· 1-4 no diving or jumping. observe all safety rules. 15 x 24 oval pool dimensions r 90"...

89
No Diving or Jumping. Observe all Safety Rules. 1-1 Gibraltar Oval Pools Part No. 1920585 rev. 0 1 Pool Component Installation Manual General Instructions SECTION Safety Rules For Pool Owners This manual must be left with the pool owner Your pool contains a large quantity of water, and is deep enough to present inherent dangers to life and health unless the following safety rules are strictly observed. First- time users run the highest risk of injury. Make sure everyone understands all safety rules before entering the pool. Post NO DIVING and NO JUMPING signs beside the pool. For additional safety information please read the enclosed booklet The Sensible Way To Enjoy Your Aboveground/Onground Swimming Pool. 1. No Jumping or Diving The top rail of your pool is not a walkway and must not be used for jumping or diving. Do not permit jumping or diving into the pool from a deck or the top rail of the pool. Diving or jumping into the pool can result in serious injury. 2. Never use the Pool Alone Never permit the pool to be used unless it is attended by at least one person other than the bather. Someone should always be available to lend assistance in an emergency. 3. Never Leave Children Unattended Never leave a child alone and unsupervised in or near the poolnot even for a sec- ond. There is no substitute for constant adult supervision. 4. No Rough-housing Do not permit rough-housing in and around your pool. Surfaces can become slip- pery and hazardous when wet. 5. Light the Pool at Night If the pool is used after dusk, adequate lighting must be provided. Illumination in the pool area must be sufficient to clearly judge pool depth and all features in and around the pool. For lighting recommendations, consult your local licensed electrical contractor. 6. Restrict Access to the Pool Do not leave chairs or other furniture beside the pool that could be used by a child to climb up into the pool. Ladders must be removed whenever the pool is unattended. A fence with a lockable gate around the pool or yard is strongly recommended and may be required by law in some jurisdictions. 7. No Alcohol or Drugs The use of alcohol or drugs does not mix with pool activities. Persons who have been drinking alcohol or using any drugs should not be allowed in the pool, and should be carefully supervised in the surrounding area. 8. Keep Your Pool Clean and Sanitary Your filter system will remove suspended particles from the water and the surface skimmer will remove insects, leaves and other debris from the water surface. Use the correct pool chemicals as directed to destroy harmful bacteria and prevent formation of algae. Remember, unsanitary water is a serious health hazard.

Upload: others

Post on 03-Jul-2020

2 views

Category:

Documents


0 download

TRANSCRIPT

Page 1:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� ����������������������������

������������ ����

❏ �����������������

���������������� �� ���

� �� �

������������ ����

�������

� ����������������������

������ �� ��������������������������

������������������������������������������������ ��������� ����

��������������� ��� ������ ��������������������������������������!����

�"��������� � �� �����#����$����%�#�������������������������������

������������������ ������ �������� ����������� ����������� ������

!���������������������"�������������� ������������#������������������

������������� ��������!"������!��#�������$����

�������� �����!����"�#��!& �������������������������#����������������������$�"�������������

�������"�$�"��������������� ��������"����#�� ��������� ������

'�������$�"������� ������������������������$����

$����#������������%�����������"� �������������������������������������������� �� ��

��� ���(�"����� ����������������������������������������"��������

&����#��' #�����(���)� �((������������ ������������������������������� �����)��������������

����& ���������������������������������������

*������+���!�,������!-�������"�*���� � ������+��������������������(��������������"������

������� �,������� �����

.���'�!��������� ���!�-� ������������������#����������� ������������������-���"�������� �

��������"���������������������$����������� ������������������

������ ������!����� �������""�����������������������������������������

���������

/�������0�%00��������������������� ������� ���������������� ����� ���������������� ����

���"������ ������.��������������"����� ������ ����������������/

������� ����#������������� ������������������������""��������

"���������������������"�$������������

1������%�0��������"��!�& ���������� ����������������"�0�� ������������� ������� � �������

����#������� ������������������ ����������������� ���������� ������

��������������������� �����������������

2���3��4����������� �� �(�� �� ���������������"������"�����������������������" �������� ��������

�#�""��������"�������������������� �����������" �������������1�� �

����������� �"��������������������� ��"����������������������"����

���������������������������������������� ��� �,����

Page 2:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

A. Introduction to Installing your PoolRead all instructions completely before you begin.

These instructions explain how to install your pool. Simply follow the step-by-step directions. Start with this part, SECTION 1 and use the other instruc-tions, SECTION 2 to 4 to put together your entire pool.

SECTIONS 1, 2 and 3 have information for several different pool sizes andstyles; follow the instructions carefully to make sure you use the informa-tion that apply to your specific pool.

SECTION 1 also has Safety Rules and instructions to help you keep yourpool clean and in good shape, year after year. Be sure to read the SafetyRules, and make sure everyone who uses your pool reads and under-stands them.

B. Determine a Location for your Pool1. The Terrain

Pay special attention to choos-ing the right location for yourpool:

� Choose a large area, as flatand level as possible.

� Choose a spot on dry, firmearth�do not install the poolon concrete, asphalt, tar pa-per, sand, gravel, peat moss,wood or chemically treatedsoil.

� Check with your pool dealer tosee if Nut Grass grows in yourarea. This type of grass maygrow up through your poolliner. Your dealer will be able toadvise how best to treat thesite.

� Sloped areas will need to bemade level by digging awayhigh spots, not by filling lowspots�be prepared to hireearth-moving equipment ifnecessary.

1

2 3

4

!Important Note:Ground prepara-tion is one of themost importantsteps in the instal-lation process. Aproper foundationwill ensure the restof the pool assem-bly goes smoothlyand that no prob-lems will occurwhen the pool isfilled with water.

Open all of theframe cartons andread all of theinstructions beforeyou begin. Be sureto read Section 2and get a com-plete overview ofthe pool base andbuttress assemblybefore starting theground prepara-tion.

1-2

Page 3:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

2. Things to AvoidDo not locate your pool near oron any of the following:

� Overhanging tree branches.� Overhead wires, clotheslines.� Buried pipes and wires�con-

tact your gas, electric andtelephone utilities to find buriedpipes and wires before youdig.

� Hilly and uneven terrain.� Areas with poor drainage.� Grass, stones and roots. Grass

will rot underneath the poolliner, and stones and roots willdamage the pool liner.

� Areas recently treated with oil-based weed killers, chemicals or fertiliz-ers.

3. Plan Ahead� Will you be adding an adjacent deck later? Be sure to leave room.� Will you be using pool accessories or other appliances that need elec-

tricity or gas? Locate your pool near these services or plan to havethem installed later by a licensed contractor.

C. Prepare the Foundation of your Pool1. Choose the Correct Ground Preparation Drawing

a. Choose the drawing that matches your pool size from the five plandrawings below. This drawing will have all of the necessary dimen-sions for the ground preparation instructions that follow.

1-3

15 x 30 Oval PoolDimensions

R 90" (229 cm)S 102" (259 cm)L 90" (229 cm)M 30-1/2" (77 cm)N 59-1/2" (151 cm)P 180" (457 cm)W 114" (290 cm)X 90" (229 cm)Y 127-1/4" (323 cm)Z 145-1/4" (369 cm)

BB

GG

K J

H I

RR

SS

XXYY ZZ

NNMM

PP

LL

FF

EEDD

AACC

WW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Pool WallPool Wall

Clearance AreaClearance Area

Support Trenches

!Important:When locating thecentreline of thepool, be sure totake into consid-eration any struc-tures (deck, patio,house) or relevantitems (changerooms, gazebo,etc.) that the poolmay need to lineup with and en-sure that the poolis in the mostvisual pleasinglocation for yourproperty.

5 6

7

Page 4:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.1-4

15 x 24 Oval PoolDimensions

R 90" (229 cm)S 102" (259 cm)L 54" (137 cm)M 30" (76 cm)N 48" (122 cm)P 108" (274 cm)W 114" (290 cm)X 90" (229 cm)Y 105" (267 cm)Z 126-1/8" (320 cm)

12 x 24 Oval PoolDimensions

R 72" (183 cm)S 84" (213 cm)L 72" (183 cm)M 24" (61 cm)N 48" (122 cm)P 144" (366 cm)W 96" (244 cm)X 72" (183 cm)Y 101-3/4" (258 cm)Z 120" (305 cm)

12 x 18 Oval PoolDimensions

R 72" (183 cm)S 84" (213 cm)L 36" (91 cm)M 36" (91 cm)P 72" (183 cm)W 96" (244 cm)X 72" (183 cm)Y 80-1/2" (204 cm)Z 102-1/2" (260 cm)

BB

GG

RR

SS

XX YY

NNMM

PP

LL

FF

EEDD

AACC

K J

H I

ZZWW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

BB

GG

RRSS

XXYY

NNMM

PP

LL

FF

EEDD

AACC

K J

H I

ZZ WW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

BB

GG

RRSS

XXYY

MM

PP

LL

FF

EEDD

AACC

K J

H I

ZZWW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

Page 5:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

2. Mark out the Areaa. Drive two pegs (A) and (B) into

the ground. These pegs willboth be on the centreline ofyour pool. Choose the rightdistance between them fromthe chart below. Note: Dis-tance A to B is equal to di-mension P on the pool draw-ings above.

Pool Size Distance between two pegs (A) and (B)

12' x 18' 72" (183 cm)12' x 24' 144" (366 cm)15' x 24' 108" (274 cm)15' x 30' 180" (457 cm)18' x 33' 180" (457 cm)

b. Use a length of string tiedbetween peg (A) and a can ofspray paint, and mark a circleon the ground. Next, do thesame for peg (B). Choose thelength of string you need foryour pool from the chart on thenext page. The circles will be12" (30 cm) bigger all roundthan the pool.

1-5

8

18 x 33 Oval PoolDimensions

R 108" (274 cm)S 120" (305 cm)L 90" (229 cm)M 30-1/2" (77 cm)N 59-1/2" (151 cm)P 180" (457 cm)W 132" (335 cm)X 108" (274 cm)Y 140-5/8" (357 cm)Z 159-3/4" (406 cm)

BB

GG

RR

SS

XX YY

NNMM

PP

LL

FF

EEDD

AACC

K J

H I

ZZ

WW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

B

A

Size of foundation areaSize of pool

12" (30 cm)

9

!Important:Determine thelocation of yourpool. Make sureyou have theproper distancesaway from anyadjacent structures(i.e. fences, houseetc.). Contact localauthorities for thisinformation andany additionalrequirementsgoverning theinstallation of apool in your area.

By using the dis-tances provided bylocal authoritiesand adding themto dimension Sfrom the drawingsabove, you cancalculate thelocation of thecentreline of thepool.

Page 6:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

Pool Size Length of String

12' x 18' 84" (213 cm)12' x 24' 84" (213 cm)15' x 24' 102" (259 cm)15' x 30' 102" (259 cm)18' x 33' 120" (305 cm)

c. Join the two pegs (A) and (B)with a piece of string. Use thisstring as a guide to paint yourcentreline on the ground withthe can of spray paint.

d. Drive a flat-topped stake (C)exactly halfway between thetwo pegs (A) and (B) on thecentreline. Stake (C) will markthe exact centre point of yourpool. The stake must be atleast 1" (25 mm) square and 6"(15 cm) long. Drive it downflush with the ground surface.

e. Replace the two pegs (A) and(B) with two more flat-toppedstakes. Drive them down flushwith the ground surface.

f. Join the two circles withstraight lines to make an oval.Use pegs and a piece of stringas a guide for the can of spraypaint.

1-6

10

B

A

C

11

!Important:Measure carefullyto make sure thecentre stake (C) isin the correctlocation, exactlyhalfway betweenpegs (A) and (B).You will use stake(C) later as areference point forother measure-ments.

B

C

A

12

Page 7:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

g. Mark areas along bothstraight sides of your oval. Usepegs and string as a guide forthe can of spray paint to markstraight lines. Use the chartbelow to find the correctwidth W from the centrelineof the pool. The ends of theside areas should line upsquarely with stakes (A) and(B).

Pool Size Distance from Centreline for Side AreaW

12' x 18' 96" (244 cm)12' x 24' 96" (244 cm)15' x 24' 114" (290 cm)15' x 30' 114" (290 cm)18' x 33' 132" (335 cm)

3. Remove the Soda. Remove all sod and plants

from the area.

b. Remove any sticks, stones androots from the area.

4. Make the Area Flat and Levela. You will use a 2-by-4 to help level the pool foundation area. Choose the

length of straight 2-by-4 you need for your pool from the chart be-low.

Pool Size Length of 2-by-4

12' x 18' 84" (213 cm)12' x 24' 84" (213 cm)15' x 24' 102" (259 cm)15' x 30' 102" (259 cm)18' x 33' 120" (305 cm)

b. Adjust the height of the stake (A, B or C) that is located at the lowestend of the pool area by hammering it down until it is exactly levelwith the ground. Place a carpenter�s level on a 2-by-4 and place theboard across the three stakes to make sure the tops are exactly levelwith each other. Adjust the other two stakes down as needed.

1-7

B

A

W

W

C

13

B

A

C

14

Remember:Your pool must beperfectly level.Take the time youneed to be sureyour foundation isperfectly level.

Page 8:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

c. Nail one end of the 2-by-4 tothe top of the stake where thelevel of the pool foundation islowest. Drill a hole for thenail in the centre of the top ofthe stake first and make thehole big enough so the nail isa little loose and can be re-moved without moving thestake. Mark the centre of thestake before you drill the holeby marking lines diagonallyfrom opposite corners (seediagram 16). Use a nail longenough to hold the end of the2-by-4 to the stake while yourotate it in a circle.

d. Put a carpenter�s level on the2-by-4 and swing the board ina circle to find the high andlow spots.

e. Remove all the high spots witha shovel, hoe or rake. Be pre-pared to hire earth-movingequipment if you need to levela large area. Remember, yourpool must be level within 1"(25 mm) across the pool. Ifnecessary, adjust the height ofthe stake and keep scrapingaway soil until the area islevel.

1-8

BB

AA

CC

18

!Hint:Use a surveyor�stransit instead of acarpenter�s level, ifone is available.

BB

AA

CC

Hole

Centreof Stake

17

15

16

BB

AA

CC

19

20

Page 9:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

f. Do not fill in low areas. Fillingwill create an unsafe founda-tion for your pool. Holes fromsmall stones and small dipsand hollows may be filled in,but the soil must be hard-packed with a tamping tool.

g. Remove the 2-by-4 from the stake and nail it to the next stake on thecentreline.

h. Repeat the last five steps until the whole oval area is level. Take yourtime and make sure the area is perfectly level. Remember, yourpool must be level within 1" (25 mm) across the pool. If necessary,adjust the height of each stake and keep scraping away soil untilthe entire area is level.

i. Make the wide areas along the sides of the oval level with the restof the area.

j. Re-check the outer 12" (30 cm)of the round ends, where thepool wall will be, and the areasalong the straight sides of theoval. Make sure there are nohigh or low spots. The bottomedge of the pool must rest flaton the ground and have nogaps under it.

5. Add Corner Stakesa. Prepare eight corner stakes (D), (E), (F) & (G), and (H), (I), (J) & (K) by

marking the centre point of each stake the same way as in step4(c).

b. Drive the eight corner stakesinto the ground. Drive themdown flush with the groundsurface. Locate each stakeexactly by using the measure-ments for your pool in thechart below. Be sure to meas-ure using the centre point ofeach stake.

c. Tie strings between stakes (H)and (I) and between (J) and (K).Pool Size Distance X Distance Y Distance W Distance Z

12' x 18' 72" (183 cm) 80-1/2" (204 cm) 96" (244 cm) 102-1/2" (260 cm)12' x 24' 72" (183 cm) 101-3/4" (258 cm) 96" (244 cm) 120" (305 cm)15' x 24' 90" (229 cm) 105" (267 cm) 114" (290 cm) 126-1/8" (320 cm)15' x 30' 90" (229 cm) 127-1/4" (323 cm) 114" (290 cm) 145-1/4" (369 cm)18' x 33' 108" (274 cm) 140-5/8" (357 cm) 132" (335 cm) 159-3/4" (406 cm)

1-9

21

Remember:The outer 12"(30 cm) of thecleared oval areamust be perfectlyflat. The bottomedge of the poolmust rest flat onthe ground andhave no gapsunder it. Take thetime you need tobe sure this area isperfectly flat andlevel.

BB

AA

CC

12"(30 cm)

22

!Hint:Instead of woodencorner stakes, youcan use 12" (30 cm)spikes.

BB

GG

FFWW

ZZ

EE

DD

H

I

J

K

AA

CCXX

YY

23

Page 10:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

6. Prepare Buttress Trenchesa. Locate the first trench by mea-

suring the distance M fromthe centre of stake (H) to thecentreline of the trench. Usethe chart below to find theright distance M for your pool.

b. Place a stake in the groundon the edge of the clearedarea at distance M,underneath the string addedin step 5(c).

