F6130450107E54837C099209F67E54837C099209F6130460107E54837C099209F67E54837C099209F6130470107E54837C099209F67E54837C099209F6130480107E54837C099209F67E54837C099209F6130490107E54837C099209F67E54837C000000001304A010000000000000000000000000000000081304B0100A140A140A140A140A140A140A140A141304C0100A140A1400000375037503751180A1801304D010001000000000000000000000000000001304E010000000000000000000000000000000001304F0100000000000000000000000000000000013050010000011002200330044005500660077001305101088009900AA10BB10CC10DD10EE10FF1013052010001011102210331044105510661077101305301088109910AA10BB10CC30DD30EE30FF301305401001FFFFFF00008203000001FFFFFF0000130550108302000001FFFFFF00008302000001FF13056010FFFF00008302000001FFFFFF0000830213057010000001FFFFFF00008302000001FFFFFF1305801000008302000001FFFFFF0000830200001305901001FFFFFF00008302000001FFFFFF00001305A0108302000001FFFFFF00008302000000001305B010000000000000000000000000000000001305C01000000000000004D20001B433100504001305D010003201000000000002028300140A0A0A1305E0103C3C1E0A00000000000064000002000E1305F0100010018000000005000800010260000013060010000C0002000102680000000F0004002013061010026A000000280004000102EA0000000313062010000C001002EE00000006007E000103AE130630100000000700200001042C000000090080130640100001044C0000000D000A000104CC000013065010000E000E000304D6000000100002002013066010050000000011000A000B054000000012130670100008000105AE000000130008000205B61306801000000014000A000105C600000029000413069010000105D0000000300018000105D400001306A01049434F4D20496E6300000000000000001306B010000000000000000000000000000000001306C010000000000000000000000000000000001306D010000000000000000000000000000000001306E010000000000000000000000000000000001306F010000000000000000000000000000000001307001000000000000000000000000000000000130710100000000000000000000000000000000013072010000000000000000000000000000000001307301000000000000000000000000000000000130740100000000000000000000000000000000013075010000000000000000000000000000000001307601000000000000000000000000000000000130770100000000000000000000000000000000013

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTION

BE CAREFUL to not pull out the speaker wire when separating the CHASSIS and the FRONT PANEL

For easy separation of the CHASSISUse a suction lifter to lift the bottom of the CHASSIS up

1 REMOVING THE CHASSIS1) Remove the ANT connector nut and 2 knobs

2 REMOVING THE MAIN UNIT1) Remove the 9 screws and the side plate from the

MAIN UNIT 2) Unsolder the 2 points shown and then remove the

MAIN UNIT

2) Remove 2 screws from the bottom of the CHASSIS3) Lift the bottom of the CHASSIS up in the direction

of the arrow

4) CAREFULLY lift the chassis out of the FRONT PANEL and turn it over in order to unplug the speaker wire

(Continued to the right above)

5) Remove the seals and nuts from the CHASSIS

ANT CONNECTOR NUT

KNOBS

FRONT PANEL

FRONT PANEL

CHASSIS

SCREWStimes2

SPEAKERWIRE

CHASSIS

FRONT PANEL

TOP SEAL

NUTStimes2 SIDE SEAL

CHASSIS

UNSOLDER

Solderremover

CHASSISSCREWStimes9

MAIN UNIT

MAIN UNIT

SIDE PLATE

Suction lifter

Suction lifterbull Part name EA950R-2bull Manufacture ESCO COLTD

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev=1130000103285010000000000A69C718000788C0013001010FD3CC15000E975A0140A320A0A3C3C0F13002010BBA18809090D32640D3A1E3C0000000013003010B5AD91B094878C822419141414325064130040100F030E00000000000000000000000000130050100000000000000000000000000000000013006010000000000000000000000000000000001300701000000000000000000000000000000000130080100000000000000000000000000000000013009010000000000000000000000000000000001300A01000000000000000000000001E8E0000001300B010000000000000000000000000000000001300C010000000000000000000000000000000001300D010000000000000000000000000000000001300E010000000000000000000000000000000001300F0100000000000000000000000000000000013010010000000000000000001000000000000001301101002EE06A8018006860000000000000000130120100001000A001205EC0000000000000000130130108302000201000003030500000000050313014010800000000000000080000000000000001301501000000000000000000000000000000000130160100000000000000000000000000000000013017010000000000000000000000000000000001301801017D7840017D784008000800000001C0313019010A1801C03A1808000800000001C03A1801301A0101C03A18080008000000019ED92C019ED1301B01092C080008000000019ED92C019ED92C01301C01080008000000019ED92C019ED92C080001301D0108000000019ED92C019ED92C0800040071301E010000019ED92C019ED92C08000800040001301F01019ED92C019ED92C080008000000019ED1302001092C019ED92C08000002D000019ED92C01302101019ED92C080008000000017D7840017D713022010840080008000400000000000000000001302301080008000400000000000000000008000130240108000400000000000000000008000800013025010400000000000000000008000800040001302601045000E0000000000FFFF09C480E809C41302701080E809C480E809C480E809C480E809C41302801080E809C480E809C480E809C480E809C41302901080E809C480E809C480E809C480E809C41302A01080E809C480E809C480E809C480E809C41302B01080E809C480E809C480E809C480E809C41302C01080E809C480E809C480E809C480E809C41302D01080E809C480E809C480E809C480E809C41302E01080E809C480E809C480E80000000081021302F0103000000100000000000081023000000113030010000000000000810230000001000000001303101000008302300000010000000000008202130320103000000100000000000081023000000113033010000000000000810230000001000000001303401000008102300000010000000000008102130350103000000100000000000081023000000113036010000000000000810230000001000000001303701000008102300000010000000000008302130380103000000100000000000083023000000113039010000000000000830230000001000000001303A010000083023000000100000000000012341303B0101593570000000000138827103E80FDF21303C010000000000000000000F8F80A0E0F02011303D010000401000001643214505050500A0A0A1303E0100A0A1E321E10100000001E14050A1E001303F0103C3C0A000000323C0032640000000010130400100000000000000000000000000000800013041010E7000009000100003C1E0800000000001304201000000000000000000000000020202020130430102020202020202020202020202020202013044010202020202020202020202020099209F6130450107E54837C099209F67E54837C099209F6130460107E54837C099209F67E54837C099209F6130470107E54837C099209F67E54837C099209F6130480107E54837C099209F67E54837C099209F6130490107E54837C099209F67E54837C000000001304A010000000000000000000000000000000081304B0100A140A140A140A140A140A140A140A141304C0100A140A1400000375037503751180A1801304D010001000000000000000000000000000001304E010000000000000000000000000000000001304F0100000000000000000000000000000000013050010000011002200330044005500660077001305101088009900AA10BB10CC10DD10EE10FF1013052010001011102210331044105510661077101305301088109910AA10BB10CC30DD30EE30FF301305401001FFFFFF00008203000001FFFFFF0000130550108302000001FFFFFF00008302000001FF13056010FFFF00008302000001FFFFFF0000830213057010000001FFFFFF00008302000001FFFFFF1305801000008302000001FFFFFF0000830200001305901001FFFFFF00008302000001FFFFFF00001305A0108302000001FFFFFF00008302000000001305B010000000000000000000000000000000001305C01000000000000004D20001B433100504001305D010003201000000000002028300140A0A0A1305E0103C3C1E0A00000000000064000002000E1305F0100010018000000005000800010260000013060010000C0002000102680000000F0004002013061010026A000000280004000102EA0000000313062010000C001002EE00000006007E000103AE130630100000000700200001042C000000090080130640100001044C0000000D000A000104CC000013065010000E000E000304D6000000100002002013066010050000000011000A000B054000000012130670100008000105AE000000130008000205B61306801000000014000A000105C600000029000413069010000105D0000000300018000105D400001306A01049434F4D20496E6300000000000000001306B010000000000000000000000000000000001306C010000000000000000000000000000000001306D010000000000000000000000000000000001306E010000000000000000000000000000000001306F010000000000000000000000000000000001307001000000000000000000000000000000000130710100000000000000000000000000000000013072010000000000000000000000000000000001307301000000000000000000000000000000000130740100000000000000000000000000000000013075010000000000000000000000000000000001307601000000000000000000000000000000000130770100000000000000000000000000000000013

4 - 1

bull RF CIRCUITS

bull 1ST IF CIRCUITS

bull 2ND IF CIRCUITS

SECTION 4 CIRCUIT DESCRIPTION

LPFANTSW

D3D22

RFAMP

Q22

BPF

D28 D24D26

BPF

T2 T1

From the TX circuits

To the 1st IF circuits

ANT

LOSW

D5D6

Q23

BPFXTAL

FI1

IFAMP

Q24

BUFF

Q8

BUFF

Q10

LPF

RX VCO

To the TX circuits

From the RF circuitsTo the 2nd IFampdemodulator circuits4635MHz

1st IF mixer

PLLIC

IC2MB15A02X3

Q26

BPF

X2

TCXO

WNSW

Q27D33D34

X1

Discriminator

BPFCERAMIC

FI2

BPFCERAMIC

FI3

WNSW

D31D32DA

converter

IF ICFrom the 1st IF

circuits

To the RX AF circuits

IC3NJM2591

153MHz

459MHz

DISC

SQIN

IC57R2A20178

450kHz

450kHz

NWC

NOIS

4-1 RECEIVER CIRCUITSRF CIRCUITSThe RX signal from the antenna is passed through the LPF and antenna SW then filtered by the 2-staged tuned BPF to eliminate unwanted out-of-band signal The filtered RX signal is amplified by the RF AMP and filtered by another 2-staged tuned BPF to obtain a good image response then applied to the 1st IF circuits

The tuned BPFs are tuned to the RX frequency by applying adequate tuning voltages ldquoT1rdquo and ldquoT2rdquo to the variable capacitors

1ST IF CIRCUITSThe RX signal from the RF circuits is applied to the 1st IF mixer and mixed with the 1st LO signal from the RX VCO resulting in the 4635 MHz 1st IF signal The 1st IF signal is filtered by the crystal filter amplified by the 1st IF AMP then applied to the 2nd IF circuits

2ND IF CIRCUITS AND DEMODULATORThe signal from the 1st IF circuits is applied to the IF demodulator IC which contains the 2nd IF mixer 2nd IF AMP FM detector etc in its package

The 1st IF signal is applied to the 2nd IF mixer and mixed with the 2nd LO signal resulting in the 450 kHz 2nd IF signal

The 2nd LO signal is generated by tripling the 153 MHz reference frequency signal oscillated by the reference frequency oscillator (TCXO)

The converted 2nd IF signal is filtered by the crystal filterfilters to eliminate unwanted signal and amplified by the 2nd IF AMP then demodulated by the detector circuit which employs a discriminator as the phase shifter

The demodulated AF signal is applied to the RX AF circuits

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

4 - 2

bull RX AF CIRCUITS

AFAM P

IC55 TPA0211DGNJ52

IC62

RXMUTE

SP1

HPF

IC58

AFAM P

IC12TA7368F

HPF

IC58

J53

Intspeaker

Extspeaker

12

LPF

IC58

LPF

IC59

the demodulatorcircuits

IC56

AF line SW

CD4066

AFON

AFO

RMUT 1

DAconverter

IC57R2A20178

RX AF CIRCUITSThe demodulated AF signal from the IF demodulator IC is passed through the LPF HPF which attenuates frequencies 300 Hz and below The filtered AF signal is passed through the AF line SW HPF which additionally attenuates frequencies 300 Hz and below de-emphasis circuit which provides ndash6 dBoct of frequency response The de-emphasized AF signal is passed through the AF SW LPF which attenuates frequencies 3 kHz and above is adjusted in level by the DA converter The level-adjusted AF signal is then applied to the AF power AMP via the AF line SW

The amplified AF signal is applied to the internal or external speaker

4-2 TRANSMITTER CIRCUITSTX AF CIRCUITSThe audio signal from the internal or external microphone (MIC signal) is passed through the MIC gain SW and applied to the MIC AMP The amplified MIC signal is passed through the MIC mute SW HPF which attenuates frequencies 300 Hz and below The filtered MIC signal is passed through the pre-emphasis circuit which provides +6 dBoct of frequency response then they applied to the limiter AMP

The amplitude-limited MIC signal is passed through the MIC line SW and applied to the splatter filter which attenuate harmonics in the MIC signal to prevent exceeding permissible deviation

The filtered MIC signal is applied to the DA converter which adjusts its level (=deviation) The level-adjusted MIC signal is applied to the TX VCO as the modulation signal

bull TX AF CIRCUITS

AMlimit

P

IC58

MICMUTE

IC62

MICGAINSW

IC62

HPF

IC58

MC51

AMMICP

IC60

LPF

IC58

Splatter

J51ExtMIC

IntMIC

DA

MODTo the modulation circuits

IC56

MIClineSW

CD4066

IC57

MODULATION CIRCUITThe modulation signal from the TX AF circuits is applied to D15 of the TX VCO to frequency-modulate it The frequency-modulated signal from the TX VCO is buffer-amplified by two buffers and applied to the TX AMP circuits via the TXRX SW (D5)

bull MODULATION CIRCUITS

LOSW

D5D6

Q14D16

FREQUENCYMODULATION

D15

BUFF

Q8

BUFF

Q10TX VCO

From the TX AF circuits

To the TX AMP circuits

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

4 - 3

bull TX AMPLIFIERS AND APC CIRCUIT

bull FREQUENCY SYNTHESIZER CIRCUITS

4-4 VOLTAGE BLOCK DIAGRAM

LPF

PWRDET

D1D2

MUTESW

Q6

ANTSW

D3D22

PWRAMP

Q1

APCAMP

IC1

DRIVEAMP

Q2

DRIVEPRE

Q3

PREAMP

Q4

LPF

T1

TMUT

ANT

From theTX VCO

To the RX circuits

LPF

LOSW

D5D6

Q13D12

Q14D16

FILTERLOOP

PLLIC

SOSCLPLST

IC2

X3

Q26

Q23

To the TX AMPs

BPF

BUFF

Q8

BUFF

Q10

BUFF

Q9

X2

TCXO

LVADJ

D14

LVADJ

D11

BUFF

IC60

LPF

IF IC

RX VCO

TX VCO

IC3

REF

BAL153MHz

459MHz 1st IF mixer

LV

LVA

T5 To the TX circuits

To the RX circuits

To both RX and TX circuits

To both RX and TX circuits

To the logical circuits

REG

Q73

REG+5V

Q74-76

REGS5

Q71

S5

CPU5REG

IC54

REGR5

Q72

S5C

VCC

R5C

+5V

T5C

S5V

R5VPWON

CPU5

T5V

TX AMPLIFIERSThe buffer amplified signal from the LO SW (D5) is amplified by the pre-AMP pre-drive AMP drive AMP and power AMP in sequence to obtain TX power The amplified TX signal is passed through the antenna SW and the LPF which eliminates harmonics and then fed to the antenna

APC CIRCUITSD1 and D2 rectify a portion of the TX signal to direct current and the APC AMP compares the voltage and the TX power control reference voltage ldquoT1rdquo The resulting voltage controls the gain of the power and drive AMPs to keep the TX power constant

4-3 FREQUENCY SYNTHESIZER CIRCUITSThe RX VCO is composed of Q13 D11 and D12 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

The TX VCO is composed of Q14 and D14ndashD16 The VCO output signal is buffer-amplified by two buffers and applied to the 1st IF mixer via the LO SW (D6) and the LPF

A portion of oscillated signal from each VCO is fed back to the PLL IC via the buffer and the LPF

The applied VCO output signal is divided and phase-compared with a 153 MHz reference frequency signal from the TCXO which is also divided The resulting signal is output from the PLL IC and DC-converted by the loop filter and then applied to the VCO as the lock voltage

When the oscillation frequency drifts its phase changes from that of the reference frequency causing a lock voltage change to compensate for the drift in the VCO oscillating frequency

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

4 - 4

4-5 PORT ALLOCATIONSbull CPU (IC51)

bull DA CONVERTER (IC57)

PINNO

LINENAME DESCRIPTION IO

1 CDECTone signal (CTCSSDTCS) decoding input

I

2 STONETone signal (52 TONE DTMF BIIS) decodingencoding

IO

13 CSFTClock frequency shiftH=Clock frequency is shifted

O

14 NWC

R X m o d e ( n a r r o w w i d e )switchingL= While receiving in the narrow

mode

O

15 EPTTExternal PTT inputH=An external PTT is pushed

I

16 ATXAutomatic TX control for VOX modeH=Microphone input is detected

O

17 BEEP Beep sounds (Square waves) O

18 AFONAF power AMP controlH= AF power AMP ( IC55) is

activatedO

19 SCK Common clock O

20 SO Common serial data O

22 KEY2[UPPER] key inputL=Pushed

I

23 KEY1[LOWER] key inputL=Pushed

I

24 PLSTPLL strobeH=Load enable

IO

25 DASTDA converter strobeH=Load enable

IO

26 ESDA EEPROM data IO

27 ESCL EEPROM clock IO

28 R5CPower supply switching controlH= Supply ing current to the

receiver circuits (R5line)O

29 T5CPower supply switching controlH= Supply ing current to the

transmitter circuits (T5line)O

30 S5CPower supply switching controlH= Supplying current to the RX

TX common circuits (S5line)O

31 PWONPower supply switching controlH= The transceivers power is

ONO

32 IPTTInternal PTT inputL=PTT pushed

I

333436

CENC2 CENC1 CENC0

CTCSSDTCS signal O

37ndash40

CBI0ndashCBI3

[ROTARY SELECTOR] input I

41 DUSEFrequency response switchingH=DTCS encoding

O

42 RLEDBusy LED (Green) controlL=LED lights (Squelch open)

O

43 TLEDBusy LED (Red) controlL=LED lights (Transmit)

O

47 MGC0 MIC gain control O

48 MGC1 MIC gain control O

49 CLICloning data

I

50 CLO O

PINNO

LINENAME DESCRIPTION IO

51 ADSWAD conversion selectH=RSSI input L=BATV input

O

53 NOISNoise level detectH=Squelch close

I

54 UNLK PLL unlock detect I

55 RMUT2RX AF mute switch controlL=AF mute

O

56 RMUT1RX AF mute switch controlL=AF mute

O

57 MMUTMIC mute switch controlL=MIC mute

O

58 TMUTTransmission muteL=TX inhibit

O

59 MDETExternal microphone connection detect

I

60 LVIN Lock voltage input I

61 TEMP Temperature sensing voltage I

62 AFVI [VOLUME CONTROL] input I

63 VOXV Microphone input sensing voltage I

64 AD5

Remaining battery voltage (or)RSSI voltage( The input signal depends on the status of pin 51)

I

PINNo

LINENAME

DESCRIPTION

23 T1(TXPO)

BPF tuning voltageTX power control

24 T2 BPF tuning voltage

7 REF Reference frequency adjust voltage

8 LVA Additional lock voltage adjustment

11 SQLC Squelch threshold setting

12 TENC CTCSS deviation adjustment

19 BAL DTCS balance

20 VRAF Max deviationAF volume adjustment

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

SECTION 5 ADJUSTMENT PROCEDURE

5 - 1

curren JIG CABLE

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Cloning softwareCS-F3000 CLONING SOFTWARE (Revision 10 or later)

JIG cableModifi ed OPC-478UUC(See the illusted below)

RF power meter(50 Ω terminated)

Measuring range 01ndash6 WFrequency range 100ndash600 MHzSWR Less than 12 1

Frequency counterFrequency range 01ndash600 MHzFrequency accuracy plusmn1 ppm or betterInput level Less than 1 mW

ModulationAnalyzer

Frequency range 30ndash600 MHzMeasuring range 0 to plusmn10 kHz Standard signal

generator (SSG)

Frequency range 01ndash600 MHzOutput level ndash20 to 90 dBmicro (ndash127 to ndash17 dBm)AC millivoltmeter Measuring range 10 mV to 10 V

OscilloscopeFrequency range DCndash20 MHzMeasuring range 001ndash20 V

AttenuatorPower attenuation 30 dBCapacity More than 6 W

Audio generator(AG)

Frequency range 300ndash3000 HzOutput level 1ndash500 mV

External speakerInput impedance 8 ΩCapacity More than 1 W

curren REQUIRED EQUIPMENTS5-1 PREPARATION

3-conductor 25 (d) mm plug

(MIC)

(GND)

33 k

3-conductor 35(d) mm plug

(CLONE)

OPC-478UUC

(GND)

(SP)

[JIG cable1]

[JIG cable2]

+ minus

ACMILLIVOLTMETER

(10 mV to 10 V)AUDIO GENERATOR

(300ndash3000 Hz1ndash500 mV)

+ minusPTT

+

47 microF

EXT SPEAKER(1 W8 Ω)

+

minus

SETTINGFrequency 1 kHzLevel 1minus500mVWaveform Sine wave

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

5 - 2

curren CONNECTION

FMdeviation meter

Speaker (8 Ω)

to the antenna connector

Attenuator30 dB

RF power meter01ndash 6 W50 Ω

Frequencycounter

Standard signal generatorndash20 to 90 dBmicro

(ndash127 to ndash17 dBm)

NEVER transmit while an SSG is connected to the antenna connector

To [SP]

To [MIC]

JIG cables

To [SP] connector

PC

to USB port

to USB port

to RS-232C portOPC-478(RS-232C type)

OPC-478U (USB type)

OPC-478UC (USB type)

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev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

curren ADJUSTMENT CHANNELSBefore starting the adjustments use the cloning software to create the same cloning fi le as shown below then upload it into the transceiver

5 - 3

Select ldquoMiddlerdquo

For [EUR] versions When adjusting ldquoDeviationrdquo in the middle band change the bandwidth to ldquoMiddlerdquo as shown below

CONVENIENT The same cloning file is availableRight-click below and select Save Embeded File to Disk

3285000013Comment=13MapRev=1130000103285010000000000A69C718000788C0013001010FD3CC15000E975A0140A320A0A3C3C0F13002010BBA18809090D32640D3A1E3C0000000013003010B5AD91B094878C822419141414325064130040100F030E00000000000000000000000000130050100000000000000000000000000000000013006010000000000000000000000000000000001300701000000000000000000000000000000000130080100000000000000000000000000000000013009010000000000000000000000000000000001300A01000000000000000000000001E8E0000001300B010000000000000000000000000000000001300C010000000000000000000000000000000001300D010000000000000000000000000000000001300E010000000000000000000000000000000001300F0100000000000000000000000000000000013010010000000000000000001000000000000001301101002EE06A8018006860000000000000000130120100001000A001205EC0000000000000000130130108302000201000003030500000000050313014010800000000000000080000000000000001301501000000000000000000000000000000000130160100000000000000000000000000000000013017010000000000000000000000000000000001301801017D7840017D784008000800000001C0313019010A1801C03A1808000800000001C03A1801301A0101C03A18080008000000019ED92C019ED1301B01092C080008000000019ED92C019ED92C01301C01080008000000019ED92C019ED92C080001301D0108000000019ED92C019ED92C0800040071301E010000019ED92C019ED92C08000800040001301F01019ED92C019ED92C080008000000019ED1302001092C019ED92C08000002D000019ED92C01302101019ED92C080008000000017D7840017D713022010840080008000400000000000000000001302301080008000400000000000000000008000130240108000400000000000000000008000800013025010400000000000000000008000800040001302601045000E0000000000FFFF09C480E809C41302701080E809C480E809C480E809C480E809C41302801080E809C480E809C480E809C480E809C41302901080E809C480E809C480E809C480E809C41302A01080E809C480E809C480E809C480E809C41302B01080E809C480E809C480E809C480E809C41302C01080E809C480E809C480E809C480E809C41302D01080E809C480E809C480E809C480E809C41302E01080E809C480E809C480E80000000081021302F0103000000100000000000081023000000113030010000000000000810230000001000000001303101000008302300000010000000000008202130320103000000100000000000081023000000113033010000000000000810230000001000000001303401000008102300000010000000000008102130350103000000100000000000081023000000113036010000000000000810230000001000000001303701000008102300000010000000000008302130380103000000100000000000083023000000113039010000000000000830230000001000000001303A010000083023000000100000000000012341303B0101593570000000000138827103E80FDF21303C010000000000000000000F8F80A0E0F02011303D010000401000001643214505050500A0A0A1303E0100A0A1E321E10100000001E14050A1E001303F0103C3C0A000000323C0032640000000010130400100000000000000000000000000000800013041010E7000009000100003C1E0800000000001304201000000000000000000000000020202020130430102020202020202020202020202020202013044010202020202020202020202020099209F6130450107E54837C099209F67E54837C099209F6130460107E54837C099209F67E54837C099209F6130470107E54837C099209F67E54837C099209F6130480107E54837C099209F67E54837C099209F6130490107E54837C099209F67E54837C000000001304A010000000000000000000000000000000081304B0100A140A140A140A140A140A140A140A141304C0100A140A1400000375037503751180A1801304D010001000000000000000000000000000001304E010000000000000000000000000000000001304F0100000000000000000000000000000000013050010000011002200330044005500660077001305101088009900AA10BB10CC10DD10EE10FF1013052010001011102210331044105510661077101305301088109910AA10BB10CC30DD30EE30FF301305401001FFFFFF00008203000001FFFFFF0000130550108302000001FFFFFF00008302000001FF13056010FFFF00008302000001FFFFFF0000830213057010000001FFFFFF00008302000001FFFFFF1305801000008302000001FFFFFF0000830200001305901001FFFFFF00008302000001FFFFFF00001305A0108302000001FFFFFF00008302000000001305B010000000000000000000000000000000001305C01000000000000004D20001B433100504001305D010003201000000000002028300140A0A0A1305E0103C3C1E0A00000000000064000002000E1305F0100010018000000005000800010260000013060010000C0002000102680000000F0004002013061010026A000000280004000102EA0000000313062010000C001002EE00000006007E000103AE130630100000000700200001042C000000090080130640100001044C0000000D000A000104CC000013065010000E000E000304D6000000100002002013066010050000000011000A000B054000000012130670100008000105AE000000130008000205B61306801000000014000A000105C600000029000413069010000105D0000000300018000105D400001306A01049434F4D20496E6300000000000000001306B010000000000000000000000000000000001306C010000000000000000000000000000000001306D010000000000000000000000000000000001306E010000000000000000000000000000000001306F010000000000000000000000000000000001307001000000000000000000000000000000000130710100000000000000000000000000000000013072010000000000000000000000000000000001307301000000000000000000000000000000000130740100000000000000000000000000000000013075010000000000000000000000000000000001307601000000000000000000000000000000000130770100000000000000000000000000000000013

5 - 4

curren ADJUSTMENT UTILITY

DEVIATION

　Click to open theldquoIO Check windowrdquo

ADJ CHANNEL

RX SENSITIVITY

MOD BALANCE

CTCSSDTCS

REF FREQUENCYSQUELCH

LOCK VOLTAGE(Adjustment)

TX OUTPUT POWER

If the below window appears the utility is password-protectedEnter the password to open the Adjust Utility window

Click or [Read ltndash TR] in the [Adjust] menu to open the Adjust Utility window as shown below

5 - 5

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

PLL LOCK VOLTAGE-Adjustment-

1ndash

bull Connect an RF power meter to the antenna connector ndash ndash

(RX) 2 bull CH 1bull Receiving

bull Select the item [RX LVA] then push [ENTER] [RX LVA]

10 V

(TX) 3 bull CH 1bull Transmitting

bull Select the item [TX LVA] then push [ENTER] [TX LVA]

10 V

PLL LOCK VOLTAGE-Verify-(RX)

1 bull CH 2bull Receiving

bull Click the [Reload (F5)] button to check on the IO Check window as illustrated below [LVIN]

(On the IO Check window)

30ndash40 V(Verify)

(TX) 2 bull CH 2bull Transmitting

27ndash39 V(Verify)

REFERENCEFREQUENCY

1 bull CH 3bull Transmitting

bull Loosely couple a frequency counter to the antenna connector [REF]

4700000 MHz(plusmn300 Hz)

5-2 FREQUENCY ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

bull IO Check window

(The values shown above are example only Each transceiver has own values)

Lock voltage

5 - 6

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

TX OUTPUT POWER(Hi power)

1 bull CH 4bull Transmitting

bull Connect an RF power meter to the antenna connector [Power (Hi)] 40 W

(L2 power) 2 bull CH 5bull Transmitting

[Power (L2)] 20 W

(L1 power) 3 bull CH 6bull Transmitting

[Power (L1)] 10 W

MODULATION BALANCE

1 bull CH 7bull Transmitting

bull Connect a modulation analyzer with an oscilloscope to the antenna connector through an attenuator

[BAL]

Square waveform

FM DEVIATION( Narrow mode)

1 bull CH 8bull Transmitting

bull Connect a modulation analyzer to the antenna connector through an attenuator

[MOD N C]plusmn205 to plusmn215

kHz

( Middle mode) 2 bull CH 9bull Transmitting

[MOD M C]plusmn325 to plusmn335

kHz

( Wide mode) 3 bull CH 9bull Transmitting

[MOD W C]plusmn405 to plusmn415

kHz

CTCSSDTCS DEVIATION

1 bull CH 10bull Transmitting

bull Connect a modulation analyzer to the antenna connector through an attenuator [CTCSSDTCS]

plusmn065 to plusmn075 kHz

[EUR] versions only

5-3 TRANSMIT ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

5 - 7

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

RX SENSITIVITY 1 bull CH 11bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 435 MHz Level 20 dBmicro (ndash87 dBm) Modulation 1 kHz Deviation plusmn3 kHz2) Put the cursor on the adjustment item

then push [ENTER]

[BPF ALL]

(Automatic adjustment)

SQUELCH 1 bull CH 12bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 400 MHz Level ndash13 dBmicro (ndash120 dBm) Modulation 1 kHz Deviation plusmn15 kHz2) Once close the squelch by increasing

[SQL] value then decrease the value to open the squelch

3) Push [ENTER] key to store the value

[SQL]

(Automatic adjustment)

The output level of the standard signal generator (SSG) is indicated as the SSGrsquos open circuit

