icom ic f 11 - f 12 series

SERVICEMANUAL

VHF TRANSCEIVERS

1-1-32, Kamiminami, Hirano-ku, Osaka, 547-0003, JapanS-13806IZ-C1V

© 2001 Icom Inc.

iF11 seriesiF12 series

INTRODUCTION

DANGER

ORDERING PARTS

REPAIR NOTES

This service manual describes the latest service informationfor the IC-F11/IC-F11S/IC-F11BR/IC-F12/IC-F12S VHSTRANSCEIVERS at the time of publication.

NEVER connect the transceiver to an AC outlet or to a DCpower supply that uses more than 8 V. Such a connectioncould cause a fire or electric hazard.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when con-necting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100mW)to the antenna connector. This could damage the transceiv-er’s front end.

Be sure to include the following four points when orderingreplacement parts:

1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>1130007020 S.IC TC7S66FU IC-F11 MAIN UNIT 1 piece8810009510 Screw BO M 2 x 4 NI-ZU IC-F11 Chassis 10 pieces

Addresses are provided on the inside back cover for yourconvenience.

1. Make sure a problem is internal before disassembling the transceiver.2. DO NOT open the transceiver until the transceiver is disconnected from its power source.3. DO NOT force any of the variable components. Turn them slowly and smoothly.4. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.5. DO NOT keep power ON for a long time when the transceiver is defective.6. DO NOT transmit power into a signal generator or a sweep generator.7. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when

using such test equipment.8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

To upgrade quality, all electrical or mechanical parts andinternal circuits are subject to change without notice or oblig-ation.

IC-F11/IC-F12 IC-F11BR/IC-F11S/IC-F12S

MODEL

IC-F11

IC-F11S

IC-F11BRIC-F12

IC-F12S

VERSIONU.S.A.

General

U.S.A.GeneralU.S.A.EuropeEurope

SYMBOLUSA-02GEN-02GEN-05USA-02GEN-02USA-02EUR-02EUR-02

CHARGER

–

BC-146–

BC-146

–

BATTERY

BP-209

–

BP-209

BP-222

BP-209

TABLE OF CONTENTS

SECTION 1 SPECIFICATIONS

SECTION 2 INSIDE VIEWS

SECTION 3 DISASSEMBLY INSTRUCTIONS

SECTION 4 CIRCUIT DESCRIPTION4-1 RECEIVER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1

4-2 TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-2

4-3 PLL CIRCUIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-3

4-4 POWER SUPPLY CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4

4-5 PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-4

SECTION 5 ADJUSTMENT PROCEDURES 5-1 PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-1

5-2 PLL ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-4

5-3 SOFTWARE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5-5

SECTION 6 PARTS LIST

SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

SECTION 8 SEMI-CONDUCTOR INFORMATION

SECTION 9 BOARD LAYOUTS9-1 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-1

9-2 SW-A AND SW-B UNITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9-3

SECTION 10 BC-146 OPTIONAL DESKTOP CHARGER INFORMATION10-1 PARTS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1

10-2 DISASSEMBLY INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-1

10-3 VOLTAGE DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-2

10-4 BOARD LAYOUT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10-2

SECTION 11 BLOCK DIAGRAM

SECTION 12 VOLTAGE DIAGRAM12-1 MAIN UNIT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12-1

12-2 SW-A AND SW-B UNITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12-2

SECTION 1 SPECIFICATIONS

1 - 1

All stated specifications are subject to change without notice or obligation.

Frequency coverage

Type of emission

Number of channels

Power supply requirement

Antenna impedance

Input impedance (Mic)

Output impedance (Audio)

Intermediate frequency

Operating temperature range

High power

Low power

stand-by

Rated audio

Dimensions(Projections not included)

Weight

RF output power (at 7.2 V DC)

Modulation system

Max. permissible deviation

External mic.connector

Frequency error

Spurious emissions

Adjacent channel power

Audio harmonics distortion

FM Hum and noise

Residual modulation

Limiting charact of modulator

Receive system

Intermediate frequencies

Sensitivity

Audio output power (at 7.2 V)

Adjacent channel selectivity

Spurious response

Intermodulation

FM Hum and noise (Typical)

Squelch sensitivity

EIA-152-C/204D or TIA-603 ETS 300 086

RE

CE

IVE

RT

RA

NS

MIT

TE

RG

EN

ER

AL

151.505 MHz–158.4075 MHz [F11BR] only 146.000 MHz–174.000 MHz146.000 MHz–174.000 MHz

16K0F3E (at 25 kHz / 30 kHz), 8K50F3E (at 12.5 kHz)

2 channel (IC-F11BR / F11S / F12S), 16 channel (IC-F11 / F12)

7.5 V (negative ground)

50 Ω normal

2.2 kΩ normal

8 Ω normal

1st: 31.050 MHz, 2nd: 450 kHz

–30 ˚C to +60 ˚C (–22˚F to +140˚F) –25 ˚C to +55 ˚C (–13˚F to +131˚F)

1.6 A (5 W) except [F11BR], 1.1 A (2 W) [F11BR] only

0.7 A (1 W)

70 mA

250 mA

54(W) × 128(H) × 37(D) mm; 21⁄8(W) × 51⁄25(H) × 115⁄32(D) inch

310 g; 10.1 oz (with BP-209), 300 g; 10.6 oz (with BP-222)

High: 5.0 W ([F11BR]: 2.0 W), Low1: 2.0 W (except [F11BR]), low2: 1.0 W

Variable reactance frequency modulation

± 5.0 kHz (25 kHz), ± 2.5 kHz (12.5 kHz)

3-conductor 2.5 mm (1⁄10 in) (2 kΩ)

±5.0 ppm ±2.0 kHz (25 kHz), ± 1.5 kHz (12.5 kHz)

73 dBc (typical) 0.25 µW < 1 GHz, 1.00 µW > 1 GHz

70 dB*1 (25 kHz), 60 dB*1 (12.5 kHz)

3 % typical at 1 kHz 40 % deviation 5 % typical at 1 kHz 60 % deviation

46 dB typ. (25 kHz), 40 dB typ. (12.5 kHz) –

– 45 dB typ. (25 kHz), 43 dB typ. (12.5 kHz)

70 % – 100 % of max. deviation

Double-conversion super heterodyne

1st: 31.050 MHz, 2nd 450 kHz

0.25 µV (typical) for 12 dB SINAD 0.25 µV (typical) for 12 dB SINAD0.63 µV EMF (typical) for 20 dB SINAD

0.5 W at 5 % distortion with an 8 Ω load, 0.6 W at 5 % distortion with 6 Ω load

70 dB typ. (25 kHz), 65 dB typ. (12.5 kHz) 70 dB typ (25 kHz), 60 dB typ. (12.5 kHz)

70 dB*1

70 dB 65 dB

46 dB*2 (25 kHz), 40 dB*2 (12.5 kHz) 45 dB*3 (25 kHz), 43 dB*3 (12.5 kHz)

0.3 µV typical at threshold

Cur

rent

dra

in(a

t 7.

2 V

) Tx

Rx

*1EIA-152-C/204D or TIA-603 is typical value, *2EIA-152-C/204D only, *3With CCITT filter

2 - 1

SECTION 2 INSIDE VIEWS

• MAIN UNIT

Power amplifier(Q1: 2SK2974)

Antenna switching circuit D1: 1SV307 D9: 1SV307 D10: MA77

TOP VIEW BOTTOM VIEW

RF amplifier(Q15: 3SK294)

VCO circuit

FM IF IC(IC3: TA31136FN(D))

Low-pass filter circuit(IC12,16: NJM12904V)

Expander IC(IC15: BU4094BCFV)

TX/RX switch(D3, D4: MA77)

Analog switch(IC6: BU4066BCFV)

APC(IC2: TA75S01F)

AF amplifier(IC4: TA7368F)

1st mixer(Q16: 3SK272)

CPU(IC7: HD6433664A24FP)

EEPROM(IC11: BR24C16FV-E2)

D/A converter(IC9: M62363FP-650C)

PLL reference oscillator(X1: CR-664A)

Crystal filter(FI1: FL-333)

PLL IC(IC1: MB15A02PFV-1)

YGR amplifier(Q4: 2SC5110-O)

Pre-drive(Q2 : 2SK2973)

( )

3 - 1

SECTION 3 DISASSEMBLY INSTRUCTIONS

• REMOVING THE CHASSIS¡ Unscrew 1 nut, A, and remove 2 knobs, B, C.™ Unscrew 2 screws, D.£ Unscrew 2 screws, H, to separate the Jack panel and the

Front panel.¢ Take off the chassis in the direction of the arrow.∞ Unplug J6 to separate the front panel and the chassis.

• REMOVING THE MAIN UNIT¡ Remove the searing rubber.™ Unsolder 2 points, E, and unscrew 2 nuts, F.£ Unscrew 9 screws, G, (silver, 2mm) to separate the chassis and the MAIN unit.¢ Take off the MAIN unit in the direction of the arrow.

Front panel

J6 (Speaker connector)

Jack panel

Chassis

CB

(Black, 2mm) x 2 D

A

(Black, 2mm) x 2 H

Guide holesMAIN unit

Sealing rubber

Chassis

E

F

Side plate

([F11BR], [F11S], [F12S] only) G

G

G

G

SECTION 4 CIRCUIT DESCRIPTION

4 - 1

4-1 RECEIVER CIRCUITS4-1-1 ANTENNA SWITCHING CIRCUITThe antenna switching circuit functions as a low-pass filterwhile receiving. However, its impedance becomes very highwhile D9 and D10 are turned ON. Thus transmit signals areblocked from entering the receiver circuits. The antennaswitching circuit employs a λ⁄4 type diode switching system.

Received signals are passed through the low-pass filter (L1,L2, C1–C5). The filtered signals are applied to the λ⁄4 typeantenna switching circuit (D9, D10).The passed signals are then applied to the RF amplifier cir-cuit.

4-1-2 RF CIRCUITThe RF circuit amplifies signals within the range of frequen-cy coverage and filters out-of-band signals.

The signals from the antenna switching circuit are amplifiedat the RF amplifier (Q15) after passing through the 2 stagestunable bandpass filter (D12, L21, C104, C105, D13, L54,C106, C111, C113). The amplified signals are applied to the1st mixer circuit (Q16) after out-of-band signals are sup-pressed at the 2 stages tunable bandpass filter (D14, C116,C117, D15, L24, C120, C122).

Varactor diodes are employed at the bandpass filters thattrack the filters and are controlled by the CPU (IC7) via theD/A convertor (IC9) using T1–T4 signals. These diodes tunethe centre frequency of an RF passband for wide bandwidthreceiving and good image response rejection.

4-1-3 1ST MIXER AND 1ST IF CIRCUITSThe 1st mixer circuit converts the received signal into a fixedfrequency of the 1st IF signal with a PLL output frequency.By changing the PLL frequency, only the desired frequencywill pass through a crystal filter at the next stage of the 1stmixer.

The signals from the RF circuit are mixed at the 1st mixer(Q16) with a 1st LO signal (114.95–142.95 MHz) comingfrom the VCO circuit to produce a 31.05 MHz 1st IF signal.

The 1st IF signal is applied to a crystal filter (FI1) to sup-press out-of-band signals. The filtered 1st IF signal isapplied to the IF amplifier (Q17), then applied to the 2ndmixer circuit (IC3, pin 16).

4-1-4 2ND IF AND DEMODULATOR CIRCUITSThe 2nd mixer circuit converts the 1st IF signal into a 2nd IFsignal. A double conversion superheterodyne system (whichconverts receive signals twice) improves the image rejectionratio and obtains stable receiver gain.

The 1st IF signal from the IF amplifier is applied to the 2ndmixer section of the FM IF IC (IC3, pin 16), and is mixed withthe 2nd LO signal to be converted into a 450 kHz 2nd IF sig-nal.

The FM IF IC contains the 2nd mixer, limiter amplifier, quad-rature detector and active filter circuits. A 2nd LO signal(30.6 MHz) is produced at the PLL circuit by tripling it’s ref-erence frequency.

The 2nd IF signal from the 2nd mixer (IC3, pin 3) passesthrough a ceramic filter (FI2) to remove unwanted hetero-dyned frequencies. It is then amplified at the limiter amplifi-er (IC3, pin 5) and applied to the quadrature detector (IC3,pins 10, 11) to demodulate the 2nd IF signal into AF signals.

4-1-5 AF CIRCUITAF signals from the FM IF IC (IC3, pin 9) are applied to theanalog switch (IC6, pin 1) after being passed through thehigh-pass filter (IC5B, pins 5, 7) via the “DET” signal. Thesignals pass through the low-pass filter (IC5D, pins 13, 14),and then applied to the analog switch (IC6, pins 9, 10) again.The output signals from the analog swtich (IC6, pin 11) areapplied to the AF power amplifier (IC4, pin 4) after beingpassed through the [VOL] control (SW-A/SW-B unit; R143)via the “VOLIN” and “VOLOUT” signals.

2ND IF AND DEMODULATOR CIRCUITS

Mixer

16

Limiteramp.

2nd IF filter450 kHz

PLL ICIC1

X115.3 MHz

IC3 TA31136F12

1st IF from the IF amplifier (Q17)

"RSSI" signal to the CPU pin 59

11109

8 7 5 3

AF signal "DET"

R5V

X2

R98C155 C154

R100R99

R93

"SQLIN" signal to the D/A convertor (IC9, pin 23)

R92

C138 C139

C140

2

2 1

Activefilter

FI2

Noisedetector

FMdetector

13

"NOIS" signal to the CPU pin 53

RSSI

Noisecomp.

