tadiran lithium batteries product data catalogue
TRANSCRIPT
Tadiran Lithium BatteriesProduct Data Catalogue
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
2
Customized battery packsThe design and assembly of battery packs require special skills, expertise and experience. Therefore it is not recommended that the end user attempt to self-assemble battery packs. It is prefer-able that any battery using lithium cells be fabricated by Tadiran to ensure proper bat-tery design and construction (see figure 1). A full battery assembly service is available from Tadiran who can be con-tacted for further information. If for any reason, this is not possible, Tadiran can review the pack design in confidence to ensure that the design is safe (in assembly and use) and capable of meeting stated performance requirements.
Figure 1: Upon request, Tadiran designs, tests, and manufactures customized battery packs.
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
2
Product Line
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
3
Page Contents4 About Tadiran5 Lithium Thionyl Chloride (LTC) Batteries
Model Terminations Catalogue number1) Size Nominal voltage
Nominal capacity
Nominal current
Max. cont. dis-charge current
Temperature range
Dimensions (mm)
SL-300 series: for standard use and stand-by6 SL-350 /S /T /P /PR /PT 11 1 0350x 00 1/2AA 3.6 V 1.2 Ah 0.6 mA 6 mA −55 ... +85 °C Ø 14.5 x 257 SL-361 /S /T /P /PR /PT 11 1 0361x 00 2⁄3AA 3.6 V 1.6 Ah 1 mA 10 mA −55 ... +85 °C Ø 14.5 x 338 SL-360 /S /T /P /PR /PT 11 1 0360x 00 AA 3.6 V 2.4 Ah 2 mA 20 mA −55 ... +85 °C Ø 14.5 x 50
SL-500 series: for extended temperature range9 SL-550 /S /T /P /PR /PT 11 1 0550x 00 1/2AA 3.6 V 0.9 Ah 0.6 mA 50 mA −55 ... +130 °C Ø 14.5 x 25
10 SL-561 /S /T /P /PR /PT 11 1 0561x 00 2⁄3AA 3.6 V 1.1 Ah 1 mA 75 mA −55 ... +130 °C Ø 14.5 x 3311 SL-560 /S /T /P /PR /PT 11 1 0560x 00 AA 3.6 V 1.8 Ah 2 mA 100 mA −55 ... +130 °C Ø 14.5 x 50
SL-700 / SL-2700 series: for enhanced start12 SL-750 /S /T /P /PR /PT 11 1 0750x 00 1/2AA 3.6 V 1.1 Ah 1 mA 50 mA −55 ... +85 °C Ø 14.5 x 2513 SL-761 /S /T /P /PR /PT 11 1 0761x 00 2⁄3AA 3.6 V 1.5 Ah 1.3 mA 75 mA −55 ... +85 °C Ø 14.5 x 3314 SL-760 /S /T /P /PR /PT 11 1 0760x 00 AA 3.6 V 2.2 Ah 2 mA 100 mA −55 ... +85 °C Ø 14.5 x 5015 SL-2770 /S /T /P 11 2 1770x 00 C 3.6 V 8.5 Ah 3 mA 230 mA −55 ... +85 °C Ø 26 x 5016 SL-2780 /S /T /P 11 2 1780x 00 D 3.6 V 19 Ah 4 mA 340 mA −55 ... +85 °C Ø 33 x 6017 SL-2790 /S /T 11 2 1790x 00 DD 3.6 V 35 Ah 10 mA 450 mA −55 ... +85 °C Ø 33 x 12318 TL-2450 /P (with insolation) 11 1 13763 02 1⁄10C 3.6 V 0.55 Ah 0.5 mA 5 mA −55 ... +85 °C Ø 24 x 5.6
TL-2450 /P (without insolation) 11 1 13763 22 1⁄10C 3.6 V 0.55 Ah 0.5 mA 5 mA −55 ... +85 °C Ø 24 x 5.6SL-800 / SL-2800 series: XOL for extended operating life
19 SL-889 Solder pins 11 1 18894 00 1⁄10D 3.6 V 1 Ah 0.5 mA 10 mA −55 ... +85 °C Ø 33 x 620 SL-886 Solder pins 11 1 18864 00 1⁄6D 3.6 V 1.5 Ah 0.5 mA 10 mA −55 ... +85 °C Ø 33 x 1021 SL-850 /S /T /P /PR /PT 11 1 0850x 00 1/2AA 3.6 V 1.2 Ah 0.5 mA 20 mA −55 ... +85 °C Ø 14.5 x 2522 SL-861 /S /T /P /PR /PT 11 1 0861x 00 2⁄3AA 3.6 V 1.6 Ah 0.5 mA 30 mA −55 ... +85 °C Ø 14.5 x 3323 SL-860 /S /T /P /PR /PT 11 1 0860x 00 AA 3.6 V 2.4 Ah 1 mA 60 mA −55 ... +85 °C Ø 14.5 x 5024 SL-2870 /S /T /P 11 2 1870x 00 C 3.6 V 8.5 Ah 3 mA 75 mA −55 ... +85 °C Ø 26 x 5025 SL-2880 /S /T /P 11 2 1880x 00 D 3.6 V 19 Ah 4 mA 100 mA −55 ... +85 °C Ø 33 x 6026 PulsesPlus TM Batteries
Model Termination Catalogue number Configuration Nominal voltage
Nominal capacity
Max. pulse current2)
Dimensions(mm)Primary cell HLC
27 TLP-91111/A/SM Flying leads 17 91111 101 AA 1550 3.6 V 2.40 Ah 3 A 55 x 32 x 1628 TLP-91311/A/SM Pressure contacts 17 91311 101 AA 1520 3.6 V 2.40 Ah 1 A Ø 16.5 x 7528 TLP-91311/A/ST Solder tags 17 91311 102 AA 1520 3.6 V 2.40 Ah 1 A Ø 16.5 x 7529 TLP-92111/A/SM Flying leads 17 92111 101 C 1550 3.6 V 8.50 Ah 3 A 55 x 44 x 2830 TLP-92311/A/SM Flying leads 17 92311 101 C 1520 3.6 V 8.50 Ah 1 A Ø 29 x 6731 TLP-93111/A/SM Flying leads 17 93111 101 D 1550 3.6 V 19.0 Ah 3 A 64 x 50 x 3532 TLP-93311/A/SM Flying leads 17 93311 101 D 1520 3.6 V 19.0 Ah 1 A Ø 34 x 7833 TLP-96111/A/SM Flying leads 17 96111 101 1/2AA 1550 3.6 V 1.2 Ah 3 A 55 x 32 x 1634 TLP-96311/A/SM Pressure contacts 17 96311 101 1/2AA 1520 3.6 V 1.2 Ah 1 A Ø 16.5 x 5034 TLP-96311/A/ST Solder tags 17 96311 102 1/2AA 1520 3.6 V 1.2 Ah 1 A Ø 16.5 x 5035 TLP-97111/A/SM Flying leads 17 97111 101 2⁄3AA 1550 3.6 V 1.6 Ah 3 A 55 x 32 x 16 36 TLP-97311/A/SM Pressure contacts 17 97311 101 2⁄3AA 1520 3.6 V 1.6 Ah 1 A Ø 16.5 x 5836 TLP-97311/A/ST Solder tags 17 97311 102 2⁄3AA 1520 3.6 V 1.6 Ah 1 A Ø 16.5 x 5837 Hybrid Layer Capacitors (HLC) for use in PulsesPlus TM Batteries
Model Maximum charge voltage
Maximum charging current
Max. cont. discharge current
Max. pulse discharge current
Maximum capacity (3.67 V)
Maximum capacity (3.9 V)
Discharge end voltage
Cell impedance
Dimensions(mm)
38 HLC-1020 3.95 V 8 mA 0.25 A 0.75 A 12.5 mAh 20 mAh 2.5 V ≤ 400 mΩ Ø 10 x 2038 HLC-1020L 3.95 V 6 mA 0.15 A 0.5 A 8 mAh 12.5 mAh 2.5 V ≤ 600 mΩ Ø 10 x 2039 HLC-1520A 3.95 V 25 mA 0.5 A 2 A 39 mAh 58 mAh 2.5 V ≤ 250 mΩ Ø 15 x 2040 HLC-1530A 3.95 V 50 mA 0.75 A 3 A 70 mAh 105 mAh 2.5 V ≤ 140 mΩ Ø 15 x 2741 HLC-1550A 3.95 V 100 mA 2 A 5 A 155 mAh 236 mAh 2.5 V ≤ 100 mΩ Ø 15 x 50
46 Tadiran Lithium Ion (TLI) Batteries – RECHARGEABLEModel Max. charge
voltageMax. charging
currentMax. cont. dis-charge current
Max. pulse dis-charge current
Maximumcapacity
Endvoltage
Cellimpedance
Dimensions(mm)
47 TLI-1020A 4.1 V 8 mA 0.16 A 0.4 A 25 mAh 2.5 V ≤ 600 mΩ Ø 10 x 2048 TLI-1520A 4.1 V 25 mA 0.5 A 1.25 A 90 mAh 2.5 V ≤ 250 mΩ Ø 15 x 2049 TLI-1530A 4.1 V 50 mA 1 A 2.5 A 150 mAh 2.5 V ≤ 175 mΩ Ø 15 x 2750 TLI-1550A 4.1 V 100 mA 2 A 5 A 330 mAh 2.5 V ≤ 100 mΩ Ø 15 x 5051 Safety and Transport Regulations
1) complete catalogue number depends on termination; see product page 2) pulse duration 1 s to 3 V 3) after 10 years of storage at RT
Overview
42 Tadiran Lithium Metal Oxide (TLM) BatteriesModel Nominal
voltageMax. cont. dis-charge current
Max. pulse dis-charge current
Maximum capacity
End voltage
Cell impedance
Capacity retention3)
Dimensions(mm)
43 TLM-1520HPM 4.0 V 1.75 A 3.75 A 125 mAh 2.8 V ≤ 100 mΩ 89 % Ø 15 x 2044 TLM-1530HPM 4.0 V 3.2 A 6.8 A 225 mAh 2.8 V ≤ 100 mΩ 89 % Ø 15 x 2745 TLM-1550HPM 4.0 V 7 A 15 A 500 mAh 2.8 V ≤ 100 mΩ 89 % Ø 15 x 50
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
3
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
4
Tadiran Batteries GmbHTadiran Batteries GmbH is one of the leading manufacturers of primary (non rechargeable) lithium batteries in Europe.
The company was founded as a Joint Venture between Tadiran and Sonnenschein in 1984 and – under the name of Sonnenschein Lithium – has successfully served the market for more than 30 years.
Together with its parent com-pany Tadiran Batteries Ltd., the company is continuously improving its performance with regard to products, highest quality and customer service.
Tadiran Batteries Ltd. is fully owned by Saft groupe S.A. (Euronext: SAFT).
The main focus of the com-pany is to achieve a maximum customer satisfaction. Thus the guide line is to be the best in design-in, in full tech-nical support and logistics.
The company is committed to the world class philosophy. The management system is certified to ISO 9001 (Qual-ity) and – since 1999 – to ISO 14001 (Environment).
Tadiran Batteries GmbH em-ploys approx. 100 people and has its production facilities in Büdingen, close to Frankfurt, Germany.
The company is a leader in the development of lithium batteries for industrial use. Its Lithium Thionyl Chloride (LTC) technology is well estab-lished for more than 35 years. Tadiran LTC batteries are suitable where a 3.6 Volt high energy primary battery is re-quired for up to 25 years and more stand alone operation.
The PulsesPlus TM technology, providing high current pulses in combination with high energy, has been successfully introduced into the market and plays a significant role especially for long distance communication (e.g. GSM) modules.
The TLM technology has been developed for applications re-quiring high power discharge after a long storage time, e.g. as a back up battery for emer-gency call devices in automo-tive telematic systems.
The RECHARGEABLE TLI series is specifically designed for long-term use in harsh environments and repre-sents an important break-through in lithium-ion battery technology.
Customer benefitsTadiran has focused its on-going efforts on promoting the understanding and further development of lithium bat-teries. This determination of-fers to the customer a number of decisive benefits such as:
Access to over 40 years of experience in research and development, production and marketing Adaptability and reliability in meeting rapidly evolving customer needs Detailed technical support in terms of design and ap-plication – before, during and after the purchase Highly qualified experts available for support on short notice Customized production of single- and multi-cell batteries to meet specific requirements Reliable delivery, secured by contractual agreements and second sourcing.
For successful use of a battery, the co-operation between the supplier and the customer must commence at the earliest possible point: at times it is simply more economical to design a circuit for the characteristics of the best suitable energy supply, rather than having to forgo its advantages because it is too late for changes.
EnvironmentThe European Battery Direc-tive 2006/66/EC restricts the use of certain hazardous substances in batteries and establishes rules for the col-lection, treatment, recycling and disposal of waste bat-teries and accumulators. It is transposed individually in each EU member state.
The following information is important for end users of batteries:
Batteries are marked with the crossed-out wheeled bin symbol.
The symbol reminds end users that batteries must not be disposed as municipal waste, but collected separately. Used batteries can be returned at the point of sale at no charge.
The reason for these regula-tions is that there are a num-ber of environmental concerns which arise when dealing with the waste management of batteries and accumulators. These relate for the most part to the metals contained in these batteries. Mercury, lead and cadmium are by far the most problematic substances in the battery waste stream. Other metals commonly used in batteries, such as zinc, cop-per, manganese, lithium and nickel, may also constitute environmental hazards.
However, the regulations apply to all batteries and not just to hazardous ones because all batteries contain substances which are more or less harmful to the environ-ment and because experience with previous regulations showed that ‘all battery’ col-lection schemes are more ef-ficient than separate schemes for certain types of portable batteries.
Batteries should be recycled because battery recycling helps to save resources by allowing for the recovery of valuable metals such as nickel, cobalt and silver and requires less energy consump-tion. For example, using recycled cadmium and nickel requires respectively 46 % and 75 % less primary energy than the extraction and refin-ing of virgin metals.
This information is based on the ‘Q&A on the Batteries Directive 2006/66/EC’ docu-ment and was downloaded from the European Commis-sion website.
A Technical Notice is available upon request with details on the disposal service offered by Tadiran.
