PEDICURE SPAOWNER’S MANUAL

Version 1.5Aug 8, 2019

Information to the User Safety Information Receiving and Inspection Specifications Identifying parts for VIP Model Important Installation Information Installation Specifications

Types of Installation Gravity Drain Installation Drain Pump Installation

Air Vent (OPTIONAL) BackFlow Valve Specifications Operation Instructions

View of the VIP Pedi-Spa Chair Spa Basin Operation / Cleaning Instructions After Each Customer and Every Night Massage Instructions Massage Chair Remote Control Operation Manual Operation Special Function Limited Warranty

3

4

5

5

6

7

7

8

8

8

8

9

9

10

11

12

12

12

12

12

13

INDEX

Please take a moment to read this entire User Manual before installation and use.

!! SAVE THESE INSTRUCTIONS !!

Information to the User

The information in this manual can be subject to change without notification and should not be construed as a commitment by CONTÉGO assuming no responsibilities for any errors that may appear in this document. This manual is believed to be complete and accurate at the time of publication. In no event shall CONTÉGO be liable for incidental or consequential damages inconnection with, or arising from the use of this manual.

© 2012 CONTÉGO Spa Designs Inc. All Rights reserved.

This book, or any part thereof, may not be reproduced in any form without the express written permission of the publisher.

12856 Brookhurst St, Garden Grove, CA 92840 USA

Phone: 714-895-8865

E-mail: support@contegospa.com

Website: www.contegospa.com

SUPPORT / CONTACTCustomer Support is available by phone, fax, mail or email at:

3

The following precautionary instructions are included to ensure the safe operation of your VIP Pedicure Spa. Before installing or using the VIP Pedicure Spa, read throughthe following guidelines in this manual. Please always keep this book nearby for all operatorsto ensure the instructions are followed. In case of a missing or damaged book, please contact usto get a replacement. Failure to comply with the instructions in this manual may posedangerous risk to the user and will void manufacturer’s warranty. It is important to follow the operating and cleaning procedures provided on page 11 to ensure the spa issanitized for each use. CONTÉGO is not liable for any infections or disease that mayresult from improper following of both operating and/or cleaning instructions.

In Emergency, immediately TURN OFF power and unplug..

Safety InformationImportant Safeguards

GROUNDING IS REQUIRED!The unit should be installed by a qualified service representative and grounded. All outlets connected to the pedicure spas must

include a GFCI device (Ground Fault Circuit Interrupter). This will reduce the rick of electric shock.

CAUTION!Risk of Electric Shock. Disconnect electric power before servicing.

WARNING!Do NOT permit children to use the unit unless an adult closely

supervises them at all times.

WARNING!To avoid danger of suffocation, please keep the Jet-Liner AWAY

from babies and children. The thin film may cling to nose and mouth and prevent breathing.

WARNING!Excessive water temperature is dangerous and should be checked

BEFORE use. Maximum Temperature of water should NEVER exceed 100Ü)�

WARNING!NEVER bring and/or operate any electrical devices in or near the

Pedicure Spa.

WARNING!Do NOT step or stand in the bowl basin. To avoid injury, ALWAYS

enter and exit the pedicure Spa slowly and carefully.

WARNING!Maximum Load in the spa chair is 250lbs (114kg).

STOPSTOP

! !

4

SHIPP ING DIMENSIONS42” Length X 56” Width X 60” Height (1 Pa llet)107 cm. Length X 142 cm. Width X 152 cm. Height

SHIPP ING WEIGHT330 lb. (pounds)

TUB CAPACITY4 .5 US G a llons (17 Liters)

SWITCHOn/ O ff Air Activa ted

JET SYSTEM100% Disposable C O NTÉG O Jet-Liner

POWER SOURCE120 VAC, 60 Hz, 3 AMP

PLUMBINGHot / Cold Wa ter: 1 / 2” FIP FittingsDra in: 1” PVC Slip Ma le FittingO ptiona l Dra in Pump: 3 / 4” PVC Slip Fema le Fitting

AIR VENT SYSTEM2” Diameter Air Hose ( O PTIO NAL)

SPECIFICATIONSPLEASE TAKE NOTE!

