nokia 515 service manual

Check the repair policy before

performing any mechanical repair on Service Level

1&2!

Service Manual for L1 and L2

Nokia 515 Dual SIM(RM-952)

Nokia 515(RM-953)Key features 2,4" display (320 x 240) with COrning Gorilla glass 5 Mpix camera with LED flash Nokia Slam support MicroSD card support up to 32 GB Micro-USB connector

Version 1.0

Exploded view Disassembly steps Assembly hints

Solder components Service devices Product controls and interfaces

Service concept

2013 Nokia | Nokia Internal Use only | All Rights Reserved.

More More More

More More More

More

Service Manual Level 1 and 2

Nokia 515 RM-953Nokia 515 Dual SIM RM-952Version 1.0

Exploded view

A-COVERI0001

UI SHIELDINGI0005

LIGHT SWAP PWBI0009

LED FLASHI0019

CAMERA LENSI0018

EARPIECE ADHESIVEI0008

EARPIECEI0007

CAMERAI0014

DISPLAYI0004

KEYMATI0002

DOME SHEETI0006

SIM2 CONNECTORI0022

IHF SPEAKERI0016

ANTENNA MODULEI0015

B-COVERI0021

RF SHIELDING LIDI0011

TYPE LABELI0013

FM/BT SHIELDING LIDI0012

BB SHIELDING LIDI0010

IHF SPEAKER GASKETI0017

SCREW TORX+ SIZE 4 M1.4 X 3.8I0003

SCREW TORX+SIZE 4 M1.4 x 0.75-4.5

I0020

DUAL SIM VARIANT RM-952 ONLY!

LIGHT SWAP PACKAGE(I0009 - I0013)2

D-COVER ASSEMBLY(I0015 - I0019)3

UI SHIELDING ASSEMBLY(I0005 - I0008)1

Only availableas assembly

Not reuseableafter removal

Repair/swaponly in level 3




Disassembly steps

1) For disassembling you need the Nokia Standard toolkit version 2. You will also need the cameraremoval tool SS-276 and the SIM door key.

2) Protect the A-COVER with protective film.

3) Push the SIM door key to the shown hole in the bottom end of the device to release the B-COVER.

4) Use the SRT-6 to release the bottom end of the B-COVER completely.

5) Lift up the bottom end of the B-COVER and remove it.

6) Lift up the BATTERY from the shown place and remove it.

7) Unscrew the two shown Torx+ size 4 screws in the order shown.

8) Start to relase the A-COVER by opening the shown clip on the bottom end of the device with the SRT-6.

9) Open the five clips on the left side of the device holding the A-COVER with the SRT-6.

10) Release also the five clips on the right side of the device with the SRT-6. The A-COVER can then beseparated.

11) Protect the DISPLAY with protective film.

12) Protect also the other side of the A-COVER window with the protective film.

13) Push in the two shown clips holding the KEYMAT with the SS-93. Then carefully push the KEYMAT tothe direction shown and remove it.

14) Unscrew the four shown Torx+ size 4 screws in the order shown.

15) Open the two shown clips holding the D-COVER with the SRT-6.

16) The D-COVER can now be separated.

17) Use the SS-93 to open the DOME SHEET connector. Be careful not to damage the connector or anycomponents nearby.

18) Use the SS-93 to release the DOME SHEET. It is not reusable, discard it after removal.

19) Open the DISPLAY connector with the SS-93. Be careful not to damage the connector or anycomponents nearby.

20) Use the SS-93 to open the two shown clips holding the UI SHIELDING.

21) Release also the clip on the bottom end. The ENGINE BOARD and the UI SHIELDING can now beseparated.

22) To remove the DISPLAY, first insert the dental tool to the shown place. Carefully open one corner ofthe DISPLAY. Be careful not to injure yourself with the sharp end of the dental tool.

23) Continue to release the DISPLAY by slowly pushing the SS-93 under it. Remove the DISPLAY.

24) Release the EARPIECE with the dental tool and remove it. Do not use it again. Discard it. If theEARPIECE ADHESIVE stays on the UI SHIELDING, remove and discard it also.

25) Place the CAMERA removal tool SS-276 on top of the CAMERA as shown. Push and hold the buttonon the SS-276 to lock it to camera.

26) Lift up the SS-276 and the CAMERA. Remove the CAMERA.

27) Open the SIM2 CONNECTOR with the SS-93. Be careful not to damage the connector or anycomponents nearby. Remove the SIM2 CONNECTOR.Note that this step is for Nokia 515 Dual SIM variant only!

28) Use the dental tool to lift up the IHF SPEAKER. Do not use the IHF SPEAKER again. Discard it.

29) Remove also the IHF SPEAKER GASKET and discard it.

30) Release the shown side of the ANTENNA MODULE with the SRT-6.

31) Then push in the clips on the opposite side with the SS-93. Remove the ANTENNA MODULE.

32) Push the CAMERA LENS out with the SS-93 and remove it.

33) Push the LED FLASH with the sharp end of the SS-93 and remove it.

34) The Nokia 515/Nokia 515 Dual SIM disassembly procedure is complete.

-END OF DISASSEMBLY-




Assembly hints

1) When placing the ANTENNA MODULE, place the shown clip of the ANTENNA MODULE to the D-COVERfirst.

2) Then press the ANTENNA MODULE to attach the three shown clips.

3) Slide the DISPLAY under the two shown hooks on the UI SHIELDING. Then press the DISPLAY carefullyto activate the adhesive.

4) Push the KEYMAT to the A-COVER as shown to get the two shown clips on place.

5) Then attach the six shown clips.

6) Fasten the four Torx+ size 4 screws to the torque of 16Ncm in the order shown.

7) Fasten the two Torx+ size 4 screws to the torque of 13Ncm in the order shown.




Solder components

F2050

S2401 S2400

G2080

X2756 X1400

X6005

X6006 X7454

X2500

X2402X2401

Batterybackup capacitor

Display connector

Grounding spring

USB fuse

SIM2 connector

RM-952 ONLYCamera socket

BT antenna spring

Grounding spring

LED flash spring

Volume + switch

Volume -switch

Antenna spring

TOP

BOTTOM

2013 Nokia | Confidential | All Rights Reserved.



Service devices

CA-101 Service cable AC-20 Travel charger SS-276 Camera removal tool

Nokia Standard Toolkit (v2)

For more information, refer to the Service Bulletin (SB-011) on Nokia Online. Supplier or

manufacturer contacts for tool re-order can be found in Recommended service equipment

document on Nokia Online.




Product controls and interfaces

2

4

7

10

5

3

1

15

16

18

13

11

86

9

12

17

14

9 End/Power key

8 Call key

7 Right selection key

6 Left selection key

5 Scroll key

4 Display

2 3.5 mm headset connector

3 Earpiece

1 Micro-USB connector

10 Keypad

11 Microphone

12 Back cover opening hole

13 Camera flash

14 Camera

15 Volume + key

16 Volume - key

17 Loudspeaker

18 Antenna area




Service concept

Flashing concept

BAT

Transceiver

Care Dummy Battery with power supply via Nokia charger or product specific battery

CA-101Service

software




Version history

Version Date Description

1.0 29.08.2012 First published version


nokia 515 service manual

Documents