proformaforenvironmental …environmentclearance.nic.in/writereaddata/online/ec/090120157tlir… ·...
TRANSCRIPT
PROFORMAFORENVIRONMENTALAPPRAISALOFMININGPROJECTS
(MININGSECTORPROJECTS)
FOR
(EXPANSION OF MINE CAPACITYFROM 0.403 MTPA TO 10.0 MTPA(ROM) & SETTINGUP OF 4.5 MTPA BENEFICIATION PLANT ALONG
WITH CRUSHING& SCREENINGPLANT)
Prepared By
(EXTENT:MLAREA 149.7343 HA)
(NABETACCREDITED, NABLACCREDITED TESTING LABORATORY &
ISO 9001: 2008 CERTIFIED COMPANY)
Chennai–600 059, Ph: 044-22395170, Cell: 09444133619
(NEAR TATIBA VILLAGE, WEST SINGHBHUM DISTRICT,JHARKHAND STATE )
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-1
PROFORMA FOR ENVIRONMENTAL APPRAISAL OF MINING PROJECTS(MINING SECTOR PROJECTS)
1. General Information
(a) Name of the project : Ghatkuri iron mines
Name of the proponent : M /s. Nirmal Kumar Pradeep Kumar.,
(b) Mailing Address : Near Jain M andir, Gandhi Tola,
P.O. Chaibasa, Jharkhand – 833201Phone – 06582-256781Fax- 06582-256781
E-mail : [email protected]
Telephone : 06582-256781
Fax No. : 06582-256781
Objective of the project : Expansion of mine capacity from0.403M TPA to 10.0 M TPA (ROM)& setting up of4.5 M TPA beneficiationplant alongwith crushing & screening plant
(c) Location of mine (s)
Village(s) Tehsil District State
Tatiba Sadar Chaibasa Singhbum West Jharkhand
Note 1 : All information to be given in the form of Annex/sshould be properly numbered andform part of reply to thisproforma.
Note 2 : Please enter √ in appropriate box where answer is Yes / No
Note 3 : No abbreviation to be used - Not av ailable or Not applicable should be clearly
mentioned.
Note 4 : Core zone is the mining lease area.Buffer zone in case of ML area up to 25 ha is to be considered as 5 km all around
the periphery of the core zone and for ML area above 25 ha. an area 10 km allaround the periphery of the core zone.
Note 5 : Adopt Scoping process in carrying out EIA study.
Note 6 : Please indicate source of data.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-2
(d) Does the proposal relate to
(i) New mine Yes No
(ii) Expansion Yes No
Increase in ML area Yes No
Increase in annualproduction Yes No
(iii) Renew al of ML Yes No
(iv) Modernization Yes No
(e) Site Information
(i) Geographical Location
Latitude
Longitude
Survey of India Topo sheet number
Elevation above Mean Sea Level
Total mining lease area (in Ha.)
(ii) Dominant nature of terrain
Flat Yes No
Undulated Yes No
Hilly Yes No
2. Land usage of the mining lease area (in ha.)
(a) Agricultural
(b) Forest
(c) Waste land (Government Land)
(d) Grazing
(e) Surface w ater bodies
220 07’ 40” - 220 08’ 43” North
850 19’ 25” - 850 20’ 53” East
No. 73 F/8
452 to 836 m
149.7343
-
149.7343
-
-
-
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-3
(f) Others (Specify) i.Road
ii. Private fallow land
Total
3. Indicate the seismic zone in which ML area falls. In case of zone IV & V, detailsof earth quakes in last 10 years.
The area is situated in Seismic Zone II of Intensity indicating seismically leastactive.
(a) Severity (Richter Scale)
(b) Impact i.e. Damage to
Life Yes No
Property Yes No
Existing mine Yes No
-
149.7343
-
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-4
4. Break-up of mining lease area (in ha.) as per approv ed conceptual plan:
Purpose Mining Lease Area Total Area acquired Area to be acquired
Government Private Government Private Total Government Private Total
Forest Others Agri. Others Forest Others Agri. Others Forest Others Agri. Others
1. Area under mining 98.9500 - - - 98.9500 12.581 - - - 12.581 86.369 - - - 86.369
2. Storage for top soil - - - - - - - - - - - - - - -
3. Overburden / Dumps - - - - - - - - - - - - - - -
4. Mineral storage 4.3220 - - - 4.3220 0.364 - - - 0.364 3.958 - - - 3.958
5. Infrastructure (Workshop,
Administrative Building)0.6100 - - - 0.6100 0.100 - - - 0.100 0.51 - - - 0.51
6. Roads 1.6830 - - - 1.6830 0.915 - - - 0.915 0.768 - - - 0.768
7. Railways - - - - - - - - - - -
8. Green Belt (Safety Zone) 44.1693 - - - 44.1693 - - - - - 44.1693 - - - 44.1693
9.Tailingspond - - - - - - - - - - - - - - -
10.Effluent treatment plant - - - - - - - - - - - - - - -
11.CHP /mineralseparation plant
- - - - - - - - - - - - - - -
12. Township area(Temporary) - - - - - - - - - - - - - - -
13.Other (Specify)
(Untouched, Area for futureexploration etc.)
