service literature gcs/cha16...service literature gcs16 series units in the 6, 7.5, 10 and 12.5 ton...

52
Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx cool units designed for commercial applications. Gas heat exchanger in 160,000, 200,000 and 270,000 (46.9, 58.6 and 79.1 kW) Btuh input sizes. Optional electric heat sec- tions with inputs of 10 to 50 kW are available in the CHA16 series units and install inside the cabinet. All GCS20 model units utilize a scroll compressor. The GCS/CHA16-072 has cone compressor and the GCS/CHA16-090, -120 and -150 has two. The scroll compressor offer high volumetric efficiency, quiet operation and the ability to start under system load. Continuous flank contact, maintained by centrifugal force, minimizes gas leakage and maximizes efficiency. The motor is internally protected from excessive current temperature. All GCS/CHA16 models are designed for horizontal or down discharge application and may be fitted with RMF16 mounting frame, REMD16 economizer and RTD11 ceiling diffuser. All GCS/CHA16 are designed to accept several different thermostat control systems such as the Honeywell T7300 or Honeywell T8621D with mini- mum field wiring. Control options such as econo- mizer and warm up kit connect to the unit with jack- plugs. When plugged in the controls become an integral part of the unit wiring. Units are also equipped with low voltage pigtails to facilitate thermostat field wiring. Information in this manual is for use by a qualified service technician only. All specifications are subject to change. Procedures outlined in this manual are represented as a recommendation only and do not supersede or replace local or state codes. WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, personal injury or loss of life. Installa- tion and service must be performend by a qualified installer or service agency. WARNING Refrigerant can be harmful if it is inhaled. Refrigerant must be used and recovered re- sponsibly. Failure to follow this warning may result in personal injury or death. Page 1 GCS/CHA16 6, 7.5, 10 and 12.5 Ton (21, 26.4, 35.2 and 44.0 kW) Table of Contents GENERAL .......................................................Page 1 SPECIFICATIONS............................................Page 2 HIGH ALTITUDE...............................................Page 3 ELECTRICAL DATA............ ............................Page 4 BLOWER DATA.............................................. .Page 4 OPTIONAL ACCESSORIES....................... .....Page 10 PARTS ARRANGEMENT.................................Page 12 I APPLICATION................................................Page 14 II UNIT COMPONENTS....................................Page 14 III OPTIONAL ELECTRIC HEAT.......................Page 25 IV PLACEMENT AND INSTALLATION.............Page 30 V ELECTRICAL CONNECTIONS.....................Page 30 VI INDOOR BLOWER OPERATION.................Page 30 VII START UP....................................................Page 31 VIII REFRIGERATION SERVICE CHECKS......Page 32 IX HEATING SERVICE CHECKS......................Page 33 X MAINTENANCE............................................. Page 35 XI ACCESSORIES.............................................Page 37 XII WIRING AND OPERATION SEQUENCE....Page 41

Upload: others

Post on 21-Apr-2020

3 views

Category:

Documents


0 download

TRANSCRIPT

Page 1: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Service Literature

GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21,26.4, 35.2 and 44.0 kW) cooling sizes are packagedcombination gas heat/dx cool units designed forcommercial applications. Gas heat exchanger in160,000, 200,000 and 270,000 (46.9, 58.6 and 79.1kW) Btuh input sizes. Optional electric heat sec-tions with inputs of 10 to 50 kW are available in theCHA16 series units and install inside the cabinet.

All GCS20 model units utilize a scroll compressor.The GCS/CHA16-072 has cone compressor and theGCS/CHA16-090, -120 and -150 has two. The scrollcompressor offer high volumetric efficiency, quietoperation and the ability to start under system load.Continuous flank contact, maintained by centrifugalforce, minimizes gas leakage and maximizesefficiency. The motor is internally protected fromexcessive current temperature.

All GCS/CHA16 models are designed for horizontalor down discharge application and may be fittedwith RMF16 mounting frame, REMD16 economizerand RTD11 ceiling diffuser.

All GCS/CHA16 are designed to accept severaldifferent thermostat control systems such as theHoneywell T7300 or Honeywell T8621D with mini-mum field wiring. Control options such as econo-mizer and warm up kit connect to the unit with jack-plugs. When plugged in the controls become anintegral part of the unit wiring. Units are alsoequipped with low voltage pigtails to facilitatethermostat field wiring.

Information in this manual is for use by a qualifiedservice technician only. All specifications aresubject to change. Procedures outlined in thismanual are represented as a recommendation onlyand do not supersede or replace local or statecodes.

WARNING

Improper installation, adjustment, alteration,service or maintenance can cause propertydamage, personal injury or loss of life. Installa-tion and service must be performend by aqualified installer or service agency.

WARNING

Refrigerant can be harmful if it is inhaled.Refrigerant must be used and recovered re-sponsibly.Failure to follow this warning may result inpersonal injury or death.

Page 1

GCS/CHA166, 7.5, 10 and 12.5 Ton

(21, 26.4, 35.2 and 44.0 kW)

Table of ContentsGENERAL .......................................................Page 1SPECIFICATIONS............................................Page 2HIGH ALTITUDE...............................................Page 3ELECTRICAL DATA............ ............................Page 4BLOWER DATA.............................................. .Page 4OPTIONAL ACCESSORIES....................... .....Page 10PARTS ARRANGEMENT.................................Page 12I APPLICATION................................................Page 14II UNIT COMPONENTS....................................Page 14III OPTIONAL ELECTRIC HEAT.......................Page 25

IV PLACEMENT AND INSTALLATION.............Page 30V ELECTRICAL CONNECTIONS.....................Page 30VI INDOOR BLOWER OPERATION.................Page 30VII START UP....................................................Page 31VIII REFRIGERATION SERVICE CHECKS......Page 32IX HEATING SERVICE CHECKS......................Page 33X MAINTENANCE............................................. Page 35XI ACCESSORIES.............................................Page 37XII WIRING AND OPERATION SEQUENCE....Page 41

Page 2: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 2

�8���3�����7��

9��#'��� ���������:��� ���������.�;�

@�,��#)� 7���#*� � !�"

���������)��*��#�#�� 8���4 ���$&'( !� ���� $���3( 3� ���� $�!��(

�7� #)����)��*��#�#�� 8���4 ���$&'( !� ���� $����( �� ���� $�"��(

���)��* �7� #)���� �&' ��� 3�����)��*�# ��*� �<<�� $4 ��.'# �( 3�� 3��

�� �*�# ��?#� ���#�A#)�� ������� 3�"

E������# ��*�@�,-���$-( �� ��

��/��*��#� ��#�*�

������ ��3�)-������+�$��%�� &*(

��)-������+�$��!��&*(

��#�*�$6�;�0��( ������ �� �������

��)-������+�$��!��&*(

<�#���# ��

4)�1���1���)���,��#)��#,� ������1� ��������$,,(�������

$%�"���%�"(<�#���# ��

4)�1��@�,��#)�,� ������$&'( �� $��"(

4)�1��#�

= � � ) �

;#� ��8�� #))�

:#��,�,���#-)�����$&'( ��%�� $��!(#�=����� ��)�� ��� �� #))�

�=����� A�) #*��F���#�� ���.�%�.����� ��� "!"�0%���=������?:��#�*� ��"�����%�

@� �/#��� #��#����9��/ �� $,�( !�!"� $��!�(

<�#���# ��7�-���#,� ���������$,,(�F�@����/���1� %.�� $3�"(���%

<�#���# �����)

;�������������$,( ��� $""�(���)

<��#������������ 8�� 7���,�� # ��� <��#������ A#)��

=�#��������� ������+��,� �������$,,( �� $�"��(

��������@� �/#��� #��#����9��/ �� $,�( �%��� $����( �"��!� $����(

�����������)

7�-���#,� ���������$,,(�F�@����/���1� %.�� $3�"(�������)

;�������������$,( ��� $!�!(

=�#,� ���������$,,(�F�@����/�-)#�� $�(� ��� $���(� �� % $�(���� $���(����

��������������)�,�����/,�$�.�( ����� $�3%"( "�"�� $��%�(

��������;#�

:� ����������1���$'( $�(� �.%� $��3( $�(�%.�� $"��(;#�

:� �����, ��!"

:� ���1# � �"� �"�

��� �$)�1(���4 ���$&'(� @# ��#)��#�.�?��?���#����" ���.������

$%��!.�3�"(�%� ���.��� ���

$%���.%��3(

��#�����)71��� #*�

6�# ��*

��� �$6�*�(���4 ���$&'(� @# ��#)��#�.�?��?���#����� ���.��� ���

$���3.����(��� ���.�!" ���

$"���."��%(6�# ��*�#�#�� 8 5� �� �$6�*�(���4 ���$&'(� @# ��#)��#�.�?��?���#��

��� ���.� �� ���$%!�".%%��(

��� ���.��� ���$���3.����(

������.�������7���,#)�<//������8�@# ��#)��#�.�?��?���#�� ����G.����G ����G.����G

�#������)8������� �����/� �������$,,(@# ��#)�#���?�.?���#�� %.�� $�3(

����,,�����#�����)8 ?�������

@# ��#) !� $��!(����)8�?����������1�������$&?#( �?�.?���#�� ��� $��!(

;�) ���78����/�/�) �� =�����#-)� � �)�# �

;�) ���$/�������( @���F���+��������$,,(

$�(������������$������"�����"�(

@� �1��*� ��/�-#������� ���)-���$&*( !��� $%�"( �!"� $%3!(

�������*�1��*� ��/�-#������� ���)-���$&*(� $�� ?#�&#*�( 3��� $���( ����� $���(

<)�� ���#)���#�#� ���� ��� ���.�%�� ���������"!"���������� +���%���#��

E���� ��# ��*�@�,-��� ���#����#����1� �� �� ����� ����� ���)��� ������� #�#���!����# �� ��� #����#���� 1� �� ��� � #�#�� ���.���� $��!� � ��3� � ����(� ��� %��.%��� $��"�(H

3"�;� $%"�;(� �� ���� #��� �,���# ���� #�� ���;� $�!��(� -.�!�;� $�3��(�1-��� ����*���#���# ���#���@57<� �� � �*�# �� ?#� � ��#� A#)��� �# �� # � ���;� $�!��(� �� ���� #��� �,���# ����

@57<�������#�#�� 8� ����� �#�� ���)������#���# ���-)�1���,� �����# ���� ������������#�#�� 8������� � ���)�����#���# ���-)�1���,� �����# ���� ���������*� � #)�#�����)�,��#���8� �,�� # ��������������9����,�� ��� ��,����/��,�-)�1������/��,#���� #-)�����,�#��,� ����� �� ���9������:#��,�,���#-)��� �� ��/�,� ����/��������-8��������#������1������#�## ���,��#)�,� ����� �� ����#)���,#��,�,���#-)��,� ����� �� ��/�,� �����/���,�#�#-)���� �� �#������ -������� ��&����1� ���� �����������/#� ���)�,� # ������� )������� ���,� ����#,��)# ��

Page 3: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 3

�8���3�����7��

9��#'��� ���������.��� ���������.� �

@�,��#)� 7���#*� �� ���"

���������)��*��#�#�� 8���4 ���$&'( ��% ���� $%���( �"� ���� $����(

�7� #)����)��*��#�#�� 8���4 ���$&'( ��! ���� $%��%( ��� ���� $����(

���)��* �7� #)���� �&' �%�� �������)��*�# ��*� �<<�� $4 ��.'# �( 3��

�� �*�# ��?#� ���#�A#)�� 3�� ��"

E������# ��*�@�,-���$-( �� ��

��/��*��#� ��#�*�

������ ��!�)-������+�

$%���&*(��)-������+�

$%�3� &*(��#�*�

$6�;�0��( ������ ��!�)-������+�

$%���&*(��)-������+�

$%�3� &*(

<�#���# ��

4)�1���1���)���,��#)��#,� ������1� ��������$,,(�"����"

$%�����%��(<�#���# ��

4)�1�� ;#� ��8@�,��#)�,� ������$&'( %� $���( %� $���(

4)�1��#�

= � � ) �

;#� ��8�� #))� :#��,�,���#-)�����$&'( %��"� $���( %��"� $���(#�

=����� ��)�� ����� #))��=�����

A�) #*��F���#�� ���.�%�.����� ��� "!"�0%���

�?:��#�*� !%"������"

@� �/#��� #��#����9��/ �� $,�( 3���� $����( ���3�� $����(

<�#���# ��7�-���#,� ���������$,,(�F�@����/���1� %.�� $3�"(���% %.�� $3�"(����

<�#���# �����)

;�������������$,( ��� $""�(���)

<��#������������ 8�� 7���,�� # ��� <��#������ A#)��

=�#��������� ������+��,� �������$,,( �� $�"��(

��������@� �/#��� #��#����9��/ �� $,�( ����� $���%(

�����������)

7�-���#,� ���������$,,(�F�@����/���1� %.�� $3�"(�������)

;�������������$,( ��� $!�!(

=�#,� ���������$,,(�F�@����/�-)#�� $�(���� $"��(���� $�(� ��� $���(� �� %

��������������)�,�����/,�$�.�( ����� $%���( ����� $%3�"(

��������;#�

:� ����������1���$'( $�(��.%� $��3( $�(� �.�� $%!%(;#�

:� �����, ��!"

:� ���1# � �"� ��"�

��# ����)��� �$)�1(���4 ���$&'(� @# ��#)��#�.�?��?���#�� �!!���.�!� ���� $�3��."���(

��#�����)71��� #*� ��� �$6�*�(���4 ���$&'(� @# ��#)��#�.�?��?���#�� �!� ���.�%� ���� $!3��.�3��(71��� #*�

6�# ��*�#�#�� 8

5� �� �$6�*�(���4 ���$&'(� @# ��#)��#�.�?��?���#�� ��� ���.�3� ���� $�%�%."���(*�#�#�� 8

������.�������7���,#)�<//������8�@# ��#)��#�.�?��?���#�� ����G.����G

�#������)8������� �����/� �������$,,(@# ��#)�#���?�.?���#�� %.�� $�3(

����,,�����#�����)8 ?�������

@# ��#) !� $��!(����)8�?����������1�������$&?#( �?�.?���#�� ��� $��!(

78����/�/�) �� =�����#-)� � �)�# �

;�) ���$/�������( @���F���+��������$,,(

$�(�������"����$�������%"���"�(�F

$�(������������$������"�����"�(

$�(�������"����$"��� �� �%"� �� "�(

F$�(������������

$"��� �� "��� �"�(

@� �1��*� ��/�-#������� ���)-���$&*( ����� $�33( ����� $"��(

�������*�1��*� ��/�-#������� ���)-���$&*(� $�� ?#�&#*�( ���"� $"��( �%�"� $���(

<)�� ���#)���#�#� ���� ��� ���.�%�� ���������"!"���������� +���%���#��

E������# ��*�@�,-������#����#����1� �� �� ����� ��������)���������� #�#���!����# �� ��� #����#���� 1� �� ��� � #�#�� ���.���� $��!� � ��3� � ����(� ��� %��.%��� $��"�(H

3"�;� $%"�;(��� ����#��� �,���# ����#�����;� $�!��(� -.�!�;� $�3��(�1-��� ����*���#���# ���#���@57<� �� � �*�# �� ?#� � ��#� A#)��� �# ��# ����;� $�!��(��� ����#��� �,���# ����

@57<�������#�#�� 8������ �#�����)������#���# ���-)�1���,� �����# ���� ������������#�#�� 8������� ����)�����#���# ���-)�1���,� �����# ���� ���������*� � #)�#�����)�,��#���8� �,�� # ��������������9����,�� ��� ��,����/��,�-)�1������/��,#���� #-)�����,�#��,� ����� �� ���9������:#��,�,���#-)���� �� ��/�,� ���/��������-8��������#������1������#�## ���,��#)�,� ����� �� ����#)���,#��,�,���#-)��,� ����� �� ��/�,� �����/���,�#�#-)���� �� �#������ �-������� ��&����1� ���� ����������/#� ���)�,� # ������� )������� ���,� ����#,��)# ��

�����6����<�

��$&� �'&$&)�#3&�� � 9���8"#%%���&�������8�� 9���8"#%%�6�8�������8��

�:� �������� ����;���

�����:�����;� �� ��: �������:����� ����=� �

�� �����������:�����;�� ��:� �������:�;=�� ��������

��� ������

� ��:� ����;=�:��=�� ��;�����

� �� ���������.�"�� ,��)�� ��9����� &� � 6�B���3"� /��� -� �� �# �#)� #�� �?�����@�����# ��/����?���� ��

Page 4: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 4

�6�������6<���

9��#'>��� ���������.��� ���������.�;�

����I��) #*�I# #I�I��I6+I�I%I��#�� ���.�%�� ���� "!"� ���.�%�� ���� "!"�

�����,,���I,#���/���I��������� �-��#&�����+�I$#,��( "� �" �� "� �" ��

�:���,�,I������ I�,�#�� 8 %� �! �� �� �� �!

��,���������# �I)�#I#,��I�I�#��� $ � #)( ���� 3�� !�" �%�%� $����( ��!� $�%��( "��� $����(

��,�����������&�I�� ��I#,��I�I�#��� $ � #)( �"� !� "� 3�� $���( ��� $3�( %!� $!�(

�������� ;�))I)�#I#,�� ��� ��% ��� %�! ��3 �����������;#�I:� �� ���&�I�� ��I#,�� ��! ��� ��3 !�% %�! ��3

<�#���# ��:� ���5� �� ������$B1( �� $��"( �� $��"(

<�#���# ��4)�1��:

;�))I)�#I#,��I !�" %�� ��! !�" %�! ��!:� �� ���&�I�� ��I#,��I �� ���� ���� ���� ���� ����

���/��I �I@# ���#) � ��� �#�#�#�I<)�� ���#)I���I,#��#)I �I� ��,���I1��� I/���I#�I�������� I��+�I��9����,�� ���'����������� ������� �����������#,�� �6���� 8��������� �-��#&���,#8�-������ ����)#����/� /����$�������)8(�@57<I�I<� ��,��I�/I����# ��*I�#�*�I#��I�)��I#�I,����I��IGI�/I)���I��) #*��

�6�������6<���

9��#'>��� ���������.��� ���������.� �

����I��) #*�I# #I�I��I6+I�I%I��#�� ���.�%�� ���� "!"� ���.�%�� ���� "!"�

�����,,���I,#���/���I��������� �-��#&�����+�I$#,��( !� %" �" !� %" %�

�:���,�,I������ I�,�#�� 8 "� �� �� "3 �3 ��

��,���������$�(�# �I)�#I#,��I�I�#��� $ � #)( ����� $%!��( ���� $�!�!( ���� $�%��(

����$%!��(

3��$����(

!�"$�"��(

��,���������$�(

���&�I�� ��I#,��I�I�#��� $ � #)( ���� $�"�( �%� $���( �3� $3�( �"���$%��( !�� $���( "�� $���(

��������;�))I)�#I#,��� �� � #) $�(���� $�(���� $�(���� $�(���� $�(�%�� $�(����

��������;#�I:� ��� ���&�I�� ��I#,��� �� � #) $�(�3�� $�(���� $�(�%�� $�(����� $�(���� $�(�"��

<�#���# ��:� ���5� �� ������$B1( %� $���(

<�#���# ��4)�1��:� ��

;�))I)�#I#,��I ���� ��� %�3 ���� ��� %�3:� ��

���&�I�� ��I#,��I �� ���� �%�� �� ���� �%��

���/��I �I@# ���#) � ��� �#�#�#�I<)�� ���#)I���I,#��#)I �I� ��,���I1��� I/���I#�I�������� I��+�I��9����,�� ���'����������� ������� �����������#,�� �6���� 8��������� �-��#&���,#8�-������ ����)#����/� /����$�������)8(�@57<I�I<� ��,��I�/I����# ��*I�#�*�I#��I�)��I#�I,����I��IGI�/I)���I��) #*��

567���<���

�����:�����;�567���8��37�9����576<<�����<������3��6<3�������<<��?�

�$"������8��������@�����6�7����A��+2#%��&#"��)-#�8��

�$"?�') #/

���� �� ����� � �������� � ���� � ����� �� ������ � �=������ �;���� � ������ �� ������� � ��������� ������� �?�') #+/ �6�%�

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

����

$3�"(

��� ���

������

� ����

������

�� �� �

������

� ��

������

=�� ����

���� �

��" ��!�

$��"�(

�3� ��!"

$��"�(

3%� ���"

$���%(

3!� ��3�

$���!(

���" ����

$��!"(

��"� ���"

$��!�(

��3� ���"

$����(

����

$����(

��� ���

������

�;� �� �

������

�� ��

������

�=� ���

����=�

=� ����

��� ��

�!� ����

$����(

3�� ���"

$���%(

3"� ��3"

$��!�(

33� ���"

$��!�(

��%� ����

$����(

���" ����

$��3�(

���� ��%�

$��3!(

����

$��%"(

�=� ��

������

�� ����

���� �

��� ����

��� ��

=� ���

��� ��

�"" ���"

$���%(

�3" ��3�

$���!(

3%" ����

$��!"(

3!" ����

$����(

���� ���"

$����(

���" ���"

$��3%(

���" ��%"

$����(

���� ���"

$����(

����

$���"(

��� ����

��� ��

�� ���

��� ��

=� ��=�

������

��" ��3�

$���!(

��" ����

$��!"(

3�" ���"

$��!�(

3�� ���"

$����(

���� ���"

$��3%(

��%" ��%�

$��3!(

��!� ����

$����(

���" ��"�

$����(

���� ����

����;�

����

$�%��(

�� ��=

������

=� ��;�

������

��" ����

$��!"(

��� ���"

$��!�(

3�� ���"

$����(

3"" ���"

$��3%(

33� ��%�

$��3!(

���" ����

$����(

���� ��"�

$����(

��3" ����

$���3(

���" ��!�

$���!(

���� ��=�

������

%���

$���"(

=� ����

���� �

��" ���"

$��!�(

��� ���"

$����(

3�� ���"

$��3%(

3"" ��%"

$����(

33� ����

$����(

���� ��"�

$����(

��"" ����

$���3(

��3� ��!�

$���!(

���� ����

$��%�(

�� � ��;�

������

��= ����

����;�

%���

$�"��(

�"� ����

$��3�(

��" ���"

$��3%(

3�� ��%"

$����(

3"" ���"

$����(

33� ��""

$����(

���� ����

$���3(

��"" ��!�

$���!(

���" ����

$��%�(

���� ��3�

$����(

�� � ����

����;�

��=� ����

��� ��

���� ���

����=�

%���

$���"(

�3" ����

$����(

3%� ��"�

$����(

3�� ��""

$����(

33" ���"

$���%(

���" ��!"

$��%�(

���� ���"

$��%�(

��3� ��3"

$���"(

���� ���"

$��"%(

�� � ���

������

��=� ���

����=�

���� ����

����;�

���� �� �

���=��

%���

$�!��(

3�� ���"

$���%(

3!� ��!�

$���!(

���" ���"

$��%�(

��%" ��3�

$����(

���" ����

$���3(

��3" ����

$��"!(

���" ����

$����(

�� ���

���� �

��= ���

���=��

���� ��

���;��

���� ���

���;=�

���� ��=�

����;�

%���

$�!3"(

3�" ��3�

$����(

���" ����

$���3(

���" ����

$��"!(

��!" ����

$����(

���" ��%�

$��!�(

��� ����

����;�

���� �� �

���=��

��;� ���

���;=�

���� ���

���� �

��� ��=

������

���� ��;

������

���� ����

������

@57< �J��))�# #����,�#������� ���#)� �� ������ �1� ���8����)�#��1� �� ���#���/�) ��������)#����@57<�J� ���#�## �,#��,�,���#-)��,� ����� �� � �������� $��"�&'(�

Page 5: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 5

567���<���

�����:���567���8��37�9����576<<�����<������3��6<3�������<<��?�

�$"������8��������@�����6�7����A��+2#%��&#"��)-#�8��

�$"?�') #/

���� �� ����� � �������� � ���� � ����� �� ������ � �=������ �;���� � ������ �� ������� � ��������� ������� � ������ �� �� ���� �?�') #+/ �6�%�

�89 5�8

����

�895�8

����

�89 5�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

%���

$���"(

� �� �

������

����

���� �

; ���

����=�

�� ���

��� ��

��� ��=�

������

�� ��;�

������

!�� ����

$��!"(

!!" ����

$����(

��� ���"

$����(

��" ��%�

$��3!(

�!" ��%"

$����(

3�" ���"

$����(

3�� ����

$���3(

3!� ��!�

$���!(

%���

$�"��(

� ����

���� �

� ���

����=�

�� ���

��� ��

� � ��=

������

�= ��;�

������

��� ����

���� �

!"" ����

$����(

!3� ����

$��3�(

��� ��%�

$��3!(

�"� ����

$����(

��" ��"�

$����(

3�" ����

$���3(

3�" ��!�

$���!(

3!" ����

$��%�(

%���

$���"(

�� ����

��� ��

��� ��=�

������

�� ��=

������

��� ��;

������

�� ���

����=�

!%" ����

$����(

!!� ����

$��3�(

��� ��%�

$��3!(

�%� ����

$����(

��" ��"�

$����(

�3" ���"

$���%(

3�" ��!"

$��%�(

3"� ���"

$��%�(

3�� ��3"

$���"(

%���

$�!��(

� � �� �

������

��� ��;�

������

� ����

���� �

�;� ���

����=�

��� ���

���=��

!"" ���"

$��3%(

!�" ��%"

$����(

��" ���"

$����(

��" ��""

$����(

�!" ���"

$���%(

3�" ��!"

$��%�(

3%" ��3�

$����(

3�� ����

$���3(

33� ����

$��"!(

%���

$�!3"(

��� ��;

������

�� ����

���� �

�� ����

���=��

��� ����

���;��

!�� ��%�

$��3!(

!!� ����

$����(

��� ��"�

$����(

�%� ����

$���3(

��� ��!�

$���!(

�3� ����

$��%�(

3�" ��3�

$����(

3�" ���"

$��"%(

3!� ���"

$����(

���� ���"

$����(

����

$��3�(

�� ���

����=�

��� ���

���=��

��� ���

���;��

��� ���

������

!�� ���"

$����(

!3� ��""

$����(

��� ���"

$���%(

��" ��!"

