specification proposal · web viewclear frame rails from back of cab to front rear suspension...

Prepared for:Doug BurkeODOT State Bid1980 W BroadColumbus, OH 43233Phone: 614-351-2831

Prepared by:Greg Simonic

CLEVELAND FREIGHTLINER, INC.

10901 Brookpark RdParma, OH 44130

Phone: 216-267-4800

ITEM 3

A proposal forOHIO DEPT OF TRANSPORTATION

Prepared byCLEVELAND FREIGHTLINER, INC.

Greg Simonic

May 23, 2016

Freightliner 108SD

Components shown may not reflect all spec'd options and are not to scale

Application Version 8.9.114Data Version PRL-14D.029FTL ODOT 3 023-16

05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

S P E C I F I C A T I O N P R O P O S A L

Description

Weight Front

Weight Rear

Price LevelSD PRL-14D (EFF:10/05/15)

Data VersionSPECPRO21 DATA RELEASE VER 029

Vehicle Configuration108SD CONVENTIONAL CHASSIS 6,829 3,748

2017 MODEL YEAR SPECIFIED

SET BACK AXLE - TRUCK

TRAILER TOWING PROVISION AT END OF FRAME FOR TRUCK

10 10

LH PRIMARY STEERING LOCATION

General ServiceTRUCK/TRAILER CONFIGURATION

DOMICILED, USA (EXCLUDING CALIFORNIA AND CARB OPT-IN STATES)