Pool Size Distance from Stake Distanceto Trench Centreline between TrenchesM N

12' x 18' 36" (91 cm) n/a12' x 24' 24" (61 cm) 48" (122 cm)15' x 24' 30" (76 cm) 48" (122 cm)15' x 30' 30-1/2" (77 cm) 59-1/2" (151 cm)18' x 33' 30-1/2" (77 cm) 59-1/2" (151 cm)(n/a = not applicable)

c. Repeat steps (a) and (b) tolocate the next trench alongthe side of the pool. Measurethe distance N from thecentreline of the first trench tothe centreline of the nexttrench. Use the chart above tofind the right distance N foryour pool. (Important Note:The 12 x 18 pool has onlyone trench per side; the 15 x24 pool has two trenches perside; the 12 x 24, 15 x 30 and 18 x 33 pools all have three trenchesper side.)

d. Place another stake in the ground on the edge of the cleared areaat distance N, underneath the string added in step 5(c).

e. Repeat steps (a) to (d) for the other side of your pool.f. Tie a string between each pair of stakes on opposite sides of the

cleared area (the stakes added in steps (b) and (d), above) to markthe centreline of the trenches.

g. Mark the centrelines along each string with the can of spray paint.h. Recheck your measurements. Make sure the distances M and N

exactly match the distances given in the chart above (see alsodiagram 26) and that the centrelines for the trenches are exactlyparallel.

i. Remove the strings. (Note: : : : : Keep the strings. They will be temporarilyreplaced later, after the trenches are dug out, to help you double-check that the trenches are parallel.)

1-10

H

I

J

K

BB

GG

FF

EE

DD

AA

CC

MPainted centreline

of trench

24

H

IBB

GG

FF

EE

DD

AA

CC

N

M

M

J

K

25

Page 11:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� ������

�� ���������

�������

�������

��������

���������

����������

���� �����

�����������

�����������

�����������

������ ����

������������

�� ��������

���������� ������������������� ����������������������������������

����������������

�� �������������������������� �

����������������������������

��������������������������

�������� ��������������� �

� �������������������������

� !����������������������

��������������"���������#$%&

�'(��������������������������

����������������)���������

��)��������������������������

'*&�+�'*&��"�����+�*&��������#,�+

#,�+�-��������������������������

�����������.��������������

����������������������������

���������������������������

�� /�������������������������

��������������"���������'&��*-

����������������������������

�����������.���������������

��������������)���������

�� 0�������������.���������#*&

�1'2���������������������

���������������������������

�������������������"��������

�������������������������������

������������������ ����������

�������������������������������

��������������������34������

�����������������5.����������+�

�� ��������������������������

'4''

20" (51 cm) 20" (51 cm)

6" (15 cm)

5-1/2" (14 cm)

36" (91 cm)

4" (10 cm) to faceof patio stone

Pool Wall Line:Line between

stakes D and Eor F and G

(N.B. the pool wallwill lie on this line)

Painted centrelineof trench

Concretepatio stone

��

Concrete patiostone

Concrete patiostone

Trench

Crushed limestone (or equivalent) base3/4" (19 mm) in bottom of trench

Crushed limestone (or equivalent) base3/4" (19 mm) in bottom of trench

��

��

�������

������������������

�� ��������!

"���������������

������������������

��� �������������

�������������

�������������

���"����������4

� ����������������

���������������4

�������

Additional crushedlimestone (or equivalent)

layer 1" (25 mm) thick

�#

Additional crushedlimestone (or equivalent)sloped up to top surfaceof patio stone

Additional crushedlimestone (or equivalent)sloped up to top surfaceof patio stone

Slope starts hereat point ASlope starts hereat point A

AA 32" (81 cm)

Pool Wall Line:Line between stakes D andE or F and G (N.B. the pool

wall will lie on this line)

4" (10 cm)

$%

!&����

����'������������

����"������������

������������������

�������������

�������������

����������������34

������������

������

����������

���������������

����������������

����"����������

�������������������

�������������

�����������

�������

6������������

����������������

�������������

��������������������

���������������4

������������������4

������������

���������������4

���������������

�������������

�������������������

�����������������

��������������

������

Page 12:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

���������7�������������������.������� .��������������������������

��������������������������������������������������������������

7����(�� ����)��� ���� ���������������� �������������������������

�������������������� ������������ ������������������������������

���������������������������������������������������������

* +����'����,��"�����'�������"��)������(��(��,��)�����'�

���������������������'��-�����������(�����������-�������.

�. /�����������(����'��0���1!�'������� )�������������34����������

5������������������������������

������������������������������

�����34������������ ���

�+�������������������� ����

�������������������������

�� ���������������������

34�����������������������

�� �.�������������������

�����**4'$*&��-52������������

����������������34����������

������*%&��8'��������������9�

������������������������

�� �����������������������

�����34��������/���������

����������������������"����4

���������������"��������������

������ ����������������������

���������������������������4

������0������������������������

������

�����+�2� ����������

0 �

'*:�+�'1: #$1&��',���� #$%&��'(����

'*:�+�*%: #$1&��',���� #$%&��'(����

'-:�+�*%: '$*&��'#���� '&��*-����

'-:�+�#,: '$*&��'#���� '&��*-����

'1:�+�##: -$1&��'8���� '4'$%&��#*����

'4'*

!&����

0����������%1&��'**

�������������9�

�����������.

����������������

�����������������

�����%-4'$%&��''-

����������������

�����������

34�������

Wooden Block (dim. B)

Wooden Block (dim. C)

Optional 48"(122 cm) Level

24" (61 cm) Carpenter’s Level

Align end withbase U-channel

22-1/2" (57 cm)

45-1/4" (115 cm)

22-1/2" (57 cm)

45-1/4" (115 cm)

Pool Wall Line:Line between stakes D and E

or F and G (N.B. the pool wallwill lie on this line)

$$

base U-channel

patio stone4" (10 cm)

32" (81 cm)A

Pool Wall Line:Line between stakes D and E

or F and G (N.B. the pool wallwill lie on this line)

$3

$�

5

5

!&����

3����������������*4

�4%������������

�����!�������

����������������

�����������������

������ ��������

�����

Page 13:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

'*

Inside of Pool

-

#

'#

%

'#

'-

'5

#

5

'*

'

%

*

'1

-

*

''

8

'8

8

-

'*

'*

1

',

(

1

',

'%

*%

''

*%

������������

4(��(��,��)

0�������

�����-�

'4'#

�� ����� ���� ����� ��� �� �

5 6����34������ '%%,##- *

' 3��� ��������� '%%,*5* *

% 0������;<=�6������ '#*,'%5 %

# ������;�=�6������ '#*,'#1 %

* >�������;�=�6������ '#*,'#( %

'' ?���@����)����'-&�+�#,& '#*,'88 %

1 !���� ��������������

'# �������6������ �� ��������������

'% 6����)��� ��������������

'- <����A���������� '#*,'%* *

'8 � ���A���������� '#*,'%* *

'5 A������ ��������������

'1 ����)��� ��������������

#, !�����6������ '#*,'8% *

�� ����� ���� ����� ��� �� �

4 ��������� ���� ����� ''1%*(# '

�� ���� ���� �� ����������� � ��� �� ���� ����

( '$%&4*,B��+�#$%&���+���� ''1%*5- *%

', '$%&4*,B�������������� ����+���� ''1%,-* '8

- #$1&4'8B��+�'&���+���� ''1%*#5 5*

8 #$1&4'8B�������������� ����+���� ''1%*#1 5*

'* B���'*�+�-$1&����4������ ������ ''1%',- '1

*% '$%&4*,B��������� ''1%*51 1

(

'*

#,

'*

'*

'#

Page 14:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������'4'%

Page 15:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� �������������������������������������������������34�����������

���������

�� 3����������������9��������

����������������������������

��� ����#%�������� ����

���������������������������

����������������������������

���������������������������

!�������*���0�����������.���������

34����������������������

����������������������������

�"������������������������

���������

�. �����-���0����������� /��������������� ���������

����'������������4����������*

����#����������<4���������%�

���������������C��������.���4

������������������������

���� ��� ������������-�����

���������8����������������

������������������������������

�4�����<4���������������������

���������������������� �������4

������������� �������������

����6�����������������������4

�� ���������������������4

����<4�������������� ��

������������ ������� ��������4

�����������4�����������������

����������������������

��������������������������

, ��������������������������

���� �����������

�� ����������������������������

���������������� ���������

�����������������4�����<4

������

'4'-

radiussedcorner

-

#

%

'

*

8

$5

!&����

3��������4��������

���������������� ��

��������������

������������4������

Make sure thispoint is

level with the resof the cleared area

exactly

Line betweenstakes D and E

or F and G

$6

Page 16:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� 0���������

���� ��

������

�����4����

<4����

������

�����������

34������

����5������

������������

�������� ��

������

�������

����������

���������

��������

<����������

��������

��������������������������-���������������8������������ ��������

��������

�� �����������������������+������'$'8&��*����� ��

��������������������������������������������34

���������������������������������������

�� D����.��� ����������� ����������������������������������������� �������4

����!�����.��� �����������������������������������������������������34

��������<���.��� ��������������������������������������������� ���

#8���/�������������������������.�������������������4�����<4�����

� �������������� ����������������� ������ �����������������������

��� ����#8���3��������������9���"�������������������������� �������4

����������������34��������������� ���"'�!�"��������������������

������ �����������������������

�� ��������������������������������������������������������������������

������������������������������������34��������� �����+������������

������� ����������������������������������������5���������������������

����������������������� �������������������������� �������������������

�����������������������

� ����������������������������������������������� ������������34��������

# 7�����'��0���1!�'������� ��������� ������������������@�������E���������������D�������F��������

�������������������������������������������������������������+4

�����������������������������!����������������������������������

������������ ���������������������������������������� ��

'4'8

�������

D���������������

������������ ����

�����������������

����������������

��������������

����

!&����

<������������

34�������������

��������������������

����������������

��������34������

�����4������

1/16"(2 mm) gap1/16"(2 mm) gap

$�

carpenter’s square

push the L and Tplates against theupright channel whiletightening the bolts

tighten these eight boltson each side of upright channel

first

tighten these four boltson each side base of U-Channel

second

tighten these six bolts oneach side base of U-Channel

last

8

-

5

$�

!&����

/����������(���

������������ ��'4'-

���������������

5��������������

3����������������9�

����������������

������������������

��� ����#%���

���� ���������

���������������

���������������

����������������0����

������.���������

34��������������

���������������

����������������

�����"������������

��������������4

�������

Page 17:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� G�������!�������*��������4

�����������'�����������������

����������������������

��������������������.��������

����������������������������

�������������������������

����������������������/����!

����������������������'���

���������������.���������

�������������������(���������

�������������������������

!�������*������

�� D�����������34��������������������������������

������������������������������"����������D������

���������������� ���������������34���������0�����

���������������������������������������������

���������������������!�����������������34������

����������������������������������������������

������������������� �������������34����������

��� �������������������������34�����������

����� ���/���������������������������"������

������������������������

��������������������34������

��������������������

���������������������"����4

������������� ����%,��

�� ��������������������������������������34�������������������

������������������������������������������� �������� ��� ���������

����� ��'4',.�!����8�������������������

3%. �/������+������+����0����������&������,��������� 8���� ��������������������������������������������

�� @� �������������������������

������������������������

34�������.��������������

���� ����������������������

����������34�����������'8&

�%'�����������������������

����������34�������

�� @� ���������������.�#&��1����

��������������+������'4'$*&

�%������������������������

���������������������������

��������������������34�������.

�� �������������������������

����������.���������������������

�����������������

baseU-channel

baseU-channel

hard-packedcrushed

limestone

$#

'4'5

!&����

3����������������*4

�4%������������

�����!�������

����������������

�����������������

������ ��������

�����Curved bottom buttress rail

must be installed between buttressesCurved bottom buttress rail

must be installed between buttresses

$�

!&����

����'������������

����"������������

������������������

�������������

�������������

����������������34

������������

������

����������

���������������

����������������

����"����������

�������������������

�������������

�����������

Make sure the space under the end ofthe base U-channel is completely filledwith crushed limestone (or equivalent)

6%

16" (41 cm)16" (41 cm)

63

�������

6������������

����������������

�������������

��������������������

���������������4

������������������4

������������

���������������4

���������������

�������������

�������������������

�����������������

��������������

������

Page 18:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� 3��� �������� ����� ���������

�����������������������

������.���� ���� ��������

�� �����������������������

����������� ���������������

���������34��������0�����������

���.��������������������

���������������� �������!����

�������������34����������

������������������������

������ ������A��������� �����

�������������������34������

�������� ���������� ����� �

��� ����������� ��������������34�������� ����� ��������������������

���� �������������

�� !������������4���������*%���������������������

��������������������������� ����%#��������

��������������������������������������������

�������������������������4�������������������,��

�� G���������������������������1�

�����������������������#,������

����������������������������

���������������<����������

�����������������������������

������������ ����%%�����

��������� ������������������+

��������������(����������

���������',����������������

��������������������������

�������������'���� ��������

�����

� <����������������������������

���������������������������

����������������� ����%-�

����������������������*%����

��������������������34������

����5��������������� �����

������������+���������������(�

�� ����������������� ����

������������� �����

�� ������������������ ���������

������������ ����������������

�������������������������������

��������

'4'1

!/��������

D���������������

������������

����������������

��������������

�������������

�����������������

��������� �����

�������������������

�����������.������4

�� ����������������

��������������������

����

Use a hold down plate to dragthe area to either side of thebase U-channel smooth and level

Use a hold down plate to dragthe area to either side of thebase U-channel smooth and level

Stand on thebase U-channelStand on thebase U-channel

6�

6$

*%

66

1

',

(

#,

65

(

5*%

Page 19:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� !������#$%=

�'(�������

�������

��������

�����"����4

���������

������ ����

������������

��������

����

��������������������������������

@�����������������������

�������������������������34

��������)����������������

�������������������� ����%5

�������������������������4

�������6� ���������� ��������

���������������������������

�������������������������4

����%(�.�����������������

����� ��������������������

��������������������������

�����������������������������

34�������������������������

���������������������������

������������������������

�������.�������������������

���������������������������

��������������������������

�������������������� �������

���������������������������

�����������������������

/�����������������������

������������������������

��������������������������

������������',��������������

����������������������������

������������������ �����

������������������������������

�����������

'4'(

baseU-channel

baseU-channel

Hard-packedcrushed

limestone

Hold downplate

Dug out areafor hold down

plate

6�

''

shift the hold down plateback and forth to make it settleshift the hold down plateback and forth to make it settle

6�

6#

''

5

''

Hold down platesmust lie flat in bottomof dug out area

Hold down platesmust lie flat in bottomof dug out area

6�

Page 20:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� <��������������������������

�����������������������������

����������������� ����-,�

��������������������������34

�����������5������������

������������4������ �������

����'*��

�� ����������������������

�������������������

34������������������ �����

��������������������������������

������������������''��������

�����34�����������5���!������

���������������������� �

��������������������������

������<����������������������

����������������������

��������������� ����-*�����

��������������������������

�����������'*����� ���������

�����������

� ���������������������������

�������������������������

'4*,

set the second hold down plate so theflanges ovset the second hold down plate so theflanges overlap

53

5�

''

5

''

',

5$

'*

'*

5%

'*

5

!&����

7�������� �������

����������������

34��������������

��������������

����.�����������

����������������

�����������������

����������������

�����������������

����������

Hold down plate

Bolt heads

Basechannel

Strap StrapBracket

Page 21:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

��G����������������������������������������

���������������������1���� ����������������4

�� ���������.������� �������������������������

�B��������'*�+�'1�����'*�+�*%�����������������

����������������������<�����������������������4

������ �������������������������(��������������4

���������������',�������������������������������

�������������������������'���� ��������������

�� ��������������������� ��������������������������������������������

��������������� ������������������������������

33.�9���(���'�������"������������ ������������������������ ����������������������������/�������6������

���������������������������������������������������������������

��������������"����������<�������������/�������6������������������

�����������������������������������������

56

11

',

(

'4*'

Page 22:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

3. /�������'�����(���0������9����� E����������������.���������������������������������������������������

����'#����������������������������������������������������������

3�����������������������������������������"������������������������

������������������������������������������������������������������

�����+�2� :����� �����������������;,��'��������-���.<

0��������9�� =���������9���� =���������9���0 >���9��

'*:�+�'1: �$� %���� �$� 1�����

�����'%8,,#'� �����'%8,,*(�

�����'%8,,('� �����'%8,,1(�

'*:�+�*%: %������ %���� �$� 1�����

�����'%8,',-� �����'%8,',1� �����'%8,,*(�

�����'%8,',8� �����'%8,',5� �����'%8,,1(�

'-:�+�*%: *������ %� ���� �$� 1�����

�����'%8,',-� �����'%8,,##� �����'%8,,#,�

�����'%8,',8� �����'%8,,(#� �����'%8,,(,�

'-:�+�#,: %� ���� %� ���� �$� 1�����

�����'%8,,##� �����'%8,,##� �����'%8,,#,�

�����'%8,,(#� �����'%8,,(#� �����'%8,,(,�

'1:�+�##: %� ���� %� ���� %� ���� 8�����

�����'%8,,##� �����'%8,,##� �����'%8,,##� �����'%8,,#'�

�����'%8,,(#� �����'%8,,(#� �����'%8,,(#� �����'%8,,('�

��$��H��������������������H���������������

����'1�+�##

����������

�����C�

���������

������

�������

������@��4

����'

���������

��������

��������

����

*4'

+>�=/4?���������������/��������������

������������ ���

��������������������

End rails

Buttresses

Transition B rail

Transition B rail

Transition A rail

Transition A rail

Buttress rails

3

Page 23:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

1/2" (13 mm)gap1/2" (13 mm)gap

��

��

��

��

��

��

��

��

���

No

Yes

!�� ��

������ ����

����� ���������

������������ �

������� �������

�� ���������

�������������

�����������

��� ���������

���������� �����

!�� ��

��������� ��� !

