k-2330tresources.kohler.com/plumbing/kohlerapac/pdf/2330t.pdf · marble foam padding anchor setting...

1
329mm 372mm 382mm 481mm 435mm VITREOUS CHINA UNDERCOUNTER LAVATORY / CUT-OUT TEMPLATE / INSTALLATION INSTRUCTION K-2330T KATHRYN · · · · · · · RECOMMENDED TOOLS AND MATERIALS · · · · · · · Plumbers Putty Saber Saw Tape Measure Drill Pencil Scissors Claw Hammer · · · · · · · · 1/2 UNDERCOUNTER INSTALLATION For Wood Countertops NOTE: NOTE: you may require different, more specialized tools to install this lavatory to countertop materials other than wood or wood composites. Install so future removal from underneath the countertop is possible to avoid damage to the countertop. Check the desired lavatory location for clearance between the backsplash, faucet, lavatory, and cabinet. Cut out the template. Carefully position and trace the template on the countertop as directed on the template. Mark the faucet hole centerline on the countertop. Drill a 1/2" pilot hole on the inside of the cut line. Cut out the countertop opening with a saber or keyhole saw. Mark and pre-drill the wood screw holes at the locations shown on the template. Waterproof any exposed areas of wood. · · · · · · · · ROUGH-IN 356mm-Based on 305mm riser which may require cutting. (T) (S) Pop-up drain typically 327mm. 327 356 - 305 (T) (S) " 225mm 29mm 13mm 171mm 502mm 397mm 127mm 1-1/4 OUTET (32mm) 3/8 COLD (9.5mm) OF FITTING C L 3/8 (9.5mm) HOT (T) (S) " " · · · · · · · · · · · · 3/8 BEFORE YOU BEGIN · · · · · · · · · · · · This lavatory can be installed in either undercounter or tile-in installations. Follow the instructions that apply to your installation. Observe local plumbing codes. Prior to installation, unpack the new lavatory and inspect it for damage. Return the lavatory to its protective carton until you are ready to install it . Inspect the waste and supply tubing, and replace as needed. Failure to follow these precautions may result in a poor installation. Undercounter lavatories should be installed by experienced installers. Do not use adhesives or adhesive sealants with this product. Install so future removal from underneath countertop is possible to avoid countertop damage. Due to the variety of installations possible with this lavatory, you may need to use procedures other than those described. Remember, because of the variety of tiles available, you must take careful measurements prior to installation. For a replacement installation, make sure the existing cutout is the same size or smaller than the cutout for the new lavatory. It is very important that the proper materials are used with your lavatory. Proper selection of tile is critical for a good installation. 3/8 tile is recommended. Because of the variance in tile thickness, your carpenter, tiler, and plumber must all be aware of the exact type of tile you choose. After selecting the tile, provide a sample to each contractor involved in the project. It is very inportant that the carpenter, tiler, and plumber maintain good communication and discuss requirements. For Undercounter Installation: For Tile-in Installation: " 134mm FOR UNDERCOUNTERINSTALLATION CUT ALONG THIS LINE FOR TILE-IN INSTALLATION CUT ALONG THIS LINE INNER RIM OF LAVATORY OUTER RIM OF LAVATORY TILE-IN LAVATORY UNDERCOUNTER LAVATORY WHEN PLOTTING TEMPLATE FULL SIZE: make sure horizontal and verfical dimensions match the dimensions labeled on the template. Applicable Lavatory: PRODUCT INFORMATION 432mm 330mm Overflow Less Glazed Underside 432mm 330mm Overflow and Glazed Underside 432mm 330mm Overflow and Glazed Underside Less K-2330T K-2330T-G K-2330T-N Shown Not Shown Not Shown Fixture*: Outlet * Approximate Measurements For Comparison Only. D. 44mm Basin Area Water Depth 432mm 330mm 432mm 330mm 76mm 114mm K-2330T-N K-2330T-G K-2330T 1039387-T01-A ã ã , 2004 Copyright Kohler China Ltd., 2004 432 330 432 330 76 114 K-2330T-N K-2330 -G T K-2330T 432 330 432 330 432 330 K-2330T K-2330T-G K-2330T-N * * 44 K-2330T ........................K-3020T .................... ........................K-6839T ORDER INFORMATION Kathryn Console Table ....................K-3020T Kathryn Console Lavatory ...............K-2330T Kathryn Console Leg.......................K-6839T Marble Foam Padding Anchor Setting Tool Wood Screw Anchor Screw A S pply ealant Clamp · · · · · · 25 NOTE: NOTE: Caution: Risk of personal injury or product damage. Do not overtighten. non-abrasive Do not use adhesives or adhesive sealants. Apply a continuous bead of quality sealant to the top surface of the lavatory rim where it will contact the countertop. The screws provided should be used on countertops with a minimum 1" (25mm) thickness. For thinner countertops, use appropriate anchors and fasteners. Lavatories are very heavy. Get help lifting the lavatory. For wood, wood composite, and