cdx-r3300ee - especarchive.espec.ws/files/sony_cdx-r3300ee_sm.pdfcdx-r3300ee cd player section...

1

Ver 1.0 2004. 02

Model Name Using Similar Mechanism NEW

CD Drive Mechanism Type MG-611MA-186//Q

Optical Pick-up Name KSS1000E

SERVICE MANUAL East European ModelCDX-R3300EE

CD player sectionSignal-to-noise ratio 120 dBFrequency response 10 – 20,000 HzWow and flutter Below measurable limit

Tuner sectionFMTuning range FM1/FM2:

87.5 – 108 MHz(at 50 kHz step)FM3:65 – 74 MHz(at 30 kHz step)

Aerial terminal External aerial connectorIntermediate frequency 10.7 MHz/450 kHzUsable sensitivity 9 dBfSelectivity 75 dB at 400 kHzSignal-to-noise ratio 67 dB (stereo),

69 dB (mono)Harmonic distortion at 1 kHz

0.5% (stereo),0.3% (mono)

Separation 35 dB at 1 kHzFrequency response 30 – 15,000 Hz

AMTuning range 531 – 1,602 kHzAerial terminal External aerial connectorIntermediate frequency 10.7 MHz/450 kHzSensitivity AM: 30 µV

SPECIFICATIONS

Power amplifier sectionOutputs Speaker outputs

(sure seal connectors)Speaker impedance 4 – 8 ohmsMaximum power output 50 W × 4 (at 4 ohms)

GeneralOutputs Audio outputs terminal

(rear/sub switchable)Power aerial relay control terminalPower amplifier control terminal

Inputs Telephone ATT control terminalRemote controller input terminalAerial input terminal

Tone controls Low: ±10 dB at 60 Hz (XPLOD)Mid: ±10 dB at 1 kHz (XPLOD)High: ±10 dB at 10 kHz (XPLOD)

• The tuner and CD sections have no adjustments.

Sony Corporatione Vehicle Company

Published by Sony Engineering Corporation

9-877-558-012004B04-1

© 2004. 02

– Continued on next page –

FM/AM COMPACT DISC PLAYER

2

CDX-R3300EE

If the optical pick-up block is defective, please replace the wholeoptical pick-up block.Never turn the semi-fixed resistor located at the side of opticalpick-up block.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINEWITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

Power requirements 12 V DC car battery(negative ground)

Dimensions Approx. 178 × 50 × 179 mm(w/h/d)

Mounting dimensions Approx. 182 × 53 × 161 mm(w/h/d)

Mass Approx. 1.2 kgSupplied accessories Parts for installation and connections (1 set)

Front panel case (1)

Design and specifications are subject to change withoutnotice.

NOTES ON HANDLING THE OPTICAL PICK-UP BLOCKOR BASE UNITThe laser diode in the optical pick-up block may suffer electrostaticbreakdown because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic breakdown and also usethe procedure in the printed matter which is included in the repairparts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, ob-serve from more than 30 cm away from the objective lens.

Notes on Chip Component Replacement• Never reuse a disconnected chip component.• Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

SERVICE NOTES

This label is located on the bottom of the chassis.

TEST DISCSThis set can playback CD-R and CD-ROM discs. The followingtest discs should be used to check the capability:

CD-R test disc TCD-R082LMT (Part No. J-2502-063-1)CD-RW test disc TCD-W082L (Part No. J-2502-063-2)

Notes on CD-R/CD-RW discs• You can play CD-Rs (recordable CDs)/CD-RWs (rewritable CDs)

designed for audio use on this unit.Look for these marks to distinguish CD-Rs/CD-RWs for audiouse.

These marks denote that a disc is not for audio use.

• Some CD-Rs/CD-RWs (depending on the equipment used forits recording or the condition of the disc) may not play on thisunit.

• You cannot play a CD-R/a CD-RW that is not finalized*.

* A process necessary for a recorded CD-R/CD-RW disc to beplayed on the audio CD player.

optical pick-up

semi-fixed resistor

3

CDX-R3300EE

z UNLEADED SOLDERBoards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.(Caution: Some printed circuit boards may not come printed withthe lead free mark due to their particular size.)

: LEAD FREE MARKUnleaded solder has the following characteristics.• Unleaded solder melts at a temperature about 40°C higher than

ordinary solder.Ordinary soldering irons can be used but the iron tip has to beapplied to the solder joint for a slightly longer time.Soldering irons using a temperature regulator should be set toabout 350°C.Caution: The printed pattern (copper foil) may peel away if theheated tip is applied for too long, so be careful!

• Strong viscosityUnleaded solder is more viscous (sticky, less prone to flow)than ordinary solder so use caution not to let solder bridgesoccur such as on IC pins, etc.

• Usable with ordinary solderIt is best to use only unleaded solder but unleaded solder mayalso be added to ordinary solder.

EXTENSION CABLE AND SERVICE POSITIONWhen repairing or servicing this set, connect the jig (extension cable)as shown below.

• Connect the MAIN board (CN350) and the SERVO board (CN2)with the extension cable (Part No. J-2502-076-1).

SERVO BOARDCN2

J-2502-076-1MAIN BOARDCN350

4

CDX-R3300EE

TABLE OF CONTENTS

1. GENERALLocation of controls ................................................................. 5Connections ............................................................................. 6

2. DISASSEMBLY2-1. Sub Panel Assy .................................................................... 82-2. CD Mechanism Block ......................................................... 92-3. Main Board ......................................................................... 92-4. Chassis (T) Sub Assy ........................................................ 102-5. Roller Arm Assy ................................................................ 102-6. Chassis (OP) Assy ............................................................. 112-7. Optical Pick-up ................................................................. 112-8. SL Motor Assy (M902) ..................................................... 122-9. LE Motor Assy (M903) ..................................................... 122-10. Servo Board ....................................................................... 13

3. DIAGRAMS3-1. IC Pin Descriptions ........................................................... 143-2. Block Diagram –CD Section– ........................................... 193-3. Block Diagram –Tuner Section– ....................................... 203-4. Block Diagram –Display Section– .................................... 213-5. Printed Wiring Boards –CD Mechanism Section– ............ 223-6. Schematic Diagram –CD Mechanism Section (1/2)– ....... 233-7. Schematic Diagram –CD Mechanism Section (2/2)– ....... 243-8. Printed Wiring Board –Main Section– .............................. 253-9. Schematic Diagram –Main Section (1/2)– ........................ 263-10. Schematic Diagram –Main Section (2/2)– ........................ 273-11. Printed Wiring Board –Key Section– ................................ 283-12. Schematic Diagram –Key Section– ................................... 293-13. IC Block Diagrams ............................................................ 30

4. EXPLODED VIEWS4-1. Main Section ..................................................................... 324-2. Front Panel Section ........................................................... 334-3. CD Mechanism Section (1) ............................................... 344-4. CD Mechanism Section (2) ............................................... 354-5. CD Mechanism Section (3) ............................................... 364-6. CD Mechanism Section (4) ............................................... 37

5. ELECTRICAL PARTS LIST ........................................ 38

5

CDX-R3300EESECTION 1GENERAL This section is extracted

from instruction manual.

6

CDX-R3300EE

Connections

7

CDX-R3300EE

8

CDX-R3300EESECTION 2

DISASSEMBLY

Note : This set can be disassemble according to the following sequence.

Note : Follow the disassembly procedure in the numerical order given.

2-1. SUB PANEL ASSY

2 two claws

3 two claws

4 sub panel assy

1 two screws (+PTT 2.6 x 6)

2-1. SUB PANEL ASSY(Page 8)

2-2. CD MECHANISM BLOCK(Page 9)

SET

2-3. MAIN BOARD(Page 9)

2-4. CHASSIS (T) SUB ASSY(Page 10)

2-5. ROLLER ARM ASSY(Page 10)

2-6. CHASSIS (OP) ASSY(Page 11)

2-8. SL MOTOR ASSY (M902)(Page 12)

2-10. SERVO BOARD(Page 13)

2-7. OPTICAL PICK-UP(Page 11)

2-9. LE MOTOR ASSY (M903)(Page 12)

9

CDX-R3300EE

2-2. CD MECHANISM BLOCK

2-3. MAIN BOARD

7 bracket (CD)

5 CD mechanism block

4 CN350

3

1 screw (+PTT 2.6 x 6)

2 screw (+PTT 2.6 x 6)


1 three ground point screws (+PTT 2.6 x 6)

3 MAIN board

4 insulating sheet


10

CDX-R3300EE

2-4. CHASSIS (T) SUB ASSY

2-5. ROLLER ARM ASSY

5 SENSOR board

6 chassis (T) sub assy

4 claw

3 claw

1 two screws (+P 1.7 x 2.2)

2 two screws (+P 1.7 x 2.2)

3 washer

4 worm wheel (RA)

5 roller arm assy

1 spring (RAL)

2 spring (RAR)

11

CDX-R3300EE

2-6. CHASSIS (OP) ASSY

2-7. OPTICAL PICK-UP

4 washer

0 coil spring (damper)

9 two coil springs (damper)

qa chassis (OP) assy

5 gear (LE1)

1 CN1

lever (D)

slider (R)

6

7

8

2 Remove the six solderings.

3 tension coil spring (KF)

1 tension coil spring (CHKG)

2 chucking arm sub assy

3 screw (+B 1.4 x 5)

4 rack (SL)

5 claw

6 main shaft

7 optical pick-up

12

CDX-R3300EE

2-9. LE MOTOR ASSY (M903)

2-8. SL MOTOR ASSY (M902)

1 screw (+P 1.4 x 1.8)

2 SL motor assy (M902)

2 washer

4

qd

3 gear (LE1)

7 leaf spring (LE)

5

lever (D)

bracket (LEM)

slider (R)

6 screw (+P 1.7 x 2.2)

8 screw (+M 1.7 x 2.5)

qa screw (+M 1.7 x 2.5)qf two toothed lock screws

(+M 1.4 )

qs screw (+M 1.7 x 2.5)

9 bearing (LEB)

0 woam (LEB) assy

qg LE motor assy (M903)

1 Remove the two solderings.

13

CDX-R3300EE

2-10. SERVO BOARD

3 CN1

5 claw

6 SERVO board

4 toothed lock screw (M 1.7)

1 Remove the eight solderings.

2 Remove the three solderings.

14

CDX-R3300EESECTION 3DIAGRAMS

3-1. IC PIN DESCRIPTIONS• IC3 CXD3059AR (DIGITAL SERVO/DIGITAL SIGNAL PROCESSOR) (SERVO BOARD (1/2))