$��%�(

�!" ���"

$��%�(

3�� ��3"

$���"(

3%� ����

$��"!(

3"" ����

$����(

3�" ��%"

$��!"(

���� ���"

$���%(

����

$�3��(

��� ����

���;��

�;� ����

���;��

��� ����

������

!"� ��"�

$����(

!�� ����

$���3(

��� ��!�

$���!(

�%" ����

$��%�(

��" ��3"

$���"(

�3� ���"

$��"%(

3�� ���"

$����(

3�" ���"

$����(

3!� ����

$��!3(

33" ��"�

$���!(

���� ����

���;��

����

$��!"(

�;� ����

������

�� ���

����=�

!�" ����

$���3(

!!" ��!�

$���!(

��� ����

$��%�(

�%� ��3�

$����(

�"" ����

$���3(

��� ����

$��"!(

3�� ���"

$����(

3%" ��%"

$��!"(

3�� ���"

$���%(

3�" ����

$��3�(

���� ��!�

$����(

��� ��=

������

����

$��!�(

�� ��

������

!�� ���"

$���%(

!!� ��!"

$��%�(

!3" ���"

$��%�(

��" ����

$���3(

�"� ����

$��"!(

�!" ����

$����(

3�� ��%�

$��!�(

3�" ���"

$���%(

3"� ��""

$��3�(

3!" ���"

$��3�(

���� ����

$���3(

��� ��;

������

�� � ���

����=�

����

$���"(

!�� ��!"

$��%�(

!�" ���"

$��%�(

!3" ��3"

$���"(

��� ����

$��"!(

��" ����

$����(

�!� ��%�

$��!�(

�3" ����

$��!3(

3�� ��""

$��3�(

3�" ���"

$��3�(

3!� ����

$���3(

33" ��3�

$����(

���" %���

$����(

���� ���

���� �

��� ����

������

"���

$�%��(

!�" ��3"

$���"(

!3� ���"

$��"%(

��� ����

$����(

��" ��%�

$��!�(

�!� ����

$��!3(

�3� ��"�

$���!(

3�" ���"

$��3�(

3�� ��!"

$���"(

3�" ��3�

$����(

33� %��"

$����(

���� %��"

$��%"(

��� ����

������

�� ����

��� ���������

"���

$��""(

!3" ����

$����(

��� ��%�

$��!�(

��� ����

$��!3(

��" ��"�

$���!(

�3� ���"

$��3�(

3�" ����

$���3(

3�� ��3�

$����(

3�� %���

$����(

3�" %��"

$��%"(

���" %��"

$����(

���� ����

��� ��������� ������� �������

@57< �J��))�# #����,�#������� ���#)� �� ������ �1� ���8����)�#��1� �� ���#���/�) ��������)#����@57<�J� ���#�## �,#��,�,���#-)��,� ����� �� � ���%���� $�����&'(�

Page 6: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 6

567���<���

�����:� �567���8��37�9����576<<�����<������3��6<3�������<<��?�

���<�<<�����<������3��6<3�������<97�7�

�$"

������8��������@�����6�7����A��+2#%��&#"��)-#�8��

�$"?�') #+/

���� �� ����� � �������� � ���� � ����� �� ������ � �=������ �;���� � ������ �� ������� � ��������� ������� � ������ �� �� ���� � ���������+/ �6�%� �89 5�8

����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

%���$�!3"(

��� ��� ����=�

� ��� ���=��

�; ��� ���;��

�� ��� ������

!�� ���"$����(

!3" ��""$����(

��" ��!�$���!(

��� ����$��%�(

�3� ��3"$���"(

3�� ���"$��"%(

3�" ���"$����(

3!" ��%�$��!�(

���" ���"$���%(

���� �� ���;��

�� ����������

%3��$����(

��� �������=��

�� �������;��

�� �������;��

!�� ���"$����(

!!� ��""$����(

��" ���"$���%(

�%" ��!"$��%�(

��" ��3�$����(

�3" ����$���3(

3�" ���"$����(

3"" ���"$����(

3�� ����$��!3(

���� ��""$��3�(

��� ��� ���;=�

���� ��=�����;�

����$��3�(

�� �������;��

�=� �������;��

�� ����������

!"� ��"�$����(

!�� ����$���3(

��" ��!"$��%�(

��" ���"$��%�(

�!" ����$���3(

3�" ����$��"!(

3%" ���"$����(

3�� ��%"$��!"(

33� ��"�$���!(

���" ���"$��3�(

���� ��� ���� �

���� ��;�������

����$�3%"(

� ��� ���;��

�;� ��� ������

�� �� �������

!�� ����$���3(

!3� ��!�$���!(

��� ���"$��%�(

�"" ��3"$���"(

��" ����$��"!(

3�� ����$����(

3�� ��%"$��!"(

3!� ��"�$���!(

33" ����$��3�(

���� ����������

�� � ��;�������

��� ����������

����$�3��(

��� ��� ������

�� ��� ����=�

!%" ��""$����(

!!� ��!�$���!(

��� ����$��%�(

�%� ��3�$����(

��� ���"$��"%(

�3� ���"$����(

3�� ��%�$��!�(

3"� ���"$���%(

3!" ��""$��3�(

���" ��!�$����(

���� ��= ������

�� ����������

��=� ����������

�%��$��%�(

�=� ����������

�� �� ������

!"� ���"$���%(

!�� ����$��%�(

��� ��3�$����(

��� ����$���3(

�!� ���"$����(

3�� ��%�$��!�(

3%� ����$��!3(

3"" ��""$��3�(

3�" ��!�$����(

���� ����$���3(

��� ��; ������

���� ����������

��= ��� ������

����$��!"(

�; �� �������

�� ��� ������

!�� ��!"$��%�(

!3� ��3�$����(

��� ����$���3(

�"� ����$��"!(

��� ���"$����(

3�� ����$��!3(

3%" ��"�$���!(

3�" ���"$��3�(

33� ����$���3(

���� ��; ������

��� ����������

���� ��������;�

��; ��� ��� ��

�"��$���"(

�� ��������;�

!�� ��!"$��%�(

!!� ���"$��%�(

��� ��3"$���"(

�%� ����$��"!(

��� ���"$����(

�3� ��%"$��!"(

3�� ��"�$���!(

3�" ���"$��3�(

3!" ����$���3(

���� ��3�$����(

��� ��� ����=�

�� � ��������;�

��� ��� ��� ��

���� �� �������

����$��!�(

��� ����������

!"� ���"$��%�(

!�� ��3"$���"(

��" ����$��"!(

��� ����$����(

�!� ��%"$��!"(

3�� ��"�$���!(

3%� ���"$��3�(

3"" ��!"$���"(

3�� ��3�$����(

���� %��"$����(

��� ��������;�

���� ��� ��� ��

��= �� �������

���� ��� ������

�!��$����(

��� ��=�������

!�" ��3"$���"(

!3" ���"$��"%(

��" ����$����(

�"" ��%"$��!"(

��� ���"$���%(

3�� ����$��3�(

3%" ��!"$���"(

3�" ��3�$����(

33� %���$����(

���" %��"$��%"(

���� ����������

��� ��� ��� ��

��;� ��������;�

��� ��� ���=��

����$���"(

!�" ��3�$����(

!!" ���"$��"%(

��" ����$����(

�%" ��%�$��!�(

��" ���"$���%(

�3� ��""$��3�(

3�� ��!�$����(

3�" ���"$���%(

3!" %���$����(

���� %��"$��%"(

��� ����������

�� � ��� ��� ��

��� ��������;�

���� ��� ���=��

��� ��;����;��

�3��$�%��(

!"" ����$���3(

!�" ���"$����(

��� ��%�$��!�(

��" ����$��!3(

�!" ��""$��3�(

3�� ��!�$����(

3%� ���"$���%(

3"" %���$����(

3�" %��"$��%"(

���� %�%�$����(

��� ��� ��� ��

���� ��������;�

��= ��� ���=��

��� ��= ���=��

���� ��� ������

"���$�%��(

!!� ���"$����(

��� ��%�$��!�(

�%� ����$��!3(

��� ��""$��3�(

��" ��!�$����(

3�" ���"$���%(

3�� %���$����(

3�" %���$��%�(

33� %��"$����(

���� ��� ��� ��

���� �� ���� �

��� ����������

��;� ��= ���=��

��� ��� ������

���� ����������

"���$���"(

!�" ���"$����(

��" ����$��!3(

��� ��""$��3�(

�!� ��!�$����(

�3" ����$���3(

3�" ��3"$����(

3"� %���$��%�(

3!" %��"$����(

���� %���$��"�(

��� �� ���� �

�� � ����������

��� ��= ���=��

���� �������;=�

��� ����������

��� ����������

"���$��""(

!3" ����$��!3(

��" ��""$��3�(

�"" ��!�$����(

��� ����$���3(

3�� ��3"$����(

3%" %���$��%�(

3�� %��"$����(

3�" %���$��"�(

���� %�""$���"(

��� ����������

���� ��= ���=��

��= �������;=�

���� ����������

���� ����������

�� �� �������

"%��$�"��(

��� ��"�$���!(

��� ���"$��3�(

��" ����$���3(

�3" ��3"$����(

3�� %���$��%�(

3�" %��"$����(

3!� %���$��"�(

33" %�""$���"(

���� ����������

��� ��= ���=��

���� �������;=�

��; ����������

��� ����������

���� �� �������

��� ��� ������

"���$�""�(

��" ���"$��3�(

�"� ����$���3(

��� ��3"$����(

3�" %���$��%�(

3%� %��"$����(

3"" %���$��"�(

3�� %�""$���"(

���" %�!�$��!�(

���� ��= ���=��

�� �������;=�

��=� ��� ������

��� ��� ���� �

��� �� �������

�� � ��� ������

���� ��=���� =�

""��$�"3"(

�%" ����$���3(

��" ��3"$����(

�3� %���$��%�(

3�" %��"$����(

3�" %���$��"�(

3!� %�""$���"(

33" %�!�$��!�(

���� ��= ���=��

���� �������;=�

��� ��� ������

��;� ��� ���� �

���� �� �������

��� ��� ������

�� ��=���� =�

��=� ���������

"���$���"(

�"� ��3"$����(

�!" %���$��%�(

3�� %���$��%3(

3%� %���$��"�(

3"" %�""$���"(

3�� %�!�$��!�(

���" %��"$���!(

���� ��� ������

�� � ��� ������

��� ��� ���� �

���� �� �������

���� ��� ������

��� ��= ������

��� ���������

��;� ������==�

"!��$��3�(

��� %���$��%�(

�3� %��"$����(

3�" %���$��"�(

3�� %�""$���"(

3�" %�!�$��!�(

33� %��"$���!(

���" ����$��3�(

���� ����������

���� ��� ���� �

��= �� �������

���� ������� ��

���� ��= ������

�� ���������

��� ������==�

��; �� ���;;�

"���$�!%"(

�!" %��"$����(

3�� %���$��"�(

3�" %�""$���"(

3"" %�!�$��!�(

3!" %��"$���!(

���� ����$��3�(

��� ����������

�� � ��� ���� �

��� �� ����;�

��; ������� ��

���� ��= ������

���� ���������

��� ������==�

��= �� ���;;�

��� � ������

"3��$�!�"(

�3� %���$��"�(

3�" %�""$���"(

3�� %�!�$��!�(

3�" %�3�$��3�(

33� ���"$%���(

���" ����$%��%(

��� ��� ���� �

���� �� ����;�

��= ������� ��

��� ��= ������

���� �� ������

�� � ������==�

���� �� ���;;�

��; � ������

��� �� ����;�

����$��%�(

3�� %�""$���"(

3�" %�!�$��!�(

3"� %��"$���!(

3!" ���"$%���(

���� ����$%��%(

��� ��������=�

�� � �� ����;�

���� ������� ��

��; ��;�������

��� �� ������

���� �� ���;��

���� ���������

��=� � ������

��� �� ����;�

��� �; ������

@57<�J��))�# #����,�#������� ���#)� �� ������ �1� ���8����)�#��1� �� ���#���/�) ��������)#���

@57<�J� ���#�## �,#��,�,���#-)��,� ����� �� � ���%���� $�����&'(�

Page 7: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 7

567���<���

�����:�����;� 567���8��37�9����576<<�����<������3��6<3�������<<��?�

�$"������8��������@�����6�7����A��+2#%��&#"��)-#�8��

�$"?�') #/

���� �� ����� � �������� � ���� � ����� �� ������ � �=������ �;���� � ������ �� ������� � ��������� ������� �?�') #+/ �6�%�

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

�89 5�8

����

����

$3�"(

= ���

������

��� ����

������

�=� ���

������

�� �� �

������

�� ����

���� �

=�� ���

����=�

��" ��!"

$��"�(

3�� ����

$����(

3"" ��3�

$���!(

���� ��3"

$��!�(

���" ���"

$��!�(

��3� ���"

$����(

����

$����(

�� ���

������

��� �� �

������

��� ��

������

� ���

����=�

�; ����

��� ��

=�� ���

��� ��

��� ���"

$���%(

3�" ��3�

$���!(

3�" ����

$��!"(

���" ���"

$��!�(

��"� ���"

$����(

��3� ���"

$��3%(

����

$��%"(

�� ��

������

�� ����

���� �

�� ����

��� ��

�= ���

��� ��

=� ��=�

������

��" ��3�

$���!(

3�" ��3"

$��!�(

3�� ���"

$��!�(

3�� ����

$����(

���� ����

$��3�(

��"" ��%�

$��3!(

��3" ����

$����(

����

$���"(

��� ����

��� ��

�� ���

��� ��

�=� ��=�

������

=�� ��;�

������

�"" ��3"

$��!�(

�3� ���"

$��!�(

3%� ����

$����(

3�" ����

$��3�(

���� ��%�

$��3!(

��%" ��%"

$����(

��!� ���"

$����(

���" ��""

$����(

����

$�%��(

� � ��=

������

�= ��;�

������

=�� ��;

������

�"" ���"

$��!�(

�3� ����

$����(

3�" ����

$��3�(

3"" ��%�

$��3!(

33� ��%"

$����(

���" ���"

$����(

��"" ��""

$����(

��3� ���"

$���%(

���" ��!"

$��%�(

%���

$���"(

�; ����

���� �

=�� ���

����=�

��� ���"

$����(

�3� ����

$��3�(

3�" ��%�

$��3!(

3"" ����

$����(

3�" ���"

$����(

���� ��""

$����(

��"� ���"

$���%(

���� ��!"

$��%�(

���" ���"

$��%�(

��� ��;

���� �

%���

$�"��(

=�� ����

���;��

�!� ���"

$��3%(

3�� ��%"

$����(

3%� ����

$����(

3�� ��"�

$����(

33� ����

$���3(

���� ��!�

$���!(

��"� ��!"

$��%�(

���� ���"

$��%�(

���� ��3"

$���"(

���� ���

��� ��

���� ���

������

%���

$���"(

��" ����

$����(

3�" ��"�

$����(

3�� ��""

$����(

3!� ���"

$���%(

���� ��!"

$��%�(

���" ����

$��%�(

��"" ��3�

$����(

���" ����

$���3(

���� ����

$��"!(

���� ����

������

��� ����

������

��; ����

����;�

%���

$�!��(

3%� ���"

$���%(

3�� ��!"

$��%�(

3�" ����

$��%�(

���� ��3�

$����(

���� ����

$���3(

���" ����

$��"!(

��3� ����

$����(

���� ��%�

$��!�(

��� ����

����;�

���� �� �

���=��

���� ����

���;��

��� ����

������

%���

$�!3"(

3!" ��3�

$����(

���" ����

$���3(

��%� ����

$��"!(

��"" ����

$����(

���� ��%�

$��!�(

��� ����

����;�

���� �� �

���=��

�� ����

���;��

��=� ����

������

��� ��=�

����;�

���� ��;�

������

�� ����

������

@57< �J��))�# #����,�#������� ���#)� �� ������ �1� ���8����)�#��1� �� ���#���/�) ��������)#��������?#*��3�/�����������8���������� #����# #�@57<�J� ���#�## �,#��,�,���#-)��,� ����� �� � �������� $��"�&'(�

�����:���567���8��37�9����576<<�����<������3��6<3�������<<��?�

�$"������8��������@�����6�7����A��+2#%��&#"��)-#�8��

�$"?�') #/

���� �� ����� � �������� � ���� � ����� �� ������ � �=������ �;���� � ������ �� ������� � ��������� ������� � ������ �� �� ���� �?�') #+/ �6�%�

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

�895�8

����

%���

$���"(

�� �� �

������

� ����

���� �

= ���

����=�

��� ����

��� ��

� ��=�

������

�;� ��=

������

��� ��;

������

!"�� ����

$��!"(

!��� ���"

$��!�(

���� ���"

$����(

���� ����

$��3�(

�!�� ��%�

$��3!(

�3"� ����

$����(

3�"� ���"

$����(

%���

$�"��(

���� ����

������

�� ����

��� ��

�� ���

��� ��

��� ��=�

������

��� ��;�

������

�� ��;

������

!%"� ���"

$��!�(

!�"� ����

$����(

!3"� ����

$��3�(

��"� ��%�

$��3!(

�"�� ��%"

$����(

���� ���"

$����(

3�"� ��"�

$����(

3%�� ����

$���3(

%���

$���"(

�� ����

��� ��

; ��=�

������

��� ��=

������

��� ��;

������

�;� ����

���� �

��� ����

���=��

!"�� ���"

$����(

!��� ���"

$��3%(

���� ��%"

$����(

�%"� ����

$����(

��"� ��"�

$����(

�3�� ����

$���3(

3�"� ���"

$���%(

3��� ��!"

$��%�(

%���

$�!��(

= ��=

������

��� ��;�

������

� � ����

���� �

�=� ���

����=�

��� ���

���=��

!��� ���"

$��3%(

!!�� ��%�

$��3!(

!3"� ����

$����(

��"� ��"�

$����(

�"�� ��""

$����(

�!"� ���"

$���%(

3��� ��!�

$���!(

3�"� ����

$��%�(

3"�� ��3�

$����(

%���

$�!3"(

��� ��;

������

�� ���

����=�

��� ����

���=��

��� ����

���;��

��� ����

���;��

!��� ����

$����(

!�"� ���"

$����(

��"� ��""

$����(

���� ���"

$���%(

��"� ��!�

$���!(

�3�� ����

$��%�(

3�"� ��3�

$����(

3��� ����

$���3(

3�"� ����

$��"!(

����

$��3�(

��� ����

���=��

�� ����

���;��

�; ����

���;��

�� ���

������

!"�� ���"

$����(

!��� ��""

$����(

��"� ���"

$���%(

�%�� ��!�

$���!(

�""� ����

$��%�(

���� ��3�

$����(

3�"� ����

$���3(

3%�� ����

$��"!(

3""� ����

$����(

3��� ��%�

$��!�(

����

$�3��(

�� ����

���;��

�;� ���

������

��� ���

����=�

!�"� ��""

$����(

!!"� ���"

$���%(

���� ��!�

$���!(

��"� ����

$��%�(

�"�� ��3�

$����(

�!"� ����

$���3(

3��� ����

$��"!(

3��� ����

$����(

3�"� ��%�

$��!�(

3!�� ����

$��!3(

33�� ���"

$���%(

����

$��!"(

�;� ���

����=�

�� ��

������

!�"� ���"

$���%(

!!�� ��!�

$���!(

!3"� ����

$��%�(

���� ��3�

$����(

��"� ����

$���3(

�!�� ����

$��"!(

�3"� ����

$����(

3�"� ��%�

$��!�(

3��� ����

$��!3(

3��� ��"�

$���!(

3�"� ����

$��3�(

���"� ��!�

$����(

����

$��!�(

�� ���

������

!�"� ��!"

$��%�(

!!�� ���"

$��%�(

!3"� ��3"

$���"(

���� ���"

$��"%(

���� ����

$��"!(

��"� ����

$����(

�3�� ��%�

$��!�(

3��� ����

$��!3(

3%"� ��"�

$���!(

3""� ����

$��3�(

3��� ��!"

$���"(

����� ����

$���3(

��� ��;

������

����

$���"(

!�"����"

$��%�(

!!�� ��3"

$���"(

!3"� ���"

$��"%(

��"� ���"

$����(

���� ���"

$����(

��"� ��%"

$��!"(

��"� ���"

$���%(

3��� ��""

$��3�(

3%�� ���"

$��3�(

3""� ��!"

$���"(

3!"� ���"

$���%(

�����%���

$����(

��������

������

��������

����;�

"���

$�%��(

!!�����"

$��"%(

!3"� ���"

$����(

���� ��%�

$��!�(

���� ��%"

$��!"(

��"� ��"�

$���!(

��"� ����

$��3�(

3��� ��!�

$����(

3%�� ����

$���3(

3""� ��3�

$����(

3!"� %���

$����(

33"� %���

$��%�(

���"�%��"

$����(

��� ���

��� ��

�� ���

��� ��

"���

$��""(

������%�

$��!�(

���� ����

$��!3(

��"� ��""

$��3�(

��"� ����

$��3�(

�3�� ��!"

$���"(

3��� ���"

$���%(

3%�� ��3"

$����(

3""� %���

$��%�(

3!"� %���

$��%3(

33"� %�%�

$����(

���"�%���

$��"�(����� ����� �����

@57< �J��))�# #����,�#������� ���#)� �� ������ �1� ���8����)�#��1� �� ���#���/�) ��������)#��������?#*��3�/�����������8���������� #����# #�@57<�J� ���#�## �,#��,�,���#-)��,� ����� �� � ���%���� $����&'(�

Page 8: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 8

567���<���

�����:� �567���8��37�9����576<<�����<������3��6<3�������<<��?�

���<�<<�����<������3��6<3�������<97�7�

�$"

������8��������@�����6�7����A��+2#%��&#"��)-#�8��

�$"?�') #+/

���� �� ����� � �������� � ���� � ����� �� ������ � �=������ �;���� � ������ �� ������� � ��������� ������� � ������ �� �� ���� � ���������+/ �6�%� �89 5�8

����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

�89 5�8����

%���$�!3"(

=� ��;�������

�� �������� �

� � �������=��

�=� �������;��

��� �������;��

!�� ��%"$����(

!�" ���"$����(

!3" ��""$����(

��� ���"$���%(

��" ��!�$���!(

�!� ����$��%�(

�3" ��3�$����(

3�� ����$���3(

3�� ���"$��"%(

3�" ���"$����(

%3��$����(

;� �������� �

�� ��� ����=�

��� ��� ���=��

�;� ��� ���;��

��� ��� ������

!"� ���"$����(

!!" ��""$����(

��" ���"$���%(

�%� ��!"$��%�(

�"" ����$��%�(

��� ��3�$����(

3�� ����$���3(

3�" ����$��"!(

3"� ����$����(

3!� ���"$����(

����$��3�(

�� ��� ����=�

��� ��� ���=��

��� ��� ���;��

��� ��� ������

��� ��� ����=�

!�� ��""$����(

!�" ����$���3(

��� ��!�$���!(

�%" ����$��%�(

��� ��3�$����(

��" ����$���3(

3�� ����$��"!(

3%" ����$����(

3"" ���"$����(

3�� ��%"$��!"(

����$�3%"(

�� �������=��

� � �������;��

�=� �������;��

��� ����������

!�� ��"�$����(

!�" ����$���3(

!3" ��!�$���!(

��� ����$��%�(

��" ��3�$����(

�!� ����$���3(

�3" ����$��"!(

3�" ����$����(

3�� ��%�$��!�(

3�" ����$��!3(

3�" ���"$���%(

����$�3��(

��� �������;��

��� �������;��

�;� ����������

��� �� �������

!"� ����$���3(

!!" ��!�$���!(

��" ����$��%�(

�%� ��3�$����(

�"" ����$���3(

��� ����$��"!(

3�� ����$����(

3�" ��%�$��!�(

3"� ����$��!3(

3!� ��"�$���!(

33� ��""$��3�(

�%��$��%�(

��� ��� ���;��

��� ��� ������

��� �� �������

��� ��������;�

!�� ��!�$���!(

!�" ����$��%�(

��� ��3�$����(

��� ����$���3(

��� ����$��"!(

��" ����$����(

3�� ��%�$��!�(

3%" ����$��!3(

3"" ��"�$���!(

3�� ����$��3�(

���� ��!�$����(

����$��!"(

� � ��� ������

�= ��� ����=�

��� �� ������

!�� ���"$���%(

!!� ����$��%�(

!3" ��3�$����(

��� ����$���3(

��" ����$��"!(

�!� ����$����(

�3" ��%�$��!�(

3�� ����$��!3(

3�� ��"�$���!(

3�" ����$��3�(

3�" ��!�$����(

���" ����$���3(

�"��$���"(

�� ��� ����=�

�; �� ������

�� ��� ������

!"� ��!"$��%�(

!�� ��3�$����(

��" ����$���3(

�%� ����$��"!(

�"" ����$����(

��� ��%�$��!�(

3�" ����$��!3(

3�" ��"�$���!(

3"� ����$��3�(

3!� ��!�$����(

33" ���"$���%(

���" ��3"$����(

����$��!�(

�� �� �������

�� ��� ������

!%" ��!"$��%�(

!�� ���"$��%�(

!3� ��3"$���"(

��" ����$��"!(

��� ����$����(

��" ��%�$��!�(

�3� ����$��!3(

3�� ��"�$���!(

3%" ����$��3�(

3�� ��!"$���"(

3�� ���"$���%(

���� ��3"$����(

���� ��� ����=�

�!��$����(

�;� ��� ������

�� ����������

!�" ���"$��%�(

!!" ��3"$���"(

��� ����$��"!(

��" ����$����(

�"� ��%�$��!�(

�!" ����$��!3(

3�� ��""$��3�(

3�� ����$��3�(

3�" ��!"$���"(

3�" ���"$���%(

33� ��3"$����(

���� %��"$����(

���� ��������;�

����$���"(

��� ����������

��� ��= ����=�

!"" ��3"$���"(

!�" ���"$��"%(

��� ����$����(

�%" ��%�$��!�(

��� ����$��!3(

��" ��""$��3�(

3�" ����$��3�(

3%� ��!"$���"(

3"" ���"$���%(

3!" %���$����(

33" %���$��%�(

���" %���$��%3(

���� ����������

�3��$�%��(

��� ��=�������

!�� ��3"$���"(

!!� ���"$��"%(

!3" ���"$����(

��� ��%�$��!�(

��" ����$��!3(

�!� ��"�$���!(

�3" ���"$��3�(

3�" ��!"$���"(

3�� ���"$���%(

3�� %���$����(

3�" %���$��%�(

���" %���$��%3(

��� ��� ��� ��

��� ��� ��� ��

"���$�%��(

�� ��;�������

!"" ���"$��"%(

!�� ���"$����(

��" ��%�$��!�(

�%� ����$��!3(

�"" ��"�$���!(

��� ���"$��3�(

3�" ��!"$���"(

3�" ���"$���%(

3"� %���$����(

3!� %���$��%�(

33� %���$��%3(

���" %�%"$��"�(

��� ��� ��� ��

�� ��������;�

"���$���"(

!%" ����$���3(

!�" ���"$����(

!3� ���"$����(

��" ����$��!3(

��� ��"�$���!(

��" ���"$��3�(

�3� ��!"$���"(

3�" ��3�$����(

3%" %���$����(

3�� %��"$��%"(

3�� %��"$����(

���� %�%"$��"�(

���� �� �������

���� ��������;�

���� ����������

"���$��""(

!"� ���"$����(

!!" ���"$����(

��� ����$��!3(

�%� ��""$��3�(

�"� ���"$��3�(

�!" ��!"$���"(

3�� ��3�$����(

3�" %��"$����(

3�" %��"$��%"(

3�" %��"$����(

33� %���$��"�(

���� %�"�$����(

���� ��� ������

�� � ��� ���=��

���� ��= ���=��

"%��$�"��(

!�� ���"$����(

!3� ����$��!3(

��" ��"�$���!(

��� ���"$��3�(

��" ����$���3(

��" ��3�$����(

3�� %���$����(

3%" %��"$��%"(

3"" %��"$����(

3!" %���$��"�(

���� %�""$���"(

���� ��� ������

���� ��=����=��

���� ��;����;��

��=� ��� ������

"���$�""�(

!!" ����$��!3(

��� ��"�$���!(

��" ���"$��3�(

�"� ��!"$���"(

�!" ��3�$����(

�3" %���$����(

3�� %��"$��%"(

3�" %�%�$����(

3�" %���$��"�(

3�" %�""$���"(

���� %�!�$��!�(

���� ��=����=��

�� � ��; ���; �

���� ��� ������

��;� ����������

""��$�"3"(

!�" ��"�$���!(

��� ����$��3�(

�%" ��!"$���"(

��� ��3�$����(

��" %��"$����(

3�� %��"$��%"(

3%� %�%�$����(

3"" %��"$��"!(

3!" %�""$���"(

33" %�!�$��!�(

���" %���$���%(

��� ��; ���; �

�� ��� ������

��� ����������

��; ��� ���� �

"���$���"(

��� ���"$��3�(

��" ��!"$���"(

�"� ��3�$����(

�!" %��"$����(

�3" %��"$��%"(

3�� %�%�$����(

3�� %��"$��"!(

3�" %���$���3(

3�" %�!�$��!�(

���" %��"$���!(

��� ��; ���; �

��� ����������

��� ��� ������

��= ��� ���� �

��� �� �������

"!��$��3�(

��� ��!"$���"(

�%" ��3�$����(

��� %��"$����(

��" %���$��%3(

3�" %�%�$����(

3%� %��"$��"!(

3"� %�""$���"(

3!" %�!"$����(

33" %��"$���!(

���" ����$��3�(

��� ����������

�� ��� ������

��� ��������=�

��; �� ����;�

��� ��� ������

"���$�!%"(

��" ��3�$����(

�"� %��"$����(

�!� %��"$��%"(

�3" %�%�$����(

3�� %��"$��"!(

3�� %���$���3(

3�� %�!�$��!�(

3�" %�3�$��3�(

���" ����$��3�(

��� ��� ������

��� ����������

��� ��� ������

��= �� ����;�

��� ������� ��

��� ��= ������

"3��$�!�"(

�%" %��"$����(

��� %���$��%3(

��" %�%"$��"�(

3�" %��"$��"!(

3%� %���$���3(

3"� %�!"$����(

3!" %�3�$��3�(

33" ���"$%���(

���" ����$%��%(

��� ����������

�� ��� ������

��� ����������

��; ��� ��� ��

��� ��;�������

���� ���������

����$��%�(

�"� %���$��%3(

�!� %�%�$����(

�3" %��"$��"!(

3�� %��"$��!�(

3�� %�!"$����(

3�� %�3�$��3�(

3�" ���"$%���(

���" ����$%��%(

��� ��� ���� �

��� �� �������

��� ��� ������

��= ��=���� =�

��� ��; ����;�

��� ������=��

���� ������==�

@57<�J��))�# #����,�#������� ���#)� �� ������ �1� ���8����)�#��1� �� ���#���/�) ��������)#��������?#*��3�/�����������8���������� #����# #�

@57<�J� ���#�## �,#��,�,���#-)��,� ����� �� � ���%���� $�����&'(�

Page 9: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 9

567���<���

������7�B�������������

��&�'�#%$%&��+#:$�+2#%4�&#"-�)-#�8��

��$&9 � '

�$"?�') #�#& ��9<��9 �9<���9

��<���&#!.<�4�<$//)%#"3<��9��#'

��

�#&�*�!�"�&�"

��9<��9<�4�.3'�4

�9<���9��"$C��&�' � ���%

��$�# �''���%3<��3')%2���

+/ 6�%

�*�!�"�&�"��$'

<�4�.3'�4�+��� $C#"

��"$C��&�'�+��� $C#"

����%7!#�

��$�#����%7!#�

�''���%D�$�#%7!#�

3')%2<$//)%#"

���� 3�" ����� $�"( ����� $�!( ����� $"( ���"� $%!( ����� $%�( ����� $�!( ����� $��(

���� ���� ����� $�!( ���"� $%!( ���%� $!( ����� $�"( ���"� $%!( ���%� $%�( ����� $�!(

���� ���" ����� $%�( ���3� $�!( ���%� $!( ����� $"�( ����� $�"( ���"� $%!( ����� $%"(

���� ���" ���%� $%�( ���%� $"!( ����� $��( ����� $��( ����� $"�( ����� $�"( ���!� $��(

�����0�!� ���� �%�� ����� $%"( ���!� $�!( ����� $��( ���!� $�!( ����� $��( ����� $"�( ����� $"�(�����0�!������0�3� %��� ���" ����� $��( ��%�� $!!( ���"� $��( ��%�� $��( ���3� $!�( ���"� $��( ���"� $��(

%��� �"�� ����� $�"( ��%"� $�!( ���"� $��( ����� $���( ��%!� $3�( ��%�� $��( ��%�� $!!(

%��� ���" ���3� $�!( ����� $���( ����� $�"( ��"�� $���( ���"� $���( ��%3� $3!( ��%!� $3�(

%��� �!�� ����� $"�( ���!� $��!( ����� $�"( ����� $�"�( ��"�� $�%�( ����� $��3( ����� $��3(

%��� �!3" ���%� $"!( ��"!� $���( ���!� $�!( ��!%� $���( ���%� $�"!( ��"!� $���( ��"�� $��!(

%��� �!�� ����� $%�( ����� $%"( ���%� $!( ��%�� $3�( ����� $!�( ���%� $"!( ���"� $%!(

%��� �!3" ���%� $%�( ���"� $%!( ����� $��( ����� $33( ��%�� $��( ����� $�"( ����� $�"(

���� ��3� ����� $%"( ����� $��( ����� $��( ����� $��3( ��%�� $3�( ���3� $!�( ����� $"�(

���� �3�� ���"� $%!( ���!� $��( ���"� $��( ���3� $���( ����� $33( ��%%� $��( ����� $��(

�����0��� ���� ��!" ����� $��( ����� $�"( ���"� $��( ��"�� $�%�( ����� $��3( ��%!� $3�( ���!� $�!(

���� ��!� ���!� $��( ����� $"�( ����� $�"( ����� $��3( ���3� $���( ����� $���( ��%�� $!!(

���� ���" ����� $�"( ����� $""( ���!� $�!( ���"� $���( ��"%� $�%�( ����� $���( ��%"� $�!(

"��� �%�� ���3� $�!( ����� $��( ���3� $��( ���3� $�!�( ��"�� $���( ��"�� $���( ��%3� $3!(

"��� ��"" ����� � $"�( ���!� $�!( ����� $�"( ��!"� $���( ����� $�"�( ��"�� $�%�( ���%� $��!(

���� �3�� ���!� $��( ����� $�"( ����� $�"( ���3� $���( ����� $33( ��%%� $��( ����� $��(

���� ��!" ����� $�"( ����� $"�( ���!� $�!( ��"�� $�%�( ����� $��3( ��%!$3�( ���!� $�!(

���� ��!� ����� $"�( ����� $"�( ���!� $�!( ����� $��3( ���3� $���( � ����� $���( ��%�� $!!(

���� ���" ����� $"�( ���%� $"!( ����� $��( ���"� $���( ��"%� $�%�( ����� $���( ��%"� $�!(

�����0�"� "��� �%�� ����� $""( ����� $�"( ����� $��( ���3� $�!�( ��"�� $���( ��"�� $���( ��%3� $3!(

"��� ��"" ����� $��( ��%�� $!!( ���3� $��( ��!"� $���( ����� $�"�( ��"�� $�%�( ���%� $��!(

"��� �""� ���"� $��( ��%�� $�"( ����� $�"( ����� $��%( ����� $��3( ��"�� $�%3( ���!� $��!(

"��� ���� ����� $�"( ��%�� $3�( ����� $%�( ����� $��3( ��!%� $���( ����� $�"3( ��"�� $��3(

"��� �!%" ����� $!�( ����� $33( ���%� $%�( ��3!� $���( ��!3� $�3�( ���3� $�!�( ��"�� $���(

���6���<�33����������7�<���

��//#+&$*#�2"�4���-#

9��#'����$"?�') # ��<��

�&#!.<�4�3<��3')%2

+/ 6�% /&� /&�

���" ���� ��� �� �3 !���3 ��� �� �� !����

�����0�!� %��� ���" �!� �� %% �� �� �� �"� �� %� ����3�����0�!������0�3� %%!" �"3" %�� �� %! 3����� ��� �� %� 3� �� ��

%!"� �!!� %�� �� �� ��� �� �� %�� �� %� 3� �� ��

���� ��!" %�� �� �� ��� �� �% %�� �� �� ��� �� ��

�����0��� �3"� �%%" %�� �� �! ��� �� �� %�� �� �" ��� �� ��

""�� �"3" �%� �� "� �%� �� �� ��� �� "� ��� �� �"

���� �3�� %3� �� �� ��� �� �� ��� �� �� ��� �� �"

�����0�"� "��� �%�� ��� �� "� ��� �� �" �%� �� "� �%� �� ��

"��� �!%" �%� �� "� �%� �� �� �"� �� "� ��� �� ��

�7���1���� �������+�� #)������� ��#)��� #���� #��#��� ��#,� �#��)�����)�#���*� ����� 0)� I����//�����-�/���� ���,#��,�,���)��� 8���������� ��"��/ ��$�"�,(�����,��� ���;�������������

Page 10: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 10

78��7��6������7����

�&# ���������.��� ���������.�;�

5�&&� 8�4#"��&", �40""!"!��� �������:����)-���$"�&*(

��$'�)�"�:�?A����# ��� ��)�1����*�#��� ����� �� ��� �������)��@� �����1� ��6#�)���#��� ��6��

���&"�'�,%&# % ���� 5� ���#)� 7�,���# ���� ��� ��)�� �8� �,�

� � � & < ) - � � )) � 7 ���.�%����) ��E;� ;�8��

�"���+�%#�#�&#"%:<����������������,��������)�-���# ����# �#))� �,����7�,���# ����#� �0# �

������) ��E=; �;E��# ��

"!"���) ��F= �;E��

<$//#"#�&$�'��&2�'!,���&"�'� �� ;������� 1� �� �����,�+���#,���� ���)�0� # �� �� ���� #����������#))�1���)�� ����-� 1������ ����#���#���� ����#���$1����������#��)�1�� ��� �#)�8(

����

<$//)%#"%��&#!.<�4������)�,���,�*��))�� ���-)���/)�� ����)������ �)#�*����� ���*��))� �����)# ���//����-���1� ��/)#�*�� ��#�*��*����*��/������� ��� ������ �#��� ����$�����#���/)�1( ��� ���#))8���#)��$������ ����0�����)# ���( �##� �� ��70-#�����)��*�*��������)#� ������)��*�

�7=��03"��"� )-��� $"!� &*(

<$//)%#"%�3')%2�� ���)�,���,�*��))�� �/����-)#�� )������ �)#�*�� ��� ���*��))� �����)# ���//�����-���1� �/)#�*�� ��#�*��*����*��/������� ��� ������ �#��� ����$�����#���/)�1( ��� ���#))8���#)��$������ ���������)#0 ���( �##� �� ��70-#�����)��*�*��������)#� ������)��*�

;=��03"3"� )-��� $�%�&*(

�"��%$&$��%��)!!',����#&)"���������1� ���//����� ���� #))��������/�,��� ��*�/�#,� �*#)�#��+��� ��)���� ��� ��� �/)#�*���/��������/����� ������� ��� �/�))8�����)# �

��7��0�3%�� )-��� $�!�&*(

�+��� $C#"<� !#"%�<�4�.3'�4�� ��:���#���#))8�)��&���������)# ��#���#���� 0���� #���#,���� � �)�*0��������� ����� ����� � �8)���-�#���*� � � #��)����� ��)��#)��$�� ����#,����( ������) �/�))8�,��)# ��*������*��� ����#,����,� �� �#0>�� #-)��,���,�,�#,�������� �����1� �� �,���� #������ ��))�� � ��)�0� # �� #0

:��)�@����@� �' �

�<:=��:0�3���)-���$�!�&*(

>�� #-)��,���,�,�#,�������� �����1� �� �,���� #������ ��))�� � ��)�0� # �� #0>�� #-)���� ����#����� �#)�8���� ��) ��� �����G��� ����#���#>�� #-)� �*�#�� 8���0�#�� �#���#,�����/������� ���1������#,�)��#�� �/�����@57<����;�����#��.���#�� �#�������1� ���)�#�#-)��#)�,���,�,����/�#,��/�) �� ������9����#��,�� �-�����������#�# �)8�/���/��)���� #))# ����$����-�)�1(

@� �/#��#��#

����/ ���$�����,�(

�+��� $C#" <� !#" ���� �<�4� /'�4� ;�� ��� 1� � �<:=��: �����,�+�� #,����5����@�� ��6 =

�+��� $C#"<� !#"�����<�4�:/'�4����;�������1� ���<:=��:� �����,�+���#,����$����#-���(�� :�� �-�����������#�# �)8� @���F���+�

�/�;�) ���$�(�%���.��������.�����

$��3�����3����"(

�+��� $C#"<� !#"%���"$C��&�'�� ��:���#���#))8�)��&���������)# ��#���#���� ����#���#,�0��� ��)�*0��������� ����� ����� ��8)���-�#���*� �� #��)����� ��)���#)��$�� ����#,����( �����) �/�))8�,��)# ��*������*��� ����#,����,� �� �#>�� #-)��,���,�,�#,�������� �����1� �� ,����#������ ��))�� ���)�0� # ��#>�� #-)���� ����#����� �#)�8���� ��) ��� �����G��� ����#��#>�� #-)� �*#)�#��+��� ��)��#-��� �/)#�*��#���������*������� ����#������ ��� ���1������#,�)��#�� /����� �/�))8�����)# ��@57<���5� ����#�������1� �� 1���)�#�#-)��#)�,���,�,����/�#,��/�) ���������9�����#��,�� �-����������#�# �)8��)�����9�������� ���#)�6���+�� #)�����)8�#���� ��������B� �/����� ������� ���

<:=6��:0�3����)-���$"��&*(

�+��� $C#" <� !#" ���� ���"$C��&�'� ;�� ��� 1� � <:=6��: �����,�+�� #,����5����@�� �=�=�

�+��� $C#"<� !#"�������"$C��&�'����;�������1� ��<:=6��:� �����,�+���#,����$����#-���(�� :�� �-�����������#�# �)8� @���F���+�

�/�;�) ���$�(�������"����

$�������%"����"(

�+��� $C#"�"�*$&,�G2�)%&<� !#"%���"$C��&�'�� �� ;������� 1� �� <:=6��� ����+�� #)� �����,�+��#,������� ���� � 1�������������# ��/�-��*)#���#,�����/������� ��#�������/������� �-���������/�������

�<=��0�3.��� $"� )-��(� $�� &*(@� � /#��� #��#� �� ���%� �9�� / �� $����� ,�(�����1� �

<:=6��:

��$'�)�"�%����6�#�8�� 8�/��)���� #))�����)�*�#����� �� �����)��/��,�#,#*���@� �����1� �����)���#��� ��6��

��"$C��&�'�)!!',����#&)"��$"E$&���?��������� ������� ���� ����� �/)#�*���/������� ��#�1#���/��0����� � 1��/�))����#��)��/��������/���������#���������*� �/�) ���#�������#��)�/�������

�40""!"�4�� �������%�� )-��� $���&*(

6�4� 0$#�&���&"�'%�:�))�1����� �����# �����1�� ����;� $��!�!��( �40"!��%4��������� �40"!��%4�� �� F=��

68��8"�!��#E$&% $�4��!�"36( =6��

7)&���"�$"<� !#"�#+&$��������&��,���#���#)�#,���� ��� ����#�*�#-)����� ��#��)�/��0������ $�1�0/)�1� #��)��# ����( � 1�0������ �#-��� � $��� ��)� #�����( � �)�#�#-)�� ��)8���0 �#�� /�#,� 8�� /�) �� /������� � � �"G $/���( �� ��� #�� #>�� #-)� ,#��#) �� #� �

:��)�@����@� �' �

5�=��0�3��� )-��� $�3�&*(

�#���/�#,�� 8���/�) ���/������� ��� ���"G� $/���(��� ����#���#>�� #-)� �,#��#)����#� �0,# �������# ����$&� ���9�����/���#� �,# �������# ���( ���� #))�������� �/����1�0/)�1�#��)��#0 ���� ���� #))������� ����#����� �/�������+�� #)�#��)��# ����

@���F���+��/�;�) ���

$�(������������$���� �� "��� �� �"(

7)&���"�$"<� !#"9�&�"$C#�<� !#"E$&���%����� ����#,����#� �# �� ��)�*0��������� ��� � ���:�!�)-���$%�&*(

���/9�)�&$�-3"� #���@#�)���� ����/������� �,# ��� ����� ������@# ���#)����/��*���� �#� ����������� �������&���&���1�

�:;��0�3��!� )-��� $�3� &*(

�'#+&"$+�#�&:�;#� ��8����/��)���� #))� ���)���1����������,���)�,�� � � �,���)#8�/����)�,�� �� #*��* ������#)��)�,�� �)�,� ���� ��)� �,#8�-�� 1�0� #*����� ��))� ���9�������� ���#)�;����4)��&

<�6��0��.3"

��0�"0��0%�0��� &'

$#))� ��) #*��(

��$& 3 %# 5'�+� ��9 ��� /�� �)�� ��� ��# ��� #))# ��� ����* �#����� #� ,� � ��*���.�%���) �6��$"�� #,�(

��$&3)%#5'�+� :� ��9����� /��� �)�� ���� ��# � ��� #))# ��� � 1����*� �#������ #�� ,��� ��*����1� /�������

������) �6��$�"� #,�(����1��/�������

"!"���) �6��$��� #,�(

Page 11: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 11

78��7��6������7����

�&# ���������.��� ���������:� �

5�&&� 8�4#"��&", �40""!"!��� �������:����)-���$"�&*(

��$'�)�"�:�?A����# ��� ��)�1����*�#��� ����� �� ��� �������)��@� �����1� ��6#�)���#��� ��6��

���&"�'�,%&# % ���� <�*�������*� 6#�-��&

�"���+�%#�#�&#"%:<����������������,��������)�-���# ����# �#))� �,����7�,���# ����#� �0

���.�%�A

��E;��"���+�%#�#�&#"%:<����������������,��������)�-���# ����# �#))� �,����7�,���# ����#� �0

# �� ����A ��E=;

"!"�A ��F=

<$//#"#�&$�'��&2�'!,���&"�'���;�������1� �������,�+���#,���� ���)�0� # ���� ����#����������#))�1���)�� ����-� 1������ ����#���#���� ����#���$1����������#��)�1�� ��� �#)�8(

����

<$//)%#"%��&#!.<�4������)�,���,�*��))�� ���-)���/)�� ����)������ �)#�*����� ���*��))� �����)# ���//����-���1� ��/)#�*�� ��#�*��*����*��/������� ��� ������ �#��� ����$�����#���/)�1( ��� ���#))8���#)��$������ ��������)# ���( �##� �� ��70-#�����)��*�*��������)#� ������)��*�

�7=��0�%"��"� )-��� $3%� &*(

<$//)%#"%�3')%2�����)�,���,�*��))�� �/����-)#��)������ �)#�*����� ���*��))� �����)# ���//�����-���1� �/)#�*�� ��#�*��*����*��/������� ��� ������ �#��� ����$�����#���/)�1( ��� ���#))8���#)��$������ ���������)#0 ���( �##� �� ��70-#�����)��*�*��������)#� ������)��*�

;=��0�%"�!�� )-��� $!3� &*(

�"��%$&$��%��)!!',����#&)"���������1� ���//����� ���� #))��������/�,��� ��*�/�#,� �*#)�#��+��� ��)���� ��� ��� �/)#�*���/��������/����� ������� ��� �/�))8�����)# �

��7��0��%�� )-��� $�!�&*(

�+��� $C#"<� !#"%�<�4�.3'�4����:���#���#))8�)��&���������)# ��#���#���� ���#���#,���� ��)�*0��������� ����� ����� ��8)���-�#���*� �� #��)����� ��)���#)��$�� 0����#,����( � ��� ��) �/�))8�,��)# ��*������*��� ����#,����,� �� � #>�� #-)�,���,�,�#,�������� �����1� �� �,����#������ ��))�� ���)�0� # ��#>�� #-)���� 0��� #�� �� �#)�8 ��� ��) � � ���G �� ��� #�� #>�� #-)� *�#�� 8 ���#�� #�� #,�0

:��)@����@� �' �

�<:=��:0�����)-���$%��&*(

�<:=��:��"����)-��$�"�&*(

����#����� �#)�8���� ��) ��� �����G��� ����#���#>�� #-)� �*�#�� 8����#�� �#���#,�0����/������� ���1������#,�)��#�� �/�����@57<����;�����#��.���#�� �#�������1� ���)�#�#-)��#)�,���,�,����/�#,��/�) �� ������9����#��,�� �-�����������#�# �)8�/���/��)���� #))# ����$����-�)�1(

@� �/#��#��#

����/ ���$�����,�( %���/ ���$��%%�,�(

�+��� $C#" <� !#" ���� �<�4�:/'�4� � ;�� ��� 1� � �<:=��: �����,�+�� #,����

5���@��

��6�� �=6��

�+��� $C#"<� !#"�����<�4�:/'�4�� ��;������� 1� ���<:=��:� �����,�+���#,����$����#-���(�� :�� �-�����������#�# �)8� @���F

��+���/;�) ���

$�(�%���.��������.�����$��3���"������"(

$�(�����.��������.�����$�������"������"(

�+��� $C#"<� !#"%���"$C��&�'����:���#���#))8�)��&���������)# ��#���#���� ����#���#,�0��� ��)�*0��������� ����� ����� ��8)���-�#���*� �� #��)����� ��)���#)��$�� ����#,����( �����) � /�))8� ,��)# ��*� �����*� �� ���� #,���� ,� �� � #>�� #-)�� ,���,�,� #,���� ���� ����1� �� �,����#������ ��))�� ���)�0� # �� #>�� #-)���� ����#����� �#)�8���� ��) ��� �����G�� ����#���#>�� #-)� �*#)�#��+��� ��)��#-��� �/)#�*��#���������*������� ����#������ ��� ���1�����#,�)��#�� �/����� �/�))8�����)# ��@57<���5� ����#�������1� �� 1���)�#�#-)��#)�,���,�,����/�#,��/�) ���������9�����#��,�� �-����0�������#�# �)8��)�����9�������� ���#)�6���+�� #)�����)8�#���� ��������B� �/����� ������� ���

<:=6��:0���%"�)-���$���&*(

<:=6��:��"��!� )-�� $�"� &*(

�+��� $C#" <� !#" ���� ���"$C��&�'� � ;�� ��� 1� � <:=6��: �����,�+�� #,����

5���@��

�=�=� �=���

�+��� $C#"<� !#"�������"$C��&�'�� ��;������� 1� �� <:=6��:� �����,�+���#,����$����#-���(�� :�� �-�����������#�# �)8� @���F

��+���/;�) ���

$�(�������"����$�������%"����"(

$�(�������"����$"��� �� �%"� �� �"(

�+��� $C#"�"�*$&,�G2�)%&<� !#"%���"$C��&�'�� ��;������� 1� ��<:=6�������+�� #)������,�+��#,������� ���� � 1�������������# ��/�-��*)#���#,�����/������� ��#�������/������� �-���������/�������

�<=��0�3.�� �$"� )-��(� $��&*(@� � /#��� #��#� �� ���%� �9�� / �� $����� ,�(����

1� �� <:=6��:

��$'�)�"�%����6�#�8�� 8�/��)���� #))�����)�*�#����� �� �����)��/��,�#,#*���@� �����1� �����)���#��� ��6��

��"$C��&�'�)!!',����#&)"��$"E$&���?��������� ������� ���� ����� �/)#�*���/������� ��#�1#��/������� � 1��/�))����#��)��/��������/���������#���������*� �/�) ���#�������#��)�/�������

�40""!"�44�� ����

%"� )-��� $���&*(

�4�""!"�4�$ ����(

%3� )-��� $���&*(

6�4� 0$#�&���&"�'%�:�))�1����� �����# �����1�� ����;� $��!�!��( �40"!� �%4'� � �6=��

