io intex owner's manual - intexcorp.ru cleaner... · intex® owner's manual auto cleaner...
TRANSCRIPT
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 1
INTEX® OWNER'S MANUALAUTO CLEANER
IMPORTANT SAFETY RULESREAD, UNDERSTAND AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFOREINSTALLING AND USING THIS PRODUCT.
Warning 1Parts Reference 2Set Up Instructions 3-4Operating Instructions 5Debris Net Cleaning 5
• TO REDUCE THE RISK OF INJURY, DO NOT PERMIT CHILDREN TO USE THIS PRODUCT. • DO NOT OPERATE THE FILTER PUMP WHILE THE POOL IS OCCUPIED OR IN USE.• REMOVE THE PRODUCT FROM THE POOL WHILE THE POOL IS OCCUPIED OR IN USE.• TURN OFF OR UNPLUG THE FILTER PUMP BEFORE ADJUSTING, CLEANING OR
SERVICING.• REMOVE THE PRODUCT FROM THE POOL BEFORE PLACING A POOL COVER OVER THE
POOL.• STORE THE PRODUCT AND ACCESSORIES IN A DRY AND SAFE PLACE INDOORS.• FOR POOL AND FILTER PUMP PROBLEMS REFER TO THEIR RESPECTIVE OWNER'S
MANUAL FOR ADVICE.
FAILURE TO FOLLOW THESE WARNINGS MAY RESULT IN PROPERTY DAMAGE, SERIOUSINJURY OR DEATH.
WARNING
CONTENTS
100IO-R1-0611
This Filter-Pump system is intended to be used only for the purposes described in the manual!Failure to follow all product, package and package insert safety and installation instructions couldresult in electric shock, entanglement, other serious injury or death.
Filter Pump Flow Rate Requirement: 2000 - 5000 gallons/hour (7570 - 18925 liters/hour)
Long Term Storage 6General Aquatic Safety 6Trouble Shooting Guide 6Intex Service Center Locations 7
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 2
PARTS REFERENCEBefore assembling your product, please take a few minutes to check the contents and becomefamiliar with all the parts.
06AC-05
06AC-09
06AC-10 06AC-01 06AC-02
06AC-03 06AC-04
06AC-08 F-26
06AC-06
06AC-07
06AC-0106AC-0206AC-0306AC-0406AC-0506AC-0606AC-0706AC-0806AC-0906AC-10
F-26
12211112211
Hose AHose BHose CHose DCleaner TopDebris NetCleaner BaseBumperScrewHose AdaptorHose Clamp
REF. NO. DESCRIPTION
13311112211
QTY.
OTHER POOLS24’ (732cm) ROUND METAL
FRAME POOLS &16’ x 32’ (488 x 975cm)
RECTANGULAR METAL FRAME POOLS
1. With screws (06AC-09), connect the bumpers (06AC-08) to the cleaner at both ends. See (Fig. 1).
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 3
Set Up Instructions
2. From inside of the pool, unscrew the strainer grid from the water return connector (upper hose connection). See (Fig. 2).
3. Screw the hose adaptor (06AC-10) to hose A (06AC-01). See (Fig. 3).
4. Screw the end of hose A (06AC-01) with adaptor to the threaded strainer connector, from inside of the pool. See (Fig. 4).
06AC-10
06AC-01
Fig (2)
Fig (3)
Fig (4)
Threaded StrainerConnector
06AC-01
Bottom HoseConnection
Upper HoseConnection
Threaded StrainerConnector
Strainer Grid
Inside of thePool Wall
06AC-09
06AC-08Fig (1)
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 4
Set Up Instructions (cont.) 5. Connect the rest of the hoses together outside the pool, in the order of hose description
(Fig. 5), B-B-B-C-C-C-D or B-B-C-C-D.
6. With hose clamp (F-26), fasten the end of hose D (06AC-04) to the top connection of cleaner. A small coin can be used to tighten the hose clamp. See (Fig. 6).