×2

R94

Q18

4 - 2

The applied AF signals are amplified at the AF power ampli-fier circuit (IC4, pin 4) to obtain the specified audio level. Theamplified AF signals output from pin 10 as “AFOUT”signalare applied to the internal speaker (SP1) as the “SP” signalvia the [SP] jack when no plug is connected to the jack.

4-1-6 SQUELCH CIRCUITA squelch circuit cuts out AF signals when no RF signals arereceived. By detecting noise components in the AF signals,the squelch switches the AF mute switch.

A portion of the AF signals from the FM IF IC (IC3, pin 9) as“DET” signal are applied to the D/A convertor IC (IC9, pin24). The signals from the D/A convertor (IC9, pin 23) as“SQLIN” signals are applied to the active filter section (IC3,pin 8) where noise components are amplified and detectedwith an internal noise detector.

The active filter section amplifies noise components. The fil-tered signals are rectified at the noise detector section andconverted into “NOIS” (pulse type) signals at the noise com-parator section. The “NOIS” signal output from IC3, pin 13,and is applied to the CPU (IC7, pin 53).

The CPU detects the receiving signal strength from thenumber of the pulses, and outputs “EXST”, “SO”, “SCK” sig-nals. The signals are applied to the expander IC (IC15, pins1, 2, 3), and then outputs “RMUT” signal from pin 4. Thissignal controls the analog switch (IC6, pin 13) to cut the AFsignal line.

4-2 TRANSMITTER CIRCUITS4-2-1 MICROPHONE AMPLIFIER CIRCUITThe microphone amplifier circuit amplifies audio signals with+6 dB/octave pre-emphasis characteristics from the micro-phone to a level needed for the modulation circuit.

The AF signals from the microphone are applied to themicrophone amplifier circuit (IC5c, pin 10) after being passthrough the high-pass filter (C186, C187). The amplified AFsignals are passed through the low-pass filter circuit (IC5d,pins 13, 14) via the mute switch (IC6, pins 2, 3, 4). The fil-tered AF signals are applied to the modulator circuit afterbeing passed through the mute switch (IC6, pins 8, 9, 10).

4-2-2 MODULATION CIRCUITThe modulation circuit modulates the VCO oscillating signal(RF signal) using the microphone audio signal.

The audio signals change the reactance of a diode (D6) tomodulate an oscillated signal at the VCO circuit (Q10, Q11).The oscillated signal is amplified at the buffer-amplifiers (Q5,Q7), then applied to the T/R switching circuit (D3, D4).

4-2-3 DRIVE/POWER AMPLIFIER CIRCUITSThe signal from the VCO circuit passes through the T/Rswitching circuit (D3) and is amplified at the YGR (Q4), pre-drive (Q2) and power amplifier (Q1) to obtain 5 W ([F11BR]is 2 W) of RF power (at 7.2 V DC). The amplified signalpasses through the antenna switching circuit (D1) via thepower detector (D2), and low-pass filter and is then appliedto the antenna connector.

The bias current of the YGR amplifier (Q4), pre-drive (Q2)and the power amplifier (Q1) is controlled by the APC circuit.

4-2-5 APC CIRCUITThe APC circuit (IC2) protects the drive and the poweramplifiers from excessive current drive, and selects HIGH orLOW output power.

The signal output from the power detector circuit (D2) isapplied to the differential amplifier (IC2, pin 3), and the “T4”signal from the expander (IC9, pin 11), controlled by theCPU (IC7), is applied to the other input for reference.

When the driving current is increased, input voltage of thedifferential amplifier (pin 3) will be increased. In such cases,the differential amplifier output voltage (pin 4) is decreasedto reduce the driving current.

APC CIRCUIT

Q1Poweramp.

Q2Pre-driveramp.

IC2

+

—

Q4YGRamp.

VCC

T5V

RF signalfrom PLL

to antenna

T4

TXCQ14

S5VAPC control circuit

Power detectorcircuit (D2)

D2

LPF

D1, D9, D10ANTSW

AFamp.

LPF

HPF

"DET" signalfrom IC3, pin 9

"NWC" signalfrom IC15, pin 14

Q21

Analogswitch

IC6

IC5B

IC5D

AF VOL.R1

SW-A/SW-Bunit

IC4SP

111

9, 102, 3

AF CIRCUIT

4 - 3

4-3 PLL CIRCUIT4-3-1 GENERALA PLL circuit provides stable oscillation of the transmit fre-quency and receive 1st LO frequency. The PLL output com-pares the phase of the divided VCO frequency to the refer-ence frequency. The PLL output frequency is controlled by acrystal oscillator and the divided ratio (N-data) of a pro-grammable divider.

The PLL circuit, using a one chip PLL IC (IC1), directly gen-erates the transmit frequency and divided ratio based onserial data from the CPU and compares the phases of VCOsignals with the reference oscillator frequency. The PLL ICdetects the out-of-step phase and output from pin 5. The ref-erence frequency (15.3 MHz) is oscillated by X1.

4-3-2 TX LOOPThe generated signal at the VCO (Q10, Q11, D5, D7) entersthe PLL IC (IC1, pin 8) and is divided at the programmabledivider section and is then applied to the phase detectorsection.

The phase detector compares the input signal with a refer-ence frequency, and then outputs the out-of-phase signal(pulse-type signal) from pin 5.

The pulse-type signal is converted into DC voltage (lockvoltage) at the loop filter (R40–R42, C75, C76), and thenapplied to varactor diodes (D5, D7) of the VCO to stabilizethe oscillated frequency.

4-3-3 RX LOOPThe generated signal at the VCO (Q10, Q11, D5, D7) entersthe PLL IC (IC1, pin 8) and is divided at the programmabledivider section and is then applied to the phase detectorsection.

The phase detector compares the input signal with a refer-ence frequency, and then outputs the out-of-phase signal(pulse-type signal) from pin 5.

The pulse-type signal is converted into DC voltage (lockvoltage) at the loop filter (R40–R42, C75, C76), and thenapplied to varactor diode (D5) of the VCO to stabilize theoscillated frequency. The lock voltage is also used for thereceiver circuit for the bandpass filter center frequency. Thelock voltage from the loop filter is amplified at the bufferamplifier (Q13) and then applied to the CPU (IC7, pin 60).The signal is analyzed at the CPU, and then applied to theD/A convertor (IC9). The D/A convertor outputs “T1”, “T2”,“T3”, “T4” signals to RF bandpass filters D12–D15 to sup-press harmonic components.

4-3-4 VCO CIRCUITThe VCO outputs from Q11 and Q10 are buffer amplified atQ7 and Q5, and are then sent to the T/R switch (D3, D4).The receive LO signal is applied to the 1st mixer circuit(Q16) through an attenuator, and the tramsmit signal isapplied to the YGR amplifier (Q4). A portion of the VCO out-put is reapplied to the PLL IC (IC1, pin 8) via the bufferamplifier (Q6) and low-pass filter (L18, R53, C89–C91).

Shift register

PrescalerPhasedetector

Loopfilter

Programmablecounter

Programmabledivider

X115.3 MHz

30.6 MHz signalto the FM IF IC

Buffer

Buffer

Buffer

Q5

Q6

Q7

91011

SCK

IC1 (PLL IC)

SOPLST

to transmitter circuit

to 1st mixer circuit

D3

D4

2

1

5 8

Q10, Q11, D5, D7

VCO

Crystaloscillator

×2

Q18

LPF

PLL CIRCUIT

MOD

D6"DEV" signal from theD/A convertor (IC9, pin 22)

4 - 4

4-4 POWER SUPPLY CIRCUITSVOLTAGE LINE

LINE

HV

VCC

CPU5V

T5V

R5V

S5V

+5V

VCO5V

DESCRIPTION

The voltage from the attached battery pack.

The same voltage as the HV line (battery volt-age) which is controlled by the power swtich([VOL] control).

Common 5 V converted from the VCC line by the+5 regulator circuit (IC10). The output voltage isapplied to the CPU (IC7), reset circuit (IC8) andetc.

5 V for transmitter circuits regulated by the T5regulator circuit (Q27).

5 V for receiver circuits regulated by the R5 reg-ulator circuit (Q26).

Common 5 V converted from the VCC line by theS5 regulator circuit (Q24, Q19).

The same voltage as the CPU5V line for the ana-log swtich (IC6), buffer amplifier (Q13), etc.

The same voltage as the +5V line for the VCO(Q10, Q11) and buffer amplifiers (Q5–Q7).

4-5 PORT ALLOCATIONS4-5-1 CPU (IC7)

Pinnumber

7

13141920

232425

28

29

30

36

37

38

39

40

41

42

43

44

45

46

5152

53

54

55

57

58

59

60

Portname

RES

SENC0SENC1SENC2SENC3

CENC0CENC1CENC2

SCK

SO

BEEP

PLST

DAST

EXST

PTT

TXC

RLED

TLED

AFON

ESDA

CLI

CLO

F1F2

NOIS

UNLK

TEMP

CDEC

SDEC

RSSI

LVIN

Description

Input port for RESET signal.

Outputs single tone encode signal.

Outputs CTCSS/DTCS data signal.

Outputs serial clock signal to the PLLIC (IC1), EEPROM (IC11), etc.

Outputs data signal to the PLL IC(IC1) and D/A convertor (IC9).

Outputs beep audio signal.

I/O port for strobe signal from/to PLLIC (IC9).

• Outputs strobe signal to the D/A con-vertor (IC9).

• Input port for the initial version sig-nal.

Outputs strobe signal for the expanderIC (IC15).

Input port for [PTT] swtich signal.High: While [PTT] switch is pushed.

Outputs TX mute control signal.High: While transmitting

Outputs BUSY LED control signal.High: While receiving.

Outputs TX LED control signal.high: While transmitting.

Outputs control signal for the regulatorcircuit of AF power amplifier.High: While squelch is open, etc.

I/O port for data signal from/to theEEPROM (IC11).

Input port for cloning signal.

Outputs the cloning signal.

Input ports for the customization keysignals.

Input port for the noise pulse signal forthe squelch function.

Input port for PLL unlock signal.High: PLL is locked.

Input port for the transceiver’s internaltempereture detection.

Input port for CTCSS/DTCS signals.

Input port for single tone decode sig-nal.

Input port for the RSSI voltage.

Input port for the PLL lock voltage.

4 - 5

Pinnumber

61

62

Portname

BDET

BATV

Description

Input port for the battery’s type detec-tion.

Input port for battely voltage detection.

4-5-3 D/A CONVERTOR IC (IC9)

Pinnumber

2, 3,10, 11

14

15

22

Portname

T1–T4

REF

BAL

DEV

Description

Output tunable bandpass filters con-trol signals.

Outputs differential voltage for the ref-erence oscillator (Q31, D19, X1).

Outputs DTCS balance control signal.

Outputs modulating signal for themodulator circuit (D6).

CPU (IC7)–continued

4-5-2 OUTPUT EXPANDER IC (IC15)

Pinnumber

4

5

6

7

11

12

13

14

Portname

CSFT

RMUT

MMUT

DUSE

T5C

R5C

S5C

NWC

Description

Outputs clock shift control signal forCPU.

Outputs RX mute control signal.

Outputs TX mute control signal.

Outputs low-pass filter cut-off frequen-cy control signal when DTCS is acti-vated.

Outputs T5 regulator control signal.Low: While transmitting.

Outputs R5 regulator control signal.Low: While receiving.

Outputs S5 regulator control signal.Low: While power is ON.

Outputs Narrow/Wide of channelspacing control signal.Low: While Narrow is selected.

5 - 1

5-1 PREPARATIONWhen you adjust the contents on page 5-5 or 5-6, SOFTWARE ADJUSTMENT, the optional CS-F11 ADJ ADJUSTMENT SOFTWARE(Rev. 1.0 or later), OPC-478 CLONING CABLE and a JIG CABLE (see illustration at page 5-2) are required.

REQUIRED TEST EQUIPMENT

SECTION 5 ADJUSTMENT PROCEDURES

EQUIPMENT

DC power supply

RF power meter(terminated type)

Frequency counter

FM deviation meter

Digital multimeter

GRADE AND RANGE

Output voltage : 7.2 V DCCurrent capacity : 5 A or more

Measuring range : 1–10 WFrequency range : 300–600 MHzImpedance : 50 ΩSWR : Less than 1.2 : 1

Frequency range : 0.1–600 MHzFrequency accuracy : ±1 ppm or betterSensitivity : 100 mV or better

Frequency range : DC–600 MHzMeasuring range : 0 to ±5 kHz

Input impedance : 10 MΩ/V DC or better

EQUIPMENT

Audio generator

Attenuator

Standard signal generator (SSG)

DC voltmeter

Oscilloscope

AC millivoltmeter

GRADE AND RANGE

Frequency range : 300–3000 HzOutput level : 1–500 mV

Power attenuation : 40 or 50 dBCapacity : 10 W or more

Frequency range : 120–600 MHzOutput level : 0.1 µV–32 mV

(–127 to –17 dBm)

Input impedance : 50 kΩ/V DC or better

Frequency range : DC–20 MHzMeasuring range : 0.01–20 V

Measuring range : 10 mV–10 V

SYSTEM REQUIREMENTS• IBM PC compatible computer with an RS -232C serial port

(38400 bps or faster)• Microsoft Windows 95 or Windows 98• Intel i486DX processor or faster (Pentium 100 MHz or

faster recommended)• At least 16 MB RAM and 10 MB of hard disk space• 640×480 pixel display (800×600 pixel display recommend-

ed)

ADJUSTMENT SOFTWARE INSTALLATIONq Boot up Windows.