UTILITY/REPAIR/MAINTENANCE SERVICE

GOVERNMENT BUSINESS SEGMENT

DIRT/SAND/ROCK COMMODITY

TERRAIN/DUTY: 100% (ALL) OF THE TIME, IN TRANSIT, IS SPENT ON PAVED ROADS

MAXIMUM 8% EXPECTED GRADE

SMOOTH CONCRETE OR ASPHALT PAVEMENT - MOST SEVERE IN-TRANSIT (BETWEEN SITES) ROAD SURFACE

FREIGHTLINER SD VOCATIONAL WARRANTY

EXPECTED FRONT AXLE(S) LOAD : 20000.0 lbs

EXPECTED REAR DRIVE AXLE(S) LOAD : 26000.0 lbs

EXPECTED GROSS VEHICLE WEIGHT CAPACITY : 46000.0 lbs

EXPECTED GROSS COMBINATION WEIGHT : 80000.0 lbs


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

Truck ServiceFRONT PLOW/END DUMP BODY

EngineCUM ISL 330 HP @ 2000 RPM, 2200 GOV RPM, 1000 LB/FT @ 1400 RPM

Electronic Parameters65 MPH ROAD SPEED LIMIT

CRUISE CONTROL SPEED LIMIT SAME AS ROAD SPEED LIMIT

PTO MODE ENGINE RPM LIMIT - 900 RPM

PTO RPM WITH CRUISE SET SWITCH - 900 RPM

PTO RPM WITH CRUISE RESUME SWITCH - 900 RPM

PTO MODE CANCEL VEHICLE SPEED - 5 MPH

PTO GOVERNOR RAMP RATE - 250 RPM PER SECOND

PTO MINIMUM RPM - 700

REGEN INHIBIT SPEED THRESHOLD - 5 MPH

Engine Equipment2016 ONBOARD DIAGNOSTICS/2010 EPA/CARB/GHG17 BUT NOT FINAL GHG17 CONFIGURATION

NO 2008 CARB EMISSION CERTIFICATION

NO 2013 ENGINE ESCALATOR

STANDARD OIL PAN

ENGINE MOUNTED OIL CHECK AND FILL

SIDE OF HOOD AIR INTAKE WITH FIREWALL MOUNTED DONALDSON AIR CLEANER AND INSIDE/OUTSIDE AIR WITH SNOW DOOR

10

DR 12V 200 AMP 28-SI QUADRAMOUNT PAD ALTERNATOR WITH REMOTE BATTERY VOLT SENSE

(2) ALLIANCE MODEL 1231, GROUP 31, 12 VOLT MAINTENANCE FREE 2250 CCA THREADED STUD BATTERIES

BATTERY BOX FRAME MOUNTED

STANDARD BATTERY JUMPERS

SINGLE BATTERY BOX FRAME MOUNTED LH SIDE UNDER CAB

WIRE GROUND RETURN FOR BATTERY CABLES WITH ADDITIONAL FRAME GROUND RETURN


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

NON-POLISHED BATTERY BOX COVER

CUMMINS TURBOCHARGED 18.7 CFM AIR COMPRESSOR WITH INTERNAL SAFETY VALVE

ELECTRONIC ENGINE INTEGRAL SHUTDOWN PROTECTION SYSTEM

RH OUTBOARD UNDER STEP MOUNTED HORIZONTAL AFTERTREATMENT SYSTEM ASSEMBLY WITH RH B-PILLAR MOUNTED VERTICAL TAILPIPE

30 25

ENGINE AFTERTREATMENT DEVICE, AUTOMATIC OVER THE ROAD REGENERATION AND DASH MOUNTED REGENERATION REQUEST SWITCH

10 FOOT 06 INCH (126 INCH+0/-5.9 INCH) EXHAUST SYSTEM HEIGHT

RH CURVED VERTICAL TAILPIPE B-PILLAR MOUNTED ROUTED FROM STEP

6 GALLON DIESEL EXHAUST FLUID TANK -35 -10

100 PERCENT DIESEL EXHAUST FLUID FILL

STANDARD DIESEL EXHAUST FLUID PUMP MOUNTING

LH MEDIUM DUTY STANDARD DIESEL EXHAUST FLUID TANK LOCATION

STANDARD DIESEL EXHAUST FLUID TANK CAP

ALUMINUM AFTERTREATMENT DEVICE/MUFFLER/TAILPIPE SHIELD(S)

HORTON DRIVEMASTER ADVANTAGE ON/OFF FAN DRIVE

AUTOMATIC FAN CONTROL WITHOUT DASH SWITCH, NON ENGINE MOUNTED

CUMMINS SPIN ON FUEL FILTER

COMBINATION FULL FLOW/BYPASS OIL FILTER

1200 SQUARE INCH ALUMINUM RADIATOR

ANTIFREEZE TO -34F, ETHYLENE GLYCOL PRE-CHARGED SCA HEAVY DUTY COOLANT

GATES BLUE STRIPE COOLANT HOSES OR EQUIVALENT

CONSTANT TENSION HOSE CLAMPS FOR COOLANT HOSES

RADIATOR DRAIN VALVE

1350 ADAPTER FLANGE FOR FRONT PTO PROVISION

20

PHILLIPS-TEMRO 1000 WATT/115 VOLT BLOCK HEATER

4


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

BLACK PLASTIC ENGINE HEATER RECEPTACLE MOUNTED UNDER LH DOOR

ELECTRIC GRID AIR INTAKE WARMER

DELCO 12V 38MT HD STARTER WITH INTEGRATED MAGNETIC SWITCH

TransmissionALLISON 3000 RDS AUTOMATIC TRANSMISSION WITH PTO PROVISION

Transmission EquipmentALLISON VOCATIONAL PACKAGE 223 - AVAILABLE ON 3000/4000 PRODUCT FAMILIES WITH VOCATIONAL MODELS RDS, HS, MH AND TRV

