pre-feasibility report - welcome to...
Post on 10-Apr-2018
223 Views
Preview:
TRANSCRIPT
PRE-FEASIBILITY REPORT
OF
CHEJA PATHAR (MASONARY STONE)
MINING PROJECT
(M.L. No. 94/2005, ML Area: 1.0 ha)
Near
(Village- Kundala ki Dhani)
Tehsil - Neem Ka Thana
District- Sikar (Raj.)
PROJECT PROPONENT
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar
1381, S.G.M. Nagar, Faridabad (Haryana)
Pin Code-121001
Contact Person: Shri Manoj Kumar
Contact No.: 9649803020
INDEX
S. NO. PARTICULARS PAGE NO.
1.0 EXECUTIVE SUMMARY 1
2.0 ENVIRONMENTAL MANAGEMENT PLAN 1
2.1.1 AIR POLLUTION CONTROL 1
2.1.2 WATER MANAGEMENT 1
2.1.3 NOISE POLLUTION CONTROL MEASURES 2
2.1.4 LAND RECLAMATION 2
2.1.5 SOLID WASTE MANAGEMENT 2
2.1.6 GREENBELT DEVELOPMENT 2
3.0 INTRODUCTION OF THE PROJECT/ BACKGROUND INFORMATION 2
4.0 Project Description 3
5.0 Site analysis 8
6.0 Planning brief 11
7.0 Proposed infrastructure 11
8.0 Rehabilitation and resettlement (R&R) plan 12
9.0 Project schedule & cost estimates 12
10.0 Analysis of proposal 13
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 1
PRE – FEASIBILITY REPORT
1.0 EXECUTIVE SUMMARY
Table-1
Salient features of the Project
S. No. Particulars Details
A. Mining Lease Details
1 Nature of the Project Cheja pathar (Masonary Stone) Mining project
2 Mining Lease Number 94/05
3 Mining Lease Area 1.0 ha
4 Lease Holder (Proposed) Shri Ashok Kumar S/o Shri Ram Kumar Gurjar
B Location
5 Village Kundala Ki Dhani
6 Tehsil Neem Ka Thana
7 District Sikar
8 State Rajasthan
9 Latitude & Longitude FRP Well chhatri road Latitude - 27°46’05.6” N Longitude
- 75°54’19.58’’E
C. Requirement of the Project
10 Water Requirement 3 KLD
11 Manpower Requirement 32 person
12 Cost of the project Rs. 50 Lakhs
13 Cost for Environmental
Protection Measures
Rs. 1.5 lakhs per annum
14 Seismic Zone II
2.0 ENVIRONMENTAL MANAGEMENT PLAN
2.1.1 Air Pollution Control Measures
���� Periodical water spraying on the haul roads will be done.
���� Plantation will be done on lease boundary.
2.1.2 Water Management
���� There is no surface water body within the mining lease area.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 2
���� The rain water collected in mining pit will be diverted in the abandoned pit of
major mineral mining lease and used for water sprinkling and plantation.
���� Domestic waste water generated from office toilet will be disposed in soak pits
via septic tank.
2.1.3 NOISE POLLUTION CONTROL MEASURES
���� Proper maintenance of all machines will be carried out which will reduce noise
generation during operations.
���� Workers exposed to high noise levels will be provided with ear defenders.
2.1.4 Land Reclamation
���� Total mining lease area 1.0 hectares.
���� The excavated area will be converted as water reservoir as well as plantation
on the lease boundary will be done.
2.1.5 Solid Waste Management
���� Lessee dispatches Cheja Pather as ROM. No sorting will take place at site. Thus,
waste will not be generated separately.
2.1.6 Green Belt Development
���� Green Belt will be developed around the mining lease area. Native species will
be planted Local Species will be preferred for plantation.
3.0 INTRODUCTION OF THE PROJECT/ BACKGROUND INFORMATION
Consent to Operate (CTO) has been issued by RSPCB. Now applying for
Environmental Clearance with Cheja Pathar (Masonary Stone) (M.L. No. 94/05, ML
Area 1.0 ha) located near Village: Kundala ki Dhani, Tehsil:Neem Ka Thana, District:
Sikar (Rajasthan) of Shri Ashok Kumar S/o Shri Ram Kumar Gurjar.
