![Page 1: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/1.jpg)
1
Instruction Manual
PRINTED 0612 315627-001
Keep thIs Manual In the pocKet on heater for future reference whenever MaIntenance adjustMent or servIce Is requIred.
coMMercIal Gas water heaters
• for Your safety •AN ODORANT IS ADDED TO THE GAS USED
BY THIS WATER HEATER.
Models Bt-80, Bt-100series 300, 301
InstallatIon - operatIon - servIce - MaIntenance - lIMIted warrantY
PlAcE THESE INSTRUcTIONS ADjAcENT TO HEATER AND NOTIfY OWNER TO kEEP fOR fUTURE REfERENcE.
Read and understand this instructionmanual and the safety messagesherein before installing, operating orservicing this water heater.
Failure to follow these instructions andsafety messages could result in deathor serious injury.
This manual must remain with thewater heater.
500 Tennessee Waltz ParkwayAshland city, TN 37015
Low Lead Content
WARNING: If the information in theseinstructions is not followed exactly, a fireor explosion may result causing propertydamage, personal injury or death.
Do not store or use gasoline or otherflammable vapors and liquids in thevicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:Do not try to light any appliance.Do not touch any electrical switch; donot use any phone in your building.Immediately call your gas supplierfrom a neighbor’s phone. Follow thegas supplier’s instructions.
If you cannot reach your gas supplier,call the fire department.
Installation and service must beperformed by a qualified installer,service agency or the gas supplier.
••
•
•
![Page 2: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/2.jpg)
2
SAfE INSTAllATION, USE AND SERVIcE...................... 3
APPROVAlS ......................................................................3
GENERAl SAfETY INfORMATION .................................. 4
INTRODUcTION ................................................................5
Abbreviations Used .....................................................5
QualifiedInstallerorServiceAgency........................... 5
PreparingfortheNewInstallation ............................... 5
INSTAllATION cONSIDERATIONS ............................. 6-9
RoughInDimensions ..................................................6
Thermometers .............................................................7
FactstoConsiderAboutLocation ............................... 7
HighAltitude ................................................................8
Clearances ..................................................................8
Insulation Blankets ......................................................9
Hard Water ..................................................................9
CirculationPumps .......................................................9
INSTAllATION REqUIREMENTS .................................. 10
GasSupplySystems .................................................10
GasPressureRequirements ..................................... 10
SupplyGasRegulator ...............................................10
MixingValves ............................................................10
WaterPiping .............................................................. 11
ClosedWaterSystems .............................................. 11
ThermalExpansion ................................................... 11
Temperature-PressureReliefValve ......................... 11
FillingtheWaterHeater ............................................. 12
AirRequirements.......................................................12
UnconfinedSpace .....................................................13
ConfinedSpace .........................................................13
FreshAirOpeningsforConfinedSpaces .................. 13
OutdoorAirThroughTwoOpenings .......................... 13
OutdoorAirThroughOneOpening ........................... 13
OutdoorAirThroughTwoHorizontalDucts ............... 14
OutdoorAirThroughTwoVerticalDucts ................... 14
AirFromOtherIndoorSpaces .................................. 14
Venting ......................................................................14
SupplyGasRegulator ...............................................15
GasPiping .................................................................16
SedimentTraps .........................................................17
lIGHTING & OPERATING INSTRUcTIONS .............. 18,19
TEMPERATURE REGUlATION ...................................... 20
fOR YOUR INfORMATION .............................................20
Start Up conditions ...................................................20
Operational conditions ..............................................21
PERIODIc MAINTENANcE .............................................22
VentingSystemInspection ........................................ 22
BurnerInspection ......................................................22
BurnerCleaning ........................................................22
Housekeeping ...........................................................23
AnodeRodInspection ...............................................23
Temperature-PressureReliefValveTest ................... 23
REcOMMENDED PROcEDURE fOR PERIODIc
REMOVAl Of lIME DEPOSITS fROM TANk
TYPE cOMMERcIAl WATER HEATERS ........................ 23
DelimingSolvents......................................................24
TankCleanoutProcedure .......................................... 24
DelimingUsingFlo-JugMethod ................................ 24
DrainingandFlushing ...............................................25
Service ......................................................................25
lEAkAGE cHEckPOINTS ..............................................26
TROUBlESHOOTING GUIDElINES ............................... 27
WATER PIPING DIAGRAMS .......................................28-33
NOTES .............................................................................34
WARRANTY .....................................................................35
taBle of contents
![Page 3: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/3.jpg)
3
safe InstallatIon, use and servIce
Theproperinstallation,useandservicingofthiswaterheaterisextremelyimportanttoyoursafetyandthesafetyofothers.Manysafety-relatedmessagesandinstructionshavebeenprovidedinthismanualandonyourownwaterheatertowarnyouandothersofapotentialinjuryhazard.Readandobeyallsafetymessagesandinstructionsthroughoutthismanual.Itisveryimportantthatthemeaningofeachsafetymessageisunderstoodbyyouandotherswhoinstall,use,orservicethiswaterheater.
Allsafetymessageswillgenerallytellyouaboutthetypeofhazard,whatcanhappenifyoudonotfollowthesafetymessage,andhowtoavoidtheriskofinjury.TheCaliforniaSafeDrinkingWaterandToxicEnforcementActrequirestheGovernorofCaliforniatopublishalistofsubstancesknown to theStateofCalifornia tocausecancer,birthdefects,orother reproductiveharm,and requiresbusinesses towarnofpotentialexposuretosuchsubstances.ThisproductcontainsachemicalknowntotheStateofCaliforniatocausecancer,birthdefects,orotherreproductiveharm.ThiswaterheatercancauselowlevelexposuretosomeofthesubstanceslistedintheAct.
DANGER
WARNING
CAUTION
CAUTION
DANGER indicates an imminentlyhazardous situation which, if not avoided,will result in injury or death.
This is the safety alert symbol. It is used to alert you topotential personal injury hazards. Obey all safetymessages that follow this symbol to avoid possibleinjury or death.
WARNING indicates a potentially hazardoussituation which, if not avoided, could resultin injury or death.
CAUTION indicates a potentially hazardoussituation which, if not avoided, could result inminor or moderate injury.
CAUTION used without the safety alertsymbol indicates a potentially hazardoussituation which, if not avoided, could result inproperty damage.
approvals
Low Lead Content
![Page 4: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/4.jpg)
4
General safetY InforMatIon
![Page 5: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/5.jpg)
5
ThankYouforpurchasingthiswaterheater.Properlyinstalledandmaintained,itshouldgiveyouyearsoftroublefreeservice.
aBBrevIatIons used
AbbreviationsFoundInThisInstructionManual:• UL-UnderwritersLaboratoriesInc.• ANSI-AmericanNationalStandardsInstitute• NFPA-NationalFireProtectionAssociation• ASME-AmericanSocietyofMechanicalEngineers• AHRI-Air-Conditioning,HeatingandRefrigerationInstitute• CAN-Canada• EPACT-EnergyPolicyAct• CSA-CanadianStandardsAssociation
This gas-firedwater heater is design certified byUnderwritersLaboratoriesInc.underAmericanNationalStandard/CSAStandard forGasWaterHeatersANSIZ21.10.3•CSA4.3(currentedition).
qualIfIed Installer or servIce aGencY
InstallationandserviceofthiswaterheaterrequiresabilityequivalenttothatofaQualifiedAgency(asdefinedbyANSIbelow)inthefieldinvolved. Installation skills suchas plumbing, air supply, venting,gassupplyandelectricalsupplyarerequiredinadditiontoelectricaltestingskillswhenperformingservice.
ANSIZ223.12006Sec.3.3.83:“QualifiedAgency”-“Anyindividual,firm, corporation or company that either in person or through arepresentativeisengagedinandisresponsiblefor(a)theinstallation,testingorreplacementofgaspipingor(b)theconnection,installation,testing, repair or servicing of appliances and equipment; that isexperiencedinsuchwork;thatisfamiliarwithallprecautionsrequired;and that has compliedwith all the requirements of the authorityhavingjurisdiction.”
Ifyouarenotqualified (asdefinedbyANSIabove)and licensedorcertifiedasrequiredby theauthorityhaving jurisdiction toperformagiventaskdonotattempttoperformanyoftheproceduresdescribedinthismanual.Ifyoudonotunderstandtheinstructionsgiveninthismanualdonotattempttoperformanyproceduresoutlinedinthismanual.
preparInG for the InstallatIon
1. Read the “GeneralSafety” section, page4of thismanualfirstandthentheentiremanualcarefully.Ifyoudon’tfollow
thesafetyrules,thewaterheaterwillnotoperateproperly.ItcouldcauseDEATH,SERIOUSBODILYINJURYAND/ORPROPERTY DAMAGE.
This manual contains instructions for the installation,operation,andmaintenanceofthegas-firedwaterheater.Italsocontainswarningsthroughoutthemanualthatyoumustreadandbeawareof.Allwarningsandallinstructionsareessentialtotheproperoperationofthewaterheaterandyoursafety.Sincewecannotputeverythingonthefirstfewpages,READ THE ENTIRE MANUAl BEfORE ATTEMPTING TO INSTAll OR OPERATE THE WATER HEATER.
2.The installationmust conformwith these instructions andthelocalcodeauthorityhavingjurisdiction.Intheabsenceoflocalcodes,theinstallationmustcomplywiththecurrenteditions of the National Fuel Gas Code, ANSI Z223.1/NFPA54orCAN/CSA-B149.1theNaturalGasandPropaneInstallation Code. All documents are available from theCanadianStandardsAssociation,8501EastPleasantValleyRoad, Cleveland, OH 44131. NFPA documents are alsoavailable from theNational Fire Protection Association, 1BatterymarchPark,Quincy,MA02269.
3.If after reading thismanual youhaveanyquestionsordonotunderstandanyportionoftheinstructions,callthelocalgasutilityorthemanufacturerwhosenameappearsontheratingplate.
4.Carefully plan the place where you are going to put thewater heater. Correct combustion, vent action, and ventpipeinstallationareveryimportantinpreventingdeathfrompossiblecarbonmonoxidepoisoningandfires,seeFigures3 and 7.
Examinethelocationtoensurethewaterheatercomplieswiththe“LocatingtheNewWaterHeater”sectioninthismanual.
5.ForCaliforniainstallationthiswaterheatermustbebraced,anchored, or strapped to avoid falling or moving duringan earthquake. See instructions for correct installationprocedures. Instructionsmaybeobtained fromCaliforniaOffice of the State Architect, 400 P Street, Sacramento, cA 95814.
6.MassachusettsCoderequiresthiswaterheatertobeinstalledin accordance withMassachusetts 248-CMR 2.00: StatePlumbingCodeand248-CMR5.00.
IntroductIon
![Page 6: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/6.jpg)
6
rouGh In dIMensIons
taBle 1. dIMensIons and recoverY ratInGs
dIMensIons
Model units a B c d e f G h j K l M
BT-80Natural & lP
InchescM
611/8155.25
581/2148.6
2911/1675.4
261/267.3
153/1638.6
410.2
141/239.4
1640.6
11/43.2
1NPT
1/2NPT
1115/1630.3
BT-100Natural & lP
InchescM
685/8174.3
661/2168.9
3015/1678.59
273/470.5
153/1638.6
410.2
153/440.0
1640.6
11/43.2
11/4NPT
1/2NPT
1115/1630.3
recoverY ratInGs
ModelInput approx.
Gal. cap.
approx. liter cap.
temp. rise
c° 17 22 28 33 39 44 50 56 61 67 72 78rating Btu/hr
rating kw f° 30 40 50 60 70 80 90 100 110 120 130 140
BT-80 75,100 22 74 280GPH 243 182 146 121 104 91 81 73 66 61 56 52lPH 916 686 550 456 392 343 305 275 249 230 211 196
BT-100 75,100 22 98 371GPH 243 182 146 121 104 91 81 73 66 61 56 52lPH 916 686 550 456 392 343 305 275 249 230 211 196
Recoveryratingsbasedon80%thermalefficiency.
InstallatIon consIderatIons
fIGure 1.
![Page 7: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/7.jpg)
7
therMoMeters (not supplied)Thermometersshouldbeobtainedandfieldinstalled.Thermometersareinstalledinthesystemasameansofdetectingthetemperatureoftheoutletwatersupply.
ThisWaterHeaterhasbeendesigncertifiedascomplyingwithANSIZ21.10.3-CSA4.3currenteditionforwaterheatersandisconsideredsuitablefor:
Water (Potable) Heating and Space Heating:All models areconsideredsuitableforwater(potable)heatingandspaceheating.
HOTTERWATERCANSCALD:Waterheatersareintendedtoproducehotwater.Waterheatedtoatemperaturewhichwillsatisfyspaceheating,clotheswashing,dishwashing,andothersanitizingneedscanscaldandpermanentlyinjureyouuponcontact.Somepeoplearemorelikelytobepermanentlyinjuredbyhotwaterthanothers.Theseincludetheelderly,children,theinfirm,orphysically/mentallyhandicapped.Ifanyoneusinghotwaterinyourhomefitsintooneofthesegroupsorifthereisalocalcoderequiringacertaintemperaturewateratthehotwatertap,thenyoumusttakespecialprecautions.Inadditiontousingthelowestpossible temperature setting that satisfies your hotwater needs,ameanssuchasa*MixingValveshouldbeusedatthehotwatertapsusedbythesepeopleoratthewaterheater.Mixingvalvesareavailableatplumbingsupplyorhardwarestores.Consultaqualifiedinstaller or service agency. Followmixing valvemanufacturer’sinstructions for installationof valves.Beforechanging the factorysettingonthethermostat,readthe“TemperatureRegulation”sectioninthismanual,seeFigures17and18.
facts to consIder aBout the locatIon
Carefully choose an indoor location for the newwater heater,because the placement is a very important consideration forthe safety of the occupants in the building and for themosteconomical use of the water heater. This water heater is notforuseinmanufactured(mobile)homesoroutdoorinstallation.
Whetherreplacinganoldwaterheaterorputtingthewaterheaterinanewlocation,thefollowingcriticalpointsmustbeobserved:
1.Selectalocationindoorsascloseaspracticaltothegasventorchimneytowhichthewaterheaterventisgoingtobeconnected,andascentralizedwiththewaterpipingsystemaspossible.
2.Selected location must provide adequate clearances forservicingandproperoperationofthewaterheater.