About Tadiran
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
4
Lithium Thionyl Chloride (LTC) Batteries
4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0 400300200100Ah / dm3
6
5
4
3
2
1
Positive terminalPlastic coverWelding seamCell coverGlass-to-metal sealInsulatorCurrent collectorLithium anodeCathodeSeparatorInsulating sleeveCell canNegative terminal
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
5
IntroductionThe Lithium Thionyl Chloride (LTC) battery The Tadiran lithium thionyl chloride inorganic electrolyte battery is a power source that is suited to the requirements of the new generation in microelectronics. For example, CMOS memories as well as utility meters require a light-weight power source to pro-vide a safe and reliable per-formance over a wide range of environmental conditions, for long periods of time.
The Tadiran lithium battery is a component that can be permanently connected to a circuit and, in many cases, will last the entire lifetime of the equipment.
Battery characteristicsThe major advantages of the Tadiran lithium battery are:
High cell voltageThe battery has a nominal voltage of 3.6 Volts, which is considerably higher than any other commercially available primary cell.
Wide temperature range The batteries are capable of operating in a wide tem-perature range normally from −55 °C to +85 °C. One series, however, has an extended temperature range of up to +130 °C.
High energy density The electrochemical system offers the highest energy den-sity of any available primary battery: up to ~650 Wh / kg and ~1280 Wh / dm3 (see figure 2).
Superior shelf life and reliability The Tadiran lithium battery has an outstandingly long shelf life. Tests have shown that storage for ten years at room tempera-ture results in a capacity loss of less than 1 % per year.
Tadiran lithium batteries are also extremely reliable. Fail-ure rates in memory back-up applications were found to be below 200 fit (fit: Failures in Time. 1 fit = 1 failure in 109 component hours).
Safe design The battery’s design has a major influence on its safety characteristics (see figure 1).
In the bobbin version, the cathode is cylindrical in shape. The anode is swaged against the inner wall of the battery case. This offers several advantages in terms of safety. In the event of an unintentional short-circuit, the discharge currents do not become very strong. The heat generated, primarily at the contact surface between the anode and cathode, can easily be channelled to the outside. This design leads to a safe battery that needs no additional rupture vent.
In the flat battery versions, the anode is pressed onto the bottom of the case, and the cathode is disk-shaped. Flat batteries are wider than they are high. They are just as safe as the bobbin type batteries.
Hermetically sealed caseThe hermetically sealed case is essential for the long shelf life and inherent safety of the devices in which the batteries are used. The cover is welded to the can. A glass-to-metal seal is used to insulate the positive terminal. The chemical reactionThe battery consists of a lith-ium (Li) anode, a carbon (C) cathode, and a non-aqueous electrolyte (a solution of lith-ium tetra-chloroaluminate in thionyl chloride). This solution performs a dual task: as the electrolyte for ion transport, and as an active depolarizer.
The Teflon™-bonded carbon cathode serves as a catalyst for cathodic reduction.
The generally accepted reaction mechanisms are as follows:
Anodic reaction: 4 Li → 4 Li+ + 4 e−
Cathodic reaction: 2 SOCl2 + 4 e− → SO2 + S + 4 Cl−
Overall reaction: 4 Li + 2 SOCl2 → S + 4 LiCl + SO2
Most of the sulphur dioxide generated during discharge dissolves in the electrolyte, preventing pressure build-up within the battery. Long-term behaviourThe long shelf life of the Tadiran lithium batteries is a result of the fact that a thin protective layer of LiCl forms on the anode as soon as the lithium first comes into con-tact with the electrolyte. This layer prevents further reaction or loss of capacity on stand. The problem of anode cor-rosion, as occurs in aqueous systems, is thus eliminated.
On the other hand, the protec-tive layer on the anode may cause a delay in the voltage build-up if relatively high loads are applied, or after extended storage at elevated temperatures. This voltage delay is not experienced at all in microampere applica-tions, such as in typical CMOS circuits.
Features and attributes of the various seriesSL-300 series Keywords: standard use and stand-by
Excellent shelf life (10 years) Extremely low self-discharge (1 % or less per year) Suited for long-term use with low current For operation at low current levels with long stands Intermittent discharge with medium current level provided the average is not below the active current level (2 µA / cm² anode surface area) Temperature range from −55 °C to +85 °C
SL-500 series Keywords: extended tempera-ture range
Extension of temperature range up to +130 °C Somewhat smaller capacity Otherwise like the SL-700 series
SL-700 series Keywords: for enhanced start
Major improvement of voltage delay (TMV) at the start of discharge at medium current levels
Intermittent discharge at medium current levels Best results if used after no more than 3 years of storage Otherwise like the SL-300 series
SL-2700 series (iXtra) Keywords: for fast voltage re-covery after long term storage and/or use
Higher voltage under pulse load even with low background currents Improved voltage delay behaviour at ambient and elevated temperatures Fast voltage recovery after long term storage More capacity Higher discharge rate No orientation effect
SL-800/2800 series (XOL)Keywords: for eXtended operation life
More capacity Extra low self discharge Extra low passivation during long term use
Figure 2:Comparison of different battery systems. The curves represent typical best values of commercial cylindrical cells when discharged at +25 °C at the 1000 hour rate. The area under the curves corresponds to the energy density listed below. 1 Li/SOCl2 1280 Wh / dm3
2 Li/SO2 430 Wh / dm3
3 Li/CFx 550 Wh / dm3 4 Li/MnO2 580 Wh / dm3 5 Li/FeS2 450 Wh / dm3 6 Alkaline 280 Wh / dm3
Figure 1: Cross sectional view of a ½AA size cell (bobbin-design)
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
5
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1
2
3
4
5
1:2:3:4:5:
6 mA2 mA
0.6 mA0.2 mA
0.02 mA
1
2
3
45
Operating Voltage
Temperature / °C
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
1:2:3:4:5:6:7:
560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
180 kΩ560 kΩ
~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA~0.02 mA
~0.006 mA
0.90 Ah1.10 Ah1.20 Ah1.15 Ah1.05 Ah0.95 Ah0.85 Ah
1 2 3 4 5 6 7
Ø 4.2
0.15 thick
0.2 thick
1–0.1
4+0.
5
3.5
0.2 thick
1–0.1 10.16
4+0.
5
3.5
45 45
3.17
Ø 14.7–1.2
Ø 0
.8
Ø 0
.8
25.2
–1.2
0.7±
0.3
7±0.5
+0.2−0.3
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
6
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-350 Size: 1/2AA
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.2 Ah
Nominal current 0.6 mA
Max. continuous discharge current 6 mA
Anode surface area 6 cm2
Lithium content 0.35 g
Weight 9.6 g
Volume 4 cm3
Temperature range −55 °C ... +85 °C
› Standard use and stand-by
Available Terminations Catalogue No.SL-350/S Standard 11 1 03501 00
SL-350/T Tags 11 1 03502 00
SL-350/P Pins 11 1 03503 00
SL-350/PR Pins radial 11 1 03506 00
SL-350/PT Polarized tags 11 1 03508 00
SL-350/S SL-350/T
SL-350/P
SL-350/PTSL-350/PR
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
6
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Operating Voltage
Temperature / °C
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:4:5:6:
10 mA3 mA1 mA
0.3 mA0.1 mA
0.01 mA
1
2
3
45
6
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
5 61 2 3 4 7
1:2:3:4:5:6:7:
330 Ω1.0 kΩ3.3 kΩ10 kΩ33 kΩ
100 kΩ330 kΩ
~10 mA~3 mA~1 mA
~0.3 mA~0.1 mA
~0.03 mA~0.01 mA
1.00 Ah1.35 Ah1.60 Ah1.60 Ah1.50 Ah1.35 Ah1.10 Ah
1.6
1.4
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
1
2
3
45
+
4545
3.5
3.5
Ø 0
.8
Ø 0
.8Ø 14.7−1.2
7±0.5
0.7±
0.3
33.5
−1.
5
1−0.1 1−0.1
4+0.
5
4+0.
5
3.17
0.15 thick
0.2 thick
10.16
0.2 thick
Ø 4.2−0.3+0.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
7
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-361 Size: 2⁄3AA › Standard use and stand-by
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.6 Ah
Nominal current 1 mA
Max. continuous discharge current 10 mA
Anode surface area 9 cm2
Lithium content 0.5 g
Weight 12.5 g
Volume 5.2 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-361/S Standard 11 1 03611 00
SL-361/T Tags 11 1 03612 00
SL-361/P Pins 11 1 03613 00
SL-361/PR Pins radial 11 1 03616 00
SL-361/PT Polarized tags 11 1 03618 00
SL-361/S SL-361/T
SL-361/P
SL-361/PTSL-361/PR
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
7
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
2.5
2.0
1.5
1.0
0.5
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1
2
3 4
5
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Operating Voltage
Temperature / °C
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:4:5:
20 mA6 mA2 mA
0.2 mA0.02 mA
4
5
3
2
1
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
1 2 3 4 5 6 7
1:2:3:4:5:6:7:
180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
180 kΩ
~20 mA~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA~0.02 mA
1.5 Ah2.1 Ah2.4 Ah2.4 Ah2.3 Ah2.1 Ah1.9 Ah
+
4545
Ø 0
.8
Ø 0
.8
50.5
−1.
5
1−0.1 1−0.1
3.17
0.15 thick
0.2 thick0.2 thick
Ø 4.2−0.3+0.2
0.7±
0.3
7±0.5
3.5
3.5
10.16
4+0,
5
4+0,
5
Ø 14.7–1.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
8
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-360 Size: AA
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 2.4 Ah
Nominal current 2 mA
Max. continuous discharge current 20 mA
Anode surface area 14 cm2
Lithium content 0.65 g
Weight 18 g
Volume 8 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-360/S Standard 11 1 03601 00
SL-360/T Tags 11 1 03602 00
SL-360/P Pins 11 1 03603 00
SL-360/PR Pins radial 11 1 03606 00
SL-360/PT Polarized tags 11 1 03608 00
SL-360/S SL-360/T
SL-360/P
SL-360/PTSL-360/PR
› Standard use and stand-by
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
8
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Ø 4.2
0.15 thick
0.2 thick
1–0.1
4+0.
5
3.5
0.2 thick
1–0.1 10.16
4+0.
5
3.5
45 45
3.17
Ø 14.7–1.2
Ø 0
.8
Ø 0
.8
25.2
–1.2
0.7±
0.3
7±0.5
+0.2−0.3
1: 6 mA2: 2 mA3: 0.6 mA4: 0.06 mA5: 0.006 mA
4
5
3
2
1
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
115
130
145
Temperature / °C
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
1:2:3:4:5:6:7:
180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
180 kΩ
~20 mA~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA~0.02 mA
0.50 Ah0.80 Ah0.85 Ah0.90 Ah0.85 Ah0.80 Ah0.70 Ah
654321 7
3 4 5 6
2
1
7
Volt
s
2
3
4
0 2 4 6 s 10
1010.10.01 100 1000
Available Capacity1.2
1.0
0.8
0.6
0.4
0.2
0.0
Current / mA
Capa
city
to
2 Vo
lts
/ Ah
123
4
5
61: +120 °C2: +80 °C3: +50 °C4: +25 °C5: 0 °C6: –30 °C
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
9
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 150 °C, incinerate, or expose contents to water.
SL-550 Size: 1/2AA
Available Terminations Catalogue No.SL-550/S Standard 11 1 05501 00
SL-550/T Tags 11 1 05502 00
SL-550/P Pins 11 1 05503 00
SL-550/PR Pins radial 11 1 05506 00
SL-550/PT Polarized tags 11 1 05508 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 0.9 Ah
Nominal current 0.6 mA
Max. continuous discharge current 50 mA
Pulse current capability 100 mA
Anode surface area 6 cm2
Lithium content 0.35 g
Weight 9.6 g
Volume 4 cm3
Temperature range −55 °C ... +130 °C
SL-550/S SL-550/T
SL-550/P
SL-550/PTSL-550/PR
› Extended temperature range › iXtra – long term high performance
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
9
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
1: 10 mA2: 3 mA3: 1 mA4: 0.1 mA5: 0.01 mA
4
5
3
2
1
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
115
130
145
Temperature / °C
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
1:2:3:4:5:6:7:
100 Ω330 Ω
1 kΩ3.3 kΩ10 kΩ33 kΩ
100 kΩ
~30 mA~10 mA
~3 mA~1 mA
~0.3 mA~0.1 mA
~0.03 mA
0.60 Ah0.80 Ah1.00 Ah1.10 Ah1.10 Ah1.00 Ah0.85 Ah
1 2 3 4 5 6 7
2
3
4
Volt
s
0 2 4 6 s 10
1
23 4 5 6 7
+
4545
3.5
3.5
Ø 0
.8
Ø 0
.8Ø 14.7−1.2
7±0.5
0.7±
0.3
33.5
−1.
5
1−0.1 1−0.1
4+0.
5
4+0.
5
3.17
0.15 thick
0.2 thick
10.16
0.2 thick
Ø 4.2−0.3+0.2
0.0
0.2
0.4
0.6
0.8
1.0
1.2
1.4
1.6
1010.1 000100110.0
2: 80 °C3: 50 °C4: 25 °C
120 °C
5: –30 °C
1:
Available Capacity
Capa
city
to
2 Vo
lts
/ Ah
Current / mA
3
2
14
5
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
10
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 150 °C, incinerate, or expose contents to water.
SL-561 Size: 2⁄3AA
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.1 Ah
Nominal current 1 mA
Max. continuous discharge current 75 mA
Pulse current capability 150 mA
Anode surface area 9 cm2
Lithium content 0.5 g
Weight 12.5 g
Volume 5.2 cm3
Temperature range −55 °C ... +130 °C
Available Terminations Catalogue No.SL-561/S Standard 11 1 05611 00
SL-561/T Tags 11 1 05612 00
SL-561/P Pins 11 1 05613 00
SL-561/PR Pins radial 11 1 05616 00
SL-561/PT Polarized tags 11 1 05618 00
› Extended temperature range › iXtra – long term high performance
SL-561/S SL-561/T
SL-561/P
SL-561/PTSL-561/PR
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
10
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
1: 20 mA2: 6 mA3: 2 mA4: 0.2 mA5: 0.02 mA
4
5
3
2
1
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
115
130
145
Temperature / °C
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
1:2:3:4:5:6:7:
56 Ω180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
~60 mA~20 mA
~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA
1.40 Ah1.60 Ah1.70 Ah1.80 Ah1.70 Ah1.60 Ah1.40 Ah
1 2 3 4 5 6 7
2
3
4
Volt
s
0 2 4 6 s 10
1
23 4 5 6 7
0
0.5
1.0
1.5
2.0
2.5
1010.1 000100110.0
2: 80 °C3: 50 °C4: 25 °C
120 °C
5: –30 °C
1:
Available Capacity
Capa
city
to
2 Vo
lts
/ Ah
Current / mA
5
4
3
2
1
+
4545
Ø 0
.8
Ø 0
.8
50.5
−1.