Pin No. Pin Name I/O Pin Description

1 MIRR I/O Mirror signal input/output (Not used in this set)

2 DFCT I/O Defect signal input/output (Not used in this set)

3 FOK I/O Focus OK signal input/output

4 VSS — Ground

5 LOCK I/O Lock signal input/output (Not used in this set)

6 MDP O Spindle motor servo control signal output

7 SSTP I Disc most inner detection signal input (Fixed at L in this set)

8 IOVSS1 — Digital ground

9 SFDR O Sled drive signal output (FWD direction)

10 SRDR O Sled drive signal output (REV direction)

11 TFDR O Tracking drive signal output (FWD direction)

12 TRDR O Tracking drive signal output (REV direction)

13 FFDR O Focus drive signal output (FWD direction)

14 FRDR O Focus drive signal output (REV direction)

15 IOVDD1 — Digital power supply pin (+3.3 V)

16 AVDD0 — Analog power supply pin (+3.2 V)

17 AVSS0 — Analog ground

18 NC — Not used. (Open)

19 E I E signal input

20 F I F signal input

21 TEI I Tracking error signal input

22 TEO O Tracking error signal output

23 FEI I Focus error signal input

24 FEO O Focus error signal output

25 VC I/O VC voltage output/Center voltage input

26 A I A signal input

27 B I B signal input

28 C I C signal input

29 D I D signal input



32 RFDCO I/O RFDC signal input/output (Not used in this set)

33 PDSENS I Reference voltage input (Fixed at L in this set)

34 AC_SUM O RFAC summing amplifier signal output

35 EQ_IN I Equalizer circuit signal input

36 LD O APC amplifier signal output

37 PD I APC amplifier signal input


39 RFC I EQ cut off frequency adjustment input


41 RFACO O RFAC signal output

42 RFACI I RFAC signal input


44 BIAS I Asymmetry circuit constant current input

45 ASYI I Asymmetry comparate voltage input

46 ASYO O EFM full swing signal output

47 VPCO O Charge pump output

48 VCTL I VCO2 control voltage input


50 CLTV I VCO1 control voltage input

51 FILO O Filter signal output

15

CDX-R3300EE


52 FILI I Filter signal input

53 PCO O Charge pump output


55 DDVROUT O DC/DC converter output

56 DDVRSEN I DC/DC converter output voltage monitor signal input


58 DDCR I Reset signal input


60 BCKI I D/A interface bit clock signal input

61 PCMDI I D/A interface serial data signal input

62 LRCKI I D/A interface LR clock signal input

63 LRCK O D/A interface LR clock signal output

64 VSS — Ground

65 PCMD O D/A interface serial data signal output

66 BCK O D/A interface bit clock signal output

67 VDD — Power supply pin (+2.6 V)

68 EMPH O Not used. (Open)

69 EMPHI I Not used. (Fixed at L in this set)


71 DOUT — Digital out signal output (Not used in this set)

72, 73 TEST I Test pin (Normally, fixed at L)



76 XVSS — Ground

77 XTAO O Master clock signal output (16.9344 MHz)

78 XTAI I Master clock signal input (16.9344 MHz)

79 XVDD — Power supply pin (+2.6 V)


81 AOUT1 O L channel analog signal output

82 VREFL O L channel reference voltage output

83, 84 AVSS1,AVSS2 — Analog ground

85 VREFR O R channel reference voltage output

86 AOUT2 O R channel analog signal output




90 RMUT O R channel “0” detection flug output

91 LMUT O L channel “0” detection flug output


93 XTSL I Sub clock signal input (Fixed at L in this set)


95 XTACN I Oscillation circuit control signal input (Fixed at H in this set)

96 SQSO O Sub 80 bit, PCM peak and level data signal output

97 SQCK I Clock signal input

98 SBSO O Sub P-W serial data signal output (Not used in this set)

99 EXCK I Clock signal input (Not used in this set)

100 XRST I System reset signal input

101 SYSM I Mute signal input (Fixed at L in this set)

102 DATA I Serial data signal input

103 VSS — Ground

104 XLAT I Latch signal input

105 CLOK I Serial data transfer clock signal input


16

CDX-R3300EE


107 SENS O SENS signal output

108 SCLK I Clock signal input

109 ATSK I/O Input/output for anti-shock. (Fixed at L in this set)

110 WFCK O WFCK signal output (Not used in this set)

111 XUGF O XUGF signal output (Not used in this set)

112 XPCK O XPCK signal output (Not used in this set)

113 GFS O GFS signal output

114 C2PO O C2PO signal output

115 SCOR O Sub code sync signal output


117 C4M O 4.2366 MHz signal output (Not used in this set)

118 WDCK O Word clock signal output (Not used in this set)

119 COUT I/O Track count signal output/output (Not used in this set)


17

CDX-R3300EE

• IC500 MN101E01KDK (SYSTEM CONTROL) (MAIN BOARD (2/2))Pin No. Pin Name I/O Pin Description

1 DAVDD — D/A converter power supply (+) pin (+3.3 V)

2 NCO O Not used. (Open)

3 DAVSS — D/A converter power supply (–) pin

4 UNISO O SONY-BUS data output (Not used in this set)

5 UNISI I SONY-BUS data input (Not used in this set)

6 UNICKO O SONY-BUS clock output (Not used in this set)

7 RETRA_SW IRetractable CD door open/close detection switch input

(L: CD door open, H: CD door close)

8, 9 NCO O Not used. (Open)

10 VDD1 — Power supply pin (+3.3 V)

11 MMOD I Not used. (Fixed at L in this set)

12 OSCOUT O Main clock output (27.648 MHz)

13 OSCIN I Main clock input (27.648 MHz)

14 VSS1 — Ground

15 XIN I Sub clock input (32.768 kHz)

16 XOUT O Sub clock output (32.768 kHz)


18 MOD1 — Not used. (Fixed at H in this set)

19 RESET I Microcomputer reset input

20 RCIN1 I Rotary commander SHIFT key input

21 ACCIN I Accessory power supply detection input

22 TESTIN I Test mode detection input

23 TELATT I Telephone attenuator detection input

24 ATT O Audio mute control output

25 ADON O A/D converter power supply control output


27 KEYACK I Key acknowledge detection input

28 TUATTIN I Not used. (Fixed at L in this set)

29 CDON I Servo power supply control input from CD system control IC.

30 CDMON I Loading 6V power supply control input from CD system control IC.

31 BUIN I Backup power supply detection input

32 to 35 NCO O Not used. (Open)

36 BUSON O BUS ON output to CD system control IC.

37 SYSRST O System reset output to CD system control IC.


42 Z_MUTE I Mute zero cross detection input from CD system control IC.


50 BBESEL I Fixed at H in this set.


52 AREASEL1 I Destination area initial setting input (Fixed at L in this set)

53 AREASEL0 I Destination area initial setting input (Fixed at H in this set)


57 EJECT_OK_SW O Eject OK output

58 PANELSW I Front panel detach detection input (L: with front panel, H: without front panel)

59 DIAG I Mode input from power amp IC.

60 VOLATT O Attenuator control output to electronic volume IC.

61 NOSESW O Not used. (Open)


63 VSS2 — Ground

64 TUATT O Tuner mute control output

65 NCO (TUON) O Not used. (Open)

66 NSMASK O Not used. (Open)

18

CDX-R3300EE


67 E2P_CKO O Serial clock output to EEPROM communication.

68 E2P_SIO I/O Serial data input/output with EEPROM communication.

69 DOORIND O Not used. (Open)

70 AMPSTB O Standby control output to power amp IC.


72 FLS.SO/LCDSO O Serial data output to LCD driver IC.

73 FLS.SI/LCDCE O Chip enable output to LCD driver IC.

74 LCDCKO O Serial clock output to LCD driver IC.


79 I2C_SIO I/O I2C bus serial data input/output


81 I2C_CKO O I2C bus serial clock output

82 DAVN I Not used. (Fixed at L in this set)

83 SIRCS I SIRCS signal input


85 BEEP O Beep output to power amp IC.




91 VSS3 — Ground

92 QUALITY I Not used. (Fixed at L in this set)

93 VSM I S-meter voltage detection input

94, 95 KEYIN1, 0 I Key input 1, 0

96 RCIN0 I Rotary commander key input


100 VREF+ — A/D converter power supply (+) pin (+3.3 V)

19 19

CDX-R3300EE

46ASYO

RF AMP,DIGITAL SERVO,DIGITAL SIGNAL PROCESSOR

IC3

41RFACO

24FEO

22TEO

42 RFACI

23 FEI

21 TEI

13 FFDR

PD1

PD2

E

F

I-V A

MP

PD LD

DETECTOR

45 ASYI

27

26

29

28

19

20

E

C

D

A

B

F

36 LD 37PD

(FOCUS)

(TRACKING)

2-AXIS DEVICE

OPTICALPICK-UP BLOCK

(KSS1000E)

• Signal path: CD

LASER DIODE

M

M

M

13

12

VO1–

VO1+

6

7

VO4+

VO4–

8

9 VO3–

VO3+

5

4

VOL+

VOL–FWD

REV

1

2

VIN2+ 22

14 FRDRVIN2– 21

11 TFDRVIN1+B 19

12 TRDRVIN1–B 18

9 SFDRVIN4+ 31

10 SRDRVIN4– 32

6 MDPVIN3+ 25

MUTE 34

11

10

VO2–

VO2+

M903(LOADING)

M901(SPINDLE)

M902(SLED)

FOCUS/TRACKING COIL DRIVE,SLED/SPINDLE/LOADING

MOTOR DRIVEIC1

3FOK96SQSO97SQCK100XRST102DATA104XLAT105CLOK107SENS

CD-L81AOUT1

86AOUT2 R-CH

18 CD SQCK15 CD XRST14 CD DATA13 CD XLAT

53 MEC_SELFSW

45 MEC_INSW

42 MEC_LIMIT

12 CD CLOK11 CD SENS

108SCLK 10 CD SCLK113GFS 8 CD GFS114C2PO 7 CD C2PO115SCOR 52 CD SCOR

81 X1

80 X0

MEC LOAD43

MEC EJECT44

CDSYSTEM CONTROL

IC4

AUDIO INTERFACEIC8

+1.5V REGIC7

SYSTEM CONTROLIC500 (1/3)19 CD FOK

16 CD SQSO

DRON41

SD1O14LRCK1B19LRCK1A16SD0O11BCK1B18BCK1A15

CLCK22SRMSTB41RESET2STANDBY3BUCK36I2C SCL7I2C SDA6BUSO28

SW2(SELF)

46 MEC_DSWSW1(DOWN)

SW3(DISC IN)

SW4(LIMIT)

91LMUT 22 CD LMUT

90RMUT 23 CD RMUT

51BU IN75RSTX

61EJECT OK

67MECON CHK

69EMPH32DEC SDA31DEC SCL30DEC INT29DEC STBY28DEC XRST27DEC SSTBY37DEC XMUTE

65DECON

63MECON64CDON66ZMUTE

60A ATT

PD1

E

F

LD

PD

FCS+

FCS–

TRK+

TRK–

PD2

LD DRIVEQ1

+3.3VCONTROL

Q5,6

+1.5VCONTROL

Q2,3

• R-ch is omitted due to same as L-ch.

