peugeot partner owners manual 2004
TRANSCRIPT
-
5/20/2018 Peugeot Partner Owners Manual 2004
1/78
10 YOUR PARTNER AT A GLANCE
HEATING
N Symbol Function
Air flow adjustment.1
Air flow adjustmentand air intake control.
2
3
Air distributionadjustment.
4
Temperatureadjustment.
48
-
5/20/2018 Peugeot Partner Owners Manual 2004
2/78
PRACTICAL INFORMATION100
22-12-2003
BATTERY
To charge the battery using a battery charger: Disconnect the battery,
Follow the instructions for use given by the battery charger manufacturer, Reconnect starting with the negative () terminal,
Check that the terminals and connectors are clean. If they are covered withsulphate (white or greenish deposit), disconnect them and clean them.
To start the vehicle from another battery: Connect the red cable to the positive (+) terminals of the two batteries,
Connect one end of the green or black cable to the negative () terminal of theslave battery,
Connect the other end of the green or black cable to an earth point on thebroken down vehicle as far as possible from the battery.
Operate the starter, let the engine run.
Wait for the engine to return to idle, then disconnect the cables.
Never disconnect a terminal when the engine is running.
Never charge a battery without first disconnecting the terminals.
After every reconnection of the battery, switch on the ignition andwait 1 minute before starting to allow the electronic systems to beinitialised. If slight difficulties are experienced after this, pleasecontact a PEUGEOT dealer. A flat battery will prevent
the engine from starting.
It is advisable to disconnect the battery if the vehicle is not to be usedfor a period of more than one month.
ECONOMY MODE FUNCTION
After the engine has stopped, withthe key in the accessories position,certain functions (windscreen wiper,
electric windows, courtesy lights,audio equipment etc.) can only beused for thirty minutes, to preventdischarging the battery.
Once the thirty minutes are over, themessage "Eco mode active"appears on the multifunction displayand the active functions are put onstandby.
-
5/20/2018 Peugeot Partner Owners Manual 2004
3/78
PRACTICAL INFORMATION
22-12-2003
FITTING AUDIO EQUIPMENT
Your vehicle is equipped with certainfactory-fitted audio equipment:
roof aerial,
coaxial aerial cable, basic interference suppression,
supply to front speakers,
two 8-way connectors.
Making the connections
A1 :
A2 :
A3 : A4 :
A5 :
A6 : (+ve) Accessories
A7 : (+ve) Permanent
A8 : (ve) Earth
B1 : (+)
B2 : ()
B3 : (+) Front right speaker
B4 : () Front right speaker
B5 : (+) Front left speaker
B6 : () Front left speaker
B7 : (+)
B8 : ()
FITTING SPEAKERS
The factory-fitted equipment allowsthe fitting of 165 mm diameterspeakers in the front doors.
Contact a PEUGEOTdealer before fitting audioequipment or speakers inyour vehicle.
-
5/20/2018 Peugeot Partner Owners Manual 2004
4/78
SNOW SCREEN*The snow screen is installed on thelower part of the front bumper to pre-vent the accumulation of snow at theradiator cooling fan.
When the snow has cleared, donot forget to remove the snowscreen.
FITTING
Offer up the snow screen facingits centring pin A on the frontbumper.
Put it in place by pressing ateach clip B located in the fourcorners.
REMOVAL
Pass a screwdriver into the holelocated near each of the clips. Use the screwdriver as a lever to
unclip the four clips B in turn.
* According to destination.
PRACTICAL INFORMATION102
TOWING YOUR VEHICLE
Without lifting (four wheels on the ground)
You must always use a tow bar.
From the front or the rearAttach the tow bar to the towing eye.
By lifting (two wheels only on the ground)
It is preferable to lift the vehicle by the wheels.
Never use the radiator crossmember.
22-12-2003
-
5/20/2018 Peugeot Partner Owners Manual 2004
5/78
PRACTICAL INFORMATION
22-12-2003
TOWING A TRAILER,CARAVAN, BOAT etc.
Only use original PEUGEOT towbars that have been tested and
approved from the design stage ofyour vehicle.
The tow bar must be fitted by aPEUGEOT dealer.
Your vehicle is basically designed fortransporting people and luggage but itmay also be used for towing a trailer.
Driving with a trailer subjects thetowing vehicle to more significantstress and its driver must be particu-larly careful.
Air density decreases with altitude,
thus reducing engine performance.Above 1 000 metres, the maximumtowing load must be reduced by 10 %and so on for every 1 000 metres ofaltitude.
Driving advice
Distribution of loads: Distribute theload in the trailer so that the heaviestitems are as close as possible to theaxle and the nose weight approachesthe maximum permitted withoutexceeding it.
Cooling: Towing a trailer on a slopeincreases the temperature of thecoolant.
As the fan is electrically controlled,its cooling capacity is not dependenton the engine speed.
On the contrary, use a high gear to
lower the engine speed, and reduceyour speed.
The maximum towing load on a longslope depends on the gradient andthe outside temperature.
In all cases, pay attention to thecoolant temperature.
If the warning light comes on, stopthe vehicle and switch off the engineas soon as possible.
Tyres: Check the tyre pressures ofthe towing vehicle and of the trailer,observing the recommended pres-sures.
Braking: Towing increases the brakingdistance.
Lights: Check the electrical sig-nalling on the trailer.
Side wind: Take into acount theincreased sensitivity to side wind.
-
5/20/2018 Peugeot Partner Owners Manual 2004
6/78
PRACTICAL INFORMATION104
22-12-2003
ACCESSORIES FOR YOUR PARTNER
For your PEUGEOT only use accessories and original parts approved by the manufacturer.
These accessories and parts are all adapted to your PEUGEOT, after being tested and approved for reliability andsafety, which PEUGEOT cannot guarantee for other products.
A wide choice of original accessories, approved by PEUGEOT, is available through the dealer network. They all carrythe PEUGEOT guarantee.
Safety : Separation grille, window protectors, anti-theft alarm, wheel locks, parking assistance,signalling triangle, first aid kit, fog lamps, safety jacket...
Comfort : Rear and side windows, audio-telephone console, covers compatible with side air bags,mats, luggage net, door deflectors...
Loading : Roof bars, thermoformed interior protectors, wooden interior fittings, loading roller...
Communication : Audio systems, audio-telephone, speakers, CD changer, navigation system...
Customising : Alloy wheels, door sills, mud flaps, ...
Leisure : Tow bar, roof bars, snow chains, tailgate bicycle carrier...
Children : Booster seats and child seats...
Maintenance products : Screenwash, interior and exterior maintenance and cleaning products...
Before installing any electrical accessory on your vehicle, contact a PEUGEOT dealer.
-
5/20/2018 Peugeot Partner Owners Manual 2004
7/78
CONSUMPTION
Fuel consumption values correct at time of printing.
In accordance with directive 99/100 in M.P.G. (litres/100 km)
Engine Gearbox Model Urban driving Inter- Mixed Emission of
codes urban CO2 by weight(g/km)
1.1 litre Manual GBHFXB
1.4 litre Manual GBKFWB 29.1 (9.7) 45.6 (6.2) 37.6 (7.5) 175GCKFWB
1.9 litre Diesel Manual GBWJYB/K 32.1 (8.8) 49.6 (5.7) 40.9 (6.9) 181GCWJYB PLC
2 litre Turbo HDI Manual GBRHYB 39.2 (7.2) 57.6 (4.9) 49.6 (5.7) 152
GCRHYB
TECHNICAL DATA
22-12-2003
-
5/20/2018 Peugeot Partner Owners Manual 2004
8/78
TECHNICAL DATA
Engine 1.1 litre 1.4 litre
Model 600 kg 600 kg 800 kgGearbox Manual Manual Manual
Model codes GBHFXB GBKFWB GCKFWB
Kerb weight 1 108 1 108 1 110
Gross vehicleweight (GVW) 1 690 1 690 1 890
Gross train weight (GTW)* 2 440 2 590 2 790
Unbraked trailer 500 500 500
Braked trailer (within GTW) 750 900 900
Recommended nose weight
WEIGHTS AND TOWING LOADS (IN KG)
* In the case of a towing vehicle, the speed is limited to 60 mph (100 km/h).
Engine 1.9 litre D 2 litre Turbo HDI
Model 600 kg 800 kg 600 kg 800 kg
Gearbox Manual Manual Manual Manual
Model codes GBWJYB/K GCWJYB PLC GBRHYB GCRHYB
Kerb weight 1 163 1 225 1 211 1 211
Gross vehicle
weight (GVW) 1 755 1 955 1 790 1 990 Gross train weight (GTW)* 2 855 3 055 2 890 3 090
Unbraked trailer 500 500 500
Braked trailer (within GTW) 1 100 1 100 1 100
Recommended nose weight
22-12-2003
108
-
5/20/2018 Peugeot Partner Owners Manual 2004
9/78
AIR CONDITIONING
50
YOUR PARTNER AT A GLANCE
N Symbol Function
Air conditioningcontrol.
1
Air flow adjustmentand air intake control.
2
3
Air distributionadjustment.
4
Temperatureadjustment.
-
5/20/2018 Peugeot Partner Owners Manual 2004
10/78
THE IDENTIFICATION FEATURES OF YOUR PARTNER
A. Manufacturer's plate (under the bonnet, on the front right wing).
B. Serial number on the bodywork (under the bonnet, on the right-hand crossmember).
C. Tyres and paint colour reference.
The label C on the driver's door pillar, near the hinges, gives: the wheel and tyre sizes,
the tyre pressures: (tyre pressure checks must be carried out cold, at least every month),
the paint colour reference.