ALLISON VOCATIONAL RATING FOR ON/OFF HIGHWAY APPLICATIONS AVAILABLE WITH ALL PRODUCT FAMILIES

PRIMARY MODE GEARS, LOWEST GEAR 1, START GEAR 1, HIGHEST GEAR 6, AVAILABLE FOR 3000/4000 PRODUCT FAMILIES ONLY

SECONDARY MODE GEARS, LOWEST GEAR 1, START GEAR 1, HIGHEST GEAR 6, AVAILABLE FOR 3000/4000 PRODUCT FAMILIES ONLY

PRIMARY SHIFT SCHEDULE RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE

SECONDARY SHIFT SCHEDULE RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE

PRIMARY SHIFT SPEED RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE

SECONDARY SHIFT SPEED RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED BY ENGINE AND VOCATIONAL USAGE

DYNAMIC SHIFT SENSING AND ACCELERATION RATE MANAGEMENT RECOMMENDED BY DTNA AND ALLISON, THIS DEFINED VOCATIONAL USAGE

DRIVER SWITCH INPUT - DEFAULT - NO SWITCHES

VEHICLE INTERFACE WIRING CONNECTOR WITHOUT BLUNT CUTS, AT BACK OF CAB

ELECTRONIC TRANSMISSION CUSTOMER ACCESS CONNECTOR FIREWALL MOUNTED


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

CUSTOMER INSTALLED CHELSEA 277 SERIES PTO

PTO MOUNTING, LH SIDE OF MAIN TRANSMISSION

MAGNETIC PLUGS, ENGINE DRAIN, TRANSMISSION DRAIN, AXLE(S) FILL AND DRAIN

ELECTRONIC CONTROL T-HANDLE SHIFT LEVER, DASH MOUNTED

TRANSMISSION PROGNOSTICS - ENABLED 2013

WATER TO OIL TRANSMISSION COOLER, IN RADIATOR END TANK

TRANSMISSION OIL CHECK AND FILL WITH ELECTRONIC OIL LEVEL CHECK

SYNTHETIC TRANSMISSION FLUID (TES-295 COMPLIANT)

Front Axle and EquipmentDETROIT DA-F-20.0-5 20,000# FL1 71.0 KPI/3.74 DROP SINGLE FRONT AXLE

210

MERITOR 16.5X6 Q+ CAST SPIDER CAM FRONT BRAKES, DOUBLE ANCHOR, FABRICATED SHOES

10

NON-ASBESTOS FRONT BRAKE LINING

CONMET CAST IRON FRONT BRAKE DRUMS

FRONT BRAKE DUST SHIELDS 5

SKF SCOTSEAL PLUS XL FRONT OIL SEALS

VENTED FRONT HUB CAPS WITH WINDOW, CENTER AND SIDE PLUGS - OIL

STANDARD SPINDLE NUTS FOR ALL AXLES

BENDIX VERSAJUST AUTOMATIC FRONT SLACK ADJUSTERS

STANDARD KING PIN BUSHINGS

TRW THP-60 POWER STEERING WITH RCH45 AUXILIARY GEAR

130

POWER STEERING PUMP

4 QUART POWER STEERING RESERVOIR 5

OIL/AIR POWER STEERING COOLER 5

ORGANIC SAE 80/90 FRONT AXLE LUBE

Front Suspension20,000# FLAT LEAF FRONT SUSPENSION 310

GRAPHITE BRONZE BUSHINGS WITH SEALS - FRONT SUSPENSION


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

FRONT SHOCK ABSORBERS

Rear Axle and EquipmentRS-26-185 26,000# T-SERIES SINGLE REAR AXLE

255

5.86 REAR AXLE RATIO

IRON REAR AXLE CARRIER WITH STANDARD AXLE HOUSING

MXL 17T MERITOR EXTENDED LUBE MAIN DRIVELINE WITH HALF ROUND YOKES

MERITOR 16.5X7 P CAM REAR BRAKES, DOUBLE ANCHOR, CAST SHOES

20

NON-ASBESTOS REAR BRAKE LINING

BRAKE CAMS AND CHAMBERS ON FORWARD SIDE OF DRIVE AXLE(S)

WEBB HEAVY WEIGHT CAST IRON REAR BRAKE DRUMS

80

REAR BRAKE DUST SHIELDS 5

SKF SCOTSEAL PLUS XL REAR OIL SEALS

HALDEX GOLDSEAL LONGSTROKE 1-DRIVE AXLE SPRING PARKING CHAMBERS

BENDIX VERSAJUST AUTOMATIC REAR SLACK ADJUSTERS

ORGANIC SAE 80/90 REAR AXLE LUBE

STANDARD REAR AXLE BREATHER(S)

