lind24-evo · lamp is instant starting and provides the utmost in quality, sustained output and...
TRANSCRIPT
Model LIND30-EVO
Model LIND24-EVO-2PM
Model LIND24-EVO
2
ultraviolet.com • buyultraviolet.com
GERMICIDAL ULTRAVIOLET
Ultraviolet is a unique and rapid
method of disinfection. It utilizes
germicidal ultraviolet lamps producing
ultraviolet wavelengths at 254
nanometers (nm)—a level that is
lethal to bacteria, virus and other
microorganisms.
An ever growing range of industries
and consumer applications have found
ultraviolet to be the ideal solution for
their air treatment needs.
Atlantic Ultraviolet equipment and
systems are manufactured in the USA.
ABOUT US
Since 1963, Atlantic Ultraviolet
Corporation® has pioneered
the discovery and development
of beneficial uses of ultraviolet
energy. Over the years
these efforts have led to the
development of valuable, cost effective and environmentally sound techniques and
products now known and respected throughout the world.
The UV application specialists at Atlantic Ultraviolet Corporation® assist customers
in the selection of germicidal lamps and equipment. Their specialized knowledge is
a valuable resource in formulating effective and cost-conscious ultraviolet solutions.
Extensive inventories and a dedicated staff enable Atlantic Ultraviolet to fulfill its
commitment to provide fast deliveries and responsive customer service.
Model LIND24-EVO
3
ultraviolet.com • buyultraviolet.com
EconomicalSystem requires very little
power to operate.
SafeLow risk of over-exposure.
FastDisinfects air in seconds,
reducing the risk of cross infection
and exposure of occupants to
infectious airborne microbes.
AutomaticContinuous disinfection without
special attention.
DurablePolished Stainless Steel and
Aluminum construction.
VersatileThree styles available (pendent
mount and wall mount) to handle
different room configurations.
Low MaintenanceAnnual lamp replacement
and periodic cleaning is all
that is required.
ADVANTAGES PRINCIPLE OF OPERATION
Model LIND24-EVO Wall Mount, Single Lamp
The Hygeaire® design has been carefully conceived to direct germicidal ultraviolet
rays to purify the upper room air of occupied spaces in order to reduce the risk of
cross infection and exposure of occupants to infectious airborne microbes.
The operation of the Hygeaire® is as follows:
1. Ultraviolet rays project across the upper room air.
2. Bacteria and virus that are carried into the ultraviolet field by convection
currents or air circulation are destroyed.
3. The air in the room is continuously being purified.
Reflector
Louver
Germicidal Ultraviolet Lamp
UltravioletGermicidalRays
4
ultraviolet.com • buyultraviolet.com
Hygeaire® LIND24-EVO & LIND30-EVO Wall Mount Indirect Fixture
SPECIAL FEATURES
Steadfast™ LampholderSet includes a stationary and a spring-loaded, telescopic holder that holds a single pin lamp securely. The spring-loaded feature on one end facilitates convenient, quick and easy lamp changes.
Stainless Steel ConstructionThe fixture is manufactured in Type 304 stainless steel for unparalleled strength, durability and an attractive finish.
Polished ReflectorInterior surface includes a special polished reflector which provides a highly reflective surface to maximize ultraviolet intensity.
LouversUnique construction directs ultraviolet rays to the upper portion of the room.
Interlock Safety SwitchSwitch protects field technicians from exposure to ultraviolet wavelengths by automatically disconnecting power to the lamp when fixture is opened.
Model LIND24-EVO Wall Mount, Single Lamp
(see page 8 for Optional Accessories)
STER-L-RAY ® Germicidal LampLamp is instant starting and provides the utmost in quality, sustained output and longevity. (see page 8 for information)
• deliver high uv lamp output
• lightweight
• operate cool for longer life
• versatile—each operates a wide range of lamps
• save energy through high efficiency
• provide silent operation
Surelite™ Electronic Ballasts
State-of-the-art electronic ballasts are designed to operate ultraviolet lamps. The Hygeaire® Ultraviolet Indirect Disinfection System includes three unique electronic variable output versions (EVO) of the Surelite™ with an adjustable feature mounted to base of the fixture.