TECHNICAL DATA
22-12-2003
-
5/20/2018 Peugeot Partner Owners Manual 2004
11/78
SPECIAL FEATURES112
22-12-2003
THE ALARM SYSTEM*
The alarm offers two types ofprotection:
exterior protection: the alarmsounds if a door, the boot or thebonnet is opened;
interior protection: the alarmsounds if there is a variation in thevolume inside the vehicle(breaking of a window or move-ment inside the vehicle).
Setting the alarm
Switch the ignition off and get out ofthe vehicle.
Activate the alarm within five minutesfollowing your exit from the vehicle,by locking using the remote controlkey (the red indicator light on theswitch 1, which can be seen from theoutside, flashes once a second).
When the alarm is triggered, thesiren sounds and the directionindicators flash for thirty seconds.
After it has been triggered, the alarmbecomes operational again.
Note: if you wish to lock your vehiclewithout setting the alarm, lock itusing the lock.
Warning key in the door
If, on setting the alarm, a door, theboot or the bonnet are not closedcorrectly, the siren sounds for amoment.
Close the vehicle correctly to set thealarm.
If the interior protection alarm istriggered ten times in succession, itis disarmed automatically. It must beset again in order for it to operatecorrectly.
Disarming the alarm
Unlock the vehicle using the remotecontrol key (the red indicator light onthe switch 1 goes out).
Note: if the warning light flashes, itis a sign that the alarm has been
triggered in your absence.To stop it, switch on the ignition.
* According to destination.
Note: when the alarm is set, but theremote control no longer works: unlock the doors using the key
and open the door; the alarm istriggered;
switch the ignition on within tenseconds; the alarm is disarmed.
To set the alarm with exteriorprotection only.
If, while you are away from the vehicle,you wish to leave a window partiallyopen or a pet inside the vehicle, youneed to select exterior protection only:
Switch off the ignition.
Press the button 2 until the light 1comes on continuously.
Get out of the vehicle.
Press the locking button of theremote control.
The doors lock.
The red light on the switch flashesonce a second.
Malfunction
When the ignition is switched on,fixed lighting of the red indicator light,located in the centre of the fascia,indicates a siren connection fault.
Contact a PEUGEOT dealer to have
the system checked.
Do not make any modifica-tions to the alarm system.
-
5/20/2018 Peugeot Partner Owners Manual 2004
12/78
12 YOUR PARTNER AT A GLANCE
-
5/20/2018 Peugeot Partner Owners Manual 2004
13/7879
YOUR PARTNER AT A GLANCE
FRONT FITTINGS
1. STORAGE COMPARTMENTS IN THE DOORS
A.Bottle holder.
B. Can holder.
C. Storage compartment.
2. OVERHEAD STORAGE WITH MAP READING LIGHT
3. COURTESY LIGHT
4. SUN VISORS
5. GLOVE BOX
To open the glove box with lid, lift the handle (version with air conditioning).
6. LIGHTER
7. REMOVABLE ASHTRAY
Lift the lid to open the ashtray.
To empty it, after opening, remove it by pulling upwards.
8. 12 V ACCESSORIES SOCKETThis is located at the bottom of the centre console.
It permits the connection of a telephone charger, a baby's bottle warmer, ...
9. STORAGE DRAWER
To open it, lift it slightly and pull it forwards.
-
5/20/2018 Peugeot Partner Owners Manual 2004
14/78
14 YOUR PARTNER AT A GLANCE
OPENING THE BONNET
Inside the vehicle: Pull the con-trol on the left-hand side, underthe fascia panel.
Outside the vehicle:Lift the control, raise thebonnet and secure thestrut to keep the bonnetopen
FILLING WITH FUEL
This operation must be carried out with the engine switched off.
Insert the key then turn it to the left.
Remove the cap.
An indication shows which type of fuel to use.
When you fill your tank, do not continue after the third cut-off of the pump.This could cause a malfunction.
The capacity of the tank is approximately 55 litres for petrol enginesand 60 litres for Diesel engines.
Note: the right-hand sliding side door cannot be opened while the fueltank cap is removed.
Low fuel level warning light
From the time this light comes on, you have enoughfuel left to cover approximately 30 miles (50 km). 70 69
18
-
5/20/2018 Peugeot Partner Owners Manual 2004
15/78
PEUGEOT SERVICING
Your vehicle benefits from extended service intervals.
For petrol engines: every 20,000 miles (30 000 km) or every two years.
For direct injection diesel engines: every 12,000 miles (20 000 km) or every two years. For indirect injection diesel engines: every 10,000 miles (15 000 km) or every two years.
Your service indicator informs you when a service is due; the point at which a service is due is calculated from the last indi-cator zero reset (see corresponding section).
This point is determined by two parameters:
the distance travelled,
the time elapsed since the last service.
Note: the distance remaining may be weighted by the time factor, depending on the driver's style of driving.
The extension of the service intervals means that the engine oil level must be checked regularly: topping up of theoil between oil changes is normal.
This is why the PEUGEOT network is offering you an intermediate service between regular services.
The date of this visit is not shown by the service indicator. It is to be carried out at least every 10,000 miles(15 000 km) for petrol engines; every 6,000 miles (10 000 km) for direct injection diesel engines and every5,000 miles (7 500 km) for indirect injection diesel engines.
A PEUGEOT dealer will carry out a quick check and top up the levels if necessary (oil, coolant, windscreen washup to 2 litres).
If the oil level is too low there is a risk of serious damage to the engine: check the engine oil level at least every2,000 to 3,000 miles (3 000 to 5 000 km), depending on the conditions of use.
This extended servicing has been made possible by modifications to our vehicles and to the lubricants:
THUS IT IS ESSENTIAL TO USE ONLY LUBRICANTS WHICH ARE SUITED TO YOUR ENGINE AND RECOMMENDEDBY THE MANUFACTURER (see "Lubricants" pages).
PEUGEOT SERVICING18
22-12-2003
-
5/20/2018 Peugeot Partner Owners Manual 2004
16/78
PEUGEOT SERVICING
22-12-2003
SPECIAL FEATURES
Some of your vehicle's vital components have specific servicing schedules.
The brake fluid must be replaced every 36,000/40,000 miles (60 000 km) or every 2 years.
The passenger compartment filter must be checked at each visit to the PEUGEOT dealer (intermediate visits and regularservices).
The timing belt: consult your PEUGEOT dealer.
Arduous conditions of useIf the vehicle is used in certain particularly arduous conditions:
Continuous door-to-door use. Town use (e.g. taxi). Repeated short journeys, with the engine cold in low temperatures.
Or in long stays in the following conditions:
Hot countries with temperatures often above 30 C. Cold countries with temperatures often below minus 15 C. Countries with a dusty atmosphere. Countries whose lubricants or fuels do not conform to our recommendations.
It is necessary to follow an "Arduous Conditions" servicing schedule, which includes special operations and shorterservice intervals:
Every 12,000 miles (20 000 km) or every year for petrol engine vehicles. Every 10,000 miles (15 000 km) or every year for Direct Injection Diesel engine vehicles. Every 6,000 miles (10 000 km) or every year for Indirect Injection Diesel engine vehicles.
-
5/20/2018 Peugeot Partner Owners Manual 2004
17/78
PEUGEOT SERVICING
22-12-2003
SPECIAL FEATURES
Some of your vehicle's vital components have specific servicing schedules.
The brake fluid must be replaced every 36,000/40,000 miles (60 000 km) or every 2 years.
The passenger compartment filter must be checked at each visit to the PEUGEOT dealer (intermediate visits and regularservices).
The timing belt: consult your PEUGEOT dealer.
Arduous conditions of useIf the vehicle is used in certain particularly arduous conditions:
Continuous door-to-door use. Town use (e.g. taxi). Repeated short journeys, with the engine cold in low temperatures.
Or in long stays in the following conditions:
Hot countries with temperatures often above 30 C. Cold countries with temperatures often below minus 15 C. Countries with a dusty atmosphere. Countries whose lubricants or fuels do not conform to our recommendations.
It is necessary to follow an "Arduous Conditions" servicing schedule, which includes special operations and shorter
service intervals: Every 12,000 miles (20 000 km) or every year for petrol engine vehicles. Every 10,000 miles (15 000 km) or every year for Direct Injection Diesel engine vehicles. Every 6,000 miles (10 000 km) or every year for Indirect Injection Diesel engine vehicles.
-
5/20/2018 Peugeot Partner Owners Manual 2004
18/78
2 YOUR PARTNER AT A GLANCE
O G C
-
5/20/2018 Peugeot Partner Owners Manual 2004
19/78
YOUR PARTNER AT A GLANCE
1 - Speaker (tweeter).
2 - Windscreen demistingvents.
3 -Controls: Electric windows. Demisting of rear door
windows or tailgate. Air conditioning.
4 - Central locking button.
5 - Multifunction display orclock.
6 - Hazard lights button.
7 - Central adjustableheating/ventilation vents.
8 - Lights and directionindicators stalk.
9 - Cruise control.
10 - Instrument panel.
11 - Driver's air bag.Horn.
12 - Windscreen wash-wipestalk.
13 - Audio equipment steeringwheel control.
14 - Steering lock and ignition.
15 - Fuse box.
16 - Passenger air bagdisarming control*.
17 -
Alarm.18 - Steering wheel adjustment
control.
19 - Passenger's electric mirrorcontrol.
20 - Headlamp heightadjustment.
21 - Heated seats control.
22 - Handbrake.
23 - 12 V accessories socket.
24 - Removable ashtray.
25 - Lighter.
26 - Storage.
27 - Gear lever.
28 - Heating/air conditioningcontrols.