68��8"�!��#E$&% $�4��!�"36(� =6��

7)&���"�$"<� !#"�#+&$��������&��,���#���#)�#,���� ��� ����#�*�#-)����� ��#��)�/��0������$�1�0/)�1�#��)��# ����( � 1�0�������#-��� �$��� ��)�#�����( ��)�#�#-)����)8��� �#��/�#,� 8�� /�) �� /������� � � �"G $/���( �� ��� #�� #>�� #-)� ,#��#) �� #� �,# �� ��

:��)@����@� �' �

5�=��0���%� )-��� $���&*(

5�=����""�� )-��� $�%�&*(

/�#,�� 8���/�) ���/������� ��� ���"G�$/���(��� ����#���#>�� #-)� �,#��#)����#� �,# �����0��# ���� $&� � ��9����� /��� #� �,# ��� ����# ���( � ��� #))�� ��� ��� � /��� �1�0/)�1� #��)��# ���� ��� #))������� ����#����� �/�������+�� #)�#��)��# ����

@���F��+���/;�) ���

$�(������������$���� �� "��� �� �"(

$�(������������$���� �� "��� �� �"(

7)&���"�$"<� !#"9�&�"$C#�<� !#"E$&���%����� ����#,����#� �# �� ��)�*0��������� ��� � ���:�!�)-���$%�&*(

���/9�)�&$�-3"� #� �� @#�)���� ����/������� � ,# ��� ����� � ����� @# ���#)����/��*� ��� �#� ������0����� ��������&���&���1�

�:;��0����3� )-��� $"��&*(

�'#+&"$+�#�&:�;#� ��8����/��)���� #))� ���)���1����������,���)�,�� � � �,���)#8�/����)�,�� �� #*��* ������#)��)�,�� �)�,� ���� ��)� �,#8�-�� 1�0� #*����� ��))� ���9�������� ���#)�;����4)��&

<�6��0�%"

�"0��0%�0���"�� &'

$#))� ��) #*��(

��$& 3)%# 5'�+� ��9���� /�� �)�� ��� ��# ��� #))# ��� 1����* �#����� #� ,��� ��*���.�%���) �6� $!�� #,�( �6� $!�� #,�(

��$&3)%#5'�+�:� ��9�����/��� �)�� ������# ���� #))# ��� � 1����*��#������ #��,��� ��*����1� /�������

������) �6��$%"� #,�( �6��$%"� #,�(����1��/�������

"!"���) �6��$�"� #,�( �6��$%�� #,�(

Page 12: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 12

3������

�?�87���7��7�6

567���97�7�

78��7��657��7987�������B

�7�<�����3��

�7�<������7�6

�7���7657@

�798����7�����2�%��#+� !"#%%�"�

5������

���?�6?�

�795����7������<����

�����@���������5��3�6���������@��@�H

��<�87�������B

��������7���76�����7�

36��57@�7?��

�����8�����������9����:�;� ��#'%2�4��

3������

�����8�����������9����:�;� ��#'%2�4��

�?�87���7��7�6

567���97�7�

�7�<�����3���:���:� ���?��3����

�7�<������7�6

�7���7657@

�798����7���:���2�%��#+� !"#%%�"�

3�6�������

�6����������9�E��857@

�6���������������7�

Page 13: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 13

3������

���������:�����;��7���7657@

3����8����7���������;�:�7�6B�

��7��<

E��7��<77�3����6�B��;�7�6B�

�5��E��798����7�

�7�����7���;�7�6B�

IE���795����7������6�B�����;�:��

E��798����7��7�����7�

���7?��67�<������

� ��J7�6B�

E�567����7�����7�

�����37�9����

�����37�9������F?76�7�6B�

IE��$%'�+�&#�$�&2#2#�&%#+&$���������:�������;�:�)�$&%�

3������

���������:����� ��7���7657@

��3����8����7�

�������37�9��

�������37�9��

��7��<

E��7��<77�3����6�B

�5��

E��798����7��7�����7�

E���795����7������6�B����7�6B�

E��798����7��7�����7�

���7?��67�<������� ��J7�6B�

E�567����7�����7�

��3����8����7�

Page 14: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

I-APPLICATION

GCS/CHA16 6 and 7.5 ton units are available in one cabinetsize and GCS/CHA16 10 and 12.5 ton units are available inon size. All models are applicable for commercial threephase installations. GCS/CHA16 models are factoryequipped with the hardware required for installing optionalthermostat control systems like the T7300 or T8621D (referto the Engineering Handbook for more specific applicationdata).

II-UNIT COMPONENTS

GCS16 unit components are shown in figure 1. CHA16 unitcomponents are shown in figure 2.

A-Control Box Components

The GCS/CHA16 control box is shown in figures 3 and 4.The control box is located in the upper portion of the com-pressor compartment behind the compressor compartmentaccess panel. Note that the burner ignition control (GCSmodels only) is located in the heating control section locatedjust above the manifold/burner assembly.

The condenser fan can be accessed by removing the fangrill located on the top of the unit.

The indoor blower access panel (all units) is located to theleft side of the heating compartment access.

1-Transformer T1

All GCS/CHA16-072/090/120/150 units use a single linevoltage to 24VAC transformer mounted in the control box.The transformer supplies power to control circuits in the unit.Transformers are rated at 70VA and are protected by a 3.5amp circuit breaker (CB). Transformers use two primaryvoltage taps as shown in figure 5.

2-Terminal Strip TB34

Terminal strip TB34 distributes 24V power from transformerT1 to the control box components.

3-Transformer T3 (G & J Voltage Only)

All GCS16-072/090/120/150 G and J units use one 230VACtransformer mounted in the control box. The transformer hasan output rating of 115VA .55A @ 230V. T3 transformersupplies 230VAC power to combustion air inducer motor B6.

CAUTION

Remove all power to disconnect beforeservicing.Electrical shock resulting in death or injurymay result if power is not disconnected.

Page 14

4-Outdoor Fan Relay K10

Outdoor fan relay K10 used in GCS/CHA16-090/120/150units, is a DPDT relay with a 24V coil. K10 energizesoutdoor fans B4 and B5 (120/150 units) in response tothermostat demand.

5-Cooling Contactor K1 & K2

K1 and K2 are 24V coil contactors used to energize thecompressor(s) in response to thermostat demand. In GCS/CHA16-072 units, K1 energizes condenser fan B4 alongwith compressor B1 and K2 energizes compressor B2 inresponse to second stage cooling demand. All GCS/CHA16-072/090/120/150 units use three-pole-double-breakcontactors.

6-Indoor Blower Contactor K3

All GCS/CHA16-072/090/120/150 units use a three-poledouble brake contactor to energize the indoor blower andoptional economizer. The coil is energized by a blowerdemand from indoor thermostat terminal “G” (coolingdemand or fan switch in “ON” position).

7-Condenser Fan Motor Capacitor C1 & C2

GCS/CHA16-072/090/120/150 series units use single phasePSC condenser fan motors. See condenser fan motornameplate for capacitor ratings.

B-Heat Control Section (GCS Only)

Page 15: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 15

�:�-�$&$�����&"�'��

<������2�+���C�"��

�!�"�"#'�&#�+� !��#�&%+��&�$�2$-2*�'&�-#�<$%+���#+&!�4#"0#/�"#%#"*$+$�-)�$&�>�2#$-�$&$��+��&"�'$%��&/$#'�"#!�$"�0'#�

���+�)%#)�%�/#�!#"�&$��$�()",�"�#�&2�

�����7��'#+&"�%&�&$+�$%+2�"-#+���//#+&#'#+&"��$++� !��#�&%����#!"#+�)&$��%�)"$�-)�$&

$�%&�''�&$�����%#"*$+#&�!"�&#+&&2##'#+&"��$++��&"�'%�8"#+�)&$��%4$''2#'!&��*�$�+��&"�'#G!�%)"#&�#'#+&"�%&�&$+�$%+2�"-#0,!)&&$�-&2#)�$&&2#+��&"�'���&2#&#+2�$+$���&&2#%� ##'#+&"�%&�&$+!�&#�&$�'��#)&"�'$C##'#+&"�.%&�&$++2�"-#0,&�)+2$�-2�������''&��'%����)�!�$�&#�)�$&%)"/�+#%)+2�%&2#-�%*�'*#�"0'�4#"�#+�0#/�"#!#"/�" $�-��,

%#"*$+#!"�+#�)"#�

�6����7������<�����������<�

8"#+�)&$��%���8"�+#�)"#%

���� �������3���� ,��)���� ��#�� ��������.�"����� �

1�))�-���9������1� ��#�;��1#)��*�� ������� ��)������/�*���

!�� �������!�� #�� �������3���� ,��)� ��� �� 1�))� -�

�9������1� ��#�L���������� ��)������/�*�������7����*�� ���

��� ��)��������� ����� ,#���/��� ����P�*#���#)������ ��)

�*�� ��� �#��/)#,��������*�� 7������ �1�))����#))8��*�� ����

���/��� � # �,� H���1���� � ��� �*�� ���� # �,� ���9�����

�������� ����� ��#)��/����*�� ����-�/����)��&��*��� ���/ ������

���� � ��� �*�� ���� ��� ��)� #� �,# ��#))8� ���� �� #�� �������

�����,����# �,� ��# ��*�� �����:#��#)����� �#/ ���)��&�� ���0

9������-��#&��*�#����,#&��*���1��� �� ����*�� ������� ��)�

����/�*����3� $;��1#)���� ��)(����/�*���� ��� $L���������� ��)(

/�����*�� ������9������1� ���� ��#)�� �,��*��

;)#,����� �/��# ����������*�����������#))���������� ��

������/�/)#,������*�#���# ��*��8�)���������# ��-8�#��#-0

�������/�/)#,����*�#)�� /� �����#����� � ������ ��)�1�))��,,��0

# �)8���� #� � ����*�� ������9������#�� ����)��&��� ��/��*�� ������

�� �*#����#/ ��� ��� ���� ��#)������� #-)����/���,����#,����*�#)

�#)���

7�����*�� ������� ��)���� ���//�*#��/)�1��,,��# �)8���� �������

�/�#���1���/#�)������������� ��# �����/�*#��#����1�� � ������0

��)�1�))���� #� � ����*�� ������9������#����� ������� �)�/)#,����

�� #-)���������8� �,�)��&���� �

5��#���# ��*��,#� � ��� �����,-�� ����#�����������������0

*�+��� ���� ��� ��,-�� ���� #������������#���/�))����� � ��

��,-�� ���� #��������� �1� ��� � ���� �)����� ����*�+��*��*�� ���

��� ��)��%�� 7��� �*�� ������� ��)� �����#�� #� %�� �� ��� �����

�)#8� �� #))�1� ��� ��,-�� ���� #���������� �� ���*�� ���#��

*#����/��,� �����,-�� ������#,-���#���� ������/�����#���

�/ ��� ����)#8 � ����*�� ������� ��)�� �����#� ��# ���*#���#)��

�����#�&��)�� ����#�� ���/)#,��������*��)�� �������#�&0

��*�� �����,,��# �)8�#/ ���/)#,������������7�����,-�� ���

#��� ������� � ��� ������ �� ����# �� ����*��� � ��� ��# ��*� �0

,#���/� ���/)#,��/#�)������/� ���-����������� ��*�� � � ����*�� ���

��� ��)�1�))�# �,� � ���*�� �� ���-���������� �� 1��,���� �,����/

�*�� �����#��� �-�� �- #���� #/ ��� ��� ���� # �,� � ��� ��� ��)

1�))�)��&��� ��7����*�� ������� ��)������ �#>�� #-)��

7���L���������� ��)�����))�� �# �����/�*��������7�����#�����0

��� �����#������� �������� � ������ ��)� ����� ��<#����/� ��

��#�� ��,��#)�� #��� ��� �/���-8�/��� ����� 7��� ��#�&� �)��0

����1���������� �� �� �����#�&0�)�*0 8��������� ������ ��

�/� ������ ��)�

3������

�8��E

����?76����

87������?����8���

�7���?�6?����?��7��8���

�736�9�����7�

��7��<

�78?���

3����6������7��7���76

F7���7�������7��7���76

3�����=

��56��

9��)/�+&)"#"�� $��'�$-��'9$+"�� !%

<"�!7)&

L56@�5@ ��"���� ��3

;<@'��� ���� %

Page 16: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 16

��<73<�9��<

ÉÉÉÉ

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉÉÉ

����97����<�9��<+� 0)%&$���$"567���

���?�6?�������7��8��E

567���

������7�����6

���7�<� � ��7�

733

3����6:������7��7���76��9���

ÉÉÉÉÉÉ ÉÉ

ÉÉÉÉ É ÉÉ

ÉÉ

�� ����������B�6�

��=�K���:����������<73����97����

<�9��<

� � �

4)�1���� #� ��%�� ���"��������#/ ���/)#,�������������'�����*��0 ��������������#�8� ��#) � �����# ��*��8�)��-�*������*�� ������#�&��,#��� ����/���#� � #)��/�����Q%�� �������������/��,� ���-�*��0���*��/� ��� ��#)���������/� ���/)#,���������� �� ��)�����/�/)#,�����*� ��� ��# ��*� �8�)� � *#�� �#)��� ��,#���������#���*�� �����#�&�-�*����/���������������/�/)#,������ �� ��-�/���� ������/���������� ���#�&�� ����#�� �����# ��*��8�)����� ��������//)#,������� �� �� ������*� ��������������*�� ������ ��#) � ����� ��)��8�)��� ����*�� ��� ��,�)� �� �*�� ���� ��9������ -�/���)��&��*��� ����K��%#+�

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉ

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ ÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉÉÉÉÉ

3����6�7�9�6������7���L�������9�����79���6

����97����<�9��<

+� 0)%&$���$"567���

���?�6?�

������7��8��E

567���

������7�����6

���7�<�� �� � � ���

7���67��<

733�78��

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ+� 0)%&$���$"8�7?�������

��

������6�:������7�����98���L�����:��9�����79���6ÉÉÉÉÉÉ

ÉÉÉÉÉÉ

����97����<�9��<+� 0)%&$���$"567���

���?�6?�������7��8��E

567���

������7�����6

���7�<�� �� � ��7�

733

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉ

ÉÉÉ

ÉÉ

� �����

�����������97����5B5���E���<�9��<

3����667�E7��

+� 0)%&$���$"8�7?������� ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

� � �

3�����;

3�������

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉ

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ ÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉÉÉÉÉ

F7���7��7�9�6������7���L�������9�����79���6

����97����<�9��<

+� 0)%&$���$"567���

���?�6?�

������7��8��E

567���

������7�����6

���7�<� � �� � � ���

7���67��<

733�78����<73<�9��<

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

+� 0)%&$���$"8�7?�������

��

������6�:������7�����98���L�����:��9�����79���6ÉÉÉÉÉÉ

ÉÉÉÉÉÉ

����97����<�9��<

+� 0)%&$���$"567���

���?�6?�������7��8��E

567���

������7�����6

���7�<�� �� � ��7�

733

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉ

ÉÉÉÉÉÉ

ÉÉ

� ��� ��

���������<

67�E7��

+� 0)%&$���$"8�7?������� ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉ

ÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉÉ

ÉÉÉÉÉÉ

����97����<�9��<

+� 0)%&$���$"567������?�6?�

������7��8��E

567���

������7�����6

���7�<�� ��

7�

733

������7��7���76��9���

ÉÉÉ ÉÉ

ÉÉÉÉ ÉÉ

ÉÉ ÉÉÉÉÉÉ

�� ����������B�6�

��K���:�������� ��<73����97����<�9��<

� � �

������ �������

Page 17: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 17

�:�� 0)%&$���$"���)+#"�#'�,E��

��)#8 �B�%� ���#�=?=7���)#8�����# �������#��/�))�1�P��!��#�

�3��� �,��)����� �����# ���� ��)���� ��� � �3���� #�� ���.�"�

,��)����� ������ ��)�-����B�%��������*�+��-8���# ��*��0

,#��/��,� ��� ���,�� # �#���������*�+�� ����*��� � ��

��# ��*��,#����'��������*�+� �B�%����,#))8���������0

#� ���)���� ������*�+�� �����,-�� ����#����������#��-�*��

#� ��# ��*� ��9������

�:�����"5'�4#"<#'�,�#'�,E�

��)#8 �B�"� ���#����� �������� �-�#�� )��# �� ��� �����# ��*

��� ��)���� ����1��������������1� �� ���*#���#)����B�"�����0

��*��� ���������#��������-)�1����)#8��/��"����������

�,��#���"����������//� �,������*�#���# ��,#���'���

��������#��,#��/�����# � ���*#���#)���1�))������#�� ��

��� �,���)#8�1�))�-�*����'������# ��,#������# ��/��� ��

*#���#)���1�))��)����#�� ����//� �,��1�))�-�*���

�:�����"5'�4#"6$ $&�#'�,E����)#8�B��� ��� #� =?=7� ��)#8�)��# ����� ��� ��� ��)�-�����

�������3����,��)��#����� �����# ��*���� ��)���� ����/��

�������!� � �������3���� #�� ���.�"�� ,��)��� ��)#8

B������1��������������1� ��)�,� �����#�������/��� ����)�,�

����� �B�������� #� ���)���� ����*�+��*�-)�1������ #� ��

B%�� ��,�) #�����)8 � �B����� ��� #� �������������*�+��*

���*#���#)���

:��%<#'�,<6��%&�-#��#'�,�7�,�� �)#8� =�%� ��� )��# �� ��� ��� ��# ��*� ��� ��)� ��� ����

�������������*�������#�����# ��,#� �=�%���� �# ���#����

������ �,���)#8�-�/�����)����*�� ��@�5����� #� ����/ ��� ��

�)#8 �=�%�����*�+���'����� ���*#���#)���-���*��*�������

� #*����# ��=�%����1��������������1� �� ���*#���#)���#����0

����-)�1���)�,� ���)#8�B���

�:�#�&$�-�� !��#�&%

�:�#�&�G+2��-#"�3$-)"#%��������

�))�������� ������#��#)�,���+��� ��)� �-�)#����# �����#�*0

���� <#��� �-�� �#�� #� ,# ����*� ����� � -������� ��,-�� ���

#&��� �)#��� # � �#��� �-�� �� �#���� #�� ��� �#1�� ��1#��

����*�� �#��� �-�� -8� ��� ��,-�� ���� #��� -)�1���� � 6�# � ��

�#��/�����/��,� #))� ���/#���� �/� ��� ��# � ����#�*��� �-���

7�� � ����)8� #��� -)�1�� � ��� ��))�� -8� ��� �*�� ���� ��� ��)

/������#���#������#))����/#�����/� ��� �-��� ���� �#� � �����#

�/� �����,-�� �����7�����#����/� ��� �-����������,#��,�,

��# � ����#�*��

�����:�������;�:������@�����������956B

3�������

5�����

�795����7��������956B

?����7�����7�

���?�6?�

�����@���������5��

36��57@

�����:�;�:�:����� ������@�����������956B

3�������

5�����

���?�6?�

�����@���������5��

36��57@

�795����7��������956B

Page 18: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

2-Burner Assembly (Figure 13)

The burners are controlled by the spark electrode, flamesensing electrode, gas valve GV1 and combustion airblower B6. The spark electrode, flame sensing electrodeand gas valve GV1 are directly controlled by ignition controlA3.

a-Burners

All units use inshot burners. Burners are factory set and donot require adjustment. Burner shutters are designed to befully open only. Units are furnished with a peep hole withcover in the access panel for flame viewing. Always operateunit with access panel in place. Burners can be individuallyremoved for service. Burner maintenance and service isdetailed in the MAINTENANCE section of this manual.

b-Orifice

Each burner uses an orifice which is matched to the burnerinput. The orifice is threaded into the manifold. The burner issupported by the orifice and will easily slide off for service.

Each orifice and burner are sized specifically to the unit.

3-Flame Rollout Switch S47 (figure 14)

Flame rollout switch S47 is a high temperature limit locatedjust above the burner on all units. See figure 13. The limit isa N.C. SPST manual re-set thermostat connected in serieswith ignition control A3. When S47 senses flame rollout,ignition control immediately closes the gas valve. The switchis factory set to open at 180o and cannot be adjusted.

Page 18

4-Primary High Temperature Limit S10

S10 is the primary limit for gas heat. See figure 15 for bothtypes used. On GCS16-090-1 models units, S10 is locatedin the heating compartment and mounted to the lowerportion of the panel dividing the heating compartment fromthe blower compartment. On GCS16-072 and GCS16-090-2models, S20 is located in the return air area. On GCS16-120/150 models, S10 is located in the blower compartment.Primary limit S10 is wired in series with the burner controlA3. S10 N.C. contacts open to de-energize the ignitioncontrol when excessive heat is reached in the heat ex-changer. At the same time, the N.O. contacts close energiz-ing K20 blower limit relay, which in turn energizes the blowerrelay K3 energizing indoor blower B3. See table 2 for factoryset point. Stick type limit used on GCS16-072 and 090-2models must be installed with limit face in DOWN position.

5-Secondary Limit S21

All GCS16 model units are equipped with a secondary limit(disc type limit figure 15). On GCS16-072/090 models, S21is located in the blower compartment. On GCS16-120/150models, S21 is located in the return air (behind filters). Thelimit is auto-re-set thermostat which opens on temperaturerise. S21 is wired in series with the ignition control. The limitis used to de-energize the ignition control and shut down theunit when temperature in the blower compartment becomestoo high. The limit is factory set and is not adjustable. Seetable 2. This is a safety shutoff function of this unit and mustnever be bypassed.

GCS16 Unit S10 Set Pointo S21 Set Pointo

072-1 200 175090-1 180 150090-2 200 175120-1 180 150120-2 170 150150-1 170 150

Table 2

Page 19: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 19

�:�� 0)%&$���$"8"�*#�4$&+2��=

��������������������������� !��"#$%�

7�� ���,-�� ����#����������1� ���$���(� ���#��?�7�@�5���/0

/���� �#)�����������1� ������� ��,��� �����,-�� ����#�����0

����� ����# ����� �� /)���-)�� ����� ������ �� ���� ���� �/� ��

�1� ��� �� ���-)�1���������*���7���� ���������/� ����1� �����

����� �� ���# ,�������������/�*���������7����1� ������1���

����������1� ���*�� ������� ��)��%���?������1� ��������)����

1������,-�� ����#������������#�����/�))������ ��#))�1� ��

�*�� ������� ��)� ������*�+����7����������� �# � �����,-�� ���

#�����������������# ��*�#��#))�1�� �����# ��*��8�)�� �����0

�����

��,-�� ����#����������1� ����������/#� ��8��� �#�����0#0

>�� #-)����� ����� �1�))�-����� ��������/��1� ���

���������������������&������ !��"#$%�

��,-�� ����#����������1� ����������#��?�7�@�5����� ��/�*#)

�1� ��������� �����,-�� ����#���,� ���� �������� ��,��� ��

��,-�� ����#��������������# �����7����1� ������1���������0

�����1� ���*�� ������� ��)��%��5��� #� ��� � ����1� ����)����

1���� �����,-�� ����#���,� �����#�����#��� ������$������

�"����?:(� ��#))�1���1��� �� ����*�� ������� ��)�$������ �-8

�)����* � �# � �����,-�� ����#�����������������# ��*�-�/���

#))�1��*� ����*�� ������� ��)� ��-������*�+�(�

�:�� 0)%&$���$"���)+#"5�

��,-�� ����#����������4����������/�����#��� �� ���-�����

1��)���)�#���*� �����,-�� ������#,-����/����#�� � �*#����

7��� ������� ����� #� ?�� � ���.�%�A�� � ���*)�� ��#�� � �.�"

���,� ���� 7��� ������� -�*���� ����# ��*� �,,��# �)8� ����

��������*�#� ���,�� # ��,#��#�� ���������*�+�� �,,�0

�# �)8� 1���� ���,�� # � �,#�� ��� �# ��/���� 6�1���� � #

��)���#,-��� ���1�� �����R; � ���-)�1���,#8� #&����� ���"

�������-�/������ # ����-�*������))���,-�� ����#���������

,� ����#�����#)��#���#��� �-����)��

��������������������������� !��"#$%�

7�� � �-�� ������ ��*� ���� �� ��� ������� ������*� ,�� � -�

�)���� ���#�,#����� �# �1�))������� �������# �� /��,���)0

)�� ��*� ��� ��� �-��� ���� /�*���� ���� � ��� ���,#)� /��� #� �,#))

#,��� ��/�������# �� ��/��,���� ��� �-������*���� �����#0

������7��� �-��#���1� ���,�� �-��#))�1�� ���#���#���,�0

)# ��������# ��-� 1���� ���,�� # ��,#�����/� ��� �-�

������� �������� �# �#���,�)# ��������# ����� �#������

��� �-� � ������ �,#8������,������)8����,#8�)��&��� �

3�������

5�

��=

=:3')#?#�&�3$-)"#���

�987�����?#�&+�!�%%# 0', )%&0#$�%&�''#�4$&2�)& ��$/$+�&$�����, ��$/$+�&$��&�&2#*#�&+�!�%%# 0',�"/�$')"#&�$�%&�''�%%# 0',+��"#.%)'&$�$ !"�!#"�!#"�&$�����4$''*�$�&2#����

���+#"&$/$+�&$���/&2#)�$&�

�����7�<���&%&�"&�"�!#"�&#)�$&)�'#%%*#�&+�!$%$�

!'�+#�

3�������

�7873����?������E�� ?�����8

����956B

�����:�������;�:�36��?���

�7873����

?�����8�%#+)"#4$&2�%+"#4%!"�*$�#��

�����:�;�:��������� �36��?���

Page 20: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 20

;:��%?�'*#�?��3$-)"#�=�

�#� ��#)����A�����#� 1��� #*������#� �*#���#)���������

#))� ��������� ������ ��#����9������1� ���#)����,#��/#�0

����-8�'�� ����*�����;��� �� #*��$)�1�/���(����9���&�����0

��*�$���#���//����)���� �#��%�������(��������� #*������)�1

������*�$�����������������//����%��������(��5��#��#))�/��

/��� �� #*����# �$)�1�/���( � ����#)����������*�+��-8� ����*��0

������� ��)���,�) #�����)8�1� ����#�&��)�� �����5��#��#))

/���������� #*����# �$'�(� �,���=�%�����*�+���'����� ��

�#)���#/ ���#�%�,��� ���)#8������ #-)��%�/���*#���#)���,#�0

�/�)��#�*�������,#��#)���� ��//�&��-�������������� ����#)��

/������ ��//��7���&��-��,,��# �)8��)�����-� ��� #*���1� �0

�� ��)#8�

��56��9��$/�'�8"#%%)"#���-#

A#)��� � #*� @# N�'��� ��?�O�'���

��1� ;��� ������ ��� "�"��� ��%

6�*�� ;��� %�!� ��� ��% ���"� �� ��"

3������=

<:�

�?:��:�

��

�?:�

���?�6?���7����N7�H87����7�

������7<�������?�6?�

�9���376<8�������87��

������9����69���376<8��������<F���9����������<����8

���6��8�������87��

��:�-�$&�"�3'� #�#�%�"3$-)"#�;

*�� ��� ����#���)��# ����� ����# ���/� ���)�/ �,�� �-�������7��

������� ������)��# ����� �����*� �,�� �-�������# ���4� ���*��0

���#���������#���/#� ���� �� ���)�1���-������-�#�&� �����

/�*���� �%���2#%#�%�"���$-�$&�"�"#$�#�&$+�'+� !�.