5-4 RECEIVE ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

6 - 1

SECTION 6 PARTS LIST

IC1 1110002751 SIC TA75S01F(TE85RF) T 32588IC2 1140005991 SIC MB15A02PFV1-G-BND-ERE1 T 429247IC3 1110007320 SIC NJM2591V-TE1-ZZZB B 458389IC51 1140015230 SIC R4F20102NFA (EMPTY) B 77738IC52 1130015240 SIC R1EX24016ATA00A B 85252IC53 1110007620 SIC NJU7704F3-42A-TE1-ZZZB B 876446IC54 1180003600 SREG NJM2871BF05-TE1-ZZZB T 156348IC55 1110007610 SIC TPA0211DGNR B 138421IC56 1130011770 SIC CD4066BPWR T 801188IC57 1110007550 SIC R2A20178NP B 725245IC58 1110005340 SIC NJM12902V-TE1-ZZZB T 80112IC59 1110006350 SIC LM2902PWR T 801259IC60 1110005340 SIC NJM12902V-TE1-ZZZB B 65175IC61 1140013200 SIC CD4053BPWR T 801383IC62 1130011770 SIC CD4066BPWR T 66781 Q1 1560001700 SFET RD07MUS2B-T112 B 286135Q2 1560001241 SFET RD01MUS1-T113 B 361144Q3 1530000371 STRA 2SC3356-T1B S (R25) B 413129Q4 1530003311 STRA 2SC5107-O(TE85RF) B 462134Q6 1590004050 STRA LDTA144EET1G ltSLVJgt T 33359Q8 1530003311 STRA 2SC5107-O(TE85RF) T 556186Q9 1530003311 STRA 2SC5107-O(TE85RF) B 581194Q10 1530003311 STRA 2SC5107-O(TE85RF) T 61191Q11 1590004070 STRA LDTC144EET1G ltSLVJgt B 508252Q12 1590004070 STRA LDTC144EET1G ltSLVJgt B 63236Q13 1530002920 STRA 2SC4226-T1 R25 T 565226Q14 1530002920 STRA 2SC4226-T1 R25 T 622223Q15 1530002851 STRA 2SC4116-BL(TE85RF) B 627162Q17 1560000541 SFET 2SK880-Y(T5RICOMF) B 526295Q19 1590004070 STRA LDTC144EET1G ltSLVJgt B 635336Q21 1560000841 SFET 2SK1829(TE85RF) B 257315Q22 1580000731 SFET 3SK293(TE85LF) B 21229Q23 1580000731 SFET 3SK293(TE85LF) B 364273Q24 1530002601 STRA 2SC4215-O(TE85RF) B 383426Q25 1590004070 STRA LDTC144EET1G ltSLVJgt T 493351Q26 1530002851 STRA 2SC4116-BL(TE85RF) T 396301Q27 1590004050 STRA LDTA144EET1G ltSLVJgt B 56364Q51 1590001650 STRA XP4601(TX) T 65542Q52 1590004070 STRA LDTC144EET1G ltSLVJgt T 754314Q58 1590003431 STRA UNR911HG0L B 54971Q59 1590004070 STRA LDTC144EET1G ltSLVJgt B 49173Q63 1520000460 STRA 2SB1132 T100 R B 151355Q64 1590001190 STRA XP6501-(TX)AB B 19336Q71 1510001090 STRA KTA2015Y-RTKP B 651366Q72 1510000771 STRA 2SA1586-GR(TE85LF) B 657303Q73 1510001090 STRA KTA2015Y-RTKP B 786238Q74 1520000460 STRA 2SB1132 T100 R B 53344Q75 1590001190 STRA XP6501-(TX)AB T 45352Q76 1590004070 STRA LDTC144EET1G ltSLVJgt T 68352Q81 1590003271 STRA UNR9210G0L B 705458Q82 1590004050 STRA LDTA144EET1G ltSLVJgt T 716395Q83 1590004050 STRA LDTA144EET1G ltSLVJgt T 716416Q84 1590004070 STRA LDTC144EET1G ltSLVJgt B 192441Q85 1590004070 STRA LDTC144EET1G ltSLVJgt B 224441 D1 1750001800 SDIO RB886CS T2RA B 13866D2 1750001800 SDIO RB886CS T2RA B 138105D3 1750001890 SDIO HVD142AKRF-E B 157148D5 1750001890 SDIO HVD142AKRF-E B 496152D6 1750001890 SDIO HVD142AKRF-E B 496166D11 1750001550 SVAR HVD376BKRF-E T 568264D12 1750001840 SVAR HVD350BKRF-E T 54287D14 1750001550 SVAR HVD376BKRF-E T 604261D15 1750001650 SVAR 1SV309(TPH3F) T 646282D16 1750001840 SVAR HVD350BKRF-E T 625282D18 1750001810 SDIO L1SS400T1G ltSLVJgt T 463326D21 1750001810 SDIO L1SS400T1G ltSLVJgt B 281333D22 1750001890 SDIO HVD142AKRF-E B 157183D24 1750001780 SVAR HVB350BYPTL-E B 181238D26 1750001780 SVAR HVB350BYPTL-E B 181267D28 1750001780 SVAR HVB350BYPTL-E B 292267D31 1750001790 SDIO 1SS390 TE61 B 541398D32 1750001790 SDIO 1SS390 TE61 B 517368D33 1750001790 SDIO 1SS390 TE61 B 567398D34 1750001790 SDIO 1SS390 TE61 B 581385D35 1750001810 SDIO L1SS400T1G ltSLVJgt T 37563D51 1750001820 SDIO LRB706F-40T1G ltSLVJgt B 679458D52 1750001790 SDIO 1SS390 TE61 B 87337D53 1750001810 SDIO L1SS400T1G ltSLVJgt B 69131D55 1750001810 SDIO L1SS400T1G ltSLVJgt B 219338 FI1 2030000870 SMON MFT463P3 46350 MHz (FL-442) B 362346FI2 2020002460 CER LTM450GW ltJJEgt FI3 2020002570 CER LTM450HW ltJJEgt X1 6070000310 SDIS JTBM450CX70 ltJJEgt T 476409X2 6050012050 SXTA CR-794 TTS14VSB-A6 153 MHz T 41915X51 6050012730 SXTA CR-864 (SMD-4912288 MHz) ltJJEgt T 869385 L1 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 9575L2 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 106105

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

L3 6200013010 SCOI 030-09-5TL 103N ltCOMOgt B 127134L4 6200002851 SCOI NLV25T-R82J B 182166L5 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 182134L6 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 207134L7 6200012980 SCOI 040-14-5TR 183N ltCOMOgt B 236134L8 6200013860 SCOI MLK1005S12NJT B 41107L9 6200013840 SCOI MLK1005S18NJT B 455107L11 6200010850 SCOI LQW18AN22NG00D (LQW1608A22NG00) B 139166L13 6200007700 SCOI LQW2BHN22NJ03L B 151224L14 6200007700 SCOI LQW2BHN22NJ03L B 152281L15 6200007680 SCOI LQW2BHN12NJ03L B 258276L16 6200007680 SCOI LQW2BHN12NJ03L B 327276L18 6200013800 SCOI MLK1005S39NJT B 364235L19 6200013780 SCOI MLK1005S56NJT B 344251L20 6200004770 SCOI ELJNC R56J-F B 394277L23 6200012170 SCOI MLG1608SR18J-T T 394346L24 6200012170 SCOI MLG1608SR18J-T T 415318L31 6200013810 SCOI MLK1005S33NJT T 538177L32 6200013810 SCOI MLK1005S33NJT B 563204L33 6200013830 SCOI MLK1005S22NJT T 592183L35 6190002030 SCOI MLG1608S 1R0J-T B 591266L36 6200013580 SCOI 030-09-4TR 5PER ltCOMOgt T 543261L37 6190002030 SCOI MLG1608S 1R0J-T T 565287L40 6200013630 SCOI 030-09-3TR 58N 5PER ltCOMOgt T 638249L41 6200011860 SCOI LQW18ANR47G00D T 589274L42 6190002030 SCOI MLG1608S 1R0J-T T 605288L47 6200013840 SCOI MLK1005S18NJT B 513204L48 6200013990 SCOI MLK1005S1N0ST B 327131 R1 7030005070 SRES ERJ2GEJ 683 X (68K) B 7255R2 7030009140 SRES ERJ2GEJ 272 X (27K) B 12589R3 7030005120 SRES ERJ2GEJ 102 X (1K) B 1418R4 7030005120 SRES ERJ2GEJ 102 X (1K) B 14189R5 7030009140 SRES ERJ2GEJ 272 X (27K) B 125109R6 7030004990 SRES ERJ2GEJ 221 X (220) B 203179R11 7030009140 SRES ERJ2GEJ 272 X (27K) T 29959R12 7030005050 SRES ERJ2GEJ 103 X (10K) T 31759R13 7030005090 SRES ERJ2GEJ 104 X (100K) T 326113R14 7030005310 SRES ERJ2GEJ 124 X (120K) T 308113R15 7030005170 SRES ERJ2GEJ 474 X (470K) T 34859R16 7030005530 SRES ERJ2GEJ 100 X (10) T 35796R17 7030008280 SRES ERJ2GEJ 271 X (270) T 34876R18 7030005120 SRES ERJ2GEJ 102 X (1K) T 35776R21 7030005530 SRES ERJ2GEJ 100 X (10) B 332108R22 7030005040 SRES ERJ2GEJ 472 X (47K) B 34191R23 7030005060 SRES ERJ2GEJ 333 X (33K) B 32391R26 7030004970 SRES ERJ2GEJ 470 X (47) B 382108R27 7030005040 SRES ERJ2GEJ 472 X (47K) B 38291R29 7030004970 SRES ERJ2GEJ 470 X (47) B 4198R30 7030005220 SRES ERJ2GEJ 223 X (22K) B 418151R31 7030004980 SRES ERJ2GEJ 101 X (100) B 45598R32 7030005220 SRES ERJ2GEJ 223 X (22K) B 457152R33 7030005050 SRES ERJ2GEJ 103 X (10K) B 496131R34 7030004980 SRES ERJ2GEJ 101 X (100) B 49614R35 7030005040 SRES ERJ2GEJ 472 X (47K) B 518166R41 7030005530 SRES ERJ2GEJ 100 X (10) T 574177R42 7030005070 SRES ERJ2GEJ 683 X (68K) T 574193R43 7030004980 SRES ERJ2GEJ 101 X (100) B 545188R44 7030005090 SRES ERJ2GEJ 104 X (100K) B 599189R45 7030004980 SRES ERJ2GEJ 101 X (100) T 632179R46 7030005090 SRES ERJ2GEJ 104 X (100K) T 628193R51 7030005010 SRES ERJ2GEJ 681 X (680) B 528252R52 7030008370 SRES ERJ2GEJ 561 X (560) B 615223R53 7030006020 SRES RR0510P-682-D (68K) T 583238R54 7030006020 SRES RR0510P-682-D (68K) T 581254R55 7030006020 SRES RR0510P-682-D (68K) T 595238R56 7030006020 SRES RR0510P-682-D (68K) T 603251R57 7030009320 SRES ERJ2GEJ 4R7 X (47) T 619242R63 7030005220 SRES ERJ2GEJ 223 X (22K) B 626277R64 7030005530 SRES ERJ2GEJ 100 X (10) T 642264R65 7030005600 SRES ERJ2GEJ 273 X (27K) B 644261R66 7030005100 SRES ERJ2GEJ 154 X (150K) B 654261R67 7030007290 SRES ERJ2GEJ 222 X (22K) B 609164R68 7030005170 SRES ERJ2GEJ 474 X (470K) B 626299R70 7030005310 SRES ERJ2GEJ 124 X (120K) B 626318R71 7030005050 SRES ERJ2GEJ 103 X (10K) B 503295R72 7030004980 SRES ERJ2GEJ 101 X (100) B 499279R73 7030005040 SRES ERJ2GEJ 472 X (47K) B 556305R76 7030005120 SRES ERJ2GEJ 102 X (1K) T 491255R77 7030008410 SRES ERJ2GEJ 392 X (39K) T 467255R78 7030005120 SRES ERJ2GEJ 102 X (1K) T 467243R80 7410001130 SARR EXB28V102JX T 444299R81 7030005100 SRES ERJ2GEJ 154 X (150K) B 62353R82 7030005050 SRES ERJ2GEJ 103 X (10K) T 401194R83 7030005580 SRES ERJ2GEJ 560 X (56) T 467209R87 7030005090 SRES ERJ2GEJ 104 X (100K) T 635277R88 7510001730 STHE ERTJOEP 473J T 566133R89 7030010080 SRES ERJ2RHD 104 X (100K) T 583133R101 7030005110 SRES ERJ2GEJ 224 X (220K) B 281321R102 7030005170 SRES ERJ2GEJ 474 X (470K) B 258333R103 7030008400 SRES ERJ2GEJ 182 X (18K) B 281309R104 7030005050 SRES ERJ2GEJ 103 X (10K) B 181218R105 7030005050 SRES ERJ2GEJ 103 X (10K) B 203272R106 7030005240 SRES ERJ2GEJ 473 X (47K) B 18329R107 7030005050 SRES ERJ2GEJ 103 X (10K) B 20231

6 - 2

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R108 7030005080 SRES ERJ2GEJ 823 X (82K) B 19229R109 7030005530 SRES ERJ2GEJ 100 X (10) B 21231R110 7030004980 SRES ERJ2GEJ 101 X (100) B 221254R112 7030004970 SRES ERJ2GEJ 470 X (47) B 258254R113 7030007300 SRES ERJ2GEJ 332 X (33K) B 242285R114 7030005090 SRES ERJ2GEJ 104 X (100K) B 274268R115 7030005090 SRES ERJ2GEJ 104 X (100K) B 31268R116 7030005310 SRES ERJ2GEJ 124 X (120K) B 354293R117 7030005090 SRES ERJ2GEJ 104 X (100K) B 334251R118 7030005310 SRES ERJ2GEJ 124 X (120K) B 364251R119 7030005100 SRES ERJ2GEJ 154 X (150K) B 364293R120 7030005710 SRES ERJ2GEJ 121 X (120) B 394251R121 7030007300 SRES ERJ2GEJ 332 X (33K) B 412277R122 7030004970 SRES ERJ2GEJ 470 X (47) B 433251R123 7030005530 SRES ERJ2GEJ 100 X (10) B 392298R125 7030008370 SRES ERJ2GEJ 561 X (560) B 356408R126 7030007290 SRES ERJ2GEJ 222 X (22K) B 39408R127 7030005090 SRES ERJ2GEJ 104 X (100K) B 373408R128 7030005010 SRES ERJ2GEJ 681 X (680) B 391444R132 7030005050 SRES ERJ2GEJ 103 X (10K) B 474176R134 7030005090 SRES ERJ2GEJ 104 X (100K) B 404403R135 7030007290 SRES ERJ2GEJ 222 X (22K) T 43367R136 7030007290 SRES ERJ2GEJ 222 X (22K) T 43376R137 7030008410 SRES ERJ2GEJ 392 X (39K) T 457351R138 7030005000 SRES ERJ2GEJ 471 X (470) B 43355R139 7030005090 SRES ERJ2GEJ 104 X (100K) B 483355R140 7030008410 SRES ERJ2GEJ 392 X (39K) B 465346R141 7030005240 SRES ERJ2GEJ 473 X (47K) B 465337R142 7030005090 SRES ERJ2GEJ 104 X (100K) B 465319R143 7030005040 SRES ERJ2GEJ 472 X (47K) B 483328R146 7030004970 SRES ERJ2GEJ 470 X (47) B 45644R147 7030005030 SRES ERJ2GEJ 152 X (15K) B 471422R148 7030005120 SRES ERJ2GEJ 102 X (1K) T 378314R149 7030007060 SRES ERJ2GEJ 684X (680K) T 378296R151 7030005600 SRES ERJ2GEJ 273 X (27K) B 51739R152 7030005210 SRES ERJ2GEJ 822 X (82K) B 539351R153 7030007300 SRES ERJ2GEJ 332 X (33K) B 555385R154 7030005210 SRES ERJ2GEJ 822 X (82K) B 575369R155 7030005600 SRES ERJ2GEJ 273 X (27K) B 588398R156 7030005120 SRES ERJ2GEJ 102 X (1K) B 203218R157 7030005120 SRES ERJ2GEJ 102 X (1K) B 31251R158 7030005120 SRES ERJ2GEJ 102 X (1K) B 594357R159 7030005290 SRES ERJ2GEJ 682 X (68K) B 297238R301 7030007340 SRES ERJ2GEJ 153 X (15K) B 684124R302 7030008010 SRES ERJ2GEJ 123 X (12K) B 666124R303 7030005720 SRES ERJ2GEJ 563 X (56K) B 675124R304 7030005030 SRES ERJ2GEJ 152 X (15K) B 693107R310 7030005220 SRES ERJ2GEJ 223 X (22K) T 662367R311 7030005220 SRES ERJ2GEJ 223 X (22K) T 646379R312 7030005220 SRES ERJ2GEJ 223 X (22K) T 646396R313 7030007300 SRES ERJ2GEJ 332 X (33K) T 626396R314 7030006610 SRES ERJ2GEJ 394 X (390K) T 637412R315 7030005080 SRES ERJ2GEJ 823 X (82K) T 637428R316 7030005000 SRES ERJ2GEJ 471 X (470) T 673428R317 7030005290 SRES ERJ2GEJ 682 X (68K) T 664396R318 7030005050 SRES ERJ2GEJ 103 X (10K) T 673396R321 7030007340 SRES ERJ2GEJ 153 X (15K) T 737277R322 7030008300 SRES ERJ2GEJ 184 X (180K) B 69133R323 7030005720 SRES ERJ2GEJ 563 X (56K) B 7033R324 7030005220 SRES ERJ2GEJ 223 X (22K) B 70933R325 7030005290 SRES ERJ2GEJ 682 X (68K) T 728295R326 7030005240 SRES ERJ2GEJ 473 X (47K) T 737295R327 7030005240 SRES ERJ2GEJ 473 X (47K) T 755295R328 7030005240 SRES ERJ2GEJ 473 X (47K) T 755277R329 7030005040 SRES ERJ2GEJ 472 X (47K) T 779295R330 7030005090 SRES ERJ2GEJ 104 X (100K) T 745329R331 7030005240 SRES ERJ2GEJ 473 X (47K) T 774316R341 7030005070 SRES ERJ2GEJ 683 X (68K) T 848311R342 7030005070 SRES ERJ2GEJ 683 X (68K) T 848294R343 7030005070 SRES ERJ2GEJ 683 X (68K) T 848277R344 7030005070 SRES ERJ2GEJ 683 X (68K) T 866277R345 7030005070 SRES ERJ2GEJ 683 X (68K) T 85726R346 7030005240 SRES ERJ2GEJ 473 X (47K) T 857243R347 7030005050 SRES ERJ2GEJ 103 X (10K) B 813154R348 7030005090 SRES ERJ2GEJ 104 X (100K) T 823346R349 7030005160 SRES ERJ2GEJ 105 X (1M) T 832346R350 7030005050 SRES ERJ2GEJ 103 X (10K) T 866243R351 7030008290 SRES ERJ2GEJ 183 X (18K) T 755243R352 7030005050 SRES ERJ2GEJ 103 X (10K) T 71812R353 7030005210 SRES ERJ2GEJ 822 X (82K) T 727102R354 7030005160 SRES ERJ2GEJ 105 X (1M) T 754102R355 7030005050 SRES ERJ2GEJ 103 X (10K) T 737243R359 7030005210 SRES ERJ2GEJ 822 X (82K) B 561105R360 7030007290 SRES ERJ2GEJ 222 X (22K) B 56196R361 7030005000 SRES ERJ2GEJ 471 X (470) B 251439R362 7030005060 SRES ERJ2GEJ 333 X (33K) B 51675R363 7030005000 SRES ERJ2GEJ 471 X (470) B 57887R364 7030005090 SRES ERJ2GEJ 104 X (100K) T 59555R366 7030005100 SRES ERJ2GEJ 154 X (150K) B 57896R368 7030005700 SRES ERJ2GEJ 274 X (270K) T 61787R369 7030005100 SRES ERJ2GEJ 154 X (150K) T 617104R370 7030005170 SRES ERJ2GEJ 474 X (470K) B 61711R371 7030005290 SRES ERJ2GEJ 682 X (68K) T 74584R372 7030009290 SRES ERJ2GEJ 562 X (56K) T 80284R373 7030005080 SRES ERJ2GEJ 823 X (82K) T 847102R374 7030008410 SRES ERJ2GEJ 392 X (39K) T 865102R375 7030005000 SRES ERJ2GEJ 471 X (470) T 85612R377 7030005060 SRES ERJ2GEJ 333 X (33K) T 847138R378 7030005050 SRES ERJ2GEJ 103 X (10K) T 865156R379 7030005700 SRES ERJ2GEJ 274 X (270K) T 847156R381 7030005700 SRES ERJ2GEJ 274 X (270K) T 709156R382 7030005170 SRES ERJ2GEJ 474 X (470K) T 718138R383 7030008310 SRES ERJ2GEJ 564 X (560K) T 709138R384 7030005090 SRES ERJ2GEJ 104 X (100K) T 809154R385 7030005310 SRES ERJ2GEJ 124 X (120K) T 745138

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R386 7030005060 SRES ERJ2GEJ 333 X (33K) T 736138R387 7030005030 SRES ERJ2GEJ 152 X (15K) T 736156R388 7030008010 SRES ERJ2GEJ 123 X (12K) B 788137R389 7030005800 SRES RR0510P-102-D (1K) B 779137R390 7030005810 SRES RR0510P-152-D (15K) B 772155R391 7030007290 SRES ERJ2GEJ 222 X (22K) T 745156R393 7030005700 SRES ERJ2GEJ 274 X (270K) B 61778R394 7030005090 SRES ERJ2GEJ 104 X (100K) B 60862R395 7030005310 SRES ERJ2GEJ 124 X (120K) B 60878R396 7030005700 SRES ERJ2GEJ 274 X (270K) B 61762R397 7030008300 SRES ERJ2GEJ 184 X (180K) B 60846R398 7030005050 SRES ERJ2GEJ 103 X (10K) B 61794R401 7030005120 SRES ERJ2GEJ 102 X (1K) T 662358R402 7030005000 SRES ERJ2GEJ 471 X (470) B 685225R403 7030010040 SRES ERJ2GEJ-JPW B 675287R406 7030005090 SRES ERJ2GEJ 104 X (100K) B 127456R408 7030004980 SRES ERJ2GEJ 101 X (100) B 356463R412 7030005040 SRES ERJ2GEJ 472 X (47K) B 168383R413 7030005090 SRES ERJ2GEJ 104 X (100K) T 198322R414 7030005230 SRES ERJ2GEJ 334 X (330K) B 215349R416 7030005120 SRES ERJ2GEJ 102 X (1K) B 215358R417 7030007340 SRES ERJ2GEJ 153 X (15K) B 213371R418 7030005120 SRES ERJ2GEJ 102 X (1K) B 198379R420 7030005090 SRES ERJ2GEJ 104 X (100K) T 796323R421 7210003061 VAR TP76N00N-15F-A103-2251A R423 7030005090 SRES ERJ2GEJ 104 X (100K) T 69378R424 7030005090 SRES ERJ2GEJ 104 X (100K) T 52387R426 7030007340 SRES ERJ2GEJ 153 X (15K) B 69363R427 7030005230 SRES ERJ2GEJ 334 X (330K) B 68446R428 7030005030 SRES ERJ2GEJ 152 X (15K) B 65131R429 7030006610 SRES ERJ2GEJ 394 X (390K) B 66831R430 7030005160 SRES ERJ2GEJ 105 X (1M) B 71731R431 7030005050 SRES ERJ2GEJ 103 X (10K) B 666348R432 7030005040 SRES ERJ2GEJ 472 X (47K) B 705309R433 7030005050 SRES ERJ2GEJ 103 X (10K) B 675303R434 7030005050 SRES ERJ2GEJ 103 X (10K) B 70530R435 7030005050 SRES ERJ2GEJ 103 X (10K) B 768245R436 7030005040 SRES ERJ2GEJ 472 X (47K) B 75430R437 7030005050 SRES ERJ2GEJ 103 X (10K) B 84347R438 7030007290 SRES ERJ2GEJ 222 X (22K) T 48333R439 7030007290 SRES ERJ2GEJ 222 X (22K) T 83284R440 7030009280 SRES ERJ2GEJ 391 X B 175436R441 7030005050 SRES ERJ2GEJ 103 X (10K) B 208436R442 7030007280 SRES ERJ2GEJ 331 X (330) B 202337R451 7030005530 SRES ERJ2GEJ 100 X (10) B 852373R453 7030008010 SRES ERJ2GEJ 123 X (12K) B 879352R454 7030005220 SRES ERJ2GEJ 223 X (22K) B 87322R455 7030008010 SRES ERJ2GEJ 123 X (12K) B 861352R456 7030005050 SRES ERJ2GEJ 103 X (10K) B 876427R457 7030005040 SRES ERJ2GEJ 472 X (47K) T 80735R458 7030005120 SRES ERJ2GEJ 102 X (1K) B 81330R459 7030005120 SRES ERJ2GEJ 102 X (1K) B 80430R460 7410001140 SARR EXB28V104JX B 77730R461 7030005040 SRES ERJ2GEJ 472 X (47K) B 84308R462 7030005040 SRES ERJ2GEJ 472 X (47K) B 84299R463 7030005050 SRES ERJ2GEJ 103 X (10K) T 718377R464 7030005090 SRES ERJ2GEJ 104 X (100K) T 734348R466 7410001140 SARR EXB28V104JX B 69540R467 7410001140 SARR EXB28V104JX B 69537R468 7030008400 SRES ERJ2GEJ 182 X (18K) T 70416R469 7030009280 SRES ERJ2GEJ 391 X T 70395R470 7030005090 SRES ERJ2GEJ 104 X (100K) B 747461R471 7030007340 SRES ERJ2GEJ 153 X (15K) B 726454R472 7030005090 SRES ERJ2GEJ 104 X (100K) B 726472R473 7410001140 SARR EXB28V104JX B 777461R474 7030007340 SRES ERJ2GEJ 153 X (15K) B 726463R475 7030005090 SRES ERJ2GEJ 104 X (100K) B 79530R476 7030005120 SRES ERJ2GEJ 102 X (1K) B 759461R477 7030005120 SRES ERJ2GEJ 102 X (1K) B 852345 C1 4030011650 SCER C1005 CH 1H 1R5B-T B 8557C2 4030009720 SCER C1005 CH 1H 080C-T B 10657C3 4030011630 SCER C1005 CH 1H 0R5B-T B 1258C4 4030011650 SCER C1005 CH 1H 1R5B-T B 91105C5 4030009720 SCER C1005 CH 1H 080C-T B 107149C6 4030011630 SCER C1005 CH 1H 0R5B-T B 12510C7 4030019740 SCER C1005 JB 1H 102K-T B 14966C8 4030011670 SCER C1005 CH 1H 2R5B-T B 124149C9 4030011700 SCER C1005 CH 1H 040B-T B 124158C10 4030019740 SCER C1005 JB 1H 102K-T B 148134C11 4030019740 SCER C1005 JB 1H 102K-T B 165134C12 4030009720 SCER C1005 CH 1H 080C-T B 177118C13 4030009760 SCER C1005 CH 1H 150J-T B 197118C14 4030007050 SCER C1608 CH 1H 220J-T B 214103C18 4030019740 SCER C1005 JB 1H 102K-T B 198191C19 4030019740 SCER C1005 JB 1H 102K-T B 182192C20 4030019740 SCER C1005 JB 1H 102K-T T 335113C21 4030019740 SCER C1005 JB 1H 102K-T T 30859C22 4030019740 SCER C1005 JB 1H 102K-T T 39259C23 4030019930 SCER C1005 JB 1A 104K-T T 317113C24 4030019950 SCER C1005 JB 0J 224K-T T 35759C25 4030019810 SCER C1005 JB 1E 103K-T T 357113C26 4030019740 SCER C1005 JB 1H 102K-T T 36696C27 4030019740 SCER C1005 JB 1H 102K-T T 36676C28 4030019970 SCER C1005 JB 0J 105K-T T 37576C29 4030019740 SCER C1005 JB 1H 102K-T B 37391C36 4030011320 SCER C1005 CH 1H 470J-T B 238161C37 4030014260 SCER C1005 JB 1H 331K-T B 247161C38 4030019740 SCER C1005 JB 1H 102K-T B 327151C39 4030011320 SCER C1005 CH 1H 470J-T B 327141C45 4030011320 SCER C1005 CH 1H 470J-T B 327121C47 4030014260 SCER C1005 JB 1H 331K-T B 33291C51 4030011700 SCER C1005 CH 1H 040B-T B 391142C52 4030019740 SCER C1005 JB 1H 102K-T B 4189

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

5 - 5

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

PLL LOCK VOLTAGE-Adjustment-

1ndash

bull Connect an RF power meter to the antenna connector ndash ndash

(RX) 2 bull CH 1bull Receiving

bull Select the item [RX LVA] then push [ENTER] [RX LVA]

10 V

(TX) 3 bull CH 1bull Transmitting

bull Select the item [TX LVA] then push [ENTER] [TX LVA]

10 V

PLL LOCK VOLTAGE-Verify-(RX)

1 bull CH 2bull Receiving

bull Click the [Reload (F5)] button to check on the IO Check window as illustrated below [LVIN]

(On the IO Check window)

30ndash40 V(Verify)

(TX) 2 bull CH 2bull Transmitting

27ndash39 V(Verify)

REFERENCEFREQUENCY

1 bull CH 3bull Transmitting

bull Loosely couple a frequency counter to the antenna connector [REF]

4700000 MHz(plusmn300 Hz)

5-2 FREQUENCY ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

bull IO Check window

(The values shown above are example only Each transceiver has own values)

Lock voltage

5 - 6

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

TX OUTPUT POWER(Hi power)

1 bull CH 4bull Transmitting

bull Connect an RF power meter to the antenna connector [Power (Hi)] 40 W

(L2 power) 2 bull CH 5bull Transmitting

[Power (L2)] 20 W

(L1 power) 3 bull CH 6bull Transmitting

[Power (L1)] 10 W

MODULATION BALANCE

1 bull CH 7bull Transmitting

bull Connect a modulation analyzer with an oscilloscope to the antenna connector through an attenuator

[BAL]

Square waveform

FM DEVIATION( Narrow mode)

1 bull CH 8bull Transmitting

bull Connect a modulation analyzer to the antenna connector through an attenuator

[MOD N C]plusmn205 to plusmn215

kHz

( Middle mode) 2 bull CH 9bull Transmitting

[MOD M C]plusmn325 to plusmn335

kHz

( Wide mode) 3 bull CH 9bull Transmitting

[MOD W C]plusmn405 to plusmn415

kHz

CTCSSDTCS DEVIATION

1 bull CH 10bull Transmitting

bull Connect a modulation analyzer to the antenna connector through an attenuator [CTCSSDTCS]

plusmn065 to plusmn075 kHz

[EUR] versions only

5-3 TRANSMIT ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

5 - 7

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

RX SENSITIVITY 1 bull CH 11bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 435 MHz Level 20 dBmicro (ndash87 dBm) Modulation 1 kHz Deviation plusmn3 kHz2) Put the cursor on the adjustment item

then push [ENTER]

[BPF ALL]

(Automatic adjustment)

SQUELCH 1 bull CH 12bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 400 MHz Level ndash13 dBmicro (ndash120 dBm) Modulation 1 kHz Deviation plusmn15 kHz2) Once close the squelch by increasing

[SQL] value then decrease the value to open the squelch

3) Push [ENTER] key to store the value

[SQL]

(Automatic adjustment)

The output level of the standard signal generator (SSG) is indicated as the SSGrsquos open circuit

