o&m - manual index for acbil project

of 10

MAIN INDEX

Sl No Sections Description Page No

1 I General Write up of the Power plant

2 II Boiler 4773

3 III Electrostatic Precipitator (ESP) 306

4 IV Steam Turbine Generator 861

5 V Critical Piping 190

6 VI Balance of Plant - Mechanical

7 VII Balance of Plant - Electrical

8 VIII Control & Instrumentation

of 10

Section-1 - Index

General Write up of the Power plant

Volume – 1

Chapter Clause Description Page No

1 1.00.00 Project Information ----

2 2.00.00 Plant operational general write-up 43

3 3.00.00 Over all plant SLD 2

4 4.00.00 Plant P&ID 117

5 5.00.00 Key Plan ----

6 6.00.00 Water Balance Diagram 2

7 7.00.00 Vendor Information 18

8 8.00.00 CCOE approved Document 4

of 10

Section-II - Index

Boiler


1 1.00.00 Introduction of General Write Up 166

1 1.00.00 Boiler Pressure Part 566

2 2.00.00 Piping 87

3 3.00.00 Boiler Non Pressure Parts 541

4 4.00.00 Fuel Feeding & Firing System 513

5 5.00.00 Fan 405

Volume – 3 Controls & Instrumentations

1 1.00.00 Control & Instrumentation Documents 566

2 2.00.00 Control & Instrumentation System Documents 967

3 3.00.00 925

Volume – 4 Drawings

1 1.00.00 Drawings 31

Notes : Index for Volume – 2 Mechanical Documents 2

Index for Volume – 3 Controls & Instrumentations 2

Index for Boiler 2

Volume – 1 General Description of CFBC Boiler

Volume – 2 Mechanical Documents

Control &Instrumentation Data Sheets & Vendor Instruction Manuals Field Instrumentation

of 10

Section-III - Index

Electrostatic Precipitator (ESP)

Volume – 1


1

1.00.00 Technical Specification

306

1.01.00 Working Principle

1.02.00 Component Description

1.03.00 Safety Precautions

1.04.00 Commissioning

1.05.00 Maintenance

1.06.00 Trouble Shooting

1.07.00 Sub vendor manuals & Data sheet

of 10

Section-IV - Index

Steam Turbine Generator


1 1.00.00 General description and main technical specification

1232 2.00.00 Steam Turbine Manual of Installation

3 3.00.00 Startup / Operation instruction of Steam Turbine

Volume – 2 Instruction of Turbine Auxiliary Equipments

1 1.00.00 Instruction of Condenser

191

2 2.00.00 Instruction of LP heaters

3 3.00.00 Instruction of HP heaters

4 4.00.00 Instruction of Gland steam Condenser

5 5.00.00 Instruction of Pneumatic check valve & control device

6 6.00.00 Instruction of Drain Flash Tank

7 7.00.00 Instruction of Layout of High & Low heater drainage valve

8 8.00.00 Instruction of water level alarm

9 9.00.00 Instruction of Air Tank

10 10.00.00 Lube Oil system Instruction

11 11.00.00

12 12.00.00 Instruction of Shaft jacking device

13 13.00.00 Instruction of Oil Vapor Extractor

14 14.00.00 Instruction of Turning gear

15 15.00.00 Instruction of Rubber ball cleaning device

16 16.00.00 Data Sheet for Turbine Generator

Volume – 3 Turbine Electrical

1 1.00.00 Generator162

2 2.00.00 AVR and Excitation System

Volume – 4 Control and instrumentation

1 1.00.00 C&I Documents

1992 2.00.00 C&I TG-DCS Documents

3 3.00.00 C&I System Panels

Volume – 5 General Arrangement Drawings

1 1.00.00 GA Drawings 184

Notes : Index for Steam Turbine Generator 2

Volume – 1 Technical Specification, Installation, Operation and Maintenance of Steam Turbine