- - - - - - - - - - - - - - -
TOTAL149.7343
- - -149.7343
13.960 - - - 13.960 135.7743 - - - 135.7743
Note:* Area under Mining includes beneficiation plant also.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-5
5 . Township : Nil
( a ) Total area (in ha.) --
( b ) No. of dw elling units --
( c) Distance from mine site --
6 . Distance of water bodies (in km)
Distance fromRiver Bank* Other Water Bodies*
Sea / creek / lake / nalla etc. (specify)
Mine lease boundary - River Karo – 2.75 km (E)River Koina – 7.50 km (NW)
[* From highest flood line / high tide line]
7. For projects falling within the Coastal Regulation Zone (CRZ)
Not Applicable
Whether the mineral to be mined is of rare nature
and not available outside CRZ?Yes --- No ---
[If yes, annex a scaled location map showing low tide line (LTL), high tide line (HTL) duly
demarcated by one of the authorized agencies* [*Director, Space Application Centre,
Ahmedabad; Centre for Earth SciencesStudies, Thiruvananthapuram; Institute of Remote
Sensing, Anna University, Chennai; Institute of Wetland Management & Ecological Designs,
Kolkata; Naval Hydrographer’s Office, Dehradun; National Institute of Oceanography,
Panjim,Goa; and National Institute of Ocean Technology, Chennai], boundary of mining
lease area, distance of ML area from LTL and HTL, CRZ boundary and CRZ classification
of the project area asper the approved Coastal Zone Management Plan, and settlements,
sand dunes, mangroves, forest land / patches, turtle breeding and nesting sites etc., if any,
in the project area.]
8.Indicate aerial distance from the periphery of core zone / area from the peripheryof buffer zone to the boundary of following(Buffer zone up to 10 km from lease boundary) :
Sl. No. Areas NameAerial Distance (km)
CoreZone *
BufferZone *
1 National Park / Sanctuary Nil - -2 Biosphere Reserve / Tiger Reserve / - - -
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-6
Elephant Reserve / any otherReserve
Singhbum ElephantReserve
Within the lease area
3 Forest (RF / PF / unclassif ied) Karampada R.F. Lease is part of itGhatkuri R.F. Lease is part of itKodolibad R.F. - 6.0
Uliburu R.F. - 1.5Karo R.F. Adjacent -Thakurani R.F. - 6.0Siddhamath R.F. - 6.4Lakraghat R.F. - 9.5
4 Habitat for migratory birds Nil - -5 Corridor for animals of schedule I &
II of the Wildlife(Protection) Act, 1972
Karampada ElephantCorridor
- 8.0
6 Archaeological sites* Notif ied* Others
Nil - -
7 Defence Installation Nil - -8 Industries /
Thermal Pow er PlantsNil - -
9 Other Mines Few mines of SteelAuthority of India Ltd
M ines ,Generalproduce Co M ines,
Singhbhum M ineralCo, R M c dill &
Co,RameswarJuteM ills, Kamaljeet SinghAhluwalliah, ML Jain &Sons, T.P.Sao, ShreeDeokabhai Bheljee,
Usha M artin Ltd,Indian Iron Steel & Co,
OM DC
- Scatteredin the
buffer zone
10 Airport Jamshedpur - 140
Ranchi 275
11 Railw ay Lines Bolani RSBarajamda .RS
2.758.5
12 National / State Highw ays Hatgamaraya– KiriburuRoad (State Highway No51.
Passesthroughthe lease
area[* Buffer zone in case of ML area up to 25 ha. is to be considered as 5 km all around theperiphery of the core zone and for ML area above 25 ha. an area 10 km all around theperiphery of the core zone].
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-7
9. Description of flora & fauna separately in the core and buffer zones*
[* Consult the Wildlife (Protection) Act, 1972 as amended subsequently and list species w ith(1) Common name (2) Scientif ic name and (3) under w hich schedule of the Wildlife(Protection) Act the identif ied species fall. Get the list authenticated by an Expert in the field /credible scientif ic institute / University / Chief Wildlife Warden off ice. Information to bebased on field survey.]
A Flora Core Zone Buffer Zone
(i) Agricultural crops - Paddy, Radish, Banana etc.
(ii) Commercial crops - -(iii) Plantation Pongamia glabra, Cassia tora etc.(iv)
Natural vegetation/forest type --
Shorea robusta, Terminalia tomentosa,Adina cordifolia, Madhuca indica,Pterocarpusmarsupium, Mitragynaparviflora, Lagerstromia parviflora,Bridelia retusa, Albizzia procera,Hymenodictyon excelsum, Salamaliamalabarica, Gmelina arborea, Cleistanhuscollinus, Dalbergia latifolia. Dalbergiapaniculata, Syzygium cuminii, Dilleniapentagyna, Careya arborea, Diospyrosspp., M allotusphilippinensis, Emblicaoffici-nalis, Buchnania lanzan, Diospyrosmelanoxylon, Terminalia chebula, Kydiacalycina Ougeinia oojeinensis,Woodfordia fruticosa, Clerodendronviscosum, Indigofera pulchella, Moghaniasemialata, Phoenixacaulis, Grewia spp.,Embelia arborea, Ixora Themedequadrivalvis, Imperatacylinderica,Thysanolaena, Bauhinia vahlii, Buteasuperba, Smila zeylanica, Combretumdecandrum, B. parviflora
(v) Grass lands -- --(vi) Endangered species
(Refer Annexure – 20 of EIA report)(vii) Endemic species
(viii) Others (Specify)B Fauna
(i)Total listing of faunal elements
(ReferAnnexure - 21of EIA report)
(Refer Annexure – 21 of EIA report)
(ii)Endangered species Schedule – I species: Asian Elephant is present in the
buffer zone(iii) Endemic species Nil(iv) Migratory species Nil(v) Details of aquatic fauna, if
applicableNot applicable Not applicable
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-8
10. Details of mineral reserves(as per approved Mining Plan)
Quantity (in million tonnes)(a) Proved
(b) Indicated
(c) Inferred
(d) Mineable reserves/resource (Total)
11. Major geological formation / disturbances in the mining lease area
(a) Geological maps submitted Yes No
Refer Figure No – 2.3
(b) Geological sections submitted Yes No
Refer Figure No – 2.4
(c) Contour map submitted Yes No
Refer Figure No – 2.5
(d) Whether the presence, if any,noted of
(i) Faults Yes No
(ii) Dykes Yes No
(iii) Shear Zone Yes No
[(iv) Folds Yes No
(v) Other w eakzones Yes No
(e) Source of data (Indicate)
12. Production of mineral(s) and life of mine
(a) Rated capacity of mine mineral w ise (Tonnes / annum)
(b) Life of mine at proposed capacity (Years)
(c) Lease period (Years)
(d) Date of expiry of lease (D /M /Y)
(e) Indicate in case of existing mines
(i) Date of opening of mine
--
10.0 MTPA(ROM)
169.170
--
156.993
19 years
3rd renewal from27.07.2013submitted
20 years
Year 1953
Recent Mining plan report
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-9
(ii) Production in thelast 5 yearsfrom year………to year ………in million tonnes.
