installation, use & care guide whole house · mon - fri 8 am - 5 pm pst my system serial #:...
TRANSCRIPT
System installation requires the services of a licensed plumber.
P R E M I U M W A T E R F I L T R A T I O N
EVO100
INSTALLATION, USE & CARE GUIDE
WHOLE HOUSEWater Filtration System
Read & Save These Instructions.
IMPORTANT
QUESTIONS? 1.800.879.8909
(int’l +1.775.359.9500) MON - FRI 8 AM - 5 PM PST
My System Serial #:
Serial Number is located on filter housing base.
System Certified by IAPMO R&T against NSF/ANSI Standard 53 and CSA B483.1 for the reduction of Lead, Cysts, Perfluorooctanoic Acid (PFOA) and Perfluorooctane Sulfonate (PFOS).
TABLE OF CONTENTS
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Important Use Guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Product Specifications and Performance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Where to Install . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
System Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Filter Cartridge Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Replacing the Filter Cartridge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
WHAT’S IN THE BOX [MODEL: EVO100]
EVO100 Filter Housing Assembly (includes Top Cap and Snap Ring)
WaterChef® EVR1 Filter Cartridge
Flow Control Valve
Reducer Tees (2)
Flow Meter Assembly
Straight 1” MNPT Connectors (2)
90º Elbow 1” MNPT Connectors (2)
3/8” Drain Valve Assembly with Shut-off
Umbrella Cover with Monitor Assembly
and Battery Backup
Power Supply
Also Included: - Food Grade Silicone - AAA Batteries (3) - 3/8” O.D. Drain Hose (5ft.) - Installation, Use & Care Guide - Performance Data Sheet - Product Registration Card
waterchef.com1
waterchef.com
INTRODUCTION
2
•Readthismanualcompletelybeforeattemptingtoinstallorusethisproduct.Ifsystemisnotmaintained andoperatedasspecifiedinthismanual,thereisariskofexposuretocontaminants. •Testingwasperformedunderstandardlaboratoryconditions,actualperformancemayvary.Actual performanceisdependentoninfluentwaterquality,flowrates,systemdesignandapplication. For optimal performance, replace your Filter Cartridge upon the first occurrence of the following: - Annually -Younoticeatasteorodorrecurrence,orasignificantreductioninflowrate - System LEDs turn RED (indicating rated capacity of the filter cartridge has been reached)
•Donotusewaterthatismicrobiologicallyunsafeorofunknownqualitywithoutadequatedisinfection beforeoraftertheSystem. • Individualsrequiringspecificmicrobiologicalpurityshouldconsulttheirphysician. •Systemscertifiedforcystreductionmaybeusedondisinfectedwaterthatmaycontainfilterablecysts. • InstallationofthisSystemmustcomplywithallstateandlocallawsandregulations. •Forresidentialuseonly. •ThecontaminantsorothersubstancesremovedorreducedbythisSystemmaynotbeinallusers’water. •Systemtobesuppliedonlywithcoldwater. • Ifthisoranyothersystemisinstalledinametal(conductive)plumbingsystem(i.e.copperofgalvanized metal),theplasticcomponentsofthesystemwillinterruptthecontinuityoftheplumbingsystem.Asa result,anyerrantelectricityfromimproperlygroundedappliancesdownstreamorpotentialgalvanicactivity intheplumbingsystemcannolongergroundthroughcontiguousmetalplumbing.Somehomesmayhave beenbuiltinaccordancewithbuildingcodesthatactuallyencouragedthegroundingofelectricalappliances throughtheplumbingsystem.Consequently,theinstallationofabypassconsistingofthesamematerial astheexistingplumbingoragrounded“jumperwire”bridgingtheequipmentandreestablishingthe contiguousconductivenatureoftheplumbingsystemmustbeinstalledpriortosystemuse. •FlushnewCartridgesforaminimumof10minutespriortouse. •Spentabsorptionmediawillnotberegeneratedandused.Ifabsorptionmediaisaffectedbychlorine, influentwillbetreatedtoremovechlorine. •DONOTUSEextralubricants,unapprovedsealants,ortoolstotightenhandtightenonlyparts.Useof toolsonhandtightenonlypartswillvoidwarranty. •ForthisSystemtocontinuetoperformastestedandrepresented,besuretouseonlygenuine,certified WaterChef®FilterCartridges.Foradditionalpurchaseinformation,contactWaterChefCustomerCare at 1.800.879.8909(int’l+1.775.359.9500)orvisitusonlineatwww.waterchef.com.
Congratulations on the purchase of your new WaterChef® Premium Whole House Water Filtration System!