29 - Audio RB3 or RD3.
30 - Lower glove box.
31 - Upper glove box orpassenger air bag.
32 - Bonnet release.
33 - Side adjustable heating/ventilation vents.
34 -
Side windowde-icing/demisting vents.
* According to destination.
22
-
5/20/2018 Peugeot Partner Owners Manual 2004
20/78
TYPES OF SERVICE
Each vehicle has its own servicing cycle, based upon the engine type.
This cycle consists of alternating two types of service, A and C, intermediate visits and a few additional operations depend-ing on your vehicle; these correspond to key stages in the life of your vehicle.
When the first service is carried out and at each subsequent service, your dealer will advise you of the type andcontent of the next service due.
PEUGEOT SERVICING22
22-12-2003
THE MAINTENANCE CYCLE FOR YOUR PARTNER PETROL
Service every 20,000 miles (30,000 km) or 2 years.
1st service at
6,000 miles (10,000 km)or 6 months*.
This is necessaryin order to benefitfrom the warranty.
* Whichever comes first.
Intermediate top-up visit included inthe Fixed Services.
MILES (KM) 20,000 (30,000) 40,000 (60,000) 60,000 (90,000) 80,000 (120,000)
100,000 (150,000) 120,000 (180,000) 140,000 (210,000) 160,000 (240,000) 180,000 (270,000)
These services are carried out with synthetic based oil; Fuel Economy oil orsynthetic oil may also be used.Arduous conditions of use (see corresponding section).
-
5/20/2018 Peugeot Partner Owners Manual 2004
21/78
PEUGEOT SERVICING
22-12-2003
Intermediate top-up visit included inthe Fixed Services.
THE MAINTENANCE CYCLE FOR YOUR PARTNER TURBO DIESEL HDI
Service every 12,000 miles (20,000 km) or 2 years.
1st Service at6,000 miles (10,000 km)
or 6 months*.This is necessary in order to
benefit from the warranty.
These services are carried out with synthetic based oil; Fuel Economy oil or synthetic oil may also be used.
Arduous conditions of use (see corresponding section).
* Whichever comes first.
MILES (KM) 12,000 (20,000) 24,000 (40,000) 36,000 (60,000) 48,000 (80,000) 60,000 (100,000)
72,000 (120,000) 84,000 (140,000) 96,000 (160,000) 108,000 (180,000) 120,000 (200,000) 132,000 (220,000) 144,000 (240,000)
24
-
5/20/2018 Peugeot Partner Owners Manual 2004
22/78
PEUGEOT SERVICING
22-12-2003
Intermediate top-up visit included inthe Fixed Services.
THE MAINTENANCE CYCLE FOR YOUR PARTNER INDIRECT INJECTION DIESEL
Service every 10,000 miles (15,000 km) or 2 years.
1st Service at 6,000 miles(10,000 km) or 6 months*.
This is necessary in order to benefitfrom the warranty.
These fixed services are carried out with synthetic based oil; Fuel Economy oil or synthetic oil may also be used.
Arduous conditions of use (see corresponding section).
* Whichever comes first.
MILES (KM) 10,000/90,000 (15,000/135,000) 20,000/100,000 (30,000/150,000) 30,000/110,000 (45,000/165,000)
40,000/120,000 (60,000/180,000) 50,000/130,000 (75,000/195 000) 60,000/140,000 (90,000/210,000) 70,000/150,000 (105,000/225,000) 80,000/160,000 (120,000/240,00)
-
5/20/2018 Peugeot Partner Owners Manual 2004
23/78
PEUGEOT SERVICING
22-12-2003
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
LevelOperations Description of operation 1st service
A C Intermediate
DRAIN/REFILL Engine oil Bleed fuel filter (diesel) Oil filter
Petrol filter (according to engine) REPLACE Diesel filter or element (according to engine)
Air filter element Spark plugs (petrol) Engine oil (check + top-up) Manual gearbox oil (check + top-up) Battery (check + top-up) if cap is removable
LEVEL Screen wash (check + top-up) Coolant (check + top-up) Brake fluid (check + top-up) Power steering f luid (check + top up according to specification) Operation of lights and indicators
Condition of glass, headlamp and light lenses and mirrors Horn Windscreen washer jets Condition of wiper blades Condition and tension of the ancillary drive belts Handbrake Condition of hydraulic circuits (hoses and covers)
CHECK Condition of rubber boots and gaiters Brake pads Play in hubs, link rods, ball joints, flexible mountings Shock absorbers Rear drum brake lining wear
Condition and pressure of tyres (including spare wheel) Emission control check as per current legislation (petrol) Smoke opacity (diesel) Passenger compartment filter (according to specification) Visual check of the whole vehicle
SERVICE* Courtesy vehicle
ROAD TEST
: All driving conditions. : Arduous conditions. * According to destination.
26
-
5/20/2018 Peugeot Partner Owners Manual 2004
24/78
(1) Minimum quality standard: Petrol engines: ACEA A3 and API SH/SJ; Diesel engines: ACEA B3 and API CF/CD.ACEA = Association des Constructeurs Europens Automobiles (Association of European Automobile Manufacturers) -
API = American Petroleum Institute.If oil is used which does not conform to the ACEA A3-B3 standards, this requires the "Arduous Conditions"
servicing schedule to be followed, which involves shorter intervals between services.* This Fuel Economy oil can only be used in engines designed for its use.
TRADE NAMES OF RECOMMENDED ENGINE LUBRICANTS IN EUROPE(1)
P E T R O L D I E S E L D I E S E L P E T R O L
22-12-2003
-
5/20/2018 Peugeot Partner Owners Manual 2004
25/78
PEUGEOT SERVICING
22-12-2003
Recommendations forrecommended lubricants
The oils which appear in the tableopposite are suitable for mostpurposes.
The diagram opposite states theoptimum range of viscosity depen-ding on the temperatures at whichthe oils are to be used.
It is also possible to use "superiorquality" synthetic oils.
In the absence of semi-synthetic orsynthetic oils, oils of ACEA A1/A2and API SH/SJ/SL quality (for petrolengines), or ACEA B1/B2 and APICD/CF quality (for diesel engines)may be used by following the
"Arduous Conditions" servicingschedule which specifies shorterintervals.
Do not hesitate to ask for advicefrom a PEUGEOT dealer to maintaindriving pleasure and to minimise themaintenance cost of your vehicle.
For countries outside Europe, pleasecontact a local PEUGEOT dealer.
ONLY ONLYManual Gearbox ESSO GEAR OIL BV TOTAL TRANSMISSION BV
75W80 PR 9736.41 75W80 PR 9730.A2
Power steering ESSO ATF D TOTAL Fluide AT42PR 9730.94 PR 9730.A3
Other recommended products
Brake fluid PEUGEOT DOT4
Coolant PROCOR TM 108/GLYSANTIN G33 or REVKOGEL 2000
ONLY protection to 35 C
28
-
5/20/2018 Peugeot Partner Owners Manual 2004
26/78
INSTRUMENTS AND CONTROLS
22-12-2003
1. Seat belt not fastened warninglight*
2. Passenger air bag disarmingwarning light*
3. Front and side air bags warninglight
4. Front fog lamps indicator light
5. Anti-lock braking system (ABS)warning light6. Rear fog lamp indicator light7. Diesel pre-heat warning light8. Left hand direction indicator9. Total distance recorder, service
indicator and engine oil levelindicator
10. Right hand direction indicator
11. Engine diagnostics warning light
12. Main beam headlamps indicatorlight
13. Handbrake, low brake fluid leveland electronic brake forcedistribution warning light
14. Dipped beam headlampsindicator light
15. Battery charge warning light
16. Engine oil pressure andtemperature warning light
17. Water in diesel filter warning light
18. Low coolant level warning light
19. Coolant temperature indicator
20. Total distance recorder button
21. Central (STOP) warning light
22. Speedometer
23. Rev counter
24. Lighting rheostat button
25. Fuel level indicator
26. Low fuel level warning light
* According to destination.
INSTRUMENT PANEL: PETROL-DIESEL MANUAL GEARBOX
INSTRUMENTS AND CONTROLS
-
5/20/2018 Peugeot Partner Owners Manual 2004
27/78
INSTRUMENTS AND CONTROLS
22-12-2003
Instrument panel display
After switching on the ignition, three functions are shown in succession:
service indicator (see corresponding section),
engine oil level indicator (Diesel),
total distance recorder/total and trip distances.
Note: the total and trip distances are displayed for 30 seconds when the ignition is switched off, on opening the driver's door,as well as on locking and unlocking the vehicle.
Engine oil level (Diesel)
When the ignition is switched on, the engine oil level is indicated for approximately 10 seconds, after the servicinginformation.
Maximum
Note: a surplus of oil can cause damage to the engine.
Minimum
Check the level with the dipstick and top it up. The level indicated is only correct if the vehi-cle has been on stable, level ground, with the engine stopped, for 10 minutes.
Oil level gauge fault
The 6 segments flash to indicate a fault in the oil level gauge.
There is a risk the engine will be damaged.
Consult a PEUGEOT dealer.
INSTRUMENTS AND CONTROLS32
-
5/20/2018 Peugeot Partner Owners Manual 2004
28/78
Lighting rheostat
With the lights on, press the buttonto vary the intensity of the lighting ofthe instruments and controls. Whenthe lighting reaches the minimum(or maximum) setting, release the
button then press it again toincrease (or reduce) the brightness.
As soon as the lighting is of therequired brightness, release thebutton.
Total distance recorder
Briefly pressing button 1 alternatesbetween the total and trip distancedisplays.
To reset the trip recorder to zero,when it is displayed press the button
for more than 3 seconds.
