-V',,'\

NOTICE

SUB:- QRS/SPECIFICATIONIN RIO ROVERVEHICLE

This is general information ofthe firms/manufacturers dealing with the lightmotor vehicle(4x2,4x4) that mentioned QRs as per appendix-"A" & Provision .forFixing, Installing Telecommunication Equipments as per appendix- "B" enclosed,With Drawing have been framed by board of officer of sub group of CAPF.All the

1interested vendors/firms are requested to go through the same and give their,comments/suggestions. if any by.07-01-15 on e.maillD .Itcelldelhi@ITBP.Gov-in,2. A hard copy of suggestion may also be sent in Fax no.(011-26046834) To Dy.Inspector General, SHQ(DELHI) ITBPOLICEMHA/Govt. Of India. Po- Madangir

I .Tigri Camp New Delhi 110062 ,so as to reach this office byt5'-01-15.

I

\I

1II

Ii

IIII!I

ItI'

Appendix "A"

O.R.lSpecification & Trial Directives in R/o Rover Vehicles.wS.No Parameter O.R.lSnecification

i) The vehicle primarily be used foproviding effective communication betweencarcade /convey and also up to base station

1 General (i.e. Coy/unit HQ.Other estt. etc.)ii) Vehicles should be Light Motor Vehicle4X2 / 4X4 wheel drive meeting latest CMVRnorms. (user to decide as per theirreauirement & area of deolovmentlEngine should be direct injection commonrail turbo charged diesel engine withprovision of overheat protection and toprevent seizure of engines in extreme coldcondition, engine shall meet at least 8S.11Ior better (user to specify as per their areaof deployment) emission norms prescribedin latest CMVR with modification &applicable to special purpose vehicleswherever required confirming toARAI/SAE/VRDE standard max grosspower not less than SOkw, Torque not less170 NM in between 1000-2200 RPM.

2 Engine ORPetrol engine MPFI with provision ofoverheat protection & to prevent seizure ofengine in extreme cold conditions. Engineshall meet at least 8S-11Ior better(user tospecify as per their area of deployment) &above emission norms prescribed in latestCMVR, with modification & applicable tospecial purpose vehicles whereverrequired conforming to ARAI/SAEstandard. max gross power not less than70kw Torque not less 130NM @ 1000-2800RPM.(Note:- Diesel/Patrol engine- user to decideas per reauirement & area of deployment.)

3 Clutch Sin!!le Plate drv friction tvDei) Minimum S speed manual.ii) Type synchromesh in all fwd gears &

4 rransmission constant mesh in reverse gear.iii) No of gear minimum S forward & one

reverse.S Steerin!! Power steerin!!

Front-Independent Suspension along with6 Suspension anti roll bar, telescopic shock absorber

Rear-semi elliptical spring telescopic shockabsorberi) Service brake-Tandem Master Cylindervacuum assisted with anti-lock brake

7 8rakes system.ii) Front-Ventilated Disc/drum.iii) Rear- Disc/Drum Typei) Radial Tubeless Tyres and provision

8 Tyres with fitting customized non-skid chain.ii) Provision for spare wheel.

Suggestions/comments

,.' . 1

I:

9 Fuel tank Not less than 50 Itrscapacity

10 Turning Rad. Not more than 07 mtrs.11 Ground Minimum 190

clearance12 Grade ability Min 30 degree & side slope sustaining

capabilitv at least max 15 de"ree.13 Piston 1200-3000cc

Displacement14 Overall i) Length 3900mm-6000mm

dimensions ii) Width 1500mm-2000mmiii) Height 1700mm-2000mmiv)wheel base 2400mm-2900mmwhere telecom equipments need to be

15 Load body installed minimum area length 1600mmwidth 1500mmSeats for four person(R.O. 02, R.T.01 &

16 Seats Runner with weapon 01) & all seatsj

provided with safety seat belts.17 Speed a) Not less than 90kmph fully loaded on.18 Special i) Provision for Toe-Hooks & D-

Feature shackles at front & rear.i) Cold starting facility and able to operate

Facilities & on Sub Zero level temperature up to -40'C19 Equipments ii) Bracket arrangement for fitting

Required GPS/Fire Extinguishers etc.a) Provision with tool kit rack, mechanicaljack, Shovel 01, Pick axis 01, Toe Wire 01workshop manual & service manual.

