«the weak point in the sterilization cycle»

19
«THE WEAK POINT IN THE STERILIZATION CYCLE» HYGIENE AND SAFETY OF THE DENTAL UNIT WATERLINES WATER TREATMENT AND DISINFECTION IN A DENTAL CLINIC

Upload: others

Post on 13-Nov-2021

1 views

Category:

Documents


0 download

TRANSCRIPT

Page 1: «THE WEAK POINT IN THE STERILIZATION CYCLE»

«THE WEAK POINT IN THE STERILIZATION CYCLE»

HYGIENE AND SAFETY OF THE DENTAL UNIT WATERLINES

WATER TREATMENT AND DISINFECTION IN A DENTAL CLINIC

Page 2: «THE WEAK POINT IN THE STERILIZATION CYCLE»

IN THE DENTAL CLINIC, THE RISK OF

CROSS INFECTIONS DISEASESCAN GREATLY INCREASE FOR PROBLEMS RESULTING FROM WATER

Page 3: «THE WEAK POINT IN THE STERILIZATION CYCLE»

THE DOUBLE PROBLEM

A) BIOLOGIC BIOFILM AEROSOL CROSS INFECTIONS

B) TECHNICAL LIMESTONE RESIDUES OBSTRUCTION OF PIPES AND SOLENOID VALVES

Page 4: «THE WEAK POINT IN THE STERILIZATION CYCLE»

WATER AND DENTAL UNIT

The bacterial growth leads to the formation of biofilm.

During the surgical practice the patients, the assistant and the dentist come in direct contact, or through aerosol, whithmany infectious and pathogens agents, both viral and bacterial.

in the water supply networks of dental clinics it’s possible to find : legionella, pseudomonas, tuberculosis bacteria, AIDS virus and hepatitis C, because in the water circuit get in also saliva and blood of the patients, which undergo treatments.

Page 5: «THE WEAK POINT IN THE STERILIZATION CYCLE»

WHAT HAVE WE DONE UNTIL NOWADAYS ?

• softeners : increase the bacterial load

• several disinfection systems: require a lot of attention and time by the operators

• disinfectants: don’t contrast and don’t removethe biofilm (calbenium, glutaraldehyde, hydrogen peroxide, peracetic acid, etc…)

• backwater valves: unsatisfactory results

• incoming water filters don’t contrast the backflow.

IN THESE WAYS THE RISK OF CROSS INFECTIONS ARISING FROM BIOFILM HAS NOT BEEN REDUCED

Page 6: «THE WEAK POINT IN THE STERILIZATION CYCLE»

WHAT COULD YOU DO THEN TO REDUCETHE RISK RESULTING FROM CROSS INFECTIONS ?

• You should use pure water,

disinfected continuously!

• To do so you must use water filtered

with the reverse osmosis system and

continuously disinfected with

chlorine dioxide (ClO2) because:

(water with high solvency power and free of salts)

+

(the most effective disinfectant scientifically recognized, viricide, germicide, able to penetrate the biofilm)

GUARANTEEThe most satisfactory and economic result

for water treatment and disinfection in dental clinics

Page 7: «THE WEAK POINT IN THE STERILIZATION CYCLE»

IT’S THE SAFEST AND THE MOST WIDESPREAD WATER FILTRATION

SYSTEM IN THE WORLD.

By applying a pressure on the surface of a concentrated solution, in our case the water of the water mains, and filtrating itwith a semipermeable membrane (the osmotic membrane) we achieveuncontamined water, without viruses, limestone and all the undesiredsubstances.

REVERSE OSMOSIS

Page 8: «THE WEAK POINT IN THE STERILIZATION CYCLE»

OUR SOLUTION: OSMO STERILCombination REVERSE OSMOSIS + CHLORINE DIOXIDE

REVERSE OSMOSISBEING THE SAFEST WATER FILTRATION SYSTEM, IT’S THE MOST WIDESPREAD IN THE WORLD BECAUSE IT’S USED IN ALL THE SITUATIONS WHERE WE NEED THE CERTAINTY OF HAVING CLEAN WATER FREE FROM VIRUS, BACTERIAS AND LIMESTONE.

CHLORINE DIOXIDEIT‘S UNIVERSALLY RECOGNIZED AS THE BEST BIOCIDE THAT SCIENCE HAS MADE AVAILABLE TO MAN. USED IN «CONTINUOUS» IT GUARANTEES A SAFE VIRUCIDAL, ANTIBACTERIAL ACTION AND AGGRESSIVE AGAINST BIOFILM.

Page 9: «THE WEAK POINT IN THE STERILIZATION CYCLE»

LET’S TALK ABOUT AEROSOL ANDCOVID-19

Clarified that COVID-19 infects by inhalation, the greatest dangerfor the dentist and assistants isthe spray of the turbine whichcan generate a contaminatedaerosol.

Installing OSMO STERIL, the aerosol which will be producedwill be surely less dangeroussince it’s generated from water addictioned with chlorinedioxide.