�#�&%���4#*#"#�+2'$�#)!�$//#"#�&',&�&2#+#�&#"

'$�#�/&2#0)"�#"������/�*��������=����*��*�� ��� ���#�&� �#�0

�)�� ����*�� ��� �*�� ��� �)�� ���� #�� #���� #������ �� ��

*������)�� ����� �=����*�����# ��� � /)#,�� ���������-8�#

������ � �#���� #)��*� ��� *����� �)�� ��� � ����*�� ��

/)#,��#���� �� ����������

�:�!�"��'#+&"��#

7�� ���#�&��)�� ������������� �� �� ����*�� ������� ��)

-8�#�",,���)����������)# ��� �#�����*����) #*��1����

7�� � 1���� ����� �.�O� /�,#)�� 9���&� ������ � ��� ��� �)��0

���� ��� #�� /�,#)�� ��#�&� �)�*� 8��� ��,��#)� ��� ��

�*�� ������� ��)���������/�*�������/���*#���,�������

0:3'� #�#�%�"

;)#,� ����������-8���� �/��# ���� ����*�� ���/)#,������0

��*����

�987��������"�#"&� �G$ $C#%!�"�#�#"-,&�&2##'#+.&"��#&2#2$-2*�'&�-#4$"#%2�)'���&"#%&��&2#0�&&� �/)�$&*#%&$0)'#!��#'���%2�)'�&�)+2)�$&+�0$�#&�%'$&&'#�%!�%%$0'#�

3������;

�����7������7�

3�������

����7�

��=N%!�"�-�!

�6 �6��=N%!�"�-�!

�����7�

Page 21: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 21

86�95����7987��������������:���

3�������

86�95����7987��������������:�;�

5��798����7�

������8�������������

<����

<��������6���

6�L��<6���

5��798����7���<�����

<��������6�����������

<��������6�����<�����

������8���������������<�����

������8���������������������

<�����

6�L��<6�����������

6�L��<6�����<�����

5��798����7���������

�@8����7�?�6?�

�������5�65

�@8����7�

?�6?�

�������

5�65

�@8����7�

?�6?�

�������

5�65

�����7�6���

�����7�6���

Page 22: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 22

3�������

86�95����7987��������������:����� �

6�L��<6���

��<�����

6�L��<6���

��������

<�����

<��������6���

��<�����

<��������6���

��������

������8�������

��������<�������!&$���

5��798����7�

��<�����

5��798����7�

�������� ������8���������������������

��!&$���

�@8����7�?�6?�

�@8����7�?�6?�

�������5�65

�������5�65

Page 23: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

���766�798����7�=��6���<

���75@

3�������

3�������

Page 23

<:���'$�-�� !��#�&%

�) �",�/3#�&)"#%

�))���� ������=C����)��*�����)��*�������.�6������� ��,#8

#)��� -�� ����)�,�� �� -8� /��)0��� #))�� �����,�+���� �))

��� ������#����*)���)#-� 8��� ���#����/�����#���# ���1� �

��/)�� �-��*�#��#� ���,#)����#�������#)���$N7CAO(��#�� ��

���#������ ������ $/�*����� ��( �� �))� ,��)�� ���� �#10

����*�� 8������������/#���

�:�+"�''�� !"#%%�"

�))����.�6������� ��� �)�+�

#� ����))� ��,��������� 7��

���.�6�����!��1�))��#��

���� ��,�������� #�� ��

���.�6�����3�.���.�"�

1�))� �#��� 1��� 7��� ����))

��,�����������*�������,0

�)� � �//����� � #�� ��9�����

/�1� ,����*� �#� ��� � �� �� 0

#1#8��#*�#,� �/� ��� ����))

��,��������������1�����/�*0

���� �%�� 7��� ����))�� #��� )�0

�# ����� ��� ����/� �����,0

���������#�� #�� ��� ,� ��

��� )��# �� ��� ��� -� �,��/

�����,���������#��� �7��� ��)�)���)�����,,��# �)8�-�)�1� ��

,� ���#����)�������������/�� �� ���,����*��#� ���/� �����,0

����������7���)�1������ �����/� �����,�����������))����������

��)�1��������������1��)����)8� ������8� ����/� ������))������0

����� ����*���������������

7�� �����))����#���,�)����,��������������� ���� ����#����

������9�������#)���#����/� �������))�#��� ��������� �������0

������;�*����������1�� ���-#��������))�/��,���71����� ��#)

����))��#���,# �� �*� ����/��,��*������� ��������#)���#���

$/�*�����"(�� �5�������))���0

,#���� � # ���#�8 � 1��)�

���� �������#))�1�� ����0

-� �$/�*��������(���@� �� �#

��� ��-� ��*� ����))� ���

�� � �� # �� ��� ���� -�

,���)8 ���-� ��� ���� # ���0

#�8�����))�

7�� ����� ���)��&1������-� ��*�����))��#1��*#���� �� ����� 0

��� ������� � ��#��� *#�� ���&� � ���# �� -8� ��� 1�� ����))�

$/�*���� ����(�� 7��� ��� ��/�*#)� #� ���� �/� ��� ��-� ��*� ����))

��#)���//� ���/)#�&���/� �������))��$/�*�������%(������ �����-� ��*

,� ������� ����� � ���*#�����/����� �1#�� ������ ����/� ��

����))� #�� ��� *#�� ���&� � -���,��� ��,������� $/�*���

����(�

'��� � ��,�������*#����#����� ������ �� �� ��������#�*�

��� ��#))8��� ��#���#,-���#������#�*����� ���� ��� ����/� ��

��,�������� $/�*����%(�� 7��� ����#�*�� ��������� /�����*

�1����� ��� �������))���)�����#)� ���������#��)�1����*��

$ ���(��/� �������))��$/�*�����"(���=����*�#����*)����-� ������#)

���&� �� �/� *#�� #��� ��,������� ��,�) #�����)8� �������*

�,�� ����� ���������,���������

�����7���B���766

7�5��������766

<��������

�����7�

��7��:�����7�73���766�

��8����6�<5B<��������8�������

<��������8�������

3������

<������2�+�2�C�"��

�� !"#%%�" )%&0#-"�)��#��<���&�!#"�&#4$&2�)&!"�&#+&$*#+�*#"�*#" &#" $��'%� ��!�+$&�"%+��&�$�2$-2*�'&�-#�<$%+���#+&!�4#"0#./�"#"# �*$�-+�*#"�<$%+2�"-#+�.!�+$&�"% 0#/�"# %#"*$+$�- )�$&� <$%.+���#+&!�4#"0#/�"#%#"*$+$�-)�$&�

���+�)%#)�%�/#�!#"�&$�� $�()",�"�#�&2�

Page 24: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

The scroll compressor is tolerant to the effects of liquidreturn. If liquid enters the scrolls, the orbiting scroll isallowed to separate from the stationay scroll. The liquid isworked toward the center of the scroll and is discharged. Ifthe compressor is replace, conventional cleanup practicesmust be used.

Due to its efficiency, the scroll compressor is capable ofdrawing a much deeper vacuum than reciprocating com-pressors. Deep vacuum operation can cause internal fusitearcing rsulting in damaged internal parts and compressorfailure. It is permissible to “pump-down” the system usingthe compressor but never use a scroll compressor fordrawing a vacuum on the system. The type of damage canbe detected and will result in denial of warranty claims.

For compressor specifications see compressor nameplateor ELECTRICAL DATA section in this manual. All compres-sors are protected by internal overload protection circuitry.

2-Condenser Fan and Motor B4 & B5

The specificiations section in this manual shows the specifi-cations of condenser fans used in GCS/CHA16s’. Thecondenser fan is controlled by cooling contactor K1.

Page 24

3-Indoor Blower Motor B3

All GCS/CHA16 model units use three-phase, PSC, beltdriven blower motors. See motor nameplate or ELECTRI-CAL DATA section for motor specifications.

4-Evaporator Coil

All GCS/CHA16 model units have a single slab evaporatorcoil. The ocil in the GCS/CHA16-072/090/120 has threerows and the GCS/CHA16-150 has four rows, of rifledcopper tubes fitted with ripple-edged aluminum fins. AThermal Expansion Valve (TXV) feeds multiple parallelcircuits through the coil. See figure 27.

CAUTION

The head of a scroll compressor may be hotsince it is in constant contact with dischargegas.

Contact could result in serious burns.

Page 25: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 25

:����#�%#"��$'

�))� ���.�6���� ,��)� ��� �� �#��� #� ���*)�� ��������� ���)�

<#�� ����)��#�� 1����1���/��������� �-���/� ��1� ������)��

�*� �#)�,���,����#���� /����

�:�$-28"#%%)"#�4$&+2��D��

6�*������������1� ������$��,���������(�#���!�$��,����0

�����(�#���,#��#))8����� ��?�7�@������*������������1� ����

1����������������������������������)��# ����� �������#�*�

)���� $��,�������� �(� #�� 1���� ��� ������� 1� �� ��,�������

��� #� ���B����!����)��# ����� �������#�*��)����$��,����0

���� �(� #�� 1���� ��� ������� 1� �� ��,�������� ��� #� ��� B��

'��� � ����#�*�� ��������� ������ #-���� �"�S��� ���*� $%��%

&?#S � �3� &?#(� ����1� ���������#�� �����,�������������

����*�+�� $ ��� �����,�+��� �#����� ����� ������# �(���/ ��

������-)�,��#��-����/����#�������� � � ����1� ����#�

-������ �-8�������*���� ����1� ���-� ����7�����*����������

�1� ����� #��� � #�#�� ��,����� �� ��� ��� ���.

�6�����!�.�3� � -� � �� ���#)� ��� ��� ���.�6�������.�"��

�:3"##C#%&�&�4$&+2��;D� �

�))����.�6����,��)���� ��#��� � �9������1� ��#�)�1� �,0

���# ��� �/���+�� # ��1� ������3����1��������������1� �����*�

��������� �1� ��� ��� #�� ��,�������� ��� #� ��� B�� /��� #))

,��)�� � �"�����1��������������1� ���� ����/#����)#8�B��

�� ���#)���*������������1� ����!�#����,����������� #� ��

B����� �����3����.�"���,��)����)8����3�#���"��#����?�7

@����#� ������ ��1� �����1����������# ��3�R;S%�R;�$���!�R��S

��! �R�(���� �,���# ��������#���)�����# �"��R;�S���R;�$����

R�� S� ���� � R�(� ��� #� �,���# ���� ������ 7�������� ����)� ����*

/���+�� # � ����������*���,������������# ���� �� �,���#��0

)8���#-)�� �����,�������$�(��� �)� ������)�1#�,����//����� )8

��,�) �#�8�#���,�)# ��/��� �

/�/���+�� # �� ����/��9��� )8���� �����)�����* �����&� ������

��#�*� �#���/)�1�#��/�) ����-�/����#))�1��*���� �-#�&��������#0

�����:#&������� ���)�,��# ������ �����1�����,�*� ����,� �

����-��)����

=:<"$#"

�))����.�6����,��)���� ���#���#�/�) ��������)��# ����� ��

)�9���)�����/��#�����/��*��#� ������� �# � ������ ��/��#������0

���������)��7����������,�������� #,��#� ��#��,��� ���

/��,� ����8� �,�

���:7!&$���'�'#+&"$+�#�&

7#-)��� �� ����*�� !� ���1� #))� �����-)�� �6���� �� <�6��

,# ������#���)�� ���#)��# ��*���<�6����#� ��#��#�*�,��

������1�����/�*���������))�<�6������ �������� ��/��)�� ������#

�)�,�� � ������������ )8� �� ���#��� ��#,��:�) ��)��� #*�

�)�,�� � � #��� ��9������ ��� #�� �//� -8� �,�� �)#8�� ��� ��0

������� �� ���,�� # ��,#��

�:���&�+&�"E�

��� #� ��� B�"� ��� #� ����0��)�� ��-)�0-��#&� ��� #� ��

)��# ����� ������ ��)�-�����))�<�6����)�� ������# ����0

����� #��� �9������ 1� �� B�"�� B�"� ��� �9������ 1� �� #

��A��� ���)� 1����� ��� ����*�+�� 1���� ��)� � ��)#8� B3

�)������ '���� B�"� ��� ����*�+� � ��� ��# ��*� �)�,�� �

$/��� � � #*�� ��# ��*� �)�,�� �� �/� �9������ 1� �� ,�) �0

� #*�� ��# ��(� #��� ����*�+��

�:���&�+&�"E��

��� #� ��� B��� ��� #)��� #� ����0��)�� ��-)�0-��#&� ���0

#� ��� )��# �� ��� ��� ��� ��)� -���� �))� ,�) ��)�� � #*�

<�6�� � �)�� ���� ��# � ��� ����� #��� �9������ 1� �� B���

B�� � ����9������1� ��#���A������)�1����� �������*�+�

#/ ��� �,���)#8�=����)������'����B����������*�+� � ��

������ � #*�� ��# ��*� �)�,�� �� #��� ����*�+��

�:���&�+&�"E��

��� #� ��� B�!� ��� #)��� #� ����0��)�� ��-)�0-��#&� ���0

#� ���)��# ����� ������ ��)�-�����))� ������ #*��<�6��

�)�� ������# ���� �����#����9������1� ��B�!��B�!��#��#

��A��� ���)� 1����� ��� ����*�+�� #/ ��� �,�� �)#8�� =��

#��=����)���������9�������'����B�!��������*�+� � ��

���0� #*�� ��# ��*� �)�,�� �� #��� ����*�+��

�:���&�+&�"E�=

��� #� ���B������#)���#� ����0��)����-)�0-��#&���� #� ��

)��# ����� ������ ��)�-����<�6��0�%"�"������.�%�A��)��0

������# ���� ���#��� �9������1� ��B����B����#��#���A��

���)�1������������*�+��#/ ��� �,���)#8��=�� �=���#��=�"

�)���� ��� ��9������� '���� B������ ����*�+� � /��� �0� #*�

��# ��*��)�,�� ��#��� ����*�+��

:�#'�,E;

��)#8� B3� ��� #� ����0��)�� ��-)�0 ���1� ��)� � ��)#8� ��0

���� ���)�� ���#))8����)# �� ����6����#��<�6�����A

������ ��� 7������)��/���)#8�B3� ��������� �� ��/��� �� #*�

��# ��*��,#��/��,� ����6�����'����B3��������*�+�

������� ���/���� #� ���1� ���� '����B30���1� ���� � ��

������-)�1����������*�+��� '����B30���)���� ������

� #*�� �)�� ���� ��# � ��� ��#-)�� $-� ��� � ����*�+�� �� �)

������� #*���,#�������������/��,� ��� ���,�� # (�

'����B30%��)���� ���� #� ���B�"��������*�+��

Page 26: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 26

��56�������:���97<�6�

�'#+&"$+�#�&9��#'���D�#&�#$-2&

����/�&#!%

?�'&%��!)&

�4��!)&

5&)27)&!)&

���&�'��$&D�'#+&"$+�#�&9$�$ ) �$"+)$&� !�+$&,

��� !�" �" ���

���� ��� �� !��

��<�6��0��.3"0��

���.�%�

��%� 3�� %� ���

��

���.�%�������=� ��� ���� %� ��������=�

�����������

��� ��� �� !���������

"!"� � ��� 3�� %� ��� ��"!"������=�%� )-�

��� ���� %� ���

��

%�� )-��$�!� &*( ""� ��� �� !��$�!� &*(

� "!" 3�� %� ��� ���

��� ���� %� ���

��

��� ���% %� ��� �3

���� ���� �% ���

<�6��0��.3"0�"���.�%�

��%� �%�" �� ��� ""

���.�%�������;� ��� �"�� "� ���

""

�����;������������

��� ���� �% ����������

"!"� � ��� �%�� �� ��� �!"!"������;�%� )-�

��� �"�� "� ���

�!

%�� )-��$�!� &*( ""� ���� �% ���$�!� &*(

� "!" �%�� �� ��� ���

��� �"�� "� ���

��

��� �"�� "� ��� ��

����� ���� "! %��

<�6��0��.3"0�����.�%�

���%� ���� �� ��� !�

���.�%��������� ��� ���� �� %��

!�

���������������� �

��� ���� "! %������� �

"!"� � ��� ���� �� ��� %""!"�����=���� )-�

��� ���� �� %��

%"

��� )-��$�3� &*( ""� ���� "! %��$�3� &*(

� "!" ���� �� ��� ���

��� ���� �� %��

��

��� ���" !� ��� ��

����� �"�� �� ���

<�6��0��.3"0%����.�%�

���%� �!�" 3% 3�� ���

���.�%��������� ��� %��� ��� ���

���

������������������

��� �"�� �� ����������

"!"� � ��� �!�� 3% 3�� "�"!"�����=���� )-�

��� %��� ��� ���

"�

��� )-��$�3� &*( ""� �"�� �� ���$�3� &*(

� "!" �!�� 3% 3�� ���

��� %��� ��� ���

��

��� %��� ��� ��� ���

�%��� %%�� ��� !��

<�6��0��.3"0�����.�%�

�%�%� %��� ��" ��� �%�

���.�%��������� ��� ���� �%� "��

�%�

������������������

��� %%�� ��� !���������

"!"� �� ��� %��� ��" ��� �""!"�����=��"% )-�

��

��� ���� �%� "��

�"

"%� )-��$��� &*( ""� %%�� ��� !��$��� &*(

�� "!" %��� ��" ��� "���

��� ���� �%� "��

"�

���/�� � ��@# ���#)�����#�#�#��<)�� ���#)�����,#��#)� ��� ��,����1��� �/����#��������� ���+����9����,�� �������1�������� #-)��/���# � )�#� ���!°;� $!"��(��:#8�-������1� �� 1��� #*����� ��)�

��56� �����:�;�97<�6�

�'#+&"$+�#�&9��#'���D�#&�#$-2&

����/�&#!%

?�'&%��!)&

�4��!)&

5&)27)&!)&

���&�'��$&D�'#+&"$+�#�&9$�$ ) �$"+)$&� !�+$&,

��� !�" �" ���

���� ��� �� !��

��<�6��0��.3"0��

���.�%�

��%� 3�� %� ���

��

���.�%�������=� ��� ���� %� ��������=�

�����������

��� ��� �� !���������

"!"� � ��� 3�� %� ��� ��"!"������=�%� )-�

��� ���� %� ���

��

%�� )-��$�!� &*( ""� ��� �� !��$�!� &*(

� "!" 3�� %� ��� �!�

��� ���� %� ���

�!

��� ���% %� ��� �3

���� ���� �% ���

<�6��0��.3"0�"���.�%�

��%� �%�" �� ��� ""

���.�%�������;� ��� �"�� "� ���

""

�����;������������

��� ���� �% ����������

"!"� � ��� �%�� �� ��� �!"!"������;�%� )-�

��� �"�� "� ���

�!

%�� )-��$�!� &*( ""� ���� �% ���$�!� &*(

� "!" �%�� �� ��� ���

��� �"�� "� ���

��

��� �"�� "� ��� ��

����� ���� "! %��

<�6��0��.3"0�����.�%�

���%� ���� �� ��� !�

���.�%��������� ��� ���� �� %��

!�

���������������� �

��� ���� "! %������� �

"!"� � ��� ���� �� ��� %""!"�����=���� )-�

��� ���� �� %��

%"

��� )-��$�3� &*( ""� ���� "! %��$�3� &*(

� "!" ���� �� ��� ���

��� ���� �� %��

��

��� ���" !� ��� ��

����� �"�� �� ���

<�6��0��.3"0%����.�%�

���%� �!�" 3% 3�� ���

���.�%��������� ��� %��� ��� ���

���

������������������

��� �"�� �� ����������

"!"� � ��� �!�� 3% 3�� "�"!"�����=���� )-�

��� %��� ��� ���

"�

��� )-��$�3� &*( ""� �"�� �� ���$�3� &*(

� "!" �!�� 3% 3�� ���

��� %��� ��� ���

��

��� %��� ��� ��� ���

�%��� %%�� ��� !��

<�6��0��.3"0�����.�%�

�%�%� %��� ��" ��� �%�

���.�%��������� ��� ���� �%� "��

�%�

������������������

��� %%�� ��� !���������

"!"� �� ��� %��� ��" ��� �""!"�����=��"% )-�

��

��� ���� �%� "��

�"

"%� )-��$��� &*( ""� %%�� ��� !��$��� &*(

�� "!" %��� ��" ��� "���

��� ���� �%� "��

"�

���/�� � ��@# ���#)�����#�#�#��<)�� ���#)�����,#��#)� ��� ��,����1��� �/����#��������� ���+����9����,�� �������1�������� #-)��/���# � )�#� ���!°;� $!"��(��:#8�-������1� �� 1��� #*����� ��)�

Page 27: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 27

��56��

�����:���97<�6�

�'#+&"$+�#�&9��#'���D�#&�#$-2&

����/�&#!%

?�'&%��!)&

�4��!)&

5&)27)&!)&

���&�'��$&D�'#+&"$+�#�&9$�$ ) �$"+)$&� !�+$&,

��� ���% %� ���

���� ���� �% ���

"3<�6��0�%"0�"

���.�%�

��%� �%�" �� ���

"3

���.�%��������� ��� �"�� "� ����������

�����������

��� ���� �% ����������

"!"� � ��� �%�� �� ��� �3"!"��������%� )-�

��� �"�� "� ���

�3

%�� )-��$�!� &*( ""� ���� �% ���$�!� &*(

� "!" �%�� �� ��� �%�

��� �"�� "� ���

�%

��� �"�� "� ���

���� ���� "! %��

!�<�6��0�%"0��

���.�%�

��%� ���� �� ���

!�

���.�%��������� ��� ���� �� %���������

�����������

��� ���� "! %���������

"!"� � ��� ���� �� ��� %!"!"���������� )-�

��� ���� �� %��

%!

��� )-��$�3� &*( ""� ���� "! %��$�3� &*(

� "!" ���� �� ��� �3�

��� ���� �� %��

�3

��� ���" !� ���

����� �"�� �� ���

���<�6��0�%"0%�

���.�%�

���%� �!�" 3% 3��

���

���.�%��������� ��� %��� ��� ����������

���������=�

��� �"�� �� ��������=�

"!"� �� ��� �!�" 3% 3�� "�"!"���������� )-�

��

��� %��� ��� ���

"�

��� )-��$�3� &*( ""� �"�� �� ���$�3� &*(

�� "!" �!�� 3% 3�� ����

��� %��� ��� ���

��

��� %��� ��� ���

����� %%�� ��� !��

�%�<�6��0�%"0��

���.�%�

���%� %��� ��" ���

�%�

���.�%��������� ��� ���� �%� "���������

���������;�

��� %%�� ��� !�������;�

"!"� �� ��� %��� ��" ��� �!"!"��������"% )-�

��

��� ���� �%� "��

�!

"%� )-��$��� &*( ""� %%�� ��� !��$��� &*(

�� "!" %��� ��" ��� "%��

��� ���� �%� "��

"%

��� %!�" ��� ���

����� ���� ��% %��

�%�<�6��0�%"0"�

���.�%�

���%� ���� �"! ���

�%�

���.�%������� � ��� "��� �!� �������� �

�����������

��� �%�� ��3 "���������

"!"� �� ��� ���� �"! ��� �!"!"������ �"� )-�

��

��� "��� �!� ���

�!

"�� )-��$��� &*( ""� �%�� ��3 "��$��� &*(

�� "!" ���� �"! ��� "%��

��� "��� �!� ���

"%

���/�� � ��@# ���#)�����#�#�#��<)�� ���#)�����,#��#)� ��� ��,����1��� �/����#��������� ���+����9����,�� �������1�������� #-)��/���# � )�#� ���!°;� $!"��(��:#8�-������1� �� 1��� #*����� ��)�

��56��

�����:� �97<�6�

�'#+&"$+�#�&9��#'���D�#&�#$-2&

����/�&#!%

?�'&%��!)&

�4��!)&

5&)27)&!)&

���&�'��$&D�'#+&"$+�#�&9$�$ ) �$"+)$&� !�+$&,

��� ���% %� ���

���� ���� �% ���

"3<�6��0�%"0�"

���.�%�

��%� �%�" �� ���

"3

���.�%��������� ��� �"�� "� ����������

�����������

��� ���� �% ����������

"!"� � ��� �%�� �� ��� �3"!"��������%� )-�

��� �"�� "� ���

�3

%�� )-��$�!� &*( ""� ���� �% ���$�!� &*(

� "!" �%�� �� ��� ���

��� �"�� "� ���

��

��� �"�� "� ���

���� ���� "! %��

!�<�6��0�%"0��

���.�%�

��%� ���� �� ���

!�

���.�%��������� ��� ���� �� %���������

�����������

��� ���� "! %���������

"!"� � ��� ���� �� ��� %!"!"���������� )-�

��� ���� �� %��

%!