Rear Suspension30,000# FLAT LEAF SPRING REAR SUSPENSION WITH HELPER AND RADIUS ROD

160

SPRING SUSPENSION - NO AXLE SPACERS

STANDARD AXLE SEATS IN AXLE CLAMP GROUP

FORE/AFT CONTROL RODS

Brake SystemWABCO 4S/4M ABS WITH TRACTION CONTROL

REINFORCED NYLON, FABRIC BRAID AND WIRE BRAID CHASSIS AIR LINES

FIBER BRAID PARKING BRAKE HOSE

STANDARD BRAKE SYSTEM VALVES

STANDARD AIR SYSTEM PRESSURE PROTECTION SYSTEM

STD U.S. FRONT BRAKE VALVE


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

RELAY VALVE WITH 5-8 PSI CRACK PRESSURE, NO REAR PROPORTIONING VALVE

BW AD-9 BRAKE LINE AIR DRYER WITH HEATER 20

AIR DRYER FRAME MOUNTED

ALUMINUM AIR BRAKE RESERVOIRS MOUNTED INSIDE RAILS

NO LOWER THAN 3"

CLEAR FRAME RAILS FROM BACK OF CAB TO FRONT REAR SUSPENSION BRACKET, BOTH RAILS OUTBOARD

BW DV-2 AUTO DRAIN VALVE WITH HEATER TO WET TANK; DRAIN VALVE CABLES ON ALL OTHER TANKS

Trailer ConnectionsAIR CONNECTIONS TO END OF FRAME WITH GLAD HANDS FOR TRUCK AND DUST COVERS

48" ADDITIONAL LINE AT END OF FRAME

PRIMARY CONNECTOR/RECEPTACLE WIRED FOR COMBINATION STOP/TURN, CENTER PIN POWERED THROUGH IGNITION WITH STOP SIGNAL PREWIRE PACKAGE

SAE J560 7-WAY PRIMARY CABLE RECEPTACLE MOUNTED END OF FRAME WITH 48" ADDITIONAL CABLE AT REAR CROSSMEMBER

UPGRADED CHASSIS MULTIPLEXING UNIT

Wheelbase & Frame4275MM (168 INCH) WHEELBASE

7/16X3-9/16X11-1/8 INCH STEEL FRAME (11.11MMX282.6MM/0.437X11.13 INCH) 120KSI

170 150

BODY COMPANY INSTALLED ADDITIONAL FRONT FRAME REINFORCEMENT FOR SNOW PLOW

1775MM (70 INCH) REAR FRAME OVERHANG

FRAME OVERHANG RANGE: 61 INCH TO 70 INCH

24 INCH INTEGRAL FRONT FRAME EXTENSION 140 -20

CALC'D BACK OF CAB TO REAR SUSP C/L (CA) : 102.45 in

CALCULATED EFFECTIVE BACK OF CAB TO REAR SUSPENSION C/L (CA) : 99.45 in

CALC'D FRAME LENGTH - OVERALL : 303.16

CALC'D SPACE AVAILABLE FOR DECKPLATE : 102.45 in


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

CALCULATED FRAME SPACE LH SIDE : 62.69 in

CALCULATED FRAME SPACE RH SIDE : 82.36 in

SQUARE END OF FRAME

FRONT CLOSING CROSSMEMBER

LIGHTWEIGHT HEAVY DUTY ALUMINUM ENGINE CROSSMEMBER

-12

STANDARD MIDSHIP #1 CROSSMEMBER(S)

STANDARD REARMOST CROSSMEMBER

STANDARD SUSPENSION CROSSMEMBER

Chassis EquipmentOMIT FRONT BUMPER, CUSTOMER INSTALLED SPECIAL BUMPER, DOES NOT COMPLY WITH FMCSR 393.203

-110

GRADE 8 THREADED HEX HEADED FRAME FASTENERS

Fuel Tanks70 GALLON/264 LITER ALUMINUM FUEL TANK - LH

5

25 INCH DIAMETER FUEL TANK(S)

PLAIN ALUMINUM/PAINTED STEEL FUEL/HYDRAULIC TANK(S) WITH POLISHED STAINLESS STEEL BANDS

FUEL TANK(S) FORWARD

PLAIN STEP FINISH

FUEL TANK CAP(S)