"�#��$�������

���������������

������%&��������

������� ������

������������� '�

������������

�� ������&��

�������&����

� �������

�� ( ������������������������

�&����������� � "��%��

��)����*� ����� ��� ���"�$

������ ���"�$$�+��������

���� � �����������������

�������������,��� ������

����)����� ���

�� ( ��������� ����� ���������"��%

��$�-���������������������

�����������������������

" ��������� ����$�� ����

������������������&����

�� ������"��%��$" ���������

�.���/$�������� �������

���%�� �����������������

���� ������� ��� ���������

���������� ��������� ������

�������)��������������" ��

������� 012$�

�� -���������������������� ���

��� ���������������&������ �

�����"��%��$�

�� (�%����)��� *�������

� ��������� ����� ���������"��

%����)��%����� �3������

����� ���"�$$�4��)�����!

"��#��$������&�������

��������� " �����������

������)��� ����������

� *������$�

�� 4�%������������ ���� �

����� ��������� �� �����

���������5 ���������� ����

�������������������� ����"6$�

��� �������� �������������

�������� ������������

������ ��� ���� ���� ���

" ������ ������������0$�

" �������� ���&�����&����

��������� ���� ����� ����

���� �$

�� ( ������

� !�������

4��)�����!

"��#��$

������

�&�����

�� �����

���� �

Page 24:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� 7������������������

��� ��%�� ���� ����������

�� ����������������

��%��������8���� ��� ��!

"�/#��$ �������������&���

���+��%������� ��������

����� ������� ������ �

&������ �������������5 �

�����������' ��)��������

����������� ��� �����������%��)������� �&������������5 �

�����������' ��)��������%�����&������� ��� ������ ���

��� ��� �����)��&�������������

�� 5 ����������' ��)��� %��� �����������)������������������

������ ��)���

9� :���)�������&���� ���� �������������

�" � ������#����$���%������ +��)����������� "��%�0��

�2$��� �������9�������

�����������������������

������� �����������

������������ ����� ��

����������

�� ;� �������������)�������

����"��%�0$&����&� ��������

��� ���& "��%��$�����

�� �5�������" ������������

���)������������ ��������

&��%������������&��!

������������������$

������� ���� ������ ����

���������� ����)�����������

� ��&���������0���

� ����������� �����)�������

���������2��������%&����

����%����)��(�%���)�������

����������$'����������������<

��=�� ��������������

�������>������'������� � �

������������� ��������

�� +�������� ���& �

�� :����� ��� "�$��"�$������

���������)�����������"��%

�2$�

�� :����� ��� "�$��"�$�������� ������������ � �

���

��

! ����

(�%��&������

����� ���

������������

�� ���������

��%������

� ������ ������

�����%��������

������������%�+��

����� ��� ����

������ �������

������ � ����

��� ������� ���

�������� ���

�)���%����'�

��)���������

������ �

(�%��&�����

������� ��

����� ��� %��

������$���'�!

������� ����!��

?�����!*��!"�/*

�/��$ ���������

�!"0��$������

�����������&���

��� ������� ����

����������&

�����-���%���

��� ������� ���

&���&����� %��

��������&�

��

�0

��

��

�2

B

A

�� ��

�0

�2

!�� ��

8����������

��������������

����������� �

����������*�

�� ������ ����

����������������

������ ���������

����&����

vertical profile X

vertical profile Y

Page 25:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�" (����!��������$)�(� !�� ,��� ����% ���&������

���� �������������)����

&��� ���� �%���������

��)����&�������������� ��

�� ;������������������ ����

������%&������ ������� ����

�� -��������%������������

��"������� $�)�����

��������������!#"0#��$

�����5 ������������������� �������� ������� ����!���

����� ���%����� ��!�������!"�0��� #��$����� ���� ��

�%�������@����� ���� ������:���)����-�%�������������&���

� � �������:�� ������� �%������ ���� ��9������&�������

�����������&��������������� ����:���������&�������

�������&����� ���� ������������� ���������-�%�������

�" *��$��!����(�$��� ���� @�����&���-��������� �����%��������������� ���������

�!!���� ���� ��������� �� +������� �����&���������������&���

���� ������� �-����� �����

�� +���� ���������� ��-��������������������%�������� �

�����%����� �� ������%��������

��

���������

-���������� ��

�� ���� ��

�%����������)��

������������

������������

� �������� �

���� �+�� ���)���

���������)� ���

��������������

�������� ���

Page 26:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

(Retainerforbeadedlineronly)

2

3 4

SECTIONPool Component Installation Manual

Assembling the PoolWall & Liner

3-1

3

Caution:Do not attempt toinstall the pool wallin the wind. Wait fora calm day.

1Remember:For best results,mount the skimmeron the downwindside of the pool(that is, directlyacross from themost common winddirection).

Locate the skimmeron this side

Wind

Hint:Secure the slottedtube connector tothe wall with a pieceof duct tape afterinstallation to pre-vent it from lifting offthe wall.

Hint:Bring the followingitems onto the poolfoundation beforeyou start uncoilingthe pool wall: thepool liner, someextra brick sand tomake the cove inStep 5, and a ladderto climb out after thewall is assembled.

A. Assemble your Pool WallThis section is for Round and Oval pools (Round pools are shown).

1. Set the Pool Wall in placea. Wait for a calm day. Do not attempt to install the pool wall in the

wind.

b. Unpackage the coiled poolwall and stand it on a pieceof cardboard or plywood atthe centre of the pool. Thecut-outs for the through-the-wall skimmer should be to-wards the top of the wall.Look for a �THIS WAY UP� labeland arrow.

c. Start uncoiling the wall, guid-ing the bottom edge into thecurved bottom rail. The start-ing end of the wall must bepositioned over a baseplate, and the skimmer andreturn holes should be posi-tioned where the pump andfilter will be.

d. Set lengths of slotted tubeonto the top edge of the wallas you uncoil it and join theslotted tubes with connectorsas you go, leaving a 1/2" (13mm) gap between each.Make sure the gap is directlyabove the base plate (thisapplies to round pools, ovalpools and Gibraltar Stylepools). (If you have a beadedpool liner, set lengths of linerretainer on the top edge ofthe wall first, then the slottedtubes and connectors.)

Page 27:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

e. Work around the foundation until the entire pool wall is uncoiledinto the bottom rails and the top edge is covered with slotted tubesand connectors (and beaded liner retainers if you have a beadedpool liner).

2. Join the Ends of the Pool Walla. Line up the holes in the two

ends of the pool wall.

b. To line up the holes, make the circle bigger orsmaller by nudging the base plates in or outwith your foot.

c. Join the ends of the pool wallwith a bolt and nut througheach hole. Place each bolthead towards the inside ofthe pool and each nut to-wards the outside.

d. Tighten each bolt and nutsecurely.

e. Cover the seam and boltheads on the inside of thepool wall completely with 2"(50 mm) duct tape.

3-2

Remember:The bolt heads mustbe toward the insideof the pool. Cover thebolt heads with ducttape.

Hint:Stick a screwdriverthrough two of theholes to help line upthe ends of the wall.

7

5

6

8

Page 28:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

12

3-3

3. Make sure the Pool Wall isLevela. Use a length of string and a

line-level to check across thetop edge of the pool wall tosee if it is level. Check thewall in several different di-rections. The wall must belevel. If the level is off bymore than 1" (25 mm) acrossthe diameter of the pool, takethe wall apart and level thefoundation again.

4. Make sure the Pool Wall isRounda. Using a tape measure, meas-

ure across the circle at eachbase plate. The pool wallmust be round within 1" (25mm) (all of the measure-ments must be within 1" (25mm) of each other). Adjustthe circle by nudging thebase plates in or out withyour foot.

b. Adjusting the pool to the proper shape maycause the base rails and base plates to slip outof alignment a little. Recheck all of the baseplates to make sure each one is centred wherethe base rails meet.

5. Install the Styrofoam Sheets (optional)a. If you chose the option of using Styrofoam instead of brick sand,

you can now install the sheets of Styrofoam previously cut out inStep 1a. Reassemble the sheets in the centre of the pool and jointhem with duct tape along the whole length of each seam. Re-member to wait until the pool wall has been installed in Section 3before installing the Styrofoam.

11

Caution:The pool must belevel within 1"(25 mm) across thediameter. A poolthat is not level isdangerous and maycollapse.

9

10

Page 29:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.3-4

Caution:The �Wall-Saver�gasket is importantfor protectionagainst corrosion.Failure to install thisgasket properly onthe cutout for 6" or12" skimmers mayvoid the warranty ofyour pool wall. If thegasket is damaged,get a replacementfrom your pooldealer.Note: The "Wall-Saver" gasket is notrequired or providedfor walls using 14"skimmers.

16

Hint:If possible, unfoldthe liner on the grassone to two hoursbefore installation.Be careful not toleave the liner toolong or you maydamage the grass.

13

Remember:The cove is animportant part of thepool structure. Takeyour time to make acomplete, full-sizecove.

17

14

15

6. Make a Covea. Make a curved cove about 6"

(15 cm) high and 8" (20 cm)wide all around the bottomof the pool wall on the inside.

b. Use fine earth or brick sandto make the cove, and packit firmly into shape.

7. Install the �Wall-Saver� Gasketa. The Wall-Saver gasket pro-

vides a water-tight sealaround the skimmer cut-outfor the through-the-wall skim-mer. Gently spread apart thetwo layers of the gasket andinsert it into the skimmer cut-out so that it sandwiches thewall. Be very careful not totear or damage the seam inthe gasket or the gasketmay leak. Take extra carenot to cut or damage thegasket when you are install-ing the skimmer later. If thegasket is damaged, youmust get a replacement fromyour pool dealer.

Note: The "Wall-Saver" gasketis not required or providedfor walls using 14" skim-mers.

B. Install your PoolLiner1. Set the liner in place

a. Open the carton. Do not useanything sharp to open thecarton.

b. Unpack and unfold the linerand spread it out in the sunto warm it up. Inspect all theseams and surfaces for holes.

Page 30:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

18

19

c. Spread out the liner, smoothside down. The curved seamshould be centred on thecove at the base of the wall.The other seams will formstraight lines across the bot-tom of the pool.

d. Smooth out all the wrinkles inthe bottom.

2. Fasten the Liner in place(Overlap Liner only)

This step applies only if you have an OverlapLiner. See the next page if you have a BeadedLiner or V-Bead Liner.

a. Lift the sides of the liner and drape them overthe top of the pool wall. If you have a 52" (132cm) high pool, pull the liner up until there is 2"(5 cm) overhang; if you have a 48" (122 cm) highpool, pull the liner up until there is 6" (15 cm)overhang.

b. Fasten the liner to the top of the wall with plasticcoping. Let the liner hang slack for now. Do notpull the liner tight.

c. Start filling the pool with water. As the pool fills,work out all the wrinkles and smooth the liner tothe wall. Remove the plastic coping around thetop edge of the wall one piece at a time andadjust the liner. Keep smoothing out the wrin-kles.

3. Trim the Plastic Coping and Roll Up the ExcessLinera. After all the wrinkles in the liner are removed,

trim any extra length of plastic coping so thereis no overlap.

b. Roll up any excess liner hanging below theplastic coping and tape it in place near the topof the pool wall. Important: Do not trim off theexcess liner.

3-5

Remember:Do not trim off theexcess liner. (If theliner ever needs tobe removed, trim-ming the liner willmake re-installationvery difficult.) In-stead, roll up anyexcess liner andtape it in place nearthe top of the poolwall.

Hint:To smooth out thewrinkles in step 2(c),use a vacuumcleaner: block theskimmer outlet withcardboard and tapeand put the vacuumhose through theskimmer return hole,between the linerand pool wall. Sealthe hole with tapeand keep the hose 4"to 6" (10 to 15 cm)above the sand coveso you don�t suck upany sand. Start thevacuum and run ituntil most of thewrinkles are gone.Then, stop thevacuum and add 1"(2.5 cm) of water tothe pool. Finally,remove the vacuumhose and unplug theskimmer hole.

20

21

Page 31:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

22

23

3-6

24

25

4. Fasten the Liner in place (Beaded Liner only)This step applies only if you have a Beaded Liner. See the previouspage if you have an Overlap Liner or below if you have a V-BeadLiner.

a. Lift the sides of the liner andinsert the beaded edge intothe liner retainer on the topedge of the pool wall.

b. Start filling the pool withwater. As the pool fills, workout all the wrinkles andsmooth the liner to the wall.

5. Fasten the Liner in place (V-Bead Liner only)This step applies only if you have a V-Bead Liner.

See steps 2 and 3 if you have an Overlap Liner,or step 4 if you have a Beaded Liner.

a. Remove the slotted tubes andconnectors from the top edgeof the pool wall. Important:do not remove all of the slot-ted tubes at once; removeonly two lengths of slottedtube at a time.

b. Hook the V-bead over theedge of the pool wall.

c. The space between the endsof the slotted tubes at the topsof the locations where theverticals will be attached,should be about 1/2" (13 mm).If you have a Gibraltar OvalSystem , refer to page 2-6,step 2 in the Gibraltarmanual.

d. Replace the two lengths ofslotted tube and connectors.

e. Repeat steps (a) to (d) untilyou have gone around theentire pool and finishedattaching the pool liner inplace.

f. Start filling the pool with water. As the pool fills, work out all thewrinkles and smooth the liner to the wall.

6. Proceed to Section 4a. Continue with Section 4 to finish assembling your pool.

Page 32:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�!!���� ���� ��������� �� +������� �+���(�$��� ��

,'� �-���$�������(�$��� ��.�*�����.��!!��'��+����&� /�������

�� (�� ��������������������&������)��%�� ��������������'�� !����

���������� �������������������� ����6 ���&���� ���������

���������������������� ��� ���������������������*������%

���!"����$������&��������������� ������������ ��%������

�� 6�������&���� � �������������������������������� ������

������ ���&��������������� ����0����� �3�"������ ��%

������� � ������% ��������������������!"��#��$���������

%������� �3�$�:���������������� ������ ������ ���������

� ���������&������� ����� �

�� 6�����������&����� ���� ����������������� ���� �����

�� ������ �1�)���������������� �����������)���������

���%����������������&���&������� %����������

���

���������

?��������������

&������������!

"�/��$��&����

�������)�������

����� �����

������� ������

���������

Page 33:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� ���������������������������0

Buttresses

Slotted end tubes

Transition A slottedtube

Transition B slottedtube

Transition B slottedtube

Transition A slottedtube

Buttressslotted tubes

18 x 33 Pool

��

!�� ��

5 ����!"0��$

����������������

��������� ��

���2!"�0��$

����� ����������

��������)�����

���������� ��

����������&����

+�� &������)��

��� ����������

������)������

������� ������

����

!�� ��

5 �����������

������������

������ ��������

�����%�����������

&��������������

��������� �������%

�� �����������

!�� ��-����� ��� ����������������� �����&���&��������������� ��������� � �������� �����)����������������� ���&����

,'� �-���$�������(�$��� ��.�*�����.������$��(�����2!3�&��'��'��+����&� /�

�" (����'��*����,����� ����$��� +�� ���������� ���������������� ������&��������������

5 �������������&������ �����%�� ���������� �� ����������

���%�������"����� ���� ��&�������� ��������������$�-��

����� �� ����������������������������&���� %�����������

9����� ���������� &���������� � %��������)������!"����$

������&�������"(�%����)�����!�!�������� ��� ������� ��

�� �������� �������������������&������ �������� ���������� ��

������� �$

*����(�4� 5�� ���-�� !�%������%�!��2&��'������ ��"3���������6��� 6�� ����� �6����� 6�� ����� �6����� 7 !�6���

��A*� A �� �%����& �� ����"����B//. $ "����B//.2$"����B//��$ "����B//�/$

��'*��' �&���� ����� �� ����"����B/�/0$ "����B/�/�$ "����B//.2$"����B//.�$ "����B//.�$ "����B//�/$

�0'*��' �&���� ����� �� ����"����B/�/0$ "����B/�//$ "����B//.B$"����B//.�$ "����B//��$ "����B//��$

�0'*�/' ����� ����� �� ����"����B/�//$ "����B/�//$ "����B//.B$"����B//��$ "����B//��$ "����B//��$

� '*��' ����� ����� ����� 2����"����B/�//$ "����B/�//$ "����B/�//$ "����B//. $"����B//��$ "����B//��$ "����B//��$ "����B//��$

"��C������������>����C�����������$

���%��������(�$��� ��.�(67*��� �����������&���*��� ��� �"�$�"�$��"�$����� ����"�$D

+��� *��

����� ���

��% �3�

����� �

�������

�%�� ��

������

���� �?���

�����

��& ���

�������

�������

�%���

Page 34:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

,'� �-���$�������(�$��� ��.�*�����.�� ������'��+����&� /��8����(������2+3.�2/3�� !�2'3��+����(�����2�3�

�" 9�� ��'��7 !���+��'��*����,����� �������������������� ���������������

���������%� ���������������� ����������

��������� ����������

�� 6�������������������������� �������� ����

���&������� ����� ���������� �����������

�����&���� �!"�/��$�( ��������� �������"��%6$

������� ��!������ ���������� "��%�$����������!

"�/��$ �����+����� ������� ���� ������ �-�

��� ���� ������� ������� ��� ���������&����

��������� � ����������� ����������������

����������,��� ��������� ������� �����������%

� ���������� �&��%��� ��������������� �����

���%&���������������%�

�� �������������������� � � ���������� �������&������� ��

��� ���������� �������� �����)������� ���������������!"��

��$�

,'� �-���$�������(�$��� ��.�*�����.������$��(�����2�3�&��'��'��+����&� /�

�" :���� ��'��;� ���� ����$��2���!�!�;� ���� �-3�� ���� ������������������������������� �� �������� ���!