WaterChefFiltrationSystemsarecraftedusingthefinestmaterialsandworkmanship,andwillserveyoureliablyformanyyearstocomewhenoperatedandmaintainedaccordingtothedirectionscontainedinthisguide.
Youhavemadeawiseinvestmentinprovidingqualitywaterforyouandyourlovedones.Nowpleasetake afewminutestolearnaboutallthefeaturesandbenefitsyournewSystemhastooffer!
IMPORTANT USE GUIDELINES
CITYWATERINLET
WELLWATERINLET
PRESSURETANK
PRE-FILTER
SYSTEMEVO100
WATERMETER
PUMP
SERVICERelief ValveMUST be Installed
Grounded & Unswitched
115-Volt Outlet
OFFOFF
PRODUCT SPECIFICATIONS
PERFORMANCE
WHERE TO INSTALL
Installation . . . . . . . . . . . . . . . . . . Whole HouseParticleRetentionSize . . . . . . . . . . . . . Sub-MicronIntelligentMonitor. . . . . . . . . . . . . . . . . . . . LEDRatedCapacity . . . . . . . . 100,000 gallons (378,541 L)RatedServiceFlow . . . . . . . . . . . . . . . 4.51gpmPeakFlow&ReductionofLead . . . . . [email protected]%
ReplacementFilterCartridge . . . . . . . . . . . . . EVR1MaximumWorkingPressure . . . . 125psig(8.89kg/cm2)MinimumWorkingPressure . . . . . 20psig(1.41kg/cm2)MaximumOperatingTemperature . . . . . . 120 ̊F/50 ̊CMinimumOperatingTemperature. . . . . . . . .34 ̊F/1 ̊CElectricalRequirements. . . Grounded&Unswitched115V, 3-AAA Batteries
WATERCHEF® WHOLE HOUSE WATER FILTRATION SYSTEM (Model: EVO100)
RefertoPerformanceDataSheetforactualcontaminantandsubstancereductioncapabilities.
ManufacturerinternallytestedforChlorine and Chloramine reduction.
waterchef.com3
ThissystemhasbeencertifiedbyIAPMOforNSF/ANSIStandard53andCSAB483.1forthespecific performanceclaimsverifiedandsubstantiatedbytestdata.Actualperformanceisdependentoninfluent waterquality,flowrates,systemdesignandapplications.Yourresultsmayvary.Performanceclaimsarebasedonacompletesystem,includingfiltercartridge,housing,andconnectiontoapressurizedwatersource.Thisfiltermustbeoperatedaccordingtothesystem’sspecificationsinordertodelivertheclaimedperformance.Itisessentialtofollowoperational,maintenance,andfilterreplacementrequirements,as directedforeachapplication,forthisfilterandsystemtoperformcorrectly.ReadthePerformanceDataSheetaccompanyingthesystemandchangethefiltercartridgeassuggested.
System Certified by IAPMO R&T against NSF/ANSI Standard 53 and CSA B483.1 for the reduction of Lead, Cysts, Perfluorooctanoic Acid (PFOA) and Perfluorooctane Sulfonate (PFOS).
waterchef.com
To Power Supply
INLET
NOTE: Flow Direction arrows embossed on the Flow Control Valve are incorrect for thisapplication. Plumb unit opposite of arrows.
Drain Valve
Plumber’s Tape ThreadsDO NOT Overtighten
OUTLET
OFFOFF
or
4
SYSTEM INSTALLATION
PART IDENTIFICATION
1.ConnectReducerTees3toInlet/OutletCap Assembly2locatedonbottomofFilterHousing . (Reducer Tee with plugged fitting installs on the right side.) Hand Tighten Only
2.ConnectFlowMeterAssembly4toReducerTees 3;wiredFlowMetershouldbeplacedonthe Outlet Side (right). (Note the flow direction arrow on meter body.) Hand Tighten Only
3.ConnectFlowControlValve5toFlowMeter Assembly4.Hand Tighten Only
4.UseeitherStraightor90ºElbow1”MNPT Connectors6forconnectingyourplumbing system. Hand Tighten Only
5. InstallDrainValveAssembly7intoleftReducer Tee3usingthethreadedconnectionand plumber’stape.Hand Tighten Only
6. Install3AAAbatteriesinUmbrellaCover8; connecttopowersupply.
Filter Housing BottomInlet/OutletCapAssembly ReducerTees(2) (1 plugged fitting) FlowMeterAssembly FlowControlValve
6 Straightor90ºElbow1”MNPTConnectors (2 each)7 3/8”DrainValveAssemblywithShut-Off8 UmbrellaCover(with Monitor Assembly and Battery Backup)
NOT SHOWN: Power Supply
PlacewiredFlowMeteron the Outlet Side (right). Note the flow direction arrow on meter body.