Installationofwaterheatermustbeaccomplishedinsuchamannerthatifthetankoranyconnectionsshouldleak,flowwillnotcausedamageto
thestructure.Forthisreason,itisnotadvisabletoinstallwaterheaterinanatticorupperfloor.Whensuchlocationscannotbeavoided,asuitablemetaldrainpanshouldbeinstalledunderthewaterheater.MetalDrainpansareavailableatyourlocalhardwarestore.Suchametaldrainpanmusthaveaminimumlengthandwidthofatleast2”(51mm)greaterthanwaterheaterdimensionsandmustbepipedtoanadequatedrain.Thepanmustnotrestrictcombustionairflow.
Waterheaterlifedependsuponwaterquality,waterpressureandtheenvironmentinwhichthewaterheaterisinstalled.Waterheatersaresometimesinstalledinlocationswhereleakagemayresultinpropertydamage,evenwiththeuseofadrainpanpipedtoadrain.However,unanticipateddamagecanbereducedorpreventedbyaleakdetectororwatershut-offdeviceusedinconjunctionwithapipeddrainpan.Thesedevicesareavailablefromsomeplumbingsupplywholesalersandretailers,anddetectandreacttoleakageinvariousways:
• Sensorsmountedinthedrainpanthattriggeranalarmorturnofftheincomingwatertothewaterheaterwhenleakageisdetected.
• Sensorsmountedinthedrainpanthatturnoffthewatersupplytotheentirehomewhenwaterisdetectedinthedrainpan.
• Watersupplyshut-offdevicesthatactivatebasedonthewaterpressuredifferentialbetweenthecoldwaterandhotwaterpipesconnectedtothewaterheater.
• Devicesthatwillturnoffthegassupplytoagaswaterheaterwhileatthesametimeshuttingoffitswatersupply.
INSTAllATIONS IN AREAS WHERE flAMMABlE lIqUIDS (VAPORS)ARELIKELYTOBEPRESENTORSTORED(GARAGES,STORAGEANDUTILITYAREAS,ETC.):Flammableliquids(suchasgasoline,solvents,propane[LPorbutane,etc.]andothersubstancessuchasadhesives,etc.)emitflammablevaporswhichcanbeignitedbyagaswaterheater’spilotlightormainburner.Theresultingflashbackandfirecancausedeathorseriousburnstoanyoneinthearea,aswellaspropertydamage.Ifinstallationinsuchareasisyouronlyoption,theninstallationmustbeaccomplishedinawaythatthepilotflameandmainburnerflameareelevatedfromflooratleast18inches.Whilethismayreducechancesofflammablevapors,fromafloorspillbeingignited,gasolineandotherflammablesubstancesshouldneverbestoredor
![Page 8: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/8.jpg)
8
usedinthesameroomorareacontainingagaswaterheaterorotheropenflameorsparkproducingappliance.NOTE:Flammablevaporsmaybedrawnbyaircurrentsfromotherareasofthestructuretotheappliance.Also,thewaterheatermustbelocatedand/orprotectedsoit isnotsubjecttophysicaldamagebyamovingvehicle.
Thiswaterheatermustnotbeinstalleddirectlyoncarpeting.Carpetingmustbeprotectedbymetalorwoodpanelbeneaththewaterheaterextendingbeyondthefullwidthanddepthofthewaterheaterbyatleast3”(76.2mm)inanydirection,orifthewaterheaterisinstalledinanalcoveorcloset,theentirefloormustbecoveredbythepanel.Failuretoheedthiswarningmayresultinafirehazard.
hIGh altItude
Waterheaterscoveredinthismanualhavebeentestedandapprovedfor installationatelevationsup to7,700 feet (2,347m)abovesealevel.Forinstallationabove7,700feet(2,347m),thewaterheater’sBtuinputshouldbereducedattherateof4percentforeach1,000feet(305m)abovesealevelwhichrequiresreplacementoftheburnerorificeinaccordancewiththeNationalFuelGasCodeANSIZ223.1/NFPA54ortheNaturalGasandPropaneInstallationCodeCAN/CSAB149.1.Contactyourlocalgassupplierforfurtherinformation.
Failuretoreplacethestandardorificewiththeproperhighaltitudeorificewhen installed at elevations above 7,700 feet (2,347m)couldresultinimproperandinefficientoperationofthewaterheater,producingcarbonmonoxidegasinexcessofthesafelimits.Thiscouldresultinseriousinjuryordeath.Contactyourlocalgassupplierforanyspecificchangesthatmayberequiredinyourarea.
clearances
Minimumclearancesbetween thewater heater and combustibleconstructionare0inchatthesidesandrear,4”(102mm)atthefront,and6”(153mm)fromtheventpipe.Clearancefromthetopofthejacketis12”(305mm)onmostmodels.
fIGure 2.
Agaswater heater cannot operate properlywithout the correctamountofairforcombustion.Donotinstallinaconfinedareasuchasacloset,unlessyouprovideairasshowninthe“LocatingTheNewWaterHeater”section.Neverobstructtheflowofventilationair.Ifyouhaveanydoubtsorquestionsatall,callyourgassupplier.Failuretoprovidetheproperamountofcombustionaircanresultin a fire or explosion and cause death, serious bodily injury, orpropertydamage.
fIGure 3.
Ifthiswaterheaterwillbeusedinbeautyshops,barbershops,cleaning establishments, or self-service laundries with drycleaning equipment, it is imperative that thewater heater orwater heaters be installed so that combustionand ventilationairbetakenfromoutsidetheseareas.
Propellantsofaerosolspraysandvolatilecompounds,(cleaners,chlorinebasedchemicals,refrigerants,etc.)inadditiontobeinghighlyflammableinmanycases,willalsochangetocorrosivehydrochloricacidwhenexposedtothecombustionproductsofthewaterheater.Theresultscanbehazardous,andalsocauseproductfailure.
![Page 9: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/9.jpg)
9
InsulatIon BlanKets
Do not obstruct water heater air intakewith insulating blanket.Gas and carbon monoxide detectorsare available.Install water heater in accordance withthe instruction manual.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Breathing Hazard - Carbon Monoxide Gas
Insulation blankets are available to the general public forexternal use on gas water heaters but are not necessarywith these products. The purpose of an insulation blanket isto reduce the standby heat loss encountered with storagetankheaters.Thewaterheaterscoveredbythismanualmeetor exceed the Energy Policy Act standards with respect toinsulation and standby heat loss requirements, making aninsulationblanketunnecessary.
Should you choose to apply an insulation blanket to thisheater,youshouldfollowtheseinstructions.SeetheFeaturesand Components section of this manual for identificationof components mentioned below. Failure to follow theseinstructions can restrict the air flow required for propercombustion,potentially resulting in fire,asphyxiation, seriouspersonalinjuryordeath.
• do notapplyinsulationtothetopofthewaterheater,asthiswillinterferewithsafeoperationofthedrafthood.
• do notcoverthethermostatortheTemperature-PressureReliefValve.
• do notallowtheinsulationtocomewithin2inches(5cm)ofthefloortopreventblockageofcombustionairflowto the burner.
• do notcovertheinstructionmanual.Keepitonthesideofthewaterheaterornearbyforfuturereference.
• doobtainnewwarningandinstructionlabelsfromthemanufacturerforplacementontheblanketdirectlyovertheexistinglabels.
• doinspecttheinsulationblanketfrequentlytomakecertainitdoesnotsag,therebyobstructingthecombustionairflow.
hard water
Wherehardwaterconditionsexist,watersofteningorthethresholdtype ofwater treatment is recommended. Thiswill protect thedishwashers,coffeeurns,waterheaters,waterpipingandotherequipment. See theMaintenance Section in thismanual forsedimentandlimescaleremovalprocedures.
cIrculatIon puMps
Acirculatingpumpisusedwhenasystemrequiresacirculatingloop or there is a storage tank used in conjunction with thewater heater. SeeWater Piping Diagrams in thismanual forinstallationlocationofcirculatingpumps.
SeetheCirculationPumpWiringDiagramsbelowforelectricalhookup information. Install in accordance with the currentedition of the National Electrical Code, NFPA 70 or theCanadianElectricalCode,CSAC22.1.
Allbronzeorstainlesssteelcirculatingpumpsarerecommendedforusedwithcommercialwaterheaters.
Somecirculatingpumpsaremanufacturedwithsealedbearingsanddonotrequirefurtherlubrication.Somecirculatingpumpsmustbeperiodicallyoiled.Refer to thepumpmanufacturer’sinstructionsforlubricationrequirements.
CIRCULATING PUMP WIRING DIAGRAMSTORAGE TANK OR BUILDING RECIRCULATION
FIELD SUPPLIED TEMPERATURE CONTROLINSTALLED IN THE STORAGE TANKOR CIRCULATING LOOP RETURN LINE
CIRCPUMP
MOTOR
L1 HOT
L2 NEUTRAL
120 VACPOWER
NOTE: USE SEPARATE 120 VAC POWERSUPPLY FOR PUMP CIRCUIT. DO NOTSHARE POWER WITH APPLIANCE AS THISMAY CAUSE ELECTRICAL LINE NOISE ANDLEAD TO ERRATIC CONTROL SYSTEMOPERATION.
fIGure 4.
CIRCULATING PUMP WIRING DIAGRAMDISHWASHER LOOP WITH TOGGLE SWITCH
FIELD SUPPLIED TEMPERATURECONTROL INSTALLED IN THECIRCULATING LOOP RETURN LINE
DISHWASHERTOGGLESWITCH
CIRCPUMP
MOTOR
L1 HOT
L2 NEUTRAL
120 VACPOWER
NOTE: USE SEPARATE 120 VAC POWERSUPPLY FOR PUMP CIRCUIT. DO NOTSHARE POWER WITH APPLIANCE AS THISMAY CAUSE ELECTRICAL LINE NOISE ANDLEAD TO ERRATIC CONTROL SYSTEMOPERATION.
fIGure 5.
![Page 10: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/10.jpg)
10
Gas supplY sYsteMs
Lowpressure building gas supply systemsare definedas thosesystemsthatcannotunderanycircumstancesexceed14”W.C.(1/2PSIGauge).Thesesystemsdonotrequirepressureregulation.Measurementsshouldbetakentoinsurethatgaspressuresarestableandfallwithintherequirementsstatedonthewaterheaterratingplate.readingsshouldbe takenwithallgasburningequipmentoff (staticpressure)andwithallgasburningequipmentrunningatmaximumrate(dynamicpressure).Thegassupplypressuremustbestablewithin1.5”W.C.fromstatictodynamicpressuretoprovidegoodperformance.Pressuredropsthatexceed1.5”W.C.maycauseroughstarting,noisycombustionornuisanceoutages.Increasesorspikesinstaticpressureduringoffcyclesmaycausefailuretoigniteorinseverecasesdamagetoappliancegasvalves.Ifyourlowpressuresystemdoesnotmeettheserequirements,theinstallerisresponsibleforthecorrections.
HighPressurebuildingsupplysystemsusepressuresthatexceed14”W.C. (1/2PSIGauge).Thesesystemsmustusefieldsuppliedregulatorstolowerthegaspressuretolessthan14”W.C.(1/2PSIGauge).Appliancesrequiregasregulatorsthatareproperlysizedforthewaterheaterinputanddelivertheratingplatespecifiedpressures.Gassupplysystemswherepressureexceeds5PSIoftenrequiremultipleregulatorstoachievedesiredpressures.Systemsinexcessof5PSIbuildingpressureshouldbedesignedbygasdeliveryprofessionalsforbestperformance.Waterheatersconnectedtogassupplysystemsthatexceed14”W.C.(1/2PSIGauge)atanytimemustbeequippedwithagassupplyregulator.
Gas pressure requIreMents
Naturalgasmodelsrequireaminimumgassupplypressureof4.5”W.C.(1.12kPa).Propanegasmodelsrequireaminimumgassupplypressure of 11”W.C. (2.74 kPa).Theminimum supply pressureismeasuredwhile gas is flowing (dynamicpressure).The supplypressure(dynamic)shouldneverfallbelowthespecifiedminimumsupplypressure.Thesupplypressureshouldbemeasuredwithallgasfiredappliancesconnectedtothecommonmainfiringatfullcapacity.Ifthesupplypressuredropsmorethan1.5”W.C.(0.37kPa)asgasbeginstoflowtothewaterheaterthenthesupplygassystemincludingthegaslineand/orthegasregulatormayberestrictedorundersized.SeeSupplyGasregulatorsectionandGasPipingsectionofthismanual.Thegasvalveonallmodelshasamaximumgassupplypressurelimitof14”W.C.(3.48kPa)Themaximumsupplypressureismeasuredwhilegasisnotflowing(staticpressure).
supplY Gas reGulator
Themaximumallowablegassupplypressureforthiswaterheateris14.0inchesW.C.(3.48kPa).Installapositivelock-upgaspressureregulatorinthegassupplylineifinletgaspressurecanexceed14.0inchesW.C.(3.48kPa)atanytime.regulatorsmustbesized/usedaccordingtomanufacturer’sspecifications.Ifapositivelock-upregulatorisrequiredfollowtheseinstructions:
1. Positivelock-upgaspressureregulatorsmustberatedatorabove theinputBtu/hrratingofthewaterheatertheysupply.2. Positivelock-upgaspressureregulator(s)shouldbeinstalledno closerthan3feet(1meter)andnofartherthan8feet(2.4meters) ofequivalentlengthfromthewaterheater’sinletgasconnection.3. Afterinstallingthepositivelock-upgaspressureregulator(s)aninitial nominalsupplypressuresettingof7.0”W.C.whilethewaterheater isoperatingisrecommendedandwillgenerallyprovidegood waterheateroperation.Someadditionadjustmentmayberequired latertomaintainasteadygassupplypressure.4. When installingmultiplewater heaters in the samegas supply system it is recommended that individual positive lock-upgas pressureregulatorsbeinstalledateachunit.
MIxInG valves
Water temperature over 125°F (52°C)can cause severe burns instantlyresulting in severe injury or death.
Children, the elderly and the physically or mentally disabled are at highest risk for scald injury.
Feel water before bathing or showering.
Temperature limiting devices such asmixing valves must be installed when required by codes and to ensure safe temperatures at fixtures.