- Quit all applications when Windows is running.w Insert the cloning software CD-ROM into the appropriate

CD-ROM drive.e Select ‘Run’ from the [Start] menu.r Type the setup program name using the full path name,

then push the [Enter] key. (For example; D:\ setup)t Follow the prompts.y Program group ‘CS-F11’ appears in the ‘Programs’ folder

of the [Start] menu.

STARTING SOFTWARE ADJUSTMENTq Connect transceiver and PC with the optional OPC-478

and the JIG cable.w Boot up Windows, and turn the transceiver power ON.e Click the program group ‘CS-F11 ADJ’ in the ‘Programs’

folder of the [Start] menu, then CS-F11 ADJ’s window isappeared.

r Click ‘Connect’ on the CS-F11’s window, then appearstransceiver’s up-to-date condition.

t Set or modify adjustment data as desired.

IBM is a registered trademark of International BussinessMachines Corporation in the U.S.A. and other countries.Microsoft and Windows are registered trademarks ofMicrosoft Corporation in the U.S.A. and other countries.Screen shots produced with permission from MicrosoftCorporation. All other products or brands are registeredtrademarks or trademarks of their respective holders.

5 - 2

JIG CABLE

+( CLONE)

( GND)

+( SP)

( SPE)

3-conductor 3.5(d) mm plug

OPC-478JIG cableto IC-F4GT/GS [SP] jack

CS-F11 ADJ Rev.1.0File

COM 1: OPEN

Option

Connect Reload (F5) Disp para

[A / D]VIN : 197 : C5h : 7.73 VTEMPS : 190 : BEh : 32.23 ’CLVIN : 98 : 62h : 1.92 VSD : 0 : 00h : 0.00 VREMOT : 14 : 0Eh : 0.27 VBDET : 255 : FFh : 5.00 V

Power (Hi) : 98 [ # # # # # # # # ] Power (L2) : 54 [ # # # # ]Power (L1) : 255 [ # # # # # # # # # # # # # # # # # # # ]DTCS BAL : 132 [ # # # # # # # # # # ]

MOD W : 92 [ # # # # # # # ]MOD N : 50 [ # # # # ]

SQL : 85 [ # # # # # # # ]BPF ALL : [Enter] to sweepBPF T1 : 23 [ # # # # # # # # # # # # ] [Enter] to sweepBPF T2 : 22 [ # # # # # # # # ] [Enter] to sweepBPF T3 : 9 [ # # # # # # # # # # # ] [Enter] to sweepBPF T4 : 7 [ # # # # # # # # # ] [Enter] to sweep

TXF : [Enter] to start

[D / A]BPF T1 : 90 : 5Ah : 1.76 VBPF T2 : 45 : 2Dh : 0.88 VBPF T3 : 76 : 4Ch : 1.49 VT4/POW : 60 : 3Ch : 1.18 VREF : 112 : 70h : 2.20 VDTCS BL. : 141 : 8Dh : 55.29 Dev : 45 : 2Dh : 0.88 VSQL Lev : 150 : 96h : 58.96

CH No. : 01 (RX Freq = 216.050, TX Freq = < ) RF Power: High

: Transceiver’s connection state: Reload adjustment data: Receive sensitivity measurement: Connected DC voltage: PLL lock voltage: Operating channel select: RF output power

NOTE:

SCREEN DISPLAY EXAMPLE

1

5

11

1234567

891011121314

: DTCS wave balance: FM deviation: Squelch level: Receive sensitivity (automatically): Receive sensitivity (manually): Reference frequency: Adjustment items

The above values for settings are example only. Each transceiver has its own specific values for each setting.

4

2

8

3

6

7

9

12

10

13 14

5 - 3

to an RS-232C port

Personalcomputer

to [MIC]

to [SP]

JIG cable

DB9 female plug(incl. level converter circuit)

CONNECTION

to the antenna connector

RF power meter0.1 10 W/50

Frequencycounter

Attenuator40 dB or 50 dB

FMdeviation meter

Standard signal generator0.1 V to 32 mV

( 127 dBm to 17 dBm)

SINAD meter

Speaker (8 )

Audio generator

OPC-478

CAUTION:DO NOT transmit while an SSG is connected to the antenna connector.

DC POWERSUPPLY

GND

+

Battery type detectorBattery type detector

DC POWER CABLE CONNECTIONS

NOTE: When you adjust the output power (highpower), the battery type detector must be con-nected to GND (see illustration at above).Ohterwise the transceiver does not transmit highpower, the output power will be low.

5 - 4

L16PLL lock voltage adjustment

TOP VIEW

RF power meter

LVPLL lock voltage check point

5-2 PLL ADJUSTMENT

PLL LOCKVOLTAGE

1

2

3

• Operating frequency: 174.000 MHz*1

158.4075 MHz*2

• Transmitting


151.505 MHz*2

• Receiving

• Transmitting

MAIN Connect a digital multimeter to check pointLV.

4.0 V

0.8–1.8 V

0.8–1.8 V

MAIN L16

Verify

ADJUSTMENT ADJUSTMENT CONDITIONSUNIT LOCATION

VALUEUNIT ADJUST

MEASUREMENT ADJUSTMENT

5 - 5

1

1

2

3

1

2

1


158.4075 MHz*2

• High/Low switch : Low• Connect the RF power meter or 50 Ω

dummy load to the antenna connector.• Transmitting


151.505 MHz*2

• High/Low switch : High• Transmitting

• High/Low switch : Low2• Transmitting

• High/Low switch : Low1• Transmitting

• Operating frequency:146.000 MHz*1

151.505 MHz*2

• High/Low switch : Low1• Channel spacing : Wide• Connect the audio generator to the

[MIC] jack and set as: 1.0 kHz/150 mVrms

• Set the FM deviation meter as:HPF : OFFLPF : 20 kHzDe-emphasis : OFFDetector : (P–P)/2

• Transmitting

• Channel spacing : Narrow• Transmitting


158.4075 MHz*2

• High/Low switch : Low1• Channel spacing : Wide• No audio applied to the [MIC] jack.• DTCS code : 007• Transmitting

REFERENCEFREQUENCY[TXF]

OUTPUTPOWER[POWER(Hi)]

[POWER(L2)]

[POWER(L1)]

FMDEVIATION(Wide)[MOD W]

(Narrow)[MOD N]

DTCS WAVEFORM[DTCS BAL]

Toppanel

Toppanel

Toppanel

Toppanel

Loosely couple a frequnecycounter to the antenna connec-tor.

Connect an RF power meter tothe antenna connector.

Connect an FM deviation meterto the antenna connectorthrough the attenuator.

Connect an FM deviation meterwith an oscilloscope to theantenna connector through anattenuator.

174.0000 MHz*1

158.4075 MHz*2

5.0 W*1

2.0 W*2

2.0 W

1.0 W

Between ±4.05 kHzand ±4.15 kHz

Between ±2.05 kHzand ±2.15 kHz

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

5-3 SOFTWARE ADJUSTMENTSelect an operation using [↑ ] / [↓ ] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

Set to flat wave form

*1IC-F11, F11S, F12 and F12S. *2IC-F11BR only.

5 - 6

Minimum distortionlevel

12 dB SINAD

At the point wherethe audio signals

just appears.

1 • Operating frequency:146.000 MHz*1

151.505 MHz*2

• Channel spacing :Narrow• Connect a standard signal generator to

the antenna connector and set as:Frequency : 146.000 MHz*1

151.505 MHz*2

Level : 10 µV* (–87 dBm)Modulation : OFFDeviation : ±1.75 kHz

• Receiving


156.956 MHz*2

• Channel spacing : Narrow• Connect a standard signal generator to

the antenna connector and set as:Frequency : 160.000 MHz*1

156.956 MHz*2

Level : 0.2 µV* (–121 dBm)Modulation : 1 kHzDeviation : ±1.75 kHz

• Receiving

• Receiving

RXSENSITIVITY[BPF T1]–[BPF T4]

SQUELCHLEVEL[SQL]

Toppanel

Toppanel

Connect a SINAD meter with an8 Ω load to the [SP] jack.

Connect a SINAD meter with an8Ω load to the [SP] jack.

ADJUSTMENT ADJUSTMENT CONDITIONMEASUREMENT

VALUEUNIT LOCATION

*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.

SOFTWARE ADJUSTMENT – continuedSelect an operation using [↑ ] / [↓ ] keys, then set specified value using [←] / [→] keys on the connected computer keyboard.

CONVENIENT: The BPF T1–BPF T4 can be adjusted automatically.q-1: Set the cursol to “BPF ALL” on the adjustment program and then push [ENTER]

key.q-2: The connected PC tunes BPF T1–BPF T4 to peak levels.

orw-1: Set the cursol to one of BPF T1, T2, T3, or T4 as desired.w-2: Push [ENTER] key to start tuning.w-3: Repeat w-1 and w-2 to perform additional BPF tuning.

1

2

*1IC-F11, F11S, F12 and F12S. *2IC-F11BR only.

[MAIN UNIT][SW-A UNIT] ([F11] AND [F12] ONLY)

Q1 1590003020 S.TRANSISTOR XP4216-(TX)

R1 7210003060 VARIABLE TP76N00N-15F-10KA-2251R2 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)R3 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)

F1 5210000710 S.FUSE KAB 2402 322 NA29

DS1 5040002070 S.LED LNJ107W5PRW

S1 2250000450 ENCODER TP70QF4161-16F-2458A

EP1 0910054463 PCB B 5603C

Q1 1590003020 S.TRANSISTOR XP4216-(TX)

R1 7210003060 VARIABLE TP76N00N-15F-10KA-2251R2 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)R3 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)

F1 5210000710 S.FUSE KAB 2402 322 NA29

DS1 5040002070 S.LED LNJ107W5PRW

W1 7120000470 JUMPER ERDS2T0W2 7120000470 JUMPER ERDS2T0

EP1 0910054473 PCB B 5604C

IC1 1140005990 S.IC MB15A02PFV1-G-BND-ERIC2 1110002750 S.IC TA75S01F (TE85R) IC3 1110003490 S.IC TA31136FN (D,EL) IC4 1110001810 S.IC TA7368F (TP1) IC5 1110005320 S.IC NJM13403V-TE1IC6 1130008090 S.IC BU4066BCFV-E1IC7 1140009850 S.IC HD6433664A24FP (FX-2458A-1) IC8 1110005770 S.IC S-80942CNMC-G9C-T2IC9 1190000350 S.IC M62363FP-650CIC10 1110005350 S.IC NJM2870F05-TE1IC11 1130010490 S.IC BR24C16FV-E2IC12 1110005330 S.IC NJM12904V-TE1IC13 1130007020 S.IC TC7S66FU (TE85R) IC15 1130007570 S.IC BU4094BCFV-E2IC16 1110005330 S.IC NJM12904V-TE1

Q1 1560001050 S.FET 2SK2974 Q2 1560001020 S.FET 2SK2973 (MTS101P)

S.=Surface mount

Q4 1530003420 S.TRANSISTOR 2SC5110-O (TE85R) Q5 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) Q6 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) Q7 1530003310 S.TRANSISTOR 2SC5107-O (TE85R) Q8 1590000430 S.TRANSISTOR DTC144EUA T106Q10 1530003230 S.TRANSISTOR 2SC5085-Y (TE85R) Q11 1530003230 S.TRANSISTOR 2SC5085-Y (TE85R) Q12 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ13 1560000540 S.FET 2SK880-Y (TE85R) Q14 1590000720 S.TRANSISTOR DTA144EUA T106Q15 1580000750 S.FET 3SK294 (TE85L) Q16 1580000660 S.FET 3SK272-(TX) Q17 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) Q18 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) Q19 1520000460 S.TRANSISTOR 2SB1132 T100 RQ20 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ21 1590000430 S.TRANSISTOR DTC144EUA T106Q22 1590002530 S.TRANSISTOR UN911H (TX) Q23 1590000720 S.TRANSISTOR DTA144EUA T106Q24 1520000460 S.TRANSISTOR 2SB1132 T100 RQ25 1590001190 S.TRANSISTOR XP6501-(TX) .ABQ26 1510000920 S.TRANSISTOR 2SA1577 T106 QQ27 1510000920 S.TRANSISTOR 2SA1577 T106 QQ28 1590000430 S.TRANSISTOR DTC144EUA T106Q29 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) Q30 1590001770 S.TRANSISTOR XP1213 (TX) Q31 1530002600 S.TRANSISTOR 2SC4215-O (TE85R) Q32 1590000660 S.TRANSISTOR DTC144TU T106Q33 1560000840 S.FET 2SK1829 (TE85R) A onlyQ35 1590000430 S.TRANSISTOR DTC144EUA T106Q36 1560000840 S.FET 2SK1829 (TE85R)