IMPORTANT
DO NOT USE extra lubricants or unapproved sealants; DO NOT USE tools to tighten hand tighten only parts. Use of tools on hand tighten only parts will void warranty.
NOTE
Allow 3 feet of open space above the System to allow for filter cartridge installation and replacement.
A
A
A
B
B
B
C
C
C
C
C
D
D
D
D
E
E
E
FF
F
G
G
G
H
H
H
waterchef.com
FILTER CARTRIDGE INSTALLATION
5
System comes pre-assembled without the Cartridge installed.
1.PressdownontheHousingAssembly’sTopCapwithbothhands tounseattheSnapRing. (fig. A) RemovetheSnapRingbycarefully graspingthehandleandpullinginward,thenupward.TheRing shouldslidecompletelyoutofthegroove. (fig. B)
2.RemovetheTopCapfromtheHousingbyholdingtheCapHandles and lifting. (fig. C) (Place the Cap on a clean and dry surface, free of debris, so that no contamination of the O-ring occurs.)
3.RemovepackagingfromFilterCartridge.
4.SlidetheCartridgeintotheHousingTankwiththedoubleO-ring facingdown. WhileloweringCartridgeintoTank,aligntheCartridge withthecenteropeninginthebottomoftheTank.Pressdown ontheCartridgesothatthedoubleO-ringseatsintothebottom, centeropening.(fig. D)
5.RepositiontheTopCapintoitsoriginallocationontheHousing.
6.ReattachtheSnapRingthenpullupontheTopCaphandlesto seat the O-ring.
7.TurnwatersupplyONbyopeningtheInlet&OutletValveson theFlowControlValve.
8.AstheSystemfillswithwater,pushdownontheREDPressure ReleaseButtonontheTopCaptorelievetheSystemofair.Keep Button pushed down until ALL air is released and water starts to come out of the Button. Release Button. (fig. E)
9.SeatUmbrellaCoverontopofHousingAssembly(fig. F) and check for leaks.
10.FlushSystembyrunningwaterthroughSystemfor10minutes beforeuse.
B
C
D
F
IMPORTANT
Repeat flushing procedure each time a new Filter Cartridge is installed.
A
SnapRing
TopCap
UmbrellaCover
CapHandles
Bottom,CenterOpening
HousingTank
Pressure Release Button
E
waterchef.com
REPLACING THE FILTER CARTRIDGE
FILTER STATUS NOTIFICATIONS
6
1.TurnOFFthewatersupplytotheSystembyshuttingofftheInlet &OutletValvesontheFlowControlValve.
2.RemoveUmbrellaCoverfromthetopoftheHousing.Replacethe 3AAAbatterieswithnewbatteries.ResettheIntelligentMonitor™
bypushingandholdingtheResetButtononthemonitorboard for3seconds.TheGREENLEDlightswillflash3timesto confirmreset. (fig. G)
3.DepressurizetheSystembypushingdownontheREDPressure ReleaseButtonontheTopCapoftheHousinguntilALLtheairor waterpressureiscompletelyreleased. (fig. H)
4.PressdownontheTopCapwithbothhandstounseattheSnap Ring. (fig. I) RemovetheSnapRingbycarefullygraspingthe handleandpullinginward,thenupward.TheRingshouldslide completelyoutofthegroove. (fig. J)
5.RemovetheTopCapfromtheHousingbyliftingupontheCap Handles.RemovetheoldFilterCartridge.
6.Connect3/8”O.D.Tubing(included with EVO100 System) to the DrainValvethatconnectstotheinletsideoftheFiltrationSystem. RunthehosetoafloordrainorbucketthenOPENtheDrainValve andflushoutthebottomoftheSystem.
Thebuilt-inIntelligentMonitor™measureswaterandflowrateinreal-time,notifyingyouaboutremainingfiltercartridgelifewithsimplecolor-codedLEDnotifications.
GREEN
Peak Operating Performance
FILTER IS GOOD
YELLOW
Under 10% of Filter Life Remains
ORDER NEW FILTER
RED
End of Filter Life has Been Reached
REPLACE FILTER NOW
(continued on following page)
AAA
AAA
AAA
SnapRing
Pressure Release Button
UmbrellaCover (underside) AAA Batteries
Reset Button
TopCap
I
H
G
J
waterchef.com
REPLACING THE FILTER CARTRIDGE
7
7.RemovepackagingfromnewFilterCartridgethenslideinto HousingTankwiththedoubleO-ringfacingdown. (fig. K)
8.PositiontheCartridgesothatitisalignedwiththebottom,center openingintheTank.(fig. ) PressdownontheCartridgesothat thedoubleO-ringsealseatsintothebottom,centeropening.