(iii) Projected production for the next5 years from year xxxxx to yearxxxx in tonnes.
(iv) Whether mining w as suspended after Yes Noopening of the mine?
If yes, details thereof including last productionfigure and reason for the same.
M ining operation inthismine is temporary suspended from 28.07.2013 for want
of TWP.
(f) Whether plans & sections provided? Yes No
Refer Figure No. 2.4 to 2.7 & 4.11
13. Type and method of mining operations
TYPE METHODOpencast Manual
Underground Semi-mechanised
Both Mechanised
14. Details of ancillary operations for mineral processing
(a) Existing
Year Production in MTPA
2009-10 283267.6102010-11 298562.922011-12 82050.002012-13 314224.00
2013- 14 upto 27.07.2014 244574.00
YearProposedproductionROM in MT
2014-15 4032242015-16 21360182016-17 45405752017-18 10000125
Total 17079942
S.No Particulars of Crusher & ScreenPlants
No’s
1 200 TPH Mobile Crushing Plant 1
2 250 TPH Mobile Screening Plant 2
✓
✓
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-10
(b) Additional
15. Mine details
(a) Opencast mine
(i) Stripping ratio (mineral in tonnes to over burden in m3)
(ii) Ultimate w orking depth (in m bgl)
(iii) Indicate present w orking depth in case ofexisting mine (in m bgl)
(iv) Thickness of top soil (in m.)
Minimum
Maximum
Average
(v) Thickness of overburden (in m.)
Minimum
Maximum
Average
(vi) Mining Plan
Height and w idth of the bench inoverburden / w aste.
Height & w idth of the bench in ore body /coal seam.
Proposed inclination / slope of the sides of theopencast mine (separately for overburden, coal /ore and overall slope of the pit sides) both w hileoperating the mine as w ell as at the time ofclosure of the mine.
Whether transverse sections across the Yes Noopencast mine at the end of f if th year
S.No
Particulars of Crusher & ScreenPlants
No’s
11500 TPH Stationary ScreeningCrushing Plant
1
2 100 TPH Mobile Crushing Plant 23 200 TPH Mobile Crushing Plant 1
4 250 TPH Mobile Screening Plant 1
490m RL
Almost Nil
--
--
1: 0.02 (T: m 3)
+652m RL
--
--
--
---
Height – 10 mWidth – 15 m
33.0°
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-11
and at the end of the life of the minehave been submitted?Refer Figure No – 2.7 & 4.13
(vii) Type of blasting, if any, to be adopted.
(b) Underground mine Not Applicable
(i) Seam / Ore body Min.Depth (m) Max. Depth (m) Avg. thickness (m)
Rate of dip Direction of dipin degree
(ii) Mode of entry into the mine
Shaft
Adit
Incline
(iii) Details of machinery
On surface
At Face
For transportation
Others
(iv) Method of stoping (metalliferrous mines)
Open
Filled
Shrinkage
Caving
Combination of above
Others (Specify)
Deep hole drillingand blasting
adopted.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-12
(v) Extraction method
[ Caving
Stow ing
Partial extraction
(vi) Subsidence
Predicted max. subsidence (in m)
Max. value of tensile strain (in mm/m)
Max. slope change (in mm/m)
Whether identif ied possible subsidencearea(s) superimposed on Surface Yes NoPlan has been submitted?
Major impacts on surface featureslike natural drainage pattern, houses,buildings, w ater bodies, roads, forest,etc.
Salient features of subsidencemanagement (monitoring and control).
16. Surface drainage pattern at mine site
(a) Whether the pre-mining surface drainage plan Yes Nosubmitted?(Refer Figure No – 3.21)
(b) Do you propose any modif ication / diversion Yes Noin the existing natural drainage pattern at anystage? If yes, w hen. Provide location mapindicating contours, dimensions of w ater body to bediverted, direction of f low of w ater and proposedroute / changes, if any i.e. realignment of river / nallah /any other w ater body falling w ithin core zone and
its impact.
17. Embankment and / or weir construction(a) Do you propose, at any stage, construction of
(i) Embankment for protection against f lood? Yes No
(ii) Weir for w ater storage for the mine? Yes No
(b) If so, provide details thereof.
(c) Impact of embankment on HFL and settlement Not Applicablearound.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-13
(d) Impact of w eir on dow nstreamusers of w ater. Not Applicable
18. Vehicular traffic density (outside the ML area)
A detailed study on impact on logistic system due to expansion is studied andgiven in para 4.9, Chapter- IV.
Type of vehicles No. of vehicles per day
(a) Existing
(b) After the proposed activity
(c) Whether the existing road Yes Nonetw ork is adequate?If no, provide details of alternativeproposal?
19. Loading, transportationand unloading of mineral and waste rocks on surface:
(a) Manual Yes Yes No
(b) Tubs, mine cars, etc. Yes No
(c) Scraper, shovels, dumpers / trucks. Yes No]
(d) Conveyors (belt, chain, etc.) Yes No
(e) Others (specify).