Thoroughly inspect each shipment immdiately upon arrival. It is important that you notify the driver and insist on a notation of the damages. Make this notation directly on the freight company’s waybill or bill of lading. Failure to

note the damage on the waybill or bill of lading may impede and/or prevent any claims that you may have against the freight carrier.

If missing parts or damage is found, then please notify the carrier at once and request an inspection. DO NOT DISCARD THIS SHIPPING BOX. If you

give the carrier a clear receipt for goods that have been damaged in transit, you do so at your own risk and expense.

RECEIV ING AND INSPECTION

U.S. Patent No.: US 9,439,831 B2

U.S. Patent No.: US 9,289,353 B2

U.S. Patent No.: US 7,950,079 B2

5

BACK RESTCUSHIONWITH MASSAGE

LARGEBACKREST

ARMREST

CONTEGOJET-LINER

AIRJETSWITCH

DRAIN PLUGCONTROL

INFINITYOVERFLOW

ADJUSTABLEFOOT RESTS

HOT/COLD WATER VALVE

EASYDRAINPULL HANDLE AIR VENT

(OPTIONAL)

Identifying parts for VIP Model6

AIRJETSWITCH

JETSBUTTON

54 in

68 in

16 in

IMPORTANT INSTALLATION INFORMATION

Power Source:120 VAC, 60Hz, 3Amp GFCI protected curcuit must be used to supply power to the pedicure spa.

Plumbing:Note: You are responsible for your valves, connection, and compliance to local codes.

• Shut off valve is recommended.• 0.5 inch fitting will be use for hot and cold water lines.• inlet backflow valve (optional - see specifications).• 1.25 inch fitting will be use for the gravity drain.• 3/4 inch fitting will be used for drain pump. (Please see Wall drain/Gravity drain installation page for more information)

Licensed Installation Required:Please check your local plumbing and electrical codes. Installation of this pedicure spa must comply with both. You must have a licensed plumber and electrician complete applicable connections to your pedicure spa.

Note: Failure to comply with federal, state, or local codes will result in warranty being null and void.

OPTIONALDRAIN PUMP

7

NOT ALL chairs are equipt with Air Vents.The air vent connection can beprovided upon request only.

Specification: 2” pipe.

*NOTE*

¼ The 1st DRAIN should be at 18in.

¼ Therefore, draining spaces should be at 36in.

¼ The AIR VENT should be 9in.

!! NOTICE !!

42” (106.68 cm)

21 in

9 in

18 in

BACKVIEW OF BASE

T Y P E S O F I N S T A L L A T I O NWA

LL

WA

LL

U N D E R G R O U N D P L U M B I N GThe complex diagram below illustrates the ideal placement and sources ofboth water, drainage, and electrical power for the VIP Pedicure Spa Chair.The utilities should be placed exactly within the footprint of the whole chair.

8

AIR VENTS

THE AIR VENT CAN BEOPENED OR CLOSED

Not all chairs are equipped with Air Vents. The air ventconnection can be provided upon request only.

Specification: 2” pipe.

*NOTE*¼ The 1st DRAIN should be at 18in.

¼ Therefore, draining spaces should be at 36in.

¼ The AIR VENT should be 9in.

8cm – 10cm

11/2” or 1.5” (4 cm)

Electrical BoxGFI Outlet

1/2“ (1 cm) HOT / COLDWater Valve

Electrical WireHot/Cold Water Supply

LED Light

OPTIONAL:Drain Pump

3/4“ (2cm)PVC Slip

CheckValve

SIDE VIEW

3“ - 4“

Flex Hose

22” (56 cm)

Distribution Box

SIDE VIEW

11/2” or 1.5” (4 cm)

4” (10 cm)

26-30” (66-76 cm)

Electrical BoxGFI Outlet

DistributionBox

Flex Hose

LED LightHot/ColdWater Valve

1/2“ or 0.5” (1 cm) HOT / COLDWater Valve

1” (2.5 cm)PVC

4” (10 cm)

OPENING INSIDE WALL

BETWEEN CHAIRS FOR

CONNECT PLUMBING

2” 4 in

36 in

54 in

19 in

26 in

BackFlow Valve

Vacuum Breaker for Inlet water may be needed. This is based onCity Specifications. Please check with the city on their plumbing requirments.