Waterheatedtoatemperaturewhichwillsatisfyclotheswashing,dishwashing,andothersanitizingneedscanscaldandcausepermanentinjuryuponcontact.Shortrepeatedheatingcyclescausedbysmallhotwaterusescancausetemperaturesatthepointofusetoexceedthewaterheater’stemperaturesettingbyupto20°F(11°C).Somepeoplearemorelikelytobepermanentlyinjuredbyhotwaterthanothers.These include theelderly, children, the infirmand thephysically/mentallydisabled.Table2 shows theapproximate time-to-burnrelationshipfornormaladultskin.Ifanyoneusinghotwaterprovidedby thewaterheaterbeing installed fits intooneof thesegroupsorifthereisalocalcodeorstatelawrequiringacertainwatertemperatureatthepointofuse,thenspecialprecautionsmustbetaken.In addition to using the lowest possible temperature setting thatsatisfiesdemandoftheapplicationaMixingValveshouldbeinstalledatthewaterheaterorathotwatertapstofurtherreducesystemwatertemperature.SeeFigure6.Mixing valves are available at plumbing supply stores.Consulta Qualified Installer or ServiceAgency. Followmixing valvemanufacturer’sinstructionsforinstallationofthevalves.
taBle 2.
Water Temperature°F
Timefor1stDegreeBurn
(LessSevereBurns)
TimeforPermanentBurns2nd&3rdDegree
(MostSevereBurns)
110 (normalshowertemp.)116 (painthreshold)116 35minutes 45minutes122 1minute 5minutes131 5seconds 25seconds140 2seconds 5seconds149 1second 2seconds154 instantaneous 1second
(U.S.GovernmentMemorandum,C.P.S.C.,PeterL.Armstrong,Sept.15,1978)
HOT WATEROUTLET
TO TANKINLET
CHECKVALVE
MIXINGVALVE
COLDWATERINLET
TEMPERED WATEROUTLET
12” TO 15”(30-38 cm)
CHECKVALVE
fIGure 6.
InstallatIon requIreMents
![Page 11: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/11.jpg)
11
water pIpInG
water (potaBle) heatInG and space heatInG
Thiswaterheatershallnotbeconnectedtoanyheatingsystemsorcomponent(s)usedwithanon-potablewaterheatingappliance.
Allpipingcomponentsconnectedtothisunit forspaceheatingapplicationsshallbesuitableforusewithpotablewater.
Toxicchemicals,suchasthoseusedforboilertreatmentshallnotbeintroducedintothissystem.
Whenthesystemrequireswaterforspaceheatingattemperatureshigherthanrequiredfordomesticwaterpurposes,amixingvalvemustbeinstalled.PleaserefertoFigure2forsuggestedpipingarrangement.
Thesewaterheaterscannotbeusedinspaceheatingapplicationsonly.
closed water sYsteMs
Water supply systemsmay, because of code requirements orsuch conditions as high line pressure, among others, haveinstalled devices such as pressure reducing valves, checkvalves,andbackflowpreventers.Devicessuchasthesecausethewatersystemtobeaclosedsystem.
therMal expansIon
Aswaterisheated,itexpands(thermalexpansion).Inaclosedsystemthevolumeofwaterwillgrowwhenit isheated.Asthevolumeofwatergrowstherewillbeacorrespondingincreaseinwater pressure due to thermal expansion. Thermal expansioncancauseprematuretankfailure(leakage).Thistypeoffailureis not covered under the limited warranty. Thermal expansioncanalsocause intermittentTemperature-PressureReliefValveoperation: water discharged from the valve due to excessivepressurebuildup.Thisconditionisnotcoveredunderthelimitedwarranty.TheTemperature-PressureReliefValveisnotintendedfortheconstantreliefofthermalexpansion.
A properly sized thermal expansion tankmust be installed onall closed systems to control the harmful effects of thermalexpansion.Contacta localplumbingserviceagency tohaveathermalexpansiontankinstalled.
fIGure 7.
NOTE: To protect against untimely corrosion of hot and coldwaterfittings,it isstronglyrecommendedthatdi-electricunionsorcouplingsbeinstalledonthiswaterheaterwhenconnectedtocopperpipe.Figure7showsthetypicalattachmentofthewaterpipingtothewaterheater.Thewaterheaterisequippedwith1”NPTthreadednipple (75 gallon models) or 1.25” NPT threaded nipple (100gallonmodels)waterconnections.
teMperature-pressure relIef valve
Explosion HazardTemperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.Can cause serious injury or death.
This water heater is providedwith a properly rated/sized andcertified combinationTemperature-PressureRelief Valve (T&Pvalve)bythemanufacturer.Thevalveiscertifiedbyanationallyrecognizedtesting laboratory thatmaintainsperiodic inspectionof production of listed equipment ofmaterials asmeeting therequirements for Relief Valves for HotWater Supply Systems,ANSIZ21.22•CSA4.4,andthecoderequirementsofASME.If replaced, thenewT&Pvalvemustmeet the requirementsoflocalcodes,butnotlessthanacombinationTemperature-PressureReliefValve rated/sizedandcertifiedas indicated in theaboveparagraph.Thenewvalvemustbemarkedwithamaximumsetpressurenottoexceedthemarkedhydrostaticworkingpressureofthewaterheater(150psi=1,035kPa)andadischargecapacitynotlessthanthewaterheaterBtu/hrorkWinputrateasshownonthewaterheater’smodelratinglabel.
![Page 12: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/12.jpg)
12
NOTE: Inaddition to the factory installedTemperature-PressureReliefValveon thewaterheater,each remotestorage tank thatmaybeinstalledandpipedtoawaterheatingappliancemustalsohave its own properly sized, rated and approvedTemperature-PressureReliefValveinstalled.CallthetollfreetechnicalsupportphonenumberlistedonthebackcoverofthismanualfortechnicalassistanceinsizingaTemperature-PressureReliefValveforremotestoragetanks.Forsafeoperationof thewaterheater, theTemperature-PressureReliefValvemustnotberemovedfromitsdesignatedopeningnorplugged.TheTemperature-PressureReliefValvemustbeinstalleddirectlyintothefittingofthewaterheaterdesignedforthereliefvalve.Installdischargepipingsothatanydischargewillexitthepipewithin6inches(15.2cm)aboveanadequatefloordrain,orexternaltothebuilding.Incoldclimatesitisrecommendedthatitbeterminatedatanadequatedraininsidethebuilding.Becertainthatnocontactismadewithanyliveelectricalpart.Thedischargeopeningmustnotbeblockedorreducedinsizeunderanycircumstances.Excessivelength,over30feet(9.14m),oruseofmorethanfourelbowscancauserestrictionandreducethedischargecapacityofthevalve.No valve or other obstruction is to be placed between theTemperature-PressureReliefValveandthetank.Donotconnectdischargepipingdirectlytothedrainunlessa6”(15.2cm)airgapisprovided.Topreventbodilyinjury,hazardtolife,orpropertydamage,the relief valvemustbeallowed todischargewater inadequatequantitiesshouldcircumstancesdemand.Ifthedischargepipeisnotconnectedtoadrainorothersuitablemeans,thewaterflowmaycausepropertydamage.
Water Damage Hazard• Temperature-Pressure Relief Valve discharge pipe must terminate at adequate drain.
CAUTION
t&p valve discharge pipe requirements:• Shallnotbesmallerinsizethantheoutletpipesizeofthevalve,orhaveanyreducingcouplingsorotherrestrictions.
• Shallnotbepluggedorblocked.• Shallnotbeexposedtofreezingtemperatures.• Shallbeofmateriallistedforhotwaterdistribution.• ShallbeinstalledsoastoallowcompletedrainageofboththeTemperature-PressureReliefValveandthedischargepipe.
• Mustterminateamaximumofsixinchesaboveafloordrainorexternaltobuilding.Incoldclimates,itisrecommendedthatdischargepipebeterminatedatanadequatedraininsidebuilding.
• Shallnothaveanyvalveorotherobstructionbetweenthereliefvalveandthedrain.
Burn hazard.
Hot water discharge.
Keep clear of Temperature-Pressure Relief Valvedischarge outlet.
TheTemperature-PressureReliefValvemustbemanuallyoperatedatleasttwiceayear.Cautionshouldbetakentoensurethat(1)nooneisinfrontoforaroundtheoutletoftheTemperature-PressureReliefValvedischargeline,and(2)thewatermanuallydischargedwill not cause any bodily injury or property damage becausethewatermaybeextremelyhot. Ifaftermanuallyoperating thevalve,itfailstocompletelyresetandcontinuestoreleasewater,immediatelyclosethecoldwaterinlettothewaterheater,followthedraininginstructionsinthismanual,andreplacetheTemperature-PressureReliefValvewithaproperlyrated/sizednewone.
NOTE:ThepurposeofaTemperature-PressureReliefValve istopreventexcessivetemperaturesandpressuresinthestoragetank.TheT&P valve is not intended for the constant relief of thermalexpansion.Aproperlysizedthermalexpansiontankmustbeinstalledon all closed systems to control thermal expansion, seeClosedWaterSystemsandThermalExpansiononpage11.If youdonot understand these instructionsor haveanyquestionsregardingtheTemperature-PressureReliefValvecallthetollfreenumberlistedonthebackcoverofthismanualfortechnicalassistance.
fIllInG the water heater
Neverusethiswaterheaterunless it iscompletely fullofwater.Topreventdamagetothetank,thetankmustbefilledwithwater.Watermustflowfromthehotwater faucetbeforeturning“ON”gasto thewater heater.
Tofillthewaterheaterwithwater:1.Close thewaterheaterdrainvalveby turning thehandle to the
right(clockwise).Thedrainvalveisonthelowerfrontofthewaterheater.
2. Open the cold water supply valve to the water heater. NOTE:Thecoldwatersupplyvalvemustbeleftopenwhenthewater heater is in use.
3.Toinsurecompletefillingofthetank,allowairtoexitbyopeningthenearesthotwaterfaucet.Allowwatertorununtilaconstantflowisobtained.Thiswillletairoutofthewaterheaterandthepiping.
4. Checkallwaterpipingandconnections for leaks.Repairasneeded.
aIr requIreMents
Breathing Hazard - Carbon Monoxide GasInstall water heater in accordance withthe Instruction Manual and NFPA 54 orCAN/CSA-B149.1.To avoid injury, combustion and ventilationair must be taken from outdoors.Do not place chemical vapor emittingproducts near water heater.
Breathing carbon monoxide can cause brain damage ordeath. Always read and understand instruction manual.
Forsafeoperationanadequatesupplyof freshuncontaminatedair forcombustionandventilationmustbeprovided.
An insufficient supply of air can cause recirculation of combustionproducts resulting in contamination thatmaybehazardous to life.Suchaconditionoftenwillresultinayellow,luminousburnerflame,causingsootingofthecombustionchamber,burnersandfluetubesandcreatesariskofasphyxiation.
DonotinstallthewaterheaterinaconfinedspaceunlessanadequatesupplyofairforcombustionandventilationisbroughtintothatspaceusingthemethodsdescribedintheConfinedSpacesectionthatfollows.
Neverobstructtheflowofventilationair. Ifyouhaveanydoubtsorquestionsatall,callyourgassupplier.Failure toprovidetheproper
![Page 13: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/13.jpg)
13
amountofcombustionaircanresultinafireorexplosionandcausepropertydamage,seriousbodilyinjuryordeath.
unconfIned spaceAnUnconfinedSpace isonewhosevolume isnot less than50cubic feet per 1,000 Btu/hr (4.8 cubicmeters per kW) of thetotalinputratingofallappliancesinstalledinthespace.Roomscommunicatingdirectlywith thespace, inwhich theappliancesare installed, through openings not furnished with doors, areconsideredapartoftheunconfinedspace.
Makeupairrequirementsfortheoperationofexhaustfans,kitchenventilation systems, clothesdryersand fireplacesshall alsobeconsidered in determining the adequacy of a space to providecombustion,ventilationanddilutionair.
unusuallY tIGht constructIonInunconfinedspacesinbuildings,infiltrationmaybeadequatetoprovideairforcombustion,ventilationanddilutionoffluegases.However,inbuildingsofunusuallytightconstruction(forexample,weatherstripping,heavilyinsulated,caulked,vaporbarrier,etc.)additionalairmustbeprovidedusing themethodsdescribed intheConfinedSpacesectionthatfollows.
confIned spaceAConfinedSpaceisonewhosevolumeislessthan50cubicfeetper1,000Btu/hr(4.8cubicmetersperkW)ofthetotalinputratingofallappliancesinstalledinthespace.
Openingsmustbeinstalledtoprovidefreshairforcombustion,ventilationanddilution inconfinedspaces.Therequiredsize for theopenings isdependentonthemethodusedtoprovidefreshairtotheconfinedspaceandthetotalBtu/hrinputratingofallappliancesinstalledinthespace.
dIrect vent applIancesAppliances installed in aDirectVent configuration that derive allair for combustion from the outdoor atmosphere through sealedintakeairpipingarenotfactoredinthetotalapplianceinputBtu/hrcalculationsusedtodeterminethesizeofopeningsprovidingfreshairintoconfinedspaces.
exhaust fansWhereexhaustfansareinstalled,additionalairshallbeprovidedtoreplacetheexhaustedair.Whenanexhaustfanisinstalledinthesamespacewithawaterheater,sufficientopeningstoprovidefreshairmustbeprovidedthataccommodatetherequirementsforallappliancesintheroomandtheexhaustfan.Undersizedopeningswillcauseairtobedrawnintotheroomthroughthewaterheater’sventsystemcausingpoorcombustion.Sooting,seriousdamagetothewaterheaterandtheriskoffireorexplosionmayresult.Itcanalsocreateariskofasphyxiation.
louvers and GrIllesThefreeareasofthefreshairopeningsintheinstructionsthatfollowdonottakeintoaccountthepresenceoflouvers,grillesorscreensintheopenings.
Therequiredsizeofopeningsforcombustion,ventilationanddilutionairshallbebasedonthe“netfreearea”ofeachopening.Wherethefreeareathroughadesignoflouverorgrilleorscreenisknown,itshallbeusedincalculatingthesizeofopeningrequiredtoprovidethefreeareaspecified.Wherethelouverandgrilledesignandfreeareaarenotknown,itshallbeassumedthatwoodlouverswillhave25%freeareaandmetallouversandgrilleswillhave75%freearea.Nonmotorizedlouversandgrillesshallbefixedintheopenposition.
fresh aIr openInGs for confIned spacesThe following instructions shall be used to calculate the size,number and placement of openings providing fresh air forcombustion, ventilation and dilution in confined spaces. Theillustrationsshowninthissectionofthemanualareareferencefor the openings that provide fresh air into confined spacesonly.Donot refer to these illustrations for thepurposeofventinstallation. See Venting Installation on page 18 for completeventinginstallationinstructions.
outdoor aIr throuGh two openInGs
fIGure 8.