�&�%�����%������ ����&���������������������������������

������+���������������������%�����������������������

� ���������������� ������� ������ ����� ����������������

�������������������&����

�� 4������ ��� ������������ �����������������������������

�������������������������&����

,'� �-���$�������(�$��� ��.�*�����.�� ������'��+����&� /��8����(����2$3��+����(����2�3�

" 1�)����%�<��� 6������ ��� ����������

��������������� � ����

���&��� �������&���

������%�+����)������������

�����&���&���������������

��&���� ����������� �

���� �,��� �����������

�� �������)�&������

�� � ��������� � �����

��������/������������%

�������)��

��2

ButtressButtress

3“ (7.5 cm)3“ (7.5 cm)

4“ (10 cm)4“ (10 cm)

��

4" (10 cm)4" (10 cm)

buttressbuttress

��

6

Page 35:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

A. Attach your Verticals and Top Rails1. Continue filling your Pool

a. Continue filling your pool with water. Do not put in more than 12" (30 cm)of water until the top rails and vertical columns are all attached.

b. Keep working on the top rails and vertical columns while the pool fills.

• See the drawing on the next page for an overview of all the parts usedto install the verticals, top rails and top connectors.

2. Install the Vertical Columnsa. Line up the bottom of one verti-

cal column (key 1) with the twosmall tabs on one base plate(key 2). The tabs must be on theinside of the vertical column.The end of the vertical withthree holes must be nearest thetop and the end with two holesnearest the bottom.

b. Line up the screw holes andfasten with one self-tappingscrew on each side (key 3).

c. Hook a top plate (key 4) over the top edge of the poolwall (key 5). Place the top plate down over the top ofthe vertical column with the tabs on the outside ofthe column. Make sure the vertical column isstraight up and down.

d. Line up the screw holes and fasten with one self-tapping screw on each side and one on the front(key 6).

e. Repeat the last four steps for each of the vertical columns around thepool wall.

SECTION Pool Component Installation Manual

Installing the TopRails & Verticals

!Hint:Use the ridges in thepool wall to makesure the verticalcolumn is straight upand down.

4-1

4

1

2

1

3

2

4

65

Page 36:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

Overview ofVertical, Top Railand Top ConnectorAssembly

4-2

3

1

2

5

8

6

4

7

11

10

9

Page 37:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

3. Install the Top Railsa. Place a top rail (key 7) with one end on top of the top

plate. The side of the top rail facing the centre of thepool is shorter than the side facing the outside of thepool. The side of the top rail facing the outside of thepool will form a large overhang.

b. Line up the holes as shown. Fasten through the twooval holes into the holes marked ‘A‘ in the top platebelow with two self-tapping screws (key 8). Do nottighten the screws yet. Leave the screws slightlyloose until all the top rails are in place.

c. Repeat the last two steps for the other end of the top rail.d. Repeat steps (a) to (c) to install the rest of the top rails around the top of

the pool wall.e. Make the pool settle into a

perfect circle by pushing the topof the pool wall vigorouslyinward at each vertical (this willhelp make the bottom of thepool wall shift into a perfectcircle).

f. Adjust all the top rails to line upevenly with each other andtighten all the screws.

4. Install the Top Connectorsa. Tip lower

half of thetop connec-tor (key 10)and hook itonto the twoouter cor-ners of theupper half (key 9). Tip lower half of the top connector (key 10) into place(the upper half of the top connector will rotate on the corners of thelower half like a hinge, locking the two parts together).

b. Fasten the upper and lowerhalves of the two-piece topconnector (key 9 and 10) withtwo self-drilling ‘Teks’ screws(key 12). Be sure to hold the twoparts together very tightly, tomake a tight joint with the twoscrews.

4-3

3

8

7

Push vigorouslyPush vigorously

4

Upper Half

Lower Half

765

9

10

!Important:You will find the self-drilling ‘Teks’screws (key 12) inthe Top Pack, inpackage number1184232. Do notconfuse these withthe other self-tap-ping screws. 8

12

9

10

9

Page 38:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

c. Line up the assembled upperand lower halves of a two-piecetop connector (key 9 and 10)above the ends of two top rails.

d. Hook theupper halfunder theinsideedges of thetop railsand holdthe hooksfirmly in place. Bring the lower connector down into place under the toprails by spreading the sides out completely, as shown in diagram 11, andgently stretching it across and down, as shown in diagrams 12 and 13.

e. Line up the two screw holes inthe lower half connector withthe two holes in the verticalcolumn. Fasten the connector inplace with two self-tappingscrews (key 11). Tighten thescrews.

f. Repeat the last five steps for therest of the top connectors.

4-4

10

9

10

131211

!Caution:Be sure to spread thesides of the lowerhalf connectorcompletely beforestretching it acrossthe top rails or theconnector may bedamaged.

1411

Page 39:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.4-5

g. For oval pools only: at thetransition points only, where theend rail meets the side rail,make sure the side rail lines upproperly with the end rail. If itdoesn’t line up the connectorwill appear crooked from above(see diagram 15). If the connec-tor isn’t centred between therails, temporarily remove theconnector and loosen the screws on the side rail. Shift the side rail in orout from the centre of the pool until the connector can be properly cen-tred between the rails (see diagram 16).

h. Coat all showing screw heads with clear outdoor varnish.

B. Fill your Pool with Water1. Finish filling the pool

a. Fill the pool with water to 2" (5 cm) below the lowest opening. Next,follow the installation instructions for your skimmer.

Crooked ConnectorCrooked Connector Centred ConnectorCentred Connector

Side RailSide RailTransition RailTransition Rail Move the Side Rail

slightly to centre the Connector

Move the Side Rail slightly to centre the

Connector

15 16

!Important:The pool wall maybulge and shift a littlewhile filling withwater. This is normal.

!Caution:Before anyone usesyour pool, read andfollow all the SafetyRules in Section 1.This pool is not fordiving or jumping.

Page 40:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�!!���� ���� ��������� �� +������� �+���(�$��� ��

,'� �-���$�������(�$��� ��.�*�����.������$��(������&��'��'��+����&� /�

�" � �������'��6�������� �����=���� �� ��%���������������� ��������&���%�������

����������������������� ����%� �� �������%��������-�����

��

�� ( ���������� ������� ���&��

��������� � �5 �����E6'��

����������������� �

��&�����������;� ��

�����������&��)������ ��

���������������&&����&�

���������� ���& "��%.$�=�

����������%����� ���&

%���4��)���� ���& ������%

��� ������������������ ���

�������,��� ������)�����

��� ��������� �����������

��&" ����������A*� A����

��� ����)� ������� $�

�� ( ��������������)�������

� ��&�-���������������

���������� ������������� ����

�� ������� ������������ ����6

������� ���������&����

$������!�!��������� ���

�������(�%��������� $� �

�$�����������������'�����

���������� ��&�����

����� �������� ��� ���"�$��

��������� ���"�$>��������

������&�������� ��� ���

"�$�7�%������������� ��

���6������������ �)���

���������&����� ��������

����������>�?��������

������� ��&�����������

;������� ������������ �� �

����E6'���������������

���� � ��&��������

���;� �������������&�

�)������ �������������

����&&����&� ����������

���& "��%.$�

=�� ����������%����� ���& %���4��)���� ���& ������%��� �

����������������� ����������

��B

Transition ATransition A

Side RailSide Rail

End RailEnd Rail

Vertical

Buttress

��

use hole Buse hole B

buttressbuttress

Transition Atop railTransition Atop rail

��

.

first vertical onround end of pool

use hole Ause hole A

first vertical onround end of pool

��

.

Connectors

!������� ��

(����B!"� ��$���

�����" ���������

��$� ��&�

%���������

�������� ������

����������

� ���������

��� �������� ��

�� ����������

6��������( ������

���(���������

�������������

�������&���%���

������% ��&���

2!"�0#��$���

�����" ��&

����&$�������B!

"� #��$��������

" �����������$

�� ��� �������

� �����8��������

���"�$����

�����

6" (15 cm) Top Plate

Page 41:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� ������&������������� ����6������� ���������������

����"��% $�)���������������������� ��������������)�����

�����������)�������� ��&�����������"������� ������������

�� ���"�$�� ��&�������� ��� ��$+���������&��������������)���

�������� ������������&����( �������������� ��&�

�������������%��� ����������� ����)���%���2!"���$���&��

����� ��������� �?������������ ���& %������� �%�������

�������9� �������� ������

������� �����%�����)������� ����� �������������&���9� �

����� ���������������������)������� ����� ���� ��������

�%/� ��-������������� ������&��������������������

&����(�%���������9� ������������)��������%����%�����

����)��������������� ����� ����&�����������������������

�����

�� @����������������� ������� ����6�������������%���� �����

(�������������� ���������)����� ��� ������������� �������>

������)������ �������� ������������������������ �������

������%���� �������&���� �" ����������A*� A������� ����)�

������� >�%�)�����&������)�������9������� ���������$(���

�� ����������� �������� ��� ������� �����%���� ��������

���� %��9� �� ������ �������������� ��������������������

��������������+���)������ ���)��������*������%�!"0�#��$

��9� ����������������������

�� :����� ��� "�$��"�$����������� �������������

�" �+��'����� ����� ������ ��!��������!�����!�� !@���$���+����&��'���

�������� +���������%� ���&�����

����� ������������ �*���

������ ���������" ���������A

*� A������� ����)� ���

���� �$

�� 8���������������� �����

�����"��% $�����������

��������" ������������A*� A

����������������)����

�������� ���������$8�������

��������)�����+�����<�����

$������������������

����������������%�� ��

��� �����&�%�������9� ��

������)�����%����)��

���� �(�%����)����A*� A

�����9����� ���"�$�&�

��

first vertical onround end of pool

use hole Ause hole A

first vertical onround end of pool

��

.

ButtressButtress

OverlapOverlap

Side railSide rail

Transition Atop railTransition Atop rail

Page 42:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� �������������� �������

� ������������� ���������

�����&����� �� ���!"��

��$������ !"�.��$�&�%

�������������� ��������

+������������%� ���&���

��������������!���������

��)��������&������ A

��B�+����� ����A� ������

��������������� ��������

���!"����$�&�%�+�� &�����

������%��

&������������ ����������� ���������+�� �������B� �� �

�������������������� ������������ !"�.��$�&�%�+�� &��������

�����������&���!"2��$ ���&���� �����

�� +��������������� ��������!"2��$ ���&���� �

���&�&���� ��������������� �����������

�&��)������ �������������������������������

���� ���������B�+������ ���������� ���� &���

������������������ ������&���!"2��$ ���&

���� �������������������

�� (�%����������� ���� �����������������������

���!"2��$���������!"� ��$������ !"0���$

��&������� ����������������������B�

,�� ��������� �����%��������

�� :���)������� ���������������������!"2��$���� � �����

���� ��������������B�

�� @�������� ������������������!"����$���A� ������� �&

"� �������&�������� ��������������$�

�� ;� ����� ��������������� ���������������

�� :����� ��� "�$��"�$��� �������������� �����������������

�����

9� @�����&������������� ��� �*�������%��������-�����

������������������� ����������������� ����8���6�����-����������������

�� �������

�� (�%����)����A*� A��������&������������A������������

�������������&��������&���� �������� �����+�����B

����������&�������������A������!"�.��$�&�%�������

A�+������������������� ��������!"2��$ ���&���� ������&

������)� ��� "�$��"9$�

�� @�����&���-�������-������%���������

��.

Line Y for new holesTwo linesthrough oldoval holes,intersectingline Y

Transition Atop rail

XY

��

1-1/8"(29 mm) 1/2"

(13 mm)1/2"(13 mm)

Cut lineCut lineYY

XX

Line fornew holesLine fornew holes

Side railSide rail

Transition A top railTransition A top rail

Page 43:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

=" 1�� ��� � /�-����*���6����%����)���� ���� ������%�������������&��� �� ������� ������

������������� �����

�" 6'��;� ���� @�������������������%������� �

�� ,��������� �����������������&��������������

�" *����,����� !�#����$���%���� ��� F����������&�����)������������ ������� ���&�)��% �

����&������� ����=�� ���� ����� �)� ��������� ������ �� �

�� �� �����% ������������������ ������&�%�

�� :�������� ��&�� ���&���� &���������������)��� ��

�� @���������������� ����� ���������%������ ������� �� ��

�� +������ ������� ���� �%�������������� &��������������

�� ������;����&����������� �����������

�� G)��%�&�%��� ���&�����&������)���%�����������!"�/��$�����

:���)�������������������������������&����������������

���� ������ ������������&����-��-���������� ������� �

����)����������

�� 8�% ����������������%���� ����� �����������������

�� �4��� ���������*������������%�

���/

%����� �

@��������

������%�������

�����������

���� ��� ��%

���� ������&�%�

���������

6%�� �%���� �

�������&����� �

����������

������%&�������

�� ������6����%

�� �������&���

�������� ��

Page 44:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

7" ,� ����4� /�-����*���6����������� &����� �� ��%���� ������&��� ��������� ��

����%�����������%������&�����

�" ;�&����'��,�����;�<���� 4�&�����&������)���%�������������� �����2!"�0��$����&���

&����������������

�� :���)������ � ������������� ������������������� �1�)�

���������&��������!��� �!�+�����'���)������'���� /.�� !���)������

�'��'��������'����������+��'���)�����������+��C *;CDD7="

�" %'�$)�����9�� ���� !�($��&��� ,��� ��������������9��� ������������������������%������

����������&����� �� ������������������������

�� ,��� ������ ���& ������ ���������

�" %'�$)�+�������8����% ������� ���� �%���� &��������� ������

�" %'�$)��'��;� ��,��� ������������������� ���������������������&���&���

��� ���������=�� �������)��������������������:���)�������

����&���)�������*� ���&�����%�=�� �������������&��������

�������������&�����

" :� !� /�;��)�,��� ������������ ����� �@������������������ ��������

�%���� &����)�%�������4��� ����&��������� � �)���

��������%��������

" *�����$$��������:���)������������ ���� �����������������������������4��)�

��� ����������$'�!����������&����G ���������� ����������

� ������� !��'����� � /�����'����������+��'���)������������ ���

�'����$$�������!�&�����$� �!��� �����!�����-

�" 6'��:�����?� ���������� � ��������������;����&���&�����3��� �������

�%���������������

����

%����� �

=�� ����������

���&��������%���

����������&�����

��!�� �������)�

��������6����%

������������ �

����&�����

���������

;��������� ����

���H8���

������3��F��I��

�����&���

&�����3��������

���� ���������

���&������ �

� ������� ���%

)����������

&�����%�

Page 45:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �����������������������������

������� ��,� ����4� /� ���$�

����*�����+��&������)���� ���������������� ��!"B2��$����&��� ������

������������������&�����-����� &������ �������)���%�����

����������� ������ ���������� '�������� ��������������

&���������<������'���������$'�!�����'���)������� !������ �+���� /�"

6'����� � /�����'����������+��'���)������1C(6����)������� �����'��

�$$�������!�&�����$� �!��� �����!�����-"

*�����&��'���E�2���$�3��)�������(���������������)�����8���������3��F��"8���J�������B/�� $�� �

��� �������������!"�/��$ ������" ������ ����������&$�

:����������� �������'��F*����,� ����4� /�G��H�� !�+����&��'��&� ����4� /

���$�!����.�� ��$$��!� $��&��'��'����� ����$��� �.���-�<��!��'������

&���� �-"

+��8���������3��F��"8���J�������B/�� $� �� ��)�����������%���

�����������

����*�����=�� �������$'��'�������$�<��������������� �)������� �������� ���%

��������� �������

( ������8���������3��F��"8���J�������B/�� $������ ������������

��� ��� �&������ ������������7 ��� ������ �����%����� ��%

������������������������������������ ��&����&������������

��������������&�����

3" (76 mm)

12" (30 cm) Wide Mouth Skimmer

Pool Winterizing KitMaintain water level at least 3" (76 mm) below skimmer opening throughout the winter

Page 46:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

F. Safety Rules For Pool OwnersYour pool contains a large quantity of water, and is deep enough topresent inherent dangers to life and health unless the following safetyrules are strictly observed. First-time users run the highest risk of injury.Make sure everyone understands all safety rules before entering thepool. Post NO DIVING and NO JUMPING signs beside the pool.

For additional safety information please read the enclosed bookletThe Sensible Way To Enjoy Your Aboveground/Onground SwimmingPool.

1. No Jumping or DivingThe top rail of your pool is not a walkway and must not be used forjumping or diving. Do not permit jumping or diving into the poolfrom a deck or the top rail of the pool. Diving or jumping into thepool can result in serious injury.

2. Never use the Pool AloneNever permit the pool to be used unless it is attended by at leastone person other than the bather. Someone should always be avail-able to lend assistance in an emergency.

3. Never Leave Children UnattendedNever leave a child alone and unsupervised in or near the pool�not even for a second. There is no substitute for constant adult su-pervision.

4. No �Rough-housing�Do not permit �rough-housing� in and around your pool. Surfacescan become slippery and hazardous when wet.

5. Light the Pool at NightIf the pool is used after dusk, adequate lighting must be provided.Illumination in the pool area must be sufficient to clearly judge pooldepth and all features in and around the pool. For lighting recom-mendations, consult your local licensed electrical contractor.

6. Restrict Access to the PoolDo not leave chairs or other furniture beside the pool that could beused by a child to climb up into the pool. Ladders must be removedwhenever the pool is unattended. A fence with a lockable gatearound the pool or yard is strongly recommended and may berequired by law in some jurisdictions.

