magnetic measurementstijubaby.weebly.com/uploads/4/3/6/9/4369784/module_4_part1.pdf · magnetic...

MAGNETIC MEASUREMENTS

• The measurement of different magnetic phenomena is known as magnetic measurements

• The magnetic phenomena to be measured are – Flux

– Flux density

– Magnetising force

– Perrmeability

– B-H Curve

33

TYPES OF TESTS

• Study of magnetic measurements are classified as:

– DC tests or ballistic tests

– AC tests – done at high frequencies

– Steady state tests – to measure air gap flux

34

DC OR BALLISTICS TESTS

• For determining

– Flux/ flux density of a magnetic specimen

– B-H Curves

– Plotting Hysteresis loop

35

Edited with the trial version of Foxit Advanced PDF Editor

To remove this notice, visit:www.foxitsoftware.com/shopping

http://www.foxitsoftware.com/shopping

MEASUREMENT OF FLUX/FLUX DENSITY

36


• Ring specimen is wound with a coil

• Coil carries current I

• Coil is connected in series with resistance R and calibrating coil to BG – Ballistic Galvanometer

• Current through the coil is reversed so that an emf is developed in the coil

• That emf is measured by BG

37


38





• Θ – throw of galvanometer

• Gq- galvanometer constant

39

MEASUREMENT OF MAGNETISING

FORCE (H)

40




MEASUREMENT OF MAGNETISING FORCE (H)

41

MEASUREMENT OF MAGNETISING FORCE (H)

• Magnetizing force can be determined by measuring H on the surface of material

• It is due to tangential forces on the surface are equal in magnitude on both sides

• Coil is position to measure flux density B

• If permeability is known then H can be found

42

Determination of B-H Curve

• Two methods:

– Method of reversals

– Step by step method

43




Determination of B-H Curve by METHOD OF REVERSALS

44


Construction

• Ring shaped specimen is used

• Thin tape is put on ring

• Coil is insulated by paraffined wax and is uniformly wound over the tape

45


Working

• Specimen is demagnetised

• Magnetising current I is set to small vlue

• BG switch K is closed and switch S is operated 20 times backward and forward – to bring the specimen to reproducible magnetic state

• Key K is opened

• Value of flux corresponding to reproducible magnetic state ie H is taken

46


Working

• Value of B can be formulated by knowing relative permeability and value of H

• Flux is the ration of B (flux density) to area ofspecimen

• The above steps are repeated by various values of H upto maximum testing point

• B-H Curve is plotted from values of B and H

47




Determination of B-H Curve by STEP BY STEP METHOD

48


• No reversal of magnetizing current

• Current is given to the coil by a potential divider having number of tappings

• By varying the position of tapping, current I can be varied so H can be increased upto desired maximum value

49


Working

• Initially switch S1 is open

• Tapping is put at position 1

• Key K is open

• Switch S1 is closed

• Deflection in the galvanometer is noted – B(flux density)

• Current I is also noted

50


Working

• Procedure is repeated in taping 2, 3, etc…

• Value of B and current is noted

• 𝐻 =𝑁𝐼

𝑙

• By knowing value of current I, H is found

• From the above values B-H Curve is plotted

51


52

COMPARISON OF BAR AND RING SPECIMENS

Ring specimen Bar specimen

Ballistic tests gives high accuracy Ballistic tetss gives less accuracy

End effects are absent End effects are present

Free from errors due to magnetic leakage Errors are there due to magnetic leakage

Uniform winding should be there Uniform winding is easy

Magnetic flux density is not same at inner and outer portions

Uniform magnetic flux density all over the specimen

60

PERMEAMETERS

• Permeameters are instruments used to plot B-H

curves of straight magnetic specimens

• It gives true value of H in the relation

𝐵 = μ𝐻

• It generally consists of steel frame to which bar

type magnetic specimen is connected

61




PERMEAMETERS

Perm

eam

eter

s Hopkinson

permeameter

Ewing double bar permeameter

Illovici Permeameter

Burrow’s permeameter

Fahy’s Simplex Permeameter

National physical laboratory (England) form Permeamter

62

Hopkinson’s Permeameter (Bar and Yoke Method)

63


• Test coil is wound on central part of specimen

• Bar is clamped between two halves of massive iron yoke

64


65


66


67


• Flux density B is measured by Ballistic Galvanometer

68

EWING DOUBLE BAR PERMEAMETER

69


• Two similar bar specimens under test

• Two pairs of magnetisng coils, one pair exactly half length of other, axial length is same

• Bar specimens are fixed into two yokes

• Position of yokes on the bars can be adjusted

• Tests are done at length l and l/2

70


71


72


73


• Flux density B is measured by ballistic galvanometer

• B-H curves are plotted for full and half lenghts

74




BURROW’S PERMEAMETER

80


• S1- bar specimen to be tested

• S2- similar specimen

• M1,M2- magnetising windings

• A1,A2, B2,B2- compensating windings for elimination of leakage at joints

• C, C’- similar search coils

• D1, D2 – search coils having half number of turns of C, C’

81


82

BURROW’S PERMEAMETER Working

83


84

FLUXMETERS

• A special type of ballistic galvanometer

– Very small control torque

– High electromagnetic damping

• Grassot fluxmeter

92

FLUXMETERS Grassot flux meter

93


Construction

• Small cross section carrying coil C

• Cross section is suspended in narrow air gap of permanent magnet

• Current is injected to the coil through annealed silver springs

94


Construction

• Pointer is fixed to moving system

• Scale of pointer is calibrated in terms of flux turns

• Flux meter is designed by Grassot

95


• Spirals of silver spring makes controlling torque minimum

• Since controlling torque is minimum, pointer takes some time to come back to zero position

• Readings are obtained by taking by the deflection between initial and final positions of pointer

96


• Resistance of coil is minimum

• Inductance of coil is large

97


• Let ϕ1 − 𝑖𝑛𝑡𝑒𝑟𝑙𝑖𝑛𝑘𝑖𝑛𝑔 𝑓𝑙𝑢𝑥 𝑖𝑛 𝑖𝑛𝑖𝑡𝑖𝑎𝑙

position

ϕ2 − 𝑖𝑛𝑡𝑒𝑟𝑙𝑖𝑛𝑘𝑖𝑛𝑔 𝑓𝑙𝑢𝑥 𝑖𝑛 𝑓𝑖𝑛𝑎𝑙

position

98


• Let Ɵ1 − 𝑖𝑛𝑖𝑡𝑖𝑎𝑙 𝑑𝑒𝑓𝑙𝑒𝑐𝑡𝑖𝑜𝑛

Ɵ2 − 𝑓𝑖𝑛𝑎𝑙 𝑑𝑒𝑓𝑙𝑒𝑐𝑡𝑖𝑜𝑛

99


100


Advantages

• Deflection is same irrespective of change in flux

• Portable

101

Differences

102

magnetic measurementstijubaby.weebly.com/uploads/4/3/6/9/4369784/module_4_part1.pdf · magnetic...

Documents