20. Mineral(s) transportation outside the ML area
Qty. (in TPD) Percentage (%) Length (in km)
(a) Road
(b) Rail
(c) Conveyors
(d) Rope way
(e) Water ways
(f) Pipeline
(g) Others (Specify)
Total
Note
* Including short tripsby road to nearby railway sidings
10T to 17T
2750
24750*
27500
-
-
-
-
-
Max 300
121
229710T to 17T
10
90
100
-
-
-
-
-
Around 15
-
-
-
-
-
-
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-14
21. Baseline Meteorological and Air Quality data(a) Micro-meteorological data
[Continuous monitoring through autographic instrument for one full season other than monsoon](i) Wind rose pattern for one full season (16 points of compass i.e. N, NNE, NE, ---) based on 24-hourly data. For coastal area also
furnish day-time and night time data. Day time
Night time 24 – hours periodFor wind rose Refer Figure No 3-10A & B and for daily meteorological data Refer Annexure - 17
(ii) Site specif ic monitored data
MonthTemperature in
◦c Humidity in (%) Pressure (mmHg) Wind Speed in KmphPre-dominent Wind
Direction FromRain Fallin mm
MIN MAX MIN MAX MIN MAX MIN MAX
October – 2013 13 26.4 50 90.4 702.6 744.2 0 8.2 SW 318
November –2013
11 26.5 51 89.6 713.9 720.9 0 10.2 W 0
December –2013
9.1 23.5 51 89.2 702.6 720.9 0 8.9S, SW
0
9.1 26.5 50 90.4 702.6 744.2 0 10.2 S, SW 318
* 24-hours rainfall should be reported from 08:30 hrs. IST of previous day to 08:30 hrs. IST of the day.* Rainy day is considered w hen more than 1mm for 24 hrs..** Visual observations of cloud cover should be recorded four times a day at regular intervals.
(iii) Indicate name and distance of the nearest IMD meteorologicalstation from w hich climatological data have been obtained - Site specific data was collected by installingfor reporting in the EIA report, if any. Continuousweather monitoring station
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-15
(b) Ambient air quality data* (RPM, SPM, SO2, and NOx)
[*Monitoring should be carried out covering one full season except monsoon – same season as in 21 (a) (i)][*Frequency of sampling: Sampling to be done twice a weekfor the entire season 24 hourly for SPM & RPM. For gaseouspollutants24- hourly data
be given irrespective of the sampling period. ]
(i) Season and period for w hich monitoring has been carried out. Post Monsoon Season of 2013(ii) No. of samples collected at each monitoring station: 24 samples
VALUES IN µg/m3
PARAMETERS Cat. PM 10 PM 2.5 SO2 NOX
LOCATION Min. Av e Max. Min. Av e Max. Min. Av e Max. Min. Av e Max.(R, I,S)
GA1 MINE SITE R 55.2 60.4 63.6 20.6 25.3 30.3 <3.0 <3.0 3.8 4.8 6.0 7.1
GA2 SHADAL R 51.2 60.1 67.4 20.8 24.6 29.3 <3.0 <3.0 3.9 4.7 5.8 6.9
GA3 TATIBA R 50.4 59.7 68.5 20.3 25.0 31.2 3.2 3.7 4.2 5.4 6.3 7.3
GA4 BARAIBUR1 R 54.2 63.3 72.3 23.1 27.4 32.9 3.4 4.1 4.9 5.5 6.4 7.5
GA5 KIRIBURU R 54.8 61.9 71.2 22.7 27.2 32.0 3.1 3.7 4.2 5.1 5.9 6.8
GA6 BARBIL R 60.4 67.3 80.5 23.4 29.1 36.0 3.2 4.0 4.8 5.7 7.6 8.8
GA7 BARJAMDA R 65.6 72.2 80.6 24.7 30.1 35.8 3.7 4.4 5.1 5.5 6.9 9.8
GA8 LASARDAVILLAGE
R 44.8 52.5 62.2 19.8 23.5 28.0 <3.0 <3.0 3.8 4.7 6.2 7.0
GA9 SITALDIBURU R 52.1 56.3 60.5 22.7 24.9 27.1 <3.0 <3.0 3.7 4.8 5.9 7.1
GA10 GUA R 58.2 69.5 79.1 24.2 31.2 36.1 3.3 4.0 4.6 5.7 6.8 7.9
Permissible AAQ std. (CPCB) R,
I100 100 60 80
S 100 100 60 80
Note: Category - R - Residential, I - Industrial, S – Sensitive, BDL-Below Detect able Limit, DL- Detection Limit.
**Pb for mineral specif ic sites only.# Annex a location map indicating location of AAQstations, their direction and distance w ith respect to project site. Refer Figure No 3-11
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-16
22. Stack and emission details, if any* -
Sl.No.
Process / unit ofoperation (e.g.
DG Set, Boiler)
Height ofstack (m)
Internaltop dia.
(m)
Flue gasexit
velocity(m/sec)
Emission rate (kg/hr) Heatemission
rate fromtop of
stack(K.cal/hr)
Exhaust / Flue gas
SPM SO2 NOx COTemp
OC
Density Specific
Heat
Volumetric
flow rate(m
3/hr.)
1. DG- 1000KVA(6 nos)
10 0.30 15 50mmg/nm3
- 350 3800
23. Details of fugitive emissions during mining operations*
The fugitive emissions during mining operations are mostly the dust from various sources such as blasting, drilling, excavation and movementof vehicles.
Please refer Para 4.2.1 of Chapter –IV of EIA/EM P report.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-17
24. Air Quality Impact Prediction (AQIP)*
(a) Details of model(s) used for AQIP including grid size, terrain features, and inputmeteorological data.
Model Used - ISCST3Grid Size - 500 mTerrain features - undulating terrainMeteorological data - Meteorological data generated at mine site
for Post monsoon season -2013
(b) Maximum incremental GLC values of pollutants based on prediction exercise
(in μg/m3)
[* Question Number 22, 23 & 24 need notbe filled-in for mineshaving ML area of 25 ha. or less.]