(I) Identification of Project and Project Proponent
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar is has a mining lease for
Masonary stone, (M.L. No 94/05, Area 1.0 ha.) Village: Kundala ki Dhani,
Tehsil:Neem Ka Thana, District: Sikar (Rajasthan).
(ii) Brief Description of the Nature of Project
This is Cheja Pathar (Masonary Stone) Mining Project (M.L. No. 94/05, ML Area
1.0 ha).This is an opencast semi mechanized mining project.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 3
(III) Need for the Project & Its Importance to the Country/ Region
The mineral Cheja Pathar (Masonary Stone) is used in various construction
activities and will be sold to nearby areas to fulfill the requirements of the local
region.
(IV) Demand – Supply Gap
Considering the demand of mineral sufficient availability of the mineral in the
area, it is essential to have Cheja Pathar (Masonary Stone) mine to sustain the
supply of mineral for construction purpose.
(v) Imports vs. Indigenous Production
It is a cheap mineral used in construction activities in rural therefore export is
not possible
(vi) Export Possibility
There is no export possibility as these mineral is quite cheap and locally
available in abundance and used in rural areas.
(vii) Domestic/Export Markets
These minerals have only domestic market and will fulfill the requirement of
local.
(viii) Employment Generation (Direct and Indirect) due to the Project
Approx 32 manpower will be needed to run the mine.
4.0 PROJECT DESCRIPTION
(i) Type of Project Including Interlinked And Independent Projects, If Any
There is no interlinked or interdependent project based on mineral produced.
The mineral will be sold directly.
(ii) Location (map showing general location, specific location, and project
boundary & project site layout) with coordinates
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 4
Figure1: Location Map
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 5
(iii) Details of Alternate Sites Considered
No alternative site has been taken into consideration due to availability of
mineral resources in the area in question.
(iv) Size and magnitude of operation
Proposed production of Cheja Pathar (Masonary Stone) 254000 TPA, Area 1.0
ha.
(v) Project Description with Process Detail
1. Salient features along with project vicinity details of the Mining
project is given below:
Table - 2
Salient Features of the Project
S. No. Particulars Details
1 Name of the Project Cheja pathar (Masonary Stone) Mining project
2 Mineral Cheja pathar (Masonary Stone)
3 Mining Lease Number 94/05
4 Mining Lease Area 1.0 ha
5 Lease Holder (Proposed) Shri Ashok Kumar S/o Shri Ram Kumar Gurjar
7 Elevation Range in the
area
417 mRL to 424 mRL
8 General ground level 400 mRL
10 Ultimate Working Depth 375 mRL
2. Geology of The Area
Mineral resource map of district the rocks of the area belong to Ajabgarh
group of Delhi Supeer Group.
Strategraphic sequence of Regional Geology is given below:
Recent Soil
Post Delhi Pegmatite, Granite, albetite
Delhi Super
Group
Ajabgarh Group Brecciated quartzite,quartzite,Ortho
Quartzite, Phyllite, Impure
marble,amphibolites,Carbonaceous
Phyllite,Quartzite, calc silicate
Alwar Group Massive quartzite,schist,conglomerate
quartzite,calc-silicate
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 6
LOCAL GEOLOGY
Recent Soil
Post Delhi Absent
Delhi Super Group Ajabgarh Group Quartzite
3. Method of Mining
Proposed method of mining will be semi mechanized opencast by
forming proper benches by driling, control blasting. The mining is
proposed as per present situation of the deposit.
Hydrauluic machinaries will be deployed for excavation of cheja pather
and loading of the cheja pather. Tippres will be deployed for the
transportation of the cheja pather.
PROCESS FLOW CHART OF MINING
TOP SOIL & O.B. REMOVAL
DRILLING
BLASTING
LOADING
TRANSPORT
TO CONSUMERS
4. Loading & Transport
Tyre mounted Hydraulic excavator will be deployed from time to time
and when required. Trucks and tracor troley will be deployed for
transportation of cheja pather.
5. Waste Generation & Disposal
The lessee dispatches Cheja Pather (Masonary Stone )as ROM. No sorting
will take place at site. Thus, waste will not be generated separately.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 7
6. Conceptual Plan
The conceptual mining plan for 5 years considering proposed capacity of
mine for the mineral has been prepared by considering the probable
category of reserve excluding reserves falling in safety zone.