5-4 RECEIVE ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

6 - 1

SECTION 6 PARTS LIST

IC1 1110002751 SIC TA75S01F(TE85RF) T 32588IC2 1140005991 SIC MB15A02PFV1-G-BND-ERE1 T 429247IC3 1110007320 SIC NJM2591V-TE1-ZZZB B 458389IC51 1140015230 SIC R4F20102NFA (EMPTY) B 77738IC52 1130015240 SIC R1EX24016ATA00A B 85252IC53 1110007620 SIC NJU7704F3-42A-TE1-ZZZB B 876446IC54 1180003600 SREG NJM2871BF05-TE1-ZZZB T 156348IC55 1110007610 SIC TPA0211DGNR B 138421IC56 1130011770 SIC CD4066BPWR T 801188IC57 1110007550 SIC R2A20178NP B 725245IC58 1110005340 SIC NJM12902V-TE1-ZZZB T 80112IC59 1110006350 SIC LM2902PWR T 801259IC60 1110005340 SIC NJM12902V-TE1-ZZZB B 65175IC61 1140013200 SIC CD4053BPWR T 801383IC62 1130011770 SIC CD4066BPWR T 66781 Q1 1560001700 SFET RD07MUS2B-T112 B 286135Q2 1560001241 SFET RD01MUS1-T113 B 361144Q3 1530000371 STRA 2SC3356-T1B S (R25) B 413129Q4 1530003311 STRA 2SC5107-O(TE85RF) B 462134Q6 1590004050 STRA LDTA144EET1G ltSLVJgt T 33359Q8 1530003311 STRA 2SC5107-O(TE85RF) T 556186Q9 1530003311 STRA 2SC5107-O(TE85RF) B 581194Q10 1530003311 STRA 2SC5107-O(TE85RF) T 61191Q11 1590004070 STRA LDTC144EET1G ltSLVJgt B 508252Q12 1590004070 STRA LDTC144EET1G ltSLVJgt B 63236Q13 1530002920 STRA 2SC4226-T1 R25 T 565226Q14 1530002920 STRA 2SC4226-T1 R25 T 622223Q15 1530002851 STRA 2SC4116-BL(TE85RF) B 627162Q17 1560000541 SFET 2SK880-Y(T5RICOMF) B 526295Q19 1590004070 STRA LDTC144EET1G ltSLVJgt B 635336Q21 1560000841 SFET 2SK1829(TE85RF) B 257315Q22 1580000731 SFET 3SK293(TE85LF) B 21229Q23 1580000731 SFET 3SK293(TE85LF) B 364273Q24 1530002601 STRA 2SC4215-O(TE85RF) B 383426Q25 1590004070 STRA LDTC144EET1G ltSLVJgt T 493351Q26 1530002851 STRA 2SC4116-BL(TE85RF) T 396301Q27 1590004050 STRA LDTA144EET1G ltSLVJgt B 56364Q51 1590001650 STRA XP4601(TX) T 65542Q52 1590004070 STRA LDTC144EET1G ltSLVJgt T 754314Q58 1590003431 STRA UNR911HG0L B 54971Q59 1590004070 STRA LDTC144EET1G ltSLVJgt B 49173Q63 1520000460 STRA 2SB1132 T100 R B 151355Q64 1590001190 STRA XP6501-(TX)AB B 19336Q71 1510001090 STRA KTA2015Y-RTKP B 651366Q72 1510000771 STRA 2SA1586-GR(TE85LF) B 657303Q73 1510001090 STRA KTA2015Y-RTKP B 786238Q74 1520000460 STRA 2SB1132 T100 R B 53344Q75 1590001190 STRA XP6501-(TX)AB T 45352Q76 1590004070 STRA LDTC144EET1G ltSLVJgt T 68352Q81 1590003271 STRA UNR9210G0L B 705458Q82 1590004050 STRA LDTA144EET1G ltSLVJgt T 716395Q83 1590004050 STRA LDTA144EET1G ltSLVJgt T 716416Q84 1590004070 STRA LDTC144EET1G ltSLVJgt B 192441Q85 1590004070 STRA LDTC144EET1G ltSLVJgt B 224441 D1 1750001800 SDIO RB886CS T2RA B 13866D2 1750001800 SDIO RB886CS T2RA B 138105D3 1750001890 SDIO HVD142AKRF-E B 157148D5 1750001890 SDIO HVD142AKRF-E B 496152D6 1750001890 SDIO HVD142AKRF-E B 496166D11 1750001550 SVAR HVD376BKRF-E T 568264D12 1750001840 SVAR HVD350BKRF-E T 54287D14 1750001550 SVAR HVD376BKRF-E T 604261D15 1750001650 SVAR 1SV309(TPH3F) T 646282D16 1750001840 SVAR HVD350BKRF-E T 625282D18 1750001810 SDIO L1SS400T1G ltSLVJgt T 463326D21 1750001810 SDIO L1SS400T1G ltSLVJgt B 281333D22 1750001890 SDIO HVD142AKRF-E B 157183D24 1750001780 SVAR HVB350BYPTL-E B 181238D26 1750001780 SVAR HVB350BYPTL-E B 181267D28 1750001780 SVAR HVB350BYPTL-E B 292267D31 1750001790 SDIO 1SS390 TE61 B 541398D32 1750001790 SDIO 1SS390 TE61 B 517368D33 1750001790 SDIO 1SS390 TE61 B 567398D34 1750001790 SDIO 1SS390 TE61 B 581385D35 1750001810 SDIO L1SS400T1G ltSLVJgt T 37563D51 1750001820 SDIO LRB706F-40T1G ltSLVJgt B 679458D52 1750001790 SDIO 1SS390 TE61 B 87337D53 1750001810 SDIO L1SS400T1G ltSLVJgt B 69131D55 1750001810 SDIO L1SS400T1G ltSLVJgt B 219338 FI1 2030000870 SMON MFT463P3 46350 MHz (FL-442) B 362346FI2 2020002460 CER LTM450GW ltJJEgt FI3 2020002570 CER LTM450HW ltJJEgt X1 6070000310 SDIS JTBM450CX70 ltJJEgt T 476409X2 6050012050 SXTA CR-794 TTS14VSB-A6 153 MHz T 41915X51 6050012730 SXTA CR-864 (SMD-4912288 MHz) ltJJEgt T 869385 L1 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 9575L2 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 106105

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

L3 6200013010 SCOI 030-09-5TL 103N ltCOMOgt B 127134L4 6200002851 SCOI NLV25T-R82J B 182166L5 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 182134L6 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 207134L7 6200012980 SCOI 040-14-5TR 183N ltCOMOgt B 236134L8 6200013860 SCOI MLK1005S12NJT B 41107L9 6200013840 SCOI MLK1005S18NJT B 455107L11 6200010850 SCOI LQW18AN22NG00D (LQW1608A22NG00) B 139166L13 6200007700 SCOI LQW2BHN22NJ03L B 151224L14 6200007700 SCOI LQW2BHN22NJ03L B 152281L15 6200007680 SCOI LQW2BHN12NJ03L B 258276L16 6200007680 SCOI LQW2BHN12NJ03L B 327276L18 6200013800 SCOI MLK1005S39NJT B 364235L19 6200013780 SCOI MLK1005S56NJT B 344251L20 6200004770 SCOI ELJNC R56J-F B 394277L23 6200012170 SCOI MLG1608SR18J-T T 394346L24 6200012170 SCOI MLG1608SR18J-T T 415318L31 6200013810 SCOI MLK1005S33NJT T 538177L32 6200013810 SCOI MLK1005S33NJT B 563204L33 6200013830 SCOI MLK1005S22NJT T 592183L35 6190002030 SCOI MLG1608S 1R0J-T B 591266L36 6200013580 SCOI 030-09-4TR 5PER ltCOMOgt T 543261L37 6190002030 SCOI MLG1608S 1R0J-T T 565287L40 6200013630 SCOI 030-09-3TR 58N 5PER ltCOMOgt T 638249L41 6200011860 SCOI LQW18ANR47G00D T 589274L42 6190002030 SCOI MLG1608S 1R0J-T T 605288L47 6200013840 SCOI MLK1005S18NJT B 513204L48 6200013990 SCOI MLK1005S1N0ST B 327131 R1 7030005070 SRES ERJ2GEJ 683 X (68K) B 7255R2 7030009140 SRES ERJ2GEJ 272 X (27K) B 12589R3 7030005120 SRES ERJ2GEJ 102 X (1K) B 1418R4 7030005120 SRES ERJ2GEJ 102 X (1K) B 14189R5 7030009140 SRES ERJ2GEJ 272 X (27K) B 125109R6 7030004990 SRES ERJ2GEJ 221 X (220) B 203179R11 7030009140 SRES ERJ2GEJ 272 X (27K) T 29959R12 7030005050 SRES ERJ2GEJ 103 X (10K) T 31759R13 7030005090 SRES ERJ2GEJ 104 X (100K) T 326113R14 7030005310 SRES ERJ2GEJ 124 X (120K) T 308113R15 7030005170 SRES ERJ2GEJ 474 X (470K) T 34859R16 7030005530 SRES ERJ2GEJ 100 X (10) T 35796R17 7030008280 SRES ERJ2GEJ 271 X (270) T 34876R18 7030005120 SRES ERJ2GEJ 102 X (1K) T 35776R21 7030005530 SRES ERJ2GEJ 100 X (10) B 332108R22 7030005040 SRES ERJ2GEJ 472 X (47K) B 34191R23 7030005060 SRES ERJ2GEJ 333 X (33K) B 32391R26 7030004970 SRES ERJ2GEJ 470 X (47) B 382108R27 7030005040 SRES ERJ2GEJ 472 X (47K) B 38291R29 7030004970 SRES ERJ2GEJ 470 X (47) B 4198R30 7030005220 SRES ERJ2GEJ 223 X (22K) B 418151R31 7030004980 SRES ERJ2GEJ 101 X (100) B 45598R32 7030005220 SRES ERJ2GEJ 223 X (22K) B 457152R33 7030005050 SRES ERJ2GEJ 103 X (10K) B 496131R34 7030004980 SRES ERJ2GEJ 101 X (100) B 49614R35 7030005040 SRES ERJ2GEJ 472 X (47K) B 518166R41 7030005530 SRES ERJ2GEJ 100 X (10) T 574177R42 7030005070 SRES ERJ2GEJ 683 X (68K) T 574193R43 7030004980 SRES ERJ2GEJ 101 X (100) B 545188R44 7030005090 SRES ERJ2GEJ 104 X (100K) B 599189R45 7030004980 SRES ERJ2GEJ 101 X (100) T 632179R46 7030005090 SRES ERJ2GEJ 104 X (100K) T 628193R51 7030005010 SRES ERJ2GEJ 681 X (680) B 528252R52 7030008370 SRES ERJ2GEJ 561 X (560) B 615223R53 7030006020 SRES RR0510P-682-D (68K) T 583238R54 7030006020 SRES RR0510P-682-D (68K) T 581254R55 7030006020 SRES RR0510P-682-D (68K) T 595238R56 7030006020 SRES RR0510P-682-D (68K) T 603251R57 7030009320 SRES ERJ2GEJ 4R7 X (47) T 619242R63 7030005220 SRES ERJ2GEJ 223 X (22K) B 626277R64 7030005530 SRES ERJ2GEJ 100 X (10) T 642264R65 7030005600 SRES ERJ2GEJ 273 X (27K) B 644261R66 7030005100 SRES ERJ2GEJ 154 X (150K) B 654261R67 7030007290 SRES ERJ2GEJ 222 X (22K) B 609164R68 7030005170 SRES ERJ2GEJ 474 X (470K) B 626299R70 7030005310 SRES ERJ2GEJ 124 X (120K) B 626318R71 7030005050 SRES ERJ2GEJ 103 X (10K) B 503295R72 7030004980 SRES ERJ2GEJ 101 X (100) B 499279R73 7030005040 SRES ERJ2GEJ 472 X (47K) B 556305R76 7030005120 SRES ERJ2GEJ 102 X (1K) T 491255R77 7030008410 SRES ERJ2GEJ 392 X (39K) T 467255R78 7030005120 SRES ERJ2GEJ 102 X (1K) T 467243R80 7410001130 SARR EXB28V102JX T 444299R81 7030005100 SRES ERJ2GEJ 154 X (150K) B 62353R82 7030005050 SRES ERJ2GEJ 103 X (10K) T 401194R83 7030005580 SRES ERJ2GEJ 560 X (56) T 467209R87 7030005090 SRES ERJ2GEJ 104 X (100K) T 635277R88 7510001730 STHE ERTJOEP 473J T 566133R89 7030010080 SRES ERJ2RHD 104 X (100K) T 583133R101 7030005110 SRES ERJ2GEJ 224 X (220K) B 281321R102 7030005170 SRES ERJ2GEJ 474 X (470K) B 258333R103 7030008400 SRES ERJ2GEJ 182 X (18K) B 281309R104 7030005050 SRES ERJ2GEJ 103 X (10K) B 181218R105 7030005050 SRES ERJ2GEJ 103 X (10K) B 203272R106 7030005240 SRES ERJ2GEJ 473 X (47K) B 18329R107 7030005050 SRES ERJ2GEJ 103 X (10K) B 20231

6 - 2

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R108 7030005080 SRES ERJ2GEJ 823 X (82K) B 19229R109 7030005530 SRES ERJ2GEJ 100 X (10) B 21231R110 7030004980 SRES ERJ2GEJ 101 X (100) B 221254R112 7030004970 SRES ERJ2GEJ 470 X (47) B 258254R113 7030007300 SRES ERJ2GEJ 332 X (33K) B 242285R114 7030005090 SRES ERJ2GEJ 104 X (100K) B 274268R115 7030005090 SRES ERJ2GEJ 104 X (100K) B 31268R116 7030005310 SRES ERJ2GEJ 124 X (120K) B 354293R117 7030005090 SRES ERJ2GEJ 104 X (100K) B 334251R118 7030005310 SRES ERJ2GEJ 124 X (120K) B 364251R119 7030005100 SRES ERJ2GEJ 154 X (150K) B 364293R120 7030005710 SRES ERJ2GEJ 121 X (120) B 394251R121 7030007300 SRES ERJ2GEJ 332 X (33K) B 412277R122 7030004970 SRES ERJ2GEJ 470 X (47) B 433251R123 7030005530 SRES ERJ2GEJ 100 X (10) B 392298R125 7030008370 SRES ERJ2GEJ 561 X (560) B 356408R126 7030007290 SRES ERJ2GEJ 222 X (22K) B 39408R127 7030005090 SRES ERJ2GEJ 104 X (100K) B 373408R128 7030005010 SRES ERJ2GEJ 681 X (680) B 391444R132 7030005050 SRES ERJ2GEJ 103 X (10K) B 474176R134 7030005090 SRES ERJ2GEJ 104 X (100K) B 404403R135 7030007290 SRES ERJ2GEJ 222 X (22K) T 43367R136 7030007290 SRES ERJ2GEJ 222 X (22K) T 43376R137 7030008410 SRES ERJ2GEJ 392 X (39K) T 457351R138 7030005000 SRES ERJ2GEJ 471 X (470) B 43355R139 7030005090 SRES ERJ2GEJ 104 X (100K) B 483355R140 7030008410 SRES ERJ2GEJ 392 X (39K) B 465346R141 7030005240 SRES ERJ2GEJ 473 X (47K) B 465337R142 7030005090 SRES ERJ2GEJ 104 X (100K) B 465319R143 7030005040 SRES ERJ2GEJ 472 X (47K) B 483328R146 7030004970 SRES ERJ2GEJ 470 X (47) B 45644R147 7030005030 SRES ERJ2GEJ 152 X (15K) B 471422R148 7030005120 SRES ERJ2GEJ 102 X (1K) T 378314R149 7030007060 SRES ERJ2GEJ 684X (680K) T 378296R151 7030005600 SRES ERJ2GEJ 273 X (27K) B 51739R152 7030005210 SRES ERJ2GEJ 822 X (82K) B 539351R153 7030007300 SRES ERJ2GEJ 332 X (33K) B 555385R154 7030005210 SRES ERJ2GEJ 822 X (82K) B 575369R155 7030005600 SRES ERJ2GEJ 273 X (27K) B 588398R156 7030005120 SRES ERJ2GEJ 102 X (1K) B 203218R157 7030005120 SRES ERJ2GEJ 102 X (1K) B 31251R158 7030005120 SRES ERJ2GEJ 102 X (1K) B 594357R159 7030005290 SRES ERJ2GEJ 682 X (68K) B 297238R301 7030007340 SRES ERJ2GEJ 153 X (15K) B 684124R302 7030008010 SRES ERJ2GEJ 123 X (12K) B 666124R303 7030005720 SRES ERJ2GEJ 563 X (56K) B 675124R304 7030005030 SRES ERJ2GEJ 152 X (15K) B 693107R310 7030005220 SRES ERJ2GEJ 223 X (22K) T 662367R311 7030005220 SRES ERJ2GEJ 223 X (22K) T 646379R312 7030005220 SRES ERJ2GEJ 223 X (22K) T 646396R313 7030007300 SRES ERJ2GEJ 332 X (33K) T 626396R314 7030006610 SRES ERJ2GEJ 394 X (390K) T 637412R315 7030005080 SRES ERJ2GEJ 823 X (82K) T 637428R316 7030005000 SRES ERJ2GEJ 471 X (470) T 673428R317 7030005290 SRES ERJ2GEJ 682 X (68K) T 664396R318 7030005050 SRES ERJ2GEJ 103 X (10K) T 673396R321 7030007340 SRES ERJ2GEJ 153 X (15K) T 737277R322 7030008300 SRES ERJ2GEJ 184 X (180K) B 69133R323 7030005720 SRES ERJ2GEJ 563 X (56K) B 7033R324 7030005220 SRES ERJ2GEJ 223 X (22K) B 70933R325 7030005290 SRES ERJ2GEJ 682 X (68K) T 728295R326 7030005240 SRES ERJ2GEJ 473 X (47K) T 737295R327 7030005240 SRES ERJ2GEJ 473 X (47K) T 755295R328 7030005240 SRES ERJ2GEJ 473 X (47K) T 755277R329 7030005040 SRES ERJ2GEJ 472 X (47K) T 779295R330 7030005090 SRES ERJ2GEJ 104 X (100K) T 745329R331 7030005240 SRES ERJ2GEJ 473 X (47K) T 774316R341 7030005070 SRES ERJ2GEJ 683 X (68K) T 848311R342 7030005070 SRES ERJ2GEJ 683 X (68K) T 848294R343 7030005070 SRES ERJ2GEJ 683 X (68K) T 848277R344 7030005070 SRES ERJ2GEJ 683 X (68K) T 866277R345 7030005070 SRES ERJ2GEJ 683 X (68K) T 85726R346 7030005240 SRES ERJ2GEJ 473 X (47K) T 857243R347 7030005050 SRES ERJ2GEJ 103 X (10K) B 813154R348 7030005090 SRES ERJ2GEJ 104 X (100K) T 823346R349 7030005160 SRES ERJ2GEJ 105 X (1M) T 832346R350 7030005050 SRES ERJ2GEJ 103 X (10K) T 866243R351 7030008290 SRES ERJ2GEJ 183 X (18K) T 755243R352 7030005050 SRES ERJ2GEJ 103 X (10K) T 71812R353 7030005210 SRES ERJ2GEJ 822 X (82K) T 727102R354 7030005160 SRES ERJ2GEJ 105 X (1M) T 754102R355 7030005050 SRES ERJ2GEJ 103 X (10K) T 737243R359 7030005210 SRES ERJ2GEJ 822 X (82K) B 561105R360 7030007290 SRES ERJ2GEJ 222 X (22K) B 56196R361 7030005000 SRES ERJ2GEJ 471 X (470) B 251439R362 7030005060 SRES ERJ2GEJ 333 X (33K) B 51675R363 7030005000 SRES ERJ2GEJ 471 X (470) B 57887R364 7030005090 SRES ERJ2GEJ 104 X (100K) T 59555R366 7030005100 SRES ERJ2GEJ 154 X (150K) B 57896R368 7030005700 SRES ERJ2GEJ 274 X (270K) T 61787R369 7030005100 SRES ERJ2GEJ 154 X (150K) T 617104R370 7030005170 SRES ERJ2GEJ 474 X (470K) B 61711R371 7030005290 SRES ERJ2GEJ 682 X (68K) T 74584R372 7030009290 SRES ERJ2GEJ 562 X (56K) T 80284R373 7030005080 SRES ERJ2GEJ 823 X (82K) T 847102R374 7030008410 SRES ERJ2GEJ 392 X (39K) T 865102R375 7030005000 SRES ERJ2GEJ 471 X (470) T 85612R377 7030005060 SRES ERJ2GEJ 333 X (33K) T 847138R378 7030005050 SRES ERJ2GEJ 103 X (10K) T 865156R379 7030005700 SRES ERJ2GEJ 274 X (270K) T 847156R381 7030005700 SRES ERJ2GEJ 274 X (270K) T 709156R382 7030005170 SRES ERJ2GEJ 474 X (470K) T 718138R383 7030008310 SRES ERJ2GEJ 564 X (560K) T 709138R384 7030005090 SRES ERJ2GEJ 104 X (100K) T 809154R385 7030005310 SRES ERJ2GEJ 124 X (120K) T 745138

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R386 7030005060 SRES ERJ2GEJ 333 X (33K) T 736138R387 7030005030 SRES ERJ2GEJ 152 X (15K) T 736156R388 7030008010 SRES ERJ2GEJ 123 X (12K) B 788137R389 7030005800 SRES RR0510P-102-D (1K) B 779137R390 7030005810 SRES RR0510P-152-D (15K) B 772155R391 7030007290 SRES ERJ2GEJ 222 X (22K) T 745156R393 7030005700 SRES ERJ2GEJ 274 X (270K) B 61778R394 7030005090 SRES ERJ2GEJ 104 X (100K) B 60862R395 7030005310 SRES ERJ2GEJ 124 X (120K) B 60878R396 7030005700 SRES ERJ2GEJ 274 X (270K) B 61762R397 7030008300 SRES ERJ2GEJ 184 X (180K) B 60846R398 7030005050 SRES ERJ2GEJ 103 X (10K) B 61794R401 7030005120 SRES ERJ2GEJ 102 X (1K) T 662358R402 7030005000 SRES ERJ2GEJ 471 X (470) B 685225R403 7030010040 SRES ERJ2GEJ-JPW B 675287R406 7030005090 SRES ERJ2GEJ 104 X (100K) B 127456R408 7030004980 SRES ERJ2GEJ 101 X (100) B 356463R412 7030005040 SRES ERJ2GEJ 472 X (47K) B 168383R413 7030005090 SRES ERJ2GEJ 104 X (100K) T 198322R414 7030005230 SRES ERJ2GEJ 334 X (330K) B 215349R416 7030005120 SRES ERJ2GEJ 102 X (1K) B 215358R417 7030007340 SRES ERJ2GEJ 153 X (15K) B 213371R418 7030005120 SRES ERJ2GEJ 102 X (1K) B 198379R420 7030005090 SRES ERJ2GEJ 104 X (100K) T 796323R421 7210003061 VAR TP76N00N-15F-A103-2251A R423 7030005090 SRES ERJ2GEJ 104 X (100K) T 69378R424 7030005090 SRES ERJ2GEJ 104 X (100K) T 52387R426 7030007340 SRES ERJ2GEJ 153 X (15K) B 69363R427 7030005230 SRES ERJ2GEJ 334 X (330K) B 68446R428 7030005030 SRES ERJ2GEJ 152 X (15K) B 65131R429 7030006610 SRES ERJ2GEJ 394 X (390K) B 66831R430 7030005160 SRES ERJ2GEJ 105 X (1M) B 71731R431 7030005050 SRES ERJ2GEJ 103 X (10K) B 666348R432 7030005040 SRES ERJ2GEJ 472 X (47K) B 705309R433 7030005050 SRES ERJ2GEJ 103 X (10K) B 675303R434 7030005050 SRES ERJ2GEJ 103 X (10K) B 70530R435 7030005050 SRES ERJ2GEJ 103 X (10K) B 768245R436 7030005040 SRES ERJ2GEJ 472 X (47K) B 75430R437 7030005050 SRES ERJ2GEJ 103 X (10K) B 84347R438 7030007290 SRES ERJ2GEJ 222 X (22K) T 48333R439 7030007290 SRES ERJ2GEJ 222 X (22K) T 83284R440 7030009280 SRES ERJ2GEJ 391 X B 175436R441 7030005050 SRES ERJ2GEJ 103 X (10K) B 208436R442 7030007280 SRES ERJ2GEJ 331 X (330) B 202337R451 7030005530 SRES ERJ2GEJ 100 X (10) B 852373R453 7030008010 SRES ERJ2GEJ 123 X (12K) B 879352R454 7030005220 SRES ERJ2GEJ 223 X (22K) B 87322R455 7030008010 SRES ERJ2GEJ 123 X (12K) B 861352R456 7030005050 SRES ERJ2GEJ 103 X (10K) B 876427R457 7030005040 SRES ERJ2GEJ 472 X (47K) T 80735R458 7030005120 SRES ERJ2GEJ 102 X (1K) B 81330R459 7030005120 SRES ERJ2GEJ 102 X (1K) B 80430R460 7410001140 SARR EXB28V104JX B 77730R461 7030005040 SRES ERJ2GEJ 472 X (47K) B 84308R462 7030005040 SRES ERJ2GEJ 472 X (47K) B 84299R463 7030005050 SRES ERJ2GEJ 103 X (10K) T 718377R464 7030005090 SRES ERJ2GEJ 104 X (100K) T 734348R466 7410001140 SARR EXB28V104JX B 69540R467 7410001140 SARR EXB28V104JX B 69537R468 7030008400 SRES ERJ2GEJ 182 X (18K) T 70416R469 7030009280 SRES ERJ2GEJ 391 X T 70395R470 7030005090 SRES ERJ2GEJ 104 X (100K) B 747461R471 7030007340 SRES ERJ2GEJ 153 X (15K) B 726454R472 7030005090 SRES ERJ2GEJ 104 X (100K) B 726472R473 7410001140 SARR EXB28V104JX B 777461R474 7030007340 SRES ERJ2GEJ 153 X (15K) B 726463R475 7030005090 SRES ERJ2GEJ 104 X (100K) B 79530R476 7030005120 SRES ERJ2GEJ 102 X (1K) B 759461R477 7030005120 SRES ERJ2GEJ 102 X (1K) B 852345 C1 4030011650 SCER C1005 CH 1H 1R5B-T B 8557C2 4030009720 SCER C1005 CH 1H 080C-T B 10657C3 4030011630 SCER C1005 CH 1H 0R5B-T B 1258C4 4030011650 SCER C1005 CH 1H 1R5B-T B 91105C5 4030009720 SCER C1005 CH 1H 080C-T B 107149C6 4030011630 SCER C1005 CH 1H 0R5B-T B 12510C7 4030019740 SCER C1005 JB 1H 102K-T B 14966C8 4030011670 SCER C1005 CH 1H 2R5B-T B 124149C9 4030011700 SCER C1005 CH 1H 040B-T B 124158C10 4030019740 SCER C1005 JB 1H 102K-T B 148134C11 4030019740 SCER C1005 JB 1H 102K-T B 165134C12 4030009720 SCER C1005 CH 1H 080C-T B 177118C13 4030009760 SCER C1005 CH 1H 150J-T B 197118C14 4030007050 SCER C1608 CH 1H 220J-T B 214103C18 4030019740 SCER C1005 JB 1H 102K-T B 198191C19 4030019740 SCER C1005 JB 1H 102K-T B 182192C20 4030019740 SCER C1005 JB 1H 102K-T T 335113C21 4030019740 SCER C1005 JB 1H 102K-T T 30859C22 4030019740 SCER C1005 JB 1H 102K-T T 39259C23 4030019930 SCER C1005 JB 1A 104K-T T 317113C24 4030019950 SCER C1005 JB 0J 224K-T T 35759C25 4030019810 SCER C1005 JB 1E 103K-T T 357113C26 4030019740 SCER C1005 JB 1H 102K-T T 36696C27 4030019740 SCER C1005 JB 1H 102K-T T 36676C28 4030019970 SCER C1005 JB 0J 105K-T T 37576C29 4030019740 SCER C1005 JB 1H 102K-T B 37391C36 4030011320 SCER C1005 CH 1H 470J-T B 238161C37 4030014260 SCER C1005 JB 1H 331K-T B 247161C38 4030019740 SCER C1005 JB 1H 102K-T B 327151C39 4030011320 SCER C1005 CH 1H 470J-T B 327141C45 4030011320 SCER C1005 CH 1H 470J-T B 327121C47 4030014260 SCER C1005 JB 1H 331K-T B 33291C51 4030011700 SCER C1005 CH 1H 040B-T B 391142C52 4030019740 SCER C1005 JB 1H 102K-T B 4189

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

5 - 6

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

TX OUTPUT POWER(Hi power)

1 bull CH 4bull Transmitting

bull Connect an RF power meter to the antenna connector [Power (Hi)] 40 W

(L2 power) 2 bull CH 5bull Transmitting

[Power (L2)] 20 W

(L1 power) 3 bull CH 6bull Transmitting

[Power (L1)] 10 W

MODULATION BALANCE

1 bull CH 7bull Transmitting

bull Connect a modulation analyzer with an oscilloscope to the antenna connector through an attenuator

[BAL]

Square waveform

FM DEVIATION( Narrow mode)

1 bull CH 8bull Transmitting

bull Connect a modulation analyzer to the antenna connector through an attenuator

[MOD N C]plusmn205 to plusmn215

kHz

( Middle mode) 2 bull CH 9bull Transmitting

[MOD M C]plusmn325 to plusmn335

kHz

( Wide mode) 3 bull CH 9bull Transmitting

[MOD W C]plusmn405 to plusmn415

kHz

CTCSSDTCS DEVIATION

1 bull CH 10bull Transmitting

bull Connect a modulation analyzer to the antenna connector through an attenuator [CTCSSDTCS]

plusmn065 to plusmn075 kHz

[EUR] versions only

5-3 TRANSMIT ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

5 - 7

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

RX SENSITIVITY 1 bull CH 11bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 435 MHz Level 20 dBmicro (ndash87 dBm) Modulation 1 kHz Deviation plusmn3 kHz2) Put the cursor on the adjustment item

then push [ENTER]

[BPF ALL]

(Automatic adjustment)

SQUELCH 1 bull CH 12bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 400 MHz Level ndash13 dBmicro (ndash120 dBm) Modulation 1 kHz Deviation plusmn15 kHz2) Once close the squelch by increasing

[SQL] value then decrease the value to open the squelch

3) Push [ENTER] key to store the value

[SQL]

(Automatic adjustment)

The output level of the standard signal generator (SSG) is indicated as the SSGrsquos open circuit

