- 1 - JC-215H-51

Published by Service Dept.

Printed in Japan

Clarion Co., Ltd.Export Division - 22-3, Shibuya 2-chome, Shibuyaku, Tokyo, 150-8335 Japan Tel: 03-3400-1121

Service Dept.- 50 kamitoda,Toda-shi,Saitama,335-8511 Japan Tel: 048-443-1111 FAX:048-433-6996

298-5712-00 Jan.1999 P

Service Manual

Model

HONDA Motorcycle GenuineCB Radio

JC-215H-51

SPECIFICATIONSGeneralPower supply voltage:13.8V DC

Ground: Negative

Consumption current: 2.0A or below

(at transmission)

Back-up consumption current:

1.0mA or below

Frequency range: 26.965MHz to 27.405MHz(40ch)

Frequency tolerance: 0.005? or less

Radio wave type: A3E

Antenna impedace: 50?

Dimensions(mm): 105(W)? 35(H)? 150(D)

Weight: 620g

Transmitter sectionPower output: 4.0W

Transmission S/N: 40dB or higher

Modulation sensitivity:? 40dBV? 3dB

Receiver sectionPractical sensitivity: 6dB? V or below(S/N 10dB)

S/N: 35dB or higher

Distortion factor: 8? or below

Squelch sensitivity: Thershold;8dB? V or below

Tight;25dB? V or higher

Audio output level: 0.5V or higher

NOTEWe cannot supply PWB with component parts in prin-

ciple. When a circuit on PWB has failure, please re-

pair it by component parts base. Parts which are not

mentioned in service manual are not supplied.

Specification and design are subject to change with-

out notice for further improvement.

COMPONENTJC-215H-51Main unit

1

(Genuine No. 08E95-MBY-10001)

ch

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

MHz

26.965

26.975

26.985

27.005

27.015

27.025

27.035

27.055

27.065

27.075

27.085

27.105

27.115

27.125

27.135

27.155

27.165

27.175

27.185

27.205

ch

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

MHz

27.215

27.225

27.255

27.235

27.245

27.265

27.275

27.285

27.295

27.305

27.315

27.325

27.335

27.345

27.355

27.365

27.375

27.385

27.395

27.405

www.electronicsrepair.net

- 2 -JC-215H-51

■WIRE CONNECTIONS

■ To engineers in charge of repairor inspection of our products.

Before repair or inspection, make sure to fol-low the instructions so that customers and En-gineers in charge of repair or inspection canavoid suffering any risk or injury.1. Use specified parts.

The system uses parts with special safety featuresagainst fire and voltage. Use only parts with equiva-lent characteristics when replacing them.The use of unspecified parts shall be regarded as re-modeling for which we shall not be liable. The onus ofproduct liability (PL) shall not be our responsibility incases where an accident or failure is as a result ofunspecified parts being used.

2. Place the parts and wiring back in their original posi-tions after replacement or re-wiring.For proper circuit construction, use of insulation tubes,bonding,gaps to PWB, etc, is involved. The wiring con-nection and routing to the PWB are specially plannedusing clamps to keep away from heated and high volt-age parts. Ensure that they are placed back in theiroriginal positions after repair or inspection.If extended damage is caused due to negligence dur-ing repair, the legal responsibility shall be with the re-pairing company.

3. Check for safety after repair.Check that the screws, parts and wires are put backsecurely in their original position after repair. Ensure

for safety reasons there is no possibility of secondaryploblems around the repaired spots.If extended damage is caused due to negligence ofrepair, the legal responsibility shall be with the repair-ing company.

4. Caution in removal and making wiring connection tothe parts for the automobile.Disconnect the battery terminal after turning the igni-tion key off. If wrong wiring connections are made withthe battery connected, a short circuit and/or fire mayoccur. If extensive damage is caused due to negli-gence of repair, the legal responsibility shall be withthe repairing company.

5. Cautions regarding chips.Do not reuse removed chips even when no abnormal-ity is observed in their appearance. Always replacethem with new ones. (The chip parts include resis-tors, capacitors, diodes, transistors, etc). The nega-tive pole of tantalum capacitors is highly susceptibleto heat, so use special care when replacing them andcheck the operation afterwards.

6. Cautions in handling flexible PWBBefore working with a soldering iron, make sure thatthe iron tip temperature is around 270℃. Take carenot to apply the iron tip repeatedly(more than threetimes)to the same patterns. Also take care not to ap-ply the tip with force.