ALLIANCE FUEL FILTER/WATER SEPARATOR WITH HEATED BOWL

EQUIFLO INBOARD FUEL SYSTEM

HIGH TEMPERATURE REINFORCED NYLON FUEL LINE

TiresMICHELIN XZU-S2 315/80R22.5 20 PLY RADIAL FRONT TIRES

100

MICHELIN XDS 12R22.5 16 PLY RADIAL REAR TIRES

156

HubsCONMET PRESET PLUS IRON FRONT HUBS

CONMET PRESET PLUS IRON REAR HUBS

Wheels


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

MAXION WHEELS 10041 22.5X9.00 10-HUB PILOT 5.25 INSET 5-HAND STEEL DISC FRONT WHEELS

66

MAXION WHEELS 90260 22.5X8.25 10-HUB PILOT 2-HAND HD STEEL DISC REAR WHEELS

80

Cab Exterior108 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CAB

AIR CAB MOUNTS

NONREMOVABLE BUGSCREEN MOUNTED BEHIND GRILLE

SHORT FENDER WITH MUDFLAP

BOLT-ON MOLDED FLEXIBLE FENDER EXTENSIONS

10

LH AND RH EXTERIOR GRAB HANDLES WITH SINGLE RUBBER INSERT

STATIONARY BLACK GRILLE

BLACK HOOD MOUNTED AIR INTAKE GRILLE

FIBERGLASS HOOD

CAB FLOOR, TOE BOARD AND FIREWALL HEAT SHIELD

5

SINGLE 14 INCH ROUND HADLEY AIR HORN UNDER LH DECK

SINGLE ELECTRIC HORN

SINGLE HORN SHIELD

ALL UNIT(S) KEYED ALIKE WITH CUSTOMER SPECIFIED KEY NUMBER FT1010

REAR LICENSE PLATE MOUNT END OF FRAME

HALOGEN COMPOSITE HEADLAMPS WITH BLACK BEZELS

LED AERODYNAMIC MARKER LIGHTS

INTEGRAL STOP/TAIL/BACKUP LIGHTS

STANDARD FRONT TURN SIGNAL LAMPS

DUAL WEST COAST BRIGHT FINISH HEATED MIRRORS WITH LH AND RH REMOTE

DOOR MOUNTED MIRRORS

102 INCH EQUIPMENT WIDTH

LH AND RH 8 INCH BRIGHT FINISH CONVEX MIRRORS MOUNTED UNDER PRIMARY MIRRORS

STANDARD SIDE/REAR REFLECTORS

63X14 INCH TINTED REAR WINDOW


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

TINTED DOOR GLASS LH AND RH WITH TINTED OPERATING WING WINDOWS

RH AND LH ELECTRIC POWERED WINDOWS, PASSENGER SWITCHES ON DOOR(S)