77

78X1

16.9344MHzX2

18.43MHz

XTAI

XTAO

66BCK60BCKI61PCMDI63LRCK62LRCKI65PCMD

EJECK OK SW

M-ATT

BU INSYS RST

97

CD ON

VOUT

29CDM ON30

Z MUTE

MECH+6V

42

56UNISI25RXD57UNISO26TXD58UNICLK

UNISI5

UNISO4

UNICKO6

50BUS ON BUSON36

68CDON CHK

15 VDD3CE

+3.3V

+1.5V

VDDT+3.3V

+3.3V

D601

MAINSECTION

MAINSECTION

A

B

3-2. BLOCK DIAGRAM — CD SECTION —

(Page 20)

(Page 20)

2020

CDX-R3300EE

J1(ANTENNA) 1

ANT

CDL

CDR

CD-L

TU-L

R-CH

3R

AUDIO 8.3V

TUNER UNITTU1

6S-METER14SDA

SYSTEM CONTROLIC500 (2/3)

24

ACCIN 21

TELATT 23

AMPSTB 70BEEP 85

CDSECTION

A

CDSECTION

B

311

CN700

19

FL+FL-

210

RL+RL-

412

13

7

FR+FR-

15

RR+RR-

TEST

ACC

ATT

16 +B (BATT)

8 GND

R-CH

F90110A

TU_ATT

BATT

3.3V

17

19

18BATT

EEP_CKO67

VSM

13SCLATT

BATTD493

59

TESTIN

DIAG

2293

VOLATT60

SOUND CONTROLELECTRONIC VOLUME

IC400

NCBUS-LCH

5

C29

B27

SDASCL

MUTE

CONT.

EVR

29

I2C_SIOI2C_CKO

7981

17E2P-SDA16E2P-SCL

7TUN MUTE

11VDD5V

10VCC8.3V

68 EEP_SIO

64

R-CH

25

29

AUDIO OUT REAR-1L

R-2

R-CH

J400

5 AMP-R

27

35

3734333130

6 ANT-R

BEEPSTB

FL

RL

SUB-L

4 SCL2 SDA

CONT.

97

620

POWER AMPIC300 (1/2)

MULTIPLE VOLTAGEREGULATORIC300 (2/2)

VP2VP1

• Signal path

: FM

: AM

　　　: CD

• R-ch is omitted due to same as L-ch.

12

BUIN

M-ATT

31

4L

OUTF2

23

OUTR2

22

SYSRST 37

RESET 19+5V REG.

Q3

BACK-UP CHECK/LOW VOLTAGE

CHECKQ606,607

OVER VOLTAGEDET.

Q605,D602,603

RESETIC502

LINE MUTECONTROLQ491,492

TELATT

Q701

I2CBUS

ACCCHECKQ702

MUTEQ440

MUTEQ450

11

MUT

E

TONE

INPU

T SE

LECT

OR

EFFECT

OUTS217

MUTEQ480

53

DIAG

AMP-REM

ANT-REM

B.UP+BPANEL+BMECH 6V

SERVO 3.3VAUDIO +B

3.3VPANEL+BMECH 6VSERVO 3.3VAUDIO 8.3V

VP

D302

D301

D351S103

(RESET)

MUT

E

1622I2C

BUS3130

BU INSYS RST

1 4

3-3. BLOCK DIAGRAM — TUNER SECTION —

(Page 19)

(Page 19)

21 21

CDX-R3300EE

3-4. BLOCK DIAGRAM — DISPLAY SECTION —

S900-908,910-922

KEY ACKSWITCH

Q501

REMOTERECEIVER

IC971

X50132.768kHz

15

16

12

13

95 72747394

27

25

2096

83

SYSTEM CONTROLIC500 (3/3)

LCD DRIVERIC901

KEYIN0 DATACLKCE

LCDSOLCDCKO

LCDCEKEYIN1

KEYACK

ADON

RCIN1RCIN0

SIRCS

XIN

XOUT

OSCOUT

OSCIN

7RETRA_SW

X50027.648MHz

6364

62

COM4

COM1

LCDLCD901

PANEL +B

PANEL +B

LED902-908,910-922

LED931,932(LCD BACK LIGHT)

D501

J561(REMOTE IN)

51|

54

3|

50

|

SEG3

SEG50|

DICLCE

1 DIMMER

PANEL +B

KEYILLUMINATION( )

PANEL +B

D963

D962

LED961(DISC IND)

S961OPEN

KEY MATRIX

3

34 LCD DRIVECONTROL

IC9814

LEDDRIVER

Q901

DIMMER ON/OFFSWITCH

Q902

THIS NOTE IS COMMON FOR PRINTED WIRINGBOARDS AND SCHEMATIC DIAGRAMS.(In addition to this, the necessary note isprinted in each block.)

for schematic diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwise

specified.• % : indicates tolerance.• f : internal component.• C : panel designation.

• A : B+ Line.• Power voltage is dc 14.4V and fed with regulated dc power

supply from ACC and BATT cords.• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.

F : FMf : AMJ : CD

for printed wiring boards:• X : parts extracted from the component side.• Y : parts extracted from the conductor side.• a : Through hole.• : Pattern from the side which enables seeing.

(The other layer’s patterns are not indicated.)

Note: The components identified by mark 0 or dotted linewith mark 0 are critical for safety.Replace only with part number specified.

Caution:Pattern face side: Parts on the pattern face side seen from the(Side B) pattern face are indicated.Parts face side: Parts on the parts face side seen from the(Side A) parts face are indicated.

32.768kHz

IC500 qh (XOUT)

— Main Board —

2

27.648MHz

IC500 qs (OSCOUT)

2.8Vp-p

2.6Vp-p

1

• Waveforms— Servo Board —(MODE: CD PLAY)

IC3 whwk (A, C)

3

0V

Approx.150mVp-p

16.9344MHz

IC3 uj (XTAO)

0V

2

Approx. 100mVp-p

IC3 wd (FEI)

1

Approx. 100mVp-p

IC3 wa (TEI)

IC3 wjwl (B, D)

4

6

2Vp-p

IC3 ra (RFACO)

5

18.43MHz

IC4 ia (X1)

7

1Vp-p

Approx.150mVp-p

Approx.0.8Vp-p

2222

CDX-R3300EE

3-5. PRINTED WIRING BOARDS — CD MECHANISM SECTION — • Refer to page 21 for Common Note for Printed Wiring Boards. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

2 3 4 5 6 7 8 9 10 11 12 13 14

SW3

SW2

Q1

C81

R49

R147

IC8

C86

C85

R48

IC1

Q6

R47

C75

R123

C92 C64

C59C58

C57

C56

C54

R50

C49

R7

C50

C47

C46

C44C43

C42

C41

C40

C39 C38

C36

C35

C34

C33

C32

C30C28

C29

C25

C24

C23

C22

C19

C14

Q5

C11

C8

C6

C2

C115

C1

R13

6

R5

R114

R111

R11

0

R109

R10

7

R106

C107

R13

3

R52

R46

R10

1

R44

C91

R43

SW1

R42

R41

R40

R92 R

91

R85

R77

R39

R38

R70

R54

R116

R149

C65

R55

C60

R12

6

R11

R12

R14

R37

R15

R56

R16

X1

C83

R18

R64

R61

R60

R29R25

R24

R23

R12

4

R14

5

R139

X2

C63

IC7

R117

R22

C77

R14

0

Q3

Q2

IC4

R141

R14

2

R143

C74

R148

R146

FB2

FMB7

FMB8

R2

CN1

R6

R1

C79

C27

C55

R97

C67

C66

C109

C110

C16

C51

CN2

C45

R12

2

C37

R78

C26

C21

C13

C7

C5

C4

C3

BP3

BP2

BP1

R119

R11

5

R108R99

R98

R8

R87

R86

R81

R80

R76R68

R74

R73

R71

R69

R45

C52

R9

R10

C53

R13

R17

R19R20

R57

R21

R79

R67

R65

R62

R59

R28

R27R26

R3

R12

7R12

8

R12

9

R53

R4

R72

R144

C10

IC3

C48

C18

FB1

FB5

(Page 25)

IC1 G-2IC3 C-10IC4 E-2IC7 B-2IC8 C-2

Q1 C-4Q2 B-2Q3 B-2Q5 A-2Q6 A-2

• SemiconductorLocationRef. No. Location

23 23

CDX-R3300EE

3-6. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (1/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.

Note:• Voltage is dc with respect to

ground under no-signal conditions.no mark : CD PLAY

(Page 27)

TP39

R49

R48

R97

R50

R78

TP56

BP3

BP2

R52

R46

R98

R44

R43

R42

R40

R76

R77

R68

R45

TP133

C65

C52

C53

TP135

R79

R67

R65

R64

R61

R59

R29

R25

R24

TP34

4TP

343

R53

TP43

TP65

R72

TP181

TP180

TP175

TP38

TP48

TP132

TP14

1

TP13

7

TP41

TP51

TP46

TP139

TP129

TP37

TP12

7

TP54

TP123

TP40

TP49

C10

TP72

TP136

TP11

6

TP36

TP47

TP42

TP55

TP128

TP53

TP57

TP59

TP60

TP61

TP98

TP97

TP96

TP62

TP94

TP63

C48

C5

R12R7

C6

C30

C22C23

C24C25

C28

C33

C45

C37C34

C38

C39

C40

C42

C43

C44

C46

R54

C64

C50

C57

C59

C58

C54

R124

R114

C35

R38

C29

R22

R23

TP71

TP140

C27TP50

TP44 TP45

R13

R6

TP35TP34

TP33

TP32

TP30TP29TP28

TP27TP26

TP25TP24

TP23TP22

TP21

R1

C4

TP99

R41C47

R55

TP167 C55

R70

R71

R60

R56

C41

FB2

FB5

R133

CN2

Q1

CN1

X1

C81

R14

9

IC3

C49

C107

C60

(Page 24)

2424

CDX-R3300EE

3-7. SCHEMATIC DIAGRAM — CD MECHANISM SECTION (2/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.

• Refer to page 30 for IC Block Diagrams.

Note:• Voltage is dc with respect to

ground under no-signal conditions.no mark : CD PLAY

IC B/D

IC B/D

R2

R47

R123

C16

C19

C18

C14

C13

C8

BP1

R136

R115

R5

R111

R107

R106R101

R92

R91

R8

R81

R39 R73

R9

R10

R11

R14R15

R16

R17

R18

R19

R20

R21

R28R27R26

R3TP

249

TP231TP230

TP226

R4

R139

TP11

TP12

TP19

TP20

R117

TP9

R140

R141

R142R143

C74

R110

R146

R57

R14

7

R14

8

C11

C21

C32

C36

C66

R86R85

C67C56

FB1

R99

C86C115

C77C75

R144

C92

C91

C85

C26

C83

C109

C110

TP31

R87

R145

TP52

R69

TP58

R74

R80

R119C51

C7

TP13

TP14

TP15

TP16

TP17

TP18

TP7

TP8

R116

R108

IC1

M903

M901

M902

IC8

IC7

Q6

C79

Q2

Q3Q5

C3

C2

C1

C63SW4

SW3

SW1

X2

SW2

R37

IC4

R12

2

R12

6

R12

7R

128

R12

9

R62

R109

(Page 23)