INSTRUMENTS AND CONTROLS
22-12-2003
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
29/78
MULTIFUNCTION DISPLAY
This displays the following infor-mation: the time,
the date,
the audio system displays,
a door check (e.g.: ''left front dooropen''),
warning messages (e.g.: ''remotecontrol battery flat'') or informationmessages (e.g.: ''eco modeactive''), displayed temporarily.
CLOCK
Button 1: hour adjustment
Button 2: minute adjustment
Press and hold the button for rapidadvance.
YOUR PARTNER IN DETAIL
22-12-2003
Adjusting the parameters
Press and hold button 1 for two sec-onds to access the settings; the dataflashes, indicating it is ready to bemodified.
Then, each press of button 1 scrolls
through the various data in the fol-lowing order:
language of information displayed,
hours (12 then 24 hour mode),
minutes,
year,
month,
day.
Pressing button 2 alters the value ofthe parameter selected. Press and
hold for rapid advance (return to startafter the last possible value).
After 7 seconds with no action, themain display returns; the modifieddata are now recorded.
4 YOUR PARTNER AT A GLANCE
-
5/20/2018 Peugeot Partner Owners Manual 2004
30/78
THE KEYS
The keys allow you to switch onthe ignition and operate the pas-senger air bag disarming switch,as well as to independently ope-rate the locks on the doors andthe fuel filler cap.
Central locking
From the front doors, the keysallow you to lock and unlock thedoors and tailgate.
If one of the doors or the tailgateis open, it is impossible to oper-ate the central locking.
The remote control performs the
same functions at a distance.
The remote control keyLocking
Press button A to lock the vehicle.
This is confirmed by fixed lighting
of the direction indicators forapproximately two seconds.
Vehicles fitted withdeadlockingDeadlocking renders the exteriorand interior door controls inope-rative.Pressing button A deadlocksthe vehicle.This is confirmed by fixed lightingof the direction indicators forapproximately two seconds.Pressing button A again withinfive seconds following deadlock-ing, changes the deadlocking tosimple locking.This is confirmed by fixed lightingof the direction indicators forapproximately two seconds.
Unlocking
Press button B to unlock thevehicle.This is confirmed by rapid flash-
ing of the direction indicators.Locating the vehicle
To locate your vehicle, previouslylocked, in a car park:
press button A,the courtesy lightscome on and thedirection indica-tors flash for a few
STARTING
STOP position (S):The ignition is off.
Accessories position (A): The
ignition is off but the accessoriescan be used.
On position (M):The ignition is on.
Starting position (D):
Operates the starter.
61
YOUR PARTNER IN DETAIL46
-
5/20/2018 Peugeot Partner Owners Manual 2004
31/78
YOUR PARTNER IN DETAIL
22-12-2003
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
32/78
VENTILATION
1. Windscreen de-icing or demisting vents.
2. Front window de-icing or demisting vents.
3. Side vents.
4. Centre vents.5. Air outlets to front footwells.
Advice on operation
Select the air distribution most suited to your requirements and the climatic conditions.
Gradually adjust the temperature setting for your comfort.
Position the air control in the ''Outside Air'' position.
For perfectly even air distribution, take care not to obstruct the exterior air intake grille and the vents. Check that thepassenger compartment filter is in good condition.
YOUR PARTNER IN DETAIL
22-12-2003
De-icing the rear screen and mirrors
With the engine running, pressing the control de-ices the rear screen and mirrors.
It switches off automatically after approximately twelve minutes.
Pressing the control again switches the de-icing system on again for twleve minutes.It is possible to stop operation of the de-icing by pressing the control before thetwelve minutes have elapsed.
YOUR PARTNER IN DETAIL48
-
5/20/2018 Peugeot Partner Owners Manual 2004
33/78
22-12-2003
2. Air flow adjustment and airintake control
Turn the control from posi-tion 1 to position 4 to obtainan air flow sufficient toensure your comfort.
Intake of exterior air.
This is the normal operating position.
Passenger compartmentisolation.
This position prevents exteriorodours and smoke entering the
passenger compartment.
As soon as possible, position thecontrol in the exterior air intakeposition to prevent misting of thewindows.
HEATING1. Air flow adjustment
Turn the control from posi-tion 1 to position 4 to obtain
an air flow sufficient toensure your comfort.
YOUR PARTNER IN DETAIL
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
34/78
22-12-2003
Windscreen, side windowsand footwells.
Footwells.
These settings are recommendedfor cold climates.
Centre and side vents.
This setting is recommended forhigh temperatures.
4. Air distribution adjustment
Windscreen and side win-dows (de-icing/demisting).
To quickly de-ice or demist thewindscreen and side windows:
position the air intake control in the''Outside Air" position,
turn the temperature and air flowcontrols to maximum,
close the centre vents.
YOUR PARTNER IN DETAIL
3. Temperature adjustment
To be adjusted to your requirements.
From blue (exterior temperature) tored (hot).
YOUR PARTNER AT A GLANCE
-
5/20/2018 Peugeot Partner Owners Manual 2004
35/78
STEERING WHEELSTALKS
LIGHTING
Front and rear lights (ring A)
Lights off
Side lights
Dippedheadlamps/Mainbeam headlamps
Vehicles fitted witha rear fog lamp(ring B)
Turn the ring forwards.
Vehicles fitted withfront fog lamps and arear fog lamp (ring B)
Front fog lamps (1st turn of thering forwards).
Front fog lamps and rear fog lamp
(2nd turn of the ring forwards).
To switch off: turn the ring rearwards.
71
WINDSCREEN WIPERS
Front
2 Rapid wipe
(heavy rain).1 Normal wipe
(moderate rain).
I Intermittent wipe.
0 Off.
Single wipe.
Windscreen wash-wipe:pull the stalk towards you.
Rear
Off Intermittent Wash-wipe wipe
72
YOUR PARTNER IN DETAIL50
-
5/20/2018 Peugeot Partner Owners Manual 2004
36/78
1. Air conditioning
The air conditioning is designed to operate in all seasons. In summer, it enablesthe temperature to be lowered and in winter, above 0 C, it increases the effec-tiveness of the demisting.
Press the switch to activate the air conditioning. The indicator light comes on.
2. Air flow adjustment and airintake control
Turn the control from posi-tion 1 to position 4 to obtainan air flow sufficient toensure your comfort.
YOUR PARTNER IN DETAIL
22-12-2003
AIR CONDITIONING
The air conditioning does not operate while the air flow adjustment controlis in the minimum position.
Note: It is quite normal that the condensation created by the air conditioningresults in a flow of water under the vehicle when it is stationary.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
37/78
4. Air distribution adjustment
Windscreen and side win-dows (de-icing/demisting).
To quickly de-ice or demist the wind-screen and side windows:
turn the temperature and air flowcontrols to maximum,
close the centre vents,
position the air intake control inthe "Outside Air" position,
start the air conditioning.
Windscreen, side windowsand footwells.
Footwells.
These settings are recommendedfor cold climates.
Centre and side vents.
This setting is recommended forhigh temperatures.
Intake of exterior air.
This is the normal operating posi-tion.
Recirculation of interior air.
This position prevents exteriorodours and smoke entering the pas-senger compartment.
Used simultaneously with the airconditioning, recirculation enablesboth heating and cooling perform-ance to be improved.
Used without the air conditioning,recirculation may result in misting ofthe windows.
As soon as possible, position thecontrol in the exterior air intake posi-tion.
22-12-2003
3. Temperature adjustment
To be adjusted to your requirements.
From blue (cold when the air condi-tioning is on) to red (hot).
Important precaution
Operate the air conditioning systemfor 5 to 10 minutes, once or twice amonth, to keep it in perfect workingorder.
If the system does not produce cold air,do not use it and contact a PEUGEOTdealer.
Note: to optimise the operation ofthe air conditioning, leave the ventsopen.
YOUR PARTNER IN DETAIL52
-
5/20/2018 Peugeot Partner Owners Manual 2004
38/78
22-12-2003
To remove the head restraint,place it in the top position, pressthe tabs and pull it upwards.
To put it back in position, locate
the stems of the restraint in theholes, taking care to keep themin line with the seat back.
2- Seat back angle adjustment
Turn the knob.
3- Forwards-backwardsadjustment (driver)
Lift the control and slide the seatforwards or backwards.
SEATS
1- Head restraint heightadjustment
To raise or lower the restraint,slide it.
The adjustment is correctwhen the upper edge of thehead restraint is level withthe top of the head.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
39/78
22-12-2003
Never drive with thehead restraints removed;
they must be in placeand correctly adjusted.
Do not place heavyobjects in the drawers.
4- Storage drawer (version withpassenger air bag)
There is a storage drawer underthe driver's or passenger seat.
To open it, lift it and pull.
5- Heated seats switch
Press the switch. The tempera-ture is controlled automatically.
Pressing the switch again stopsoperation.
Note: the command for activationof heating of the seat(s) remainsmemorised for two minutes afterthe ignition has been switched off.
YOUR PARTNER IN DETAIL54
-
5/20/2018 Peugeot Partner Owners Manual 2004
40/78
22-12-2003
MULTIFUNCTION PASSENGER SEAT*
To fold the seat back:
Pull the control 1 upwards and tilt the seat back.
This provides a flat surface, recesses for drinks and a strap for retaining documents.
To fold the seat fully:
Pull the control 2 upwards and tilt the whole seat.
It is not necessary to remove the head restraint.
This provides access to a box which enables you to store objects so that they cannot be seen from outside the vehicle orto wedge long objects passed through the roof flap.