D1 1750000580 S.DIODE 1SV307 (TPH3) D2 1790001670 S.DIODE RB706F-40T106D3 1790000620 S.DIODE MA77 (TX) D4 1790000620 S.DIODE MA77 (TX) D5 1720000780 S.VARICAP HVU350B TRFD6 1790001260 S.DIODE MA2S077-(TX) D7 1720000780 S.VARICAP HVU350B TRFD9 1750000580 S.DIODE 1SV307 (TPH3) D10 1790000620 S.DIODE MA77 (TX) D12 1720000780 S.VARICAP HVU350B TRFD13 1720000780 S.VARICAP HVU350B TRFD14 1720000780 S.VARICAP HVU350B TRFD15 1720000780 S.VARICAP HVU350B TRFD16 1790000620 S.DIODE MA77 (TX) D17 1790001670 S.DIODE RB706F-40T106D18 1790001250 S.DIODE MA2S111-(TX) A onlyD19 1750000830 S.VARICAP HVC362TRFD20 1790001250 S.DIODE MA2S111-(TX) D21 1790001250 S.DIODE MA2S111-(TX) D22 1790000620 S.DIODE MA77 (TX) D23 1790001250 S.DIODE MA2S111-(TX) D24 1720000360 S.DIODE HSU88TRFD25 1790001250 S.DIODE MA2S111-(TX)

FI1 2010002430 S.XTAL FL-311 (31.05 MHz)FI2 2020001840 CERAMIC ALFYM450F=K

X1 6050011070 S.XTAL CR-664A (15.300 MHz) X2 6070000190 S.DISCRIMINATOR CDBCB450KCAY24-RX3 6050011180 S.XTAL CR-702 (14.7456 MHz)

L1 6200008580 S.COIL 0.30-1.4-6TL 32NL2 6200009800 S.COIL 0.26-1.1-7TR 30NL3 6200002860 S.COIL NL 252018T-4R7JL4 6200008280 S.COIL 0.30-1.7-7TL 50NL5 6200008230 S.COIL 0.30-1.3-5TL 22NL6 6200003590 S.COIL EXCCL3225U1L9 6200005710 S.COIL ELJRE 27NG-FL10 6200006980 S.COIL ELJRE R10G-F

6 - 1

SECTION 6 PARTS LIST

REF ORDER DESCRIPTIONNO. NO.REF ORDER DESCRIPTIONNO. NO.

A: [F12] and [F12S] B: [F11], [F11BR] and [F11S]C: [F11]and [F12]

[SW-B UNIT] ([F11BR], [F11S] AND [F12S] ONLY)REF ORDER DESCRIPTIONNO. NO.

[MAIN UNIT]REF ORDER DESCRIPTIONNO. NO.

[MAIN UNIT][MAIN UNIT]

S.=Surface mount

L11 6200006980 S.COIL ELJRE R10G-FL15 6200004920 S.COIL MLF1608A 2R2K-TL16 6200008190 S.COIL 0.25-1.9-8TL 80NL17 6200002860 S.COIL NL 252018T-4R7JL18 6200005720 S.COIL ELJRE 33NG-FL19 6200008280 S.COIL 0.30-1.7-7TL 50NL20 6200008280 S.COIL 0.30-1.7-7TL 50NL21 6200007750 S.COIL LQW2BHN56NJ01LL22 6200007750 S.COIL LQW2BHN56NJ01LL24 6200007750 S.COIL LQW2BHN56NJ01LL25 6200009180 S.COIL ELJRE R10J-F3L26 6200005540 S.COIL ELJNC R47K-FL27 6200001980 S.COIL NL 252018T-1R0JL28 6200001980 S.COIL NL 252018T-1R0JL29 6200009210 S.COIL NL 252018T-390JL50 6200009180 S.COIL ELJRE R10J-F3L51 6200007690 S.COIL LQW2BHN18NJ01LL52 6200008260 S.COIL 0.30-1.7-8TL 60NL53 6200008510 S.COIL 0.30-0.9-4TR 10.5NL54 6200007750 S.COIL LQW2BHN56NJ01LL56 6200002690 S.COIL MLF1608A 1R0M-T

R1 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R2 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) R3 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R4 7030005040 S.RESISTOR ERJ2GEJ 472 X (4.7 kΩ)R5 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) R6 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R7 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R8 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω) R9 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R10 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R13 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R16 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R17 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R18 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R19 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R20 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R21 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) R22 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) R23 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R24 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R26 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R27 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R28 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) R29 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) R31 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R32 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R34 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R35 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R36 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R37 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R38 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R39 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R40 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) R41 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R42 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω) R43 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) R44 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R45 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R46 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R47 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) R48 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R49 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R50 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R51 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R52 7410000950 S.ARRAY EXB-V8V 102JVR53 7030003290 S.RESISTOR ERJ3GEYJ 560 V (56 Ω) R54 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R55 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R56 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R57 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R58 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) R59 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R60 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R61 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R62 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R63 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ)

R64 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) A7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) B

R65 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) A7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) B

R66 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R68 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R70 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R71 7030005050 S.RESISTOR ERJ2GEJ 103 X (10 kΩ) R72 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R73 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R74 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R75 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R76 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) R77 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R78 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R79 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R80 7030003210 S.RESISTOR ERJ3GEYJ 120 V (12 Ω) R81 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R83 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R85 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω) R86 7030003330 S.RESISTOR ERJ3GEYJ 121 V (120 Ω) R88 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) R89 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R90 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R91 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) R92 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R93 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) R94 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) R95 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) R96 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) R97 7030003780 S.RESISTOR ERJ3GEYJ 684 V (680 kΩ) R98 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ)R99 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)R100 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)R102 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R103 7030003260 S.RESISTOR ERJ3GEYJ 330 V (33 Ω) R104 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R105 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ) R106 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R107 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R109 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R110 7030004910 S.RESISTOR ERJ3GEYF 332 V (3.3 kΩ) R111 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) R112 7030004730 S.RESISTOR ERJ3GEYF 222 V (2.2 kΩ) R113 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) R114 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R115 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R116 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R117 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R118 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R119 7030003730 S.RESISTOR ERJ3GEYJ 274 V (270 kΩ) R120 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R121 7030010320 S.RESISTOR ERJ3GEYF 153 V (15 kΩ) R122 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R123 7030008090 S.RESISTOR ERJ3EKF 1503 V (150 kΩ) R124 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) R125 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R126 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) R127 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R128 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R129 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R130 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R131 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) R132 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R133 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R134 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R136 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R137 7030005270 S.RESISTOR ERJ3GEYJ 204 V (200 kΩ) R138 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R139 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R140 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) B only R141 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R142 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R143 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R146 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R147 7410000950 S.ARRAY EXB-V8V 102JVR148 7410000950 S.ARRAY EXB-V8V 102JVR149 7410000950 S.ARRAY EXB-V8V 102JVR151 7510001470 S.THERMISTOR NTCG20 4AG 473J-TR152 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ) R153 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ)

6 - 2



S.=Surface mount


R154 7030003940 S.RESISTOR ERJ3GEYF 104 V (100 kΩ) R155 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R156 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R157 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R158 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R159 7030003570 S.RESISTOR ERJ3GEYJ 123 V (12 kΩ) R160 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R161 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R163 7410000950 S.ARRAY EXB-V8V 102JVR164 7410000950 S.ARRAY EXB-V8V 102JVR165 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R166 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R167 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R168 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R169 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R170 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R171 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R172 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R173 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R174 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R175 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R176 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R177 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R178 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ) R179 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) R180 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R181 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R182 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R183 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R184 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R185 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R187 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R188 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R189 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R190 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R191 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R192 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) R193 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R194 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R195 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R196 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R197 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R198 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R199 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R200 7410000770 S.ARRAY EXB-V4V 102JV (1 kΩ) R201 7410000950 S.ARRAY EXB-V8V 102JVR202 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R203 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) R204 7030003750 S.RESISTOR ERJ3GEYJ 394 V (390 kΩ) R205 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ) R206 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) R207 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ) R208 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R209 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R210 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R211 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R212 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ) R213 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R214 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R215 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R216 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R217 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R218 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R219 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) R220 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R221 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R222 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R223 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R224 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R225 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R226 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) R227 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) A onlyR228 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) A onlyR229 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) A onlyR230 7030003610 S.RESISTOR ERJ3GEYJ 273 V (27 kΩ) R232 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) R233 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R234 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R238 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R239 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) R240 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)

R241 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R242 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R243 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ) R244 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R245 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) B

7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) AR246 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) R247 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R248 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω) R249 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R250 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) R251 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ) R252 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R253 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)

C1 4030007000 S.CERAMIC C1608 CH 1H 090D-TC2 4030006980 S.CERAMIC C1608 CH 1H 070D-TC3 4030009650 S.CERAMIC C1608 CH 1H 240J-TC4 4030011530 S.CERAMIC C1608 CH 1H 110J-TC5 4030007050 S.CERAMIC C1608 CH 1H 220J-TC6 4030006860 S.CERAMIC C1608 JB 1H 102K-TC7 4030006860 S.CERAMIC C1608 JB 1H 102K-TC8 4030007090 S.CERAMIC C1608 CH 1H 470J-TC9 4030006860 S.CERAMIC C1608 JB 1H 102K-TC10 4030007040 S.CERAMIC C1608 CH 1H 180J-TC11 4030007030 S.CERAMIC C1608 CH 1H 150J-TC12 4030006860 S.CERAMIC C1608 JB 1H 102K-TC13 4030007030 S.CERAMIC C1608 CH 1H 150J-TC14 4030007030 S.CERAMIC C1608 CH 1H 150J-TC15 4030006860 S.CERAMIC C1608 JB 1H 102K-TC17 4030007110 S.CERAMIC C1608 CH 1H 680J-TC18 4030007090 S.CERAMIC C1608 CH 1H 470J-TC20 4030006860 S.CERAMIC C1608 JB 1H 102K-TC21 4030006860 S.CERAMIC C1608 JB 1H 102K-TC23 4030011600 S.CERAMIC C1608 JB 1E 104K-TC24 4030017430 S.CERAMIC ECJ0EC1H101JC25 4030006860 S.CERAMIC C1608 JB 1H 102K-TC26 4030006860 S.CERAMIC C1608 JB 1H 102K-TC27 4030006860 S.CERAMIC C1608 JB 1H 102K-TC33 4030007130 S.CERAMIC C1608 CH 1H 101J-TC34 4030006860 S.CERAMIC C1608 JB 1H 102K-TC35 4030007090 S.CERAMIC C1608 CH 1H 470J-TC36 4030007040 S.CERAMIC C1608 CH 1H 180J-TC37 4030006860 S.CERAMIC C1608 JB 1H 102K-TC38 4030007000 S.CERAMIC C1608 CH 1H 090D-TC39 4030007020 S.CERAMIC C1608 CH 1H 120J-TC40 4030006860 S.CERAMIC C1608 JB 1H 102K-TC41 4030006980 S.CERAMIC C1608 CH 1H 070D-TC42 4030007050 S.CERAMIC C1608 CH 1H 220J-TC43 4030006860 S.CERAMIC C1608 JB 1H 102K-TC44 4030009520 S.CERAMIC C1608 CH 1H 020B-TC45 4030007090 S.CERAMIC C1608 CH 1H 470J-TC46 4030006860 S.CERAMIC C1608 JB 1H 102K-TC48 4030006860 S.CERAMIC C1608 JB 1H 102K-TC49 4030009500 S.CERAMIC C1608 CH 1H 0R5B-TC51 4030009520 S.CERAMIC C1608 CH 1H 020B-TC56 4550006450 S.TANTALUM ECST1EY105RC57 4030007090 S.CERAMIC C1608 CH 1H 470J-TC58 4510004630 S.ELECTROLYTIC ECEV1CA100SRC59 4030007090 S.CERAMIC C1608 CH 1H 470J-TC60 4030006860 S.CERAMIC C1608 JB 1H 102K-TC61 4030006860 S.CERAMIC C1608 JB 1H 102K-TC62 4030011600 S.CERAMIC C1608 JB 1E 104K-TC63 4030006860 S.CERAMIC C1608 JB 1H 102K-TC64 4030011600 S.CERAMIC C1608 JB 1E 104K-TC65 4030009520 S.CERAMIC C1608 CH 1H 020B-TC66 4030008750 S.CERAMIC C1608 CH 1H 360J-TC67 4030006870 S.CERAMIC C1608 JB 1H 222K-TC69 4030007120 S.CERAMIC C1608 CH 1H 820J-TC70 4030006860 S.CERAMIC C1608 JB 1H 102K-TC71 4030006860 S.CERAMIC C1608 JB 1H 102K-TC72 4030006860 S.CERAMIC C1608 JB 1H 102K-TC73 4030007090 S.CERAMIC C1608 CH 1H 470J-TC75 4550006450 S.TANTALUM ECST1EY105RC76 4550006600 S.TANTALUM ECST0JY335RC78 4030006860 S.CERAMIC C1608 JB 1H 102K-TC80 4030007090 S.CERAMIC C1608 CH 1H 470J-TC81 4030007130 S.CERAMIC C1608 CH 1H 101J-TC82 4030011600 S.CERAMIC C1608 JB 1E 104K-TC83 4030007130 S.CERAMIC C1608 CH 1H 101J-T