7. No Alcohol or DrugsThe use of alcohol or drugs does not mix with pool activities. Personswho have been drinking alcohol or using any drugs should not beallowed in the pool, and should be carefully supervised in the sur-rounding area.

1-8

Page 47:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� ����������������������������

Channel-Lok 1 Oval Pools❏ ����� ���������������

���������������� �� ���

� �� �

������������ ����

�������

� ����������������������

������ �� ��������������������������

� ���� ��� �������������������� ��������������������� ����� �����������������

�������� ��������������������������� �� ����������������������������� �������!�����

��"���������������������������#� ����$�����%#����������� ����������������������

������ �� ����������������� ���� ������ �������������������� ����������� ��

! ������� ������������ �"�� �������������������� ���� #��������������������

������������� ��������!"������!��#�������$����

�������� �����!����"�#��!&���� ������ ��� ���� ������ �����#�������������� �������� ��$�"����� ��������

���������"���$�"����� ����������� ������ ���� "�����#� ������� ������ ������� ��

'����� ��$�"�������� ������ ������������������� �����$����

$����#������������%������������"�������� ��� � ���������������������������� ��������� ������� �� ��������

���� ������( "� ����� ��������� ���� ���� ���������������������"��������

&����#��' #�����(���)� �((������������������ ��������������������� ����������� �)� ������� �������

����&��������� ��� ��������� ��� ������������������� ��

*������+���!�,������!-���������"���*� ����� �����+�������� ����� ���� ���(���������� �� "�������

���������,�� ������������

.���'�!��������� ���!�-������� ������������������#����������������������� ���� ������-���"���� ��������

� �����"���� �������������� ��������$������ ���������������������������

� ��������� ���! �������������� ""����� ����� ������� ���� ���������������������

� ����� ��

/�������0�%00��������������������������� �� ��������������� ����������� ������� ���� ������� ����������

���" ������� ������ ���.���������� ����" ���������������� ����������������/

������������� �# �������� ��������� �� ������������ �������� ""��������

"�� ����������� ��������� "��$��������� ���

1������%�0��������"��!�&������� ���� � �� ���������������"�0������� ���������������� ����� ���� ���

����#������ � �� ������������������� ����� �� ���� ������������ �������� ���� �

������������������������������ ����������

2���3��4����������� �� �(�� �� ��� ���������������"��������" ����������������������� "�����������������������

�#�""����������" ������������������� ������� ������ "������������������1������

� ������� �����"����������������� ������ ����"���� ����������������� �"�� �

��������������������������������������� ����������,���

Page 48:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

%� ����(�0��������� ����!����������� (� ��������0�����0�����������������!���

&�������������� ����0������ ��� ��������� ���� ���(�"����� �� �����������

�������������� ����(���������������������������������������� �������������

�� ������������$� �*� ������ �������� ����������� ��

����������5�$���&������ �"�� ��� ������������������� ����,�����

������2�� �� ��������������� ������������� �"#�������� ������������� �"�

�� ������������ �� ������������� ��

������������ ����� ������������������� ���� ������� ��#����� ��

� �������������� ����������������������3�������� ���������� ��

���������"#����������� ����� ������� ���� �������������������������"�

6� "����� �'�0 �����������������

�� ������ ������������������ ��� ��� ��

��������������� ��� ��� ��� ��

� �4

5 6� ������������������

����������� ��� ���

5 6� ������ �� ����������"

����)(���������������� � ��� ��������������������

��������������������" ���

� �� �����"������������

� ���

5 6���#������� ���� ���������

�����������7������ ������� ��

����&��������� �������"�

�� �������� ����� ���� �

�������� �������������� �� ����

������ �� ����� ���������

�����

5 (� ������������������� � �

"�������� ������������

������� ������ ����������� �

�� ��) ����������� �����

�����" ���������"������

���������

$ &

*

!����� ����7

7� ����������

�� ����� ��� �����

" ����"� ����

�������������������

��� ���� ������/

����������( ���

��������������������

������� �����"�

���� ����" ����

�������� ��� �

��"������� ����

���������� ����

�����������������

�������� �����

��"����� �����

������� �����

��������� �������

�����!����3������

� �����(���� ��8

��������� "�

������ ������ �

����� �� �����

�����������" ��

�� ��������������

�� ����������

�� ��

��8

Page 49:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

$� ����!����%#��("����� ����� ���� ������ �

����� ������� �� ����4

5 ��������������� �������

5 ���������������� ����������

5 3��������������������)� ��

����� ������������������

������ �������������� ������ �����

�������������������� �

����

5 9���������������������

5 /���������� ���������

5 7������� �������� ����7���

������ ����������������� �

������������ �������� �������

�"�������� ��������

5 /������������������������� ��� ���������#�����������"����� ���������,�

����

&� �� ��%� (5 :����� �� �����������$��������#�����;�3�������� ������ "�

5 :����� �� ��������� ������� ����� �� ����������������������������

�������� ����;�. ����� ���� �������������������� ������� ���

���"��������������� ������������� ����� ��

�� ��� ��������( ����������������

�� ������������0�8����(���� � ����"� ���!� 6� ������������������"������� ���� ����,���� "������������

�������� �� ���&���������������������� �����������������"���

�� ���� �������� ����������� ����������� �������� �� ��

��<

�.�9�&:��# ������

"��������

� =�>�?88=��"@

� ��8>�?8A=��"@

' =�>�?88=��"@

� <���B8>�?CC��"@

� A=��B8>�?�A���"@

� �D�>�?EAC��"@

; �8=>�?<8D��"@

< =�>�?88=��"@

4 �8C��BE>�?<8<��"@

= �AC��BE>�?<==��"@

BB

GG

K J

H I

RR

SS

XXYY ZZ

NNMM

PP

LL

FF

EEDD

AACC

WW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Pool WallPool Wall

Clearance AreaClearance Area

Support Trenches

!����� �7

:����� ���������

����������� �����

� ����������

�#����� �� �����

���� �����������

������?���#����� �

� ���@� ��������

���"��?�����

� "����,� �

����@���������� �

"�������� �����

��������������

�������������� �

����������" ��

������������

� ��� ��� ��� ��

�� ������

. /

1

Page 50:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� ���������������������������E

�.�9�$*��# ������

"��������

� =�>�?88=��"@

� ��8>�?8A=��"@

' AE>�?�<C��"@

� <�>�?CF��"@

� ED>�?�88��"@

� ��D>�?8CE��"@

; �8=>�?<8D��"@

< =�>�?88=��"@

4 ��A>�?8FC��"@

= �<=�CBD>�?<AA��"@

�$�9�$*��# ������

"��������

� C8>�?�D<��"@

� DE>�?8�<��"@

' C8>�?�D<��"@

� 8E>�?F���"@

� ED>�?�88��"@

� �EE>�?<FF��"@

; ���>�?8D8G�"@

< C8>�?�D<��"@

4 ����<BE>�?8AD��"@

= �<8��BE>�?<<F��"@

�$�9��2��# ������

"��������

� C8>�?�D<��"@

� DE>�?8�<��"@

' <F>�?=���"@

� <F>�?=���"@

� C8>�?�D<��"@

; ���>�?8D8G�"@

< C8>�?�D<��"@

4 D���B8>�?8�E��"@

= ��F�<BE>�?8=C��"@

BB

GG

RR

SS

XX YY

NNMM

PP

LL

FF

EEDD

AACC

K J

H I

ZZWW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

BB

GG

RRSS

XXYY

NNMM

PP

LL

FF

EEDD

AACC

K J

H I

ZZ WW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

BB

GG

RRSS

XXYY

MM

PP

LL

FF

EEDD

AACC

K J

H I

ZZWW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

Page 51:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

$� � �>������%� � '������ ������?/@����?3@����

������ �����&��������������

��� �� ������0����� �

� ���� ���6� ������������

�������� ����������"��� "

��������� �� �����7'���

�����%�� �6���������� ����"���� ���� ������� ������

����� ��

�������? "�� �0���������!��@%A� �(�@6A

�8H�0��DH C8>�?�D<G�"@

�8H�0�8EH �EE>�?<FFG�"@

�AH�0�8EH ��D>�?8CE��"@

�AH�0�<�H �D�>�?EACG�"@

�DH�0�<<H �D�>�?EACG�"@

� 1����������� �������������

�����������?/@�������� �

��������������"�#��������

�������� �������0���� ����

�"��� ������?3@��6� ������

������� ���������� �������� �

� ���� ���� "���������� �����

��0�������&���������������� �

�8>�?<�G�"@� ���������� ���

��������� ��

��A

2

�2�9�&&��# ������

"��������

� ��D>�?8CE��"@

� �8�>�?<�A��"@

' =�>�?88=��"@

� <���B8>�?CC��"@

� A=��B8>�?�A���"@

� �D�>�?EAC��"@

; �EC>�?<C<��"@

< ��D>�?8CE��"@

4 �E��ABD>�?<AC��"@

= �C8�<BD>�?E<D��"@

BB

GG

RR

SS

XX YY

NNMM

PP

LL

FF

EEDD

AACC

K J

H I

ZZ

WW

Measuring StakesMeasuring Stakes

Centre PointCentre Point

CentrelineCentreline

Pool AreaPool Area

Clearance AreaClearance Area

Support TrenchSupport Trenches

Pool WallPool Wall

B

A

Size of foundation areaSize of pool

12" (30 cm)

B

!����� �7

'����"�������

� ��� �� ��� ��

� ���� >����

� ��������

�� ������������

����� "���

�$���������������

?�������������� ���

����@��6 ������ ��

��� �������� ������

��� �"�� ����

�������� ��

�������"����

� ����������

�������� �� ��

� ������ ������

3����������������

�������� ����� �

� ������ ������

������������"

� ���"���� ���

�� "������������

���� ����

�����������

� ��� �� �����

����������� �����

� ��

Page 52:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�������? '�!���������!

�8H�0��DH DE>�?8�<G�"@

�8H�0�8EH DE>�?8�<G�"@

�AH�0�8EH ��8>�?8A=��"@

�AH�0�<�H ��8>�?8A=G�"@

�DH�0�<<H �8�>�?<�AG�"@

�� I ��������� ������?/@����?3@

������������ ����������1�������

����������������� ������� ��

����������� �������� ��������

������� ������������

�� '���������� �������#��?6@

9 0���� ��� �� ����������

�� ������?/@����?3@� �����

������������(�#��?6@������"�#

�����0����������� ���� ��� ��

� ���&�����#��"���� ���

������>�?8AG""@����������F>

?�AG�"@�� ����'�������� ��

����������������� �����������

�� J������������ ������?/@���

?3@�������� �" �������� ����

��#����'�������"�� ��������

����������� �����������

�� I ��������� �������������

��������������� �"#���� ��

1������������������ ��������

���������� ��������� ������

�����

��F

�:

B

A

C

��

!����� �7

%��������������

� �"#����������

���������#��?6@���

�������� �����

� ��� ���9 0��

� ��� � ������

�����?/@����?3@�

� �������������#�

?6@��������

����������� ����� �

�����"������

"�����

B

C

A

�$

Page 53:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� %�#������ ��� ��

�������������� ��� ��� ���1��

������������������������� �

������� ������������� �"�#

���������������1�����������

�� ��� ����������� �����

��(�C;��� "���������������

������� ���&�������� �����

����������� �����������

���������������#���?/@���

?3@�

�������? "�� �0�������������������(�%�

;

�8H�0��DH ���>�?8D8G�"@

�8H�0�8EH ���>�?8D8G�"@

�AH�0�8EH �8=>�?<8D��"@

�AH�0�<�H �8=>�?<8D��"@

�DH�0�<<H �EC>�?<C<G�"@

&� ���#�����(� J�" ������ ����������

�� "��������

� J�" ���������#����� ������

� ����� "��������

*� � >���%� ��� � �(�'#�� � ������������8� ��E�� ���������������� ��� ����� ������6� ������

������� ���� �!�8� ��E�� �������� ��� ���� ���� "���������� ��

� ��

�������? '�!�����$,��,*

�8H�0��DH DE>�?8�<G�"@

�8H�0�8EH DE>�?8�<G�"@

�AH�0�8EH ��8>�?8A=��"@

�AH�0�<�H ��8>�?8A=�G�"@

�DH�0�<<H �8�>�?<�AG�"@

� /�$��������������� ��������#��?/��3� ��6@��������� ���������������

���� ������� ����� ���""���������� ���������������9 0������

����������� �������������������K������� ���8� ��E������������

����� ���������������#���� �"#������������ �������0���������

��������� ������/�$�������� ������� ���#���� ������������

��C

B

A

W

W

C

�&

B

A

C

�*

�����7

� ���� ��"���� �

���������������

&#��������"��� �

������ � ������

� ���� ����� ����

���������������

Page 54:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� ���� ������� ������8� ��E��

����� �� ��������#�����������

����� ������� ��� ����� ����

������'������� ���� �����

�����������0�� ������� �� �

������#�����������"#�����

� ��� ����� ����� �����������

��������� ��������� �����

" ������� ���" �������

��#���%�#������������ �����

��#�� �� ���� ������������� ��

��"�#������������� ����

�� "� �� ������ ������?���

����"��F@��1��������� ��

�� ����� �� ����������� �����

8� ��E�� �������#��������� �

� ������������������

�� �������������K������� �����

8� ��E�������������� �����

��������� �����������������

� ���� ���

�� J�" ���������������� �������

��� ����� �� ���#���3������

������ �����������" ���

�����"�������� �������� �����

����������J�"�" ����� ��

� ����� ���������������>

?8AG""@��� �������� ���-�

�����������$��������������� �

������#�����#�����������

���� ������������������

�����

��D

BB

AA

CC

�2

!D��7

1��������� �K�

�������������� ��

��������K����������

�������� ���

BB

AA

CC

Hole

Centreof Stake

�1

�.

�/

BB

AA

CC

�B

$:

Page 55:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� "������������� �������!������

�������������������� ����

�� ��� ��� ���� ���9 ������ "

�"����� ��������"�������

���� �� ���"�� ������������

�������� ������ ������

��#����������"������ ��

�� J�" ������8� ��E��� "�������#������������� �������0����#�� �����

�����������

�� J����������������������������������� ��� ��������������&#��� ��

��"�����"#��������������������0����#���J�"�" ����� ��

� ����� ���������������>�?8A�""@��� �������� ���-�����������

�$��������������� ��������#�����#���������������� ��������

����������������������

�� %#���������������� ������������� ������ ��������������������

���������

$� J�����#����� ������8>�?<���"@

������� �������������������

� ����������� �������������

� ��������������������� �����

���%#�����������������

����� ��� ���� ����&��� �� "

����� ������� ������������� �������� �����������

�������������

.� %((�������� >�� �������������� �������#���?'@��?�@��?!@�L�?7@�����?9@��?-@��?I@�L�?M@� �

"�#���������������� ��� ��������#�������"��������������

E?�@�

� '��������������� �������#��

��� ������� �����'�������"

� �������������������� ���

��������. ����������#�

�0����� ������������"������

"������ ��� ���� ��������

����� �� ���3�������� �"���

���������������������� ��� �

������#��

�� &����������� ���������#���?9@

���?-@���� �������?I@����?M@�

�������? "�� �0�< "�� �0�4 "�� �0�; "�� �0�=

�8H�0��DH C8>�?�D<G�"@ D���B8>�?8�EG�"@ ���>�?8D8G�"@ ��F�<BE>�?8=C��"@

�8H�0�8EH C8>�?�D<G�"@ ����<BE>�?8ADG�"@ ���>�?8D8��"@ �<8��BE>�?<<F��"@

�AH�0�8EH =�>�?88=��"@ ��A>�?8FC��"@ �8=>�?<8D��"@ �<=�CBD>�?<AA��"@

�AH�0�<�H =�>�?88=��"@ �8C��BE>�?<8<G�"@ �8=>�?<8D��"@ �AC��BE>�?<==��"@

�DH�0�<<H ��D>�?8CEG�"@ �E��ABD>�?<ACG�"@ �EC>�?<C<��"@ �C8�<BD>�?E<D��"@

��=

$�

�����7

&��� ������8>

?<�G�"@� �����

������� ����

"���� �����������

�����&��� �� "

����� ������� �

������������ �

������ ������

���� ����

����������&#�����

��"��� ��������

�����������������

����������������

�����

BB

AA

CC

12"(30 cm)

$$

!D��7

-������ ��� ���

� �������#����� �

��������8>�?<���"@

���#���

BB

GG

FFWW

ZZ

EE

DD

H

I

J

K

AA

CCXX

YY

$&

Page 56:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

/� ��� ��6��������0��� . ��������������������� ��"��

�����������(�� �0����� "����������� ����#��?9@�� ����

0����� ��������������1��

��������� �� ��� ���������

��������������%�� ��� ���� ��

� ��������#����������� ���

����������� ������������

�������������%�

�������������������������

��������A?�@�

�������? "�� �0������� > "�� �0

�����0�������� �������0��

� �

�8H�0��DH <F>�?=�G�"@ �B

�8H�0�8EH 8E>�?F�G�"@ ED>�?�88G�"@

�AH�0�8EH <�>�?CF��"@ ED>�?�88G�"@

�AH�0�<�H <���B8>�?CCG�"@ A=��B8>�?�A�G�"@

�DH�0�<<H <���B8>�?CCG�"@ A=��B8>�?�A�G�"@

?�B�N�� ������� ��@

�� J�����������?@����? @��

� ����������0���������� ��

��������� ������� ���%�����

����(�� �0����� "����

����������� ��������������������

��������������� ��������0�

��������1������������ ���

�������������������������� �

� ���� ���?����� ����4

&����8G0G�D�� ����� ���

�����������������2������A�0

8E�� �������������������

����2������8G0G8E���AG0G<������D�0�<<�� �������������������

���������@

�� ������ �������#����������� ���� ����������� ���������������

�����������������������������������������������A?�@�

�� J�����������?@�� �?�@�� ������ ���������� ��� ���� ��

�� &����������� ��������������� ����#��� �� �� ����������� �����

����������?������#�����������������? @����?�@�� �@�� �"�#

��������������� ���������������

�� %�#������������������ �������������������������� ������������

�� J�����#�� ���"�����"������%#��������������������%�����

9 0��"���������������������������������� ��?������

����"�8F@������������������������� ������������������9 0��

� � ������ J�" ���������������?���M�����������������&��������� ����"� �����

��������������������������������������� ����� ������� �

� � ������#����������������������������@

����

H

I

J

K

BB

GG

FF

EE

DD

AA

CC

MPainted centreline

of trench

$*

H

IBB

GG

FF

EE

DD

AA

CC

N

M

M

J

K

$.