Note: Additional Pipe fittings may be needed for installation.

Operation InstructionsSea Basin Operation

Adding Water :

1. Prepare the basin following cleaning instructions on page 11.

2. Place the Jet-Liner with AirJet in the bowl (See Instructions on next page).

3. Add water to the basin by lifting the fill valve. Turn towards RED for hot water and BLUE for cold water. Continue to fill the water until the basin is full or else the water will start to overflow.CAUTION: Always check water temperature before use. The watertemperature should NOT H[FHHG����Ü)����Ü&��

4. Turn off water by pushing handle downward.

5. Press the silver On/Off button to start or stop Jet-Liner

Draining Water :

6. Ensure the Jet-Liner is turned off by pressing the silver button.

7. Pull on EasyDrain to rip the Jet-Liner and begin draining.

8. If needed, Press the silver button to activate the drain pump.

9. When the basin has been completely drained (Turn off the draim pump if needed), remove and dispose the Jet-Liner (See instructions on next page).

9

FRONTVIEW

DIAGONAL VIEWVIEW OF

THE VIP

PEDI SPA

CHAIR

SIDE VIEW

10

EASYDRAINPULL HANDLE

HOT/COLDWATER VALVE

AIRJETSWITCHBUTTON

PLACE THE JET-LINER IN THE PEDI-BOWL AND INSERT THE AIRJET (TUBES) INTO CHANNELS.

FILL THE BOWL WITH WATER.

SERVICE THE CLIENT. WHEN FINISHED, PULL THE EASYDRAIN HANDLE AND LET THE WATER DRAIN UNTIL ITS COMPLETELY EMPTY.

REMOVE BOTH THE JET-LINER AND AIRJET (TUBES) FROM THE BOWL AND DISPOSE IN TRASH.

BASIC STEPS OF USING THE

IMPORTANT NOTE:TO ENSURE THE SAFETY FOR THE

CUSTOMER, BOTH THE CONTEGO

JET-LINER AND ITS AIRJET IS

ONLY ONE TIME USE. AFTER EACH

SERVICE, PLEASE PROPERLY DISPOSE

OF BOTH IN THE TRASH. IT IS

REQUIRED TO REPLACE BOTH THE

JET-LINER AND AIRJET WITH ANOTHER

ONE AND MAKE SURE TO CLEAN

THE PEDI-BOWL WITH EACH USE!

CLEANING INSTRUCTIONSPlease check with the state board code in your area for specific spa disinfectant procedures.

AFTER EACH CUSTOMER AND EVERY NIGHT

1. Remove and disposed of any Jet-Liner and AirJet.

2. Thoroughly clean the inside surface of the spa tub, foot rest, and armrest with a Sanitex Disinfectant Solution.

3. Thoroughly clean the rest of the spa basin surface with a Sanitex Disinfectant Solution.

11

1

2

4 5 6

3

MAKE SURE THE PEDI-BOWL ISPROPERLY (100%) CLEAN!!!

BEFORE BEING READY TO USE!