Area about 0.8518 ha. will be used in mining up to the end of life of
the mine up to 25.0 m. depth. & area about 0.1482 ha. will be used
in plantation on periphery of lease boundary.
At the conceptual stage of mining, the excavated area about 0.8518
ha. out of which area about 0.0204 ha will be backfilled &
reclaimed by Plantation and rest area about 0.8314 ha will be
converted in to water reservoir.
(vi) Raw Material Required Along With Estimated Quantity, Likely Source,
Marketing Area of Final Products, Mode of Transport of Raw Material and
Finished Product
The cheja pather (masonary stone) will be transported tipper and tractor
trolley. No raw material will be required.
(vii) Resources Optimization/ Recycling and Reuse Envisaged in the Project, if
any, should be briefly Outlined
No waste water will be generated from mining operation.Domestic sewage
water generated from office toilet will be disposed in soak pits via septic tank.
(viii) Availability of Water Its Source, Energy /Power Requirement and Source
A. Water requirement:
Total water requirement for the proposed project will be 3 KLD which
will be sourced from nearby villages.
B. Power requirement:
The electric power will not be use for the process of mining.
(ix) Quantity of Waste to Be Generated (Liquid and Solid) And Scheme for
Their Management/Disposal:
Domestic sewage water generated from office toilet will be disposed in soak
pits via septic tank.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 8
5.0 SITE ANALYSIS
(i) Connectivity
The lease area about 1 km from Kundala Ki Dhani. Dispensary, hospital and
educational facilities are available in Neem Ka Thana. Railway line is available
in Neem Ka Thana which is at a distance of about 13 km. The lease area is well
connected through roads.
(ii) Land Form, Land Use and Land Ownership
Existing Land Use Pattern
The total ML area of 1.0 ha comprises of Govt. land.
(iii) Topography
The lease area is undulated terrains. The highest contour is 424 mRL and
lowest is 417 mRL. This provides elevation difference of 7 m RL.
(iv) Existing Land Use Pattern {Agriculture, Non-Agriculture, Forest, Water
Bodies (Including Area Under CRZ)}, Shortest Distances From The
Periphery Of The Project To Periphery Of The Forests, National Park,
Wild Life Sanctuary, Eco Sensitive Areas, Water Bodies (Distance From
The HFL Of The River), CRZ. In Case Of Notified Industrial Area, A Copy Of
The Gazette Notification.
Table – 3
Environmental Settings
S. No. Particular Details
1 Nearest Village Kundala Ki Dhani
2 Nearest city/ town Sikar at distance is ~ 77 Km from the mine site
3 Nearest Railway Station Neem ka Thana Railway Station ~ 13 km
4 Nearest Airport Jaipur international Airport,Jaipur ~ 105 km
5 Archaeological Important Place None, within 10 km radius area of mine site.
6 Ecological Sensitive Areas
(National Park, Wildlife
Sanctuary, Biosphere Reserve
etc.)
There is no National Park, Wild Life Sanctuaries,
Biosphere Reserves, Tiger Reserves, Wildlife
Corridors, etc. within 10 km radius
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 9
7 Reserved/Protected Forest
within 10 km radius
• Patan PF ( ~ 6.0 km NE )
• Kharjo PF ( ~ 8.0 km ENE )
• PF ( ~ 8.0 km ENE )
• PF ( ~ 2.5 km SE )
• Gadrata PF ( ~ 5.5 km SSE )
• PF ( ~ 3.0 km SW )
• Ganwari PF ( ~ 1.5 km SSE )
• Dokan PF ( ~ 0.5 km N )
8 Nearest River / water body • Dokan Dam ( ~ 2.0 km ENE )
• Krishnawati Nadi ( ~ 6.5 km ESE )
• Rajpur Dam ( ~ 6.0 km ESE )
• Jhilo Dam ( ~ 7.50 km N )
9. Interstate bounadries No interstate boundary is within 10 km radius of the
lease area.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 10
Figure-2 Key Plan
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 11
(V) Existing Infrastructure:
There is no building & structure within mining lease area except some vegetations
existing on the lease area which will be cleared when required. Total lease area is Govt.
Land.
