wheelhorse charger 9 owners manual 1-7931_396
TRANSCRIPT
WHEEL-HORSE PRODUCTS, INC.
OWNERS MANUAL
CHARGER 9
MODEL
1·7931
SOUTH BEND, IND.
A. The tractor is wheel and tire
separate carton.
B.
ASSEMBLY
BATTERY
one carton with the Part No. in a
the ten
caps. Remove or any seal-
NOTE: time of
been used to close or re-
to level
of and at be above 60°F. Never fill bat-
3. BOOST CHARGE: 15 amps. for 10 minutes or 7 amps. for 30 minutes. if necessary, after
4. Install rear of tractor.
service, add
DO NOT ADD ACID.
TIRES
front 16 x and
has been
f1ated to air pressure. The rear tires are 8.50 x 12 and should have 6 to 8 pg'Lnl~UIi
BEFORE YOU
the Tnt:tnrv
Manual.
2
Wheel-a-Matic Transmission: The transmission been filled with Automatic Transmission fluid at the
is "A" automatic which is used in automobiles and at any service
A. Remove cated under and insert
I). Now check level make sure transmission is filled
,hr,ft',..;;", all grease lubricant every to ten hours of nn,,,.,.,,,,tin
Refer to IV for the location
should be used where
OPERATING INSTRUCTIONS
direction and are controlled control handle located on the
To go Forward the control handle Forward.
• To go Backward the control handle Back.
To control handle in Neutral
• You may also the tractor at the foot on the left side.
The tractor is affected ment of the control handle. For safest control handle should not be moved too
on
TOWING INSTRUCTIONS
This tractor should never be towed or DUlsne,a with-out first the valve.
A. The face of the
is located on the sur-or tow directions
B. CAUTION: Do not tow for distance or over a of seven miles per hour.
STARTING ENGINE
the a
valve on gas tank.
2. The tractor has a all way to
Pull throttle lever ~ way out and to the to lock it in Note: The throttle control
device. Turn the throttle control to the to the desired and turn
4. Pull choke lever the out to choke en· If is warm been
be
5. choke in to off to the
or out to desired
6. When in cold weather the
• Use
the and the not have to turn the transmission.
PARKING BRAKE
creep. released. Caution: Do
to the transmission. left before
TRANSMISSION CARE
oil filter after first ten hours. every year or 100 hours of
as
JtAJt outomatic transmission oil.
• Check oil and maintain at proper level as indicated on
1 fer to Check
CARE OF TRACTOR
air cleaner This will add to
3. structions.
tires
4. tractor covered and nof in use.
5. these
a
6. grass and dirt off transmission transmission
7. level
NOTE: If tractor has been in necessary
8. Control Handle Friction
when
may be
The control lever is friction loaded so The tension been
should
force at control lever. Be sure to
tension has and
nof lubricotion.
9. Neutral
A. If tion this
should creep while neutral corrected. To check for creep
not
surface and de· and can·
B. To make neutral
Block
2. Remove of the which hold it.
3. loosen set screw in arm with allen
4.
5.
on
and
front
ng1ogled, insert screwdriver cam and rotate
until rear wheels set screw in arm and re-
6. NOTE: The on the proper
must be
7.
8. Your tractor is as as the you it. See your Wheel Horse for a after each season of use.
AnACHING TOOLS
All drawn ........ I .. 'n"'nt'" attach seconds .
3-
SAFETY SUGGESTIONS Recommended by Power Eq'lip,nellt
Know controls and how to read the owners manual.
2. not allow children to nor adults it without proper instruction.
3. Clear work of which be up and thrown.
4. all clutches and shift into neutral before away from power driven
5. Do not carry passengers. a safe distance away.
and
children and
6. Never direct of any material toward allow anyone near machine
in or area to another.
10. alert and other hidden Know what is behind you, before
11. Beware of reduce and to
control. 12. Don't or start ""nn,,,n
or downhill. 13. Use care when loads or
and
unaway,
14. Watch out for traffic when near rOI~d'wrlv;;:
4
1 flammable.
a.
with care it is
container.
b. motor -up
c. cap
d. garage gases
machine in devices in
in owner's manual.
p CI,FICATIONS
Overall Wheelbase """"'" ....• " .. , ...•.•........ Width Overall ... ........ . ...................... 36
inches inches
. , , ., ... ,' . .,.33 inches
Ibs. Crop Clearance .... ,
........... 13
H.P.
