diagnosis procedures ecu
TRANSCRIPT
G - TESTS W/CODES - 6-CYLArticle Text
1993 Mazda MX-3For NONE
Copyright © 1998 Mitchell Repair Information Company, LLCMonday, February 28, 2005 05:24PM
ARTICLE BEGINNING1993 ENGINE PERFORMANCEMazda Self-Diagnostics
MX-3 1.8L
INTRODUCTION If no faults were found while performing F - BASIC TESTING,proceed with self-diagnostics. If no fault codes or only pass codesare present after entering self-diagnostics, proceed to appropriateH - TEST W/O CODES article for diagnosis by symptom (i.e., ROUGH IDLE,NO START, etc.).
SELF-DIAGNOSTIC SYSTEMHard Failures
Hard failures cause malfunction indicator light (CHECKENGINE) to illuminate and remain on until problem is repaired. Iflight comes on and remains on (light may flash) during vehicleoperation, cause of malfunction must be determined using diagnostic(code) charts. If a sensor fails, control unit will use a substitutevalue in its calculations to continue engine operation. In thiscondition, commonly known as limp-in mode, the vehicle runs butdriveability will not be optimum.
Intermittent Failures Intermittent failures may cause CHECK ENGINE light to flickeror illuminate and go out after the intermittent fault goes away.However, the corresponding trouble code will be retained in ECUmemory. If related fault does not reoccur within a certain time frame,related trouble code will be erased from ECU memory. Intermittentfailures may be caused by a sensor, connector or wiring relatedproblems. See INTERMITTENTS in H - TESTS W/O CODES article.
RETRIEVING CODESAccessing Trouble Codes
1) Using jumper wire, connect self-diagnostic connectorterminals TEN and GND. See Fig. 1. Connector is located at back ofleft front wheelwell. 2) With ignition on and engine stopped, observe malfunctionindicator light (CHECK ENGINE). Note trouble codes. Check TROUBLE CODEIDENTIFICATION chart for possible cause. If light remains oncontinuously, MIL circuit is grounded or ECU is defective. If no codesare found, go to J - PIN VOLTAGE CHARTS article.
Memorized vs. Non-Memorized Codes Some sensor or circuit failures are stored in ECU and areknown as memorized codes. While other circuit failures, called non-memorized codes, are not stored. Non-memorized codes can be retrievedif ignition is not turned off before accessing codes.
NOTE: To access non-memorized trouble codes, DO NOT stop engine. Connect jumper wire across self-diagnostic connector terminals TEN and GND. Observe MIL and note trouble codes.
AFTER-REPAIR PROCEDURE
G - TESTS W/CODES - 6-CYLArticle Text (p. 2)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
After indicated service or replacement is performed, clearcodes. See CLEARING CODES. Recheck ECU memory. No codes should bepresent. If codes are present, see appropriate trouble code chartunder CODE CHARTS to repair vehicle.
Fig. 1: Locating Self-Diagnostic ConnectorCourtesy of Mazda Motors Corp.
CLEARING CODESClearing Trouble Codes
1) Disconnect negative battery cable. Depress brake pedal forat least 5 seconds. Reconnect battery cable. 2) Ground test connector with jumper wire. Turn ignition on,but DO NOT start engine for 6 seconds. Start engine and run at 2000RPM for 2 minutes. Verify no codes are displayed.
CODE CHARTSNOTE: See J - PIN VOLTAGE CHARTS article to identify ECU connector terminals.
NOTE: Trouble Codes 6, 12, 55, 57, 58, 60, 61, 62 and 63 are automatic transmission-related problems. If codes are present, see appropriate TRANSMISSION SERVICE & REPAIR article.