[**Information on item no. 2 & 3 to be provided in caseswith captive power generation of 500 KVAand above]
Code
LocationBaseline
concentrati
on (g/m3)
PredictedIncrementalConcentratio
n (g/m3)
PostProject
Concentration
(g/m3)
GA1 MINE SITE 63.6 12.0 75.6GA2 SHADAL 67.4 4.0 71.4GA3 TATIBA 68.5 8.0 76.5
GA4 BARAIBUR1 72.3 8.0 80.3
GA5 KIRIBURU 71.2 1.0 72.2GA6 BARBIL 80.5 1.0 81.5GA7 BARJAMDA 80.6 1.0 81.6
GA8LASARDAVILLAGE
62.2 1.0 63.2
GA9 SITALDIBURU 60.5 1.0 61.5GA10 GUA 79.1 1.5 80.6
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-18
25. Water requirement (m 3/day)
Sl.no Purpose Quantity, m3/day
1. Green belt, w ork shop& dust suppression 409
2.Beneficiation plant Makeup w ater @ 112m3/hr x
18 hrs/day2016
3. Domestic 75
Total 2500
*Treated domestic effluent and work shop water will be reused.
26. Source of water supply*
S. No. Source m 3/day
1 River (name) Koina River &Bore well - 2500
2 Ground w ater(fromBore Well w ithin ML area)
3 Mine w ater (sump / pit) NIL
4 Other surface w ater bodies (specify) NIL
[*Annex a copy of sanction letter / permission from the concerned authority (Central GroundWater Authority in case of ground water abstraction isfrom notified area / State Ground Water
Board in case of non-notified area / State Irrigation Department for surface water pumping) fordrawing water.]
The ML area is located in the “Safe” category zone. Application for NOC made. (ReferAnnexure – 12 & 13)
27. Lean season flow in case of pumping from river / nalla (cumecs)
28. Ground water potential of the study area
28.1. Ground water availability
(a) Range of w ater table (m bgl)
(i) Pre-monsoon
Core Zone
Buffer zone
(ii) Post-monsoon
Core Zone
Buffer zone
NA
------
7.5 m to 16.50 m
-----
0.42 m to 9.60 m
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-19
(b) Total annual replenishable recharge (million m3/ year) of the block
By ground w ater table fluctuation method
By rainfall inf iltration factor method
(c) Annual draft excluding estimated draft throughmine discharge (million m3/ year)
(d) Estimated draft through mine discharge (million m3/ year)
(e) Net annual ground w ater availability (million m3/ year)
(f) Stage of ground w ater development is %
28.2. Water demand
Detailsgiven in Para 3.6.5, Chapter – III & Para 4.3, Chapter - IV
S.
No.
Usage Present Consumption Additional proposed
as per local plan
Total
(MM3 per year)
Surface Ground Surface Ground Surface Ground
1 Domestic
2 Irrigation
3 Industry
4 Mining
5 Others
(specify)
Total
29. Water quality*
(a) Annex physico -chemical analysis of w ater at intake point **
The bore well water inside the mine lease area (GW1) is given in Table 3.15B, Chapter –III & Koina River (SW3) in Table 3.15A, Chapter - III
(b) In case of existing mine, annex report on quality of w ater dischargei.e. complete physico - chemical analysis**
The results of the 9 surface and ground water samplesare given in Table 3.15A& B, Chapter – III.
[*For non-discharging minesat least four ground water samples to be taken preferably fromdownstream direction of the mine in pre-monsoon and post-monsoon periodsand analysed.
For discharging mines six samples are to be analysed]
**All parameters as per BIS 10500. Indicate name of Methodology, Equipment used foranalysis, and Detection Level (DL) for each parameter.
4.81
13.34
13.318
8.53
36.05%
Nil
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-20
*** Wherever any analytical parameter isbelow detection level, “BDL” (Below Detection Level)should be written instead of ‘NIL’.
30. Impact on ground water regime / stream / lake / springs due to mine dewatering
The ground water table level isat 418m AM SL in the core zone. Ultimate depthof working of the mine will be 490 m above M SL. As such the mine workingswill notintersect ground water table and assuch, problemsof water seepage into mineworkingswill not occur
(a) Radius of influence (in m) - Not Applicable
[To be estimated based on analysis of pumpingtest data and application of empirical formula]
(b) Whether saline w ater ingress w ill take place? Yes No(applicable to coastal areas)
(c) Impact on stream / lake / springs – A detailed Hydrological investigationincluding pump test was conducted. Study detailsare given in para 3.6.5 Chapter – III& Para 4.3.6, Chapter – IV.
[* Prov ide a comprehensiv e hydro-geological assessment report i f the average mine
dewatering ismore than 100 m3/day and or going below water table in non-monsoon period.
The report should be based on preferably latest one year pre-monsoon and post-monsoon
baseline data covering information on ground water situation, aquifer characteristics, water
level conditions(April – May and November), estimate of ground water resources, predicted
impact of the project on ground water regime and detailed remedial / conservation measures
such as artificial recharge of ground water etc. The report should be based on actual field
inventory out of existing wells, at least 30 observation wells in the buffer zone with
supplementary information from secondary sources (mention name). For estimation** of
ground water resource (refer question no. 28 above) be designated study area of the buffer
zone may be sub-divided into command and non-command areas, watershed-wise (in case of
hard rock / consolidated formations) / block-wise / mandal-wise in case of alluvial /
unconsolidated formations)]
[**For estimating ground water resources in the area follow the Ground Water EstimationCommittee recommendations of 1997]
31. Waste Water Management
Mine
(a) Daily average discharge (m3/day) from different sources
(i) Mine w ater discharge during
Lean period
There will be no intersection of water table.
-
-
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-21
Monsoon period
(ii) Workshop
(iii) Domestic
(iv) Beneficiation / Washeries
(v) Coal Handling Plant
(vi) Tailings pond
(vii) Others (Specify)
Total
(b) Waste w ater treatment plant; f lowsheet for treatment process attached. Yes No
ETP diagram isgiven as Figure No - 4.3 & STP diagramisshown as Figure No 4.8.
