FEATURES

65 SAE net hp (69,1 PS)

Single-lever loader control

Power Shift Hi-Lo-Reverse

Hydraulic track adjustment

Sealed track rollers and idlers

Hydraulically-boosted power steering

Roll-over protective structure (ROPS)

Vandal protection

ADD VERSATILITY WITH:

Winch

Fairlead and drawbar

Ripper

Backhoe

Log and Pulpwood fork

Log and Lumber fork

Integral log arch

ENGINE PERFORMANCE

ENGINE PERFORMANCE

:iwwI3':>---'~a:w3':0<l.W<na:0Iw'"«a:"'

TORQUE

60

50

HORSEPOWER

40

30

FUEL CONSUM PTiON

1100 1300 1500 1700 1900 2100 2300 2500

ENGINE SPEE[)~RPM

*SAE Standard

LOADER SPECIFICATIONS

Buckets:Digging

SAE HeapedCapacity

1% cu. yd.(0,96 m3)

13/4 cu. yd.(1,34 m3)

1% cu. yd.(0,96 m3)

Light Materials

Multipurpose

165

155 I I-"-en--'

145, Z

135w::>0a:0I-a:I0::I"'iff"'--'I--'

w::>"-

.500

.450.400.350

Width72.25 in.(1,84 m)78.25 in.(1,99 m)

73 in.(1,85 m)

Operating Information:Breakout force. . . . . . . . . . . .14,360lb. (6513kg)Lifting capacity, full height. . .9,000 lb. (4082 kg)Maximum dumping angle. . . . . . . . . . . . .50 deg.Raisingtime 7.0sec.Dumpingtime 1.6sec.Lowering time 4.0sec.

20

JD450-BLOADER

I

l/L cc-'

'~ --~i"'{,I // C\I I' "\

,~\ 1/ h..- \" " 1\ -/," "p;/&

'£./ ');. /~, //,o/-"A- r - //// \\// //

/ / , '-q,/

7 0 ,/ / / / -/\ /0 ",...( / '( /V " ",,/ ,/ \\ ' 0\ /' ')J.'

~

/\ " /./,/ ).' ",/

/ / /'1-' 2 ft 9 in/ / /'/ .'"m 'jI (8" mm) I

8'(/:///11 l

:~:.:. :':::J:;-::.<7 1;:-::::~"*'- - - - :, , "- -- \ /-0

1..--

10ft.9in.(3,28m)

8 ft. 7 in.(2,61 m)

7 ft. 11.8 in.

(2'11

I ' \ .L --.:: r~ 4.5tn.(114mm) l

O1T

~ 13 ft. 8.25 in. (4,17 m)

SPECIFICATIONS-JD450-B LOADER(Specifications and design subject to change without notice. Wherever applicable, specifications are in accordance with IEMC andSAE Standards. Except where otherwise noted, these specifications are based on a unit equipped with 1Y. cu. yd. (0,93 m3) digging bucket,roll-over protective structure, and standard equipmenl.)

Horsepower (@ 2,500 engine rpm): SAEGross 70Net. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65

DIN

69,1PS-Net engine flywheel horsepower is for an engine equipped with fan, air

cleaner, water pump. lubricating oil pump. fuel pump. alternator and muf-fler. The gross engine horsepower is without 'fan. Gross and net flywheelhorsepower ratings are under SAE standard conditions of 500-ft. altitudeand B5°F. temperature and DIN 70 020 standard conditions of 760 mm Hgbarometer (sea level) and 20°C. temperature.

...