TROUBLE CODE IDENTIFICATION
G - TESTS W/CODES - 6-CYLArticle Text (p. 3)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 2: Trouble Code IdentificationCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 4)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 3: Trouble Code Identification (Cont.)Courtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 2 (NE2 SIGNAL - DISTRIBUTOR)
Fig. 4: Trouble Code No. 2 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 5)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 5: Trouble Code No. 2 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 3 (G SIGNAL - DISTRIBUTOR)
Fig. 6: Trouble Code No. 3 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 6)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 7: Trouble Code No. 3 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 4 (NE1 SIGNAL - DISTRIBUTOR)
Fig. 8: Trouble Code No. 4 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 7)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 9: Trouble Code No. 4 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 5 (KNOCK SENSOR)
Fig. 10: Trouble Code No. 5 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 8)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 11: Trouble Code No. 5 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 8 (AIRFLOW METER)
Fig. 12: Trouble Code No. 8 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 9)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 13: Trouble Code No. 8 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 9 (COOLANT THERMOSENSOR)
Fig. 14: Trouble Code No. 9 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 10)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 15: Trouble Code No. 9 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 10 (INTAKE AIR THERMOSENSOR)
Fig. 16: Trouble Code No. 10 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 11)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 17: Trouble Code No. 10 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 12 (THROTTLE SENSOR)
Fig. 18: Trouble Code No. 12 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 12)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 19: Trouble Code No. 12 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 14 (ATMOSPHERIC PRESSURE SENSOR)* Replace the ECU.
TROUBLE CODE NO. 15 (OXYGEN SENSOR)
Fig. 20: Trouble Code No. 15 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 13)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 21: Trouble Code No. 15 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 16 (EGR POSITION SENSOR)
Fig. 22: Trouble Code No. 16 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
G - TESTS W/CODES - 6-CYLArticle Text (p. 14)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 23: Trouble Code No. 16 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODES NO. 17 & 24 (FEEDBACK SYSTEM)
G - TESTS W/CODES - 6-CYLArticle Text (p. 15)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 24: Trouble Codes No. 17 & 24 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 25 (PRESSURE REGULATOR SOLENOID VALVE)
G - TESTS W/CODES - 6-CYLArticle Text (p. 16)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 25: Trouble Code No. 25 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 26 (PURGE CONTROL SOLENOID VALVE)
Fig. 26: Trouble Code No. 26 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
Fig. 27: Trouble Code No. 26 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 28 (EGR VACUUM VALVE SOLENOID)
G - TESTS W/CODES - 6-CYLArticle Text (p. 17)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 28: Trouble Code No. 28 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 29 (EGR VENT VALVE SOLENOID)
Fig. 29: Trouble Code No. 29 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
Fig. 30: Trouble Code No. 29 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 34 (IDLE SPEED CONTROL)
G - TESTS W/CODES - 6-CYLArticle Text (p. 18)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 31: Trouble Code No. 34 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 41 (VARIABLE INERTIA CHARGING SYSTEMSOLENOID 1)
Fig. 32: Trouble Code No. 41 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 46 (VARIABLE INERTIA CHARGING SYSTEMSOLENOID 2)
G - TESTS W/CODES - 6-CYLArticle Text (p. 19)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 33: Trouble Code No. 46 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
Fig. 34: Trouble Code No. 46 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 67 (ELECTRICAL COOLING FAN RELAY)
G - TESTS W/CODES - 6-CYLArticle Text (p. 20)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 35: Trouble Code No. 67 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
Fig. 36: Trouble Code No. 67 - SchematicCourtesy Of Mazda Motors Corp.
TROUBLE CODE NO. 69 (COOLANT THERMOSENSOR)
G - TESTS W/CODES - 6-CYLArticle Text (p. 21)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
Fig. 37: Trouble Code No. 69 - Diagnostic FlowchartCourtesy Of Mazda Motors Corp.
Fig. 38: Trouble Code No. 69 - SchematicCourtesy Of Mazda Motors Corp.
SUMMARY
G - TESTS W/CODES - 6-CYLArticle Text (p. 22)1993 Mazda MX-3For NONE Copyright © 1998 Mitchell Repair Information Company, LLC
If no hard fault codes (or only pass codes) are present,driveability symptoms exist or intermittent codes exist, proceed toH - TESTS W/O CODES article for diagnosis by symptom (i.e., ROUGHIDLE, NO START, etc.) or intermittent diagnostic procedures.
END OF ARTICLE