20 Documents b) Proper & secured place for keepingand tools Stove with Koil should be provided ..

c) . In addition to abdve space for keepingJ

Dry Ration, rice, dal etc provision should beprovided.Supplier to impart training to force

21 Training personnel for operation and maintenanceof the vehicle.Logistic support package shall be provided

22 Logistics including workshop repair manual.illustrated parts catalogue operation andmaintenance manual.After sale service to be provided on

23 After sale requirement along with supply of spareservice parts, maintenance parts should be readily

available for 15 years from the date ofpurchase.Supplier will provide guarantee formaintaining the vehicle for three year with

24 Warranty further extended warranty for the next fiveyear rates for such warranty should bequoted in offer as of cost.

(1- PROVISION FOR FIXING, INSTALLINGFOLLOWINGTELECOMMUNICATION EQUIPMENTS :-

Appendix "B"

S.NO PARTICULARS IQtv Wei~ht (K.1 OR/soecifications "'uouestions 'comments1 Mounting Bracket of HFTX / Rx LHP- 01 OSkg (+ 10kg for HF TX / Rx

26SD LHP-265D1 =15 k.05 kg (+ 4.4 kg for Mounting a) No unfinished joint are left open without finding and

2 Mounting Bracket of Mobile data 01 data equipment (SMART) burning.equipment(SMART) will be fitted on mounting b) Any supporting reinforcement from inside to protect from

trav1 = 9.4 k. inside to protect the vehicle against any side damage.3 Provision for Printer LX800DX (will 01 04kg c) All electrical wiring harness should be properly secured &

be fitted with well crow sten) have safe roof.4 Provision for VHF set 25watt (will be 01 03kg d) .Provision for fitting latest wireless and radio

fitted on mountin. bracket1 communication.5 ISATphone (it is hand held but can 01 - e) Fitting of the telecommunication equipment should be such

be fitted on ducking unit for use with that it prevent the entry of dust and particles into the system.external antenna 1 & sufficient space should be provided so that

6 provision for fitting of Vehicular 03 90kg telecommunication equipment be fitted easily.antenna for LHP-265D(rear side of f) Proper space for battery box with provisioo of slidingthe vehicle) (accommodating three batteries and printer will he placed)

7 Battery Bank of 12V 65AHCSMF 01 03kg g) Propel' space for AC/DC Gen Set EM-650.VRLABtvs.

8 AC/DC Gen set EM6S0 Honda/ 01 20 kgkirloskar etc.

Dimensions:-S.NO PARTICULARS LENGTH BREATH HEIGHT WEIGHT/ Suggestions/comments

rmm) rmm) . rmm1 HEIGHTFROMFLOOR1 Lower racklfibre/wooden 1 1000-1020 600-610 300-310 7S0mm above from the2 UDDerracklfibre/wooden 1 1000-1020 400-410 150-150 floor of veh.3 LHD-265 with mountin. trav 263-283 231-241 150-160 8ke4 SMARTwith mountin. trav 305-315 305-315 210-215 6ke5 Printer 430-440 315-325 158-165 5ke6 EM-650 Gen Set 410-420 270-280 375385 2Skg

7 Seat-l for 001'. and co-onr. 1000-1020 375-385 525-535 S2Smm above from the8 Seat-2 for 001'. and co-onr. 1000-1020 375-385 252-260 floor of veh.

-;" ' ..':' .

. ~ LAYOUT PLAN Of="ROVER" .VEHICL,E. - --.,"

HE ANTENNA. ...

NOrE--

EJIII- (i5() GEN

ALL }>IMENSION 'N MM"""",m.e.~~"lIo_:~~,

oIn-

Pf

..':'

., ~. ,", ' .

Tx DATA }:OCATA RS 232C

Nfr OIClrAJ.llEIWORK

. \.,. . ~":". :." .

".' .'. '.

iI

,SMART EOUIPMEi'fT

SETUP FO I TERFACE WITH DIGI~AL NETWORKFig. 4.5 (UNE DIAGRAM)

.. -- _ ..

..... ,. . ,".. ,!.

