092274r-hpusp01v01 part 15b classa-艾緯 oncell 5004...

Report No：092274R-HPUSP01V01

Page: 1 of 33

Test Report

Product Name ： Industrial Cellular Router

Model No. ： OnCell 5004-HSDPA

Applicant ： Moxa Inc.

Address ： Fl.4, No. 135, Lane 235, Pao-Chiao Rd.,

Shing Tien City, Taipei, Taiwan, R.O.C.

Date of Receipt ： 2009/02/20

Issued Date ： 2009/04/14

Report No. ： 092274R-HPUSP01V01

Report Version ： V1.0

The test results relate only to the samples tested.

The test report shall not be reproduced except in full without the written approval of Quie Tek Corporation.

This report must not be used to claim product endorsement by NVLAP any agency of the U.S. Government


Page: 2 of 33

Test Report Cert i f icat ion Issued Date: 2009/04/14 Report No.: 092274R-HPUSP01V01

The test results relate only to the samples tested.

The test report shall not be reproduced except in full without the written approval of Quie Tek

Corporation.

This report must not be used to claim product endorsement by NVLAP any agency of the U.S.

Government

Product Name ： Industrial Cellular Router

Applicant ： Moxa Inc.

Address ： Fl.4, No. 135, Lane 235, Pao-Chiao Rd., Shing Tien

City, Taipei, Taiwan, R.O.C.

Manufacturer : Moxa Inc.

Model No. ： OnCell 5004-HSDPA

FCC ID. ： DoC

Rated Voltage ： DC 12~48V

EUT Voltage ： DC 24V

Trade Name ： Moxa

Applicable Standard ： FCC CFR Title 47 Part 15 Subpart B: 2007 Class A

CISPR 22: 2005 ICES-003 Issue 4: 2004 Class A

Classification ： A

Test Result ： Complied

Documented By

：

( E n g i n e e r i n g A d m . A s s i s t a n t / N i c o l e H u a n g )

Tested By ：

( E n g i n e e r / N o N o C h a n g )

Approved By ：

( M a n a g e r / V i n c e n t L i n )


Page: 3 of 33

TABLE OF CONTENTS

Description Page 1. General Information .................................................................................................................4 1.1. EUT Description ..........................................................................................................................4 1.2. Test mode ....................................................................................................................................5 1.3. Tested System Details................................................................................................................6 1.4. Configuration of tested System ................................................................................................7 1.5. EUT Exercise Software ..............................................................................................................8 1.6. Test Facility ..................................................................................................................................9 2. Radiated Emission .................................................................................................................10 2.1. Test Equipment List ..................................................................................................................10 2.2. Test Setup ..................................................................................................................................10 2.3. Limits...........................................................................................................................................11 2.4. Test Procedure ..........................................................................................................................12 2.5. Uncertainty.................................................................................................................................13 2.6. Test Result .................................................................................................................................14 2.7. Test Photo ..................................................................................................................................22

Attachement...............................................................................................................................24 　 EUT Photograph .......................................................................................................................24

Reference: Laboratory of License


Page: 4 of 33

1. General Information

1.1. EUT Description

Product Name Industrial Cellular Router

Trade Name Moxa

Model No. OnCell 5004-HSDPA

TX Frequency 824MHz~849MHz(GSM 850/WCDMA Band V)

1850MHz ~ 1910MHz(PCS 1900/WCDMA Band II)

RX Frequency 869MHz~894MHz(GSM 850/WCDMA Band V)

1930MHz ~ 1990MHz(PCS 1900/WCDMA Band II)

Antenna Type MFR: CHINMORE, Part No: EM-B10.0X104-157

Hardware version

(Test Version)-Main board V1.2

Hardware version

(Test Version)-RF board V1.1

Software version

(Test Version) V1.0.1


Page: 5 of 33

1.2. Test mode

Quie Tek has verified the construction and function in typical operation. All the test modes were

carried out with the EUT in normal operation, which was shown in this test report and defined as:

Pre-Test Mode

EMI Mode 1: GSM 850 GPRS Link

Mode 2: GSM 850 EGPRS Link

Mode 3: GSM 850 GPRS/EGPRS Idle

Mode 4: PCS 1900 GPRS Link

Mode 5: PCS 1900 EGPRS Link

Mode 6: PCS 1900 GPRS/EGPRS Idle

Mode 7: WCDMA Band V RMC Link

Mode 8: WCDMA Band V HSDPA Link

Mode 9: WCDMA Band V RMC/HSDPA Idle

Mode 10: WCDMA Band II RMC Link

Mode 11: WCDMA Band II HSDPA Link

Mode 12: WCDMA Band II RMC/HSDPA Idle

Final Test Mode

RE Mode 1: GSM 850 GPRS Link

Mode 2: GSM 850 EGPRS Link

Mode 4: PCS 1900 GPRS Link

Mode 5: PCS 1900 EGPRS Link

Mode 7: WCDMA Band V RMC Link

Mode 8: WCDMA Band V HSDPA Link

Mode 10: WCDMA Band II RMC Link

Mode 11: WCDMA Band II HSDPA Link


Page: 6 of 33

1.3. Tested System Details

The types for all equipments, plus descriptions of all cables used in the tested system

(including inserted cards) are:

Product Manufacturer Model No. Serial No. Power Cord

1 N/A N/A N/A N/A N/A


Page: 7 of 33

1.4. Configuration of tested System

Connection Diagram

Signal Cable Type Signal cable Description

A Terminal (LAN) Cable Non-Shielded, 0.3m

B Antenna Cable Non-Shielded, 0.1m


Page: 8 of 33

1.5. EUT Exercise Software

1 Setup the EUT and simulators as shown on 1.4

2 Turn on the power of all equipments.

3 The EUT was set to communicate with CMU200.

4 Repeat the above procedure (3).


Page: 9 of 33

1.6. Test Facility

Ambient conditions in the laboratory:

Items Test Item Required (IEC 68-1) Actual

Temperature (C) ANSI C63.4 RE 15-35 20

Humidity (%RH) 30-60 56

Barometric pressure (mbar) 860-1060 950-1000

Site Description: File on

Federal Communications Commission

FCC Engineering Laboratory

7435 Oakland Mills Road

Columbia, MD 21046

FCC Registration Number :92195

Accreditation on NVLAP

NVLAP Lab Code: 200533-0

Site Name: Quie Tek Corporation

Site Address: No. 5-22, Ruei-Shu Valley, Ruei-Ping Tsuen,

Lin Kou Shiang, Taipei 244 Taiwan, R.O.C.

TEL : 886-2-8601-3788 / FAX : 886-2-8601-3789

E-Mail : [email protected]


Page: 10 of 33

2. Radiated Emission

2.1. Test Equipment List

The following test equipment are used during the radiated emission test:

Test Site Equipment Manufacturer Model No./ Serial No. Last Cal.

Test Receiver R & S ESVS 10 / 834468/003 July, 2008

Spectrum

Analyzer

Advantest R3162/ 00803480 May, 2008

Pre-Amplifier Advantest BB525C/ 3307A01812 May, 2008

Bilog Antenna SCHAFFNER CBL6112B / 2697 Nov., 2008

Horn Antenna ETS 3115/ 0005-6160 Jul., 2008

OATS 3

Pre-Amplifier QTK QTK-AMP-01/ 0001 Jul., 2008

Note: 1. All equipments that need to be calibrate are with calibration period of 1 year.

2.2. Test Setup


Page: 11 of 33

2.3. Limits

Under 1GHz test shall not exceed the following value:

Limits

Frequency (MHz)

Distance (m) dBuV/m

30 – 230 10 40

230 – 1000 10 47

Remark: 1. The tighten limit shall apply at the edge between two frequency bands. 2. Distance refers to the distance in meters between the measuring instrument antenna and the

closed point of any part of the device or system.