45m3/day of domestic treated effluent will be used for green belt / plantation.
5m3/day of treated workshop effluent will be reused in the work shop.
(c) Quantity of w ater recycled / reused /to be recycled in
(i) Percentage 100%
(ii) m3 /day 50m3/day
(d) Point of f inal discharge :
Final Point Quantity discharged (in m3/day)
1. Surface(i) Agricultural land(ii) Waste land(iii) Forest land(iv) Green belt 45.0
2. River / nallah
3. Lake
4. Sea
5. Others (specify)
Total 45.0
-
45
50
5
Nil
Nil
Nil
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-22
(e) Users of discharge w ater
(i) Human Yes No
(ii) Livestock Yes No
(iii) Irrigation Yes No
(iv) Industry Yes No
(v) Others (specify)
(f) Details of the river / nalla, if f inal eff luent is / w ill be discharged (cumecs)
Not applicable as no effluent will be discharged outside
(i) Average flow rate
(ii) Lean season flow rate
(iii) Aquatic life
(iv) Analysis of river w ater 100 meters Yes Noupstream and 100 meters dow nstreamof discharge point submitted.
Township
(a) Waste w ater generation fromtow nship (m3/day)
(b) Are you planning to provide sew age Yes No
Treatment plant?
(c) Usage of treated w ater Yes No
Treated water will be used for Green belt / Plantation32. Attach water balance statement in the form of a flow diagram indicating
Source (s), consumption (Section-wise) and output.
Treated Work shop effluent willbe reused in the work shop
Nil
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-23
33. Ambient noise level LEq dB(A) : Details given in Para 3.3.4.5, Table No – 3.17
of EIA/EMP Report
Sl.No Locationcode
LocationDay Equivalent. Night Equivalent.
1. GN1 M INE SITE 46.4 41.6
2. GN2 SHADAL 43.0 40.9
3. GN3 TATIBA 49.1 40.2
4. GN4 BARAIBURI 50.0 40.6
5. GN5 KIRIBURU 43.7 40.3
6. GN6 BARBIL 51.4 41.8
7. GN7 BARJAM DA 51.9 41.5
8 GN8 LASARDA VILLAGE 48.2 38.3
9 GN9 SITALDIBURU 44.9 39.0
10 GN10 GUA 52.3 41.8
Norms: Residential: Day time 55 Leq. dB(A) , Night Time 45 Leq. dB(A)Industrial Ambient - Day time 75 Leq. dB(A) , Night Time 70 Leq. dB(A)
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-24
34. Solid Waste
(a) Top soil and Solid w aste quantity and quality
Name (Lump/fines/slurry/Sludge/others)
Composition Quantity(m
3/month)
Method of disposal
Mining activity*
a. Top Soil
b. Over burden
c. Others (specify)
There is no generation of waste during the course of miningoperation. However, there will be generation of 6% wastefrom the screening and crushing unit.About 1177608 MT or 452926.5038 cum. of waste sogenerated during plan period will be partly used for roadmaintenance, filling of low lying areas and balance quantityis proposed to be dumped within the ML area over an areaof 3.58 ha. Beyond plan period, out of the total waste of9733965 cum from the mine and plant, about 40% i.e.3893586 cum will be utilized for road construction andmaintenance. The remaining waste of the mine i.e. 5840379cu m, will be utilized for back filling over an area of 14 hafrom 6th year onwards. As such there will not be anyexternal waste dump in the conceptual stage.
Effluent Treatment Plant
(sludge)Almost Nil - -
Total
[* Annex layout plan indicating the dump sites.]
Location of dumpsare shown in Figure No – 2.5, Chapter - II.
(b) (i) Does w aste (s) contain anyhazardous/toxic substance/radioactive materials or Yes Noheavy metals?
(ii) If yes, w hether details and Yes Noprecautionary measuresprovided?
(c) Recovery and recycling possibilities. Can be used for refilling
(d) Possible user(s) of the solid w aste. In the post mining stage, theexternal dumps will berehandled and backfilledinto the mined out void.
(e) (i) Is the solid w aste suitable forbackfilling? Yes No
(ii) If yes, w hen do you proposeto start backfilling.
In the next scheme periodonly
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-25
(in million m3)Solid waste (s) Already
accumulated(A)
To be generated
(B)
% of A & B to be
backfil led
A B
Over burden Reply vide SL.No. 34 100%
Others (specify) - -
Land reclamation Plan
(f) In case w aste is to be dumped on the ground, indicate(i) Associated environmental problems
Detailsare given in Para 2.2.7, Chapter – II & Para 4.3.4, Chapter – IV
(ii) Number & type of w aste dumps
No. of external dumps
Max. projected height of dumps (in m)
No. of terraces and height of each stage
Overall slope of the dump (degree)
Proposed reclamation measures
(iii) Section of the w aste dump in relationto the adjacent ground profile attached. Yes No
Refer Figure No. 4.5, Chapter - IV35. Fuel / Energy requirements*
[*To be f urnished f or mines having ML area more than 25 ha. or captiv e power generation of 500KVA andabov e]
(a) Total pow er requirement (in MW)
S. No Mine Site Township Others(specify)
Total
1 Present 150 KVA - 150 KVA2 Proposed /
additional6000KVA - 6000KVA
Total 6000KVA 6000KVA
(b) Source of pow er (in MW)
S. No. SEB/Grid* Captiv e power plant DG Sets1 Present Yes No Emergency
purpose only2 Proposed Yes NoTotal Yes No
[* Annex a copy of the sanction letter from the concerned authority]
11
28°
Stabilisationof dumpswith coir matting,planttion,construction of retaining wall,garland drains around the dumps with
settling pods, check dams etc.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-26
(c) Details of fuelsS.No. Fuel Daily Consumption
(LPD)Calorific
v alue(Kcals/kg)
% Ash % Sulphur
Existing Proposed
1
2
3
HSD
LSHS
Other(specify)
2000
-
-
35000
-
-
10500
-
-
--
-
<.5%
-
-
36. Storage of inflammable / explosive materials
Adequate capacity will be created after expansion
S. No. Name Number ofStorages
Consumption(in TPD)
Maximum Quantity atany point of time
1 Fuels
2 Explosives
37. Human Settlement
Core Zone Buffer Zone
Population* - 156641
No. of vil lages - 56
Number of households
vil lage-wise- 34869
[* As per 2001 census record or actual survey]
As per 2001 census record
38. Rehabilitation & Resettlement (R&R) Plan* - Not Applicable[*Provide a comprehensive rehabilitation plan, if more than 1000 people are likely to bedisplaced, other-wise a summary plan]
(a) Villages falling w ithin the study area
Villages
Number Name
Core zone Nil --
500 m from the blasting site (s) Nil --
Buffer zone 56 Given in Table No – 3.1of EIA Report
Township site - -
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-27
(b) Details of village(s) in the core zone: Not ApplicableS.