:, , .., . ,..

t

i

.\

I

....i...'.. '., .._- .. ,:;~.. ""'"... ~ ""\ /-:d

"\ . -' , . ',,~~ . - .. ,'oQ'J . ~.:

,.

,.. .~'...

;;, .~~: . :

'.'.... :"

:: },......'. 'l~:'.,.' ".:.J'"

. ~-.",',

. '.:'...... , .'" ". ,

, "

~. : : '. :.:' ,t ~. .

, ' ':',.' ',:',:,;;::-: :,~,";'::~".~,~,::,':~',~,;,:,~',,(~;::,;,:,...:,:..,::~..: ~. ; '.:; ,.,': '... ' ..:' .:";. ," :.,'~..' ..:'.... .,,', .., ..... - .'

~1-2. ,~-m-~(~"tIls) LHP 265D, m-qp;r~

. ,".!

'. "~~65D

MARKING DETAIS

I 1. BATTERY PACK2. BATTERY BOX

3. INTERCONNECTING CABLEi12

. HAND SET

5. EXTERNAl BATIERY ADAPTER BOX (EBAB)

6. MAINS (lDAPTER UNIT (MAU)

7. BATTERY CABLE (FOR EBAB)

8. MAINS CABLE ..139. INTERCONNECTING. eAaLE (EBAB TO MAU)

I.' .

10. NINIPRINTERIl~. ;

,11. ImtRCONNECTlNG CABLE (SUARr TO PRINTER)

12. BATTERY CHAGING ADOPTER (BCA)

._--_ ... -- ;-=.:..- ._---..13. KEYBOARD illUMINATION UNIT

14. CARRYING HARNESS

15 CARRYING CASE15

16. MOUNTING TRAY fOR SMART14

' ..~"

:~'!E'~'"r'.. . .. .~.~@ORY CHARGING ADAPTER

16

FIG. 1.6

LIST OF ACCESSORIES OF EQUIPMENT SMART

-_. . - ~ .. "-j

/lVft ,.._~_'

~fr .i . t .~............

w.iJi --tt;"> !"''Il41W4 :

- - - ... .~~.

\~--..,,..,,,..

-I1t~.~{.fJf"~J'~of t-et..

. ;"... -' ~ - -_. _..

.' j r"f .f~,~J -r:f.l..,

J

.._I()l'f!o~ ..>.

_./L',

8 '1.'-(,G-P...Y ~ PIH r", ...,

. .-1,f

;' I. I. I.'! I.' I

f

!I .

.:; 66: -rc:-),-'\ C) p f~

t:'c.

. ,

i !_.J.. ..

. - ...._-", -- -, -_. -- -_.-._-

-16. '!fTWffCfi'1~Cf'1H~~LHP265DCfiT~Wi(1~-qim~~tl ~_~~~t fcl;~~ ~IM:tH~~~~wNaqfOl,:r~~~~~~Wff~~, ~i5T~~~1

q~ttI/Q;n~ 'kr17. ~fiCfi(1llls-q LHP 265D CfiT"WCfi-ut('P:lia1lTT~# QW4IQ'11C:liT~tl .4-6 ~~ # mvr~>lCfif{CfiT~t I W l1fqnun # t I

~

-~..-.. '.-'.- _:.~.;, ..r;J.~:'! '~/RTr. .

. ' . .... .!l:-,

- ,

231

195 I. 18

! Ii ~~:=__..::::::.:::::::::....:.Jii.._~:15 TYl'1JOEil EilO~ii ! i !i! Eil Eil i iiii

.~ ! i! I: i! \~.iii fiiii1 i 1i Eil Eililll ! .ji : i

--__ ; Eil._.Eil _ ! LI- ! ~~-- ----- ----- -w-:-o-l _J_. '

. ...4-6

+rtafiTr~CfiT4~~ 14'11 ~

~~

. nr. 3lT~ft:r4:Tq LHP 265D ~ll16 # ~mR(Slll\jlT~rtl ~~~~ 4-81J.Cf4-9#f:~1,-

--.\

HF ~ LHP 2650 - 'l

/.

.. ~4-9

LHP 265D CfiT~il~(O\

I. ,"-:j .

I~I.VI?]H~~~Lh.lliJ.k~~~ k?@~~~ \-l)W\!>l.W' (g)

-: ~t6ID.~ }?=I>t