6 - 3




S.=Surface mount

C84 4030006900 S.CERAMIC C1608 JB 1H 103K-TC85 4510005860 S.ELECTROLYTIC ECEV1HA2R2SRC86 4030006860 S.CERAMIC C1608 JB 1H 102K-TC87 4030007090 S.CERAMIC C1608 CH 1H 470J-TC88 4030011600 S.CERAMIC C1608 JB 1E 104K-TC89 4030006860 S.CERAMIC C1608 JB 1H 102K-TC90 4030007100 S.CERAMIC C1608 CH 1H 560J-TC91 4030007100 S.CERAMIC C1608 CH 1H 560J-TC92 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC93 4030007090 S.CERAMIC C1608 CH 1H 470J-TC94 4030007090 S.CERAMIC C1608 CH 1H 470J-TC95 4030006860 S.CERAMIC C1608 JB 1H 102K-TC96 4030011600 S.CERAMIC C1608 JB 1E 104K-TC97 4030011600 S.CERAMIC C1608 JB 1E 104K-TC98 4030006900 S.CERAMIC C1608 JB 1H 103K-TC99 4030011530 S.CERAMIC C1608 CH 1H 110J-TC100 4030007040 S.CERAMIC C1608 CH 1H 180J-T A

4030007050 S.CERAMIC C1608 CH 1H 220J-T BC101 4030007010 S.CERAMIC C1608 CH 1H 100D-T A

4030009910 S.CERAMIC C1608 CH 1H 040B-T BC102 4030009910 S.CERAMIC C1608 CH 1H 040B-T A

4030011770 S.CERAMIC C1608 CH 1H 060B-T BC103 4030017460 S.CERAMIC ECJ0EB1E102KC104 4030007060 S.CERAMIC C1608 CH 1H 270J-T B

4030007090 S.CERAMIC C1608 CH 1H 470J-T AC105 4030009530 S.CERAMIC C1608 CH 1H 030B-T A

4030009550 S.CERAMIC C1608 CH 1H 2R5B-T BC106 4030009510 S.CERAMIC C1608 CH 1H 010B-TC107 4030006860 S.CERAMIC C1608 JB 1H 102K-TC108 4030007090 S.CERAMIC C1608 CH 1H 470J-TC109 4030006900 S.CERAMIC C1608 JB 1H 103K-TC110 4030007090 S.CERAMIC C1608 CH 1H 470J-TC111 4030009530 S.CERAMIC C1608 CH 1H 030B-T A

4030009910 S.CERAMIC C1608 CH 1H 040B-T BC112 4030006900 S.CERAMIC C1608 JB 1H 103K-TC113 4030007100 S.CERAMIC C1608 CH 1H 560J-TC114 4030017460 S.CERAMIC ECJ0EB1E102KC115 4030006860 S.CERAMIC C1608 JB 1H 102K-TC116 4030009550 S.CERAMIC C1608 CH 1H 2R5B-TC117 4030007120 S.CERAMIC C1608 CH 1H 820J-TC118 4030006860 S.CERAMIC C1608 JB 1H 102K-TC119 4030009540 S.CERAMIC C1608 CH 1H 1R5B-TC120 4030007070 S.CERAMIC C1608 CH 1H 330J-T B

4030007110 S.CERAMIC C1608 CH 1H 680J-T AC121 4030006860 S.CERAMIC C1608 JB 1H 102K-TC122 4030009350 S.CERAMIC C1608 CH 1H 3R5B-T A

4030011770 S.CERAMIC C1608 CH 1H 060B-T BC123 4030007040 S.CERAMIC C1608 CH 1H 180J-TC124 4030006860 S.CERAMIC C1608 JB 1H 102K-TC125 4030007060 S.CERAMIC C1608 CH 1H 270J-TC126 4030007070 S.CERAMIC C1608 CH 1H 330J-TC127 4030007090 S.CERAMIC C1608 CH 1H 470J-TC128 4030006860 S.CERAMIC C1608 JB 1H 102K-TC129 4030007100 S.CERAMIC C1608 CH 1H 560J-TC130 4030006900 S.CERAMIC C1608 JB 1H 103K-TC132 4030006860 S.CERAMIC C1608 JB 1H 102K-TC133 4030009510 S.CERAMIC C1608 CH 1H 010B-TC134 4030007000 S.CERAMIC C1608 CH 1H 090D-TC136 4030006900 S.CERAMIC C1608 JB 1H 103K-TC137 4030007130 S.CERAMIC C1608 CH 1H 101J-TC138 4030006860 S.CERAMIC C1608 JB 1H 102K-TC139 4030006860 S.CERAMIC C1608 JB 1H 102K-TC140 4030007120 S.CERAMIC C1608 CH 1H 820J-TC142 4030006860 S.CERAMIC C1608 JB 1H 102K-TC143 4030006860 S.CERAMIC C1608 JB 1H 102K-TC144 4030006860 S.CERAMIC C1608 JB 1H 102K-TC145 4030008680 S.CERAMIC C2012 JF 1C 105Z-TC146 4030006860 S.CERAMIC C1608 JB 1H 102K-TC147 4030011600 S.CERAMIC C1608 JB 1E 104K-TC148 4030007010 S.CERAMIC C1608 CH 1H 100D-TC149 4030007040 S.CERAMIC C1608 CH 1H 180J-TC150 4030009520 S.CERAMIC C1608 CH 1H 020B-TC151 4030007040 S.CERAMIC C1608 CH 1H 180J-TC152 4030007010 S.CERAMIC C1608 CH 1H 100D-TC153 4030006900 S.CERAMIC C1608 JB 1H 103K-TC154 4030007160 S.CERAMIC C1608 CH 1H 181J-TC155 4030007160 S.CERAMIC C1608 CH 1H 181J-TC156 4030006860 S.CERAMIC C1608 JB 1H 102K-TC157 4030006860 S.CERAMIC C1608 JB 1H 102K-T

C158 4030006860 S.CERAMIC C1608 JB 1H 102K-TC159 4030006860 S.CERAMIC C1608 JB 1H 102K-TC160 4510004640 S.ELECTROLYTIC ECEV1CA470SPC161 4030006860 S.CERAMIC C1608 JB 1H 102K-TC162 4030006850 S.CERAMIC C1608 JB 1H 471K-TC163 4550006741 S.TANTALUM TEMSVC 0J 107M (TW) 12RC164 4030008920 S.CERAMIC C1608 JB 1H 473K-TC165 4030007090 S.CERAMIC C1608 CH 1H 470J-TC166 4550006700 S.TANTALUM ECST1AY106RC167 4030008920 S.CERAMIC C1608 JB 1H 473K-TC168 4030009660 S.CERAMIC C1608 JF 1C 224Z-TC169 4550006650 S.TANTALUM ECST1CY685RC170 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC171 4030009660 S.CERAMIC C1608 JF 1C 224Z-TC172 4510006090 S.ELECTROLYTIC ECEV0GA470SRC173 4030011600 S.CERAMIC C1608 JB 1E 104K-TC174 4030007150 S.CERAMIC C1608 CH 1H 151J-TC175 4030008770 S.CERAMIC C1608 JB 1H 562K-TC176 4030009970 S.CERAMIC C1608 JB 1H 182K-TC177 4550006170 S.TANTALUM ECST1AY225RC178 4030006900 S.CERAMIC C1608 JB 1H 103K-TC179 4030008680 S.CERAMIC C2012 JF 1C 105Z-TC181 4030008920 S.CERAMIC C1608 JB 1H 473K-TC182 4030008920 S.CERAMIC C1608 JB 1H 473K-TC183 4030011600 S.CERAMIC C1608 JB 1E 104K-TC184 4030007160 S.CERAMIC C1608 CH 1H 181J-TC185 4030011600 S.CERAMIC C1608 JB 1E 104K-TC186 4030006870 S.CERAMIC C1608 JB 1H 222K-T A

4030008770 S.CERAMIC C1608 JB 1H 562K-T BC187 4030008880 S.CERAMIC C1608 JB 1H 223K-T B onlyC188 4510004630 S.ELECTROLYTIC ECEV1CA100SRC189 4030006850 S.CERAMIC C1608 JB 1H 471K-TC190 4030008920 S.CERAMIC C1608 JB 1H 473K-TC191 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC192 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC193 4030007050 S.CERAMIC C1608 CH 1H 220J-TC194 4030007030 S.CERAMIC C1608 CH 1H 150J-TC195 4030007110 S.CERAMIC C1608 CH 1H 680J-TC196 4030006850 S.CERAMIC C1608 JB 1H 471K-TC197 4510005430 S.ELECTROLYTIC ECEV0JA220SRC198 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC199 4030006860 S.CERAMIC C1608 JB 1H 102K-TC200 4030008890 S.CERAMIC C1608 JB 1H 273K-TC201 4030007090 S.CERAMIC C1608 CH 1H 470J-TC202 4030006860 S.CERAMIC C1608 JB 1H 102K-TC203 4030006900 S.CERAMIC C1608 JB 1H 103K-TC204 4030006900 S.CERAMIC C1608 JB 1H 103K-TC205 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC206 4550006200 S.TANTALUM ECST0JY106RC207 4510004630 S.ELECTROLYTIC ECEV1CA100SRC208 4030006900 S.CERAMIC C1608 JB 1H 103K-TC209 4030008630 S.CERAMIC C1608 JF 1H 104Z-TC210 4510005430 S.ELECTROLYTIC ECEV0JA220SRC211 4030006900 S.CERAMIC C1608 JB 1H 103K-TC212 4030006900 S.CERAMIC C1608 JB 1H 103K-TC213 4030006860 S.CERAMIC C1608 JB 1H 102K-TC214 4030007090 S.CERAMIC C1608 CH 1H 470J-TC215 4030006860 S.CERAMIC C1608 JB 1H 102K-TC216 4030006900 S.CERAMIC C1608 JB 1H 103K-TC217 4030011600 S.CERAMIC C1608 JB 1E 104K-TC218 4030008910 S.CERAMIC C1608 JB 1H 393K-TC219 4030011600 S.CERAMIC C1608 JB 1E 104K-TC220 4030009490 S.CERAMIC C1608 JB 1H 821K-TC221 4030006900 S.CERAMIC C1608 JB 1H 103K-TC222 4030011600 S.CERAMIC C1608 JB 1E 104K-TC223 4030007090 S.CERAMIC C1608 CH 1H 470J-TC224 4030008900 S.CERAMIC C1608 JB 1H 333K-TC225 4510004650 S.ELECTROLYTIC ECEV1EA4R7SRC226 4030011600 S.CERAMIC C1608 JB 1E 104K-TC227 4030006900 S.CERAMIC C1608 JB 1H 103K-TC228 4030011600 S.CERAMIC C1608 JB 1E 104K-TC229 4030009880 S.CERAMIC C1608 JB 1H 682K-TC230 4030006900 S.CERAMIC C1608 JB 1H 103K-TC231 4030008910 S.CERAMIC C1608 JB 1H 393K-TC232 4030008920 S.CERAMIC C1608 JB 1H 473K-TC233 4030011600 S.CERAMIC C1608 JB 1E 104K-TC234 4030009490 S.CERAMIC C1608 JB 1H 821K-TC235 4030009490 S.CERAMIC C1608 JB 1H 821K-TC236 4030008880 S.CERAMIC C1608 JB 1H 223K-TC237 4030006860 S.CERAMIC C1608 JB 1H 102K-TC238 4030006860 S.CERAMIC C1608 JB 1H 102K-T

6 - 4



S.=Surface mount

[MAIN UNIT]

C239 4030006860 S.CERAMIC C1608 JB 1H 102K-TC240 4030007090 S.CERAMIC C1608 CH 1H 470J-TC242 4030008470 S.CERAMIC C1608 JB 1H 272K-TC243 4030008770 S.CERAMIC C1608 JB 1H 562K-TC244 4030007160 S.CERAMIC C1608 CH 1H 181J-TC245 4030009630 S.CERAMIC C1608 JB 1H 822K-TC246 4030007110 S.CERAMIC C1608 CH 1H 680J-TC247 4030011600 S.CERAMIC C1608 JB 1E 104K-TC248 4030011600 S.CERAMIC C1608 JB 1E 104K-TC249 4030017480 S.CERAMIC C1608 JB 1A 474K-T A onlyC252 4030007130 S.CERAMIC C1608 CH 1H 101J-TC253 4030007000 S.CERAMIC C1608 CH 1H 090D-TC255 4030007050 S.CERAMIC C1608 CH 1H 220J-TC257 4030011600 S.CERAMIC C1608 JB 1E 104K-TC258 4030007090 S.CERAMIC C1608 CH 1H 470J-TC259 4030006900 S.CERAMIC C1608 JB 1H 103K-TC260 4030006860 S.CERAMIC C1608 JB 1H 102K-TC261 4030006860 S.CERAMIC C1608 JB 1H 102K-TC262 4030011600 S.CERAMIC C1608 JB 1E 104K-TC265 4030006980 S.CERAMIC C1608 CH 1H 070D-TC266 4550000530 S.TANTALUM TESVA 1V 104M1-8LC267 4030011770 S.CERAMIC C1608 CH 1H 060B-TC268 4030009550 S.CERAMIC C1608 CH 1H 2R5B-TC269 4030006860 S.CERAMIC C1608 JB 1H 102K-TC270 4030006860 S.CERAMIC C1608 JB 1H 102K-T

J1 6910013720 CONNECTOR IMSA-9230B-04Z120-T C onlyJ2 6910013730 CONNECTOR IMSA-9230B-07Z120-TJ3 6510021900 S.CONNECTOR BM02B-ASRS-TFJ4 6450001680 CONNECTOR HSJ1122-010010J5 6450002250 CONNECTOR HSJ1456-010320

MC1 7700002540 MICROPHON SKP-4538

S1 2230001060 S.SWITCH EVQ-PUL 02KS2 2230001060 S.SWITCH EVQ-PUL 02KS3 2230001060 S.SWITCH EVQ-PUL 02K

W8 7030003860 S.JUMPER ERJ3GE JPW VW11 7030003860 S.JUMPER ERJ3GE JPW V B onlyW12 7030003860 S.JUMPER ERJ3GE JPW V B onlyW13 7030003860 S.JUMPER ERJ3GE JPW V B only

EP1 0910054484 PCB B 5680DEP4 6910013370 S.BEAD BLM18BB221SN1DEP5 6910013370 S.BEAD BLM18BB221SN1DEP6 6910013370 S.BEAD BLM18BB221SN1DEP7 6910013370 S.BEAD BLM18BB221SN1D A only

6 - 5

REF ORDER DESCRIPTIONNO. NO.