The confined space shall be provided with two permanentopenings,onecommencingwithin12inches(300mm)ofthetopandonecommencingwithin12inches(300mm)ofthebottomoftheenclosure.Theopenings shall communicate directlywith theoutdoors.SeeFigure8.Eachopeningshallhaveaminimumfreeareaof1squareinchper4,000Btu/hr(550mm2perkW)oftheaggregateinputratingofallappliancesinstalledintheenclosure.Eachopeningshallnotbelessthan100squareinches(645cm2).
outdoor aIr throuGh one openInG
fIGure 9.
Alternatively a single permanent opening, commencingwithin 12inches(300mm)ofthetopoftheenclosure,shallbeprovided.SeeFigure9.Thewaterheatershallhaveclearancesofatleast1inch(25mm)fromthesidesandbackand6inches(150mm)fromthefrontoftheappliance.Theopeningshalldirectlycommunicatewiththeoutdoorsorshallcommunicatethroughaverticalorhorizontalducttotheoutdoorsorspacesthatfreelycommunicatewiththeoutdoorsandshallhaveaminimumfreeareaofthefollowing:1. 1square inchper3000Btu/hr (733mm2perkW)of the total
inputratingofallapplianceslocatedintheenclosure,and2. Notlessthanthesumoftheareasofallventconnectorsin
thespace.
![Page 14: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/14.jpg)
14
outdoor aIr throuGh two horIzontal ducts
fIGure 10.
Theconfinedspaceshallbeprovidedwithtwopermanenthorizontalducts,onecommencingwithin12 inches(300mm)of the topandone commencingwithin 12 inches (300mm)of thebottomof theenclosure.Thehorizontalductsshallcommunicatedirectlywiththeoutdoors.SeeFigure10.Eachductopeningshallhaveaminimumfreeareaof1squareinchper2,000Btu/hr(1100mm2perkW)oftheaggregateinputratingofallappliancesinstalledintheenclosure.Whenductsareused,theyshallbeofthesamecrosssectionalareaasthefreeareaoftheopeningstowhichtheyconnect.Theminimumdimensionofrectangularairductsshallbenotlessthan3inches.
outdoor aIr throuGh two vertIcal ducts
The illustrations shown in this section of the manual are areference for the openings that provide fresh air into confinedspacesonly.do not refer to these illustrations for the purpose of ventinstallation. See Venting Installation on page 18 for completeventinginstallationinstructions.
fIGure 11.
Theconfinedspaceshallbeprovidedwith twopermanentverticalducts,onecommencingwithin12 inches(300mm)of the topandone commencingwithin 12 inches (300mm)of thebottomof the
enclosure.The vertical ducts shall communicate directlywith theoutdoors.SeeFigure11.Eachductopeningshallhaveaminimumfreeareaof1squareinchper4,000Btu/hr(550mm2perkW)oftheaggregateinputratingofallappliancesinstalledintheenclosure.Whenductsareused,theyshallbeofthesamecrosssectionalareaasthefreeareaoftheopeningstowhichtheyconnect.Theminimumdimensionofrectangularairductsshallbenotlessthan3inches.
aIr froM other Indoor spaces
fIGure 12.
Theconfinedspaceshallbeprovidedwithtwopermanentopenings,one commencingwithin 12 inches (300mm) of the top and onecommencingwithin12inches(300mm)ofthebottomoftheenclosure.SeeFigure12.Eachopeningshallcommunicatedirectlywithanadditionalroom(s)ofsufficientvolumesothatthecombinedvolumeofallspacesmeetsthecriteriaforanUnconfinedSpace.Eachopeningshallhaveaminimumfreeareaof1squareinchper1,000Btu/hr(2200mm2perkW)oftheaggregateinputratingofallappliancesinstalledintheenclosure.Eachopeningshallnotbelessthan100squareinches(645cm2).
ventInG
![Page 15: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/15.jpg)
15
Ifthewaterheaterisbeinginstalledasareplacementforanexistingheaterinpre-existingventing,athoroughinspectionofexistingventingsystemmustbeperformedpriortoanyinstallationwork.VENTDAMPERS-Anyventdamper,whetheritisoperatedthermallyorotherwisemustberemovedifitsuseinhibitsproperdraftingofthewater heater.ThermallyOperatedVentDampers:thisgas-firedwaterheaterhasathermalefficiencyatorabove80%whichmayproducearelativelylowfluegastemperature.Suchtemperaturesmaynotbehighenoughtoproperlyopenthermallyoperatedventdampers.Thiswouldcausespillageofthefluegasesandmaycausecarbonmonoxidepoisoning.VentdampersmustbearevidenceofcertificationascomplyingwiththecurrenteditionoftheAmericanNationalStandardANSIZ21.66CGA 6.14 (covering electrically andmechanically actuated ventdampers).Beforeinstallationofanyventdamper,consultthelocalgasutilityforfurtherinformation.Toinsureproperventingofthisgas-firedwaterheater,thecorrectventpipediametermustbeutilized.Anyadditionsordeletionsofothergasappliancesonacommonventwiththiswaterheatermayadverselyaffecttheoperationofthewaterheater.Consultyourgassupplierifanysuchchangesareplanned.Forproperventing incertain installations,a largerdiameterventpipemay be necessary.Consult your gas supplier to aid you indeterminingtheproperventingforyourwaterheaterfromtheventtables in thecurrenteditionof theNationalFuelGasCodeANSIZ223.1/NFPA54ortheNaturalGasandPropaneInstallationCodecAN\cSA B 149.1. Periodically check the venting system for signs of obstruction ordeteriorationandreplaceifneeded.Thecombustionandventilationairflowmustnotbeobstructed.Thewaterheaterwithdrafthoodinstalledmustbeconnectedtoachimneyorlistedventpipesystem,whichterminatestotheoutdoors.Never operate the water heater unless it is vented to the outdoors andhasadequateair supply toavoid risksof improperoperation,explosion or asphyxiation.• For proper draft hoodattachment, thedraft hood legsmaybe
angledslightlyinward.• Placethedrafthoodlegsinthereceivingholesonthetopofthe
waterheater.The legswill snap in theholes togivea tight fit.Securedrafthoodwiththesuppliedbrackets.
• Placetheventpipeoverthedrafthood.Withtheventpipeinposition,drillasmallholethroughboththeventpipeanddrafthood.Securethemtogetherwithasheetmetalscrew.SeeFigure13.
Obstructedordeterioratedventsystemsmaypresentserioushealthrisk or asphyxiation.
fIGure 13.
The vent pipe from thewater heatermust be no less than thediameter of the draft hood outlet on thewater heater andmustslopeupwardat least1/4inchperlinearfoot(21mmpermeter).SeeFigure14.
All ventgasesmustbecompletelyvented to theoutdoorsof thestructure (dwelling). Installonly thedrafthoodprovidedwith thenewwaterheaterandnootherdrafthood.
Ventpipesmustbesecuredateachjointwithsheetmetalscrews.
fIGure 14.
Theremustbeaminimumof6”(153mm)clearancebetweensinglewall vent pipe and any combustiblematerial. Fill and seal anyclearancebetweensinglewallventpipeandcombustiblematerialwithmortarmix,cement,orothernoncombustiblesubstance.Forother thansinglewall, followventpipemanufacturer’s clearancespecifications.Toinsureatightfitoftheventpipeinabrickchimney,sealaroundtheventpipewithmortarmixcement.
Failure to have required clearances between vent piping andcombustiblematerialwillresultinafirehazard.
Be sure vent pipe is properly connected to prevent escape ofdangerousfluegaseswhichcouldcausedeadlyasphyxiation.
Chemicalvaporcorrosionoftheflueandventsystemmayoccurifairforcombustioncontainscertainchemicalvapors.Spraycanpropellants, cleaningsolvents, refrigeratorandairconditionerrefrigerants, swimming pool chemicals, calcium and sodiumchloride, waxes, bleach and process chemicals are typicalcompoundswhicharepotentiallycorrosive.
![Page 16: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/16.jpg)
16
Gas pIpInG
Contact your local gas service company to ensure that adequategasserviceisavailableandtoreviewapplicableinstallationcodesforyourarea.SizethemaingaslineinaccordancewithTable3.Thefiguresshownareforstraightlengthsofpipeat0.5in.W.C.pressuredrop,whichisconsiderednormalforlowpressuresystems.Note:Fittingssuchaselbows,teesandlineregulatorswilladdtothepipepressuredrop.AlsorefertothecurrenteditionsoftheNationalFuelGasCode(NFPA54)orNaturalGasandPropaneInstallationCode(CAN/CSAB149.1).Makesuregassuppliedissametypelistedonmodelratingplate.Theinletgaspressuremustnotexceed14inchwatercolumn(2.6kPa)fornaturalandpropane(L.P.)gas.Theminimuminletgaspressureshownonratingplateisthatwhichwillpermitfiringatratedinput.Ifthegascontrolvalveissubjectedtopressuresexceeding1/2poundpersquareinch(3.5kPa),thedamagetothegascontrolvalvecouldresultinafireorexplosionfromleakinggas.Ifthemaingaslineshut-offservingallgasappliancesisused,alsoturn“off”thegasateachappliance.Leaveallgasappliancesshut“off”untilthewaterheaterinstallationiscomplete.Agaslineofsufficientsizemustberuntothewaterheater.ConsultthecurrenteditionofNationalFuelGasCodeANSIZ223.1/NFPA54ortheNaturalGasandPropaneInstallationCodeCAN/CSAB149.1andyourgassupplierconcerningpipesize.Theremustbe:• Areadilyaccessiblemanualshutoffvalve inthegassupply line
servingthewaterheater,and• Asedimenttrapaheadofthegascontrolvalvetohelppreventdirt
andforeignmaterialsfromenteringthegascontrolvalve.• Aflexiblegasconnectororagroundjointunionbetweentheshut
offvalveandcontrolvalvetopermitservicingoftheunit.Besuretocheckallthegaspipingforleaksbeforelightingthewaterheater.Useasoapywatersolution,notamatchoropenflame.Rinseoffsoapysolutionandwipedry.Theminimum inletgaspressureshownon the ratingplate is thatwhichwillpermitfiringattheratedinput.
taBle 3. Gas supplY lIne sIzes (In Inches)* MaxIMuM capacItY of pIpe In cuBIc feet per hourlenGth
In feet
noMInal Iron pIpe sIzes (Inches) Input In thousands (Btu/hr)
1/2" 3/4" 1" 1 1/4" 1 1/2" 2" 2 1/2" 3" 4"
10 175 360 680 1400 2100 3960 6300 11000 23000
20 120 250 465 950 1460 2750 4360 7700 15800
30 97 200 375 770 1180 2200 3520 6250 12800
40 82 170 320 660 990 1900 3000 5300 10900
50 73 151 285 580 900 1680 2650 4750 9700
60 66 138 260 530 810 1520 2400 4300 8800
70 61 125 240 490 750 1400 2250 3900 8100
80 57 118 220 460 690 1300 2050 3700 7500
90 53 110 205 430 650 1220 1950 3450 7200
100 50 103 195 400 620 1150 1850 3250 6700
125 44 93 175 360 550 1020 1650 2950 6000
150 40 84 160 325 500 950 1500 2650 5500
175 37 77 145 300 460 850 1370 2450 5000
200 35 72 135 280 430 800 1280 2280 4600
taBle 4.
lenGth In
Meters
noMInal Iron pIpe sIzes (Inches) Input In Kw
1/2" 3/4" 1" 1 1/4" 1 1/2" 2" 2 1/2" 3" 4"
3 51 105 199 410 615 1160 1845 3221 6735
6 35 73 142 278 428 805 1277 2255 4626
9 28 59 110 225 346 644 1031 1830 3748
12 24 50 94 193 290 556 878 1552 3192
15 21 44 83 170 264 492 776 1391 2840
18 19 40 76 155 237 445 703 1259 2577
21 18 37 70 143 220 410 659 1142 2372
24 17 35 64 135 202 381 600 1083 2196
27 16 32 60 126 190 357 571 1010 2108
31 15 30 57 117 182 337 542 952 1962
38 13 27 51 105 161 299 483 864 1757
46 12 25 47 95 146 278 439 776 1610
53 11 23 42 88 135 249 401 717 1464
61 10 21 40 82 126 234 375 688 1347
Usepipejointcompoundorteflontapemarkedasbeingresistanttotheactionofpetroleum[Propane(L.P.)]gases.
Thewaterheateranditsgasconnectionmustbeleaktestedbeforeplacingthewaterheaterinoperation.
The water heater and its individual shut-off valve shall bedisconnectedfromthegassupplypipingsystemduringanypressuretestingofthatsystemattestpressuresinexcessof1/2poundpersquareinch(3.5kPa).Itshallbeisolatedfromthegassupplypipingsystem by closing its individual manual shut-off valve during anypressuretestingof thegassupplypipingsystemat testpressuresequaltoorlessthan1/2poundpersquareinch(3.5kPa).ConnectingthegaspipingtothegascontrolvalveofthewaterheatercanbeaccomplishedbyeitherofthetwomethodsshowninFigures15 and 16.
fIGure 15. Gas pIpInG wIth flexIBle connector.
fIGure 16. Gas pIpInG wIth allBlacK Iron pIpe to Gas control.
![Page 17: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/17.jpg)
17
sedIMent traps
Asedimenttrapshallbeinstalledasclosetotheinletofthewaterheateraspracticalat thetimeofwaterheater installation.Thesediment trapshallbeeithera tee fittingwithacappednipplein thebottomoutletorotherdevice recognizedasaneffectivesediment trap. If a tee fitting is used, it shall be installed inconformancewith one of themethods of installation shown intheFigures15and16.
Contaminantsinthegaslinesmaycauseimproperoperationofthegascontrolvalvethatmayresultinfireorexplosion.Beforeattachingthegaslinebesurethatallgaspipeiscleanontheinside.Totrapanydirtorforeignmaterialinthegassupplyline,asedimenttrapmustbeincorporatedinthepiping.Thesedimenttrapmustbereadilyaccessible.Install inaccordancewiththe“GasPiping”section.RefertothecurrenteditionoftheNationalFuelGasCode,ANSIZ223.1/NFPA54ortheNaturalGasandPropaneInstallationCodeCAN/CSAB149.1.
![Page 18: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/18.jpg)
18
![Page 19: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/19.jpg)
19
for Your safetY read Before lIGhtInG
Before lIGhtInG: entIre sYsteM Must Be fIlled wIth water and aIr purGed at faucets.
warnInG: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
1.STOP!Readthesafetyinformationaboveon this label.