Above 1GHz test shall not exceed the following value:

FCC Part 15 Subpart B Paragraph 15.109 Limits (dBuV/m)

Frequency

(MHz) Distance(m) dBuV/m

30-88 10 39

88-216 10 43.5

216-960 10 46.4

Above 960 10 49.5

Remark:

1. The tighter limit shall apply at the edge between two frequency bands.

2. Distance refers to the distance in meters between the measuring

instrument antenna and the closed point of any part of the device or

system.

3. RF Voltage (dBuV/m) = 20 log RF Voltage (uV/m)


Page: 12 of 33

2.4. Test Procedure

The EUT and its simulators are placed on a turn table which is 0.8 meter above ground.

The turn table can rotate 360 degrees to determine the position of the maximum emission level

and the antenna can move up and down between 1 meter and 4 meters to find out the

maximum emission level.

Both horizontal and vertical polarization of the antenna are set on measurement. In order to find

the maximum emission, all of the interface cables must be manipulated on radiated

measurement.

For an unintentional radiator, including a digital device, the spectrum shall be investigated from

the lowest radio frequency signal generated or used in the device, without going below the

lowest frequency for which a radiated emission limit is specified, up to the frequency shown in

the folowing table: Highest frequency generated or used in

the device or on which the device operates or tunes (MHz)

Upper frequency of measurement range (MHz)

Below 1.705 30

1.705 – 108 1000

108 – 500 2000

500 – 1000 5000

Above 1000 5th harmonic of the highest frequency or

40 GHz, whichever is lower

On any frequency or frequencies below or equal to 1000 MHz, the radiated limits shown are

based on measuring equipment employing a quasi-peak detector function and above 1000

MHz, the radiated limits shown are based measuring equipment employing an average

detector function.

When average radiated emission measurement are included emission measurement Above

1000 MHz, there also is a limit on the radio frequency emissions, as measured using

instrumentation with a peak detector function, corresponding to 20 dB above the maximum

permitted average limit.

For class A, the measurement distance between the EUT and antenna is 10 meters for under

1GHz and above 1GHz.

For class B, the measurement distance between the EUT and antenna is 10 meters for under

1GHz and 3 meters for above 1GHz.

The bandwidth below 1GHz setting on the field strength meter (R&S Test Receiver ESCS 30) is


Page: 13 of 33

120 kHz and above 1GHz is 1MHz.

2.5. Uncertainty

The measurement uncertainty is defined as ± 3.8 dB


Page: 14 of 33

2.6. Test Result

Product Industrial Cellular Router

Test Mode Mode 1: GSM 850 GPRS Link

Date of Test 2009/04/10 Test Site OATS 3

Test Condition Radiated Emission Test Range 30-1000MHz

Frequency Correct Reading Measurement Margin Limit

Factor Level Level

MHz dB dBuV dBuV/m dB dBuV/m

Horizontal

32.697 18.243 2.074 20.317 -19.683 40.000

192.672 12.607 16.735 29.342 -10.658 40.000

287.316 17.125 14.738 31.863 -15.137 47.000

384.050 19.650 18.465 38.115 -8.885 47.000

480.315 21.677 15.178 36.855 -10.145 47.000

671.948 24.570 10.756 35.326 -11.674 47.000


Factor Level Level


Vertical

40.310 15.863 7.753 23.615 -16.385 40.000

124.419 15.036 15.129 30.165 -9.835 40.000

192.318 12.603 20.551 33.154 -6.846 40.000

247.856 16.152 18.834 34.986 -12.014 47.000

385.111 19.683 17.632 37.315 -9.685 47.000

480.624 21.687 12.009 33.696 -13.304 47.000

Note:

1. All Readings below 1GHz are Quasi-Peak, above are performed with peak and/or

average measurements as necessary.

2. “ * ”, means this data is the worst emission level.