9. Set up the Filter Pump following the Filter Pump owner's manual. The auto cleaner is now ready touse.
7. Place auto cleaner into the water. Fill up the hose assembly with water by submerging the hose into the water to remove all of the entrapped air from the hose.
8. Connect hose B (06AC-02) from the hose assembly to the hose A (06AC-01) which was already installed in step 4. See (Fig. 7).
Fig (5)
Fig (6)
Fig (7)
(B)
06AC-04
F-26
06AC-02
(B) (B) (C) (C) (C) (D)
06AC-01
(B) (B) (D)(C) (C)
or
Operating Instructions
1. The filter pump is an airtight system. In a counter-clockwise motion turn the top air release valve 1 – 2 turns to open it.
2. When water starts flowing out of the air release valve hole, screw in the air release valve back into the filter housing cover. Do not over tighten the valve.
3. Connect the filter pump to the power outlet and turn ON the pump. 4. Hold the auto cleaner at an angle with the top bumper pushed in so water jets out. See (Fig. 8).
This will evacuate all the air in the hose and auto cleaner, so the cleaner will sink to the bottom and keep the pool clean.
5. The auto cleaner will change direction each time one of the bumpers touches the pool sidewall. This action will result in the entire bottom being cleaned.
Debris Net Cleaning1. Make sure the filter pump is turned off, and disconnect the power cord from the electrical outlet.
Remove the auto cleaner from the pool.2. Unlock four buckles located on the four sides. See (Fig. 9).
3. Remove the debris net (06AC-06) from the cleaner base (06AC-07). If debris is on the debris net and cleaner base, use garden hose to flush the debris off. See (Fig. 10).
4. Reassemble auto cleaner reversing steps 1, 2 and 3.
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 5
06AC-06
Fig (8)
Fig (9)
Fig (10)
06AC-07
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 6
LONG TERM STORAGE 1. Make sure the filter pump is turned off, and disconnect the power cord from the electrical outlet. 2. Using the Set Up instructions in reverse, disassemble the auto cleaner.3. Clean and air dry all the accessories and parts thoroughly. 4. Keep the hoses straight during storage.5. The original packaging can be used for storage. Store in a dry, cool storage location.
GENERAL AQUATIC SAFETY GUIDELINESWater recreation is both fun and therapeutic. However, it involves inherent risks of injury anddeath. To reduce your risk of injury, read and follow all product, package and package insert warningsand instructions. Remember, however, that product warnings, instructions and safety guidelines coversome common risks of water recreation, but do not cover all instances or risk and or danger.For additional safeguards, also familiarize yourself with the following general guidelines as well asguidelines provided by nationally recognized Safety Organizations:• Learn to swim.• Take the time to learn CPR and first aid.• Instruct anyone who is watching your children about potential pool hazards and about the use of
protective devices such as locked doors, barriers, etc. Demand constant supervision.• Teach children what to do in case of an emergency.• Always use common sense and good judgement when enjoying any water activity.• Supervise, Supervise, Supervise.
TROUBLE SHOOTING GUIDE Q. What should I do if Auto Cleaner doesn’t move or movement is very slow?A. 1. Pull the cleaner’s hose and lift auto cleaner off from the wrinkles.
2. Check the circulation line: i. Ensure the filter pump is turned on.ii. Ensure the plunger valves are opened.ii. Clean or replace cartridge.
Q. What should I do if Auto Cleaner lifts off from the pool floor?A. Release air from the auto cleaner by following the “Owner’s Manual”.
Q. What is the easiest way to carry the Auto Cleaner out from the pool after used?A. Release the water inside the auto cleaner by following the steps below:
1. Make sure the filter pump is turned off, and disconnect the power cord from the electrical outlet.
2. Pull the cleaner’s hose slowly and lift the auto cleaner up just right below the water surface.3. Hold the hose with one hand, and lift the auto cleaner up slowly with an angle (either head or
tail up) by carrying the cleaner bottom with another hand.4. After the water has been fully released from the auto cleaner, carry the auto cleaner out with
both hands. DO NOT lift the hose or bumper which could be damaged.