5
1−0.1 1−0.1
3.17
0.15 thick
0.2 thick0.2 thick
Ø 4.2−0.3+0.2
0.7±
0.3
7±0.5
3.5
3.5
10.16
4+0,
5
4+0,
5
Ø 14.7–1.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
11
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 150 °C, incinerate, or expose contents to water.
SL-560 Size: AA
Available Terminations Catalogue No.SL-560/S Standard 11 1 05601 00
SL-560/T Tags 11 1 05602 00
SL-560/P Pins 11 1 05603 00
SL-560/PR Pins radial 11 1 05606 00
SL-560/PT Polarized tags 11 1 05608 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.8 Ah
Nominal current 2 mA
Max. continuous discharge current 100 mA
Pulse current capability 200 mA
Anode surface area 14 cm2
Lithium content 0.65 g
Weight 18 g
Volume 8 cm3
Temperature range −55 °C ... +130 °C
› Extended temperature range › iXtra – long term high performance
SL-560/S SL-560/T
SL-560/P
SL-560/PTSL-560/PR
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
11
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
1010.10.01 100 1000
1
4
3
2
Available Capacity1.2
1.0
0.8
0.6
0.4
0.2
0.0
Current / mA
Capa
city
to
2 Vo
lts
/ Ah
1:2:3:4:
+72 °C+55 °C+25 °C−30 °C
4
5
3
2
1
Operating Voltage
1:2:3:4:5:
6 mA2 mA
0.6 mA0.06 mA
0.006 mA
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Temperature / °C
Volt
age
/ V
−50 −35 −20 −5 10 25 40 55 70 85 100
64
21 5
3
12
41
6
Voltage Response at +25 °C, Pulse: 10 mA
Basic current (bc)None 5 µA 10 µA
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Volt
age
/ V
0 0.1 0 0.1 0 0.10.2
1: after 1 year at bc2: after 2 years at bc3: after 4 years at bc
4: after 5 years at bc5: after 7 years at bc6: after 10 years at bc
Time / s
20 2 4 6 s 10
3
4
3 4 5 6
2
1
7
Time / h
Volt
age
/ V
654321 7
Typical Discharge Curves at +25 °C
180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
180 kΩ
~20 mA~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA~0.02 mA
0.5 Ah1.0 Ah1.1 Ah1.1 Ah1.1 Ah
1.05 Ah0.95 Ah
1:2:3:4:5:6:7:
4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.00.1 1 10 102 103 104 105
Volt
sØ 4.2
0.15 thick
0.2 thick
1–0.1
4+0.
5
3.5
0.2 thick
1–0.1 10.16
4+0.
5
3.5
45 45
3.17
Ø 14.7–1.2
Ø 0
.8
Ø 0
.8
25.2
–1.2
0.7±
0.3
7±0.5
+0.2−0.3
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
12
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-750/S SL-750/T
SL-750/P
SL-750/PTSL-750/PR
SL-750 Size: 1/2AA › iXtra – long term high performance
Available Terminations Catalogue No.SL-750/S Standard 11 1 07501 00
SL-750/T Tags 11 1 07502 00
SL-750/P Pins 11 1 07503 00
SL-750/PR Pins radial 11 1 07506 00
SL-750/PT Polarized tags 11 1 07508 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.1 Ah
Nominal current 1 mA
Max. continuous discharge current 50 mA
Pulse current capability 100 mA
Anode surface area 6 cm2
Lithium content 0.35 g
Weight 9.6 g
Volume 4 cm3
Temperature range −55 °C ... +85 °C
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
12
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
1:2:3:4:5:6:7:
100 Ω330 Ω1.0 kΩ3.3 kΩ10 kΩ33 kΩ
100 kΩ
~30 mA~10 mA
~3 mA~1 mA
~0.3 mA~0.1 mA
~0.03 mA
0.80 Ah1.35 Ah1.50 Ah1.50 Ah1.50 Ah1.45 Ah1.30 Ah
1 2 3 4 5 6 7
2
3
4
Volt
s
0 2 4 6 s 10
1
23 4 5 6 7
1.6
1.4
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:
+72 °C+55 °C+25 °C−30 °C
1
2
3
4
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1:2:3:4:5:
10 mA3 mA1 mA
0.1 mA0.01 mA
1
2
3
4
5
Voltage Response at +25 °C, Pulse: 15 mA
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Time / s
64
21 4
6
0 0 00.1 0.1 0.10.2
1: after 1 year at bc2: after 2 years at bc
4: after 5 years at bc5: after 7 years at bc6: after 10 years at bc
Basic current (bc)None 7.5 µA 15 µA
1 4
12
5
+
4545
3.5
3.5
Ø 0
.8
Ø 0
.8Ø 14.7−1.2
7±0.5
0.7±
0.3
33.5
−1.
5
1−0.1 1−0.1
4+0.
5
4+0.
5
3.17
0.15 thick
0.2 thick
10.16
0.2 thick
Ø 4.2−0.3+0.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
13
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-761 Size: 2⁄3AA
Available Terminations Catalogue No.SL-761/S Standard 11 1 07611 00
SL-761/T Tags 11 1 07612 00
SL-761/P Pins 11 1 07613 00
SL-761/PR Pins radial 11 1 07616 00
SL-761/PT Polarized tags 11 1 07618 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.5 Ah
Nominal current 1.3 mA
Max. continuous discharge current 75 mA
Pulse current capability 150 mA
Anode surface area 9 cm2
Lithium content 0.5 g
Weight 12.5 g
Volume 5.2 cm3
Temperature range −55 °C ... +85 °C
SL-761/S SL-761/T
SL-761/P
SL-761/PTSL-761/PR
› iXtra – long term high performance
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
13
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
2.5
2.0
1.5
1.0
0.5
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:
+72 °C+55 °C+25 °C−30 °C
43
2
1
Operating Voltage
Temperature / °C
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:4:5:
20 mA6 mA2 mA
0.2 mA0.02 mA
4
5
3
2
1
Voltage Response at +25 °C, Pulse: 20 mA
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Time / s0 0 00.1 0.1 0.10.2
1: after 1 years at bc2: after 2 years at bc
4: after 5 years at bc5: after 7 years at bc6: after 10 years at bc
Basic current (bc)None 10 µA 20 µA
64
21 5
4
12
41
6
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
0 2 4 6 s 10
1:2:3:4:5:6:7:
56 Ω180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
~60 mA~20 mA
~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA
1.4 Ah1.8 Ah2.1 Ah2.2 Ah2.2 Ah2.2 Ah2.0 Ah
1 2 3 4 5 6 7
2
3
4
Volt
s
23 4 5 6 7
1
+
4545
Ø 0
.8
Ø 0
.8
50.5
−1.
5
1−0.1 1−0.1
3.17
0.15 thick
0.2 thick0.2 thick
Ø 4.2−0.3+0.2
0.7±
0.3
7±0.5
3.5
3.5
10.16
4+0,
5
4+0,
5
Ø 14.7–1.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
14
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-760 Size: AA
Available Terminations Catalogue No.SL-760/S Standard 11 1 07601 00
SL-760/T Tags 11 1 07602 00
SL-760/P Pins 11 1 07603 00
SL-760/PR Pins radial 11 1 07606 00
SL-760/PT Polarized tags 11 1 07608 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 2.2 Ah
Nominal current 2 mA
Max. continuous discharge current 100 mA
Pulse current capability 200 mA
Anode surface area 14 cm2
Lithium content 0.65 g
Weight 18 g
Volume 8 cm3
Temperature range −55 °C ... +85 °C
SL-760/S SL-760/T
SL-760/P
SL-760/PTSL-760/PR
› iXtra – long term high performance
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
14
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321 7
3 4 5 6
2
1
7
Volt
s
2
3
4
0 2 4 6 s 10
1:2:3:4:5:6:7:
33 Ω100 Ω330 Ω1.0 kΩ3.3 kΩ 10 kΩ33 kΩ
~100 mA~30 mA~10 mA
~3 mA~1 mA
~0.3 mA~0.1 mA
2.2 Ah5.8 Ah7.9 Ah8.5 Ah8.4 Ah7.8 Ah6.9 Ah
10
8
6
4
2
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
1
2
3
4
5
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1
2
3
456
7
1:2:3:4:5:6:7:
60 mA30 mA10 mA
3 mA1 mA
0.3 mA0.1 mA
Voltage Response at +25 °C, Pulse: 40 mA
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Time / s0 0 00.1 0.1 0.10.2
1: after 2 years at bc2: after 5 years at bc
3: after 8 years at bc4: after 10 years at bc
Basic current (bc)None 25 µA 45 µA
1
2
3
4
3
2
1
3
21
50.0
−2
0.7±
0.3
Ø 26.2−1
Ø 4.2−0.3+0.2
Ø 0
.8
Ø 0
.8
45 45
0.15 thick
3.17
16−2+1
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
15
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-2770 Size: C
Available Terminations Catalogue No.SL-2770/S Standard 11 2 17701 00
SL-2770/T Tags 11 2 17702 00
SL-2770/P Pins 11 2 17703 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 8.5 Ah
Nominal current 3 mA
Max. continuous discharge current 230 mA
Pulse current capability 400 mA
Anode surface area 30 cm2
Lithium content 2.5 g
Weight 49.5 g
Volume 26 cm3
Temperature range −55 °C ... +85 °C
› iXtra – long term high performance
SL-2770/S
SL-2770/P
SL-2770/T
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
15
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
20
15
10
5
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
5
4
3
2
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
7 6 5 43
2
11:2:3:4:5:6:7:
100 mA60 mA20 mA
6 mA2 mA
0.6 mA0.2 mA
Voltage Response at +25 °C, Pulse: 60 mA
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Time / s0 0 00.1 0.1 0.10.2
4
3
2
1
4
3
2
1
3
2
1
1: after 2 years at bc2: after 5 years at bc
3: after 8 years at bc4: after 10 years at bc
Basic current (bc)None 50 µA 100 µA
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321 7
3 4 5 6
2
1
7
Volt
s
2
3
4
0 2 4 6 s 10
1:2:3:4:5:6:7:
33 Ω56 Ω
180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ
~100 mA~60 mA~20 mA
~6 mA~2 mA
~0.6 mA~0.2 mA
9.0 Ah13.1 Ah16.9 Ah18.7 Ah18.6 Ah17.2 Ah15.4 Ah
45 45
Ø 0
.8
Ø 0
.8
+
3.17
0.15 thick
0.7±
0.3
Ø 4.2−0.3+0.2
12−2+1
Ø 32.9−0.7
61.5
−2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
16
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-2780 Size: D
SL-2780/S
SL-2780/P
SL-2780/T
Available Terminations Catalogue No.SL-2780/S Standard 11 2 17801 00
SL-2780/T Tags 11 2 17802 00
SL-2780/P Pins 11 2 17803 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 19 Ah
Nominal current 4 mA
Max. continuous discharge current 340 mA
Pulse current capability 600 mA
Anode surface area 45 cm2
Lithium content 5 g
Weight 93 g
Volume 51 cm3
Temperature range −55 °C ... +85 °C
› iXtra – long term high performance
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
16
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Available Capacity40
35
30
25
20
15
10
5
00.01 0.1 1 10 100 1000
Current / mA
Capa
city
to
2 Vo
lts
/ Ah
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
3
4
5
2
1
Operating Voltage3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Temperature / °C
Volt
age
/ V
−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:4:5:6:7:
300 mA100 mA
30 mA10 mA
3 mA1 mA
0.3 mA
1
23
4567
Voltage Response at +25 °C, Pulse: 120 mA3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
Volt
age
/ V
0 0.1 0 0.1 0 0.10.2Time / s
Basic current (bc)
None 100 µA 200 µA
1: after 2 years at bc2: after 5 years at bc
3: after 8 years at bc4: after 10 years at bc
111
2
2
2
33
3
4
4
654321 7
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.00.1 1 10 102 103 104 105
Time / h
Volt
age
/ V
1:2:3:4:5:6:7:
10 Ω33 Ω
100 Ω330 Ω1.0 kΩ3.3 kΩ10 kΩ
~300 mA~100 mA
~30 mA~10 mA
~3 mA~1 mA
~0.3 mA
20.2 Ah28.7 Ah33.4 Ah35.0 Ah32.5 Ah30.2 Ah27.5 Ah
Ø 32.9−0.7
123.
5±1
0.7±
0.3
12−2 +1
3.17
0.15 thick
Ø 4.2+0.2−0.3
Ø 32.9−0.7
123.
5±1
0.7±
0.3
12−2 +1
3.17
0.15 thick
Ø 4.2+0.2−0.3
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
17
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-2790 Size: DD
Available Terminations Catalogue No.SL-2790/S Standard 11 2 17901 00
SL-2790/T Tags 11 2 17902 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 35 Ah
Nominal current 10 mA
Max. continuous discharge current 450 mA
Pulse current capability 1000 mA
Anode surface area 90 cm2
Lithium content 10 g
Weight 190 g
Volume 105 cm3
Temperature range −55 °C ... +85 °C
SL-2790/S
SL-2790/T
› iXtra – long term high performance
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
17
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
0.6
0.5
0.4
0.3
0.2
0.1
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+80 °C+50 °C+25 °C
0 °C−30 °C
5
4
3 2
1
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1
2
3
1:2:3:
2 mA0.2 mA
0.02 mA
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321
2 3 4 5
1
6
1:2:3:4:5:6:
3.3 kΩ10 kΩ33 kΩ
100 kΩ330 kΩ
1000 kΩ
~1 mA~0.3 mA~0.1 mA
~0.03 mA~0.01 mA
~0.003 mA
0.53 Ah0.55 Ah0.54 Ah0.50 Ah0.45 Ah0.42 Ah
2
3
4
Volt
s
0 2 4 6 s 10
Ø 24.0 +0.5 max.
7.62Ø 0.785
6±0.
2
10.6
max
.