��� )-��$�3� &*( ""� ���� "! %��$�3� &*(

� "!" ���� �� ��� �3�

��� ���� �� %��

�3

��� ���" !� ���

����� �"�� �� ���

���<�6��0�%"0%�

���.�%�

���%� �!�" 3% 3��

���

���.�%��������� ��� %��� ��� ����������

���������=�

��� �"�� �� ��������=�

"!"� �� ��� �!�" 3% 3�� "�"!"���������� )-�

��

��� %��� ��� ���

"�

��� )-��$�3� &*( ""� �"�� �� ���$�3� &*(

�� "!" �!�� 3% 3�� ����

��� %��� ��� ���

��

��� %��� ��� ���

����� %%�� ��� !��

�%�<�6��0�%"0��

���.�%�

���%� %��� ��" ���

�%�

���.�%��������� ��� ���� �%� "���������

���������;�

��� %%�� ��� !�������;�

"!"� �� ��� %��� ��" ��� �!"!"��������"% )-�

��

��� ���� �%� "��

�!

"%� )-��$��� &*( ""� %%�� ��� !��$��� &*(

�� "!" %��� ��" ��� "%��

��� ���� �%� "��

"%

��� %!�" ��� ���

����� ���� ��% %��

�%�<�6��0�%"0"�

���.�%�

���%� ���� �"! ���

�%�

���.�%������� � ��� "��� �!� �������� �

�����������

��� �%�� ��3 "���������

"!"� �� ��� ���� �"! ��� �!"!"������ �"� )-�

��

��� "��� �!� ���

�!

"�� )-��$��� &*( ""� �%�� ��3 "��$��� &*(

�� "!" ���� �"! ��� "%��

��� "��� �!� ���

"%

���/�� � ��@# ���#)�����#�#�#��<)�� ���#)�����,#��#)� ��� ��,����1��� �/����#��������� ���+����9����,�� �������1�������� #-)��/���# � )�#� ���!°;� $!"��(��:#8�-������1� �� 1��� #*����� ��)�

Page 28: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 28

�:�#'�,E�;

��)#8�B�3����#����*)�0��)����-)�0 ���1���)� ���)#8�#)��

�� ���� ���)�� ���#))8����)# �� ����6������A��������� �

/��,� ���<�6�����A������� ���7������)��/���)#8�B�3�������0

��� �� �� �����0� #*�� ��# ��*� �,#�� /��,� ��

�6�����'����B�3��������*�+� �#����*)���� ��/���� #� �

�1� ���� '����B�30���)���� ������0� #*�� �)�� ������#

�������*�+��

�:�$ #<#'�,<6�

7�,���)#8� =��� ���/#� ��8���� #))����� #))�,�) ��)�0� #*�

�)�� ���� ��# � ��� ��� =��� #))�1�� � #*��*� -8� �������*� #

�,���� ���#)�-� 1���� ���/��� �#����������# ��*��)�0

,�� ��� 7��� �)#8� ��� ��)� ��� #� ���*)�0��)�� ���*)�0 ���1

��A��� ��)#8� 1� �� ���,#))8� ����� ��� #� ��� '���� ��

��)#8����)��������*�+� � ������ #� ��#����)#8��%�����0

����-�/�����)����*��'���� �����)#8����)�����0����*�+�

������ #� ��#����)#8����������-�/����������*�

=����������*�+��1� ��/��� �� #*�� ���,�� # ��,#����

"�&'����.�%�A� �)�� ������# ���� �����#))�� ����,�) ��)�0

� #*�� �)�� ������# ���� � �=����������*�+����)8�#/ �����0

������*�#�������� #*�� ���,�� # � �,#��

=:�$ #<#'�,<6�

7�,���)#8�=��������� ��#)� ��=���� ����/#� ��8���� #))�

���#))�,�) ��)�0� #*���)�� ������# ���� ��1� ��# �)�#� � ����

� #*����/��)�� ������# ��=���#))�1��� #*��*�-8��������*

#� �,�� �� ���#)� -� 1���� ���������#�� ������# ��*

�)�,�� �� �7����)#8������� ��#)� ��=���

=����������*�+��1� ��������� #*�� ���,�� # ��,#����

"�&'� ���.�%�A� �)�� ���� ��# � ��� ��� �� #))� � ���� ,�) ��)�0

� #*���)�� ������# ���� � � =��� ��� ����*�+����)8� #/ ��� �,�

�)#8�=����)�����

;:�$ #<#'�,<6

7�,���)#8�=�"������)8��������"�&'����.�%�A��)��0

������# ���� ���7����)#8������� ��#)� ��=���#��=���

=�"�#))�1��/����� #*����/���# �-8��������*�#� �,�

�� ���#)� -� 1���� ��� ���� #�� /��� �� ��# ��*� �)�0

,�� ��

��:3)%#3�

;% � ��� #� ������ � )�,� ��*� /���� ������ �� ��� ������� 1� �

�#�� � )�*� �/� �)�� ���� ��# � $�#��� � #*�� �/� �)�� ���� ��#

����� �����/����(��;�������������6�������������# ��*

��� �����#������1����� #-)����

��56�=

������6���������������7�3����������

��?�'&�-#

3��%&�&�-#

3����%����

3��"��&�-#

3��&2�&�-#

��&'����.�%�A

��� �,��"�A

��&'��� � "!"A

%�� #,����A

�"&'���.�%�A

��� �,��"�A

�"&'��� � "!"A

%�� �,����A

��&'���.�%�A

��� �,��"�A

��� �,��"�A

��� �,��"�A

��&'��� � "!"A

��� �,����A

%�&'���.�%�A

��� �,��"�A

��� �,��"�A

��� �,��"�A

%�&'��� � "!"A

��� �,����A

��&'���.�%�A

��� �,��"�A

��� �,��"�A

��&'��� � "!"A

��� �,����A

%�� �,����A

��� �,����A

"�&'���.�%�A

��� �,��"�A

%�� �,�����

��� �,����A

%�� �,����A

"�&'��� � "!"A

��� �,����A

%�� �,����A

��:�$-2�# !#"�&)"#6$ $&�� �8"$ �",�

��"���� ������,#�8���*�� �,���# ����)�,� �� ����)��# ����

����)�� ������# ���� ��,,��# �)8��1�� ��#,�/��,� ��

��# ��*� �)�,�� ��� ��"� ��� #� ���*)�0��)�� ���*)�0 ���1

���,#))8��)���� ���,�� # �1��������������1� �� ���/���

� #*����� #� ������)�

'������"������ �����# ��*�#����-)�,���� ����8� �, ����0

#� ���B�"�����0����*�+���'����B�"�����0����*�+� �/���

� #*��#��#))���-��9��� �� #*����/���# �#����0����*�+��

������ ��� ������-)�1��������� ��))��-8��,#�� $B3� ��0

,#��������*�+�( � ���������-)�1������ ����������# ��*�

��:�$-2�# !#"�&)"#6$ $&�����#+����",�

<#�����# ��*��)�,�� �#���,-)8�����)�� ���#))8������� �� �

1����*�� �,���# ����)�,� ������$��/��� ��1����*��#*�#,����

-#�&��/� ����,#��#)(��<#���)�,� ���������� ������������1� �

����)�*��/� ��� ����0��#����)�,�� �#���,-)8��7��� ����)�*

�/��#���#���,-)8������ ��9������1� ��#�)�,� ��7����0��#��

����# ��*���#�#� ���� ����#))�1������/� ���� ���� 1��)�,� �� �

��� �� � ��� ����)�*�

<#�� �����)�,� ������8���#))8�)��# ��#>#��� � �� ����)�0

,�� � � � ��� ��� �� ��*�� ���� ��� #� ���*)����)�� ���,#))8

�)���� ���,�� # �� 7��� ���,�� # � #� �# ��� ��� #� �,0

���# ��� ������#���#��� �-������ ��5���� ����� �� �,��

-�� ���)#���

Page 29: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 29

3������=

��� #� ���B�"

K16K17K18

DL2

DL4

DL5 K9

K19

7�

;% ;%

�����%

�@=

��� #� ���B����� #� ���B�!��� #� ���B��

K15

7�#��/��,���7�

?�)� ���)#8�B3

7�,��=�)#8�=��

7�,��=�)#8�=�"

?��,#�8���,� ���"$���.�%�A���)8(

?��,#�8���,� ���"$����F�"!"A���)8(

;% ;%

7��,��#)�� ����74%

;���� � ;%

?�)� � ��)#8� B�3

7�,�� =�)#8� =��

�����#�8� ��,� �� ���

�����:�� : �����7��

��:�#" $��'�&"$!�5�

<)�� ������# �)���� ��) #*�� ������ ����� #��� ,#�� �

��,��#)�� ����74%�)��# ����� ��� �)�� ������# �,#&�

���-���� �6������� ��)�� ���#)������� �����#��� #)��

,#�������

��:�"��%/�" #"��

7�����#�)������) #*�� ����A� �#��/��,���)��# ����� ��

�)�� ������# ���� ��)�-���� 7��� �#��/��,����������

��A�����1��� ��#))�<�6������ ��)��$��� #� ������)�

#�� �,���)#8�(��?�)� ���)#8��$B3�#��B�3(��)�*0��� �

����6����������� ��A������� ����)# ����

� :�#�&$�-�'# #�&%

6�# ��*��)�,�� ��#�����,������/���)���1����-#��

������,������������� )8� �� ���#��� ��#,��6�# ��*

�)�,�� ��#�������*�+������ )8�-8���� #� ������� ��

<�6������ ��)�-����5��������*�+� ���# � �#��/�����

��� #� #������� 5��� �,���# ���� ��� �� ����������0

����-8����,#�8� #�������#�8���*�� �,���# ���

)�,� ���5��������� ���� �� ��������������-8�/�����

<#��� � #*�� �/� �)�� ���� ��# � ������ �� �/� ����� �)�0

,�� �� ������ �� ��� #� ����0��#��� #��#�*�,�� �

<)�,�� ��������.�%�A���� ��#��������� �����#�N=�)0

#O�#��#�*�,�� ��<)�,�� ���������#��"!"A���� ��#��

������ �����N'8�O�#��#�*�,�� �

<#���� #*���������*�+���������� )8�-8�#� ����0��)�

��-)�0-��#&���� #� ���#�������� �� ��-8��#/� 8�)�,0

� ��

Page 30: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 30

�?:86���9�����<�����66���7�

:#&� ������ ������ ������� #))�����#����#����1� �� ������ #)0

)# ���� ��� ��� �����#��#))�#��)��#-)�������� �����#������0

�������� ����/������� �������9�����*������/� ����� ���#)����/

,��� ��*� /�#,�� $�:;��(�

?:�6�������6�7������7��

�:3$#'��$"$�-

��� �/��)�1����*�������1����� ������ ��#*�#,���� �����/� ���

,#��#)�

5:8�4#"�)!!',

��/�� � ��� #� 0������� �����#����/����)���)8� �� ������ �1��0

��*� �#*�#,� 1���� ��������*�� � ��/��� �� ��� � �#,��)# ��/��

,���,�,������� �#,�#�� 8�#��,#��,�,�/������+�����=*�'&

)�$&%�"#/$#'�4$"#�4$&2"#�4$"#+���#+&#�&�+��&"�'

&"��%/�" #"!"$ �",� ���*�'& )�$&% �"# /�+&�",4$"#�

4$&2�"��-#4$"#+���#+&#�&�+��&"�'&"��%/�" #"!"$.

�",�

<������# �*#�''!�4#"&��$%+���#+&

0#/�"#%#"*$+$�-�

�'#+&"$+�'%2�+�"#%)'&$�-$��#�&2�"$�()", �,"#%)'&$/!�4#"$%��&

�$%+���#+&#��

?�:��<77�O567���

78�����7���<F���9���

�:5'�4#"7!#"�&$��

� �� 4)�1�������# �������,#��#))8��� �# � ��� ���,�� # ���-0

-#�� �/#���1� ����'� ��/#���1� ������7������ ��� �-)�1���

1�))�����# ����� ������)8�

� �� '� ��/#���1� ���������7����� ��� � ���-)�1����1�))��8�)�

1� ���,#���4)�1����#���� ������� �1�))�-���//� 1���

�8� �,��1� ���������733����� ����

5:<#&#" $�$�-��$&�39

� �� 7�� �/�))�1��*�,�#����,�� ��,�� �-��,#��1� ��#��8

���������)������-)�1���1� ��� �#����)��*��,#�������/�)0

����,�� �-�� ����)#���1����,�#����,�� ��#��� #&���

��� '� ��#))�#�������#��)������)#�� �,�#������ # �����������

�� ���#) � ����� �$/��,�����)8� ���� ���(�

� %� :�#����� ��� ������ -)�1��� ,� ��� �?:�

��� ��/�� � �� #-)�� ��� N4�5'<�� =�7�O���� ���������� # ��

��������� #�� �?:� ��#��*�� �� � ��,���� ��� � �;:�

�"� 7����;:��#��-��#>�� ��# � ���,� �����))�8����������)0

)�������1�#�� ����#>�� #-)����))�8��)��&1���� �������#��

�;:��7�������� ���)��&1���� ������#����;:��������/�*0

�����3�

�:5'�4#"5#'&��()%& #�&

������������� ������������������������������

��������������� ��������� ����������

:#��,�, �)�/��#��1�#���#��-���- #���� /��,�-�) ����)8� �/

������� ��))�8� #)�*�,�� � #�� -�) � ������� #��� ,#�� #����

7���������1�-�) �#/ ���#�������������������/�����# �����7���

1�))�#))�1�-�) � ��� �� ���#����# �*��������7�� �����#���-�)

������ �)������)��&��*�-�) �#����))�,��� ��*��)# ���7�*� ��

-�) ���� �# � ���,� ���,��� ��*��)# ��������#���� ��#)����� ����

��� �/�*�����3�

<:�2#+�5#'&�#�%$��

5��� ��������* �-�) ������ ����-�) �#��-�#���*�)�/�������&

-�) � �������#��/�))�1�P

��� :�#����� ��#�� )��* �� C�� ���� /�*���� %��

��� ���)8� ���������)#�� /����� �� ��� ��� �/� ��#�� $C(� 1� �

����*����������� ���/)�� �-�) ��.��O�/�������8�������/

��#�� )��* �������",,��������,,��/���#�� )��* ��

<�#,�)�P � =�/)�� ���� �� #���� �/� #� ��O� ��#�� 1��)� -�

��.��O ����".�O�

<�#,�)�P �=�/)�� ������ #�����/�#����,,���#��1��)

-�� �,,�

�%� :�#���� � -�) � �/)�� ���� /������ ;��� #� ���� -�) � ��

�/)�� ���� /����� ����)� -�� "� )-��� $%"&?#(�� �� ��1� -�)

�/)�� ���� /���������)�-��!� )-��� $��&?#(�

�� /����� -�)�1� ����� �#)���� ����# ��� #�� ���� ��0

������ -�) �� �� /����� #-���� ����� �#)���� ����# ��� #�

���� ������� �-�) �

3������;

567����8��<�<F���9���

567�������6

97�7�D8�66�B

�7���������39677����66�������D

����8�66�B�67�E����

��67����8�66�B�

�7<��������39����8�66�B

�7������67�E����

�78�����8�66�B�

�7��������5�6������7��:6��%#��'�+�$�-0�'&%��:8)'' �&�" �)�&$�-!'�&#��:�$-2&#� �&�" �)�&$�-!'�&#%�!'�&#$%*#"&$+�'�

97�7�97������86���

67�E���576��

5�6�

Page 31: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

������8���������867����7��

9��79����

����

3�������

Page 31

9������5�6������7�

3�������

<�36����7�����H8������73�8��7��� 8����� 73�8��

;5��<

�:��9#�%)"#<$%+2�"-#�&�&$+8"#%%)"#

�� � ���# �� #��)��# �����#�����1�����/�*����%��

�� � ?�����#��.�O��#,� �����)��

���� � ,#��,� ��� ����

/)����1� �� ����������*���/

��)�� ��� ����)# ����� � ��#)

#����� ��)�� 1� �� ���,#0

*�,�� � ������ � +��������/

,#��,� �� � �� ��� ��0

��#�*��$����)8(������/��8�0

�,�� � ������ �� ��������/

,#��,� �� � �� �� ���� ��

#�� #-����

%� � '� ����)8� ���-)�1���,� ���������* ��-������ ���,#0

��,� �� � ��#��*�

�� � ����/�*�����3� /����������#�*�� ��� ��� �����

"� � ��#)� �����)��1��������&� �����,�)� ��

?��:�����.�878�����7�

�:8"#'$ $��",�2#+�%

��� :#&� ��������� ������� #))�����#����#����1� �� ������ #)0

)# ������� ��� �����#��#��)��#-)�������

�� � ����� ��)�� ���#)�1����* �-� ��/��)�#��/#� ��8���� #))�

/���)����������� �������7�*� ���#�� ��9�����

%� � ����& � ��������� �# ���/��*��#� �)�����#������*�������0

����#������ ���-�#*#��� � ����#-��� ����� ������/��*��0

#� �)�����

�� � ����& ���) #*��# � ����������� ��1� �����A�) #*��,��

-��1� �����#�*��)�� ����� ����#,��)# ����/��� ������)

�����1�����,�#�8�#���#��� �����) #*������ �������0

��� ��-�/����� #� ��*� ������ �

"� � ������& ���) #*��1� ����� �������*���/���1�������� �1� ���

�#�*�� )�� �� ��� ��� � �#,��)# � � � ��� ��� � #�� �����)

��1��� ��,�#�8�� ����&� #,���#*�� �/� ��� �� � ��/��� �

�#,��)# � �/����# ��������*�#,���

5:���'$�-�&�"&�!

� �� �� �/#���1� ��� �����7����7��#��,�����8� �,���)��0

�����1� ��� �����)���>�� � ���,�� # � ��#��� ��*�-�)�1

���,� �,���# ���� �� -���*� ��� #))� ��,���������� ��,0

���������1�))� � #� � #���8�)������,#�� /��,� ���,�0

� # �

� �� <#�� ���/��*��#� ������� �������#�# �)8���#�*��1� ������

��/��*��#� � �������� � �# ��*��)# �� /��������� �#,��� ��/

��#�*��

�%� ��/�� � �� �<;��<��75@� �K�7<:� �<�A�<

�6<�B ���� ����/����������,� ��� ������&���/��*��#�

��#�*��

�:�2"##82�%#�+"�''�� !"#%%�"

7�������#�������))���,���������,�� �-����#�����9���0

�#))8� �� ������� ������ ���,�������� �� # ���� #�� ����#0

����

� ���,��������� #� 0�� �#�������������#�*��#������������0

������������������# ������������,����������#���*� #�

����# �����<�����������,��������������,#8�#)�������# �

�������� ���#���*�� /�����#�*�� #����� ���������������

�� �/��� �������,#))8 �/�))�1� ������ ���P

��� =�������� �/��)���1�������)8� ����� �

� �� ��������#�8� 1��/��)���1���)�#�� �� ������ �

� %� ��#��)8�/��)���1�������)8� ����� �

=����#�*�� #����� ������������������)�����# �� # � ����

���,#)�� #� 0����#�*���

<:�#�&$�-�&�"&�!������9��#'%�

��������2�+����0)"�2�C�"��

�2$%)�$&$%#1)$!!#�4$&2��$"#+&%!�"�$-�$&$��%,%&# �<���&�&&# !&&�'$-2& ��)�'',�

4<;5�<���67@���,�))�#))�#����� ���#��)�#����#��#�/��

*#���4������� ���,�))���� � �� ���-#����/���� �-��#������,�

*#�������#����� �#��#���#��1�))��� )����� ���/)�������-#���

��� ���)8�8�����#�� ������������� ���� ���*#����� ��)�&��-�

@���� ����� ��)���/� ���&��-�1�))��� ������������ ����-8��#�

�� �� � �8� �� ���#��� � � �#))� #� 9�#)�/��� �������� �������#��

;��������# �,� �����#���,#8�����) ����#�/����������)������

Page 32: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 32

��%?�'*#7!#"�&$���3$-)"#���

�:8'�+$�-3)"��+#��7!#"�&$��

7������� �����9������1� ��#��#� �,# �����#�&��*�� �����8�0

�,��7�������������)� �� ���#����/�#��#/� 8���� �1� �,���

���,�� # � �1� ��� �� N5;; O� ���� �� ���� ��� ���,�� #

�1� ��� ��N6<�7O����� ����

��� �� � ���,�� # � ��)�1�� ��� ��*�

��� 7�����//�#))��)�� ���#)���1��� ��#��)�#����

�%� 7����#��)�#��������9������1� ��#���*�� ����������1����#� �,# ��#))8� )�*� �� ��� -������� =����&� �8� �� )�*� �-8�#��

��� ��,��� � ��# � #������ �#��)

�"� 7���� &��-� ��� *#�� �#)��� �)��&1���� � �� �//�� =�� �� /�����

��� � '#� �"�,��� ��� ���)�#���� �#�8�*#���/�8��� �����,�))*#� � �75?T� ,,��# �)8� �#))� ��� *#�� ����)���� /��,� #���*�-����*�-��)��*��;�))�1� ���*#������)�������� ���0 ������/�8������� ��,�))�*#��*�� �� ������ �� ���

3�������

�����:�7<�������?�6?��?�

7��733E�75

9���376<�<F���9��������3����

7��6��8�������87��

�!� �7����&��-����*#���#)������� ���)��&1���� � ��7��

��� � ���)#��� ��# � #������ �#��)�

�3� �7�������#))��)�� ���#)���1��� ����� �

���� ��� � ���,�� # � ���������� ��*�

���� �/� ���#��)�#����1�))��� �����# � �/�))�1� ������ ��� ����N7��7����5//��#��7����� O�

�:���)"�7//��%����$&

�� � ��� � ���,�� # �� ��)�1�� ��� ��*�

�� � �7�����//��)�� ���#)���1��� ����� ��/������������ ��-��,#��

%�� � ��,���� ��# � ��� ���� #������ �#��)�

�� � �7����&��-����*#���#)����)��&1���� � ��733�

"� � � ���)#��� ��# � ��� ���� #������ �#��)�

�:��/#&,�"� #"-#�+,�2)&��4�P

7�����//���1��� �� ������ ����)���� ���,#��#)�#�.���,#���*#�

�#)����

3:�G&#��#�8#"$���2)&��4�P

7���� �//� ��� ���,�� # � ��� �� � �� N�@5���?<=O� ,����)����#))�*#���#)����-� ���� ���#)�#���� ���#)� �� ������ � ������� �*#��)�#&#*���� �� �����,-�� ������#,-�����7�����//��1��� �� ������ ����))�#�������#��)� ��������#����� ��#��,�� �-�� ����)#���#���������

?���:��3��������7��B���9

���?�������E��������:<���&#G+##��� #!'�&#+2�"-#)��#"��,

+���$&$��%�

7������� ����/#� ��8���#�*��#������)���9��������/�� ����#0>�� ,�� ��/� ����8� �,���9��������#�*� ����)#�,� �����#�*� ��#��# � � ����8� �, �#��#���9������#,��)# ����#�*��

�7��:�8� �,� ��#�*��*� ��� �� � ����,,���� -�)�1� ��R;

$�"R�(� � �� �,���# ����� -�)�1� ��R;� $�"R�( ��� ��#�*�

)%&-��1��*����� �� ����8� �,�

/� 1��*���*� /#��)� ���� #��� �� � #�#�)#-)� � ��� �� ����&� ��

��#�*� ����� ���/�))�1��*���������P

��� � #��� *#�*�� ,#��/�)�� #�� ����# �� ��� � ��� ���)��*

,����� �)� �8� �,� � #-�)�+��� $#������,# �)8� /���� ,��0

� ��(� �:#&�������#))��� ����#���#,�����#����)����

��� ����& � �#��� �8� �,� ���#�# �)8� 1� �� #))� � #*��� ����# 0

��*�

�%� ��� �#� ���,�,� ��� ��#����# �)8�,�#����� ����� ���

#,-��� � �,���# ����

��� ���)8� ����� ���� �,���# ���� �� #-)���3 ��� ���������

�� � ��,���� ���,#)� ����# ��*� ����������

��56�;���������:����7�9�678�������8��������

7)&���"��$'��&#"$�-�$"�# !

<�%+2�"-#K��!%$-

�)+&$��K !%$-

�"R; �3� �3

!"R; ��� !%

�"R; ��� !"

3"R; ��� !�

��"R; %�! !�

��"R; %"� ��

��56������������:�;��7�9�678�������8��������

7)&���" �������� ��������7)&���"��$'

��&#"$�-�$"�# !

<�%+2�"-#K��!%$-

�)+&$��K !%$-

<�%.+2�"-#K��!%$-

�)+&$��K !%$-

�"�; �3� !� �3� !%

!"�; ��� !� ��� !"

�"�; ��� !� ��� !!

3"�; �3� !3 �3� !�

��" �; %�" �� %�" !3

��"�; %�� �� %�� ��

��56������������:����7�9�678�������8��������

5� ������)

����7� � ����7� ����)

<� ����*����7�,�

=���#�*�Q�������*

��� ����Q"���*

=���#�*�Q�������*

��� ����Q"���*

�"R; ��3 !� ��� !�

!"R; ��� !% ��� !�

�"R; ��� !� ��� !%

3"R; �!3 !� �!� !%

��"R; %�� !! %�� !"

��"R; %"3 !3 %"� !!

Page 33: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 33

��56���

���������:� ��7�9�678�������8��������

5� ������)

����7� � ����7� ����)

<� ����*����7�,�

=���#�*�Q�������*

��� ����Q"���*

=���#�*�Q�������*

��� ����Q"���*

�"R; �3� �� �3� ��

!"R; ��� !� ��" !�

�"R; �"� !� �"" !�

3"R; ��� !% ��� !�

��"R; %�! !� %�� !3

��"R; �"" !" %�% ��

�"� ��,�#��� ������,#)�����# ��*����������� �� �������0

�������- #����/��,� ��� *#�*���� :������#��# �������

���������������,#8�-������� ����� ���//�������

��� ��� #))# ������ ��*��/��#� � �//�������� ���)� ,�#�

�# � ����8� �,������ �������)8���#�*����� �# �#����-0

)�,����� ��1� ����,����,����� ���� ����8� �,����".