No.
Village name Population* Average Annual
IncomeTribal Others
No Villages as the project is within the ML area
[*As per 2001 census / actual survey]
(c) Population to be displaced and / or Land oustees – Not Applicable.
Name of village(s) falling w ithin Number of oustees
Land(only)
Homestead(only)
Land andHomestead (both)
Mining Lease
Tow nship Site
(d) Whether R&R package has been finalised? Not ApplicableIf yes, salient features of R&R plan for oustees.
(i) Site details w here the people are proposed tobe resettled & facilities existing / to be created.
(ii) Funds earmarked for compensation package.
(iii) Agency /Authority responsible for theirresettlement.
(iv) Time of commencement of resettlementof Project Affected People (PAP).
(v) Period by w hich resettlement of PAP w illbe over.
39. Lease -wise plantationdetails
(a) Lease area (in ha.) Existing mine New mine
(i) Area broken up
(ii) To be broken up
(iii) Area not to be broken-up
(b) Tow nship area (in ha.)
-
-
-
- -
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-28
(c) Area afforested and proposed (in ha.)
Peripheral Dumps Roads Tow nship Others
(i) Existing - - - - -
(ii) Proposed - - - - 148.0413
(IncludesBackfilled & Reclaimedmine area, Sub grade / M ineral storage,
Infrastructure, Safety zone)
(d) No. and type of trees planted and proposed
(i) Existing
When plantation w as started? Month / Year
No.of plant species planted Number saplings (per ha.)
Survival rate % ● Avg. height
(ii) Proposed
No. of plant species to be planted Number of saplings (per ha.)
Region specific plantation will be carriedout as per suggestion of forest departmentofficials.
1600
40. Environmental health and safety
(a) What major health and safety hazards are anticipated?The main health hazards associated in the mining activity are:1. Respiratory problems due to air borne dust.2. Hearing loss due to noise level.
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-29
The safety hazards associated with the mining activity are :
1. Mishaps due to human errors.2. Fall from the heights.3. Operation of HEMM.
(b) What provisions have been made/proposed to bemade to conform to health and safety requirements?
Health:All the work men and staff are medically examined as per DGMS circular applicable tooccupational health. Air borne dust is suppressed by regular water sprinkling. Heavymachineries is provided with airtight AC cabins. Personal protective equipment like earmuff /plug, safety shoes, helmets, dust masks are provided as per provisions of Mines Act, 1952.
Periodical medical examination of all the employees are carried out as per the requirements ofMines Rules. Suitable medical care will be taken in case of detection of any abnormalities.
Safety:1. Personal protective equipment provided to the employees.2. Railings & pulley guards provided at places wherever required.3. All electric equipment are and will be provided with proper earthling.4. Regular training programme for the workers are and will be conducted.5. Safety audits and inspections are carried out.6. Safety committee and management meetings and are regularly conducted to review and
take actions for continual improvement in health & safety aspect.7. Implementing occupational, health & safety management system in accordance with BS
OHSAS 18001:2007.All the safety measures will be taken as per the Mines Act 1952 and rules & regulations madethere under(c) In case of an existing mine
(i) Comprehensive report on health statusof the w orkers as under the Mines Act annexed. Yes No
Refer Para – 4.8.1, Annexure - 23(ii) Mineralogical composition of RPM (dust) -
Free silica
Chromium* (Total as w ell as Hexavalent)
Lead**
[* Only for Chromite mines]
[**Only for Base Metal mines] Silica valuesare BDL (DL-0.05mg/m3)
(d) Information on radiation protection measures, if applicable. – Not applicable
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-30
41. Environmental Management Plan
Salient features of environmental protection measures
S.No.
Environmentalissues*
Already practiced, if applicable Proposed
1 Air pollution Regular water sprinkling with 3 nos.of 12 KL and 1 No of 7KL watertankersat mineral handling, mineraldispatch roads, mines haulage, etc. Providing dry-fog dust suppression atcrushing & screening plants. No overloading of trucks & ensuringthat all mineral dispatch trucks arecovered by tarpaulin.
Regular and proper preventivemaintenance schedules of machineryand emissions tests are done withdiesel smoke meter equipment toensure emission values.
Loading & unloading points areequipped with water sprinklingarrangement system.
Greenbelt in the mine area
Give vide Para4.2.1, Chapter - IV
2 Water pollution Construction of 5nos of check damsat strategic pointsinside the M L areato control the silt carry-over alongwith run-off into nearby water bodies
Construction of Retaining wall at thetoe of the existing dumps
3. Waterconservation
Site-specific rainwater harvestingmeasures with provisions of percolationpit cum check weir at the strategic points
4. Noise pollution M aking operators cabin sound proof,proper maintenance of equipments,provision of ear muffs to personnelworking in noise prone area, selection ofsilent DG Sets while procurement itself,plantation /Green belt development
5. Solid w aste /Tailings
Sloping of dump slopes, stabilizing thedump top and slopes, vegetation ofslopes with coir matting or plantation,construction of retaining walls with vent /weep holes, stone pitching of dumpslopes wherever necessary, proper
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-31
drainage arrangement with settlingponds, greenery development etc.