(−) (+)
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
18
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
TL-2450 Size: 1⁄10C
Available Terminations Catalogue No.TL-2450/P Pins (with insolation disc) 11 1 13763 02
TL-2450/P Pins (without insolation disc) 11 1 13763 22
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 0.55 Ah
Nominal current 0.5 mA
Max. continuous discharge current 5 mA
Pulse current capability 10 mA
Anode surface area 4.3 cm2
Lithium content 0.2 g
Weight 8.8 g
Volume 2.6 cm3
Temperature range −55 °C ... +85°C
TL-2450 (with insolation disc)
7.62Ø 0.785
5.6±
0.2
10.6
max
.
TL-2450 (without insolation disc)
A high temperature version TLH-2450 is also available.For more information please refer to Tadiran’s website.
› iXtra – long term high performance
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
18
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+80 °C+50 °C+25 °C
0 °C−30 °C
1
3
2
54
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1:2:3:
3 mA0.3 mA
0.03 mA
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321
2 3 4 5
1
6
Volt
s
2
3
4
0 2 4 6 s 10
1:2:3:4:5:6:
1.0 kΩ3.3 kΩ10 kΩ33 kΩ
100 kΩ 330 kΩ
~3 mA~1 mA
~0.3 mA~0.1 mA
~0.03 mA~0.01 mA
0.98 Ah1.00 Ah0.98 Ah0.95 Ah0.92 Ah0.85 Ah
(–)
(+)
(–)
Ø 33.0−0.8
7.62Ø 0.76
15.2
4
3.2±
0.5
6.2±
0.3
(9.6
)
2 m
in.
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
19
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-889 Size: 1⁄10D
Available Terminations Catalogue No.SL-889/P Pins 11 1 18894 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1 Ah
Nominal current 0.5 mA
Max. continuous discharge current 10 mA
Pulse current capability 20 mA
Anode surface area 7.5 cm2
Lithium content 0.3 g
Weight 16 g
Volume 5 cm3
Temperature range −55 °C ... +85 °C
› XOL – extended operating life
SL-889
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
19
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
0.0
2.0
1.5
1.0
0.5
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+80 °C+50 °C+25 °C
0 °C−30 °C
1
3
2
5
4
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1:2:3:
3 mA0.3 mA
0.03 mA
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321
2 3 4 5
1
6
2
3
4
Volt
s
0 2 4 6 s 10
1:2:3:4:5:6:
1.0 kΩ3.3 kΩ10 kΩ33 kΩ
100 kΩ 330 kΩ
~3 mA~1 mA
~0.3 mA~0.1 mA
~0.03 mA~0.01 mA
1.50 Ah1.70 Ah1.65 Ah1.60 Ah1.50 Ah1.40 Ah
Ø 33.0−0.8
7.62Ø 0.76
15.2
4
2 m
in.
3.
2±0.
5
9.9±
0.3
(13.
1)
(−)
(−)
(+)
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
20
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-886 Size: 1⁄6D
Available Terminations Catalogue No.SL-886/P Pins 11 1 18864 00
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.7 Ah
Nominal current 0.5 mA
Max. continuous discharge current 10 mA
Pulse current capability 20 mA
Anode surface area 7.5 cm2
Lithium content 0.5 g
Weight 21 g
Volume 8.2 cm3
Temperature range −55 °C ... +85 °C
› XOL – extended operating life
SL-886
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
20
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
15
43
2
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1:2:3:
2 mA0.2 mA
0.02 mA
1
2
3
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321
2 3 4 5
1
6
1:2:3:4:5:6:
1.8 kΩ5.6 kΩ18 kΩ56 kΩ
180 kΩ 560 kΩ
~2 mA~0.6 mA~0.2 mA
~0.06 mA~0.02 mA
~0.006 mA
0.80 Ah1.20 Ah1.15 Ah1.05 Ah1.00 Ah0.90 Ah
2
3
4
Volt
s
0 2 4 6 s 10
Ø 4.2
0.15 thick
0.2 thick
1–0.1
4+0.
5
3.5
0.2 thick
1–0.1 10.16
4+0.
5
3.5
45 45
3.17
Ø 14.7–1.2
Ø 0
.8
Ø 0
.8
25.2
–1.2
0.7±
0.3
7±0.5
+0.2−0.3
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
21
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-850 Size: 1/2AA
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.2 Ah
Nominal current 0.5 mA
Max. continuous discharge current 20 mA
Pulse current capability 50 mA
Anode surface area 6 cm2
Lithium content 0.35 g
Weight 9.6 g
Volume 4 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-850/S Standard 11 1 08501 00
SL-850/T Tags 11 1 08502 00
SL-850/P Pins 11 1 08503 00
SL-850/PR Pins radial 11 1 08506 00
SL-850/PT Polarized tags 11 1 08508 00
› XOL – extended operating life
SL-850/S SL-850/T
SL-850/P
SL-850/PTSL-850/PR
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
21
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
1.6
1.4
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
12
3
45
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1:2:3:
3 mA0.3 mA
0.03 mA
1
2
3
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321
2 3 4 5
1
6
2
3
4
Volt
s
0 2 4 6 s 10
1:2:3:4:5:6:
1.0 kΩ3.3 kΩ10 kΩ33 kΩ
100 kΩ 330 kΩ
~3 mA~1 mA
~0.3 mA~0.1 mA
~0.03 mA~0.01 mA
1.20 Ah1.60 Ah1.60 Ah1.55 Ah1.45 Ah1.35 Ah
+
4545
3.5
3.5
Ø 0
.8
Ø 0
.8Ø 14.7−1.2
7±0.5
0.7±
0.3
33.5
−1.
5
1−0.1 1−0.1
4+0.
5
4+0.
5
3.17
0.15 thick
0.2 thick
10.16
0.2 thick
Ø 4.2−0.3+0.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
22
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-861 Size: 2⁄3AA
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 1.6 Ah
Nominal current 0.5 mA
Max. continuous discharge current 30 mA
Pulse current capability 75 mA
Anode surface area 9 cm2
Lithium content 0.5 g
Weight 12.5 g
Volume 5.2 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-861/S Standard 11 1 08611 00
SL-861/T Tags 11 1 08612 00
SL-861/P Pins 11 1 08613 00
SL-861/PR Pins radial 11 1 08616 00
SL-861/PT Polarized tags 11 1 08618 00
SL-861/S SL-861/T
SL-861/P
SL-861/PTSL-861/PR
› XOL – extended operating life
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
22
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
2.5
2.0
1.5
1.0
0.5
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
5
43
2
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1
2
3
1:2:3:
6 mA0.6 mA
0.06 mA
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
654321
2 3 4 5
1
6
2
3
4
Volt
s
0 2 4 6 s 10
1:2:3:4:5:6:
560 Ω1.8 kΩ5.6 kΩ18 kΩ56 kΩ
180 kΩ
~6 mA~2 mA
~0.6 mA~0.2 mA
~0.06 mA~0.02 mA
1.90 Ah2.40 Ah2.40 Ah2.30 Ah2.15 Ah2.00 Ah
+
4545
Ø 0
.8
Ø 0
.8
50.5
−1.
5
1−0.1 1−0.1
3.17
0.15 thick
0.2 thick0.2 thick
Ø 4.2−0.3+0.2
0.7±
0.3
7±0.5
3.5
3.5
10.16
4+0,
5
4+0,
5
Ø 14.7–1.2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
23
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-860 Size: AA
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 2.4 Ah
Nominal current 1 mA
Max. continuous discharge current 60 mA
Pulse current capability 120 mA
Anode surface area 14 cm2
Lithium content 0.65 g
Weight 18 g
Volume 8 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-860/S Standard 11 1 08601 00
SL-860/T Tags 11 1 08602 00
SL-860/P Pins 11 1 08603 00
SL-860/PR Pins radial 11 1 08606 00
SL-860/PT Polarized tags 11 1 08608 00
SL-860/S SL-860/T
SL-860/P
SL-860/PTSL-860/PR
› XOL – extended operating life
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
23
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
10
8
6
4
2
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
54
32
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1:2:3:
10 mA1 mA
0.1 mA
1
2
3
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
54321
53 4
21
Volt
s
2
3
4
0 2 4 6 s 10
1:2:3:4:5:
330 Ω1.0 kΩ3.3 kΩ10 kΩ33 kΩ
~10 mA~3 mA~1 mA
~0.3 mA~0.1 mA
6.0 Ah8.4 Ah8.5 Ah8.2 Ah7.7 Ah
50.0
−2
0.7±
0.3
Ø 26.2−1
Ø 4.2−0.3+0.2
Ø 0
.8
Ø 0
.8
45 45
0.15 thick
3.17
16−2+1
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
24
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-2870 Size: C
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 8.5 Ah
Nominal current 3 mA
Max. continuous discharge current 75 mA
Pulse current capability 200 mA
Anode surface area 30 cm2
Lithium content 2.5 g
Weight 49.5 g
Volume 26 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-2870/S Standard 11 2 18701 00
SL-2870/T Tags 11 2 18702 00
SL-2870/P Pins 11 2 18703 00
› XOL – extended operating life
SL-2870/S SL-2870/T
SL-2870/P
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
24
Piles LTC
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
20
15
10
5
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+80 °C+50 °C+25 °C
0 °C−30 °C
5
42
13
Operating Voltage
Volt
age
/ V
3.8
3.6
3.4
3.2
3.0
2.8
2.6
2.4
−50 −35 −20 −5 10 25 40 55 70 85 100Temperature / °C
1
2
3
1:2:3:
20 mA2 mA
0.2 mA
Typical Discharge Curves at +25 °C4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
Volt
age
/ V
0.1 1 10 102 103 104 105
Time / h
54321
53 4
21
1:2:3:4:5:
180 Ω560 Ω1.8 kΩ5.6 kΩ18 kΩ
~20 mA~6 mA~2 mA
~0.6 mA~0.2 mA
13.5 Ah17.5 Ah18.8 Ah18.3 Ah17.0 Ah
Volt
s
2
3
4
0 2 4 6 s 10
45 45
Ø 0
.8
Ø 0
.8
+
3.17
0.15 thick
0.7±
0.3
Ø 4.2−0.3+0.2
12−2+1
Ø 32.9−0.7
61.5
−2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
25
LTC Batteries
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion, and
severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
SL-2880 Size: D
System Lithium Thionyl Chloride
Nominal voltage 3.6 V
Nominal capacity 19 Ah
Nominal current 4 mA
Max. continuous discharge current 100 mA
Pulse current capability 250 mA
Anode surface area 45 cm2
Lithium content 5 g
Weight 93 g
Volume 51 cm3
Temperature range −55 °C ... +85 °C
Available Terminations Catalogue No.SL-2880/S Standard 11 2 18801 00
SL-2880/T Tags 11 2 18802 00
SL-2880/P Pins 11 2 18803 00
› XOL – extended operating life
SL-2880/S SL-2880/T
SL-2880/P
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
25
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
PulsesPlus TM Batteries
Impedance Loss and how to Overcome it4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.00 5 10 15 20
Working time / years
Volt
age
/ V
SL-2880 @ +25 °Ccont. load: 68 kΩ (~50 µA)pulse load: 150 mA1: Voltage on background current2: Pulse voltage
R-4201
2
HLC-1520 connected
GSM Discharge Curves4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.00 5 10 15 20 25
Time / min
Volt
age
/ V 12345
67HLC-1550A charged to 3.6 VGSM profile (TDMA, 1 Slot)150 mA continuous current2 A peak current for 577 µs every 4.615 ms1: +25 °C 2: +10 °C 3: 0 °C 4: −10 °C 5: −20 °C 6: −30 °C 7: −40 °C
How to Design a Long Life Application
0 5 10 15 20 25 30Typical battery design life / years
Max
. avg
. cur
rent
dra
w /
μA
0
40
80
120
160
200
240
280
320
TLP-93111/A (SL-2880, D-size, XOL cell,19 Ah nominal capacity,with HLC-1550A)
1: +70 °C2: +55 °C3: +25 °C
123
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
26
IntroductionThe PulsesPlus TM battery The PulsesPlus TM battery series was introduced by Tadiran Batteries in order to extend the range of applications for the Lithium Thionyl Chloride (LTC) battery by eliminating the voltage delay, increasing the pulse current capability and minimizing the impedance loss of the battery. A proprietary Hy-brid Layer Capacitor (HLC) was developed for this purpose. A PulsesPlus TM battery is formed by connecting one or more primary lithium thionyl chloride batteries in parallel with one or more HLCs.
The Hybrid Layer CapacitorThis HLC is a secondary element. Its electrodes comprise Lithium Intercalated Compounds and are spirally wound. The HLC has been optimized with respect to self discharge, temperature range and durability by carefully selecting the material properties of the electrodes and the her-metical glass to metal seal.
PerformanceAs a result, the PulsesPlus TM battery outperforms conven-tional high rate lithium bat-
teries such as lithium sulphur dioxide (Li/SO2) batteries, lithium manganese dioxide (Li/MnO2) batteries as well as spirally wound lithium thionyl chloride (Li/SOCl2) batteries. Compared to these battery systems, PulsesPlus TM batter-ies deliver higher voltage and higher capacity. These batteries also offer unmatched service life due to their extremely low self-discharge.
AdvantagesThe performance advan-tages of the PulsesPlus TM battery include:
Higher voltage – 3.6 V versus 3.0 V Higher capacity – e.g. 19 Ah for D size cell (versus 7 Ah for other Lithium batteries) Lower self discharge – less than 1 % per year (versus 5 % per year with spiral wound) Lower impedance (internal resistance) High pulse current capability No passivation effect High reliability (hermetic laser sealing, glass-to-metal seal) Widest operating tem-perature – −40 °C to +85 °C (versus 0 °C to +60 °C) Greater safety, UL registra-tion of the component cells
No impedance lossThe PulsesPlus TM battery overcomes the impedance loss which occurs when an LTC battery is used to deliver high pulse currents over a long time. This effect is demonstrat-ed in figure 1 where a D-size
cell was discharged under a continuous load of ~50 µA and short pulses of 150 mA.
The battery is able to de-liver this current at a voltage level of 3 Volts, at least for a period of 2 years. From the low average current draw of 50 µA, one would be misled to assume that the battery could continue to deliver these pulse currents for more
than 10 or 20 years. However, after 2 years, the voltage level under pulse load starts to decline reaching as low as 1.5 Volts after 5 years. At this voltage level, most applica-tions would stop to work and the battery would be consid-ered as discharged. However, it is not, as can be seen from the red curve showing the bat-tery voltage under background load. It stays at 3.6 Volts, even after 5 and 10 years. Connecting Tadiran’s Hybrid Layer Capacitor (HLC) in paral-lel solves the problem. The HLC maintains its low internal resistance throughout the remaining battery life. During that time period the pulse voltage stays always above 3.4 Volts. The duration for that test is more than 14 years.