5-4 RECEIVE ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

6 - 1

SECTION 6 PARTS LIST

IC1 1110002751 SIC TA75S01F(TE85RF) T 32588IC2 1140005991 SIC MB15A02PFV1-G-BND-ERE1 T 429247IC3 1110007320 SIC NJM2591V-TE1-ZZZB B 458389IC51 1140015230 SIC R4F20102NFA (EMPTY) B 77738IC52 1130015240 SIC R1EX24016ATA00A B 85252IC53 1110007620 SIC NJU7704F3-42A-TE1-ZZZB B 876446IC54 1180003600 SREG NJM2871BF05-TE1-ZZZB T 156348IC55 1110007610 SIC TPA0211DGNR B 138421IC56 1130011770 SIC CD4066BPWR T 801188IC57 1110007550 SIC R2A20178NP B 725245IC58 1110005340 SIC NJM12902V-TE1-ZZZB T 80112IC59 1110006350 SIC LM2902PWR T 801259IC60 1110005340 SIC NJM12902V-TE1-ZZZB B 65175IC61 1140013200 SIC CD4053BPWR T 801383IC62 1130011770 SIC CD4066BPWR T 66781 Q1 1560001700 SFET RD07MUS2B-T112 B 286135Q2 1560001241 SFET RD01MUS1-T113 B 361144Q3 1530000371 STRA 2SC3356-T1B S (R25) B 413129Q4 1530003311 STRA 2SC5107-O(TE85RF) B 462134Q6 1590004050 STRA LDTA144EET1G ltSLVJgt T 33359Q8 1530003311 STRA 2SC5107-O(TE85RF) T 556186Q9 1530003311 STRA 2SC5107-O(TE85RF) B 581194Q10 1530003311 STRA 2SC5107-O(TE85RF) T 61191Q11 1590004070 STRA LDTC144EET1G ltSLVJgt B 508252Q12 1590004070 STRA LDTC144EET1G ltSLVJgt B 63236Q13 1530002920 STRA 2SC4226-T1 R25 T 565226Q14 1530002920 STRA 2SC4226-T1 R25 T 622223Q15 1530002851 STRA 2SC4116-BL(TE85RF) B 627162Q17 1560000541 SFET 2SK880-Y(T5RICOMF) B 526295Q19 1590004070 STRA LDTC144EET1G ltSLVJgt B 635336Q21 1560000841 SFET 2SK1829(TE85RF) B 257315Q22 1580000731 SFET 3SK293(TE85LF) B 21229Q23 1580000731 SFET 3SK293(TE85LF) B 364273Q24 1530002601 STRA 2SC4215-O(TE85RF) B 383426Q25 1590004070 STRA LDTC144EET1G ltSLVJgt T 493351Q26 1530002851 STRA 2SC4116-BL(TE85RF) T 396301Q27 1590004050 STRA LDTA144EET1G ltSLVJgt B 56364Q51 1590001650 STRA XP4601(TX) T 65542Q52 1590004070 STRA LDTC144EET1G ltSLVJgt T 754314Q58 1590003431 STRA UNR911HG0L B 54971Q59 1590004070 STRA LDTC144EET1G ltSLVJgt B 49173Q63 1520000460 STRA 2SB1132 T100 R B 151355Q64 1590001190 STRA XP6501-(TX)AB B 19336Q71 1510001090 STRA KTA2015Y-RTKP B 651366Q72 1510000771 STRA 2SA1586-GR(TE85LF) B 657303Q73 1510001090 STRA KTA2015Y-RTKP B 786238Q74 1520000460 STRA 2SB1132 T100 R B 53344Q75 1590001190 STRA XP6501-(TX)AB T 45352Q76 1590004070 STRA LDTC144EET1G ltSLVJgt T 68352Q81 1590003271 STRA UNR9210G0L B 705458Q82 1590004050 STRA LDTA144EET1G ltSLVJgt T 716395Q83 1590004050 STRA LDTA144EET1G ltSLVJgt T 716416Q84 1590004070 STRA LDTC144EET1G ltSLVJgt B 192441Q85 1590004070 STRA LDTC144EET1G ltSLVJgt B 224441 D1 1750001800 SDIO RB886CS T2RA B 13866D2 1750001800 SDIO RB886CS T2RA B 138105D3 1750001890 SDIO HVD142AKRF-E B 157148D5 1750001890 SDIO HVD142AKRF-E B 496152D6 1750001890 SDIO HVD142AKRF-E B 496166D11 1750001550 SVAR HVD376BKRF-E T 568264D12 1750001840 SVAR HVD350BKRF-E T 54287D14 1750001550 SVAR HVD376BKRF-E T 604261D15 1750001650 SVAR 1SV309(TPH3F) T 646282D16 1750001840 SVAR HVD350BKRF-E T 625282D18 1750001810 SDIO L1SS400T1G ltSLVJgt T 463326D21 1750001810 SDIO L1SS400T1G ltSLVJgt B 281333D22 1750001890 SDIO HVD142AKRF-E B 157183D24 1750001780 SVAR HVB350BYPTL-E B 181238D26 1750001780 SVAR HVB350BYPTL-E B 181267D28 1750001780 SVAR HVB350BYPTL-E B 292267D31 1750001790 SDIO 1SS390 TE61 B 541398D32 1750001790 SDIO 1SS390 TE61 B 517368D33 1750001790 SDIO 1SS390 TE61 B 567398D34 1750001790 SDIO 1SS390 TE61 B 581385D35 1750001810 SDIO L1SS400T1G ltSLVJgt T 37563D51 1750001820 SDIO LRB706F-40T1G ltSLVJgt B 679458D52 1750001790 SDIO 1SS390 TE61 B 87337D53 1750001810 SDIO L1SS400T1G ltSLVJgt B 69131D55 1750001810 SDIO L1SS400T1G ltSLVJgt B 219338 FI1 2030000870 SMON MFT463P3 46350 MHz (FL-442) B 362346FI2 2020002460 CER LTM450GW ltJJEgt FI3 2020002570 CER LTM450HW ltJJEgt X1 6070000310 SDIS JTBM450CX70 ltJJEgt T 476409X2 6050012050 SXTA CR-794 TTS14VSB-A6 153 MHz T 41915X51 6050012730 SXTA CR-864 (SMD-4912288 MHz) ltJJEgt T 869385 L1 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 9575L2 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 106105

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

L3 6200013010 SCOI 030-09-5TL 103N ltCOMOgt B 127134L4 6200002851 SCOI NLV25T-R82J B 182166L5 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 182134L6 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 207134L7 6200012980 SCOI 040-14-5TR 183N ltCOMOgt B 236134L8 6200013860 SCOI MLK1005S12NJT B 41107L9 6200013840 SCOI MLK1005S18NJT B 455107L11 6200010850 SCOI LQW18AN22NG00D (LQW1608A22NG00) B 139166L13 6200007700 SCOI LQW2BHN22NJ03L B 151224L14 6200007700 SCOI LQW2BHN22NJ03L B 152281L15 6200007680 SCOI LQW2BHN12NJ03L B 258276L16 6200007680 SCOI LQW2BHN12NJ03L B 327276L18 6200013800 SCOI MLK1005S39NJT B 364235L19 6200013780 SCOI MLK1005S56NJT B 344251L20 6200004770 SCOI ELJNC R56J-F B 394277L23 6200012170 SCOI MLG1608SR18J-T T 394346L24 6200012170 SCOI MLG1608SR18J-T T 415318L31 6200013810 SCOI MLK1005S33NJT T 538177L32 6200013810 SCOI MLK1005S33NJT B 563204L33 6200013830 SCOI MLK1005S22NJT T 592183L35 6190002030 SCOI MLG1608S 1R0J-T B 591266L36 6200013580 SCOI 030-09-4TR 5PER ltCOMOgt T 543261L37 6190002030 SCOI MLG1608S 1R0J-T T 565287L40 6200013630 SCOI 030-09-3TR 58N 5PER ltCOMOgt T 638249L41 6200011860 SCOI LQW18ANR47G00D T 589274L42 6190002030 SCOI MLG1608S 1R0J-T T 605288L47 6200013840 SCOI MLK1005S18NJT B 513204L48 6200013990 SCOI MLK1005S1N0ST B 327131 R1 7030005070 SRES ERJ2GEJ 683 X (68K) B 7255R2 7030009140 SRES ERJ2GEJ 272 X (27K) B 12589R3 7030005120 SRES ERJ2GEJ 102 X (1K) B 1418R4 7030005120 SRES ERJ2GEJ 102 X (1K) B 14189R5 7030009140 SRES ERJ2GEJ 272 X (27K) B 125109R6 7030004990 SRES ERJ2GEJ 221 X (220) B 203179R11 7030009140 SRES ERJ2GEJ 272 X (27K) T 29959R12 7030005050 SRES ERJ2GEJ 103 X (10K) T 31759R13 7030005090 SRES ERJ2GEJ 104 X (100K) T 326113R14 7030005310 SRES ERJ2GEJ 124 X (120K) T 308113R15 7030005170 SRES ERJ2GEJ 474 X (470K) T 34859R16 7030005530 SRES ERJ2GEJ 100 X (10) T 35796R17 7030008280 SRES ERJ2GEJ 271 X (270) T 34876R18 7030005120 SRES ERJ2GEJ 102 X (1K) T 35776R21 7030005530 SRES ERJ2GEJ 100 X (10) B 332108R22 7030005040 SRES ERJ2GEJ 472 X (47K) B 34191R23 7030005060 SRES ERJ2GEJ 333 X (33K) B 32391R26 7030004970 SRES ERJ2GEJ 470 X (47) B 382108R27 7030005040 SRES ERJ2GEJ 472 X (47K) B 38291R29 7030004970 SRES ERJ2GEJ 470 X (47) B 4198R30 7030005220 SRES ERJ2GEJ 223 X (22K) B 418151R31 7030004980 SRES ERJ2GEJ 101 X (100) B 45598R32 7030005220 SRES ERJ2GEJ 223 X (22K) B 457152R33 7030005050 SRES ERJ2GEJ 103 X (10K) B 496131R34 7030004980 SRES ERJ2GEJ 101 X (100) B 49614R35 7030005040 SRES ERJ2GEJ 472 X (47K) B 518166R41 7030005530 SRES ERJ2GEJ 100 X (10) T 574177R42 7030005070 SRES ERJ2GEJ 683 X (68K) T 574193R43 7030004980 SRES ERJ2GEJ 101 X (100) B 545188R44 7030005090 SRES ERJ2GEJ 104 X (100K) B 599189R45 7030004980 SRES ERJ2GEJ 101 X (100) T 632179R46 7030005090 SRES ERJ2GEJ 104 X (100K) T 628193R51 7030005010 SRES ERJ2GEJ 681 X (680) B 528252R52 7030008370 SRES ERJ2GEJ 561 X (560) B 615223R53 7030006020 SRES RR0510P-682-D (68K) T 583238R54 7030006020 SRES RR0510P-682-D (68K) T 581254R55 7030006020 SRES RR0510P-682-D (68K) T 595238R56 7030006020 SRES RR0510P-682-D (68K) T 603251R57 7030009320 SRES ERJ2GEJ 4R7 X (47) T 619242R63 7030005220 SRES ERJ2GEJ 223 X (22K) B 626277R64 7030005530 SRES ERJ2GEJ 100 X (10) T 642264R65 7030005600 SRES ERJ2GEJ 273 X (27K) B 644261R66 7030005100 SRES ERJ2GEJ 154 X (150K) B 654261R67 7030007290 SRES ERJ2GEJ 222 X (22K) B 609164R68 7030005170 SRES ERJ2GEJ 474 X (470K) B 626299R70 7030005310 SRES ERJ2GEJ 124 X (120K) B 626318R71 7030005050 SRES ERJ2GEJ 103 X (10K) B 503295R72 7030004980 SRES ERJ2GEJ 101 X (100) B 499279R73 7030005040 SRES ERJ2GEJ 472 X (47K) B 556305R76 7030005120 SRES ERJ2GEJ 102 X (1K) T 491255R77 7030008410 SRES ERJ2GEJ 392 X (39K) T 467255R78 7030005120 SRES ERJ2GEJ 102 X (1K) T 467243R80 7410001130 SARR EXB28V102JX T 444299R81 7030005100 SRES ERJ2GEJ 154 X (150K) B 62353R82 7030005050 SRES ERJ2GEJ 103 X (10K) T 401194R83 7030005580 SRES ERJ2GEJ 560 X (56) T 467209R87 7030005090 SRES ERJ2GEJ 104 X (100K) T 635277R88 7510001730 STHE ERTJOEP 473J T 566133R89 7030010080 SRES ERJ2RHD 104 X (100K) T 583133R101 7030005110 SRES ERJ2GEJ 224 X (220K) B 281321R102 7030005170 SRES ERJ2GEJ 474 X (470K) B 258333R103 7030008400 SRES ERJ2GEJ 182 X (18K) B 281309R104 7030005050 SRES ERJ2GEJ 103 X (10K) B 181218R105 7030005050 SRES ERJ2GEJ 103 X (10K) B 203272R106 7030005240 SRES ERJ2GEJ 473 X (47K) B 18329R107 7030005050 SRES ERJ2GEJ 103 X (10K) B 20231

6 - 2

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R108 7030005080 SRES ERJ2GEJ 823 X (82K) B 19229R109 7030005530 SRES ERJ2GEJ 100 X (10) B 21231R110 7030004980 SRES ERJ2GEJ 101 X (100) B 221254R112 7030004970 SRES ERJ2GEJ 470 X (47) B 258254R113 7030007300 SRES ERJ2GEJ 332 X (33K) B 242285R114 7030005090 SRES ERJ2GEJ 104 X (100K) B 274268R115 7030005090 SRES ERJ2GEJ 104 X (100K) B 31268R116 7030005310 SRES ERJ2GEJ 124 X (120K) B 354293R117 7030005090 SRES ERJ2GEJ 104 X (100K) B 334251R118 7030005310 SRES ERJ2GEJ 124 X (120K) B 364251R119 7030005100 SRES ERJ2GEJ 154 X (150K) B 364293R120 7030005710 SRES ERJ2GEJ 121 X (120) B 394251R121 7030007300 SRES ERJ2GEJ 332 X (33K) B 412277R122 7030004970 SRES ERJ2GEJ 470 X (47) B 433251R123 7030005530 SRES ERJ2GEJ 100 X (10) B 392298R125 7030008370 SRES ERJ2GEJ 561 X (560) B 356408R126 7030007290 SRES ERJ2GEJ 222 X (22K) B 39408R127 7030005090 SRES ERJ2GEJ 104 X (100K) B 373408R128 7030005010 SRES ERJ2GEJ 681 X (680) B 391444R132 7030005050 SRES ERJ2GEJ 103 X (10K) B 474176R134 7030005090 SRES ERJ2GEJ 104 X (100K) B 404403R135 7030007290 SRES ERJ2GEJ 222 X (22K) T 43367R136 7030007290 SRES ERJ2GEJ 222 X (22K) T 43376R137 7030008410 SRES ERJ2GEJ 392 X (39K) T 457351R138 7030005000 SRES ERJ2GEJ 471 X (470) B 43355R139 7030005090 SRES ERJ2GEJ 104 X (100K) B 483355R140 7030008410 SRES ERJ2GEJ 392 X (39K) B 465346R141 7030005240 SRES ERJ2GEJ 473 X (47K) B 465337R142 7030005090 SRES ERJ2GEJ 104 X (100K) B 465319R143 7030005040 SRES ERJ2GEJ 472 X (47K) B 483328R146 7030004970 SRES ERJ2GEJ 470 X (47) B 45644R147 7030005030 SRES ERJ2GEJ 152 X (15K) B 471422R148 7030005120 SRES ERJ2GEJ 102 X (1K) T 378314R149 7030007060 SRES ERJ2GEJ 684X (680K) T 378296R151 7030005600 SRES ERJ2GEJ 273 X (27K) B 51739R152 7030005210 SRES ERJ2GEJ 822 X (82K) B 539351R153 7030007300 SRES ERJ2GEJ 332 X (33K) B 555385R154 7030005210 SRES ERJ2GEJ 822 X (82K) B 575369R155 7030005600 SRES ERJ2GEJ 273 X (27K) B 588398R156 7030005120 SRES ERJ2GEJ 102 X (1K) B 203218R157 7030005120 SRES ERJ2GEJ 102 X (1K) B 31251R158 7030005120 SRES ERJ2GEJ 102 X (1K) B 594357R159 7030005290 SRES ERJ2GEJ 682 X (68K) B 297238R301 7030007340 SRES ERJ2GEJ 153 X (15K) B 684124R302 7030008010 SRES ERJ2GEJ 123 X (12K) B 666124R303 7030005720 SRES ERJ2GEJ 563 X (56K) B 675124R304 7030005030 SRES ERJ2GEJ 152 X (15K) B 693107R310 7030005220 SRES ERJ2GEJ 223 X (22K) T 662367R311 7030005220 SRES ERJ2GEJ 223 X (22K) T 646379R312 7030005220 SRES ERJ2GEJ 223 X (22K) T 646396R313 7030007300 SRES ERJ2GEJ 332 X (33K) T 626396R314 7030006610 SRES ERJ2GEJ 394 X (390K) T 637412R315 7030005080 SRES ERJ2GEJ 823 X (82K) T 637428R316 7030005000 SRES ERJ2GEJ 471 X (470) T 673428R317 7030005290 SRES ERJ2GEJ 682 X (68K) T 664396R318 7030005050 SRES ERJ2GEJ 103 X (10K) T 673396R321 7030007340 SRES ERJ2GEJ 153 X (15K) T 737277R322 7030008300 SRES ERJ2GEJ 184 X (180K) B 69133R323 7030005720 SRES ERJ2GEJ 563 X (56K) B 7033R324 7030005220 SRES ERJ2GEJ 223 X (22K) B 70933R325 7030005290 SRES ERJ2GEJ 682 X (68K) T 728295R326 7030005240 SRES ERJ2GEJ 473 X (47K) T 737295R327 7030005240 SRES ERJ2GEJ 473 X (47K) T 755295R328 7030005240 SRES ERJ2GEJ 473 X (47K) T 755277R329 7030005040 SRES ERJ2GEJ 472 X (47K) T 779295R330 7030005090 SRES ERJ2GEJ 104 X (100K) T 745329R331 7030005240 SRES ERJ2GEJ 473 X (47K) T 774316R341 7030005070 SRES ERJ2GEJ 683 X (68K) T 848311R342 7030005070 SRES ERJ2GEJ 683 X (68K) T 848294R343 7030005070 SRES ERJ2GEJ 683 X (68K) T 848277R344 7030005070 SRES ERJ2GEJ 683 X (68K) T 866277R345 7030005070 SRES ERJ2GEJ 683 X (68K) T 85726R346 7030005240 SRES ERJ2GEJ 473 X (47K) T 857243R347 7030005050 SRES ERJ2GEJ 103 X (10K) B 813154R348 7030005090 SRES ERJ2GEJ 104 X (100K) T 823346R349 7030005160 SRES ERJ2GEJ 105 X (1M) T 832346R350 7030005050 SRES ERJ2GEJ 103 X (10K) T 866243R351 7030008290 SRES ERJ2GEJ 183 X (18K) T 755243R352 7030005050 SRES ERJ2GEJ 103 X (10K) T 71812R353 7030005210 SRES ERJ2GEJ 822 X (82K) T 727102R354 7030005160 SRES ERJ2GEJ 105 X (1M) T 754102R355 7030005050 SRES ERJ2GEJ 103 X (10K) T 737243R359 7030005210 SRES ERJ2GEJ 822 X (82K) B 561105R360 7030007290 SRES ERJ2GEJ 222 X (22K) B 56196R361 7030005000 SRES ERJ2GEJ 471 X (470) B 251439R362 7030005060 SRES ERJ2GEJ 333 X (33K) B 51675R363 7030005000 SRES ERJ2GEJ 471 X (470) B 57887R364 7030005090 SRES ERJ2GEJ 104 X (100K) T 59555R366 7030005100 SRES ERJ2GEJ 154 X (150K) B 57896R368 7030005700 SRES ERJ2GEJ 274 X (270K) T 61787R369 7030005100 SRES ERJ2GEJ 154 X (150K) T 617104R370 7030005170 SRES ERJ2GEJ 474 X (470K) B 61711R371 7030005290 SRES ERJ2GEJ 682 X (68K) T 74584R372 7030009290 SRES ERJ2GEJ 562 X (56K) T 80284R373 7030005080 SRES ERJ2GEJ 823 X (82K) T 847102R374 7030008410 SRES ERJ2GEJ 392 X (39K) T 865102R375 7030005000 SRES ERJ2GEJ 471 X (470) T 85612R377 7030005060 SRES ERJ2GEJ 333 X (33K) T 847138R378 7030005050 SRES ERJ2GEJ 103 X (10K) T 865156R379 7030005700 SRES ERJ2GEJ 274 X (270K) T 847156R381 7030005700 SRES ERJ2GEJ 274 X (270K) T 709156R382 7030005170 SRES ERJ2GEJ 474 X (470K) T 718138R383 7030008310 SRES ERJ2GEJ 564 X (560K) T 709138R384 7030005090 SRES ERJ2GEJ 104 X (100K) T 809154R385 7030005310 SRES ERJ2GEJ 124 X (120K) T 745138

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R386 7030005060 SRES ERJ2GEJ 333 X (33K) T 736138R387 7030005030 SRES ERJ2GEJ 152 X (15K) T 736156R388 7030008010 SRES ERJ2GEJ 123 X (12K) B 788137R389 7030005800 SRES RR0510P-102-D (1K) B 779137R390 7030005810 SRES RR0510P-152-D (15K) B 772155R391 7030007290 SRES ERJ2GEJ 222 X (22K) T 745156R393 7030005700 SRES ERJ2GEJ 274 X (270K) B 61778R394 7030005090 SRES ERJ2GEJ 104 X (100K) B 60862R395 7030005310 SRES ERJ2GEJ 124 X (120K) B 60878R396 7030005700 SRES ERJ2GEJ 274 X (270K) B 61762R397 7030008300 SRES ERJ2GEJ 184 X (180K) B 60846R398 7030005050 SRES ERJ2GEJ 103 X (10K) B 61794R401 7030005120 SRES ERJ2GEJ 102 X (1K) T 662358R402 7030005000 SRES ERJ2GEJ 471 X (470) B 685225R403 7030010040 SRES ERJ2GEJ-JPW B 675287R406 7030005090 SRES ERJ2GEJ 104 X (100K) B 127456R408 7030004980 SRES ERJ2GEJ 101 X (100) B 356463R412 7030005040 SRES ERJ2GEJ 472 X (47K) B 168383R413 7030005090 SRES ERJ2GEJ 104 X (100K) T 198322R414 7030005230 SRES ERJ2GEJ 334 X (330K) B 215349R416 7030005120 SRES ERJ2GEJ 102 X (1K) B 215358R417 7030007340 SRES ERJ2GEJ 153 X (15K) B 213371R418 7030005120 SRES ERJ2GEJ 102 X (1K) B 198379R420 7030005090 SRES ERJ2GEJ 104 X (100K) T 796323R421 7210003061 VAR TP76N00N-15F-A103-2251A R423 7030005090 SRES ERJ2GEJ 104 X (100K) T 69378R424 7030005090 SRES ERJ2GEJ 104 X (100K) T 52387R426 7030007340 SRES ERJ2GEJ 153 X (15K) B 69363R427 7030005230 SRES ERJ2GEJ 334 X (330K) B 68446R428 7030005030 SRES ERJ2GEJ 152 X (15K) B 65131R429 7030006610 SRES ERJ2GEJ 394 X (390K) B 66831R430 7030005160 SRES ERJ2GEJ 105 X (1M) B 71731R431 7030005050 SRES ERJ2GEJ 103 X (10K) B 666348R432 7030005040 SRES ERJ2GEJ 472 X (47K) B 705309R433 7030005050 SRES ERJ2GEJ 103 X (10K) B 675303R434 7030005050 SRES ERJ2GEJ 103 X (10K) B 70530R435 7030005050 SRES ERJ2GEJ 103 X (10K) B 768245R436 7030005040 SRES ERJ2GEJ 472 X (47K) B 75430R437 7030005050 SRES ERJ2GEJ 103 X (10K) B 84347R438 7030007290 SRES ERJ2GEJ 222 X (22K) T 48333R439 7030007290 SRES ERJ2GEJ 222 X (22K) T 83284R440 7030009280 SRES ERJ2GEJ 391 X B 175436R441 7030005050 SRES ERJ2GEJ 103 X (10K) B 208436R442 7030007280 SRES ERJ2GEJ 331 X (330) B 202337R451 7030005530 SRES ERJ2GEJ 100 X (10) B 852373R453 7030008010 SRES ERJ2GEJ 123 X (12K) B 879352R454 7030005220 SRES ERJ2GEJ 223 X (22K) B 87322R455 7030008010 SRES ERJ2GEJ 123 X (12K) B 861352R456 7030005050 SRES ERJ2GEJ 103 X (10K) B 876427R457 7030005040 SRES ERJ2GEJ 472 X (47K) T 80735R458 7030005120 SRES ERJ2GEJ 102 X (1K) B 81330R459 7030005120 SRES ERJ2GEJ 102 X (1K) B 80430R460 7410001140 SARR EXB28V104JX B 77730R461 7030005040 SRES ERJ2GEJ 472 X (47K) B 84308R462 7030005040 SRES ERJ2GEJ 472 X (47K) B 84299R463 7030005050 SRES ERJ2GEJ 103 X (10K) T 718377R464 7030005090 SRES ERJ2GEJ 104 X (100K) T 734348R466 7410001140 SARR EXB28V104JX B 69540R467 7410001140 SARR EXB28V104JX B 69537R468 7030008400 SRES ERJ2GEJ 182 X (18K) T 70416R469 7030009280 SRES ERJ2GEJ 391 X T 70395R470 7030005090 SRES ERJ2GEJ 104 X (100K) B 747461R471 7030007340 SRES ERJ2GEJ 153 X (15K) B 726454R472 7030005090 SRES ERJ2GEJ 104 X (100K) B 726472R473 7410001140 SARR EXB28V104JX B 777461R474 7030007340 SRES ERJ2GEJ 153 X (15K) B 726463R475 7030005090 SRES ERJ2GEJ 104 X (100K) B 79530R476 7030005120 SRES ERJ2GEJ 102 X (1K) B 759461R477 7030005120 SRES ERJ2GEJ 102 X (1K) B 852345 C1 4030011650 SCER C1005 CH 1H 1R5B-T B 8557C2 4030009720 SCER C1005 CH 1H 080C-T B 10657C3 4030011630 SCER C1005 CH 1H 0R5B-T B 1258C4 4030011650 SCER C1005 CH 1H 1R5B-T B 91105C5 4030009720 SCER C1005 CH 1H 080C-T B 107149C6 4030011630 SCER C1005 CH 1H 0R5B-T B 12510C7 4030019740 SCER C1005 JB 1H 102K-T B 14966C8 4030011670 SCER C1005 CH 1H 2R5B-T B 124149C9 4030011700 SCER C1005 CH 1H 040B-T B 124158C10 4030019740 SCER C1005 JB 1H 102K-T B 148134C11 4030019740 SCER C1005 JB 1H 102K-T B 165134C12 4030009720 SCER C1005 CH 1H 080C-T B 177118C13 4030009760 SCER C1005 CH 1H 150J-T B 197118C14 4030007050 SCER C1608 CH 1H 220J-T B 214103C18 4030019740 SCER C1005 JB 1H 102K-T B 198191C19 4030019740 SCER C1005 JB 1H 102K-T B 182192C20 4030019740 SCER C1005 JB 1H 102K-T T 335113C21 4030019740 SCER C1005 JB 1H 102K-T T 30859C22 4030019740 SCER C1005 JB 1H 102K-T T 39259C23 4030019930 SCER C1005 JB 1A 104K-T T 317113C24 4030019950 SCER C1005 JB 0J 224K-T T 35759C25 4030019810 SCER C1005 JB 1E 103K-T T 357113C26 4030019740 SCER C1005 JB 1H 102K-T T 36696C27 4030019740 SCER C1005 JB 1H 102K-T T 36676C28 4030019970 SCER C1005 JB 0J 105K-T T 37576C29 4030019740 SCER C1005 JB 1H 102K-T B 37391C36 4030011320 SCER C1005 CH 1H 470J-T B 238161C37 4030014260 SCER C1005 JB 1H 331K-T B 247161C38 4030019740 SCER C1005 JB 1H 102K-T B 327151C39 4030011320 SCER C1005 CH 1H 470J-T B 327141C45 4030011320 SCER C1005 CH 1H 470J-T B 327121C47 4030014260 SCER C1005 JB 1H 331K-T B 33291C51 4030011700 SCER C1005 CH 1H 040B-T B 391142C52 4030019740 SCER C1005 JB 1H 102K-T B 4189

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

5 - 7

ADJUSTMENT TRANSCEIVERrsquoSCONDITION OPERATION ADJUSTMENT

ITEM VALUE

RX SENSITIVITY 1 bull CH 11bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 435 MHz Level 20 dBmicro (ndash87 dBm) Modulation 1 kHz Deviation plusmn3 kHz2) Put the cursor on the adjustment item

then push [ENTER]

[BPF ALL]

(Automatic adjustment)

SQUELCH 1 bull CH 12bull Receiving

1) Connect an SSG to the antenna connector and set it as

Frequency 400 MHz Level ndash13 dBmicro (ndash120 dBm) Modulation 1 kHz Deviation plusmn15 kHz2) Once close the squelch by increasing

[SQL] value then decrease the value to open the squelch

3) Push [ENTER] key to store the value

[SQL]

(Automatic adjustment)

The output level of the standard signal generator (SSG) is indicated as the SSGrsquos open circuit

5-4 RECEIVE ADJUSTMENTS1) Select an adjustment item using [uarr][darr] on the PCs keyboard2) Set or modify the adjustment value as specifi ed using [larr][rarr] on the PCs keyboard then push [ENTER]

6 - 1

SECTION 6 PARTS LIST

IC1 1110002751 SIC TA75S01F(TE85RF) T 32588IC2 1140005991 SIC MB15A02PFV1-G-BND-ERE1 T 429247IC3 1110007320 SIC NJM2591V-TE1-ZZZB B 458389IC51 1140015230 SIC R4F20102NFA (EMPTY) B 77738IC52 1130015240 SIC R1EX24016ATA00A B 85252IC53 1110007620 SIC NJU7704F3-42A-TE1-ZZZB B 876446IC54 1180003600 SREG NJM2871BF05-TE1-ZZZB T 156348IC55 1110007610 SIC TPA0211DGNR B 138421IC56 1130011770 SIC CD4066BPWR T 801188IC57 1110007550 SIC R2A20178NP B 725245IC58 1110005340 SIC NJM12902V-TE1-ZZZB T 80112IC59 1110006350 SIC LM2902PWR T 801259IC60 1110005340 SIC NJM12902V-TE1-ZZZB B 65175IC61 1140013200 SIC CD4053BPWR T 801383IC62 1130011770 SIC CD4066BPWR T 66781 Q1 1560001700 SFET RD07MUS2B-T112 B 286135Q2 1560001241 SFET RD01MUS1-T113 B 361144Q3 1530000371 STRA 2SC3356-T1B S (R25) B 413129Q4 1530003311 STRA 2SC5107-O(TE85RF) B 462134Q6 1590004050 STRA LDTA144EET1G ltSLVJgt T 33359Q8 1530003311 STRA 2SC5107-O(TE85RF) T 556186Q9 1530003311 STRA 2SC5107-O(TE85RF) B 581194Q10 1530003311 STRA 2SC5107-O(TE85RF) T 61191Q11 1590004070 STRA LDTC144EET1G ltSLVJgt B 508252Q12 1590004070 STRA LDTC144EET1G ltSLVJgt B 63236Q13 1530002920 STRA 2SC4226-T1 R25 T 565226Q14 1530002920 STRA 2SC4226-T1 R25 T 622223Q15 1530002851 STRA 2SC4116-BL(TE85RF) B 627162Q17 1560000541 SFET 2SK880-Y(T5RICOMF) B 526295Q19 1590004070 STRA LDTC144EET1G ltSLVJgt B 635336Q21 1560000841 SFET 2SK1829(TE85RF) B 257315Q22 1580000731 SFET 3SK293(TE85LF) B 21229Q23 1580000731 SFET 3SK293(TE85LF) B 364273Q24 1530002601 STRA 2SC4215-O(TE85RF) B 383426Q25 1590004070 STRA LDTC144EET1G ltSLVJgt T 493351Q26 1530002851 STRA 2SC4116-BL(TE85RF) T 396301Q27 1590004050 STRA LDTA144EET1G ltSLVJgt B 56364Q51 1590001650 STRA XP4601(TX) T 65542Q52 1590004070 STRA LDTC144EET1G ltSLVJgt T 754314Q58 1590003431 STRA UNR911HG0L B 54971Q59 1590004070 STRA LDTC144EET1G ltSLVJgt B 49173Q63 1520000460 STRA 2SB1132 T100 R B 151355Q64 1590001190 STRA XP6501-(TX)AB B 19336Q71 1510001090 STRA KTA2015Y-RTKP B 651366Q72 1510000771 STRA 2SA1586-GR(TE85LF) B 657303Q73 1510001090 STRA KTA2015Y-RTKP B 786238Q74 1520000460 STRA 2SB1132 T100 R B 53344Q75 1590001190 STRA XP6501-(TX)AB T 45352Q76 1590004070 STRA LDTC144EET1G ltSLVJgt T 68352Q81 1590003271 STRA UNR9210G0L B 705458Q82 1590004050 STRA LDTA144EET1G ltSLVJgt T 716395Q83 1590004050 STRA LDTA144EET1G ltSLVJgt T 716416Q84 1590004070 STRA LDTC144EET1G ltSLVJgt B 192441Q85 1590004070 STRA LDTC144EET1G ltSLVJgt B 224441 D1 1750001800 SDIO RB886CS T2RA B 13866D2 1750001800 SDIO RB886CS T2RA B 138105D3 1750001890 SDIO HVD142AKRF-E B 157148D5 1750001890 SDIO HVD142AKRF-E B 496152D6 1750001890 SDIO HVD142AKRF-E B 496166D11 1750001550 SVAR HVD376BKRF-E T 568264D12 1750001840 SVAR HVD350BKRF-E T 54287D14 1750001550 SVAR HVD376BKRF-E T 604261D15 1750001650 SVAR 1SV309(TPH3F) T 646282D16 1750001840 SVAR HVD350BKRF-E T 625282D18 1750001810 SDIO L1SS400T1G ltSLVJgt T 463326D21 1750001810 SDIO L1SS400T1G ltSLVJgt B 281333D22 1750001890 SDIO HVD142AKRF-E B 157183D24 1750001780 SVAR HVB350BYPTL-E B 181238D26 1750001780 SVAR HVB350BYPTL-E B 181267D28 1750001780 SVAR HVB350BYPTL-E B 292267D31 1750001790 SDIO 1SS390 TE61 B 541398D32 1750001790 SDIO 1SS390 TE61 B 517368D33 1750001790 SDIO 1SS390 TE61 B 567398D34 1750001790 SDIO 1SS390 TE61 B 581385D35 1750001810 SDIO L1SS400T1G ltSLVJgt T 37563D51 1750001820 SDIO LRB706F-40T1G ltSLVJgt B 679458D52 1750001790 SDIO 1SS390 TE61 B 87337D53 1750001810 SDIO L1SS400T1G ltSLVJgt B 69131D55 1750001810 SDIO L1SS400T1G ltSLVJgt B 219338 FI1 2030000870 SMON MFT463P3 46350 MHz (FL-442) B 362346FI2 2020002460 CER LTM450GW ltJJEgt FI3 2020002570 CER LTM450HW ltJJEgt X1 6070000310 SDIS JTBM450CX70 ltJJEgt T 476409X2 6050012050 SXTA CR-794 TTS14VSB-A6 153 MHz T 41915X51 6050012730 SXTA CR-864 (SMD-4912288 MHz) ltJJEgt T 869385 L1 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 9575L2 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 106105