9.RepositiontheTopCapintoitsoriginallocationonHousing.
10.ReattachtheSnapRingthenpullupontheTopCapHandlesto seat the O-rings.
11.CLOSEtheDrainValvethenturnONthewatersupplytotheSystem byopeningtheInlet&OutletValvesontheFlowControlValve.
12.AsSystemfillswithwater,pushdownontheREDPressure ReleaseButtononTopCaptorelieveSystemofair.(fig. M) Keep Button pushed down until ALL air is released and water starts to come out of the Button. Release Button.
13.SeatUmbrellaCoverontopofHousingAssembly(fig. N) and check for leaks.
14.FlushSystembyrunningwaterthroughSystemfor10minutes beforeuse.If lights are not flashing GREEN, see step 2.
Housing Tank
UmbrellaCover
Bottom, Center Opening
Filter Cartridge
K
L
N
Pressure Release Button
MIMPORTANT
Repeat flushing procedure each time a new Filter Cartridge is installed.
waterchef.com 8
INTELLIGENT MONITOR™
POWER
OPERATION
Thisunitistobepoweredusing+12VDC.Thepowerunitisawiretailwith2.5mm,centerpositivebarreljack.
TheIntelligentMonitor™hasabatterybackupthatuses3AAAsizebatteries.ThebatteryholderispartoftheMonitorAssemblylocatedinsidetheUmbrellaCaponthetopoftheSystem.ItcanbeaccessedbyliftingtheUmbrellaCapfromtheSystem.Batterylifewillvarybasedonwaterflowwhenrunningonbatterymodeandtypeofbatteriesused.Withhighcontinuousflow,thebatteriesareexpectedtolastapproximately14days.Withnoflow,thebatteriesareexpectedtolastapproximately6months.
TheIntelligentMonitor™keepstrackofthegallonsofwaterthatpassthroughtheSystem.TheMonitorisremovableforinspectionandcleaning.MakesurewaterisbypassedorturnedoffwhenremovingtheMonitorformaintenance.TheMonitorhasathreepinplugthatconnectstotheelectronicboardintheUmbrellaCap.
LEDsSimplecolor-codedLEDnotificationsdisplaytheusagestatusofthefiltercartridge:
GREEN 100%-10%offilterliferemains YELLOW Under10%offilterliferemains RED Endoffilterlifehasbeenreached
Ifthereisflow,LEDsshouldalternatelyblinkinthefollowingpattern:1-2-3-2(repeat).ThefrequencythattheLEDsblinkcorrespondstotheflowratereceivedfromtheMonitor.ForeveryrevolutionfromtheMonitor, theLEDpatternshouldbeincrementedtoturnoffthenextLED.Iftherearenorevolutionsfor2seconds,allLEDswillturnonsolid.
Ifthebatteriesarelow,themiddleLEDwillturnWHITE.Thebatterylevelischeckedonceanhourto minimizethebatterydrainfromcheckingthevoltage.
Reset ButtonTheResetButtonallowsfortheIntelligentMonitor™tobereset.
ToresettheIntelligentMonitor™,pressandholdtheResetButtonfor3seconds.Oncereset,theLEDsshouldflashgreen3timestoconfirmreset.
Power Monitoring and Battery ModeInadditiontomonitoringwaterusage,theIntelligentMonitor™alsomonitorstheSystem’s12VDCpowerandbatterypower.Ifthereisapowerfailureandnobatteriesareinstalled,theMonitor’svaluewillbesavedtonon-volatilememory.Whenpowerisresumed,thegalloncountwillresumefromwhereitleftoffwhenpowerwaslost.
Ifthereisapowerfailureandbatteriesareinstalled,theMonitorgoesintobatterymode.Duringbatterymode,theLEDsshouldshutoff.IftheMonitorisintheYELLOWorREDstate,orifthebatteryvoltagegetslow,theLEDswillflashonintheappropriatecolorfor.125secondsevery4seconds.IftheResetButtonispressedinbatterymode,theLEDswillturnonfor4secondsandthenreturntobatterymode.
waterchef.com9
5-YEAR LIMITED WARRANTYWaterChef®warrants that this filtrationsystemwill be free fromdefects inmaterialsandworkmanship in manufacturingfortheperiodoffiveyears(60months)fromthedateofpurchase.Thiswarrantyisextendedtotheoriginalpurchaser.UseofthisproductconstitutesBuyer’sacceptanceofthisLimitedWarranty.WaterChef,at itssolediscretion,will repairorreplacethisproductorcomponentoftheproductfoundtobedefectiveduringthiswarrantyperiod.Replacementwillbemadewithaneworremanufacturedproductorcomponent.Iftheproductisnolongeravailable,replacementmaybemadewithasimilarproductofequalorgreatervalue.Thisisyourexclusivewarranty.Thiswarranty isvalid for theoriginal retailpurchaser fromthedateoforiginal retailpurchaseand isnot transferable.Keeptheoriginalsalesreceipt.Proofofpurchaseisrequiredtoobtainwarrantyservice.
