module 8: open feedlot construction and management for water and air quality protection
DESCRIPTION
Module 8: Open Feedlot Construction and Management for Water and Air Quality Protection. By Jeff Lorimor. Introduction. Open feedlots are defined as confined areas that are devoid of vegetation or crop residue where animals are held for 45 days per year. CAFO Definition. - PowerPoint PPT PresentationTRANSCRIPT
Certified Nutrient Management Planning 8-1Logo
Module 8: Open Feedlot Construction and Management for Water and Air Quality Protection
By Jeff Lorimor
Certified Nutrient Management Planning 8-2Logo
Introduction
Open feedlots are defined as confined areas that are devoid of vegetation or crop residue where animals are held for 45 days per year.
Certified Nutrient Management Planning 8-3Logo
CAFO Definition
Federal regulations define a Concentrated Animal Feeding Operation (CAFO) as a feedlot with capacity equal or exceeding:
1,000 beef animals. 700 dairy cows. 2,500 swine over 55 pounds. Other species of EPA-defined sizes.
Certified Nutrient Management Planning 8-4Logo
NPDES Permit
CAFOS must obtain National Pollutant Discharge Elimination System (NPDES) permits. The permits:
Require capturing feedlot runoff. Require pumping captured liquids onto crops. Prohibit releasing runoff except in very large
storms (25-yr, 24-hr storm).
Certified Nutrient Management Planning 8-5Logo
Other CAFO Requirements Weekly inspection of storm water control
devices Must have depth markers in containments Record-keeping requirements
Certified Nutrient Management Planning 8-6Logo
Nearby Water Feedlots should not have streams running
through them. Feedlots should not drain directly into streams,
ditches, tile intakes, or other waterways leading directly to waters of the state.
Certified Nutrient Management Planning 8-7Logo
Runoff Control and Management
Complete containment Contain all runoff in a basin below the lot. To prevent overflow, land apply (irrigate) the
liquids. Discharge systems
Useful for lots smaller than CAFOs Release after settling solids in a manner that
prevents water pollution.
Certified Nutrient Management Planning 8-8Logo
Diversions Runoff control should start by diverting clean
water away from the lot surface.
Downspouts
Certified Nutrient Management Planning 8-9Logo
Settling Solids All feedlots should have
solids settling basins (debris basins) to capture solids from the feedlot runoff.
Certified Nutrient Management Planning 8-10Logo
Settling Solids (continued) Solids settling basins do not store liquids
permanently. Liquid velocity is slowed, but the liquid is
released. State regulations may determine basin
design. Porous outlets should be unplugged frequently
to enhance liquid release. Solids should be removed frequently.
Certified Nutrient Management Planning 8-11Logo
Nutrients are in Solids Most of the nutrients (>
90%) from open feedlots are found in the solids, not in runoff liquids.
Certified Nutrient Management Planning 8-12Logo
Containment Structures Must have capacity to store runoff from the 25-yr, 24-hr
storm If inadequate capacity exists, pump out the
containment. Maintain the structure in good condition.
Control erosion. Eliminate rodents. Keep mowed. Maintain depth indicator gauge. Keep accurate records.
Certified Nutrient Management Planning 8-13Logo
Air Quality In Western states, dust and odor are bigger
concerns than water quality. They are affected by the moisture content of the feedlot surface. Too dry…dust results Too wet…odor results
In more humid regions, surface runoff is the primary concern.
Certified Nutrient Management Planning 8-14Logo
Between 25%–40% Moisture is Optimum in a Feedlot
01020304050
60708090
100
0 10 20 30 40 50 60 70 80 90 100
Moisture Content, %w.b.
Du
st/O
do
r P
ote
nti
al
Dust Potential
Odor Potential
Certified Nutrient Management Planning 8-15Logo
Corral Construction If possible, build on 3%-5% slopes. Avoid pen-to-pen drainage. Build mounds up and down the slope, not across
the slope. Build mounds so cattle have access to them
without going through a pothole. Provide convenient access for manure removal.
Certified Nutrient Management Planning 8-16Logo
Properly Constructed Mounds Stay Dry
Certified Nutrient Management Planning 8-17Logo
Open Lot Maintenance Proper maintenance
is the most important factor in avoiding air and water quality problems with open lots.
Pull blades are better than push blades for maintenance.
Certified Nutrient Management Planning 8-18Logo
Make Mounds of Good Soil–Not Manure
Mounds should run up and down, rather than across, the slope.
Certified Nutrient Management Planning 8-19Logo
Open Lot Dust is a Function of
Loose manure depth on the corral surface.
The moisture content of the loose manure.
Hoof action arising from cattle activity.
Certified Nutrient Management Planning 8-20Logo
Corral MaintenanceKeep the surface as hard, smooth, and dry as
possible.
Minimize hoof prints that can hold water.
Scrape manure to maintain a 1"-2” base of manure above the soil surface.
Frequently inspect and fill holes and depressions.
Certified Nutrient Management Planning 8-21Logo
Stocking density (animals per unit area). Animal bodyweight. Number of days on feed. Corral surface condition (e.g., wallows, “dust
pots”). Manure harvesting frequency.
Dust Emissions
Loose manure depth is a function of…
Certified Nutrient Management Planning 8-22Logo
Loose Manure Depth
Deep and soft Thin and well
compacted
Certified Nutrient Management Planning 8-23Logo
Manure not yet harvested > 2” deep
Manure harvested within previous 3 days < 1” deep
Certified Nutrient Management Planning 8-24Logo
Manure Moisture Content
Certified Nutrient Management Planning 8-25Logo
Moisture from Heat Control Sprinkling lots during hot weather can create wet
conditions in humid areas. Sprinkle only intermittently. Locate sprinklers in areas that will not create
potholes. Sprinklers should provide 0.25”/day or more. Patterns should overlap 50% of the diameter. Do not sprinkle the feed apron.
Certified Nutrient Management Planning 8-26Logo
Stocking Density Increased stocking density adds more moisture
to the lot surface from cattle urination. Texas research showed reduced Pm-10
emission at 75 sq ft/head vs. 150 sq ft/head. Other factors such as cattle performance are
important in determining maximum density.
Certified Nutrient Management Planning 8-27Logo
Manure Moisture ContentF
eed
apro
n
1 2 3 4
Water Trough
High activity; High moisture
Low activity;Low moisture
Certified Nutrient Management Planning 8-28Logo
Dust Control Applying water to the feedyard surface,
passively or actively, helps but is not a cure-all. Frequent manure harvesting (> 1 per turn)
decreases water requirements and increases water effectiveness.
Use the off-season to get ready. Prioritize within the yard and the corral.
Certified Nutrient Management Planning 8-29Logo
Mortality Management for Odor Control Limit exposure to the elements; use rapid
rendering service pickup.
Compost. Perforate or cleave thoracic cavity and cover
carcass with 1'-2' of dry, organic material.
Burial is no longer acceptable in many states.
Certified Nutrient Management Planning 8-30Logo
Summary Preventing water and air pollution from open
feedlots starts with good lot design. Management and maintenance are the keys to
ongoing pollution prevention. Maintain smooth dry lots. Adjust moisture and scrape carefully to
minimize particulate and gas emissions.