If your vehicle is not fitted with a load blocking partition, it can accommodate long objects (up to 2.10 m).
These must be placed on the front edge of the instrument panel and secured using the rear bar of the boot or using the lashingrings.
* According to destination.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
41/78
22-12-2003
LASHING RINGS
Use the 6 lashing rings on the lug-gage compartment floor to secureyour loads.
You can use suitable load retainers(half-height partitions, grille, etc.)supplied by your PEUGEOT dealer.
For greater safety,always ensure that theloads transported arestowed securely.
YOUR PARTNER IN DETAIL56
-
5/20/2018 Peugeot Partner Owners Manual 2004
42/78
22-12-2003
GENERAL POINTS RELATING TO CHILD SEATS
Although one of PEUGEOT's main criteria when designing your vehicle, thesafety of your children also depends on you.
For maximum safety, please follow these precautions:
Since 1992, all children under the age of 10 must travel in approved childseats* suited to their weight, on seats fitted with a seat belt.
A child weighing less than 9 kg must travel in the rearwards facingposition both in the front and in the rear. PEUGEOT recommends thatchildren should travel in the "rearwards facing" position up to the age oftwo.
Statistically, the safest seats in your vehicle for the transportation ofchildren are the rear seats.PEUGEOT recommends that children travel in the rear even when a"rearwards facing" child seat is used.
If a child is travelling on a booster seat, check that the lap section of the seatbelt passes over the child's thighs correctly. The chest section of the seatbelt must be positioned on the child's shoulder without touching the neck.PEUGEOT recommends that you use a booster seat with a back, fitted with aseat belt guide at shoulder level.
Remember to fasten the seat belt or the child seat harness keeping the slackin relation to the child's body to a minimum, even for short journeys.
* According to current legislation in the country.** Consult the relevant administration in your country for information regarding
the rules for transporting children on the front passenger seat.
Rules for transporting childrenon the front passenger seat**
Children under the age of 10 mustnot travel in the forwards facingposition, unless the rear seats arealready occupied by other childrenor the rear seats cannot be used(absent or folded). In this case,adjust the front passenger seat tothe intermediate position and leavethe passenger air bag armed.The transportation of children in therearwards facing position is permit-ted. In this position, it is essential todisarm the passenger air bag.Otherwise, the child would risk beingkilled or seriously injured if the airbag were to inflate.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
43/78
CHILD SEATS RECOMMENDED BY PEUGEOT
PEUGEOT offers a complete range of child seats which are secured using the seat belt:
Group 0+: from birth to 13 kg
L1 - "Britax Babysure": installed in the rear-facing position in the front and in the rear using a three-point seat belt.
In the front, it is compulsory to disarm the passenger air bag and the vehicle's seat must be adjusted to the intermediatelongitudinal position.
Group 1: from 9 to 18 kg
L2 - "Rmer Prince": installed in the rear using a two or three-point seat belt.
For the safety of your child, it is imperative that the restraining cushion is used.
Group 2: from 15 to 25 kg
L3 - "Rmer Vario'': installed in the rear using a two or three-point seat belt.
22-12-2003
YOUR PARTNER IN DETAIL58
-
5/20/2018 Peugeot Partner Owners Manual 2004
44/78
22-12-2003
Groups 2 and 3: from 15 to 36 kg
L4 - "Recaro Start'': installed in the rear using a three-point seat belt.
The height and width at the shoulders and length of the seat cushion mustbe adjusted according to the age and build of your child.
L5 - "Klippan Optima": installed in the rear using a three-point seat belt.From the age of 6 years (approximately 22 kg), the booster is used on its own.
Groups 1, 2 and 3: from 9 to 36 kg
L6 - "Kiddy Life": installed in the rear using a three-point seat belt.
The height and width at the shoulders and the length of the seat cushionmust be adjusted according to the age and build of your child.
For the safety of young children (from 9 to 18 kg), PEUGEOT recommendsuse of the restraining cushion.
Never leave one or morechildren alone and unsu-pervised in a vehicle.
Never leave a child or ananimal in a vehicle which isexposed to the sun and has the
windows closed.To protect your young childrenfrom the sun, fit blinds on the rearwindows.
Never leave the keys withinreach of children inside the vehi-cle.
Observe strictly the recommen-dations for assembling andsecuring the child seat as shownin the child seat instructions.
To prevent the doors from openingaccidentally, use the child lock*.
Also, do not open the rear windowsmore than a third*.
* According to model.
Disarm the passenger air bag when installing a "rearwards facing" childseat on the front passenger seat. Otherwise, the child would risk beingkilled or seriously injured were the air bag to inflate.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
45/78
SUMMARY TABLE FOR THE INSTALLATION OF CHILD SEATS
In accordance with European regulations (Directive 2000/3), the table below indicates the options for the installation of childseats secured using the seat belt and universally approved (child seats which can be installed in all vehicles using a seatbelt), in accordance with the weight of the child and the seat in the vehicle:
U : seat suitable for the installation of a child seat secured using the seat belt and "universally" approved. "Rear facing" and"forward facing" child seats.
(a) Group 0: from birth to 10 kg.
(b) The rules for transporting children on the front passenger seat are specific to each country. Consult the legislation in forcein your country.
Weight of the child and indicative ageSeat
Weight below 13 kg Weight from 9 to 18 kg Weight from 15 to 25 kg Weight from 22 to 36 kg(groups 0 (a) and 0+) (group 1) (group 2) (group 3)
From birth to From From From1 year approx. 1 to 3 years approx. 3 to 6 years approx. 6 to 10 years approx.
Front passenger seat (b) U U U U
22-12-2003
6 YOUR PARTNER AT A GLANCE
-
5/20/2018 Peugeot Partner Owners Manual 2004
46/78
SEATS
Driver and passenger seats
1 - Head restraint heightadjustment.
Never travel with the
head restraints removed.
2 - Seat back angle adjustment.
3 - Forwards-backwards adjustment.
4 - Storage drawer (passenger ordriver).
52
YOUR PARTNER IN DETAIL60
-
5/20/2018 Peugeot Partner Owners Manual 2004
47/78
22-12-2003
SEAT BELTS
Seat belt height adjustment
To lower or raise: slide the controldownwards or upwards.
Fastening the seat belts
Pull the strap, then insert the end intothe buckle.
Seat belts with pre-tensioner
Safety in the event of front impacts
has been improved by the introduc-tion of seat belts with pre-tensioner.
Depending on the seriousness of theimpact, the pre-tensioning systeminstantly tightens the seat belts andpulls them against the bodies of theoccupants.
The pre-tensioning seat belts areactive when the ignition is on.
To be effective, a seatbelt must be tightenedas close to the body aspossible.
Depending on the nature and
seriousness of the impact, thepre-tensioning system may betriggered before and indepen-dently of the air bags.
In all cases, the air bag warninglight on the instrument panelcomes on.
Following an impact, have thesystem checked by a PEUGEOTdealer.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
48/78
THE KEYS
The keys allow you to switch on theignition and operate the passengerair bag disarming switch as well as toindependently operate the locks onthe doors and the fuel filler cap.
Central locking
From the front doors, the keys allowyou to lock, deadlock and unlock thedoors and tailgate.
If one of the doors or the tailgate isopen, the central locking does notwork.
The remote control performs thesame functions at a distance.
Locating your vehicle
To locate your vehicle, if you havelocked it, in a car park:
press button A, the courtesylights come on and the directionindicators flash for a few seconds.
The remote controlLockingPress button A to lock the vehicle.This is confirmed by fixed lighting ofthe direction indicators for approxi-mately two seconds.
DeadlockingDeadlocking renders the interior andexterior door controls inoperative.
Pressing buttonA deadlocks the vehicleThis is confirmed by fixed lighting ofthe direction indicators for approxi-mately two seconds.Pressing button A again within fiveseconds following deadlocking switch-es from deadlocking to simple locking.This is confirmed by fixed lighting ofthe direction indicators for approxi-
mately two seconds.UnlockingPress button B to unlock the vehicle.This is confirmed by rapid flashing ofthe direction indicators.Note: if the vehicle is locked andunlocking is activated inadvertently,unless the doors are opened within30 seconds, the vehicle will lockautomatically.
Changing the battery of theremote control
The "battery flat" information is pro-vided by an audible signal accompa-nied by the message "Remote con-trol battery flat" on the screen.
To change the battery, unclip thecasing using a coin at the ring(CR 2016/3 volt battery).
If the remote control does not workafter the battery has been changed,re- programme the remote control.
Programming the remotecontrol
Switch off the ignition.
Switch the ignition on again. Press button A immediately for a
few seconds.
Switch off the ignition and removethe remote control key from theignition lock. The remote control isnow working again.
22-12-2003
YOUR PARTNER IN DETAIL62
-
5/20/2018 Peugeot Partner Owners Manual 2004
49/78
Confidential card
The confidential card contains theidentification code necessary for anywork carried out by a PEUGEOTdealer on the electronic immobiliser
system. This code is hidden by afilm, which should be removed only ifnecessary.
Keep your card in a safe place,never inside the vehicle.
Key in ignition
A buzzer sounds on opening thedriver's door, if the key has been leftin the ignition.
ELECTRONIC ENGINEIMMOBILISER
This locks the engine control systemas soon as the ignition has beenswitched off and therefore preventsstarting of the vehicle by anyone
who does not have the key.The ignition key has an electronicchip which has a special code.When the ignition is switched on, thecode must be recognised for startingto be possible.
If the system does not functioncorrectly, the central locking buttonindicator light, situated in the centreof the fascia, flashes rapidly whenthe ignition is switched on (2nd
notch), accompanied by an audiblesignal.
In this case your vehicle will notstart.