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

L3 6200013010 SCOI 030-09-5TL 103N ltCOMOgt B 127134L4 6200002851 SCOI NLV25T-R82J B 182166L5 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 182134L6 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 207134L7 6200012980 SCOI 040-14-5TR 183N ltCOMOgt B 236134L8 6200013860 SCOI MLK1005S12NJT B 41107L9 6200013840 SCOI MLK1005S18NJT B 455107L11 6200010850 SCOI LQW18AN22NG00D (LQW1608A22NG00) B 139166L13 6200007700 SCOI LQW2BHN22NJ03L B 151224L14 6200007700 SCOI LQW2BHN22NJ03L B 152281L15 6200007680 SCOI LQW2BHN12NJ03L B 258276L16 6200007680 SCOI LQW2BHN12NJ03L B 327276L18 6200013800 SCOI MLK1005S39NJT B 364235L19 6200013780 SCOI MLK1005S56NJT B 344251L20 6200004770 SCOI ELJNC R56J-F B 394277L23 6200012170 SCOI MLG1608SR18J-T T 394346L24 6200012170 SCOI MLG1608SR18J-T T 415318L31 6200013810 SCOI MLK1005S33NJT T 538177L32 6200013810 SCOI MLK1005S33NJT B 563204L33 6200013830 SCOI MLK1005S22NJT T 592183L35 6190002030 SCOI MLG1608S 1R0J-T B 591266L36 6200013580 SCOI 030-09-4TR 5PER ltCOMOgt T 543261L37 6190002030 SCOI MLG1608S 1R0J-T T 565287L40 6200013630 SCOI 030-09-3TR 58N 5PER ltCOMOgt T 638249L41 6200011860 SCOI LQW18ANR47G00D T 589274L42 6190002030 SCOI MLG1608S 1R0J-T T 605288L47 6200013840 SCOI MLK1005S18NJT B 513204L48 6200013990 SCOI MLK1005S1N0ST B 327131 R1 7030005070 SRES ERJ2GEJ 683 X (68K) B 7255R2 7030009140 SRES ERJ2GEJ 272 X (27K) B 12589R3 7030005120 SRES ERJ2GEJ 102 X (1K) B 1418R4 7030005120 SRES ERJ2GEJ 102 X (1K) B 14189R5 7030009140 SRES ERJ2GEJ 272 X (27K) B 125109R6 7030004990 SRES ERJ2GEJ 221 X (220) B 203179R11 7030009140 SRES ERJ2GEJ 272 X (27K) T 29959R12 7030005050 SRES ERJ2GEJ 103 X (10K) T 31759R13 7030005090 SRES ERJ2GEJ 104 X (100K) T 326113R14 7030005310 SRES ERJ2GEJ 124 X (120K) T 308113R15 7030005170 SRES ERJ2GEJ 474 X (470K) T 34859R16 7030005530 SRES ERJ2GEJ 100 X (10) T 35796R17 7030008280 SRES ERJ2GEJ 271 X (270) T 34876R18 7030005120 SRES ERJ2GEJ 102 X (1K) T 35776R21 7030005530 SRES ERJ2GEJ 100 X (10) B 332108R22 7030005040 SRES ERJ2GEJ 472 X (47K) B 34191R23 7030005060 SRES ERJ2GEJ 333 X (33K) B 32391R26 7030004970 SRES ERJ2GEJ 470 X (47) B 382108R27 7030005040 SRES ERJ2GEJ 472 X (47K) B 38291R29 7030004970 SRES ERJ2GEJ 470 X (47) B 4198R30 7030005220 SRES ERJ2GEJ 223 X (22K) B 418151R31 7030004980 SRES ERJ2GEJ 101 X (100) B 45598R32 7030005220 SRES ERJ2GEJ 223 X (22K) B 457152R33 7030005050 SRES ERJ2GEJ 103 X (10K) B 496131R34 7030004980 SRES ERJ2GEJ 101 X (100) B 49614R35 7030005040 SRES ERJ2GEJ 472 X (47K) B 518166R41 7030005530 SRES ERJ2GEJ 100 X (10) T 574177R42 7030005070 SRES ERJ2GEJ 683 X (68K) T 574193R43 7030004980 SRES ERJ2GEJ 101 X (100) B 545188R44 7030005090 SRES ERJ2GEJ 104 X (100K) B 599189R45 7030004980 SRES ERJ2GEJ 101 X (100) T 632179R46 7030005090 SRES ERJ2GEJ 104 X (100K) T 628193R51 7030005010 SRES ERJ2GEJ 681 X (680) B 528252R52 7030008370 SRES ERJ2GEJ 561 X (560) B 615223R53 7030006020 SRES RR0510P-682-D (68K) T 583238R54 7030006020 SRES RR0510P-682-D (68K) T 581254R55 7030006020 SRES RR0510P-682-D (68K) T 595238R56 7030006020 SRES RR0510P-682-D (68K) T 603251R57 7030009320 SRES ERJ2GEJ 4R7 X (47) T 619242R63 7030005220 SRES ERJ2GEJ 223 X (22K) B 626277R64 7030005530 SRES ERJ2GEJ 100 X (10) T 642264R65 7030005600 SRES ERJ2GEJ 273 X (27K) B 644261R66 7030005100 SRES ERJ2GEJ 154 X (150K) B 654261R67 7030007290 SRES ERJ2GEJ 222 X (22K) B 609164R68 7030005170 SRES ERJ2GEJ 474 X (470K) B 626299R70 7030005310 SRES ERJ2GEJ 124 X (120K) B 626318R71 7030005050 SRES ERJ2GEJ 103 X (10K) B 503295R72 7030004980 SRES ERJ2GEJ 101 X (100) B 499279R73 7030005040 SRES ERJ2GEJ 472 X (47K) B 556305R76 7030005120 SRES ERJ2GEJ 102 X (1K) T 491255R77 7030008410 SRES ERJ2GEJ 392 X (39K) T 467255R78 7030005120 SRES ERJ2GEJ 102 X (1K) T 467243R80 7410001130 SARR EXB28V102JX T 444299R81 7030005100 SRES ERJ2GEJ 154 X (150K) B 62353R82 7030005050 SRES ERJ2GEJ 103 X (10K) T 401194R83 7030005580 SRES ERJ2GEJ 560 X (56) T 467209R87 7030005090 SRES ERJ2GEJ 104 X (100K) T 635277R88 7510001730 STHE ERTJOEP 473J T 566133R89 7030010080 SRES ERJ2RHD 104 X (100K) T 583133R101 7030005110 SRES ERJ2GEJ 224 X (220K) B 281321R102 7030005170 SRES ERJ2GEJ 474 X (470K) B 258333R103 7030008400 SRES ERJ2GEJ 182 X (18K) B 281309R104 7030005050 SRES ERJ2GEJ 103 X (10K) B 181218R105 7030005050 SRES ERJ2GEJ 103 X (10K) B 203272R106 7030005240 SRES ERJ2GEJ 473 X (47K) B 18329R107 7030005050 SRES ERJ2GEJ 103 X (10K) B 20231

6 - 2

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R108 7030005080 SRES ERJ2GEJ 823 X (82K) B 19229R109 7030005530 SRES ERJ2GEJ 100 X (10) B 21231R110 7030004980 SRES ERJ2GEJ 101 X (100) B 221254R112 7030004970 SRES ERJ2GEJ 470 X (47) B 258254R113 7030007300 SRES ERJ2GEJ 332 X (33K) B 242285R114 7030005090 SRES ERJ2GEJ 104 X (100K) B 274268R115 7030005090 SRES ERJ2GEJ 104 X (100K) B 31268R116 7030005310 SRES ERJ2GEJ 124 X (120K) B 354293R117 7030005090 SRES ERJ2GEJ 104 X (100K) B 334251R118 7030005310 SRES ERJ2GEJ 124 X (120K) B 364251R119 7030005100 SRES ERJ2GEJ 154 X (150K) B 364293R120 7030005710 SRES ERJ2GEJ 121 X (120) B 394251R121 7030007300 SRES ERJ2GEJ 332 X (33K) B 412277R122 7030004970 SRES ERJ2GEJ 470 X (47) B 433251R123 7030005530 SRES ERJ2GEJ 100 X (10) B 392298R125 7030008370 SRES ERJ2GEJ 561 X (560) B 356408R126 7030007290 SRES ERJ2GEJ 222 X (22K) B 39408R127 7030005090 SRES ERJ2GEJ 104 X (100K) B 373408R128 7030005010 SRES ERJ2GEJ 681 X (680) B 391444R132 7030005050 SRES ERJ2GEJ 103 X (10K) B 474176R134 7030005090 SRES ERJ2GEJ 104 X (100K) B 404403R135 7030007290 SRES ERJ2GEJ 222 X (22K) T 43367R136 7030007290 SRES ERJ2GEJ 222 X (22K) T 43376R137 7030008410 SRES ERJ2GEJ 392 X (39K) T 457351R138 7030005000 SRES ERJ2GEJ 471 X (470) B 43355R139 7030005090 SRES ERJ2GEJ 104 X (100K) B 483355R140 7030008410 SRES ERJ2GEJ 392 X (39K) B 465346R141 7030005240 SRES ERJ2GEJ 473 X (47K) B 465337R142 7030005090 SRES ERJ2GEJ 104 X (100K) B 465319R143 7030005040 SRES ERJ2GEJ 472 X (47K) B 483328R146 7030004970 SRES ERJ2GEJ 470 X (47) B 45644R147 7030005030 SRES ERJ2GEJ 152 X (15K) B 471422R148 7030005120 SRES ERJ2GEJ 102 X (1K) T 378314R149 7030007060 SRES ERJ2GEJ 684X (680K) T 378296R151 7030005600 SRES ERJ2GEJ 273 X (27K) B 51739R152 7030005210 SRES ERJ2GEJ 822 X (82K) B 539351R153 7030007300 SRES ERJ2GEJ 332 X (33K) B 555385R154 7030005210 SRES ERJ2GEJ 822 X (82K) B 575369R155 7030005600 SRES ERJ2GEJ 273 X (27K) B 588398R156 7030005120 SRES ERJ2GEJ 102 X (1K) B 203218R157 7030005120 SRES ERJ2GEJ 102 X (1K) B 31251R158 7030005120 SRES ERJ2GEJ 102 X (1K) B 594357R159 7030005290 SRES ERJ2GEJ 682 X (68K) B 297238R301 7030007340 SRES ERJ2GEJ 153 X (15K) B 684124R302 7030008010 SRES ERJ2GEJ 123 X (12K) B 666124R303 7030005720 SRES ERJ2GEJ 563 X (56K) B 675124R304 7030005030 SRES ERJ2GEJ 152 X (15K) B 693107R310 7030005220 SRES ERJ2GEJ 223 X (22K) T 662367R311 7030005220 SRES ERJ2GEJ 223 X (22K) T 646379R312 7030005220 SRES ERJ2GEJ 223 X (22K) T 646396R313 7030007300 SRES ERJ2GEJ 332 X (33K) T 626396R314 7030006610 SRES ERJ2GEJ 394 X (390K) T 637412R315 7030005080 SRES ERJ2GEJ 823 X (82K) T 637428R316 7030005000 SRES ERJ2GEJ 471 X (470) T 673428R317 7030005290 SRES ERJ2GEJ 682 X (68K) T 664396R318 7030005050 SRES ERJ2GEJ 103 X (10K) T 673396R321 7030007340 SRES ERJ2GEJ 153 X (15K) T 737277R322 7030008300 SRES ERJ2GEJ 184 X (180K) B 69133R323 7030005720 SRES ERJ2GEJ 563 X (56K) B 7033R324 7030005220 SRES ERJ2GEJ 223 X (22K) B 70933R325 7030005290 SRES ERJ2GEJ 682 X (68K) T 728295R326 7030005240 SRES ERJ2GEJ 473 X (47K) T 737295R327 7030005240 SRES ERJ2GEJ 473 X (47K) T 755295R328 7030005240 SRES ERJ2GEJ 473 X (47K) T 755277R329 7030005040 SRES ERJ2GEJ 472 X (47K) T 779295R330 7030005090 SRES ERJ2GEJ 104 X (100K) T 745329R331 7030005240 SRES ERJ2GEJ 473 X (47K) T 774316R341 7030005070 SRES ERJ2GEJ 683 X (68K) T 848311R342 7030005070 SRES ERJ2GEJ 683 X (68K) T 848294R343 7030005070 SRES ERJ2GEJ 683 X (68K) T 848277R344 7030005070 SRES ERJ2GEJ 683 X (68K) T 866277R345 7030005070 SRES ERJ2GEJ 683 X (68K) T 85726R346 7030005240 SRES ERJ2GEJ 473 X (47K) T 857243R347 7030005050 SRES ERJ2GEJ 103 X (10K) B 813154R348 7030005090 SRES ERJ2GEJ 104 X (100K) T 823346R349 7030005160 SRES ERJ2GEJ 105 X (1M) T 832346R350 7030005050 SRES ERJ2GEJ 103 X (10K) T 866243R351 7030008290 SRES ERJ2GEJ 183 X (18K) T 755243R352 7030005050 SRES ERJ2GEJ 103 X (10K) T 71812R353 7030005210 SRES ERJ2GEJ 822 X (82K) T 727102R354 7030005160 SRES ERJ2GEJ 105 X (1M) T 754102R355 7030005050 SRES ERJ2GEJ 103 X (10K) T 737243R359 7030005210 SRES ERJ2GEJ 822 X (82K) B 561105R360 7030007290 SRES ERJ2GEJ 222 X (22K) B 56196R361 7030005000 SRES ERJ2GEJ 471 X (470) B 251439R362 7030005060 SRES ERJ2GEJ 333 X (33K) B 51675R363 7030005000 SRES ERJ2GEJ 471 X (470) B 57887R364 7030005090 SRES ERJ2GEJ 104 X (100K) T 59555R366 7030005100 SRES ERJ2GEJ 154 X (150K) B 57896R368 7030005700 SRES ERJ2GEJ 274 X (270K) T 61787R369 7030005100 SRES ERJ2GEJ 154 X (150K) T 617104R370 7030005170 SRES ERJ2GEJ 474 X (470K) B 61711R371 7030005290 SRES ERJ2GEJ 682 X (68K) T 74584R372 7030009290 SRES ERJ2GEJ 562 X (56K) T 80284R373 7030005080 SRES ERJ2GEJ 823 X (82K) T 847102R374 7030008410 SRES ERJ2GEJ 392 X (39K) T 865102R375 7030005000 SRES ERJ2GEJ 471 X (470) T 85612R377 7030005060 SRES ERJ2GEJ 333 X (33K) T 847138R378 7030005050 SRES ERJ2GEJ 103 X (10K) T 865156R379 7030005700 SRES ERJ2GEJ 274 X (270K) T 847156R381 7030005700 SRES ERJ2GEJ 274 X (270K) T 709156R382 7030005170 SRES ERJ2GEJ 474 X (470K) T 718138R383 7030008310 SRES ERJ2GEJ 564 X (560K) T 709138R384 7030005090 SRES ERJ2GEJ 104 X (100K) T 809154R385 7030005310 SRES ERJ2GEJ 124 X (120K) T 745138

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R386 7030005060 SRES ERJ2GEJ 333 X (33K) T 736138R387 7030005030 SRES ERJ2GEJ 152 X (15K) T 736156R388 7030008010 SRES ERJ2GEJ 123 X (12K) B 788137R389 7030005800 SRES RR0510P-102-D (1K) B 779137R390 7030005810 SRES RR0510P-152-D (15K) B 772155R391 7030007290 SRES ERJ2GEJ 222 X (22K) T 745156R393 7030005700 SRES ERJ2GEJ 274 X (270K) B 61778R394 7030005090 SRES ERJ2GEJ 104 X (100K) B 60862R395 7030005310 SRES ERJ2GEJ 124 X (120K) B 60878R396 7030005700 SRES ERJ2GEJ 274 X (270K) B 61762R397 7030008300 SRES ERJ2GEJ 184 X (180K) B 60846R398 7030005050 SRES ERJ2GEJ 103 X (10K) B 61794R401 7030005120 SRES ERJ2GEJ 102 X (1K) T 662358R402 7030005000 SRES ERJ2GEJ 471 X (470) B 685225R403 7030010040 SRES ERJ2GEJ-JPW B 675287R406 7030005090 SRES ERJ2GEJ 104 X (100K) B 127456R408 7030004980 SRES ERJ2GEJ 101 X (100) B 356463R412 7030005040 SRES ERJ2GEJ 472 X (47K) B 168383R413 7030005090 SRES ERJ2GEJ 104 X (100K) T 198322R414 7030005230 SRES ERJ2GEJ 334 X (330K) B 215349R416 7030005120 SRES ERJ2GEJ 102 X (1K) B 215358R417 7030007340 SRES ERJ2GEJ 153 X (15K) B 213371R418 7030005120 SRES ERJ2GEJ 102 X (1K) B 198379R420 7030005090 SRES ERJ2GEJ 104 X (100K) T 796323R421 7210003061 VAR TP76N00N-15F-A103-2251A R423 7030005090 SRES ERJ2GEJ 104 X (100K) T 69378R424 7030005090 SRES ERJ2GEJ 104 X (100K) T 52387R426 7030007340 SRES ERJ2GEJ 153 X (15K) B 69363R427 7030005230 SRES ERJ2GEJ 334 X (330K) B 68446R428 7030005030 SRES ERJ2GEJ 152 X (15K) B 65131R429 7030006610 SRES ERJ2GEJ 394 X (390K) B 66831R430 7030005160 SRES ERJ2GEJ 105 X (1M) B 71731R431 7030005050 SRES ERJ2GEJ 103 X (10K) B 666348R432 7030005040 SRES ERJ2GEJ 472 X (47K) B 705309R433 7030005050 SRES ERJ2GEJ 103 X (10K) B 675303R434 7030005050 SRES ERJ2GEJ 103 X (10K) B 70530R435 7030005050 SRES ERJ2GEJ 103 X (10K) B 768245R436 7030005040 SRES ERJ2GEJ 472 X (47K) B 75430R437 7030005050 SRES ERJ2GEJ 103 X (10K) B 84347R438 7030007290 SRES ERJ2GEJ 222 X (22K) T 48333R439 7030007290 SRES ERJ2GEJ 222 X (22K) T 83284R440 7030009280 SRES ERJ2GEJ 391 X B 175436R441 7030005050 SRES ERJ2GEJ 103 X (10K) B 208436R442 7030007280 SRES ERJ2GEJ 331 X (330) B 202337R451 7030005530 SRES ERJ2GEJ 100 X (10) B 852373R453 7030008010 SRES ERJ2GEJ 123 X (12K) B 879352R454 7030005220 SRES ERJ2GEJ 223 X (22K) B 87322R455 7030008010 SRES ERJ2GEJ 123 X (12K) B 861352R456 7030005050 SRES ERJ2GEJ 103 X (10K) B 876427R457 7030005040 SRES ERJ2GEJ 472 X (47K) T 80735R458 7030005120 SRES ERJ2GEJ 102 X (1K) B 81330R459 7030005120 SRES ERJ2GEJ 102 X (1K) B 80430R460 7410001140 SARR EXB28V104JX B 77730R461 7030005040 SRES ERJ2GEJ 472 X (47K) B 84308R462 7030005040 SRES ERJ2GEJ 472 X (47K) B 84299R463 7030005050 SRES ERJ2GEJ 103 X (10K) T 718377R464 7030005090 SRES ERJ2GEJ 104 X (100K) T 734348R466 7410001140 SARR EXB28V104JX B 69540R467 7410001140 SARR EXB28V104JX B 69537R468 7030008400 SRES ERJ2GEJ 182 X (18K) T 70416R469 7030009280 SRES ERJ2GEJ 391 X T 70395R470 7030005090 SRES ERJ2GEJ 104 X (100K) B 747461R471 7030007340 SRES ERJ2GEJ 153 X (15K) B 726454R472 7030005090 SRES ERJ2GEJ 104 X (100K) B 726472R473 7410001140 SARR EXB28V104JX B 777461R474 7030007340 SRES ERJ2GEJ 153 X (15K) B 726463R475 7030005090 SRES ERJ2GEJ 104 X (100K) B 79530R476 7030005120 SRES ERJ2GEJ 102 X (1K) B 759461R477 7030005120 SRES ERJ2GEJ 102 X (1K) B 852345 C1 4030011650 SCER C1005 CH 1H 1R5B-T B 8557C2 4030009720 SCER C1005 CH 1H 080C-T B 10657C3 4030011630 SCER C1005 CH 1H 0R5B-T B 1258C4 4030011650 SCER C1005 CH 1H 1R5B-T B 91105C5 4030009720 SCER C1005 CH 1H 080C-T B 107149C6 4030011630 SCER C1005 CH 1H 0R5B-T B 12510C7 4030019740 SCER C1005 JB 1H 102K-T B 14966C8 4030011670 SCER C1005 CH 1H 2R5B-T B 124149C9 4030011700 SCER C1005 CH 1H 040B-T B 124158C10 4030019740 SCER C1005 JB 1H 102K-T B 148134C11 4030019740 SCER C1005 JB 1H 102K-T B 165134C12 4030009720 SCER C1005 CH 1H 080C-T B 177118C13 4030009760 SCER C1005 CH 1H 150J-T B 197118C14 4030007050 SCER C1608 CH 1H 220J-T B 214103C18 4030019740 SCER C1005 JB 1H 102K-T B 198191C19 4030019740 SCER C1005 JB 1H 102K-T B 182192C20 4030019740 SCER C1005 JB 1H 102K-T T 335113C21 4030019740 SCER C1005 JB 1H 102K-T T 30859C22 4030019740 SCER C1005 JB 1H 102K-T T 39259C23 4030019930 SCER C1005 JB 1A 104K-T T 317113C24 4030019950 SCER C1005 JB 0J 224K-T T 35759C25 4030019810 SCER C1005 JB 1E 103K-T T 357113C26 4030019740 SCER C1005 JB 1H 102K-T T 36696C27 4030019740 SCER C1005 JB 1H 102K-T T 36676C28 4030019970 SCER C1005 JB 0J 105K-T T 37576C29 4030019740 SCER C1005 JB 1H 102K-T B 37391C36 4030011320 SCER C1005 CH 1H 470J-T B 238161C37 4030014260 SCER C1005 JB 1H 331K-T B 247161C38 4030019740 SCER C1005 JB 1H 102K-T B 327151C39 4030011320 SCER C1005 CH 1H 470J-T B 327141C45 4030011320 SCER C1005 CH 1H 470J-T B 327121C47 4030014260 SCER C1005 JB 1H 331K-T B 33291C51 4030011700 SCER C1005 CH 1H 040B-T B 391142C52 4030019740 SCER C1005 JB 1H 102K-T B 4189

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

6 - 1

SECTION 6 PARTS LIST

IC1 1110002751 SIC TA75S01F(TE85RF) T 32588IC2 1140005991 SIC MB15A02PFV1-G-BND-ERE1 T 429247IC3 1110007320 SIC NJM2591V-TE1-ZZZB B 458389IC51 1140015230 SIC R4F20102NFA (EMPTY) B 77738IC52 1130015240 SIC R1EX24016ATA00A B 85252IC53 1110007620 SIC NJU7704F3-42A-TE1-ZZZB B 876446IC54 1180003600 SREG NJM2871BF05-TE1-ZZZB T 156348IC55 1110007610 SIC TPA0211DGNR B 138421IC56 1130011770 SIC CD4066BPWR T 801188IC57 1110007550 SIC R2A20178NP B 725245IC58 1110005340 SIC NJM12902V-TE1-ZZZB T 80112IC59 1110006350 SIC LM2902PWR T 801259IC60 1110005340 SIC NJM12902V-TE1-ZZZB B 65175IC61 1140013200 SIC CD4053BPWR T 801383IC62 1130011770 SIC CD4066BPWR T 66781 Q1 1560001700 SFET RD07MUS2B-T112 B 286135Q2 1560001241 SFET RD01MUS1-T113 B 361144Q3 1530000371 STRA 2SC3356-T1B S (R25) B 413129Q4 1530003311 STRA 2SC5107-O(TE85RF) B 462134Q6 1590004050 STRA LDTA144EET1G ltSLVJgt T 33359Q8 1530003311 STRA 2SC5107-O(TE85RF) T 556186Q9 1530003311 STRA 2SC5107-O(TE85RF) B 581194Q10 1530003311 STRA 2SC5107-O(TE85RF) T 61191Q11 1590004070 STRA LDTC144EET1G ltSLVJgt B 508252Q12 1590004070 STRA LDTC144EET1G ltSLVJgt B 63236Q13 1530002920 STRA 2SC4226-T1 R25 T 565226Q14 1530002920 STRA 2SC4226-T1 R25 T 622223Q15 1530002851 STRA 2SC4116-BL(TE85RF) B 627162Q17 1560000541 SFET 2SK880-Y(T5RICOMF) B 526295Q19 1590004070 STRA LDTC144EET1G ltSLVJgt B 635336Q21 1560000841 SFET 2SK1829(TE85RF) B 257315Q22 1580000731 SFET 3SK293(TE85LF) B 21229Q23 1580000731 SFET 3SK293(TE85LF) B 364273Q24 1530002601 STRA 2SC4215-O(TE85RF) B 383426Q25 1590004070 STRA LDTC144EET1G ltSLVJgt T 493351Q26 1530002851 STRA 2SC4116-BL(TE85RF) T 396301Q27 1590004050 STRA LDTA144EET1G ltSLVJgt B 56364Q51 1590001650 STRA XP4601(TX) T 65542Q52 1590004070 STRA LDTC144EET1G ltSLVJgt T 754314Q58 1590003431 STRA UNR911HG0L B 54971Q59 1590004070 STRA LDTC144EET1G ltSLVJgt B 49173Q63 1520000460 STRA 2SB1132 T100 R B 151355Q64 1590001190 STRA XP6501-(TX)AB B 19336Q71 1510001090 STRA KTA2015Y-RTKP B 651366Q72 1510000771 STRA 2SA1586-GR(TE85LF) B 657303Q73 1510001090 STRA KTA2015Y-RTKP B 786238Q74 1520000460 STRA 2SB1132 T100 R B 53344Q75 1590001190 STRA XP6501-(TX)AB T 45352Q76 1590004070 STRA LDTC144EET1G ltSLVJgt T 68352Q81 1590003271 STRA UNR9210G0L B 705458Q82 1590004050 STRA LDTA144EET1G ltSLVJgt T 716395Q83 1590004050 STRA LDTA144EET1G ltSLVJgt T 716416Q84 1590004070 STRA LDTC144EET1G ltSLVJgt B 192441Q85 1590004070 STRA LDTC144EET1G ltSLVJgt B 224441 D1 1750001800 SDIO RB886CS T2RA B 13866D2 1750001800 SDIO RB886CS T2RA B 138105D3 1750001890 SDIO HVD142AKRF-E B 157148D5 1750001890 SDIO HVD142AKRF-E B 496152D6 1750001890 SDIO HVD142AKRF-E B 496166D11 1750001550 SVAR HVD376BKRF-E T 568264D12 1750001840 SVAR HVD350BKRF-E T 54287D14 1750001550 SVAR HVD376BKRF-E T 604261D15 1750001650 SVAR 1SV309(TPH3F) T 646282D16 1750001840 SVAR HVD350BKRF-E T 625282D18 1750001810 SDIO L1SS400T1G ltSLVJgt T 463326D21 1750001810 SDIO L1SS400T1G ltSLVJgt B 281333D22 1750001890 SDIO HVD142AKRF-E B 157183D24 1750001780 SVAR HVB350BYPTL-E B 181238D26 1750001780 SVAR HVB350BYPTL-E B 181267D28 1750001780 SVAR HVB350BYPTL-E B 292267D31 1750001790 SDIO 1SS390 TE61 B 541398D32 1750001790 SDIO 1SS390 TE61 B 517368D33 1750001790 SDIO 1SS390 TE61 B 567398D34 1750001790 SDIO 1SS390 TE61 B 581385D35 1750001810 SDIO L1SS400T1G ltSLVJgt T 37563D51 1750001820 SDIO LRB706F-40T1G ltSLVJgt B 679458D52 1750001790 SDIO 1SS390 TE61 B 87337D53 1750001810 SDIO L1SS400T1G ltSLVJgt B 69131D55 1750001810 SDIO L1SS400T1G ltSLVJgt B 219338 FI1 2030000870 SMON MFT463P3 46350 MHz (FL-442) B 362346FI2 2020002460 CER LTM450GW ltJJEgt FI3 2020002570 CER LTM450HW ltJJEgt X1 6070000310 SDIS JTBM450CX70 ltJJEgt T 476409X2 6050012050 SXTA CR-794 TTS14VSB-A6 153 MHz T 41915X51 6050012730 SXTA CR-864 (SMD-4912288 MHz) ltJJEgt T 869385 L1 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 9575L2 6200012490 SCOI 030-09-6TR 136N ltCOMOgt B 106105