Application in GSM modulesOne major application for PulsesPlus TM batteries is in GSM communication modules for data exchange. GSM is the global system for mobile communication also used for mobile phones. The GSM network uses a multiplexing technology called time divi-sion multiple access (TDMA) in order to provide multiple communication channels with the same signal, dividing it into 8 time slots. A typical TDMA transmission requires a basic current of 150 mA and a pulse current of 2 A for 577 µs every 4.615 ms. Figure 2 shows the voltage behaviour of a Pulses Plus TM battery with one HLC-1550A under these conditions at
various temperature levels between −40 °C and +25 °C. The chart shows two curves for each temperature level. The upper curve corresponds to the voltage level under the background current of 150 mA while the lower curve cor-responds to the voltage level under the peak current of 2 A. Curves at higher temperatures are not shown but can be con-sidered to lie slightly above the curves for +25 °C.
Extremely low self dischargeThe PulsesPlus TM battery can be used where 20 years of continuous power are required for applications including GSM and radio modules. This is due to the stability of both Tadiran’s primary LTC battery and the HLC with respect to the sealing system, the internal resistance, and the self-discharge.
Fit for 20 years of lifeFigure 3 shows the maximum average current draw of a TLP-93111/A PulsesPlus TM battery as a function of the design life of the battery. This battery will typically deliver 20 years opera-tion life when the average cur-rent is not more than 87.5 µA at +25 °C. Under these conditions, the accumulated self discharge loss of the battery is less than 15 % during its operating life. As a result it is fair to say that Tadiran’s Pulses Plus TM battery is the smallest and most cost effective battery for a 20 year stand alone power supply.
Variable designPulsesPlus TM batteries can be assembled in a great variety of combinations. The primary cell can be selected from Tadiran’s large range of 3.6 Volt LTC bat-teries. A special range of LSC (Lithium Sulphuryl Chloride) cells with a nominal voltage of 3.9 Volts is also available, often allowing a more economic approach where equipment needs to operate at very low temperatures. Each of these primary cells can be combined with one or more HLCs from a range of four sizes. Series and parallel combinations of more primary cells extend the voltage range and capacity range where necessary. Only a few standard combinations can be shown in this catalogue. Contact Tadiran for a customized application proposal.
Figure 1: Impedance Loss and how to Overcome it
Figure 2: GSM Discharge Curves
Figure 3: How to Design a Long Life Application
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
26
32
1
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V
1:2:3:
300 mA750 mA
1500 mA
4&5
3
2
1
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
300 mA600 mA
1000 mA
2.5
2.0
1.5
1.0
0.5
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
5
43
2
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
32 max.
55 m
ax.
16 m
ax.
100±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
27
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
TLP-91111/ASystem LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 2.4 Ah
Nominal current 2 mA
Max. 1 s pulse to 3 V 3 A
Max. pulse length @ 0.5 A to 2.8 V 1000 s
Delay time to 3 V @ 0.5 A none
Weight 55 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 87 %
Available Terminations Catalogue No.TLP-91111/A/SM Flying leads 17 91111 101
› High energy › Up to 3 A pulse capability › Instant voltage response › No passivation effect
B = LTC batteryC = HLCF = PTC (optional)
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-91111/A/SM
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
27
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
3
2
1
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
4&5
Maximum Pulse Width from 3.6 V to 2.8 V1.2
1.0
0.8
0.6
0.4
0.2
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
3211:2:3:
100 mA200 mA300 mA
2.5
2.0
1.5
1.0
0.5
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
5
43
2
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
100 mA250 mA500 mA
+ + 18±2
Ø 7 Ø 7
75 m
ax.
75 m
ax.
Ø 16.5 max. Ø 16.5 max. 23±2
+ + 18±2
Ø 7 Ø 7
75 m
ax.
75 m
ax.
Ø 16.5 max. Ø 16.5 max. 23±2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
28
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Do not charge. Battery can explode if disassembled, heated above 100 °C, incinerated, or contents exposed to water.
TLP-91311/A › High energy › Up to 1 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 2.4 Ah
Nominal current 2 mA
Max. 1 s pulse to 3 V 1 A
Max. pulse length @ 0.125 A to 2.8 V 1000 s
Delay time to 3 V @ 0.125 A none
Weight 40 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 90 %
Available Terminations Catalogue No.TLP-91311/A/SM Pressure contacts 17 91311 101
TLP-91311/A/ST Solder tags 17 91311 102
B = LTC batteryC = HLCF = PTC (optional)
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-91311/A/SM TLP-91311/A/ST
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
28
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
32
1
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V
1:2:3:
300 mA750 mA
1500 mA
4&5
3
2
1
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
300 mA600 mA
1000 mA
10
8
6
4
2
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
54
32
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
55 m
ax.
28 m
ax.
44 max.
100±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
29
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 8.5 Ah
Nominal current 3 mA
Max. 1 s pulse to 3 V 3 A
Max. pulse length @ 0.5 A to 2.8 V 1000 s
Delay time to 3 V @ 0.5 A none
Weight 100 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 93 %
Available Terminations Catalogue No.TLP-92111/A/SM Flying leads 17 92111 101
TLP-92111/A › High energy › Up to 3 A pulse capability › Instant voltage response › No passivation effect
B = LTC batteryC = HLCF = PTC (optional)
Note:For best performance battery should be mounted in the ap-plication in uprightor horizontal orientation.
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-92111/A/SM
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
29
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
3
2
1
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
4&5
Maximum Pulse Width from 3.6 V to 2.8 V1.2
1.0
0.8
0.6
0.4
0.2
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
3211:2:3:
100 mA200 mA300 mA
10
8
6
4
2
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
54
32
1
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
100 mA250 mA500 mA
67 m
ax.
Ø 29 max.
75±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
30
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
TLP-92311/A › High energy › Up to 1 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 8.5 Ah
Nominal current 3 mA
Max. 1 s pulse to 3 V 1 A
Max. pulse length @ 0.125 A to 2.8 V 1000 s
Delay time to 3 V @ 0.125 A none
Weight 80 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 93 %
Available Terminations Catalogue No.TLP-92311/A/SM Flying leads 17 92311 101
B = LTC batteryC = HLCF = PTC (optional)
Note:For best performance battery should be mounted in the ap-plication in uprightor horizontal orientation.
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-92311/A/SM
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
30
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
32
1
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V
1:2:3:
300 mA750 mA
1500 mA
4&5
3
2
1
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
300 mA600 mA
1000 mA
20
15
10
5
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+80 °C+50 °C+25 °C
0 °C−30 °C
5
42
13
64 m
ax.
35 m
ax.
50 max.
100±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
31
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
TLP-93111/A › High energy › Up to 3 A pulse capability › Instant voltage response › No passivation effect
B = LTC batteryC = HLCF = PTC (optional)
Note:For best performance battery should be mounted in the ap-plication in uprightor horizontal orientation.
Both the LTC battery and the HLC are UL recognized.
B C
F
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 19 Ah
Nominal current 4 mA
Max. 1 s pulse to 3 V 3 A
Max. pulse length @ 0.5 A to 2.8 V 1000 s
Delay time to 3 V @ 0.5 A none
Weight 140 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 96 %
Available Terminations Catalogue No.TLP-93111/A/SM Flying leads 17 93111 101
TLP-93111/A/SM
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
31
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
3
2
1
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
4&5
Maximum Pulse Width from 3.6 V to 2.8 V1.2
1.0
0.8
0.6
0.4
0.2
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
3211:2:3:
100 mA200 mA300 mA
20
15
10
5
0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
1:2:3:4:5:
+80 °C+50 °C+25 °C
0 °C−30 °C
5
42
13
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
100 mA250 mA500 mA
78 m
ax.
Ø 34 max.
75±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
32
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
TLP-93311/A › High energy › Up to 1 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 19 Ah
Nominal current 4 mA
Max. 1 s pulse to 3 V 1 A
Max. pulse length @ 0.125 A to 2.8 V 1000 s
Delay time to 3 V @ 0.125 A none
Weight 120 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 96 %
Available Terminations Catalogue No.TLP-93311/A/SM Flying leads 17 93311 101
B = LTC batteryC = HLCF = PTC (optional)
Note:For best performance battery should be mounted in the ap-plication in uprightor horizontal orientation.
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-93311/A/SM
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
32
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
32
1
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V
1:2:3:
300 mA750 mA
1500 mA
4&5
3
2
1
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
300 mA600 mA
1000 mA
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
15
43
2
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
55 m
ax.
32 max.
16 m
ax.
100±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
33
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
TLP-96111/A › High energy › Up to 3 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 1.2 Ah
Nominal current 0.6 mA
Max. 1 s pulse to 3 V 3 A
Max. pulse length @ 0.5 A to 2.8 V 1000 s
Delay time to 3 V @ 0.5 A none
Weight 45 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 78 %
Available Terminations Catalogue No.TLP-96111/A/SM Flying leads 17 96111 101
B = LTC batteryC = HLCF = PTC (optional)
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-96111/A/SM
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
33
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
3
2
1
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
4&5
Maximum Pulse Width from 3.6 V to 2.8 V1.2
1.0
0.8
0.6
0.4
0.2
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
3211:2:3:
100 mA200 mA300 mA
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
15
43
2
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
100 mA250 mA500 mA
+ + 18±2
Ø 7 Ø 7
50 m
ax.
50 m
ax.
Ø 16.5 max. Ø 16.5 max. 23±2
+ + 18±2
Ø 7 Ø 7
50 m
ax.
50 m
ax.
Ø 16.5 max. Ø 16.5 max. 23±2
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
34
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Do not charge. Battery can explode if disassembled, heated above 100 °C, incinerated, or contents exposed to water.
TLP-96311/A › High energy › Up to 1 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 1.2 Ah
Nominal current 0.6 mA
Max. 1 s pulse to 3 V 1 A
Max. pulse length @ 0.125 A to 2.8 V 1000 s
Delay time to 3 V @ 0.125 A none
Weight 30 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 83 %
Available Terminations Catalogue No.TLP-96311/A/SM Pressure contacts 17 96311 101
TLP-96311/A/ST Solder tags 17 96311 102
B = LTC batteryC = HLCF = PTC (optional)
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-96311/A/SM TLP-96311/A/ST
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
34
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
32
1
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V
1:2:3:
300 mA750 mA
1500 mA
4&5
3
2
1
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
300 mA600 mA
1000 mA
1.6
1.4
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
12
3
45
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
55 m
ax.
16 m
ax.
32 max.
100±10
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
35
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Risk of fire or explosion. Do not charge, incinerate, disassemble, heat above 100 °C, or expose contents to water.
TLP-97111/A › High energy › Up to 3 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 1.6 Ah
Nominal current 1 mA
Max. 1 s pulse to 3 V 3 A
Max. pulse length @ 0.5 A to 2.8 V 1000 s
Delay time to 3 V @ 0.5 A none
Weight 45 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 80 %
Available Terminations Catalogue No.TLP-97111/A/SM Flying leads 17 97111 101
B = LTC batteryC = HLCF = PTC (optional)
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-97111/A/SM
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
35
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
3
2
1
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
4&5
Maximum Pulse Width from 3.6 V to 2.8 V1.2
1.0
0.8
0.6
0.4
0.2
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
3211:2:3:
100 mA200 mA300 mA
1.6
1.4
1.2
1.0
0.8
0.6
0.4
0.2
0.0
Capa
city
to
2 Vo
lts
/ Ah
0.01 0.1 1 10 100 1000Current / mA
Available Capacity
12
3
45
1:2:3:4:5:
+72 °C+55 °C+25 °C
0 °C−30 °C
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
100 mA250 mA500 mA
+ + 18±2
Ø 7 Ø 7
58 m
ax.
58 m
ax.
23±2Ø 16.5 max.Ø 16.5 max.
+ + 18±2
Ø 7 Ø 7
58 m
ax.
58 m
ax.
23±2Ø 16.5 max.Ø 16.5 max.
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
36
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Do not charge. Battery can explode if disassembled, heated above 100 °C, incinerated, or contents exposed to water.
TLP-97311/A › High energy › Up to 1 A pulse capability › Instant voltage response › No passivation effect
System LTC and HLC
Nominal voltage 3.6 V
Nominal capacity 1.6 Ah
Nominal current 1 mA
Max. 1 s pulse to 3 V 1 A
Max. pulse length @ 0.125 A to 2.8 V 1000 s
Delay time to 3 V @ 0.125 A none
Weight 35 g
Temperature range −40 °C ... +85 °C
Capacity retention after 10 year storage 85 %
Available Terminations Catalogue No.TLP-97311/A/SM Pressure contacts 17 97311 101
TLP-97311/A/ST Solder tags 17 97311 102
B = LTC batteryC = HLCF = PTC (optional)
Both the LTC battery and the HLC are UL recognized.
B C
F
TLP-97311/A/SM TLP-97311/A/ST
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
36
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
37
IntroductionTemperature range −40 °C ... +85 °C for operation in PulsesPlus TM batteries
−30 °C ... +60 °C for storage and independent use
Electrical characteristicsDischarge end voltage 2.5 V Discharge below 2.5 V at +25 °C and discharge below 2 V at −40 °C
may lead to an increase of the internal resistance.Max. charge voltage 3.95 V
Shelf life in PulsesPlus TM batteries used independently@ +25 °C 10 years 3 years@ +60 °C 7 years 4 weeks@ +85°C ≥ 1 year 1 week
Cycle life at 3.6 V at 3.9 Vto 1 % DOD1) 400000 cycles 100000 cyclesto 10 % DOD 40000 cycles 10000 cyclesto 100 % DOD 4000 cycles 1000 cycles
1) DOD = depth of discharge
Hybrid Layer Capacitors (HLCs)
PropertiesHybrid Layer Capacitors are a kind of rechargeable battery. They are used as a capacitor in PulsesPlus TM batteries, where they are connected in parallel to Tadiran Lithium Batteries. The electrodes of HLCs com-prise Lithium intercalation compounds. They have low im-pedance and can deliver high current pulses. The perform-ance and reliability properties of HLCs have been carefully optimized to match those of Tadiran Lithium Batteries. The result is a battery with a maximum of both energy and power density for stand alone use of up to 25 years.
SafetyWARNING:HLCs are designed for use in PulsesPlus TM batteries. When used independently, they must not be fast charged.