Contact a PEUGEOT dealer assoon as possible.
22-12-2003
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
50/78
Make a careful note of the number on each key. The key number is coded on the label attached to the key.
If the keys are lost, your PEUGEOT dealer can rapidly supply you with new keys.
The high frequency remote control is a sensitive system; do not operate it while it is in your pocket as there is apossibility that it may unlock your vehicle, without you being aware of it.
The remote control does not operate when the key is in the ignition, even when the ignition is switched off, except for
reprogramming.Do not operate the deadlocking function if there is anyone inside the vehicle.
Driving with the doors locked may make access to the passenger compartment by the emergency services more difficultin an emergency.
As a safety precaution (with children on board), remove the ignition key when you leave the vehicle, even for a short time.
Do not repeatedly press the button of your remote control out of range of your vehicle.
You run the risk of stopping it from working and the remote control would have to be reprogrammed.
When purchasing a second-hand vehicle:
ensure that you are given the confidential card;
have the key codes memorised by a PEUGEOT dealer, to ensure that the keys in your possession are the only oneswhich can start the vehicle.
Do not make any modifications to the electronic engine immobiliser system.
22-12-2003
YOUR PARTNER IN DETAIL62
-
5/20/2018 Peugeot Partner Owners Manual 2004
51/78
Confidential card
The confidential card contains theidentification code necessary for anywork carried out by a PEUGEOTdealer on the electronic immobilisersystem. This code is hidden by afilm, which should be removed only ifnecessary.
Keep your card in a safe place,never inside the vehicle.
Key in ignition
A buzzer sounds on opening thedriver's door, if the key has been leftin the ignition.
ELECTRONIC ENGINEIMMOBILISER
This locks the engine control systemas soon as the ignition has beenswitched off and therefore preventsstarting of the vehicle by anyone
who does not have the key.The ignition key has an electronicchip which has a special code.When the ignition is switched on, thecode must be recognised for startingto be possible.
If the system does not functioncorrectly, the central locking buttonindicator light, situated in the centreof the fascia, flashes rapidly whenthe ignition is switched on (2nd
notch), accompanied by an audiblesignal.
In this case your vehicle will notstart.
Contact a PEUGEOT dealer assoon as possible.
22-12-2003
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
52/78
Make a careful note of the number on each key. The key number is coded on the label attached to the key.
If the keys are lost, your PEUGEOT dealer can rapidly supply you with new keys.
The high frequency remote control is a sensitive system; do not operate it while it is in your pocket as there is apossibility that it may unlock your vehicle, without you being aware of it.
The remote control does not operate when the key is in the ignition, even when the ignition is switched off, except for
reprogramming.Do not operate the deadlocking function if there is anyone inside the vehicle.
Driving with the doors locked may make access to the passenger compartment by the emergency services more difficultin an emergency.
As a safety precaution (with children on board), remove the ignition key when you leave the vehicle, even for a short time.
Do not repeatedly press the button of your remote control out of range of your vehicle.
You run the risk of stopping it from working and the remote control would have to be reprogrammed.
When purchasing a second-hand vehicle:
ensure that you are given the confidential card;
have the key codes memorised by a PEUGEOT dealer, to ensure that the keys in your possession are the only oneswhich can start the vehicle.
Do not make any modifications to the electronic engine immobiliser system.
22-12-2003
YOUR PARTNER IN DETAIL64
-
5/20/2018 Peugeot Partner Owners Manual 2004
53/78
22-12-2003
FRONT DOORS AND SLIDINGSIDE DOORS
Front doors
Side doors
Opening the doors from outside
Locking/Unlocking fromthe inside
Front doors
To lock, lower button A.
The closing control of one of the frontdoors permits complete locking of
the vehicle.
To unlock and open, lift button A andpull the handle towards you.
The driver's door opening controlpermits complete unlocking of thevehicle.
Sliding side doors
The side door opening/closing controlonly controls the door concerned.
To close, push the control B forwardsand slide the door.
To open, pull the control B rearwardsand slide the door.
Note: if the fuel tank cap is removed,the right-hand side door cannot beopened.
Side doors
Opening the doors from inside
The driver's door opening controlpermits complete unlocking of thevehicle.
Front doors
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
54/78
22-12-2003
Locking from the inside
Lower or raise control C to lock orunlock from the inside.
Locking from the inside
Pressing control D operates the
central locking, when the doors areclosed.
Unlocking from the inside
Press control D.
It is still possible to open the doorsfrom the inside.
Note:
doors locked and ignition off: theindicator light flashes,
doors locked and ignition on: theindicator light remains on.
Automatic central locking
Your vehicle can lock automaticallywhile driving (speed greater than6 mph (10 km/h)). You can activateor deactivate this function.
Activation
Press and hold control D.
Activation of the function isaccompanied by an audible signal.
Deactivation
Press and hold control D.
Deactivaton of the function isaccompanied by an audible signal.
YOUR PARTNER IN DETAIL66
-
5/20/2018 Peugeot Partner Owners Manual 2004
55/78
22-12-2003
REAR DOORS
Opening the doors from outside
To open, pull the rear right door han-dle C towards you and open the rearleft door by pulling the lever D on theinside.
You can unlock the rear doors byinserting the key in the lock E.
LOCKING/UNLOCKINGTHE TAILGATE
To open the tailgate, operate thehandle A and lift it.
You can unlock the tailgate by
inserting the key in the lock B.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
56/78
Opening the rear doors to 180
To open the rear doors to 180,release the check strap C towardsyou when the door is partially open.
When closing the door, the checkstrap hooks itself in place againautomatically.
Opening the doors from inside
The rear door opening controls only unlock these doors.
To open, lift lever A.
To open the other door, push lever B.
Note: when closing from the inside, close the right-hand door first ensuring thatlever B is in the vertical position then close the left-hand door.
22-12-2003
YOUR PARTNER IN DETAIL66
-
5/20/2018 Peugeot Partner Owners Manual 2004
57/78
22-12-2003
REAR DOORS
Opening the doors from outside
To open, pull the rear right door han-dle C towards you and open the rearleft door by pulling the lever D on theinside.
You can unlock the rear doors byinserting the key in the lock E.
LOCKING/UNLOCKINGTHE TAILGATE
To open the tailgate, operate thehandle A and lift it.
You can unlock the tailgate by
inserting the key in the lock B.
YOUR PARTNER IN DETAIL68
-
5/20/2018 Peugeot Partner Owners Manual 2004
58/78
22-12-2003
REAR ROOF FLAP
To open the rear flap:
pull the lever A,
lift the rear flap,
pass the point of resistance tosecure it using the retaining strutsB.
To close the rear flap:
check that the support bar issecured correctly,
lower the rear flap to lock it.
LONG LOAD SUPPORT BAR
A support bar is provided for transporting long loads, after opening the rear roofflap.
Fold back the support bar by lifting the lever C.Support it to the door pillar.Support the long loads to be transported.Reposition the support bar with one hand.Ensure that it is secured correctly.
Notes:
the side openings D can be used as hooking points. the rear bumper has been strengthened to serve as a footrest on entering the
vehicle.
Never drive without the support bar in place.The rear doors only lock when the support bar is installed.When the rear roof flap is open, take care when driving under over-hangs of limited height.
Use a regulation device when a load protrudes from your vehicle by more thanone metre.Never rest a load directly on the rear doors.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
59/78
22-12-2003
OPENING THE BONNET
Inside the vehicle: pull the handle on
the left-hand side, under the fascia.Outside the vehicle: lift the catchand raise the bonnet.
BONNET STRUT
Secure the strut to hold the bonnet
open.Before closing the bonnet, replacethe strut in its housing.
To close
Lower the bonnet and release it atthe end of its travel. Check that thebonnet is locked.
YOUR PARTNER AT A GLANCE
-
5/20/2018 Peugeot Partner Owners Manual 2004
60/78
AIR BAGS
The air bag system has beendesigned to maximise the safetyof the occupants in the event of
serious collisions. It works in con-junction with the pretensioningseat belts.
Front air bags
These are folded in the centre ofthe steering wheel for the driverand in the fascia for the front pas-senger. They are deployed simulta-neously, except in cases where thepassenger air bag is disarmed.
Precautions regardingthe passenger air bag
disarm the air bag if you installa rear-facing child seat,
activate the air bag for anadult passenger.
Disarming the passengerair bag*
With the ignition off, insert theignition key into the passen-ger air bag slot 1 and turn it tothe "OFF" position.
As soon as you remove the childseat, turn the air bag switch to the"ON" position to activate the airbag again.
Operating check
With the ignition switchedon (2nd notch), illumina-tion of this warning lightindicates that the pas-
senger air bag is disarmed (slot inthe "OFF" position).The warning light remains onthroughout the disarming process.
Side air bags*
Side air bags are incorporatedinto the front seat back frame, onthe door side.
They are deployed independentlyof each other, on whichever sidethe collision occurs.
* According to destination82 83
YOUR PARTNER IN DETAIL70
A i di i i d hi h
-
5/20/2018 Peugeot Partner Owners Manual 2004
61/78
22-12-2003
FILLING WITH FUEL
Low fuel level
When the minimumfuel level in the tank isreached, this warninglight comes on.
You have enough fuel remaining todrive for approximately 30 miles(50 km).
The engine must be switched offwhen filling with fuel.
Insert the key then turn it to the
left. Remove the cap.
An indication reminds you whichtype of fuel to use.
When you fill your tank, do not con-tinue after the third cut-off of thepump. This could cause your vehicleto malfunction.
The capacity of the tank isapproximately 55 litres for petrolengines and 60 litres for Dieselengines.