Surelite™ Electronic Ballasts offers these advantages over conventional ballasts:
5
ultraviolet.com • buyultraviolet.com
INSTALLATION
SPECIFICATIONS—Hygeaire® LIND24-EVO & LIND30-EVO Wall Mount Indirect Fixture
Wattage is Lamp Watts including ballast loss (approximate). Output at 254 nanometers at 100 hours and 80 degrees F (approximate).
• 120 Volts 50/60 Hz and 220-230 Volts 50/60 Hz fixtures are available—specify when ordering.• Consult factory with other specific power requirements.• Bottom of fixture must be installed at a minimum height of 7 feet above the floor, see page 11 for more information.
Figure 1 – Shows the back side of Hygeaire® Model LIND24-EVO or Model LIND30-EVO;
note the four mounting holes in the back of the fixture. The fixture is to be mounted on a
plumb and vertical surface, at a minimum height of 7 feet from the bottom of the fixture to
the floor, in a location that must be able to safely support 16 pounds.
Model LampPower
Consumption
Total Ultraviolet
Output
Exterior Housing Dimensions Rated Average Lamp Life
Length Width Depth
LIND24-EVO 05-1348-R (1) 31 Watts 8.5 Watts 24” 5-11/32” 7-7/8” 10,000 Hours
LIND30-EVO 05-1352-R (1) 37 Watts 11 Watts 30” 5-3/8” 8-5/16” 10,000 Hours
Mounting Holes
Model LIND24-EVO / LIND30-EVO
6
ultraviolet.com • buyultraviolet.com
SPECIAL FEATURES
Hygeaire® LIND24-EVO-2PM Pendent Mount Indirect Fixture
Pendent Mount Canopy SetSecures Hygeaire® LIND24-EVO-2PM to surface (see Figure 3 on page 7 for full pendant).
Steadfast™ LampholderSet includes a stationary and a spring-loaded, telescopic holder that holds a single pin lamp securely. The spring-loaded feature on one end facilitates convenient, quick and easy lamp changes.
Stainless Steel ConstructionThe fixture is manufactured in Type 304 stainless steel for unparalleled strength, durability and an attractive finish.
Polished ReflectorInterior surface includes a special polished reflector which provides a highly reflective surface to maximize ultraviolet intensity.
LouversUnique construction directs ultraviolet rays to the upper portion of the room.
Model LIND24-EVO-2PM Pendent Mount, Double Lamp
(see page 8 for Optional Accessories)
STER-L-RAY ® Germicidal LampLamp is instant starting and provides the utmost in quality, sustained output and longevity. (see page 8 for information)
Interlock Safety SwitchSwitch protects field technicians from exposure to ultraviolet wavelengths by automatically disconnecting power to the lamp when fixture is opened.
• deliver high uv lamp output
• lightweight
• operate cool for longer life
• versatile—each operates a wide range of lamps
• save energy through high efficiency
• provide silent operation
Surelite™ Electronic Ballasts
State-of-the-art electronic ballasts are designed to operate ultraviolet lamps. The Hygeaire® Ultraviolet Indirect Disinfection System includes three unique electronic variable output versions (EVO) of the Surelite™ with an adjustable feature mounted to base of the fixture.
Surelite™ Electronic Ballasts offers these advantages over conventional ballasts:
7
ultraviolet.com • buyultraviolet.com
Model LampPower
Consumption
Total Ultraviolet
Output
Exterior Housing Dimensions Rated Average Lamp Life
Length Width Depth
LIND24-EVO-2PM 05-1348-R (2) 61.4 Watts 17 Watts 24” 10-17/32” 7-7/8” 10,000 Hours
INSTALLATION
SPECIFICATIONS— Hygeaire® LIND24-EVO-2PM Pendent Mount Indirect Fixture
Wattage is Lamp Watts including ballast loss (approximate). Output at 254 nanometers at 100 hours and 80 degrees F (approximate).