7. Turn the unit OFF during disassembly and parts re-placement. Recheck all work before you apply powerto the unit.

M . C . UE H - 1 1 2 8 V - A

C BJ C - 2 1 5 H - 5 1

P O R T A B L EP L A Y E R

C D A U T O C H A N G E R

R A D I O A N T E N N A R E C E P T A C L E( J A S O ) S T E R E O M I N I

J A C K ( )

1 3 P D I N C O N N E C T O R( F E M A L E )

1 3 P D I N C O N N E C T O R( M A L E )

1 8 P O U T L E T S O C K E T

2 0 P O U T L E T S O C K E T

C B A N T E N N A R E C E P T A C L E( J A S O )

3 P O U T L E T S O C K E T

1 3 P D I N C O N N E C T O R( F E M A L E )

B O D Y H A R N E S S

C B A N T E N N A

A M / F M R A D I O A N T E N N A

- 3 - JC-215H-51

■EXPLANATION OF IC

■MB89133APFM-G449 052-9203-01 CB Transceiver Control

1. Outward Form : 48 pins QFP

2. Terminal Description

pin 1 : AVCC : － : Positive supply voltage for A/D converter.pin 2 : RST : IN : Reset signal input.pin 3 : MOD0 : － : Not in use.pin 4 : MOD1 : － : Not in use.pin 5 : X0 : － : Clockpin 6 : X1 : － : 4.194MHzpin 7 : VCC : － : Positive supply voltage.pin 8 : X0A : － : Not in use.pin 9 : X1A : － : Not in use.pin 10 : N.C. : － : Not in use.pin 11 : N.C. : － : Not in use.pin 12 : N.C. : － : Not in use.pin 13 : N.C. : － : Not in use.pin 14 : N.C. : － : Not in use.pin 15 : POP SW : O : Pop noise killer control signal output.pin 16 : RX SW : O : RX audio switch control signal output.pin 17 : POWER 8V : O : 8V power supply control signal output.pin 18 : TEST OUT : O : Not in use.pin 19 : GND : － : Ground.pin 20 : TEST IN : IN : Not in use.pin 21 : VCO SHIFT : O : VCO sift signal output. "H"= TX , "L"= RXpin 22 : TX ON : O : TX ON signal output.pin 23 : RX ON : O : RX ON signal output.pin 24 : PLL LE : O : PLL load enable signal output.pin 25 : PLL DATA : O : PLL data output.

■ADJUSTMENTSAdjusting VCO1. Set CB channel to CH20(27.205MHz).2. Connect a DC voltmeter to TP101(V.CONT).3. Adjust L113 so that the voltmeter reading becomes

2.0±0.05V while trasmitting(TX), and adjust L114 sothat the volmeter reading becomes 2.0±0.05V whilereceiving a signal(RX).

Adjusting TX power1. Set CB channel to CH20(27.205MHz), and connect

a power meter to ANT.2. Turn the core of L106 so that it moves top.3. Adjust VR101 so that the power becomes maximun.4. Adjust IFT105,L111 and L109 in this order so that

the power becomes maximun.5. Adjust L104 so that the power becomes maximum.6. Adjust VR101 so that the powermeter reading be-

comes 3.7±0.05W.7. Make sure that the power is 3.2 to 4.0W when CB

channel is set CH1 and CH40.

Adjusting modulation1. Set CB channel to CH20(27.205MHz).2. Connect low frequency oscillator to the MIC-IN ter-

minal of the DIN connector, and set the oscillator'soutput to 1kHz,100mV.

3. Adjust VR102 so that the depth of modulation at thistime becomes 70％.

4. Set the cscillator's output to 1kHz,10mV.5. Adjust VR103 so that the depth of modulation at this

time becomes 50％.

Adjusting receive sensitivity1. Set CB channel to 20CH(27.205MH), set SQ level to

1, and set VOL level to 10.2. Connect SSG to ANT(set SSG output to 70dBμ), and

connect an AC voltmeter(synchroscope) to the audiooutput. Adjust IFT4,IFT103,IFT106,IFT101 and L102in this order so that the audio output becomes maxi-mum.

3. Make sure that S/N is more than 10dB when CB chan-nel is set CH20 and SSG output is set 5dBμ.

Adjusting squelch1. Set CB channel to CH20(27.205MHz), and set SSG

output to 10dBμ.2. Connect a DC voltmeter to TP102(SQ).3. Adjust VR104 so that the voltmeter reading becomes

1.6±0.05V.4. Threshold sensitivity

Set CB channel to CH20(27.205MHz), set VOL levelto 10, and set SSG output to 4dBμMake sure that the waveform disappeares when SQlevel is set 1 to 2.

5. Tight sensitivitySet CB channel to CH20(27.205MHz), set SQ levelto 20, set VOL level to 10, and set SSG output to 0dBμ. Increase SSG output, and make sure that thewaveform appeares when SSG output is et 25dBμ.

pin 26 : PLL CLK : O : PLL clock output.pin 27 : PLL LOCK : IN : PLL lock signal input.pin 28 : PTT : IN : PTT signal input.pin 29 : N.C. : － : Not in use.pin 30 : N.C. : － : Not in use.pin 31 : N.C. : － : Not in use.pin 32 : N.C. : － : Not in use.pin 33 : CB KEY_ : IN : CB Key request signal input. Negative logic.pin 34 : AUDIO MUTE : O : Audio mute signal output.pin 35 : BEEP : O : Beep sound output.pin 36 : START KEY_ : IN : Start key signal input. Negative logic.pin 37 : CB RESET : IN : CB reset signal input.pin 38 : IGNIT SW_ : IN : Ignition switch signal input. Negative logic.pin 39 : C2B CE : O : Chip enable signal output of Serial data

communication line.pin 40 : C2B SI : IN : Serial data input.pin 41 : C2B SO : O : Serial data output.pin 42 : C2B CLK : O : Clock out of Serial data communication line.pin 43 : AVSS : － : Ground for A/D converter.pin 44 : AVREF : － : Reference voltage for A/D converter.pin 45 : POWER 5V : O : 5V power supply control signal output.pin 46 : N.C. : － : Not in use.pin 47 : N.C. : － : Not in use.pin 48 : SQ LEVEL : IN : Input terminal of SQ level detector.

