manual peerless 1108 vertturbinepump ols
TRANSCRIPT
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 1/45
B-2633119
Rev. 11/08
Read this entire manual before attempting to install, operate, adjust, service,
repair or disassemble this pump. Instructions are
also included for installing and operating a water
level testing system using air pressure. Proper
installation and maintenance of this pump will
contribute to maximum efciency and a long, trouble-free life. Before starting the installation,
review the entire procedures given in this manual,
omitting those sections which do not apply to the
particular pump to be installed. Then, refer to it
step by step during the actual procedure. Failure
to read and comply with installation and operating
instructions will void the responsibility of the
manufacturer and may also result in bodily injury as
well as property damage.
This bulletin is intended to be a permanent part of
your pump installation and should be preserved ina convenient location for ready reference. If these
instructions should become soiled, obtain a new
copy from Peerless Pump. Include the pump model
and/or serial number with your request.
NOTICE
Peerless Pump Company cannot be held
responsible for inadequate performance of or
damage to a pump or for injury to personneldue to any of the following causes.
Installation of the pump in a well which
is unsuitable as tested by the procedure
described in Section 2 of this manual.
Installation of the pump on an inadequate
foundation as described in Section 4 of this
manual.
Air or gas in the well. If there is evidence
of air or gas, consult your Peerless Pump
dealer.
Erosion of pump parts by sand in the water
(sand cutting).Restarting of a pump whose impellers are
packed with sand (sand locked).
Failure to adhere to the warnings and
cautions which are outlined in this
manual.
C.
D.
E.
F.
WARNING
The pumps described by this manual are
specically designed for pumping water, andmust not be used to pump any other uid,
particularly combustible uids.
These pumps must not be installed in any
manner except as specied herein, and
must not be operated at speeds, capacities,
pressures or temperatures other than those
stipulated for in the purchase order.
Lubricants which can contaminate the water
to be pumped or which are soluble in water
must not be used in these pumps.
ANY VIOLATION OF THESE WARNINGS MAY
RESULT IN SEVERE PROPERTY DAMAGE OR
GRAVE PERSONAL INJURY.
A.
B.
Peerless Pump Company
Vertical Turbine Pumps
Open Line Shaft Construction
Installation, Operation And Maintenance Instructions
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 2/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 3/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 4/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 5/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 6/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 7/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 8/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 9/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 10/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 11/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 12/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 13/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 14/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 15/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 16/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 17/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 18/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 19/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 20/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 21/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 22/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 23/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 24/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 25/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 26/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 27/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 28/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 29/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 30/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 31/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 32/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 33/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 34/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 35/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 36/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 37/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 38/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 39/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 40/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 41/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 42/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 43/45
7/25/2019 Manual Peerless 1108 VertTurbinePump OLS
http://slidepdf.com/reader/full/manual-peerless-1108-vertturbinepump-ols 44/45