Page 57:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� ������

�� ���������

�������

�������

��������

���������

����������

���� �����

�����������

�����������

�����������

������ ����

������������

�� ��������

���������� ������������������� ����������������������������������

����������������

�� �������������������������� �

����������������������������

��������������������������

�������� ��������������� �

� �������������������������

� !����������������������

��������������"���������#$��%&

����������������������������

�����"������������� ��������

������������������������������

������������������'���������

��'��������������������������

#%$�(�#%$��"�����(�%$��������)*�(

)*�(�&��������������������������

�����������+��������������

����������������������������

���������������������������

�� ,�������������������������

��������������"���������#$��%&

����������������������������

������ +������� �����������

�����������+���������������

���������������������������

������������������������������

��������������������������

����������������������������

� ������������������������������������������������������

���������������������������������������������������������

#-##

20" (51 cm) 20" (51 cm)

4" (10 cm)

3" (8 cm)

21" (53 cm)

5" (13 cm)

21" (53 cm) to faceof patio stone

17" (43 cm)17" (43 cm)

Pool Wall Line:String line between

stakes D and Eor F and G

(N.B. the pool wallwill lie on this line)

Painted centrelineof trench Concrete

patio stone12" (30 cm)square

Concrete patiostone

Concrete patiostone

Trench

Crushed limestone (or equivalent) base1" (25 mm) in bottom of trench

Crushed limestone (or equivalent) base1" (25 mm) in bottom of trench

�!

�"

#�����$

������������������

��%��������&

����������������

������������������

��� �������������

�������������

�������������

���"����������-

� ����������������

���������������-

�������

Additional crushedlimestone (or equivalent)

layer 1" (25 mm) thick

�'

!(���$

#����������������

����"������������

������������������

�������������

�������������

����������������.-

������������

������

����������

���������������

����������������

����"����������

�������������������

�������������

�����������

#�����$

/������������

����������������

�������������

��������������������

���������������-

������������������-

������������

���������������-

���������������

�������������

�������������������

�����������������

��������������

������

Page 58:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������#-#%

)� *���+�� *���+�� ,� �

# .��� �� ��������������% 0�� ��� ��������������) /���������� #11*))2 %1 0�� ����/������ #)%*#&% #3 4����5�������!�������/������ #)%*#&) #6 !���� ��������������## 7���0����'��� #)%*#2& ##) �������/������ �� ��������������#1 /����'��� ��������������#& 4����5���������� #)%*#&& ##2 � ���5���������� #)%*#&& ##3 5������ ��������������#6 ����'��� ��������������#8 ��������� �/������ #)%*#&* %%* !�������/������ #)%*#&# %%) /����'��� #)%*#&1 #%3 � ���5�������!�������/������ #)%*#&) #

)� *���+�� *���+�� ,� �

- ��������� ��� ����� ##61%81 #�� ���� ���� �� ����������� � ��� �� ���� ����

#* #91$-%*:�������������� ����(���� ##61*&% 12#% :���#%�(�#9%$����-������ ##6)%3) #1

�����+����������'�����%# #91$-%*:��(�)91$���(���� ##61%3& &*%1 #91$-%*:��������� ##61%36 6%2 #91$-%*:��(�%-#91$���(��������� ##61%32 1

Inside of Pool

*����-������

.����������

/�������

0������

#)

%1

#1

##

6

%#

6

#*

7

)

%

%3

#

)

19

#8

20

20

4

%)

#3

#)

#%

#%

#6

#%

#%

21 10

10

21

21

10

26

#2

#&

#%

%#

%1

10

#)

21

Page 59:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������#-#)

HARDWARE FOR POOLS

SELF TAPPING

SCREW

#12 x 1/2 INCH

LONG

1183273

PHILLIPS NUMBER 3

SCREWDRIVER

OR

RED HANDLE #2

ROBERTSON SCREWDRIVER

SERRATED

FLANGE

HEXAGON NUT

1/4-20

1184052 7/16 INCH WRENCH OR

SOCKET

HEXAGON HEAD

BOLT 1/4-20 x 3/4

INCH LONG1184275

7/16 INCH WRENCH OR

SOCKET

HEXAGON HEAD

BOLT 1/4-20x2-1/4

INCH LONG1184276

7/16 INCH WRENCH OR

SOCKET

NUT CLIP

1/4-201184278 NO TOOL REQUIRED

DESCRIPTIONPART

NUMBERACTUAL SIZE

TOOL REQUIRED FOR

INSTALLATION

Page 60:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

!� /�����0��������������/����������/���#�������� ,�����������������������

����)�+���������������������

����%*��������������������

�������������#8������ �����

���������%#���������������#*��

�������������� �������������

#8�������������������������

�����������������������

� �����������������������-

����������������������������-

��������������������������

���������������������������������������������������������������������������������������������

+���$���������������������������������������������������!����8+������

"� 1���������-���������/���#�������� '���������������������

�����������&*�����������������

����������������������������

�����������������������������

#3$��1);����������������

����� ������� �����'���<�

4������������ ����)%���0����

������������������������������

�������������� ���������

�������������%$��&�������������

������� �����������������

������������

�� ������������3��������6�������

����������������������������

�������������

�� .����������������=��������

�����������������������������

���������������������

������������������������

�������������>�����������+����

����������������������-�������������������������-

�����������"������������������

����������������,������������

�����������������������������-

�������������#3$��1);���

������������������ �������

����'���<��4������������-

�����)%�����))��

#-#1

base channelpatiostone

21" (53 cm)17" (43 cm)A

Pool Wall Line:String line between stakesD and E or F and G (N.B. thepool wall will lie on this line)

2" (5 cm)

23

2�

&*

&*

Make sure this end of the basechannel assembly is 17“ (43 cm)from the Pool Wall Line

Pool Wall Line:String line betweenstakes D and E or Fand G

Make sure the top of thebase channel islevel with the rest of thecleared area

exactly

22

arrow

))

#8

#8

%*

%*

%#

#*

24

!(���$

?��������������

������������#8�

�����������

�����������������

���������������

)��������� ������

�������������

�������������

����������������

������ ������

!(���$

.����������������%-

�-1������������

�����!�������

����������������

�����������������

������ ��������

�����

Page 61:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

'� #��������0��������������/����������� �������������������������

��������������������������

�������������� �����������

����1��������������������

�����������&*������ �����

���������%#���������������#*��

��������������� ����������

�������������������� �������

�����������������+������������

��� ����)1������������������

������� ������������������-

������������������������������������������������

�� ����������������������������

����3�����%3�������������

��������� ������������-����

������ ��-������������/�������

�������� �������������������

����������������

�� @������������������������%)�

�����������������������

�������������3�����%3��������

�������������������������-

���������&*������ ����������

����%#���������������#*��

�� @������������� �������#��������

��������������%)������ ������

���������%#���������������#*��

��������������������������

�������� ���������������������

����������������������������

�������� �����������������

������������������������������

����������

#�����$

@���������������

������������ ����

�����������������

����������������

��������������

����

&*

1

#*

%#

#*

25

&*

3

#*

%#

#*

2!

%3

%)

#

%#

#*

2"

%)

26 2

3

%3

#-#&

Page 62:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������#-#2

�� <���������������!�������%+����������������

���������+������ ����������������������������

����������������������������(������#9#2$��%����

������������������������������������������� �����

�����������������������������

�� !��������������������������������������������������������������������

���������������������������������������������������������������������

��������������������� �����(����%$��&*��������������������� ����

�����������������������������������6��������������������������������

������������ �������������������������� ������������������������������

������������

� ��������������������������������������������������������������������

34��7��������/���#�������� ��������� ������������������0�������?���������������@�������A��������

�������������������������������������������������������������(-

�����������������������������!����������������������������������

������������ ���������������������������������������� ��

�� B�������!�������%��������-

�����������#�����������������

����������������������

��������������������+��������

����������������������������

�������������������������

����������������������1����&���$������������������#���

���������������+���������

�������������������#*���������

�������������������������

!�������%������

�� @����������������������������������������������

���������������������������"����������@���������

������������� ������������������������>���������-

�����������������������������������������������

����������������!���������������������������

������������������������������������������

������������������� �����������������������

��� ����������������������������������������-

�� ���,���������������������������"�������0�����

�����������������������������������������

�� ���������������������������������������������������������

������������������������������������������� �����(������ ���������

����� ��#-#*+�!����2�������������������

Curved bottom buttress railmust be installed between buttresses

Curved bottom buttress railmust be installed between buttresses

54

1/16"(2 mm) gap1/16"(2 mm) gap

2'

basechannel

basechannel

hard-packedcrushed

limestone

hard-packedcrushed

limestone53

Page 63:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

33� �1������(���������*��������������� 8���� ������������������������������������������������6��

�� .��� �������� ����� ���������

�����������������������

������+���� ���� ����������� �

����������������������������

���� ������������� ���������

�����������������������������

�����%*$��&#���������������

����������������������������

�������������>���������������+

����������������������������

�����"���������������� ������

!���������������������������

������������������������

������ ������5��������� �����

���������������������������

������ ���������� ����� ����� ����������� ��������������������

� ����� ������������������������� �������������

�� !������������-���������%1���������������������

������������������������������������������

��������������������������������������������������

�������������������������������������-���������

�����������

�� 4����������������������������

������������������������������

������ ����11��������������

���������%1�������������������

����������������&*�����

��������� ������������������(

��������������8���� ��������

�������� �����������

������ �����

�� ����������������������������������������� ������������������������������

��������

#-#3

Stand on thebase channelStand on thebase channel

Use a hold down plate to dragthe area to either side of thebase channel smooth and level

Use a hold down plate to dragthe area to either side of thebase channel smooth and level

5�

!(���$

.����������������%-

�-1������������

�����!�������

����������������

�����������������

������ ��������

�����

52%1

!(���$

#����������������

����"������������

������������������

�������������

�������������

���������������

������������

������

����������

���������������

����������������

����"����������

�������������������

�������������

�����������

#�����$

/������������

����������������

������������������

���������������

���������������-

������������������-

������������

���������������-

���������������

�������������

�������������������

�����������������

��������������

������

55

8

&*

%1

Page 64:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� !������)91C

�#8�������

�������

��������

�����"����-

���������

������������

�������

����������

0�����������������������

�����������������������������-

����'���������������������

��������������� ����12�������

�������������������������/� ��

������� ���������������������

������������������������

��������������� ����13�+�����

����������������� ��

�������������������������

�����������������������������

��������������������������

�����������������������������

�������������������������

����������������������+����

���������������������������

���������������������������

���������������������������

������ ��������������������

��������������������������

�����������

1�������$������������������������������������������������

�������������������������������������������������������� �����

������������������������������������������

� 4��������������������������

�����������������������������

����������������� ����16�

�������������������������

�����������&*������������

������������-������ �������

����#%��

basechannel

basechannel

Hard-packedcrushed

limestone

Hold downplate

56

##

shift the hold down plateback and forth to make it settleshift the hold down plateback and forth to make it settle

5

5!

##

&*

##

#-#6

5"

#%

&*

!(���$

<�������� �������

����������������

��������������

�������������+

��������������

������������������

��������������������

�����������������

����������

Hold down plate

Bolt heads

Base channelStrap

Page 65:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������#-#8

�� ��������������������� ����������������������������������

� ���������������������������������������������

�����������������������������������������B�������

������������������������������������������

�����������6���� ������������������-�� ��������+

������ ������������������������������������#%;(;#6

����#%�(�%1������������������������������

���������4����������������������������� ����������

��������������%#��������������������#*����������

����������������������� ��������������������

��������� ��������������

�� ��������������������� ��� ����������������������������������������

�������������� �������������������

3���9���������������������������� ������������������������ ������������������ ����������,�������/������

���������������������������������������������������������������

��������������"����������4�������������,�������/������������������

�����������������������������������������

5'

66

#*

%#

Page 66:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� ���������� ����������������� ������������� ���� �������������������� � ���������������� �������

�������������������������������������� �������� ������� �������

���� ������� ������ ��������� ��� ��������� �� � ��������� �������

���������������� ��������������������������� ������������������

�������� � ������������� �������������� �������

! �����"�� ������ ����"���# ������ ����"���! ����"��

�$%�&��'% �(� )����� �(� '�����

������)*++��� ������)*++$,�

������)*++,�� ������)*++',�

�$%�&�$)% )���� � )��� �(� '�����

������)*+�+-� ������)*+�+'� ������)*++$,�

������)*+�+*� ������)*+�+.� ������)*++',�

�-%�&�$)% $���� � )�/���� �(� '�����

������)*+�+-� ������)*++��� ������)*++�+�

������)*+�+*� ������)*++,�� ������)*++,+�

�-%�&��+% )�/���� )�/���� �(� '�����

������)*++��� ������)*++��� ������)*++�+�

������)*++,�� ������)*++,�� ������)*++,+�

�'%�&���% )�/���� )�/���� )�/���� *�����

������)*++��� ������)*++��� ������)*++��� ������)*++���

������)*++,�� ������)*++,�� ������)*++,�� ������)*++,��

��(��0��� ���������1������0��������������

�����'�&���

������� ��

������2�

�� ����

�����

�������

������3��4

/�����

������ ��

��� ����

��������

����

$4�

� �!�"# �������������������������$�� ��

������������ ���

�������������������%

End rails

Butresses

Transition B rail

Transition A rail

Transition B rail

Transition A rail

Buttress rails

Page 67:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

%

&'

��

��

��

$4$

1/2" (13 mm)gap1/2" (13 mm)gap

(

�)

��

*+

�)

No Yes

,-

!.���/

5�����������/

������ ����� �� ��

�����������������

�� �������������

���� ���/���/��

������ ��������

��������������

���� ���/�� � ��

�� �������� �����

!.���/

!���� ������� ��('6

��7������� ������

��� ����� ������

��/� ���� ��������

��������� ������

���� ������������8

������ ���� ��

������� ������

������������

��� ����

9 �����������

��������������

�����&��� ����(':

&��(':����+�&��+����

� ������������

������ ����� ��

����� �������

��� ���� �����

������� �������

�������� ��

�� ������������

�����/������ ��

��������� �����!�

���� ��������� ��

�������������

� �������������� �4

��/� ������ �������

;�� ����)�

�� <���� � ���� ��������������4

����� ���� �������������

��������$�&��'������������ ������

����/�� ��� ��������������� ��

���������� ��� �� ����� ������ ��

���/� ��=�������� ���/�����

��������

�� <���� � �������������0���������������;�������������������

������ �� ����� ������ ����4

��/� ���������/�����������)�

��������� ���� �������� �4

/� ������ ����������� ������

�)����������/�����'��,������+��

���������/����������������� ��������� �� ����� �����

����������� ������� ���� ��

���������� ����� �������� �������/��������� ���� ������

��������/�����-�����*��

�� ;���� ���� ����������� �������1

������0����� �/� ������ ���

������� ��������)��

�� <��������������'�&��������

����� � �����������������������

������������� ������2������

����� ��� ���������>��������($6

���7����/����� ����� ��

�������� ����������������/�����

��� �������������/������ ��

�'�&���������

�� >���� � ��������������������

�� �������� ���������������

�����������������/�����������

� ���/�� ������ �� ������ �����

� �����#���������� ������ ����

�� ����������������������� �

�������������� ���� ����������

�������������������/����4�

���/���4-����#���/� ����� ������� ��������� ���� ����

�������� ����� ����������

/� <���� � ��

���������

>��������($6

���7���

/�����4

����� ��

�������� ��

�����

Page 68:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� ?� ����������� ���� ���� ����

������������������������

������� ����� ������������

������������@� ���� ������$6

��+7����� ���������/�����

���������� ������������ �� ��

/�������� ��� �����������

�� �� ������������� ��������

��������� ��8������ ������

���� ����� ���� ��������������� ���������������� �� ���/���������

��������� ��8������������$4��4)��� ������� ���� ����� ����������

���� ��������������� �������� ����

�� ������������ ��8��������������� ��������������� ������� ������

����� ��������

A� "�������� ����������� ���������� ���/�����

%� �������2����3��������� ������� ���������������-����

�*�������������A������ �4

/� ��������� 4�����������/� 4

������������!���� �������

���/� ������ �������� ������

�������� �

�� B�� ��� ����� 4�������� ���

����������-���� �� ������4 ��4

���/��������������$�� �� ��

��� ��������� ������� ������

.�����$.����#���/� ����� 4������� �������������� ����� �����

������������/�������� ��

��� ������ ��������

���������/�������� ����� ��

���������������� ������ �������

���������������/�����-�����

��� �������������� ������ ���

������/�����*� ������ ���������

�������������<��������� ���

����������3����� �����������C

���D����� ���������������

��������1���������������� �����������������������0�

�� ��/� ��� ����������

�� "���� �� �������������������� ��

��/� 4�������� ������������

�*��

�� "���� �� �������� ���������� ������ ���� ���� �������

$4�

��

!#���/

<�������� �� ��

�� ���� ����

������ �������

�������� ������

�����������

��� �������� ����

��� �������������

� ������ ���

������ ���� �������

��� ������������

���� ������

���/� ���� ���/�

������� �����

���������������

���8 ������ ������

�������������

<�������� ����4

� ����������/

�� ���� �������

���������3� ���

��������������

3�/����$6�&��$6���+�&

�+������ �������

$6��-�������������

��� ��������� �

����������� ����

������/�� �����

������;����� ��

����������� ���

�� ���� ��������

������ ������

B

A

�-

�% �'

�-

�*

!.���/

@ ��� � ���

���/� ��� �����/�

��� ���� �������

�������������&4

��������/��� ��

��/� � ���� ������

������������ ��� ��

�������

vertical profile X

vertical profile Y

�,

�&

�-

�$

�$

�*

.