After filling the tank, lock the cap.
When the cap is removed,the right-hand sliding sidedoor cannot be opened.
The key cannot be removed fromthe lock until the cap has beenreplaced on the fuel tank.
YOUR PARTNER IN DETAIL
"F ll h " li htiF t f l d
-
5/20/2018 Peugeot Partner Owners Manual 2004
62/78
THE LIGHTS STALK
Front and rear lightsSelection is by turning ring A.
Lights off
Side lights
Dipped/main beamheadlamps
Dipped/Main beam change
Pull the stalk towards you.
Note: with the ignition off, when thedriver's door is opened, a buzzersounds if you have left your lights on.
Vehicles fitted with a rear foglamp only (ring B)
Rotate the ring forwards.
This only operates with the dipped/main beam headlamps.
Vehicles fitted with front fog
lamps and a rear fog lamp(ring B)
Front fog lamps (first rotation of thering forwards)
Front and rear fog lamps (2nd rota-tion of the ring forwards)
Note: to switch off the rear fog lampand the front fog lamps, turn the ringbackwards twice in succession.
"Follow-me-home" lighting
In poor light, or at night, if you leaveyour vehicle, the side lights anddipped headlamps may remain onfor approximately one minute.
To activate this function:
place the key in the STOP posi-tion,
place the lights stalk in position O,
flash the headlamps,
exit the vehicle and lock it.
Direction indicators(flashers)
Left: downwards.
Right: upwards.
Front fog lamps andrear fog lamp
Rotate the ring forwards to switch onand backwards to switch off. The
status is confirmed by the indicatorlight on the instrument panel.
In good or rainy weather,both day and night, the
front fog lamps and therear fog lamp are dazz-ling and are prohibited.
Do not forget to switch them offwhen they are no longer needed.
22-12-2003
YOUR PARTNER IN DETAIL72
In the Intermittent position the wip Note: if a bicycle carrier is usedWINDSCREEN
-
5/20/2018 Peugeot Partner Owners Manual 2004
63/78
22-12-2003
Front windscreen wiper
2 Fast wipe (heavy rain).1 Normal wipe
(moderate rain).I Intermittent wipe.0 Off. Single wipe
(press downwards).
Operation
In position 1 or 2, when the vehiclestops, the windscreen wiper
changes to a lower wiping speed,then resumes its initial speed whenthe vehicle starts again.
In the Intermittent position, the wip-ing speed is proportional to thespeed of the vehicle.
Windscreen and headlamp wash
Pull the windscreen wiper stalk
towards you. The windscreen washthen the windscreen wipers operatefor a fixed period.
The windscreen wash and head-lamp wash operate simultaneouslyfor two seconds, only if the head-lamps are on.
Note: if a bicycle carrier is used,contact a PEUGEOT dealer to havethis function disarmed.
WINDSCREENWIPER STALK
Rear windscreen wash
Turn ring A past the firstnotch: the windscreen washthen the windscreen wiperoperate for a fixed time.
Rear windscreen wiper
Turn ring A to the first notch.The wiping speed isinversely proportional to the
speed of the vehicle.
Automatic rear windscreen wiping
place the front wipers stalk in a
position other than 0. engage reverse gear.
the rear wiper operates with inter-mittent wiping.
In winter, in the event of aconsiderable amount ofsnow or ice, switch on therear screen demister.Once de-icing is complete,
remove the snow or ice which has
accumulated on the rear wiperblade. You can now operate therear windscreen wiper.
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
64/78
ELECTRIC WINDOWS
1. Driver's electric windowswitch
2. Passenger electric windowswitch
You have two options:
Manual operation:
Press switch 1. The window stopsas soon as the switch is released.
Automatic operation (driver):
Press and hold switch 1. Onetouch completely opens or closesthe window.
Automatic closing only operateswhen the engine is running.
Always remove the igni-tion key when leaving thevehicle, even for a shorttime.
If an obstacle is encounteredwhile the electric windows are inuse, you must reverse the move-ment of the window. To do this,press the switch concerned.
When the driver operates thepassenger electric windowswitches, he must ensure that noone is preventing correct closingof the windows.
The driver must ensure that pas-sengers use the electric windowscorrectly.
Be aware of children when oper-
ating the windows.
22-12-2003
YOUR PARTNER IN DETAIL
-
5/20/2018 Peugeot Partner Owners Manual 2004
65/78
AREAS FOR TOLL CARDS/CAR PARK TICKETS
The athermic windscreen has two
non-reflective zones located eitherside of the base of the interior mirror.
They are intended for affixing tollcards and/or car park tickets.
HEADLAMP ADJUSTMENT
Depending on the load in your vehi-cle, it is recommended that the
headlamp beam is adjusted.
0 1 or 2 people in the front seats.
3 people.
1 5 people.
2 5 people + maximum authorisedload.
3 Driver + maximum authorisedload.
Initial setting is position 0.
22-12-2003
YOUR PARTNER IN DETAIL76
-
5/20/2018 Peugeot Partner Owners Manual 2004
66/78
HORN
Press one of the spokes orthe centre of the steering
wheel.
22-12-2003
STEERING WHEEL HEIGHT
ADJUSTMENT
When stationary, push the handle
fowards to unlock the steeringwheel.
Adjust it to the desired height.
Pull the handle towards you fully tolock the steering wheel.
HAZARD WARNING LIGHTS
Press the button, the direction indi-cators flash.
They can operate with the ignitionoff.
YOUR PARTNER IN DETAIL78
-
5/20/2018 Peugeot Partner Owners Manual 2004
67/78
22-12-2003
YOUR PARTNER IN DETAIL
FRONT FITTINGS
-
5/20/2018 Peugeot Partner Owners Manual 2004
68/78
22-12-2003
1. Storage in the doors
A. Bottle holder.
B. Can holder.
C. Storage compartment.
2. Overhead storage with map reading light
Overhead storage maximum load: 5 kg.
3. Courtesy light
4. Sun visors
5. Glove box
To open the glove box with cover, lift the handle (version with air conditioning).
6. Lighter
7. Removable ashtray
Pull the cover to open the ashtray.
To empty, after opening, remove it by pulling upwards.
8. 12 V accessories socket
This is located at the bottom of the centre console.
It permits the connection of a telephone charger, a baby's bottle warmer, ...
9. Storage drawer
To open the drawer, lift it slightly and pull it forwards.
8 YOUR PARTNER AT A GLANCE
-
5/20/2018 Peugeot Partner Owners Manual 2004
69/78
ELECTRIC WINDOWS
1 - Driver's electric window.2 - Passenger's electric window.
Manual mode:
Press the switch. The window stops as soon as the switch is released.
Automatic mode (driver):
Press and hold the switch. One touch completely opens or closes the window.
73
Move the manual control 3 in all four directions to adjust.
Electric control for the passenger's side mirror
From the driver's seat, adjust in all four directions by operating the control 4.74
EXTERIOR MIRRORS
ANTI-LOCK BRAKINGSYSTEM (ABS)
YOUR PARTNER IN DETAIL80
-
5/20/2018 Peugeot Partner Owners Manual 2004
70/78
HANDBRAKE
Applying
When parking, pull the handbrake toimmobilise your vehicle.
Releasing
Pull the handle and press the buttonto release the handbrake.
Illumination of this warninglight and of the STOP warn-ing light, accompanied by
an audible signal (while thevehicle is moving), indicates that thehandbrake is still applied or has notbeen released fully.
SYSTEM (ABS)
The ABS with Electronic BrakeForce Distribution (EBFD) increasesthe stability and manoeuvrability of
your vehicle, particularly on poor orslippery road surfaces.
Note: when changing wheels (tyresand rims), make sure that these areapproved.
The anti-lock braking system comesinto operation automatically whenthere is a risk of wheel lock.
Illumination of this warning light,accompanied by an audible signal,indicates a malfunction of the elec-tronic brake force distribution, which
can cause a loss of control of thevehicle when braking.
Stop immediately.
Contact a PEUGEOT dealer.
22-12-2003
Normal operation of the ABS maymake itself felt by slight vibrationsof the brake pedal.
In emergency braking, pressvery firmly without releasingthe pressure.
YOUR PARTNER IN DETAIL
Operation Changing a memorised speed
-
5/20/2018 Peugeot Partner Owners Manual 2004
71/78
22-12-2003
CRUISE CONTROL
Cruise control enables the vehicle tomaintain a steady speed programmedby the driver, regardless of the road
characteristics and without the driverhaving to touch the accelerator orbrake pedals.
In order for it to be memorised, thevehicle speed must be greater than25 mph (40 km/h), and fourth gear atleast must be engaged.
Place switch 1 in the ON position.A speed can be memorised.
Place switch 1 in the OFF positionto cancel.
Memorising a speed
As soon as you reach the chosenspeed, press button 2 or 3. Thismemorises the speed, which will bemaintained automatically.
Note: It is possible to accelerate anddrive momentarily at a speed greaterthan the memorised speed. Whenthe accelerator pedal is released, thevehicle will return to the memorisedspeed.
Cancelling the memorisedspeed
If you wish to cancel the memorisedspeed:
press button 4 or the brake or clutchpedal.
Recalling the memorised speedAfter cancellation, press button 4.Your vehicle will return to the lastmemorised speed.
To memorise a speed higher thanthe previous one: press button 3; release it when you have reached
the required speed.
To memorise a speed lower than theprevious one:
press button 2;
release it when you have reachedthe required speed.
Cancelling the cruise control
Place switch 1 in the OFF positionor switch off the ignition.
Do not use cruise control onslippery roads or in heavytraffic.