- 4 -JC-215H-51

■BLOCK DIAGRAM

RF CIRCUIT

CB ANT

RF POWER

AMP

Q106

2SC1945

DRIVER

AMP

Q108

2SC2166

RF AMP

Q110

2SC2088

RF AMP

Q113,114

2SC2712

MOD AMP

Q111

2S

A817

Q102

2SC19

59Q103 2SA18

69

ALC

IC10

1TA2011S

PLL

IC10

3PLL2001S

LPF

VCO

Q121,124

2SC2404

D108

HVU17

SHIFT SW

Q126

2SC2714

LPF

Q125,127

2SC2712

TX:26.965

27.405MHz

RX:16.275

16.715MHz

10.24MHz

RF AMP

Q104

2SK302

IF AMP

Q111,112

2SC2404

MIXER

MIXER

Q107

2SC2408

Q109

2SC2408

10.69MHz

450kH

z

DET

D106

1SS119

NOISE

BLANKER

D107

1SS198

AF AMP

Q120

2SC2714

AM NOISE

CANCELL

ER

IC10

2TA20

51F

N

AF AMP

IC11

1NJM

4558M

LPF

SQ DET

Q117

2SC2712

SQ SW

Q101

DTC123

JKIC10

1TC4W

66F

AF AMP

IC10

2NJM

4558M

E VOL

IC10

4LC75391M

AF AMP

& LPF

IC10

5NJM

4558M

CPU

IC10

8MB89133APFM

-G49

9

HPF &

AF AMP

IC10

3NJM

4558M

AF AMP

IC10

6NJM

4558M

AUDIO

OUT

MIC IN TO

MCU

AUDIO

CIRCUIT

4.19MHz

- 5 - JC-215H-51

■EXPLODED VIEW・PARTS LIST

1 313-1671-00 CASE 1

2 347-5347-00 GASKET 1

3 331-1965-00 BOTTOM PLATE 1

4 039-1344-00 AUDIO PWB 1(WITHOUT COMPONENT)

5 313-1672-00 HEATSINK A 1

6 039-1345-00 RF PWB 1(WITHOUT COMPONENT)

7 313-1673-00 HEATSINK B 1

8 855-3432-01 EXTENSION LEAD 1

8-1 714-3010-87 MACHINE SCREW(M3×10) 2

9 716-1779-00 SCREW(M3×8) 9

10 732-3006-11 SEMS SCREW(M3×6) 6

11 714-3006-11 MACHINE SCREW(M3×6) 7

12 286-9159-00 SETPLATE 1

13 331-2064-00 SHIELD CASE A 1

14 331-2065-00 SHIELD CASE B 1

15 335-0833-01 LEAD HOLDER 1

11 2

2

39

4

1 0

1 0

1 0

1 1

1 1

1 17

5

6

1 1

1 0

1 0

1 0

1 5

8 - 18

9

9

1 3

1 4

C o i l

6

NO. PART NO. DESCRIPTION Q'TYNO. PART NO. DESCRIPTION Q'TY

Side view of RF PWB

- 6 -JC-215H-51

■ELECTRICAL PARTS LISTRF PWB section(B1)