3. Measurement Level = Reading Level + Correct Factor


Page: 15 of 33


Test Mode Mode 2: GSM 850 EGPRS Link




Factor Level Level


Horizontal

39.648 16.088 7.077 23.165 -16.835 40.000

192.185 12.602 15.560 28.162 -11.838 40.000

286.196 17.093 15.554 32.648 -14.352 47.000

396.158 19.980 16.234 36.214 -10.786 47.000

480.316 21.677 15.958 37.635 -9.365 47.000

627.154 24.082 7.614 31.696 -15.304 47.000


Factor Level Level


Vertical

39.168 16.251 6.936 23.187 -16.813 40.000

114.168 15.013 11.472 26.485 -13.515 40.000

192.355 12.604 19.565 32.169 -7.831 40.000

384.165 19.653 18.491 38.145 -8.855 47.000

482.196 21.714 13.201 34.915 -12.085 47.000

672.986 24.588 7.253 31.840 -15.160 47.000

Note:



2. " ", means this data is the worst emission level.



Page: 16 of 33


Test Mode Mode 4: PCS 1900 GPRS Link




Factor Level Level


Horizontal

39.485 16.143 6.054 22.197 -17.803 40.000

188.475 12.548 11.311 23.859 -16.141 40.000

287.697 17.133 15.456 32.589 -14.411 47.000

384.169 19.653 18.271 37.925 -9.075 47.000

481.151 21.701 15.455 37.156 -9.844 47.000

675.395 24.614 10.345 34.959 -12.041 47.000


Factor Level Level


Vertical

41.325 15.511 6.188 21.698 -18.302 40.000

192.358 12.604 20.558 33.162 -6.838 40.000

250.697 16.320 14.645 30.965 -16.035 47.000

384.165 19.653 17.831 37.485 -9.515 47.000

481.117 21.701 13.224 34.925 -12.075 47.000

864.152 27.180 4.516 31.696 -15.304 47.000

Note:






Page: 17 of 33


Test Mode Mode 5: PCS 1900 EGPRS Link




Factor Level Level


Horizontal

40.685 15.734 6.880 22.615 -17.385 40.000

192.745 12.608 12.360 24.968 -15.032 40.000

287.695 17.133 16.163 33.296 -13.704 47.000

384.165 19.653 18.501 38.155 -8.845 47.000

481.025 21.699 13.563 35.262 -11.738 47.000

575.286 23.354 13.760 37.113 -9.887 47.000


Factor Level Level


Vertical

41.252 15.536 8.162 23.698 -16.302 40.000

114.398 15.020 11.838 26.858 -13.142 40.000

192.417 12.604 20.582 33.186 -6.814 40.000

384.315 19.658 18.467 38.125 -8.875 47.000

482.330 21.716 16.248 37.964 -9.036 47.000

864.023 27.178 5.467 32.645 -14.355 47.000

Note:






Page: 18 of 33


Test Mode Mode 7: WCDMA Band V RMC Link




Factor Level Level


Horizontal

38.956 16.323 5.851 22.174 -17.826 40.000

192.648 12.607 13.711 26.318 -13.682 40.000

287.315 17.125 17.500 34.625 -12.375 47.000

384.169 19.653 17.298 36.952 -10.048 47.000

480.165 21.673 14.522 36.195 -10.805 47.000

627.164 24.082 6.067 30.150 -16.850 47.000


Factor Level Level


Vertical

39.700 16.070 8.875 24.945 -15.055 40.000

73.650 9.550 5.618 15.168 -24.832 40.000

192.145 12.602 20.923 33.525 -6.475 40.000

384.156 19.653 17.512 37.165 -9.835 47.000

481.957 21.709 12.453 34.162 -12.838 47.000

672.495 24.578 5.298 29.875 -17.125 47.000

Note:






Page: 19 of 33


Test Mode Mode 8: WCDMA Band V HSDPA Link




Factor Level Level


Horizontal

41.185 15.560 7.603 23.162 -16.838 40.000

192.625 12.607 16.878 29.485 -10.515 40.000

288.475 17.150 16.113 33.262 -13.738 47.000

384.169 19.653 17.514 37.168 -9.832 47.000

481.965 21.709 12.459 34.168 -12.832 47.000

672.158 24.570 7.125 31.695 -15.305 47.000


Factor Level Level


Vertical

40.152 15.916 6.942 22.858 -17.142 40.000

121.698 15.138 12.414 27.552 -12.448 40.000

192.345 12.604 21.144 33.748 -6.252 40.000

247.695 16.140 18.545 34.685 -12.315 47.000

384.485 19.663 17.296 36.959 -10.041 47.000

481.256 21.702 13.483 35.185 -11.815 47.000

Note:






Page: 20 of 33


Test Mode Mode 10: WCDMA Band II RMC Link




Factor Level Level


Horizontal

41.225 15.545 6.770 22.315 -17.685 40.000

192.485 12.605 15.558 28.163 -11.837 40.000

250.316 16.313 13.172 29.485 -17.515 47.000

384.162 19.653 17.599 37.252 -9.748 47.000

481.145 21.701 14.244 35.945 -11.055 47.000

575.195 23.352 12.594 35.945 -11.055 47.000


Factor Level Level


Vertical

41.113 15.585 7.111 22.696 -17.304 40.000

114.185 15.014 11.471 26.485 -13.515 40.000

192.487 12.605 20.920 33.525 -6.475 40.000

384.169 19.653 18.304 37.958 -9.042 47.000

481.152 21.701 16.257 37.958 -9.042 47.000

864.155 27.180 4.405 31.585 -15.415 47.000

Note:






Page: 21 of 33


Test Mode Mode 11: WCDMA Band II HSDPA Link




Factor Level Level


Horizontal

41.575 15.423 6.164 21.587 -18.413 40.000

193.487 12.620 13.544 26.165 -13.835 40.000

286.958 17.117 14.993 32.110 -14.890 47.000

383.645 19.638 18.348 37.985 -9.015 47.000

481.055 21.700 16.495 38.195 -8.805 47.000

575.295 23.354 12.801 36.154 -10.846 47.000


Factor Level Level


Vertical

41.628 15.404 7.761 23.165 -16.835 40.000

114.755 15.032 10.137 25.168 -14.832 40.000

192.485 12.605 20.880 33.485 -6.515 40.000

384.054 19.650 18.305 37.955 -9.045 47.000

482.175 21.714 15.244 36.957 -10.043 47.000

864.152 27.180 6.378 33.558 -13.442 47.000

Note:






Page: 22 of 33

2.7. Test Photo

Test Mode: Mode 1: GSM 850 GPRS Link Mode 2: GSM 850 EGPRS Link Mode 4: PCS 1900 GPRS Link Mode 5: PCS 1900 EGPRS Link Mode 7: WCDMA Band V RMC Link Mode 8: WCDMA Band V HSDPA Link Mode 10: WCDMA Band II RMC Link Mode 11: WCDMA Band II HSDPA Link

Description: Front View of Radiated Test


Page: 23 of 33

Description： Back View of Radiated Test


Page: 24 of 33

Attachement

EUT Photograph

(1) EUT Photo

(2) EUT Photo


Page: 25 of 33

(3) EUT Photo

(4) EUT Photo


Page: 26 of 33

(5) EUT Photo

(6) EUT Photo


Page: 27 of 33

(7) EUT Photo

(8) EUT Photo


Page: 28 of 33

(9) EUT Photo

(10) EUT Photo


Page: 29 of 33

(11) EUT Photo

(12) EUT Photo


Page: 30 of 33

(13) EUT Photo

(14) EUT Photo


Page: 31 of 33

(15) EUT Photo

(16) EUT Photo


Page: 32 of 33

(17) EUT Photo


Page: 33 of 33

Reference: Laboratory of License

092274r-hpusp01v01 part 15b classa-艾緯 oncell 5004...

Documents