8

1-PIECE TINTED CURVED BONDED WINDSHIELD WITH HEATED WIPER BLADE PARK AREAS

8 LITER WINDSHIELD WASHER RESERVOIR, CAB MOUNTED, WITHOUT FLUID LEVEL INDICATOR

Cab InteriorOPAL GRAY VINYL INTERIOR

MOLDED PLASTIC DOOR PANEL

MOLDED PLASTIC DOOR PANEL

BLACK MATS WITH SINGLE INSULATION

DASH MOUNTED ASH TRAY(S) WITHOUT LIGHTER

IN DASH STORAGE BIN

CENTER STORAGE CONSOLE MOUNTED ON BACKWALL

20

LH DOOR MAP POCKET

(2) CUP HOLDERS LH AND RH DASH

GRAY/CHARCOAL FLAT DASH

SMART SWITCH EXPANSION MODULE

HEATER, DEFROSTER AND AIR CONDITIONER

STANDARD HVAC DUCTING WITH SNOW SHIELD FOR FRESH AIR INTAKE

MAIN HVAC CONTROLS WITH RECIRCULATION SWITCH

STANDARD HEATER PLUMBING

DENSO HEAVY DUTY AIR CONDITIONER COMPRESSOR

BINARY CONTROL, R-134A

PREMIUM INSULATION

SOLID-STATE CIRCUIT PROTECTION AND FUSES

12V NEGATIVE GROUND ELECTRICAL SYSTEM

DOME DOOR ACTIVATED LH AND RH, DUAL READING LIGHTS, FORWARD CAB ROOF

LH AND RH ELECTRIC DOOR LOCKS

(1) 12 VOLT POWER SUPPLY IN DASH


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

BASIC HIGH BACK AIR SUSPENSION DRIVER SEAT WITH MECHANICAL LUMBAR AND INTEGRATED CUSHION EXTENSION

30

BASIC HIGH BACK NON SUSPENSION PASSENGER SEAT

INBOARD DRIVER SEAT ARMREST, NO PASSENGER SEAT ARMREST

LH AND RH INTEGRAL DOOR PANEL ARMRESTS

VINYL WITH VINYL INSERT DRIVER SEAT

VINYL WITH VINYL INSERT PASSENGER SEAT

3 POINT FIXED D-RING RETRACTOR DRIVER AND PASSENGER SEAT BELTS

ADJUSTABLE TILT AND TELESCOPING STEERING COLUMN

10

4-SPOKE 18 INCH (450MM) STEERING WHEEL

DRIVER AND PASSENGER INTERIOR SUN VISORS

Instruments & ControlsGRAY DRIVER INSTRUMENT PANEL

GRAY CENTER INSTRUMENT PANEL

BLACK GAUGE BEZELS

LOW AIR PRESSURE INDICATOR LIGHT AND AUDIBLE ALARM

2 INCH PRIMARY AND SECONDARY AIR PRESSURE GAUGES

DASH MOUNTED AIR RESTRICTION INDICATOR WITH GRADUATIONS

ELECTRONIC CRUISE CONTROL WITH SWITCHES IN LH SWITCH PANEL

KEY OPERATED IGNITION SWITCH AND INTEGRAL START POSITION; 4 POSITION OFF/RUN/START/ACCESSORY

ICU3S, 132X48 DISPLAY WITH DIAGNOSTICS, 28 LED WARNING LAMPS AND DATA LINKED

HEAVY DUTY ONBOARD DIAGNOSTICS INTERFACE CONNECTOR LOCATED BELOW LH DASH

2 INCH ELECTRIC FUEL GAUGE

PROGRAMMABLE RPM CONTROL - ELECTRONIC ENGINE

ELECTRICAL ENGINE COOLANT TEMPERATURE GAUGE


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

2 INCH TRANSMISSION OIL TEMPERATURE GAUGE

ENGINE AND TRIP HOUR METERS INTEGRAL WITHIN DRIVER DISPLAY

CUSTOMER FURNISHED AND INSTALLED PTO CONTROLS

ELECTRIC ENGINE OIL PRESSURE GAUGE

OVERHEAD INSTRUMENT PANEL

SMARTPLEX HUB MODULE WITH OVERHEAD SWITCH MOUNTING, CENTER CONSOLE (12 SWITCH SLOTS, NO CB)