$.

Page 69:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

$

�+

%�

�+ �* %)

$

$* )

�.

�.

$4)

�(

�.

!���������/

������������ ���

� � ���������� ��

���/�������

����� ����� �� ��

�� ����� ������/� �

!.���/

@�� �� � ��� ������

�������/������ ��

��� ��/���������

������ ������ �

������� � ���� �

������ � ������/�4

������������/

���� ���������/

���������"�����

����� � ������ ��

������ �������

������ ������ �

������/���

������ ��

'� ���������2����3����� ;� �������� ����������.����

����������������/� ���������

4�������� ���� ��� �������

��� ���� ����� ���)������� �����&

��/���

�� "���� �� ������������������� ��

� ���������#���/� ������ ���� ����� ����������� �������

������������������������4

� ����� ����

&� ���������4��5������� E������

���/���

����������

$�������&�4

�� ��

����2�� ��

����� � ��

���� �����

���������� ������/���

���/�� ������ ��/������

��� ������ ����������.���� �� ��

�� ����� ������/� �����������4

����� ������ ������������/���

$���

�� @���������� �������� ��

������� ������/���� ������

��� ��������������������� �

���� ������� ����� ���# � ��

����� ���������/� ���� �������

��� ������/����������� �� ��

���/���������� ������)����

�����������������������4

/������'������,���2��������1

����/����������/� ������/�4

��������������������

��������� �� �����������4

������� ���������� ������/�4

����������� �� ��� ���� �

������ ����� ��������������

���� ������� ����� ��

�� B�� ��� ����� ���������� ������/���������� �� ������/����������

�����)���� �� ���$4�()6��-.������� �������$*������� ��������+���4�������� �/� ��� ����� ����������������� �������/����/�� ���������

�������� ���������/����$���

Page 70:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� B�� ��� ������ ����������.�

����������� ������������� ��

����� �� ��� ������ ��������

������-������*�����/� ������4

�����/��������������$��

�� "���� �� �������� ���������� ��

��� ���� ���� ���������� ��

� ���/� ������������������

-� ������� ����36������ =�����������������������

������ �� ����� ������������

�� ����������� �����������

���������� ���� � �������� �

�� =������������� ��� �������

��������� ���������� �

����������� ��������� ���4

�� ��

�� ;��������������������������

���������������������� ��

����� ����������$67�-7���

�����

����������� ������� ���������������� ��������� �������������������

�����������������6�����4�($6��$-�����'7���� ��������� ������ ��������

9 � ������� �� ���� ��"������ ���; ��������� �� ������������ ����

"���� �� ���� ������������ ������A���� ������ ���� � �������/� ��

�������/ ����������������"�������� ����� �� �� �������������

�������� �������������� ���/� ���; ��������

,� ���3�������3����'�� 9�� ������ ��;�� ������ ����������������������������/������ ��

0�����������������������7������������������������������/��� �

������ �� ��������;�� �����������)�

�� ������ � �������/������;�� ����$���� ����������� �������� �����

�� ���������������������/���������

0�����������������������7��������7����3����'

8���� 3�������3����'9����09�����7�������5�����/

�� < �������������� �� � ���������������������� ��� ���������������

������� �������� �� ��� ��� ���������� ��#�� �������������������

�������� �� ����� ��������� ��������� �� � ������ ���������&��� ��

�($6���������/����� ����� ����� ����������� ��� �������������� ��� �

�� #� ��� ������������ �����/�������� ����� ����������������������

���/������ ����� ����� �������������: ��������2��� ���/�������

��������������/� �������������/��� �����($6����7�������������/���

����������2����"������������ ���������� ��� �������������������

������ ������ ����� �������������

$4-

%'

��������/

;����������������

������� ����

� ��������� �����

����� �������

����� ��������

������� �������

�������������������

����� �� ������4

��������� ������

����� ����� ����

��������/

3���� ���� ������

�� ������� �����$6

��+���������� ��

� �� ������ ���

���������� ��

�������������

� ������

�$

�$

%%

Page 71:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� #� ��� ���������������������� ������������������ ������ �� �������

�� ����$�6�� ��� ���������������� ������������������������

��� ������ ��������������� ��������� �����

8���� 3�������3����'9����09�����3��������������7�������5/

�� ���������8��������3��� ������ ��� ����������������������� �������� ������� �������

���� ������� ������ ��������� ��� ��������� �� � ��������� ��� ���

���������������� ������������������������� �������������������;�

��/ �������� ��� ����� �� ��� �����/����� ������������������ ����

A���� ����� ��� ������ �������� ����������/��������/����($6��������

/����� ������������<������������������������������� ���/ ���������������������� ��� �����/����� ���������� �� ���� ����� ��� �������

������ �����

�������� � ������������� ������������������� ������! �� !���������! ��0 !���������! ��� ��! ��

�$%�&��'% �(� )����� �(� '�����������).++,'� ������).++,*�������).++�$� ������).++�+�

�$8�&�$)8 )���� � )��� �(� '�����������).+�+-� ������).+�+)� ������).++,*�������).++,$� ������).++,�� ������).++�+�

�-8�&�$)8 $���� � )�/���� �(� '�����������).+�+-� ������).+�++� ������).++,.�������).++,$� ������).++�)� ������).++���

�-8�&��+8 )�/���� )�/���� �(� '�����������).+�++� ������).+�++� ������).++,.�������).++�)� ������).++�)� ������).++���

�'8�&���8 )�/���� )�/���� )�/���� *�����������).+�++� ������).+�++� ������).+�++� ������).++,'�������).++�)� ������).++�)� ������).++�)� ������).++�$�

��(��0��� ���������1������0��������������

5������������ ����3����'9�! �,������� � ���������/��& ���� ����$������/����������� ���� ���$���F

�����'�&���

������� ��

������2�

�� ����

�����

�������

�� ��

�����3��4

/�����'

������ ��

��� ����

��������

����

$4*

Slotted endtubes

Butresses

Transition B slottedtube

Transition Aslotted tube

Transition Bslotted tube

Transition Aslotted tube

Buttressslotted tubes

�+

!.���/

����/���$6��-����

����������� � ����

���� ����������

���*6���-����

�� ���� ��� ��

������ �������� ��

�� ��� �������

�� �� ����������

��������������

����� ��� ���

����������/���4

��/��������� ��4

����

!.���/

������ � �����

��� ����������

� ����� �� ����4

���������� ������

������������/���

�������� �����������

��� �������������

!.���/;����� ����� �� ��������� ��� � �������� �������������� � ����� ��� ��� �� ���� ������� �� ������� ��/����� ������

Page 72:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

8���� 3�������3����'9����09��������7�������5�;��������%�7�9�5�������7�������%���/

%� <����� ����7������8����� !���������������/����������� ��������������

����� ������ ������������� ����� ��� ���

���������� ����������������

/� # � ��� ������������ ����������������� ������ ������ ����� ����������� ����� ��� ������� ��� �����/�

��� ���������)6���+������<���� � ������ ��� ��������#�

�� �� ������������� ����� ��� ���������!�� ����� ���)6��+������������������� ��� ������������� ����������

�������������/� ���� ���/� ���������� ������������

���� �������������� �������������� ������������

��� ��������=�������� ������ ��� �������������� �

��� ���������������������� �� ��� ����� ���� ��

��������� ��� ���������

�� 5����� ������������� ���������� ����� ����������� ����� ����������

����� ��� ����� � ��� ������� ������ ���������������� ��($6����

����

8���� 3�������3����'9����09�����3�����&��������7�������5/

&� =�������>���������3��������>����������� 5������� ���/� ����������������� ������ ���������� ����� ���� ��$6

��������������� ��������� ������������� � ��� ���� ��� ����� ��

� ���������������������� ��������������� ������ � ������� �� ��

��� �� ��������������/���������� �����/��� ������������ ���������� ���� ��� �����/����� ������

�� >�� � ������������ ����������������� � ������������/���� �� ����������4

��������� ��� �����/����� ����������

8���� 3�������3����'9����09��������7�������5�;�������-�3��7�������-���/

-� $�6�������� #��/� ������������ �������

�������� ���� �����������

������������������

��/� ������������� � ����� ��

��� ��������������� �����4

�������������� ���� � ����

���� ���=�������� ��������4

��������� ���������������

������� ���� ��������� ��

���/����$+������������� �

������������

$4.

ButtressButtress

3“ (7.5 cm)3“ (7.5 cm)

4“ (10 cm)4“ (10 cm)

%)

4" (10 cm)4" (10 cm)

buttressbuttress

�*

#

!

!

Page 73:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

(Retainerforbeadedlineronly)

2

3 4

SECTIONPool Component Installation Manual

Assembling the PoolWall & Liner

3-1

3

Caution:Do not attempt toinstall the pool wallin the wind. Wait fora calm day.

1Remember:For best results,mount the skimmeron the downwindside of the pool(that is, directlyacross from themost common winddirection).

Locate the skimmeron this side

Wind

Hint:Secure the slottedtube connector tothe wall with a pieceof duct tape afterinstallation to pre-vent it from lifting offthe wall.

Hint:Bring the followingitems onto the poolfoundation beforeyou start uncoilingthe pool wall: thepool liner, someextra brick sand tomake the cove inStep 5, and a ladderto climb out after thewall is assembled.

A. Assemble your Pool WallThis section is for Round and Oval pools (Round pools are shown).

1. Set the Pool Wall in placea. Wait for a calm day. Do not attempt to install the pool wall in the

wind.

b. Unpackage the coiled poolwall and stand it on a pieceof cardboard or plywood atthe centre of the pool. Thecut-outs for the through-the-wall skimmer should be to-wards the top of the wall.Look for a �THIS WAY UP� labeland arrow.

c. Start uncoiling the wall, guid-ing the bottom edge into thecurved bottom rail. The start-ing end of the wall must bepositioned over a baseplate, and the skimmer andreturn holes should be posi-tioned where the pump andfilter will be.

d. Set lengths of slotted tubeonto the top edge of the wallas you uncoil it and join theslotted tubes with connectorsas you go, leaving a 1/2" (13mm) gap between each.Make sure the gap is directlyabove the base plate (thisapplies to round pools, ovalpools and Gibraltar Stylepools). (If you have a beadedpool liner, set lengths of linerretainer on the top edge ofthe wall first, then the slottedtubes and connectors.)

Page 74:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

e. Work around the foundation until the entire pool wall is uncoiledinto the bottom rails and the top edge is covered with slotted tubesand connectors (and beaded liner retainers if you have a beadedpool liner).

2. Join the Ends of the Pool Walla. Line up the holes in the two

ends of the pool wall.

b. To line up the holes, make the circle bigger orsmaller by nudging the base plates in or outwith your foot.

c. Join the ends of the pool wallwith a bolt and nut througheach hole. Place each bolthead towards the inside ofthe pool and each nut to-wards the outside.

d. Tighten each bolt and nutsecurely.

e. Cover the seam and boltheads on the inside of thepool wall completely with 2"(50 mm) duct tape.

3-2

Remember:The bolt heads mustbe toward the insideof the pool. Cover thebolt heads with ducttape.

Hint:Stick a screwdriverthrough two of theholes to help line upthe ends of the wall.

7

5

6

8

Page 75:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

12

3-3

3. Make sure the Pool Wall isLevela. Use a length of string and a

line-level to check across thetop edge of the pool wall tosee if it is level. Check thewall in several different di-rections. The wall must belevel. If the level is off bymore than 1" (25 mm) acrossthe diameter of the pool, takethe wall apart and level thefoundation again.

4. Make sure the Pool Wall isRounda. Using a tape measure, meas-

ure across the circle at eachbase plate. The pool wallmust be round within 1" (25mm) (all of the measure-ments must be within 1" (25mm) of each other). Adjustthe circle by nudging thebase plates in or out withyour foot.

b. Adjusting the pool to the proper shape maycause the base rails and base plates to slip outof alignment a little. Recheck all of the baseplates to make sure each one is centred wherethe base rails meet.

5. Install the Styrofoam Sheets (optional)a. If you chose the option of using Styrofoam instead of brick sand,

you can now install the sheets of Styrofoam previously cut out inStep 1a. Reassemble the sheets in the centre of the pool and jointhem with duct tape along the whole length of each seam. Re-member to wait until the pool wall has been installed in Section 3before installing the Styrofoam.

11

Caution:The pool must belevel within 1"(25 mm) across thediameter. A poolthat is not level isdangerous and maycollapse.

9

10

Page 76:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.3-4

Caution:The �Wall-Saver�gasket is importantfor protectionagainst corrosion.Failure to install thisgasket properly onthe cutout for 6" or12" skimmers mayvoid the warranty ofyour pool wall. If thegasket is damaged,get a replacementfrom your pooldealer.Note: The "Wall-Saver" gasket is notrequired or providedfor walls using 14"skimmers.

16

Hint:If possible, unfoldthe liner on the grassone to two hoursbefore installation.Be careful not toleave the liner toolong or you maydamage the grass.

13

Remember:The cove is animportant part of thepool structure. Takeyour time to make acomplete, full-sizecove.

17

14

15

6. Make a Covea. Make a curved cove about 6"

(15 cm) high and 8" (20 cm)wide all around the bottomof the pool wall on the inside.

b. Use fine earth or brick sandto make the cove, and packit firmly into shape.

7. Install the �Wall-Saver� Gasketa. The Wall-Saver gasket pro-

vides a water-tight sealaround the skimmer cut-outfor the through-the-wall skim-mer. Gently spread apart thetwo layers of the gasket andinsert it into the skimmer cut-out so that it sandwiches thewall. Be very careful not totear or damage the seam inthe gasket or the gasketmay leak. Take extra carenot to cut or damage thegasket when you are install-ing the skimmer later. If thegasket is damaged, youmust get a replacement fromyour pool dealer.

Note: The "Wall-Saver" gasketis not required or providedfor walls using 14" skim-mers.

B. Install your PoolLiner1. Set the liner in place

a. Open the carton. Do not useanything sharp to open thecarton.

b. Unpack and unfold the linerand spread it out in the sunto warm it up. Inspect all theseams and surfaces for holes.

Page 77:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

18

19

c. Spread out the liner, smoothside down. The curved seamshould be centred on thecove at the base of the wall.The other seams will formstraight lines across the bot-tom of the pool.

d. Smooth out all the wrinkles inthe bottom.

2. Fasten the Liner in place(Overlap Liner only)

This step applies only if you have an OverlapLiner. See the next page if you have a BeadedLiner or V-Bead Liner.

a. Lift the sides of the liner and drape them overthe top of the pool wall. If you have a 52" (132cm) high pool, pull the liner up until there is 2"(5 cm) overhang; if you have a 48" (122 cm) highpool, pull the liner up until there is 6" (15 cm)overhang.

b. Fasten the liner to the top of the wall with plasticcoping. Let the liner hang slack for now. Do notpull the liner tight.

c. Start filling the pool with water. As the pool fills,work out all the wrinkles and smooth the liner tothe wall. Remove the plastic coping around thetop edge of the wall one piece at a time andadjust the liner. Keep smoothing out the wrin-kles.

3. Trim the Plastic Coping and Roll Up the ExcessLinera. After all the wrinkles in the liner are removed,

trim any extra length of plastic coping so thereis no overlap.

b. Roll up any excess liner hanging below theplastic coping and tape it in place near the topof the pool wall. Important: Do not trim off theexcess liner.

3-5

Remember:Do not trim off theexcess liner. (If theliner ever needs tobe removed, trim-ming the liner willmake re-installationvery difficult.) In-stead, roll up anyexcess liner andtape it in place nearthe top of the poolwall.

Hint:To smooth out thewrinkles in step 2(c),use a vacuumcleaner: block theskimmer outlet withcardboard and tapeand put the vacuumhose through theskimmer return hole,between the linerand pool wall. Sealthe hole with tapeand keep the hose 4"to 6" (10 to 15 cm)above the sand coveso you don�t suck upany sand. Start thevacuum and run ituntil most of thewrinkles are gone.Then, stop thevacuum and add 1"(2.5 cm) of water tothe pool. Finally,remove the vacuumhose and unplug theskimmer hole.