100IO
(100IO) AUTO CLEANER ENGLISH 7.5” X 10.5” 11/18/2005
SAVE THESE INSTRUCTIONS Page 7
For service questions or to order replacement parts, please contact the appropriate office listedbelow or visit www.intextrading.com for answers to most frequently asked questions.
AREAS LOCATION• CHILE / ARGENTINA / COMEXA S.A
PERU / URUGUAY SAN IGNACIO 0201, PARQUE INDUSTRIAL PORTEZUELO, QUILICURA, SANTIAGO, CHILETEL: 56-2-339 9000FAX: 56-2-339 9022E-mail: [email protected]
• SAUDI ARABIA SAUDI ARABIAN MARKETING & AGENCIES CO. LTD.PRINCE AMIR MAJED STREET,AL-SAFA DISTRICT. JEDDAH,KINGDOM OF SAUDI ARABIATEL: 966-2-693 8496FAX: 966-2-271 4084 E-mail: [email protected]: www.samaco.com.sa
• AUSTRIA STEINBACH GMBH AUSTRIAAISTINGERSTRAßE 24311 SCHWERTBERGTEL: 0900 460 467 996FAX: 0900 460 467 997E-mail: [email protected]: www.intexcorp.at
• CZECH REPUBLIC / INTEX TRADING S.R.O.EASTERN EUROPE BENESOVSKA 23,
101 00 PRAHA 10CZECH REPUBLICTEL: 420-2-717 32247FAX: 420-2-673 12552E-mail: [email protected]
• BELGIUM N.V. NICOTOY S.A.STASEGEMSESTEENWEG 72 8500 KORTRIJKTEL: 0800 92088FAX: 32-56.20.37.61E-mail: [email protected]
• DENMARK K.E. MATHIASEN A/SSINTRUPVEJ 12DK-8220 BRABRANDDENMARKTEL: +45 89 44 22 00FAX: +45 86 24 02 39E-mail: [email protected]
• SWEDEN LEKSAM ABBRANDSVIGSGATAN 6,S-262 73 ÄNGELHOLM,SWEDENTEL: +46 431 44 41 00FAX: +46 431 190 35E-mail: [email protected]
• NORWAY NORSTAR ASPINDSLEVEIEN 1N-3221 SANDEFJORDNORWAYTEL: +47 33 48 74 10FAX: +47 33 48 74 11E-mail: [email protected]
• FINLAND NORSTAR OYRUUKINTIE 20FIN-02330 ESPOOFINLANDTEL: +358 9 8190 530FAX: +358 9 8190 5335E-mail: [email protected]
• RUSSIA LLC BAUERKIEVSKAYA STR., 20, 121165 MOSCOW, RUSSIATEL: 095-249-9400/8626/9802FAX: 095-742-8192 E-mail: [email protected]: www.intex.su
• POLAND KATHAY HASTERUL. LUTYCKA 3,60-415 POZNANTEL: +48 61 8498 381/380FAX: +48 61 8474 487
• HUNGARY RECONTRA LTD.H-1113 BUDAPEST, DARÓCZI ÚT 1-3, HUNGARYTEL: +361 372 5200/113FAX: +361 209 2634E-mail: [email protected]
• BRAZIL KONESUL MARKETING & SALES LTDARUA INÁCIO BORBA, 835 - CEP. 04715-020, CHÁCARA SANTO ANTONIO - SÃO PAULO - SP - BRASILTEL: 55 (11) 5183 8866FAX: 55 (11) 5183 8866E-mail: [email protected]
AREAS LOCATION• ASIA INTEX (HONG KONG) LTD.