25 25

CDX-R3300EE

1

A

B

C

D

E

F

G

H

I

J

2 3 4 5 6 7 8 9 10 11 12 13 14

R370

R371

R604

R603

D603

D602

Q605

Q606

Q607

R615

R616

JC703

JC350

R351

C354

R702

D703

C995

C996

R709

R70

1

D701

JC70

2

R707

R708

R70

6

Q70

2

R704

Q701

R703R513

R512

Q501

R514

JC505

JC506

R511

R510

C501

R112

R506

R507

R505

C500

IC500

C518

R53

0C517C519

R526 R527

C515

C514

R529R528

C516

R101

D102

D107

D108

R115 D105

D106

D104

D103

R105

R102R103R104

R106

R107R108

R109

R302 C319

JC504R517

R520

C318

R301

Q492

Q491

C492D492

R491

R492

C504

C301C304C305

C309

C310

C803

C801

C800C802

R6

R7

C8

C6 C3 D

2 C7

R10

Q3

JC1

R9

R5

R4

C403C404

IC40

0

R480

R470R430

R420

R450

R440R404

C411

R481

R471

R421

R441R431

R45

1

R453

R433

Q430

Q45

0

R432 R452JC401

R423

Q420

Q44

0

Q47

0

Q480

C452 C432

R442 R422

D702

R509R508

C513

C510

C511

C512

JC50

8

R523 R524

JC30

0

JC301

JC403

R472R482

JC50

3

D493

JC40

2 JC501

D491

D351

JC701

JC50

2

JC509

D501

IC50

2

D601

R532

JC511

JC601

JC423

L1

R535

R533

L2

JC30

2

JC30

3

JC30

4

C703

L356

L357

L352

L351

L354

C312

L359

C522

R443

JC400

D101

L358

L353

L355

C520

J1

CN700

F901

IC300

TU1

CN102

C701

D70

4

C351

C353

C352

C355

C405

C406

C702

C502

S103

C317

C505

C491

C314

C316

C306

C308

C5

C2

C400

C412

C481

C471

C421

C441

C431

C451

C303

R705

JW1

JW2

JW3 J

W4

JW5

JW6

JW7

JW8

JW9

JW11

JW12

JW14

JW15

JW16

JW17 J

W18

JW19

JW20

JW22

JW23

JW24JW26

JW28

JW29

JW30

JW31

JW32

JW33

JW34

JW35

JW36

JW38

JW39

JW42

JW44

JW45

JW47

JW48

JW49

JW50

JW53

JW55

JW56

JW57

JW58

JW59

JW60

JW61

JW62 JW64

JW65

JW66

JW67

JW68

JW69

JW70

JW71

JW73

JW74

JW75JW76

JW78

JW79

JW80

JW81

JW82

JW83

JW84

JW85

JW86

JW87J

W88

JW90

JW91JW

92

JW93

JW94

JW95

JW98

JW99

JW101

JW102

JW105

JW106 JW108JW109

JW111

JW112

JW113

JW11

4

JW11

5

JW11

6

JW11

7

JW11

8

JW11

9

JW12

0

JW12

1

JW13

1

JW125

JW126

X501

CN35

0

C506

JW127

JW12

9

JW122

JW123

J400

X500

D304

D303D302

D301

D31

1

D31

2D30

9

D31

0

D30

6

D30

5

D30

7

D30

8 L700

JW40

JW13

C521

JW96

JW97

JW110

JW89

JW52

JW51

JW128

JW10

3

JW10

4

C320

JW12

4C321

J561

3-8. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 21 for Common Note on Printed Wiring Boards. : Uses unleaded solder.

(Page 28)

(Page 22)

D602 E-10D603 E-10D701 C-8D702 E-10D703 C-9D704 C-10

IC300 B-6IC400 E-4IC500 H-6IC502 H-8

Q3 F-3Q420 B-4Q430 C-4Q440 B-4Q450 C-4Q470 B-3Q480 B-3Q491 E-6Q492 E-6Q501 G-7Q605 F-10Q606 F-10Q607 F-10Q701 G-7Q702 G-8

Ref. No. LocationD2 E-3D101 I-4D102 I-4D103 I-3D104 H-3D105 H-3D106 H-3D107 I-2D108 I-2D301 C-8D302 C-8D303 C-9D304 C-9D305 C-6D306 C-6D307 C-6D308 C-6D309 C-6D310 C-6D311 D-7D312 D-7D351 G-8D491 E-6D492 E-6D493 F-7D501 I-5D601 H-8

• Semiconductor LocationRef. No. Location

2626

CDX-R3300EE

3-9. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.

• Refer to page 30 for IC Block Diagrams.

Note:• Voltage is dc with respect to ground under no-signal

(detuned) condition.no mark : FM( ) : AM< > : CD PLAY

(Page 27)

IC B/D

IC B/D

C5

C303

C306C308

C317

D491

D493 R4

R5

R10

R301

R302

R420

R421R422

D2

D492

D704

Q3

Q491

Q492

R430

R431

R432

R440

R441

R442

R443

R450

R451

R452

R470

R471

R472

R480

R481

R482

R491

R492

R706

R707

R708

C2

C491

JC701

L700

Q420

Q430

Q440

Q450

Q470

Q480

D30

1

D30

2

D303 D304D305D306D307D308D309D310D311D312R709

JC304

C320

C321

C701

JC403

C452

C432

C492

C411

JC1

C6

C8

C3

C481

C471

JC702

C703

C319

C318

JC302 C304JC300

C301

JC303

JC301

C309

C305

C310

C312

C504

C506

R453

R433

C316 C314

R423

JC400

JC401

JC423

C441

C421

C451

C431

D702

D703

C702C403C404

C405C406

C400

R404

C412

L2

L1

R7 R6

C7

R705 JC402

J1

F901

D701R701

JC703

R703

R704

R702

J400

IC400

CN700

C996C995

IC300

C802

C800

C801

C803

Q701

Q702

R9

TU1

27 27

CDX-R3300EE

3-10. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 21 for Common Note on Schematic Diagram and Waveforms.

(Page 23)

(Page 29)

(Page 26)


(detuned) condition.no mark : FM( ) : AM< > : CD PLAY

C352

C353

C355

C502

D351

D601

R101

R102

R103R104

R105R106

R107

R351

R370R371

D602

R112

R508

R51

0

R51

1

R514

R523

R603

JC503

JC509

R507

C351

D501

R50

9

D10

4

D10

3D

102

D10

1

D10

5D

106

D10

7D

108

C521

R533

R51

3

C501

JC350

L359

JC506 JC505

C518

C517

C516

C519

JC502

C500

JC504 JC508

C513

C511

C510

C522

R109 R108

R524

R528 R529

R526

R527

C354

C512

R506

R532

C514

IC502

JC601

D603 R604

Q605

R616R615

Q607Q606

J561

CN350

JC511

R520

Q501

R512

X500

R505

R535

JC501

C505

C515

S103

R115

R530

L354C520

X501

CN102

R517

L358L351

L352

L353

L356L355

L357

IC500

2828

CDX-R3300EE

3-11. PRINTED WIRING BOARD — KEY SECTION — • Refer to page 21 for Common Note on Printed Wiring Boards. : Uses unleaded solder.

(Page 25)

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11 12 13 14

LED916

LED911

LED

902

LED912

LED913

LED914LED917LED918LED919LED920LED921LED908LED907

S905 S906

S904

S922 S910

LED

905

S902

LED932

S917

S911

LED906

LED961

LCD901

S912

IC971

LED922

LED903

LED931

S913S914

LED915

R950

R951

R949

S915

R914

S916S918S919S920S921S908S907S903

R932

R93

1

R93

3

R913

S900

LED904

LED910

S901

S961

C991

CN901

IC901

D902

D96

4

D901

C971

R97

7

R992

R996

R99

5

R994

R98

9

C992

C993 C994

C995

R937

R901

D96

2

R90

3

R902

R907

R912

R911

R95

6

R91

5

R91

6

R91

7

R918R919R920R921

R98

6

D96

3

R974

R991

R961

R945

R955

R97

1

R97

2

R98

2 R98

1

R983

R98

4

R993

R985

R98

7

R98

8

D99

1

C996

IC981 C98

2

D903

C981

R96

2

R96

3

R938

R94

2

R94

1R922

R957R975

Q901

Q90

2 R92

4

R92

5R92

6

D992

R978

R946

R997

R998

R905

R904

R906

IC971 D-14IC981 H-6

LED902 A-14LED903 D-3LED904 D-2LED905 A-1LED906 B-1LED907 D-4LED908 D-5

Ref. No. LocationD901 H-11D902 G-11D903 G-13D962 H-5D963 H-4D964 H-5D991 H-6D992 H-9

IC901 H-8

• Semiconductor LocationRef. No. Location

LED910 C-12LED911 B-13LED912 C-13LED913 D-12LED914 D-11LED915 D-10LED916 D-10LED917 D-9LED918 D-8LED919 D-7

Ref. No. Location Ref. No. LocationLED920 D-6LED921 D-6LED922 C-3LED931 C-11LED932 C-4LED961 B-7

Q901 G-4Q902 H-4

29 29

CDX-R3300EE

3-12. SCHEMATIC DIAGRAM — KEY SECTION — • Refer to page 21 for Common Note on Schematic Diagram.


(detuned) condition.no mark : FM

(Page27)

R984

R985

R986

CN901

R996

R994R995

R987

R988

R989

R925

R926

R931

R932

R962

R902

R903

R912

R913

R949

R950

R977

R975

D963

R993

D902

R992

R901

R904

R905

R906

R907

R911

R914

R915

R916

R917

R918

R919

R920

R921

R922

R961

R972

D90

1LED902

LED903

LED904

LED905

LED906

LED907

LED908

LED910

LED911

LED912 LED913

LED914

LED915

LED916

LED917

LED918

LED919

LED920

LED921

LED922

LED932

LED961

D903

R998

R997

R978

R971

R981R982R983

R924

R974

C971

C982

C996

C991C992C993

C994C995

C981

D99

1

R991

D99

2

D96

4

D96

2

S900 S910

S901

S902

S903

S911

S912

S913

S914

S915

S916

S904

S905

S906

S907

S908

S917

S918

S919

S920

S921

S922

S961

LED931 IC971

IC981

IC901

Q902

LCD901

Q901

R933

R937

R938

R941

R942

R945

R946

R951

R956

R955

R957

R963

3030

CDX-R3300EE

IC300 TDA8588BJ/N2

MUT

EM

UTE

ENABLELOGIC

STANDBY/MUTE

BATTERYDETECTION

CHIP DETECT/DIAGNOSTIC

PROTECTION/DIAGNOSTIC

SWITCH

REGU

LATO

R

SWITCH

REFERENCEVOLTAGE

LOADDUMPPROTECTION

TEMPERATUREPROTECTION

BACK-UPSWITCHREGULATOR

1

3

5

7

9

11

13

15

17

19

21

23

25

27

29

31

33

35

37

2

4

6

8

10

12

14

16

18

20

22

24

26

28

30

32

34

36

TAB

OUT-FL-

OUT-FL+

OUT-RL-

OUT-RL+

IN-RL

S-GND

IN-RR

OUT-RR+

OUT-RR-

OUT-FR+

OUT-FR-

DIAG

ANT-REM

AMP-REM

SERVO5V

MECH6V

VP

B.UP+B

SDA

SCL

VP2

PGND3

SVR

IN-FL

IN-FR

BEEP

PGND2

VP1

STB

PGND1

RST

CRES

AUDIO8.3V

GND

PANEL+B

CBU

FL

RL

RR

VP

FR

I2C BUS

IC1 LA6560-TE-L-E

3-13. IC BLOCK DIAGRAMS

IC7 R1114N151D-TR-FA

1FWDINPUT

2REV

3VCC2

4VLO-

GND

5VLO+

6VO4+

7VO4-

8VO3+

9VO3-

36 S-GND

35 VCONT

34 MUTE

33 VIN4

GND

32 VIN4-

31 VIN4+

30 VREF-IN

29 VIN1-SW

28 VREF-OUT

REG-OUT27

REG-IN26

VIN3+25

VIN323

VIN2+22

VIN2-21

VIN220

VIN1+B19

VIN3-24

OUTPUTCONTROL

LEVELSHIFT

MUTE

THERMAL SHUTDOWN

BTL-AMPOUTPUTON/OFF

VIN1/VREF-SWLEVELSHIFT

10VO2+

11VO2-

12VO1+

13VO1-

14VCC1

15VIN1

16VIN1-A

17VIN1+A

18VIN1-B

AMP-B

AMP-A

LEVELSHIFT

LEVELSHIFT

L H

1

VREF

VDD

GND

CE

CURRENTLIMIT

2

3

5 VOUT

NC4

31

CDX-R3300EE

IC400 BD3808FS-FE2

32 31 30 29 28 27 26 25 24 23 22

I2C BUSLOGIC

VCO

MIX

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

FADER(0~-58,-∞dB)