44

AM/FM/WB RADIO WITH BLUETOOTH AND MICROPHONE, FRONT USB PORT, FRONT AND REAR AUXILIARY INPUTS AND J1939

10

DASH MOUNTED RADIO

(2) RADIO SPEAKERS IN CAB

AM/FM ANTENNA MOUNTED ON FORWARD LH ROOF

2

POWER AND GROUND STUDS IN/UNDER DASH

SINGLE FIBERGLASS LH MIRROR MOUNTED CB ANTENNA WITH BRACKET AND LEAD

ELECTRONIC MPH SPEEDOMETER WITH SECONDARY KPH SCALE, WITHOUT ODOMETER

STANDARD VEHICLE SPEED SENSOR WITH ADDITIONAL SIGNAL FOR CUSTOMER USE LOCATED BETWEEN DRIVER AND PASSENGER SEATS

ELECTRONIC 3000 RPM TACHOMETER

IGNITION SWITCH CONTROLLED ENGINE STOP

6 ON/OFF LATCHING SMARTPLEX SWITCHES

BW TRACTOR PROTECTION VALVE

TRAILER HAND CONTROL BRAKE VALVE 2

DIGITAL VOLTAGE DISPLAY INTEGRAL WITH DRIVER DISPLAY

SINGLE ELECTRIC WINDSHIELD WIPER MOTOR WITH DELAY AND ARCTIC TYPE BLADES

MARKER LIGHT SWITCH INTEGRAL WITH HEADLIGHT SWITCH AND SINGLE CONNECTOR AND SWITCH FOR CUSTOMER FURNISHED SNOW PLOW LIGHTS, LOW BEAMS OFF WITH HIGH BEAMS

TWO VALVE PARKING BRAKE SYSTEM WITH WARNING INDICATOR


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Description

Weight Front

Weight Rear

SELF CANCELING TURN SIGNAL SWITCH WITH DIMMER, WASHER/WIPER AND HAZARD IN HANDLE

INTEGRAL ELECTRONIC TURN SIGNAL FLASHER WITH HAZARD LAMPS OVERRIDING STOP LAMPS

DesignPAINT: ONE SOLID COLOR

ColorCAB COLOR A: L0006EB WHITE ELITE BC

BLACK, HIGH SOLIDS POLYURETHANE CHASSIS PAINT

NO FUEL TANK CABINET PAINT

POWDER WHITE (N0006EA) FRONT WHEELS/RIMS (PKWHT21, TKWHT21, W, TW)

POWDER WHITE (N0006EA) REAR WHEELS/RIMS (PKWHT21, TKWHT21, W, TW)

STANDARD E COAT/UNDERCOATING

Certification / ComplianceU.S. FMVSS CERTIFICATION, EXCEPT SALES CABS AND GLIDER KITS

Secondary Factory OptionsCORPORATE PDI CENTER OPTION INSTALLATION/MODIFICATION ONLY

T O T A L V E H I C L E S U M M A R Y

Weight SummaryWeight

FrontWeight

RearTotal

Weight

Factory Weight+ 8063 lbs 4659 lbs 12722 lbs

Total Weight+ 8063 lbs 4659 lbs 12722 lbs


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

(+) Weights shown are estimates only.If weight is critical, contact Customer Application Engineering.


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

D I M E N S I O N S

VEHICLE SPECIFICATIONS SUMMARY - DIMENSIONS

Wheelbase (545)............................................................................................................................4275MM (168 INCH) WHEELBASERear Frame Overhang (552)......................................................................................1775MM (70 INCH) REAR FRAME OVERHANGFifth Wheel (578)......................................................................................................................................................NO FIFTH WHEEL Mounting Location (577).................................................................................................................NO FIFTH WHEEL LOCATION Maximum Forward Position (in)......................................................................................................................................................0 Maximum Rearward Position (in)...................................................................................................................................................0 Amount of Slide Travel (in).............................................................................................................................................................0 Slide Increment (in)........................................................................................................................................................................0 Desired Slide Position (in)...........................................................................................................................................................0.0Cab Size (829).................................................................................108 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CABSleeper (682).................................................................................................................................NO SLEEPER BOX/SLEEPERCABExhaust System (016)........RH OUTBOARD UNDER STEP MOUNTED HORIZONTAL AFTERTREATMENT SYSTEM ASSEMBLY WITH RH B-PILLAR MOUNTED VERTICAL TAILPIPE

TABLE SUMMARY - DIMENSIONS


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

Performance calculations are estimates only. If performance calculations are critical, please contact Customer Application Engineering.