Engine Oil Capacity . """" .. 2.5 Fuel Capacity .. ., . , . , ,. " . .,', ... .6 quarts
5.50-8 Pneumatic wheel (rear) Terra-Type 8.50 x 12" Pneumatic: (23" wheel dia.)
forward 0 to 7 Reverse 0 to M.P,H.
Turning Radius outside of outside wheel) .....••. ,.... ..6'
FIG. I
FIG. II FIG. III
-5 -
HOOD RELEASE
Fig. IV
-6-
7
8
&
9
pages 12 and 13 for Transmission break down Parts
When ordering olways list Part name
Item Port Item No. No. No. No. Req'd.
7627 59 7665 60 6825 61
12 62 932120·4 5 14 3926 6 3988 1
7 6 936125 2 8 9
10 8
4 4
6 6465 937022 2
2 920081·4 2 7432 1 6129 2 3 920009·4 6
82 83 84
5631 85 3 86
30 31 3 6 32 33 2 34 2
1
6472 x X 5628 5629 915002.6 4
Neutral
44 2 1230 45 Rod Neutral 5450 46 Hairpin 5458 47 Hairpin 7 4 48 933188 Roll 106 49 5448 Ass'y. 107
Plunger 108 109 110 4
10.16 4
1
2 5186
57 Pin
58
o
154 7229 155 156 7185 157 3023 158 7618 159 160 161 162 163 164 165 166 167 168
175
pages 12 and 13 for Transmission break down and Parts
Screw Self Tap
Clip Connector Three
ordering parts always list Pari No.
No. Req'd.
1 2 I
4
2 2
4
5
1 1 2
2 1
2 2
176 177 178 179 180 181 182 183 184 185 186 187 188 189 190 191 192 193 194 195 196 197 198 199
204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220
222 223 224 225 226 227 228
11-
Description
7464 latch fender
5977 7617 7616
7559
7417
7018 7019
7027 7230 5455
5467
933182
5438 5437 5432 5433 5434 5435 1004 Whe,,1 K6-2O
5637 Ass'y. Wheel, &
5635 Wheel
4999 Beoring Boll
5636 Tire 16 5.50-8 5512 Tube
2844 Washer
2816 7420 Wheel
7469 933215 937014 7468 7561 7568
7477 5604 7421 7634 7633
No. Req'd.
2
2 2 1
2
ARTS LIS
(Order No. 5054 for Cemple,,, TI'Q1'I6mi$sion)
p<> rts P'Clrt No. Nome of
No, I'"m Req'd. No,
1.0.
Ball 2
2
LD. 2
I.D.
3915
6455
5960
2822 R.H.
2821
2819 2
2827
I.D,
2828 Thru.! ::1
645.0 Reelr
6451 Rear LH,
2920 Axl"
933217 Roll Pin >< 2
Block 64 971113
Gear 7267
5963 Gear -22
.'!964 Geor 33 Teeth
Shaft Die. 971015
1" Shaft 7054
971018
5999 71
72
73 7051
74 7050 CO"" 2
33 9151 7049 2
34 3
35 7152
36 7753 2
37 7754 2
5990
Pipe
Support &Iotk 7977
48" ROTARY MOWER
42" ROTARY MOWER
36" MOWER
37" THROWER 211)
50" SICKLE BAR MOWER 31
111 )
32" DISC 151
TILLER 2
2" PLOW 411
TRAILING CULTIVATOR 711
TWO SECTION CULTIVATOR 72
BLADE 1 1
TOOTH HARROW 161
4-WHEEl UTILITY WAGON
2-WHEEl TRAILER
SPIKED DISC AERATOR
LAWN ROLLER 1)
FRONT AND REAR WHEEL DISCS 1)
FRONT
ATTACHMENT CLUTCH
TIRE CHAINS
HYDRAULIC POWER LIFT 11
WHEelS 1
· .
..
15
Printed in U.S.A. 8-14-67 FORM NO. 396