• 120 Volts 50/60 Hz and 220-240 Volts 50/60 Hz fixtures are available—specify when ordering.• Consult factory with other specific power requirements.• Bottom of fixture must be installed at a minimum height of 7 feet above the floor, see page 11 for more information.
Figure 2 – Shows the top of Hygeaire® Model LIND24-EVO-2PM
(above). Note the two mounting holes on the top of this fixture
(these are for the Pendent Mount Canopy Set attachment). The
fixture is to be mounted at a minimum height of 7 feet from the
bottom of the fixture to the floor, in a location that must be able to
safely support 32 pounds.
Figure 3 – Shows Hygeaire® Model LIND24-EVO-2PM
complete with Pendent Mount Canopy Set (left).
Mounting Holes
Model LIND24-EVO-2PM
8
ultraviolet.com • buyultraviolet.com
GENUINE STER-L-RAYSTER-L-RAY ® GERMICIDAL LAMPS
STER-L-RAY ®, the STER-L-RAY ® logo, ArmorLite™, and the ArmorLite™ logo are trademarks of Atlantic Ultraviolet Corporation.
CAUTION: Exposure to direct or reflected germicidal ultraviolet rays will cause painful eye irritation and reddening of the skin. Personnel subject to such exposure must wear suitable faceshield, gloves and protective clothing.
Hg - LAMP CONTAINS MERCURY, manage in accord with disposal laws, see: LampRecycle.org.
Instant StartGermicidal Lamps
STER-L-RAY ® Germicidal Lamps are shortwave, low pressure tubes that
produce ultraviolet wavelengths lethal to microorganisms.
Approximately 95% of the ultraviolet energy emitted from STER-L-RAY ®
germicidal lamps is at 254 nanometers, the region of germicidal effectiveness
most destructive to bacteria, mold and virus.
OPTIONAL ACCESSORIES
Zenith™ UV-C DetectorThe Zenith™ UV-C Detector is a sensitive hand-held, self-contained battery operated ultraviolet meter that can be used for:• Monitoring UV-C Germicidal Lamp Intensity & Aging• Measuring UV-C Germicidal Fixture Leakage
ArmorLite™ Safety ShieldProtective coating applied to STER-L-RAY ® Germicidal Lamps ensures protection for employees, products and work environments by eliminating the dangers associated with fragments of broken lamps.
(Lamp on right has ArmorLite™ coating. Available with lamps used in ALL Hygeaire® fixtures at the time of purchase. The coating is installed at the factory.)
Promate™ Warning SignsTo be affixed to entry door(s) to warn that an ultraviolet disinfection treatment is in progress and area should NOT be entered.
Promate™ Face ShieldLightweight visor with adjustable headgear provides eye and face protection from germicidal ultraviolet rays.
Promate™ Safety GlassesSafety eyewear should be used as general-purpose safety protection and for additional shielding from germicidal ultraviolet rays.
9
ultraviolet.com • buyultraviolet.com
ORGANISM ALTERNATE NAME TYPE DISEASE DOSE*
Corynebacterium diphtheriae C. diphtheriae Bacteria Diptheria 6,500
Legionella pneumophila L. pneumophila Bacteria Legionnaire’s Disease 12,300
Mycobacterium tuberculosis M. tuberculosis Bacteria Tuberculosis (TB) 10,000
Pseudomonas aeruginosa P. aeruginosa Bacteria 3,900
Serratia Marcescens S. marcescens Bacteria 6,160
Staphlylococcus aureus S. aureus Bacteria 6,600
Staphlylococcus epidermidis S. epidermidis Bacteria 5,800
Adeno Virus Type III Virus 4,500
Coxsackie A2 Virus 6,300
Influenza Virus Flu 6,600
OPERATING CHARACTERISTICS
ULTRAVIOLET DOSAGE
Germicidal lamps provide effective protection against microorganisms. A small cross-section is shown below.
*Nominal Ultraviolet dosage (µWSec/cm2) necessary to inactivate better than 99% of specific microorganism. Consult factory for more complete listing.