marble countertops, install the lavatory to the countertop with the clamps and screws provided. For other countertop materials, refer to the countertop manufacturer's instructions for recommended fasteners. Position the lavatory squarely under the cutout before tightening the clamps. Draw the lavatory rim up against the countertop until it is snug. Immediately wipe away any excess sealant. Make the final drain and faucet connections to complete the lavatory installation. Be sure to follow the instructions packed with the drain and faucet. Clean up with a cleaner. · · · · · · · · · · · · · · · · · · 3/4 (19.05mm) 3/4 (19.05mm) 1/2 10 1 · · · · · · 25 CAUTION: Risk of personal injury or product damage. NOTE: Lavatories are very heavy. Get help lifting the lavatory. Position the lavatory in the countertop opening. Verify the fit and position. Remove the lavatory. Place a 1" (25mm) spot of sealant at each corner of the frame where it will contact lavatory. Apply additional sealant if using shims. Carefully position the lavatory. Use sealant in space between lavatory and tile. Tile and grout to allow an acceptable space between the tile and lavatory. · · · · · · Lavatory Sealant Tile Mortar or Adhesive Route or Shim as Required to Level Tile Water Resistant Underlayment or Backing Material (19.05mm)Minimum 19.05mm 3/ " 8 4 TILE-IN INSTALLATION NOTE: Do not use: NOTE: NOTE Tile backer board installed over plywood is the recommended underlayment for installing this lavatory. Tile should be bonded to the backer board with dry set or latex portland mortar. Acceptable underlayments include: Tile backer board over 3/4" exterior grade plywood; 3/4" exterior grade plywood. Flakeboard; Interior grade plywood; Gypsum wallboard. Consult with the tile contractor to determine the material to be used. Check the desired lavatory location for clearance between the backsplash, faucet, lavatory, and cabinet. Cut out the template. Position and trace the template on the countertop as directed on the template. Drill a 1/2 pilot hole on the inside of the cut line. Cut out the countertop with a saber or keyhole saw. Measure and compare the thickness of the lavatory rim and tile. The lavatory rim thickness is 3/8" (10mm) +/-1/32" (1mm). Because of the varying thickness of the tile and lavatory, or if adhesive or mortar bed installation is used, make allowances to shim the lavatory, or route the underlayment as required. : The lavatory is designed to be installed flush or slightly lower than the surrounding tile. Provide shims, or route the underlayment, as needed. · · · · · · · · · · · · / · · · · · · 10 16 For Marble/Stone Countertops For All Installations · · · · · · Position the countertop upside down on foam padding to protect the surface. Mark and drill 3/8" (10mm) holes 5/8" (16mm) deep at the locations shown on the template. Use a setting tool and hammer to secure the anchors. If the countertop has not been installed, install it at this time. Drill the faucet holes according to the faucet installation instructions. Install the faucet to the countertop according to the manufacturer , s instructions. Install the drain to the lavatory according to the drain manufacturer , s instructions. ( ) ( ) 138 19 200021 Plumbing Fixtures and Fittings Limited One-year Warranty Kohler plumbing fixtures and fittings are warranted to be free of manufacturing defects. This product is warranted for one year from date of purchase. Kohler China will be responsible for any problems caused by manufacturing defects provided with the invoice. Kohler China will, at its election, repair, replace or make appropriate adjustment where Kohler China inspection discloses any such defects occurring in normal usage within one year after purchase. Implied warranties including that of merchantability and fitness for a particular purpose are expressly limited in duration to the duration of this warranty, Kohler China disclaims any liability for special, incidental or consequential damages. Damages to the product caused by misuse, abuse and installation that is not in accordance with the owner's manual are not covered by this warranty. To obtain quick warranty service, please contact your dealer, or write to Kohler China. (Original sales receipt must be provided as the proof of purchase.) Kohler China Investment Company Ltd. Central Customer Service Center 19/F, Shanghai Square, 138 Huai Hai Road, Luwan District, Shanghai, PRC Zip Code: 200021 This is our exclusive written warranty. ( ) IMPORTANT CONSUMER INFORMATION (CARE AND CLEANING) To keep your lavatory looking new, make sure you rinse it out thoroughly after each use. DO NOT ABRASIVES on this product, as they will scratch and ruin the surface. Stubborn stains, paint, or tar can be removed with turpentine or paint thinner. (19.05mm) (19.05mm)