Installation,Operation and maintenance manual of Turbine oil conditioning Purifier

of 10

Section-V - Index

Critical Piping

Volume – 1


1 1.00.00 Control Valves

1902 2.00.00 Safety Relief Valve

3 3.00.00 Safety Valve

4 4.00.00 Spring Hanger

of 10

Section-VI - Index

Balance of Plant - Mechanical


Volume – 1 Water System

1 1.00.00 Operation & Maintenance Manual

Volume – 2 Ash Handling System

1 1.00.00 Dense Phase Ash Handling System 970

2 2.00.00 Redler Chain Conveyor 73

3 3.00.00 Chain and Bucket Elevator 66

4 4.00.00 RIECO Vendor Drawings 6

5 5.00.00 RUD India Chain Conveyor 61

6 6.00.00 O&M Manual for Actuators 14

Notes : Index for Volume – 2 Ash Handling System 3

Volume – 3 Fire Fighting System


3162 2.00.00 Data Sheet for Fire Fighting System

3 3.00.00 G.A Drawing for Fire Fighting System

Volume – 4 Elevator


522 2.00.00 Data Sheet for Elevator

3 3.00.00 G.A Drawing for Elevator

Volume – 5 Air Compressor


2 2.00.00 Data Sheet for Air Compressor

3 3.00.00 G.A Drawing for Air Compressor

Volume – 6 LDO Unloading System


2 2.00.00 G.A Drawing for LDO Unloading System

Volume – 7 LP Piping System

1 1.00.00 Cooling Tower Makeup Water System 325

2 2.00.00 Service Water System 235

3 3.00.00 DM Water Transfer System ----

4 4.00.00 Potable Water System ----

5 5.00.00 CT BlowDown System 137

6 6.00.00 Boiler BlowDown System 171

7 7.00.00 Portable Drain Pump 34

Volume – 8 HVAC

of 10



2 2.00.00 Data Sheet for HVAC

3 3.00.00 G.A Drawing for HVAC

Volume – 9 Self Cleaning Strainer


322 2.00.00 Data Sheet for Self Cleaning Strainer

3 3.00.00 G.A Drawing for Self Cleaning Strainer

Volume – 10 Portable Compressor


1012 2.00.00 Data Sheet for Portable Compressor

3 3.00.00 G.A Drawing for Portable Compressor

Volume – 11 EOT Crane


652 2.00.00 Data Sheet for EOT Crane

3 3.00.00 G.A Drawing for EOT Crane

Volume – 12 HOT Crane


362 2.00.00 Data Sheet for HOT Crane

3 3.00.00 G.A Drawing for HOT Crane

Volume – 13 Electric Hoist


432 2.00.00 Data Sheet for Electric Hoist

3 3.00.00 G.A Drawing for Electric Hoist

Volume – 14 Plate Heat Exchanger


842 2.00.00 Data Sheet for Plate Heat Exchanger

3 3.00.00 G.A Drawing for Plate Heat Exchanger

Volume – 15 Rubber Expansion Joint

1 1.00.00 Operation & Maintenance Manual 18

2 2.00.00 Data Sheet & G.A Drawing for Rubber Expansion Joint

Volume – 16 Cooling Water System

1 1.00.00 Cooling Tower 268

2 2.00.00 Main Cooling Water System and Auxiliary Cooling Water System 114

3 3.00.00 Demineralised Closed Circuit Cooling Water System 49

4 4.00.00 Gas Chlorination System 101

5 5.00.00 Chemical Conditioning System ----

of 10

Section-VII - Index

Balance of Plant - Electrical

Volume – 1


1 1.00.00 400KV Switchyard

2 2.00.00 Transformer & Accessories

3 3.00.00 Busduct

4 4.00.00 HT Panel

5 5.00.00 LT Panel

6 6.00.00 Motors

7 7.00.00 DC System

8 8.00.00 UPS

9 9.00.00 Diesel Generator

10 10.00.00 Illumination System

11 11.00.00 Electrical Control Panel

12 12.00.00 Layout Drawings

13 13.00.00 DC Starter Panels

of 10

Section-VIII - Index

Balance of Plant - C&I


Volume – 1 Water Treatment Plant (WTP)

1 1.00.00 Instrument list

2 2.00.00 PLC system

3 3.00.00 Vendor Documents by BOP_mechanical

Volume – 2 Cooling Water System

1 1.00.00 Cooling water system (MCW/ACW/CT/DMCCW) 151

Volume – 3 Ash Handling System

1 1.00.00 Ash Handling Plant – AHP

2 2.00.00 Bed ash handling system


4 4.00.00 Vendor Documents

Volume – 4 Fire Fighting System

1 1.00.00 Fire fighting & alarm system


Volume – 5 HVAC

1 1.00.00 HVAC system


3 3.00.00 P&V system

Volume – 6 Air Compressor

1 1.00.00 Air Compression system (plant air)


Volume – 7 Gas Chlorination System

1 1.00.00 Gas Chlorination system

Volume – 8 Sewage Treatment System

1 1.00.00 Sewage Treatment System

Volume – 9 Drawing Files

1 1.00.00 Fire Alarm System Building / Floor Wise Drawings 13