2. Set the thermostat to the lowest setting by turningthermostatdialfullyclockwise until it stops.
3. Push the gas control knob down slightly and turnclockwise to“OFF”(FigureA).
NOTE:GascontrolknobCANNOTbeturnedfrom“PILOT” to“OFF”unlessitispusheddownslightly.Donotforce.4. Removethe innerandouterdoors locatedbelowand
behindthegascontrolunit.5. Waitfive(5)minutestoclearoutanygas. Ifyouthen
smellgasSTOP!Follow“B”inthesafetyinformation aboveonthislabel.Ifyoudonotsmellgas,goto the next step.
6. FindPilot.Followmetaltubefromthebottom,rightofthegascontroltothepilotburner.(FigureD).
7. Turngascontrolknobcounterclockwise to“PILOT”(FigureB).
8.Pushgascontrolknobdownallthewayandholdit down. Immediately light thepilotwithamatch.Continue to
holdthegascontrol knobdown foraboutone (1)minuteafterthepilotislit.Releasethegascontrolknobanditwillpopbackup.Pilotshouldremainlit.Ifitgoesout,repeatSteps3through8.Itmaytakeseveralminutesforairtoclearthelines,beforethepilotwilllight. • Ifknobdoesnotpopupwhenreleased,stopand immediatelycallyourservicetechnicianorgas supplier. • Ifthepilotwillnotstaylitafterseveraltries,turnthe gascontrolknobto“OFF”(FigureA)andcallyour servicetechnicianorgassupplier.9. Replaceinnerandouterburnerdoors.10. Atarm’slengthaway,turnthegascontrolknob counterclockwise to“ON”(FigureC).11. Setthermostattodesiredsetting(SeeFigure).
cautIon: hotter water increases the risk of scald injury. consult the instruction manual before changing temperature.
lIGhtInG InstructIons
to turn off Gas to applIance1. Setthethermostattolowestsetting. 2. Pushgascontrolknobdownslightlyandturnclockwise
to“OFF”.Donotforce,seeFigureA.
top vIew fIGure “d”Gas control
A. Thisappliancehasapilotwhichmustbelightedbyhand.Whenlightingthepilot,followtheseinstructionsexactly.
B. Before lIGhtInG:smellallaroundtheapplianceareaforgas.Besuretosmellnexttothefloorbecausesomegasisheavierthanairandwillsettleonthefloor.
what to do If You sMell Gas • Donottrytolightanyappliance. • Donottouchanyelectricswitch;donotuse
anyphoneinyourbuilding. • Immediatelycallyourgassupplierfroma
neighbor’sphone.Followthegassupplier’s instructions.
• Ifyoucannotreachyourgassupplier,callthe firedepartment.
C. Useonlyyourhandtopushdownorturnthegascontrolknob.Neverusetools.Iftheknobwillnotpushdownorturnbyhand,don’ttrytorepairit,callaqualifiedservicetechnician.Forceorattemptedrepairmayresultinafireor explosion.
D.Donotuse thisappliance if anypart hasbeenunderwater.Immediatelycontactaqualifiedinstallerorserviceagencytoreplaceafloodedwaterheater.Donotattempttorepairtheunit!Itmustbereplaced!
![Page 20: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/20.jpg)
20
start up condItIons
draft hood operatIonCheck draf t hood operation by per forming a worst casedepressurization of the building.With all doors and windowsclosed, andwith all air handling equipment and exhaust fansoperating such as furnaces, clothes dryers, range hoods andbathroomfans,amatchflameshouldstillbedrawnintothedrafthoodofthewaterheaterwithitsburnerfiring.Iftheflameisnotdrawn toward the draft hood, shut off water heater andmakenecessaryairsupplychangestocorrect.
condensatIonWhenever the water heater is f illed with cold water, somecondensatewillformwhiletheburnerison.Awaterheatermay
Shortrepeatedheatingcyclescausedbysmallhotwaterusescancause temperaturesat thepointofuse toexceed the thermostatsettingbyupto30°F(16.7°C). Ifyouexperiencethistypeofuseyou should consider using lower temperature settings to reducescaldhazards.
Anywaterheater’sintendedpurposeistoheatwater.Hotwaterisneededforcleansing,cleaning,andsanitizing(bodies,dishes,clothing). Untempered hot water can present a scald hazard.Dependingonthetimeelement,andthepeopleinvolved(adults,children, elderly, infirm, etc.) scaldingmay occur at differenttemperatures.
HOTTERWATERCANSCALD:Waterheatersareintendedtoproducehotwater.Waterheatedtoatemperaturewhichwillsatisfyspaceheating,clotheswashing,dishwashing,andothersanitizingneedscanscaldandpermanentlyinjureyouuponcontact.Somepeoplearemorelikelytobepermanentlyinjuredbyhotwaterthanothers.Theseincludetheelderly,children,theinfirm,orphysically/mentallyhandicapped.Ifanyoneusinghotwaterinyourhomefitsintooneofthesegroupsorifthereisalocalcodeorstatelawrequiringacertaintemperaturewateratthehotwatertap,thenyoumusttakespecialprecautions. In addition to using the lowest possible temperaturesettingthatsatisfiesyourhotwaterneeds,ameanssuchasamixingvalve should be used at the hot water taps used by these people or atthewaterheater.Mixingvalvesareavailableatplumbingsupplyorhardwarestores,seeFigure2.Followmanufacturer’sinstructionsforinstallationofthevalves.Beforechangingthefactorysettingonthethermostat,readthe“TemperatureRegulation”sectioninthismanual,seeFigures17and18.
teMperature reGulatIon
for Your InforMatIonappeartobeleakingwheninfactthewateriscondensation.Thisusuallyhappenswhen:
a.Anewwaterheaterisfilledwithcoldwaterforthefirsttime.
b.Burninggasproduceswatervaporinwaterheaters,particularlyhighefficiencymodelswherefluetemperaturesarelower.
c.Largeamountsofhotwaterareusedinashorttimeandtherefillwaterinthetankisverycold.
Moisturefromtheproductsofcombustioncondenseonthecoolertank surfacesand formdropsofwaterwhichmay fall onto theburnerorotherhotsurfacestoproducea“sizzling”or“frying”noise.
Excessive condensation can cause pilot outage due to waterrunningdownthefluetubeontothemainburnerandputtingoutthe pilot.
Neverallowsmallchildrentouseahotwatertap,ortodrawtheirownbathwater.Neverleaveachildorhandicappedpersonunattendedin a bathtub or shower.
NOTE:Awatertemperaturerangeof120°F-140°F(49°C-60°C)isrecommendedbymostdishwashermanufacturers.
Thethermostatofthiswaterheaterhasbeenfactorysetatitslowestposition (PIlOT lIGHTING). It is adjustable andmust be reset tothe desired temperature setting to reduce the risk of scald injury.Themark( )indicativeofapproximately120°F(49°C)ispreferredstartingpoint.SomeStateshavearequirementforalowersetting.
Turn thewater temperaturedial clockwise ( ) to decrease thetemperature,orcounterclockwise( )toincreasethetemperature.
Shouldoverheatingoccurorthegassupplyfailtoshutoff,turnoffthemanualgascontrolvalvetothewaterheater.
fIGure 17.
Water Temperature°F
Timefor1stDegreeBurn
(LessSevereBurns)
TimeforPermanentBurns2nd&3rdDegree
(MostSevereBurns)
110 (normalshowertemp.)116 (painthreshold)116 35minutes 45minutes122 1minute 5minutes131 5seconds 25seconds140 2seconds 5seconds149 1second 2seconds154 instantaneous 1second
(U.S.GovernmentMemorandum,C.P.S.C.,PeterL.Armstrong,Sept.15,1978)
fIGure 18.
![Page 21: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/21.jpg)
21
checKInG Gas InputWiththisheaterinoperation,determinewhetheritisreceivingthefullratedinputofgas.Thismaybedonebytimingthegasmeterandmeasuringgaspressurewithagaugeormanometer.Whentheheaterisoperatingatfullcapacity(fullgasinput)itshouldconsumeapproximately1cubicfootofgasinthetimeshowninTable5.
taBle 5. Input checK tIMe requIred to consuMe 1 cu. ft. of Gas
Model type of Gas Btu per cu. ft.
approx. time required to consume 1 cu. ft. of Gas
BT-80 Natural Propane
1050 2500 50.3sec.119.8sec.
BT-100 Natural Propane
1050 2500 50.3sec.119.8sec.
Use this formula to “clock” themeter. Be sure that other gasconsumingappliancesarenotoperatingduringthisinterval.
3,600XH=Btu/Hr T
T=Timeinsecondsneededtoburnonecubicfootofgas.
H=HeatingvalueofgasinBtu’spercubicfootofgas.
Btu/Hr=Actualheaterinputrate.
Example:(UsingBT-80heater)
T=50.3seconds/ft3
H=1,050Btu/ft3(naturalgas)
Btu/Hr=?
3,600X1,050=75,100Btu/Hr(22.0kW) 50.3
Comparetheactualinputratetothatgivenontheheater’sratingplate.Intheexample,theBT-80’sfullinputrateshouldbe75,100Btu/Hrfornaturalgas.
Becauseof the suddennessandamount ofwater, condensationwatermaybediagnosedasa“tankleak”.Afterthewaterinthetankwarmsup(about1-2hours),theconditionshoulddisappear.
Donot assume thewater heater is leakinguntil therehasbeenenoughtimeforthewaterinthetanktowarmup.
Anundersizedwaterheaterwillcausemorecondensation.Thewaterheatermustbesizedproperlytomeetthefamily’sdemandsforhotwaterincludingdishwashers,washingmachinesandshowerheads.
Excessivecondensationmaybenoticedduringthewinterandearlyspringmonthswhenincomingwatertemperaturesareattheirlowest.
Goodventingisessentialforagasfiredwaterheatertooperateproperlyaswellastocarryawayproductsofcombustionandwatervapor.
sMoKe/odorItisnotuncommontoexperienceasmallamountofsmokeandodorduringtheinitialstart-up.Thisisduetoburningoffofoilfrommetalparts, and will disappear in a short while.
stranGe soundsPossiblenoisesduetoexpansionandcontractionofsomemetalpartsduringperiodsofheat-upandcool-downdonotnecessarilyrepresentharmfulordangerousconditions.
Condensationcausessizzlingandpoppingwithintheburnerareaduringheatingandcoolingperiodsandshouldbeconsiderednormal.See“Condensation”inthissection.
operatIonal condItIons
sMellY waterIneachwaterheaterthereisinstalledatleastoneanoderod(seeparts section) for corrosionprotectionof the tank.Certainwaterconditionswill causea reactionbetween this rodand thewater.Themostcommoncomplaintassociatedwiththeanoderodisoneofa“rotteneggsmell”inthehotwater.Thisodorisderivedfromhydrogensulfidegasdissolvedinthewater.Thesmellistheresultoffourfactorswhichmustallbepresentfortheodortodevelop:
a.Aconcentrationofsulfateinthesupplywater.
b.Littleornodissolvedoxygeninthewater.
c.Asulfate reducingbacteriawhichhasaccumulatedwithin thewaterheater(thisharmlessbacteriaisnontoxictohumans).
d.Anexcessofactivehydrogeninthetank.Thisiscausedbythecorrosionprotectiveactionoftheanode.
Smellywatermaybeeliminatedorreducedinsomewaterheatermodelsbyreplacingtheanode(s)withoneoflessactivematerial,and then chlorinating thewater heater tank and all hot waterlines.ContactthelocalwaterheatersupplierorserviceagencyforfurtherinformationconcerninganAnodeReplacementKitandthischlorinationtreatment.
Ifthesmellywaterpersistsaftertheanodereplacementandchlorinationtreatment,wecanonlysuggestthatchlorinationoraerationofthewatersupplybeconsideredtoeliminatethewaterproblem.
do not remove the anode leaving the tank unprotected. By doing so, all warranty on the water heater tank is voided.
![Page 22: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/22.jpg)
22
(generally two weeks or more). Hydrogen gas is extremelyflammable and explosive. To prevent the possibility of injuryunder these conditions,we recommend the hotwater faucet,located farthest away, be opened for severalminutes beforeanyelectricalapplianceswhichareconnectedtothehotwatersystemareused(suchasadishwasherorwashingmachine).Ifhydrogengasispresent,therewillprobablybeanunusualsoundsimilartoairescapingthroughthepipeasthehotwaterfaucetisopened.Theremustbenosmokingoropenflamenearthefaucetatthetimeitisopen.
hIGh water teMperature shut off sYsteMThiswaterheater isequippedwithanautomaticgasShut-offsystem.Thissystemworkswhenhighwatertemperaturesarepresent.ThehightemperatureShut-offisbuiltintothegascontrolvalve. It is non-resettable. If the high temperature Shut-offactivates,thegascontrolvalvemustbereplaced.Contactyourgassupplierorserviceagency.Turn“OFF”theentiregassupplyto the water heater.
“aIr” In hot water faucets
HYDROGENGAS: Hydrogen gas can be produced in a hotwatersystemthathasnotbeenusedforalongperiodoftime
perIodIc MaIntenanceventInG sYsteM InspectIon
Atleastonceayearavisualinspectionshouldbemadeoftheventingsystem.Youshouldlookfor:
1.Obstructions which could cause improper venting. The combustionandventilationairflowmustnotbeobstructed.
2.Damageordeteriorationwhichcouldcause improperventing orleakageofcombustionproducts.
3.Rustedflakesaroundtopofwaterheater.
Besure theventpiping isproperlyconnected topreventescapeofdangerousfluegaseswhichcouldcausedeadlyasphyxiation.
Obstructionsanddeterioratedventsystemsmaypresentserioushealth risk or asphyxiation.
Chemicalvaporcorrosionoftheflueandventsystemmayoccurifairforcombustioncontainscertainchemicalvapors.Spraycanpropellants, cleaning solvents, refrigerator and air conditionerrefrigerants,swimmingpoolchemicals,calciumandsodiumchloride,waxes,bleachandprocesschemicalsaretypicalcompoundswhicharepotentiallycorrosive.
Ifafterinspectionofventsystemyoufoundsootingordeterioration,somethingiswrong.Callthelocalgasutilitytocorrectproblemandcleanorreplacetheflueandventingbeforeresumingoperationofwater heater.
Burner InspectIon
Flood damage to awater heatermay not be readily visible orimmediatelydetectable.However,overaperiodoftimeafloodedwater heaterwill create dangerous conditionswhich can causeDEATH, SERIOUS BODIlY INjURY, OR PROPERTY DAMAGE. Contactaqualifiedinstallerorserviceagencytoreplaceafloodedwaterheater.Donotattempttorepairtheunit!Itmustbereplaced!
Atleastonceayearavisualinspectionshouldbemadeofthemainburnerandpilotburner,seeFigure19.