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION

C101 176-7097-00 7pF CHC102 043-0298-00 120pFC103 042-0397-06 35V0.1μFC104 043-0298-03 330pFC105 176-3901-00 39pF CHC107 173-6821-11 6800pF JC108 178-1022-78 1000pFC109 043-0298-02 270pFC110 184-2273-21 10V220μFC111 178-4732-78 0.047μFC112 178-4732-78 0.047μFC113 043-0299-00 470pFC114 178-4732-78 0.047μFC115 043-0298-02 270pFC116 043-0298-01 150pFC117 178-4732-78 0.047μFC119 178-1022-78 1000pFC120 178-4732-78 0.047μFC121 176-5601-00 56pF CHC122 178-1022-78 1000pFC123 178-2232-78 0.022μFC124 178-1242-78 0.12μFC125 178-4712-78 470pFC126 043-0299-00 470pFC127 178-1042-78 0.1μFC128 178-5632-78 0.056μFC129 178-1022-78 1000pFC130 178-1032-78 0.01μFC131 178-8232-78 0.082μFC132 042-0472-00 10V47μFC133 178-1022-78 1000pFC134 042-0398-03 16V3.3μF TANC135 042-0403-01 16V10μF TANC136 176-2201-00 22pF CHC137 178-4732-78 0.047μFC138 178-1032-78 0.01μFC139 178-2732-78 0.027μFC140 042-0397-00 16V1μF TANC141 178-4712-78 470pFC142 178-4712-78 470pFC143 176-5601-00 56pF CHC144 176-4701-00 47pF CHC145 176-5096-00 5pF CHC146 178-6832-78 0.068μFC147 178-1022-78 1000pFC148 178-1032-78 0.01μFC150 178-1032-78 0.01μFC151 178-1032-78 0.01μFC152 178-4732-78 0.047μFC153 184-4763-41 25V47μFC154 178-1022-78 1000pFC155 178-1032-78 0.01μFC156 178-4732-78 0.047μFC157 042-0416-00 16V4.7μFC158 178-2232-78 0.022μFC159 042-0416-00 16V4.7μFC160 176-1811-00 180pF CHC161 178-3332-78 0.033μFC162 178-2232-78 0.022μFC163 178-5632-78 0.056μFC164 176-2201-00 22pF CHC165 178-4732-78 0.047μFC166 178-3332-78 0.033μFC167 042-0406-03 16V22μFC168 178-1032-78 0.01μFC169 178-2232-78 0.022μFC170 176-1511-00 150pF CHC172 178-4732-78 0.047μFC175 178-3332-78 0.033μFC177 178-1032-78 0.01μFC178 178-6832-78 0.068μF

C179 178-2212-78 220pFC181 178-4732-78 0.047μFC182 178-3332-78 0.033μFC183 042-0397-00 16V1μF TANC184 178-1032-78 0.01μFC185 176-1511-00 150pF CHC186 176-5601-00 56pF CHC187 178-1032-78 0.01μFC188 042-0397-00 16V1μF TANC189 178-1055-79 1μFC190 042-0403-01 16V10μF TANC191 178-1022-78 1000pFC192 178-8222-78 8200pFC193 178-1032-78 0.01μFC194 176-1011-00 100pF CHC195 176-1501-00 15pF CHC196 176-6801-00 68pF CHC197 176-3301-00 33pF CHC198 176-1011-00 100pF CHC199 176-2201-00 22pF CHC200 178-3312-78 330pFC201 178-1032-78 0.01μFC202 176-3901-00 39pF CHC203 176-3301-00 33pF CHC204 042-0423-01 16V2.2μFC205 178-3332-78 0.033μFC207 178-1032-78 0.01μFC208 178-1032-78 0.01μFC209 178-1042-78 0.1μFC210 178-1042-78 0.1μFC265 178-1032-78 0.01μFC266 178-1022-78 1000pFC268 163-4763-30 16V47μFC269 163-4763-30 16V47μFC276 178-1032-78 0.01μFC277 178-1032-78 0.01μFC279 184-1073-41 25V100μFC286 184-1083-41 25V1000μFC300 178-1055-79 1μFC301 178-1032-78 0.01μFC302 178-1022-78 1000pFC303 178-1022-78 1000pFC304 178-1032-78 0.01μFC305 042-0397-06 35V0.1μFC306 178-1022-78 1000pFC307 178-1055-79 1μFC308 178-6832-78 0.068μFC309 042-0403-01 16V10μF TANC310 178-1032-78 0.01μFC311 042-0423-04 10V 4.7μFC312 178-1032-78 0.01μFC313 178-1022-78 1000pFC314 042-0403-01 16V10μF TANC315 178-1032-78 0.01μFC316 178-1032-78 0.01μFC340 178-1022-78 1000pFC341 176-1096-00 1pF CKC400 178-3312-78 330pFC401 178-1055-79 1μFC600 042-0423-04 10V 4.7μFC601 184-1073-41 25V100μFC602 178-1022-78 1000pFC603 176-3301-00 33pF CHC610 176-3301-00 33pF CHC611 176-1201-00 12pF CHC612 178-4732-78 0.047μFC613 042-0472-00 10V47μFC614 176-5096-00 5pF CHC617 178-2232-78 0.022μFC618 178-3912-78 390pFC619 042-0397-02 35V0.33μF