"#+&��,%,%&# !"�0'# %0#/�"#!"�+##�$�-�

��� /�����#�*����������� �����*� ���,������/��*��#� �/��,� ��

�8� �,��/�����#�*��������������)�1 �#���/��*��#� � �� ��

�8� �,�

��������,������#�*�� ��� �����,�� ��

��))�1� ����8� �,� ��� #-�)�+���#��� �,����/��*��#�

��� #����� ��,����

�!� ��� � ���/�))�1��*�#����#���,� ���#)��*�1� �� ������0

,#)�����# ��*����������� �����/��,���#��*��

�2�"-#?#"$/$+�&$��:�!!"��+29#&2��

� �� ����*� ����#,�� ���,�,� �� ���,�#���)�9��� �,���#0

���� ���� ����#,-��� � �,���# ����

�����#���7�,���# ����U���9��� �,���# ����,�����#,0

-��� � �,���# ����

�3� �����#��� �,���# ��������)�-��#�����1����� #-)���%�

���#����#��� �,���# ����*��# ��� �#���#)������1����0

��# ���#��������#�*������#����#��� �,���# ����)���

�#���#)������1�� ����# ���#��������#�*��

��� =���� ����� ���#����#���,� ����/��8� �,������������

�� � ,# ��� ���������� ���1��� 7��� #����#��� ,� ��� ��

�� ��#)��/���*����)8���������������#�*���8� �,��

��56���

��������� 6�L��<��98�9�����95������98�������������� ������ ������

��!� � �R;� Q��� � $%�%R��Q� ��"( @.�

��3� ���;� Q���$��!��� Q���"( ���;� Q���$������ Q���"(

���� ���;� Q���$"�"��� Q���"( !�;� Q���$%����� Q���"(

��"� � �R;� Q� �� $���R�� Q� ��"( � 3R;� Q��� $"R��Q� ��"(

�@:��������B���9���?�������E�

�:�������������

�!!'$+�&$��%����#1)$"# #�&%

�))� ������� #��� ������ #�� ����������*����� �/���1� ���

,��/��# ����

��/�� � �� ��� ������ 5���# ���� #�� �� #))# ���� �� ��� ���

:#��#) �/���,������/��,# ����

5:��%8$!$�-

�#� �����)8������*�,�� ��� �#))�1�,���� �#����"O'����������

���������-� 1����*#��,� ���#����� �������)8�*#�������,��

�� �-���,#))��� �#����� �*#�������� ����

��,����� �������� ���#��>��� ���/�*#�������*�9���-�

����� #� � �� ���#� �����/���?�� *#��

�:�#%&$�-��%8$!$�-8"#%%)"#

�987�������+�%## #"-#�+,%2)&��4�$%"#1)$"#�&)"��//&2# �$�%2)&.�//*�'*#����$%+���#+&&2# �$�!�4#"&�)�$&��2#%#+��&"�'%%2�)'�0#!"�!#"','�0#'#�0,&2#$�%&�''#"�

9����69�������:733?�6?�

��66�7��76<����8����������@����73�� 8������H�����

���?�6?���8

���8�8�������8�7��<���

3��6<8�7?�<�<6���8���������8

3�������

'��� ���������� �� ��*�*#��)���� � ���*#���#)���,�� �-����0

������ ��#�����)# �����#���#)�����#��-��#,#*���/���-0

>�� �� ��,���� �#����"����*�$��O'���(�� � ���� ;�*���� %%�

/� �� ��������������9�#)� ����� )���� �#����"����*�$��O'���(

���� ���,#���,#��#)���� 0�//��#)���-�/����� �� ��*� �����)# �

��� �/��,�*#������)8��8� �,�

'��� �����&��*������*������� ����/���*#��)�#&� �����#���#�

��)� �������� �������/�����,�#������,,���&� ������ ��0

*�� ���#���#�����#�,/�)���������������#������,� #)�����

��� *#�� �����*�� 7��� ���� �/� �����#) 8� �#�� ��#&� =� �� ��� ��

� ���*)8� ����,,����� � ��� #�#�)#-)�� ����*�� ������� ��0

����#� ���,-���%�4������<���&)%# �&+2#%+���'#%

/'� #�"�&2#"%�)"+#�/$-�$&$��&�+2#+�/�"-�%'#��%�

Page 34: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 34

<:�#%&$�-��%�)!!',8"#%%)"#

'��� � �� ��*�*#������)8� �������� � ������ � �� � *#�*�� �

��� ��)� � ��������� #� �/$#'�!"�*$�#���� � 7�� � ����)8� *#�

���������1� ����� � /����*�# �,#��,�,��# ��� �:#&������� ��

��#��*�/#))��1� ���� ����#�*���/� ���/�))�1��*��#)��������1

���������,#8�����) �������# �������# �������N����/����O��6�*�

����������#������) � ������,#��� �#,#*�� �� ���*#���#)��

����N����/����O��;����# ��#)�*#����� � �����# ��*����������#

��� ��� � *#�� ������ ���� ,�� � -�� -� 1���� ��"O'���� #�

���"O'��� ��;�����?��*#����� � �����# ��*����������# � ������

*#�������� ����,�� �-��-� 1��������O'���� #�� �%�"O'���

5��,�) ��)����� ���� #))# ���� ��#������ �����)�-������&�

���#�# �)8 �1� ��#��1� ��� � ���� ������� ������# ��*������0

�)8����������,�� �/#))�1� ���� ����#�*��)�� ����� �����������

�#�#*�#���

�:�2#+������()%&9��$/�'�8"#%%)"#

�/ ���)��������������#�� -���� ����&�� #�� #>�� � � ����&

,#��/�)� ���������� ��/��� -#�&� �� /�*���� %�� /��� )��# ���� �/

,#��/�)����������#>�� ,�� �����1�#����������� #���� 0

)� �

7�� �*#���#)������/#� ��8��� �#������)��� ���9�����#>�� 0

,�� � � ��))�*#���#)����#���/#� ��8� ��*�)# ��� :#��/�)� ����0

�����/����# ��#)�*#���������O�)�1�/����E#��%�!O���*��/�����;��

��?����� � �,#��/�)�������������"�"O�)�1�/���E�#�����"O���*�

/�����7�����,#��/�)�����������#��� ����#,�� /���#))������

,��)����*#�)�����/����� �#����+���7���*#���#)�������)

��,�)� �)8�#���,,��# �)8��8�)���//���� ������� ��/�*#����

��1���/#�)������7���,#��#)���� 0�//�&��-��#��-������ ���,0

,��# �)8 ���� ��//�*#������)8�

+#�%!� ,�#�%��-.�,��/�0�1,2�3����-��3,1��.��04

0������,2�3����-��3,1��.��00�����0��,��/�051��

�987�����3�"%�/#&,+���#+&�%2)&.�//*�'*#0#&4##�&2# ��� #&#"���&2#-�%&�!&�!#" $&%2)&�//�/-�%!"#%%)"#&�&2# ��� #&#"�

�� � ������ �#� �� �*#�*�� �� ����� )� ���������� #����� ��

*#���#)������ #� � ������ �#��#))�1�/����,��� ���/��� ��

��� � ����#���� �#8�� # ��

�� � '��)��1#� ��*�/��� ������ � ��� #-�)�+� ��� ���� ���/)#,��

7�� � /)#,�� ����)� -�� � #-)�� 1� ��� � /)#��-#�&� #�

����)��� �)�/ �/��,� ���-��������#���@# ��#)�*#������)

-����-)�������?��*#������)�-����,�� )8�-)���1� ����,�

��#�*�� � ��#&��

%� � �/ ���#))�1��*� ������ � ��� #-�)�+��/��� /����,��� �� � ��0

���� ���,#��/�)�����������:#&��#>�� ,�� ���/������0

�#�8�

��� =�������� � ��# ��*� �,#�� #�� ����� #�� #�� #����# �

��#��*� �#�� -���� �- #����

3:8"�!#"��%3'�4��!!"�G$ �&#�

7������&�/����������*#��/)�1� ��-������ �� ��,����47�6���0

�� �/��,���� ��# ��*��)# ����� ���*#����# ��*��#�#�� 8� #-)����

N�?<�;�� 75@�O ���� ������� ����,#��#)��=����� ��������

�# ��*�-8� ���47�6�������-���/�� ��/�#�#�)#-)��*#�������) ���

�����,-����/���-��� /�� ���������� ��9������=� ��,���� ��

/)�1��/�*#�� ����*��*#��,� ���/��� 1��,��� ���#��,�) ��)8

-8�%�� ��*� �����)8�/)�1��/�*#�� �� ���-�������

�:3'� #�#�%$�-

;)#,� ������� ����#���)�� ���#)������� �1������#�����/��,� ��

�*�� ������� ��)� ����*�� �����������)�� ��������*���� ���0

��# ����� 7��� ������ � �#����� /��,� ��� ������� ����*�� ��

/)#,�� ��*������)�� ���� ����,�)� ��#��#/� 8������� ���7��

�)�� ���������)�-��)��# ����� ��� ����#���# �)�#� ��.�O���0

���� ���/)#,������)������=���� �-����)�� �������7�� ,�#0

�����/)#,�������� �/�))�1� ������������-�)�1P

�� � =�������� ���1��� ����� �

�� � ��,��� � )�#�-� 1����������*��)�� ����#�� �*��0

������� ��)�� �� #))�#�,����#,��,� ��� ����������-�0

1���� ��� ������*� �)�� ���� #�� ��� ��� ��)�� ���

/�*���� %��

%� � �������� ���1���#��#>�� � ���,�� # �/�����# ��*

�,#��

��� ��� � #-)�� ��� #/ ��� /)#,�� ��� �� #-)����� /��� ,� ��

��#��*� �=���� �-����)�� �����

"� � /� ��� ,� ��� ��#)�� ��#�� � � ��� )�#�� #��� ��������

=�������� � ��1��� #�� �������� � )�#�� /��� ������

��)#�� 8�

��� '��� �/������ ��������� ���1��� ����� �-�/������0

������ ��*�,� �����:#&��������������1�������������0

)8��������� ��-�/������������ ��*���1��� ����� �

��56���

9��)/�+&)"#"�� $��'�$-��'9$+"�� !%

<"�!7)&

L56@�5@ ��"���� ��3

;<@'��� ���� %

3�������

�@75@�5@7�5�

=��� � :��5�:?:<7<�

�<@�@�<�<�7�5=<

Page 35: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 35

@:9����������

��� ������)�-�������� ��8�#�)8�-8�#�9�#)�/����������� ���0

����#��

�'#+&"$+ %2�+� 2�C�"� ��� ���-#" �/#G!'�%$��� ��� +�)%# $�()", �#�&2 �"!"��)+& �" !"�!#"&, �� �-#� �)"� �//-�%���#'#+&"$+�'!�4#"&�)�$&0#/�"#!#"/�" $�- ��, �$�&#���+# �"%#"*$+$�-�!#"�&$��%��&2#)�$&�3�''�4'$-2&$�- $�%&")+&$��% �&&�+2#� &� )�$&42#� !)&&$�- )�$& 0�+� $�&� �!#"�&$������/&#"%#"*$+#�" �$�&#���+#�

�������Q

<��-#"�/%2�"! #&�''$+#�-#%����+�)%#$�()",����#+�"#42#�%#"*$+$�-)�$&&��*�$��++$�#�&�'+��&�+&4$&2%2�"!#�-#%�

�����7�Q

�:6)0"$+�&$��

�))�,� ���-�#���*��#������)�-���# ���@��/�� ����)�-���# ���

�����9�����

5:3$'&#"%

��� � ����9������1� �� /�����)�# �� ���1�#1#8� 8��� /�) ����

;�) ���� ����)� -�� ����&�� #�� ���)#��� 1���� ������#�8

1� ��/�) �����/�)�&��&���#����+�����,�)8���,����/�) ���#�����

�#��) �#���)���/�) ������������ #-)���"�/���9�#� � 8�#����+��

7#&� ��� ���/�#���/)�1����� ����,#�&��*����/�) ���/�#,��1���

����� #))��*�/�) ����

3������

3�6�����97?�6

8�663�6�����8��<7��73������6

@57<�;�) ��� �,�� �-������������ �/�������9���#)�� �/������

��� �#�##�

��56��

��� D�#� � 8 ��+�O

��!�.�3� � �����������

���� ������������

���� �������"����

��"� ������������

��"� �������"����

�:5)"�#"%���� ��#'%��',�

� �� ?������#))8���#,����-������ /)#,��� /���������� #���#�0

#��� �����*� �����# ��*���#��������������� ������� ���

���/��� ��/� ���-��������,�#� ,�� ��#�������#��)�

� �� 4�/���� �#��� ��# ��*� ��#���� ��#,���� ��� -������� /��

#�8������ �����-)��&#*��1�����,#8��#�����������

�%� �)�#��-�������#��/�))�1�P

#� 7�����//�-� ���)�� ���#)���1���#��*#������)8� ����� �

-� ��,��� �#�������#��)� ��-��������,�#� ,�� �

�� ��,��� � -������ �� #����*��)���#��)�/ �-�������/��,

���/����

� �)�#��#��������#�8�#�����)#���-����������/� ��� #��0

��*��)����� :#&������� �# �-��������#��)���� ��������� )8�

��#�&�*#�������*�� ����#��/)#,��������*��)�� ����,��

-��������)8��� �� ���� 6<�7@�� �5:?5@<@7����� ���

/��������� �*#������)#��� #�������#��)�

<��-#"�/#G!'�%$������+�)%# $�()",�"�#�&2� <� ��& �*#"&$-2&#� �$� 0)"�#" �)�&$�-%+"#4%���)-&$-2&#���',�

�������Q

������ �����)�� ���#)���1���#��*#������)8��;�))�1�)�*� 0

��*���� ��� �����# #���� ����� �#������������ �������

���#�������#��)� ������&�/)#,��

Page 36: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 36

<:�� 0)%&$���$"���)+#"���� ��#'%��',�

��,-�� ����#����������������*��1� �����������&����,-��0

����#��������������# ����-�/����#))�1��*���1��� �� ���*#�

��� ��))���� �#�� ��� ��))��� 1�))� �� � ����# �� �/� ������� ����-0

� ��� ��

��������,#)�����# ��*����� ���� � �����,-�� ����#�������0

����1���)�����)�-������&��#���)�#��������� �� �����# ��*

��#�����6�1���� �� �����)�-����#,�����������#))8�����*

�����# ��*���#���� ���� #-)����#����#)��)�#���*������)��

'� ����1�������)8��������� � � ������� �����/� ���-)�1��

1���)��#��-��� ��,����-8�)��&��*� ����*�� ������ �����0

��*�

�'#��$�-+� 0)%&$���$"���)+#"���?#�&��!

� �� ��� ��//���1�������)8�#��*#�� ����� �

� �� ��,��� �/��������1���� #����*���� ��#�� �������/���� �

�)�#� ���� ��#��#��������#�8�

�%� ��,���� ����1�� ��)��*� ��,-�� ���� #��� ������� �� /)��

-���#����� ������� ����7#&���#����� � ��)�������#,#*�

��� ��������

��� �)�#� �-)�1���1���)�-)#���1� ��#��,#))�-�����#��1���

�//�#�8��� �/��,�������*���)�#��#���,�)# ���� �/��,

/��� ��/�/)���-���

�"� ���)#�� ���,-�� ����#����������,� ���-8���������*� ���

��������� � � ��� ����,,���� �# � �����,-�� ����#��

�������*#�&� �-�� ���)#�������*� ��#���,-)8�

��� �)�#� � )������� ��� ��,-�� ���� #��� ����)8� $��*� � ���� �/

��# ���� ���(�����*�#��,#))�-�����

�:3')#8�%%�-#4�,���3')#5�G����9��#'%��',�

� �� ��,��� ���,-�� ����#����������#���,-)8�#�������-�

������ ����=�

��� ��,��� � /)��� -��� ������ #�� /)��� �-�� ��))�� ��� �)# ��

�)�#� �1� ��#�1����-�����#����9�����

�%� ?�))� �-��-#//)��� /��,���# �����#�*��� �-���#���)�#�

�-���1� ��#�1����-�����

��� ������� � �-��-#//)���#����#���,-)�� ������ ��7���/)��

-��� ������ *#�&� � #�� ��,-�� ���� #��� ������� *#�&�

����)�#)���-�����)#�������*���#���,-)8�

3:�*�!�"�&�"��$'����� �#���)�#�����)�# �-�*�����*��/��#������)��*�#����# 0

��*���#������)�#������*�,�)�� ��*�� ������,,����#)����)

�)�#������;)�������)�#��������# ���#���1� ��1# ��� #&��*

�#����� � ��*� �����)# ��� �/�) ����#���� ����#����� ��1� �

�:����#�%#"��$'�)�#� �������������)�#���#))8�1� ��� ��*�� ������,,����#)

���)��)�#����#�������� �,�� �)8�����*� ������)��*���#����

�987������/ �4�#" +� !'�$�% �/ $�%)//$+$#�& +��'$�- )�$&%2�)'� 0# -�)-#� ��� "#/"$-#"��& +2�"-#+2#+�#�� �#/#" &� -�)-# ��$/�'� �&&�+2 #�&+2#+�$�-+2�"-#���+2�"-$�-%#+&$��%$�&2$%$�.%&")+&$��%�

�:�)!!',�$"5'�4#"�2##'����#))8� ������ �����)8�#���-)�1���1���)� /���#���,�)# �

�� ������ ��7�����//���1���-�/����# �,� ��*� ����,����#�0

������#��)���� ���)�#��-)�1���1���)�

�:�'#+&"$+�'

�� � ����&�#))�1����*�/���)����������� �����

�� � ����&�/��������� ���) #*��# ���� �$��� �����# ��*(�

%� � ����& � #,���#1� ��� -� �� ��������� /#�� ,� ��� #�

-)�1���,� ����

;#�� :� ��� �# ��*� ?)# �� VVVV� � � �� �#)� VVVVVVVV

����� 4)�1��� :� ��� �# ��*� ?)# �VVVV� �� �#)VVVV

Page 37: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

�93��97������3��9�

3�������

Page 37

@�:������7����

�:�93��9�)�&$�-3"� #

'��� ���� #))��*� #� ������ ���

��� #� ��,-�� �-)�� ���/#��� /��

�1�/)�1� ����#�*�� #��)��#0

���� � �:;��� ���/� ,��� ��*

$/�*���� %�(� /�#,�� ��� ��9�����

5 ���1��� � ��� �:;��� ��� ���0

�,,���� -� � �� � ��9�����

7�� ������ ��/��� �,��� ����

#� /)# � $���/(� ���/#�� � :��7� -�� ������ �� ����� #))� �*��

#������� ���,�)���/� ������ � �������� ��#**��*�� �7��

����� �:��7�-��,��� ��)���)�1� �����.��O�����)���#��/��

���#�8����� ����

7�� � #���,-)�� �:;��� ,��� ��*� /�#,�� ������1�����/�*���

%�� ����/��� �� ����:;������ #))# ������� ��� �����/���� #�)���/

������� #���,-)8� #�� ,��� ��*�� ���/� ,��� ��*� /�#,�

:��7 �-���9�#��� �����/�-�/����,��� ��*���?)���,��8� �,

:��7 �-����� #))��-�/������� ������ �����,��� ��*�/�#,������0

/��� �� � �:;��� ��� #))# ���� ��� ��� ����� /��� ������� �)���,

���� ��� ����

:#�8 � 8�����/����/�/�#,��*���������� ���#��-������ ��,���

������������ �������*�������//���� ����/�� ��� �����

�:��9<��9<�4�/'�4�+��� $C#"

7�� � �<:=��:� �����,�+���� $/�*���� %!(� ����� #� �� � �/

#,���� � ��#))�1��� ������������ ��� ����#��� ��-������/��

���)��*�1������ ������,�� 8�#�� �,���# ����#���#���� 0

#-)�� ���� ���#)�$���� #*�(����)��*��,#��������� �� �

�����,��������1��)�� ���#,�������,#����������/��� ���

#���-���,�����#���� #-)� � ����� ����#���#,������)���� �

#� ���� ��,���� ,���,�,� ���� ���� 1��)�� ��� ��,�������

���)��*������� ��8�)���#�������

3�������

��9<��9<7��367���7�79�J��

�7���7687��� �R��

3������=

�����68B�����

° °

��������?�

4

=

°; °�

!%

!�

�!

�%

�%

��

�3

�!

4

=

�+��� $C#"7!#"�&$��

�:��&2�'!,���&"�'P�#&!�$�&���&"�'

7�� �&�8� �������,�+�������# ������� ����� �#)�8����0

��)���7����� �#)�8���� ��)�������� ��� � #)���# ����0

�� ��/� ����� ����#���$ �,���# �����)�����,�� 8(�#�

����� �# ���/��,# ���� ����� ��)� ���#,��� ��/��� ���

#���-���*� ��� �� ����8� �,���'���� ����� �#)�8��/��� 0

����#������-�)�1� ������ ��)��� ���� � ������ ��)�#� �0

# ���#�,� ���1�������� ����#>�� �� ����� ����#,�0

���� ��,�� � ������)��*��,#����/� ���-��)��*�

'��� � ��� ��# � ��� �� � ������ #-���� ��� ��� ��)� �� 0

���� � ������ ��)��0#� ��# ���#�� ���#,������)���

�� �������� �,���,�,����� ����$�� ��)���(����� ����

71�� 8�����/�#>�� ,�� �,#8�-��,#��# � ������ ��)�

7�� �/��� � ��� ������ ��)��� ���� �� �7����� ���� �� ��0

,����� ��� �,���# ���� #�� ��,�� 8� ���� ����� #

1����� ��� �� ���� #��� #,����� 1�))� ����� #�� �)����

7�� �����,,������ ���� ����N��O��/� ��������,�+��

���#))�1��*�#���1�������� ���1#�,���� �����,���� �� ��

�8� �, � ������ ��)�,#8�-����#�*�� ��#� )�1����� 0

���� �$4 �����=(�� ���/��� ���� �#)�8���#� �/�*����%��

Page 38: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 38

�G� !'#P

/� ����� �#)�8���� ��)������ �# ��� ���� �N�O�#�����1����

/�*����%� � ���/�))�1��*��� �# �������)��������������)��*

�,#� �1���� ����� ����#������# �!"°�#����������� ���0

,�� 8�1��)������ ��������,�+����� ����#���#,����

����� ��� �)�+���� ����#���/������)��*���7�����,�������

���)��*������� �1��)� -�� ��#-)��� � 6�1���� ��/� ����� 0

����#�������)���#�*�� ��!�°;� $#����� ��� �,���# ���(

#��!�������� ���,�� 8�$#��#,# �������������,�� 8( � ��

N � #)���# ���� �� O��/� ����� ����#���1��)������#-���

����� �#)�8���� ��)��� ���� �#����#� ��# �� ���#,�0

���,� ��� �� �������� �,���,�,����� ������/����)��*��0

,#������ �))������� �1���� ��� � #)���# ��/� ����� ����#��

������ #-���� ��� ��� ��)� �� ���� � ���)��*� �,#�� ��

��� ��/��,� ��������,�+��� �� �����,�����������)��*

������ �

0:9$�$ ) 8�%$&$��

7�� ������� 8����/�#>�� ,�� �1�����,#8�-��,#��#

��� ��� ��)� ��� ��� ,���,�,� ���� ���� �/� ��� �� ���

#,��� � -)#���� � <#��� �����,�+��� �#�� #� ,���,�,

���� �����1� ���$�� �� ��,� ��(�1�����#))�1�� ����� 0

���� #,����� �� -�� #>�� �� �� #� ����� � ,���,�,

���� ������7����#))�1��#������ �#,��� ��/�#�������#�*�

# �#))� �,�������*���� �����# ������'������� �����# ���

� ��� � ���#,����������/�))8��)������7����� �� ��,0

� ������)��# ����� ����� �#)�8���� ��)�/#���$,��)# 0

��*� �����,�+��(�

+:��&2�'!,�#�%�"

7�� ��� �#)�8�����������)��# ����� ����� ������� ���

�/� ����� ����#,����-)#���$#�����1�����/�*����%3(�

7�� ��������,��� ���� ��� � #)���# ���� �� ��/� ����� 0

����#���$ �,���# �����)�����,�� 8(�#������� �����0

/��,# ���� �� ����� �#)�8���� ��)���7����� �#)�8����0

��)� ����� ��� ��/��,# ���� �� � ��,���� �/� �� ���� #��

�#��-������/������)��*�

3������;

�����68B����7��66��7�79�J���

�����68B����7�

7��<77����<�98���

<�98���77<

�:9$G#��$"�#�%�"

7�� � ������� ,�#������ ��� ����) #� � �,���# ���� �/

���,����#����1�� ��#,��/� �����#���# ������)���7��

,����#��� �,���# �����������-8� ����� �#)�8���� ��)

1���� �� ���� #,����� #��� ����� �� ��)�� � ��,���

1�� ��� ��� ����#���#,���������)��)������:��)# 0

��*������,�+����#����9������1� ��#����*)��,����#��

�������

7�� �,����#����������$-�)-(����)��# ����� �������)8�#��

� ��#,� � 7��� ������� $,��)# ��*� �����,�+��(� /� �

����*��#�/#� ��8�����)�����)����� ����#��)������*

������ ��� ����#������)8�#���

Page 39: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 39

#:9��)'�&$�-<� !#"9�&�"�2#+�

���#,4#''��� ;�

�� �=�������� � ,#��� ��1��� �� ��� ������

�� �7���� ���,�� # ���� ��)� ��5;;����� ����$����0

���� ,��(�

%� ��� #))� >�,���� #������ ��,��#)�� ��3� ��� -)�1��

��)#8������� ���� ��)�-���

�� ��� #))�>�,����#�������� �#)�8���� ��)� ��,��#)�

7�#��7��������/�*�������/���� )��# ����

"� ���� ��� ���1��� ����� ���5� ����#,��������)

����� �� /�))8� ����� ���� ���� $��� �� 3�� ����� ��0

9�����/���/�))� �#��)(���5-������ �#��)�/���������

#,��� �����# ����

�� �=�������� ���1��� �� ������ ���5� ����#,���

����)������*��� ���� ���)�������� ����

!� ���,��� �7�#��7��>�,���� ������� ������1��� �

������ ���5� ����#,��������)������ ��,���0

,�,����� ������>�� �,���,�,�#,�������� ���

�� � )��# �������� ��)������/�*�������

�� �=�������� ���1��� ����� �#����,����>�,������

-)�1��� ��)#8� ��,��#)�� ��3�� ���)#��� #))� �#��)��

��� ������1��� ����� �

3�������

97<�6������76�<����������68B�7���76

7� 7��

4 �

=Q

Q

"

7�

?�?