6. Landdegradation
Reclamation by back filling andafforestation of backfilled area and minebenches.
7. Erosion &Sediment
By proper stabilisation of dumps.
8. Top soil -
9. Ground vibration Use of non-electric detonators alongwith delays Controlled blasting techniques
Carrying out vibration studies andfollowing the recommendations ofblasting studies. Periodical vibrational monitoring.
10. Others (specify) Regular monitoring of environmentalparameters and implementation ofvarious environmental controlmeasures. Please refer Chapter-6, ofEIA/EM P report.As a commitment towards protection ofenvironment and providing soundenvironment management, proponentwill be implementing EnvironmentM anagement System (EM S) inaccordance with ISO 14001:2004.
[* As applicable]
42. Compliance withenvironmental safeguards (For existing units)
(a) Status of the compliance of conditions ofenvironmental clearance issued by MoEF, Yes Noif any, enclosed.(Refer Annexure – 5)
(b) Status of the compliance of ‘Consent toOperate’ issued by SPCB, if any, enclosed. Yes No
(Refer Annexure - 25)
(c) Latest 'environmental statement' enclosed. Yes No
(Refer Annexure - 26)
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-32
43. Scoping of EIA
Whether environmental impact assessmentof the project has been carried out by Yes Nofollow ing scoping process?
TOR issued by MOEFIf yes, a copy of scoping of EIA Yes Noannexed.
Refer Enclosure 1.1 at the end of chapter - I
44. Mine closure
(a) Have you planned mine closure? Yes No
Only progressive mine closure planned in the mining scheme. Final / Conceptual mineclosure will be planned one year prior to final closure of mine
(b) Submitted a conceptual mine Yes Noclosure plan.
(c) If yes, indicate estimated amount forimplementing the same (in Rs. lakhs)
45. Capital cost of the project (in Rs. Lakh)(Based on latest estimate) Rs. 9500 Lakhsfor M ines& 12000
Lakhsfor Beneficiationplant
46. Cost of environmental protection measures (in Rs. Lakh)
Already spent - Rs.86.63 Lakhs;Additional – Rs. 674.95 lakhs
Refer Table 6.2 of EIA report
47. Amount earmarkedfor socio-economicwelfare measures for the nearby villages spentother than R&R plans.
In the last 3 yearsRs.165.50 Lakhsis spentFor future activitiesneed based assessment with an estimate of Rs. 2852.72lakhsismade. Rs. 500 Lakhsper year will be spent in future.
48. Public Hearing
(a) Date of Advertisement
(b) New spapers in w hich the advertisement appeared
-
Hindusthan Timesin Englishand Dainik Jagaran in Hindi
18.01.2014
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-33
(c) Date of public hearing (DD/MM/YYYY)
(d) Public Hearing Panel chaired by & members present
(e)No. of people attended the public hearing meetingand number of people from the lease area.
(f) Summary/details of public hearing in tabular form. Enclosed as Annexure – 24and para 7.2.2 Chapter - VII
Issues raised by thePublic
Response/Commitment of ProjectProponents
Suggestions made by thePublic Hearing Panel
Given in Para 7.2.2, Chapter - VII
49. Whether the following approvals* (wherever applicable) have been obtained?
(i) Site clearance from MoEF Yes No
(TOR issued by MOEF which is enclosed in Chapter – 1 end)
(ii) ‘Consent for Establishment’ from the
State Pollution Control Board Yes No
Refer Annexure - 9
(iii) NOC from Atomic Mineral Division Yes No
(iv) Mining plan approval from IBM /
Ministry of Coal Yes No
(v) In case of existing mines, mining Yes No
scheme approval from IBM
Refer Annexure – 2
Shri Ajit Shankar, Additional Deputy Commissioner, West Singhbhum,
Shri Ram Narayan Choudhary, Regional Officer, SPCB, Jamshedpur,
and Shri Sanjaya Kumar Srivastav, Head office, SPCB, Ranchi
2000 people attended of which
about 28 persons expressed
their views
20.02.2014
PROFORMA FOR GHATKURI IRON ORE MINES (EXPANSION OF MINE CAPACITY FROM 0.403 MTPA TO10.0 MTPA (ROM) & SETTING UP OF 4.5 MTPA BENEFICIATION PLANT ALONG W ITH CRUSHING & SCREENING PLANT)
Creative Engineers & Consultants Q-34
(vi) Forestry clearance under FCA, 1980 Yes No
Refer Annexure – 6, 7 (Application)
(vii) NOC from Chief Controller of
Explosives Yes No
(viii) Commitment regarding availability /pumping of w ater fromthe concerned Yes NoAuthorities
Refer Annexure – 11 & 12 (Application)(ix) In case of ML area falling in notif ied areas
of the Central Ground Water Authority, Yes NoNOC from them.
[* Annex copiesof approvalsand number them]
50. Was / is there any court case relatingto the project or related activities? Yes No
I f so, provide details present status.
As the production of the mine was enhanced after 2003-04, without obtainingthe requisite environmental clearance, the complaint case has been filed in the courtof Chief Judicial M agistrate at West Singhbhum, Chaibasa on 13.06.2012 vide circlecase no C/7 C.C.140/2012 under Section 15 of E(P) Act.
Verificat ion: The data and information given in this proforma are true to the best of myknowledge and belief.
Date: Signature of the applicant* with
full name & address
Place: [* Owner or his authorized signatory]
Given under the seal of organisation onbehalf of whom the applicant is signing