Overcharge above 3.95 V may lead to capacity loss and/or an increase of internal resistance.
Overcharge above 4.4 V may lead to excessive internal pressure. This may result in explosion or rupture.
HLCs must not be charged after a deep discharge below 2.5 Volts.
TransportHLCs have passed the UN transport tests. They contain less than 0.3 g lithium equiva-lent and are not restricted under international dangerous goods regulations. For more information on classification and transport regulations, please refer to Tadiran’s technical notice: www.tadiranbatteries.de/regulations/
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
37
Maximum Pulse Width from 3.6 V to 2.8 V0.4
0.3
0.2
0.1
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
3
2
1
4&5
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
30 mA60 mA
100 mA
Voltage Curve at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
2.6
Ope
n ci
rcui
t vo
ltag
e / V
Available capacity / As0.01 0.1 1 10 102 103
15 mA discharge
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
30 mA75 mA
150 mA
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
38
Performance Data(Typical values in PulsesPlus TM batteries stored at +25 °C)
CAUTION: Fire, explosion,
and severe burn hazard. Do not disassemble, heat above 100 °C, or incinerate.
Use as part of PulsesPlus™ battery only. Do not charge above 3.95 V.
+
Ø 10±0.5
7±1
3.7±
0.5
0.7±0.02 7.5
3.17
21−
1
HLC-1020
+
Ø 10±0.5
7±1
3.7±
0.5
0.7±0.02 7.5
3.17
21−
1
System Lithium Intercalated CompoundsVersion HLC-1020 (HLC-1020L)
Nominal voltage 3.67 V / optional 3.9 V
Nominal capacity 45 As @ 3.67 V70 As @ 3.9 V
(30 As @ 3.67 V)(45 As @ 3.9 V)
Nominal current 15 mA
Max. continuous discharge current 250 mA (150 mA)
Pulse current capability 750 mA (500 mA)
Max. charge voltage 3.95 V
Max. charge current 8 mA (6 mA)
Discharge end voltage 2.5 V
Cell impedance max. 400 mΩ (max. 600 mΩ)
Lithium content 0.01 g
Weight 4.2 g
For more data please refer to page 37.
Available Terminations Catalogue No.HLC-1020/S Standard 13 0 11021 02
HLC-1020/T Tags 13 0 11022 02
HLC-1020/TP Polarized tags 13 0 11027 02
HLC-1020L/S Standard 13 0 13021 02
HLC-1020L/T Tags 13 0 13022 02
HLC-1020L/TP Polarized tags 13 0 13027 02
HLC-1020(L)/S HLC-1020(L)/T
HLC-1020(L)/TP
› Delivering high current pulses › Up to 25 years lifetime and more › Wide operating temperature range › Low self discharge
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
38
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
0.13
0.2
0.2 7.5
4.0±
0.5
4.0±
0.5
3.17
+
Ø 15.5−1
21−
1
Ø 14.5+0.2
7±1
0.7±0.02
0.7±0.02
3.7±
0.5
3.7±
0.5
0.13
0.2
0.2 7.5
4.0±
0.5
4.0±
0.5
3.17
+
Ø 15.5−1
21−
1
Ø 14.5+0.2
7±1
0.7±0.02
0.7±0.02
3.7±
0.5
3.7±
0.5
0.13
0.2
0.2 7.5
4.0±
0.5
4.0±
0.5
3.17
+
Ø 15.5−1
21−
1
Ø 14.5+0.2
7±1
0.7±0.02
0.7±0.02
3.7±
0.5
3.7±
0.5
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Pulse duration / s0.01 0.1 1 10 102 103 104
32
1
1:2:3:
100 mA250 mA500 mA
3
2
1
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
4&5
Maximum Pulse Width from 3.6 V to 2.8 V1.2
1.0
0.8
0.6
0.4
0.2
0.0
Puls
e am
plit
ude
/ A
Pulse width / s0.01 0.1 1 10 102 103 104
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
3211:2:3:
100 mA200 mA300 mA
Voltage Curve at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
2.6
Ope
n ci
rcui
t vo
ltag
e / V
Available capacity / As0.01 0.1 1 10 102 103
50 mA discharge
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
39
Performance Data(Typical values in PulsesPlus TM batteries stored at +25 °C)
CAUTION: Fire, explosion,
and severe burn hazard. Do not disassemble, heat above 100 °C, or incinerate.
Use as part of PulsesPlus™ battery only. Do not charge above 3.95 V.
HLC-1520ASystem Lithium Intercalated CompoundsNominal voltage 3.67 V, optional 3.9 V
Nominal capacity 140 As (39 mAh) @ 3.67 V210 As (58 mAh) @ 3.9 V
Nominal current 25 mA
Max. continuous discharge current 500 mA
Pulse current capability 2000 mA
Max. charge voltage 3.95 V
Max. charge current 25 mA
Discharge end voltage 2.5 V
Cell impedance max. 250 mΩ (@ 1 kHz, RT)
Lithium content 0.02 g @ 3.67 V0.03 g @ 3.9 V
Weight 7.7 g
For more data please refer to page 37.
Available Terminations Catalogue No.HLC-1520A/S Standard 13 0 11521 02
HLC-1520A/T Tags 13 0 11522 02
HLC-1520A/TP Polarized tags 13 0 11527 02
HLC-1520/S HLC-1520/T
HLC-1520/TP
› Delivering high current pulses › Up to 25 years lifetime and more › Wide operating temperature range › Low self discharge
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
39
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
3
2
1
4&5
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
150 mA300 mA500 mA
1 2 3
Voltage Curve at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
2.6
0.01 0.1 1 10 102 103
Ope
n ci
rcui
t vo
ltag
e / V
Available capacity / As
100 mA discharge
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V 32
1
1:2:3:
150 mA400 mA750 mA
4.0±
0.5
3.170.13
0.2 0.7±0.02
3.7±
0.5
7±1
Ø 14.5+0.2
Ø 15.5−1
28−
1
7.5
+
4.0±
0.5
3.170.13
0.2 0.7±0.02
3.7±
0.5
7±1
Ø 14.5+0.2
Ø 15.5−1
28−
1
7.5
+
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
40
Performance Data(Typical values in PulsesPlus TM batteries stored at +25 °C)
CAUTION: Fire, explosion,
and severe burn hazard. Do not disassemble, heat above 100 °C, or incinerate.
Use as part of PulsesPlus™ battery only. Do not charge above 3.95 V.
HLC-1530ASystem Lithium Intercalated CompoundsNominal voltage 3.67 V, optional 3.9 V
Nominal capacity 250 As (70 mAh) @ 3.67 V380 As (105 mAh) @ 3.9 V
Nominal current 50 mA
Max. continuous discharge current 750 mA
Pulse current capability 3000 mA
Max. charge voltage 3.95 V
Max. charge current 50 mA
Discharge end voltage 2.5 V
Cell impedance max. 140 mΩ (@ 1 kHz, RT)
Lithium content 0.02 g @ 3.67 V0.05 g @ 3.9 V
Weight 10.3 g
For more data please refer to page 37.
Available Terminations Catalogue No.HLC-1530A/S Standard 13 0 11531 02
HLC-1530A/T Tags 13 0 11532 02
HLC-1530A/TP Polarized tags 13 0 11537 02
HLC-1530/S HLC-1530/T
HLC-1530/TP
› Delivering high current pulses › Up to 25 years lifetime and more › Wide operating temperature range › Low self discharge
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
40
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
4.0±
0.5
4.0±
0.5
+
Ø 15.5-1
Ø 14.5+0.2
52-1
7±1
0.13
0.2 0.7±0.02
0.7±0.02 7.5
3.7±
0.5
3.7±
0.5
0.2
3.17
4.0±
0.5
4.0±
0.5
+
Ø 15.5-1
Ø 14.5+0.2
52-1
7±1
0.13
0.2 0.7±0.02
0.7±0.02 7.5
3.7±
0.5
3.7±
0.5
0.2
3.17
4.0±
0.5
4.0±
0.5
+
Ø 15.5-1
Ø 14.5+0.2
52-1
7±1
0.13
0.2 0.7±0.02
0.7±0.02 7.5
3.7±
0.5
3.7±
0.5
0.2
3.17
32
1
Voltage during a Pulse at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.80.01 0.1 1 10 102 103 104
Pulse duration / s
Volt
age
/ V
1:2:3:
300 mA750 mA
1500 mA
4&5
3
2
1
0.01 0.1 1 10 102 103 104
Pulse width / s
Puls
e am
plit
ude
/ A
Maximum Pulse Width from 3.6 V to 2.8 V4.0
3.5
3.0
2.5
2.0
1.5
1.0
0.5
0.0
1:2:3:4:5:
−40 °C−20 °C
0 °C+25 °C+85 °C
321
Pulse Voltage after 1 s4.0
3.8
3.6
3.4
3.2
3.0
2.8
Volt
age
/ V
Temperature / °C−50 −35 −20 −5 10 25 40 55 70 85 100
1:2:3:
300 mA600 mA
1000 mA
Voltage Curve at +25 °C4.0
3.8
3.6
3.4
3.2
3.0
2.8
2.6
0.01 0.1 1 10 102 103
Ope
n ci
rcui
t vo
ltag
e / V
Available capacity / As
200 mA discharge
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
41
Performance Data(Typical values in PulsesPlus TM batteries stored at +25 °C)
CAUTION: Fire, explosion,
and severe burn hazard. Do not disassemble, heat above 100 °C, or incinerate.
Use as part of PulsesPlus™ battery only. Do not charge above 3.95 V.
HLC-1550ASystem Lithium Intercalated CompoundsNominal voltage 3.67 V, optional 3.9 V
Nominal capacity 560 As (155 mAh) @ 3.67 V850 As (240 mAh) @ 3.9 V
Nominal current 50 mA
Max. continuous discharge current 2000 mA
Pulse current capability 5000 mA
Max. charge voltage 3.95 V
Max. charge current 100 mA
Discharge end voltage 2.5 V
Cell impedance max. 100 mΩ (@ 1 kHz, RT)
Lithium content 0.05 g @ 3.67 V0.10 g @ 3.9 V
Weight 20 g
For more data please refer to page 37.
Available Terminations Catalogue No.HLC-1550A/S Standard 13 0 11551 02
HLC-1550A/T Tags 13 0 11552 02
HLC-1550A/TP Polarized tags 13 0 11557 02
HLC-1550/S HLC-1550/T
HLC-1550/TP
› Delivering high current pulses › Up to 25 years lifetime and more › Wide operating temperature range › Low self discharge
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
41
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
CDMA Discharge after Accelerated Ageing
0 5 10 15Time / min
Volt
age
/ V
2.0
3.0
2.5
3.5
4.0
1
2
TLM-1550HPMdischarge @ –20 °Cafter 3 weeks storage @ +72 °C1: 0.5 A for 3.75 ms every 6.25 ms, followed by2: 2.5 A for 2.5 ms
Comparison TLM versus Li/MnO2
0 0.1 0.2 0.3 0.4 0.5 0.6Capacity / Ah
Volt
age
/ V
1
3
2
42.0
3.0
2.5
3.5
4.0 1 : TLM-1550/HPM under 2 A @ +25 °C 2 : TLM-1550/HPM under 1 A @ –20 °C 3 : CR123A under 2 A @ +25 °C 4 : CR123A under 1 A @ –20 °C
Impedance Growth during Storage
0 500 1000 1500 2000Time / days
Inte
rnal
res
ista
nce
/ mΩ
1
2
TLM-1550HPM1: @ RT2: @ +72 °C
0
50
100
150
200
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
42
IntroductionThe TLM batteryThe Tadiran TLM series, the newest product innovation from Tadiran Batteries, is distinguished by its extremely high power in the decisive moment – when it really mat-
ters! It stands for guaranteed power even after long storage or stand-by up to more than 10 years. Its outstanding properties make it the ideal back-up battery for the eCall system, surgical instruments, and other special applications.
Military versionTLM batteries are also avail-able in a more robust version for military applications. For more information see www.tadiranbatteries.de >> products >> TLM batteries >> Military version.
Advantages High voltage 4.0 V Very high pulse current capability Immediate response, no passivation effect Wide operating temperature range (−40 °C to +85 °C) High reliability (hermetic laser sealing, glass-to-metal seal) Outstanding storage capability (up to 10 years) Recognized safety (UL) Very low self discharge Easy health monitoring during storage
Outperforms competitionCompared to other commer-cial high rate lithium batter-ies, TLM batteries are superior with respect to their voltage, energy content, and tempera-ture behaviour.
Figure 1 shows a comparison with CR123A batteries. These batteries have almost the same volume as TLM-1550HPM and belong to the Lithium Manganese Dioxide 3 Volt system. Under a 2 Ampere dis-charge at room temperature, they deliver almost the same capacity as TLM-1550HPM but at much lower voltage. Under 1 Ampere discharge at −20 °C, CR123A delivers almost no capacity above 2 Volts, while TLM-1550HPM still delivers more than 70 % of its nomi-nal capacity.
Application in eCall modulesOne major application for TLM batteries is the so-called Autonomous Telematics Box or Advanced Telematics Module where the TLM battery serves as the back-up battery for eCall, the automatic emer-gency call system for cars in Europe. The requirements for this system include operation under high pulse currents at low temperature at any time up to 10 years after installation. Even under these severe condi-tions, an air time of more than 10 minutes is required. Dur-ing this air time, the system exchanges both car condition and position data and voice signals between the car and an emergency call centre.
Smallest high power batteryFigure 2 shows the behav-iour of TLM-1550HPM under these conditions. The battery was subjected to accelerated ageing by storing it at +72 °C for 3 weeks prior to the test.
It was then cooled down to −20 °C and discharged under a simulated application load profile comprising 2.5 A of 2.5 ms duration every 6.25 ms on a basic load of 0.5 A. The upper curve (1) shows the voltage on the basic load while the lower curve (2)
shows the voltage during the 2.5 A pulses. The discharge duration is clearly in excess of 10 minutes. TLM-1550HPM is the smallest battery com-mercially available on the market that can fulfil these requirements.
Enduring low impedanceFor demanding applications like the back-up battery in eCall systems, the durability of the battery in a wide tem-perature range is a decisive factor. Especially two para-
meters need to be sufficiently low and stable: self discharge and internal resistance. The development of self discharge, expressed as capacity loss over storage time, is shown in the data sheets of TLM batteries on the following pages while Figure 3 shows the develop-
ment of the internal resistance of TLM-1550HPM over time at two different storage tem-peratures. It remains within the specified limits, even after storage at +72 °C for 3 years.