WHAT IS NOT COVEREDThis warranty does not cover filter cartridges, systems that were not installed in compliance with the installationinstructionsbyalicensedplumber,normalwearofcomponentsorthefollowing: •DamagecausedbyimproperinstallationorusecontrarytotheInstallation,Use&CareGuide,disassembly, modificationoralterationbyanyoneotherthanWaterCheforaWaterChefauthorized servicecenter. •Damagecausedbynegligentuseormisuseof theproduct,neglect,oxidizingagents (suchaschlorine, ozonechloraminesandotherrelatedcomponents). •Damageduetoexcessivesediment inwatersupplyorclogging(replacementofpre-filtercartridgeisthe purchaser’sresponsibility),usewithnon-potablewatersuppliesorusewithwaterpressurethatisoutside thespecifiedoperatingrange. •Damagecausedbyaccident,fire,freezing,floodoractsofGod. •Cost of labor or expenses expended in the installation and/or removal of system, filter cartridges, or any surroundingdevice. •Incidentalorconsequentialdamagecausedbyafailureoftheproductorthebreachofanyexpressedor impliedwarranty.Excepttotheextentprohibitedbyapplicablelaw,anyimpliedwarrantyormerchantability islimitedtothedurationoftheabovewarranty.ThisWarrantyifvoidediftheproductisusedwithnon-genuineWaterChefpartsorreplacementfiltercartridges.Somestates,provincesorjurisdictionsdonotallowtheexclusionorlimitationoftheincidentalorconsequentialdamages,sotheabovelimitationorexclusionmaynotapplytoyou.Thiswarrantygivesyouspecificlegalrightsandyoumayhaveotherrightswhichvaryfromstatetostateorprovincetoprovince.
HOW TO OBTAIN WARRANTY SERVICECall 1.800.879.8909 (int’l +1.775.359.9500) or email customercare@waterchef.comwithinthewarrantyperiodtodescribetheproblem.Ifitisdeterminedthatitisnecessarytoreturnthedefectivepart,aReturnAuthorization Numberwillbeissued.Parts returned without a Return Authorization Number will be refused.Packtheproductinashippingcarton,usingnewspaperorotherpackingmaterialstoprotecttheproductfromdamageintransit.Beforesealingthecarton,besuretoincludeproofofpurchaseandproofofinstallationbylicensedplumber.BecertaintoincludeyourreturnshippingaddressandReturnAuthorizationNumberontheoutsideof the carton.Uponreceivingtheproduct,wewillrepairorreplacethepartandreturnittothereturnaddressontheshippingcarton at no cost to you (U.S. customers only).
P R E M I U M W A T E R F I L T R A T I O N
EVO100 WHOLE HOUSE WATER FILTRATION SYSTEM
waterchef.com
WATERCHEF® PRODUCT REGISTRATION
10
Thank you for choosing WaterChef®!Don’tforgettotakeamomenttoregisteryournewSystem.Doingsowillallowustobetterserveyouintheeventthattechnicalorwarrantyassistanceiseverrequired.
Simply visit www.waterchef.com to register your system online,orifyouprefer,youmaycompleteandreturnthisregistrationformto:WaterChefCustomerCare·3760BarronWay·Reno,NV89511
NAME:
STREET ADDRESS:
CITY: STATE: ZIP:
PHONE: ( ) EMAIL:
MODEL #: EVO100 SERIAL #: DATE OF PURCHASE: / /
PURCHASED FROM:
Sign me up for WaterChef Updates, Special Promotions & Exclusive Discounts!
Please send me Courtesy Email Notifications when it’s time to replace my filter cartridge.
We value your privacy and will not sell or share your information with anyone. You may unsubscribe from updates and cartridge reminder notifications at any time.
NOTES
1-404-0122 r19.10
WaterChef® | 3760BarronWay·Reno,NV89511 | tel 1.800.879.8909 | int’l +1.775.359.9500 email [email protected]| web waterchef.com