C620 163-4753-50 35V4.7μFC642 178-1032-78 0.01μFC643 178-6832-78 0.068μFC645 184-1073-41 25V100μFC665 178-3932-78 0.039μFD101 001-0330-00 1SS119D102 001-0330-00 1SS119D103 001-0330-00 1SS119D104 001-0516-00 MA111D105 001-0516-00 MA111D106 001-0330-00 1SS119D107 001-0361-10 1SS198D108 001-3204-90 HVU17-TRD117 001-0360-00 S5566BD118 001-0601-00 DE3L2OUD120 001-0330-00 1SS119D121 001-0330-00 1SS119D122 001-0330-00 1SS119D123 001-0574-43 DTZ8.2AD130 001-0330-00 1SS119D131 001-0360-00 S5566BD132 001-0601-00 DE3L2OUD133 001-0330-00 1SS119D134 001-0330-00 1SS119FIL101 060-0264-10 0.01μF EMIIC101 051-5808-00 TA2011SIC102 051-4200-90 TA2051FNIC103 051-6207-08 PLL2001S-ETIC109 051-0352-01 TA78L05FIC110 051-0718-10 NJM7808FAIC111 051-0350-55 NJM4558MIC112 051-1461-00 NJU7201U50IFT101 005-0922-00 27MHzIFT102 005-0967-00 10.7MHzIFT103 005-0750-00 IFTIFT104 005-2503-00 SFPS450H6 450kHzIFT105 005-0922-00 27MHzIFT106 005-0922-00 27MHzIFT4 005-0753-00 IFTL101 010-2046-00 0.22μHL102 010-2039-00 27MHzL103 010-2159-00 COILL104 010-2159-00 COILL105 010-2159-00 COILL106 010-1792-00 COILL107 010-2160-00 9μHL108 010-2052-00 2.2mHL109 010-2158-00 0.32mHL110 010-2046-24 22μHL111 010-4209-00 0.32μHL113 010-4207-00 1μHL114 010-4208-00 1.2μHL115 010-2199-74 10μH JL125 010-2046-31 82μHL130 010-2199-59 0.56μH JL133 010-2285-05 BLM21A102SL134 010-2285-05 BLM21A102SL135 010-2285-05 BLM21A102SL136 060-0198-00 2BF113T-01P100 076-0232-02 2PP101 076-0232-03 3PP105 076-0533-08 8PP106 076-0533-08 8PQ101 100-0817-00 2SA8170Q102 102-1959-00 2SC1959Q103 100-1869-25 2SA1869YQ104 108-0302-50 2SK302Y.GRQ105 102-2712-00 2SC2712Q106 102-1945-00 2SC1945Q107 192-2480-00 2SC2480-T,S-TXQ108 102-2166-00 2SC2166

- 7 - JC-215H-51

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION

Q109 192-2480-00 2SC2480-T,S-TXQ110 102-2086-00 2SC2086Q111 102-2404-00 2SC2404B,C,DQ112 102-2404-00 2SC2404B,C,DQ113 102-2714-25 2SC2714YQ114 102-2712-00 2SC2712Q115 100-1313-00 2SA1313O,YQ116 102-2714-25 2SC2714YQ117 102-2712-00 2SC2712Q118 100-1313-00 2SA1313O,YQ119 125-2020-05 DTC123JKQ120 102-2712-00 2SC2712Q121 102-2404-00 2SC2404B,C,DQ122 100-1313-00 2SA1313O,YQ123 125-2020-05 DTC123JKQ124 102-2404-00 2SC2404B,C,DQ125 102-2712-00 2SC2712Q126 102-2714-25 2SC2714YQ127 102-2712-00 2SC2712Q140 100-1869-25 2SA1869YQ141 125-2020-05 DTC123JKQ142 100-1313-00 2SA1313O,YQ143 125-2020-05 DTC123JKQ144 102-2712-00 2SC2712Q600 102-2712-00 2SC2712R101 117-1021-10 1/10W 1kΩR102 117-5601-10 1/10W 56ΩR103 117-2711-10 1/10W 270ΩR104 117-4791-10 1/10W 4.7ΩR105 117-1231-10 1/10W 12kΩR106 117-1011-10 1/10W 100ΩR107 117-3921-10 1/10W 3.9kΩR108 117-2221-10 1/10W 2.2kΩR112 117-3301-10 1/10W 33ΩR113 117-3921-10 1/10W 3.9kΩR115 117-1031-10 1/10W 10kΩR116 117-1001-10 1/10W 10ΩR117 117-3311-10 1/10W 330ΩR119 117-1011-10 1/10W 100ΩR120 117-3311-10 1/10W 330ΩR121 117-1031-10 1/10W 10kΩR122 117-1031-10 1/10W 10kΩR123 117-1211-10 1/10W 120ΩR124 117-1231-10 1/10W 12kΩR125 117-1531-10 1/10W 15kΩR126 117-2221-10 1/10W 2.2kΩR127 117-6821-10 1/10W 6.8kΩR129 117-2741-10 1/10W 270kΩR130 117-5621-10 1/10W 5.6kΩR131 117-4711-10 1/10W 470ΩR133 117-6831-10 1/10W 68kΩR134 117-2711-10 1/10W 270ΩR135 117-1821-10 1/10W 1.8kΩ