Figure 1: Comparison TLM versus Li/MnO2
Figure 2: CDMA Discharge after Accelerated Ageing
Figure 3: Impedance Growth during Storage
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
42
Volt
age
/ V
Capacity / mAh
Discharge Capability at RT4.5
4
3.5
3
2.5
2
1.5
1
0.50
321
1:2:3:
1 A125 mA5 mA
0 20 100 14012040 60 80
Capacity / mAh
Volt
age
/ V
Discharge at 250 mA and several Temperatures
1:2:3:4:
−40 °C−20 °C+22 °C+85 °C
3
4
4.54
3.5
3
2.5
2
1.5
1
0.50
1 2
0 20 60 1008040 120
Ageing during Storage50
40
30
20
10
00 5 10 15 20 25
Accu
mul
ated
cap
acit
y lo
ss1) /
%
Time / years
1:2:3:
+25 °C+55 °C+70 °C
1
3 2
1) when tested at RT under 12 mA to 2.8 V
Voltage Curve
4.0
3.5
3.0
2.5
2.0
0 25 50 75 100 125 150
Volt
age
/ V
Capacity / mAh
4.0±
0.5
+
0.13
0.7±0.02
7±1
3.7±
0.5
0.2 7.5
3.17Ø 14.5+0.2
Ø 15.5−1
21−
1
4.0±
0.5
+
0.13
0.7±0.02
7±1
3.7±
0.5
0.2 7.5
3.17Ø 14.5+0.2
Ø 15.5−1
21−
1
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
43
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion,
and severe burn hazard. Do not charge, disassemble, heat above 100 °C, incinerate, or short circuit.
TLM-1520HPM
TLM-1520HPM/S TLM-1520HPM/T
Available Terminations Catalogue No.TLM-1520HPM/S Standard 12 0 22521 02
TLM-1520HPM/T Tags 12 0 22522 02
TLM-1520HPM/TP Polarized tags 12 0 22527 02
System Lithium Metal Oxide
Nominal voltage 4.0 V
Nominal capacity 125 mAh
Nominal current 5 mA
Max. continuous discharge current 1.75 A
Pulse current capability 3.75 A
Cell impedance max. 100 mΩ
Anode surface area 90 cm2
Lithium content 0.04 g
Weight 9 g
Volume 3.2 cm3
Temperature range −40 °C ... +85 °C
TLM-1520HPM/TP
› High power 4 Volt cell › No voltage delay › Long shelf life › End of life indication capability
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
43
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Ageing during Storage50
40
30
20
10
00 5 10 15 20 25
Accu
mul
ated
cap
acit
y lo
ss1) /
%
Time / years
1:2:3:
+25 °C+55 °C+70 °C
1
3 2
1) when tested at RT under 20 mA to 2.8 V
Capacity / mAh
4.54
3.5
3
2.5
2
1.5
1
0.50
Volt
age
/ V
Discharge at 450 mA and several Temperatures
1
1:2:3:4:
−40 °C−20 °C+22 °C+85 °C
2
3
4
0 50 150 200 250100
Volt
age
/ V
Capacity / mAh
Discharge Capability at RT4.5
4
3.5
3
2.5
2
1.5
1
0.50
50 150 2502000
3
1
1:2:3:4:
1.8 A450 mA225 mA9 mA
2
4
100
4.0±
0.5
0.13
0.2 7.5
Ø 14.5+0.2
Ø 15.5–1
28–1
3.7±
0.5
7±1
0.7±0.02
3.17
+
Voltage Curve
4.0
3.5
3.0
2.5
2.0
0 50 100 150 200 250 300
Volt
age
/ V
Capacity / mAh
4.0±
0.5
0.13
0.2 7.5
Ø 14.5+0.2
Ø 15.5–1
28–1
3.7±
0.5
7±1
0.7±0.02
3.17
+
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
44
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion,
and severe burn hazard. Do not charge, disassemble, heat above 100 °C, incinerate, or short circuit.
TLM-1530HPM
TLM-1530HPM/S TLM-1530HPM/T
Available Terminations Catalogue No.TLM-1530HPM/S Standard 12 0 22531 02
TLM-1530HPM/T Tags 12 0 22532 02
TLM-1530HPM/TP Polarized tags 12 0 22537 02
System Lithium Metal Oxide
Nominal voltage 4.0 V
Nominal capacity 225 mAh
Nominal current 9 mA
Max. continuous discharge current 3.2 A
Pulse current capability 6.8 A
Cell impedance max. 100 mΩ
Anode surface area 160 cm2
Lithium content 0.1 g
Weight 11 g
Volume 4.4 cm3
Temperature range −40 °C ... +85 °C
TLM-1530HPM/TP
› High power 4 Volt cell › No voltage delay › Long shelf life › End of life indication capability
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
44
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Voltage Curve
Capacity / mAh
Volt
age
/ V
4.0
3.5
3.0
2.5
2.0
0 100 200 300 400 500 600
+
Ø 15,5-1
Ø 14,5+0,2
51-1
7±1
0,13
0,7±0,02 7,5
3,7±
0,5
0,2
3,17
4,0±
0,5
Volt
age
/ V
0 100Capacity / mAh
Discharge capability at RT4.5
4
3.5
3
2.5
2
1.5
1200 400300 500 600
1:2:3:
5 A2.5 A0.5 A
2
1 3
Volt
age
/ V
0 100Capacity / mAh
Discharge capability @ 2A at several temperatures4.00
3.50
3.00
2.50
2.00
1.50200 400300 500
1:2:3:4:5:
–40 °C–30 °C–20 °C+22 °C+72 °C
4 5
2
1
3
Ageing during Storage50
40
30
20
10
00 5 10 15 20 25
Accu
mul
ated
cap
acit
y lo
ss1) /
%
Time / years
1:2:3:
+25 °C+55 °C+70 °C
1
3 2
1) when tested at RT under 50 mA to 2.8 V
+
Ø 15.5-1
Ø 14.5+0.2
51-1
7±1
0.13
0.7±0.02 7.5
3.7±
0.5
0.2
3.17
4.0±
0.5
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
45
Performance Data(Typical values for batteries stored at +25 °C for one year)
WARNING: Fire, explosion,
and severe burn hazard. Do not charge, disassemble, heat above 100 °C, incinerate, or short circuit.
TLM-1550HPM
TLM-1550HPM/S TLM-1550HPM/Z2/T
Available Terminations Catalogue No.TLM-1550HPM/S Standard 12 0 22551 02
TLM-1550HPM/Z2/T Tags* 12 1 22552 02
TLM-1550HPM/Z2/TP Polarized tags* 12 1 22557 02
* with PTC SRP 200
System Lithium Metal Oxide
Nominal voltage 4.0 V
Nominal capacity 500 mAh
Nominal current 100 mA
Max. continuous discharge current 7 A
Pulse current capability 15 A
Cell impedance max. 100 mΩ
Anode surface area 360 cm2
Lithium content 0.4 g
Weight 20 g
Volume 8 cm3
Temperature range −40 °C ... +85 °C
TLM-1550HPM/Z2/TP
› High power 4 Volt cell › No voltage delay › Long shelf life › End of life indication capability
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
45
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
4.0
3.5
3.0
2.5
2.0
Volt
age
/ V
Time
200
150
100
50
0
Current / mA
2
11:2:
VoltageCurrent
Charging Principle CCCV
GSM Discharge Curves
4.0
3.5
3.0
2.5
2.0
Volt
age
/ V
Time / min0 5 10 15 20 25 30 35
1:2:
2.0 A / 577 µs150 mA / 4.6 ms
1
2
1
2
2
2
1
1
+20 °C –10 °C –30 °C –40 °C
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
46
IntroductionTLI-BatteryThe TLI series is specifi-cally designed for long-term use in harsh environments. It represents an important breakthrough in recharge-able lithium-ion battery technology.
Standard rechargeable lithium ion cells have inherent draw-backs which have an impact on long term applications. These include short operating life (maximum 5 years), low maximum cycle life (1000 cy-cles), high self-discharge (up to 60 % per year), and limited temperature range (0 °C to 60 °C) with no possibility of charging at low and high temperatures.
By contrast, TLI series batter-ies utilize technology found in Tadiran’s patented hybrid lay-er capacitor (HLC). Tadiran’s technology has been field-proven in millions of cells to deliver 25 years and more service life. TLI series batter-ies modify this technology to deliver reliable, long-term performance under extreme environmental conditions.
Characteristics Wide operating tempera-ture (– 40 °C to + 85 °C) Short time storage up to + 90 °C possible Ability to deliver high current pulses (up to 5 A) Low self-discharge (less than 5 % per year) Up to 5 times extended cycle life (5000 full charge/discharge cycles) Long operating time (10 years) Charging possible at extreme temperatures (10h-rate) Hermetically sealed cell (glass-to-metal seal) Certified safety (UL) Easy monitoring of cell fitness during storage
Table 1 shows a comparison of a standard lithium ion cell 18650 with the TLI-1550. It can be seen that the charac-teristics of the TLI series are superior in terms of power, self-discharge and operating temperature range.
Figure 1 shows the constant current/constant voltage (CCCV) charging principle which is recommended for the TLI series. The battery is charged with a constant current until the maximum voltage is reached. Afterwards, the charging current is de-creased to maintain constant voltage. Charging may be discontinued when a prede-fined end-of-charge current is reached. With the maximum current, charging takes ap-proximately 6.5 hours in the temperature range between –20 °C and +50 °C. In the extended temperature range between –40 °C and +85 °C the maximum charging current is five times lower, resulting in a five times longer charging time.
TLI in eCall applicationsThe TLI battery ensures con-stant power supply even under high current pulses. This is required for applications like bidirectional wireless commu-nication modules. One major application for TLI batteries is
the so-called AutonomousTelematics Box or Advanced Telematics Module where the TLI battery serves as the back-up battery for eCall, the automatic emergency call system for cars in Europe. The requirements for this system include operation under high pulse currents at low tem-perature at any time up to 10 years after installation. Even under these severe conditions, an air time of more than 10
minutes is re-quired. During this air time, the system exchanges both car condition and position data and voice signals between the car and an emergency call centre.
Figure 2 shows the behaviour of TLI-1550 in a typical eCall application after an ageing period of one month at 72 °C. The GSM transmission profile of the application requires a 2 A pulse for the duration of 577 µs followed by a 150 mA pulse for 4.6 ms. This load alternation is continuously repeated. Even at a tempera-ture of –40 °C a TLI-1550 cell ensures an air time of more than 15 minutes.
ProtectionIn order to ensure a high level of safety, TLI cells 1530 and 1550 should be protected by a PTC either on the battery or on the PC-board. Recommend-ed PTC types include SRP120 and SRP200, respectively, as follows: SRP120 limits the discharge current to 1.2 A and SRP200 to 2 A. In special cases cells can be used with-out PTC. TLI batteries have no inte-grated overcharge protec-tion. The protection circuit should be designed by the customer and be approved by Tadiran. Please refer to the TLI guidelines posted on Tadiran’s website under products >> TLI-batteries.
Approval by TadiranThe design of the following items should be approved by Tadiran:
Implementation of the protection circuit against overcharge, e.g. by limita-tion of the charging voltage and charging current to the values given in the individual data sheets Implementation of low voltage protection against deep discharge
Characteristics 18650 Li-Ion TLI-1550ADimensions Ø 18 mm x 64 mm Ø 15 mm x 50 mmCapacity 3.2 Ah 0.4 Ah
Power:
@ +25 °C 18W 18 W
@ –20 °C < 3 W > 6 W
Temperature range:
Storage –20 °C to +60 °C –40 °C to +85 °C Discharge –20 °C to +60 °C –40 °C to +85 °C Charge ±0 °C to +45 °C –40 °C to +85 °CSelf discharge 20 % per year < 5 % per yearOperating life 5 years 10+ years
Table 1: Comparison of TLI-1550 versus a standard lithium ion cell 18650
Figure 1: Charging principle CCCV. Example for TLI-1550
Figure 2: Discharge behaviour of TLI-1550 under the GSM profile after storage at 72 °C for one month
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
46
Discharge Curve at 100 mA
4.0
3.5
3.0
2.5
2.0
0 5 10 15 20 25 30
Volt
age
/ V
Capacity / mAh
1:2:3:4:5:
–40 °C–30 °C–20 °C
0 °C+22 °C
21 3 4 5
Cycling Performance
0 1000 2000 3000 4000
Capa
city
/ m
Ah
Cycles
0
40
30
20
10
Discharge Curve at 25 °C
4.0
3.5
3.0
2.5
2.0
0 5 10 15 20 25 30
Volta
ge /
V
Capacity / mAh
1:2:3:4:
400 mA200 mA100 mA
10 mA
213
4
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
47
Performance Data(Typical values for batteries stored at +25 °C for one year)
Warning: Fire, explosion,
and severe burn hazards. Do not disassemble, heat above 100 °C, short circuit, incinerate or expose contents to water.
Do not charge above 4.1 V.Please refer to TLI-guidelines.
+
Ø 10±0.5
7±1
3.7±
0.5
0.7±0.02 7.5
3.17
21−
1
TLI-1020A
TLI-1020A/S TLI-1020A/T
TLI-1020A/TP
› RECHARGEABLE › Up to 5000 cycles › Extremely low self discharge rate › Charging possible at extreme temperatures
System Lithium Intercalated CompoundsNominal voltage 4 V
Max. capacity 25 mAh
Max. continuous discharge current 160 mA
Pulse current capability 400 mA
Discharge end voltage 2.5 V
Max. charge voltage 4.1 V
Max. charge current 8 mA 1.6 mATemperature range –20 °C ... +50 °C –40 °C ... +85 °C
Cell impedance @ 1 kHz, RT max. 600 mΩ
Nominal energy max. 0.09 Wh
Weight 4.2 g
For more information please refer to page 46.