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

G V W R

VEHICLE SPECIFICATIONS SUMMARY - GVWR

Cab Size (829).................................................................................108 INCH BBC FLAT ROOF ALUMINUM CONVENTIONAL CABExpected Front Axle(s) Load (lbs).............................................................................................................................................20000.0Expected Pusher Axle(s) Load (lbs)..................................................................................................................................................0.0Expected Rear Axle(s) Load (lbs)..............................................................................................................................................26000.0Expected Tag Axle(s) Load (lbs).......................................................................................................................................................0.0Expected GVW (lbs).....................................................................................................................................................................46000Expected GCW (lbs)..................................................................................................................................................................80000.0Front Axle (400).....................................................DETROIT DA-F-20.0-5 20,000# FL1 71.0 KPI/3.74 DROP SINGLE FRONT AXLEFront Suspension (620)....................................................................................................20,000# FLAT LEAF FRONT SUSPENSIONFront Hubs (418).........................................................................................................CONMET PRESET PLUS IRON FRONT HUBSFront Disc Wheels (502). MAXION WHEELS 10041 22.5X9.00 10-HUB PILOT 5.25 INSET 5-HAND STEEL DISC FRONT WHEELSFront Tires (093).............................................................................MICHELIN XZU-S2 315/80R22.5 20 PLY RADIAL FRONT TIRESFront Brakes (402)..........MERITOR 16.5X6 Q+ CAST SPIDER CAM FRONT BRAKES, DOUBLE ANCHOR, FABRICATED SHOESSteering Gear (536)...................................................................TRW THP-60 POWER STEERING WITH RCH45 AUXILIARY GEARRear Axle (420)...................................................................................................RS-26-185 26,000# T-SERIES SINGLE REAR AXLERear Suspension (622)...............................30,000# FLAT LEAF SPRING REAR SUSPENSION WITH HELPER AND RADIUS RODRear Hubs (450)............................................................................................................CONMET PRESET PLUS IRON REAR HUBSRear Disc Wheels (505).................MAXION WHEELS 90260 22.5X8.25 10-HUB PILOT 2-HAND HD STEEL DISC REAR WHEELSRear Tires (094)............................................................................................MICHELIN XDS 12R22.5 16 PLY RADIAL REAR TIRESRear Brakes (423).....................................................MERITOR 16.5X7 P CAM REAR BRAKES, DOUBLE ANCHOR, CAST SHOESPusher / Tag Axle (443)...........................................................................................................................NO PUSHER OR TAG AXLEPusher / Tag Suspension (626)..................................................................................................NO PUSHER OR TAG SUSPENSIONPusher / Tag Hubs (449).........................................................................................................................NO PUSHER OR TAG HUBSPusher/Tag Disc Wheels (509)........................................................................................................NO PUSHER/TAG DISC WHEELSPusher / Tag Tires (095)...............................................................................................................................NO PUSHER/TAG TIRESPusher / Tag Brakes (456)........................................................................................................................NO PUSHER/TAG BRAKES

TABLE SUMMARY - GVWR


05/23/2016 7:28 AM

of 20





Phone: 216-267-4800



05/23/2016 7:28 AM

of 20





Phone: 216-267-4800

F R A M E R B M

VEHICLE SPECIFICATIONS SUMMARY - FRAME RBM

Wheelbase (545)............................................................................................................................4275MM (168 INCH) WHEELBASEFrame Rails (546)........................7/16X3-9/16X11-1/8 INCH STEEL FRAME (11.11MMX282.6MM/0.437X11.13 INCH) 120KSI(546) Yield Strength (psi)...............................................................................................................................................................120000 Section Modulus (per rail) (cu in)...............................................................................................................................................21.6 RBM (per rail) (lbf-in)..........................................................................................................................................................2590000Inner Frame Reinforcement (547)...........................................................................................NO INNER FRAME REINFORCEMENTOuter Frame Reinforcement (548). BODY COMPANY INSTALLED ADDITIONAL FRONT FRAME REINFORCEMENT FOR SNOW PLOW

TABLE SUMMARY - FRAME RBM



05/23/2016 7:28 AM

of 20

specification proposal · web viewclear frame rails from back of cab to front rear suspension...

Documents