VOLUME(+23~-79dB,-∞dB

1dB STEP)

VOLUME(+23~-79dB,-∞dB

1dB STEP)

INPUT GAIN(0~15dB,1dB STEP)

INPUT SELECTOR(4 STEREO INCLUDE 1 ISOLATION INPUT)

INPUT GAIN(0~15dB,1dB STEP)

ANTI-ALIASINGFILTER

ANTI-ALIASINGFILTER

MUTE

fc:40kHz fc:40kHz

MUTE

6 7 8 9 10 113 4 521

DGND

AGND FI

L

AN AP2

AP1 B1 B2 C1 C2 D1 D2

DS11

DS21

DS31 NC NC

12 14 1613 15

SDA

SCL

MUT

E

SEL

ADJ

VCC

OUTF

1

OUTR

1

OUTF

2

OUTR

2

DS12

DS22

DS32

OUTS

1

OUTS

2

21 20 19 18 17

VCC

VCC/2

TONEPASS

BASSfo:60,70,80,100,120,140,160,200HzQ:0.5,0.75,1,1.25

MIDDLEfo:500Hz,1kHzQ:1

TABLEfo:5,7.5,10,12.5kHz

TONEPASS

EFFECT (0dB~+20dB,2dB STEP)

EFFECT (0dB~+20dB,2dB STEP) 2ND ORDER

LPF

2ND ORDER LPFfc:OFF,80,120,160HzQ: 0.707

BASS,TREBLE, MIDDLE(-15dB~+15dB,1dB STEP)

BASS,TREBLE, MIDDLE(-15dB~+15dB,1dB STEP)

GAIN+ATT(+10~-29,

-∞dB)

32


EXPLODED VIEWS

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• Color Indication of Appearance PartsExample :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinet’s Color• Accessories are given in the last of this parts list.

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

Ref. No. Part No. Description Remark

4-1. MAIN SECTION

R


R

1 X-3384-176-2 PANEL SUB ASSY, SUB2 3-042-244-11 SCREW (T)3 X-3383-739-1 LOCK ASSY (S)4 3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT5 A-3283-513-A MAIN BOARD, COMPLETE

6 3-246-481-01 PLATE (TU), GROUND

7 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10ATU1 A-3220-961-A TUNER UNIT (TUX-032//Q3)#1 7-685-792-09 SCREW +PTT 2.6X6 (S)#2 7-685-790-01 SCREW +PTT 2.6X4 (S)

#6 7-685-793-09 SCREW +PTT 2.6X8 (S)

not supplied

F901

not supplied

not supplied

TU1

not supplied

#1

#1

#1

#6

#2

#1

MG-611MA-186//Q

A

A

B

B

1

2

3

4

7

5

6

33

CDX-R3300EE

4-2. FRONT PANEL SECTION

Ref. No. Part No. Description RemarkRef. No. Part No. Description Remark

51 X-3384-683-2 PANEL SUB ASSY, FRONT52 3-258-947-01 FILTER (IR)53 1-780-096-11 CONDUCTIVE BOARD, CONNECTION54 A-3372-541-A RETRACTABLE ASSY55 X-3384-380-1 BUTTON ASSY (S)

56 3-246-479-01 SPRING (RELEASE)57 3-258-952-01 SHEET (ILLUMINATOR)58 3-258-948-01 PLATE (CD), LIGHT GUIDE

59 3-258-937-01 PANEL, FRONT BACK60 X-3383-264-2 CASE ASSY (for FRONT PANEL)61 A-3372-774-A PANEL COMPLETE ASSY, FRONT62 3-266-165-01 SPACER (B)63 3-266-163-01 SPACER (A)

64 3-253-896-11 SHEET (H), ADHESIVELCD901 1-805-451-11 DISPLAY PANEL, LIQUID CRYSTAL#3 7-685-106-19 SCREW +P 2X10 TYPE2 NON-SLIT

LCD901

not supplied

not supplied

not suppliednot supplied

not supplied

not supplied

not supplied

not supplied(KEY board)

not supplied

#3

#3

51

52

54

5655

64

62

63

53

57

58 59

6061

34

CDX-R3300EE

4-3. CD MECHANISM SECTION (1)(MG-611MA-186//Q)

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

101 A-3372-444-A CHASSIS (T) SUB ASSY102 3-253-729-11 SPRING (LTR), TENSION COIL103 3-257-892-11 SPRING (DAMPER), COIL104 3-257-892-01 SPRING (DAMPER), COIL105 3-253-695-11 SPRING (KF), TENSION COIL

106 3-259-033-01 DAMPER (S)

107 3-352-758-31 SCREW (M1.7), TOOTHED LOCK108 A-3283-357-A SERVO BOARD, COMPLETE109 X-3384-088-1 LEVER (L) ASSY110 X-3384-089-1 LEVER (R) ASSY#4 7-627-552-87 SCREW, PRECISION +P 1.7X2.2

not supplied(SENSOR board)

not supplied

not supplied

#4

101102

103

104

105

106

107

108

109

110

35

CDX-R3300EE



151 A-3372-445-A CHASSIS (OP) COMPLETE ASSY152 3-316-938-91 SCREW (B1.4X5), TAPPING

0153 8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP)154 A-3372-448-A CHASSIS (OP) SUB ASSY (including M901)155 A-3372-449-A ARM SUB ASSY, CHUCKING

156 A-3372-446-A LEVER (SL) SUB ASSY

157 X-3384-090-2 LEVER (SL) ASSY158 3-264-165-12 SCREWM902 A-3372-447-A MOTOR ASSY, SL (SLED)SW4 1-571-099-11 SWITCH (1 KEY) (LIMIT)#5 7-627-850-77 SCREW, PRECISION +P 1.4X1.8


not supplied

SW4

not supplied

not supplied

not supplied

#5

M902

151152

153

154(including M901)

155

156

157

158

36

CDX-R3300EE



201 3-348-993-01 WASHER202 3-259-024-01 WHEEL (RA), WORM203 A-3372-441-A ARM ASSY, ROLLER204 3-259-455-11 SPRING (RAL)205 3-253-713-11 SPRING (RAR)

206 3-259-469-11 SPRING (LE), LEAF207 2-134-636-21 SCREW (M1.7X2.5)

208 3-259-467-11 BRACKET (LEM)209 3-345-648-91 SCREW (M1.4), TOOTHED LOCK210 A-3372-450-A WORM (LEB) ASSY211 3-259-468-11 BEARING (LEB)M903 A-3372-443-A MOTOR ASSY, LE (LOADING)

#4 7-627-552-87 SCREW, PRECISION +P 1.7X2.2

#4

M903

208 210

211

209

207

207

207

201202

203

204

205

206

37

CDX-R3300EE



251 3-259-429-11 WHEEL (LE), WORM252 3-344-223-01 WASHER253 3-259-470-11 GEAR (LE1)254 3-253-755-12 LEVER (D)

255 3-899-829-01 WASHER (SLIT)256 3-259-032-01 GEAR (LE2)257 A-3337-998-A CHASSIS (M) BLOCK ASSY

251

252

252254

255

256

257

253

38


ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

• -XX and -X mean standardized parts, sothey may have some difference from theoriginal one.

• RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

• Items marked “*” are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• SEMICONDUCTORSIn each case, u : µ, for example:uA.. : µA.. uPA.. : µPA..uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..

• CAPACITORSuF : µF

• COILSuH : µH



When indicating parts by referencenumber, please include the board.

KEY

KEY BOARD**********

1-780-096-11 CONDUCTIVE BOARD, CONNECTION3-258-952-01 SHEET (ILLUMINATOR)

< CAPACITOR >

C971 1-135-834-11 CERAMIC CHIP 2.2uF 6.3VC981 1-165-908-11 CERAMIC CHIP 1uF 10% 10VC982 1-135-834-11 CERAMIC CHIP 2.2uF 6.3VC991 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25VC992 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C993 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC994 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC995 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC996 1-165-908-11 CERAMIC CHIP 1uF 10% 10V

< CONNECTOR >

CN901 1-794-312-11 PIN, CONNECTOR 12P

< DIODE >

D901 8-719-085-72 DIODE UMZ6.8ENTRD902 8-719-083-66 DIODE UDZS-TE17-18BD903 8-719-978-33 DIODE DTZ-TT11-6.8BD962 8-719-072-70 DIODE MA2ZD14001S0D963 8-719-404-50 DIODE MA111-TX

D964 8-719-083-66 DIODE UDZS-TE17-18BD991 8-719-069-54 DIODE UDZS-TE17-5.1BD992 8-719-404-50 DIODE MA111-TX

< IC >

IC901 6-705-180-01 IC LC75827WIC971 6-600-163-01 IC RS-770 (IR)IC981 6-705-374-01 IC MM3033DULE

< LIQUID CRYSTAL DISPLAY >

LCD901 1-805-451-11 DISPLAY PANEL, LIQUID CRYSTAL

< DIODE >

LED902 6-500-450-01 LED CL-195SR-CD-T (OFF)LED903 6-500-450-01 LED CL-195SR-CD-T (SOURCE)LED904 6-500-450-01 LED CL-195SR-CD-T (– (VOLUME))LED905 6-500-450-01 LED CL-195SR-CD-T (ATT)LED906 6-500-450-01 LED CL-195SR-CD-T (+ (VOLUME))

LED907 6-500-450-01 LED CL-195SR-CD-T (MODE)LED908 6-500-450-01 LED CL-195SR-CD-T (SEL)LED910 6-500-450-01 LED CL-195SR-CD-T (EQ3)LED911 6-500-450-01 LED CL-195SR-CD-T (SEEK +/>/M)LED912 6-500-450-01 LED CL-195SR-CD-T (SEEK –/./m)

LED913 6-500-450-01 LED CL-195SR-CD-T (BTM)LED914 6-500-450-01 LED CL-195SR-CD-T (SCRL)LED915 6-500-450-01 LED CL-195SR-CD-T (SENS)LED916 6-500-450-01 LED CL-195SR-CD-T (6)LED917 6-500-450-01 LED CL-195SR-CD-T (5)

LED918 6-500-450-01 LED CL-195SR-CD-T (4/SHUF)LED919 6-500-450-01 LED CL-195SR-CD-T (3/REP)LED920 6-500-450-01 LED CL-195SR-CD-T (2/ALBUM +)LED921 6-500-450-01 LED CL-195SR-CD-T (1/ALBUM –)LED922 6-500-450-01 LED CL-195SR-CD-T (DSPL)