R136 117-3311-10 1/10W 330ΩR137 117-1011-10 1/10W 100ΩR138 117-3311-10 1/10W 330ΩR139 117-3331-10 1/10W 33kΩR140 117-2221-10 1/10W 2.2kΩR141 117-2221-10 1/10W 2.2kΩR142 117-5601-10 1/10W 56ΩR143 117-2221-10 1/10W 2.2kΩR144 117-4721-10 1/10W 4.7kΩR145 117-1021-10 1/10W 1kΩR146 117-2221-10 1/10W 2.2kΩR147 117-8221-10 1/10W 8.2kΩR148 117-1231-10 1/10W 12kΩR149 117-1231-10 1/10W 12kΩR150 117-6811-10 1/10W 680ΩR151 117-3311-10 1/10W 330ΩR152 117-1011-10 1/10W 100ΩR153 117-3931-10 1/10W 39kΩR154 117-3321-10 1/10W 3.3kΩR155 117-4721-10 1/10W 4.7kΩR156 117-5621-10 1/10W 5.6kΩR158 117-3921-10 1/10W 3.9kΩR159 117-4721-10 1/10W 4.7kΩR160 117-6831-10 1/10W 68kΩR161 117-1831-10 1/10W 18kΩR163 117-4741-10 1/10W 470kΩR164 117-8231-10 1/10W 82kΩR167 117-1011-10 1/10W 100ΩR168 117-1011-10 1/10W 100ΩR170 117-5631-10 1/10W 56kΩR172 117-8221-10 1/10W 8.2kΩR175 117-6821-10 1/10W 6.8kΩR176 117-5631-10 1/10W 56kΩR177 117-4721-10 1/10W 4.7kΩR178 117-4701-10 1/10W 47ΩR179 117-1831-10 1/10W 18kΩR180 117-2231-10 1/10W 22kΩR181 117-2231-10 1/10W 22kΩR182 117-2211-10 1/10W 220ΩR183 117-2721-10 1/10W 2.7kΩR184 117-3321-10 1/10W 3.3kΩR185 117-1021-10 1/10W 1kΩR186 117-4701-10 1/10W 47ΩR187 117-1211-10 1/10W 120ΩR188 117-3311-10 1/10W 330ΩR189 117-4721-10 1/10W 4.7kΩR190 117-1831-10 1/10W 18kΩR191 117-3931-10 1/10W 39kΩR194 117-1211-10 1/10W 120ΩR195 117-3311-10 1/10W 330ΩR196 117-4731-10 1/10W 47kΩR197 117-2731-10 1/10W 27kΩR198 117-5621-10 1/10W 5.6kΩ

R199 117-2721-10 1/10W 2.7kΩR202 117-1021-10 1/10W 1kΩR203 117-1021-10 1/10W 1kΩR204 117-1021-10 1/10W 1kΩR205 117-5631-10 1/10W 56kΩR206 117-1021-10 1/10W 1kΩR207 117-8221-10 1/10W 8.2kΩR208 117-2221-10 1/10W 2.2kΩR210 117-5621-10 1/10W 5.6kΩR211 117-5621-10 1/10W 5.6kΩR290 117-1031-10 1/10W 10kΩR300 117-4711-10 1/10W 470ΩR301 117-1041-10 1/10W 100kΩR303 117-1031-10 1/10W 10kΩR304 117-4721-10 1/10W 4.7kΩR305 117-1011-10 1/10W 100ΩR307 117-5621-10 1/10W 5.6kΩR308 117-1831-10 1/10W 18kΩR309 117-6831-10 1/10W 68kΩR310 117-4711-10 1/10W 470ΩR311 117-2231-10 1/10W 22kΩR312 117-1031-10 1/10W 10kΩR313 117-1841-10 1/10W 180kΩR314 117-2241-10 1/10W 220kΩR315 117-3331-10 1/10W 33kΩR316 117-1531-10 1/10W 15kΩR317 117-1041-10 1/10W 100kΩR318 117-1041-10 1/10W 100kΩR319 117-4731-10 1/10W 47kΩR320 117-1841-10 1/10W 180kΩR321 117-4731-10 1/10W 47kΩR322 117-1831-10 1/10W 18kΩR323 117-4721-10 1/10W 4.7kΩR324 117-8221-10 1/10W 8.2kΩR330 111-1211-91 1/4WS 120ΩR353 117-1011-10 1/10W 100ΩR354 117-4721-10 1/10W 4.7kΩR600 117-5601-10 1/10W 56ΩR601 117-1031-10 1/10W 10kΩR602 117-5631-10 1/10W 56kΩR614 117-5631-10 1/10W 56kΩR615 117-4731-10 1/10W 47kΩR620 111-2221-91 1/4WS 2.2kΩR621 111-2221-91 1/4WS 2.2kΩR801 117-1231-10 1/10W 12kΩT300 009-0603-00 CHOKETH101 002-0186-10 DTN-D501KTH102 002-0216-08 DTN-T203T333KSVR101 012-4864-11 220kΩVR102 012-4864-05 4.7kΩVR103 012-4864-05 4.7kΩVR104 012-4864-11 220kΩX101 061-1070-00 10.24MHz

Audio PWB section(B2)