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

L3 6200013010 SCOI 030-09-5TL 103N ltCOMOgt B 127134L4 6200002851 SCOI NLV25T-R82J B 182166L5 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 182134L6 6200012610 SCOI 040-09-2TL 28N ltCOMOgt B 207134L7 6200012980 SCOI 040-14-5TR 183N ltCOMOgt B 236134L8 6200013860 SCOI MLK1005S12NJT B 41107L9 6200013840 SCOI MLK1005S18NJT B 455107L11 6200010850 SCOI LQW18AN22NG00D (LQW1608A22NG00) B 139166L13 6200007700 SCOI LQW2BHN22NJ03L B 151224L14 6200007700 SCOI LQW2BHN22NJ03L B 152281L15 6200007680 SCOI LQW2BHN12NJ03L B 258276L16 6200007680 SCOI LQW2BHN12NJ03L B 327276L18 6200013800 SCOI MLK1005S39NJT B 364235L19 6200013780 SCOI MLK1005S56NJT B 344251L20 6200004770 SCOI ELJNC R56J-F B 394277L23 6200012170 SCOI MLG1608SR18J-T T 394346L24 6200012170 SCOI MLG1608SR18J-T T 415318L31 6200013810 SCOI MLK1005S33NJT T 538177L32 6200013810 SCOI MLK1005S33NJT B 563204L33 6200013830 SCOI MLK1005S22NJT T 592183L35 6190002030 SCOI MLG1608S 1R0J-T B 591266L36 6200013580 SCOI 030-09-4TR 5PER ltCOMOgt T 543261L37 6190002030 SCOI MLG1608S 1R0J-T T 565287L40 6200013630 SCOI 030-09-3TR 58N 5PER ltCOMOgt T 638249L41 6200011860 SCOI LQW18ANR47G00D T 589274L42 6190002030 SCOI MLG1608S 1R0J-T T 605288L47 6200013840 SCOI MLK1005S18NJT B 513204L48 6200013990 SCOI MLK1005S1N0ST B 327131 R1 7030005070 SRES ERJ2GEJ 683 X (68K) B 7255R2 7030009140 SRES ERJ2GEJ 272 X (27K) B 12589R3 7030005120 SRES ERJ2GEJ 102 X (1K) B 1418R4 7030005120 SRES ERJ2GEJ 102 X (1K) B 14189R5 7030009140 SRES ERJ2GEJ 272 X (27K) B 125109R6 7030004990 SRES ERJ2GEJ 221 X (220) B 203179R11 7030009140 SRES ERJ2GEJ 272 X (27K) T 29959R12 7030005050 SRES ERJ2GEJ 103 X (10K) T 31759R13 7030005090 SRES ERJ2GEJ 104 X (100K) T 326113R14 7030005310 SRES ERJ2GEJ 124 X (120K) T 308113R15 7030005170 SRES ERJ2GEJ 474 X (470K) T 34859R16 7030005530 SRES ERJ2GEJ 100 X (10) T 35796R17 7030008280 SRES ERJ2GEJ 271 X (270) T 34876R18 7030005120 SRES ERJ2GEJ 102 X (1K) T 35776R21 7030005530 SRES ERJ2GEJ 100 X (10) B 332108R22 7030005040 SRES ERJ2GEJ 472 X (47K) B 34191R23 7030005060 SRES ERJ2GEJ 333 X (33K) B 32391R26 7030004970 SRES ERJ2GEJ 470 X (47) B 382108R27 7030005040 SRES ERJ2GEJ 472 X (47K) B 38291R29 7030004970 SRES ERJ2GEJ 470 X (47) B 4198R30 7030005220 SRES ERJ2GEJ 223 X (22K) B 418151R31 7030004980 SRES ERJ2GEJ 101 X (100) B 45598R32 7030005220 SRES ERJ2GEJ 223 X (22K) B 457152R33 7030005050 SRES ERJ2GEJ 103 X (10K) B 496131R34 7030004980 SRES ERJ2GEJ 101 X (100) B 49614R35 7030005040 SRES ERJ2GEJ 472 X (47K) B 518166R41 7030005530 SRES ERJ2GEJ 100 X (10) T 574177R42 7030005070 SRES ERJ2GEJ 683 X (68K) T 574193R43 7030004980 SRES ERJ2GEJ 101 X (100) B 545188R44 7030005090 SRES ERJ2GEJ 104 X (100K) B 599189R45 7030004980 SRES ERJ2GEJ 101 X (100) T 632179R46 7030005090 SRES ERJ2GEJ 104 X (100K) T 628193R51 7030005010 SRES ERJ2GEJ 681 X (680) B 528252R52 7030008370 SRES ERJ2GEJ 561 X (560) B 615223R53 7030006020 SRES RR0510P-682-D (68K) T 583238R54 7030006020 SRES RR0510P-682-D (68K) T 581254R55 7030006020 SRES RR0510P-682-D (68K) T 595238R56 7030006020 SRES RR0510P-682-D (68K) T 603251R57 7030009320 SRES ERJ2GEJ 4R7 X (47) T 619242R63 7030005220 SRES ERJ2GEJ 223 X (22K) B 626277R64 7030005530 SRES ERJ2GEJ 100 X (10) T 642264R65 7030005600 SRES ERJ2GEJ 273 X (27K) B 644261R66 7030005100 SRES ERJ2GEJ 154 X (150K) B 654261R67 7030007290 SRES ERJ2GEJ 222 X (22K) B 609164R68 7030005170 SRES ERJ2GEJ 474 X (470K) B 626299R70 7030005310 SRES ERJ2GEJ 124 X (120K) B 626318R71 7030005050 SRES ERJ2GEJ 103 X (10K) B 503295R72 7030004980 SRES ERJ2GEJ 101 X (100) B 499279R73 7030005040 SRES ERJ2GEJ 472 X (47K) B 556305R76 7030005120 SRES ERJ2GEJ 102 X (1K) T 491255R77 7030008410 SRES ERJ2GEJ 392 X (39K) T 467255R78 7030005120 SRES ERJ2GEJ 102 X (1K) T 467243R80 7410001130 SARR EXB28V102JX T 444299R81 7030005100 SRES ERJ2GEJ 154 X (150K) B 62353R82 7030005050 SRES ERJ2GEJ 103 X (10K) T 401194R83 7030005580 SRES ERJ2GEJ 560 X (56) T 467209R87 7030005090 SRES ERJ2GEJ 104 X (100K) T 635277R88 7510001730 STHE ERTJOEP 473J T 566133R89 7030010080 SRES ERJ2RHD 104 X (100K) T 583133R101 7030005110 SRES ERJ2GEJ 224 X (220K) B 281321R102 7030005170 SRES ERJ2GEJ 474 X (470K) B 258333R103 7030008400 SRES ERJ2GEJ 182 X (18K) B 281309R104 7030005050 SRES ERJ2GEJ 103 X (10K) B 181218R105 7030005050 SRES ERJ2GEJ 103 X (10K) B 203272R106 7030005240 SRES ERJ2GEJ 473 X (47K) B 18329R107 7030005050 SRES ERJ2GEJ 103 X (10K) B 20231

6 - 2

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R108 7030005080 SRES ERJ2GEJ 823 X (82K) B 19229R109 7030005530 SRES ERJ2GEJ 100 X (10) B 21231R110 7030004980 SRES ERJ2GEJ 101 X (100) B 221254R112 7030004970 SRES ERJ2GEJ 470 X (47) B 258254R113 7030007300 SRES ERJ2GEJ 332 X (33K) B 242285R114 7030005090 SRES ERJ2GEJ 104 X (100K) B 274268R115 7030005090 SRES ERJ2GEJ 104 X (100K) B 31268R116 7030005310 SRES ERJ2GEJ 124 X (120K) B 354293R117 7030005090 SRES ERJ2GEJ 104 X (100K) B 334251R118 7030005310 SRES ERJ2GEJ 124 X (120K) B 364251R119 7030005100 SRES ERJ2GEJ 154 X (150K) B 364293R120 7030005710 SRES ERJ2GEJ 121 X (120) B 394251R121 7030007300 SRES ERJ2GEJ 332 X (33K) B 412277R122 7030004970 SRES ERJ2GEJ 470 X (47) B 433251R123 7030005530 SRES ERJ2GEJ 100 X (10) B 392298R125 7030008370 SRES ERJ2GEJ 561 X (560) B 356408R126 7030007290 SRES ERJ2GEJ 222 X (22K) B 39408R127 7030005090 SRES ERJ2GEJ 104 X (100K) B 373408R128 7030005010 SRES ERJ2GEJ 681 X (680) B 391444R132 7030005050 SRES ERJ2GEJ 103 X (10K) B 474176R134 7030005090 SRES ERJ2GEJ 104 X (100K) B 404403R135 7030007290 SRES ERJ2GEJ 222 X (22K) T 43367R136 7030007290 SRES ERJ2GEJ 222 X (22K) T 43376R137 7030008410 SRES ERJ2GEJ 392 X (39K) T 457351R138 7030005000 SRES ERJ2GEJ 471 X (470) B 43355R139 7030005090 SRES ERJ2GEJ 104 X (100K) B 483355R140 7030008410 SRES ERJ2GEJ 392 X (39K) B 465346R141 7030005240 SRES ERJ2GEJ 473 X (47K) B 465337R142 7030005090 SRES ERJ2GEJ 104 X (100K) B 465319R143 7030005040 SRES ERJ2GEJ 472 X (47K) B 483328R146 7030004970 SRES ERJ2GEJ 470 X (47) B 45644R147 7030005030 SRES ERJ2GEJ 152 X (15K) B 471422R148 7030005120 SRES ERJ2GEJ 102 X (1K) T 378314R149 7030007060 SRES ERJ2GEJ 684X (680K) T 378296R151 7030005600 SRES ERJ2GEJ 273 X (27K) B 51739R152 7030005210 SRES ERJ2GEJ 822 X (82K) B 539351R153 7030007300 SRES ERJ2GEJ 332 X (33K) B 555385R154 7030005210 SRES ERJ2GEJ 822 X (82K) B 575369R155 7030005600 SRES ERJ2GEJ 273 X (27K) B 588398R156 7030005120 SRES ERJ2GEJ 102 X (1K) B 203218R157 7030005120 SRES ERJ2GEJ 102 X (1K) B 31251R158 7030005120 SRES ERJ2GEJ 102 X (1K) B 594357R159 7030005290 SRES ERJ2GEJ 682 X (68K) B 297238R301 7030007340 SRES ERJ2GEJ 153 X (15K) B 684124R302 7030008010 SRES ERJ2GEJ 123 X (12K) B 666124R303 7030005720 SRES ERJ2GEJ 563 X (56K) B 675124R304 7030005030 SRES ERJ2GEJ 152 X (15K) B 693107R310 7030005220 SRES ERJ2GEJ 223 X (22K) T 662367R311 7030005220 SRES ERJ2GEJ 223 X (22K) T 646379R312 7030005220 SRES ERJ2GEJ 223 X (22K) T 646396R313 7030007300 SRES ERJ2GEJ 332 X (33K) T 626396R314 7030006610 SRES ERJ2GEJ 394 X (390K) T 637412R315 7030005080 SRES ERJ2GEJ 823 X (82K) T 637428R316 7030005000 SRES ERJ2GEJ 471 X (470) T 673428R317 7030005290 SRES ERJ2GEJ 682 X (68K) T 664396R318 7030005050 SRES ERJ2GEJ 103 X (10K) T 673396R321 7030007340 SRES ERJ2GEJ 153 X (15K) T 737277R322 7030008300 SRES ERJ2GEJ 184 X (180K) B 69133R323 7030005720 SRES ERJ2GEJ 563 X (56K) B 7033R324 7030005220 SRES ERJ2GEJ 223 X (22K) B 70933R325 7030005290 SRES ERJ2GEJ 682 X (68K) T 728295R326 7030005240 SRES ERJ2GEJ 473 X (47K) T 737295R327 7030005240 SRES ERJ2GEJ 473 X (47K) T 755295R328 7030005240 SRES ERJ2GEJ 473 X (47K) T 755277R329 7030005040 SRES ERJ2GEJ 472 X (47K) T 779295R330 7030005090 SRES ERJ2GEJ 104 X (100K) T 745329R331 7030005240 SRES ERJ2GEJ 473 X (47K) T 774316R341 7030005070 SRES ERJ2GEJ 683 X (68K) T 848311R342 7030005070 SRES ERJ2GEJ 683 X (68K) T 848294R343 7030005070 SRES ERJ2GEJ 683 X (68K) T 848277R344 7030005070 SRES ERJ2GEJ 683 X (68K) T 866277R345 7030005070 SRES ERJ2GEJ 683 X (68K) T 85726R346 7030005240 SRES ERJ2GEJ 473 X (47K) T 857243R347 7030005050 SRES ERJ2GEJ 103 X (10K) B 813154R348 7030005090 SRES ERJ2GEJ 104 X (100K) T 823346R349 7030005160 SRES ERJ2GEJ 105 X (1M) T 832346R350 7030005050 SRES ERJ2GEJ 103 X (10K) T 866243R351 7030008290 SRES ERJ2GEJ 183 X (18K) T 755243R352 7030005050 SRES ERJ2GEJ 103 X (10K) T 71812R353 7030005210 SRES ERJ2GEJ 822 X (82K) T 727102R354 7030005160 SRES ERJ2GEJ 105 X (1M) T 754102R355 7030005050 SRES ERJ2GEJ 103 X (10K) T 737243R359 7030005210 SRES ERJ2GEJ 822 X (82K) B 561105R360 7030007290 SRES ERJ2GEJ 222 X (22K) B 56196R361 7030005000 SRES ERJ2GEJ 471 X (470) B 251439R362 7030005060 SRES ERJ2GEJ 333 X (33K) B 51675R363 7030005000 SRES ERJ2GEJ 471 X (470) B 57887R364 7030005090 SRES ERJ2GEJ 104 X (100K) T 59555R366 7030005100 SRES ERJ2GEJ 154 X (150K) B 57896R368 7030005700 SRES ERJ2GEJ 274 X (270K) T 61787R369 7030005100 SRES ERJ2GEJ 154 X (150K) T 617104R370 7030005170 SRES ERJ2GEJ 474 X (470K) B 61711R371 7030005290 SRES ERJ2GEJ 682 X (68K) T 74584R372 7030009290 SRES ERJ2GEJ 562 X (56K) T 80284R373 7030005080 SRES ERJ2GEJ 823 X (82K) T 847102R374 7030008410 SRES ERJ2GEJ 392 X (39K) T 865102R375 7030005000 SRES ERJ2GEJ 471 X (470) T 85612R377 7030005060 SRES ERJ2GEJ 333 X (33K) T 847138R378 7030005050 SRES ERJ2GEJ 103 X (10K) T 865156R379 7030005700 SRES ERJ2GEJ 274 X (270K) T 847156R381 7030005700 SRES ERJ2GEJ 274 X (270K) T 709156R382 7030005170 SRES ERJ2GEJ 474 X (470K) T 718138R383 7030008310 SRES ERJ2GEJ 564 X (560K) T 709138R384 7030005090 SRES ERJ2GEJ 104 X (100K) T 809154R385 7030005310 SRES ERJ2GEJ 124 X (120K) T 745138

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R386 7030005060 SRES ERJ2GEJ 333 X (33K) T 736138R387 7030005030 SRES ERJ2GEJ 152 X (15K) T 736156R388 7030008010 SRES ERJ2GEJ 123 X (12K) B 788137R389 7030005800 SRES RR0510P-102-D (1K) B 779137R390 7030005810 SRES RR0510P-152-D (15K) B 772155R391 7030007290 SRES ERJ2GEJ 222 X (22K) T 745156R393 7030005700 SRES ERJ2GEJ 274 X (270K) B 61778R394 7030005090 SRES ERJ2GEJ 104 X (100K) B 60862R395 7030005310 SRES ERJ2GEJ 124 X (120K) B 60878R396 7030005700 SRES ERJ2GEJ 274 X (270K) B 61762R397 7030008300 SRES ERJ2GEJ 184 X (180K) B 60846R398 7030005050 SRES ERJ2GEJ 103 X (10K) B 61794R401 7030005120 SRES ERJ2GEJ 102 X (1K) T 662358R402 7030005000 SRES ERJ2GEJ 471 X (470) B 685225R403 7030010040 SRES ERJ2GEJ-JPW B 675287R406 7030005090 SRES ERJ2GEJ 104 X (100K) B 127456R408 7030004980 SRES ERJ2GEJ 101 X (100) B 356463R412 7030005040 SRES ERJ2GEJ 472 X (47K) B 168383R413 7030005090 SRES ERJ2GEJ 104 X (100K) T 198322R414 7030005230 SRES ERJ2GEJ 334 X (330K) B 215349R416 7030005120 SRES ERJ2GEJ 102 X (1K) B 215358R417 7030007340 SRES ERJ2GEJ 153 X (15K) B 213371R418 7030005120 SRES ERJ2GEJ 102 X (1K) B 198379R420 7030005090 SRES ERJ2GEJ 104 X (100K) T 796323R421 7210003061 VAR TP76N00N-15F-A103-2251A R423 7030005090 SRES ERJ2GEJ 104 X (100K) T 69378R424 7030005090 SRES ERJ2GEJ 104 X (100K) T 52387R426 7030007340 SRES ERJ2GEJ 153 X (15K) B 69363R427 7030005230 SRES ERJ2GEJ 334 X (330K) B 68446R428 7030005030 SRES ERJ2GEJ 152 X (15K) B 65131R429 7030006610 SRES ERJ2GEJ 394 X (390K) B 66831R430 7030005160 SRES ERJ2GEJ 105 X (1M) B 71731R431 7030005050 SRES ERJ2GEJ 103 X (10K) B 666348R432 7030005040 SRES ERJ2GEJ 472 X (47K) B 705309R433 7030005050 SRES ERJ2GEJ 103 X (10K) B 675303R434 7030005050 SRES ERJ2GEJ 103 X (10K) B 70530R435 7030005050 SRES ERJ2GEJ 103 X (10K) B 768245R436 7030005040 SRES ERJ2GEJ 472 X (47K) B 75430R437 7030005050 SRES ERJ2GEJ 103 X (10K) B 84347R438 7030007290 SRES ERJ2GEJ 222 X (22K) T 48333R439 7030007290 SRES ERJ2GEJ 222 X (22K) T 83284R440 7030009280 SRES ERJ2GEJ 391 X B 175436R441 7030005050 SRES ERJ2GEJ 103 X (10K) B 208436R442 7030007280 SRES ERJ2GEJ 331 X (330) B 202337R451 7030005530 SRES ERJ2GEJ 100 X (10) B 852373R453 7030008010 SRES ERJ2GEJ 123 X (12K) B 879352R454 7030005220 SRES ERJ2GEJ 223 X (22K) B 87322R455 7030008010 SRES ERJ2GEJ 123 X (12K) B 861352R456 7030005050 SRES ERJ2GEJ 103 X (10K) B 876427R457 7030005040 SRES ERJ2GEJ 472 X (47K) T 80735R458 7030005120 SRES ERJ2GEJ 102 X (1K) B 81330R459 7030005120 SRES ERJ2GEJ 102 X (1K) B 80430R460 7410001140 SARR EXB28V104JX B 77730R461 7030005040 SRES ERJ2GEJ 472 X (47K) B 84308R462 7030005040 SRES ERJ2GEJ 472 X (47K) B 84299R463 7030005050 SRES ERJ2GEJ 103 X (10K) T 718377R464 7030005090 SRES ERJ2GEJ 104 X (100K) T 734348R466 7410001140 SARR EXB28V104JX B 69540R467 7410001140 SARR EXB28V104JX B 69537R468 7030008400 SRES ERJ2GEJ 182 X (18K) T 70416R469 7030009280 SRES ERJ2GEJ 391 X T 70395R470 7030005090 SRES ERJ2GEJ 104 X (100K) B 747461R471 7030007340 SRES ERJ2GEJ 153 X (15K) B 726454R472 7030005090 SRES ERJ2GEJ 104 X (100K) B 726472R473 7410001140 SARR EXB28V104JX B 777461R474 7030007340 SRES ERJ2GEJ 153 X (15K) B 726463R475 7030005090 SRES ERJ2GEJ 104 X (100K) B 79530R476 7030005120 SRES ERJ2GEJ 102 X (1K) B 759461R477 7030005120 SRES ERJ2GEJ 102 X (1K) B 852345 C1 4030011650 SCER C1005 CH 1H 1R5B-T B 8557C2 4030009720 SCER C1005 CH 1H 080C-T B 10657C3 4030011630 SCER C1005 CH 1H 0R5B-T B 1258C4 4030011650 SCER C1005 CH 1H 1R5B-T B 91105C5 4030009720 SCER C1005 CH 1H 080C-T B 107149C6 4030011630 SCER C1005 CH 1H 0R5B-T B 12510C7 4030019740 SCER C1005 JB 1H 102K-T B 14966C8 4030011670 SCER C1005 CH 1H 2R5B-T B 124149C9 4030011700 SCER C1005 CH 1H 040B-T B 124158C10 4030019740 SCER C1005 JB 1H 102K-T B 148134C11 4030019740 SCER C1005 JB 1H 102K-T B 165134C12 4030009720 SCER C1005 CH 1H 080C-T B 177118C13 4030009760 SCER C1005 CH 1H 150J-T B 197118C14 4030007050 SCER C1608 CH 1H 220J-T B 214103C18 4030019740 SCER C1005 JB 1H 102K-T B 198191C19 4030019740 SCER C1005 JB 1H 102K-T B 182192C20 4030019740 SCER C1005 JB 1H 102K-T T 335113C21 4030019740 SCER C1005 JB 1H 102K-T T 30859C22 4030019740 SCER C1005 JB 1H 102K-T T 39259C23 4030019930 SCER C1005 JB 1A 104K-T T 317113C24 4030019950 SCER C1005 JB 0J 224K-T T 35759C25 4030019810 SCER C1005 JB 1E 103K-T T 357113C26 4030019740 SCER C1005 JB 1H 102K-T T 36696C27 4030019740 SCER C1005 JB 1H 102K-T T 36676C28 4030019970 SCER C1005 JB 0J 105K-T T 37576C29 4030019740 SCER C1005 JB 1H 102K-T B 37391C36 4030011320 SCER C1005 CH 1H 470J-T B 238161C37 4030014260 SCER C1005 JB 1H 331K-T B 247161C38 4030019740 SCER C1005 JB 1H 102K-T B 327151C39 4030011320 SCER C1005 CH 1H 470J-T B 327141C45 4030011320 SCER C1005 CH 1H 470J-T B 327121C47 4030014260 SCER C1005 JB 1H 331K-T B 33291C51 4030011700 SCER C1005 CH 1H 040B-T B 391142C52 4030019740 SCER C1005 JB 1H 102K-T B 4189

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

6 - 2

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R108 7030005080 SRES ERJ2GEJ 823 X (82K) B 19229R109 7030005530 SRES ERJ2GEJ 100 X (10) B 21231R110 7030004980 SRES ERJ2GEJ 101 X (100) B 221254R112 7030004970 SRES ERJ2GEJ 470 X (47) B 258254R113 7030007300 SRES ERJ2GEJ 332 X (33K) B 242285R114 7030005090 SRES ERJ2GEJ 104 X (100K) B 274268R115 7030005090 SRES ERJ2GEJ 104 X (100K) B 31268R116 7030005310 SRES ERJ2GEJ 124 X (120K) B 354293R117 7030005090 SRES ERJ2GEJ 104 X (100K) B 334251R118 7030005310 SRES ERJ2GEJ 124 X (120K) B 364251R119 7030005100 SRES ERJ2GEJ 154 X (150K) B 364293R120 7030005710 SRES ERJ2GEJ 121 X (120) B 394251R121 7030007300 SRES ERJ2GEJ 332 X (33K) B 412277R122 7030004970 SRES ERJ2GEJ 470 X (47) B 433251R123 7030005530 SRES ERJ2GEJ 100 X (10) B 392298R125 7030008370 SRES ERJ2GEJ 561 X (560) B 356408R126 7030007290 SRES ERJ2GEJ 222 X (22K) B 39408R127 7030005090 SRES ERJ2GEJ 104 X (100K) B 373408R128 7030005010 SRES ERJ2GEJ 681 X (680) B 391444R132 7030005050 SRES ERJ2GEJ 103 X (10K) B 474176R134 7030005090 SRES ERJ2GEJ 104 X (100K) B 404403R135 7030007290 SRES ERJ2GEJ 222 X (22K) T 43367R136 7030007290 SRES ERJ2GEJ 222 X (22K) T 43376R137 7030008410 SRES ERJ2GEJ 392 X (39K) T 457351R138 7030005000 SRES ERJ2GEJ 471 X (470) B 43355R139 7030005090 SRES ERJ2GEJ 104 X (100K) B 483355R140 7030008410 SRES ERJ2GEJ 392 X (39K) B 465346R141 7030005240 SRES ERJ2GEJ 473 X (47K) B 465337R142 7030005090 SRES ERJ2GEJ 104 X (100K) B 465319R143 7030005040 SRES ERJ2GEJ 472 X (47K) B 483328R146 7030004970 SRES ERJ2GEJ 470 X (47) B 45644R147 7030005030 SRES ERJ2GEJ 152 X (15K) B 471422R148 7030005120 SRES ERJ2GEJ 102 X (1K) T 378314R149 7030007060 SRES ERJ2GEJ 684X (680K) T 378296R151 7030005600 SRES ERJ2GEJ 273 X (27K) B 51739R152 7030005210 SRES ERJ2GEJ 822 X (82K) B 539351R153 7030007300 SRES ERJ2GEJ 332 X (33K) B 555385R154 7030005210 SRES ERJ2GEJ 822 X (82K) B 575369R155 7030005600 SRES ERJ2GEJ 273 X (27K) B 588398R156 7030005120 SRES ERJ2GEJ 102 X (1K) B 203218R157 7030005120 SRES ERJ2GEJ 102 X (1K) B 31251R158 7030005120 SRES ERJ2GEJ 102 X (1K) B 594357R159 7030005290 SRES ERJ2GEJ 682 X (68K) B 297238R301 7030007340 SRES ERJ2GEJ 153 X (15K) B 684124R302 7030008010 SRES ERJ2GEJ 123 X (12K) B 666124R303 7030005720 SRES ERJ2GEJ 563 X (56K) B 675124R304 7030005030 SRES ERJ2GEJ 152 X (15K) B 693107R310 7030005220 SRES ERJ2GEJ 223 X (22K) T 662367R311 7030005220 SRES ERJ2GEJ 223 X (22K) T 646379R312 7030005220 SRES ERJ2GEJ 223 X (22K) T 646396R313 7030007300 SRES ERJ2GEJ 332 X (33K) T 626396R314 7030006610 SRES ERJ2GEJ 394 X (390K) T 637412R315 7030005080 SRES ERJ2GEJ 823 X (82K) T 637428R316 7030005000 SRES ERJ2GEJ 471 X (470) T 673428R317 7030005290 SRES ERJ2GEJ 682 X (68K) T 664396R318 7030005050 SRES ERJ2GEJ 103 X (10K) T 673396R321 7030007340 SRES ERJ2GEJ 153 X (15K) T 737277R322 7030008300 SRES ERJ2GEJ 184 X (180K) B 69133R323 7030005720 SRES ERJ2GEJ 563 X (56K) B 7033R324 7030005220 SRES ERJ2GEJ 223 X (22K) B 70933R325 7030005290 SRES ERJ2GEJ 682 X (68K) T 728295R326 7030005240 SRES ERJ2GEJ 473 X (47K) T 737295R327 7030005240 SRES ERJ2GEJ 473 X (47K) T 755295R328 7030005240 SRES ERJ2GEJ 473 X (47K) T 755277R329 7030005040 SRES ERJ2GEJ 472 X (47K) T 779295R330 7030005090 SRES ERJ2GEJ 104 X (100K) T 745329R331 7030005240 SRES ERJ2GEJ 473 X (47K) T 774316R341 7030005070 SRES ERJ2GEJ 683 X (68K) T 848311R342 7030005070 SRES ERJ2GEJ 683 X (68K) T 848294R343 7030005070 SRES ERJ2GEJ 683 X (68K) T 848277R344 7030005070 SRES ERJ2GEJ 683 X (68K) T 866277R345 7030005070 SRES ERJ2GEJ 683 X (68K) T 85726R346 7030005240 SRES ERJ2GEJ 473 X (47K) T 857243R347 7030005050 SRES ERJ2GEJ 103 X (10K) B 813154R348 7030005090 SRES ERJ2GEJ 104 X (100K) T 823346R349 7030005160 SRES ERJ2GEJ 105 X (1M) T 832346R350 7030005050 SRES ERJ2GEJ 103 X (10K) T 866243R351 7030008290 SRES ERJ2GEJ 183 X (18K) T 755243R352 7030005050 SRES ERJ2GEJ 103 X (10K) T 71812R353 7030005210 SRES ERJ2GEJ 822 X (82K) T 727102R354 7030005160 SRES ERJ2GEJ 105 X (1M) T 754102R355 7030005050 SRES ERJ2GEJ 103 X (10K) T 737243R359 7030005210 SRES ERJ2GEJ 822 X (82K) B 561105R360 7030007290 SRES ERJ2GEJ 222 X (22K) B 56196R361 7030005000 SRES ERJ2GEJ 471 X (470) B 251439R362 7030005060 SRES ERJ2GEJ 333 X (33K) B 51675R363 7030005000 SRES ERJ2GEJ 471 X (470) B 57887R364 7030005090 SRES ERJ2GEJ 104 X (100K) T 59555R366 7030005100 SRES ERJ2GEJ 154 X (150K) B 57896R368 7030005700 SRES ERJ2GEJ 274 X (270K) T 61787R369 7030005100 SRES ERJ2GEJ 154 X (150K) T 617104R370 7030005170 SRES ERJ2GEJ 474 X (470K) B 61711R371 7030005290 SRES ERJ2GEJ 682 X (68K) T 74584R372 7030009290 SRES ERJ2GEJ 562 X (56K) T 80284R373 7030005080 SRES ERJ2GEJ 823 X (82K) T 847102R374 7030008410 SRES ERJ2GEJ 392 X (39K) T 865102R375 7030005000 SRES ERJ2GEJ 471 X (470) T 85612R377 7030005060 SRES ERJ2GEJ 333 X (33K) T 847138R378 7030005050 SRES ERJ2GEJ 103 X (10K) T 865156R379 7030005700 SRES ERJ2GEJ 274 X (270K) T 847156R381 7030005700 SRES ERJ2GEJ 274 X (270K) T 709156R382 7030005170 SRES ERJ2GEJ 474 X (470K) T 718138R383 7030008310 SRES ERJ2GEJ 564 X (560K) T 709138R384 7030005090 SRES ERJ2GEJ 104 X (100K) T 809154R385 7030005310 SRES ERJ2GEJ 124 X (120K) T 745138