LED931 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT R)LED932 6-500-459-01 LED NSCW505T-ARS (LCD BACK LIGHT L)LED961 8-719-082-38 LED CL-270SR-C-TS (DISC IND)

< TRANSISTOR >

Q901 8-729-027-58 TRANSISTOR DTC143ZKA-T146Q902 8-729-027-58 TRANSISTOR DTC143ZKA-T146

< RESISTOR >

R901 1-216-819-11 METAL CHIP 680 5% 1/10WR902 1-216-819-11 METAL CHIP 680 5% 1/10WR903 1-216-819-11 METAL CHIP 680 5% 1/10WR904 1-216-821-11 METAL CHIP 1K 5% 1/10WR905 1-216-823-11 METAL CHIP 1.5K 5% 1/10W

R906 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR907 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR911 1-216-819-11 METAL CHIP 680 5% 1/10WR912 1-216-819-11 METAL CHIP 680 5% 1/10WR913 1-216-819-11 METAL CHIP 680 5% 1/10W

R914 1-216-821-11 METAL CHIP 1K 5% 1/10WR915 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR916 1-216-823-11 METAL CHIP 1.5K 5% 1/10WR917 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR918 1-216-827-11 METAL CHIP 3.3K 5% 1/10W

R919 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR920 1-218-867-11 METAL CHIP 6.8K 5% 1/10WR921 1-216-833-11 METAL CHIP 10K 5% 1/10WR922 1-216-835-11 METAL CHIP 15K 5% 1/10WR924 1-216-805-11 METAL CHIP 47 5% 1/10W

39

CDX-R3300EE


R925 1-216-807-11 METAL CHIP 68 5% 1/10WR926 1-216-805-11 METAL CHIP 47 5% 1/10WR931 1-216-809-11 METAL CHIP 100 5% 1/10WR932 1-216-809-11 METAL CHIP 100 5% 1/10WR933 1-216-809-11 METAL CHIP 100 5% 1/10W




R971 1-216-817-11 METAL CHIP 470 5% 1/10WR972 1-216-817-11 METAL CHIP 470 5% 1/10WR974 1-216-817-11 METAL CHIP 470 5% 1/10WR975 1-216-845-11 METAL CHIP 100K 5% 1/10WR977 1-216-864-11 METAL CHIP 0 5% 1/10W



R991 1-216-864-11 METAL CHIP 0 5% 1/10WR992 1-216-840-11 METAL CHIP 39K 5% 1/10WR993 1-216-857-11 METAL CHIP 1M 5% 1/10WR994 1-216-821-11 METAL CHIP 1K 5% 1/10WR995 1-216-821-11 METAL CHIP 1K 5% 1/10W

R996 1-216-821-11 METAL CHIP 1K 5% 1/10WR997 1-216-803-11 METAL CHIP 33 5% 1/10WR998 1-216-864-11 METAL CHIP 0 5% 1/10W

< SWITCH >

S900 1-786-653-11 SWITCH, TACTILE (EJECT (R))S901 1-786-653-11 SWITCH, TACTILE (EJECT (L))S902 1-771-884-31 SWITCH, TACTILE (OFF)S903 1-771-884-31 SWITCH, TACTILE (SOURCE)S904 1-771-884-31 SWITCH, TACTILE (– (VOLUME))

S905 1-771-884-31 SWITCH, TACTILE (ATT)S906 1-771-884-31 SWITCH, TACTILE (+ (VOLUME))S907 1-771-884-31 SWITCH, TACTILE (MODE)S908 1-771-884-31 SWITCH, TACTILE (SEL)S910 1-771-884-31 SWITCH, TACTILE (EQ3)

S911 1-771-884-31 SWITCH, TACTILE (SEEK +/>/M)S912 1-771-884-31 SWITCH, TACTILE (SEEK –/./m)S913 1-771-884-31 SWITCH, TACTILE (BTM)

S914 1-771-884-31 SWITCH, TACTILE (SCRL)S915 1-771-884-31 SWITCH, TACTILE (SENS)S916 1-771-884-31 SWITCH, TACTILE (6)S917 1-771-884-31 SWITCH, TACTILE (5)S918 1-771-884-31 SWITCH, TACTILE (4/SHUF)

S919 1-771-884-31 SWITCH, TACTILE (3/REP)S920 1-771-884-31 SWITCH, TACTILE (2/ALBUM +)S921 1-771-884-31 SWITCH, TACTILE (1/ALBUM –)S922 1-771-884-31 SWITCH, TACTILE (DSPL)S961 1-529-566-61 SWITCH, PUSH (1 KEY) (OPEN)

*************************************************************

A-3283-513-A MAIN BOARD, COMPLETE*********************

7-685-134-19 SCREW +P 2.6X8 TYPE2 NON-SLIT7-685-793-09 SCREW +PTT 2.6X8 (S)7-685-795-09 SCREW +PTT 2.6X12 (S)

< CAPACITOR >

C2 1-126-947-11 ELECT 47uF 20% 16VC3 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC5 1-126-947-11 ELECT 47uF 20% 16VC6 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC7 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C8 1-115-412-11 CERAMIC CHIP 680PF 5% 25VC301 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC303 1-128-551-11 ELECT 22uF 20% 25VC304 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC305 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V

C306 1-126-964-11 ELECT 10uF 20% 50VC308 1-126-964-11 ELECT 10uF 20% 50VC309 1-115-340-11 CERAMIC CHIP 0.22uF 10% 25VC310 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC312 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V

C314 1-126-964-11 ELECT 10uF 20% 50VC316 1-126-964-11 ELECT 10uF 20% 50VC317 1-126-961-11 ELECT 2.2uF 20% 50VC318 1-162-923-11 CERAMIC CHIP 47PF 5% 50VC319 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

C320 1-126-947-11 ELECT 47uF 20% 16VC321 1-126-964-11 ELECT 10uF 20% 50VC351 1-128-551-11 ELECT 22uF 20% 25VC352 1-128-551-11 ELECT 22uF 20% 25VC353 1-128-551-11 ELECT 22uF 20% 25V

C354 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC355 1-128-551-11 ELECT 22uF 20% 25VC400 1-126-964-11 ELECT 10uF 20% 50VC403 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16VC404 1-127-715-11 CERAMIC CHIP 0.22uF 10% 16V

C405 1-126-960-11 ELECT 1uF 20% 50VC406 1-126-960-11 ELECT 1uF 20% 50VC411 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC412 1-126-947-11 ELECT 47uF 20% 16VC421 1-126-964-11 ELECT 10uF 20% 50V

C431 1-126-964-11 ELECT 10uF 20% 50VC432 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC441 1-126-964-11 ELECT 10uF 20% 50VC451 1-126-964-11 ELECT 10uF 20% 50VC452 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

KEY MAIN

40

CDX-R3300EE


C471 1-126-964-11 ELECT 10uF 20% 50VC481 1-126-964-11 ELECT 10uF 20% 50VC491 1-126-947-11 ELECT 47uF 20% 16VC492 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC500 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C501 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC502 1-104-665-11 ELECT 100uF 20% 10VC504 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC505 1-125-710-11 DOUBLE LAYERS 0.1F 5.5VC506 1-126-924-11 ELECT 330uF 20% 10V

C510 1-162-916-11 CERAMIC CHIP 12PF 5% 50VC511 1-162-917-11 CERAMIC CHIP 15PF 5% 50VC512 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC513 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC514 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C515 1-216-864-11 METAL CHIP 0 5% 1/10WC516 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC517 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC518 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50VC519 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V

C520 1-216-864-11 METAL CHIP 0 5% 1/10WC521 1-126-964-11 ELECT 10uF 20% 50VC522 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC701 1-131-868-81 ELECT 3300uF 20% 16VC702 1-126-961-11 ELECT 2.2uF 20% 50V

C703 1-163-038-11 CERAMIC CHIP 0.1uF 25VC800 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC801 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC802 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10VC803 1-125-891-11 CERAMIC CHIP 0.47uF 10% 10V

C995 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50VC996 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V

< CONNECTOR >

CN102 1-794-311-21 PLUG, CONNECTOR 12PCN350 1-817-536-11 CONNECTOR, BOARD TO BOARD 28PCN700 1-774-701-21 PIN, CONNECTOR 16P

< DIODE >

D2 8-719-036-94 DIODE RD5.6SB-T1D101 8-719-056-83 DIODE UDZ-TE-17-6.8BD102 8-719-056-83 DIODE UDZ-TE-17-6.8BD103 8-719-056-83 DIODE UDZ-TE-17-6.8BD104 8-719-056-83 DIODE UDZ-TE-17-6.8B

D105 8-719-056-83 DIODE UDZ-TE-17-6.8BD106 8-719-056-83 DIODE UDZ-TE-17-6.8BD107 8-719-056-83 DIODE UDZ-TE-17-6.8BD108 8-719-056-83 DIODE UDZ-TE-17-6.8BD301 8-719-200-82 DIODE 11ES2

D302 8-719-200-82 DIODE 11ES2D303 8-719-200-82 DIODE 11ES2D304 8-719-200-82 DIODE 11ES2D305 8-719-200-82 DIODE 11ES2D306 8-719-200-82 DIODE 11ES2

D307 8-719-200-82 DIODE 11ES2D308 8-719-200-82 DIODE 11ES2D309 8-719-200-82 DIODE 11ES2D310 8-719-200-82 DIODE 11ES2

D311 8-719-200-82 DIODE 11ES2D312 8-719-200-82 DIODE 11ES2D351 8-719-041-79 DIODE MA721WA-TXD491 8-719-404-50 DIODE MA111-TXD492 8-719-036-94 DIODE RD5.6SB-T1

D493 8-719-040-04 DIODE MA721WK-(TX)D501 8-719-820-05 DIODE 1SS181D601 8-719-040-04 DIODE MA721WK-(TX)D602 8-719-056-93 DIODE UDZ-TE-17-18BD603 8-719-056-83 DIODE UDZ-TE-17-6.8B

D701 8-719-056-93 DIODE UDZ-TE-17-18BD702 8-719-056-93 DIODE UDZ-TE-17-18BD703 8-719-056-93 DIODE UDZ-TE-17-18BD704 8-719-049-38 DIODE 1N5404TU

< IC >

IC300 6-705-360-01 IC TDA8588BJ/N2IC400 6-705-372-01 IC BD3808FS-FE2IC500 6-804-050-01 IC MN101E01KDKIC502 8-759-659-13 IC PST3428UL

< JACK >

J1 1-815-185-13 JACK (ANTENNA)J400 1-774-698-11 JACK, PIN 2P (AUDIO OUT REAR)J561 1-566-822-41 JACK (REMOTE IN)

< JUMPER RESISTOR >

JC1 1-216-296-11 SHORT CHIP 0JC300 1-216-296-11 SHORT CHIP 0JC301 1-216-296-11 SHORT CHIP 0JC302 1-216-296-11 SHORT CHIP 0JC303 1-216-296-11 SHORT CHIP 0

JC304 1-216-864-11 METAL CHIP 0 5% 1/10WJC350 1-216-296-11 SHORT CHIP 0JC400 1-216-864-11 METAL CHIP 0 5% 1/10WJC401 1-216-296-11 SHORT CHIP 0JC402 1-216-864-11 METAL CHIP 0 5% 1/10W