C101 178-1055-79 1μFC102 178-1055-79 1μFC103 178-1032-78 0.01μFC104 042-0403-01 16V10μF TANC105 042-0416-02 10V10μFC106 178-1032-78 0.01μFC107 178-1032-78 0.01μFC108 042-0403-01 16V10μF TANC109 178-1022-78 1000pFC110 042-0416-02 10V10μFC111 178-1032-78 0.01μFC112 178-3322-78 3300pFC113 178-1055-79 1μFC114 042-0403-01 16V10μF TANC115 178-1032-78 0.01μFC116 163-4763-30 16V47μFC117 178-1032-78 0.01μF

C118 178-3322-78 3300pFC119 178-1032-78 0.01μFC120 042-0403-01 16V10μF TANC121 178-1055-79 1μFC122 178-8222-78 8200pFC123 178-1822-78 1800pFC124 178-1055-79 1μFC125 178-3912-78 390pFC126 042-0416-02 10V10μFC127 178-1032-78 0.01μFC128 178-1055-79 1μFC129 178-1055-79 1μFC130 042-0403-01 16V10μF TANC131 178-1032-78 0.01μFC132 178-1055-79 1μFC133 178-1032-78 0.01μFC134 178-1032-78 0.01μF

C135 178-1032-78 0.01μFC136 178-1032-78 0.01μFC137 178-1032-78 0.01μFC138 178-1032-78 0.01μFC139 178-1032-78 0.01μFC140 178-1032-78 0.01μFC141 178-1022-78 1000pFC142 178-1032-78 0.01μFC143 178-1022-78 1000pFC144 178-1032-78 0.01μFC145 042-0416-02 10V10μFC146 178-1032-78 0.01μFC147 178-1042-78 0.1μFC148 178-1042-78 0.1μFC149 178-1822-78 1800pFC150 178-4732-78 0.047μFC151 042-0403-01 16V10μF TAN

- 8 -JC-215H-51

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION

C152 178-1032-78 0.01μFC153 176-6801-00 68pF CHC154 176-6801-00 68pF CHC155 042-0397-06 35V0.1μFC156 178-2212-78 220pFC157 178-2212-78 220pFC158 178-2212-78 220pFC159 178-2212-78 220pFC160 178-2212-78 220pFC161 178-2212-78 220pFC162 178-2212-78 220pFC163 178-2212-78 220pFC164 178-2212-78 220pFC165 178-2212-78 220pFC166 178-2222-78 2200pFC167 178-2222-78 2200pFC168 178-1055-79 1μFC169 178-6812-78 680pFC170 178-1055-79 1μFC171 178-1032-78 0.01μFC172 178-1032-78 0.01μFC173 178-1032-78 0.01μFC174 042-0416-02 10V10μFC175 178-1032-78 0.01μFC176 042-0403-01 16V10μF TANC177 178-1032-78 0.01μFC178 178-1032-78 0.01μFC179 178-1055-79 1μFC180 178-1032-78 0.01μFC181 178-1032-78 0.01μFC182 178-1522-78 1500pFC183 178-1032-78 0.01μFC184 042-0416-02 10V10μFC185 178-1055-79 1μFC186 178-2222-78 2200pFC190 178-1055-79 1μFD101 001-0516-00 MA111D102 001-0528-30 MA8051-HD103 001-0516-00 MA111D104 001-0528-30 MA8051-HD105 001-0516-00 MA111D106 001-0367-00 1SS226D107 001-0516-00 MA111D108 001-0516-00 MA111D109 001-0516-00 MA111D110 001-0528-23 MA8043-MD111 001-0584-25 MA8091D112 001-0584-25 MA8091D113 001-0584-25 MA8091IC101 051-7100-08 TC4W66F-TE12LIC102 051-0350-55 NJM4558MIC103 051-0350-55 NJM4558MIC104 051-5010-90 LC75391MIC105 051-0350-55 NJM4558MIC106 051-0350-55 NJM4558MIC107 051-5403-08 S-80725-SN-DN-T1IC108 052-9203-01 MB89133APFM-

G499J101 074-1142-08 8PJ102 074-1142-08 8PL101 010-2285-05 BLM21A102SL102 010-2285-05 BLM21A102SL103 010-2285-05 BLM21A102SL104 010-2285-05 BLM21A102S