The guidelines of our ISS and of the World Health Organization indicate Chlorine Dioxide as the most effectivebiocide available, against viruses and also COVID-19.

We can therefore state that the unitsfed with OSMO STERIL are able to limit the spreading risk of COVID-19 in the air and reduce its danger to doctors, assistants and patients.

Page 10: «THE WEAK POINT IN THE STERILIZATION CYCLE»

WHY OSMO STERIL SHOULD BE INSTALLED?

To definitively, effectively and safely resolve the viral and bacterial proliferation that occurs in the dental unit and prevent the formation of the biofilm.

To eliminate limestone, main cause of technicalanomalies.

OSMO STERIL is a centralized device for water treatment and disinfection in dental clinics which feeds:

• PLURI: up to 10 dental units + 3 autoclaves + thetap of the sterilization room

• TRIO: up to 3 dental units + 2 autoclaves + thetap of the sterilization room

•The single dental unit in the MONO version

In a completely automatic way, without the intervention of the assistants.

Page 11: «THE WEAK POINT IN THE STERILIZATION CYCLE»

THE DENTAL UNIT WATERLINES

WITHOUT OSMO STERIL WITH OSMO STERIL

Page 12: «THE WEAK POINT IN THE STERILIZATION CYCLE»

THE BENEFITS OF OSMO STERIL

• It creates a barrier at the entrance of the dental unit which prevents water to bring bacterial load from the outside.

• It supplies the hydraulic network with water without any inorganiccomponents and bacteria so itprevents the formation of molecularbiofilm (excellent substrate for microorganisms growth).

• It prevents the breakdown of the dental units, the pipes and the solenoid valves, due to limestone.

• It produces continuously disinfectedwater that systematically kills bacteriaand viruses which can enter the water network through backflow of the dentalunit and contaminate the pipes in the whole clinic as well as those of the samebuilding where the dental clinic is located

• It favors faster healing of patientsundergoing dental surgery

• It protects professionals from trouble and legal costs for diseases caused from cross infections.

FOLLOWS

Page 13: «THE WEAK POINT IN THE STERILIZATION CYCLE»

THE BENEFITS OF OSMO STERILFOLLOWS

• It does not require the operators’ intervention since provides all the operations automatically, exceptchanging the CHLORINE DIOXIDE bottle which takes more or less 2 minsand must be done every 30 days.

• It allows to fill the ultrasound tanks and gives the possibility to rinse the instruments with very pure water before packaging.

• It guarantees to get perfectly polishedinstruments without any limestonedeposit and it thus ensures a perfectsterilization.

• It produces demineralized water and automatically feeds the autoclaves for sterilization.

• It eliminates the problem of the purchase and storage of distilled water for the autoclave or its production with often expensive systems.

Page 14: «THE WEAK POINT IN THE STERILIZATION CYCLE»

THE QUALITY AND SAFETY OF OSMO STERIL WATER

ENSURE

TO SAVE TIME AND MONEYGAINING IN HEALTH AND ECOLOGY

• It makes disinfection "operator free"” …………………….. time saver!

• It uses the best disinfectant at the best price ………...….. savings on products!

• It reduces the working times of assistants …………….. saving on costs for staff !

• It prevents the equipments to stop due to technicalproblems arising from water………………………………… cutting costs for technical assistance!

• It is ecological …………………………………………………………….. water pure & safe onsite!

WITH OSMO STERIL

HEALTH, SAFETY AND SAVING MONEY ARE AT 1° ST PLACE

Page 15: «THE WEAK POINT IN THE STERILIZATION CYCLE»

OSMO STERIL MONOThe plug and play solution to sanitize all pre-installed dental units

• It can be easily connected to allexisting and pre-installed dentalunits because it does not requirededicated plant engineering.

• It is aimed at small and medium-sized studios.

• Competitive in terms of costswith the main integrateddisinfection systems.

Page 16: «THE WEAK POINT IN THE STERILIZATION CYCLE»

OSMO STERIL TRIO AND PLURIThe ideal solution for newly designed clinics or under renovation clinics

• At practically zero cost, during the executionof the hydraulic system of the study, weproceed to the construction of the dedicatedwater network for OSMO STERIL and thenfeed the units, the autoclaves and the sink of the sterilization room.

• For pre-existing clinics it will be necessary to evaluate together with the plant engineer the possibility of adapting the water network to OSMO STERIL needs; opportunity achievablein most cases.

Page 17: «THE WEAK POINT IN THE STERILIZATION CYCLE»

EXAMPLE OF A WATER SYSTEM FOR A DENTAL

SURGERY

Page 18: «THE WEAK POINT IN THE STERILIZATION CYCLE»

EXAMPLE OF SYSTEM INSTALLED

Page 19: «THE WEAK POINT IN THE STERILIZATION CYCLE»

THANK YOU

FOR YOUR KIND ATTENTION