henkels & mccoy renewable energy services
TRANSCRIPT
• Founded in 1923
• One of the largest privatelyheld utility infrastructure engineering and construction companies in the nation
• Top-tier ENR SpecialtyContractors
• 84+ Offices in North America
• 5,500+ Employees
• 7,000+ pieces of equipment
• Annual revenues approximately $1.0+ billion - 2009
• Performance Focus: Safety, Quality, Productivity
Who is Henkels & McCoy?
Corporate Headquarters: Blue Bell, Pennsylvania
2
Management Management Leadership and Leadership and
CommitmentCommitment
Management Management Leadership and Leadership and
CommitmentCommitment
Establish a BaselineEstablish a BaselineAssessment/What it was Assessment/What it was
& & What it isWhat it is
Establish a BaselineEstablish a BaselineAssessment/What it was Assessment/What it was
& & What it isWhat it is
H&M Safety H&M Safety ““Taking The Next Step”Taking The Next Step”
Set GoalsSet GoalsLeading Practice & ExpectationsLeading Practice & Expectations
Set GoalsSet GoalsLeading Practice & ExpectationsLeading Practice & Expectations
Develop and Develop and Implement Regional Implement Regional
PlansPlans““Close the Gaps”Close the Gaps”
Develop and Develop and Implement Regional Implement Regional
PlansPlans““Close the Gaps”Close the Gaps”
Henkels & McCoy Safety Culture
13
Review and AdjustReview and AdjustWhat it could be?What it could be?
&&How far can we take it?How far can we take it?
Review and AdjustReview and AdjustWhat it could be?What it could be?
&&How far can we take it?How far can we take it?
SAFETY, SAFETY, SAFETY
4
Renewable Energy Businesses
Utility Wind PV Solar CSP Solar
Hydro/Kinetic
Power Conversion &
Storage Solutions
Power Collection, Distribution & Electrical
Control Solutions
Turnkey Project
Construction
24 by 7 Field Support
HV & MV Test
Services
5
Pre Start-Up Services – Critical Studies
• Underground cable loading capacity
• Load flow study
• Power factor study
• Transient switching study
• Coordination studies
• Grounding studies of collection system
• Arc-flash hazard analysis study
• Transient over-voltage study
• Short circuit study
• Protective device coordination
• Commissioning plan development
6
Medium & High Voltage Services
• H&M has provided high voltage services to the heavy industrial and utility industries for 80+ years
• Strong safety record - EMR rating of 1
• Travel globally 24 by 7
7
Start-Up / Commissioning Services
• Protective relay and power metering testing and calibration
• Earth/Grounding Fall-of-Potential Testing
• Transformer Testing and Dress Out
• Power Cables (DC HighPot, VLF, Partial Discharge)
• Circuit Breakers (SF6 & Vacuum)
• Vacuum fill SF6 gas breakers
• Switchgear
• Station batteries and DC charging systems
8
Preventative Maintenance Services
• Transformer testing (power factor, turns ratio, winding resistance, Sweep Frequency Response)
• Insulating oil analysis
• SF6 gas analysis, leak detection, Vacuum Circuit Breaker Testing
• High Voltage Switch - Cable and transformers are already covered
• Ground grid testing
• Station battery testing
• Power and Power Quality Testing (Harmonics, Power Factor, Transients)
• Substation preventative maintenance and repair
• Infrared Inspection
• Switchgear and bus duct testing
9
Preventative Maintenance Services
• Protective relay testing & calibration (electro-mechanical, solid state, microprocessor)
• Meter calibration
• Motor & Generator testing
• OCB breaker testing and repair
• Low voltage & medium voltage breaker testing
• Power system studies
• Thermographic surveys
• Station battery system testing
• Earth/ground testing - This can be removed as it is cover under " Ground Grid Testing“
• Power cable testing and locating (DC HighPot, VLF, Partial Discharge)
10
24 Hour Emergency Response
Utilize the following techniques 24/7 hour response:
• Phone support – In some instances, we can isolate a problem area to allow re-energization of the remaining substation or facility before manpower can get on site.
• Ready to travel – Most sites can be reached by our one of field technicians within 24 hours.
• Video support – with the use of digital photos or video, we can provide guidance over the phone while immediately getting started on locating replacement parts and equipment before the field tech ever gets on site.
11
Special Projects
PLC-based Generator testing system developed for Siemens through partnerships
• H&M with partners like Siemens, Wind Power Test Simulator and Operator Training Facility
Digital power control projects for Power Clients