L105 010-2285-05 BLM21A102SL106 010-2285-05 BLM21A102SL107 010-2285-05 BLM21A102SL108 010-2285-05 BLM21A102SL109 010-2285-05 BLM21A102SL110 010-2285-05 BLM21A102SP101 076-0232-14 14PQ101 125-2020-05 DTC123JKQ102 100-1313-00 2SA1313O,YQ103 125-2017-07 RN1427Q104 125-2017-07 RN1427Q105 125-2017-07 RN1427Q106 102-2712-00 2SC2712Q107 102-2712-00 2SC2712Q108 102-2712-00 2SC2712Q109 102-2712-00 2SC2712Q110 102-2712-00 2SC2712Q111 102-3326-00 2SC3326R101 117-4731-10 1/10W 47kΩR102 117-4731-10 1/10W 47kΩR103 117-4731-10 1/10W 47kΩR104 117-1031-10 1/10W 10kΩR105 117-1031-10 1/10W 10kΩR106 117-2231-10 1/10W 22kΩR107 117-2231-10 1/10W 22kΩR108 117-4731-10 1/10W 47kΩR109 117-1031-10 1/10W 10kΩR110 117-1031-10 1/10W 10kΩR111 117-1031-10 1/10W 10kΩR112 117-8231-10 1/10W 82kΩR113 117-8231-10 1/10W 82kΩR114 117-8231-10 1/10W 82kΩR115 117-8231-10 1/10W 82kΩR116 117-8231-10 1/10W 82kΩR117 117-8231-10 1/10W 82kΩR118 117-8231-10 1/10W 82kΩR119 117-8231-10 1/10W 82kΩR120 117-1031-10 1/10W 10kΩR121 117-1031-10 1/10W 10kΩR122 117-1031-10 1/10W 10kΩR123 117-8231-10 1/10W 82kΩR124 117-8231-10 1/10W 82kΩR125 117-8231-10 1/10W 82kΩR126 117-8231-10 1/10W 82kΩR127 117-8231-10 1/10W 82kΩR128 117-8231-10 1/10W 82kΩR129 117-8231-10 1/10W 82kΩR130 117-8231-10 1/10W 82kΩR131 117-1031-10 1/10W 10kΩR132 117-1031-10 1/10W 10kΩR133 117-1031-10 1/10W 10kΩR134 117-2721-10 1/10W 2.7kΩR135 117-6831-10 1/10W 68kΩR136 117-2221-10 1/10W 2.2kΩR137 117-2221-10 1/10W 2.2kΩR138 117-1031-10 1/10W 10kΩR139 117-1231-10 1/10W 12kΩR140 117-2231-10 1/10W 22kΩR141 117-2231-10 1/10W 22kΩR142 117-2231-10 1/10W 22kΩR144 117-4731-10 1/10W 47kΩR145 117-1031-10 1/10W 10kΩR146 114-2711-21 2W 270ΩR147 117-4721-10 1/10W 4.7kΩ

R148 117-4721-10 1/10W 4.7kΩR149 117-1031-10 1/10W 10kΩR150 117-1031-10 1/10W 10kΩR151 117-4731-10 1/10W 47kΩR152 117-4731-10 1/10W 47kΩR153 117-4721-10 1/10W 4.7kΩR154 117-4721-10 1/10W 4.7kΩR155 117-1031-10 1/10W 10kΩR156 117-1031-10 1/10W 10kΩR157 117-1831-10 1/10W 18kΩR158 117-3321-10 1/10W 3.3kΩR159 117-1031-10 1/10W 10kΩR160 117-1031-10 1/10W 10kΩR161 117-1031-10 1/10W 10kΩR162 117-1031-10 1/10W 10kΩR163 117-1031-10 1/10W 10kΩR164 117-1031-10 1/10W 10kΩR165 117-1031-10 1/10W 10kΩR166 117-4721-10 1/10W 4.7kΩR167 117-4721-10 1/10W 4.7kΩR168 117-1041-10 1/10W 100kΩR169 117-1031-10 1/10W 10kΩR170 117-3331-10 1/10W 33kΩR171 117-4721-10 1/10W 4.7kΩR172 117-4721-10 1/10W 4.7kΩR173 117-8231-10 1/10W 82kΩR174 117-1041-10 1/10W 100kΩR175 117-1041-10 1/10W 100kΩR176 117-5631-10 1/10W 56kΩR177 117-1011-10 1/10W 100ΩR178 117-6821-10 1/10W 6.8kΩR179 117-2231-10 1/10W 22kΩR180 117-1021-10 1/10W 1kΩR181 117-2731-10 1/10W 27kΩR182 117-1241-10 1/10W 120kΩR183 117-1031-10 1/10W 10kΩR184 117-1031-10 1/10W 10kΩR185 117-4731-10 1/10W 47kΩR186 117-4731-10 1/10W 47kΩR187 117-1021-10 1/10W 1kΩR188 117-3311-10 1/10W 330ΩR189 117-1031-10 1/10W 10kΩR190 117-1031-10 1/10W 10kΩR191 117-2221-10 1/10W 2.2kΩR192 117-4721-10 1/10W 4.7kΩR193 117-1011-10 1/10W 100ΩR194 117-2231-10 1/10W 22kΩR195 117-2231-10 1/10W 22kΩR196 117-2231-10 1/10W 22kΩR197 117-4701-10 1/10W 47ΩR198 117-4701-10 1/10W 47ΩR199 117-4701-10 1/10W 47ΩR200 117-4701-10 1/10W 47ΩR201 117-4701-10 1/10W 47ΩR202 117-4701-10 1/10W 47ΩR203 117-4721-10 1/10W 4.7kΩR204 117-1011-10 1/10W 100ΩR205 117-1011-10 1/10W 100ΩR206 117-1011-10 1/10W 100ΩR210 117-1841-10 1/10W 180kΩR211 114-2711-21 2W 270ΩX101 060-0130-50 LST4.19MGW