JC403 1-216-864-11 METAL CHIP 0 5% 1/10WJC423 1-216-864-11 METAL CHIP 0 5% 1/10WJC501 1-216-864-11 METAL CHIP 0 5% 1/10WJC502 1-216-296-11 SHORT CHIP 0JC503 1-216-864-11 METAL CHIP 0 5% 1/10W

JC504 1-216-296-11 SHORT CHIP 0JC505 1-216-296-11 SHORT CHIP 0JC506 1-216-296-11 SHORT CHIP 0JC508 1-216-296-11 SHORT CHIP 0JC509 1-216-864-11 METAL CHIP 0 5% 1/10W

JC511 1-216-864-11 METAL CHIP 0 5% 1/10WJC601 1-216-864-11 METAL CHIP 0 5% 1/10WJC701 1-216-864-11 METAL CHIP 0 5% 1/10WJC702 1-216-296-11 SHORT CHIP 0JC703 1-216-296-11 SHORT CHIP 0

< COIL >

L1 1-469-844-11 INDUCTOR 2.2uHL2 1-469-844-11 INDUCTOR 2.2uHL351 1-500-245-11 INDUCTOR, FERRITE BEADL352 1-500-245-11 INDUCTOR, FERRITE BEADL353 1-469-876-11 INDUCTOR, FERRITE BEAD

MAIN

41

CDX-R3300EE


L354 1-500-245-11 INDUCTOR, FERRITE BEADL355 1-469-876-11 INDUCTOR, FERRITE BEADL356 1-500-245-11 INDUCTOR, FERRITE BEADL357 1-469-876-11 INDUCTOR, FERRITE BEADL358 1-469-876-11 INDUCTOR, FERRITE BEAD

L359 1-216-295-11 SHORT CHIP 0L700 1-456-617-11 COIL, CHOKE 250uH

< TRANSISTOR >

Q3 8-729-920-85 TRANSISTOR 2SD1664-QRQ420 6-550-752-01 TRANSISTOR DTC614TKT146Q430 6-550-752-01 TRANSISTOR DTC614TKT146Q440 6-550-752-01 TRANSISTOR DTC614TKT146Q450 6-550-752-01 TRANSISTOR DTC614TKT146

Q470 6-550-752-01 TRANSISTOR DTC614TKT146Q480 6-550-752-01 TRANSISTOR DTC614TKT146Q491 8-729-424-08 TRANSISTOR UN2111Q492 8-729-421-19 TRANSISTOR UN2213Q501 8-729-424-08 TRANSISTOR UN2111

Q605 8-729-421-22 TRANSISTOR UN2211Q606 8-729-421-19 TRANSISTOR UN2213Q607 8-729-010-25 TRANSISTOR MSD601-RT1Q701 8-729-010-25 TRANSISTOR MSD601-RT1Q702 8-729-010-25 TRANSISTOR MSD601-RT1

< RESISTOR >

R4 1-216-839-11 METAL CHIP 33K 5% 1/10WR5 1-216-843-11 METAL CHIP 68K 5% 1/10WR6 1-216-809-11 METAL CHIP 100 5% 1/10WR7 1-216-809-11 METAL CHIP 100 5% 1/10WR9 1-216-864-11 METAL CHIP 0 5% 1/10W

R10 1-216-821-11 METAL CHIP 1K 5% 1/10WR101 1-216-809-11 METAL CHIP 100 5% 1/10WR102 1-216-809-11 METAL CHIP 100 5% 1/10WR103 1-216-809-11 METAL CHIP 100 5% 1/10WR104 1-216-809-11 METAL CHIP 100 5% 1/10W

R105 1-216-809-11 METAL CHIP 100 5% 1/10WR106 1-216-809-11 METAL CHIP 100 5% 1/10WR107 1-216-809-11 METAL CHIP 100 5% 1/10WR108 1-218-871-11 METAL CHIP 10K 0.5% 1/10WR109 1-218-871-11 METAL CHIP 10K 0.5% 1/10W

R112 1-216-864-11 METAL CHIP 0 5% 1/10WR115 1-216-864-11 METAL CHIP 0 5% 1/10WR301 1-216-809-11 METAL CHIP 100 5% 1/10WR302 1-216-841-11 METAL CHIP 47K 5% 1/10WR351 1-216-845-11 METAL CHIP 100K 5% 1/10W

R370 1-216-809-11 METAL CHIP 100 5% 1/10WR371 1-216-809-11 METAL CHIP 100 5% 1/10WR404 1-218-881-11 METAL CHIP 27K 0.5% 1/10WR420 1-216-809-11 METAL CHIP 100 5% 1/10WR421 1-216-809-11 METAL CHIP 100 5% 1/10W

R422 1-216-841-11 METAL CHIP 47K 5% 1/10WR423 1-216-864-11 METAL CHIP 0 5% 1/10WR430 1-216-809-11 METAL CHIP 100 5% 1/10WR431 1-216-809-11 METAL CHIP 100 5% 1/10WR432 1-216-841-11 METAL CHIP 47K 5% 1/10W

R433 1-216-864-11 METAL CHIP 0 5% 1/10WR440 1-216-809-11 METAL CHIP 100 5% 1/10W

R441 1-216-809-11 METAL CHIP 100 5% 1/10WR442 1-216-841-11 METAL CHIP 47K 5% 1/10WR443 1-216-864-11 METAL CHIP 0 5% 1/10WR450 1-216-809-11 METAL CHIP 100 5% 1/10WR451 1-216-809-11 METAL CHIP 100 5% 1/10W

R452 1-216-841-11 METAL CHIP 47K 5% 1/10WR453 1-216-864-11 METAL CHIP 0 5% 1/10WR470 1-216-809-11 METAL CHIP 100 5% 1/10WR471 1-216-809-11 METAL CHIP 100 5% 1/10WR472 1-216-841-11 METAL CHIP 47K 5% 1/10W

R480 1-216-809-11 METAL CHIP 100 5% 1/10WR481 1-216-809-11 METAL CHIP 100 5% 1/10WR482 1-216-841-11 METAL CHIP 47K 5% 1/10WR491 1-216-805-11 METAL CHIP 47 5% 1/10WR492 1-216-864-11 METAL CHIP 0 5% 1/10W

R505 1-216-845-11 METAL CHIP 100K 5% 1/10WR506 1-216-813-11 METAL CHIP 220 5% 1/10WR507 1-216-864-11 METAL CHIP 0 5% 1/10WR508 1-216-845-11 METAL CHIP 100K 5% 1/10WR509 1-216-845-11 METAL CHIP 100K 5% 1/10W

R510 1-216-845-11 METAL CHIP 100K 5% 1/10WR511 1-216-845-11 METAL CHIP 100K 5% 1/10WR512 1-216-845-11 METAL CHIP 100K 5% 1/10WR513 1-216-845-11 METAL CHIP 100K 5% 1/10WR514 1-216-841-11 METAL CHIP 47K 5% 1/10W

R517 1-216-845-11 METAL CHIP 100K 5% 1/10WR520 1-216-845-11 METAL CHIP 100K 5% 1/10WR523 1-216-845-11 METAL CHIP 100K 5% 1/10WR524 1-216-833-11 METAL CHIP 10K 5% 1/10WR526 1-216-825-11 METAL CHIP 2.2K 5% 1/10W

R527 1-216-825-11 METAL CHIP 2.2K 5% 1/10WR528 1-216-845-11 METAL CHIP 100K 5% 1/10WR529 1-216-845-11 METAL CHIP 100K 5% 1/10WR530 1-218-871-11 METAL CHIP 10K 0.5% 1/10WR532 1-216-845-11 METAL CHIP 100K 5% 1/10W



R705 1-249-425-11 CARBON 4.7K 5% 1/4WR706 1-216-841-11 METAL CHIP 47K 5% 1/10WR707 1-216-841-11 METAL CHIP 47K 5% 1/10WR708 1-216-829-11 METAL CHIP 4.7K 5% 1/10WR709 1-216-821-11 METAL CHIP 1K 5% 1/10W

< SWITCH >

S103 1-692-431-21 SWITCH, TACTILE (RESET)

< TUNER >

TU1 A-3220-961-A TUNER UNIT (TUX-032//Q3)

MAIN

42

CDX-R3300EE


< VIBRATOR >

X500 1-813-160-11 VIBRATOR, CERAMIC (27.648MHz)X501 1-813-202-11 VIBRATOR, CRYSTAL (32.768kHz)

*************************************************************

SENSOR BOARD**************

< SWITCH >

SW2 1-529-566-61 SWITCH, PUSH (1 KEY) (SELF)SW3 1-529-566-61 SWITCH, PUSH (1 KEY) (DISC IN)

*************************************************************

A-3283-357-A SERVO BOARD, COMPLETE**********************

< CAPACITOR >

C1 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC2 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC3 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC4 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC5 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C6 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC7 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC8 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC10 1-104-609-11 ELECT CHIP 100uF 20% 4VC11 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V


C21 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC22 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC23 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50VC24 1-162-962-11 CERAMIC CHIP 470PF 10% 50VC25 1-162-967-11 CERAMIC CHIP 0.0033uF 10% 50V

C26 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC27 1-126-208-21 ELECT CHIP 47uF 20% 4VC28 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC29 1-164-156-11 CERAMIC CHIP 0.1uF 25VC30 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C32 1-164-156-11 CERAMIC CHIP 0.1uF 25VC33 1-164-156-11 CERAMIC CHIP 0.1uF 25VC34 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC35 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC36 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C37 1-164-677-11 CERAMIC CHIP 0.033uF 10% 16VC38 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC39 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC40 1-162-969-11 CERAMIC CHIP 0.0068uF 10% 25VC41 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C42 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC43 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC44 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC45 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC46 1-162-965-11 CERAMIC CHIP 0.0015uF 10% 50V

C47 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C48 1-104-609-11 ELECT CHIP 100uF 20% 4VC49 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC50 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3VC51 1-164-156-11 CERAMIC CHIP 0.1uF 25VC52 1-100-381-11 ELECT CHIP 10uF 20% 16V

C53 1-100-381-11 ELECT CHIP 10uF 20% 16VC54 1-164-156-11 CERAMIC CHIP 0.1uF 25VC55 1-164-156-11 CERAMIC CHIP 0.1uF 25VC56 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC57 1-164-156-11 CERAMIC CHIP 0.1uF 25V

C58 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC59 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC60 1-100-381-11 ELECT CHIP 10uF 20% 16VC63 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25VC64 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16V

C65 1-126-208-21 ELECT CHIP 47uF 20% 4VC66 1-164-156-11 CERAMIC CHIP 0.1uF 25VC67 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC74 1-126-208-21 ELECT CHIP 47uF 20% 4VC75 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V

C77 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC79 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC81 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC83 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC85 1-125-837-11 CERAMIC CHIP 1uF 10% 6.3V