Engine: John Deere, 4-cylinder, diesel, 4-stroke cycleBore and stroke. . . . . . . . . . . .. . . . .4.02x4.33 in (102x110 mm)Piston displacement. . . . . . . . . . . . . . . . . .219 cu. in. (3588 cm3)Compression ratio 16.2t01Maximum torque @ 1,400 rpm . .164.5Ib-ft (22,74 kg-m)NACC or AMA (U.S. Tax) horsepower. . . . . . . . . . . . . . . . .23.84Lubrication .Pressure system w/full-flow filterMain bearings 5Cooling. . . . . . . . . . Pressurized w/thermostat and fixed bypassFan BlowerAir cleaner w/restriction indicator. . . . . . . . . . . . . . . . . . . . . DryElectrical system. . . . . . . . . . . . . . . . . . . . . . 12-volt w/alternatorBattery. . . . . . . . . . . . . . . . . . . .Reserve capacity: 150 minutes

Transmission. . . H-L-R: 4 speed ranges; with high, low, and re-verse speeds shifted hydraulically without clutching in eachrange.

Clutch 11-in.(279mm)single-disk

Gear: Travel Speeds: Gear: Travel Speeds:Range 1 mph km/h Range 3 mph km/h

Low 1.3 2,1 Low 3.0 4,8High 1.8 2,9 High 4.3 6,9Reverse 1.7 2,7 Reverse 4.1 6,6

Range 2 Range 4Low 2.0 3,2 LowHigh 2.8 4,5 HighReverse 2.7 4,3 Reverse

.'

4.76.76.4

7,610,810,3

Steering: Hydraulic power-assistClutches. . . . . . . . . . . . . . . .11 in. (279mm); 9 disks per clutchBrakes. . . . . .Self-energizing,contracting band; bonded lining

Hydraulic System:Control. . . . . . . . . . . . . . Single-lever, triple hydraulic systemPump Gear,28gpm(106Ipm)Pressure.. ..2,250 psi (158,2 kg/cm2)Oil lines. . . . . . Seamless steel tubing; double-wire-braid hoseFilter. . . . . . . . . . . . . . . . Dual filtration, micronic and wire mesh

Hydraulic Cylinders: Bore StrokeBoom, two 4.25-in.(108mm) 28.25-in.(718mm)Bucket, two. .. .3.5-in. (89 mm) 31.1-in. (790 mm)Cylinder rods. . Ground, heat-treated, chrome-plated, polishedBoom cylinder rods .2.25-in. (57 mm) dia.Bucket cylinder rods 2-in.(51mm)dia.

Tracks (5-roller track frames w/rock guards):Triple semi-grouser, open-center shoes. . . . . . 14-in. (356 mm)Track shoes, each side 37Ground contact area .2,128 sq. in. (13729 cm2)Ground pressure 7.8 psi (0,548 kg/cm2)Length of track on ground. . . . . . . . . . . . . . . . . .76 in. (1,93 m)Trackguage 52in.(1,32m)Carrier roller 1Adjustment HydraulicClearance at rear crossbar. . . . . . . . . . . . . .14.25in. (362 mm)

Capacities: U.S. LitersCooling system 4 gal. 15,1Fueltank 31gal. 117,3Crankcase, including filter. . . . . . . . . . . . . . . . .9 qt. 8,5Transmission 8gal. 30,3Final-drive (each) 6.5qt. 6,2Loader hydraulic reservoir. . . . . . . . . . . . . . . . .7 gal. 26,5Loader hydraulic system. . . . . . . . . . . . . . . . . . .13 gal. 49,2

Additional Standard Equipment:Front bottom guardFront hitch ......

Deluxe cushion seat w/arm restsKey switch w/push-button safety startPrecleanerElectric hourmeterCigaret lighterVandal protectionGrease gunBottom guard counterweight

w/fixed drawbar \Bucket level indicaforRadiator sand shieldSprocket weightsLightsTrash-resistant radiatorTransistorized voltage regulatorEngine side shields

SAE Operating Weight. . . . . . . . . . . . . . . . .16,700 lb. (7582 kg)

Special Equipment:TachometerEther starting aidPTO (1,000 rpm)Upper and lower front idler shieldsSpark arresting mufflerAltitude compensatorRaPS w/canopy and seat belt~

Cab (includes RaPS)Two batteriesReturn to digRear counterweight for multipurpose

bucket or log loaderWinch drive

...

21