Upload: others

Post on 09-Oct-2020

1 views

Category:

Documents


0 download

TRANSCRIPT

Page 1: K-2330Tresources.kohler.com/plumbing/kohlerapac/pdf/2330t.pdf · Marble Foam Padding Anchor Setting Tool Wood Screw Anchor Screw ASpply ealant Clamp 25 NOTE: NOTE: Caution: Risk of

329mm372mm382mm

481mm

435mm

VITREOUS CHINA UNDERCOUNTER LAVATORY/

CUT-OUT TEMPLATE / INSTALLATION INSTRUCTION

K-2330TKATHRYN

RECOMMENDED

TOOLS AND

MATERIALS�

Plumbers Putty

Saber Saw

Tape Measure

Drill

Pencil

Scissors

Claw Hammer

1/2

UNDERCOUNTERINSTALLATION

For Wood Countertops

NOTE:

NOTE:

you may require different, morespecialized tools to install this lavatory tocountertop materials other than wood orwood composites.

Install so future removal fromunderneath the countertop is possible toavoid damage to the countertop.

Check the desired lavatory location forclearance between the backsplash, faucet,lavatory, and cabinet.Cut out the template.Carefully position and trace the templateon the countertop as directed on thetemplate.Mark the faucet hole centerline on thecountertop.Drill a 1/2" pilot hole on the inside of thecut line.Cut out the countertop opening with asaber or keyhole saw.

Mark and pre-drill the wood screw holesat the locations shown on the template.Waterproof any exposed areas of wood.

ROUGH-IN

356mm-Based on 305mm riser whichmay require cutting.

(T)

(S)

Pop-up drain typically 327mm.

327

356 - 305

(T)

(S)

"

225mm

29mm

13mm

171mm

502mm

397mm

127mm

1-1/4OUTET

(32mm)

3/8COLD

(9.5mm)

OF FITTINGCL

3/8 (9.5mm)HOT

(T)(S)

""

3/8

BEFORE YOU BEGIN�

This lavatory can be installed in eitherundercounter or tile-in installations.Follow the instructions that apply to yourinstallation.Observe local plumbing codes.Prior to installation, unpack the newlavatory and inspect it for damage.Return the lavatory to its protectivecarton until you are ready to install it .Inspect the waste and supply tubing, andreplace as needed.Failure to follow these precautions mayresult in a poor installation.

Undercounter lavatories should beinstalled by experienced installers.Do not use adhesives or adhesivesealants with this product.Install so future removal from underneathcountertop is possible to avoidcountertop damage.

Due to the variety of installations possiblewith this lavatory, you may need to useprocedures other than those described.Remember, because of the variety of tilesavailable, you must take carefulmeasurements prior to installation.For a replacement installation, make surethe existing cutout is the same size orsmaller than the cutout for the newlavatory.It is very important that the propermaterials are used with your lavatory.Proper selection of tile is critical for agood installation. 3/8 tile isrecommended. Because of the variancein tile thickness, your carpenter, tiler, andplumber must all be aware of the exacttype of tile you choose.After selecting the tile, provide a sampleto each contractor involved in the project.It is very inportant that the carpenter, tiler,and plumber maintain goodcommunication and discuss requirements.

For Undercounter Installation:

For Tile-in Installation:

"

134mm

FOR UNDERCOUNTERINSTALLATIONCUT ALONG THIS LINE

FOR TILE-IN INSTALLATIONCUT ALONG THIS LINE

INNER RIM OF LAVATORY

OUTER RIM OF LAVATORY

TILE-IN LAVATORY UNDERCOUNTERLAVATORY

WHEN PLOTTING TEMPLATE FULL SIZE:make sure horizontal and verfical dimensionsmatch the dimensions labeled on the template.

Applicable Lavatory:

PRODUCT INFORMATION

432mm 330mm OverflowLess Glazed Underside

432mm 330mm Overflowand Glazed Underside

432mm 330mmOverflow and Glazed Underside

Less

K-2330T

K-2330T-G

K-2330T-N

Shown

Not Shown

Not Shown

Fixture*:

Outlet* Approximate Measurements For Comparison Only.

D. 44mm

Basin Area Water Depth

432mm 330mm

432mm 330mm

76mm

114mmK-2330T-N

K-2330T-G

K-2330T

1039387-T01-A

, 2004

Copyright Kohler China Ltd., 2004

432 330

432 330

76

114K-2330T-N

K-2330 -GT

K-2330T

432 330

432 330

432 330

K-2330T

K-2330T-G

K-2330T-N

*

*

44

K-2330T

........................K-3020T

....................

........................K-6839T

ORDER INFORMATION

Kathryn Console Table ....................K-3020T

Kathryn Console Lavatory...............K-2330T

Kathryn Console Leg.......................K-6839T

Marble

FoamPadding

Anchor

Setting Tool

Wood Screw

Anchor ScrewA Spply ealant

Clamp

25

NOTE:

NOTE:

Caution: Risk of personal injury or product damage.