Relative Spectral EnergyDistribution (Typical)
Germicidal Effectiveness As Related to Wavelength
100
80
60
40
20
0
RE
LA
TIV
E E
FF
EC
TIV
EN
ES
S
INT
EN
SIT
Y
100
80
60
40
20
0
100 200 300 400 500 600
WAVELENGTH (NANOMETERS)
200 225 250 275 300
WAVELENGTH (NANOMETERS)
10
ultraviolet.com • buyultraviolet.com
APPLICATIONS
• Laboratories
• Hospitals
• Clinics
• Maternity Areas
• Labor & Delivery Areas
• Pathology Labs
• Kidney Dialysis Labs
• Operating Rooms
• Methadone Clinics
• Burn Centers
• TB Clinics
• Homeless Shelters
• Prisons & Jails
• Detention Centers
• Nursing Homes
• Universities
• Schools
• Veterinary Clinics
• Animal Husbandry
• Kennels
• Food Industry
• Food Processing
• Dairy Processing
• Bakeries
• Office Buildings
• Conference Rooms
• Clean Rooms
• Pharmaceutical Mfg.
• Electronic Production
• Cosmetic Production
The principal application of Hygeaire® germicidal ultraviolet is to purify the
upper room air in occupied spaces in order to reduce the risk of cross infection
and exposure of occupants to infectious airborne microbes. These fixtures
are designed to project the ultraviolet rays across the upper room air thereby
destroying bacteria and viruses that are carried into the ultraviolet field by
convection currents or air circulation.
It is an important requirement when applying indirect germicidal ultraviolet
wavelengths to upper air to keep the rays in the occupied level (below 6-1/2
feet) within acceptable limits. Therefore, mounting in the appropriate position is
essential for safe use.
Our Ultraviolet Application Specialists are here to help you determine the best
location for the installation of the Hygeaire®.
As with all indirect ultraviolet fixtures, occasional ultraviolet measurements are
required to ensure that ultraviolet intensities within the occupied area remain at the
maximum treatment levels without exceeding the safety limits. The Hygeaire®
fixture includes a variable output ballast, providing an adjustment to comply with
the safety standard.
Our Zenith™ UV-C Detector is an optional accessory (described on page 8).
However we feel that it is a necessary tool to ensure that the ultraviolet levels are
optimized for treatment and safety purposes.
11
ultraviolet.com • buyultraviolet.com
Distance from the back of the fixture (feet)
Dis
tanc
e fro
m th
e flo
or (f
eet)
UV measurements given inmicrowatts per squarecentimeter (µW/cm2)
Germicidal Zone:UV≥10µW/cm2
Stray UV Zone
100
0.2
0.2
50 20 10200
1234
765
00 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
89
101112
fixture
APPLICATIONS
0
5
10
15
20
17.5
12.5
7.5
2.5
15 10 5 0 5 10 15Distance from the center of the fixture (feet)
Dis
tanc
e fro
m th
e ba
ck o
f the
fixt
ure
(feet
)
fixture
10
20
50
UV measurements given inmicrowatts per squarecentimeter (µW/cm2)
Floor areacoverage 213 ft2
(UV≥10µW/cm2)
Figure 4
Distribution of UV rays from
Hygeaire® Model LIND24-EVO
wall mounted fixture.
Figure 5
Example of the coverage area of
the Hygeaire® Model LIND24-EVO
wall mounted fixture.
The Standard of Excellence In Ultraviolet
Manufacturers / Engineers / Sales / Service – Germicidal Ultraviolet - Equipment & Lamps
Document No. 98-0901 • February 2020 ©2020 by Atlantic Ultraviolet Corporation ®
The information and recommendations contained in this publication are based upon data collected by the Atlantic Ultraviolet Corporation® and are believed to be correct. However, no guarantee or warranty of any kind, expressed or implied, is made with respect to the information
contained herein. Specifications and information are subject to change without notice.
375 Marcus Boulevard • Hauppauge, NY 11788 • 631.273.0500 • Fax: 631.273.0771 Email: [email protected] • Ultraviolet.com • BuyUltraviolet.com