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

R386 7030005060 SRES ERJ2GEJ 333 X (33K) T 736138R387 7030005030 SRES ERJ2GEJ 152 X (15K) T 736156R388 7030008010 SRES ERJ2GEJ 123 X (12K) B 788137R389 7030005800 SRES RR0510P-102-D (1K) B 779137R390 7030005810 SRES RR0510P-152-D (15K) B 772155R391 7030007290 SRES ERJ2GEJ 222 X (22K) T 745156R393 7030005700 SRES ERJ2GEJ 274 X (270K) B 61778R394 7030005090 SRES ERJ2GEJ 104 X (100K) B 60862R395 7030005310 SRES ERJ2GEJ 124 X (120K) B 60878R396 7030005700 SRES ERJ2GEJ 274 X (270K) B 61762R397 7030008300 SRES ERJ2GEJ 184 X (180K) B 60846R398 7030005050 SRES ERJ2GEJ 103 X (10K) B 61794R401 7030005120 SRES ERJ2GEJ 102 X (1K) T 662358R402 7030005000 SRES ERJ2GEJ 471 X (470) B 685225R403 7030010040 SRES ERJ2GEJ-JPW B 675287R406 7030005090 SRES ERJ2GEJ 104 X (100K) B 127456R408 7030004980 SRES ERJ2GEJ 101 X (100) B 356463R412 7030005040 SRES ERJ2GEJ 472 X (47K) B 168383R413 7030005090 SRES ERJ2GEJ 104 X (100K) T 198322R414 7030005230 SRES ERJ2GEJ 334 X (330K) B 215349R416 7030005120 SRES ERJ2GEJ 102 X (1K) B 215358R417 7030007340 SRES ERJ2GEJ 153 X (15K) B 213371R418 7030005120 SRES ERJ2GEJ 102 X (1K) B 198379R420 7030005090 SRES ERJ2GEJ 104 X (100K) T 796323R421 7210003061 VAR TP76N00N-15F-A103-2251A R423 7030005090 SRES ERJ2GEJ 104 X (100K) T 69378R424 7030005090 SRES ERJ2GEJ 104 X (100K) T 52387R426 7030007340 SRES ERJ2GEJ 153 X (15K) B 69363R427 7030005230 SRES ERJ2GEJ 334 X (330K) B 68446R428 7030005030 SRES ERJ2GEJ 152 X (15K) B 65131R429 7030006610 SRES ERJ2GEJ 394 X (390K) B 66831R430 7030005160 SRES ERJ2GEJ 105 X (1M) B 71731R431 7030005050 SRES ERJ2GEJ 103 X (10K) B 666348R432 7030005040 SRES ERJ2GEJ 472 X (47K) B 705309R433 7030005050 SRES ERJ2GEJ 103 X (10K) B 675303R434 7030005050 SRES ERJ2GEJ 103 X (10K) B 70530R435 7030005050 SRES ERJ2GEJ 103 X (10K) B 768245R436 7030005040 SRES ERJ2GEJ 472 X (47K) B 75430R437 7030005050 SRES ERJ2GEJ 103 X (10K) B 84347R438 7030007290 SRES ERJ2GEJ 222 X (22K) T 48333R439 7030007290 SRES ERJ2GEJ 222 X (22K) T 83284R440 7030009280 SRES ERJ2GEJ 391 X B 175436R441 7030005050 SRES ERJ2GEJ 103 X (10K) B 208436R442 7030007280 SRES ERJ2GEJ 331 X (330) B 202337R451 7030005530 SRES ERJ2GEJ 100 X (10) B 852373R453 7030008010 SRES ERJ2GEJ 123 X (12K) B 879352R454 7030005220 SRES ERJ2GEJ 223 X (22K) B 87322R455 7030008010 SRES ERJ2GEJ 123 X (12K) B 861352R456 7030005050 SRES ERJ2GEJ 103 X (10K) B 876427R457 7030005040 SRES ERJ2GEJ 472 X (47K) T 80735R458 7030005120 SRES ERJ2GEJ 102 X (1K) B 81330R459 7030005120 SRES ERJ2GEJ 102 X (1K) B 80430R460 7410001140 SARR EXB28V104JX B 77730R461 7030005040 SRES ERJ2GEJ 472 X (47K) B 84308R462 7030005040 SRES ERJ2GEJ 472 X (47K) B 84299R463 7030005050 SRES ERJ2GEJ 103 X (10K) T 718377R464 7030005090 SRES ERJ2GEJ 104 X (100K) T 734348R466 7410001140 SARR EXB28V104JX B 69540R467 7410001140 SARR EXB28V104JX B 69537R468 7030008400 SRES ERJ2GEJ 182 X (18K) T 70416R469 7030009280 SRES ERJ2GEJ 391 X T 70395R470 7030005090 SRES ERJ2GEJ 104 X (100K) B 747461R471 7030007340 SRES ERJ2GEJ 153 X (15K) B 726454R472 7030005090 SRES ERJ2GEJ 104 X (100K) B 726472R473 7410001140 SARR EXB28V104JX B 777461R474 7030007340 SRES ERJ2GEJ 153 X (15K) B 726463R475 7030005090 SRES ERJ2GEJ 104 X (100K) B 79530R476 7030005120 SRES ERJ2GEJ 102 X (1K) B 759461R477 7030005120 SRES ERJ2GEJ 102 X (1K) B 852345 C1 4030011650 SCER C1005 CH 1H 1R5B-T B 8557C2 4030009720 SCER C1005 CH 1H 080C-T B 10657C3 4030011630 SCER C1005 CH 1H 0R5B-T B 1258C4 4030011650 SCER C1005 CH 1H 1R5B-T B 91105C5 4030009720 SCER C1005 CH 1H 080C-T B 107149C6 4030011630 SCER C1005 CH 1H 0R5B-T B 12510C7 4030019740 SCER C1005 JB 1H 102K-T B 14966C8 4030011670 SCER C1005 CH 1H 2R5B-T B 124149C9 4030011700 SCER C1005 CH 1H 040B-T B 124158C10 4030019740 SCER C1005 JB 1H 102K-T B 148134C11 4030019740 SCER C1005 JB 1H 102K-T B 165134C12 4030009720 SCER C1005 CH 1H 080C-T B 177118C13 4030009760 SCER C1005 CH 1H 150J-T B 197118C14 4030007050 SCER C1608 CH 1H 220J-T B 214103C18 4030019740 SCER C1005 JB 1H 102K-T B 198191C19 4030019740 SCER C1005 JB 1H 102K-T B 182192C20 4030019740 SCER C1005 JB 1H 102K-T T 335113C21 4030019740 SCER C1005 JB 1H 102K-T T 30859C22 4030019740 SCER C1005 JB 1H 102K-T T 39259C23 4030019930 SCER C1005 JB 1A 104K-T T 317113C24 4030019950 SCER C1005 JB 0J 224K-T T 35759C25 4030019810 SCER C1005 JB 1E 103K-T T 357113C26 4030019740 SCER C1005 JB 1H 102K-T T 36696C27 4030019740 SCER C1005 JB 1H 102K-T T 36676C28 4030019970 SCER C1005 JB 0J 105K-T T 37576C29 4030019740 SCER C1005 JB 1H 102K-T B 37391C36 4030011320 SCER C1005 CH 1H 470J-T B 238161C37 4030014260 SCER C1005 JB 1H 331K-T B 247161C38 4030019740 SCER C1005 JB 1H 102K-T B 327151C39 4030011320 SCER C1005 CH 1H 470J-T B 327141C45 4030011320 SCER C1005 CH 1H 470J-T B 327121C47 4030014260 SCER C1005 JB 1H 331K-T B 33291C51 4030011700 SCER C1005 CH 1H 040B-T B 391142C52 4030019740 SCER C1005 JB 1H 102K-T B 4189

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

6 - 3

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C53 4030014260 SCER C1005 JB 1H 331K-T B 427107C54 4030019740 SCER C1005 JB 1H 102K-T B 42798C55 4030009740 SCER C1005 CH 1H 100C-T B 391125C57 4030014260 SCER C1005 JB 1H 331K-T B 373108C59 4030019650 SCER C1005 CH 1H 050B-T B 43714C60 4030011320 SCER C1005 CH 1H 470J-T B 45589C61 4030019740 SCER C1005 JB 1H 102K-T B 472116C62 4030009720 SCER C1005 CH 1H 080C-T B 455116C63 4030019650 SCER C1005 CH 1H 050B-T B 474152C64 4030019740 SCER C1005 JB 1H 102K-T B 496121C65 4030019740 SCER C1005 JB 1H 102K-T B 51214C71 4030009740 SCER C1005 CH 1H 100C-T T 529177C72 4030019740 SCER C1005 JB 1H 102K-T B 554171C73 4030019740 SCER C1005 JB 1H 102K-T T 538193C74 4030019650 SCER C1005 CH 1H 050B-T T 583193C76 4030019740 SCER C1005 JB 1H 102K-T B 563188C77 4030019740 SCER C1005 JB 1H 102K-T T 646193C78 4030019740 SCER C1005 JB 1H 102K-T T 592199C79 4030019930 SCER C1005 JB 1A 104K-T B 645164C80 4030014260 SCER C1005 JB 1H 331K-T B 615236C81 4030011680 SCER C1005 CH 1H 030B-T T 583177C82 4030011320 SCER C1005 CH 1H 470J-T B 554188C83 4030011720 SCER C1005 CH 1H R75B-T T 583222C84 4030014260 SCER C1005 JB 1H 331K-T T 544227C85 4030019740 SCER C1005 JB 1H 102K-T T 544218C86 4030009710 SCER C1005 CH 1H 070C-T T 565245C87 4030009830 SCER C1005 CH 1H 180J-T T 544236C88 4030009830 SCER C1005 CH 1H 180J-T T 565254C89 4030009790 SCER C1005 CH 1H 330J-T T 568276C90 4030011650 SCER C1005 CH 1H 1R5B-T T 536276C91 4030019970 SCER C1005 JB 0J 105K-T B 596289C92 4030010080 SCER C1005 CH 1H 240J-T T 552276C93 4030014260 SCER C1005 JB 1H 331K-T B 576294C94 4030011320 SCER C1005 CH 1H 470J-T T 491264C101 4030011630 SCER C1005 CH 1H 0R5B-T T 595222C102 4030019930 SCER C1005 JB 1A 104K-T T 642206C103 4030019740 SCER C1005 JB 1H 102K-T T 642215C104 4030011700 SCER C1005 CH 1H 040B-T T 604238C105 4030009730 SCER C1005 CH 1H 090C-T T 642224C106 4030009760 SCER C1005 CH 1H 150J-T T 619251C107 4030009790 SCER C1005 CH 1H 330J-T T 606274C108 4030019650 SCER C1005 CH 1H 050B-T T 642233C109 4030019740 SCER C1005 JB 1H 102K-T B 617299C110 4030011630 SCER C1005 CH 1H 0R5B-T T 626264C111 4030020040 SCER C1005 CH 1H 200J-T T 615274C116 4030019970 SCER C1005 JB 0J 105K-T B 644277C117 4030013880 SCER C1005 JB 1H 222K-T B 635277C118 4030011320 SCER C1005 CH 1H 470J-T B 659249C120 4030019740 SCER C1005 JB 1H 102K-T B 617318C121 4030019490 SCER C2012 JB 1A 106K-T B 619193C122 4030019810 SCER C1005 JB 1E 103K-T B 609148C123 4030019740 SCER C1005 JB 1H 102K-T B 481279C124 4030019740 SCER C1005 JB 1H 102K-T B 547305C127 4030013890 SCER C1005 JB 1H 152K-T B 635299C132 4550000270 STAN TEESVA 1E 474M8R T 489295C133 4030019900 SCER C1005 JB 1A 473K-T T 467264C134 4550000460 STAN TEESVA 1C 105M8R T 467295C141 4030009840 SCER C1005 CH 1H 060C-T B 554204C142 4030009710 SCER C1005 CH 1H 070C-T B 535188C147 4030009710 SCER C1005 CH 1H 070C-T B 513195C149 4030019740 SCER C1005 JB 1H 102K-T T 467218C150 4030019740 SCER C1005 JB 1H 102K-T T 431203C152 4030019740 SCER C1005 JB 1H 102K-T T 431185C153 4030011320 SCER C1005 CH 1H 470J-T T 445326C154 4030011320 SCER C1005 CH 1H 470J-T T 436326C155 4030011320 SCER C1005 CH 1H 470J-T T 427326C156 4030019930 SCER C1005 JB 1A 104K-T T 486326C157 4030019810 SCER C1005 JB 1E 103K-T T 41194C158 4030009740 SCER C1005 CH 1H 100C-T T 392194C159 4030019930 SCER C1005 JB 1A 104K-T T 401109C160 4030019740 SCER C1005 JB 1H 102K-T T 419109C171 4030011700 SCER C1005 CH 1H 040B-T B 15316C172 4030011660 SCER C1005 CH 1H 020B-T B 153172C173 4030019740 SCER C1005 JB 1H 102K-T B 139188C175 4030011320 SCER C1005 CH 1H 470J-T B 139205C176 4030009780 SCER C1005 CH 1H 270J-T B 158239C177 4030009840 SCER C1005 CH 1H 060C-T B 158248C178 4030011660 SCER C1005 CH 1H 020B-T B 145252C179 4030009840 SCER C1005 CH 1H 060C-T B 158257C180 4030009780 SCER C1005 CH 1H 270J-T B 158266C181 4030009710 SCER C1005 CH 1H 070C-T B 17429C182 4030019740 SCER C1005 JB 1H 102K-T B 203227C183 4030019740 SCER C1005 JB 1H 102K-T B 203254C184 4030019930 SCER C1005 JB 1A 104K-T B 203263C186 4030019930 SCER C1005 JB 1A 104K-T B 19231C188 4030019740 SCER C1005 JB 1H 102K-T B 23231C189 4030019740 SCER C1005 JB 1H 102K-T B 239254C192 4030019740 SCER C1005 JB 1H 102K-T B 239272C194 4030019740 SCER C1005 JB 1H 102K-T B 221272C195 4030011670 SCER C1005 CH 1H 2R5B-T B 232285C196 4030009750 SCER C1005 CH 1H 120J-T B 274285C197 4030011630 SCER C1005 CH 1H 0R5B-T B 292289C198 4030009750 SCER C1005 CH 1H 120J-T B 31285C199 4030011670 SCER C1005 CH 1H 2R5B-T B 344268C200 4030009760 SCER C1005 CH 1H 150J-T B 344285C201 4030019740 SCER C1005 JB 1H 102K-T B 315238C203 4030019930 SCER C1005 JB 1A 104K-T B 297247C206 4030011320 SCER C1005 CH 1H 470J-T B 474166C208 4030011660 SCER C1005 CH 1H 020B-T B 374235C209 4030011660 SCER C1005 CH 1H 020B-T B 354235C210 4030019650 SCER C1005 CH 1H 050B-T B 354251C212 4030019740 SCER C1005 JB 1H 102K-T B 344235C213 4030011320 SCER C1005 CH 1H 470J-T B 384251C214 4030019740 SCER C1005 JB 1H 102K-T B 374251C215 4030009830 SCER C1005 CH 1H 180J-T B 422277

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C216 4030019740 SCER C1005 JB 1H 102K-T B 414251C217 4030019810 SCER C1005 JB 1E 103K-T B 404251C218 4030019810 SCER C1005 JB 1E 103K-T B 376298C220 4030009710 SCER C1005 CH 1H 070C-T B 404346C221 4030011320 SCER C1005 CH 1H 470J-T B 424251C223 4030019740 SCER C1005 JB 1H 102K-T B 433235C224 4030019740 SCER C1005 JB 1H 102K-T B 457176C225 4030019810 SCER C1005 JB 1E 103K-T B 39398C226 4030019810 SCER C1005 JB 1E 103K-T B 373444C227 4030019810 SCER C1005 JB 1E 103K-T B 356418C228 4030011630 SCER C1005 CH 1H 0R5B-T B 356398C231 4030010250 SCER C1005 CH 1H 101J-T B 409418C232 4030009770 SCER C1005 CH 1H 220J-T T 43386C233 4030019740 SCER C1005 JB 1H 102K-T B 40939C234 4030019810 SCER C1005 JB 1E 103K-T T 473351C235 4030019490 SCER C2012 JB 1A 106K-T B 445426C236 4030019740 SCER C1005 JB 1H 102K-T B 471431C238 4030019740 SCER C1005 JB 1H 102K-T B 413403C239 4030014260 SCER C1005 JB 1H 331K-T T 43396C240 4030019740 SCER C1005 JB 1H 102K-T B 447355C241 4030011320 SCER C1005 CH 1H 470J-T B 465328C242 4030019680 SCER C1005 CH 1H 181J-T B 483346C243 4030019680 SCER C1005 CH 1H 181J-T B 465355C244 4030019930 SCER C1005 JB 1A 104K-T B 50237C251 4030011680 SCER C1005 CH 1H 030B-T T 415346C252 4030010090 SCER C1005 CH 1H 560J-T T 394334C253 4030009840 SCER C1005 CH 1H 060C-T T 415336C254 4030010090 SCER C1005 CH 1H 560J-T T 394325C255 4030019810 SCER C1005 JB 1E 103K-T T 415296C256 4030009740 SCER C1005 CH 1H 100C-T T 392246C257 4030019810 SCER C1005 JB 1E 103K-T T 369314C261 4030019930 SCER C1005 JB 1A 104K-T B 505386C262 4030019810 SCER C1005 JB 1E 103K-T B 502407C263 4030019810 SCER C1005 JB 1E 103K-T B 571415C264 4030019810 SCER C1005 JB 1E 103K-T B 53936C265 4030019810 SCER C1005 JB 1E 103K-T B 587369C266 4030019810 SCER C1005 JB 1E 103K-T B 574351C267 4030019930 SCER C1005 JB 1A 104K-T T 509346C301 4030019930 SCER C1005 JB 1A 104K-T B 693124C302 4030019850 SCER C1005 JB 1E 183K-T B 666141C303 4030019690 SCER C1005 CH 1H 221J-T B 684107C304 4030019460 SCER C1608 JB 0J 106M-T T 62642C305 4030019900 SCER C1005 JB 1A 473K-T T 764329C306 4030019890 SCER C1005 JB 1A 393K-T T 655379C307 4030019930 SCER C1005 JB 1A 104K-T T 635396C308 4030019800 SCER C1005 JB 1H 682K-T T 655396C309 4030019860 SCER C1005 JB 1E 223K-T T 673412C310 4030019930 SCER C1005 JB 1A 104K-T T 626379C312 4030019850 SCER C1005 JB 1E 183K-T T 746295C313 4030019930 SCER C1005 JB 1A 104K-T T 77295C314 4030019750 SCER C1005 JB 1H 122K-T T 74626C316 4030019930 SCER C1005 JB 1A 104K-T T 774307C318 4030019810 SCER C1005 JB 1E 103K-T B 706287C321 4030019740 SCER C1005 JB 1H 102K-T T 857294C322 4030019740 SCER C1005 JB 1H 102K-T T 857277C323 4030019710 SCER C1005 JB 1H 391K-T T 84826C324 4030019810 SCER C1005 JB 1E 103K-T T 86626C325 4030011320 SCER C1005 CH 1H 470J-T T 87526C326 4030019810 SCER C1005 JB 1E 103K-T T 718156C328 4030019970 SCER C1005 JB 0J 105K-T T 728243C329 4030013910 SCER C1005 JB 1H 472K-T T 746243C330 4030019810 SCER C1005 JB 1E 103K-T T 727138C331 4030019810 SCER C1005 JB 1E 103K-T T 72712C332 4030013910 SCER C1005 JB 1H 472K-T T 736102C333 4030013910 SCER C1005 JB 1H 472K-T T 745102C334 4030019740 SCER C1005 JB 1H 102K-T B 15466C335 4030019740 SCER C1005 JB 1H 102K-T B 26439C336 4030019970 SCER C1005 JB 0J 105K-T B 56187C337 4030019740 SCER C1005 JB 1H 102K-T B 52575C338 4030019740 SCER C1005 JB 1H 102K-T B 50775C339 4030019740 SCER C1005 JB 1H 102K-T B 53475C340 4030019930 SCER C1005 JB 1A 104K-T B 578105C342 4030019740 SCER C1005 JB 1H 102K-T B 47164C343 4030019490 SCER C2012 JB 1A 106K-T B 57673C344 4030019930 SCER C1005 JB 1A 104K-T T 59564C346 4030019890 SCER C1005 JB 1A 393K-T T 79284C347 4030019810 SCER C1005 JB 1E 103K-T T 82284C348 4030019890 SCER C1005 JB 1A 393K-T T 81284C349 4030019930 SCER C1005 JB 1A 104K-T T 856102C350 4030019750 SCER C1005 JB 1H 122K-T T 865138C351 4030019690 SCER C1005 CH 1H 221J-T T 856156C352 4030019930 SCER C1005 JB 1A 104K-T T 86512C354 4030019930 SCER C1005 JB 1A 104K-T T 847232C356 4030019490 SCER C2012 JB 1A 106K-T B 76928C357 4030019810 SCER C1005 JB 1E 103K-T T 83233C358 4030019930 SCER C1005 JB 1A 104K-T T 82333C361 4030019930 SCER C1005 JB 1A 104K-T B 768222C362 4030019930 SCER C1005 JB 1A 104K-T B 721197C363 4030019930 SCER C1005 JB 1A 104K-T B 69287C364 4030013910 SCER C1005 JB 1H 472K-T B 60894C365 4030011320 SCER C1005 CH 1H 470J-T B 61746C371 4030013910 SCER C1005 JB 1H 472K-T T 73612C372 4030019680 SCER C1005 CH 1H 181J-T T 754138C373 4030019900 SCER C1005 JB 1A 473K-T T 745174C376 4030019740 SCER C1005 JB 1H 102K-T B 77137C377 4550007320 STAN F930J226MAABMA B 797171C378 4030019740 SCER C1005 JB 1H 102K-T B 772171C380 4030011320 SCER C1005 CH 1H 470J-T B 60811C381 4030019850 SCER C1005 JB 1E 183K-T B 6848C382 4030019850 SCER C1005 JB 1E 183K-T B 68463C383 4030009800 SCER C1005 JB 1H 471K-T B 69346C385 4030019930 SCER C1005 JB 1A 104K-T B 71741C388 4030019740 SCER C1005 JB 1H 102K-T B 20935C389 4030019740 SCER C1005 JB 1H 102K-T B 43628C390 4030019740 SCER C1005 JB 1H 102K-T B 53128

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

6 - 4

REF PARTS DESCRIPTION M

HV NO NO LOCATION

[MAIN-A UNIT]

C391 4030011320 SCER C1005 CH 1H 470J-T B 373463C393 4520000020 SNIO NOJC227M006 B 198409C395 4520000020 SNIO NOJC227M006 T 217371C397 4030019740 SCER C1005 JB 1H 102K-T T 26365C398 4030019740 SCER C1005 JB 1H 102K-T B 12232C399 4030019930 SCER C1005 JB 1A 104K-T B 222371C400 4550006250 STAN TEESVA 1A 106M8R T 129408C401 4030019930 SCER C1005 JB 1A 104K-T B 122376C403 4030019930 SCER C1005 JB 1A 104K-T B 158396C404 4030019930 SCER C1005 JB 1A 104K-T B 122385C405 4030019970 SCER C1005 JB 0J 105K-T B 193337C406 4030019740 SCER C1005 JB 1H 102K-T T 207322C408 4030019930 SCER C1005 JB 1A 104K-T T 52378C410 4030019740 SCER C1005 JB 1H 102K-T T 113393C412 4030019740 SCER C1005 JB 1H 102K-T T 65428C413 4030019740 SCER C1005 JB 1H 102K-T T 68448C414 4030019740 SCER C1005 JB 1H 102K-T T 81231C415 4030019740 SCER C1005 JB 1H 102K-T T 65308C416 4030019740 SCER C1005 JB 1H 102K-T T 61231C417 4030019740 SCER C1005 JB 1H 102K-T T 37308C421 4030019930 SCER C1005 JB 1A 104K-T T 75412C423 4030019810 SCER C1005 JB 1E 103K-T B 652384C424 4030019740 SCER C1005 JB 1H 102K-T T 638344C426 4030019810 SCER C1005 JB 1E 103K-T B 69303C427 4030019930 SCER C1005 JB 1A 104K-T T 73726C429 4030019810 SCER C1005 JB 1E 103K-T B 772257C430 4030019930 SCER C1005 JB 1A 104K-T T 659114C431 4510009870 SELE 10 CE 100 LD T 147271C432 4030019740 SCER C1005 JB 1H 102K-T T 143317C433 4030019930 SCER C1005 JB 1A 104K-T T 162322C434 4030019810 SCER C1005 JB 1E 103K-T T 143326C435 4030019740 SCER C1005 JB 1H 102K-T T 18322C436 4550007320 STAN F930J226MAABMA B 852444C437 4030019930 SCER C1005 JB 1A 104K-T T 171322C451 4030009790 SCER C1005 CH 1H 330J-T B 866385C452 4030009740 SCER C1005 CH 1H 100C-T B 861373C453 4030009770 SCER C1005 CH 1H 220J-T B 87352C454 4030019930 SCER C1005 JB 1A 104K-T B 861322C456 4030019930 SCER C1005 JB 1A 104K-T B 879322C457 4030019870 SCER C1005 JB 1A 273K-T B 868469C458 4030019930 SCER C1005 JB 1A 104K-T T 847455C459 4030019930 SCER C1005 JB 1A 104K-T B 852406C460 4030019930 SCER C1005 JB 1A 104K-T B 795461C461 4030019930 SCER C1005 JB 1A 104K-T B 804461C462 4030019930 SCER C1005 JB 1A 104K-T B 813461C465 4030019930 SCER C1005 JB 1A 104K-T T 77435C466 4030019810 SCER C1005 JB 1E 103K-T T 7935C467 4030019930 SCER C1005 JB 1A 104K-T B 852322 J51 6450000131 CON HSJ1102-018540 J52 6450002250 CON HSJ1456-010320 J53 6510021901 SCON BM02B-ASRS-TF(LF)(SN) T 305345 F51 5210000970 SFUS ERBSE3R00U T 107376 DS51 5040002670 SLED CL-165HRYG T 26379 MC51 7700002920 MIC EM9745P-38-G-01 ltHORgt S51 2260001900 SWI SW-149 (SKHLLD) S52 2260002800 SSWI SW-167 (SKQTLAE010) B 39218S53 2260002800 SSWI SW-167 (SKQTLAE010) B 48718S54 2250000670 ENC TP70TF5169-159F-3285 EP3 6910018460 SBEA MMZ1005Y102C-T T 637193EP4 6910018460 SBEA MMZ1005Y102C-T T 419194EP5 6910018460 SBEA MMZ1005Y102C-T T 41109EP6 6910014730 SBEA MPZ2012S331A-T B 22417EP11 6910021240 SBEA MMZ1005A152ET T 549245EP14 6910021240 SBEA MMZ1005A152ET T 604222EP51 6910018460 SBEA MMZ1005Y102C-T B 203466 MP3 8510016471 SCAS 2775 VCO CASE-1 T 588232MP4 6910014760 SPLA OG-503040 B 668184MP5 6910014760 SPLA OG-503040 B 17995

M=Mounted side (T Mounted on the Top side B Mounted on the Bottom side)S=Surface mount

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

7 - 1

[CHASSIS PARTS] REF ORDER

DESCRIPTION QTY NO NO

J1 6910021491 ANT CONNECTOR 106-1 1

SP1 2510001560 045P01202-02 1

W1 8900009640 OPC-963 1

EP1 0910065992 B-7262B 1

MP1 8010021710 3285 CHASSIS 1MP2 8210026010 3285 FRONT PANEL (Incl MP3ndash9) 1MP3 8210025830 3285 PTT PANEL 1MP4 8930080110 3285 PTT BUTTON 1MP5 8930080130 3285 PTT RUBBER 1MP6 8930079890 3285 LOCK PLATE 1MP7 8210025800 3285 BOTTOM PANEL 1MP8 8930080380 3285 SHAFT 1MP9 8930080180 SP NET (F) 1MP10 8930080170 3285 NAME SHEET 1MP11 8930080120 3285 LENS 1MP12 8930080620 O-RING (CF) 1MP13 8930080630 3285 SP PLATE 1MP14 8930042350 1922 MIC SHEET 1MP15 8930080410 3285 MIC SPONGE 1MP16 8930079900 3285 TERMINAL HOLDER 1MP17 8930080100 3285 PLUS TERMINAL 1MP18 8930080400 3285 MINUS TERMINAL 1MP19 8930069710 THERMALLY SHEET (BC) 1MP20 8830003390 VR NUT (AB) 2MP21 8930080090 3285 SIDE PLATE 1MP22 8930080150 3285 SIDE SEAL 1MP23 8930080140 3285 TOP SEAL 1MP24 8830003440 3285 ANT NUT 1MP25 8610014180 KNOB N-389 (Incl MP26) 1MP26 8610007510 KNOB SPRING NO7800 1MP27 8610014190 KNOB N-390 1MP28 8610007920 KNOB SPRING NO1500 1MP31 8810008761 SCREW BT B0 2X8 NI-ZC3 (BT) 2MP32 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 9MP33 8810009511 SCREW BT B0 2X4 NI-ZC3 (BT) 1MP34 8810009181 0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT) 2

[MAIN-A UNIT]

[ACCESSORIES]

REF ORDER DESCRIPTION QTY NO NO

J51 6450000131 HSJ1102-018540 1J52 6450002250 HSJ1456-010320 1J53 6510021901 BM02B-ASRS-TF (LF) (SN) 1

MC51 7700002920 EM9745P-38-G-01 1

S51 2260001900 SW-149 (SKHLLD) 1S52 2260002800 SW-167 (SKQT) 1S53 2260002800 SW-167 (SKQT) 1S54 2250000670 TP70TF5169-159F-3285 1

MP2 8510016461 2775 VCO COVER-1 1MP3 8510016471 2775 VCO CASE-1 1MP4 6910014760 OG-503040 1MP5 6910014760 OG-503040 1MP6 8930080760 SPONGE (KT) 1MP7 8930080770 INSULATION SHEET (MQ) 1

REF ORDER DESCRIPTION QTY NO NO

EP1 (Optional) FA-SC57U-1 1

EP2 (Optional) BP-264 EXP [USA-11] [USA-12] [EUR-21] [EUR-22] [UK-01] [UK-02] [EXP-11] [EXP-12] [EXP-21] [EXP-22] [EXP-01] [AUS-21] [AUS-22] [RUS-21] [RUS-22] 1 (Optional) BP-265 [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [EXP-03] [AUS-23] [RUS-23] 1

EP3 (Optional) BC-191 EXP [USA-11] [EUR-21] [UK-01] [EXP-11] [EXP-21] [AUS-21] [RUS-21] 1 (Optional) BC-192 EXP [USA-12] [EUR-22] [UK-02] [EXP-12] [EXP-22] [AUS-22] [RUS-22] 1 (Optional) BC-193 EXP [USA-13] [EUR-23] [UK-03] [EXP-13] [EXP-23] [AUS-23] [RUS-23] 1

EP4 (Optional) BC-123SA (L) [USA-11] [USA-13] [EUR-22] [EXP-11] [EXP-13] [EXP-22] [RUS-22] 1 (Optional) BC-147SA [USA-12] [EXP-12] 1 (Optional) BC-123SE (L) [EUR-21] [EUR-23] [EXP-21] [EXP-23] [RUS-21] [RUS-23] 1 (Optional) BC-123SV (L) [AUS-21] [AUS-23] 1 (Optional) BC-147SV [AUS-22] 1

MP1 (Optional) MB-124 1MP2 8210025840 3285 JACK PANEL 1MP3 8810004861 SCREW PH M2X6 ZK3 2

SECTION 7 MECHANICAL PARTS

Refer to ldquoBOARD LAYOUTSrdquo for the locationScrew abbreviations A B0 BT Self-tapping PH Pan head ZK Black NI-ZU Nickel-Zinc SUS Stainless

EP1EP2

MP1MP2

MP3

EP3 EP4

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

7 - 2

MP10(C)

MP6(C)

MP7(C)

MP18(C)

MP33(C)

S54(M)

MP16(C)

MP11(C)

MP12(C)

MP9(C)

MP3(C)

MP4(C)MP5(C)

MP24(C)

MP27(C)

MP25(C)

SP1(C)

MP2(C)

MP8(C)

MP1(C)

MP23(C)

MP22(C)

ANT PCB

J1(C)

MP13(C) MC51(M) MP2(M)

MP34times2(C)

MP34times2(C)

MP32(C)

MP32(C)

J52(M)

MP6(M)

J51(M)

MP21(C)

S51(M)

MP20times2(C)

MP31times2(C)

MP31times2(C)

MP19(C)

MP14(C)

MP17(C)

R421(M)

MP15(C)

W1(C)

MAIN UNIT

UNIT ABBREVIATIONS(C) CHASSIS PARTS(M) MAIN-A UNIT

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

8 - 1

SECTION 8 BOARD LAYOUTSThe combination of top side and bottom side of this

bull MAIN-A UNIT (TOP VIEW)

[SPEAKER MICROPHONE JACK]