SECTION 7 MECHANICAL PARTS AND DISASSEMBLY

7 - 1

REF. NO. ODER NO. DESCRIPTION QTY.

SP1 2510001100 Speaker 036D0601 1

MP1 8210017711 2458 front panel-1 1MP4 8930054680 2458 release button 1MP6 8930054690 2458 lens 1MP8 8930054881 2458 plus terminal-1 1MP9 8010018502 2458 chassis-2 1MP10 8930054710 2458 A-main seal A 1

8930054720 2458 B-main seal B 1MP11 8930042350 1922 mic sheet 1MP12 8930050840 2251 minus terminal 1MP13 8830001550 Nut (J) 1MP14 8830001550 Nut (J) A 1

8830001570 Nut (K) B 1MP15 8950005320 2337 contact 1MP18 8610010910 Knob N-281 1MP19 8610010920 Knob N-282 A only 1MP21 8810000100 Screw PH M 2 x 4 ZK 2MP22 8810009560 Screw B0 M 2 x 6 ZK 2MP26 8930053680 Spring (AG) 1MP27 8210017091 2337 terminal holder-1 1MP28 8930052840 2337 T-rubber 1MP29 8810009510 B0 M02 x 4 NI-ZU (BT) 10MP30 8930043760 1923 Mic seal 1MP32 8950004671 ANT connector 101A 1MP33 8830001250 ANT connector 101 nut 1MP34 8930055110 2458 side plate 1MP35 8810009510 Screw B0 M 2 x 4 NI-ZU (BT) B only 1MP39 8810009180 Screw B0 M 2 x 5 NI-ZU (BT) 1

[CHASSIS PARTS]


MP1 8510013000 2336 VCO case 1MP2 8510011101 1922 VCO cover-1 1MP5 8410002370 2337 PA Heatsink 1MP6 8510014320 2458 A-main shield 1

[MAIN UNIT]

Screw abbreviations B0, BT: Self-tappingPH: Pan headNI: NickelZK: BlackNI-ZU: Nickel-zinc


EP1 Optional product Antenna FA-SC55V-1 1EP2 Optional product Battery BP-222 [F11BR] 1

Optional product Battery BP-209 (RBRC-Recycle) [USA]*2 1Battery BP-209 (EXP-Recycle) [GEN],[EUR]

EP4 Optional product BC-147A C only 1EP5 Optional product BC-146 ACC C only 1MP1 Optional product 1922 Belt clip-1 except [GEN-05] 1MP2 8210017730 2458 Jack panel 1MP3 8810004860 Screw PH M 2 x 6 ZK 2

[ACCESSORIES]

EP1

MP1

MP2

MP3

EP2

EP4

EP5

A: [F11], [F12] B: [F11BR], [F11S], [F12S]C: [F11BR], [F11S]*1

*1: For [USA] only.

*2: Except [F11BR]

7 - 2

UNIT abbreviation (C): CHASSIS PARTS, (M): MAIN UNIT, (A): Accessories

MAIN unit

MP28 (C)MP15 (C)

MP10 (C)

MP21 (C)

MP32 (C)

MP8 (C)

MP29 (C)

MP29 (C)

MP12 (C)

MP9 (C)

MP22 (C)

IC-F11BR, F11S, F12S

MP34 (C)

MP27 (C)

MP14 (C)MP13 (C)

MP39 (C)

MP29 (C)

MP35 (C)([F11BR, F11S, F12S] only)

MP29 (C)

MP2 (A)

MP3 (A)

MP11 (C)

MP30 (C)

MP29 (C)

MP29 (C)MP2 (M)

MP1 (M)

MP1 (C)

MP6 (M)

MP6 (C)

MP4 (C)

MP26 (C)

MP33 (C)

MP19 (C)([F11, F12] only)

MP18 (C)

SP1 (C)

SECTION 8 SEMI-CONDUCTOR INFORMATION

8 - 1

2SC5085 Y(Symbol: MCY)

2SK1829(Symbol: K1)

2SC5107 O(Symbol: MFO)

2SC5110 O(Symbol: MGO)

2SK880 Y(Symbol: XY)

2SK2974(Symbol: K2974)

2SC4116 GR(Symbol: LG)

2SA1577 Q(Symbol: HQ)

2SB1132 R(Symbol: BARB)

3SK272(Symbol: K)

2SC4215 O(Symbol: QO)

2SK2973(Symbol: K1)

DTC144 TU(Symbol: 06)

DTC144 EU(Symbol: 26)

UN911 H(Symbol: 6P)

XP1213(Symbol: 9L)

3SK294(Symbol: UV)

DTA144 EU(Symbol: 16)

• TRANSISTOR AND FET’S

B

E

C

B

E

C

B

E

C

G

S

D

S

D

G(top view)

S

B

E

C

B

E

C

B

E

C

B

E

C

B

E

C

B

C

E

E1

B1

B2

C1

C2

E

C

B

E

B

E

C

S

D

G

G1

G2

S

D

XP6501 AB(Symbol: 5N)

XP4216(Symbol: 8U)

E1

E2

B2

C1

B1

C2

B

E

C

G1

G2

S

D

E1

C2

B1

C1

E2

B2

• DIODES

MA77(Symbol: 4B)

HVU350 B(Symbol: 4)

MA2S077(Symbol: S)

HSU88(Symbol: 9)

MA2S111(Symbol: A)

1SV307(Symbol: TX)

RB706F-40(Symbol: 3J)

A C

A C

HVC362(Symbol: V2)

SECTION 9 BOARD LAYOUTS

9 - 1

9-1 MAIN UNIT• TOP VIEW

C196

R159

C194

C19

3

C19

1

C84

C43 L11

C86

C20

1

C20

8

C20

9

R23

0

R25

1

R19

R20

R34 R21

4

R39

R32

R29

R26

C46

C60

R15

5

R24

8

C24

6

C22

4

C23

0

C94

R16

6

R11

1

R11

0

R16

7

R11

5

R81

C26

0

C26

2

C21

3

C35

L9

C26

1

C18

C20

C33

C24

C25

C23

7C

23

R54

R1

EP

6

R80

R11

7

R13

9

R77

R17

R25

3

R24

4

R23

8

R6

R3

R10

2R

164

R9 R8

R24

3

R16

R25

2

R18

R92

C12

5

C36

C12

4

C38

C48

R16

8

R23

4

R20

6

R20

8R

207

R12

8

R13

7

C20

4 C21

4

C93

C18

4

C25

8

C25

2

C63

C73 C26

8C71

D6

C25

9

C20

5

R24

6

R17

0

R15

3

R16

9

C24

2

C24

3

R22

4 R21

5

R18

9

R22

5R

226

R24

5

R19

4

R19

1

R19

7

R15

6

X3

C85

C19

7

Q24

Q36

Q6

Q10

D4

Q4

L53

D24

D2

L52

L51

R2

C16

6D22

IC10

L17

D5

D7

L29

Q23

C22

5

C58

IC12

IC13 Q30

C18

8

C17

2

IC5

C16

0

L6

Q1

L3

S2 S3 S1

X3

X1

R16

3

IC15

R151

R164

R222

R223

C244

R122

R50

R51

D19

C223

C269 C229

C228

C231R196

R198 R112 R123

R94

R121

R114

R13

R79

R10 R5

R4

R56

R95

R55

R7

R78

R221

R120

R138

R136 R129

R203R104

R204

R209

R205

R113

R116

C185 C270

C236

C159

C158

C157

C9

C8

C156

C103

R71

C114

R63

C34

C21C37

C26

C27

C255 C17

C15

C140

C143

C175

C174

C233 C232

C235

C226

W11

R143

R146

R22 R23R21

R31

R35

R24

R187

R188

R195

R190

R193

R192

C253

C44

C61

C65 C51

C69

C66

C67

C40 C267

C41

L50

L10

L15

C62

R250 R249

C87

C88 C192

IC16

X1

C210

C206

Q8

Q7Q5

C177

C145

D3

C163

Q2

J3

Q14

Q11

L16

C207

Q25

FI2

X2

MC1

MP1, MP2

MP6

J3 J4

B5680DVHF

X2

A

J2J1

J2 to the SW-A/B units

1

7 GNDTLEDRLEDVCCVOLINVOLOUTCBI0

J1 to the SW-A unit

1

4 CBI3CBI2CBI1CBI0

J3 to the speaker

12G

ND

SP

9 - 2

• BOTTOM VIEW

R130

Q21

L26

Q16

Q17

R147

R200

R149

Q18

C76

Q13 Q31

Q27Q26

IC1

IC11

IC7

Q28

Q33

L19

L4

IC2

C169

L1

L2

L5

D17

IC4

Q19Q

20

D32

MP5

FI1

L21

L54

L20

L22

IC6

L24

L28

Q35

Q29

L27 Q12

R52

C56

C75

C26

6

R14

8R

201

IC3Q15

R125

R119

R118R127

R73

R242

R165

R75

R83

C202 C154

C155

Q22

C189

C187

C186

C203C178C176

R93

R100

R99

R98

R184

R176

R158

R154

R210

R212

C195 D16

R233

R234

W13

R177

R199

R239

R36

R40

R53

R232

R172 R171

R174R173

R202

R46

R180

R182

R220

R181

R185

R141

R140

R86 R90

R89

R76

R133

R229

R62

R64

C161

C101

C100

C99

C5

C2

C6 C7

C98

C96

R59

R60

R103 R247

R105

R211

CHASSISMP15

R109R61

R57 C165

C167

C134

D9

D1

D18

C162

C106

C113

C115 C119 C138

IC9

C126

C127C137

C128C136

C39

C49

C148

C146

C147

C219

C142

C152

C57 C42

C91

C89

C216

C80

C92C83

C81

C212

C82

C64

C70

C211

C90

C217

C227

C153

C123

C121

C129

C118

D10

R13

4R

228

R13

1

R65

R66

R72

R74

R85

R88 R28

R38

D20

D23

D21

R45

R41

R43

R44

R27

R42

R49

R48

R16

1

R47R24

0

R37

R91

R14

2

R97

C15

0

C14

9

C45

C15

1

C59

C72

C78

R95

R18

3

R17

8

R17

9

R21

6

R24

1

R21

7

R21

8

R21

9

R15

7

R16

0

R15

2

R96

R24

5

R68

R22

7R

70

R13

2

R12

6

R12

4

C18

2

C18

1

C18

3

C10

5

C10

4

C4

C10

C11

C12

C97

C23

8 C23

9

C17

1

C17

0

C16

8

C21

5

R21

3

R58

R10

7R

106

R17

5

C24

0

W8

EP

4

EP

5

C14

C13

C3

C1

C10

2

D12

D13

C25

7

C10

7

C26

5

C11

1

L56

C24

9

C10

8

C11

2

C10

9

C17

3C

179

C12

2

C19

0 C22

2 C22

0

C24

8

L18

C24

7

C20

0

C19

9

C19

8

C21

8W

12C22

1

C13

2

C13

0 C13

3

C13

9C

144

L25

C11

6

D14

D15

C11

7

C12

0

C11

0

IC8

D25

9 - 3

9-2 SW-A AND SW-B UNITS• TOP VIEW

SW-A UNIT

F1

Q1 DS

1

B56

03C

SW-B UNIT

F1

Q1 DS

1

9 - 4

• BOTTOM VIEWSW-A UNIT

SW-B UNIT

R2

R3

R1S1

J2 to the MAIN unit J2

1 7

CB

I0V

OLO

UT

VO

LIN

VC

CR

LED

TLE

DG

ND


1 4

CB

I0C

BI1

CB

I2C

BI3

S1

W1 R2

R3

W2 R1

B5604C


1 7

CB

I0V

OLO

UT

VO

LIN

VC

CR

LED

TLE

DG

ND

10 - 1

SECTION 10 BC-146 OPTIONAL DESKTOP CHARGER INFORMATION


MP1 8010018620 2447 case (A) 1MP2 8110007450 2447 cover 1MP3 8930039620 Leg cushion (A) 4MP4 8930055020 2480 spacer 1MP5 8930055030 2480 BC-spacer 1MP6 8810008660 Screw B0 M 3 x 8 NI-ZU (BT) 1

[CHASSIS UNIT]

10-1 PARTS LIST 10-2 DISASSEMBLY INFORMATION

MP1

MP2

MP6

MP3

MP4

MP5

MP3

CHARGE unit

MP3

MP3 NOTE:BA :CHASSIS UNIT

:CHARGE UNIT

A

A

A

MP1 B

MP2 B

A

A

A

A

A

A


[CHARGE UNIT]

R1 7010007550 RESISTOR ERG3SJ680H 1R2 7010007100 RESISTOR PSD1/4V 1 kΩ 1 J1 6510023070 CONNECTOR HEC2305-01-250 1

DS1 5040001390 LED TLG124A 1

EP1 0910053820 PCB B 5650 1

MP1 8930051341 2338 TERMINAL-1MP2 8930051341 2338 TERMINAL-1

Screw abbreviations B0, BT:Self-tappingNI-ZU :Nickel-Zinc

NOTE: BC-146 is included with IC-F11BR and IC-F11S (For USA).