Available Terminations Catalogue No.TLI-1020A/S Standard 13 2 11021 02
TLI-1020A/T Tags 13 2 11022 02
TLI-1020A/TP Polarized tags 13 2 11027 02
+
Ø 10±0.5
7±1
3.7±
0.5
0.7±0.02 7.5
3.17
21−
1
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
47
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Available Terminations Catalogue No.TLI-1520A/Z2/T Tags* 13 3 11522 02
TLI-1520A/Z2/TP Polarized tags* 13 3 11527 02
* with PTC SRP 200
4.0±
0.5
+0.13
0.7±0.02
7±1
3.7±
0.5
0.2 7.5
3.17
Ø 14.5+0.2
Ø 15.5−1
21+
2
TLI-1520A/Z2
Discharge Curve at 25 °C
4.0
3.5
3.0
2.5
2.0
0 20 40 60 80 100 120
Volt
age
/ V
Capacity / mAh
1:2:3:4:
1250 mA625 mA250 mA
50 mA
34
21
Discharge Curve at 500 mA
4.0
3.5
3.0
2.5
2.0
0 20 40 60 80 100 120
Volt
age
/ V
Capacity / mAh
1:2:3:4:5:
−40 °C−30 °C−20 °C
0 °C+22 °C
2
1
3
45
Cycling Performance
0 1000 2000 3000 4000
Capa
city
/ m
Ah
Cycles
0
120
90
60
30
TLI-1520A/Z2/T
TLI-1520A/Z2/TP
+
Ø 15.5-1
Ø 14.5+0.2
52+
2
7±1
0.13
0.7±0.02 7.5
3.7±
0.5
0.2
3.17
4.0±
0.5
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
48
Performance Data(Typical values for batteries stored at +25 °C for one year)
Warning: Fire, explosion,
and severe burn hazards. Do not disassemble, heat above 100 °C, short circuit, incinerate or expose contents to water.
Do not charge above 4.1 V.Please refer to TLI-guidelines.
TLI-1520A › RECHARGEABLE › Up to 5000 cycles › Extremely low self discharge rate › Charging possible at extreme temperatures
System Lithium Intercalated CompoundsNominal voltage 4 V
Max. capacity 90 mAh
Max. continuous discharge current 500 mA
Pulse current capability 1.25 A
Dischage end voltage 2.5 V
Max. charge voltage 4.1 VMax. charge current 25 mA 5 mATemperature range –20 °C ... +50 °C –40 °C ... +85 °C
Cell impedance @ 1 kHz, RT max. 250 mΩ
Nominal energy max. 0.3 Wh
Weight 9 g
For more information please refer to page 46.
PDC1
7Eng
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
48
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
Available Terminations Catalogue No.TLI-1530A/Z2/T Tags* 13 3 11532 02
TLI-1530A/Z2/TP Polarized tags* 13 3 11537 02
* with PTC SRP 200
TLI-1530A/Z2
Discharge Curve at 1 A
4.0
3.5
3.0
2.5
2.0
0 25 50 75 100 125 150
Volt
age
/ V
Capacity / mAh
1:2:3:4:5:
−40 °C−30 °C−20 °C
0 °C+22 °C
21
3
45
Cycling Performance
0 1000 2000 3000 4000
Capa
city
/ m
Ah
Cycles
0
160
120
80
40
Discharge Curve at 25 °C
4.0
3.5
3.0
2.5
2.0
0 25 50 75 100 125 150
Volt
age
/ V
Capacity / mAh
1:2:3:4:
2500 mA1250 mA
500 mA50 mA
1
4.0±
0.5
3.170.13
0.2 0.7±0.02
3.7±
0.5
7±1
Ø 14.5+0.2
Ø 15.5−1
29+
2
7.5
+
TLI-1530A/Z2/T
TLI-1530A/Z2/TP
+
Ø 15.5-1
Ø 14.5+0.2
52+
2
7±1
0.13
0.7±0.02 7.5
3.7±
0.5
0.2
3.17
4.0±
0.5
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
49
Performance Data(Typical values for batteries stored at +25 °C for one year)
Warning: Fire, explosion,
and severe burn hazards. Do not disassemble, heat above 100 °C, short circuit, incinerate or expose contents to water.
Do not charge above 4.1 V.Please refer to TLI-guidelines.
TLI-1530A › RECHARGEABLE › Up to 5000 cycles › Extremely low self discharge rate › Charging possible at extreme temperatures
System Lithium Intercalated CompoundsNominal voltage 4 V
Max. capacity 150 mAh
Max. continuous discharge current 1 A
Pulse current capability 2.5 A
Dischage end voltage 2.5 V
Max. charge voltage 4.1 VMax. charge current 50 mA 10 mATemperature range –20 °C ... +50 °C –40 °C ... +85 °C
Cell impedance @ 1 kHz, RT max. 175 mΩ
Nominal energy max. 0.5 Wh
Weight 10 g
For more information please refer to page 46.
PDC1
7Eng
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
49
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
+
Ø 15.5-1
Ø 14.5+0.2
52+
2
7±1
0.13
0.7±0.02 7.5
3.7±
0.5
0.2
3.17
4.0±
0.5
Discharge Curve at 25 °C
4.0
3.5
3.0
2.5
2.0
Volt
age
/ V
Capacity / mAh0 60 120 180 240 300 360
1:2:3:4:
5.0 A2.5 A1.0 A0.1 A
34
21
Discharge Curve at 2 A
4.0
3.5
3.0
2.5
2.0
0 60 120 180 240 300 360
Volt
age
/ V
Capacity / mAh
1:2:3:4:5:6:7:
–40 °C–30 °C–20 °C–10 °C
0 °C+25 °C+80 °C
2
1
3
45
67
Cycling Performance
0 1000 2000 3000 4000
Capa
city
/ m
Ah
Cycles
0
400
300
200
100
150
250
50
350
TLI-1550A/Z2 TLI-1550A/Z2/T
TLI-1550A/Z2/TP
+
Ø 15.5-1
Ø 14.5+0.2
52+
2
7±1
0.13
0.7±0.02 7.5
3.7±
0.5
0.2
3.17
4.0±
0.5
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
50
Performance Data(Typical values for batteries stored at +25 °C for one year)
Warning: Fire, explosion,
and severe burn hazards. Do not disassemble, heat above 100 °C, short circuit, incinerate or expose contents to water.
Do not charge above 4.1 V.Please refer to TLI-guidelines.
TLI-1550A › RECHARGEABLE › Up to 5000 cycles › Extremely low self discharge rate › Charging possible at extreme temperatures
System Lithium Intercalated CompoundsNominal voltage 4 V
Max. capacity 330 mAh
Max. continuous discharge current 2 A
Pulse current capability 5 A
Discharge end voltage 2.5 V
Max. charge voltage 4.1 VMax. charge current 100 mA 20 mATemperature range –20 °C ... +50 °C –40 °C ... +85 °C
Cell impedance @ 1 kHz, RT max. 100 mΩ
Nominal energy max. 1.32 Wh
Weight 20 g
For more information please refer to page 46.
Available Terminations Catalogue No.TLI-1550A/Z2/T Tags* 13 3 11552 02
TLI-1550A/Z2/TP Polarized tags* 13 3 11557 02
* with PTC SRP 200
PDC1
7Eng
Toutes les valeurs sont exclusivement données à titre d’information. Elles dépendent également des conditions d’utilisation et ne constituent donc pas une garantie de per-formance. Sous réserve de toute modification.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
50
Caractéristiques techniques(pour des piles stockées à 25 °C pendant 1 an)
System Size Type Exempted1) Lithium content [g]
UN Test passed
UN Number
LithiumThionylChloride (LTC)
BEL SL-840 Yes 0.13 Yes 3090/911⁄10C TLH-2450 TL-2450 Yes 0.18 Yes 3090/911⁄10D SL-786 SL-886 Yes 0.3 Yes 3090/911⁄6D SL-789 SL-889 Yes2) 0.5 Yes 3090/911⁄2AA SL-350 SL-550 SL-750 SL-850 Yes2) 0.35 Yes 3090/912⁄3AA SL-361 SL-561 SL-761 SL-861 Yes2) 0.5 Yes 3090/91
AA SL-360 SL-560 SL-760 SL-860 Yes2) 0.65 Yes 3090/91
C SL-2770 SL-2870 No 2.5 Yes 3090/91
D SL-2780 SL2880 No 5 Yes 3090/91
DD SL-2790 No 10 Yes 3090/91
Hybrid Layer Capacitors(HLC)
1⁄2AAA HLC-1020 (3.67 V and 3.9 V) Yes 0.01 Yes 3090/911⁄2AA HLC-1520 (3.67 V) Yes 0.02 Yes 3090/912⁄3AA HLC-1530 (3.67 V) Yes 0.02 Yes 3090/91
AA HLC-1550 (3.67 V) Yes 0.05 Yes 3090/911⁄2AA HLC-1520 (3.9 V) Yes 0.03 Yes 3090/912⁄3AA HLC-1530 (3.9 V) Yes 0.05 Yes 3090/91
AA HLC-1550 (3.9 V) Yes 0.1 Yes 3090/91
TLM batteries 1⁄2AA TLM-1520HPM Yes 0.04 Yes 3090/912⁄3AA TLM-1530HPM Yes 0.1 Yes 3090/91
AA TLM-1550HPM Yes 0.4 Yes 3090/91TLI batteries 1⁄2AAA TLI-1020A Yes < 0.09 Wh Yes 3480/81
1⁄2AA TLI-1520A Yes < 0.3 Wh Yes 3480/812⁄3AA TLI-1530A Yes < 0.5 Wh Yes 3480/81
AA TLI-1550A Yes < 1.32 Wh Yes 3480/81
Table 2: Classification of Tadiran Lithium Batteries 1) if conditions mentioned in Tadiran’s technical notice are fulfilled 2) see also IATA DGR under UN 3090 / PI 968 / Table 968-II
Table 1: Maximum reverse current
Any values given here are for informational purposes only. They also depend on actual conditions of use and are not warranties of future performance. Subject to change.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
51
Safety & Transport RegulationsStandardsGeneral safety recommenda-tions for lithium batteries have been published in the standards UL 1642 and IEC 60086-4.
UL-recognitionTadiran Lithium Batteries are recognized by UL under file MH 12827, please refer to UL ONLINE CERTIFICATIONS DIRECTORY for further infor-mation. The following text or a modified version thereof appears on each battery:
WARNING: Fire, explosion, and severe burn hazard. Do not recharge, disassemble, heat above 100 °C, incinerate, or expose contents to water.
Classification of lithium batteriesLithium metal batteriesare dangerous goods, UN No.3090. Lithium ion batteriesare dangerous goods, UN No.3480. Table 2 indicates which Tadiran Lithium cells are exempted from the dangerous goods regulations and which are not. In air transport, exemptions are limited.
For more information on classification and transport regulations, please refer to Tadiran’s technical notice: www.tadiranbatteries.de/regulations/
UN testsTable 2 also shows the sta-tus of UN-tests for Tadiran Lithium Batteries accord-ing to the UN Handbook of Tests and Criteria, part III, sub-section 38.3. Regarding Tadiran Lithium Batteries not listed in table 2, please ap-ply to Tadiran Batteries for a confirmation.
Protection against chargingWhenever lithium batter-ies are not the single power source in a circuit the follow-ing measures are recom-mended by the Underwriters Laboratories:
The battery should not be con-nected in series with an elec-trical power source that would increase the forward current through the battery.
The circuit shall include one of the following:
A. Two suitable diodes in series with the battery to prevent any reverse (charg-ing) current. The second diode provides protection if the other one fails; or
B. A blocking diode or the equivalent to prevent any reverse (charging) current and a resistor to limit current in case of a diode failure. The resistor should be sized to limit the reverse (charging) current to the maximums IR max shown in table 1.
In addition to this UL require-ment, which gives the safety limits, Tadiran Batteries rec-ommend to limit the reverse (charging) current to values below 10 µA. This will ensure that service life is not affected.
Type IR max
SL-350 15 mASL-360 50 mASL-361 20 mASL-550 15 mASL-560 50 mASL-561 15 mASL-750 15 mASL-760 50 mASL-761 20 mASL-840 15 mASL-850 15 mASL-860 50 mASL-861 20 mASL-886 25 mASL-889 20 mASL-2770 15 mASL-2780 50 mASL-2790 100 mASL-2870 15 mASL-2880 50 mATLM-1520HPM 100 mATLM-1530HPM 100 mATLM-1550HPM 100 mA
Protection against forced dischargeForced discharge of a cell can occur when it is connected in series with other cells. A by-pass diode should be provided in parallel with each cell in a series connection. The effect of a by-pass diode is that cur-rent passes through the diode if a cell has been discharged, preventing forced discharge.
REACH and RoHSAll Tadiran cell are compliant with REACH regulation and RoHS directive.
Toutes les valeurs données ici ont but d‘informer uniquement. Elles dépendent aussi des conditions réelles d‘utilisation et ne sont pas des garanties de performance future. Sous réserve de modifications.
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN ALLEMAGNE • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
2Fra
51
Your Distributor
Tadiran Batteries GmbH • Industriestr. 22 • 63654 BÜDINGEN GERMANY • Tel.: +49 (0)6042 954-0 • www.tadiranbatteries.de
PDC1
7Eng
Tadiran Lithium Batteries – Applications
Lithium Thionyl Chloride (LTC) BatteriesPulsesPlus TM Batteries Tadiran Lithium Metal Oxide (TLM) BatteriesTadiran Lithium Ion (TLI) Batteries
TrackingAnimalsCorrosionData loggersElectronic toll collectionOn-board unitsPersonalPipelinesRailwaysTrucks, containers, trailers
AirbagsAutomatic collision devicesBelt tensionersBrake controllersCommunication modulesDigital tachographsDoors / latchesEngine controllersIn-car computersStolen vehicle recovery systemsTelematics / eCallTyre pressure monitoring systems
AutomotiveProcess automationWireless sensor networksControllersFault detectorsIndustrial PCsProcess logic control
Industrial automation
Cash machinesPoint of sale terminalsTelephone exchange boards
Office automation
BeaconsBuoysLife jacket lightsOil drilling / MWD Seismic sensorsUnderwater positioning systems
Off-shore
DefibrillatorsDispensersImplantable devicesInfusion pumpsSurgical instruments
Medical Electronic scalesGambling machinesTaximetersVending machines
Instrumentation
Alarm and security systemsSmoke detectorsWireless alarm systemsPIR detectorsCash transport and asset protection systemsOffender monitoring systems
Utility MeteringAutomatic meter reading (AMR)Electricity, gas, water, heat, calorimetersHeat cost allocatorsPrepayment metersCommunication modulesSmart electricity meters with a GSM module
MilitaryEmergency Power supply for UAVsFuzesGas masksGuidance systemsNight vision gogglesTargeting devicesEjection seats
High end consumerDiving computersSet top boxesSports electronics