MASSAGE INSTRUCTIONSU S I N G T H E R E M O T E C O N T R O L

12

POWERON/OFF

V I B R A T I O N

H E A T

L O W E R M A S S A G E

U P P E R M A S S A G E

A U T O M A T I C M A S S A G E

13

VIP PEDICURE SPALimited Warranty

CONTÉGO Spa Designs Inc., has designed and manufactured the VIP Pedicure Spa to the highest standards. Accordingly,CONTÉGO Spa Designs Inc., expressly warrants the VIP Pedicure Spa as follows:

To the original owner of the VIP Pedicure Spa, CONTÉGO Spa Designs Inc., may repair or replace, as optional, any VIPPedicure Spa that are found to be defective in material or workmanship upon inspection by a factory authorized representative of CONTÉGO Spa Designs Inc., This Limited Warranty covers the following:

• Air Pumps: Twenty Four (24) months from date of shipment from CONTÉGO facility. • Basin: Twelve (12) months from date of shipment from CONTÉGO facility. • Other Components/Parts: Twelve (12) months from shipment from CONTÉGO facility • Accessories: Twelve (12) months from shipment from CONTÉGO facility • Shipping Costs: Twelve (12) months from the date of shipment CONTÉGO will cover normal shipping costs associated with replacement parts. Expedited shipping costs will incur an additional charge.

The exchange of a VIP Pedicure Spa is limited to supplying a replacement VIP Pedicure Spa of equal style. Owner is responsible for all labor and shipping costs necessary to replace a VIP Pedicure Spa.

NO CONSEQUENTIAL, INCIDENTAL, CONTINGENT, INDIRECT, SPECIAL OR OTHER DAMAGES WILL BE ALLOWED WHATSOEVER. This limited warranty is null and void if the VIP is removed from it’s original installation, or is not installed in accordance with specifications of CONTÉGO Spa Designs Inc., or national, state or local codes, regulations and ordinances. Furthermore, this limited warranty is null and void if the VIP Pedicure Spa is subjected to improper installation or maintenance, negligence, improper cleaning or any other circumstanc-es beyond CONTÉGO Spa Designs Inc., control. In order for your Limited Warranty to be valid, your VIP Pedicure Spa must be installed by a licensed professional in accordance with CONTÉGO Spa Designs Inc., installation instructions.

EXCLUDED FROM LIMITED WARRANTY:

1) Unauthorized repairs. 2) Damage due to freight, accident, natural disaster and/or abuse. 3) Staining, fading or discoloration of the seat, seat back, armrests or pivoting leg supports. 4) Damage or malfunctions due to improper installation including but not limited to, failure to comply with all national, state and local plumbing, electrical and building codes. 5) Damage or malfunctions due to improper installation including but not limited to, failure to comply with all national, state and local plumbing, electrical and building codes. 6) Fading, discoloration or staining of any part due to improper water additives or harmful cleaning agents or chemicals. Damage to drain pump due to obstruction in drain hose.

For service or information regarding this limited warranty, please contact:

Contégo Spa Designs Inc, • 12856 Brookhurst St, Garden Grove, CA 92840 USAPhone 714-895-8865 • www.contegospa.com

This limited warranty is to the original owner and is not transferable. The original owner agrees by using the VIP Pedicure Spa theobligation of CONTÉGO Spa Designs Inc., shall not extend to indirect or contingent damages or injury. Furthermore, the obligations ofCONTÉGO Spa Designs Inc., are limited to those set forth herein. This limited warranty is the exclusive remedy and is in lieu of all otherwarranties, express or limited, including, but not limited to, any implied warranty of fitness or merchantability for a particular purpose. Nodistributor, dealer or other person has the right or authority to bind CONTÉGO Spa Designs Inc., to changes to this limited warranty.Consequently, CONTÉGO Spa Designs Inc., is not responsible for such warranties or representations.

ADDITIONAL PROVISIONS • Any assistance CONTÉGO Spa Designs Inc., provides to the original owner above and beyond the scope of this limited warranty does not constitute a waiver of such terms, limitations or exclusions. Furthermore, such assistance does not extend this limited warranty. • CONTÉGO Spa Designs Inc., shall not be liable for any other obligations or liabilities as a result of breach of contract of warranty, negligence or strict liability with regards to the VIP Pedicure Spa. • This Limited Warranty applies only to the VIP Pedicure Spas installed in any one of the fifty states of the United States, the District of Columbia or provinces of Canada.