10 - 2

10-3 VOLTAGE DIAGRAM

10-4 BOARD LAYOUT

MP1R1 68

J1HEC0470-01-230

R21k

DS1TLG124A

MP2

C : 13.8VN : 13.8V

C : 7.2VN : 13.8V

C : 9.2VN : 13.8V

J1

MP1

MP2

B5650

R1

R2

DS1

11 - 1

SECTION 11 BLOCK DIAGRAM

146–174MHzANT

Q12SK2974

D1: 1SV307D9,D10: MA77

D2RB706F-40Q2

2SK2973Q42SC5110

VCOSW

D3,D4MA77Q7

2SC5107Q52SC5107

Q8 DTC144UED22 MA77

R5VS5V

Q12XP6501

Q10 2SC5085Q11 2SC5085D5 HVU350D7 HVU350

LVIN BUFF

Q132SK880

IC1MB15A02PFV1

X1CR-664A

REF

BAL

DEV

15.3MHz

Q182SC4116

REF

Q312SC4215D19HVC362

114.95–174MHz

DET

PLSTSOSCKUNLK

SECOND MIXERIF AMPSQL AMPDETECTOR

MOD

TX VCO

30.6 MHz

D6MA2S077

IC3TA31136FN

IF ICNOIS

Q62SC5107

Q172SC4215

FI1FL-311

31.05MHz

Q163SK272

114.95–142.95MHz

D15HVU350

D14HVU350

D13HVU350

PWRDET

T4

IC2TA75S01F

D12HVU350

MUTESW

LPFANTSW

PWRAMP

YGRAMP

PREDRIVE

APCAMP

Q14DTA144EU

TXC

EXT.MIC

T1

MC1KUC3523

+5V

PTTSW

Q22UN911H

J4

HSJ1122 010010

T2

Q153SK294

PTT

T4

T3

MIXER

FI2

RSSI

450kHz

X2CDBCA450CX24

ALFYM450F=K

SQ

LIN

MICDET

DEV

DET

D/A

T1T2T3T4

Q21DTC144EU

IC5CNJM13403V

IC5BNJM13403V

IC9M62363FP

IC6BU4066BCFV

IC5DNJM13403V

IC6BU4066BCFV

ANALOGSW

ANALOGSW

AF VRR1

VOLIN

2ch VERSIONS1 AS-244-A13

VCC

CH SELECT/EMERGENCY

S1SW-A TP70QF4161SW-B (EMER) SKHHLP014A

VOLOUT

CBI0

AF AMPREG

AFONSP+

SP–

Q19 2SB1132Q20 XP6501

AFOUT

S3

J5

HSJ1456-01-220A

INT.SP

PTT

INT.MIC

F1

F2

EXT.SPIC4TA7368F

CLI, CLO

CLONE

CLONEBUFF Q32 DTC144TU

F1

F2

PTT

TXC

D17 RB706F-40

BATT

FUSE

F1

LED SW

Q1 XP4216

HV

CBI0CBI1CBI2CBI3

RLEDTLED

TX LED

BUSY LED

DS1LNJ107W5PRW

IC16NJM12904V

SWW/NNWC

DASTSCKSO

Q292SC4116

CTCSS/DTCS

REF

BAL

IC12ANJM12904V

RESTO-RATION

FILSW

FILSW

CDEC

IC12BNJM12904V

Q30XP1213

Q28DTC144EU

ANALOGSW

IC13TC7S66FU

DUSE

CENC0CENC1CENC2

SENC0SENC1SENC2SENC3

+5REG

S5REG

VCC

+5V

S5V

IC10NJM2870

Q242SB1132

S5CONT

Q23DTA144EU

Q25XP6501 EEPROM

RESET

CPU5V

RES

IC8S-8094ANMP

RMUT

MMUT

DUSE

SOSCKEXST

IC15

SCKESDA

CPUIC7HD6433664

IC11HN58X2416TI

X3CR-702

BEEP

NOIS

RSSI

LVIN

BDET

TEMP

BATV

D16MA77SHIFT

SW

EXP-ANDER

NWC

CSFTS5CR5C

T5C

BU4094BCFV

R5REG

T5REG

R5V

T5V

Q262SA1577

Q272SA1577

SDEC

IC5ANJM13403V

Explanatory notes

COMMON LINE

TX LINE

RX LINE

CONTROL LINE

BPFBPFBPFBPF RFAMP

TX / RXSWBUFFBUFF

BUFFATT

XTRLBPFAMP

RIPPLEFIL

LOOPFIL

PLLIC

BPF

LPF

x 3

CERAMICBPF

MIC

AF AMP

LPF

AMP

HPF

HPF

LPF LPF

BE

EP

TO

NE

TO

NE

RM

UT

RM

UT

MM

UT

CT

CS

S

R5C

LPF

LPF

MAIN UNIT

SW-A/SW-B UNIT

BUFF

Q362SK1829

12 - 1

SECTION 12 VOLTAGE DIAGRAM

R47 47

Q112SC5085 Y

VCC

CBI0CBI1CBI2CBI3

RLEDTLED

CBI0

C1560.001

C1570.001

C1580.001

C1590.001

W13D only

W12D only

W11D only

VOLINVOLOUT

C9347 P

C9447 P

F1

F2

C840.01

R5147 k

D19HVC362

C852.2

R5010 kREF

BAL

R521k

C920.1

D20MA2S111

R232150 k

OSCINOSCOUT

VPVCC

DOGND

LDFINCLOCK9

DATA10LE11 FC12NC13FOUT14P15 R

16

87654321

R246 22

SCKUNLK

PLSTSO

LVIN

DEV+5VR5VS5V

+5VR5VS5V

DEV

R5VS5V

VCCS5V+5V

VOLIN

VOLOUTAFOUT

C860.001

C1502 P

C1530.01

R961.2 k

R97680 kC152

10 P C14918 P

L28

C15118 P

R100100 k

1.2 k470

R438.2 k

R4510 k

R4947 k

D21MA2S111

C8047 P

R4882 k

C83100 P

C81100 P

R461.2 k

X1CR-664A

C252100 P

C890.001

C9056 P

R421

R5356 C91

56 PC8747 P

L1833 nH

C880.1

C1440.001C145

1C1460.001

C1470.1

C14810 P

R9447

R221100 k

C1430.001

FI2ALFYM450F=K

O I

R95150

R98390 k

L27

C154180 P

C155180 P

C780.001

R441 kC82

0.1

C7347 P

C1380.001

C1390.001

NO

IS

RS

SI

DE

T

R93330

X2CDBCA450CX24

C14082 P

R921.2 k

C763.3

R40220

R412.2 k

T5VVCO5V

C480.001

2

3

R5VS5V

RSSI

L25C12747 P

C1280.001

C1300.01

C1320.001

C1331 PC134

9 P

C1360.01

R83100

R85560

R88820

R89470

R90120 k

R91680

R86120

L26C12956 P

C137100P

MIC MIC

C189470 P

C1900.047

R141470

R142100 k

C18810

PTT

C1820.047

C1830.1

C184180 P

C1850.1

R13610 k

R138470

R139100 k

R14015 k except A

C1860.0056 B 0.0022 A

8 9

10

C1870.022 except A

R137200 k

R1344.7 k

VCCS5V+5V

C1810.047

R12710 k7

R13210 k

R126180 k

R12847 k

R12910 k

C2570.1

R13312 k

R13012 k

R1315.6 k

R24222 k

C1791

R1251 M

C2020.001

VOLIN

VOLOUT

SQLIN

VCC

AFOUT

R165470

SCKSO

T1T2T3T4DAST

SCKSO

T1T2

DASTSCKSO

T1T2

T3T4

DAST

SQLINVCC

+5V

R16910k

1 32

456

VOLIN

VO

LIN

VOLOUT

VO

LOU

T

AFOUT

SQLIN

SQLIN

SQ

LIN

VCC

VC

C

+5V

+5V

R5V

R5V

S5V

S5V

R5V

S5V

R5V

S5V

T5V

T5V

VC

C

+5V

R5V

S5V

T5V

AF

OU

T

+5V

MIC

R17110 kR173

10 kC2130.001

MIC

OPTMIC

C2150.001

C2370.001

R17533 k

EP4

EP5

J4

C21447 P

MC1MIC

PTT

EXT.MIC

EXT.SP

BDET

C21022

C2110.01

C2120.01

R1724.7 k

R1744.7 k

R210120 k

R211100 k R217

47 kR218100 k

D17RB706F-40

R213470

R21622 k

R2481

S5V S5V

R5V

C20710

C2080.01

C2090.1

R1702.2 k

C2050.1

R219220 k

C2590.01

C20610

C2030.01

C2040.01

C235820 P

R166470 k

R167470 k

R168470 k

R2031.5 k

R204390 k

R205180 k

R20682 k

R20739 k

R208100 k

R209100 k

C2360.022 1

23

11

4

R187470

R5V

C2240.033

C2260.1

C2290.0068

C2300.01

C2330.1

C234820P

R188470 k

R189100 k

R19047k

R19147k

R19218 k

R193220 k

R19468 k

R195120 k

R19722 k

54 3

2

1

3

21 5

4

C2270.01

C2280.1

R19622 k

C2320.047

3

21

4

8

56

7

C2254.7

C2310.039

R19822 k

R22468 k

R22568 k

R22668 k

C2430.0056

C2450.0082

3

21

4

8

C244180 P

C24668 P

C22347 P

R2141 k

R22268 k R223

68 k

C2420.0027

C25847 P

R21522 k

AFOUTSPCLONE

C2390.001

C24047 P

J5

VCC

+5V

+5V +5V

S5V

C2380.001

4

56 1

SP

C5810

C5947 P

LV C5747 P

VCCT5V

S5V

R2202.2 k

L17

C751

C490.5 P

R3533 k

R3882 k

T5C

CLI

CLO

R5C

BD

ET

SE

NC

3

SE

NC

2

TO

NE

DE

T

SD

EC

CD

EC

SE

NC

1

S5C

SE

NC

0

5

67

VCCT5V

S5V+5V

+5V +5V

+5V

VCC

NW

C

MM

UT

R5C RM

UT

I/O1

O/I2

O/I3

I/O4

CONT.B5

CONT.C6

VEE7

141312111098I/O

O/IO/II/O

CONT.DCONT.A

VDD

CT

RL

GN

DV

B

VIN

VO

UT

RE

F

REF

DUSE

BA

L

BAL

DE

V

DEV

+5V

DE

T

DETSQLIN

S1

S2

1234

J1C only

FromSW-A UNIT

From/toSW-A and SW-BUNITS

1234567

J2

C1610.001

C162470 P

C16047

SPEAKER

W1CHASSIS UNIT

OPC-963

12

SP1

12

J3

S3

910111213141516

87654321

OSCOUTOSCIN

MIXOUTVCCIFINDECFILOUTFILIN AFOUT

QUADIFOUT

RSSIN-DETN-REC

GNDMIXIN

C1420.001

VIN11

VOUT12

VOUT23

VIN24

VDD5

LD6

CLK7

DI8

VIN39

VOUT310

VOUT411

VIN412

242322212019181716151413VIN5

VOUT5VOUT6

VIN6DO

VDAREFRESET

GNDVIN7

VOUT7VOUT8

VIN8

6

5

Q102SC5085 Y

Q8DTC144EU

Q163SK272

Q172SC4215 O

IC6 BU4066BCFVIC5B NJM13403V

Q21 DTC144EU

IC9 M62363FP-650CIC10NJM2870

Q262SA1577 QQ27

2SA1577 Q

Q182SC4116 GR

IC1 MB15A02PFV-1

Q312SC4215 O

IC3 TA31136FN(D)

Q132SK880 Y

Q12 XP6501 AB

IC5ANJM13403V

IC13TC7S66FU

Q30 XP1213

IC12BNJM12904V

IC12ANJM12904V

IC16B NJM12904V

Q24 2SB1132 R

Q25XP6501 AB Q23

DTA144 EU

IC16ANJM12904V

Q32DTC144TU

Q22 UN911H

IC5C NJM13403V

FI1FL-311

1 3

5 4 2

D24HSU88

C2690.001

C2539 P

R249 470 k

R23027 k

R250 470 kR251120 k

EP7 A only

C720.001

R2847

R29820

C700.001

C640.1

C630.001

C561

C6982 P

C670.0022

C6636 P

R47 47

C2700.001

Q362SK1829 R31

4.7 k

C512 P

C600.001

Q112SC5085 Y

C610.001

C652 P

R324.7 k

L15

L1680 nH

D7HVU350B

D5HVU350B

C2682.5 P

R37220 k R27

10 kR2401 k C71

0.001

R361 k

D22MA77

C620.1

R3447 k

R391 kD6

MA2S077

4.9 V

4.8 V15.3 MHz0.75 V P-P

4.7 V0 V

UNLOCK 0.5 VLOCK 4.5 V

2.9 V0 V

PTT ON 4.8VPTT OFF 0V

WIDE 4.8 VNAR 0 V

2.1 V

1.0 V0 V

2.5 V

0.7 V0 V

3 V P-P

5/2 tonecodetransmitting

4.8 V

4.9 V0 V

0 V4.9 V

2.1 V

3.5 V0 V

4.5 V0 V

1.8 V0 V

VCC

T5V

VCO5V

a

b

R5V

S5V

RSSI

c

d

VCC

S5V

e

f

VOLIN

g

VOLOUT

AFOUT

BUS LINE 1

BUS LINE 2

VCC

+5V

h

BUS LINE 3

S5V

DUSE

MAIN UNIT(1) MAINUNIT(2)