Do not overtighten.

non-abrasive

Do not use adhesives or adhesive sealants.Apply a continuous bead of quality sealant to the top surface of thelavatory rim where it will contact the countertop.

The screws provided should be used on countertops with aminimum 1" (25mm) thickness. For thinner countertops, useappropriate anchors and fasteners.

Lavatories are very heavy. Get help lifting the lavatory.For wood, wood composite, and marble countertops, install thelavatory to the countertop with the clamps and screws provided.For other countertop materials, refer to the countertopmanufacturer's instructions for recommended fasteners.Position the lavatory squarely under the cutout before tighteningthe clamps. Draw the lavatory rim up against the countertop until itis snug.Immediately wipe away any excess sealant.Make the final drain and faucet connections to complete thelavatory installation. Be sure to follow the instructions packed withthe drain and faucet.Clean up with a cleaner.

3/4 (19.05mm)3/4 (19.05mm)

1/2

101

25

CAUTION: Risk of personal injury or product damage.

NOTE:

Lavatories are very heavy. Get help lifting the lavatory.Position the lavatory in the countertop opening. Verify the fit andposition.Remove the lavatory.Place a 1" (25mm) spot of sealant at each corner of the framewhere it will contact lavatory.

Apply additional sealant if using shims.Carefully position the lavatory.Use sealant in space between lavatory and tile.Tile and grout to allow an acceptable space between the tile andlavatory.

Lavatory

Sealant

Tile

Mortar orAdhesive

Route or Shim asRequired to Level Tile

Water ResistantUnderlayment orBacking Material

(19.05mm)Minimum19.05mm

3/ "84

TILE-IN INSTALLATIONNOTE:

Do not use:

NOTE:

NOTE

Tile backer board installed over plywood is the recommendedunderlayment for installing this lavatory. Tile should be bonded to thebacker board with dry set or latex portland mortar.Acceptable underlayments include:

Tile backer board over 3/4" exterior grade plywood;3/4" exterior grade plywood.

Flakeboard;Interior grade plywood;Gypsum wallboard.

Consult with the tile contractor to determine the material to beused.

Check the desired lavatory location for clearance between thebacksplash, faucet, lavatory, and cabinet.Cut out the template.Position and trace the template on the countertop as directed onthe template.Drill a 1/2 pilot hole on the inside of the cut line.Cut out the countertop with a saber or keyhole saw.Measure and compare the thickness of the lavatory rim and tile.The lavatory rim thickness is 3/8" (10mm) +/-1/32" (1mm). Becauseof the varying thickness of the tile and lavatory, or if adhesive ormortar bed installation is used, make allowances to shim thelavatory, or route the underlayment as required.

: The lavatory is designed to be installed flush or slightly lowerthan the surrounding tile.

Provide shims, or route the underlayment, as needed.

/�

10 16

For Marble/Stone Countertops

For All Installations

Position the countertop upside down on foam padding to protectthe surface. Mark and drill 3/8" (10mm) holes 5/8" (16mm) deep atthe locations shown on the template.Use a setting tool and hammer to secure the anchors.

If the countertop has not been installed, install it at this time.Drill the faucet holes according to the faucet installation instructions.Install the faucet to the countertop according to the manufacturer,sinstructions.Install the drain to the lavatory according to the drainmanufacturer,s instructions.

( )

( )

13819

200021

Plumbing Fixtures and Fittings Limited One-year Warranty

Kohler plumbing fixtures and fittings are warranted to be free of manufacturing defects.

This product is warranted for one year from date of purchase. Kohler China will beresponsible for any problems caused by manufacturing defects provided with the invoice.Kohler China will, at its election, repair, replace or make appropriate adjustment whereKohler China inspection discloses any such defects occurring in normal usage within oneyear after purchase.

Implied warranties including that of merchantability and fitness for a particular purposeare expressly limited in duration to the duration of this warranty, Kohler China disclaimsany liability for special, incidental or consequential damages. Damages to the productcaused by misuse, abuse and installation that is not in accordance with the owner'smanual are not covered by this warranty.

To obtain quick warranty service, please contact your dealer, or write to Kohler China.(Original sales receipt must be provided as the proof of purchase.)

Kohler China Investment Company Ltd.Central Customer Service Center19/F, Shanghai Square, 138 Huai Hai Road,Luwan District, Shanghai, PRCZip Code: 200021

This is our exclusive written warranty.

( ) IMPORTANT CONSUMER INFORMATION(CARE AND CLEANING)

To keep your lavatory looking new, make sure you rinse it out thoroughly after each use.

DO NOT ABRASIVES on this product, as they will scratch and ruin the surface. Stubborn

stains, paint, or tar can be removed with turpentine or paint thinner.

(19.05mm)(19.05mm)