PRACTICAL INFORMATION88
CHECKING THE LEVELS Viscosity selectionI ll h il l d
Slacken the cap to the first notch torelease the pressure to prevent any
-
5/20/2018 Peugeot Partner Owners Manual 2004
72/78
22-12-2003
Oil level
Check the level regularly and topup between changes. The maxi-mum consumption is 0.5 l per600 miles (1 000 km).
Check the level with the vehicleon level ground, engine cold,using the oil level gauge on theinstrument panel or the dipstick.
Dipstick
There are two marks onthe dipstick:
A = maximum
Never fill past this mark.B = minimum
To maintain the reliabilityof engines and emissioncontrol systems, the useof additives in engine oilis prohibited.
In all cases, the oil selected mustmeet the manufacturer's require-ments.
Brake fluid level: The level must always be
between the DANGER and MAXI-MUM marks in the reservoir.
If the level drops substantially,contact a PEUGEOT dealerimmediately.
Fluid change:
Must be carried out according tothe manufacturer's servicingschedule.
Use fluids recommended by themanufacturer, which fulfil DOT4standards.
Note: Brake fluid is harmful to healthand very corrosive. Avoid all contactwith the skin.
Cooling system
Use the fluid recommended by themanufacturer.
When the engine is warm, thetemperature of the coolant iscontrolled by the engine fan. As this
fan can operate with the ignition keyremoved and because the coolingsystem is pressurised, wait for atleast one hour after the engine hasstopped before carrying out anywork.
release the pressure to prevent anyrisk of scalding. When the pressurehas dropped, remove the cap andtop up the level.
Note: The coolant does not need tobe changed.
Used oil
Do not dispose of used oil, brakefluid or coolant into drains or into theground.
Power steering reservoir
Open the reservoir, with the
engine at ambient temperature.The level should always beabove the MIN. mark and closeto the MAX. mark.
Windscreen and headlamp*wash level
For best quality cleaning and foryour safety, we would advise thatyou use products recommended byPEUGEOT.
* According to destination.
Oil change
According to the information given in"PEUGEOT SERVICING".
Note: Avoid used oil from cominginto prolonged contact with the skin.
PRACTICAL INFORMATION
RUNNING OUT OF FUEL(DIESEL)
CHECKS Oil filter
-
5/20/2018 Peugeot Partner Owners Manual 2004
73/78
Only use products recom-mended by PEUGEOT.
To ensure best perform-ance from components as impor-tant as the power steering and thebraking system, PEUGEOTselects and offers quite specificproducts.
To prevent damage to the elec-trical units, avoid washing theengine.
22-12-2003
(DIESEL)
If you should run out of fuel, it isnecessary to re-prime the circuit: fill the fuel tank with at least five
litres of diesel,
operate the manual re-primingpump, under the bonnet under theprotective cover, until fuelappears in the transparent pipe,
operate the starter until theengine starts.
FUEL SUPPLY CUT-OFF
(PETROL)In a serious collision, a mechanismprevents fuel from reaching theengine.
To re-establish the fuel supply, pressthe switch on the corner of the frontright-hand suspension assembly,under the bonnet.
Battery
At the start of winter, have yourbattery checked by a PEUGEOTdealer.
Air filter and passengercompartment filterHave the filter elements replacedregularly. If you drive in dusty con-ditions, change them twice asoften.
Brake pads
Brake pad wear depends on thestyle of driving, in particular for vehi-cles which are used in town, overshort distances.
It may be necessary to check thethickness of the pads, even betweenservices.
Handbrake
Where the handbrake travel is toogreat or there is a reduction in theperformance of the system, thehandbrake should be adjusted, evenbetween services.
Have the system checked by aPEUGEOT dealer.
Change the filter regularly, in accor-dance with the servicing schedule.
Manual gearbox
This does not require an oil change.Check the level in accordance with themanufacturer's servicing schedule.
YOUR PARTNER AT A GLANCE
To activate
-
5/20/2018 Peugeot Partner Owners Manual 2004
74/78
STEERING WHEEL HEIGHTADJUSTMENT
When stationary, push thecontrol A forwards to unlockthe steering wheel.
Adjust the height of the steer-ing wheel.
Lock it by pulling control Atowards you fully.
76
CRUISE CONTROL
The cruise control makes it possi-ble to maintain a constant vehiclespeed, programmed by the driv-er, irrespective of the profile of
the road and without any actionon the accelerator or the brakepedal.
In order for the vehicle speed to bememorised, it must be greater thanapproximately 25 mph (40 km/h)and fourth or fifth gear must beengaged.
Place the knob 1 in the ONposition.
A speed can now be memo-rised.
Place the knob 1 in the OFFposition to deactivate thesystem.
Memorising a speed
When you reach the requiredspeed, press button 2 or 3. Thespeed is memorised and will bemaintained automatically.
Deactivating
the memorised speedIf you wish to deactivate thememorised speed:
press button 4 or the brake orclutch pedal.
Recalling the memorisedspeed
After deactivation, press button 4.Your vehicle reverts to the lastmemorised speed.
Cancelling the storedspeed
Place the knob 1 inthe OFF position orswitch off the ignition.
81
PRACTICAL INFORMATION90
-
5/20/2018 Peugeot Partner Owners Manual 2004
75/78
10-11-2003
CHANGING A WHEEL
Parking the vehicle
If possible, park the vehicle onlevel, stable and non-slipperyground.
Apply the handbrake, switch offthe ignition and engage first orreverse gear.
Access to the spare wheel andthe jack
The wheel is located outside thevehicle, under the rear floor, sup-
ported by a metal carrier. Remove the jack and the wheel-
brace 1, secured behind the dri-ver's seat.
Using the wheelbrace 1, slacken the spare wheel carrier retaining bolt, locatedon the inside near the closing system.
Lift the carrier to release the hook rearwards, then lower it.
Remove the chock 2 located in the spare wheel.
Removing a wheel
Chock the rear of the wheel diagonally opposite the wheel to be changed,using the chock 2.
Remove the wheel trim using the wheelbrace 1, by pulling at the valve pas-sage hole.
Slacken the wheel bolts.
Place the jack under the locating point on the sub-frame A that is closest tothe wheel to be changed. Ensure that the entire surface of the jack base plateis in contact with the ground.
Extend the jack, completely unscrew the bolts and remove the wheel.
PRACTICAL INFORMATION
For your safety, always
-
5/20/2018 Peugeot Partner Owners Manual 2004
76/78
10-11-2003
Refitting the wheel
After positioning the wheel, lightly pre-tighten the bolts using the wheelbrace.
Compress the jack and release it.
Fully tighten the bolts using the wheelbrace.
Replace the trim, starting at the valve passage hole, and press it on using thepalm of the hand.
Replacing the wheel in the carrier
Replace the chock 2 in the wheel.
Replace the wheel in the carrier.
Lift the wheel then the carrier and reposition the hook.
Do not forget to fully tighten the spare wheel carrier retaining bolt.
Stow the wheelbrace 1 and the jack.
change a wheel:
on level, stable and non slipperyground,
with the handbrake applied,
wiith first or reverse gearengaged,
with the vehicle chocked,
never go underneath a vehicleraised using a jack (use an axlestand).
After changing the wheel
Have the tightening of the boltsand the pressure of the sparetyre checked as soon as possi-ble by a PEUGEOT dealer.
Have the punctured tyrerepaired and replace it on thevehicle as soon as possible.
PRACTICAL INFORMATION90
-
5/20/2018 Peugeot Partner Owners Manual 2004
77/78
22-12-2003
CHANGING A WHEEL
Parking the vehicle
If possible, park the vehicle onlevel, stable and non-slipperyground.
Apply the handbrake, switch offthe ignition and engage first orreverse gear.
Access to the spare wheel andthe jack
The wheel is located outside thevehicle, under the rear floor, sup-
ported by a metal carrier. Remove the jack and the wheel-
brace 1, secured behind the dri-ver's seat.
Using the wheelbrace 1, slacken the spare wheel carrier retaining bolt, locatedon the inside near the closing system.
Lift the carrier to release the hook rearwards, then lower it.
Remove the chock 2 located in the spare wheel.
Removing a wheel
Chock the rear of the wheel diagonally opposite the wheel to be changed,using the chock 2.
Remove the wheel trim using the wheelbrace 1, by pulling at the valve pas-sage hole.
Slacken the wheel bolts.
Place the jack under the locating point on the sub-frame A that is closest tothe wheel to be changed. Ensure that the entire surface of the jack base plateis in contact with the ground.
Extend the jack, completely unscrew the bolts and remove the wheel.
PRACTICAL INFORMATION
For your safety, alwaysh h l
-
5/20/2018 Peugeot Partner Owners Manual 2004
78/78
22-12-2003
Refitting the wheel After positioning the wheel, lightly pre-tighten the bolts using the wheelbrace.
Compress the jack and release it.
Fully tighten the bolts using the wheelbrace.
Replace the trim, starting at the valve passage hole, and press it on using thepalm of the hand.
Replacing the wheel in the carrier Replace the chock 2 in the wheel.
Replace the wheel in the carrier.
Lift the wheel then the carrier and reposition the hook.
Do not forget to fully tighten the spare wheel carrier retaining bolt.
Stow the wheelbrace 1 and the jack.
change a wheel:
on level, stable and non slipperyground,
with the handbrake applied,
with first or reverse gearengaged,
with the vehicle chocked,
never go underneath a vehicleraised using a jack (use an axlestand).
After changing the wheel
Have the tightening of the boltsand the pressure of the spare
tyre checked as soon as possi-ble by a PEUGEOT dealer.
Have the punctured tyrerepaired and replace it on thevehicle as soon as possible.