C110 1-107-826-11 CERAMIC CHIP 0.1uF 10% 16VC115 1-162-966-11 CERAMIC CHIP 0.0022uF 10% 50V

< CONNECTOR >

CN1 1-794-153-21 CONNECTOR, FPC (ZIF) 16PCN2 1-817-275-21 CONNECTOR, BOARD TO BOARD 28P

< JUMPER RESISTOR >

FB1 1-216-864-11 METAL CHIP 0 5% 1/10WFB2 1-216-864-11 METAL CHIP 0 5% 1/10WFB5 1-216-864-11 METAL CHIP 0 5% 1/10W

< IC >

IC1 6-705-366-01 IC LA6560-TE-L-EIC3 8-753-216-86 IC CXD3059BRIC4 6-804-028-01 IC MB90487PFV-G-105-BNDE1IC7 6-705-364-01 IC R1114N151D-TR-FAIC8 6-705-365-01 IC TC94A34FG-002

< TRANSISTOR >

Q1 8-729-904-87 TRANSISTOR 2SB1197K-RQ2 8-729-928-90 TRANSISTOR DTC114EEQ3 8-729-904-87 TRANSISTOR 2SB1197K-RQ5 8-729-904-87 TRANSISTOR 2SB1197K-RQ6 8-729-928-90 TRANSISTOR DTC114EE

< RESISTOR >

R1 1-218-941-81 RES-CHIP 100 5% 1/16W

MAIN SENSOR SERVO

43

CDX-R3300EE

R2 1-218-971-11 RES-CHIP 33K 5% 1/16WR3 1-218-971-11 RES-CHIP 33K 5% 1/16WR4 1-218-965-11 RES-CHIP 10K 5% 1/16WR5 1-218-965-11 RES-CHIP 10K 5% 1/16WR6 1-218-965-11 RES-CHIP 10K 5% 1/16W

R7 1-208-635-11 RES-CHIP 10 5% 1/16WR8 1-218-971-11 RES-CHIP 33K 5% 1/16WR9 1-218-971-11 RES-CHIP 33K 5% 1/16WR10 1-218-965-11 RES-CHIP 10K 5% 1/16WR11 1-218-965-11 RES-CHIP 10K 5% 1/16W

R12 1-208-635-11 RES-CHIP 10 5% 1/16WR13 1-218-965-11 RES-CHIP 10K 5% 1/16WR14 1-218-990-11 SHORT CHIP 0R15 1-218-990-11 SHORT CHIP 0R16 1-218-990-11 SHORT CHIP 0

R17 1-218-965-11 RES-CHIP 10K 5% 1/16WR18 1-218-965-11 RES-CHIP 10K 5% 1/16WR19 1-218-969-11 RES-CHIP 22K 5% 1/16WR20 1-218-969-11 RES-CHIP 22K 5% 1/16WR21 1-218-990-11 SHORT CHIP 0


R27 1-218-965-11 RES-CHIP 10K 5% 1/16WR28 1-218-990-11 SHORT CHIP 0R29 1-218-977-11 RES-CHIP 100K 5% 1/16WR37 1-218-947-11 RES-CHIP 330 5% 1/16WR38 1-218-967-11 RES-CHIP 15K 5% 1/16W

R39 1-218-941-81 RES-CHIP 100 5% 1/16WR40 1-218-990-11 SHORT CHIP 0R41 1-218-985-11 RES-CHIP 470K 5% 1/16WR42 1-218-965-11 RES-CHIP 10K 5% 1/16WR43 1-218-977-11 RES-CHIP 100K 5% 1/16W

R44 1-218-957-11 RES-CHIP 2.2K 5% 1/16WR45 1-218-971-11 RES-CHIP 33K 5% 1/16WR46 1-218-957-11 RES-CHIP 2.2K 5% 1/16WR47 1-218-977-11 RES-CHIP 100K 5% 1/16WR48 1-218-941-81 RES-CHIP 100 5% 1/16W

R49 1-218-953-11 RES-CHIP 1K 5% 1/16WR50 1-218-941-81 RES-CHIP 100 5% 1/16WR52 1-218-941-81 RES-CHIP 100 5% 1/16WR53 1-218-959-11 RES-CHIP 3.3K 5% 1/16WR54 1-218-961-11 RES-CHIP 4.7K 5% 1/16W

R55 1-218-953-11 RES-CHIP 1K 5% 1/16WR56 1-218-973-11 RES-CHIP 47K 5% 1/16WR57 1-218-941-81 RES-CHIP 100 5% 1/16WR59 1-218-941-81 RES-CHIP 100 5% 1/16WR60 1-218-990-11 SHORT CHIP 0

R61 1-218-985-11 RES-CHIP 470K 5% 1/16WR62 1-218-965-11 RES-CHIP 10K 5% 1/16WR64 1-218-941-81 RES-CHIP 100 5% 1/16WR65 1-218-941-81 RES-CHIP 100 5% 1/16WR67 1-218-941-81 RES-CHIP 100 5% 1/16W

R68 1-218-990-11 SHORT CHIP 0R69 1-218-973-11 RES-CHIP 47K 5% 1/16WR70 1-218-945-11 RES-CHIP 220 5% 1/16W

R71 1-218-941-81 RES-CHIP 100 5% 1/16WR72 1-218-990-11 SHORT CHIP 0R73 1-218-941-81 RES-CHIP 100 5% 1/16WR74 1-218-941-81 RES-CHIP 100 5% 1/16WR76 1-218-941-81 RES-CHIP 100 5% 1/16W

R77 1-218-990-11 SHORT CHIP 0R78 1-218-941-81 RES-CHIP 100 5% 1/16WR79 1-218-941-81 RES-CHIP 100 5% 1/16WR80 1-218-977-11 RES-CHIP 100K 5% 1/16WR81 1-218-941-81 RES-CHIP 100 5% 1/16W


R97 1-218-941-81 RES-CHIP 100 5% 1/16WR98 1-218-941-81 RES-CHIP 100 5% 1/16WR99 1-218-965-11 RES-CHIP 10K 5% 1/16WR101 1-218-969-11 RES-CHIP 22K 5% 1/16WR106 1-218-969-11 RES-CHIP 22K 5% 1/16W

R107 1-218-965-11 RES-CHIP 10K 5% 1/16WR108 1-218-941-81 RES-CHIP 100 5% 1/16WR109 1-218-953-11 RES-CHIP 1K 5% 1/16WR110 1-218-945-11 RES-CHIP 220 5% 1/16WR111 1-218-990-11 SHORT CHIP 0

R114 1-218-941-81 RES-CHIP 100 5% 1/16WR115 1-218-941-81 RES-CHIP 100 5% 1/16WR116 1-218-941-81 RES-CHIP 100 5% 1/16WR117 1-218-990-11 SHORT CHIP 0R119 1-218-941-81 RES-CHIP 100 5% 1/16W

R122 1-218-965-11 RES-CHIP 10K 5% 1/16WR123 1-218-990-11 SHORT CHIP 0R124 1-216-864-11 METAL CHIP 0 5% 1/10WR126 1-218-965-11 RES-CHIP 10K 5% 1/16WR127 1-218-965-11 RES-CHIP 10K 5% 1/16W

R128 1-218-965-11 RES-CHIP 10K 5% 1/16WR129 1-218-965-11 RES-CHIP 10K 5% 1/16WR133 1-216-864-11 METAL CHIP 0 5% 1/10WR136 1-218-977-11 RES-CHIP 100K 5% 1/16WR139 1-218-957-11 RES-CHIP 2.2K 5% 1/16W

R140 1-218-941-81 RES-CHIP 100 5% 1/16WR141 1-218-941-81 RES-CHIP 100 5% 1/16WR142 1-218-941-81 RES-CHIP 100 5% 1/16WR143 1-218-941-81 RES-CHIP 100 5% 1/16WR144 1-218-965-11 RES-CHIP 10K 5% 1/16W

R145 1-218-977-11 RES-CHIP 100K 5% 1/16WR146 1-218-941-81 RES-CHIP 100 5% 1/16WR147 1-218-941-81 RES-CHIP 100 5% 1/16WR148 1-218-941-81 RES-CHIP 100 5% 1/16WR149 1-218-941-81 RES-CHIP 100 5% 1/16W

< SWITCH >

SW1 1-529-565-61 SWITCH, PUSH (1 KEY) (DOWN)

< VIBRATOR >

X1 1-795-561-21 VIBRATOR, CERAMIC (16.9344MHz)X2 1-795-822-21 VIBRATOR, CERAMIC (18.43MHz)

*************************************************************


SERVO

44

CDX-R3300EE

MISCELLANEOUS***************

7 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)0153 8-820-207-02 OPTICAL PICK-UP (KSS1000E/K1RP)

154 A-3372-448-A CHASSIS (OP) SUB ASSY (including M901)F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10AM902 A-3372-447-A MOTOR ASSY, SL (SLED)

M903 A-3372-443-A MOTOR ASSY, LE (LOADING)SW4 1-571-099-11 SWITCH (1 KEY) (LIMIT)

*************************************************************

ACCESSORIES************

3-263-513-11 MANUAL, INSTRUCTION (ENGLISH,RUSSIAN)3-263-514-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH,

RUSSIAN)X-3383-264-2 CASE ASSY (for FRONT PANEL)

*************************************************************

PARTS FOR INSTALLATION AND CONNECTIONS***************************************

301 X-3382-647-1 FRAME ASSY, FITTING302 X-3381-154-1 SCREW ASSY (BS4), FITTING303 3-349-410-11 BUSHING304 3-261-542-01 COLLAR305 1-465-459-21 ADAPTOR, ANTENNA

306 3-246-471-01 KEY (FRAME)307 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER)



302301

307

306

303

304 305

45

CDX-R3300EE

MEMO

46

CDX-R3300EE

REVISION HISTORY

Clicking the version allows you to jump to the revised page.Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.

Ver. Date Description of Revision1.0 2004. 02 New

COVERTABLE OF CONTENTSGENERALDISASSEMBLYSUB PANEL ASSYCD MECHANISM BLOCKMAIN BOARDCHASSIS (T) SUB ASSYROLLER ARM ASSYCHASSIS (OP) ASSYOPTICAL PICK-UPSL MOTOR ASSY (M902)LE MOTOR ASSY (M903)SERVO BOARD

DIAGRAMSIC PIN DESCRIPTIONSBLOCK DIAGRAM-CD SECTION-BLOCK DIAGRAM-TUNER SECTION-BLOCK DIAGRAM-DISPLAY SECTION-PRINTED WIRING BOARDS-CD MECHANISM SECTION-SCHEMATIC DIAGRAM-CD MECHANISM SECTION (1/2)-SCHEMATIC DIAGRAM-CD MECHANISM SECTION (2/2)-PRINTED WIRING BOARD-MAIN SECTION-SCHEMATIC DIAGRAM-MAIN SECTION (1/2)-SCHEMATIC DIAGRAM-MAIN SECTION (2/2)-PRINTED WIRING BOARD-KEY SECTION-SCHEMATIC DIAGRAM-KEY SECTION-IC BLOCK DIAGRAMS

EXPLODED VIEWSMAIN SECTIONFRONT PANEL SECTIONCD MECHANISM SECTION (1)CD MECHANISM SECTION (2)CD MECHANISM SECTION (3)CD MECHANISM SECTION (4)

ELECTRICAL PARTS LISTKEYMAINSENSORSERVO

REVISION HISTORY

cdx-r3300ee - especarchive.espec.ws/files/sony_cdx-r3300ee_sm.pdfcdx-r3300ee cd player section...

Documents