The lease area about 1 km from Kundala KI Dhani. Post and Telegraph, Hospital, Bank,
Education and all market facilities are available at Neem Ka Thana. Jaipur International
Air Port is the nearest airport approx. 105 km from the mine site. Railway facilities
available at Neem Ka Thana which is approx 13 km.The lease area is well connected
through roads.
6.0 PLANNING BRIEF
(i) Planning Concept (Type of Industries, Facilities, and Transportation etc.) Town
and Country Planning/Development Authority Classification
Uses: This is a mining Project
(ii) Population Projection
Manpower required will be engaged from nearby areas. No significant influx of people is
anticipated in the area.
(iii) Land Use Planning
The extent of proposed mining lease area is 1.0 ha. The area comprises of Got. land.
(iv) Assessment of Infrastructure Demand (Physical & Social)
Lessee will assess the demand of infrastructure (Physical & Social) in nearby area of the
proposed mine site and same will be developed under social work
(v) Amenities/Facilities
Mining Management will develop the Amenities/Facilities in the nearby area of the
proposed mine site as per requirement of local people of the nearby area under
corporate social responsibility programs.
7.0 PROPOSED INFRASTRUCTURE
(i) Residential Area (Non Processing Area)
This is not required as mine workers comes from nearby villages. Rest shelter to the
workers already exists in the major mining lease of the lessee.
(ii) Green Belt
Green belt will be developed on strategic area and equal to 33% of the lease area.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 12
(iii) Connectivity
The lease area about 1 km from Kundala KI Dhani. Post and Telegraph, Hospital, Bank,
Education and all market facilities are available at Neem Ka Thana. Jaipur International
Air Port is the nearest airport approx. 105 km from the mine site. Railway facilities
available at Neem Ka Thana which is approx 13 km. from the mine site.
(iv) Water Management (Source & Supply of water)
The water is required for drinking purpose only and drinking water is available by the
water tanks in the lease area.
(v) Sewerage System
Domestic sewage water generated from office toilet will be disposed in soak pits via
septic tank. Outside discharge is not envisaged.
(vi) Industrial Waste Management
No industrial waste water will be generated from this mine mining operation.
(vii) Solid Waste Management
The lessee dispatches Cheja Pather (Masonary Stone) as ROM. No sorting will take place
at site. Thus, waste will not be generated separately
(viii) Power Requirement & Supply/Source
Electric power will not be required in mining operations.
8.0 REHABILITATION AND RESETTLEMENT (R & R) PLAN
(i) Policy To Be Adopted (Central/State) In Respect Of The Project Affected Persons
Including Home Oustees, Land Oustees And Landless Laborers (Brief Outline To
Be Given)
Not Applicable as the lease area falls in Govt. land.
9.0 PROJECT SCHEDULE & COST ESTIMATES
(i) Likely Date Of Start Of Construction And Likely Date Of Completion (Time
Schedule For The Project To Be Given)
This is a case of existing mine Consent to Operate has been already issued by RSPCB.
Now Environmental Clearance required as per As per MoEF Office No. J-
13012/12/2013-IA-II (I) dated 24.12.2013 the project is comes under B2 Category.
Cheja Pathar (Masonary Stone) Mining Project (M.L. No.94/05, ML Area 1.0 ha)
Near Village: Kundala Ki Dhani, Tehsil –Neem Ka Thana, District-Sikar (Rajasthan)
Pre- Feasibility Report
Shri Ashok Kumar S/o Shri Ram Kumar Gurjar 13
(ii) Estimated Project Cost Along With Analysis In Terms Of Economic Viability of the
Project
(i) Total Project Cost : Rs 50.0 Lakhs
(ii) Environment Protection Cost : Rs 1.50 Lakhs Per annum
10.0 ANALYSIS OF PROPOSAL
� Proposed Cheja Pathar (Masonary stone) Mining Lease will result in growth of the
surrounding areas by increasing direct and indirect employment opportunities in the
region including ancillary development and supporting infrastructure. Special emphasis
on Financial and Social benefits will be given to the local people including tribal
population, if any, in the area.
� Development of social amenities will be in the form of medical facilities, education to
underprivileged and creation of self help groups.
� No major adverse effect on environment is envisaged as the required mitigation
measures are inbuilt in the project.
top related