Youshouldcheck forsooting.Soot isnotnormalandwill impairpropercombustion.
Sootbuild-up indicatesaproblemthat requirescorrectionbeforefurtheruse.Turn“OFF”gastowaterheaterandleaveoffuntilrepairsaremade,becausefailuretocorrectthecauseofthesootingcanresultinafirecausingdeath,seriousinjury,orpropertydamage.
natural
propane
fIGure 19.
Burner cleanInG
If inspectionoftheburnershowsthatcleaningisrequired,turnthe gas control knob clockwise ( ) to the “OFF” position,depressingslightly.
note: the knob cannot be turned from “pIlot” to “off” unless knob is depressed slightly. do not force.
Loosedepositsonoraroundtheburnercanberemovedbycarefullyusingthehoseofavacuumcleanerinsertedthroughtheaccessdoorofthewaterheater.Iftheburnerneedstoberemovedforadditionalcleaning,callaserviceagencytoremoveandcleantheburnerandcorrecttheproblemthatrequiredtheburnertobecleaned.
![Page 23: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/23.jpg)
23
ItisrecommendedthattheTemperature-PressureReliefValveshouldbecheckedtoensurethatitisinoperatingconditionevery6months.Whenchecking theTemperature-PressureReliefValveoperation,makesurethat(1)nooneisinfrontoforaroundtheoutletoftheTemperature-PressureReliefValvedischargeline,and(2)thatthewaterdischargewillnotcauseanypropertydamage,asthewatermaybeextremelyhot.Usecarewhenoperatingvalveasthevalvemaybehot.Tocheckthereliefvalve,lifttheleverattheendofthevalveseveraltimes,seeFigure20.Thevalveshouldseatproperlyandoperatefreely.Ifaftermanuallyoperatingthevalve,itfailstocompletelyresetand continues to release water, immediately close the coldwater inlet to the water heater and drain the water heater, see DrainingAndFlushingonpage25.Replace theTemperature-PressureReliefValvewithaproperlyrated/sizednewone,seeTemperature-PressureReliefValveonpage11forinstructionsonreplacement.
DISCHARGE PIPE
TEMPERATURE-PRESSURERELIEF VALVE
fIGure 20.
IftheTemperature-PressureReliefValveonthewaterheaterweepsordischargesperiodically,thismaybeduetothermalexpansion.note:Excessivewater pressure is themost commoncauseofTemperature-Pressure Relief Valve leakage. Excessive watersystem pressure is most often caused by “thermal expansion”in a “closed system.” See ClosedWater Systems and ThermalExpansiononpage10.TheTemperature-PressureReliefValveisnotintendedfortheconstantreliefofthermalexpansion.Temperature-PressureReliefValveleakageduetopressurebuildup in a closed system that does not have a thermal expansiontank installed isnotcoveredunder the limitedwarranty.Thermalexpansiontanksmustbeinstalledonallclosedwatersystems.do not pluG the teMperature-pressure relIef valve openInG. thIs can cause propertY daMaGe, serIous InjurY or death.
Explosion HazardTemperature-Pressure Relief Valvemust comply with ANSI Z21.22-CSA 4.4 and ASME code.Properly sized temperature-pressure relief valve must beinstalled in opening provided.
Can result in overheating andexcessive tank pressure.Can cause serious injury or death.
recoMMended procedure for perIodIc reMoval of lIMe deposIts froM tanK tYpe coMMercIal water heaters
Theamountofcalciumcarbonate(lime)releasedfromwaterisindirectproportiontowatertemperatureandusage,seechart.Thehigherthewatertemperatureorwaterusage,themorelimedepositsaredroppedoutofthewater.Thisisthelimescalewhichformsinpipes,heatersandoncookingutensils.
houseKeepInG
Fire and Explosion HazardDo not obstruct combustion air openings at the bottom of the water heater.Do not use or store flammable vaporproducts such as gasoline, solventsor adhesives in the same room or area near water heater or other appliance.
Can cause serious injury or death.
Vacuumaroundbaseofwaterheater fordust,dirt,and lintonaregularbasis.INSTALLED INSUITABLEAREA:To insure sufficient ventilationandcombustionairsupply,properclearancesfromthewaterheatermustbemaintained.See“LocatingtheNewWaterHeater”section.Combustiblematerials such as clothing, cleaningmaterials, orflammableliquids,etc.mustnotbeplacedagainstoradjacenttothewaterheaterwhichcancauseafire.
anode rod InspectIon
Property Damage Hazard
• Avoid water heater damage.
• Inspection and replacement of anode rod required.
CAUTION
Theanoderodisusedtoprotectthetankfromcorrosion.Mosthotwatertanksareequippedwithananoderod.Thesubmergedrodsacrifices itself toprotect the tank. Insteadofcorroding the tank,waterionsattackandeatawaytheanoderod.Thisdoesnotaffectwater’stasteorcolor.Therodmustbemaintainedtokeepthetankinoperatingcondition.Anodedeteriorationdependsonwaterconductivity,notnecessarilywatercondition.Acorrodedorpittedanoderodindicateshighwaterconductivityandshouldbecheckedand/orreplacedmoreoftenthanananoderodthatappearstobeintact.Replacementofadepletedanoderodcanextendthelifeofyourwaterheater.Inspectionshouldbeconductedbyaqualifiedserviceagency,andataminimumshouldbecheckedannuallyafterthewarrantyperiod.Artificially softenedwater is exceedingly corrosive because theprocesssubstitutessodiumionsformagnesiumandcalciumions.Theuseof awater softenermaydecrease the life of thewaterheater tank.Theanoderodshouldbeinspectedafteramaximumofthreeyearsandannuallythereafteruntiltheconditionoftheanoderoddictatesitsreplacement.note: Artificially softenedwater requires the anode rod to beinspectedannually.
teMperature-pressure relIef valve test
Burn hazard.
Hot water discharge.
Keep clear of Temperature-Pressure Relief Valvedischarge outlet.
![Page 24: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/24.jpg)
24
Limeaccumulationnotonlyreducesthelifeoftheequipmentbutalsoreducesefficiencyoftheheaterandincreasesfuelconsumption.
The usage of water softening equipment greatly reduces thehardnessofthewater.However, thisequipmentdoesnotalwaysremoveallofthehardness(lime).Forthisreasonitisrecommendedthataregularschedulefordelimingbemaintained.
Thetimebetweencleaningwillvaryfromweekstomonthsdependinguponwaterconditionsandusage.
Thedepthoflimebuildupshouldbemeasuredperiodically.Heatersequippedwithcleanoutswillhaveabout2”of limebuildupwhentheleveloflimehasreachedthebottomofthecleanoutopening.Aschedulefordelimingshouldthenbesetup,basedontheamountoftimeitwouldtakefora1”buildupoflime.Itisrecommendedthatthewaterheaterinitiallybeinspectedafter6months.
Example1:Initial inspectionafter6monthsshows1/2”of limeaccumulation.Therefore,theheatershouldbedelimedonceayear.
Example2:Initialinspectionafter6monthsshows2”oflimeaccumulation.Therefore,theheatershouldbedelimedevery3months.
fIGure 21.
delIMInG solvents
UN•LIME is recommended fordeliming.UN•LIME isapatentedfoodgradeacidwhichissafetohandleanddoesnotcreatetheharmfulfumeswhichareassociatedwithotherproducts.
UN•LIMEmaybeobtainedfromyourdealer,distributororwaterheatermanufacturer.OrderPartNumber9005416105,1gallon,packed 4 gallons per case or Part Number 9005417105, 5 galloncontainer.
note:Un•LimeisnotavailableforuseinCanada.
Hydrochloric baseacids arenot recommended for useonglasslined tanks.
Observehandlinginstructionsonlabelofproductbeingused.
tanK cleanout procedure
Thefollowingpracticeswillensurelongerlifeandenabletheunittooperateatitsdesignedefficiency:
1. Onceamonththeheatershouldbeflushed.Openthedrainvalveandallowtwogallonsofwatertodrainfromtheheater.Inletwatervalveshouldremainopentomaintainpressureintank.
2. Acleanoutopeningisprovidedforperiodiccleaningofthetank.Gasmustbeshutoffandheaterdrainedbeforeopeningcleanout.
Tocleanheaterthroughcleanoutopening,proceedasfollows:
1. Drain heater.
2. Removeoutercoverplatefromlowersideofheaterjacket.
3. Removesix(6)hexheadscrewssecuringtankcleanoutplateandremoveplate.
4. Removelime,scale,orsedimentusingcarenottodamagetheglasslining.
5. Inspect cleanout plate gasket, if newgasket is required, seereplacementpartslistforitemnumber.
6. Installcleanoutplate.Besuretodrawplateuptightbytighteningscrewssecurely.
7. Replaceouterjacketcoverplate.
fIGure 22.
9. Insomewaterareasthesedimentmightnotberemovedbythismethodandmayresultinthewaterheatermakingrumblingorboiling noises.To dissolve and remove thesemore stubbornmineral deposits,A.O.SmithUN•LIMEProfessionalDelimershould be used.
delIMInG usInG flo-juG Method
UN•LIMEinthe5gallonsizeisrecommendedfordelimingoftheBT-80and100models.UN•LIMEwiththenecessaryhosesandfittingstodelimeyourheaterisalsoavailableasakit:Up-N-DownTransferKit.ContactyourlocalA.O.Smithdealer,distributoror,A.O.SmithCorporation,Telephone:(800)433-2545,Fax:(800)433-2515orWebsite:www.hotwater.com.
prepare the water heaterTodelimethewaterheaterusingtheFlo-Jugmethod,firstpreparetheheaterfordelimingasdescribedinthe“Why?When?andHow?”booklet,FormNo.4800.Theninstallthelongplasticmaleadapterfittingintothedrainvalveopeningofthewaterheater.Useteflontapeandhandtightenonly.Donotovertighten.
prepare the up-n-down transfer KItThenextstepisthepreparationontheUp-N-DownTransferKit,ifyouhavenotalreadydoneso:
1. Withthe5gallonUp-N-Downcontainerintheverticalposition,unscrewtheplasticventcapinthehandleandpiercetheplasticmembraneovertheventbossunderthecaptoallowthecontainertovent.
note: Ifyourcontainerdoesnothave theventcapandventboss,drilla3/16”(4.76mm)holeinthehandle.Whenyouhavefinisheddelimingyouwillbeabletoplugthisdrilledventwiththestainlesssteelscrewthatissuppliedwiththekit.
2. Removethecontainer’scapandcutplasticmembranelocatedinthe3/4”IPTopeningincap.Takecaretonotdamagethethreads.
3. Findthe3/4”maleadapter,applyteflontapetothethreadedendandscrewitintothe3/4”IPTopeninginthecap.
![Page 25: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/25.jpg)
25
4. Putcapwithmaleadapterbackonthecontainerandslide3/4”hoseoverendofmaleadapterandfasteninplaceusinghoseclampprovided.
delIMe usInG flo-juG Method
5. Slidethehoseclampoverendofhoseandslidehoseoverthemaleadapter in thewaterheaterdrainopeningandsecure inplaceusinghoseclamp.
6. Liftcontainertothe“Pour”PositionbeingcarefultokeeptheventinthehandleabovetheliquidlevelandpourtheUN•LIMEintothe heater.
7. Lowercontainer,youmayhavetoplacethecontaineronitsemptycartontopreventtheUN•LIMEfromflowingbackintothecontainer.
8. LetUN•LIMEremainintheheaterfor5minutesandthenlowerthecontainertothe“Drain”Position.
9. Delimingactivity is indicatedbyfoamingonthesurfaceof theUN•LIME.Ifthereisdelimingactivity,repeatsteps6thru8.
Normally,limeremovalwillbecompletedwithinonehour.Severebuild-upoflimemaytakelongerthananhourtocompletedescaling.
Note:TocheckUN•LIMEforcontinueduse,placesomescaleorwhitechalkinaglasswithasmallamountofUN•LIME.IfthematerialisvigorouslydissolvedbytheUN•LIME,itcanbereused;ifnot,theUN•LIMEshouldbereplaced.
If the temperature-pressure reliefvalveon theapplianceweepsordischargesperiodically,thismaybeduetothermalexpansion.Youmayhaveacheckvalveinstalledinthewaterlineorawatermeterwith a check valve.Consult your localwater supplier orserviceagencyforfurtherinformation.Donotplugthetemperature-pressurereliefvalve.
draInInG and flushInG
It is recommended that the water heater storage tank bedrained and flushed every 6 months to reduce sedimentbuildup.Thewaterheatershouldbedrainedifbeingshutdownduringfreezingtemperatures.SeeFeaturesAndComponentsinthismanualforthelocationofthewaterheatercomponentsdescribedbelow.
Burn harzard.
Hot water discharge.
Keep hands clear of drainvalve discharge.
to draIn the water heater storaGe tanK:1. Turnofftheelectricalsupplytothewaterheater.2. TurnoffthegassupplyattheMainGasShutoffValveifthe
waterheaterisgoingtobeshutdownforanextendedperiod.3. Ensurethecoldwaterinletvalveisopen.4. Openanearbyhotwaterfaucetandletthewaterrununtil
thewaterisnolongerhot.5. Closethecoldwaterinletvalvetothewaterheater.
6. Connect a hose to the water heater drain valve andterminateittoanadequatedrain.
7. Open the water heater drain valve and allow all the water to drainfromthestoragetank.
8. close the water heater drain valve when all water in the storagetankhasdrained.
9. ClosethehotwaterfaucetopenedinStep4.10. Ifthewaterheaterisgoingtobeshutdownforanextended
period,thedrainvalveshouldbeleftopen.to flush the water heater storaGe tanK:1. Turnofftheelectricalsupplytothewaterheater.2. Ensurethecoldwaterinletvalveisopen.3. Openanearbyhotwaterfaucetandletthewaterrununtil
thewaterisnolongerhot.Thenclosethehotwaterfaucet.4. Connectahose to thedrainvalveand terminate it toan
adequate drain.5. Ensure the drain hose is secured before and during the
entire flushing procedure. Flushing is performed withsystemwaterpressureappliedtothewaterheater.
6. Openthewaterheaterdrainvalvetoflushthestoragetank.7. Flush thewaterheater storage tank to removesediment
andallowthewatertoflowuntilitrunsclean.8. Close the water heater drain valve when flushing is
completed.9. Removethedrainhose.10. Fillthewaterheater-seeFillingTheWaterHeaterinthismanual.11. Turnontheelectricalsupplytoplacethewaterheaterback
in operation.12. TurnonthegassupplytothewaterheaterattheMainGas
ShutoffValve.13. Allowthewaterheatertocompleteseveralheatingcycles
toensureitisoperatingproperly.
servIce
Beforecallingforrepairservice,readthe“StartUpConditions”and“OperationalConditions”foundinthe“ForYourInformation”sectionofthismanual.