C324 P

C522 P

C60.001

R182 k

D11SV307

L132 nH

L230 nH

C8 47P

C90.001C18

47 PC200.001

R2150

L3

T5V

C340.001

C3547 P

R1310

L6

C4547 P R16

100R19100R22

220

R24100

R5V

VCO5V

S5V

RSSI RSSI

C370.001

C389 P

C3912 P

C400.001

C417 P

C4222 P

C430.001

C442 P

C460.001

R1710 k

R181 k

R2047 k

R214.7

R2368 k

R2668 k

D3MA77

L10L11

D4MA77

S5V

C210.001

C260.001

C3618 P

R868

L927 nH

C270.001

R104.7 k

R933 k

C33100 P

C25522 P C7

0.001C120.001

C150.001

C250.001

R315 k

R44.7 k

R522

L450 nH

MP5

L522 nH

R6100 k

R74.7 k

D2RB706F-40

L5260 nH

C230.1

C24100 P

C1315 P

C1415 P

C1768 P

R552.2 k

R5610 k

R5768 k

R239100 k

R5410 kC96

0.1

T4

TX

C

C970.1

R58150 kR60

100

R611 k

D9ISV307

L1950 nH

1

34

5

2

C980.01

C9911 P

L2050 nH

C100 18 P A22 P B

D10MA77

R59120 k

W8

C1024 P A6 P B

C1030.001

C10427 P B 47 P A

C1090.01

C11047 P R62

220 k

R6310 k

D12HVU350B

C1070.001

C10847 P

L2256 nH

L2156 nHR65

120 k A 270 k B

R6418 k A100 k B

R2295.6 k A only

R228470 k A only

D18MA2S111 A only

R22710 k A only

R6610 k

R68470

C249 0.47 A only

C1053 P A2.5 P B

C1061 P

C1120.01

C1140.001

C1180.001

C1191.5 P

C1210.001

C12318 P

C1240.001

C12527 P

C12633 P

R70220 kR71

10 k

R72220 k

R7310 k

R7510 k

R76820

R771 k

R7810 k

R8012

D14HVU350B

D15HVU350B

C12033 P B 68 P A

C11782 P

R79470

R81470

L2456 nH C122

3.5 P A6 P B

C1162.5 P

C1150.001

VCCS5V

VCCS5V

ANT

C1772.2

C1780.01

R117100 k

R12210 k

R12427 k

C248 0.1

R12082 k

R12115 k

R11633 k

R123150 k

R118220 k

R119270 k

C1760.0018

R11127 k

R1122.2 k

R1103.3 k

1413

12 R238100 k

R11410 k

R115120 k

C174 150 P

R113820

C1730.1

C17247

R10968 k

D23MA2S111

R1052.7 k

R1063.3 k

R1071 k

NC1

VCC2

NC3

VIN4

RIPPLE5

109876NF

PHASEPREGNDPWGND

POUT

C1700.1

C1696.8

1 2 3

456 R10410 k

C1670.047

R2471 k

C1710.22

C1680.22

C1640.047

C16547 P

R10210R103

33

C16610

C163100

AFOUT

R21215k

VOLOUT

REMO

R143100 k

R1491 k

R2411 k

VOLOUT

AFOUT

AF

ON

CPU5V

CPU5V

OSC1

TEMP

BATV

C1910.1

R152100 k

R153100 k

R154100 k

R151NTCCM20124AG473JCT

C19568 P

C20147 P R157

12 k

L29

R16010 k

C196470 P

C1990.001

R15912 k

R177 22 k

R18010 k

R17856 k

D16MA77

R1631 k

R17622 k

C2000.027 R158

12 k

R179180 k

CENC1

CENC2

CS

FT

MMUTRMUT

RES RES

CPU5V

OSC2

R1561 M

C1980.1

12315

R15510

X3 CR-702 (14.745600MHZ)

C19322 P

C19415 P

EXSTSOSCK

PLSTDASTEXSTPTT

TXCRLEDTLEDAFONESDACLICLO

R146100 k

R19947 k

BE

EP

SO

SC

KC

BI3

CB

I2C

EN

C2

CE

NC

1C

EN

C0

SE

NC

3S

EN

C2

CB

I1C

BI0

SE

NC

1S

EN

C0

R2011 k

C2160.01

R202100 k

C2470.1

R2001 kR161

10 k

DUSE

C2180.039

C2190.1

C220820 P

R18147 k

R18247 k

R18515 k

R1641 k

R18447 k

C2220.1

T5C

S5CR5C

NWC

R74220 k

C19722

C1750.0056

STRD

CLKOE

Q1Q2Q3Q4Q5Q6Q7Q8

QS9

QS10

8

16

A0 1

A1 2

A2 3

VSS 4SDA5 SCL6 WP7VCC8

NC1

OSC210

NC16

NC

NC

P52

/WK

P2

P53

/WK

P3

P54

/WK

P4

P55

/WK

P5/

AD

TR

GP

10/T

MO

WP

11P

12P

56/S

DA

P57

/SC

LP

74/T

MR

IVP

75/T

MC

IVP

76/T

MO

VN

CN

C

NC

NC

PB

0/A

N0

PB

1/A

N1

PB

2/A

N2

PB

3/A

N3

PB

7/A

N7

PB

6/A

N6

PB

5/A

N5

PB

4/A

N4

P17

/IRQ

3/T

RG

VP

16/IR

Q2

P15

/IRQ

1P

14/IR

Q0

NC

NC

P51/WKP114

NC15

NC2

AVCC3

X24

X1X1 5

VCLVCL 6

RES7

TESTTEST 8

VSSVSS 9

OSC1

OSC2OSC1 11

VCCVCC 12

P50/WKP013

17 26 3230 3118 19 20 21 22 23 24 25 27 28 29

6364 54 50 4962 61 60 59 58 57 56 55 53 52 51

48

39

33

3534

4746454443424140

383736

NC

NCNC

NMIP80/FTCI

P81/FTIOAP82/FTIOBP83/FTIOCP84/FTIOD

P85P86P87

P20/SCK3P21/RXDP22/TXD

NC

C1920.1

BD

ET

LVIN

RS

SI

SD

EC

CD

ES

UN

LKN

OIS

F2

F1

TO

NE

BEEP

T4

T3

T2

S5V

VCC VCC

T5V

S5V

ES

DA

SC

K

R234100 k

R233100 k

Q52SC5107 O

Q62SC5107 O

Q72SC5107 O

Q42SC5110 O

Q15 3SK294

IC5DNJM13403V

Q22SK2973 Q1

2SK2974

Q332SK1829 A only

Q192SB1132 R

Q20XP6501 AB

Q14DTA144EU

IC2TA75S01F

IC4 TA7368F

IC7HD6433664A24FP

IC15BU4094BCFV

IC11BR24C16FV-E2

Q28 DTC144EU

IC8 S-80942CNMC-G9C

Q292SC4116 GR

T1

OUT 1

VDD2

VSS3NC4

CD5

1LO

4567

14131211

R1471 k

R1481 k

CENC0

C2170.1

Q35DTC144EU

R1831 k

C2210.01

L5310.5 nH

R25210

EP6

C2620.1

C2600.001

R244100

C2676 P

L56

C101 10 P A4 P B

C950.001

D25MA2S111

L5456 nH

C1113 P A4 P B

C2657 P

C11356 P

D13HVU350B

R245820 B2.2 k A

C2610.001

R253470

C19 P

C411 P

C27 P

C1018 P

C1115 P

L50

L5118 nH

R2431.5 k

4.1 V

3.7 V 3.3 V 3.5 V

2.0 V0 V

0 V3.7 V

0 V2.1 V

4.6 V0 V

4.6 V0 V

2.0 V0 V

3.1 V0 V

0.6 V0 V

2.1 V

1.2 V1.3 V

0 V2.4 V

3.4 VAF ON

7.5 VAF ON

4.8 VAF ON

4.9 V

4.4 V1.6 V

1.1 V P-P14.7456 MHz

4.5 VDTCS

3.1 V P-PCTCSS code transmitting

4.9 V

NOTE

VCC

T5V

VCO5V

a

b

R5V

S5V

RSSI

c

d

VCC

S5V

e

f

g

VOLIN

VOLOUT

AFOUT

BUS LINE 1

BUS LINE 2

VCC

+5V

h

BUS LINE 3

S5V

DUSE

MAIN UNIT(2)MAINUNIT(1) A:[F12] and [F12S] B:[F11], [F11BR] and [F11S]

C:[F11] and [F12]

12 - 2

12 - 2

12-2 SW-A AND SW-B UNITS• SW-A UNIT

TP76N00N-15F-10KA-2251R1

Q1 XP4216

R3 560

R2 330

DS1LNJ107W5PRW

C 1 1 22 34 48 5

S1CP10

CP11CP12

CBI0CBI1

CP13CBI2CBI3

CP8

HVF1

654 3

2 1

CP3CP4CP5CP6

CP2

CP9 CBI0

VOLINVOLOUT

VCCRLEDTLEDGND

CP1

G

R

RX (SQL OPEN) 4.1 V

RX (SQL OPEN) 0 V

RX (SQL OPEN) 2.1 V

RX (SQL OPEN) 0 VTX 2.4 V

TX 0 V

TX 4.1 V

TX 0 V

RX (SQL OPEN) 4.8 VTX 0 VTX 4.8 VRX (SQL OPEN) 0 V

• SW-B UNIT

CHASSIS UNIT2CH VERSION

S1

W1 W2

EMERGENCY VERSIONS1

CP8HV

TP76N00N-15F-10KA-2251R1

F1CP3CP4CP5CP6

CP9

CP1CP2

654 3

2 1

Q1 XP4216

CBI0VOLOUTVOLINVCCRLEDTLEDGND

R3 560

R2 330

DS1LNJ107W5PRW

G

R

RX (SQL OPEN) 4.1 V

RX (SQL OPEN) 0 V

RX (SQL OPEN) 2.1 V

RX (SQL OPEN) 0 V

TX 0 V

TX 2.4 V

TX 0 V

TX 4.1 V

TX 4.8 VRX (SQL OPEN) 0 V

RX (SQL OPEN) 4.8 VTX 0 V

INTRODUCTION

DANGER

ORDERING PARTS

REPAIR NOTES

This service manual describes the latest service informationfor the IC-F11/IC-F11S/IC-F11BR/IC-F12/IC-F12S VHSTRANSCEIVERS at the time of publication.

NEVER connect the transceiver to an AC outlet or to a DCpower supply that uses more than 8 V. Such a connectioncould cause a fire or electric hazard.

DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when con-necting the transceiver.

DO NOT apply an RF signal of more than 20 dBm (100mW)to the antenna connector. This could damage the transceiv-er’s front end.

Be sure to include the following four points when orderingreplacement parts:

1. 10-digit order numbers2. Component part number and name3. Equipment model name and unit name4. Quantity required

<SAMPLE ORDER>1130007020 S.IC TC7S66FU IC-F11 MAIN UNIT 1 piece8810009510 Screw BO M 2 x 4 NI-ZU IC-F11 Chassis 10 pieces

Addresses are provided on the inside back cover for yourconvenience.

1. Make sure a problem is internal before disassembling the transceiver.2. DO NOT open the transceiver until the transceiver is disconnected from its power source.3. DO NOT force any of the variable components. Turn them slowly and smoothly.4. DO NOT short any circuits or electronic parts. An insulated turning tool MUST be used for all adjustments.5. DO NOT keep power ON for a long time when the transceiver is defective.6. DO NOT transmit power into a signal generator or a sweep generator.7. ALWAYS connect a 40 dB to 50 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when

using such test equipment.8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

To upgrade quality, all electrical or mechanical parts andinternal circuits are subject to change without notice or oblig-ation.

IC-F11/IC-F12 IC-F11BR/IC-F11S/IC-F12S

MODEL

IC-F11

IC-F11S

IC-F11BRIC-F12

IC-F12S

VERSIONU.S.A.

General

U.S.A.GeneralU.S.A.EuropeEurope

SYMBOLUSA-02GEN-02GEN-05USA-02GEN-02USA-02EUR-02EUR-02

CHARGER

–

BC-146–

BC-146

–

BATTERY

BP-209

–

BP-209

BP-222

BP-209

S-13806IZ-C1V-1© 2001, 2002 Icom Inc.

SERVICEMANUAL

1-1-32, Kamiminami, Hirano-ku, Osaka, 547-0003, Japan

VHF TRANSCEIVERS

icom ic f 11 - f 12 series

Documents