8TH FLOOR, DAH SING FINANCIAL CENTRE, 108 GLOUCESTER ROAD, WANCHAI, HONG KONGTEL: 852-28270000FAX: 852-23118200E-mail: [email protected]: www.intextrading.com
• EUROPE INTEX TRADING B.V.POSTBUS 1075, 4700 BB ROOSENDAAL, THE NETHERLANDSTEL: 31-(0)165-593939FAX: 31-(0)165-593969E-mail: [email protected]
• FRANCE INTEX SERVICE (FRANCE) SAS52, ROUTE NATIONALE39190 BEAUFORT, FRANCETEL: 08 90 71 20 39 (0.15 TTC/min)FAX: 03 84 25 18 09E-mail: [email protected]: www.intex-service.fr
• GERMANY STEINBACH GMBH GERMANYAN DER WELLE 4 60322 FRANKFURTTEL: 0900 1460 467 996FAX: 0900 1460 467 997E-mail: [email protected]: www.intexcorp.de
• ITALY A & A MARKETING SERVICEC/O ALVI, VIALE DELLA REPUBBLICA10 27100 PAVIA - ITALYTEL: 39-039-6886260FAX: 39-039-6043603E-mail: [email protected]: www.intexitalia.com
• UK TOY BROKERS LTDMARKETING HOUSE, BLACKSTONE ROADHUNTINGDON, CAMBS. PE29 6EF. UKTEL: 01480 414361FAX: 01480 414761E-mail: [email protected]: www.toybrokers.com
• SWITZERLAND GWM AGENCYGARTEN-U. WOHNMÖBELRÄFFELSTRASSE 25 POSTFACHCH-8045 ZURICH/SWITZERLANDTEL: 41 44 455 50 60FAX: 41 44 455 50 65E-mail: [email protected]: www.gwm.ch
• SPAIN / PORTUGAL KOKIDO BVI LIMITEDC/PLOMO 5-7, NAVE 19 POLÍGONO INDUSTRIAL AIMAYR SAN MARTÍN DE LA VEGA 28330 MADRIDTEL: 34-90-2351045FAX: 34-91-6917060E-mail: [email protected] E-mail: [email protected]
• AUSTRALIA HUNTER OVERSEAS PTY LTDLEVEL 1, 225 BAY STREET,BRIGHTON, VICTORIAAUSTRALIATEL: 61-3-9596-2144 or 1800-224-094FAX: 61-3-9596-2188E-mail: [email protected]
• NEW ZEALAND HAKA NEW ZEALAND LIMITEDUNIT 5, SENTINEL PARK, 25 AIRBORNE ROAD, ALBANYPO BOX 302171, NORTH HARBOUR, AUCKLAND 1330NEW ZEALANDTEL: 649-4159213FAX: 649-4159212E-mail: [email protected]
• MIDDLE EAST FIRST GROUP TRADINGREGION AL MOOSA GROUP BUILDING, 1ST
FLOOR, OFFICE 102 & 103, UMM HURAIR ROAD, KARAMA, DUBAI, UAETEL: 00971-4-3373322FAX: 00971-4-3375115E-mail: [email protected]: www.firstgrouptrading.com
• SOUTH AFRICA WOOD & HYDE15-17 PACKER AVENUE, INDUSTRIA 2, CAPE TOWN, SOUTH AFRICA 7460TEL: 27-21-0800-204-692FAX: 27-21-505-5600E-mail: [email protected]
©2005 ®TM Intex Recreation Corp., Long Beach, CA 90801-1440 USA®™ Trademarks used in some countries of the world under license to/®™ marques utilisées sous licence de/Marcas registradas utilizadas en algunos paises del mundo bajo licencia de/Das®™ Warenzeichen wird in einigen Ländern der Welt unter der Lizenzdavon benützt/Intex Trading Ltd., c/o Intex (HongKong) Ltd., 8th Floor, Dah Sing Financial Centre, 108 Gloucester Road,Wanchai, Hong Kong • Distributed in the European Union by/Distribué dans l’Union Européenne par/Distribuido en la unión Europeapor/Vertrieb in der Europäischen Union durch/Intex Trading B. V., P. O. Box nr. 1075 - 4700 BB Roosendaal - The NetherlandsMade in China/ Fabriqué en Chine/ Hecho en China