Ifaconditionpersistsoryouareuncertainabouttheoperationofthewaterheatercontactaserviceagency.Ifyouarenotthoroughlyfamiliarwithgascodes,yourwaterheater,andsafetypractices,contactyourgassupplierorqualifiedinstallertocheckthewaterheater.
Use the ”Leakage Checkpoints” guide to check a “Leaking” waterheater.Manysuspected“Leakers”arenotleakingtanks.Oftenthesourceofthewatercanbefoundandcorrected.
Readthismanualfirst.Thenbeforecheckingthewaterheatermakesurethegassupplyhasbeenturned“OFF”,andneverturnthegas“ON”beforethetankiscompletelyfullofwater.
Neverusethiswaterheaterunlessitiscompletelyfilledwithwater.Topreventdamagetothetank,thetankmustbefilledwithwater.Watermustflowfromthehotwaterfaucetbeforeturning“ON”gasto the water heater.
Readthismanualfirst.Thenbeforecheckingthewaterheatermakesurethegassupplyhasbeenturned“OFF”,andneverturnthegas“ON”beforethetankiscompletelyfullofwater.
Neverusethiswaterheaterunlessitiscompletelyfilledwithwater.Topreventdamagetothetank,thetankmustbefilledwithwater.Watermustflowfromthehotwaterfaucetbeforeturning“ON”gasto the water heater.
![Page 26: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/26.jpg)
26
leaKaGe checKpoInts
A.Wateratthedrafthoodiswatervaporwhichhascondensedoutofthecombustionproducts.Thisiscausedbyaprobleminthevent.Contactthegasutility.
B.*Condensationmaybeseenonpipesinhumidweatherorpipeconnectionsmaybeleaking.
C.*Theanoderodfittingmaybeleaking.
D.Smallamountsofwaterfromtemperature-pressurereliefvalvemaybeduetothermalexpansionorhighwaterpressureinyourarea.
E.*The temperature-pressure relief valvemaybe leakingat thetankfitting.
F.Waterfromadrainvalvemaybeduetothevalvebeingslightlyopened.
G.*Thedrainvalvemaybeleakingatthetankfitting.
H.Combustionproductscontainwatervaporwhichcancondenseonthecoolersurfacesofthetank.Dropletsformanddripontotheburnerorrunonthefloor. This iscommonatthetimeofstart-upafterinstallationandwhenincomingwateriscold.
I. Waterinthewaterheaterbottomoronthefloormaybefromcondensation,looseconnections,orthereliefvalve.DONOTreplacethewaterheateruntilafullinspectionofallpossiblewatersourcesismadeandnecessarycorrectivestepstaken.
Leakage fromother appliances,water lines, or ground seepageshouldalsobechecked.
* To checkwhere threaded portion enters tank, insert cottonswabbetweenjacketopeningandfitting.Ifcottoniswet,follow“Draining”instructionsinthe“PeriodicMaintenance”sectionandthenremovefitting.Putpipedopeorteflontapeonthethreadsandreplace.Thenfollow“FillingtheWaterHeater”instructionsinthe“InstallingtheNewWaterHeater”section.
![Page 27: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/27.jpg)
27
trouBleshootInG GuIdelInesTheseguidelinesshouldbeutilizedbyaqualifiedserviceagent.
Problem cause Solution
WATER lEAkS
Improperlysealed,hotorcoldsupplyconnection,reliefvalve,drainvalve,orthermostatthreads. Tightenthreadedconnections.
Leakagefromotherappliancesorwaterlines. Inspectotherappliancesnearwaterheater.
Condensationofflueproducts. RefertoCONDENSATION.
lEAkING T&P VAlVE
Thermalexpansioninclosedwatersystem. Installthermalexpansiontank(DONOTplugT&Pvalve).
Improperlyseatedvalve.Checkreliefvalveforproperoperation(DONOTplugT&Pvalve).
SMEllY WATERHighsulfateormineralcontentinwatersupply. Drainandflushheaterthoroughly,thenrefill.
Bacteriainwatersupply. chlorinate or aerate water supply.
PIlOT WIll NOT lIGHT
Gascontrolknobnotpositionedcorrectly. RefertoLIGHTINGINSTRUCTIONS.
Maingassupplyoff. Turnonmaingasshutoffvalve.
Thermocouplemalfunction. Replacepilotassemblyand/orthermocouple.
Matchnotclosetopilot Locatepilot,movematchcloser.
BURNER WIll NOT
STAY lIT
Thermocouplemalfunction. Replacepilotassemblyand/orthermocouple.
DefectiveGasControl. ReplaceGasControl.
PIlOT OUTAGE
Dirty pilot burner. Cleanpilotassembly.
Thermocouplemalfunction. Replacepilotassemblyand/orthermocouple.
DefectiveGasControl. ReplaceGasControl.
Thermocoupletipisnotincontactwithpilotflame. Insertthermocouplecorrectly.
NOT ENOUGH HOT WATER
Heaternotlitorthermostatnoton. RefertoLIGHTINGINSTRUCTIONS.
Thermostatsettoolow. RefertoTEMPERATUREREGULATION.
Heater undersized. Reducehotwateruse.
Lowgaspressure. Contactyourgassupplier.
Incomingwaterisunusuallycold. Allowmoretimeforheatertore-heat.
Leakinghotwaterpipesorfixtures. Haveplumbercheckandrepairleaks.
Hightemperaturelimitswitchactivated. Contactaserviceagencytodeterminecause.
WATER TOO HOT Thermostatsettoohigh. RefertoTEMPERATUREREGULATION.
WATER HEATER SOUNDS Condensationdrippingonburner. RefertoCONDENSATION.
SIZZLINGORRUMBlING
Sedimentorcalciuminbottomofheatertank. Cleansedimentfromtank.RefertoDRAININGinstructionsinMaintenancesectionofmanual.
SOOTING Impropercombustion. Noadjustmentavailable.Contactaserviceagencytodeterminecause.
VENT GAS ODORS
Lackofsupplyair.
Contactaserviceagencytodeterminecause.Improperlyinstalledventpiping.
Downdraft.
Poorcombustion.
![Page 28: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/28.jpg)
28
water pIpInG dIaGraMs
Oct
ober
200
9 | P
rinte
d in
U.S
.A. |
© A
. O. S
mith
Fo
r Tec
hnic
al In
form
atio
n an
d A
utom
ated
Fax
Ser
vice
, cal
l 800
-527
-195
3 or
vis
it w
ww
.hot
wat
er.c
om.
AO
SC
G61
130
| PAG
E 1
of 1
A
. O. S
mith
Cor
pora
tion
rese
rves
the
right
to m
ake
prod
uct c
hang
es o
r im
prov
emen
ts w
ithou
t prio
r not
ice.
NO
TES
:1.
P
refe
rred
pip
ing
diag
ram
.2.
Th
e te
mpe
ratu
re a
nd p
ress
ure
relie
f val
ve s
ettin
g sh
all n
ot e
xcee
d pr
essu
re ra
ting
of a
ny c
ompo
nent
in th
e sy
stem
.3.
S
ervi
ce v
alve
s ar
e sh
own
for s
ervi
cing
uni
t. H
owev
er, l
ocal
cod
es s
hall
gove
rn th
eir u
sage
.4.
The
Tan
k Te
mpe
ratu
re C
ontro
l sho
uld
be w
ired
to a
nd c
ontro
l the
pum
p be
twee
n th
e w
ater
hea
ter(
s) a
nd th
e st
orag
e ta
nk(s
).5.
The
wat
er h
eate
r’s o
pera
ting
ther
mos
tat s
houl
d be
set
5 d
egre
es F
hig
her t
han
the
Tank
Tem
pera
ture
Con
trol.
SIN
GLE
FLU
E -
(1 U
NIT
)
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K TE
MPE
RAT
UR
E C
ON
TRO
L
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
TC
OLD
CO
LD EX
PA
NS
ION
TAN
K
CO
LD W
ATE
RS
UP
PLY
PIP
E T
&P
TO
OP
EN
DR
AIN
![Page 29: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/29.jpg)
29 Oct
ober
200
9 | P
rinte
d in
U.S
.A. |
© A
. O. S
mith
Fo
r Tec
hnic
al In
form
atio
n an
d A
utom
ated
Fax
Ser
vice
, cal
l 800
-527
-195
3 or
vis
it w
ww
.hot
wat
er.c
om.
AO
SC
G61
140
| PAG
E 1
of 1
A
. O. S
mith
Cor
pora
tion
rese
rves
the
right
to m
ake
prod
uct c
hang
es o
r im
prov
emen
ts w
ithou
t prio
r not
ice.
NO
TES
:1.
P
refe
rred
pip
ing
diag
ram
.2.
Th
e te
mpe
ratu
re a
nd p
ress
ure
relie
f val
ve s
ettin
g sh
all n
ot e
xcee
d pr
essu
re ra
ting
of a
ny c
ompo
nent
in th
e sy
stem
.3.
S
ervi
ce v
alve
s ar
e sh
own
for s
ervi
cing
uni
t. H
owev
er, l
ocal
cod
es s
hall
gove
rn th
eir u
sage
.4.
Th
e Ta
nk T
empe
ratu
re C
ontro
l sho
uld
be w
ired
to a
nd c
ontro
l the
pum
p be
twee
n th
e w
ater
hea
ter(
s) a
nd th
e st
orag
e ta
nk(s
).5.
Th
e w
ater
hea
ter’s
ope
ratin
g th
erm
osta
t sho
uld
be s
et 5
deg
rees
F h
ighe
r tha
n th
e Ta
nk T
empe
ratu
re C
ontro
l.
SIN
GLE
FLU
E -
(1 U
NIT
) WIT
H V
ER
TIC
AL
STO
RA
GE
TA
NK
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K TE
MPE
RAT
UR
E C
ON
TRO
L
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
TC
OLD
EX
PA
NS
ION
TAN
KCO
LD W
ATE
RS
UP
PLY
HO
T W
ATE
RR
ETU
RN
FR
OM
FI
XTU
RE
S
HO
T W
ATE
RTO
FIX
TUR
ES
ALT
. CO
LDW
ATE
R C
ON
NE
CTI
ON
PIP
E T
&P
TO
OP
EN
DR
AIN
![Page 30: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/30.jpg)
30 Oct
ober
200
9 | P
rinte
d in
U.S
.A. |
© A
. O. S
mith
Fo
r Tec
hnic
al In
form
atio
n an
d A
utom
ated
Fax
Ser
vice
, cal
l 800
-527
-195
3 or
vis
it w
ww
.hot
wat
er.c
om.
AO
SC
G61
150
| PAG
E 1
of 1
A
. O. S
mith
Cor
pora
tion
rese
rves
the
right
to m
ake
prod
uct c
hang
es o
r im
prov
emen
ts w
ithou
t prio
r not
ice.
NO
TES
:1.
P
refe
rred
pip
ing
diag
ram
.2.
Th
e te
mpe
ratu
re a
nd p
ress
ure
relie
f val
ve s
ettin
g sh
all n
ot e
xcee
d pr
essu
re ra
ting
of a
ny c
ompo
nent
in th
e sy
stem
.3.
S
ervi
ce v
alve
s ar
e sh
own
for s
ervi
cing
uni
t. H
owev
er, l
ocal
cod
es s
hall
gove
rn th
eir u
sage
.4.
Th
e Ta
nk T
empe
ratu
re C
ontro
l sho
uld
be w
ired
to a
nd c
ontro
l the
pum
p be
twee
n th
e w
ater
hea
ter(
s) a
nd th
e st
orag
e ta
nk(s
).5.
Th
e w
ater
hea
ter’s
ope
ratin
g th
erm
osta
t sho
uld
be s
et 5
deg
rees
F h
ighe
r tha
n th
e Ta
nk T
empe
ratu
re C
ontro
l.
SIN
GLE
FLU
E -
(1 U
NIT
) WIT
H H
OR
IZO
NTA
L S
TOR
AG
E T
AN
K
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K TE
MPE
RAT
UR
E C
ON
TRO
L
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
TC
OLD
EX
PA
NS
ION
TAN
K
CO
LD W
ATE
RS
UP
PLY
HO
T W
ATE
RR
ETU
RN
FR
OM
FI
XTU
RE
S
HO
T W
ATE
RTO
FIX
TUR
ES
ALT
ER
NA
TELO
CA
TIO
N
PIP
E T
&P
TO
OP
EN
DR
AIN
![Page 31: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/31.jpg)
31 Oct
ober
200
9 | P
rinte
d in
U.S
.A. |
© A
. O. S
mith
F
or T
echn
ical
Info
rmat
ion
and
Aut
omat
ed F
ax S
ervi
ce, c
all 8
00-5
27-1
953
or v
isit
ww
w.h
otw
ater
.com
. A
OS
CG
6116
0 | P
AG
E 1
of 1
A
. O. S
mith
Cor
pora
tion
rese
rves
the
right
to m
ake
prod
uct c
hang
es o
r im
prov
emen
ts w
ithou
t prio
r no
tice.
NO
TE
S:
1.
Pre
ferr
ed
pip
ing
dia
gra
m.
2.
Th
e t
em
pe
ratu
re a
nd
pre
ssu
re r
elie
f va
lve
se
ttin
g s
ha
ll n
ot
exc
ee
d p
ress
ure
ra
ting
of
an
y co
mp
on
en
t in
th
e s
yste
m.
3.
Se
rvic
e v
alv
es
are
sh
ow
n f
or
serv
icin
g u
nit.
Ho
we
ver,
loca
l co
de
s sh
all
go
vern
th
eir
usa
ge
.4
. T
he
Ta
nk
Tem
pe
ratu
re C
on
tro
l sh
ou
ld b
e w
ire
d t
o a
nd
co
ntr
ol t
he
pu
mp
be
twe
en
th
e w
ate
r h
ea
ter(
s) a
nd
th
e s
tora
ge
ta
nk(
s).
5.
Th
e w
ate
r h
ea
ter’
s o
pe
ratin
g t
he
rmo
sta
t sh
ou
ld b
e s
et
5 d
eg
ree
s F
hig
he
r th
an
th
e T
an
k Te
mp
era
ture
Co
ntr
ol.