Int SP

2 1

C20

C21

C22

C23 52C

42C

C26

C27

C28

C71

C73

C74

C77C7

8

38C18C

C84

C85

C86

C87

C88

C89C90 C92

C94

C101

C102

C103

C104

C105

C106

C107

C108

C110

C111

C132

C133

C134

C149

C150

C152

C153

C154

C155 C156

C157

C158

C159

C160

C232

C234

C239

C251

C252 C253

C254

C255

C256

C257

C267

C304

C305

C306

C307

C308

C309

C310

C312

C313

C314

C316

C321

C322

C323

C324

C325

C326

C328

C329

C330

C331

C332

C333

C344

C346

C347

C348

C349

C350

C351

C352

C354

C357

C358

C371

C372

C373

C395

C397

C400

C406

C408C4

10

C412

C413

C414

C415

C416

C417

C421

C424

C427

C430

C431

C432 C433

C434

C435

C437

C458

C465 C466

D11

D12

D14

D15

D16

D18

D35

DS51

EP3

EP4

EP5

EP11

EP14

F51

IC1

IC2

IC54

IC56

16CI95CI

85CI

IC62

J53 L23

L24

L31 L3

3

L36

L37

L40

L41

L42

MP3

Q6

Q8Q10

Q13 Q14

Q25

Q26

Q51

Q52

Q75 Q76

Q82

Q83

R11

R12

R13

R14

R15

R16

R17

R18

R41

R42

R45

R46

R53

R54

R55

R56

R57

R64

R76R77

R78

R80

R82

R83

R87

R88 R89

R135

R136

R137

R148

R149

R310

R311

R312

R313

R314

R315

R316

R317

R318

R321

R325

R326

R327

R328

R329

R330

R331

R341

R342

R343

R344

R345

R346

R348

R349

R350

R351

R352

R353

R354

R355

R364

R368

R369

R371

R372

R373

R374

R375

R377

R378

R379

R381

R382

R383

R384

R385

R386

R387

R391

R401

R407

R413

R420

R423

R424

R438

R439

R457

R463

R464

R468

R469

X1

X2

X51

UHF B7247B

-UNLK

-RMUR1

-TMUT

CL-

-NOIS

-SO

S5V

MMUT

-ADSW

KEY1-KEY2

-T1

-PAV

-R5V

PWON

RSSI-

-VCON-VOXV

CPU5-

DISC

AFON-

FUSE

BATV

BAL-

MOD-

REF

BALDISC-

MMUT

VREF

-SCK

R5C

-PDET

-HV

-T5V

-TMUT

-AFON

FI2

FI3

J51 J52

X51

IC61

IC59

IC56

X2

IC58

IC62

MC51

IC2

X1

AFO

RLED-

SDEC

-CDEC

LVIN

TLED

RMUT2

-APCV

-EPTT-ATX

-T2

PLST

IPTT

+5V

-TEMP

T1

H0 H5 H10 H15 H20 H25 H30 H35 H40 H45 H50 H55 H60 H65 H70 H75 H80 H85 H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

8 - 2

The combination of top side and bottom side of this

bull MAIN-A UNIT (BOTTOM VIEW)

MC51

[LOWER KEY] [UPPER KEY] [PTT SWITCH]

[ROTARY SELECTOR]

[VOLUME CONTROL]

J52 J51

C1C2

C3

C4

C5

C6

C7

C8

C9

C10

C11

C12C13

C14

C18

C19

C29

C36

C37

C38

C39

C45

C47

C51

C52

C53

C54C55

C57

C59

C60

C61 C62

C63

C64

C65

C72

C76

C79

C80

C82

C91

C93

C109

C116

C117

C118

C120C121

C122

C123

C124C127

C141

C142

C147

C171

C172

C173C175

C176

C177

C178

C179

C180

C181

C182

C183

C184

C186

C188

C189

C192 C194

C195

C196

C197C198

C199C200

C201

C203

C206

C208

C209C210

C212

C213

C214

C215

C216

C217

C218

C220

C221

C223

C224

C225

C226

C227

C228

C231

C233

C235C236

C238

C240

C241

C242

C243

C244

C261

C262

C263

C264

C265

C266

C301

C302

C303

C318

C334

C335

C336

C337

C338

C339

C340

C342

C343

C356

C361

C362

C363

C364

C365

C376

C377 C378

C380

C381C382

C383

C385C388C389

C390

C391

C393

C398

C399

C401

C403

C404

C405

C423

C426

C429

C436

C451

C452

C453

C454

C456

C457

C459

C460

C461

C462

C467

D1D2

D3D5

D6

D21

D22

D24

D26D28

D31

D32

D33

D34

D51

D52

D53

D55

EP6

EP51

FI1

IC3IC51

IC52

IC53

IC55

IC57

IC60 L1

L2

L3

L4L5L6

L7

L8L9

L11

L13

L14L15

L16

L18

L19

L20

L32

L35

L47

L48

MP4

MP5

Q1

Q2

Q3

Q4

Q9

Q11

Q12

Q15

Q17

Q19

Q21

Q22

Q23

Q24

Q27

Q58

Q59

Q63Q64

Q71Q72

Q73

Q74

Q81

Q84

Q85

R1

R2

R3

R4

R5

R6

R21

R22

R23

R26R27

R29

R30

R31

R32

R33

R34

R35

R43

R44

R51

R52

R63

R65

R66

R67

R68R70

R71

R72

R73

R81

R101

R102

R103

R104

R105

R106

R107

R108

R109

R110R112R113

R114

R115

R116

R117

R118R119

R120

R121

R122

R123

R125R126 R127

R128

R132

R134

R138R139

R140

R141

R142

R143

R146

R147

R151

R152

R153

R154

R155

R156

R157

R158

R159

R301

R302

R303

R304R322

R323

R324

R347

R359

R360

R361

R362

R363

R366

R370

R388

R389

R390

R393

R394R395

R396

R397

R398

R402

R403

R406

R408

R412

R414

R416

R417

R418

R426

R427

R428R429R430

R431

R432 R433R434

R435

R436

R437

R440

R441R442

R451

R453

R454

R455

R456

R458

R459 R460R461

R462

R466R467

R470

R471

R472

R473 R474

R475

R476

R477

S52S53

-CL

PWON-RES

MOD-

+5VS5V-

SDEC-

S5V

-VCONTMUT- PDET-

T1-

-RSSI

PWON

-SQIN

+5V

NWC

CPU5-

-REF

-TEMP-VREF

MMUT-

-R5V

IC60

IC3 IC55

IC52

S52S53

LVA

-EPTT-ATX

DISC-

APCV

H0H5H10H15H20H25H30H35H40H45H50H55H60H65H70H75H80H85H90V0

V5

V10

V15

V20

V25

V30

V35

V40

V45

V50

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

9 - 1

SECTION 9 BLOCK DIAGRAM

LPF

LPF PWRDET

D1RB886CSD2RB886CS

MUTESW

LDTA144EEQ6

ANTSW

D22HVD142AD3HVD142A

PWRAMP

Q1RD07MUS2B

TXRXSW

D6HVD142AD5HVD142A

Q132SC4226D12HVD350B

Q142SC4226D16HVD350B

FILRIPPLE

Q152SC4116

VCOSW

Q11LDTC144EE

FILLOOP

PLLIC

IC2M B15A02

X3

Q262SC4116

FMMOD

D151SV309

Q233SK293

BPFRFAMP

Q223SK293

APCAMP

IC1TA75S01F

BPFXTAL

FI1FL-442

IFAMP

Q242SC4215

BUFF

Q82SC5107

BUFF

Q102SC5107

BUFF

Q92SC5107

BUFF

Q172SK880

DRIVEAMP

Q2RD01MUS1

X2CR-794

TCXO DRIVEPRE

Q32SC3356

LVADJ

D14HVD376B

LVADJ

D11HVD376B

BUFF

IC60NJM12902

VOL1

R133

PREAMP

Q42SC5107

VCOSW

Q12LDTC144EE

LPF

BPF

D28HVB350B

BPF

D26HVB350B

BPF

D24HVB350B

F51

ERBSE3R00U

12

PTTDET

Q58UNR911HG0

AFAMP

IC55 TPA0211DGN

AMP

NJM12902IC58

MICMUTE

IC62CD4066

J52

IC62CD4066

RXMUTE

LPF

LM2902IC59

T5REG

Q73KTA2015

SP1

BEEPSW

IC61CD4053

VOL1

R133

REG+5V

Q742SB1132Q75XP6501Q76LDTC144EE

CTRL

Q82Q83LDTA144EE

REGS5

Q71KTA2015

VOL1

R132

HPF

IC58NJM12902

BEEPSW

IC61CD4053

BATTERY_1

BT1

R88

SHIFTSW

D521SS390

AF VOL

R1

SW12

S1

PUSH1

PTT

PUSH1

P2

SW12

S2

EEPROM

IC52R1EX24016

MC51

EM9745P

LPF

XP4601Q51

D51LRB706FQ81UNR9210G0

CLONEBUFF

PWRCTRL

Q632SB1132Q64XP6501

AFAMP

SW12

S3

LPF

IC59LM2902

HPF

IC58NJM12902

J53

12

DET

D53L1SS400

SELECT

S54TP70TF5169

RESET

IC53NJU7704

SWFIL

Q52LDTC144EE

AMP

NLM12902IC60

SW12

S5

LPF

IC58NJM12902

Splatter

SW12

S4

CPU5REG

IC54NJM2871

LPF

NJM12902IC60

VOL1

R132

REGR5

Q722SA1586

PUSH1

P1

J51

X51CR-864

AUTO_TXCTRL

Q59LDTC144EE

AMP

NLM12902IC60

WNSW D33D341SS390

Q27LDTA144EE

X1

JTBM450CX70

WNSW

Q25LDTC144EE

BPFCERAMIC

FI2LTM450GW

BPFCERAMIC

LTM450HWFI3

WNSW

D31D321SS390

LPF

HR

YG

DS51CL-165HR

MIC_GAINCTRLCD4066

IC62

LPF

IC59LM2902

BPF

D28HVB350B

AGCCTRL

Q212SK1829

T5V

RMUT2

MMUT

RMUT1

DA

IF IC

LVIN

S5V

R5V

RX VCO

TX VCO

T2 T1

T1

TMUT

IC3NJM2591

REF

BAL

153MHz

459MHz

DISC

SQIN

4635MHz

MIXER

RSSI

LV

LVA

400-470MHz

35365 MHz-42365 MHz

R5C

VCON

VOXV

F1

S5C

VCC

R5C

MOD

ATX

+5V

12288MHz

T5C

BEEP

S5V

IC51

EPTT

AFVICPU

TBEEP

CSFT

R5V

CPU5

F2

IC56

CDEC

DUSE

DISC

CD4066

IC57

RES

SW

AFON

CTCSSDTCS DEC

PWON

ANALOG

R2A20178

SDEC

CENC0-2

RBEEP

TEMP

IPTT

CTCSSDTCS

SENC

VCC

VCC

CPU5

AFON

T5V

REFLVA

RSSI450kHz

450kHzNWC

NOIS

KEY1

KEY2

R4F20102

AFO

AFO

MGC0

MGC1

T1T2

RMUT1

MMUT

T5C

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

10 - 1

SECTION 10 VOLTAGE DIAGRAM

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (12)

J53

12

34

CP05SCP6

T5V

R5C

22k

R454

10k

R433

33k

R386

68k

R344

68k

R341

R1EX24016ATA00A

IC521

A02

A13

A24

VSS5

SDA

6SCL

7WP

8VCC

SW-167

S53

TMUT

R310

22k

DISC

LM2902PWRIC59

V+4

GND11

47k

R462

XP6501

Q64

1234 5 6

100k

R420

R2A20178IC57

1VIN2

2VDD

3LD

4CLK

5DI

6VIN3

7VOUT3

8VOUT4

9VIN4

10VIN5

11VOUT5

12VOUT6

13

VIN6

14

VDAREF1

15

VDAREF2

16

RESET

17

GND

18

VIN7

19VOUT7

20VOUT8

21VIN8

22VIN1

23VOUT1

24VOUT2

25

ERBSE3R00U

F5112

47k

R436

UNLK

100k

R423

LM2902PWR

IC599

108

SCK

68k

R343

NJM12902V

IC589

108

LRB706F

D51

100k

R475

10k

R431

RSSI

12k

R453

TEMP

12k

R455

12k

R302

1k

R416

+5V

NWC

SW-167

S52

47k

R329

NJM12902V

IC586

57

100k

R460

33k

R313

LM2902PWR

IC5913

1214

47k

R327

22

C436

470

R375

MOD

LDTC144EEQ59

NJM12902VIC58

V+4

GND11

1k

R476

TPA0211DGN

IC551

IN2

SHUTDOWN3

VDD4

BYPASS5

VO+

6SEBTL

7GND

8VO-

9

VCON

1M

R430

1SS390

D52

10k

R350

NJM12902V

IC5813

1214

100k

R467

10k

R318

CP05SCP7

180k

R322

56k

R323

L1SS400

D53

NJU7704F3

IC531

CD2

VSS3

MR4

VOUT

5VDD

SQIN

CP05SCP12

CR-864X51

CD4053B

IC61

1Y1

2Y0

3Z1

4Z

5Z0

6INH

7VEE

8VSS

9C

10

B

11

A

12

X0

13

X1

14

X

15

Y

16

VDD

22

C377

68k

R345

68k

R342

10k

R434

47k

R461

120k

R385

10k

R437

18k

R468

J52

15k

R426

47k

R326

R398

10k

NJM12902V

IC582

31

33k

R362

LDTC144EE

Q76

2SA1586

Q72

NOIS

KTA2015

Q73

R379

270k

XP6501Q75

1 2 3456

LVA

22k

R324

100kR473

100k

R330

15k

R304

470

R361

LDTA144EE

Q83

CP05SCP8

100k

R364

390

R469

CD4066BPWR

IC561

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

CP05SCP9

10kR456

TP76N00N

R421

LDTC144EE

Q52

100

R408

T1

1k

R401

R312

22k

15k

R474

S5V

R5V

10k

R463

330k

R427

SW-149

S51 100k

R470

100k

R464

R311

22k

UNR9210G0Q81

15k

R301

J51

470

R402

SO

1k

R458

15k

R471

47k

R328

PLST

HR

YG

CL-165HR

DS51

XP4601Q51

1

2

34

5

6

CP5CP06S

100k

R348

100k

R424

47k

R346

R396

270kR397

180k

LM2902PWR

IC592

31

10k

R378

CP05SCP10

LDTA144EE

Q82

MMZ1005Y102CT EP51

100k

R472

T2

100

C431

56k

R303

10 MSVA

C400

10k

R435

100k

R384

HV

68k

R371

1k

R459

LVIN

10

R451

CP05SCP11

100k

R466

2SB1132Q63

2SB1132

Q74

1k

R418

100kR413

L1SS400

D55

100k

R406

EM9745P

MC51

470

R363

47k

R457

10k

R347

47k

R432

KTA2015Q71

R394

100k

15k

R321

68k

R325

270k

R381

56k

R372

TP70TF5169

S541

A12

C13

B14

A25

C26

B27

A38

C39

B3

1k

R477

R374

39k

CD4066BPWR

IC621

IO12

O I13

O I24

IO25

CONT26

CONT37

VSS8

IO3

9OI3

10OI4

11IO4

12CONT4

13CONT1

14VDD

NJM12902V

IC602

31

NJM12902V

IC609

108

NJM12902V

IC60

6

57

NJM12902V

IC60

13

1214

NJM12902V

IC60

V+4

GND11

220

C393

LDTC144EEQ84

LDTC144EEQ85

390

R440

10k

R441

UNR911HG0Q58

10k

R352

82k

R353 1M

R354

82k

R373

47k

R412

330

R442

330k

R414

22k

R360

01

C301

01

C310

0018

C302

0047

C305

220P

C303

0039

C306

01C307

0022

C309

001

C330

001

C331

00047

C333

00047

C332

0001

C335

0001

C337

0001

C338

0001

C339

01

C340

01

C344

0018

C381

0018

C382

0001

C388

0001

C389

0001

C390

0001

C397

01

C404

01

C403

01

C399

1C405

0001

C398

0001

C406

0001

C410

0001

C413

0001

C412

0001

C416

0001

C414

0001

C415

0001

C417

0001

C435

0001

C432

0001

C424

001

C423

001

C426

001

C429

01

C427

01

C421

01

C430

01

C433

01

C437

01

C454

01

C456

01

C458

01

C459

01

C467

001

C466

0027

C457

33P

C451

10P

C452

22P

C453

01

C465

01C462

01C460

01C461

01C313

0018

C312

00012

C314

01

C316

0001

C321

0001

C322

390P

C323

001

C324

47P

C325

01

C349

01

C352

01

C354

01

C358

001

C326

00047

C371

180P

C372

00047

C364

47P

C365

01

C361

01

C362

01

C363001

C318

0001

C334

01

C401

0001

C376

0001

C378

220

C395

001

C434

01

C408

LM2902PWR

IC596

57

18k

R351

10k

R355

1

C328

00047

C329

22k

R438

R393

270k

R395

120k

0

R403

NJM2871BF05

IC541

CTRL2

GND3

NB4

VOUT

5VIN

150k

R366

150k

R369470k

R370

270k

R368

47P

C391

82k

R359

1

C336

33k

R377

220P

C351

10

C304

R314

390k

R315

82k

R316

470

68k

R317

00068

C308

0001

C342

470k

R382

560k

R383

001

C357

47k

R331

0039

C346

0039

C348

001

C347

10

C343

10

C448

10

C356

1M

R349

47 MSVB2

C379

47P

C380

00012

C350

18

R405

15k

R417

15k

R387

0047

C373

22k

R439

22k

R391

15k

R428

390k

R429

470P

C383

01

C385

15k

R390

1k

R389

12k

R388

R4F20102NFAIC51

1PB6AN6DA0

2PB7AN7DA1

3AVCC

4X2

5X1

6AVSS

7RES

8TEST

9VSS

10PJ1OSC2

11PJ0OSC1

12VCC

13P37TXD_3

14P36_RXD_3

15P35SCK3_3

16P34FTCI

17

P33FTIOD

18

P32FTIOC

19

P31FTIOB

20

P30FTIOA

21

P15IRQ5

22

P16IRQ6

23

P17IRQ7

24

P54SSO

25

P55SSCK

26

P56SDASCS

27

P57SCLSSI

28

P53TGIOB

29

P52TGIOA

30

P51TCLKB

31

P50TCLKA

32

P63FTIOD0

33P62FTIOC034P61FTIOB035NMI36P60FTIOA037P64FTIOA138P65FTIOB139P66FTIOC140P67FTIOD141P85TRAIO42P86TRBO43P87TREO44P20SCK345P21RXD46P22TXD47P23TRCOI48P25SCK3_2

49

P26RXD_2

50

P27TXD_2

51

P24TRDOI_0

52

P11IRQ1

53

P12IRQ2

54

P13IRQ3

55

PA4

56

PA5

57

PA6

58

PA7

59

PB3AN3

60

PB2AN2

61

PB1AN1

62

PB0AN0

63

PB4AN4

64

PB5AN5

SCK

T2

T5C

ESDA

PWON

KEY1

CENC1

KEY1

NWC

RBEEP

VOXV

VCON

RLED

RLED

S5V

SO

RMUT2

RSSI

IPTT

SCK

TMUT

CENC1

CBI0

NMI

HV

CL

MOD SO

NOIS

RES

REF

DAST

AFVI

T5V

T1

UNLK

S5V

DUSE

RBEEP

R5C

HV

ADSW

UNLK

LVA

RMUT1

SQIN

CBI3

BAL

LVIN

CBI2

S5C

DUSE

PLST

BEEP

STONE

MMUT

VOXV

OPT2

BATV

IPTT

MMUT

TBEEP

TBEEP

R5C

SDEC

ATX

RMUT1

STONE

KEY2

CENC0

RES

T2

R5V

MGC1

CLO

CBI1

DAST

ESCL

T1

TEMP

CENC2

TEMP

RMUT2

SO

D ISC

CENC0

TLED

TLED

RSSI

CSFT

T5C

SENC

SENC

PLST

LVA

AFO

TMUT

AFON

LVIN

KEY2

+5V

EPTT

R5C

MOD

BEEP

CDEC

S5C

CENC2

OPT1

MGC0

BATV

NOIS

SCK

OPT1

OPT2

CL T5C

DISC

+5V

+5V

DISC

SQIN

VCON

NWC

VREF

CDEC

VREF VREF

DISC

VREF

RMUT1

MMUT

VREF

VREF

AFO

AFVI

AFON

+5V

S5V

R5V

T5V

NMI

VREF

AFON

SDEC

+5V

VCC

EPTTCPU5

CPU5

CPU5

ATX

+5V+5V

+5V

PWON

S5V

CBI1CBI2CBI3CBI0

T5V

DUSE

CTCSSDTCS FILTER

ATXEPTT

IPTT

KEY1

KEY2

CL

CPU5

CPU5

VREF

+5V

CPU5

RX

TX

A

B

CD

D

A

D

B

B

C

C

A

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

10 - 2

Refer to the PARTS LIST for the value and name of component

MAIN-A UNIT (22)

Q3

2SC3356

L15

12N

Q26

2SC4116

R17

270

Q8

2SC5107

R12

10k

R45

100

R13

100k

R76

1k

1k

R4

1k

R3

Q223SK293

C134

1 SVA

183N

L7

R52

560

R146

47

R15

470k

R31

100

R56

68k

R54

68k

R83 56

RD01MUS1Q2

MB15A02PFV1

IC21

OSCIN2

OSCOUT3

VP4

VCC5

DO6

GND7

LD8

FIN9

CLOCK

10DATA

11LE

12FC

13NC

14FOUT

15P

16B

10k

R107

L40

58N

R82

10k

R71

10k

10

R21

R102

470k

Q152SC4116

Q92SC5107

R67

22k

R109 10

082U

L4

R106

47k

220

R6

Q42SC5107

2SK1829Q21

150k

R81

R101

220k

CP1

CP06S

L36

030-09

103NL3

R78

1k

R132

10k

R35

47k

ANT_BOARD

R34 100

R134

100k

R30

22k

47k

R22

R73 47k

L20

056U

136N

L2

R55

68k

Q17

2SK880

47k

R27

L13

22N

28N

L5

R33

10k

L14

22N

33k

R23

R64 10

R46

100k

R29 47

Q102SC5107

2775MP3

1 2 3 4

R110

100

L11

22N

R53

68k

R70

120kC132

047 SVA

R108

82k

R103 18k

136N

L1

28N

L6

R77 39k

R57

47

47

R26

120k

R118

LTM450GW

FI2

IO

MMZ1005Y102CTEP4

R80

1k

MMZ1005Y102CTEP5

CR-794

X21

VCON

2GND

3OUT

4VCC

82k

R152 27k

R151

27k

R155

100k

R89

ERTJ0EP473J

R88

TA75S01F

IC1

1

2

34

5

R104

10k

R105

10k

R114

100k

R115

100k

MMZ1005Y102CT

EP3

D15

1SV309

Q13

2SC4226

Q142SC4226

R87

100k

R16

10

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

Q23

3SK293

LVIN

TEMP

DISC

NOIS

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

UNLK

RSSI

33k

R153

82k

R154

D24HVB350BYPTL

1 234

D26

HVB350BYPTL

1 234

D28

HVB350BYPTL

1 234

NJM2591V

IC31

OSCIN2

OSCOUT3

MIXOUT4

V+5

IFIN6

DEC7

FILOUT8

FILIN9

AFOUT

10QUAD

11IFOUT

12RSSI

13NOISEDET

14NOISEREC

15GND

16MIXIN

R72

100

R32

22k

27k

R2

27k

R5

RD07MUS2B

Q1

R138

470

R5C

RB886CS

D1

RB886CS

D2

1SS390

D31

1SS390

D321SS390

D33

1SS390

D34

L31

33N

L32

33N

L33

22N

L19

56N

18N

L47

FL-442

FI1

1IN

2OUT

3GND

4GND

56

R14

120k

1k

R18

R147

15k

R122

47

R112

47

100k

R117

150k

R119

R116

120k

R120

120

MMZ1005A152ET

EP11

MMZ1005A152ET

EP14

MPZ2012S331AEP6

68k

R1

OG-503040

MP4

1k

R156

1k

R157

R148

1k

LDTA144EE

Q27

LDTA144EE

Q6

Q11

LDTC144EE

Q25LDTC144EE

D21

L1SS400

D18L1SS400

LDTC144EEQ12

R41

10

L8

12N

L9

18N

R51

680

L18

39N

470k

R68

HVD376B

D11

R11

27k

HVD376B

D14

D12

HVD350B

D16

HVD350B

LDTC144EEQ19

1k

R158

LTM450HWFI3

I O

X1

JTBM450CX70

R113

33k

R121

33k

R143

47k

R142

100k

L1SS400

D35

R42

68k

R43

100

R149

680k

L24

018U

L23

018U

8P

C2

8P

C5

15P

C425P

C8

4P

C9

05P

C3

05P

C6

0001

C7

0001

C10

0001

C11

0001

C19

0001

C18

0001

C38

0001

C52

0001

C54

8P

C12

15P

C13

47P

C36

47P

C39 330P

C37

330P

C47

0001

C21

0001

C22

0001

C20

0001

C26

0001

C27

022C24

01

C23

001

C25

0001

C29

1

C28

330P

C57

5P

C59

8P

C62

5P

C63

10P

C71

47P

C60

0001

C61

0001

C64

0001

C65

0001

C72

0001

C73

0001

C77

0001

C78

0001

C76

3P

C81

01

C79

075P

C83

330P

C80

330P

C84

01

C102

0001

C103

0001

C85

0001

C109

18P

C87

18P

C88

9P

C105

33P

C89

33P

C107

47P

C94

0001

C120

001

C122

330P

C93

0047

C133

0001

C123

0001

C124

47P

C118

47P

C153

47P

C154

47P

C155

01

C156

0001

C150

0001

C152

0001

C149

7P

C147

7P

C142

0001

C189

0001

C192

0001

C188

0001

C194

0001

C183

0001

C182

4P

C171

6P

C177

6P

C179

0001

C173

01

C184

2P

C178

01

C203

0001

C201

0001

C212

0001

C216

0001

C223

0001

C214

0001

C224

12P

C196

15P

C200

47P

C213

47P

C221

18P

C215

001

C217

001

C227

001

C226

001

C225

001

C218

7P

C220

100P

C231

22P

C232

001

C234

0001

C233

0001

C240

0001

C238

330P

C239

47P

C241

0001

C236

001

C262

001

C263

001

C265

001

C264

01

C261

01

C244

01

C267

001

C266

3P

C251

6P

C253

56P

C252

56P

C254

001

C255

001

C257

001

C157

10P

C158

0001

C160

01

C159

4P

C51

330P

C53

5P

C74

15P

C106

05P

C110

1C116

7P

C181

01

C186

47P

C206

2P

C208

2P

C209

5P

C210

10P

C256

R125

560

05P

C228

15P

C90

24P

C92

00015

C127

1

C91

1U

L35

1U

L37

1U

L42

20P

C111

HVD142A

D3

D22

HVD142A

22P

C14

R135

22k

22k

R136

R137

39k

D5HVD142A

D6

HVD142A

25P

C199

L16

12N

12P

C198

25P

C195

2P

C172

27P

C176

27P

C180

47P

C175

68k

R159

10P

C55

OG-503040

MP5

R139

100k

R140

39k

180P

C242

180P

C243

R141

47k

05P

C101

6P

C141

R44

100k

22k

R63

R65

27k

00022

C117

R66

150k

47P

C82

47P

C45

10N

L48

R128

680

R126

22k

R127

100k

Q24

2SC4215

05P

C197

4P

C104

5P

C108

047U

L41

10

R123

7P

C86

10

C235

10C121

15P

C1

NWC

PLSTSOSCK

NWC

SQIN

TEMP

LVIN

UNLK

HV

+5V

S5V

R5V

T5V

SO

SCK

PLST

NWC

TMUT

MOD

VCON

SQIN

LVA

T1

T2

LVIN

TEMP

DISC

NOIS

MOD

RSSI

LVA

NOIS

RSSI

DISC

R5C

T1

VCON

RSSI

T2

T1

UNLK

R5C

R5C

+5V

S5V

+5V

S5V

PAV

WNC

WNC

TMUT

T5V

R5V

R5V

APCVT5V

S5V

HV

R5V

X3 MULTI

T5V

TX VCO

APC

S5V

RX VCO

T5V

LPF

IF AMP

PLL

AGC

VCOV

HV

IF IC

RF AMP

T5V

MIX

HV

R5C

R5V

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

6F No68 Sec 1 Cheng-Teh Road Taipei Taiwan ROCPhone +886 (02) 2559 1899 Fax +886 (02) 2559 1874URL httpwwwasia-icomcomE-mail salesasia-icomcom

Zac de la Plaine 1 Rue Brindejonc des Moulinais BP 580431505 Toulouse Cedex FrancePhone +33 (5) 61 36 03 03 Fax +33 (5) 61 36 03 00URL httpwwwicom-francecomE-mail icomicom-francecom

Blacksole House Altira Park Herne Bay Kent CT6 6GZ UKPhone +44 (01227) 741741 Fax +44 (01227) 741742URL httpwwwicomukcoukE-mail infoicomukcouk

Ctra Rubi No 88 Bajos A 08174 Sant Cugat del Valles Barcelona SpainPhone +34 (93) 590 26 70 Fax +34 (93) 589 04 46URL httpwwwicomspaincomE-mail icomicomspaincom

ltCorporate Headquartersgt2380 116th Avenue NE Bellevue WA 98004 USAPhone +1 (425) 454-8155 Fax +1 (425) 454-1509URL httpwwwicomamericacomE-mail salesicomamericacomltCustomer ServicegtPhone +1 (425) 454-7619

Glenwood Centre 150-6165Highway 17 Delta BC V4K 5B8 CanadaPhone +1 (604) 952-4266 Fax +1 (604) 952-0090URL httpwwwicomcanadacomE-mail infoicomcanadacom

Unit 1 103 Garden Road Clayton VIC 3168 AustraliaPhone +61 (03) 9549-7500 Fax +61 (03) 9549-7505URL httpwwwicomnetauE-mail salesicomnetau

146A Harris Road East TamakiAuckland New ZealandPhone +64 (09) 274 4062 Fax +64 (09) 274 4708URL httpwwwicomconzE-mail inquiriesicomconz

10C07 Long silver Mansion No88 Yong DingRoad Haidian District Beijing 100039 China Phone +86 (010) 5889 539153925393 Fax +86 (010) 5889 5395

URL httpwwwbjicomcomE-mail bjicombjicomcom

81-850 Sopot ul 3 Maja 54 PolandPhone +48 (58) 550 7135 Fax +48 (58) 551 0484E-mail icompolskaicompolskacompl

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 JapanPhone +81 (06) 6793 5302Fax +81 (06) 6793 0013URL httpwwwicomcojpworldindexhtml

Communication EquipmentAuf der Krautweide 2465812 Bad Soden am Taunus GermanyPhone +49 (6196) 76685-0 Fax +49 (6196) 76685-50URL httpwwwicomeuropecomE-mail infoicomeuropecom

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER

1-1-32 Kamiminami Hirano-ku Osaka 547-0003 Japan S-14617XZ-C1copy 2009 Icom Inc

• ADDENDUM Apr 2010
• • REPLACEMENT PAGES FOR THE SPECIFICATIONS13
  • REPLACEMENT PAGES FOR THE ADJUSTMENT PROCEDURE (5-3 to 5-5 5-7)13
  • PARTS LIST
  • BOARD LAYOUTS
  • VOLTAGE DIAGRAM
  • • ADDENDUM Feb 2010
    • • REPLACEMENT PAGES (1-1 and 1-2)
      • REPLACEMENT PAGE(5-3 5-5 and 5-7)
      • PARTS LIST
      • BOARD LAYOUTS
      • VOLTAGE DIAGRAM
      • • ADDENDUM Dec132009
        • • PARTS LIST
          • BOARD LAYOUTS
          • VOLTAGE DIAGRAM
          • • FRONT13COVER
            • INTRODUCTION
            • TABLE OF CONTENTS
            • 1 SPECIFICATIONS
            • 2 INSIDE VIEWS
            • 3 DISASSEMBLY INSTRUCTION13
            • 4 CIRCUIT DESCRIPTION13
            • • RECEIVE13 CIRCUITS
              • TRANSMIT 13CIRCUITS
              • FREQUENCY SYNTHESIZER CIRCUITS
              • VOLTAGE BLOCK DIAGRAM
              • PORT ALLOCATION13
              • • 5 ADJUSTMENT 13PROCEDURE
                • • PREPARATION
                  • FREQUENCY ADJUSTMENT
                  • TRANSMIT ADJUSTMENT
                  • RECEIVE ADJUSTMENT
                  • • 6 PARTS LIST13
                    • • MAIN-A UNIT13
                      • • 7 MECHANICAL PARTS13
                        • 8 BOARD LAYOUTS13
                        • 9 BLOCK DIAGRAM13
                        • 10 VOLTAGE DIAGRAM13
                        • • MAIN-A 13UNIT
                          • • ADDRESS
                            • BACK COVER