7

�<=

%

9���9�987����7�������

/:��" �!E$&

��� �� ���#)� 1#�,� ��� &� � ,#8� -�� #�� �� �� ���

�<:=�� � ��� <:=6��� �����,�+��� $����� � ������

����*� #� 6���81�))� '!���� ��� ��)� �8� �,(�� � 7��

1#�,� ��� &� � ��)�� ��� #,����� �)���� ����*� ��*�

�� -#�&�#��,�����*�1#�,����� �'���� ��� /��� � ���0

,�� # ��,#���/� ���#8�����# ��/�� �� ���1#�,����&�

������ ����� ����#,����� ��,���,�,����� ������7��

1#�,� ��� &� � ,��� �� �� ��� ������ ��� ��� ��� ��)

,��� ��*� #��#� �/� ��� -)�1��� ��,�#� ,�� �� � 7��� &�

�)�*���� �� ������ �1����*��#��������)����-� 1���� ��

��� �#�� ��������,�+���

-:�$-2&�#'�,

5� ���#)� ��*� � ��)#8� ,�� � -�� #�� �� �����,�+��

1������*� ��� -#�&�/��� �����#���������1� ��'3!%

����)�� ��,���#���#)���� ��)��8� �,����B� ����)����#

=?=7 � ��)#8� 1����� ��� �#��1���� �� ��� �����,�+��

�#������

/�#�'3!%��8� �,������� � �����)#8���)�� ����� ���

#,���� ��)��������*��� -#�&���/�#���)�� ��,���#�0

��#)� ���,�� # � �8� �,� ��� ��� � ��� ��)#8� ��)�� ��

�� ���� #,����� �)���� ����*� �� -#�& � ������0

*�+��� ��� ������ ���,�� # � #�� ����*�+��� ��� �� 0

-#�&� ���,�� # �� �@�*� ���)#8� ����� ���9�����/���#�8

� ������� ��)��8� �,�

�:7�<��7)&���"�$"<� !#"

5�=�� � #,���� ��� ���� $/�*���� ��(� ,#8� -�� ��� #))�� #�8

�)#����� �����/� ���-��)��*���� ����� ����#����� �/�������+��0

#)�#��)��# �����#����� ����� ����#����#��)�/����1�/)�1�#�0

�)��# ������ ��/��� �� 5�=��� ��� #))# ���� ��� ��� ���� ,#��#)

/��������/���� #�)����*#���*���� #))# �����7���5�=���#,�0

��� ,� ��� &� � $%"���(� �������� ,� ���+�� ����# ���� �/� #��

#,��� � -)#���� 7��� 1#��#-)�� /�) ��� ����)��� 1� �� ��

5�=�� � �#�� -�� �)�#��� 1� �� 1# ��� #�� ,�)� � ��*�� ��

����)�-�����#8��1� ��;�) ���6#����# ���1�����8������� �

����� #))# �����;�) ���6#����# ��������?��?���� ����# ��*����

��� �#�� ���#�#�)#-)��#���������?#� �@���?���"��3� $%���"(�

3�������

7�<��<�98����<97�7�

97�7�97������5���E��

97�7�����E��9

<�98��97�7�

�:68�E$&

�))��������# ���������#���/#� ��8��� �/�������1� ���# ��#)

*#��� ������ ���#)���?���� ����������� &� � #))�1�� ��#�*�����

/��,��# ��#)� ����?���� ����)8��7���&� � ���)����#�*#���#)��

��#�*����� � &� � #�� ��1� *#�� ���/����� �������3���� ,��)�

1�))� �#��� !.����!� � �#�*� � ���#� *#�� ���/������ �������!�

�������3��� � #�� ��������.�"�� ,��)�� 1�))� �#��� �.�

@?7 ������ ���#�*#�����/�����

��/�� � �� �����?���������������&� ���� #))# ������� ��� ����/��

�����/������ #))# ��������������

Page 40: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 40

:����#�%#"��$'�)�"�E$&5� ���#)�������������)�*�#��&� � ���#�#�)#-)�� /���#))���� ��

7�� �&� � ���)����?A����# ��� ��)�1�������)�*�#��1�������

/��)���� #))��

�:6�4� 0$#�&E$&

7�� ��� ���#)�)�1�#,-��� �&� �$/�*������(�#))�1��/���,���#��0

�#)� ���)��*�����# �����1�� ���R;� $�!�!R�(

�����7��� !"#%%�" ��$&�"+����&0#)%#�4$&2�!&$���''�4� 0$#�&�$&�7!&$���'/$#'�$�%&�''#�+� !"#%.%�" ��$&�"9���0#�$%+���#+&#�0#/�"#�''�4.$�-'�4� 0$#�&�$&&�0#)%#��

7�� �)�1�#,-��� �����������1� ������1��������������1� �� ��

�������� � /#�� ��� )�#� ��� ��� �������!��,��)�#��1� �

���� B��� ��������� /#�� ��)#8� ��� �������3�.���.�"�� ,�0

�)��� ��/��� �� ��� )�1� #,-��� � &� � ��� #))# ���� ��� ��� ���

,#��#) �/���� #�)����� #))# �������� ��� �����

7�� �)�1�#,-��� �����������1� ����8�)��� ������������/#�

1��)��#))�1��*����,#)���,������������# ������7������ ��,� 0

�� �/#������# ��������) �����#���*����#���# ��*� �,���# ���

1�����#))�1�� ����8� �,� ������# ��1� ��� ���#���# ������)

����*�#��)����*��#�#�� 8�

3�������

67��95����8�������������

67��95����E����B8���6�����66���7��

6�L��<6���

<��������6���

�����7�6��������87��

�����7�6���

?�6?�<�8����7����

��7�E6778

��()%& #�&P

7�� �)�1�#,-��� �����������1� ������#>�� #-)��-� � ���#0

>�� ,�� �&��-��������#>�� ���7�@����� �� ���7�@�����

��� /���� #�� �#��� � -�� #>�� ��� � 7��� ��#)�� ��� ��� �1� ��

,�#����� � ����//������� ������������-� 1���� ������ ���7�

@� #�� #>�� #-)�� ��7�5�7� ���� ��� � �>�� ,�� � &��-

��#�*�� � ��7�5�7� ���� � -8� #>�� ��*� ��� =;;<�<@�<

-� 1��� � ��7�@� #�� ��7�5�7�

7�� �)�1�#,-��� �����������1� ������/#� ��8��� � ����7�@�#

��"���* �1� ��#��//��������/���"���*� $��7�5�7�# �������*(�

�>�� ,�� �����)��� �-���������/�#>�� ,�� ��������

#>�� � ����1� ���#��/�))�1�P

�� � �������&��-��������*�����1� ��#))�1�&��-�� ��� ���#��

�����/����� ��������� ��)�$����/�*�����%(�

3�������

67��95�����<F���9���<����6

�7�����7������67�E����

3�@�<��78

E�75�������������

�<F���9���E�75

67��95�����7���76

�����<����7������8���

67��95�����<F���9���

<�33�������%#&0,���0�S���:��87����/$G#�� $.

�)%���:7��87���

7�� /�����7�5�7����� � �����9�# �����#��-�� ���#��#�*�P

��7�5�7� U� ��7�@� ,����� ��� =;;<�<@�<�

�� � �� # � � ���&��-�#������� ���� � ����//������� ����#0

��� # � ��"���*� $����&?#(�

%� � 7�*� ��� ����������*�����1�#/ ���#>�� ��*�

�:�"��%$&$��%

5� ���#)�����)8.�� ���� �#��� �����$��7��(� #��� #�#�)#-)��/��

���� 1� �� �1�/)�1� ������� � �)�+��*� ��� �� ���#)� �:;��

���/�,��� ��*�/�#,��#������)8.�� �����//�������7��� �#���0

����,�� �-����� #))������ ����:;���,��� ��*�/�#,��-�/���

,��� ��*� ��������� �� ���/�#,������/��� �� ���,#��/#� ��0

��2�� ��� ��� ����� ���)��� 1� �� ��� �#��� ���� /��� � #�)�

��� #))# ���� ����������

=:�)!!',����#&)"�<$//)%#"%

5� ���#)�/)����,��� �����)8.�� �����//������ ;=���3"� #�

;=����%" � #�� �� ���� ,��� � ����)8.�� ���� �//�����

�7=���3" � #�� �7=����%"� #��� #�#�)#-)�� /��� ���� 1� �� ��

������ � ��/��� �� ��� ,#��/#� ����2�� ��� ��� ����� ���)��

1� �� ��� �#��� ����/���� #�)����� #))# ��������������

Page 41: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 41

@��:������<�����9���<��L�����7378�����7�

�����:���������<�����9

=

��

;

Page 42: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 42

�����:�����L�����7378�����7�

7!#"�&$���#1)#�+#���'$�-P

��� ����� ��) #*�� ����*�+��� �#��/��,��� 7��� 7�#��/��,��7� �����������A�����1��� ��#))���� ���� ��)��#�� ���0,�� # �

��� ���)��*��,#������*�+���K��#������� ��� ���,�� # �B%�-)�1�����)#8� �������*�+���A�) #*���#����� ����*���3� /���+�� # � ���������*������������1� �� � ������0*�+�� B�� ��,�������� ��� #� ��� $#���,��*� )�9��� )�����������������*������*�� ���)��������)�1�#,-��� �&� (�

�%� B��� � �)����� �� ����*�+�� ��,�������� #�� ��������/#�����,��������4��#�����������/#��4���,,��# �0)8�-�*�������# ��*����,�) #�����)8�B%������ #� ���)�������*�+��*�������-)�1���4%�#�������,�+���$�/����(�

�#�&$�-P�%&�&�-#

��� 6�# ��*� �,#����� �# ���# �'����� ��� ���,�� # �#�����*�+��� ��)#8� B�%�

�"� B�%�� ���� #� ���)��������*�+��*���,-�� ����#�������0���4���'���� ����������#/ ���#���/�))����� �������1� ��������)������6�# ��*��,#����� ������ ����*���� ��������,#�8�)�,� ����������#�8�)�,� �#��/)#,���))�� ��1� �����!� ������*�+���*�� ������� ��)��%�

���*�� ������� ��)��%� ����1#� ��%�� ������������ ��#))�1

��,-�� ���� #��� ������� 4�� �,�� �� �#1� ���#�� � *#�

/��,���,-�� ������#,-���#�� �� �� ������ /�����#���

��,-�� ���� #��� ������� 4�� ����# ��� ����*��� � ��

��# ��*��8�)��

�!��/ ��� ����*�� ������� ��)��)#8 � �%� #� ��# ��� *#�� �#)��

�A� �#�� �����#�&��)�� �����'����/)#,�����������-8

��� /)#,�� ������� $,���,�,� "� ,����#,��(� ��� ��#�&

�)�� ����� �����/�/)#,������� �������#/ ��� ���/��� � ��#)

/��� �*�� ��� ���� ��))����%�����# ��� ������#��!���� �

1��,���� �,���$������*������� ��))���,#&�(�-�/���

)��&��*��� ��/� ������ ��)�)��&���� �� ��#��-������ �-8

-��#&��*� #�� ��,#&��*� ���,�� # � �,#��

��� 4)�1��� �)#8� ��)#8� B�"� ����*�+��� -)�1��� 4%� #/ ��� �"�������)#8�

�#�&$�-P�����&�-#

�3�'� � � /��� � � #*�� ����# ��* � #�� #� ���#)� ��# ��*� �0

,#����� �# ���'����� ��� ���,�� # �

����=�% �����*�+���*#���#)����A��#/ ��������������)#8�

��� �����# ���# �/�))���# ��*��#�#�� 8�

Page 43: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 43

�B8���6�����:�;�:�������<�����9

��

=

;

��

��

Page 44: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 44

�B8���6�����:�;�:�������<�����9

=

;

� �

��

��

Page 45: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 45

�����:�;�:����:���L�����7378�����7�

7!#"�&$���#1)#�+#���'$�-P�%&��&�-#

��� ����� ��) #*�� ����*�+��� �#��/��,��� 7��� 7�#��/��,��7� �����������A�����1��� ��#))���� ���� ��)��#�� ���0,�� # �

��� ���)��*��,#������*�+���K��#������� ��� ���,�� # �B%�-)�1�����)#8� �������*�+���A�) #*���#����� ����*��� ���#)��,����� �� ����)�1�#,-��� �����������1� ��#��B"�� )�1� #,-��� � ��)#8 �������� )�1�#,-��� �����0������1� ���#��B����)�1�#,-��� ���)#8 �$#���,��*� ��)�9��� )���� ��������� ��� ��*�� ����*�(� �� ����*�+�� B����������� /#�� ��)#8�� ��,�) #�����)8� ��) #*�� �#���� ����*�� ��3� /���+�� # � ���� �����*������������1� �� ������*�+��B����,����������� #� ���

�%� B��� ��)����� ������*�+����,��������#��B������)���� �� ����*�+�� ��������� /#��� ��,�������� 4�� #�� ���0������ /#�� 4�� �,,��# �)8� -�*��� ����# ��*�� ��,�) #0�����)8� B%������ #� ���)��������*�+��*�������-)�1��4%� #�� �����,�+��� $�/� ���(�

���'$�-P�����&�-#

��� ���)��*��,#������*�+���K�� ��� ��� ���,�� # ��A�) 0#*�� �#����� ����*�� �"�� /���+�� # � B��� ��������/#����)#8 �#���!���*������������1� ��� ������*�+��B���,����������� #� ����B������� #� ���)��������*�+��*��,�������� 4��

�#�&$�-P�%&�&�-#

�"� 6�# ��*� �,#����� �# ���# �'����� ��� ���,�� # �#�����*�+�����,-�� ����#��� ������� ��)#8�B�%�

��� B�%�� ���� #� ���)��������*�+��*���,-�� ����#�������0��� 4��� <����,�+��� ��� #)��� ����*�+��� '���� ��� ��,0-�� ����#������������#���/�))����� ��������1� �������)������ 6�# ��*� �,#�� ��� ������ ����*�� ��� � ������,#�8� )�,� � ���� �����#�8� )�,� � #�� /)#,����))�� �1� �����!� ������*�+���*�� ������� ��)��%�

�!�*�� ������� ��)��%� ����1#� ��%�� ������������ ��#))�1��,-�� ���� #��� ������� 4�� �,�� �� �#1� ���#�� � *#�/��,���,-�� ������#,-���#�� �� �� ������ /�����#�����,-�� ���� #��� ������� 4�� ����# ��� ����*��� � ����# ��*��8�)��

����/ ��� ����*�� ������� ��)��)#8 � �%� #� ��# ��� *#�� �#)���A� �#�� �����#�&��)�� �����'����/)#,�����������-8 ��� /)#,�� ������� $,���,�,� "� ,����#,��(� ��� ��#�&�)�� ����� �����/�/)#,������� �������#/ ��� ���/��� � ��#)/��� �*�� ��� ���� ��))����%�����# ��� ����!�#������� � 1��,���� �,���$������*������� ��))���,#&�(�-�/���)��&��*��� ��/� ������ ��)�)��&���� �� ��#��-������ �-8-��#&��*� #�� ��,#&��*� ���,�� # � �,#��

�3� 4)�1��� �)#8� ��)#8� B�"� ����*�+��� -)�1��� 4%� #/ ��� �"�������)#8�

�#�&$�-P�����&�-#

����'� � � /��� � � #*�� ����# ��* � #�� #� ���#)� ��# ��*� �0,#����� �# ���'����� ��� ���,�� # �

���� =�% �����*�+���*#���#)����A��#/ ��������������)#8���� �����# ���# �/�))���# ��*��#�#�� 8�

Page 46: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 46

�����:����� �������<�����9

=

��;

��

Page 47: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 47

�����:����� ���L�����7378�����7�

7!#"�&$���#1)#�+#���'$�-P�%&��&�-#

��� ����� ��) #*�� ����*�+��� �#��/��,��� 7��� 7�#��/��,��7� �����������A�����1��� ��#))���� ���� ��)��#�� ���0,�� # �

��� ���)��*��,#������*�+���K��#������� ��� ���,�� # �B%�-)�1��� ��)#8� �������*�+�����,�) #�����)8 ���) #*��#���� � ����*�� ��3� /���+�� # � �� ���#)� )�1� #,-��� &� � ���� ��� ���� $#���,��*� )�9��� )���� ��������� ��� ��*�����*�(�����*�+��*�B����,����������� #� ���#��B���������� �/#����)#8�

�%� B��� ��)����� ������*�+����,��������4��#��B�����#�B���� � �)���� �� ����*�+�� ��������� /#��� 4�� #�� 4"���,������� �4��#�����������/#���4��#��4"��,,�0�# �)8�-�*�������# ��*����,�) #�����)8�B%������ #� ��)��������*�+��*�������-)�1���4%�

���'$�-P�����&�-#

��� ���)��*��,#������*�+���K�� ��� ��� ���,�� # ��A�) 0#*�� �#����� ����*�� �"�� /���+�� # � #�� �� ���#)� �!��*������������1� ��� ������*�+��B����,�����������0 #� ����B������� #� ���)��������*�+��*���,��������4��

�#�&$�-P�%&�&�-#

�"� 6�# ��*� �,#����� �# ���# �'����� ��� ���,�� # �#�����*�+��� ��,-�� ���� #��� ��)#8� B�%�

��� B�%�� ���� #� ���)��������*�+��*���,-�� ����#�������0��� 4��� <����,�+��� ��� #)��� ����*�+��� '���� ��� ��,0-�� ����#������������#���/�))����� ��������1� �������)������ 6�# ��*� �,#�� ��� ������ ����*�� ��� � ������,#�8� )�,� � ���� �����#�8� )�,� � #�� /)#,����))�� �1� �����!� ������*�+���*�� ������� ��)��%�

�!�*�� ������� ��)��%� ����1#� ��%�� ������������ ��#))�1��,-�� ���� #��� ������� 4�� �,�� �� �#1� ���#�� � *#�/��,���,-�� ������#,-���#�� �� �� ������ /�����#�����,-�� ���� #��� ������� 4�� ����# ��� ����*��� � ����# ��*��8�)��

����/ ��� ����*�� ������� ��)��)#8 � �%� #� ��# ��� *#�� �#)���A� �#�� �����#�&��)�� �����'����/)#,�����������-8 ��� /)#,�� ������� $,���,�,� "� ,����#,��(� ��� ��#�&�)�� ����� �����/�/)#,������� �������#/ ��� ���/��� � ��#)/����*�� ��� ���� ��))����%�����# ��� ������ ����*��3��� �� 1��,���� �,���$������*������� ��))���,#&�(�-�0/����)��&��*��� ��/� ������ ��)�)��&���� �� ��#��-������ -8� -��#&��*� #�� ��,#&��*� ���,�� # � �,#��

�3� 4)�1��� �)#8� ��)#8� B�"� ����*�+��� -)�1��� ��)#8� B%1����� ��� ���� ����*�+��� -)�1��� 4%� #/ ��� �"� ������)#8�

�#�&$�-P�����&�-#

����'� � � /��� � � #*�� ����# ��* � #�� #� ���#)� ��# ��*� �0,#����� �# ���'����� ��� ���,�� # �

���� =�% �����*�+���*#���#)����A��#/ ��������������)#8���� �����# ���# �/�))���# ��*��#�#�� 8�

Page 48: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 48

�����:�� : ���B?76����

=

;

��

@57<�;�� � <�6����"&'� /�))�1� � ���� �� ����*�� �� $,����� =��(�� ;��� <�6���%� /�))�1�� ������ ����*��"��;���<�6������ /�))�1�� ������ ����*���� $,�����=�"(�

��� ��� ��)���) #*����� ������# ����������)���-8�#����#�# �� �#��0/��,���7��1����������1����# �#))� �,���

��� �� � � #*�� ��# ��*� �,#�� �)����� '��� '�� ����*�+��� ��)#8B3�

�%�'����B30���1� ���� �������-)�1������ #� ���B%��������0*�+���7���������-)�1��������1����$#���� ���#)������0,�+��� ������ �� ,���,�,� ���� ���� 1���� B%0�� ��� #� ��)���(��'����B30���)���� �������� #*����# ������#-)��'����B30%��)���� ���� ��)���) #*���#����� ����*�����,#0�8�)�,� ���"� ������*�+����� #� ���B�"�#�� �,���)#8�=���

��� '��� � B�"0�� �)���� � ��# ��*� �)�,�� �� 6<�� #��� ����*�+���))� �)�,�� �� #��� #��#�*�� ��� #� N=�) #O� ���/�*��# ���� /�����.�%�A �����# ����

�"� =����)�����%��������� )# ��� ������*�+����� #� ���B���

��� '���� B��0�� �)����� ��# ��*� �)�,�� �� 6<�� #��� ����*�+��

�!� �� ���#)���# ��*��,#��'���#����� ����*��B30�� ������0*�+�� ��)#8�B�3�

��� '��� � B�30�� �1� ���� � �,�� �)#8� =��� ��� ����*�+��� =���)�����%���������)# ��� ������*�+����� #� ���B�!�#�� �,��)#8� =�"�

�3� '���� B�!0�� �)����� ��# ��*� �)�,�� �� 6<%� #��� ����*�+�

���� =�"��)�����#/ ���%��������� ������*�+����� #� ���B������� '���� B��0�� �)���� � ��# ��*� �)�,�� �� 6<�� #��� ����*�+��

��

Page 49: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

Page 49

�����:�� : ����DF?76����

7!#"�&$���#1)#�+#P

��� �� � � #*�� ��# ��*� �,#�� �)����� '��� '��#���� � ����*�����,#�8�)�,� ����"� ������*�+�����0 #� ���B�"�#����)#8�B3��B�"0����� #� ���)����#�B30� �#��B30��-� ���1� ���

��� '��� � B�"0�� �)���� � ��# ��*� �)�,�� �� 6<�� #�6<� � #��� -� �� ����*�+��� 7��� �)�,�� �� #��� #�0�#�*�� ���#�N'8�O����/�*��# ���� /������A����"!"A����# ����

�%� '��� �B30���1� ���� �������-)�1������ #� ���B%�������*�+���'����B30���1� ���� � �,���)#8�=�������#-)��$������ � ����)���� ��'�(�

��� '��� �B%��������*�+� � ���������-)�1��������10���� $#�� �� ���#)� �����,�+��������� ��,���,�,���� ����1����B%0����� #� ���)���(�

�"� �� ���#)���# ��*� �,#�� '�� �#����� ����*�B30� � �� ����*�+�� �,�� �)#8� =���

��� =�� � �)����� #/ ��� %�� �������� ��� #� ��� B��� ������*�+��

�!� '��� � B��0�� �)���� � ��# ��*� �)�,�� �� 6<%� #�6<�� #��� ����*�+��

@57<�;��� <�6����"&' � ��&'� F� %�&' �/�))�1�� ������ ����*����$,�����=��(�

Page 50: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

?#*

��"

�6����79��������6����97����������7�79�J��

=

;

��

��

��

Page 51: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

?#*

��"

�6����79��������6����97����������7�79�J��

7!#"�&$���#1)#�+#P��� <����,�+����� ����#���#,����������/�))��)����#�8 �,��-)�1���4%������ �����# ��*�$�1� ����-8�B%������ ������ (���� =#,��� �,� ��� ��,��#)�7�������1����-8���� ���� #� ���B%�1���� ��������#�-)�1����,#�����#���# ��*��,#��� �'������A������#��)���-� 1���

��,��#)��7��#��7�� � ���#,����,� ��� �������*�+��#�� ����� ����#���#,���������� ��,���,�,����� �����%� 4)�1���4%��������*�+��$������ )8(�-8� ���,�� # � ��,��#)�����5��#����)��*��,#� � ���,�� # � ��,��#)�������*�+������ #� ���B%�1�������� ��������0

*�+��� ���-)�1���$��/��� ������# ������9�������������������#*��/�����#� ���9�����(���'����B%�����*�+�� �B%����)����� ������*�+�� ���-)�1���#��B%���)����� ������*�+�� ��������,�+��� $����� ����(�#������� ����� ����#���#,����� ��,���,�,����� ����

��&2�'!,6�4�%&�&�-#���'P��� �� �#)����)��*��,#��K�������� � ���� �#)�8���� ��)����#�� ��,��#)����"� <� �#)�8���� ��)�����#��� ��,���� �# ��� ����#����#��-������/������)��*�#���#���1� ������ ���#)���)#8���B�#���B���� ���)��*��,#�������� �� ����*���� �#)�8���� ��)� ������*�+���� ���#)���)#8������ ���#)���� #� �������)���� ����,�)� ��#������� � ����*��#,����,� ��

��,��#)�� 7� #�� 7���!� '��� ������) �����#��)���#������ ��,��#)��7�#��7���/�#,����,� �� � ���#,����,� �������*�+���#���� ����#���#,����������������)8�#������������

�#����� �����) #*��#������7�#��7��#�� ����� ����#���#,����������#��#>�� �#������*)8����� �� #*�����)��*�����������-8��� ����#�����&2�'!,6�4����&�-#���'P��� <����,�+��� �� ���� #��� #,����� ��,#��� ������3� �� ���#)����)��*��,#�������� ��/��,� ���,�� # �K�� ����*���� �#)�8���� ��)� ��,��#)��%�#��"� ������*�+�� ����� �� #*����,�����������7�����

� #*����,����������������#))�#� ���#)����)��*���&2�'!,�$-2�%&�&�-#���'P

���� <� �#)�8���� ��)��� ���#)���)#8���B�#���B��1� ����� ���#)���)#8�������������*�+��#��������������5� ����#���#,������)���� ��,���,�,����� �������� ���)��*��,#�������� �/��,� ���,�� # � ��,��#)�K�� ����*���� �#)�8���� ��)� ��,��#)����#����#�� ����*���� �#)�8���� ��)� ��,��#)�"� ������*�+�� ��

�� � � #*�� ��,�����������&2�'!,�$-2����&�-#���'P

���� �� ���#)����)��*��,#�������� �/��,� ���,�� # � ��,��#)�K�� ����*���� �#)�8���� ��)� ��,��#)��%�#���� ������*�+�� ������� #*����,��������

Page 52: Service Literature GCS/CHA16...Service Literature GCS16 series units in the 6, 7.5, 10 and 12.5 ton (21, 26.4, 35.2 and 44.0 kW) cooling sizes are packaged combination gas heat/dx

?#*

��"

���?����7���