Electronic Advertising Contract AADD Bids open Thursday, October 20, 2011 Dated September 12, 2011 IH

12

STATE OF CALIFORNIA DEPARTMENT OF TRANSPORTATION

NOTICE TO BIDDERS AND

SPECIAL PROVISIONS FOR CONSTRUCTION ON STATE HIGHWAY IN ORANGE COUNTY IN LAKE FOREST, LAGUNA HILLS, AND MISSION VIEJO FROM 0.4 MILE SOUTH OF ALICIA PARKWAY

OVERCROSSING TO 0.3 MILE NORTH OF ALICIA PARKWAY OVERCROSSING

In District 12 On Route 5

Under

Bid book dated September 12, 2011 Standard Specifications dated 2006

Project Plans approved May 23, 2011 Standard Plans dated 2006

Identified by

Contract No. 12-0K6204

12-Ora-5-17.1/17.8

Project ID 1200000362

Federal-Aid ProjectIM-005-2(959)89E

*******************************************************************************************

SPECIAL NOTICES

*******************************************************************************************

Refer to Section 8-1.07, "Liquidated Damages," of the Amendments to the Standard Specifications for your project-specific liquidated damages based on your total bid.

The Department is providing an electronic Information Handout for this project. Refer to Section 2-1.03B,

"Supplemental Project Information," in the Amendments to the Standard Specifications for the location of this information.

The Department is allowing contractors to submit electronic payroll records to the District Labor Compliance

Office. Refer to section titled "Electronic Submission of Payroll Records" under Section 5, "General," of these special provisions.

Contract No. 12-0K6204

i

TABLE OF CONTENTS

NOTICE TO BIDDERS ....................................................................................................................................................... 1COPY OF BID ITEM LIST .................................................................................................................................................. 3SPECIAL PROVISIONS ...................................................................................................................................................... 7SECTION 1. (BLANK) ....................................................................................................................................................... 7SECTION 2. BIDDING ....................................................................................................................................................... 7

2-1.01 TIE BID RESOLUTION .................................................................................................................................... 72-1.02 DISADVANTAGED BUSINESS ENTERPRISES ........................................................................................... 72-1.03 OPT OUT OF PAYMENT ADJUSTMENTS FOR PRICE INDEX FLUCTUATIONS ................................... 8

SECTION 3. CONTRACT AWARD AND EXECUTION ................................................................................................. 93-1.01 SMALL BUSINESS PARTICIPATION REPORT ........................................................................................... 93-1.02 CALTRANS BIDDER - DBE INFORMATION FORM ................................................................................... 9

SECTION 4. BEGINNING OF WORK, TIME OF COMPLETION, AND LIQUIDATED DAMAGES ......................... 9SECTION 5. GENERAL ..................................................................................................................................................... 9

5-1.01 EMISSIONS REDUCTION .............................................................................................................................. 95-1.02 PERFORMANCE OF DBES ............................................................................................................................. 95-1.03 PERFORMANCE OF UDBES ......................................................................................................................... 105-1.04 PAYMENT ADJUSTMENTS FOR PRICE INDEX FLUCTUATIONS ........................................................ 105-1.05 SURFACE MINING AND RECLAMATION ACT ........................................................................................ 135-1.06 ELECTRONIC SUBMISSION OF PAYROLL RECORDS............................................................................ 145-1.07 AREAS FOR CONTRACTOR'S USE ............................................................................................................ 145-1.08 PAYMENTS ................................................................................................................................................... 155-1.09 SUPPLEMENTAL PROJECT INFORMATION ............................................................................................ 155-1.10 RELATIONS WITH CALIFORNIA REGIONAL WATER QUALITY CONTROL BOARD ...................... 15

SECTION 6. (BLANK) ..................................................................................................................................................... 15SECTION 7. (BLANK) ..................................................................................................................................................... 15SECTION 8. MATERIALS ............................................................................................................................................... 15SECTION 8-1. MISCELLANEOUS ................................................................................................................................. 15

8-1.01 PREQUALIFIED AND TESTED SIGNING AND DELINEATION MATERIALS ...................................... 158-1.02 STATE-FURNISHED MATERIALS .............................................................................................................. 218-1.03 SLAG AGGREGATE ..................................................................................................................................... 21

SECTION 8-2. CONCRETE ............................................................................................................................................. 238-2.01 PORTLAND CEMENT CONCRETE ............................................................................................................. 23

SECTION 8-3. WELDING ................................................................................................................................................ 248-3.01 WELDING ....................................................................................................................................................... 24

WELDING QUALITY CONTROL ..................................................................................................................... 25WELDING FOR OVERHEAD SIGN AND POLE STRUCTURES ................................................................... 28

SECTION 9. (BLANK) ..................................................................................................................................................... 29SECTION 10. CONSTRUCTION DETAILS ................................................................................................................... 29SECTION 10-1. GENERAL .............................................................................................................................................. 29

10-1.00 CONSTRUCTION PROJECT INFORMATION SIGNS .............................................................................. 2910-1.01 ORDER OF WORK ...................................................................................................................................... 3010-1.02 WATER POLLUTION CONTROL .............................................................................................................. 3110-1.03 CONSTRUCTION SITE MANAGEMENT .................................................................................................. 3610-1.04 TEMPORARY CONCRETE WASHOUT (PORTABLE) ............................................................................ 4510-1.05 COOPERATION ........................................................................................................................................... 4710-1.06 PROGRESS SCHEDULE (CRITICAL PATH METHOD) ........................................................................... 4710-1.07 CONSTRUCTION AREA TRAFFIC CONTROL DEVICES ...................................................................... 4910-1.08 CONSTRUCTION AREA SIGNS ................................................................................................................ 5010-1.09 MAINTAINING TRAFFIC ........................................................................................................................... 5110-1.10 CLOSURE REQUIREMENTS AND CONDITIONS ................................................................................... 5510-1.11 IMPACT ATTENUATOR VEHICLE ........................................................................................................... 5710-1.12 TRAFFIC CONTROL SYSTEM FOR LANE CLOSURE ............................................................................ 5810-1.13 TEMPORARY PAVEMENT DELINEATION ............................................................................................ 5810-1.14 PORTABLE CHANGEABLE MESSAGE SIGNS ....................................................................................... 6010-1.15 CHANNELIZER ........................................................................................................................................... 61

Contract No. 12-0K6204

ii

10-1.16 TEMPORARY TRA