20

21

Page 78:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

22

23

3-6

24

25

4. Fasten the Liner in place (Beaded Liner only)This step applies only if you have a Beaded Liner. See the previouspage if you have an Overlap Liner or below if you have a V-BeadLiner.

a. Lift the sides of the liner andinsert the beaded edge intothe liner retainer on the topedge of the pool wall.

b. Start filling the pool withwater. As the pool fills, workout all the wrinkles andsmooth the liner to the wall.

5. Fasten the Liner in place (V-Bead Liner only)This step applies only if you have a V-Bead Liner.

See steps 2 and 3 if you have an Overlap Liner,or step 4 if you have a Beaded Liner.

a. Remove the slotted tubes andconnectors from the top edgeof the pool wall. Important:do not remove all of the slot-ted tubes at once; removeonly two lengths of slottedtube at a time.

b. Hook the V-bead over theedge of the pool wall.

c. The space between the endsof the slotted tubes at the topsof the locations where theverticals will be attached,should be about 1/2" (13 mm).If you have a Gibraltar OvalSystem , refer to page 2-6,step 2 in the Gibraltarmanual.

d. Replace the two lengths ofslotted tube and connectors.

e. Repeat steps (a) to (d) untilyou have gone around theentire pool and finishedattaching the pool liner inplace.

f. Start filling the pool with water. As the pool fills, work out all thewrinkles and smooth the liner to the wall.

6. Proceed to Section 4a. Continue with Section 4 to finish assembling your pool.

Page 79:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

A. Attach your Verticals and Top Rails1. Continue filling your Pool

a. Continue filling your pool with water. Do not put in more than 12" (30 cm)of water until the top rails and vertical columns are all attached.

b. Keep working on the top rails and vertical columns while the pool fills.

• See the drawing on the next page for an overview of all the parts usedto install the verticals, top rails and top connectors.

2. Install the Vertical Columnsa. Line up the bottom of one verti-

cal column (key 1) with the twosmall tabs on one base plate(key 2). The tabs must be on theinside of the vertical column.The end of the vertical withthree holes must be nearest thetop and the end with two holesnearest the bottom.

b. Line up the screw holes andfasten with one self-tappingscrew on each side (key 3).

c. Hook a top plate (key 4) over the top edge of the poolwall (key 5). Place the top plate down over the top ofthe vertical column with the tabs on the outside ofthe column. Make sure the vertical column isstraight up and down.

d. Line up the screw holes and fasten with one self-tapping screw on each side and one on the front(key 6).

e. Repeat the last four steps for each of the vertical columns around thepool wall.

SECTION Pool Component Installation Manual

Installing the TopRails & Verticals

!Hint:Use the ridges in thepool wall to makesure the verticalcolumn is straight upand down.

4-1

4

1

2

1

3

2

4

65

Page 80:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

Overview ofVertical, Top Railand Top ConnectorAssembly

4-2

3

1

2

5

8

6

4

7

11

10

9

Page 81:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

3. Install the Top Railsa. Place a top rail (key 7) with one end on top of the top

plate. The side of the top rail facing the centre of thepool is shorter than the side facing the outside of thepool. The side of the top rail facing the outside of thepool will form a large overhang.

b. Line up the holes as shown. Fasten through the twooval holes into the holes marked ‘A‘ in the top platebelow with two self-tapping screws (key 8). Do nottighten the screws yet. Leave the screws slightlyloose until all the top rails are in place.

c. Repeat the last two steps for the other end of the top rail.d. Repeat steps (a) to (c) to install the rest of the top rails around the top of

the pool wall.e. Make the pool settle into a

perfect circle by pushing the topof the pool wall vigorouslyinward at each vertical (this willhelp make the bottom of thepool wall shift into a perfectcircle).

f. Adjust all the top rails to line upevenly with each other andtighten all the screws.

4. Install the Top Connectorsa. Tip lower

half of thetop connec-tor (key 10)and hook itonto the twoouter cor-ners of theupper half (key 9). Tip lower half of the top connector (key 10) into place(the upper half of the top connector will rotate on the corners of thelower half like a hinge, locking the two parts together).

b. Fasten the upper and lowerhalves of the two-piece topconnector (key 9 and 10) withtwo self-drilling ‘Teks’ screws(key 12). Be sure to hold the twoparts together very tightly, tomake a tight joint with the twoscrews.

4-3

3

8

7

Push vigorouslyPush vigorously

4

Upper Half

Lower Half

765

9

10

!Important:You will find the self-drilling ‘Teks’screws (key 12) inthe Top Pack, inpackage number1184232. Do notconfuse these withthe other self-tap-ping screws. 8

12

9

10

9

Page 82:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.

c. Line up the assembled upperand lower halves of a two-piecetop connector (key 9 and 10)above the ends of two top rails.

d. Hook theupper halfunder theinsideedges of thetop railsand holdthe hooksfirmly in place. Bring the lower connector down into place under the toprails by spreading the sides out completely, as shown in diagram 11, andgently stretching it across and down, as shown in diagrams 12 and 13.

e. Line up the two screw holes inthe lower half connector withthe two holes in the verticalcolumn. Fasten the connector inplace with two self-tappingscrews (key 11). Tighten thescrews.

f. Repeat the last five steps for therest of the top connectors.

4-4

10

9

10

131211

!Caution:Be sure to spread thesides of the lowerhalf connectorcompletely beforestretching it acrossthe top rails or theconnector may bedamaged.

1411

Page 83:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

No Diving or Jumping. Observe all Safety Rules.4-5

g. For oval pools only: at thetransition points only, where theend rail meets the side rail,make sure the side rail lines upproperly with the end rail. If itdoesn’t line up the connectorwill appear crooked from above(see diagram 15). If the connec-tor isn’t centred between therails, temporarily remove theconnector and loosen the screws on the side rail. Shift the side rail in orout from the centre of the pool until the connector can be properly cen-tred between the rails (see diagram 16).

h. Coat all showing screw heads with clear outdoor varnish.

B. Fill your Pool with Water1. Finish filling the pool

a. Fill the pool with water to 2" (5 cm) below the lowest opening. Next,follow the installation instructions for your skimmer.

Crooked ConnectorCrooked Connector Centred ConnectorCentred Connector

Side RailSide RailTransition RailTransition Rail Move the Side Rail

slightly to centre the Connector

Move the Side Rail slightly to centre the

Connector

15 16

!Important:The pool wall maybulge and shift a littlewhile filling withwater. This is normal.

!Caution:Before anyone usesyour pool, read andfollow all the SafetyRules in Section 1.This pool is not fordiving or jumping.

Page 84:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

0�����������������������7��������7����3����&

8���� 3�������3����&9����09�����3�����'�����7�������5/

'� ���������!�������#���/�D���� ������������ ������������� �� �� �������� ���������

���������� �������������������������������������������������;�� ���

)�

�� <�� ���� ��������������� ����

���� �����������������G#8����

����������� ����������

������������/����$���B�� ��

���/�� ��� ������������ �

��� ����� ��������� �� ��

���4 �����/�������������,���4����� �/� ���������� ���������

�� ��>����� ������������/� �

������ ���� ��� �����������

���������=�������� ������ �4

����������/����� ���/� ������

������#���/� ����$%�&��'%����

������� �����������������

�� <�� �� �����������/���� ����

������������;�� ����)����������

���������� ������������� ����

�� ���������/� ������� ����� ����#

���������������������� ���

3��� ����������� ������������� �����<��������������3��1

��3���� �� ��� ����������� ��������� ���������� �� ��

�� ������� ������ ����� ����������

�������� ��� ������1������ �� ���

��� ������ �� ������ ����� ��

�����?��� ���������� ��� �����4

����#� ������� �� ����������

� ������������� ����� �� ��

�����������?�@���� ��� ���� ������������������/����$$�

B��� ������ ���� ����������������

����?08���������������� ��

��������������������/����$��

B�� ��� ���/�� ��� ������

����� �� ��� ����� ������

�� �� ������4 �����/�������

�����,��

4����� �/� ���������� ������������ ��>����� ������������/� ������

� ���� ��� ��������������������

$4'

Transition ATransition A

Side RailSide Rail

End RailEnd Rail

Vertical

Buttress

%�

'

use hole Buse hole B

buttressbuttress

Transition Atop railTransition Atop rail

%%

,

'

first vertical onround end of pool

use hole Ause hole A

first vertical onround end of pool

%'

,

'

!���������/

<�� ���.6���'����� ��

�� ����������/���

$��������������

���������

�� ��� �����/� ��

������� ��

��� ���/� ��

����� ������������

������������� ��

#��� �����<�� ��4

����<������ ����

#���/� �������

��������� �����

������������� ��

*6���-7���� ��

�� ��������

�������� � ���.6

��'7���� ����� �

��������/����$��

���������������

��� �����@������� �

� ���������� ���

��/��

6" (15 cm) Top Plate

Connectors

Page 85:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� !�/�����/��� ��������� ��� ����� ����#� ������������������������� ��

���������'������� ��� ����� ��� ���� ���������� ���� ������������� ��

����� ��� ������ �������������������/����$�������������/����������� ��� ������� ����������������� ����������� �������������������/������4

���/����������������� �����������<�� �� ����������������������

���/����$)��5���������� �� �������������������(�*6��$������� ����

����������� ���������3���� � �/� ��� ������������ �������������/�

����� ����A� � ��������� ���

���������/����������� ������ ����������� �� ���/� ���������������A�

���������� �������� ���������� ������ ��������� ������������ ����

���5������ �����/���� ���������� ���� ������������������������

������<���������� ����A� � ��� ������ ������ ����������������� �

������� ��� ����� ������ �������� ���������� ������������������4

�/���

�� 9����� �����/ ����� ���������� ����� ����#� �������������������� ���� �

<�� ���������� ��� ����� ���������������� �������������� ������� ������ 1

��� ��������������� ��� ����� ������������� ��� ��� ����������� ��� ��

�� �������� ����������������#���/� ����$%�&��'%������������ ��������������1����������������������� �����A���� � ����� ����������<�� ��

����� �� � ��� ����� �������������� ����� ������� ������� ��� ��

��������A� ���� ������� ���������� ��� ����� ���������������� �����

�� ��� ����� �����������������������������&��� ���$6��-�7���

��A� ��� �� ������������� �������

�� "���� �� �������������������� ���� ������������ �������

&� �7�����������������������������������A��3 �7��������������/�� ������������������ ������

��� ������������ �� ������& � �

��� ����� ����������#���/� ����$%&��'%������������ ����������

������

�� @��������������� �������������

����������'��������� �� �������

������#���/����� ����$%�&��'%����������������������� ���� ���

����� ����������@���� ���� ���

��������� ���7���������3�����

��������������� ����������

������������� ��� �������

���������� �����A� ���

������������ �������������<�

�����������$%�&��'%������A��

��� �����������

$4,

first vertical onround end of pool

use hole Ause hole A

first vertical onround end of pool

%&

,

'

ButtressButtress

OverlapOverlap

Side railSide rail

Transition Atop railTransition Atop rail

%-

'

Page 86:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

�� 5� �� ���������� ��������������

������� ��� ����� �������������

���������������($6��������

�����4�('6��$,��������������

���������� �����������������

����������������� ���� ���

������� ��������������������

� � ������� ��������B�����C��������� �����B���������� �� ������

��� ��������������($6��������

����������������� ���������

���� ����/� ������ ��� ��� ����� ������������������������C�������

������ �� ���������� ��������������4�('6��$,���������������������� ��

���� �� � ��������()6��*����������������������

�� �������� ������ �������� ����()6��*����������������

����� �������� ���/�� ������ ��������������� ��

������������������� �� �����/ ����� �������� �

�� ����� � �������C�������� ����� ������� �������������� ������� ������ �������� ��������()6��*����������

����� �� ������ �����������

�� <������������������������� ��� ���������� ���

�()6��*����������4�($6���'��������$4�('6��-)����

������ ������������� ����������/� �������C�=������ �� ���� ����������������

�� "������ ��� ����� ���������������� ����()6��*�������������/� ��

������ �� ������� �������C�

/� 9 � ��� ����� �����������/� ����($6�������������B����/����������

������������� ��� ���� ��$� �� ������������

�� B�� ��� ���������������� ��� ����� ����������������

�� "���� �� �������� ������ ����� �� ��� ��������� � ���� ����������� ��

����

A� 9�� ������ �� �����������/�� �����&�������������������;�� ���

)������������������� ����������������� �����@�� �#�������; �����������������

�� �������

�� <�������������$%�&��'%����������� ���� ��/�����C����/� ������ �����

��� ����� �������� ��� ��� ����� ������������ ����������C��������

������������ ������B�� ��()6���,�������������������B������� ��4

����� ������ �������� ����()6��*���������������������� ��������

� �������� ���A��

� 9�� ������ ��;�� ����)��; ���)�������������

$4�+

Line Y for new holesTwo linesthrough oldoval holes,intersectingline Y

Transition Atop rail

XY

%(

1-1/8"(29 mm) 1/2"

(13 mm)1/2"(13 mm)

Cut lineCut lineYY

XX

Line fornew holesLine fornew holes

Side railSide rail

Transition A top railTransition A top rail

%,

Page 87:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

4� $���������5�� �����#� ����������������������� ���/��������������� �������� �� ����� ������

� �������������/����������

�� !�>������ 9����� ����������/�������������

�� =������������������������� �� ���������� ������������� �

%� ����8������2����3����� ����� H���� ����������������� ����������������5�����������������

�� ����� ������������4����������������������������������������

�� 5���������������������������������/� ������

�� "���� ���������/��������������� �������� �������������

�� 9��������� ����� �������� ���/������ ���� �����������������

�� ����������� ����������� ������������ ����� ���� ���� ����/��� �4

�� ����� ��B���� �������� �������� ������� �����

�� ������ ��������������� ����� ������������������ ���$6���+����������

"������ ��� �����/����� ������������� �������������������������4

������ ���� ������������� �����������;���;�� ����)�������� �� �������

�������/� ��������

/� @����������� �� ���� ������������ � ����������������� �������4

��/���>������ ��������&���������� ���

$4��

�� ����/

9����������

����/���������

����������� �

��� ���5�������

�������/� ������

��������/

#����� ����������

������������

��������� ��

������� ���� �4

�� ����� ��#�����

�� ���������

�����������

Page 88:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������

� 8���������5�� �����# � ���������� ����������/�������������� ������ ���������� ����� �

����������������������� ������ ���

�� >������8����>������ >����� ����� ������������������� ��� ������� �*6���-���������� ��

�� ����� ����� ��/�

�� "��������������� ������ �� ����������������� ����� ��/���$�6�

� �������������������7������6������ ���59�����6�� ��

����������������7���6���������7�D#�>DEE 4�

%� ��36���<���������3������ =���������� ���������A��� �������� ��/� �/� ��������������������

���� ���������������� ����� �������� ����� �������

�� =����������������������� ������ �/� �

'� ��367��� ��@��� ��������� ���������� ���������� ���� �4�� ����� �

&� ��36��>����=�������� ��� ������ ������������ ��� ������ �� ������������ �

��� ��������/��4������������ ������������� ��������"��������� ��������������� ����&�� ��/������� ���4������������� ����� �������

����������� ������ ���

-� =�����5>��6�=�������� ���������������������9����� ���������������������������

����������� ����������� ����>�������� ������ ������������������

����/�� ����������

,� ����033��������"����������������������������� ��������������/� ����������>����

���������������3��� �� ����������������� �� � ����������������

��� ���������������5�����������7���6�������������

����33 � ����������3�������������������

(� !�=�����3�������� � �������������� ����� ����B���� ������ ���2��/���� �� ����

��������� ��������

$4�$

�� ����/

4������������

����� �����������

�������� ������ ���

����������������

���������#����� �

��������������

��� ������ ���

��������/

B����� ����� �

���I@��

5�� ���2��/�H� :����

����� ��

��� ���2��/������4

���������������4

������� �� ����

��� �� ���������

����� ������

������ ��

Page 89:  · 1-4 No Diving or Jumping. Observe all Safety Rules. 15 x 24 Oval Pool Dimensions R 90" (229 cm) S 102" (259 cm) L 54" (137 cm) M 30" (76 cm) N 48" (122 cm)

��������������� ����� �������������������������$4��

���������8���������5#���3�

0�������/

������ ��������� �������� ������� ���� ��6��.*���������� �����������������/

���/�� � ������ ����;������ ����� ��������������������/���������/���

��������/���� �� �� ������8 ��� ��� ���������������/� ������ �����������������

����3�������6����������� ��7�����5��!�������5�����������7��

�6�����$D�!��6�������������33 � ����������3�������������������

���������%F�')3���6������/

<������ ���� �� ���������� ���@���5�� ���2��/�H� ��@�� �J�������.+��'���� ���

����� ����� �� ����$6���+�������������������� �� ����������

=��� �������������G����8���������5H��I���7�����������������5���3�1

� ���9���33�����3������������� 3�����9����������������������

����@���5�� ���2��/�H� ��@�� �J�������.+��'�����������������������������

������

0�������/

4��������3������3����� �� ��� ������������ ������������ �������������� ���� ��

��������

�������������

� ���� ��������

����B����� ������/���������������� �� �����������������/�� ��� ��� �������� �� ��

��������/��

����� ���������

����@���� ������/���������������� �� ����������� ���� �

$���B����� ������ ��/����������������� �� �����������������/�� ��� ��� �����

�� �� �����������/��

�����

?������������������ ������������������ �� ���� �������� ������������� ������ ����(��

���������������/�� �������� �������������/� ������ ���

=��� ������ ��������

��� ��6��.*���������

��������������/

���/� � � ������ ���

�6��.*����

�$6���+�����5����=� ��;������

������� ��/����������

�� ����� <�� �����/��������

��������� �