SIN
GL
E F
LU
E -
(1
UN
IT)
WIT
H M
IXIN
G V
ALV
E T
WO
TE
MP
ER
AT
UR
E
LEG
EN
DT
EM
PE
RA
TU
RE
& P
RE
SS
UR
ER
ELI
EF
VA
LVE
PR
ES
SU
RE
RE
LIE
F V
ALV
E
CIR
CU
LAT
ING
PU
MP
TAN
K T
EM
PE
RA
TU
RE
CO
NT
RO
L
DR
AIN
FU
LL P
OR
T B
ALL
VA
LVE
TE
MP
ER
AT
UR
E G
AG
E
WA
TE
R F
LOW
SW
ITC
H
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AW
ING
SH
OW
S S
UG
GE
ST
ED
PIP
ING
CO
NF
IGU
RA
TIO
N A
ND
OT
HE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FO
R A
DD
ITIO
NA
L R
EQ
UIR
EM
EN
TS
.
HO
T W
AT
ER
RE
TU
RN
MIN
IMU
M10
´́ to
12´́
HO
T W
AT
ER
OU
TLE
TT
EM
PE
RE
DW
AT
ER
RE
TU
RN
TE
MP
ER
ED
WA
TE
RO
UT
LET
CO
LD W
AT
ER
SU
PP
LYLI
NE
TE
MP
ER
AT
UR
EC
ON
TR
OL
CO
LDH
OT
EX
PA
NS
ION
TA
NK
PIP
E T
&P
TO
OP
EN
DR
AIN
2193
32_A
OS
CG
6116
0.in
dd
112
/9/0
9 1
1:24
:14
AM
![Page 32: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/32.jpg)
32 Oct
ober
200
9 | P
rinte
d in
U.S
.A. |
© A
. O. S
mith
Fo
r Tec
hnic
al In
form
atio
n an
d A
utom
ated
Fax
Ser
vice
, cal
l 800
-527
-195
3 or
vis
it w
ww
.hot
wat
er.c
om.
AO
SC
G61
170
| PAG
E 1
of 1
A
. O. S
mith
Cor
pora
tion
rese
rves
the
right
to m
ake
prod
uct c
hang
es o
r im
prov
emen
ts w
ithou
t prio
r not
ice.
NO
TES
:1.
P
refe
rred
pip
ing
diag
ram
.2.
Th
e te
mpe
ratu
re a
nd p
ress
ure
relie
f val
ve s
ettin
g sh
all n
ot e
xcee
d pr
essu
re ra
ting
of a
ny c
ompo
nent
in th
e sy
stem
.3.
S
ervi
ce v
alve
s ar
e sh
own
for s
ervi
cing
uni
t. H
owev
er, l
ocal
cod
es s
hall
gove
rn th
eir u
sage
.4.
Th
e Ta
nk T
empe
ratu
re C
ontro
l sho
uld
be w
ired
to a
nd c
ontro
l the
pum
p be
twee
n th
e w
ater
hea
ter(
s) a
nd th
e st
orag
e ta
nk(s
).5.
Th
e w
ater
hea
ter’s
ope
ratin
g th
erm
osta
t sho
uld
be s
et 5
deg
rees
F h
ighe
r tha
n th
e Ta
nk T
empe
ratu
re C
ontro
l.
SIN
GLE
FLU
E -
(2 U
NIT
S)
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K TE
MPE
RAT
UR
E C
ON
TRO
L
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
R
TO F
IXTU
RE
S
HO
TC
OLD
HO
T
HO
T W
ATER
RET
UR
NFR
OM
FIX
TUR
ES
CO
LD
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
![Page 33: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/33.jpg)
33 Oct
ober
200
9 | P
rinte
d in
U.S
.A. |
© A
. O. S
mith
Fo
r Tec
hnic
al In
form
atio
n an
d A
utom
ated
Fax
Ser
vice
, cal
l 800
-527
-195
3 or
vis
it w
ww
.hot
wat
er.c
om.
AO
SC
G61
180
| PAG
E 1
of 1
A
. O. S
mith
Cor
pora
tion
rese
rves
the
right
to m
ake
prod
uct c
hang
es o
r im
prov
emen
ts w
ithou
t prio
r not
ice.
NO
TES
:1.
P
refe
rred
pip
ing
diag
ram
.2.
Th
e te
mpe
ratu
re a
nd p
ress
ure
relie
f val
ve s
ettin
g sh
all n
ot e
xcee
d pr
essu
re ra
ting
of a
ny c
ompo
nent
in th
e sy
stem
.3.
S
ervi
ce v
alve
s ar
e sh
own
for s
ervi
cing
uni
t. H
owev
er, l
ocal
cod
es s
hall
gove
rn th
eir u
sage
.4.
Th
e Ta
nk T
empe
ratu
re C
ontro
l sho
uld
be w
ired
to a
nd c
ontro
l the
pum
p be
twee
n th
e w
ater
hea
ter(
s) a
nd th
e st
orag
e ta
nk(s
).5.
Th
e w
ater
hea
ter’s
ope
ratin
g th
erm
osta
t sho
uld
be s
et 5
deg
rees
F h
ighe
r tha
n th
e Ta
nk T
empe
ratu
re C
ontro
l.
SIN
GLE
FLU
E -
(2 U
NIT
S) T
WO
TE
MP
ER
ATU
RE
ON
E P
RE
-HE
ATE
R/O
NE
BO
OS
TER
HE
ATE
R
LEG
EN
DTE
MP
ER
ATU
RE
& P
RE
SS
UR
ER
ELI
EF
VALV
E
PR
ES
SU
RE
RE
LIE
F VA
LVE
CIR
CU
LATI
NG
PU
MP
TAN
K TE
MPE
RAT
UR
E C
ON
TRO
L
DR
AIN
FULL
PO
RT
BA
LL V
ALV
E
TEM
PE
RAT
UR
E G
AG
E
WAT
ER
FLO
W S
WIT
CH
CH
EC
K V
ALV
EW
AR
NIN
G: T
HIS
DR
AWIN
G S
HO
WS
SU
GG
ES
TED
PIP
ING
CO
NFI
GU
RAT
ION
AN
D O
THE
R D
EV
ICE
S;
CH
EC
K W
ITH
LO
CA
L C
OD
ES
AN
D O
RD
INA
NC
ES
FOR
AD
DIT
ION
AL
RE
QU
IRE
ME
NTS
.
FIN
ISH
ED
FLO
OR
HO
T W
ATE
RTO
FIX
TUR
ES
HO
T W
ATE
R R
ETU
RN
HO
TH
OT
CO
LD
HIG
HTE
MP
ER
ATU
RE
RE
TUR
N
HIG
HTE
MP
ER
ATU
RE
OU
TLE
T
CO
LD W
ATE
RS
UP
PLY
EX
PA
NS
ION
TAN
K
PIP
E T
&P
TO
OP
EN
DR
AIN
PIP
E T
&P
TO
OP
EN
DR
AIN
BO
OS
TER
HE
ATE
R
![Page 34: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/34.jpg)
34
notes
![Page 35: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/35.jpg)
35
Model Bt limited warrantyA.O.SmithCorporation,thewarrantor,extendsthefollowingLIMITEDWARRANTYtotheownerofthiswaterheater.
1. THE TANk Iftheglass-linedtankinthiswaterheatershallproveuponexaminationbythewarrantortohaveleakedduetonaturalcorrosionfrompotablewatertherein,duringthefirstTHREEyearsafterinitialinstallation,thewarrantorwillsupplyacompletenewA.O.Smithwaterheaterofequivalentsizeandcurrentmodel.Somegovernmentagenciesarerequiringenergyefficientstandardsforwaterheaters.Intheeventregulationsprohibitsaleofamodelofequivalentsizeandconstruction,A.O.Smithwillprovideamodelwhichcomplieswiththeregulationsofyourarea,inwhichcasetheconsumerwillbechargedthedifferenceinpricebetweenthelikereplacementandtheenergyefficientmodelrequired.Thewarrantyonthereplacementwaterheaterwillbelimitedtotheunexpiredtermoftheoriginalwarranty.
2. All OTHER PARTS IfwithinONEyearafterinitialinstallationofthiswaterheater,anypartorportionshallproveuponexaminationbythewarrantortobedefectiveinmaterialorworkmanship,thewarrantorwillrepairorreplacesuchpartorportionatitsoption.
3. cONDITIONS AND EXcEPTIONS Thiswarrantyshallapplyonlywhenthewaterheaterisinstalledinaccordancewithlocalplumbingandbuildingcodes,ordinancesandregulations,theprintedinstructionsprovidedwithitandgoodindustrypractices.Inaddition,atemperatureandpressurereliefvalve,certifiedbyandofficiallysanctionedandrecognizedindependenttestingagencyandapprovedbytheAmericanSocietyofMechanicalEngineers,musthavebeeninstalled.
a. Thiswarrantyshallapplyonlywhentheheateris: (1) usedattemperaturesnotexceedingthemaximumcalibratedsettingofitsthermostat; (2) usedatwaterpressurenotexceedingtheworkingpressureshownontheheater; (3) filledwithpotablewater,freetocirculateatalltimesandwiththetankfreeofdamagingwatersedimentorscaledeposits; (4) usedinanon-corrosiveandnon-contaminatedatmosphere; (5) usedwithfactoryapprovedanode(s)installed; (6) initsoriginalinstallationlocation; (7) intheUnitedStates,itsterritoriesorpossessions; (8) sizedinaccordancewithpropersizingtechniquesforcommercialand/orresidentialwaterheaters; (9) bearingaratingplatewhichhasnotbeenaltered,defacedorremoved,exceptasrequiredbythewarrantor; (10) usedinanopensystemorinaclosedsystemwithproperlysizedandinstalledthermalexpansiontank; (11) operatedwithproperlyinstalledsedimenttrap; (12) firedwiththefuelforwhichitwasfactorybuilt; (13) firedatthefactoryratedinput; (14) operatedwiththeinnerandoutercombustionchamberdoorsinplace. b. Anyaccidenttothewaterheater,anymisuse,abuse(includingfreezingorthermalexpansiondamage)oralterationof,anyoperationina
modifiedform,oranyattempttorepairtankleakswillvoidthiswarranty. c. Thiswarrantyisvoidifadeviceactingasabackflowpreventiondevice(checkvalvesetc.)isinstalledinthecoldwatersupplytheheateris
connectedto,unlessaneffectivemethodofcontrollingthermalexpansionisalsoinstalledattheheater(s)andoperationalatalltimes.Thereliefvalveinstalledontheheaterisnotanacceptablemethod.
4. SERVIcE AND REPAIR EXPENSES Underthelimitedwarrantythewarrantorwillprovideonlyareplacementwaterheaterorpartthereof.Theownerisresponsibleforallothercosts.Suchcostsmayincludebutarenotlimitedto:
a. Laborchargesforserviceremoval,repairorreinstallationofthewaterheateroranycomponentpart; b. Shipping,delivery,handling,andadministrativechargesforforwardingthenewheaterorreplacementpartfromthenearestdistributorand
returningtheclaimeddefectiveheaterorparttosuchdistributor. c. Allcostnecessaryorincidentalforanymaterialand/orpermitsrequiredforinstallationofthereplacementheaterorpart.
5. lIMITATIONS ON IMPlIED WARRANTIES Impliedwarranties,includingthewarrantyofmerchantabilityimposedonthesaleofthisheaterunderstatelawarelimitedtoone(1)yeardurationfortheheateroranyofitsparts.Somestatesdonotallowlimitationonhowlonganimpliedwarrantylasts,sotheabovelimitationmaynotapplytoyou.
6. clAIM PROcEDURE Anyclaimunderthewarrantyshouldbeinitiatedwiththedealerwhosoldtheheater,orwithanyotherdealerhandlingthewarrantor’sproducts.Ifthisisnotpracticable,theownershouldcontact:
U.S.Customers CanadianCustomers A.O.SmithCorporation A.O.SmithEnterprisesLtd. 500 Tennessee Waltz Parkway 768 Erie Street AshlandCity,TN37015 Stratford(Ontario)N5A6T3 Telephone:(800)527-1953 Telephone:(800)265-8520
a. Thewarrantorwillonlyhonorreplacementwithidenticalorsimilarwaterheaterorpartsthereofwhicharemanufacturedordistributedbythewarrantor. b. Dealerreplacementsaremadesubjecttoin-warrantyvalidationbywarrantor.
7. DISclAIMERS NO OTHER EXPRESS WARRANTY HAS BEEN OR WIll BE MADE IN BEHAlf Of THE WARRANTOR WITH RESPEcT TO THE MERcHANT-
ABIlITY Of THE HEATER OR THE INSTAllATION, OPERATION, REPAIR OR REPlAcEMENT Of THE HEATER. THE WARRANTOR SHAll NOT BE RESPONSIBlE fOR WATER DAMAGE, lOSS Of USE Of THE UNIT, INcONVENIENcE, lOSS OR DAMAGE TO PERSONAl PROPERTY OR OTHER cONSEqUENTIAl DAMAGE. THE WARRANTOR SHAll NOT BE lIABlE BY VIRTUE Of THIS WARRANTY OR OTHERWISE fOR DAMAGE TO ANY PERSONS OR PROPERTY, WHETHER DIREcT OR INDIREcT, AND WHETHER ARISING IN cONTRAcT OR IN TORT.
a. Somestatesdonotallowtheexclusionorlimitationoftheincidentalorconsequentialdamage,sotheabovelimitationsorexclusionsmaynot apply to you.
b. Thiswarrantygivesyouspecificlegalrights,andyoumayalsohaveotherrightswhichvaryfromstatetostate.
Fillinthefollowingforyourownreference.Keepit.Registrationisnotaconditionofwarranty.Themodelandserialnumberarefoundontheheater’sratingplate.
Model No. ________________________Serial No. __________________________________________________ Date Installed _____________Dealer’sName ________________________________________________________________________________________________________Dealer’sAddress ___________________________________________________________________________Phone No. __________________city and State _____________________________________________________________________________Zip ________________________
kEEP THIS WARRANTY POSTED ADjAcENT TO THE HEATER fOR fUTURE REfERENcE.
![Page 36: coMMercIal Gas water heaters - Amazon S3...3 safe InstallatIon, use and servIce The proper installation, use and servicing of this water heater is extremely important to your safety](https://reader033.vdocument.in/reader033/viewer/2022050400/5f7de96cec0e70211a18deeb/html5/thumbnails/36.jpg)
36
500 Tennessee Waltz Pkwy., Ashland city, TN 37015TechnicalSupport:800-527-1953•Parts:800-433-2545
www.hotwater.com
Copyright©2012A.O.SmithWaterHeaterCompany,Allrightsreserved.